Repair and Diagnosis (Single Page)
You are viewing the full "tree" of links on one page. This can load slowly, but is easier to search. The same page can appear multiple times under a different folder, that is why the page is so large.View "split tree" where inner folders are split out. where inner links are on separate pages.
Quick Lookups
Electrical Component Locations
Fluids
Technical Bulletins
Tire Fitment
Wiring Diagrams
- Accessories & Equipment
- Anti-Theft Systems
- Door Locks & Tailgate Locks - Power
- Description & Operation
- Trouble Shooting
- Testing
- Removal & Installation
- Door Lock Actuator Motor
- Door Lock Switch
- Removal & Installation (Continental)
- Removal & Installation (Cougar & Thunderbird)
- Removal & Installation (Crown Victoria & Grand Marquis)
- Removal & Installation (Mark VII)
- Removal & Installation (Mustang)
- Removal & Installation (Sable & Taurus)
- Removal & Installation (Tempo & Topaz)
- Removal & Installation (Town Car Master Switch)
- Wiring Diagrams
- Keyless Entry System
- Liftgate, Tailgate & Trunk Release
- Door Locks & Tailgate Locks - Power
- Cruise Control Systems
- Cruise Control System - EEC Controlled W/O Amplifier
- Diagnosis
- Testing
- Electronic Instrument Cluster
- Notes
- Quick Test
- Visual Check and Vehicle Preparation
- Equipment Hookup (Using STAR tester 007-00019 or 007-00017 or equivalent.
- Using Analog Voltmeter 059-00010 or equivalent.
- Quick Test Self-Test
- Key On, Engine Off Test
- Key On, Engine Running Test
- Service Codes
- Reading Codes - Analog Voltmeter
- Reading Codes - Rotunda Self-Test Automatic Readout (STAR) Tester 007-00017, or Super STAR Tester 007-00019 or Equivalent
- Quick Test: Key On, Engine Off (KOEO) Self Test
- Quick Test: Key On, Engine Running (KOER) Self Test
- Using Pinpoint Test
- Diagnostic By Symptom
- Pinpoint Test A - Speed Control Switches
- Pinpoint Test B - Brake On/Off (Boo)
- Pinpoint Test C - Servo Solenoids Service Code 81 Or Service Codes 81 & 82
- Pinpoint Test D - Speed Does Not Increase During Dynamic Test
- Pinpoint Test E - Does Not Hold Speed During Dynamic Test
- Pinpoint Test F - Speed Does Not Decrease During Dynamic Test
- Pinpoint Test G - Speed Sensor
- Pinpoint Test Q - No Codes, Codes Not Listed
- Electronic Instrument Cluster
- Cruise Control System - EEC Controlled W/O Amplifier
- Exterior Lights
- Gauges & Instrument Panels
- Instrument Panel - Electronic
- Description & Operation
- Testing
- Trouble Shooting
- Notes
- Display Partially Lit Or Completely Black
- Cluster Too Dim
- Display Scrambled, Segments Half Illuminated (Ghost Segments), Segments Blinking Or Missing, Display Incorrect All The Time, Display Stuck With All Segments On
- Cluster Will Not Dim
- Temperature Gauge Display Blanks Out Thermometer Symbol & Lights Top 2 & Bottom 2 Bars Of Gauge
- No Warning Tone When Thermometer Symbol Is Blinking
- Temp Gauge Always Indicates Cold (Bottom Bar Illuminated)
- Display Does Not Respond To Buttons
- Speedometer Reads 0 Mph At All Speeds With Vehicle In Motion
- Speedometer Reads Constantly Too High Or Low
- Speed Indication Jumps Up & Down Erratically
- Odometer Display Reads "Error" & Service Symbol Is On
- Display Has "S" Illuminated
- Odometer Does Not Accumulate Mileage, Or Counts 10 Miles & Jumps Back 10 Miles
- Odometer Reading Incorrect
- Mileage Constantly Reads Too High Or Low
- Tach Always Indicates Too High Or Too Low - No Tach Indication/Tach Indication Erratic
- Instant Fuel Economy Always Reads 0 Miles/Gal Or 99 Miles/Gas
- Trip Distance Does Not Accumulate
- Distance To Empty Does Not Go Below 200 Miles W/Empty Tank
- Co Displayed, Gauge Blanks Out Fuel Tank Symbol & Lights Up Top 2 & Bottom 2 Bars Of Gauge
- Cs Displayed, Gauge Blanks Out Fuel Tank Symbol & Lights Up Top 2 & Bottom 2 Bars Of Gauge
- Inaccurate Fuel Indication, Full Not Indicated When Tank Is Full, Empty Not Indicated When Tank Is Empty
- Door Ajar Warning Never/Always Comes On
- Washer Fluid Never Illuminates Or Illuminated At All Times
- Low Oil Level Warning Is Always On
- Removal & Installation
- Instrument Panel - Standard
- Description & Operation
- Testing
- Removal & Installation
- Wiring Diagrams
- Instrument Panel - Electronic
- Heated Glass/Defoggers
- Defogger - Rear Window
- Description & Operation
- Trouble Shooting
- Testing
- Removal & Installation
- Control Assembly
- Removal & Installation (Continental)
- Removal & Installation (Crown Victoria, Grand Marquis & Town Car)
- Removal & Installation (Cougar & Thunderbird)
- Removal & Installation (Escort & Mark VII)
- Removal & Installation (Mustang)
- Removal & Installation (Probe)
- Removal & Installation (Sable & Taurus)
- Removal & Installation (Tempo & Topaz)
- Timer Relay
- Control Assembly
- Wiring Diagrams
- Windshield - Heated
- Description & Operation
- Trouble Shooting
- Testing
- Removal & Installation
- Wiring Diagrams
- Defogger - Rear Window
- Infotainment
- Seats - Power
- Steering Column Switches
- Window Motors & Regulators
- Power Windows
- Description & Operation
- Testing
- Window Motor
- Window Switches
- Master Switch (1990-91 Crown Victoria, Grand Marquis & Town Car)
- Single Switch (Crown Victoria, Grand Marquis & Town Car)
- Master Switch (Mustang, Sable, Taurus, Tempo & Topaz)
- Single Switch (Mark VII, Mustang, Sable, Taurus, Tempo & Topaz)
- Master Switch (Cougar & Thunderbird)
- Single Switch (Cougar & Thunderbird)
- Master Switch (Continental)
- Single Switch (Continental)
- Removal & Installation
- Wiring Diagrams
- Power Windows
- Wiper/Washer Systems
- Anti-Theft Systems
- Body & Frame
- Door Locks
- Door Locks & Tailgate Locks - Power
- Description & Operation
- Trouble Shooting
- Testing
- Removal & Installation
- Door Lock Actuator Motor
- Door Lock Switch
- Removal & Installation (Continental)
- Removal & Installation (Cougar & Thunderbird)
- Removal & Installation (Crown Victoria & Grand Marquis)
- Removal & Installation (Mark VII)
- Removal & Installation (Mustang)
- Removal & Installation (Sable & Taurus)
- Removal & Installation (Tempo & Topaz)
- Removal & Installation (Town Car Master Switch)
- Wiring Diagrams
- Keyless Entry System
- Liftgate, Tailgate & Trunk Release
- Door Locks & Tailgate Locks - Power
- Seats - Power
- Sun Roof/T-Top/Convertible Top
- Power Windows
- Description & Operation
- Testing
- Window Motor
- Window Switches
- Master Switch (1990-91 Crown Victoria, Grand Marquis & Town Car)
- Single Switch (Crown Victoria, Grand Marquis & Town Car)
- Master Switch (Mustang, Sable, Taurus, Tempo & Topaz)
- Single Switch (Mark VII, Mustang, Sable, Taurus, Tempo & Topaz)
- Master Switch (Cougar & Thunderbird)
- Single Switch (Cougar & Thunderbird)
- Master Switch (Continental)
- Single Switch (Continental)
- Removal & Installation
- Wiring Diagrams
- Door Locks
- Brakes
- Anti-Lock Brakes
- Anti-Lock Brake System
- Anti-Lock Brake Safety Precautions
- Description
- Operation
- Component Locations
- Bleeding Brake System
- Trouble Shooting
- Diagnosis
- Diagnostic Tests Using Warning Light Symptom Chart
- Notes
- Pinpoint Test A - Anti-Lock Light On With Brake Light Off
- Pinpoint Test B - Anti-Lock Light On After Engine Starts With Brake Light Off
- Pinpoint Test C - Anti-Lock Light On While Driving Or Cycling Of Anti-Lock System
- Pinpoint Test D - Excessive Pedal Rise Or Drop During Abs Cycle
- Pinpoint Test E - Abs Pump Runs Continuously
- Pinpoint Test F - Brake Light On
- Pinpoint Test G - Anti-Lock Light Not On When Ignition Is On
- Pinpoint Test H - Spongy Brake Pedal, No Warning Light With/Without Anti-Lock Function
- Pinpoint Test J - Poor Vehicle Tracking During Anti-Lock Function, Light Off
- On-Board Self-Tests
- Removal & Installation
- Adjustments
- Torque Specifications
- Wiring Diagrams 1990-92
- Wiring Diagrams 1993
- Anti-Lock Brake System
- Mechanical - Hydraulic
- Brake System Bleeding
- Disc & Drum
- Description
- Brake System Bleeding
- Adjustments
- Brake Booster Push Rod - Except Probe
- Brake Booster Push Rod - Probe
- Brake Pressure Control Valve - Sable & TAURUS
- Drum Brake Shoes
- Front Wheel Bearings - Fwd Models
- Front Wheel Bearings - RWD Except Cougar & THUNDERBIRD
- Front Wheel Bearings - Cougar & THUNDERBIRD
- Parking Brake - W/Rear Disc Brakes
- Parking Brake - W/Rear Drum Brakes
- Rear Caliper Piston Position - Mark VII
- Rear Caliper - Mark VII
- Vacuum Parking Brake Release
- Rotor Servicing
- Cleaning & Inspection
- Removal & Installation
- Brake Booster - Escort, Tempo & Topaz
- Brake Booster - Cougar, Mustang 5.0L & THUNDERBIRD
- Brake Booster - Mustang 2.3L
- Brake Booster - Crown Victoria, Grand Marquis & Town Car
- Brake Booster - Probe
- Brake Booster - TAURUS & Sable
- Disc Brake Caliper & Pads - Front
- Disc Brake Caliper & Pads - Rear (Except Mark VII & Probe)
- Disc Brake Caliper & Pads - Rear (Mark VII)
- Disc Brake Caliper & Pads - Rear (Probe)
- Disc Brake Rotor - Front
- Disc Brake Rotor - Rear
- Drum Brake Shoe & Linings - RWD Models
- Drum Brake Shoe & Linings - Fwd Models Except Probe
- Drum Brake Shoe & Linings - Probe
- Master Cylinder
- Overhaul
- Torque Specifications
- Brake System Specifications
- Traction Control
- Anti-Lock Brake System
- Anti-Lock Brake Safety Precautions
- Description
- Operation
- Component Locations
- Bleeding Brake System
- Trouble Shooting
- Diagnosis
- Diagnostic Tests Using Warning Light Symptom Chart
- Notes
- Pinpoint Test A - Anti-Lock Light On With Brake Light Off
- Pinpoint Test B - Anti-Lock Light On After Engine Starts With Brake Light Off
- Pinpoint Test C - Anti-Lock Light On While Driving Or Cycling Of Anti-Lock System
- Pinpoint Test D - Excessive Pedal Rise Or Drop During Abs Cycle
- Pinpoint Test E - Abs Pump Runs Continuously
- Pinpoint Test F - Brake Light On
- Pinpoint Test G - Anti-Lock Light Not On When Ignition Is On
- Pinpoint Test H - Spongy Brake Pedal, No Warning Light With/Without Anti-Lock Function
- Pinpoint Test J - Poor Vehicle Tracking During Anti-Lock Function, Light Off
- On-Board Self-Tests
