Repair and Diagnosis (Single Page)
You are viewing the full "tree" of links on one page. This can load slowly, but is easier to search. The same page can appear multiple times under a different folder, that is why the page is so large.View "split tree" where inner folders are split out. where inner links are on separate pages.
Quick Lookups- Accessories & Equipment
- Anti-Theft Systems
- Power Door Locks
- Description & Operation
- Component Locations
- On-Vehicle Service
- Adjustments
- Trouble Shooting
- Notes
- One Door Lock Does Not Work
- All Door Locks Do Not Work
- All Locks Work From One Switch Only
- Door Locks Operate One Way Only
- Door Locks Work With Engine Running Only
- Fuel Door Release Does Not Operate
- Locks Do Not Work In Below Freezing Weather
- Locks Work Intermittently
- Trunk Lid Release Does Not Operate
- Component Tests
- Removal & Installation
- Torque Specifications
- Wiring Diagrams
- Special Service Tools
- Power Door Locks
- Cruise Control Systems
- Description & Operation
- Adjustments
- Testing
- Removal & Installation
- Circuit Testing
- Circuit Test A - System Inoperative
- Circuit Test B - System Operation Intermittent
- Circuit Test C - System Does Not Resume Or ACCEL/Coast Properly
- Circuit Test D - Speed Fluctuates
- Circuit Test F - System Will Not Set
- Circuit Test G - System Does Not Disengage When Clutch Is Applied
- Circuit Test H - Speed Increases Or Decreases
- Trouble Shooting
- Wiring Diagrams
- Exterior Lights
- Gauges & Instrument Panels
- Instrument Panel - Analog
- Description & Operation
- Testing
- Removal & Installation
- Wiring Diagrams
- Instrument Panel - Electronic
- Description & Operation
- System Tests
- Notes
- Test Dd: Display Will Not Dim With Headlights On
- Test Fa: Instantaneous Fuel Economy Always Reads 0 Mpg Or 99 Liters/100 Km
- Test FB: Trip Distance Does Not Accumulate
- Test FC: Distance To Empty Does Not Go Below 200 Miles (322 Km) With Fuel Tank Empty Or Always Reads "0"
- Test FC-A: Distance To Empty Always Reads 15-50 Miles To Empty Or Is Not Accurate
- Test FD: Fuel Gauge Does Not Display "E" When Tank Is Empty; "Co" Is Displayed; Display Blanks Out Fuel Tank Symbol; Top 2 & Bottom 2 Segment Bars Are Illuminated
- Test FE: Fuel Tank Does Not Display "F" When Tank Is Full; "Cs" Is Displayed; Display Blanks Out Tank Symbol; Top 2 & Bottom 2 Segment Bars Are Illuminated
- Test Ff: Inaccurate Fuel Indication
- Test SA: Display Does Not Respond To Buttons; No Warning Tone When Buttons Are Pushed Or Driver Alert Given
- Test Sb: Speedometer Reads "0" At All Speeds
- Test SC: Speedometer Reads Too High Or Too Low
- Test SD: Speedometer Jumps Up & Down Erratically
- Test Se: Odometer Display Reads "Error" & Service Symbol Is On
- Test Sf: Display Has "S" Illuminated
- Test SG: Odometer Does Not Accumulate Mileage Correctly Or It Counts 10 Miles And Jumps Back 10 Miles
- Test Sh: All Electronic Instrument Cluster Concerns
- Test SJ: Odometer Reading Incorrect
- Test SK: Tachometer Always Indicates Too High Or Too Low; No Tachometer Signal; Signal Erratic
- Test SL: Speed Alarm Cannot Be Set, Does Not Respond To Speed Button
- Test Ta: Display Not Illuminated; Too Dim, Or Totally Black
- Test Tb: Display Scrambled; Segments Half Illuminated; Segments Blinking Or Missing; Always Incorrect Display; Display Stuck With All Segments On
- Test TC: Temperature Gauge Display Blanks Out Thermometer Symbol; Top 2 And Bottom 2 Segment Bars Illuminated
- Test TD: Temperature Gauge Always Indicates Cold (Bottom Bar Of Display Illuminated)
- Test Te: Oil Pressure Gauge Blinks Oil Can Symbol; Top 2 & Bottom 2 Segment Bars Illuminated
- Test TF: No Cluster Warning Tone When Oil Can Symbol Blinks
- Test TG: Oil Pressure Gauge Always Reads Low & Gives Driver Alert; Erratic Oil Pressure Indication
- Test Th: Voltmeter Does Not Give No Charge Alert (Blinking Battery ISO Symbol)
- Test TX: No Cluster Warning Tone When Thermometer Symbol Is Blinking
- Removal & Installation
- Wiring Diagrams
- Instrument Panel - Analog
- Headlights
- Heated Glass/Defoggers
- Mirrors - Power
- Seats
- Power Seats
- Description & Operation
- Component Locations
- Trouble Shooting
- System Tests
- Notes
- Test A: Power Seat Is Completely Inoperative
- Test B: One Or More Power Seat Positions Are Inoperative
- Test C: Power Seat Moves But Is Noisy
- Test D: Power Seat Moves But Is Loose
- Test E: Power Seat Does Not Make Full Travel
- Test F: Power Seat Does Not Move Horizontally And/Or Vertically
- Test G: Power Seat Motor Diagnosis
- Test H: Both Lumbar Seats Inoperative
- Test I: One Lumbar Seat Is Inoperative
- Test J: Lumbar Motor Pump Inoperative
- Test K: Air Will Not Fill Lumbar Support Bag
- Test L: Air Fills Lumbar Support Bag But Will Not Hold Air Pressure For An Extended Length Of Time
- Test M: Lumbar Switch Inflates Back Bolster
- Test N: Bolster Motor Pump Inoperative
- Test O: Bolster Will Not Move Or Only Partially Moves While Inflating
- Test P: Bolster Moves But Will Not Maintain Inflate Position
- Test Q: Bolster Switch Inflates Lumbar Support
- Test R: Bolster Inflates But Does Not Retract
- Test S: Bolster Detaches From Seat
- Component Tests
- Removal & Installation
- Torque Specifications
- Wiring Diagrams
- Seats - Power
- Power Seats
- Steering Column Switches
- Window Motors & Regulators
- Power Windows
- Description & Operation
- Testing
- Window Motor
- Window Switches
- Master Switch (1990-91 Crown Victoria, Grand Marquis & Town Car)
- Single Switch (Crown Victoria, Grand Marquis & Town Car)
- Master Switch (Mustang, Sable, Taurus, Tempo & Topaz)
- Single Switch (Mark VII, Mustang, Sable, Taurus, Tempo & Topaz)
- Master Switch (Cougar & Thunderbird)
- Single Switch (Cougar & Thunderbird)
- Master Switch (Continental)
- Single Switch (Continental)
- Removal & Installation
- Wiring Diagrams
- Power Windows
- Wiper/Washer Systems
- Anti-Theft Systems
- Body & Frame
- Power Door Locks
- Description & Operation
- Component Locations
- On-Vehicle Service
- Adjustments
- Trouble Shooting
- Notes
- One Door Lock Does Not Work
- All Door Locks Do Not Work
- All Locks Work From One Switch Only
- Door Locks Operate One Way Only
- Door Locks Work With Engine Running Only
- Fuel Door Release Does Not Operate
- Locks Do Not Work In Below Freezing Weather
- Locks Work Intermittently
- Trunk Lid Release Does Not Operate
- Component Tests
- Removal & Installation
- Torque Specifications
- Wiring Diagrams
- Special Service Tools
- Mirrors - Power
- Seats
- Power Seats
- Description & Operation
- Component Locations
- Trouble Shooting
- System Tests
- Notes
- Test A: Power Seat Is Completely Inoperative
- Test B: One Or More Power Seat Positions Are Inoperative
- Test C: Power Seat Moves But Is Noisy
- Test D: Power Seat Moves But Is Loose
