Repair and Diagnosis (Single Page)
You are viewing the full "tree" of links on one page. This can load slowly, but is easier to search. The same page can appear multiple times under a different folder, that is why the page is so large.View "split tree" where inner folders are split out. where inner links are on separate pages.
Quick Lookups- Accessories & Equipment
- Anti-Theft Systems
- Cruise Control Systems
- Description & Operation
- Adjustments
- Testing
- Notes
- Speed Control Does Not Work
- Speed Control Is Intermittent
- Speed CTRL Operates But Does Not Resume, Accelerate Or Coast Down
- Speed Varies Up & Down
- Speed Control Does Not Disengage When Brakes Are Applied
- Speed Will Not Set
- Speed Control Does Not Disengage When Clutch Pedal Is Pressed
- Speed Gradually Increases Or Decreases After Speed Is Set
- Speed Decreases On Steep Grades Or Under Heavy Loads
- Control Switch & Circuit Test
- Speed Sensor Test
- Servo Test
- Amplifier Test
- Horn Relay Circuit Test
- Clutch Switch Test
- BRAKELIGHT Switch Test
- Vacuum Dump Valve Test
- Vacuum Reservoir Test
- Removal & Installation
- Wiring Diagrams
- Gauges & Instrument Panels
- Fuel Selector Valves
- Instrument Panel
- Heated Glass/Defoggers
- Steering Column Switches
- Window Motors & Regulators
- Power Windows
- Description & Operation
- Component Locations
- On-Vehicle Service
- Adjustments
- Component Tests
- Removal & Installation
- Door Trim Panel (Bronco & F-Series)
- Door Trim Panel (ECONOLINE)
- Door Inside Handle (Bronco & F-Series, Except F-350 Crew Cab Rear Door)
- Door Inside Handle (ECONOLINE)
- Door Lock Control Switch (Bronco & F-Series)
- Door Lock Control Switch (ECONOLINE)
- Front Door Glass (Bronco & F-Series)
- Front Door Glass (ECONOLINE)
- Movable Glass Weatherstrip (ECONOLINE)
- Tailgate Glass (Bronco)
- Tailgate Window Regulator Switch (Instrument Panel Mounted, Bronco)
- Tailgate Window Regulator Switch (Tailgate Mounted, Bronco)
- Tailgate Window Regulator Electric Motor (Bronco)
- Tailgate Window Regulator (Bronco)
- Window Motor
- Window Switch (Bronco & F-Series)
- Window Switch (ECONOLINE)
- Special Tools
- Torque Specifications
- Wiring Diagrams
- Power Windows
- Wiper/Washer Systems
- Description
- Adjustment
- Wiper Arm & Blade Assembly Adjustment
- Standard Wiper System Diagnosis & Tests (Bronco & "F" Series)
- Standard Wiper System Diagnosis & Tests ("E" Series)
- Interval Wiper System Diagnosis & Tests (Bronco & "F" Series)
- Interval Wiper System Diagnosis & Tests ("E" Series)
- Wiper Motor Current Draw Diagnosis & Test
- Circuit Breaker Diagnosis & Test
- Wiper Switch Continuity Diagnosis & Test
- Interval Governor Diagnosis & Test
- Washer Pump Motor Current Draw Diagnosis & Test
- Removal & Installation
- Overhaul
- Body & Frame
- Door Locks - Power
- Power Windows
- Description & Operation
- Component Locations
- On-Vehicle Service
- Adjustments
- Component Tests
- Removal & Installation
- Door Trim Panel (Bronco & F-Series)
- Door Trim Panel (ECONOLINE)
- Door Inside Handle (Bronco & F-Series, Except F-350 Crew Cab Rear Door)
- Door Inside Handle (ECONOLINE)
- Door Lock Control Switch (Bronco & F-Series)
- Door Lock Control Switch (ECONOLINE)
- Front Door Glass (Bronco & F-Series)
- Front Door Glass (ECONOLINE)
- Movable Glass Weatherstrip (ECONOLINE)
- Tailgate Glass (Bronco)
- Tailgate Window Regulator Switch (Instrument Panel Mounted, Bronco)
- Tailgate Window Regulator Switch (Tailgate Mounted, Bronco)
- Tailgate Window Regulator Electric Motor (Bronco)
- Tailgate Window Regulator (Bronco)
- Window Motor
- Window Switch (Bronco & F-Series)
- Window Switch (ECONOLINE)
- Special Tools
- Torque Specifications
- Wiring Diagrams
- Brakes
- Anti-Lock Brakes
- Anti-Lock Brake Safety Precautions
- Description & Operation
- Bleeding Brake System
- Trouble Shooting
- Diagnosis
- Retrieving Trouble Codes
- Trouble Codes
- No Codes
- Code 1
- Code 2 (Open Isolate Circuit)
- Code 3 (Open Dump Circuit)
- Code 4 (Closed Valve Switch Or Open Dump Valve) Bronco, "E" & "F" Series
- Aerostar, Explorer, Ranger & Navajo
- Code 5 (System Dumps Too Many Times)
- Code 6 (Speed Sensor Signal Rapidly Cuts In And Out)
- Code 7 (No Isolate Valve Self-Test)
- Code 8 (No Dump Valve Self-Test)
- Code 9 (High Sensor Resistance)
- Code 10 (Low Sensor Resistance)
- Code 11 (Stoplight Switch Circuit)
- Code 12 (Fluid Level Switch Closed During A Stop) Bronco, "E" & "F" Series
- Code 12 (Loss Of Brake Fluid For One Second During Stop) Aerostar, Explorer, Navajo & Ranger
- Code 13 (Speed Sensor Check)
- Code 14 (Program Check)
- Code 15 (Memory Failure)
- Code 16 (Aerostar)
- Testing
- Notes
- Test A - Yellow Light Off & Does Not Self-Check
- Test B - Red Light On, Yellow Light Off & Does Self-Check
- Test C - Yellow & Red Lights On Steady
- Test D - Yellow Light On, Red Light Off
- Test E - Yellow Light Flashing & Red Light Off
- Test F - Lights Okay & Rear Wheels Lock-Up
- Test G - Yellow Light Self-Checks, Red Light Does Not Self-Check
- Removal & Installation
- Torque Specifications
- Wiring Diagrams
- Mechanical - Hydraulic
- Disc & Drum
- Description & Operation
- Bleeding Brake System
- Adjustments
- Trouble Shooting
- Removal & Installation
- Disc Brake Calipers & Pads
- Brake Shoes (Except E250/350 & F250/350)
- Brake Shoes (E250/350 & F250/350)
- Brake Rotor (2WD Models)
- Brake Rotor (AEROSTAR 4WD)
- Brake Rotor (Explorer & Ranger 4WD W/Automatic Locking Hubs)
- Brake Rotor (Explorer & Ranger 4WD W/Manual Locking Hubs)
- Brake Rotor (Bronco & F150 4WD W/Automatic & Manual Locking Hubs, F250, F250 H.D. & F350 4WD W/Manual Locking Hubs)
- Brake Rotor ("F" Series Super Duty)
- Wheel Cylinders
- Master Cylinder
- Vacuum Power Booster (All Except "F" Series Super Duty)
- Hydro-Boost ("F" Series Super Duty)
- Transmission Mounted Parking Brake ("F" Series Super Duty)
- Stoplight Switch
- Height Sensing Proportioning Valve ("F" Series Super Duty)
- Brake Booster Vacuum Pump (7.3L Diesel)
- Low Vacuum Switch (7.3L Diesel)
- Cable Tension Release (AEROSTAR)
- Overhaul
- Torque Specifications
- Disc Brake Specifications
- Drum Brake Specifications
- Disc & Drum
- Traction Control
- Anti-Lock
- Anti-Lock Brake Safety Precautions
- Description & Operation
- Bleeding Brake System
- Trouble Shooting
- Diagnosis
- Retrieving Trouble Codes
- Trouble Codes
- No Codes
- Code 1
- Code 2 (Open Isolate Circuit)
- Code 3 (Open Dump Circuit)
- Code 4 (Closed Valve Switch Or Open Dump Valve) Bronco, "E" & "F" Series
- Aerostar, Explorer, Ranger & Navajo
- Code 5 (System Dumps Too Many Times)
- Code 6 (Speed Sensor Signal Rapidly Cuts In And Out)
- Code 7 (No Isolate Valve Self-Test)
- Code 8 (No Dump Valve Self-Test)
- Code 9 (High Sensor Resistance)
- Code 10 (Low Sensor Resistance)
- Code 11 (Stoplight Switch Circuit)
- Code 12 (Fluid Level Switch Closed During A Stop) Bronco, "E" & "F" Series
- Code 12 (Loss Of Brake Fluid For One Second During Stop) Aerostar, Explorer, Navajo & Ranger
- Code 13 (Speed Sensor Check)
- Code 14 (Program Check)
- Code 15 (Memory Failure)
- Code 16 (Aerostar)
- Testing
- Notes
- Test A - Yellow Light Off & Does Not Self-Check
- Test B - Red Light On, Yellow Light Off & Does Self-Check
- Test C - Yellow & Red Lights On Steady
- Test D - Yellow Light On, Red Light Off
- Test E - Yellow Light Flashing & Red Light Off
- Test F - Lights Okay & Rear Wheels Lock-Up
- Test G - Yellow Light Self-Checks, Red Light Does Not Self-Check
- Removal & Installation
- Torque Specifications
- Wiring Diagrams
- Anti-Lock
- Anti-Lock Brakes
- Drivelines & Axles
- Differentials & Drive Axles
- Differential - 8.75" & 10.25"
- Axle Ratio & Identification
- Description
- Removal & Installation
- Overhaul
- Differential Assembly
- Notes
- Disassembly
- Cleaning & Inspection
- Anti-Lock Brake Sensor
- Exciter Ring
- Bearing Races
- Bearing & Roller Assemblies
- Companion Flange
- Gears
- Axle Housing
- Differential Case
- Reassembly & Adjustments
- Pinion Depth
- Pinion Bearing Preload
- Differential Bearing Preload & Ring Gear Backlash
- Ring Gear Runout & Backlash Testing
- Final Assembly
- Differential Specifications
- Differential Assembly
- Torque Specifications
- Drive Axle - 7.5" & 8.75" TRAC-LOK Limited Slip
- Drive Axle - DANA Limited Slip
- Drive Axle - Front (DANA Ifs)
- Identification
- Description
- Trouble Shooting
- Removal & Installation
- Hubs & Bearings R & I
- Notes
- Removal (Explorer & Ranger With Dana 35 IFS)
- Installation & Adjustment (With Manual Locking Hubs)
- Installation & Adjustment (With Automatic Locking Hubs)
- Removal (Bronco & F150/250 With Manual Locking Hubs)
- Installation & Adjustment (Bronco & F150/250 With Manual Locking Hubs)
- Removal (Bronco & F150 With Dana 44 IFS & Automatic Locking Hubs & F250 HD With Dana 50 IFS
- Installation & Adjustment (Bronco & F150 With Dana 44 IFS & Automatic Locking Hubs & F250 HD With Dana 50 IFS
- Spindles & Axle Shafts
- Stub Shaft & Slip Yoke, Carrier & Bearing
- Axle Pivot Bushing