- Removal & Installation
- Adjustments
- Torque Specifications
- Wiring Diagrams 1990-92
- Wiring Diagrams 1993
- Anti-Lock Brake System
- Anti-Lock Brakes
- Drivelines & Axles
- Electrical
- Charging Systems
- Component Locations
- Fuses & Circuit Breakers
- Fuses & Circuit Breakers
- Notes
- Fuses & Circuit Breakers
- 1 - 15 Amp
- 2 - 8.25 Amp (Circuit Breaker)
- 4 - 20 Amp (1993-94) 15 Amp (1986-92)
- 5 - 15 Amp
- 6 - 15 Amp
- 7 - 15 Amp
- 8 - 15 Amp
- 9 - 30 Amp
- 10 - 20 Amp
- 11 - 20 Amp
- 12 - 20 Amp (Circuit Breaker)
- 13 - 5 Amp
- 14 - (Blank 1993-94), 20 Amp (Circuit Breaker) 1986-92
- 15 - 10 Amp
- 16 - 5 Amp
- 17 - 15 Amp
- 18 - 10 Amp
- 1 - 10 Amp
- 2 - 10 Amp
- 3 - 40 Amp
- 4 - 40 Amp
- 5 - 40 Amp
- 6 - 30 Amp
- 7 - 60 Amp
- 8 - 40 Amp
- 9 - 60 Amp
- 10 - 30 Amp
- 11 - 60 Amp
- 12 - 60 Amp
- Fuses & Circuit Breakers
- Gauges
- Instrument Panel - Electronic
- Description & Operation
- Testing
- Trouble Shooting
- Notes
- Display Partially Lit Or Completely Black
- Cluster Too Dim
- Display Scrambled, Segments Half Illuminated (Ghost Segments), Segments Blinking Or Missing, Display Incorrect All The Time, Display Stuck With All Segments On
- Cluster Will Not Dim
- Temperature Gauge Display Blanks Out Thermometer Symbol & Lights Top 2 & Bottom 2 Bars Of Gauge
- No Warning Tone When Thermometer Symbol Is Blinking
- Temp Gauge Always Indicates Cold (Bottom Bar Illuminated)
- Display Does Not Respond To Buttons
- Speedometer Reads 0 Mph At All Speeds With Vehicle In Motion
- Speedometer Reads Constantly Too High Or Low
- Speed Indication Jumps Up & Down Erratically
- Odometer Display Reads "Error" & Service Symbol Is On
- Display Has "S" Illuminated
- Odometer Does Not Accumulate Mileage, Or Counts 10 Miles & Jumps Back 10 Miles
- Odometer Reading Incorrect
- Mileage Constantly Reads Too High Or Low
- Tach Always Indicates Too High Or Too Low - No Tach Indication/Tach Indication Erratic
- Instant Fuel Economy Always Reads 0 Miles/Gal Or 99 Miles/Gas
- Trip Distance Does Not Accumulate
- Distance To Empty Does Not Go Below 200 Miles W/Empty Tank
- Co Displayed, Gauge Blanks Out Fuel Tank Symbol & Lights Up Top 2 & Bottom 2 Bars Of Gauge
- Cs Displayed, Gauge Blanks Out Fuel Tank Symbol & Lights Up Top 2 & Bottom 2 Bars Of Gauge
- Inaccurate Fuel Indication, Full Not Indicated When Tank Is Full, Empty Not Indicated When Tank Is Empty
- Door Ajar Warning Never/Always Comes On
- Washer Fluid Never Illuminates Or Illuminated At All Times
- Low Oil Level Warning Is Always On
- Removal & Installation
- Instrument Panel - Standard
- Description & Operation
- Testing
- Removal & Installation
- Wiring Diagrams
- Instrument Panel - Electronic
- Starter
- Wiring Diagrams
- Engine Mechanical
- Accessory Drive Belts
- Drive Belt Routing
- Description
- Belt Adjustment
- Drive Belt Routing
- Notes
- Drive Belt Routing (Continental 3.8L (With A/C))
- Drive Belt Routing (Cougar & THUNDERBIRD 3.8L (With A/C))
- Drive Belt Routing (Mark VII 5.0L (With A/C))
- Drive Belt Routing (Mustang 2.3L OHC (Without A/C))
- Drive Belt Routing (Mustang 2.3L OHC (With A/C))
- Drive Belt Routing (Mustang 5.0L (With A/C))
- Drive Belt Routing (Probe 3.0L)
- Drive Belt Routing (Sable & TAURUS 3.0L (With A/C))
- Drive Belt Routing (Sable & TAURUS 3.8L (With A/C))
- Drive Belt Routing (TAURUS 2.5L (With A/C))
- Drive Belt Routing (TAURUS 3.0L SHO (With A/C))
- Drive Belt Routing (Tempo & Topaz 2.3L OHC (With A/C))
- Drive Belt Routing 5.0L & 5.8L Engine (Except Mark VII & Mustang)
- Drive Belt Routing
- Engine Cooling Fan
- Cooling System (Mechanical)
- Cooling System Specifications
- Drive Belt Routing
- Description
- Belt Adjustment
- Drive Belt Routing
- Notes
- Drive Belt Routing (Continental 3.8L (With A/C))
- Drive Belt Routing (Cougar & THUNDERBIRD 3.8L (With A/C))
- Drive Belt Routing (Mark VII 5.0L (With A/C))
- Drive Belt Routing (Mustang 2.3L OHC (Without A/C))
- Drive Belt Routing (Mustang 2.3L OHC (With A/C))
- Drive Belt Routing (Mustang 5.0L (With A/C))
- Drive Belt Routing (Probe 3.0L)
- Drive Belt Routing (Sable & TAURUS 3.0L (With A/C))
- Drive Belt Routing (Sable & TAURUS 3.8L (With A/C))
- Drive Belt Routing (TAURUS 2.5L (With A/C))
- Drive Belt Routing (TAURUS 3.0L SHO (With A/C))
- Drive Belt Routing (Tempo & Topaz 2.3L OHC (With A/C))
- Drive Belt Routing 5.0L & 5.8L Engine (Except Mark VII & Mustang)
- Water Pump Removal - 3.0L SHO V6
- Mechanical
- 3.0L V6 - VIN [U]
- Engine Identification
- Adjustments
- Removal & Installation
- Fuel Pressure Release
- Engine
- Intake Manifold
- Exhaust Manifold
- Cylinder Head
- Collapsed Lifter Clearance
- Front Cover Oil Seal
- Front Timing Cover
- Timing Chain
- Camshaft
- Rear Crankshaft Oil Seal
- Water Pump
- Oil Pan
- Valve Springs
- Valve Stem Oil Seals
- Valve Guides
- Valve Seats
- Seat Correction Angles
- Valves
- Cylinder Block Assembly
- Piston & Rod Assembly
- Piston Rings
- Fitting Pistons
- Crankshaft & Bearings
- Crankshaft Thrust Bearing
- Lubrication
- Torque Specifications
- Engine Specifications
- 3.0L V6 SHO - VIN [Y]
- Engine Identification
- Adjustments
- Removal & Installation
- Fuel Pressure Release & Fuel Line Connections
- Engine
- Intake Manifold
- Exhaust Manifold
- Valve Covers
- Cylinder Head R & I
- Crankshaft Front Oil Seal
- Timing Belt
- Camshaft Seals
- Camshaft
- Valve Lifter
- Rear Crankshaft Oil Seal
- Water Pump
- Oil Pan
- Valve Springs
- Valve Stem Oil Seals
- Valve Guides
- Valve Seat
- Valves
- Seat Correction Angles
- Overhaul
- Lubrication
- Torque Specifications
- Engine Specifications
- Engine Oil Pan Removal
- Engine Removal
- 3.0L V6 - VIN [U]
- Starter
- Timing Belt Replacement - 3.0L & 3.2L - SHO
- Accessory Drive Belts
- Engine Performance
- Adjustment
- Application
- Emissions
- Calibration Labels
- EGR Function Testing - Ford - Cars
- Emission Applications
- Emission Control Abbreviations
- State Emission Standards - Diesel
- State Emission Standards - Gas
- ALASKA
- ARIZONA
- CALIFORNIA
- Colorado
- CONNECTICUT
- DELAWARE
- District Of COLUMBIA
- GEORGIA
- IDAHO
- ILLINOIS
- INDIANA
- KENTUCKY
- MARYLAND
- MASSACHUSETTS
- MISSOURI
- NEVADA
- New Jersey
- New MEXICO
- New YORK
- North CAROLINA
- OHIO
- OREGON
- PENNSYLVANIA
- RHODE Island
- TENNESSEE
- TEXAS
- UTAH
- VIRGINIA
- WASHINGTON
- WISCONSIN
- U. S. EPA ASM2525 & ASM5015 Start-Up Emission Standards
- U. S. EPA Revised Final ASM Emission Standards (ASM5015 & ASM2525)
- U.S. EPA Im240 Emission Standards
- Pin Voltage Charts
- Remove, Overhaul & Install
- Engine Controls - Remove/Install/Overhaul
- Introduction
- Crankshaft Timing Sensor R & I
- Camshaft Sensor Assembly R & I
- Synchronizer Assembly
- Distributor R & I
- Distributor Overhaul
- Oxygen Sensor R & I Precautions
- Fuel System Pressure Release
- Fuel Line Connector R & I
- Upper Intake Manifold R & I - 3.0L SHO
- Upper Intake Manifold R & I - 3.8L
- Fuel Rail R & I - 3.0L SHO & 3.8L
- Fuel Rail R & I - 3.0L Exc. SHO
- Fuel Rail R & I - 3.8L SC PFI (Supercharged)
- Injector R & I - Port Fuel Injection (PFI) Systems
- Injector R & I - Throttle Body Injection (TBI) Systems
- 2.5L TBI Fuel Assembly R & I, & Overhaul
- 3.0L PFI Throttle Body Assembly R & I
- 3.8L SC PFI Throttle Body Assembly R & I
- 3.8L PFI Throttle Body Assembly R & I
- Fuel Pressure Regulator R & I - PFI Engines
- Fuel Pressure Regulator R & I - TBI Engines
- Throttle Position Sensor (TPS) R & I - All Models
- INTERCOOLER R & I - 3.8L SC PFI
- INTERCOOLER Inlet & Outlet Tubes - 3.8L SC PFI
- Supercharger R & I - 3.8L SC PFI
- Fuel Pump R & I
- Torque Specifications
- Engine Controls - Remove/Install/Overhaul
- Sensor Range Charts
- Specifications
- Engine Controls - Specifications - 4-CYL
- Introduction
- Battery Specifications
- Fluid Capacities
- Service Intervals & Specifications
- Drive Belt Adjustment
- Engine Compression
- Ignition System Specifications
- Spark Plug Specifications
- Firing Order & Timing Marks
- Ignition Timing
- Distributor Specifications
- Fuel Pump Specifications
- Idle Speed & Mixture
- Throttle Position Sensor/Switch
- Engine Controls - Specifications - V6
- Introduction
- Battery Specifications
- Fluid Capacities
- Drive Belt Adjustment
- Engine Compression
- Valve Clearance
- Valve Arrangement (3.0L SHO)
- Ignition System
- Spark Plug Specifications
- Firing Order & Timing Marks
- Firing Order & Timing Marks (3.0L)
- Firing Order & Timing Marks (3.0L SHO)
- Spark Plug Wire Routing (3.0L SHO)
- Firing Order & Timing Marks (3.8L - Continental)
- Firing Order & Timing Marks (3.8L Cougar & THUNDERBIRD)
- Firing Order & Timing Marks (3.8L THUNDERBIRD Supercharged)
- Spark Plug Wire Routing (3.8L THUNDERBIRD Supercharged)
- Ignition Timing
- Fuel Pump Specifications
- Fuel Pressure Specifications
- Engine Controls - Specifications - 4-CYL
- System
- EGR Function Testing
- Engine Controls - Basic Testing
- Introduction
- Preliminary Inspection & Adjustments
- Fuel System
- Fuel Pressure Check
- DURASPARK II Ignition System Check
- Thick Film Ignition (TFI) System Check
- DISTRIBUTORLESS Ignition System (Dis) Checks
- Ignition Coil Resistance
- Idle Speed & Ignition Timing
- 4-Cylinder Ignition Timing Specifications
- 4-Cylinder Idle Speed Specifications
- V6 Ignition Timing Specifications
- V6 Idle Speed Specifications
- V8 Ignition Timing Specifications
- V8 Idle Speed Specifications
- Idle Mixture Adjustment
- Throttle Position Sensor (TPS) Adjustment
- Supercharger (THUNDERBIRD & Cougar)
- Summary
- Engine Controls - System/Component Tests - EEC-IV
- Introduction
- Supercharger Check
- Turbocharger Check
- Variable Induction Systems Check
- Engine Control Unit (Ecu) Tests
- Air Charge Temperature (Act) Sensor Test
- Barometric Pressure Sensor Test (2.2L Probe)
- Crankshaft Position Sensor (Cps) Test
- Cylinder Id Sensors Test (2.2L Probe Turbo Only)
- Engine Coolant Temperature (ECT) Sensor Test
- EVP Sensor Test (2.2L Probe CALIF. Only)
- Heated Gas Oxygen (HEGO) Sensor Test
- Inertia Switch Test
- Knock Sensor Test (Except 2.2L Probe Turbo)
