Technical Service Bulletins
- A/C Compressor
- Filtering Refrigerant After Compressor Replacement (98-12-5)
- Identification Of Non-Ford Approved Refrigerants (99-19-6)
- Use Of R-12 Refrigerant Substitutes (96-17-10)
- A/C System Service - List Of Bulletins To Reference (96-15-6)
- Ford Approved Flushing Procedures For A/C System (95-8-1)
- R-12 Refrigerant Substitutes - Service Tip (94-14-3)
- Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
- Use Of Correct Fluorescent Tracer Dye - Service Tip (93-20-6)
- A/C SLC Refrigerant Fittings Cleaning/New O-Ring Kit (93-6-5)
- New Refrigerant Fitting "O" Rings (91-22-5)
- Air Conditioning - Refrigerant R-12 - Service Tips (91-9-7)
- A/C "O" Ring Usage Table (90-14-8)
- Poor A/C - Clutch Pressure Cycling Switch Diagnosis (89-14-10)
- A/C Drier - Replace When Major Component Serviced (88-25-5)
- A/C Clutch Cycling Pressure Switch Diagnosis (87-6-4)
- A/C Clutch Pressure Cycling Switch Diagnostic (89-7T-19)
- Accessories Control Systems
- Anti-Lock Brakes
- Anti-Theft Systems
- No Crank - Low State Of Battery Charge (91-10-8)
- Latches - Door - Replacement Required (91-8-4)
- Treating Cosmetic Paint Damage From AIRBORN Material (89-13-3)
- Manual Vent Windows - Glass Sticks To Weatherstrip (88-14-1)
- Power Door Locks Inoperative - Rod Retainer Clip (88-7-1)
- Surface Rust On Chassis Components:Removal Procedure (88-6-6)
- Door Handle/Switches Air Leak - Foam Gaskets (87-17-9)
- Automatic Trans
- E4OD/4R100 - Fluid In-Line Filter Kit (00-3-8)
- Transmission Flush/Fill Tool Available From Rotunda (99-15-2)
- Transmission Fluid Usage Chart (98-8-8)
- 4R44E/5R55E Trans - New Service Center Support (98-1-12)
- Torque Converter Slip/DTC 628 Or P0741 In Memory (97-22-4)
- Torque Converter Replacement - Cooling SYS. Cleaning (96-26-12)
- Torque Converter Leak Test Procedure - New Tool (96-24-9)
- New Rotunda Fluid Changer - Service Tip (95-16-10)
- Adhesives & Sealants - Availability & Usage (89-12-2)
- Driveline Clank/Ratchet In Reverse - New Driveshaft (88-2-15)
- A4LD Transmission New Front Oil Pump Bolts (87-21-6)
- A/T Cooler Line Connections Leak - Modify Connectors (87-18-13)
- New ATF Applications Chart (87-18-14)
- Rear Axle Fluid Leak - New Axle Reseal Procedure (87-7-25)
- A4LD/C3 Trans Shifter Assembly Part No./Applications (87-5-34)
- A4LD/AOD Trans Rpm Up On Downshift - Service Valve (87-5-22)
- A4LD Trans Leaks/Burnt Fluid/Eng Stall/Erratic Shift (87-2-15)
- A4LD Transmission Overhaul Tips (87-2-16)
- 7.5" Rear Axle With Driveline Vibration And Boom (89-5T-24)
- Approved Adhesives & Sealants For Eng/Trans/Steering (89-6T-7)
- Vibes/Shudder Accelerating - Excess Driveshaft Angle (89-7T-30)
- Auxiliary Emission Control Systems
- EXH Gas Oxygen Sensor Silicone Sealer Contamination (93-23-6)
- Nylon Fuel Line Service (92-12-16)
- Electronic Control Modules - Damage From Arc Welding (91-7-5)
- No Start/Low Battery/Fuel Pump Noise - Pump Relay (90-18-3)
- Hard Start - Revised DURASPARK II Ignition Module (90-1-5)
- Rough Idle - Air By Pass Valve Replacement Part (89-24-4)
- Emission Maintenance Warning Module - Information (89-22-8)
- TPS Service Replacement Chart (89-16-4)
- Throttle Position Sensor Screw Removal (89-14-7)
- EEC IV Eng & 2.3L/2.5L HSC CFI Map/Bap Sensor Applications Chart (89-1-12)
- Electronic Modules - Damage From Static Electricity (88-13-3)