- Carrier Housing Assembly
- Hubs & Bearings R & I
- Overhaul
- Torque Specifications
- Drive Axle Ratio Identification
- Differential - 8.75" & 10.25"
- Driveshaft & Universal Joints
- Locking Hubs
- Differentials & Drive Axles
- Electrical
- Charging Systems
- Component Locations
- Fuses & Circuit Breakers
- Gauges
- Fuel Selector Valves
- Instrument Panel
- Starter
- Wiring Diagrams
- Engine Mechanical
- Accessory Drive Belts
- Cooling System (Mechanical)
- Mechanical
- 4.9L 6-CYL - VIN [Y]
- Engine Identification
- Adjustments
- Removal & Installation
- Overhaul
- Lubrication
- Engine Cooling
- Torque Specifications
- Engine Specifications
- 4.9L 6-CYL - VIN [Y]
- Starter
- Engine Performance
- Engine Controls - Adjustments
- Adjustments
- Engine Mechanical
- Valve Clearance
- Ignition Timing
- 7.3L Diesel Injection Timing
- Idle Speed & Mixture
- Gasoline Engines
- 7.3L Diesel
- Idle Adjustment Precautions
- 2.3L OHC, 3.0L, 4.0L & 7.5L W/Sludge Tolerant Throttle Body
- 2.9L, 4.0L & 7.5L Without Sludge Tolerant Throttle Body
- 5.0L (Except E4OD), 5.8L (Over 8500 GVW), E250 W/O 0-64K Calibration
- 4.9L, 5.0L (W/ E4OD), 5.8L (Under 8500 GVW), E250 W/ 0-64K Calibration & All 1991 1/2 5.8L
- Throttle Position Sensor (TPS)
- Fuel Injection Pump Lever (FIPL) Sensor
- Adjustments
- Application
- Emissions
- Base Ignition Timing Specifications
- Calibration Labels
- EGR Function Testing - Ford - Trucks
- Emission Applications
- Emission Control Abbreviations
- State Emission Standards - Diesel
- State Emission Standards - Gas
- ALASKA
- ARIZONA
- CALIFORNIA
- Colorado
- CONNECTICUT
- DELAWARE
- District Of COLUMBIA
- GEORGIA
- IDAHO
- ILLINOIS
- INDIANA
- KENTUCKY
- MARYLAND
- MASSACHUSETTS
- MISSOURI
- NEVADA
- New Jersey
- New MEXICO
- New YORK
- North CAROLINA
- OHIO
- OREGON
- PENNSYLVANIA
- RHODE Island
- TENNESSEE
- TEXAS
- UTAH
- VIRGINIA
- WASHINGTON
- WISCONSIN
- U. S. EPA ASM2525 & ASM5015 Start-Up Emission Standards
- U. S. EPA Revised Final ASM Emission Standards (ASM5015 & ASM2525)
- U.S. EPA Im240 Emission Standards
- Engine Controls - Pin Voltage Charts
- Introduction
- ECA Location
- EEC-IV Inputs Resistance Values
- EEC-IV Outputs Resistance Values
- 2.3L PFI Ranger - Test Pin Voltage Values
- Notes
- 2.3L (A/T) Ranger Pin Voltage Specifications
- 2.3L (A/T) Ranger Pin Voltage Specifications (Actuators/Outputs)
- 2.3L (A/T) Ranger Ignition Timing Specifications
- 2.3L (M/T) Ranger Pin Voltage Specifications
- 2.3L (M/T) Ranger Pin Voltage Specifications (Actuators/Outputs)
- 2.3L (M/T) Ranger Ignition Timing Specifications
- 2.9L PFI Ranger - Test Pin Voltage Values
- Notes
- 2.9L (A/T) Ranger Pin Voltage Specifications
- 2.9L (A/T) Ranger Pin Voltage Specifications (Actuators/Outputs)
- 2.9L (A/T) Ranger Ignition Timing Specifications
- 2.9L (M/T) Ranger Pin Voltage Specifications
- 2.9L (M/T) Ranger Pin Voltage Specifications (Actuators/Outputs)
- 2.9L (M/T) Ranger Ignition Timing Specifications
- 3.0L PFI AEROSTAR & Ranger - Test Pin Voltage Values
- Notes
- 3.0L (A/T) AEROSTAR Pin Voltage Specifications (Sensors/Inputs)
- 3.0L (A/T) AEROSTAR Pin Voltage Specifications (Actuators/Outputs)
- 3.0L (A/T) AEROSTAR Ignition Timing Specifications
- 3.0L (M/T) AEROSTAR Pin Voltage Specifications
- 3.0L (M/T) AEROSTAR Pin Voltage Specifications (Actuators/Outputs)
- 3.0L (M/T) AEROSTAR Ignition Timing Specifications
- 3.0L (A/T) Ranger Pin Voltage Specifications
- 3.0L (A/T) Ranger Ignition Timing Specifications
- 3.0L (M/T) Ranger Pin Voltage Specifications
- 3.0L (M/T) Ranger Ignition Timing Specifications
- 4.0L PFI AEROSTAR, Explorer, NAVAJO & Ranger - Test Pin Voltages
- Notes
- 4.0L A/T AEROSTAR, Explorer, NAVAJO & Ranger Pin Volt
- 4.0L (A/T) Explorer, NAVAJO & Ranger Pin Values (Actuators/Outputs)
- 4.0L (A/T) Explorer, NAVAJO & Ranger Timing Specifications
- 4.0L (M/T) Explorer, NAVAJO & Ranger Pin Voltage
- 4.0L (M/T) Explorer, NAVAJO & Ranger Pin Values
- 4.0L (M/T) Explorer, NAVAJO & Ranger Timing Specifications
- 4.9L PFI Bronco, "E" & "F" Series - Test Pin Voltage Values
- Notes
- 4.9L (A/T) Bronco, "E" & "F" (Exc. E4OD) Pin Voltage
- 4.9L (A/T) Bronco,"E"&"F" (Exc. E4OD) Pin Voltage
- 4.9L (A/T) Bronco, "E" & "F" Series (Exc. E4OD) Timing Specs
- 4.9L (A/T) Bronco, "E" & "F" (E4OD) Pin Voltage
- 4.9L Bronco, "E" & "F" Series (E4OD) Pin Voltage
- 4.9L Bronco, "E" & "F" Series (E4OD) Timing Specs
- 4.9L (M/T) Bronco, "E" & "F" Series Pin Voltage
- 4.9L (M/T) Bronco,"E"&"F" Series Pin Voltage
- 4.9L (M/T) Bronco, "E" & "F" Series Timing Specs
- 5.0L PFI Bronco, "E" & "F" Series - Test Pin Voltage Values
- Notes
- 5.0L (A/T) Bronco,"E" & "F" (Except E4OD) Pin Voltage
- 5.0L (A/T) Bronco, "E"&"F" (Exc. E4OD) Pin Voltage (Actuators/Outputs)
- 5.0L (A/T) Bronco, "E" & "F" Series (Except E4OD) Timing Specs
- 5.0L (A/T) Bronco,"E" & "F" (E4OD) Pin Voltage Values
- 5.0L (A/T) Bronco,"E"&"F" (E4OD) Pin Voltage (Actuators/Outputs)
- 5.0L (A/T) Bronco, "E" & "F" Series (E4OD) Timing Specs
- 5.0L (M/T) Bronco,"E" & "F" Series Pin Voltage (Sensors/Inputs)
- 5.0L (M/T) Bronco,"E"&"F" Series Pin Voltage
- 5.0L (M/T) Bronco, "E" & "F" Series Timing Specs
- 5.8L PFI ECM Test Pin Voltage Values
- Notes
- 5.8L (A/T) "E" & "F" (Except E4OD) Series Pin Voltage
- 5.8L (A/T) "E"&"F"(Except E4OD) Series Pin Voltage
- 5.8L (A/T) "E" & "F" (Except E4OD) Series Timing Specs
- 5.8L (A/T) Bronco,"E" & "F" Series (E4OD) Pin Voltage
- 5.8L (A/T) Bronco,"E"&"F" (E4OD) Pin Voltage
- 5.8L (A/T) Bronco, "E" & "F" Series (E4OD) Timing Specs
- 5.8L (M/T) "E" & "F" Series Pin Voltage
- 5.8L (M/T) "E" & "F" Series Pin Voltage Values
- 5.8L (M/T) "E" & "F" Series Timing Specs
- 7.3L Diesel ECM Test Pin Voltage Values
- 7.5L PFI "E" & "F" Series - Test Pin Voltage Values
- Notes
- 7.5L (A/T) "E" & "F" Series (Except E4OD) Pin Voltage
- 7.5L (A/T) "E" & "F" Series (Except E4OD) Timing Specs
- 7.5L (A/T) "E" & "F" Series (E4OD) Pin Voltage Values
- 7.5L (A/T) "E" & "F" Series (E4OD) Pin Voltage
- 7.5L (A/T) "E" & "F" Series (E4OD) Timing Specs
- 7.5L (M/T) "E" & "F" Series Pin Voltage Values
- 7.5L (M/T) "E" & "F" Series Timing Specs
- Remove, Overhaul & Install
- Engine Controls - Remove/Install/Overhaul
- Introduction
- Ignition System
- Fuel System (Gasoline)
- Fuel System Pressure Release
- Fuel Pressure Release
- Fuel Pump (All Except "E" Series)
- Fuel Pump ("E" Series High Pressure)
- Fuel Pump ("E" Series Low Pressure)
- Fuel Supply Manifold Assembly (2.3L)
- Fuel Supply Manifold Assembly (2.9L)
- Fuel Supply Manifold Assembly (3.0L)
- Fuel Supply Manifold Assembly (4.0L)
- Fuel Supply Manifold Assembly (4.9L)
- Fuel Supply Manifold Assembly (5.0L, 5.8L & 7.5L)
- Fuel Injectors (2.3L & 3.0L)
- Fuel Injectors (2.9L & 4.0L)
- Fuel Injectors (4.9L, 5.0L, 5.8L & 7.5L)
- Fuel Pressure Regulator (2.3L, 2.9L 3.0L & 4.0L)
- Removal (4.9L, 5.0L, 5.8L & 7.5L)
- Heated Exhaust Gas Oxygen (HEGO) Sensor
- Push-Connect Fittings
- Fuel Line Coupler Removal & Installation
- Upper Intake Manifold & Throttle Body (2.3L)
- Upper Intake Manifold & Throttle Body (2.9L)
- Upper Intake Manifold & Throttle Body (3.0L)
- Upper Intake Manifold & Throttle Body (4.0L)
- Upper Intake Manifold & Throttle Body (4.9L)
- Upper Intake Manifold & Throttle Body (5.0L, 5.8L & 7.5L)
- Fuel System (Diesel)
- Throttle Position Sensor (TPS)
- Torque Specifications
- Engine Controls - Remove/Install/Overhaul
- Sensor Range Charts
- Specifications
- Engine Controls - Specifications - 6-CYL
- Engine Controls - Specifications - V8
- Fuel Pressure Specifications
- System
- EGR Function Testing
- Engine Controls - Basic Testing
- Introduction
- Preliminary Inspection & Adjustments
- Compression
- Exhaust System BACKPRESSURE
- No-Start Diagnosis
- DISTRIBUTORLESS Ignition System (Dis) 2.3L
- Notes
- Test 1, Check ECA For Fault Codes
- Test 2, Check For Spark During Crank
- Test 3, Check Dis Module Pip Out
- Test 4, Check Pip Out Continuity
- Test 5, Determine Missing Spark Combination
- Test 6, Check Plugs & Wires
- Test 7, Check Dis Module VBAT
- Test 8, Check Dis Module Ignition Ground
- Test 9, Check Dis Module Mounting Screws
- Test 10, Check Right Coil Pack Circuits
- Test 11, Right Coil Pack Fault, Isolate Dis Module
- Test 12, Check Right Coil Pack VBAT
- Test 13, Check Right Coil Circuit
- Test 14, Check Pip D At Dis Module
- Test 15, Check Dis Module Coil Drivers
- Test 16, Check Right Coil Pack VBAT
- Test 17, Check Right Coil Circuit
- Test 18, Check Right Coil Circuit
- Test 19, Isolate Dis Module From Pip D
- Test 20, Check Crankshaft Sensor VBAT
- Test 21, Check Crankshaft Sensor Ignition Ground
- Test 22, Check Crankshaft Sensor Pip S
- Test 23, Check Pip Circuit For Short To Ground
- Test 24, Check Pip Circuit For Short To VBAT
- Test 25, Check Crankshaft Vane
- Test 26, Isolate EEC-IV Processor (ECA) From Pip Circuit
- Test 27, Check Pip EEC Circuit For Short To VBAT
- Test 28, Check Pip EEC Circuit For Short To Ground
- Electronic DISTRIBUTORLESS Ignition System (EDIS) 4.0L Engine