- Knock Sensor Test (2.2L Probe Turbo)
- Map/BP Sensor Test
- Mass Airflow (Ma) Sensor Test
- Neutral Drive Switch (NDS) A/C Input Test
- Power Steering Pressure Switch (PSPS) Test
- Throttle Position Sensor Test (2.2L Probe)
- TCS Sensor Test (2.2L Probe)
- Vat Sensor Test (2.2L Probe)
- Vane Air Flow Meter Test (2.2L Probe)
- Vehicle Speed Sensor (VSS) Test
- Relay Tests
- Solenoid Tests
- Ignition Module Tests
- Fuel System Tests
- Fuel Control Tests
- Idle Control System Tests
- Electric Choke Tests (5.8L V8 MCU)
- Ignition System Checks
- Timing Control Systems Tests
- Emissions/Sub-Systems Checks - Air Injection
- Air Supply Pump
- Air Silencer/Filter (Air Pump And Pulse Air Inlet)
- Air Bypass Valve (Normally Closed)
- Air Check Valve
- Air Supply Control Valve
- Air Control Valve (Switch-Relief)
- Air Pump Resonator
- Combination Air By-Pass/Air Control Valve
- Dual THERMACTOR Air Control Solenoid Valve
- Solenoid Vacuum Valve Assembly
- THERMACTOR Idle Vacuum (TIV) Valve
- Vacuum Control Valve (VCV)
- Electrical Vacuum Control Valve
- Vacuum Check Valve
- Vacuum Reservoir
- Pulse Air Valve
- Emissions/Sub-Systems Checks - EGR Systems
- Emissions/Sub-Systems Checks - Fuel Evaporation
- Emissions/Sub-Systems Checks - PCV Systems
- Emissions/Sub-Systems Checks - TAC Systems
- Engine Controls - Tests W/Codes - 3.0L
- Introduction
- Diagnostic Formats
- Service Code Descriptions
- Clearing Codes
- Reading Diagnostic Codes
- Quick Test Procedures
- Visual Check & Vehicle Preparation
- Equipment Hook-Up
- KOEO Self-Test
- KOER Self-Test
- Continuous Monitor Mode (Wiggle Test)
- Additional System Functions
- Frequently Used EEC-IV Abbreviations
- Summary
- PFI Service Code Definitions
- KOEO Code/Test Menu - 3.0L
- KOER Code/Test Menu - 3.0L
- Continuous Code/Test Menu - 3.0L
- Circuit Tests
- How To Use Circuit Tests (Tests A To X)
- ECA Sensor Resistance & Pin Voltage Reference Chart
- Test A - TFI & Dis Ignition Systems
- Test Aa - No Start (EDIS Ignition Systems)
- Test B - Checking Vehicle Battery
- Test C - Reference Voltage
- Test DA - Temperature Sensor Test (Act, ECT & Vat)
- Test Dc - Mass Airflow Sensor (MAF)
- Test Dd - EVP Sensor, EGRC Solenoid & EGRV Solenoid
- Test DF - Map/BP Sensors
- Test Dg - Knock Sensor (KS)
- Test DH - Throttle Position Sensor (TPS)
- Test DL - PFE Valve & EVR Solenoid
- Test DN - EVP Sensor & EVR Solenoid
- Test DP - Vehicle Speed Sensor (VSS)
- Test Dr - Cylinder Identification (CID) Sensor
- Test Fa - Neutral Drive Switch (NDS) A/C Input CKT
- Test FD - Brake On/Off Switch (Boo)
- Test Ff - Power Steering Pressure Switch (PSPS)
- Test H - Fuel Control
- Test J - Fuel Pump CKT (Relay & Inertia Switch)
- Test KA - EGR On/Off Control
- Test KD - Canister Purge (CANP)
- Test KE - Idle Speed Control (Air By-Pass)
- Test KF - EDF/HEDF Electric Cooling Fans
- Test KH - Service Pin Adjustment
- Test Kl - Shift Indicator Light (SIL)
- Test Km - WAC & A/C Demand Switch
- Test KP - Octane Adjust
- Test Kt - IAC Valve (IAC) - TAURUS 3.0L SHO PFI Only
- Test M, Code 77 - Dynamic Response Test
- Test Ml, Codes 70, 71 Or 72 - Malfunction Indicator
- Test N - Ignition Diagnostic Monitor (IDM)
- Test P - Spark Timing Check
- Test QA - No Codes/Codes Not Listed
- Test QB, Code 15 - KOEO Or Continuous Memory Code
- Test QC - Output State Check Not Functioning
- Test QD - Re-Initialization Check
- Test S - System Check
- Test T - AXOD Transaxle
- Test Tb - A4LD Transmission
- Test X - Integral Relay Control Module (IRCM)
- Engine Controls - Tests W/O Codes
- Introduction
- DRIVEABILITY Symptom Check Procedures
- Symptom-To-Routine Menu
- Intermittent Problem Diagnosis
- Intermittent Test Procedures
- Routine 200 - No Crank & No Start
- Routine 201 - Cranks Normally But Won't Start
- Routine 202 - Cranks Normally But Won't Run (Stalls)
- ROUTINE 203 - Cranks NORMALLY BUT SLOW TO START
- Routine 204 - Rough Idle
- Routine 205 - Misses Under Load
- Routine 206 - Low Idle (Stalls On DECEL Or Quick Stop)
- Routine 207 - Hesitates Or Stalls On Acceleration
- Routine 208 - Backfire (Intake Or Exhaust)
- Routine 209 - Lack Of Power
- Routine 210 - Surges At Steady Speed
- Routine 212 - Engine Noise
- Routine 213 - Poor Fuel Economy
- Routine 214 - High Oil Consumption
- Routine 215 - Spark Knock (Pings)
- ROUTINE 216 - ENGINE VIBRATES AT NORMAL OR HIGH Speed
- Routine 217 - Engine Runs Cold
- Routine 218 - Engine Runs Hot
- ROUTINE 219 - Exhaust SMOKE
- Routine 220 - Gas Smell
- Routine 221 - "Check Eng/SERV Soon" Always/Never On
- Routine 222 - State Emission Test Failure
- ROUTINE 223 - IMPROPER Shift
- Routine 224 - SIL & Audible Chimes "On"
- Glow Plug Testing
- 1.9L Symptom-To-Diagnostic Flow Chart Menu
- 2.3L Symptom-To-Diagnostic Flow Chart Menu
- 2.5L Symptom-To-Diagnostic Flow Chart Menu
- 3.0L Symptom-To-Diagnostic Flow Chart Menu
- 3.8L Symptom-To-Diagnostic Flow Chart Menu
- 5.0L Symptom-To-Diagnostic Flow Chart Menu
- Testing & Diagnosis
- EGR Function Testing
- Engine Controls - Basic Testing
- Introduction
- Preliminary Inspection & Adjustments
- Fuel System
- Fuel Pressure Check
- DURASPARK II Ignition System Check
- Thick Film Ignition (TFI) System Check
- DISTRIBUTORLESS Ignition System (Dis) Checks
- Ignition Coil Resistance
- Idle Speed & Ignition Timing
- 4-Cylinder Ignition Timing Specifications
- 4-Cylinder Idle Speed Specifications
- V6 Ignition Timing Specifications
- V6 Idle Speed Specifications
- V8 Ignition Timing Specifications
- V8 Idle Speed Specifications
- Idle Mixture Adjustment
- Throttle Position Sensor (TPS) Adjustment
- Supercharger (THUNDERBIRD & Cougar)
- Summary
- Engine Controls - System/Component Tests - EEC-IV
- Introduction
- Supercharger Check
- Turbocharger Check
- Variable Induction Systems Check
- Engine Control Unit (Ecu) Tests
- Air Charge Temperature (Act) Sensor Test
- Barometric Pressure Sensor Test (2.2L Probe)
- Crankshaft Position Sensor (Cps) Test
- Cylinder Id Sensors Test (2.2L Probe Turbo Only)
- Engine Coolant Temperature (ECT) Sensor Test
- EVP Sensor Test (2.2L Probe CALIF. Only)
- Heated Gas Oxygen (HEGO) Sensor Test
- Inertia Switch Test
- Knock Sensor Test (Except 2.2L Probe Turbo)
- Knock Sensor Test (2.2L Probe Turbo)
- Map/BP Sensor Test
- Mass Airflow (Ma) Sensor Test
- Neutral Drive Switch (NDS) A/C Input Test
- Power Steering Pressure Switch (PSPS) Test
- Throttle Position Sensor Test (2.2L Probe)
- TCS Sensor Test (2.2L Probe)
- Vat Sensor Test (2.2L Probe)
- Vane Air Flow Meter Test (2.2L Probe)
- Vehicle Speed Sensor (VSS) Test
- Relay Tests
- Solenoid Tests
- Ignition Module Tests
- Fuel System Tests
- Fuel Control Tests
- Idle Control System Tests
- Electric Choke Tests (5.8L V8 MCU)
- Ignition System Checks
- Timing Control Systems Tests
- Emissions/Sub-Systems Checks - Air Injection
- Air Supply Pump
- Air Silencer/Filter (Air Pump And Pulse Air Inlet)
- Air Bypass Valve (Normally Closed)
- Air Check Valve
- Air Supply Control Valve
- Air Control Valve (Switch-Relief)
- Air Pump Resonator
- Combination Air By-Pass/Air Control Valve
- Dual THERMACTOR Air Control Solenoid Valve
- Solenoid Vacuum Valve Assembly
- THERMACTOR Idle Vacuum (TIV) Valve
- Vacuum Control Valve (VCV)
- Electrical Vacuum Control Valve
- Vacuum Check Valve
- Vacuum Reservoir
- Pulse Air Valve
- Emissions/Sub-Systems Checks - EGR Systems
- Emissions/Sub-Systems Checks - Fuel Evaporation
- Emissions/Sub-Systems Checks - PCV Systems
- Emissions/Sub-Systems Checks - TAC Systems
- Engine Controls - Tests W/Codes - 3.0L
- Introduction
- Diagnostic Formats
- Service Code Descriptions
- Clearing Codes
- Reading Diagnostic Codes
- Quick Test Procedures
- Visual Check & Vehicle Preparation
- Equipment Hook-Up
- KOEO Self-Test
- KOER Self-Test
- Continuous Monitor Mode (Wiggle Test)
- Additional System Functions
- Frequently Used EEC-IV Abbreviations
- Summary
- PFI Service Code Definitions
- KOEO Code/Test Menu - 3.0L
- KOER Code/Test Menu - 3.0L
- Continuous Code/Test Menu - 3.0L
- Circuit Tests
- How To Use Circuit Tests (Tests A To X)
- ECA Sensor Resistance & Pin Voltage Reference Chart
- Test A - TFI & Dis Ignition Systems
- Test Aa - No Start (EDIS Ignition Systems)
- Test B - Checking Vehicle Battery
- Test C - Reference Voltage
- Test DA - Temperature Sensor Test (Act, ECT & Vat)
- Test Dc - Mass Airflow Sensor (MAF)
- Test Dd - EVP Sensor, EGRC Solenoid & EGRV Solenoid
- Test DF - Map/BP Sensors
- Test Dg - Knock Sensor (KS)
- Test DH - Throttle Position Sensor (TPS)
- Test DL - PFE Valve & EVR Solenoid
- Test DN - EVP Sensor & EVR Solenoid
- Test DP - Vehicle Speed Sensor (VSS)
- Test Dr - Cylinder Identification (CID) Sensor
- Test Fa - Neutral Drive Switch (NDS) A/C Input CKT
- Test FD - Brake On/Off Switch (Boo)
- Test Ff - Power Steering Pressure Switch (PSPS)
- Test H - Fuel Control
- Test J - Fuel Pump CKT (Relay & Inertia Switch)
- Test KA - EGR On/Off Control
- Test KD - Canister Purge (CANP)
- Test KE - Idle Speed Control (Air By-Pass)
- Test KF - EDF/HEDF Electric Cooling Fans
- Test KH - Service Pin Adjustment
- Test Kl - Shift Indicator Light (SIL)
- Test Km - WAC & A/C Demand Switch
- Test KP - Octane Adjust
- Test Kt - IAC Valve (IAC) - TAURUS 3.0L SHO PFI Only
- Test M, Code 77 - Dynamic Response Test
- Test Ml, Codes 70, 71 Or 72 - Malfunction Indicator
- Test N - Ignition Diagnostic Monitor (IDM)
- Test P - Spark Timing Check
- Test QA - No Codes/Codes Not Listed
- Test QB, Code 15 - KOEO Or Continuous Memory Code
- Test QC - Output State Check Not Functioning
- Test QD - Re-Initialization Check
- Test S - System Check
- Test T - AXOD Transaxle
- Test Tb - A4LD Transmission
- Test X - Integral Relay Control Module (IRCM)
- Engine Controls - Tests W/O Codes
- Introduction
- DRIVEABILITY Symptom Check Procedures
- Symptom-To-Routine Menu
- Intermittent Problem Diagnosis
- Intermittent Test Procedures
- Routine 200 - No Crank & No Start
- Routine 201 - Cranks Normally But Won't Start
- Routine 202 - Cranks Normally But Won't Run (Stalls)
- ROUTINE 203 - Cranks NORMALLY BUT SLOW TO START