- Test E: Power Seat Does Not Make Full Travel
- Test F: Power Seat Does Not Move Horizontally And/Or Vertically
- Test G: Power Seat Motor Diagnosis
- Test H: Both Lumbar Seats Inoperative
- Test I: One Lumbar Seat Is Inoperative
- Test J: Lumbar Motor Pump Inoperative
- Test K: Air Will Not Fill Lumbar Support Bag
- Test L: Air Fills Lumbar Support Bag But Will Not Hold Air Pressure For An Extended Length Of Time
- Test M: Lumbar Switch Inflates Back Bolster
- Test N: Bolster Motor Pump Inoperative
- Test O: Bolster Will Not Move Or Only Partially Moves While Inflating
- Test P: Bolster Moves But Will Not Maintain Inflate Position
- Test Q: Bolster Switch Inflates Lumbar Support
- Test R: Bolster Inflates But Does Not Retract
- Test S: Bolster Detaches From Seat
- Component Tests
- Removal & Installation
- Torque Specifications
- Wiring Diagrams
- Seats - Power
- Power Seats
- Sun Roof/T-Top/Convertible Top
- Power Windows
- Description & Operation
- Testing
- Window Motor
- Window Switches
- Master Switch (1990-91 Crown Victoria, Grand Marquis & Town Car)
- Single Switch (Crown Victoria, Grand Marquis & Town Car)
- Master Switch (Mustang, Sable, Taurus, Tempo & Topaz)
- Single Switch (Mark VII, Mustang, Sable, Taurus, Tempo & Topaz)
- Master Switch (Cougar & Thunderbird)
- Single Switch (Cougar & Thunderbird)
- Master Switch (Continental)
- Single Switch (Continental)
- Removal & Installation
- Wiring Diagrams
- Power Door Locks
- Brakes
- Anti-Lock Brakes
- Anti-Lock Brake System
- Description
- Operation
- Depressurizing Brake System
- Bleeding Brake System
- Trouble Shooting
- Diagnosis
- Diagnostic Tests Using Warning Light Symptom Chart
- Notes
- Circuit Test A - Anti-Lock Light On With Brake Light Off
- Circuit Test B - Anti-Lock Light On After Eng Starts, Brake Light Off
- Circuit Test C - Anti-Lock Light On While Driving Or Cycling Of Anti-Lock System
- Circuit Test D - Anti-Lock & Brake Light On Or Pump Motor Runs Over 60 Seconds
- Circuit Test E - Anti-Lock Light Intermittently On
- Circuit Test F - Brake Light On, Anti-Lock Light Off; Parking Brake & Brake Lining Checked
- Circuit Test G - Anti-Lock Light Not On When Ignition Is Turned On
- Circuit Test H - Spongy Brake Pedal, No Warning Light With/Without Anti-Lock Function
- Circuit Test J - Poor Vehicle Tracking During Anti-Lock Function, Light Off
- On-Board Self-Test
- Removal & Installation
- Adjustments
- Torque Specifications
- Wiring Diagrams
- Anti-Lock Brake System
- Mechanical - Hydraulic
- Traction Control
- Anti-Lock Brake System
- Description
- Operation
- Depressurizing Brake System
- Bleeding Brake System
- Trouble Shooting
- Diagnosis
- Diagnostic Tests Using Warning Light Symptom Chart
- Notes
- Circuit Test A - Anti-Lock Light On With Brake Light Off
- Circuit Test B - Anti-Lock Light On After Eng Starts, Brake Light Off
- Circuit Test C - Anti-Lock Light On While Driving Or Cycling Of Anti-Lock System
- Circuit Test D - Anti-Lock & Brake Light On Or Pump Motor Runs Over 60 Seconds
- Circuit Test E - Anti-Lock Light Intermittently On
- Circuit Test F - Brake Light On, Anti-Lock Light Off; Parking Brake & Brake Lining Checked
- Circuit Test G - Anti-Lock Light Not On When Ignition Is Turned On
- Circuit Test H - Spongy Brake Pedal, No Warning Light With/Without Anti-Lock Function
- Circuit Test J - Poor Vehicle Tracking During Anti-Lock Function, Light Off
- On-Board Self-Test
- Removal & Installation
- Adjustments
- Torque Specifications
- Wiring Diagrams
- Anti-Lock Brake System
- Anti-Lock Brakes
- Drivelines & Axles
- Differentials & Drive Axles
- Driveshaft & Universal Joints
- Electrical
- Charging Systems
- Alternator - Models W/Internal Fan & Regulator
- Alternator - W/Internal Fan & Rear Mount Regulator
- Alternator & Regulator - Models W/External Fan
- Description
- Adjustments
- Testing
- Battery Voltage Test
- No-Load Test
- Load Test
- High Voltage Test
- Low Voltage Test
- Regulator "S" & "I" Circuit Test
- Field Circuit Drain Test
- Rectifier Shorted Or Grounded & Stator Grounded Test
- Field Open Or Short Circuit Test
- Rectifier Assembly Test
- Radio Suppression Capacitor Test
- Stator Coil Grounded Test
- Stator Coil Open Test
- Rotor Open Or Short Circuit Test
- Overhaul
- Alternator Specifications
- Torque Specifications
- Component Locations
- Fuses & Circuit Breakers
- Gauges
- Instrument Panel - Analog
- Description & Operation
- Testing
- Removal & Installation
- Wiring Diagrams
- Instrument Panel - Electronic
- Description & Operation
- System Tests
- Notes
- Test Dd: Display Will Not Dim With Headlights On
- Test Fa: Instantaneous Fuel Economy Always Reads 0 Mpg Or 99 Liters/100 Km
- Test FB: Trip Distance Does Not Accumulate
- Test FC: Distance To Empty Does Not Go Below 200 Miles (322 Km) With Fuel Tank Empty Or Always Reads "0"
- Test FC-A: Distance To Empty Always Reads 15-50 Miles To Empty Or Is Not Accurate
- Test FD: Fuel Gauge Does Not Display "E" When Tank Is Empty; "Co" Is Displayed; Display Blanks Out Fuel Tank Symbol; Top 2 & Bottom 2 Segment Bars Are Illuminated
- Test FE: Fuel Tank Does Not Display "F" When Tank Is Full; "Cs" Is Displayed; Display Blanks Out Tank Symbol; Top 2 & Bottom 2 Segment Bars Are Illuminated
- Test Ff: Inaccurate Fuel Indication
- Test SA: Display Does Not Respond To Buttons; No Warning Tone When Buttons Are Pushed Or Driver Alert Given
- Test Sb: Speedometer Reads "0" At All Speeds
- Test SC: Speedometer Reads Too High Or Too Low
- Test SD: Speedometer Jumps Up & Down Erratically
- Test Se: Odometer Display Reads "Error" & Service Symbol Is On
- Test Sf: Display Has "S" Illuminated
- Test SG: Odometer Does Not Accumulate Mileage Correctly Or It Counts 10 Miles And Jumps Back 10 Miles
- Test Sh: All Electronic Instrument Cluster Concerns
- Test SJ: Odometer Reading Incorrect
- Test SK: Tachometer Always Indicates Too High Or Too Low; No Tachometer Signal; Signal Erratic
- Test SL: Speed Alarm Cannot Be Set, Does Not Respond To Speed Button
- Test Ta: Display Not Illuminated; Too Dim, Or Totally Black
- Test Tb: Display Scrambled; Segments Half Illuminated; Segments Blinking Or Missing; Always Incorrect Display; Display Stuck With All Segments On
- Test TC: Temperature Gauge Display Blanks Out Thermometer Symbol; Top 2 And Bottom 2 Segment Bars Illuminated
- Test TD: Temperature Gauge Always Indicates Cold (Bottom Bar Of Display Illuminated)
- Test Te: Oil Pressure Gauge Blinks Oil Can Symbol; Top 2 & Bottom 2 Segment Bars Illuminated
- Test TF: No Cluster Warning Tone When Oil Can Symbol Blinks
- Test TG: Oil Pressure Gauge Always Reads Low & Gives Driver Alert; Erratic Oil Pressure Indication
- Test Th: Voltmeter Does Not Give No Charge Alert (Blinking Battery ISO Symbol)
- Test TX: No Cluster Warning Tone When Thermometer Symbol Is Blinking
- Removal & Installation