- Notes
- Test 1, Check ECA For Fault Codes
- Test 2, Check For Spark During Crank
- Test 3, Check Pip At EDIS Module
- Test 4, Check Pip Continuity To EEC
- Test 5, Check IGND At EDIS
- Test 6, Check IGND Continuity To EEC
- Test 7, Check Plugs & Wires
- Test 8, Isolate EDIS Module/Pip Fault
- Test 9, Check Pip Circuit For Short To Ground
- Test 10, Check Pip Circuit For Short To Power
- Test 11, Check PWR GND To EDIS Module
- Test 12, Check PERF. W/O EDIS Diagnostic Cable Installed
- Test 13, Check PWR GND To EDIS Module
- Test 14, Check For VBAT Open To EDIS Module
- Test 15, Check VRS+ Bias At EDIS Module
- Test 16, Check VRS Amplitude At EDIS Module
- Test 17, Check VRS+ Bias/Isolate VRS/Bias Fault
- Test 18, Check VRS+ High Or Low/Bias Fault
- Test 19, Check VRS+ Circuit For Short To Ground
- Test 20, Check VRS+ Circuit For Short To VBAT
- Test 21, Check VRS Bias
- Test 22, Check VRS High Or Low/Bias Fault
- Test 23, Check VRS Circuit For Short To Ground
- Test 24, Check VRS Circuit For Short To VBAT
- Test 25, Check VRS Amplitude At EDIS Module
- Test 26, Check VRS Resistance
- Test 27, Check VRS Air Gap & Trigger Wheel
- Test 28, Check VRS High Or Low Resistance
- Test 29, Check VRS+ Shorted To VRS
- Test 30, Check VRS+ For Open Circuit
- Test 31, Check VRS For Open Circuit
- Test 32, Check For IDM Short High
- Test 33, Check For IDM Open Circuit
- Test 34, Check IDM Output From EDIS Module
- Test 35, Check For IDM Short In ECA
- Test 36, Check For IDM Short To Ground In Harness
- Test 37, Check For IDM Short To VBAT In Harness
- Test 38, Check Base Timing
- Test 39, Check Advance Spark Angle
- Test 40, Check Saw At EDIS Module
- Test 41, Check Saw For Short In EDIS Module
- Test 42, Check For Saw Short To Ground In Harness
- Test 43, Check For Saw Short To VBAT In Harness
- Test 44, Check For Saw Open
- Test 45, Inspect VR Sensor & Trigger Wheel
- Test 46, Check VBAT Open To Coil
- Test 47, Verify Vehicle Operating Mode
- Test 48, Check C1, C2 & C3 At Coil Pack
- Test 49, Check C1, C2 & C3 At Coil Pack
- Test 50, Check C1, C2 & C3 At Coil Pack
- Test 51, Check C1, C2 & C3 At EDIS
- Test 52, Check C1, C2 & C3 At Coil Pack
- Test 53, Check C1, C2 & C3 At Coil Pack
- Test 54, Check C1, C2 & C3 Coil Primary
- Test 55, Check C1, C2 & C3 For Short To Ground
- Test 56, Check C1, C2 & C3 For Short To Ground
- Thick Film Ignition (TFI) IV
- Fuel System
- Idle Speed & Ignition Timing
- Throttle Position Sensor (TPS) Adjustment
- Fuel Injection Pump Lever (FIPL) Sensor Adjustment
- Summary
- Engine Controls - System/Component Tests
- Introduction
- Electronic Control Assembly (ECA)
- Engine Sensors & Switches (ECA Inputs)
- Notes
- Air Charge Temperature (Act) Sensor
- Barometric Pressure Sensor (BP)
- Clutch Switch
- Cylinder Identification Sensor (CID) & Crankshaft Sensor
- Engine Coolant Temperature (ECT) Sensor
- EGR Valve Position (EVP) Sensor/EGR Vacuum Regulator (EVR) Solenoid
- Engine Rpm Sensor (RPMS)
- Fuel Injection Pump Lever (FIPL) Sensor
- Heated Exhaust Gas Oxygen (HEGO) Sensor
- Inertia Switch
- Knock Sensor (KS)
- Manifold Absolute Pressure (Map) Sensor
- Mass Airflow (MAF) Sensor
- Neutral Drive Switch (NDS) A/C Input
- Power Steering Pressure Switch (PSPS)
- Throttle Position Sensor (TP Or TPS)
- Vehicle Speed Sensor (VSS)
- Modules, Motors, Relays & Solenoids
- Fuel System
- Idle Control System
- Ignition System Identification
- TFI-IV System Ignition
- Notes
- Preliminary Check
- Test Equipment
- Diagnostic Aids
- Primary Circuit Test (Except Closed Bowl Distributor)
- Primary Circuit Test (Closed Bowl Distributor)
- TFI Module Resistance Test
- Pip Sensor/Stator Test (Except Closed Bowl Distributor)
- Pip Sensor/Stator Test (Closed Bowl Distributor)
- Coil Test
- Spark Timing Advance Test
- Dis System (2.3L Ranger)
- EDIS System (4.0L AEROSTAR, Explorer, NAVAJO & Ranger)
- Emission Systems & Sub-Systems
- Air Injection
- Air Supply Pump
- Air Silencer/Filter (Air Pump & Pulse Air Inlet)
- Air By-Pass Valve (Normally Closed)
- Air Check Valve
- Air Supply Control Valve
- Air Control Valve (Switch-Relief)
- Air Pump Resonator
- Combination Air By-Pass/Air Control Valve
- Dual Thermactor Air Control Solenoid Valve
- Thermactor Idle Vacuum (TIV) Valve
- Vacuum Control Valve (VCV)
- Electrical Vacuum Control Valve
- Vacuum Check Valve
- Vacuum Reservoir
- Pulse Air Valve
- Exhaust Gas RECIRCULATION (EGR)
- Fuel Evaporation
- Positive Crankcase Ventilation (PCV)
- Thermostatic Air Cleaner (TAC)
- Air Injection
- Engine Controls - Tests W/Codes - 4.9L
- Introduction
- Self-Diagnostic System
- Retrieving Codes
- Clearing Codes
- Reading Codes
- Quick Test
- Additional System Functions
- Summary
- Code-To-Test Menus - 4.9L (2-Digit Codes)
- Code-To-Test Menus - 4.9L (3-Digit Codes)
- Service Code Definitions - 2-Digit Codes
- Frequently Used EEC-IV Abbreviations
- 4.9L PFI ECM Connector Pin Voltages
- How To Use Circuit Tests
- Test A - No Start (TFI Ignition Systems)
- Test B - Checking Vehicle Battery
- Test C - Reference Voltage
- Test DA - Temperature Sensor Test (Act & ECT)
- Test DF - Map/BP Sensor
- Test Dg - Knock Sensor (KS)
- Test DH - Throttle Position Sensor (TPS)
- Test DN - EVP Sensor & EVR Solenoid
- Test DP - Vehicle Speed Sensor (VSS)
- Test FD - Brake On-Off (Boo) Switch
- Test G - In-Range MAF/TPS Fuel Injector Pulse Width Test
- Test H - Fuel Control
- Test Ha - Adaptive Fuel
- Test J - Fuel Pump Circuit (Relay & Inertia Switch)
- Test Kc - Air Management System (Am1/Am2)
- Test KD - Canister Purge (CANP)
- Test KE - Idle Speed Control (Air By-Pass)
- Test Km - WAC & A/C Demand Switches
- Test M - Dynamic Response Test
- Test Ml - STO Or Mil Lights
- Test NA - TFI Ignition Diagnostic Monitor (IDM)
- Test Pa - Spark Timing Check (TFI Vehicles)
- Test QA - No Codes/Codes Not Listed
- Test QB - Code 15, 511 Or 512 KOEO Or Continuous Memory Code
- Test QC - Output State Check Not Functioning
- Test S - System Check
- Test Ta - Neutral Drive Input
- Test Tb - A4LD Transmission
- Test TC - E4OD Automatic Transmission
- Engine Controls - Tests W/O Codes - Gasoline
- Introduction
- DRIVEABILITY Symptom Check Procedures
- Symptom-To-Routine Menu
- Intermittent Problem Diagnosis
- Intermittent Test Procedures
- Routine 200 - No Crank & No Start
- Routine 201 - Cranks Normally But Won't Start
- Routine 202 - Cranks Normally But Won't Run (Stalls)
- Routine 203 - Cranks Normally But Slow To Start
- Routine 204 - Rough Idle
- Routine 205 - Misses Under Load
- Routine 206 - Low Idle (Stalls On DECEL Or Quick Stop)
- Routine 207 - Hesitates Or Stalls On Acceleration
- Routine 208 - Backfire (Intake Or Exhaust)
- Routine 209 - Lack Of Power
- Routine 210 - Surges At Steady Speed
- Routine 211 - High Idle, Engine "Diesels"
- Routine 212 - Engine Noise
- Routine 213 - Poor Fuel Economy
- Routine 214 - High Oil Consumption
- Routine 215 - Spark Knock (Pings)
- Routine 216 - Engine Vibrates At Normal Or High Speed
- Routine 217 - Engine Runs Cold
- Routine 218 - Engine Runs Hot
- Routine 219 - Exhaust Smoke
- Routine 220 - Gas Smell
- Routine 221 - "Check Eng/SERV Soon" Always/Never On
- Routine 222 - State Emission Test Failure
- Routine 223 - Improper Shift
- Routine 224 - SIL & Audible Chimes "On"
- Using The Symptom-To-Diagnostic Flow Chart Menu
- Testing & Diagnosis
- EGR Function Testing
- Engine Controls - Basic Testing
- Introduction
- Preliminary Inspection & Adjustments
- Compression
- Exhaust System BACKPRESSURE
- No-Start Diagnosis
- DISTRIBUTORLESS Ignition System (Dis) 2.3L
- Notes
- Test 1, Check ECA For Fault Codes
- Test 2, Check For Spark During Crank
- Test 3, Check Dis Module Pip Out
- Test 4, Check Pip Out Continuity
- Test 5, Determine Missing Spark Combination
- Test 6, Check Plugs & Wires
- Test 7, Check Dis Module VBAT
- Test 8, Check Dis Module Ignition Ground
- Test 9, Check Dis Module Mounting Screws
- Test 10, Check Right Coil Pack Circuits
- Test 11, Right Coil Pack Fault, Isolate Dis Module
- Test 12, Check Right Coil Pack VBAT
- Test 13, Check Right Coil Circuit
- Test 14, Check Pip D At Dis Module
- Test 15, Check Dis Module Coil Drivers
- Test 16, Check Right Coil Pack VBAT
- Test 17, Check Right Coil Circuit
- Test 18, Check Right Coil Circuit
- Test 19, Isolate Dis Module From Pip D
- Test 20, Check Crankshaft Sensor VBAT
- Test 21, Check Crankshaft Sensor Ignition Ground
- Test 22, Check Crankshaft Sensor Pip S
- Test 23, Check Pip Circuit For Short To Ground
- Test 24, Check Pip Circuit For Short To VBAT
- Test 25, Check Crankshaft Vane
- Test 26, Isolate EEC-IV Processor (ECA) From Pip Circuit
- Test 27, Check Pip EEC Circuit For Short To VBAT
- Test 28, Check Pip EEC Circuit For Short To Ground
- Electronic DISTRIBUTORLESS Ignition System (EDIS) 4.0L Engine
- Notes
- Test 1, Check ECA For Fault Codes
- Test 2, Check For Spark During Crank
- Test 3, Check Pip At EDIS Module
- Test 4, Check Pip Continuity To EEC
- Test 5, Check IGND At EDIS
- Test 6, Check IGND Continuity To EEC