- EFI Rough Idle/Injector Terminals Loose - Diagnosis (87-13-6)
- ECM Processor Warranty Decal Information (87-11-13)
- Wiring System Testing Caution - Modify Probe Tips (87-2-5)
- 2.3/2.5L Eng New Map/Bap Sensor Application Table (89-1T-19)
- EMW/IMS Warning Module Definition Location (89-11T-20)
- Throttle Position Sensor POZIDRIVE Mount Screw Info (89-7T-9)
- Axle Shafts
- 4WD Automatic HUBLOCK Information - Service Tip (95-5-18)
- 4X4 Front Axle I.D. Tags (92-5-14)
- 4X4 General Info, Operating Characteristics & Tips (92-1-8)
- Driveline Clank/Ratchet In Reverse - New Driveshaft (88-2-15)
- Rear Axle Fluid Leak - New Axle Reseal Procedure (87-7-25)
- Rear Axle Housing Replacement (87-2-27)
- 7.5" Rear Axle With Driveline Vibration And Boom (89-5T-24)
- Vibes/Shudder Accelerating - Excess Driveshaft Angle (89-7T-30)
- Blowers, Superchargers & Turbochargers
- Body Interior
- Electrical Diode Identification And Replacements (96-24-6)
- Cruise Control Won't Work When Wet - New Connector (92-7-8)
- A/C Chemical Smell - Clutch Cycling Pressure Switch (91-11-8)
- Latches - Door - Replacement Required (91-8-4)
- Air Conditioning Odor Treatment - Service Procedure (89-25B-1)
- Poor A/C - Clutch Pressure Cycling Switch Diagnosis (89-14-10)
- Inaccurate Speedo Readings - Mechanical & Electronic (89-2-7)
- Manual Vent Windows - Glass Sticks To Weatherstrip (88-14-1)
- A/C Clutch Pressure Cycling Switch Diagnostic (89-7T-19)
- Brakes Control Systems
- Charging Systems
- Clutch
- Driveline Clank/Ratchet In Reverse - New Driveshaft (88-2-15)
- Transmission Fluid Leak - Smooth Mounting/New Gasket (87-25-12)
- Rear Axle Fluid Leak - New Axle Reseal Procedure (87-7-25)
- Asbestos Brake & Clutch Warnings (83-22-1)
- 7.5" Rear Axle With Driveline Vibration And Boom (89-5T-24)
- Knock Noise From Engine - Slave Cylinder Rattling (86-22-20)
- Vibes/Shudder Accelerating - Excess Driveshaft Angle (89-7T-30)
- Cooling Fan
- Cooling System (Mechanical)
- Use Of Recycled Coolant - Service Tip (95-18-2)
- Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
- Nylon Fuel Line Service (92-12-16)
- Cooling System - Use Of Recycled Engine Coolant (90-4-10)
- Hard Start - Revised DURASPARK II Ignition Module (90-1-5)
- Adhesives & Sealants - Availability & Usage (89-12-2)
- Revised Electric Fuel Pump Testing (87-11-15)
- Fuel Stabilizer During Extended Vehicle Storage (86-13-20)
- Diagnostic Tips For Heater Core Leaks (85-5-2)
- Approved Adhesives & Sealants For Eng/Trans/Steering (89-6T-7)
- Cruise Control Systems
- Differentials & Drive Axles
- 4WD Automatic HUBLOCK Information - Service Tip (95-5-18)
- 4X4 Front Axle I.D. Tags (92-5-14)
- 4X4 General Info, Operating Characteristics & Tips (92-1-8)
- Adhesives & Sealants - Availability & Usage (89-12-2)
- Driveline Vibration At 35-50 Mph - PITCHLINE RUNOUT (89-10-13)
- Driveline Clank/Ratchet In Reverse - New Driveshaft (88-2-15)
- Rear Axle Fluid Leak - New Axle Reseal Procedure (87-7-25)
- Rear Axle Housing Replacement (87-2-27)
- 7.5" Rear Axle With Driveline Vibration And Boom (89-5T-24)
- Vibes/Shudder Accelerating - Excess Driveshaft Angle (89-7T-30)
- Driveshaft & Universal Joints
- 4WD Automatic HUBLOCK Information - Service Tip (95-5-18)
- 4X4 Front Axle I.D. Tags (92-5-14)
- 4X4 General Info, Operating Characteristics & Tips (92-1-8)