- Routine 204 - Rough Idle
- Routine 205 - Misses Under Load
- Routine 206 - Low Idle (Stalls On DECEL Or Quick Stop)
- Routine 207 - Hesitates Or Stalls On Acceleration
- Routine 208 - Backfire (Intake Or Exhaust)
- Routine 209 - Lack Of Power
- Routine 210 - Surges At Steady Speed
- Routine 212 - Engine Noise
- Routine 213 - Poor Fuel Economy
- Routine 214 - High Oil Consumption
- Routine 215 - Spark Knock (Pings)
- ROUTINE 216 - ENGINE VIBRATES AT NORMAL OR HIGH Speed
- Routine 217 - Engine Runs Cold
- Routine 218 - Engine Runs Hot
- ROUTINE 219 - Exhaust SMOKE
- Routine 220 - Gas Smell
- Routine 221 - "Check Eng/SERV Soon" Always/Never On
- Routine 222 - State Emission Test Failure
- ROUTINE 223 - IMPROPER Shift
- Routine 224 - SIL & Audible Chimes "On"
- Glow Plug Testing
- 1.9L Symptom-To-Diagnostic Flow Chart Menu
- 2.3L Symptom-To-Diagnostic Flow Chart Menu
- 2.5L Symptom-To-Diagnostic Flow Chart Menu
- 3.0L Symptom-To-Diagnostic Flow Chart Menu
- 3.8L Symptom-To-Diagnostic Flow Chart Menu
- 5.0L Symptom-To-Diagnostic Flow Chart Menu
- Theory and Operation
- Engine Controls - Theory & Operation
- Introduction
- Air Induction System
- Supercharger Operation
- Turbocharger Operation
- Intake Air Control (IAC) System Operation (TAURUS 3.8L SHO)
- DISTRIBUTORLESS Ignition System (Dis) Operation
- Thick Film Ignition (TFI) System Operation
- DURASPARK II Ignition System Operation
- Emission Systems
- Air Injection System Operation
- Notes
- Pulse Air Valve System
- THERMACTOR Air System
- Anti-Backfire (Gulp) Valve
- Air By-Pass Valve
- Air Check Valve & Pulse Air Valve
- Air Pump
- Air Silencer/Filter
- Air Supply Control Valves
- Check Valves
- Combination Air By-Pass & Air Control Valve
- Dual THERMACTOR Air Control Solenoid Valve
- THERMACTOR Idle Vacuum (TIV) Valve
- EGR System Components Operation
- Evaporative Emission Control Systems Operation
- Notes
- CARBURETED Engines (5.8L V8 MCU)
- Fuel Injected Engines
- Carbon Canister
- Canister Purge Valve
- Canister Purge Solenoid Valve
- Carburetor Fuel Bowl Thermal Vent Valve
- Fill Control/Vent System
- Fuel Bowl Thermal Vent Valve
- Fuel Vapor Return System
- Purge Control Valve
- Purge Control Solenoid Valve
- Pressure/Vacuum Relief Fuel Cap
- Vacuum Bowl Vent & Vacuum/Thermostatic Bowl Vent Valves
- Vacuum Check Valve
- Vapor Vent System
- Positive Crankcase Ventilation (PCV)
- Self-Diagnostic Systems
- Computerized Engine Control Systems Operation
- ECA Input Sensors Operation
- Notes
- A/C Compressor Clutch Signal
- Air Charge Temperature (Act) Sensor
- Barometric Pressure (BP) Sensor
- Brake On-Off (Boo) Switch
- Clutch Engage Switch
- Coolant Temperature Sensor (CARBURETED)
- Coolant Temperature Sensor (Fuel Injected)
- Crankshaft Position Sensor (Cps)
- Cylinder Identification (CID) Sensors
- Exhaust Gas Oxygen (Ego) Sensor
- EGR Valve Position (EVP) Sensor
- Electrical Load Control Unit (ELCU)
- Engine Coolant Temperature (ECT) Sensor
- Engine Coolant Temperature (ECT) Switch
- Heated Exhaust Gas Oxygen (HEGO) Sensor
- Idle Switch
- Knock Control Unit
- Knock Sensor (KS)
- Manifold Absolute Pressure (Map)
- Mass Air (Ma) Sensor
- Mass Airflow (MAF) Meter
- Neutral Gear Switch (NGS)
- Neutral Safety Switch (NSS)
- Profile Ignition Pick-Up (Pip)
- Power Steering (P/S) Pressure Switch
- Pressure Feedback Electronic (PFE) EGR Valve
- Self-Test Output/Self-Test Input (STO/STI) Connectors
- Throttle Position Sensor (TPS)
- Vane Airflow Meter (VAF)
- Vacuum Switches (CARBURETED)
- Vane Air Temperature (Vat) Sensor
- Vehicle Speed Sensor (VSS)
- ECA Output Actuators Operation
- Notes
- Air Cleaner Cold Weather Modulator
- Air Cleaner Vacuum Motor
- A/C Wide Open Throttle Cut-Off
- By-Pass Air Control (BAC) Valve
- Canister Purge Regulator (CPR) Solenoid Valve
- Exhaust Gas RECIRCULATION (EGR) Control Solenoid Valve
- EGR Shut-Off (EGRSO) Solenoid
- EGR Vent (EGRV) Solenoid
- EGR Vacuum Regulator (EVR)
- Malfunction Indicator Light (Mil)
- Pressure Regulator Control (PRC) Solenoid Valve
- Turbo Boost Control Solenoid Valve
- Fuel Delivery Systems Operation
- Fuel Control Operation
- Idle Speed Control Systems Operation
- Engine Controls - Theory & Operation
- Vacuum Diagrams
- Wiring Diagrams
- General Information
- Abbreviations
- Basic Trouble Shooting
- Basic Trouble Shooting - General Information
- Commonly Used Abbreviations - General Information
- Emission Control Abbreviations
- Engine Performance - Trouble Shooting - General Information
- Brakes
- Anti-Lock Brake Safety Precautions - General Information
- Map - Brake Systems
- Brake Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Accelerometers
- Accumulators
- Anchor Pins
- Anti-Lock Brake Control Assembly(Module)
- Anti-Lock Brake Controller
- Anti-Lock Brake Systems
- Axle Seal
- Backing Plates
- Bleeder Screw
- Brake Abs Active Light (Blue)
- Brake Fluid
- Brake Friction Material
- Brake On - Off Switch
- Brake Pads
- Brake Pedals
- Brake Shoe Hardware
- Brake Shoes
- Brake Stoplight Switches
- Brake Warning Light (Amber)
- Brake Warning Light (Red)
- Bulb Sockets
- Bulbs And LEDS
- Caliper Hardware
- Caliper Mounting Pin
- Caliper Piston
- Caliper Shim
- Caliper Slider Pin (Bolt) Dust Boot
- Caliper Slider Pin (Bolt)
- Calipers
- Combination Valve
- Controllers
- Digital Ratio Axle Controllers And Buffers (Drab And Dram)
- Disable Switches
- Drums
- Electrical Brake Pumps
- Electrical Park Motor
- Electrical Pumps And Motors
- Electro-Magnetic Interference
- Electronic Brake Control Modulator
- Electronic Brake Distribution
- Electronic Brake Traction Control Module
- Electronic Controllers
- Electronic Traction Control
- External Brake Cable
- Flow Control Valve
- Fluid Level Sensor Switches
- Fluid
- Four Wheel Drive Switches
- Friction Material
- G Sensors
- Gaskets
- Gravitational Switches
- Grease Seal
- Height Sensing Proportioning Valve
- High Pressure Accumulator
- Hoses
- Hub
- Hydraulic Control Unit
- Hydraulic Modulators
- Hydro-Boosters
- Hydro-Electric Boosters (POWERMASTER)
- Ignition Disable Switches
- Lamp Driver Relay
- Lateral Acceleration Switches
- LEDS
- Lenses
- Low Pressure Accumulator
- Lug Nut
- Master Cylinder Cover Gasket
- Master Cylinders
- Modulators
- Motor Pack
- Motors
- Pads
- Parking Brake Cable
- Parking Brake Mechanism
- Parking Brake Shoes
- Parking Brake Switches
- Parking Brake Systems
- Pedal Travel Switches
- Pedals
- Power Distribution Center
- POWERMASTER
- Pressure Differential Switches
- Pressure Switches
- Pressure Transducers
- Proportioning Valve
- Pumps
- Relays
- RELUCTOR (Speed) Ring
- Rotors
- Self-Adjusting Systems
- Shoe Hardware
- Shoes
- Sockets
- Speed Sensor (RELUCTOR) Ring
- Speed Sensors (Electronic Wheel And Vehicle)
- Star Wheel
- Steel Brake Lines
- Stoplight Switches
- Stroke Sensor
- Switches
- Tires
- Tone Ring
- Toothed Rings (Tone Wheel)
- Traction Control System (TCS)
- Transfer Tubes
- Vacuum Boosters
- Vacuum Hoses
- Valves
- Wear Indicator
- Wheel Attachment Hardware
- Wheel Bearings, Races And Seals
- Wheel Cylinders
- Wiring Harnesses
- Yaw Rate Sensor
- Brake System CHECKSHEET
- Reason Code Explanation
- Automotive Terminology & Definitions
- Brake Systems
- Map - Routine Inspection Reference Guide
- Routine Inspection Reference Guide
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Maintenance Overview
- Antifreeze/Coolant
- Visual Inspection
- Radiator Cap Test
- Engine Fan
- Cooling System Power Flush And Refill
- Belts (Except Timing Belts)
- Belt TENSIONER
- Automatic Transmission Fluid
- Automatic Transmission Fluid Exchange & Filter Replacement
- Engine Oil
- Air Filters
- Cabin Air Filter
- Brake Fluid
- Battery
- Battery Cables
- Power Steering
- Power Steering Fluid
- Wiper Blades
- Routine Inspection CHECKSHEET
- Routine Inspection - UICS
- Brake Systems
- Drivetrain And Transmission
- Notes
- Automatic Transmission Fluid
- Clutch Master Cylinders
- Cooler Lines
- Coolers
- Differential Fluid
- Drain Plugs And Gaskets
- Filters And Screens
- Fluids And Lubricants
- Hoses, Lines, And Tubes
- Hydraulic Fluid
- Lubricants
- Manual Transmission Fluid
- Mounts (Engine, Transaxle And Transmission)
- Transfer Case Fluid
- Vacuum Hoses
- Electrical Systems
- Engine Performance And Maintenance
- Notes
- Accessory Belts
- Air Filter Elements
- Air Filter Gaskets
- Air Filter Housings And Gaskets
- Air Pump Belts
- Batteries
- Battery Connectors
- Belt Idler Assemblies (Accessory And Cam Belts)
- Belt TENSIONERS (Accessory And Cam Belt)
- Chemical Engine DECARBONIZATION
- Combustion Chamber Cleaning
- Coolant Recovery Tanks
- Coolant
- Distributor Caps
- Distributor Rotors
- Engine Cooling Systems
- Engine DECARBONIZATION
- Engine Oil Drain Plugs And Gaskets
- Engine Oil Filters And Canisters
- Engine Oil
- Fuel Filters
- Fuel Injector Cleaning
- Fuel Injectors
- Fuel System Cleaning Service
- Hose Clamps
- Hose Connectors
- Hose Couplers
- Hoses And Tubes (Fuel Lines, Radiator, Vacuum, By-Pass, Heater, Recovery Tank And Oil Coolers)
- Ignition Wires (Secondary)
- Intake Cleaning
- O2 Sensors
- PCV Breather Elements
- PCV Valves
- Radiator Caps And Pressurized Expansion Tank Caps
- Spark Plugs
- Thermostats And Housings
- Throttle Body Cleaning
- Timing Belts
- Vacuum Hoses, Tubes And Connections (Non-Metallic)
- Exhaust Systems
- Heating, Ventilation And Air Conditioning Systems
- Steering And Suspension, Wheel Alignment, Wheels And Tires
- Wheel & Tire Supplement
- Reason Code Explanation
- Automotive Terminology & Definitions
- Routine Inspection Reference Guide
- Check Lists
- Computer Relearn Procedures
- Driveline/Axles
- Drive Axle Noise Diagnosis - General Information
- Gear Tooth Contact Patterns - General Information
- Map - Drive Train & Transmission
- Drive Train & Transmission Systems
- Drivetrain And Transmission
- Notes
- Actuators (Electrical)
- Actuators (Vacuum)
- Automatic Transmission / Transaxle Assemblies/CVTS
- Automatic Transmission Fluid
- Axles
- Bearings And Races
- Bell Cranks
- Bell Housings
- Bushings (External)