- Test 7, Check Plugs & Wires
- Test 8, Isolate EDIS Module/Pip Fault
- Test 9, Check Pip Circuit For Short To Ground
- Test 10, Check Pip Circuit For Short To Power
- Test 11, Check PWR GND To EDIS Module
- Test 12, Check PERF. W/O EDIS Diagnostic Cable Installed
- Test 13, Check PWR GND To EDIS Module
- Test 14, Check For VBAT Open To EDIS Module
- Test 15, Check VRS+ Bias At EDIS Module
- Test 16, Check VRS Amplitude At EDIS Module
- Test 17, Check VRS+ Bias/Isolate VRS/Bias Fault
- Test 18, Check VRS+ High Or Low/Bias Fault
- Test 19, Check VRS+ Circuit For Short To Ground
- Test 20, Check VRS+ Circuit For Short To VBAT
- Test 21, Check VRS Bias
- Test 22, Check VRS High Or Low/Bias Fault
- Test 23, Check VRS Circuit For Short To Ground
- Test 24, Check VRS Circuit For Short To VBAT
- Test 25, Check VRS Amplitude At EDIS Module
- Test 26, Check VRS Resistance
- Test 27, Check VRS Air Gap & Trigger Wheel
- Test 28, Check VRS High Or Low Resistance
- Test 29, Check VRS+ Shorted To VRS
- Test 30, Check VRS+ For Open Circuit
- Test 31, Check VRS For Open Circuit
- Test 32, Check For IDM Short High
- Test 33, Check For IDM Open Circuit
- Test 34, Check IDM Output From EDIS Module
- Test 35, Check For IDM Short In ECA
- Test 36, Check For IDM Short To Ground In Harness
- Test 37, Check For IDM Short To VBAT In Harness
- Test 38, Check Base Timing
- Test 39, Check Advance Spark Angle
- Test 40, Check Saw At EDIS Module
- Test 41, Check Saw For Short In EDIS Module
- Test 42, Check For Saw Short To Ground In Harness
- Test 43, Check For Saw Short To VBAT In Harness
- Test 44, Check For Saw Open
- Test 45, Inspect VR Sensor & Trigger Wheel
- Test 46, Check VBAT Open To Coil
- Test 47, Verify Vehicle Operating Mode
- Test 48, Check C1, C2 & C3 At Coil Pack
- Test 49, Check C1, C2 & C3 At Coil Pack
- Test 50, Check C1, C2 & C3 At Coil Pack
- Test 51, Check C1, C2 & C3 At EDIS
- Test 52, Check C1, C2 & C3 At Coil Pack
- Test 53, Check C1, C2 & C3 At Coil Pack
- Test 54, Check C1, C2 & C3 Coil Primary
- Test 55, Check C1, C2 & C3 For Short To Ground
- Test 56, Check C1, C2 & C3 For Short To Ground
- Thick Film Ignition (TFI) IV
- Fuel System
- Idle Speed & Ignition Timing
- Throttle Position Sensor (TPS) Adjustment
- Fuel Injection Pump Lever (FIPL) Sensor Adjustment
- Summary
- Engine Controls - System/Component Tests
- Introduction
- Electronic Control Assembly (ECA)
- Engine Sensors & Switches (ECA Inputs)
- Notes
- Air Charge Temperature (Act) Sensor
- Barometric Pressure Sensor (BP)
- Clutch Switch
- Cylinder Identification Sensor (CID) & Crankshaft Sensor
- Engine Coolant Temperature (ECT) Sensor
- EGR Valve Position (EVP) Sensor/EGR Vacuum Regulator (EVR) Solenoid
- Engine Rpm Sensor (RPMS)
- Fuel Injection Pump Lever (FIPL) Sensor
- Heated Exhaust Gas Oxygen (HEGO) Sensor
- Inertia Switch
- Knock Sensor (KS)
- Manifold Absolute Pressure (Map) Sensor
- Mass Airflow (MAF) Sensor
- Neutral Drive Switch (NDS) A/C Input
- Power Steering Pressure Switch (PSPS)
- Throttle Position Sensor (TP Or TPS)
- Vehicle Speed Sensor (VSS)
- Modules, Motors, Relays & Solenoids
- Fuel System
- Idle Control System
- Ignition System Identification
- TFI-IV System Ignition
- Notes
- Preliminary Check
- Test Equipment
- Diagnostic Aids
- Primary Circuit Test (Except Closed Bowl Distributor)
- Primary Circuit Test (Closed Bowl Distributor)
- TFI Module Resistance Test
- Pip Sensor/Stator Test (Except Closed Bowl Distributor)
- Pip Sensor/Stator Test (Closed Bowl Distributor)
- Coil Test
- Spark Timing Advance Test
- Dis System (2.3L Ranger)
- EDIS System (4.0L AEROSTAR, Explorer, NAVAJO & Ranger)
- Emission Systems & Sub-Systems
- Air Injection
- Air Supply Pump
- Air Silencer/Filter (Air Pump & Pulse Air Inlet)
- Air By-Pass Valve (Normally Closed)
- Air Check Valve
- Air Supply Control Valve
- Air Control Valve (Switch-Relief)
- Air Pump Resonator
- Combination Air By-Pass/Air Control Valve
- Dual Thermactor Air Control Solenoid Valve
- Thermactor Idle Vacuum (TIV) Valve
- Vacuum Control Valve (VCV)
- Electrical Vacuum Control Valve
- Vacuum Check Valve
- Vacuum Reservoir
- Pulse Air Valve
- Exhaust Gas RECIRCULATION (EGR)
- Fuel Evaporation
- Positive Crankcase Ventilation (PCV)
- Thermostatic Air Cleaner (TAC)
- Air Injection
- Engine Controls - Tests W/Codes - 4.9L
- Introduction
- Self-Diagnostic System
- Retrieving Codes
- Clearing Codes
- Reading Codes
- Quick Test
- Additional System Functions
- Summary
- Code-To-Test Menus - 4.9L (2-Digit Codes)
- Code-To-Test Menus - 4.9L (3-Digit Codes)
- Service Code Definitions - 2-Digit Codes
- Frequently Used EEC-IV Abbreviations
- 4.9L PFI ECM Connector Pin Voltages
- How To Use Circuit Tests
- Test A - No Start (TFI Ignition Systems)
- Test B - Checking Vehicle Battery
- Test C - Reference Voltage
- Test DA - Temperature Sensor Test (Act & ECT)
- Test DF - Map/BP Sensor
- Test Dg - Knock Sensor (KS)
- Test DH - Throttle Position Sensor (TPS)
- Test DN - EVP Sensor & EVR Solenoid
- Test DP - Vehicle Speed Sensor (VSS)
- Test FD - Brake On-Off (Boo) Switch
- Test G - In-Range MAF/TPS Fuel Injector Pulse Width Test
- Test H - Fuel Control
- Test Ha - Adaptive Fuel
- Test J - Fuel Pump Circuit (Relay & Inertia Switch)
- Test Kc - Air Management System (Am1/Am2)
- Test KD - Canister Purge (CANP)
- Test KE - Idle Speed Control (Air By-Pass)
- Test Km - WAC & A/C Demand Switches
- Test M - Dynamic Response Test
- Test Ml - STO Or Mil Lights
- Test NA - TFI Ignition Diagnostic Monitor (IDM)
- Test Pa - Spark Timing Check (TFI Vehicles)
- Test QA - No Codes/Codes Not Listed
- Test QB - Code 15, 511 Or 512 KOEO Or Continuous Memory Code
- Test QC - Output State Check Not Functioning
- Test S - System Check
- Test Ta - Neutral Drive Input
- Test Tb - A4LD Transmission
- Test TC - E4OD Automatic Transmission
- Engine Controls - Tests W/O Codes - Gasoline
- Introduction
- DRIVEABILITY Symptom Check Procedures
- Symptom-To-Routine Menu
- Intermittent Problem Diagnosis
- Intermittent Test Procedures
- Routine 200 - No Crank & No Start
- Routine 201 - Cranks Normally But Won't Start
- Routine 202 - Cranks Normally But Won't Run (Stalls)
- Routine 203 - Cranks Normally But Slow To Start
- Routine 204 - Rough Idle
- Routine 205 - Misses Under Load
- Routine 206 - Low Idle (Stalls On DECEL Or Quick Stop)
- Routine 207 - Hesitates Or Stalls On Acceleration
- Routine 208 - Backfire (Intake Or Exhaust)
- Routine 209 - Lack Of Power
- Routine 210 - Surges At Steady Speed
- Routine 211 - High Idle, Engine "Diesels"
- Routine 212 - Engine Noise
- Routine 213 - Poor Fuel Economy
- Routine 214 - High Oil Consumption
- Routine 215 - Spark Knock (Pings)
- Routine 216 - Engine Vibrates At Normal Or High Speed
- Routine 217 - Engine Runs Cold
- Routine 218 - Engine Runs Hot
- Routine 219 - Exhaust Smoke
- Routine 220 - Gas Smell
- Routine 221 - "Check Eng/SERV Soon" Always/Never On
- Routine 222 - State Emission Test Failure
- Routine 223 - Improper Shift
- Routine 224 - SIL & Audible Chimes "On"
- Using The Symptom-To-Diagnostic Flow Chart Menu
- Theory and Operation
- Engine Controls - Theory & Operation
- Introduction
- Computerized Engine Controls
- Input Devices
- Notes
- A/C Compressor Clutch Signal
- Air Charge Temperature (Act) Sensor
- Barometric Pressure (BP) Sensor
- Brake On-Off (Boo) Switch
- Clutch Engage Switch
- Coolant Temperature Sensor
- Crankshaft Sensor
- EGR Valve Position (EVP) Sensor
- Engine Coolant Temperature (ECT) Sensor
- Fuel Injection Pump Lever (FIPL) Sensor
- Heated Exhaust Gas Oxygen (HEGO) Sensor
- Manifold Absolute Pressure (Map) Sensor
- Mass Airflow (MAF) Sensor
- Neutral Gear Switch (NGS)
- Neutral Safety Switch (NSS)
- Power Steering (P/S) Pressure Switch
- Profile Ignition Pick-Up (Pip)
- Self-Test Output/Self-Test Input (STO/STI) Connectors
- Throttle Position Sensor (TPS)
- Variable Reluctance Sensor (VRS)
- Vehicle Speed Sensor (VSS)
- Output Signals
- Fuel Delivery
- Fuel Control (Gasoline Engines)
- Fuel Control (7.3L Diesel)
- Idle Speed (Gasoline Engines)
- Idle Speed (7.3L Diesel)
- Ignition Systems
- Emission Systems
- Air Injection System
- EGR System
- Evaporative Emission Control
- Positive Crankcase Ventilation (PCV)
- Self-Diagnostic System
- Miscellaneous Controls
- Engine Controls - Theory & Operation
- Vacuum Diagrams
- Wiring Diagrams
- Engine Controls - Adjustments
- General Information
- Abbreviations
- Basic Trouble Shooting
- Basic Trouble Shooting - General Information
- Commonly Used Abbreviations - General Information
- Emission Control Abbreviations
- Engine Performance - Trouble Shooting - General Information
- Brakes
- Anti-Lock Brake Safety Precautions - General Information
- Map - Brake Systems
- Brake Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Accelerometers
- Accumulators
- Anchor Pins
- Anti-Lock Brake Control Assembly(Module)
- Anti-Lock Brake Controller
- Anti-Lock Brake Systems
- Axle Seal
- Backing Plates
- Bleeder Screw
- Brake Abs Active Light (Blue)