- Wiring Diagrams
- Instrument Panel - Analog
- Starter
- Wiring Diagrams
- Charging Systems
- Engine Mechanical
- Accessory Drive Belts
- Drive Belt Routing
- Belt Adjustment
- Belt Routing
- Serpentine Belt Routing (Continental 3.8L)
- Serpentine Belt Routing (Cougar 5.0L & THUNDERBIRD 3.8L)
- Serpentine Belt Routing (Cougar 5.0L & THUNDERBIRD 5.0L)
- Serpentine Belt Routing (Crown Victoria & Grand Marquis)
- Serpentine Belt Routing (Escort & Tracer 1.8L)
- Serpentine Belt Routing (Escort 1.9L & Tracer 1.9L)
- Serpentine Belt Routing (Mark VII)
- Serpentine Belt Routing (Mustang 2.3L)
- Serpentine Belt Routing (Mustang 5.0L)
- Serpentine Belt Routing (Probe 3.0L)
- Serpentine Belt Routing (Sable 3.0L & TAURUS 3.0L)
- Serpentine Belt Routing (Sable 3.8L & TAURUS 3.8L)
- Serpentine Belt Routing (TAURUS 2.5L)
- Serpentine Belt Routing (TAURUS 3.0L SHO)
- Serpentine Belt Routing (Tempo 2.3L & Topaz 2.3L)
- Serpentine Belt Routing (THUNDERBIRD 3.8L SC)
- Serpentine Belt Routing (Town Car 4.6L)
- Drive Belt Routing
- Engine Cooling Fan
- Cooling System (Mechanical)
- Cooling System Specifications
- Drive Belt Routing
- Belt Adjustment
- Belt Routing
- Serpentine Belt Routing (Continental 3.8L)
- Serpentine Belt Routing (Cougar 5.0L & THUNDERBIRD 3.8L)
- Serpentine Belt Routing (Cougar 5.0L & THUNDERBIRD 5.0L)
- Serpentine Belt Routing (Crown Victoria & Grand Marquis)
- Serpentine Belt Routing (Escort & Tracer 1.8L)
- Serpentine Belt Routing (Escort 1.9L & Tracer 1.9L)
- Serpentine Belt Routing (Mark VII)
- Serpentine Belt Routing (Mustang 2.3L)
- Serpentine Belt Routing (Mustang 5.0L)
- Serpentine Belt Routing (Probe 3.0L)
- Serpentine Belt Routing (Sable 3.0L & TAURUS 3.0L)
- Serpentine Belt Routing (Sable 3.8L & TAURUS 3.8L)
- Serpentine Belt Routing (TAURUS 2.5L)
- Serpentine Belt Routing (TAURUS 3.0L SHO)
- Serpentine Belt Routing (Tempo 2.3L & Topaz 2.3L)
- Serpentine Belt Routing (THUNDERBIRD 3.8L SC)
- Serpentine Belt Routing (Town Car 4.6L)
- Mechanical
- 5.0L V8 - VINS [E,F,T] & 5.8L V8 - VIN [G]
- Engine Identification
- Adjustments
- Removal & Installation
- Overhaul
- Lubrication
- Engine Cooling
- Torque Specifications
- Engine Specifications
- 5.0L V8 - VINS [E,F,T] & 5.8L V8 - VIN [G]
- Starter
- Accessory Drive Belts
- Engine Performance
- Adjustment
- Application
- Emissions
- Calibration Labels
- EGR Function Testing - Ford - Cars
- Emission Applications
- Emission Control Abbreviations
- State Emission Standards - Diesel
- State Emission Standards - Gas
- ALASKA
- ARIZONA
- CALIFORNIA
- Colorado
- CONNECTICUT
- DELAWARE
- District Of COLUMBIA
- GEORGIA
- IDAHO
- ILLINOIS
- INDIANA
- KENTUCKY
- MARYLAND
- MASSACHUSETTS
- MISSOURI
- NEVADA
- New Jersey
- New MEXICO
- New YORK
- North CAROLINA
- OHIO
- OREGON
- PENNSYLVANIA
- RHODE Island
- TENNESSEE
- TEXAS
- UTAH
- VIRGINIA
- WASHINGTON
- WISCONSIN
- U. S. EPA ASM2525 & ASM5015 Start-Up Emission Standards
- U. S. EPA Revised Final ASM Emission Standards (ASM5015 & ASM2525)
- U.S. EPA Im240 Emission Standards
- Engine Controls - Pin Voltage Charts
- Remove, Overhaul & Install
- Engine Controls - Remove/Install/Overhaul
- Introduction
- Crankshaft Sensor
- Camshaft Position Sensor
- Synchronizer Assembly
- Distributor
- Oxygen Sensor
- Fuel System Pressure Release
- Fuel Line Connector
- Intake Plenum & Throttle Body
- Fuel Rails
- Injectors
- Fuel Pressure Regulator
- Throttle Position Sensor (TPS)
- INTERCOOLER
- INTERCOOLER Inlet & Outlet Tubes
- Supercharger 3.8L
- Turbocharger 2.2L
- Vane Airflow Meter (VAF)
- Fuel Pump
- Emission Systems & Sub-Systems
- Engine Controls - Remove/Install/Overhaul
- Sensor Range Charts
- Engine Controls - Sensor Operating Range Charts
- Introduction
- Electronic Engine Control (EEC) 1.8L & 2.2L
- Elect. Engine Control-IV (EEC-IV) Except 1.8/2.2/5.8L
- Act & ECT Sensors
- Cylinder Identification (CID) Sensor
- EGR Valve Position (EVP) Sensor
- Exhaust Gas Oxygen (Ego) Sensor
- Mass Airflow (MAF) Sensor
- Manifold Absolute Pressure (Map) Sensor
- Pressure Feedback EGR (PFE) Sensors
- Delta Pressure Feedback EGR (DPFE)
- Manual Lever Position (MLP) Sensor
- Throttle Position Sensor (TPS)
- Transmission Oil Temperature (Tot) Sensor
- Microprocessor Control Unit (MCU) 5.8L Police
- Engine Controls - Sensor Operating Range Charts
- Specifications
- Engine Controls - Specifications - V8
- Fuel Pressure Specifications
- System
- EGR Function Testing
- Engine Controls - Basic Diagnostic Procedures
- Engine Controls - System/Component Tests - 5.0L
- Introduction
- Air Induction Systems
- Computerized Engine Controls
- Engine Sensors & Switches (ECA Inputs)
- Notes
- Air Charge Temperature (Act) Sensor
- Barometric Pressure Sensor (BP)
- Cylinder Identification Sensor (CID) & Crankshaft Sensors
- Engine Coolant Temperature (ECT) Sensor
- EGR Valve Position (EVP) Sensor/EGR Vacuum Regulator (EVR) Solenoid
- EGR Pressure Feedback (PFE) Sensor/Delta PFE/EGR Vacuum Regulator (EVR) Solenoid
- Heated Gas Oxygen (HEGO) Sensor
- Inertia Switch
- Knock Sensor (KS)
- Manifold Absolute Pressure (Map) Sensor
- Mass Airflow (Ma) Sensor
- Neutral Drive Switch (NDS) A/C Input
- Power Steering Pressure Switch (PSPS)
- Throttle Position Sensor (TP Or TPS)
- Vehicle Speed Sensor (VSS)
- Relays
- Solenoids
- Fuel System Testing
- Fuel Control System Testing
- Idle Control System
- Ignition Systems
- TFI-IV System
- Notes
- Preliminary Check
- Test Equipment
- Diagnostic Aids
- Primary Circuit Test (Except Closed Bowl Distributor)
- Non-CCD Systems
- CCD Systems
- Primary Circuit Test (Closed Bowl Distributor)
- TFI Module Resistance Test
- Pip Sensor/Stator Test (Except Closed Bowl Distributor)
- Pip Sensor/Stator Test (Closed Bowl Distributor)
- Coil Test
- Spark Timing Advance Test
- Emission Systems & Sub-Systems
- Air Injection
- Air Supply Pump
- Air Silencer/Filter (Air Pump & Pulse Air Inlet)
- Air By-Pass Valve (Normally Closed)
- Air Check Valve
- Air Supply Control Valve
- Air Control Valve (Switch-Relief)
- Air Pump Resonator
- Combination Air By-Pass/Air Control Valve
- Dual Thermactor Air Control Solenoid Valve
- Thermactor Idle Vacuum (TIV) Valve
- Vacuum Control Valve (VCV)
- Electrical Vacuum Control Valve
- Vacuum Check Valve
- Vacuum Reservoir
- Pulse Air Valve
- Exhaust Gas RECIRCULATION (EGR)
- Fuel Evaporation
- Positive Crankcase Ventilation (PCV)
- Thermostatic Air Cleaner (TAC)
- Air Injection
- Wiring Diagrams
- Engine Controls - Tests W/Codes - 5.0L
- Introduction
- Self-Diagnostic System
- Service Codes
- Retrieving Codes
- Clearing Codes
- Reading Codes
- Quick Test
- Additional System Functions
- Summary
- KOEO Code-To-Test Menu - 5.0L
- KOER Code-To-Test Menu - 5.0L
- Continuous Code-To-Test Menu - 5.0L
- Service Code Definitions
- Test Pin Identification
- How To Use Circuit Tests