- Cables (Speedometer)
- Cables (TV, Detent And Shift)
- Carrier Bearings
- Clutch Cables And Cable Housings
- Clutch Discs (Manual Transmissions)
- Clutch Forks
- Clutch Linkages (Mechanical)
- Clutch Master Cylinders
- Clutch Pedals
- Clutch Pivots
- Clutch Pressure Plates
- Clutch Release Bearings
- Clutch Slave Cylinders (Concentric)
- Clutch Slave Cylinders (Conventional Or External)
- Companion Flanges
- Connectors
- Cooler Bypass Valves
- Cooler Lines
- Coolers
- CV Joints
- Differential And Final Drive Assemblies
- Differential Fluid
- Dip Stick Tubes
- Dip Sticks (Fluid Level Indicators)
- Dowel Pins, Guides And Pilot Holes
- Drain Plugs And Gaskets
- Drive Shaft Flanges
- Drive Shafts And Half Shafts
- Dust Boots
- Engine Mounts
- Exciter Rings
- Filler Tubes
- Filters And Screens
- Flanges
- Flex Plates
- Fluid Level Indicators
- Fluids And Lubricants
- Flywheels
- Force Motors
- Gaskets
- Guides
- Half Shafts
- Hoses, Lines, And Tubes
- Housings (Bell, Case, Tail(Extension) And Auxiliary)
- Hydraulic Fluid
- Intermediate Shaft Support Bearings
- Key Interlock Systems
- Limited Slips
- Lines
- Linkages (External)
- Locking Hub Assemblies
- Locking Hub Control Knobs
- Lubricants
- Manual Transmission Fluid
- Manual Transmission/Transaxle Assemblies
- Metal Clad Seals
- METALASTIC Joints
- Modulator Pins
- Modulators
- Mounts (Engine, Transaxle And Transmission)
- Odometer Drives (Mechanical)
- Odometer Heads (Mechanical)
- Oil Pans
- Pans
- Pilot Holes
- Pressure Plates
- Pressure Switches
- Races
- Rubber Joints (METALASTIC)
- Screens
- Seals (Metal Clad)
- Seals
- Selector Interlock Systems
- Sensors
- Servos
- Shift Interlock Systems (Selector And Key Interlock Systems)
- Side Covers
- Slip Yokes
- Solenoids
- Speed Sensors (Electronic Wheel And Vehicle)
- Speedometer- Driven Gear Housing
- Speedometer/Odometer Drives (Mechanical)
- Speedometer/Odometer Heads (Mechanical)
- Speedometers/Odometers (Electronic)
- Switches
- Tone Wheels
- Toothed Rings (Tone Wheel)
- Torque Converters
- Transaxle Mounts
- Transducers (Transmission)
- Transfer Case Assemblies
- Transfer Case Fluid
- Transmission Coolers
- Transmission Mounts
- Transmission Pans
- Transmission Range Indicators (PRNDL)
- Tubes
- Universal Joints (CARDAN Or Cross Type)
- Vacuum Controls
- Vacuum Hoses
- Vacuum Motors
- Vacuum-Operated Switches
- Vehicle Speed Sensors
- Vents
- Vibration Dampers
- Wheel Attachment Hardware
- Wheel Speed Sensors
- Wiring Harnesses And Connectors
- Yokes And Slip Yokes
- Reason Code Explanation
- Automotive Terminology & Definitions
- Trouble Shooting - Clutches - General Information
- Electrical
- Map - Electrical Systems
- Electrical Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Actuator Motors (Electric)
- Actuator Motors (Vacuum)
- Air Bags
- Alternators And Generators
- Amplifiers
- Antennas
- Batteries
- Battery Cables, Wires And Connectors
- Battery Cables
- Battery Trays And Hold Down Hardware
- Battery Wires
- Belts
- Bulb Sockets
- Bulbs, Sealed Beams And LEDS
- Cd Players
- Cigarette Lighter Assemblies
- Circuit Breakers
- Clutch Switches
- Connectors
- Control Modules
- Cruise Control Brake Switches
- Cruise Control Cables
- Cruise Control Clutch Switches
- Cruise Control Linkages And Cables
- Cruise Control Reservoirs
- Cruise Control Tubes
- Cruise Control Vacuum Dump Release Valves
- Cruise Control Vacuum Hoses, Tubes And
- Cruise Control Vehicle Speed Sensors
- Defoggers
- Defrosters
- Delays
- Dimmers
- Electric Heaters
- Equalizers
- Fuse Blocks
- Fuse Boxes And Blocks
- Fuses, Fusible Links And Circuit Breakers
- Fusible Links
- Gauges
- Generators
- Ground Cables And Straps
- Ground Straps
- Headlight Adjusters
- Heating Elements (Defrosters, Defoggers, Electric Heaters And Seats)
- Horns And Sirens
- Ignition Switches
- Indicator Lights
- Keyless Entry Keypads And Transmitters
- Keyless Entry Transmitters
- LEDS
- Lenses
- Microphones
- Mirrors (ELECTROCHROMATIC And Heated)
- Motors
- Neutral Safety Switches
- Odometers, Speedometers And Tachometers (Cable Driven)
- Odometers
- Power Distribution Center
- Pulleys
- Receivers, Amplifiers, Equalizers And Sub-Woofer Volume Controls
- Relay Boxes
- Relays
- Sealed Beams
- Seat Heaters
- Security Alarm Sensors
- Sirens
- Solenoids
- Speakers And Microphones
- Speedometer And Tachometer Linkages And Cables
- Speedometer Cables
- Speedometers
- Starters
- Sub-Woofer Volume Control
- Switches
- Tachometer Cables
- Tachometers
- Tape Players And Cd Players
- TENSIONERS
- Timers
- Transceivers
- Transducers
- Vacuum Accumulators (Reservoirs)
- Voltage Regulators
- Washer Fluid Level Senders
- Washer Pumps
- Wiper Arms And Blades
- Wiper Blades
- Wiper Hoses And Nozzles
- Wiper Linkages
- Wiper Nozzles
- Wiper Pump Reservoirs
- Wiring Harnesses And Connectors
- Battery, Starting & Charging System CHECKSHEET
- Reason Code Explanation
- Automotive Terminology & Definitions
- Electrical Systems
- Using lemon2025'S System Wiring Diagrams
- Map - Electrical Systems
- Engine
- Engine Overhaul Procedures - General Information
- * Please Read This First *
- Description
- Engine Identification
- Inspection Procedures
- Cleaning Procedures
- Component Cleaning
- Cylinder Head Replacement
- Cylinder Head Overhaul
- Pistons, Connecting Rods & Bearings
- Crankshaft & Main Bearings
- Camshaft
- Timing Chains & Belts
- Timing Gears
- Oil Pump
- Break-In Procedure
- General Cooling System Service - General Information
- Engine Overhaul Procedures - General Information
- Engine Performance
- Electrostatic Discharge Warning - General Information
- Emission Control Visual Inspection Procedures
- Emission Control Labels
- Ford Calibration Labels
- Emission Control Visual Inspection
- Notes
- Positive Crankcase Ventilation (PCV)
- Thermostatic Air Cleaner (TAC)
- Fuel Evaporative System (EVAP)
- Catalytic Converters
- Fill Pipe RESTRICTOR (Fr)
- Exhaust Gas RECIRCULATION (EGR) System
- Spark Controls (SPK)
- Air Injection System (AIS)
- Oxygen Sensor (O2)
- Computerized Engine Controls (CEC)
- Early Fuel Evaporation (EFE)
- Emission Maintenance Reminder Light (EMR)
- Malfunction Indicator Light (Mil)
- Engine Performance Diagnostic Routine Outline - General Information
- Engine Performance Safety Precautions
- Map - Engine Performance & Maintenance
- Engine Performance And Maintenance (Including Exhaust Systems)
- Engine Performance & Maintenance CHECKSHEET
- Engine Performance And Maintenance
- Notes
- Accelerator Pedal Position Sensor
- Accessory Belts
- Accessory Pulleys
- Air Conditioning Cycling Switches
- Air Conditioning Pressure Sensors
- Air Ducts And Tubes
- Air Filter Elements
- Air Filter Gaskets
- Air Filter Housings And Gaskets
- Air Fuel Ratio Sensors
- Air Injection Control Solenoids
- Air Plenums
- Air Pump Belts
- Air Pumps (Electric Driven)
- Air Tubes
- Aspirator, Check And DECEL Valves
- Baffles
- Ballast Primary Supply Resistor Wires
- Ballast Resistors And Primary Supply Resistors
- Barometric Pressure Sensors
- Batteries
- Battery Cables, Wires And Connectors
- Battery Connectors
- Battery Trays And Hold Down Hardware
- Battery Wires
- Belt Idler Assemblies (Accessory And Cam Belts)
- Belt TENSIONERS (Accessory And Cam Belt)
- Belt-Driven Air Pumps
- Boost Control Mechanism
- Camshaft Position Sensors
- Carburetors And Chokes
- Casting Core Plugs And Expansion Plugs
- Charge Air Coolers ""INTERCOOLERS"" (CAC)
- Check Valves
- Chemical Engine DECARBONIZATION
- Chokes
- Clutch Pedal Position Switches
- Cold Start Injectors
- Combustion Chamber Cleaning
- Connectors
- Coolant Recovery Tanks
- Coolant
- Cooling Fan Motor Modules
- Cooling Fan Motor Relays And Modules
- Cooling Fan Motor Resistors
- Cooling Fan Motor Sensors And Switches
- Cooling Fan Motor Switches
- Cooling Fan Motors
- Crankshaft Position Sensors
- Cylinder Deactivation Solenoid
- Cylinder Head Assemblies
- DECEL Valves
- Deflectors
- Dip Stick Tubes
- Dip Sticks And Tubes
- Distributor Advances And Retarders (Mechanical And Vacuum)
- Distributor Boots And Shields
- Distributor Caps
- Distributor Retarders (Mechanical And Vacuum)
- Distributor Rotors
- Distributor Shields
- Distributors
- Early Fuel Evaporation Valves (Heat Riser Assemblies)
- EGR Coolers
- EGR Exhaust Manifold Passages
- EGR Intake And Exhaust Manifold Passages
- EGR Plates And Coolers
- Electronic Spark Control Modules
- Electronic Transmission Control Devices
- Electronic Transmission Feedback Devices
- Engine Coolant Temperature Sensors
- Engine Cooling Systems
- Engine Covers (Oil Pan, Valve Cover, Timing Cover)
- Engine DECARBONIZATION
- Engine Oil Canisters
- Engine Oil Coolers (External)
- Engine Oil Drain Plugs And Gaskets
- Engine Oil Filters And Canisters
- Engine Oil Gaskets
- Engine Oil Pressure Gauges (Mechanical)
- Engine Oil
- Evaporative Emissions (EVAP) Canister Filters
- Evaporative Emissions (EVAP) Canister Purge Devices
- Evaporative Emissions (EVAP) Canisters
- Evaporative Emissions (EVAP) Feedback Devices
- Exhaust Gas RECIRCULATION Devices
- Exhaust Gas RECIRCULATION Feedback Devices
- Expansion Plugs
- Fan Control Sensor
- Fuel Accumulators And Dampers
- Fuel And Cold Start Injectors
- Fuel Caps
- Fuel Dampers
- Fuel Delivery Check Valves
- Fuel Distributors (BOSCH Cis)
- Fuel Filler Necks And RESTRICTORS
- Fuel Filters
- Fuel Injector Cleaning
- Fuel Injectors
- Fuel Level Senders
- Fuel Pressure Regulators
- Fuel Pumps (In-Tank, External, Electrical Or Mechanical)
- Fuel Rails
- Fuel RESTRICTORS
- Fuel System Cleaning Service
- Fuel Tanks
- Fuel
- Gaskets
- Grommets (Valve Cover)
- Harmonic Dampers
- Heater Control Valves
- Heater Cores
- Hose Clamps
- Hose Connectors
- Hose Couplers
- Hoses And Tube Couplers, Connectors And Clamps
- Hoses And Tubes (Fuel Lines, Radiator, Vacuum, By-Pass, Heater, Recovery Tank And Oil Coolers)
- Housings
- Idle Air Controls
- Idle Speed Control Actuators
- Ignition Boots
- Ignition Coil Towers
- Ignition Coils
- Ignition Control Modules (ICM)
- Ignition Switches
- Ignition Terminals