- Brake Fluid
- Brake Friction Material
- Brake On - Off Switch
- Brake Pads
- Brake Pedals
- Brake Shoe Hardware
- Brake Shoes
- Brake Stoplight Switches
- Brake Warning Light (Amber)
- Brake Warning Light (Red)
- Bulb Sockets
- Bulbs And LEDS
- Caliper Hardware
- Caliper Mounting Pin
- Caliper Piston
- Caliper Shim
- Caliper Slider Pin (Bolt) Dust Boot
- Caliper Slider Pin (Bolt)
- Calipers
- Combination Valve
- Controllers
- Digital Ratio Axle Controllers And Buffers (Drab And Dram)
- Disable Switches
- Drums
- Electrical Brake Pumps
- Electrical Park Motor
- Electrical Pumps And Motors
- Electro-Magnetic Interference
- Electronic Brake Control Modulator
- Electronic Brake Distribution
- Electronic Brake Traction Control Module
- Electronic Controllers
- Electronic Traction Control
- External Brake Cable
- Flow Control Valve
- Fluid Level Sensor Switches
- Fluid
- Four Wheel Drive Switches
- Friction Material
- G Sensors
- Gaskets
- Gravitational Switches
- Grease Seal
- Height Sensing Proportioning Valve
- High Pressure Accumulator
- Hoses
- Hub
- Hydraulic Control Unit
- Hydraulic Modulators
- Hydro-Boosters
- Hydro-Electric Boosters (POWERMASTER)
- Ignition Disable Switches
- Lamp Driver Relay
- Lateral Acceleration Switches
- LEDS
- Lenses
- Low Pressure Accumulator
- Lug Nut
- Master Cylinder Cover Gasket
- Master Cylinders
- Modulators
- Motor Pack
- Motors
- Pads
- Parking Brake Cable
- Parking Brake Mechanism
- Parking Brake Shoes
- Parking Brake Switches
- Parking Brake Systems
- Pedal Travel Switches
- Pedals
- Power Distribution Center
- POWERMASTER
- Pressure Differential Switches
- Pressure Switches
- Pressure Transducers
- Proportioning Valve
- Pumps
- Relays
- RELUCTOR (Speed) Ring
- Rotors
- Self-Adjusting Systems
- Shoe Hardware
- Shoes
- Sockets
- Speed Sensor (RELUCTOR) Ring
- Speed Sensors (Electronic Wheel And Vehicle)
- Star Wheel
- Steel Brake Lines
- Stoplight Switches
- Stroke Sensor
- Switches
- Tires
- Tone Ring
- Toothed Rings (Tone Wheel)
- Traction Control System (TCS)
- Transfer Tubes
- Vacuum Boosters
- Vacuum Hoses
- Valves
- Wear Indicator
- Wheel Attachment Hardware
- Wheel Bearings, Races And Seals
- Wheel Cylinders
- Wiring Harnesses
- Yaw Rate Sensor
- Brake System CHECKSHEET
- Reason Code Explanation
- Automotive Terminology & Definitions
- Brake Systems
- Map - Routine Inspection Reference Guide
- Routine Inspection Reference Guide
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Maintenance Overview
- Antifreeze/Coolant
- Visual Inspection
- Radiator Cap Test
- Engine Fan
- Cooling System Power Flush And Refill
- Belts (Except Timing Belts)
- Belt TENSIONER
- Automatic Transmission Fluid
- Automatic Transmission Fluid Exchange & Filter Replacement
- Engine Oil
- Air Filters
- Cabin Air Filter
- Brake Fluid
- Battery
- Battery Cables
- Power Steering
- Power Steering Fluid
- Wiper Blades
- Routine Inspection CHECKSHEET
- Routine Inspection - UICS
- Brake Systems
- Drivetrain And Transmission
- Notes
- Automatic Transmission Fluid
- Clutch Master Cylinders
- Cooler Lines
- Coolers
- Differential Fluid
- Drain Plugs And Gaskets
- Filters And Screens
- Fluids And Lubricants
- Hoses, Lines, And Tubes
- Hydraulic Fluid
- Lubricants
- Manual Transmission Fluid
- Mounts (Engine, Transaxle And Transmission)
- Transfer Case Fluid
- Vacuum Hoses
- Electrical Systems
- Engine Performance And Maintenance
- Notes
- Accessory Belts
- Air Filter Elements
- Air Filter Gaskets
- Air Filter Housings And Gaskets
- Air Pump Belts
- Batteries
- Battery Connectors
- Belt Idler Assemblies (Accessory And Cam Belts)
- Belt TENSIONERS (Accessory And Cam Belt)
- Chemical Engine DECARBONIZATION
- Combustion Chamber Cleaning
- Coolant Recovery Tanks
- Coolant
- Distributor Caps
- Distributor Rotors
- Engine Cooling Systems
- Engine DECARBONIZATION
- Engine Oil Drain Plugs And Gaskets
- Engine Oil Filters And Canisters
- Engine Oil
- Fuel Filters
- Fuel Injector Cleaning
- Fuel Injectors
- Fuel System Cleaning Service
- Hose Clamps
- Hose Connectors
- Hose Couplers
- Hoses And Tubes (Fuel Lines, Radiator, Vacuum, By-Pass, Heater, Recovery Tank And Oil Coolers)
- Ignition Wires (Secondary)
- Intake Cleaning
- O2 Sensors
- PCV Breather Elements
- PCV Valves
- Radiator Caps And Pressurized Expansion Tank Caps
- Spark Plugs
- Thermostats And Housings
- Throttle Body Cleaning
- Timing Belts
- Vacuum Hoses, Tubes And Connections (Non-Metallic)
- Exhaust Systems
- Heating, Ventilation And Air Conditioning Systems
- Steering And Suspension, Wheel Alignment, Wheels And Tires
- Wheel & Tire Supplement
- Reason Code Explanation
- Automotive Terminology & Definitions
- Routine Inspection Reference Guide
- Check Lists
- Computer Relearn Procedures
- Driveline/Axles
- Drive Axle Noise Diagnosis - General Information
- Gear Tooth Contact Patterns - General Information
- Map - Drive Train & Transmission
- Drive Train & Transmission Systems
- Drivetrain And Transmission
- Notes
- Actuators (Electrical)
- Actuators (Vacuum)
- Automatic Transmission / Transaxle Assemblies/CVTS
- Automatic Transmission Fluid
- Axles
- Bearings And Races
- Bell Cranks
- Bell Housings
- Bushings (External)
- Cables (Speedometer)
- Cables (TV, Detent And Shift)
- Carrier Bearings
- Clutch Cables And Cable Housings
- Clutch Discs (Manual Transmissions)
- Clutch Forks
- Clutch Linkages (Mechanical)
- Clutch Master Cylinders
- Clutch Pedals
- Clutch Pivots
- Clutch Pressure Plates
- Clutch Release Bearings
- Clutch Slave Cylinders (Concentric)
- Clutch Slave Cylinders (Conventional Or External)
- Companion Flanges
- Connectors
- Cooler Bypass Valves
- Cooler Lines
- Coolers
- CV Joints
- Differential And Final Drive Assemblies
- Differential Fluid
- Dip Stick Tubes
- Dip Sticks (Fluid Level Indicators)
- Dowel Pins, Guides And Pilot Holes
- Drain Plugs And Gaskets
- Drive Shaft Flanges
- Drive Shafts And Half Shafts
- Dust Boots
- Engine Mounts
- Exciter Rings
- Filler Tubes
- Filters And Screens
- Flanges
- Flex Plates
- Fluid Level Indicators
- Fluids And Lubricants
- Flywheels
- Force Motors
- Gaskets
- Guides
- Half Shafts
- Hoses, Lines, And Tubes
- Housings (Bell, Case, Tail(Extension) And Auxiliary)
- Hydraulic Fluid
- Intermediate Shaft Support Bearings
- Key Interlock Systems
- Limited Slips
- Lines
- Linkages (External)
- Locking Hub Assemblies
- Locking Hub Control Knobs
- Lubricants
- Manual Transmission Fluid
- Manual Transmission/Transaxle Assemblies
- Metal Clad Seals
- METALASTIC Joints
- Modulator Pins
- Modulators
- Mounts (Engine, Transaxle And Transmission)
- Odometer Drives (Mechanical)
- Odometer Heads (Mechanical)
- Oil Pans
- Pans
- Pilot Holes
- Pressure Plates
- Pressure Switches
- Races
- Rubber Joints (METALASTIC)
- Screens
- Seals (Metal Clad)
- Seals
- Selector Interlock Systems
- Sensors
- Servos
- Shift Interlock Systems (Selector And Key Interlock Systems)
- Side Covers
- Slip Yokes
- Solenoids
- Speed Sensors (Electronic Wheel And Vehicle)
- Speedometer- Driven Gear Housing
- Speedometer/Odometer Drives (Mechanical)
- Speedometer/Odometer Heads (Mechanical)
- Speedometers/Odometers (Electronic)
- Switches
- Tone Wheels
- Toothed Rings (Tone Wheel)
- Torque Converters
- Transaxle Mounts
- Transducers (Transmission)
- Transfer Case Assemblies
- Transfer Case Fluid
- Transmission Coolers
- Transmission Mounts
- Transmission Pans
- Transmission Range Indicators (PRNDL)
- Tubes
- Universal Joints (CARDAN Or Cross Type)
- Vacuum Controls
- Vacuum Hoses
- Vacuum Motors
- Vacuum-Operated Switches
- Vehicle Speed Sensors
- Vents
- Vibration Dampers
- Wheel Attachment Hardware
- Wheel Speed Sensors
- Wiring Harnesses And Connectors
- Yokes And Slip Yokes
- Reason Code Explanation
- Automotive Terminology & Definitions
- Trouble Shooting - Clutches - General Information
- Electrical
- Map - Electrical Systems
- Electrical Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Actuator Motors (Electric)
- Actuator Motors (Vacuum)
- Air Bags
- Alternators And Generators
- Amplifiers
- Antennas
- Batteries
- Battery Cables, Wires And Connectors
- Battery Cables
- Battery Trays And Hold Down Hardware
- Battery Wires
- Belts
- Bulb Sockets
- Bulbs, Sealed Beams And LEDS
- Cd Players
- Cigarette Lighter Assemblies
- Circuit Breakers
- Clutch Switches
- Connectors
- Control Modules
- Cruise Control Brake Switches
- Cruise Control Cables
- Cruise Control Clutch Switches
- Cruise Control Linkages And Cables
- Cruise Control Reservoirs
- Cruise Control Tubes
- Cruise Control Vacuum Dump Release Valves
- Cruise Control Vacuum Hoses, Tubes And
- Cruise Control Vehicle Speed Sensors
- Defoggers
- Defrosters
- Delays
- Dimmers
- Electric Heaters
- Equalizers
- Fuse Blocks
- Fuse Boxes And Blocks
- Fuses, Fusible Links And Circuit Breakers
- Fusible Links
- Gauges
- Generators
- Ground Cables And Straps
- Ground Straps
- Headlight Adjusters
- Heating Elements (Defrosters, Defoggers, Electric Heaters And Seats)
- Horns And Sirens
- Ignition Switches