- Driveline Clank/Ratchet In Reverse - New Driveshaft (88-2-15)
- Rear Axle Fluid Leak - New Axle Reseal Procedure (87-7-25)
- Rear Axle Housing Replacement (87-2-27)
- 7.5" Rear Axle With Driveline Vibration And Boom (89-5T-24)
- Vibes/Shudder Accelerating - Excess Driveshaft Angle (89-7T-30)
- Electronic Steering
- Electronic Suspension
- Engine Control Systems
- MOTORCRAFT Fuel Injector Cleaning System (94-8-9)
- Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
- Fuel Injectors Clogged - New Fuel Injector Cleaning (91-19-3)
- Electronic Control Modules - Damage From Arc Welding (91-7-5)
- No Start/Low Battery/Fuel Pump Noise - Pump Relay (90-18-3)
- Hard Start - Revised DURASPARK II Ignition Module (90-1-5)
- Rough Idle - Air By Pass Valve Replacement Part (89-24-4)
- Emission Maintenance Warning Module - Information (89-22-8)
- TPS Service Replacement Chart (89-16-4)
- Throttle Position Sensor Screw Removal (89-14-7)
- EEC IV Eng & 2.3L/2.5L HSC CFI Map/Bap Sensor Applications Chart (89-1-12)
- Electronic Modules - Damage From Static Electricity (88-13-3)
- EFI Rough Idle/Injector Terminals Loose - Diagnosis (87-13-6)
- ECM Processor Warranty Decal Information (87-11-13)
- Fuel Line Spring Lock Coupling R & R (87-3-8)
- Wiring System Testing Caution - Modify Probe Tips (87-2-5)
- 2.3/2.5L Eng New Map/Bap Sensor Application Table (89-1T-19)
- EMW/IMS Warning Module Definition Location (89-11T-20)
- Throttle Position Sensor POZIDRIVE Mount Screw Info (89-7T-9)
- Entertainment Systems
- Exterior Body Panels
- Lower Body Stone Protection Repair Tips (90-15-3)
- Treating Cosmetic Paint Damage From AIRBORN Material (89-13-3)
- Cracks At Swing-Away Spare Tire: New Assembly (88-20-11)
- Manual Vent Windows - Glass Sticks To Weatherstrip (88-14-1)
- Surface Rust On Chassis Components:Removal Procedure (88-6-6)
- 2.9L EFI Engine Compartment Buzz - EVR Insulator Pad (87-21-15)
- Headliner Wind Noise - Roof To A-Pillar Joint Sealer (87-10-17)
- Exterior Lights
- Frames, Subframes & Crossmembers
- Frame - Rivet Replacement With Bolts - Service Tips (97-4-7)
- Lower Body Stone Protection Repair Tips (90-15-3)
- Treating Cosmetic Paint Damage From AIRBORN Material (89-13-3)
- Surface Rust On Chassis Components:Removal Procedure (88-6-6)
- 2.9L EFI Engine Compartment Buzz - EVR Insulator Pad (87-21-15)
- Headliner Wind Noise - Roof To A-Pillar Joint Sealer (87-10-17)
- Running Boards Noise/Shake - Installation Tip (87-8-12)
- Front Suspension
- Fuel System
- CALIFORNIA Reformulated Gasoline - Service Tip (96-10-7)
- MOTORCRAFT Fuel Injector Cleaning System (94-8-9)
- Internal Engine Damage: Water Entry Thru Air Intake (94-3-8)
- Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
- Nylon Fuel Line Service (92-12-16)
- Fuel Injectors Clogged - New Fuel Injector Cleaning (91-19-3)
- Hard Start - Revised DURASPARK II Ignition Module (90-1-5)
- Emission Maintenance Warning Module - Information (89-22-8)
- Inaccurate Speedo Readings - Mechanical & Electronic (89-2-7)
- CFI Fuel Injector Contamination - Replace Injector (87-17-5)
- Fuel Line Spring Lock Coupling R & R (87-3-8)
- Fuses & Circuit Breakers
- Wiring - Wire Harness Terminal Repair Kit (99-6-3)
- Electrical - New Terminal Grease For Service (98-24-6)
- Electrical Diode Identification And Replacements (96-24-6)