- Test A - No Start (TFI & Dis Ignition Systems)
- Test B - Checking Vehicle Battery
- Test C - Reference Voltage
- Test DA - Temperature Sensor Test (Act & ECT)
- Test Dc - Mass Airflow Sensor (MAF)
- Test DF - Map/BP Sensor
- Test DH - Throttle Position Sensor (TPS)
- Test DL - PFE Valve, DPFE Sensor & EVR Solenoid
- Test DN - EVP Sensor & EVR Solenoid
- Test DP - Vehicle Speed Sensor (VSS)
- Test FD - Brake On-Off (Boo) Switch
- Test G - In-Range MAF/TPS Fuel Injector Pulse Width Test
- Test H - Fuel Control
- Test Ha - Adaptive Fuel
- Test J - Fuel Pump Circuit (Relay & Inertia Switch)
- Test Kc - Air Management System (Am1/Am2)
- Test KD - Canister Purge (CANP)
- Test KE - Idle Speed Control (Air By-Pass)
- Test Km - WAC & A/C Demand Switches
- Test Ml - STO Or Mil Lights
- Test NA - TFI Ignition Ignition Diagnostic Monitor (IDM)
- Test Pa - Spark Timing Check (TFI Vehicles)
- Test QA - No Codes/Codes Not Listed
- Test QB - Code 15, 511 Or 512 KOEO Or Continuous Memory Code
- Test QC - Output State Check Not Functioning
- Test S - System Check
- Test Ta - Neutral Drive Input
- Test Tb - A4LD Transmission
- Engine Controls - Tests W/O Codes - Gasoline
- Introduction
- DRIVEABILITY Symptom Check Procedures
- Symptom-To-Routine Menu
- Intermittent Problem Diagnosis
- Intermittent Test Procedures
- Routine 200 - No Crank & No Start
- Routine 201 - Cranks Normally But Won't Start
- Routine 202 - Cranks Normally But Won't Run (Stalls)
- Routine 203 - Cranks Normally But Slow To Start
- Routine 204 - Rough Idle
- Routine 205 - Misses Under Load
- Routine 206 - Low Idle (Stalls On DECEL Or Quick Stop)
- Routine 207 - Hesitates Or Stalls On Acceleration
- Routine 208 - Backfire (Intake Or Exhaust)
- Routine 209 - Lack Of Power
- Routine 210 - Surges At Steady Speed
- Routine 211 - High Idle, Engine "Diesels"
- Routine 212 - Engine Noise
- Routine 213 - Poor Fuel Economy
- Routine 214 - High Oil Consumption
- Routine 215 - Spark Knock (Pings)
- Routine 216 - Engine Vibrates At Normal Or High Speed
- Routine 217 - Engine Runs Cold
- Routine 218 - Engine Runs Hot
- Routine 219 - Exhaust Smoke
- Routine 220 - Gas Smell
- Routine 221 - "Check Eng/SERV Soon" Always/Never On
- Routine 222 - State Emission Test Failure
- Routine 223 - Improper Shift
- Routine 224 - SIL & Audible Chimes "On"
- Using The Symptom-To-Diagnostic Flow Chart Menu
- Testing & Diagnosis
- EGR Function Testing
- Engine Controls - Basic Diagnostic Procedures
- Engine Controls - System/Component Tests - 5.0L
- Introduction
- Air Induction Systems
- Computerized Engine Controls
- Engine Sensors & Switches (ECA Inputs)
- Notes
- Air Charge Temperature (Act) Sensor
- Barometric Pressure Sensor (BP)
- Cylinder Identification Sensor (CID) & Crankshaft Sensors
- Engine Coolant Temperature (ECT) Sensor
- EGR Valve Position (EVP) Sensor/EGR Vacuum Regulator (EVR) Solenoid
- EGR Pressure Feedback (PFE) Sensor/Delta PFE/EGR Vacuum Regulator (EVR) Solenoid
- Heated Gas Oxygen (HEGO) Sensor
- Inertia Switch
- Knock Sensor (KS)
- Manifold Absolute Pressure (Map) Sensor
- Mass Airflow (Ma) Sensor
- Neutral Drive Switch (NDS) A/C Input
- Power Steering Pressure Switch (PSPS)
- Throttle Position Sensor (TP Or TPS)
- Vehicle Speed Sensor (VSS)
- Relays
- Solenoids
- Fuel System Testing
- Fuel Control System Testing
- Idle Control System
- Ignition Systems
- TFI-IV System
- Notes
- Preliminary Check
- Test Equipment
- Diagnostic Aids
- Primary Circuit Test (Except Closed Bowl Distributor)
- Non-CCD Systems
- CCD Systems
- Primary Circuit Test (Closed Bowl Distributor)
- TFI Module Resistance Test
- Pip Sensor/Stator Test (Except Closed Bowl Distributor)
- Pip Sensor/Stator Test (Closed Bowl Distributor)
- Coil Test
- Spark Timing Advance Test
- Emission Systems & Sub-Systems
- Air Injection
- Air Supply Pump
- Air Silencer/Filter (Air Pump & Pulse Air Inlet)
- Air By-Pass Valve (Normally Closed)
- Air Check Valve
- Air Supply Control Valve
- Air Control Valve (Switch-Relief)
- Air Pump Resonator
- Combination Air By-Pass/Air Control Valve
- Dual Thermactor Air Control Solenoid Valve
- Thermactor Idle Vacuum (TIV) Valve
- Vacuum Control Valve (VCV)
- Electrical Vacuum Control Valve
- Vacuum Check Valve
- Vacuum Reservoir
- Pulse Air Valve
- Exhaust Gas RECIRCULATION (EGR)
- Fuel Evaporation
- Positive Crankcase Ventilation (PCV)
- Thermostatic Air Cleaner (TAC)
- Air Injection
- Wiring Diagrams
- Engine Controls - Tests W/Codes - 5.0L
- Introduction
- Self-Diagnostic System
- Service Codes
- Retrieving Codes
- Clearing Codes
- Reading Codes
- Quick Test
- Additional System Functions
- Summary
- KOEO Code-To-Test Menu - 5.0L
- KOER Code-To-Test Menu - 5.0L
- Continuous Code-To-Test Menu - 5.0L
- Service Code Definitions
- Test Pin Identification
- How To Use Circuit Tests
- Test A - No Start (TFI & Dis Ignition Systems)
- Test B - Checking Vehicle Battery
- Test C - Reference Voltage
- Test DA - Temperature Sensor Test (Act & ECT)
- Test Dc - Mass Airflow Sensor (MAF)
- Test DF - Map/BP Sensor
- Test DH - Throttle Position Sensor (TPS)
- Test DL - PFE Valve, DPFE Sensor & EVR Solenoid
- Test DN - EVP Sensor & EVR Solenoid
- Test DP - Vehicle Speed Sensor (VSS)
- Test FD - Brake On-Off (Boo) Switch
- Test G - In-Range MAF/TPS Fuel Injector Pulse Width Test
- Test H - Fuel Control
- Test Ha - Adaptive Fuel
- Test J - Fuel Pump Circuit (Relay & Inertia Switch)
- Test Kc - Air Management System (Am1/Am2)
- Test KD - Canister Purge (CANP)
- Test KE - Idle Speed Control (Air By-Pass)
- Test Km - WAC & A/C Demand Switches
- Test Ml - STO Or Mil Lights
- Test NA - TFI Ignition Ignition Diagnostic Monitor (IDM)
- Test Pa - Spark Timing Check (TFI Vehicles)
- Test QA - No Codes/Codes Not Listed
- Test QB - Code 15, 511 Or 512 KOEO Or Continuous Memory Code
- Test QC - Output State Check Not Functioning
- Test S - System Check
- Test Ta - Neutral Drive Input
- Test Tb - A4LD Transmission
- Engine Controls - Tests W/O Codes - Gasoline
- Introduction
- DRIVEABILITY Symptom Check Procedures
- Symptom-To-Routine Menu
- Intermittent Problem Diagnosis
- Intermittent Test Procedures
- Routine 200 - No Crank & No Start
- Routine 201 - Cranks Normally But Won't Start
- Routine 202 - Cranks Normally But Won't Run (Stalls)
- Routine 203 - Cranks Normally But Slow To Start
- Routine 204 - Rough Idle
- Routine 205 - Misses Under Load
- Routine 206 - Low Idle (Stalls On DECEL Or Quick Stop)
- Routine 207 - Hesitates Or Stalls On Acceleration
- Routine 208 - Backfire (Intake Or Exhaust)
- Routine 209 - Lack Of Power
- Routine 210 - Surges At Steady Speed
- Routine 211 - High Idle, Engine "Diesels"
- Routine 212 - Engine Noise
- Routine 213 - Poor Fuel Economy
- Routine 214 - High Oil Consumption
- Routine 215 - Spark Knock (Pings)
- Routine 216 - Engine Vibrates At Normal Or High Speed