- Indicator Lights
- Keyless Entry Keypads And Transmitters
- Keyless Entry Transmitters
- LEDS
- Lenses
- Microphones
- Mirrors (ELECTROCHROMATIC And Heated)
- Motors
- Neutral Safety Switches
- Odometers, Speedometers And Tachometers (Cable Driven)
- Odometers
- Power Distribution Center
- Pulleys
- Receivers, Amplifiers, Equalizers And Sub-Woofer Volume Controls
- Relay Boxes
- Relays
- Sealed Beams
- Seat Heaters
- Security Alarm Sensors
- Sirens
- Solenoids
- Speakers And Microphones
- Speedometer And Tachometer Linkages And Cables
- Speedometer Cables
- Speedometers
- Starters
- Sub-Woofer Volume Control
- Switches
- Tachometer Cables
- Tachometers
- Tape Players And Cd Players
- TENSIONERS
- Timers
- Transceivers
- Transducers
- Vacuum Accumulators (Reservoirs)
- Voltage Regulators
- Washer Fluid Level Senders
- Washer Pumps
- Wiper Arms And Blades
- Wiper Blades
- Wiper Hoses And Nozzles
- Wiper Linkages
- Wiper Nozzles
- Wiper Pump Reservoirs
- Wiring Harnesses And Connectors
- Battery, Starting & Charging System CHECKSHEET
- Reason Code Explanation
- Automotive Terminology & Definitions
- Electrical Systems
- Using lemon2025'S System Wiring Diagrams
- Map - Electrical Systems
- Engine
- Engine Overhaul Procedures - General Information
- * Please Read This First *
- Description
- Engine Identification
- Inspection Procedures
- Cleaning Procedures
- Component Cleaning
- Cylinder Head Replacement
- Cylinder Head Overhaul
- Pistons, Connecting Rods & Bearings
- Crankshaft & Main Bearings
- Camshaft
- Timing Chains & Belts
- Timing Gears
- Oil Pump
- Break-In Procedure
- General Cooling System Service - General Information
- Engine Overhaul Procedures - General Information
- Engine Performance
- Electrostatic Discharge Warning - General Information
- Emission Control Visual Inspection Procedures
- Emission Control Labels
- Ford Calibration Labels
- Emission Control Visual Inspection
- Notes
- Positive Crankcase Ventilation (PCV)
- Thermostatic Air Cleaner (TAC)
- Fuel Evaporative System (EVAP)
- Catalytic Converters
- Fill Pipe RESTRICTOR (Fr)
- Exhaust Gas RECIRCULATION (EGR) System
- Spark Controls (SPK)
- Air Injection System (AIS)
- Oxygen Sensor (O2)
- Computerized Engine Controls (CEC)
- Early Fuel Evaporation (EFE)
- Emission Maintenance Reminder Light (EMR)
- Malfunction Indicator Light (Mil)
- Engine Performance Diagnostic Routine Outline - General Information
- Engine Performance Safety Precautions
- Map - Engine Performance & Maintenance
- Engine Performance And Maintenance (Including Exhaust Systems)
- Engine Performance & Maintenance CHECKSHEET
- Engine Performance And Maintenance
- Notes
- Accelerator Pedal Position Sensor
- Accessory Belts
- Accessory Pulleys
- Air Conditioning Cycling Switches
- Air Conditioning Pressure Sensors
- Air Ducts And Tubes
- Air Filter Elements
- Air Filter Gaskets
- Air Filter Housings And Gaskets
- Air Fuel Ratio Sensors
- Air Injection Control Solenoids
- Air Plenums
- Air Pump Belts
- Air Pumps (Electric Driven)
- Air Tubes
- Aspirator, Check And DECEL Valves
- Baffles
- Ballast Primary Supply Resistor Wires
- Ballast Resistors And Primary Supply Resistors
- Barometric Pressure Sensors
- Batteries
- Battery Cables, Wires And Connectors
- Battery Connectors
- Battery Trays And Hold Down Hardware
- Battery Wires
- Belt Idler Assemblies (Accessory And Cam Belts)
- Belt TENSIONERS (Accessory And Cam Belt)
- Belt-Driven Air Pumps
- Boost Control Mechanism
- Camshaft Position Sensors
- Carburetors And Chokes
- Casting Core Plugs And Expansion Plugs
- Charge Air Coolers ""INTERCOOLERS"" (CAC)
- Check Valves
- Chemical Engine DECARBONIZATION
- Chokes
- Clutch Pedal Position Switches
- Cold Start Injectors
- Combustion Chamber Cleaning
- Connectors
- Coolant Recovery Tanks
- Coolant
- Cooling Fan Motor Modules
- Cooling Fan Motor Relays And Modules
- Cooling Fan Motor Resistors
- Cooling Fan Motor Sensors And Switches
- Cooling Fan Motor Switches
- Cooling Fan Motors
- Crankshaft Position Sensors
- Cylinder Deactivation Solenoid
- Cylinder Head Assemblies
- DECEL Valves
- Deflectors
- Dip Stick Tubes
- Dip Sticks And Tubes
- Distributor Advances And Retarders (Mechanical And Vacuum)
- Distributor Boots And Shields
- Distributor Caps
- Distributor Retarders (Mechanical And Vacuum)
- Distributor Rotors
- Distributor Shields
- Distributors
- Early Fuel Evaporation Valves (Heat Riser Assemblies)
- EGR Coolers
- EGR Exhaust Manifold Passages
- EGR Intake And Exhaust Manifold Passages
- EGR Plates And Coolers
- Electronic Spark Control Modules
- Electronic Transmission Control Devices
- Electronic Transmission Feedback Devices
- Engine Coolant Temperature Sensors
- Engine Cooling Systems
- Engine Covers (Oil Pan, Valve Cover, Timing Cover)
- Engine DECARBONIZATION
- Engine Oil Canisters
- Engine Oil Coolers (External)
- Engine Oil Drain Plugs And Gaskets
- Engine Oil Filters And Canisters
- Engine Oil Gaskets
- Engine Oil Pressure Gauges (Mechanical)
- Engine Oil
- Evaporative Emissions (EVAP) Canister Filters
- Evaporative Emissions (EVAP) Canister Purge Devices
- Evaporative Emissions (EVAP) Canisters
- Evaporative Emissions (EVAP) Feedback Devices
- Exhaust Gas RECIRCULATION Devices
- Exhaust Gas RECIRCULATION Feedback Devices
- Expansion Plugs
- Fan Control Sensor
- Fuel Accumulators And Dampers
- Fuel And Cold Start Injectors
- Fuel Caps
- Fuel Dampers
- Fuel Delivery Check Valves
- Fuel Distributors (BOSCH Cis)
- Fuel Filler Necks And RESTRICTORS
- Fuel Filters
- Fuel Injector Cleaning
- Fuel Injectors
- Fuel Level Senders
- Fuel Pressure Regulators
- Fuel Pumps (In-Tank, External, Electrical Or Mechanical)
- Fuel Rails
- Fuel RESTRICTORS
- Fuel System Cleaning Service
- Fuel Tanks
- Fuel
- Gaskets
- Grommets (Valve Cover)
- Harmonic Dampers
- Heater Control Valves
- Heater Cores
- Hose Clamps
- Hose Connectors
- Hose Couplers
- Hoses And Tube Couplers, Connectors And Clamps
- Hoses And Tubes (Fuel Lines, Radiator, Vacuum, By-Pass, Heater, Recovery Tank And Oil Coolers)
- Housings
- Idle Air Controls
- Idle Speed Control Actuators
- Ignition Boots
- Ignition Coil Towers
- Ignition Coils
- Ignition Control Modules (ICM)
- Ignition Switches
- Ignition Terminals
- Ignition Wires (Secondary)
- Inertia Fuel Shut-Off Switches
- Intake Air Temperature Sensors
- Intake Cleaning
- Intake Manifolds
- In-Tank Fuel Strainers
- INTERCOOLERS
- Knock Sensors
- Liquid Vapor Separators
- Long Block Assemblies
- Manifold Absolute Pressure (Map) Sensors
- Mass Air Flow (MAF) Sensors
- Metal Air Manifolds And Pipes
- Metal Air Pipes
- Mix Control Solenoids
- Motor Mounts
- O2 Sensors
- Oil Pans
- Oil Pressure Sending Units
- Oil Pump Pick-Up Screens
- Oil Pumps
- O-Rings, Gaskets, Seals And Spring Locks
- Park Neutral Position Switches
- PCV Breather Elements
- PCV Orifices
- PCV Valves
- Pick-Up Assemblies (Includes Magnetic, Hall Effect And Optical)
- Power Steering Pressure Sensors
- Powertrain Control Modules (Pcm) And Prom
- Powertrain Control Prom
- Pressurized Expansion Tank Caps
- Radiator / Cooling Fan Blades
- Radiator / Cooling Fan Clutches
- Radiator Caps And Pressurized Expansion Tank Caps
- Radiators
- Roll Over Valves
- Sealing Compounds
- Seals
- Secondary Air Injection System Management Devices
- Sensors
- Short Block Assemblies
- Shrouds, Baffles And Deflectors
- Spark Plugs
- Spring Locks
- Super Chargers
- Switches
- Thermal Vacuum Valves
- Thermostatic Air Door Assemblies
- Thermostats And Housings
- Throttle Bodies
- Throttle Body Cleaning
- Throttle Cables
- Throttle Linkages And Cables
- Throttle Position Sensors
- Throttle Position Switches
- Timing Belt Sprockets
- Timing Belts
- Timing Covers
- Torque Struts
- Transmission Range Switches
- Tube Clamps
- Tube Connectors
- Tube Couplers
- Tubes
- Turbo Chargers
- Vacuum Connections
- Vacuum Hoses, Tubes And Connections (Non-Metallic)
- Vacuum Regulator Solenoids
- Vacuum Tubes
- Valve Covers
- Vehicle Speed Senors
- Volume Air Flow Sensors
- Waste Gate And Boost Control Mechanisms
- Waste Gate Control Solenoids
- Water Pumps (Electric)
- Water Pumps (Non-Electric)
- Wiring Harnesses And Connectors
- Reason Code Explanation
- Automotive Terminology & Definitions
- Parasitic Load Explanation & Test Procedures - General Information
- State Emission Standards - Diesel
- State Emission Standards - Gas
- ALASKA
- ARIZONA
- CALIFORNIA
- Colorado
- CONNECTICUT
- DELAWARE
- District Of COLUMBIA
- GEORGIA
- IDAHO
- ILLINOIS
- INDIANA
- KENTUCKY
- MARYLAND
- MASSACHUSETTS
- MISSOURI
- NEVADA
- New Jersey
- New MEXICO
- New YORK
- North CAROLINA
- OHIO
- OREGON
- PENNSYLVANIA
- RHODE Island
- TENNESSEE
- TEXAS
- UTAH
- VIRGINIA
- WASHINGTON
- WISCONSIN
- U. S. EPA ASM2525 & ASM5015 Start-Up Emission Standards
- U. S. EPA Revised Final ASM Emission Standards (ASM5015 & ASM2525)
- U.S. EPA Im240 Emission Standards
- Waveforms - Injector Pattern Tutorial - General Information
- * Please Read This First *
- Purpose Of This Article
- Is A Lab Scope Necessary?