- Generator Harness Connector Damage - Loose Contact (96-21-4)
- Cruise Control Won't Work When Wet - New Connector (92-7-8)
- No Crank - Low State Of Battery Charge (91-10-8)
- Wire Harness Terminal & Connector Service Kit (89-19-5)
- New Micro-Pin Terminal Connectors Locking/Unlocking (87-7-7)
- Wiring System Diagnosis Cautions (87-4-8)
- Engine Compartment - Use Waterproof Wire Connectors (87-2-6)
- Wiring Diagram Symbols Explanation (85-11-5)
- Gauges & Instrument Panels
- Cruise Control Won't Work When Wet - New Connector (92-7-8)
- Fuel Tank Sending Unit Wiring Damaged - New Wiring (89-14-6)
- Inaccurate Speedo Readings - Mechanical & Electronic (89-2-7)
- False Lamp Out Warnings - Trailer Lighting Install. (88-2-6)
- Sound Distortion From ETR Radio: Rework Wire Harness (87-3-4)
- Damaged Fuel Tank Sending Unit Connector Repair (89-7T-14)
- New In Car Fuel Sender Test Procedure (86-15-5)
- General Servicing
- Hazardous Waste Material
- Headlights
- Heated Glass/Defoggers
- HVAC Control Systems
- Climate Control - Repeat Heater Core Failure (01-15-6)
- Filtering Refrigerant After Compressor Replacement (98-12-5)
- Identification Of Non-Ford Approved Refrigerants (99-19-6)
- Use Of R-12 Refrigerant Substitutes (96-17-10)
- A/C System Service - List Of Bulletins To Reference (96-15-6)
- Ford Approved Flushing Procedures For A/C System (95-8-1)
- A/C "O" Ring Removal From Spring Lock Coupling (95-2-2)
- R-12 Refrigerant Substitutes - Service Tip (94-14-3)
- Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
- Use Of Correct Fluorescent Tracer Dye - Service Tip (93-20-6)
- A/C SLC Refrigerant Fittings Cleaning/New O-Ring Kit (93-6-5)
- New Refrigerant Fitting "O" Rings (91-22-5)
- A/C Chemical Smell - Clutch Cycling Pressure Switch (91-11-8)
- Air Conditioning - Refrigerant R-12 - Service Tips (91-9-7)
- Electronic Control Modules - Damage From Arc Welding (91-7-5)
- A/C "O" Ring Usage Table (90-14-8)
- Air Conditioning Odor Treatment - Service Procedure (89-25B-1)
- Poor A/C - Clutch Pressure Cycling Switch Diagnosis (89-14-10)
- A/C Drier - Replace When Major Component Serviced (88-25-5)
- Electronic Modules - Damage From Static Electricity (88-13-3)
- A/C Lever Stuck - Cable/Plenum Chamber Diagnosis (88-5-15)
- Diagnostic Tips For Heater Core Leaks (85-5-2)
- A/C Clutch Pressure Cycling Switch Diagnostic (89-7T-19)
- Identification
- Ignition Switch/Steering Lock
- Ignition System
- Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
- Nylon Fuel Line Service (92-12-16)
- New Idle Air By-Pass Kit & ECA Relearn Procedure (91-7-4)
- Poor Cold Start/Idle/Run - Fuel Recommendations (91-8-13)
- Hard Start - Revised DURASPARK II Ignition Module (90-1-5)
- Distributor Gear Matched To Distributor At Assembly (89-6-11)
- Hard/No Start - TFI Module Connection (88-20-9)
- TFI Module/Pip Sensor New EEC-IV Testing (87-21-10)
- 2.0/2.3/2.5/3.0/3.8/5.0/5.8L Eng Short IGN Coil (87-20-18)
- Revised Electric Fuel Pump Testing (87-11-15)
- TFI Stall/No Start - TFI Module Diagnosis/Sealing (87-6-10)
- 2.9L Throttle Plate Icing - Modify Air Induction SYS (87-2-31)
- New Distributor Drive Gear Removal Tool (87-2-18)
- Fuel Stabilizer During Extended Vehicle Storage (86-13-20)
- Infotainment
- Interior/Exterior Trim
- Frame - Rivet Replacement With Bolts - Service Tips (97-4-7)
- Noise At Running Board - Incorrectly Installed (95-8-6)