- Ignition Wires (Secondary)
- Inertia Fuel Shut-Off Switches
- Intake Air Temperature Sensors
- Intake Cleaning
- Intake Manifolds
- In-Tank Fuel Strainers
- INTERCOOLERS
- Knock Sensors
- Liquid Vapor Separators
- Long Block Assemblies
- Manifold Absolute Pressure (Map) Sensors
- Mass Air Flow (MAF) Sensors
- Metal Air Manifolds And Pipes
- Metal Air Pipes
- Mix Control Solenoids
- Motor Mounts
- O2 Sensors
- Oil Pans
- Oil Pressure Sending Units
- Oil Pump Pick-Up Screens
- Oil Pumps
- O-Rings, Gaskets, Seals And Spring Locks
- Park Neutral Position Switches
- PCV Breather Elements
- PCV Orifices
- PCV Valves
- Pick-Up Assemblies (Includes Magnetic, Hall Effect And Optical)
- Power Steering Pressure Sensors
- Powertrain Control Modules (Pcm) And Prom
- Powertrain Control Prom
- Pressurized Expansion Tank Caps
- Radiator / Cooling Fan Blades
- Radiator / Cooling Fan Clutches
- Radiator Caps And Pressurized Expansion Tank Caps
- Radiators
- Roll Over Valves
- Sealing Compounds
- Seals
- Secondary Air Injection System Management Devices
- Sensors
- Short Block Assemblies
- Shrouds, Baffles And Deflectors
- Spark Plugs
- Spring Locks
- Super Chargers
- Switches
- Thermal Vacuum Valves
- Thermostatic Air Door Assemblies
- Thermostats And Housings
- Throttle Bodies
- Throttle Body Cleaning
- Throttle Cables
- Throttle Linkages And Cables
- Throttle Position Sensors
- Throttle Position Switches
- Timing Belt Sprockets
- Timing Belts
- Timing Covers
- Torque Struts
- Transmission Range Switches
- Tube Clamps
- Tube Connectors
- Tube Couplers
- Tubes
- Turbo Chargers
- Vacuum Connections
- Vacuum Hoses, Tubes And Connections (Non-Metallic)
- Vacuum Regulator Solenoids
- Vacuum Tubes
- Valve Covers
- Vehicle Speed Senors
- Volume Air Flow Sensors
- Waste Gate And Boost Control Mechanisms
- Waste Gate Control Solenoids
- Water Pumps (Electric)
- Water Pumps (Non-Electric)
- Wiring Harnesses And Connectors
- Reason Code Explanation
- Automotive Terminology & Definitions
- Parasitic Load Explanation & Test Procedures - General Information
- State Emission Standards - Diesel
- State Emission Standards - Gas
- ALASKA
- ARIZONA
- CALIFORNIA
- Colorado
- CONNECTICUT
- DELAWARE
- District Of COLUMBIA
- GEORGIA
- IDAHO
- ILLINOIS
- INDIANA
- KENTUCKY
- MARYLAND
- MASSACHUSETTS
- MISSOURI
- NEVADA
- New Jersey
- New MEXICO
- New YORK
- North CAROLINA
- OHIO
- OREGON
- PENNSYLVANIA
- RHODE Island
- TENNESSEE
- TEXAS
- UTAH
- VIRGINIA
- WASHINGTON
- WISCONSIN
- U. S. EPA ASM2525 & ASM5015 Start-Up Emission Standards
- U. S. EPA Revised Final ASM Emission Standards (ASM5015 & ASM2525)
- U.S. EPA Im240 Emission Standards
- Waveforms - Injector Pattern Tutorial - General Information
- * Please Read This First *
- Purpose Of This Article
- Is A Lab Scope Necessary?
- The Two Types Of Injector Drivers
- The Two Ways Injector Circuits Are Wired
- Interpreting Injector Waveforms
- Current Waveform Samples
- Notes
- Example #1 - Voltage Controlled Driver
- Example #2 - Voltage Controlled Driver
- Example #3 - Voltage Controlled Driver
- Example #4 - Current Controlled Driver
- Example #5 - Current Controlled Driver
- Example #6 - Current Controlled Driver
- Example #7 - Current Controlled Driver
- Example #8 - Current Controlled Driver
- Voltage Waveform Samples
- Notes
- Example #1 - Voltage Controlled Driver
- Example #2 - Voltage Controlled Driver
- Example #3 - Voltage Controlled Driver
- Example #4 - Current Controlled Driver
- Example #5 - Current Controlled Driver
- Example #6 - Current Controlled Driver
- Example #7 - Current Controlled Driver
- Example #8 - Current Controlled Driver
- Map - Exhaust Systems
- Exhaust Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Catalytic Converters
- Exhaust And Tail Pipes
- Exhaust Connections
- Hangers
- Heat Risers (Mechanical EFE Devices)
- Heat Shields
- Manifolds (Cast And Tube Type)
- Mechanical EFE Devices
- Muffler Valve
- Mufflers And Resonators
- Reason Code Explanation
- Exhaust Systems
- Heating, Ventilation & A/C (HVAC)
- Map - Heating, Ventilation, & Air Conditioning
- Heating, Ventilation & Air Conditioning Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Accumulators
- Actuators (Electrical)
- Actuators (Vacuum)
- Air Conditioning Fittings
- Air Conditioning Hoses
- Air Conditioning Metal Lines
- Air Control Doors
- Air Dams (External)
- Air Distribution System
- Belts
- Blend Doors
- Blower Fans (Blower Wheel Or Squirrel Cage)
- Blower Motors
- Blower Resistors
- Blower Switches
- Cabin Air Filters
- Circuit Breakers
- Compressor Clutch Assemblies
- Compressors
- Condenser Air Seals
- Condenser Fan Motors
- Condensers
- Connectors
- Control Cables
- Control Heads (Function Selectors)
- Control Linkages
- Control Modules
- Coolant
- Cooling Fan Blades
- Cooling Fan Clutches
- Cooling Fan Motors
- Evaporator Drain Tubes
- Evaporator Filters
- Evaporator Pressure Regulators (EPRS)
- Evaporators
- Expansion Valves
- Function Selectors
- Fuses, Fusible Links And Circuit Breakers
- Fusible Links
- Gaskets
- Heater Cases
- Heater Control Valves
- Heater Cores
- Heater Hoses
- High Pressure Relief Valves (HPRV)
- Idlers
- In-Line Filters
- Metal Fittings
- Metal Lines
- Mix And Air Control Doors (Blend Doors)
- ORIFACE Tubes
- O-Rings
- Pilot-Operated Absolutes (POAS)
- Plenums
- Pressure Control Valves
- Pressure Sensors
- Pulleys
- Radiators
- Receiver-DRIERS
- Refrigerant Oil
- Refrigerant
- Relays
- Seals
- Service Ports
- Spring Lock Couplings
- Suction Throttling Valves (STVS)
- Switches (Electrical)
- TENSIONERS
- Thermistors And Pressure Sensors
- Thermostats And Housings
- Vacuum Hoses And Tubes
- Vacuum Reservoirs
- Vacuum Tubes
- Valves In Receiver (VIRS)
- Water Pumps (Electric Auxiliary)
- Wiring Harnesses And Connectors
- Heating, Ventilation & Air Conditioning System CHECKSHEET
- Reason Code Explanation
- Automotive Terminology & Definitions
- Heating, Ventilation & Air Conditioning Systems
- Map - Heating, Ventilation, & Air Conditioning
- Identification
- Metric Conversions
- Maintenance Reminder Light (Reset Procedures)
- A/C Filter Service Reminder
- Engine Oil Replacement Reminder
- Notes
- Engine Oil Replacement Reminder Reset - Procedure 01
- Engine Oil Replacement Reminder Reset - Procedure 02
- Engine Oil Replacement Reminder Reset - Procedure 03
- Engine Oil Replacement Reminder Reset - Procedure 04
- Engine Oil Replacement Reminder Reset - Procedure 05
- Engine Oil Replacement Reminder Reset - Procedure 06
- Engine Oil Replacement Reminder Reset - Procedure 07
- Engine Oil Replacement Reminder Reset - Procedure 08
- Engine Oil Replacement Reminder Reset - Procedure 09
- Engine Oil Replacement Reminder Reset - Procedure 10
- Engine Oil Replacement Reminder Reset - Procedure 11
- Engine Oil Replacement Reminder Reset - Procedure 12
- Engine Oil Replacement Reminder Reset - Procedure 13
- Engine Oil Replacement Reminder Reset - Procedure 14
- Engine Oil Replacement Reminder Reset - Procedure 15
- Engine Oil Replacement Reminder Reset - Procedure 16
- Engine Oil Replacement Reminder Reset - Procedure 17
- Engine Oil Replacement Reminder Reset - Procedure 18
- Engine Oil Replacement Reminder Reset - Procedure 19
- Engine Oil Replacement Reminder Reset - Procedure 20
- Engine Oil Replacement Reminder Reset - Procedure 21
- Engine Oil Replacement Reminder Reset - Procedure 22
- Engine Oil Replacement Reminder Reset - Procedure 23
- Engine Oil Replacement Reminder Reset - Procedure 24
- Engine Oil Replacement Reminder Reset - Procedure 25
- Engine Oil Replacement Reminder Reset - Procedure 26
- Engine Oil Replacement Reminder Reset - Procedure 27
- Engine Oil Replacement Reminder Reset - Procedure 28
- Maintenance Service Reminder (Overhead Warning Lights)
- Maintenance Service Reminder (Sri)
- Maintenance Service Reminder (VMM)
- Tire Pressure Monitor System Reminder
- Notes
- Tire Pressure Sensor Types
- TPMS Reminder Reset - Procedure 01
- TPMS Reminder Reset - Procedure 02
- TPMS Reminder Reset - Procedure 03
- TPMS Reminder Reset - Procedure 04
- TPMS Reminder Reset - Procedure 05
- TPMS Reminder Reset - Procedure 07
- TPMS Reminder Reset - Procedure 08
- TPMS Reminder Reset - Procedure 09
- TPMS Reminder Reset - Procedure 10
- Steering
- Map - Steering, Suspension, Wheel Alignment, Wheels & Tires
- Steering & Suspension Systems
- Wheel And Tire
- Steering & Suspension CHECKSHEET
- Wheels & Tires CHECKSHEET
- Steering And Suspension, Wheel Alignment, Wheels And Tires
- Notes
- Active Handling
- Active Suspension Control Modules
- Active Variable Ratio Steering
- Active Yaw Control
- Adaptive Cruise Control
- Advance TRAC
- Air Bags
- Air Ride Control Modules
- Air Ride Suspension Torsion Springs (Counter Balancing)
- Air Ride Suspension
- Air Ride Tubes
- Air Shocks And Air Struts
- Air Spring Valves
- Air Springs
- Air Suspension Control Valves
- Air Suspension DRIERS
- Axle Acceleration Sensor
- Ball Joints
- Body Acceleration Sensor
- Bushings
- Center Links
- Compressors
- Continuous Damping Control
- Control Arm Shafts
- Control Arms
- Control Modules
- Distance Regulation Control Module
- Distance Regulation Sensor
- Drag Links
- Dynamic Stability Control
- Dynamic Stability Traction Control
- Electronic Ride Control Shocks And Struts
- Electronic Stability Control
- Electronic Suspension System
- Flex Couplers
- Gaskets
- Height Sensors
- Hydraulic Hoses
- Hydraulic Power Steering Pumps
- Hydraulic Suspension Hoses
- Hydraulic Suspension Pumps
- Idler Arms
- Intermediate Shaft U-Joints
- King Pins
- Modules
- Pitman Arms
- Power Steering Belts
- Power Steering Coolers
- Power Steering Fluid
- Power Steering Hoses
- Power Steering Lines (Steel)
- Power Steering Pumps - Electric
- Power Steering Pumps
- Radar Sensor
- Radius Arms
- Relay Rods
- Relays
- Sensors
- Shock Absorbers, Strut Cartridges And Strut Assemblies
- Spindles
- Springs, Coil, Leaf And Torsion Bars
- STABILITRAC
- Stability Management System
- Steering Angle Sensor
- Steering Arms
- Steering Couplers
- Steering Dampers