- The Two Types Of Injector Drivers
- The Two Ways Injector Circuits Are Wired
- Interpreting Injector Waveforms
- Current Waveform Samples
- Notes
- Example #1 - Voltage Controlled Driver
- Example #2 - Voltage Controlled Driver
- Example #3 - Voltage Controlled Driver
- Example #4 - Current Controlled Driver
- Example #5 - Current Controlled Driver
- Example #6 - Current Controlled Driver
- Example #7 - Current Controlled Driver
- Example #8 - Current Controlled Driver
- Voltage Waveform Samples
- Notes
- Example #1 - Voltage Controlled Driver
- Example #2 - Voltage Controlled Driver
- Example #3 - Voltage Controlled Driver
- Example #4 - Current Controlled Driver
- Example #5 - Current Controlled Driver
- Example #6 - Current Controlled Driver
- Example #7 - Current Controlled Driver
- Example #8 - Current Controlled Driver
- Map - Exhaust Systems
- Exhaust Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Catalytic Converters
- Exhaust And Tail Pipes
- Exhaust Connections
- Hangers
- Heat Risers (Mechanical EFE Devices)
- Heat Shields
- Manifolds (Cast And Tube Type)
- Mechanical EFE Devices
- Muffler Valve
- Mufflers And Resonators
- Reason Code Explanation
- Exhaust Systems
- Heating, Ventilation & A/C (HVAC)
- Map - Heating, Ventilation, & Air Conditioning
- Heating, Ventilation & Air Conditioning Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Accumulators
- Actuators (Electrical)
- Actuators (Vacuum)
- Air Conditioning Fittings
- Air Conditioning Hoses
- Air Conditioning Metal Lines
- Air Control Doors
- Air Dams (External)
- Air Distribution System
- Belts
- Blend Doors
- Blower Fans (Blower Wheel Or Squirrel Cage)
- Blower Motors
- Blower Resistors
- Blower Switches
- Cabin Air Filters
- Circuit Breakers
- Compressor Clutch Assemblies
- Compressors
- Condenser Air Seals
- Condenser Fan Motors
- Condensers
- Connectors
- Control Cables
- Control Heads (Function Selectors)
- Control Linkages
- Control Modules
- Coolant
- Cooling Fan Blades
- Cooling Fan Clutches
- Cooling Fan Motors
- Evaporator Drain Tubes
- Evaporator Filters
- Evaporator Pressure Regulators (EPRS)
- Evaporators
- Expansion Valves
- Function Selectors
- Fuses, Fusible Links And Circuit Breakers
- Fusible Links
- Gaskets
- Heater Cases
- Heater Control Valves
- Heater Cores
- Heater Hoses
- High Pressure Relief Valves (HPRV)
- Idlers
- In-Line Filters
- Metal Fittings
- Metal Lines
- Mix And Air Control Doors (Blend Doors)
- ORIFACE Tubes
- O-Rings
- Pilot-Operated Absolutes (POAS)
- Plenums
- Pressure Control Valves
- Pressure Sensors
- Pulleys
- Radiators
- Receiver-DRIERS
- Refrigerant Oil
- Refrigerant
- Relays
- Seals
- Service Ports
- Spring Lock Couplings
- Suction Throttling Valves (STVS)
- Switches (Electrical)
- TENSIONERS
- Thermistors And Pressure Sensors
- Thermostats And Housings
- Vacuum Hoses And Tubes
- Vacuum Reservoirs
- Vacuum Tubes
- Valves In Receiver (VIRS)
- Water Pumps (Electric Auxiliary)
- Wiring Harnesses And Connectors
- Heating, Ventilation & Air Conditioning System CHECKSHEET
- Reason Code Explanation
- Automotive Terminology & Definitions
- Heating, Ventilation & Air Conditioning Systems
- Map - Heating, Ventilation, & Air Conditioning
- Identification
- Metric Conversions
- OEM General Information
- How To Use The Engine Performance Section
- Maintenance Reminder Light (Reset Procedures)
- A/C Filter Service Reminder
- Engine Oil Replacement Reminder
- Notes
- Engine Oil Replacement Reminder Reset - Procedure 01
- Engine Oil Replacement Reminder Reset - Procedure 02
- Engine Oil Replacement Reminder Reset - Procedure 03
- Engine Oil Replacement Reminder Reset - Procedure 04
- Engine Oil Replacement Reminder Reset - Procedure 05
- Engine Oil Replacement Reminder Reset - Procedure 06
- Engine Oil Replacement Reminder Reset - Procedure 07
- Engine Oil Replacement Reminder Reset - Procedure 08
- Engine Oil Replacement Reminder Reset - Procedure 09
- Engine Oil Replacement Reminder Reset - Procedure 10
- Engine Oil Replacement Reminder Reset - Procedure 11
- Engine Oil Replacement Reminder Reset - Procedure 12
- Engine Oil Replacement Reminder Reset - Procedure 13
- Engine Oil Replacement Reminder Reset - Procedure 14
- Engine Oil Replacement Reminder Reset - Procedure 15
- Engine Oil Replacement Reminder Reset - Procedure 16
- Engine Oil Replacement Reminder Reset - Procedure 17
- Engine Oil Replacement Reminder Reset - Procedure 18
- Engine Oil Replacement Reminder Reset - Procedure 19
- Engine Oil Replacement Reminder Reset - Procedure 20
- Engine Oil Replacement Reminder Reset - Procedure 21
- Engine Oil Replacement Reminder Reset - Procedure 22
- Engine Oil Replacement Reminder Reset - Procedure 23
- Engine Oil Replacement Reminder Reset - Procedure 24
- Engine Oil Replacement Reminder Reset - Procedure 25
- Engine Oil Replacement Reminder Reset - Procedure 26
- Engine Oil Replacement Reminder Reset - Procedure 27
- Engine Oil Replacement Reminder Reset - Procedure 28
- Maintenance Service Reminder (Overhead Warning Lights)
- Maintenance Service Reminder (Sri)
- Maintenance Service Reminder (VMM)
- Tire Pressure Monitor System Reminder
- Notes
- Tire Pressure Sensor Types
- TPMS Reminder Reset - Procedure 01
- TPMS Reminder Reset - Procedure 02
- TPMS Reminder Reset - Procedure 03
- TPMS Reminder Reset - Procedure 04
- TPMS Reminder Reset - Procedure 05
- TPMS Reminder Reset - Procedure 07
- TPMS Reminder Reset - Procedure 08
- TPMS Reminder Reset - Procedure 09
- TPMS Reminder Reset - Procedure 10
- Steering
- Map - Steering, Suspension, Wheel Alignment, Wheels & Tires
- Steering & Suspension Systems
- Wheel And Tire
- Steering & Suspension CHECKSHEET
- Wheels & Tires CHECKSHEET
- Steering And Suspension, Wheel Alignment, Wheels And Tires
- Notes
- Active Handling
- Active Suspension Control Modules
- Active Variable Ratio Steering
- Active Yaw Control
- Adaptive Cruise Control
- Advance TRAC
- Air Bags
- Air Ride Control Modules
- Air Ride Suspension Torsion Springs (Counter Balancing)
- Air Ride Suspension
- Air Ride Tubes
- Air Shocks And Air Struts
- Air Spring Valves
- Air Springs
- Air Suspension Control Valves
- Air Suspension DRIERS
- Axle Acceleration Sensor
- Ball Joints
- Body Acceleration Sensor
- Bushings
- Center Links
- Compressors
- Continuous Damping Control
- Control Arm Shafts
- Control Arms
- Control Modules
- Distance Regulation Control Module
- Distance Regulation Sensor
- Drag Links
- Dynamic Stability Control
- Dynamic Stability Traction Control
- Electronic Ride Control Shocks And Struts
- Electronic Stability Control
- Electronic Suspension System
- Flex Couplers
- Gaskets
- Height Sensors
- Hydraulic Hoses
- Hydraulic Power Steering Pumps
- Hydraulic Suspension Hoses
- Hydraulic Suspension Pumps
- Idler Arms
- Intermediate Shaft U-Joints
- King Pins
- Modules
- Pitman Arms
- Power Steering Belts
- Power Steering Coolers
- Power Steering Fluid
- Power Steering Hoses
- Power Steering Lines (Steel)
- Power Steering Pumps - Electric
- Power Steering Pumps
- Radar Sensor
- Radius Arms
- Relay Rods
- Relays
- Sensors
- Shock Absorbers, Strut Cartridges And Strut Assemblies
- Spindles
- Springs, Coil, Leaf And Torsion Bars
- STABILITRAC
- Stability Management System
- Steering Angle Sensor
- Steering Arms
- Steering Couplers
- Steering Dampers
- Steering Gears (Except Rack And Pinion)
- Steering Gears, Rack And Pinion
- Steering Knuckles
- Strike Out Bumpers
- Strut Bearing Plate Assemblies
- Strut Rods
- Suspension Pumps (Hydraulic)
- Sway Bar Links
- Sway Bar Mounting Bushings
- Sway Bars
- Switches
- Tie Rod Ends (Inner And Outer)
- Tire Pressure Monitoring System
- Tire Pressure Sensors
- Tires
- Torque Sensor
- Torsion Springs
- Track Bar Bushings
- Track Bars
- Trailing Arm Bushings
- Trailing Arms
- Valve Stems
- Vehicle Dynamics Control
- Vehicle Speed Sensor
- Vehicle Stability Assist
- Vehicle Stability/Skid Control
- Warning Lamps
- Wheel Alignment
- Wheel Attachment Hardware
- Wheel Bearings, Races And Seals
- Wheels (Rims)
- Wiring Harnesses And Connectors
- Reason Code Explanation
- Automotive Terminology & Definitions
- Wheel Alignment Theory & Operation - General Information
- Map - Steering, Suspension, Wheel Alignment, Wheels & Tires
- Traction Control Disable Procedures
- Trouble Shooting - Manual Transmission - General Information
- Heating, Ventilation & A/C (HVAC)
- A/C Compressor Oil Checking
- Isolating Compressor
- Refrigerant Oil
- Servicing Precautions
- Oil Checking
- General Servicing
- A/C Compressor Overhaul
- Removal & Installation
- Notes
- Ford FS-6 6-CYL Clutch Assembly
- Ford FS-6 6-CYL Shaft Seal
- Ford FX-15 10-CYL Clutch Assembly
- Ford FX-15 10-CYL Shaft Seal
- NIPPONDENSO 6E-171 & 6P-148 Clutch Assembly
- NIPPONDENSO 6E-171 & 6P-148 Shaft Seal
- NIPPONDENSO 10P13 Clutch Assembly
- NIPPONDENSO 10P13 Shaft Seal
- NIPPONDENSO 10P15, 10P15F Clutch Assembly
- NIPPONDENSO 10P15A Clutch Assembly
- NIPPONDENSO 10P15, 10P15F Shaft Seal
- NIPPONDENSO 10P15A Shaft Seal
- NIPPONDENSO 10PA17 & 10PA17A Clutch Assembly
- NIPPONDENSO 10PA17 & 10PA17A Shaft Seal