- Treating Cosmetic Paint Damage From AIRBORN Material (89-13-3)
- Manual Vent Windows - Glass Sticks To Weatherstrip (88-14-1)
- Adhesive BODYSIDE Mouldings & Nameplates Replacement (88-10-4)
- Surface Rust On Chassis Components:Removal Procedure (88-6-6)
- Improved Lower Sound Insulator Panels Availability (87-21-1)
- Door Glass Run/Extension Wind Noise - Foam Tape (87-10-16)
- Interior Trim: Recommended Clean-Up Tips (87-2-3)
- Interior/Illumination Lights
- Locking Hubs
- Lubrication System
- Nylon Fuel Line Service (92-12-16)
- Adhesives & Sealants - Availability & Usage (89-12-2)
- Oil Consumption Information (89-9-10)
- 2.9L EFI Water Entry Through Air Intake - New Intake (89-6-17)
- Revised Electric Fuel Pump Testing (87-11-15)
- Reading Oil Dipstick Fill Marks/Proper Oil Filling (87-9-5)
- Fuel Stabilizer During Extended Vehicle Storage (86-13-20)
- Approved Adhesives & Sealants For Eng/Trans/Steering (89-6T-7)
- Normal Oil Consumption Information (89-5T-13)
- Manual Steering
- Manual Trans
- Adhesives & Sealants - Availability & Usage (89-12-2)
- M/T Fluid Usage/Drivetrain Lubrication Charts (89-8-16)
- Manual Transmissions Hard To Shift Cold - REPL Fluid (88-22-8)
- Driveline Clank/Ratchet In Reverse - New Driveshaft (88-2-15)
- Transmission Fluid Leak - Smooth Mounting/New Gasket (87-25-12)
- Rear Axle Fluid Leak - New Axle Reseal Procedure (87-7-25)
- 7.5" Rear Axle With Driveline Vibration And Boom (89-5T-24)
- Approved Adhesives & Sealants For Eng/Trans/Steering (89-6T-7)
- Vibes/Shudder Accelerating - Excess Driveshaft Angle (89-7T-30)
- Mechanical
- Internal Engine Damage: Water Entry Thru Air Intake (94-3-8)
- Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
- 2.9L Eng Rocker Cover Oil Leak - New Rocker Covers (93-6-12)
- Nylon Fuel Line Service (92-12-16)
- New Idle Air By-Pass Kit & ECA Relearn Procedure (91-7-4)
- Poor Cold Start/Idle/Run - Fuel Recommendations (91-8-13)
- Hard Start - Revised DURASPARK II Ignition Module (90-1-5)
- 2.9L Eng CYL Head Replacement - Modified Alt Bracket (89-10T-25)
- Adhesives & Sealants - Availability & Usage (89-12-2)
- Oil Consumption Information (89-9-10)
- 2.9L EFI Water Entry Through Air Intake - New Intake (89-6-17)
- Oil Dipstick Level Markings Unclear - Reading Marks (88-8-9)
- Revised Electric Fuel Pump Testing (87-11-15)
- 2.9L Throttle Plate Icing - Modify Air Induction SYS (87-2-31)
- Fuel Stabilizer During Extended Vehicle Storage (86-13-20)
- Aluminum Oil Pan Drain Plug HELI-Coil Repair Info (86-24-15)
- Approved Adhesives & Sealants For Eng/Trans/Steering (89-6T-7)
- Knock Noise From Engine - Slave Cylinder Rattling (86-22-20)
- Normal Oil Consumption Information (89-5T-13)
- Mechanical - Air
- Mechanical - Hydraulic
- Wheels - Proper Lug Torque Procedures - Service Tip (98-5A-4)
- On-Vehicle Caliper Mounted Brake Rotor Machining EQP (94-25-2)
- Brakes Bind/Grab/Stick - New Caliper Guide Pins (93-11-7)
- Rubber Brake Hose Sweating - Leak Test Procedure (91-18-9)
- Occasional Or Intermittent Brake Squeal - Normal (90-22-6)
- Brake Shudder/Rotor Damage - Torque LUGNUTS Manually (90-19-9)
- Asbestos Brake & Clutch Warnings (83-22-1)
- Groaning/Grind Noise From Front During Light Braking (87-23-11)
- Rattle Noise From Front - New Design Caliper Pins (88-13-7)
- Rear Brake Squeal - New Brake Pads (89-20-10)