- Steering Gears (Except Rack And Pinion)
- Steering Gears, Rack And Pinion
- Steering Knuckles
- Strike Out Bumpers
- Strut Bearing Plate Assemblies
- Strut Rods
- Suspension Pumps (Hydraulic)
- Sway Bar Links
- Sway Bar Mounting Bushings
- Sway Bars
- Switches
- Tie Rod Ends (Inner And Outer)
- Tire Pressure Monitoring System
- Tire Pressure Sensors
- Tires
- Torque Sensor
- Torsion Springs
- Track Bar Bushings
- Track Bars
- Trailing Arm Bushings
- Trailing Arms
- Valve Stems
- Vehicle Dynamics Control
- Vehicle Speed Sensor
- Vehicle Stability Assist
- Vehicle Stability/Skid Control
- Warning Lamps
- Wheel Alignment
- Wheel Attachment Hardware
- Wheel Bearings, Races And Seals
- Wheels (Rims)
- Wiring Harnesses And Connectors
- Reason Code Explanation
- Automotive Terminology & Definitions
- Wheel Alignment Theory & Operation - General Information
- Map - Steering, Suspension, Wheel Alignment, Wheels & Tires
- Trouble Shooting - Manual Transmission - General Information
- Heating, Ventilation & A/C (HVAC)
- General Servicing
- A/C Clutch & Seal Removal & Installation
- Ford FX-15 10-CYL Clutch
- Ford FX-15 10-CYL Shaft Seal
- NIPPONDENSO, 6E-171 & 6P-148 6-CYL Clutch
- NIPPONDENSO, 6E-171 & 6P-148 6-CYL Shaft Seal
- NIPPONDENSO & Ford FS-6, 6-CYL Clutch
- NIPPONDENSO & Ford FS-6, 6-CYL Shaft Seal R & I
- NIPPONDENSO, 10P15 & 10P15F 10-CYL Clutch
- NIPPONDENSO 10P15 & 10P15F, Shaft Seal
- NIPPONDENSO, 10P15A 10-CYL Clutch Assembly
- NIPPONDENSO, 10P15A 10-CYL Shaft Seal
- NIPPONDENSO 10PA17 & 10PA17A 10-CYL Clutch
- NIPPONDENSO 10PA17 & 10PA17A 10-CYL Shaft Seal
- NIPPONDENSO 10PA20 10-CYL Clutch
- NIPPONDENSO 10PA20 10-CYL Shaft Seal
- A/C Compressor Application
- A/C Compressor Overhaul - 10-CYL
- A/C Compressor Overhaul - 6-CYL
- A/C Orifice Tube Removal & Installation
- A/C System General Servicing
- Using R-12 Refrigerant - Safety Precautions
- Using Individual R-12 Cans
- Multi-Can Dispensing Valves
- Can Tap Installation
- Sight Glass Indicators
- 1990 Passenger Car Service Valve Location
- 1991 Passenger Car Service Valve Locations
- 1990 Truck & Van Service Valve Location Table
- 1991 Truck & Van Service Valve Locations Table
- Stem-Type Valve Operation
- SCHRADER-Type Valve Operation
- Special Valve Connectors
- Manifold Gauge Set
- Connecting Gauge Set
- Purging Test Hoses
- Stabilizing A/C System
- Pressure Gauge Indications
- Pressure Gauge Readings
- Excessive Moisture Gauge Readings
- Defective Thermostatic Switch Gauge Readings
- MISADJUSTED Thermostatic Switch Gauge Readings
- Defective Clutch Cycling Switch Pressure Gauge Readings
- Low R-12 Charge Gauge Readings
- Very Low R-12 Charge Gauge Readings
- Orifice Tube Plugged Gauge Readings
- Expansion Or "H" Valve Stuck Closed
- Expansion Or "H" Valve Stuck Open Gauge Readings
- Compressor Malfunction Gauge Readings
- Condenser Malfunction Or R-12 Overcharge Gauge Readings
- Orifice Tube Replacement - AEROSTAR, Bronco, Explorer
- Spring Lock Coupling Clamp Table
- Orifice Tube R & I - E & F Series, Ranger
- Orifice Tube R & I - Crown VIC/Gran Marquis/TWN Car
- Orifice Tube Replacement - Escort, Probe, Tracer
- Orifice Tube Replacement - All Other
- Refrigerant Recovery
- Discharging A/C System
- Flushing A/C System
- Evacuating A/C System
- Charging A/C System
- Leak Testing
- A/C System Precautions
- Before Opening The System
- Discharging A/C System
- Disconnecting Lines & Fittings
- Component Replacement
- Using R-12 Refrigerant - Safety Precautions
- Using Individual R-12 Cans
- Multi-Can Dispensing Valves
- Can Tap Installation Flat Type Seal Cans
- Screw Type Seal Cans
- Connecting Lines & Fittings
- Placing System In Operation
- Compressor Removal Information - Isolation Method
- Compressor Removal Information-Discharge Method
- A/C System Specifications
- A/C Clutch & Seal Removal & Installation
- HVAC Control Systems
- A/C-Heater System - Automatic
- A/C System Specifications
- Description
- Operation
- Testing
- Diagnostic Procedure
- EATC Self-Diagnostic Test
- Error Code Diagnosis
- EATC System Functional Test
- Diagnosis When EATC Self-Diagnostics Indicate No Errors Found
- Notes
- Cool Air Discharge When System Is Set To 90°f In "AUTO" Mode
- Warm Air Discharge When System Is Set To 60°f In "AUTO" Mode
- Cool Air Discharge In 85°f, Maximum Heat In 90°f
- Heated Air Discharge In 65°f, Cool Air Discharge In 60°f
- No Blower
- Blower Operates In High-Speed Only
- A/C Compressor Clutch Is On When In The "OFF" Position
- Control Panel Digits & VFDS Do Not Light Up, Blower Off
- Cold Air Is Delivered During Heating When Engine Is Cold
- Set Temperature Does Not Return To Set Position After Turning Ignition Off
- Temperature Display Will Not Switch From Fahrenheit To Celsius
- System Does Not Control Temperature
- EATC Control Panel Turns On And Off Erratically, No Control Of System
- No A/C Compressor Clutch Operation
- Compressor Clutch Doesn't Disengage In "Off" Position
- Blower Speed Controller/High-Speed Blower Relay Tests
- Vacuum System
- Sensors
- Removal & Installation
- Refrigerant Lines
- Compressor (With 3.8L V6)
- Compressor (Except 3.8L V6)
- Condenser
- Receiver-Drier
- Instrument Panel (Sable)
- Instrument Panel (TAURUS)
- Evaporator Case
- Evaporator Core
- Heater Core
- Blower Motor
- Fresh-Recirculated Air Door Vacuum Actuator
- Panel-Defrost & Panel-Floor Door Vacuum Actuators
- Control Panel
- SUNLOAD Sensor
- In-Car Temperature Sensor
- Ambient Temperature Sensor
- Blower Speed Controller
- Cold Engine Lock-Out Switch
- Blend Door Actuator
- Wiring Diagrams
- A/C-Heater System - Manual
- A/C-Heater System Trouble Shooting - Manual
- Heater System
- Heater System Trouble Shooting
- A/C-Heater System - Automatic
- General Servicing
- Maintenance
- Procedures
- Maintenance Information
- Model Identification
- Maintenance Service Information
- Flexible Fuel Vehicles Information
- Service Point Locations
- Service Labor Times
- Wheel & Tire Specifications
- Battery Specifications
- Cautions & Warnings
- Supplemental Restraint System (Air Bag System)
- Air Conditioning Servicing
- Anti-Lock Brake System (1990-95 Models Only)
- Replacing Blown Fuses
- Battery Warning
- Brake Pad Wear Indicator
- Catalytic Converter
- Electrostatic Discharge Sensitive (ESD) Parts
- Fuel Pump Shutoff Switch
- Fuel System Service
- Halogen Bulbs
- Radiator Cap
- Radiator Fan
- Warranty Information
- Fuses & Circuit Breakers
- Maintenance Reminder Light (Reset Procedures)
- A/C Filter Service Reminder
- Engine Oil Replacement Reminder
- Notes
- Engine Oil Replacement Reminder Reset - Procedure 01
- Engine Oil Replacement Reminder Reset - Procedure 02
- Engine Oil Replacement Reminder Reset - Procedure 03
- Engine Oil Replacement Reminder Reset - Procedure 04
- Engine Oil Replacement Reminder Reset - Procedure 05
- Engine Oil Replacement Reminder Reset - Procedure 06
- Engine Oil Replacement Reminder Reset - Procedure 07
- Engine Oil Replacement Reminder Reset - Procedure 08
- Engine Oil Replacement Reminder Reset - Procedure 09
- Engine Oil Replacement Reminder Reset - Procedure 10
- Engine Oil Replacement Reminder Reset - Procedure 11
- Engine Oil Replacement Reminder Reset - Procedure 12
- Engine Oil Replacement Reminder Reset - Procedure 13
- Engine Oil Replacement Reminder Reset - Procedure 14
- Engine Oil Replacement Reminder Reset - Procedure 15
- Engine Oil Replacement Reminder Reset - Procedure 16
- Engine Oil Replacement Reminder Reset - Procedure 17
- Engine Oil Replacement Reminder Reset - Procedure 18
- Engine Oil Replacement Reminder Reset - Procedure 19
- Engine Oil Replacement Reminder Reset - Procedure 20
- Engine Oil Replacement Reminder Reset - Procedure 21
- Engine Oil Replacement Reminder Reset - Procedure 22
- Engine Oil Replacement Reminder Reset - Procedure 23
- Engine Oil Replacement Reminder Reset - Procedure 24
- Engine Oil Replacement Reminder Reset - Procedure 25
- Engine Oil Replacement Reminder Reset - Procedure 26
- Engine Oil Replacement Reminder Reset - Procedure 27
- Engine Oil Replacement Reminder Reset - Procedure 28
- Maintenance Service Reminder (Overhead Warning Lights)
- Maintenance Service Reminder (Sri)
- Maintenance Service Reminder (VMM)
- Tire Pressure Monitor System Reminder
- Notes
- Tire Pressure Sensor Types
- TPMS Reminder Reset - Procedure 01
- TPMS Reminder Reset - Procedure 02
- TPMS Reminder Reset - Procedure 03
- TPMS Reminder Reset - Procedure 04
- TPMS Reminder Reset - Procedure 05
- TPMS Reminder Reset - Procedure 07
- TPMS Reminder Reset - Procedure 08
- TPMS Reminder Reset - Procedure 09
- TPMS Reminder Reset - Procedure 10
- Service Indicator & Warning Lights
- Service Indicator & Warning Lights
- Notes
- Check Engine Or Engine Warning Light
- Check Oil Warning Light (If Equipped)
- Brake System Warning Light
- Amp Charging System Warning Light
- Oil Pressure Warning Light
- Anti-Lock Brake System Light (If Equipped)
- Light Out Warning Light (If Equipped)
- Low Coolant Warning Light
- Error Message (Electronic Cluster)
- Service Message (Electronic Cluster)
- Air Bag Warning Light Or Tone
- Service Indicator & Warning Lights
- Maintenance Information
- Procedures
- Restraints
- Air Bag, SRS
- Air Bag Restraint System
- Identification
- Description & Operation
- Service Precautions
- Disabling & Activating Air Bag System
- Post-Collision Inspection
- Adjustments
- Disposal Procedures
- Removal & Installation
- Testing - System Operation Check
- Wire Repair
- Torque Specifications
- Self-Diagnostics
- Supplemental Inflatable Restraint System - Post-Collision Air Bag Safety Inspection
- Supplemental Inflatable Restraint System -- Air Bag/SRS Component Inspection & Replacement Tables
- Air Bag Restraint System
- Restraints Control Systems
- Seat Belts
- Air Bag, SRS
- Steering
- Manual Steering
- Power Steering General Servicing
- Power Steering Pump
- Steering Gear - Except 2.5L
- Description & Operation
- Component Location
- Diagnosis & Testing
- Pinpoint Test A1: Module Check
- Pinpoint Test A2: Module Check (Cont.)