- Removal & Installation
- A/C System General Servicing
- Using R-12 Refrigerant - Safety Precautions
- Using Individual R-12 Cans
- Multi-Can Dispensing Valves
- Can Tap Installation
- Sight Glass Indicators
- 1990 Passenger Car Service Valve Location
- 1991 Passenger Car Service Valve Locations
- 1990 Truck & Van Service Valve Location Table
- 1991 Truck & Van Service Valve Locations Table
- Stem-Type Valve Operation
- SCHRADER-Type Valve Operation
- Special Valve Connectors
- Manifold Gauge Set
- Connecting Gauge Set
- Purging Test Hoses
- Stabilizing A/C System
- Pressure Gauge Indications
- Pressure Gauge Readings
- Excessive Moisture Gauge Readings
- Defective Thermostatic Switch Gauge Readings
- MISADJUSTED Thermostatic Switch Gauge Readings
- Defective Clutch Cycling Switch Pressure Gauge Readings
- Low R-12 Charge Gauge Readings
- Very Low R-12 Charge Gauge Readings
- Orifice Tube Plugged Gauge Readings
- Expansion Or "H" Valve Stuck Closed
- Expansion Or "H" Valve Stuck Open Gauge Readings
- Compressor Malfunction Gauge Readings
- Condenser Malfunction Or R-12 Overcharge Gauge Readings
- Orifice Tube Replacement - AEROSTAR, Bronco, Explorer
- Spring Lock Coupling Clamp Table
- Orifice Tube R & I - E & F Series, Ranger
- Orifice Tube R & I - Crown VIC/Gran Marquis/TWN Car
- Orifice Tube Replacement - Escort, Probe, Tracer
- Orifice Tube Replacement - All Other
- Refrigerant Recovery
- Discharging A/C System
- Flushing A/C System
- Evacuating A/C System
- Charging A/C System
- Leak Testing
- A/C System Precautions
- Before Opening The System
- Discharging A/C System
- Disconnecting Lines & Fittings
- Component Replacement
- Using R-12 Refrigerant - Safety Precautions
- Using Individual R-12 Cans
- Multi-Can Dispensing Valves
- Can Tap Installation Flat Type Seal Cans
- Screw Type Seal Cans
- Connecting Lines & Fittings
- Placing System In Operation
- Compressor Removal Information - Isolation Method
- Compressor Removal Information-Discharge Method
- A/C System Specifications
- A/C Compressor Overhaul
- HVAC Control Systems
- A/C-Heater System - Manual
- A/C-Heater System Trouble Shooting - Manual
- Heater System
- Description
- Operation
- Adjustments
- Trouble Shooting
- Testing
- Removal & Installation
- Control Panel - Bronco & "F" Series
- Control Panel - "E" Series
- Instrument Panel - Bronco & "F" Series
- Instrument Panel - "E" Series
- Plenum Assembly - Bronco & "F" Series
- Plenum Assembly - "E" Series
- Blower Motor Assembly - Bronco & "F" Series
- Blower Motor Assembly - "E" Series
- Heater Core - Bronco & "F" Series
- Heater Core - "E" Series
- Auxiliary Heater Core - "E" Series
- Wiring Diagrams
- A/C Compressor Oil Checking
- Maintenance
- Procedures
- Maintenance Information
- Model Identification
- Maintenance Service Information
- Service Point Locations
- Service Labor Times
- Wheel & Tire Specifications
- Battery Specifications
- Cautions & Warnings
- Supplemental Air Bag System
- Checking Automatic Transmission Fluid
- Anti-Lock Brake System
- Replacing Blown Fuses
- Battery Warning
- Brake Pad Wear Indicator
- Brake Pad Replacement
- Catalytic Converter
- Coolant (Propylene-Glycol Formulations)
- Electrostatic Discharge Sensitive (ESD) Parts
- Fuel Pump Shutoff Switch
- Fuel System Service
- Halogen Bulbs
- Radiator Fan
- Warranty Information
- Fuses & Circuit Breakers
- Maintenance Reminder Light (Reset Procedures)
- A/C Filter Service Reminder
- Engine Oil Replacement Reminder
- Notes
- Engine Oil Replacement Reminder Reset - Procedure 01
- Engine Oil Replacement Reminder Reset - Procedure 02
- Engine Oil Replacement Reminder Reset - Procedure 03
- Engine Oil Replacement Reminder Reset - Procedure 04
- Engine Oil Replacement Reminder Reset - Procedure 05
- Engine Oil Replacement Reminder Reset - Procedure 06
- Engine Oil Replacement Reminder Reset - Procedure 07
- Engine Oil Replacement Reminder Reset - Procedure 08
- Engine Oil Replacement Reminder Reset - Procedure 09
- Engine Oil Replacement Reminder Reset - Procedure 10
- Engine Oil Replacement Reminder Reset - Procedure 11
- Engine Oil Replacement Reminder Reset - Procedure 12
- Engine Oil Replacement Reminder Reset - Procedure 13
- Engine Oil Replacement Reminder Reset - Procedure 14
- Engine Oil Replacement Reminder Reset - Procedure 15
- Engine Oil Replacement Reminder Reset - Procedure 16
- Engine Oil Replacement Reminder Reset - Procedure 17
- Engine Oil Replacement Reminder Reset - Procedure 18
- Engine Oil Replacement Reminder Reset - Procedure 19
- Engine Oil Replacement Reminder Reset - Procedure 20
- Engine Oil Replacement Reminder Reset - Procedure 21
- Engine Oil Replacement Reminder Reset - Procedure 22
- Engine Oil Replacement Reminder Reset - Procedure 23
- Engine Oil Replacement Reminder Reset - Procedure 24
- Engine Oil Replacement Reminder Reset - Procedure 25
- Engine Oil Replacement Reminder Reset - Procedure 26
- Engine Oil Replacement Reminder Reset - Procedure 27
- Engine Oil Replacement Reminder Reset - Procedure 28
- Maintenance Service Reminder (Overhead Warning Lights)
- Maintenance Service Reminder (Sri)
- Maintenance Service Reminder (VMM)
- Tire Pressure Monitor System Reminder
- Notes
- Tire Pressure Sensor Types
- TPMS Reminder Reset - Procedure 01
- TPMS Reminder Reset - Procedure 02
- TPMS Reminder Reset - Procedure 03
- TPMS Reminder Reset - Procedure 04
- TPMS Reminder Reset - Procedure 05
- TPMS Reminder Reset - Procedure 07
- TPMS Reminder Reset - Procedure 08
- TPMS Reminder Reset - Procedure 09
- TPMS Reminder Reset - Procedure 10
- Service Indicator & Warning Lights
- Service Indicator & Warning Lights
- Notes
- Check Engine Or Service Engine Soon Warning Light
- Brake Warning Light
- Charging System Warning Light
- Battery Voltage Gauge
- Battery Charge Indicator
- Engine Oil Pressure Gauge
- Engine Coolant Temperature Gauge
- Rear Abs Warning Light
- Emissions Maintenance Warning Light
- Fuel Filter Restriction Light (Diesel Engines)
- Water In Fuel Light (Diesel)
- Service Indicator & Warning Lights
- Maintenance Information
- Procedures
- Steering
- Manual Steering
- Steering Knuckles - 4WD
- Steering System - Integral Power
- Power Steering
- Steering Knuckles - 4WD
- Steering System - Integral Power
- Steering Column
- Steering Gear
- Manual Steering
- Suspension
- Front Suspension
- Suspension - Front (4WD Coil)
- Description
- Wheel Bearing Adjustment
- Ball Joint Checking
- Automatic Locking Hubs R & I
- Manual Locking Hubs R & I
- Shock Absorber R & I
- Quad Shock Absorbers R & I
- Spindle & Shaft Assembly R & I
- Steering Knuckle R & I
- Ball Joint R & I
- Coil Spring R & I
- Radius Arm R & I
- Front Axle Assembly R & I
- Stabilizer Bar R & I
- Torque Specifications
- Wheel Alignment Specifications & Procedures
- Suspension - Front (4WD Coil)
- Rear Suspension
- Description
- Adjustments & Inspection
- Troubleshooting
- Removal & Installation
- REAR SPRING (F150-250-350 (4x2 & 4x4), F-SUPER DUTY CHASSIS CAB, COMMERCIAL CHASSIS, MOTORHOME CHASSIS & BRONCO)
- Rear Spring (ECONOLINE)
- Shock Absorber (ECONOLINE)
- Shock Absorber (Bronco, F-Series, F-Super Duty Chassis Cab & Lightning)
- Shock Absorber (F-Super Duty Commercial Chassis & MOTORHOME Chassis Vehicles)
- STABILIZER BAR (F-150-250-350 (4x2 & 4x4), F-SUPER DUTY CHASSIS CAB, MOTORHOME CHASSIS & BRONCO)
- Special Service Tools
- Torque Specifications
- Wheel Alignment
- Front Suspension
- Transmission
- Clutches
- Description
- Adjustments
- Hydraulic System Bleeding
- Removal & Installation
- Transfer Case
- Removal (Spicer TC-28 - Aerostar)
- Installation (Spicer TC-28 - Aerostar)
- Removal (Borg-Warner 1356 - Bronco & "F" Series)
- Installation (Borg-Warner 1356 - Bronco & "F" Series)
- Removal (Borg-Warner 1354 - Explorer & Ranger)
- Installation(Borg-Warner 1354 - Explorer & Ranger)
- Removal (Borg-Warner 1345 F150/250 4WD)
- Installation (Borg-Warner 1345 F150/250 4WD)
- Hydraulic Clutch Line
- Transmission
- Removal (Mazda M50D - Aerostar, Explorer & Ranger)
- Installation (Mazda M50D - Aerostar, Explorer & Ranger)
- Removal (Mazda M50D - "F" Series 2WD)
- Installation (Mazda M50D - "F" Series 2WD)
- Removal (Mazda M50D - Bronco & "F" Series 4WD)
- Installation (Mazda M50D - Bronco & "F" Series 4WD)
- Removal (Borg-Warner T-18 - F150/250 2WD)
- Installation (Borg-Warner T-18 - F150/250 2WD)
- Removal (Borg-Warner T-18 - Bronco & F150/250 4WD)
- Installation (Borg-Warner T-18 - Bronco & F150/250 4WD)
- Removal (Ford S5-42 ZF - E350 & "F" Series 2WD)
- Installation (Ford S5-42 ZF - E350 & "F" Series 2WD)
- Removal (Ford S5-42 ZF - Bronco & "F" Series 4WD)
- Installation (Ford S5-42 ZF - Bronco & "F" Series 4WD)
- Removal (Mitsubishi FM146 - Ranger 4WD)
- Installation (Mitsubishi FM146 - Ranger 4WD)
- Clutch Disc & Pressure Plate
- Clutch Release Bearing
- Clutch Pilot Bearing
- Clutch Hydraulic System
- Clutch Pedal R & I
- Transfer Case
- Torque Specifications
- Manual Trans
- Transfer Case
- Diagnosis & Overhaul - Borg-WARNER 1350 & 1356
- Transfer Case Diagnosis & Overhaul - Borg WARNER 1356
- Clutches
- External Pages