- Routine 217 - Engine Runs Cold
- Routine 218 - Engine Runs Hot
- Routine 219 - Exhaust Smoke
- Routine 220 - Gas Smell
- Routine 221 - "Check Eng/SERV Soon" Always/Never On
- Routine 222 - State Emission Test Failure
- Routine 223 - Improper Shift
- Routine 224 - SIL & Audible Chimes "On"
- Using The Symptom-To-Diagnostic Flow Chart Menu
- Theory and Operation
- Engine Controls - Theory & Operation - EEC-IV
- Introduction
- Air Induction System
- Computerized Engine Controls
- Control Unit
- Input Devices
- Notes
- Air Charge Temperature (ACT) Sensor
- Barometric Pressure (BP) Sensor
- Brake On-Off (BOO) Switch
- Camshaft Sensor
- Clutch Engage Switch
- Coolant Temperature Sensor
- Crankshaft Angle Sensor
- Cylinder Identification (CID) Sensors
- Exhaust Gas Oxygen (EGO) Sensor
- EGR Valve Position (EVP) Sensor
- Engine Coolant Temperature (ECT) Sensor
- Heated Exhaust Gas Oxygen (HEGO) Sensor
- Knock Sensor (KS)
- Manifold Absolute Pressure (MAP) Sensor
- Mass Airflow (MAF) Sensor
- Neutral Gear Switch (NGS)
- Power Steering (P/S) Pressure Switch
- Self-Test Output/Self-Test Input (STO/STI) Connectors
- Throttle Position Sensor (TPS)
- Vehicle Speed Sensor (VSS)
- Output Signals
- Fuel System
- Ignition Systems
- Emission Systems
- Notes
- Vacuum
- Air Injection System
- Notes
- Pulse Air Valve System
- Thermactor Air System
- Anti-Backfire (Gulp) Valve
- Air By-Pass Valve
- Air Check Valve & Pulse Air Valve
- Air Pump
- Air Silencer/Filter
- Air Supply Control Valves
- Check Valves
- Combination Air By-Pass & Air Control Valve
- Dual Thermactor Air Control Solenoid Valve
- Thermactor Idle Vacuum (TIV) Valve
- EGR System
- Evaporative Emission System
- Positive Crankcase Ventilation (PCV)
- Self-Diagnostic System
- Miscellaneous Controls
- Engine Controls - Theory & Operation - EEC-IV
- Vacuum Diagrams
- Wiring Diagrams
- General Information
- Abbreviations
- Basic Trouble Shooting
- Basic Trouble Shooting - General Information
- Commonly Used Abbreviations - General Information
- Emission Control Abbreviations
- Engine Performance - Trouble Shooting - General Information
- Brakes
- Anti-Lock Brake Safety Precautions - General Information
- Map - Brake Systems
- Brake Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Accelerometers
- Accumulators
- Anchor Pins
- Anti-Lock Brake Control Assembly(Module)
- Anti-Lock Brake Controller
- Anti-Lock Brake Systems
- Axle Seal
- Backing Plates
- Bleeder Screw
- Brake Abs Active Light (Blue)
- Brake Fluid
- Brake Friction Material
- Brake On - Off Switch
- Brake Pads
- Brake Pedals
- Brake Shoe Hardware
- Brake Shoes
- Brake Stoplight Switches
- Brake Warning Light (Amber)
- Brake Warning Light (Red)
- Bulb Sockets
- Bulbs And LEDS
- Caliper Hardware
- Caliper Mounting Pin
- Caliper Piston
- Caliper Shim
- Caliper Slider Pin (Bolt) Dust Boot
- Caliper Slider Pin (Bolt)
- Calipers
- Combination Valve
- Controllers
- Digital Ratio Axle Controllers And Buffers (Drab And Dram)
- Disable Switches
- Drums
- Electrical Brake Pumps
- Electrical Park Motor
- Electrical Pumps And Motors
- Electro-Magnetic Interference
- Electronic Brake Control Modulator
- Electronic Brake Distribution
- Electronic Brake Traction Control Module
- Electronic Controllers
- Electronic Traction Control
- External Brake Cable
- Flow Control Valve
- Fluid Level Sensor Switches
- Fluid
- Four Wheel Drive Switches
- Friction Material
- G Sensors
- Gaskets
- Gravitational Switches
- Grease Seal
- Height Sensing Proportioning Valve
- High Pressure Accumulator
- Hoses
- Hub
- Hydraulic Control Unit
- Hydraulic Modulators
- Hydro-Boosters
- Hydro-Electric Boosters (POWERMASTER)
- Ignition Disable Switches
- Lamp Driver Relay
- Lateral Acceleration Switches
- LEDS
- Lenses
- Low Pressure Accumulator
- Lug Nut
- Master Cylinder Cover Gasket
- Master Cylinders
- Modulators
- Motor Pack
- Motors
- Pads
- Parking Brake Cable
- Parking Brake Mechanism
- Parking Brake Shoes
- Parking Brake Switches
- Parking Brake Systems
- Pedal Travel Switches
- Pedals
- Power Distribution Center
- POWERMASTER
- Pressure Differential Switches
- Pressure Switches
- Pressure Transducers
- Proportioning Valve
- Pumps
- Relays
- RELUCTOR (Speed) Ring
- Rotors
- Self-Adjusting Systems
- Shoe Hardware
- Shoes
- Sockets
- Speed Sensor (RELUCTOR) Ring
- Speed Sensors (Electronic Wheel And Vehicle)
- Star Wheel
- Steel Brake Lines
- Stoplight Switches
- Stroke Sensor
- Switches
- Tires
- Tone Ring
- Toothed Rings (Tone Wheel)
- Traction Control System (TCS)
- Transfer Tubes
- Vacuum Boosters
- Vacuum Hoses
- Valves
- Wear Indicator
- Wheel Attachment Hardware
- Wheel Bearings, Races And Seals
- Wheel Cylinders
- Wiring Harnesses
- Yaw Rate Sensor
- Brake System CHECKSHEET
- Reason Code Explanation
- Automotive Terminology & Definitions
- Brake Systems
- Map - Routine Inspection Reference Guide
- Routine Inspection Reference Guide
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Maintenance Overview
- Antifreeze/Coolant
- Visual Inspection
- Radiator Cap Test
- Engine Fan
- Cooling System Power Flush And Refill
- Belts (Except Timing Belts)
- Belt TENSIONER
- Automatic Transmission Fluid
- Automatic Transmission Fluid Exchange & Filter Replacement
- Engine Oil
- Air Filters
- Cabin Air Filter
- Brake Fluid
- Battery
- Battery Cables
- Power Steering
- Power Steering Fluid
- Wiper Blades
- Routine Inspection CHECKSHEET
- Routine Inspection - UICS
- Brake Systems
- Drivetrain And Transmission
- Notes
- Automatic Transmission Fluid
- Clutch Master Cylinders
- Cooler Lines
- Coolers
- Differential Fluid
- Drain Plugs And Gaskets
- Filters And Screens
- Fluids And Lubricants
- Hoses, Lines, And Tubes
- Hydraulic Fluid
- Lubricants
- Manual Transmission Fluid
- Mounts (Engine, Transaxle And Transmission)
- Transfer Case Fluid
- Vacuum Hoses
- Electrical Systems
- Engine Performance And Maintenance
- Notes
- Accessory Belts
- Air Filter Elements
- Air Filter Gaskets
- Air Filter Housings And Gaskets
- Air Pump Belts
- Batteries
- Battery Connectors
- Belt Idler Assemblies (Accessory And Cam Belts)
- Belt TENSIONERS (Accessory And Cam Belt)
- Chemical Engine DECARBONIZATION
- Combustion Chamber Cleaning
- Coolant Recovery Tanks
- Coolant
- Distributor Caps
- Distributor Rotors
- Engine Cooling Systems
- Engine DECARBONIZATION
- Engine Oil Drain Plugs And Gaskets
- Engine Oil Filters And Canisters
- Engine Oil
- Fuel Filters
- Fuel Injector Cleaning
- Fuel Injectors
- Fuel System Cleaning Service
- Hose Clamps
- Hose Connectors
- Hose Couplers
- Hoses And Tubes (Fuel Lines, Radiator, Vacuum, By-Pass, Heater, Recovery Tank And Oil Coolers)
- Ignition Wires (Secondary)
- Intake Cleaning
- O2 Sensors
- PCV Breather Elements
- PCV Valves
- Radiator Caps And Pressurized Expansion Tank Caps
- Spark Plugs
- Thermostats And Housings
- Throttle Body Cleaning