- Pinpoint Test A3: Fuse Check
- Pinpoint Test A4: Test Drive Vehicle
- Pinpoint Test A5: Speedometer Check
- Pinpoint Test A6: Speed Sensor Circuit Check
- Pinpoint Test A7: Actuator Electrical Check
- Pinpoint Test A8: Harness Voltage At Actuator Connector Check
- Pinpoint Test A9: Actuator Mechanical Check
- Pinpoint Test A10: Actuator Electrical Check
- Pinpoint Test A11: Continuity Check
- Pinpoint Test A12: VAPS Harness & Connectors Check
- Pinpoint Test A13: VAPS Harness & Connectors Check (Cont.)
- Pinpoint Test A14: VAPS Harness & Connectors Check (Cont.)
- Pinpoint Test A15: Actuator Electrical Check
- Pinpoint Test A16: VAPS Harness & Connectors Check
- Pinpoint Test A17: VAPS Harness & Connectors Check
- Pinpoint Test A18: Continuity Check
- Pinpoint Test A19: VAPS Harness & Connectors Check (VIP Pin)
- Pinpoint Test A20: VAPS Harness & Connectors Check
- Wheel Alignment
- Lubrication
- Adjustments
- Removal & Installation
- Overhaul
- Torque Specifications
- Wiring Diagram
- Steering Gear - Integral Rack & Pinion
- Description & Operation
- Trouble Shooting
- Lubrication & Testing
- Adjustments
- Removal & Installation
- Steering Gear
- Removal (Cougar & Thunderbird)
- Installation (Cougar & Thunderbird)
- Removal (Escort, Tempo 2WD & Topaz)
- Installation (Escort, Tempo 2WD & Topaz)
- Removal (Tempo AWD)
- Installation (Tempo AWD)
- Removal (Mark VII)
- Installation (Mark VII)
- Removal (Mustang)
- Installation (Mustang)
- Removal (Sable & Taurus)
- Installation (Sable & Taurus)
- Steering Gear
- Overhaul
- Wheel Alignment
- Torque Specifications
- Power Steering
- Power Steering General Servicing
- Power Steering Pump
- Steering Gear - Except 2.5L
- Description & Operation
- Component Location
- Diagnosis & Testing
- Pinpoint Test A1: Module Check
- Pinpoint Test A2: Module Check (Cont.)
- Pinpoint Test A3: Fuse Check
- Pinpoint Test A4: Test Drive Vehicle
- Pinpoint Test A5: Speedometer Check
- Pinpoint Test A6: Speed Sensor Circuit Check
- Pinpoint Test A7: Actuator Electrical Check
- Pinpoint Test A8: Harness Voltage At Actuator Connector Check
- Pinpoint Test A9: Actuator Mechanical Check
- Pinpoint Test A10: Actuator Electrical Check
- Pinpoint Test A11: Continuity Check
- Pinpoint Test A12: VAPS Harness & Connectors Check
- Pinpoint Test A13: VAPS Harness & Connectors Check (Cont.)
- Pinpoint Test A14: VAPS Harness & Connectors Check (Cont.)
- Pinpoint Test A15: Actuator Electrical Check
- Pinpoint Test A16: VAPS Harness & Connectors Check
- Pinpoint Test A17: VAPS Harness & Connectors Check
- Pinpoint Test A18: Continuity Check
- Pinpoint Test A19: VAPS Harness & Connectors Check (VIP Pin)
- Pinpoint Test A20: VAPS Harness & Connectors Check
- Wheel Alignment
- Lubrication
- Adjustments
- Removal & Installation
- Overhaul
- Torque Specifications
- Wiring Diagram
- Steering Gear - Integral Rack & Pinion
- Description & Operation
- Trouble Shooting
- Lubrication & Testing
- Adjustments
- Removal & Installation
- Steering Gear
- Removal (Cougar & Thunderbird)
- Installation (Cougar & Thunderbird)
- Removal (Escort, Tempo 2WD & Topaz)
- Installation (Escort, Tempo 2WD & Topaz)
- Removal (Tempo AWD)
- Installation (Tempo AWD)
- Removal (Mark VII)
- Installation (Mark VII)
- Removal (Mustang)
- Installation (Mustang)
- Removal (Sable & Taurus)
- Installation (Sable & Taurus)
- Steering Gear
- Overhaul
- Wheel Alignment
- Torque Specifications
- Steering Column
- Description
- Trouble Shooting
- Safety Precautions
- Shift Indicator Cable Adjustments
- Removal & Installation
- Back-Up Power Supply (Vehicles With Air Bag)
- Notes
- Removal (Continental)
- Installation (Continental)
- Removal (Crown Victoria & Grand Marquis)
- Installation (Crown Victoria & Grand Marquis)
- Removal (Mark VII)
- Installation (Mark VII)
- Removal (Mustang)
- Installation (Mustang)
- Removal (Sable & Taurus)
- Installation (Sable & Taurus)
- Removal (Tempo & Topaz)
- Installation (Tempo & Topaz)
- Removal (Town Car)
- Installation (Town Car)
- Contact Assembly R & I
- Ignition Switch
- Lock Cylinder (Functional)
- Lock Cylinder (Non-Functional)
- Notes
- Removal (Continental)
- Installation (Continental)
- Removal (Cougar, Escort, Mustang, Tempo, Thunderbird & Topaz)
- Installation (Cougar, Escort, Mustang, Tempo, Thunderbird & Topaz)
- Removal (Crown Victoria, Grand Marquis, Mark VII, Sable, Taurus & Town Car)
- Installation (Crown Victoria, Grand Marquis, Mark VII, Sable, Taurus & Town Car)
- Lock Cylinder Gear R & I
- Lock Cylinder Housing
- Removal & Installation (Continental)
- Removal (Cougar & Thunderbird Non-tilt Wheel)
- Installation (Cougar & Thunderbird Non-tilt Wheel)
- Removal (Cougar & Thunderbird Tilt Wheel)
- Installation (Cougar & Thunderbird Tilt Wheel)
- Removal & Installation (Crown Victoria, Grand Marquis, Mark VII, Sable, Taurus & Town Car)
- Removal (Escort, Tempo & Topaz Non-Tilt Wheel)
- Installation (Escort, Tempo & Topaz Non-Tilt Wheel)
- Removal (Escort, Tempo & Topaz Tilt Wheel)
- Installation (Escort, Tempo & Topaz Tilt Wheel)
- Removal & Installation (Mustang)
- Multi-Function Switch R & I
- Shaft Bearing (Upper)
- Removal (Continental)
- Installation (Continental)
- Removal (Cougar & Thunderbird Non-Tilt Wheel)
- Installation (Cougar & Thunderbird Non-Tilt Wheel)
- Removal (Cougar & Thunderbird Tilt Wheel)
- Installation (Cougar & Thunderbird Tilt Wheel)
- Removal (Crown Victoria, Grand Marquis, Mark VII, Sable, Taurus & Town Car)
- Installation (Crown Victoria, Grand Marquis, Mark VII, Sable, Taurus & Town Car)
- Removal (Escort, Tempo & Topaz Non-Tilt Wheel)
- Installation (Escort, Tempo & Topaz Non-Tilt Wheel)
- Removal (Escort, Tempo & Topaz Tilt Wheel)
- Installation (Escort, Tempo & Topaz Tilt Wheel)
- Removal (Mustang)
- Installation (Mustang)
- Removal & Installation (Probe)
- Steering Column R & I
- Removal (Continental)
- Installation (Continental)
- Removal (Cougar & Thunderbird)
- Installation (Cougar & Thunderbird)
- Removal (Crown Victoria, Grand Marquis, Mark VII, Sable, Taurus & Town Car)
- Installation (Crown Victoria, Grand Marquis, Mark VII, Sable, Taurus & Town Car)
- Removal (Escort, Tempo & Topaz)
- Installation (Escort, Tempo & Topaz)
- Removal (Mustang)
- Installation (Mustang)
- Removal (Probe)
- Installation (Probe)
- Steering Wheel R & I
- Notes
- Removal (Continental)
- Installation (Continental)
- Removal (Crown Victoria, Grand Marquis, Mark VII, Sable, Taurus & Town Car)
- Installation (Crown Victoria, Grand Marquis, Mark VII, Sable, Taurus & Town Car)
- Removal (Escort, Cougar, Mustang, Tempo, Thunderbird & Topaz)
- Installation (Escort, Cougar, Mustang, Tempo, Thunderbird & Topaz)
- Removal (Probe)
- Installation (Probe)
- Back-Up Power Supply (Vehicles With Air Bag)
- Overhaul
- Steering Linkage
- Manual Steering
- Suspension
- Front Suspension
- Suspension - Front
- Description
- Caster & Camber Adjustments
- Riding Height Adjustments
- Front Wheel Bearings
- Ball Joint Checking
- Removal & Installation
- Torque Specifications
- Suspension - Front
- Rear Suspension
- Wheel Alignment
- Front Suspension
- Transmission
- Clutches
- Manual Trans
- Overhaul - MTX III & IV 5-Speed
- Application
- Identification
- Description
- Lubrication & Adjustments
- On-Vehicle Service
- Trouble Shooting
- Removal & Installation
- Transaxle Disassembly
- Component Disassembly & Reassembly
- Adjustments
- Cleaning & Inspection
- Transaxle Reassembly
- Torque Specifications
- Overhaul - MTX III & IV 5-Speed
- External Pages