- Mirrors
- Overdrive Unit
- Paint & Coatings
- Urethane Mounted Glass Material Usage Procedure (95-12-1)
- Paint Iron Particle Removal/Acid Rain Neutralization (95-6-1)
- Primed Sheet Metal Prep Procedure & MSDS Information (94-23-4)
- Exterior CLEARCOAT MICROCHECKING, Hazing Or Peeling (93-8-4)
- Exterior Paint Comprehensive Repair Procedures (91-18-1)
- Lower Body Stone Protection Repair Tips (90-15-3)
- Treating Cosmetic Paint Damage From AIRBORN Material (89-13-3)
- Stronger Adhesive Vinyl Tape Stripes Availability (87-24-3)
- Difficulty Matching Production Paint Colors (87-15-1)
- Surface Rust On Chassis Components:Removal Procedure (88-6-6)
- Headliner Wind Noise - Roof To A-Pillar Joint Sealer (87-10-17)
- Passive Restraints
- Procedures
- Rear Suspension
- Seats
- Sleeper
- Solar Ventilation
- Starter
- New Idle Air By-Pass Kit & ECA Relearn Procedure (91-7-4)
- No Crank - Low State Of Battery Charge (91-10-8)
- No Start/Low Battery/Fuel Pump Noise - Pump Relay (90-18-3)
- Hard Start - Revised DURASPARK II Ignition Module (90-1-5)
- Revised Electric Fuel Pump Testing (87-11-15)
- Fuel Stabilizer During Extended Vehicle Storage (86-13-20)
- Steering Column
- Steering Column Switches
- Steering Control Systems
- Steering Gear
- Steering Linkage
- Sun Roof/T-Top/Convertible Top
- Treating Cosmetic Paint Damage From AIRBORN Material (89-13-3)
- Stronger Adhesive Vinyl Tape Stripes Availability (87-24-3)
- Manual Vent Windows - Glass Sticks To Weatherstrip (88-14-1)
- Surface Rust On Chassis Components:Removal Procedure (88-6-6)
- Manual Vent Windows Stuck - Pressure Sensitive Tape (88-5-2)
- Sound Distortion From ETR Radio: Rework Wire Harness (87-3-4)
- Door Glass Flutters/Slaps W/ Window Partially Opened (89-4-9)
- Suspension Control Systems
- System
- CALIFORNIA Reformulated Gasoline - Service Tip (96-10-7)
- MOTORCRAFT Fuel Injector Cleaning System (94-8-9)
- Internal Engine Damage: Water Entry Thru Air Intake (94-3-8)
- Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
- EXH Gas Oxygen Sensor Silicone Sealer Contamination (93-23-6)
- Nylon Fuel Line Service (92-12-16)
- New Idle Air By-Pass Kit & ECA Relearn Procedure (91-7-4)
- Fuel Injectors Clogged - New Fuel Injector Cleaning (91-19-3)
- No Crank - Low State Of Battery Charge (91-10-8)
- Poor Cold Start/Idle/Run - Fuel Recommendations (91-8-13)
- Electronic Control Modules - Damage From Arc Welding (91-7-5)
- No Start/Low Battery/Fuel Pump Noise - Pump Relay (90-18-3)
- Hard Start - Revised DURASPARK II Ignition Module (90-1-5)
- Rough Idle - Air By Pass Valve Replacement Part (89-24-4)
- Emission Maintenance Warning Module - Information (89-22-8)
- TPS Service Replacement Chart (89-16-4)
- Throttle Position Sensor Screw Removal (89-14-7)
- Adhesives & Sealants - Availability & Usage (89-12-2)
- Distributor Gear Matched To Distributor At Assembly (89-6-11)
- EEC IV Eng & 2.3L/2.5L HSC CFI Map/Bap Sensor Applications Chart (89-1-12)
- Hard/No Start - TFI Module Connection (88-20-9)
- Electronic Modules - Damage From Static Electricity (88-13-3)
- TFI Module/Pip Sensor New EEC-IV Testing (87-21-10)
- 2.0/2.3/2.5/3.0/3.8/5.0/5.8L Eng Short IGN Coil (87-20-18)
- CFI Fuel Injector Contamination - Replace Injector (87-17-5)
- EFI Rough Idle/Injector Terminals Loose - Diagnosis (87-13-6)
- ECM Processor Warranty Decal Information (87-11-13)