- Timing Belts
- Vacuum Hoses, Tubes And Connections (Non-Metallic)
- Exhaust Systems
- Heating, Ventilation And Air Conditioning Systems
- Steering And Suspension, Wheel Alignment, Wheels And Tires
- Wheel & Tire Supplement
- Reason Code Explanation
- Automotive Terminology & Definitions
- Routine Inspection Reference Guide
- Check Lists
- Computer Relearn Procedures
- Driveline/Axles
- Drive Axle Noise Diagnosis - General Information
- Gear Tooth Contact Patterns - General Information
- Map - Drive Train & Transmission
- Drive Train & Transmission Systems
- Drivetrain And Transmission
- Notes
- Actuators (Electrical)
- Actuators (Vacuum)
- Automatic Transmission / Transaxle Assemblies/CVTS
- Automatic Transmission Fluid
- Axles
- Bearings And Races
- Bell Cranks
- Bell Housings
- Bushings (External)
- Cables (Speedometer)
- Cables (TV, Detent And Shift)
- Carrier Bearings
- Clutch Cables And Cable Housings
- Clutch Discs (Manual Transmissions)
- Clutch Forks
- Clutch Linkages (Mechanical)
- Clutch Master Cylinders
- Clutch Pedals
- Clutch Pivots
- Clutch Pressure Plates
- Clutch Release Bearings
- Clutch Slave Cylinders (Concentric)
- Clutch Slave Cylinders (Conventional Or External)
- Companion Flanges
- Connectors
- Cooler Bypass Valves
- Cooler Lines
- Coolers
- CV Joints
- Differential And Final Drive Assemblies
- Differential Fluid
- Dip Stick Tubes
- Dip Sticks (Fluid Level Indicators)
- Dowel Pins, Guides And Pilot Holes
- Drain Plugs And Gaskets
- Drive Shaft Flanges
- Drive Shafts And Half Shafts
- Dust Boots
- Engine Mounts
- Exciter Rings
- Filler Tubes
- Filters And Screens
- Flanges
- Flex Plates
- Fluid Level Indicators
- Fluids And Lubricants
- Flywheels
- Force Motors
- Gaskets
- Guides
- Half Shafts
- Hoses, Lines, And Tubes
- Housings (Bell, Case, Tail(Extension) And Auxiliary)
- Hydraulic Fluid
- Intermediate Shaft Support Bearings
- Key Interlock Systems
- Limited Slips
- Lines
- Linkages (External)
- Locking Hub Assemblies
- Locking Hub Control Knobs
- Lubricants
- Manual Transmission Fluid
- Manual Transmission/Transaxle Assemblies
- Metal Clad Seals
- METALASTIC Joints
- Modulator Pins
- Modulators
- Mounts (Engine, Transaxle And Transmission)
- Odometer Drives (Mechanical)
- Odometer Heads (Mechanical)
- Oil Pans
- Pans
- Pilot Holes
- Pressure Plates
- Pressure Switches
- Races
- Rubber Joints (METALASTIC)
- Screens
- Seals (Metal Clad)
- Seals
- Selector Interlock Systems
- Sensors
- Servos
- Shift Interlock Systems (Selector And Key Interlock Systems)
- Side Covers
- Slip Yokes
- Solenoids
- Speed Sensors (Electronic Wheel And Vehicle)
- Speedometer- Driven Gear Housing
- Speedometer/Odometer Drives (Mechanical)
- Speedometer/Odometer Heads (Mechanical)
- Speedometers/Odometers (Electronic)
- Switches
- Tone Wheels
- Toothed Rings (Tone Wheel)
- Torque Converters
- Transaxle Mounts
- Transducers (Transmission)
- Transfer Case Assemblies
- Transfer Case Fluid
- Transmission Coolers
- Transmission Mounts
- Transmission Pans
- Transmission Range Indicators (PRNDL)
- Tubes
- Universal Joints (CARDAN Or Cross Type)
- Vacuum Controls
- Vacuum Hoses
- Vacuum Motors
- Vacuum-Operated Switches
- Vehicle Speed Sensors
- Vents
- Vibration Dampers
- Wheel Attachment Hardware
- Wheel Speed Sensors
- Wiring Harnesses And Connectors
- Yokes And Slip Yokes
- Reason Code Explanation
- Automotive Terminology & Definitions
- Trouble Shooting - Clutches - General Information
- Electrical
- Map - Electrical Systems
- Electrical Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Actuator Motors (Electric)
- Actuator Motors (Vacuum)
- Air Bags
- Alternators And Generators
- Amplifiers
- Antennas
- Batteries
- Battery Cables, Wires And Connectors
- Battery Cables
- Battery Trays And Hold Down Hardware
- Battery Wires
- Belts
- Bulb Sockets
- Bulbs, Sealed Beams And LEDS
- Cd Players
- Cigarette Lighter Assemblies
- Circuit Breakers
- Clutch Switches
- Connectors
- Control Modules
- Cruise Control Brake Switches
- Cruise Control Cables
- Cruise Control Clutch Switches
- Cruise Control Linkages And Cables
- Cruise Control Reservoirs
- Cruise Control Tubes
- Cruise Control Vacuum Dump Release Valves
- Cruise Control Vacuum Hoses, Tubes And
- Cruise Control Vehicle Speed Sensors
- Defoggers
- Defrosters
- Delays
- Dimmers
- Electric Heaters
- Equalizers
- Fuse Blocks
- Fuse Boxes And Blocks
- Fuses, Fusible Links And Circuit Breakers
- Fusible Links
- Gauges
- Generators
- Ground Cables And Straps
- Ground Straps
- Headlight Adjusters
- Heating Elements (Defrosters, Defoggers, Electric Heaters And Seats)
- Horns And Sirens
- Ignition Switches
- Indicator Lights
- Keyless Entry Keypads And Transmitters
- Keyless Entry Transmitters
- LEDS
- Lenses
- Microphones
- Mirrors (ELECTROCHROMATIC And Heated)
- Motors
- Neutral Safety Switches
- Odometers, Speedometers And Tachometers (Cable Driven)
- Odometers
- Power Distribution Center
- Pulleys
- Receivers, Amplifiers, Equalizers And Sub-Woofer Volume Controls
- Relay Boxes
- Relays
- Sealed Beams
- Seat Heaters
- Security Alarm Sensors
- Sirens
- Solenoids
- Speakers And Microphones
- Speedometer And Tachometer Linkages And Cables
- Speedometer Cables
- Speedometers
- Starters
- Sub-Woofer Volume Control
- Switches
- Tachometer Cables
- Tachometers
- Tape Players And Cd Players
- TENSIONERS
- Timers
- Transceivers
- Transducers
- Vacuum Accumulators (Reservoirs)
- Voltage Regulators
- Washer Fluid Level Senders
- Washer Pumps
- Wiper Arms And Blades
- Wiper Blades
- Wiper Hoses And Nozzles
- Wiper Linkages
- Wiper Nozzles
- Wiper Pump Reservoirs
- Wiring Harnesses And Connectors
- Battery, Starting & Charging System CHECKSHEET
- Reason Code Explanation
- Automotive Terminology & Definitions
- Electrical Systems
- Using lemon2025'S System Wiring Diagrams
- Map - Electrical Systems
- Engine
- Engine Overhaul Procedures - General Information
- * Please Read This First *
- Description
- Engine Identification
- Inspection Procedures
- Cleaning Procedures
- Component Cleaning
- Cylinder Head Replacement
- Cylinder Head Overhaul
- Pistons, Connecting Rods & Bearings
- Crankshaft & Main Bearings
- Camshaft
- Timing Chains & Belts
- Timing Gears
- Oil Pump
- Break-In Procedure
- General Cooling System Service - General Information
- Engine Overhaul Procedures - General Information
- Engine Performance
- Electrostatic Discharge Warning - General Information
- Emission Control Visual Inspection Procedures
- Emission Control Labels
- Ford Calibration Labels
- Emission Control Visual Inspection
- Notes
- Positive Crankcase Ventilation (PCV)
- Thermostatic Air Cleaner (TAC)
- Fuel Evaporative System (EVAP)
- Catalytic Converters
- Fill Pipe RESTRICTOR (Fr)
- Exhaust Gas RECIRCULATION (EGR) System
- Spark Controls (SPK)
- Air Injection System (AIS)
- Oxygen Sensor (O2)
- Computerized Engine Controls (CEC)
- Early Fuel Evaporation (EFE)
- Emission Maintenance Reminder Light (EMR)
- Malfunction Indicator Light (Mil)
- Engine Performance Diagnostic Routine Outline - General Information
- Engine Performance Safety Precautions
- Map - Engine Performance & Maintenance
- Engine Performance And Maintenance (Including Exhaust Systems)
- Engine Performance & Maintenance CHECKSHEET
- Engine Performance And Maintenance
- Notes
- Accelerator Pedal Position Sensor
- Accessory Belts
- Accessory Pulleys
- Air Conditioning Cycling Switches
- Air Conditioning Pressure Sensors
- Air Ducts And Tubes
- Air Filter Elements
- Air Filter Gaskets
- Air Filter Housings And Gaskets
- Air Fuel Ratio Sensors
- Air Injection Control Solenoids
- Air Plenums
- Air Pump Belts
- Air Pumps (Electric Driven)
- Air Tubes
- Aspirator, Check And DECEL Valves
- Baffles
- Ballast Primary Supply Resistor Wires
- Ballast Resistors And Primary Supply Resistors
- Barometric Pressure Sensors
- Batteries
- Battery Cables, Wires And Connectors
- Battery Connectors
- Battery Trays And Hold Down Hardware
- Battery Wires
- Belt Idler Assemblies (Accessory And Cam Belts)
- Belt TENSIONERS (Accessory And Cam Belt)
- Belt-Driven Air Pumps
- Boost Control Mechanism
- Camshaft Position Sensors
- Carburetors And Chokes
- Casting Core Plugs And Expansion Plugs
- Charge Air Coolers ""INTERCOOLERS"" (CAC)
- Check Valves
- Chemical Engine DECARBONIZATION
- Chokes
- Clutch Pedal Position Switches
- Cold Start Injectors
- Combustion Chamber Cleaning
- Connectors
- Coolant Recovery Tanks
- Coolant
- Cooling Fan Motor Modules
- Cooling Fan Motor Relays And Modules
- Cooling Fan Motor Resistors
- Cooling Fan Motor Sensors And Switches
- Cooling Fan Motor Switches
- Cooling Fan Motors
- Crankshaft Position Sensors
- Cylinder Deactivation Solenoid
- Cylinder Head Assemblies
- DECEL Valves
- Deflectors
- Dip Stick Tubes
- Dip Sticks And Tubes
- Distributor Advances And Retarders (Mechanical And Vacuum)
- Distributor Boots And Shields
- Distributor Caps
- Distributor Retarders (Mechanical And Vacuum)
- Distributor Rotors
- Distributor Shields
- Distributors
- Early Fuel Evaporation Valves (Heat Riser Assemblies)
- EGR Coolers
- EGR Exhaust Manifold Passages
- EGR Intake And Exhaust Manifold Passages
- EGR Plates And Coolers
- Electronic Spark Control Modules
- Electronic Transmission Control Devices
- Electronic Transmission Feedback Devices
- Engine Coolant Temperature Sensors
- Engine Cooling Systems
- Engine Covers (Oil Pan, Valve Cover, Timing Cover)
- Engine DECARBONIZATION
- Engine Oil Canisters
- Engine Oil Coolers (External)
- Engine Oil Drain Plugs And Gaskets
- Engine Oil Filters And Canisters
- Engine Oil Gaskets
- Engine Oil Pressure Gauges (Mechanical)
- Engine Oil
- Evaporative Emissions (EVAP) Canister Filters
- Evaporative Emissions (EVAP) Canister Purge Devices
- Evaporative Emissions (EVAP) Canisters
- Evaporative Emissions (EVAP) Feedback Devices
- Exhaust Gas RECIRCULATION Devices
- Exhaust Gas RECIRCULATION Feedback Devices
- Expansion Plugs
- Fan Control Sensor
- Fuel Accumulators And Dampers
- Fuel And Cold Start Injectors
- Fuel Caps
- Fuel Dampers
- Fuel Delivery Check Valves
- Fuel Distributors (BOSCH Cis)
- Fuel Filler Necks And RESTRICTORS
- Fuel Filters
- Fuel Injector Cleaning
- Fuel Injectors
- Fuel Level Senders
- Fuel Pressure Regulators
- Fuel Pumps (In-Tank, External, Electrical Or Mechanical)
- Fuel Rails
- Fuel RESTRICTORS
- Fuel System Cleaning Service
- Fuel Tanks
- Fuel
- Gaskets
- Grommets (Valve Cover)
- Harmonic Dampers
- Heater Control Valves
- Heater Cores
- Hose Clamps
- Hose Connectors
- Hose Couplers
- Hoses And Tube Couplers, Connectors And Clamps
- Hoses And Tubes (Fuel Lines, Radiator, Vacuum, By-Pass, Heater, Recovery Tank And Oil Coolers)
- Housings
- Idle Air Controls
- Idle Speed Control Actuators
- Ignition Boots
- Ignition Coil Towers
- Ignition Coils
- Ignition Control Modules (ICM)
- Ignition Switches
- Ignition Terminals
- Ignition Wires (Secondary)
- Inertia Fuel Shut-Off Switches
- Intake Air Temperature Sensors
- Intake Cleaning
- Intake Manifolds
- In-Tank Fuel Strainers
- INTERCOOLERS
- Knock Sensors
- Liquid Vapor Separators
- Long Block Assemblies
- Manifold Absolute Pressure (Map) Sensors
- Mass Air Flow (MAF) Sensors
- Metal Air Manifolds And Pipes
- Metal Air Pipes
- Mix Control Solenoids
- Motor Mounts
- O2 Sensors
- Oil Pans
- Oil Pressure Sending Units
- Oil Pump Pick-Up Screens
- Oil Pumps
- O-Rings, Gaskets, Seals And Spring Locks
- Park Neutral Position Switches
- PCV Breather Elements
- PCV Orifices
- PCV Valves
- Pick-Up Assemblies (Includes Magnetic, Hall Effect And Optical)
- Power Steering Pressure Sensors
- Powertrain Control Modules (Pcm) And Prom
- Powertrain Control Prom
- Pressurized Expansion Tank Caps
- Radiator / Cooling Fan Blades
- Radiator / Cooling Fan Clutches
- Radiator Caps And Pressurized Expansion Tank Caps
- Radiators
- Roll Over Valves
- Sealing Compounds
- Seals
- Secondary Air Injection System Management Devices
- Sensors
- Short Block Assemblies
- Shrouds, Baffles And Deflectors
- Spark Plugs
- Spring Locks
- Super Chargers
- Switches
- Thermal Vacuum Valves
- Thermostatic Air Door Assemblies
- Thermostats And Housings
- Throttle Bodies
- Throttle Body Cleaning
- Throttle Cables
- Throttle Linkages And Cables
- Throttle Position Sensors
- Throttle Position Switches
- Timing Belt Sprockets
- Timing Belts
- Timing Covers
- Torque Struts
- Transmission Range Switches
- Tube Clamps
- Tube Connectors
- Tube Couplers
- Tubes
- Turbo Chargers
- Vacuum Connections
- Vacuum Hoses, Tubes And Connections (Non-Metallic)
- Vacuum Regulator Solenoids
- Vacuum Tubes
- Valve Covers
- Vehicle Speed Senors
- Volume Air Flow Sensors
- Waste Gate And Boost Control Mechanisms
- Waste Gate Control Solenoids
- Water Pumps (Electric)
- Water Pumps (Non-Electric)
- Wiring Harnesses And Connectors
- Reason Code Explanation
- Automotive Terminology & Definitions
- Parasitic Load Explanation & Test Procedures - General Information
- State Emission Standards - Diesel
- State Emission Standards - Gas
- ALASKA
- ARIZONA
- CALIFORNIA
- Colorado
- CONNECTICUT
- DELAWARE
- District Of COLUMBIA
- GEORGIA
- IDAHO
- ILLINOIS
- INDIANA
- KENTUCKY
- MARYLAND
- MASSACHUSETTS
- MISSOURI
- NEVADA
- New Jersey
- New MEXICO
- New YORK
- North CAROLINA
- OHIO
- OREGON
- PENNSYLVANIA
- RHODE Island
- TENNESSEE
- TEXAS
- UTAH
- VIRGINIA
- WASHINGTON
- WISCONSIN
- U. S. EPA ASM2525 & ASM5015 Start-Up Emission Standards
- U. S. EPA Revised Final ASM Emission Standards (ASM5015 & ASM2525)
- U.S. EPA Im240 Emission Standards
- Waveforms - Injector Pattern Tutorial - General Information
- * Please Read This First *
- Purpose Of This Article
- Is A Lab Scope Necessary?