- Revised Electric Fuel Pump Testing (87-11-15)
- TFI Stall/No Start - TFI Module Diagnosis/Sealing (87-6-10)
- Fuel Line Spring Lock Coupling R & R (87-3-8)
- 2.9L Throttle Plate Icing - Modify Air Induction SYS (87-2-31)
- New Distributor Drive Gear Removal Tool (87-2-18)
- Wiring System Testing Caution - Modify Probe Tips (87-2-5)
- Fuel Stabilizer During Extended Vehicle Storage (86-13-20)
- 2.3/2.5L Eng New Map/Bap Sensor Application Table (89-1T-19)
- Approved Adhesives & Sealants For Eng/Trans/Steering (89-6T-7)
- EMW/IMS Warning Module Definition Location (89-11T-20)
- Throttle Position Sensor POZIDRIVE Mount Screw Info (89-7T-9)
- Towing
- Transfer Case
- 4WD Automatic HUBLOCK Information - Service Tip (95-5-18)
- Transfer Case Shift Motor Binds At Neck (87-24-15)
- 4X4 General Info, Operating Characteristics & Tips (92-1-8)
- Adhesives & Sealants - Availability & Usage (89-12-2)
- Driveline Clank/Ratchet In Reverse - New Driveshaft (88-2-15)
- Rear Axle Fluid Leak - New Axle Reseal Procedure (87-7-25)
- A4LD Trans Leaks/Burnt Fluid/Eng Stall/Erratic Shift (87-2-15)
- Transfer Case Leaks At Input Shaft (87-2-29)
- Dummy Transfer Case On 4X2 Vehicles (86-20-14)
- 7.5" Rear Axle With Driveline Vibration And Boom (89-5T-24)
- Vibes/Shudder Accelerating - Excess Driveshaft Angle (89-7T-30)
- Transmission Control Systems
- Vacuum Pumps/Lines/Tanks/Water Trap
- Wheel Alignment
- Wheel Hubs
- Wheels & Tire System
- Wheels - Proper Lug Torque Procedures - Service Tip (98-5A-4)
- Tire Company Phone Numbers For Customer Assistance (98-5-2)
- Brake Shudder/Rotor Damage - Torque LUGNUTS Manually (90-19-9)
- Front Tire Wear - Rotate Tires And Check Alignment (86-24-27)
- Steering Pull/Drift New Align Adjusters (89-9T-22)
- Tire Wear - Load/Tire Inflation Information (89-5T-20)
- Window Motors & Regulators
- Windshield And Interior Glass - Fog/Film (96-22-1)
- Urethane Mounted Glass Material Usage Procedure (95-12-1)
- "Iridescence" Or "Mottling" In Tempered Glass (93-21-1)
- Cracks At Swing-Away Spare Tire: New Assembly (88-20-11)
- Stronger Adhesive Vinyl Tape Stripes Availability (87-24-3)
- Manual Vent Windows - Glass Sticks To Weatherstrip (88-14-1)
- Power Door Locks Inoperative - Rod Retainer Clip (88-7-1)
- Manual Vent Windows Stuck - Pressure Sensitive Tape (88-5-2)
- Sound Distortion From ETR Radio: Rework Wire Harness (87-3-4)
- Door Glass Run/Extension Wind Noise - Foam Tape (87-10-16)
- Door Glass Flutters/Slaps W/ Window Partially Opened (89-4-9)
- Revised Windshield Installation Procedures (89-6T-4)
- Wiper/Washer Systems
- Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)
- Wiring - Wire Harness Terminal Repair Kit (99-6-3)
- Electrical - New Terminal Grease For Service (98-24-6)
- Electrical Diode Identification And Replacements (96-24-6)
- Generator Harness Connector Damage - Loose Contact (96-21-4)
- Cruise Control Won't Work When Wet - New Connector (92-7-8)
- No Crank - Low State Of Battery Charge (91-10-8)
- Wire Harness Terminal & Connector Service Kit (89-19-5)
- Inaccurate Speedo Readings - Mechanical & Electronic (89-2-7)
- New Micro-Pin Terminal Connectors Locking/Unlocking (87-7-7)
- Wiring System Diagnosis Cautions (87-4-8)
- Engine Compartment - Use Waterproof Wire Connectors (87-2-6)
- Wiring Diagram Symbols Explanation (85-11-5)