- The Two Types Of Injector Drivers
- The Two Ways Injector Circuits Are Wired
- Interpreting Injector Waveforms
- Current Waveform Samples
- Notes
- Example #1 - Voltage Controlled Driver
- Example #2 - Voltage Controlled Driver
- Example #3 - Voltage Controlled Driver
- Example #4 - Current Controlled Driver
- Example #5 - Current Controlled Driver
- Example #6 - Current Controlled Driver
- Example #7 - Current Controlled Driver
- Example #8 - Current Controlled Driver
- Voltage Waveform Samples
- Notes
- Example #1 - Voltage Controlled Driver
- Example #2 - Voltage Controlled Driver
- Example #3 - Voltage Controlled Driver
- Example #4 - Current Controlled Driver
- Example #5 - Current Controlled Driver
- Example #6 - Current Controlled Driver
- Example #7 - Current Controlled Driver
- Example #8 - Current Controlled Driver
- Map - Exhaust Systems
- Exhaust Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Catalytic Converters
- Exhaust And Tail Pipes
- Exhaust Connections
- Hangers
- Heat Risers (Mechanical EFE Devices)
- Heat Shields
- Manifolds (Cast And Tube Type)
- Mechanical EFE Devices
- Muffler Valve
- Mufflers And Resonators
- Reason Code Explanation
- Exhaust Systems
- Heating, Ventilation & A/C (HVAC)
- Map - Heating, Ventilation, & Air Conditioning
- Heating, Ventilation & Air Conditioning Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Accumulators
- Actuators (Electrical)
- Actuators (Vacuum)
- Air Conditioning Fittings
- Air Conditioning Hoses
- Air Conditioning Metal Lines
- Air Control Doors
- Air Dams (External)
- Air Distribution System
- Belts
- Blend Doors
- Blower Fans (Blower Wheel Or Squirrel Cage)
- Blower Motors
- Blower Resistors
- Blower Switches
- Cabin Air Filters
- Circuit Breakers
- Compressor Clutch Assemblies
- Compressors
- Condenser Air Seals
- Condenser Fan Motors
- Condensers
- Connectors
- Control Cables
- Control Heads (Function Selectors)
- Control Linkages
- Control Modules
- Coolant
- Cooling Fan Blades
- Cooling Fan Clutches
- Cooling Fan Motors
- Evaporator Drain Tubes
- Evaporator Filters
- Evaporator Pressure Regulators (EPRS)
- Evaporators
- Expansion Valves
- Function Selectors
- Fuses, Fusible Links And Circuit Breakers
- Fusible Links
- Gaskets
- Heater Cases
- Heater Control Valves
- Heater Cores
- Heater Hoses
- High Pressure Relief Valves (HPRV)
- Idlers
- In-Line Filters
- Metal Fittings
- Metal Lines
- Mix And Air Control Doors (Blend Doors)
- ORIFACE Tubes
- O-Rings
- Pilot-Operated Absolutes (POAS)
- Plenums
- Pressure Control Valves
- Pressure Sensors
- Pulleys
- Radiators
- Receiver-DRIERS
- Refrigerant Oil
- Refrigerant
- Relays
- Seals
- Service Ports
- Spring Lock Couplings
- Suction Throttling Valves (STVS)
- Switches (Electrical)
- TENSIONERS
- Thermistors And Pressure Sensors
- Thermostats And Housings
- Vacuum Hoses And Tubes
- Vacuum Reservoirs
- Vacuum Tubes
- Valves In Receiver (VIRS)
- Water Pumps (Electric Auxiliary)
- Wiring Harnesses And Connectors
- Heating, Ventilation & Air Conditioning System CHECKSHEET
- Reason Code Explanation
- Automotive Terminology & Definitions
- Heating, Ventilation & Air Conditioning Systems
- Map - Heating, Ventilation, & Air Conditioning
- Identification
- Metric Conversions
- OEM General Information
- How To Use The Engine Performance Section
- Maintenance Reminder Light (Reset Procedures)
- A/C Filter Service Reminder
- Engine Oil Replacement Reminder
- Notes
- Engine Oil Replacement Reminder Reset - Procedure 01
- Engine Oil Replacement Reminder Reset - Procedure 02
- Engine Oil Replacement Reminder Reset - Procedure 03
- Engine Oil Replacement Reminder Reset - Procedure 04
- Engine Oil Replacement Reminder Reset - Procedure 05
- Engine Oil Replacement Reminder Reset - Procedure 06
- Engine Oil Replacement Reminder Reset - Procedure 07
- Engine Oil Replacement Reminder Reset - Procedure 08
- Engine Oil Replacement Reminder Reset - Procedure 09
- Engine Oil Replacement Reminder Reset - Procedure 10
- Engine Oil Replacement Reminder Reset - Procedure 11
- Engine Oil Replacement Reminder Reset - Procedure 12
- Engine Oil Replacement Reminder Reset - Procedure 13
- Engine Oil Replacement Reminder Reset - Procedure 14
- Engine Oil Replacement Reminder Reset - Procedure 15
- Engine Oil Replacement Reminder Reset - Procedure 16
- Engine Oil Replacement Reminder Reset - Procedure 17
- Engine Oil Replacement Reminder Reset - Procedure 18
- Engine Oil Replacement Reminder Reset - Procedure 19
- Engine Oil Replacement Reminder Reset - Procedure 20
- Engine Oil Replacement Reminder Reset - Procedure 21
- Engine Oil Replacement Reminder Reset - Procedure 22
- Engine Oil Replacement Reminder Reset - Procedure 23
- Engine Oil Replacement Reminder Reset - Procedure 24
- Engine Oil Replacement Reminder Reset - Procedure 25
- Engine Oil Replacement Reminder Reset - Procedure 26
- Engine Oil Replacement Reminder Reset - Procedure 27
- Engine Oil Replacement Reminder Reset - Procedure 28
- Maintenance Service Reminder (Overhead Warning Lights)
- Maintenance Service Reminder (Sri)
- Maintenance Service Reminder (VMM)
- Tire Pressure Monitor System Reminder
- Notes
- Tire Pressure Sensor Types
- TPMS Reminder Reset - Procedure 01
- TPMS Reminder Reset - Procedure 02
- TPMS Reminder Reset - Procedure 03
- TPMS Reminder Reset - Procedure 04
- TPMS Reminder Reset - Procedure 05
- TPMS Reminder Reset - Procedure 07
- TPMS Reminder Reset - Procedure 08
- TPMS Reminder Reset - Procedure 09
- TPMS Reminder Reset - Procedure 10
- Steering
- Map - Steering, Suspension, Wheel Alignment, Wheels & Tires
- Steering & Suspension Systems
- Wheel And Tire
- Steering & Suspension CHECKSHEET
- Wheels & Tires CHECKSHEET
- Steering And Suspension, Wheel Alignment, Wheels And Tires
- Notes
- Active Handling
- Active Suspension Control Modules
- Active Variable Ratio Steering
- Active Yaw Control
- Adaptive Cruise Control
- Advance TRAC
- Air Bags
- Air Ride Control Modules
- Air Ride Suspension Torsion Springs (Counter Balancing)
- Air Ride Suspension
- Air Ride Tubes
- Air Shocks And Air Struts
- Air Spring Valves
- Air Springs
- Air Suspension Control Valves
- Air Suspension DRIERS
- Axle Acceleration Sensor
- Ball Joints
- Body Acceleration Sensor
- Bushings
- Center Links
- Compressors
- Continuous Damping Control
- Control Arm Shafts
- Control Arms
- Control Modules
- Distance Regulation Control Module
- Distance Regulation Sensor
- Drag Links
- Dynamic Stability Control
- Dynamic Stability Traction Control
- Electronic Ride Control Shocks And Struts
- Electronic Stability Control
- Electronic Suspension System
- Flex Couplers
- Gaskets
- Height Sensors
- Hydraulic Hoses
- Hydraulic Power Steering Pumps
- Hydraulic Suspension Hoses
- Hydraulic Suspension Pumps
- Idler Arms
- Intermediate Shaft U-Joints
- King Pins
- Modules
- Pitman Arms
- Power Steering Belts
- Power Steering Coolers
- Power Steering Fluid
- Power Steering Hoses
- Power Steering Lines (Steel)
- Power Steering Pumps - Electric
- Power Steering Pumps
- Radar Sensor
- Radius Arms
- Relay Rods
- Relays
- Sensors
- Shock Absorbers, Strut Cartridges And Strut Assemblies
- Spindles
- Springs, Coil, Leaf And Torsion Bars
- STABILITRAC
- Stability Management System
- Steering Angle Sensor
- Steering Arms
- Steering Couplers
- Steering Dampers
- Steering Gears (Except Rack And Pinion)
- Steering Gears, Rack And Pinion
- Steering Knuckles
- Strike Out Bumpers
- Strut Bearing Plate Assemblies
- Strut Rods
- Suspension Pumps (Hydraulic)
- Sway Bar Links
- Sway Bar Mounting Bushings
- Sway Bars
- Switches
- Tie Rod Ends (Inner And Outer)
- Tire Pressure Monitoring System
- Tire Pressure Sensors
- Tires
- Torque Sensor
- Torsion Springs
- Track Bar Bushings
- Track Bars
- Trailing Arm Bushings
- Trailing Arms
- Valve Stems
- Vehicle Dynamics Control
- Vehicle Speed Sensor
- Vehicle Stability Assist
- Vehicle Stability/Skid Control
- Warning Lamps
- Wheel Alignment
- Wheel Attachment Hardware
- Wheel Bearings, Races And Seals
- Wheels (Rims)
- Wiring Harnesses And Connectors
- Reason Code Explanation
- Automotive Terminology & Definitions
- Wheel Alignment Theory & Operation - General Information
- Map - Steering, Suspension, Wheel Alignment, Wheels & Tires
- Trouble Shooting - Manual Transmission - General Information
- Heating, Ventilation & A/C (HVAC)
- A/C Compressor Oil Checking
- Isolating Compressor
- Refrigerant Oil
- Servicing Precautions
- Oil Checking
- General Servicing
- A/C Compressor Overhaul
- Removal & Installation
- Notes
- Ford FS-6 6-CYL Clutch Assembly
- Ford FS-6 6-CYL Shaft Seal
- Ford FX-15 10-CYL Clutch Assembly
- Ford FX-15 10-CYL Shaft Seal
- NIPPONDENSO 6E-171 & 6P-148 Clutch Assembly
- NIPPONDENSO 6E-171 & 6P-148 Shaft Seal
- NIPPONDENSO 10P13 Clutch Assembly
- NIPPONDENSO 10P13 Shaft Seal
- NIPPONDENSO 10P15, 10P15F Clutch Assembly
- NIPPONDENSO 10P15A Clutch Assembly
- NIPPONDENSO 10P15, 10P15F Shaft Seal
- NIPPONDENSO 10P15A Shaft Seal
- NIPPONDENSO 10PA17 & 10PA17A Clutch Assembly
- NIPPONDENSO 10PA17 & 10PA17A Shaft Seal
- Removal & Installation
- A/C System General Servicing
- Using R-12 Refrigerant - Safety Precautions
- Using Individual R-12 Cans
- Multi-Can Dispensing Valves
- Can Tap Installation
- Sight Glass Indicators
- 1990 Passenger Car Service Valve Location
- 1991 Passenger Car Service Valve Locations
- 1990 Truck & Van Service Valve Location Table
- 1991 Truck & Van Service Valve Locations Table
- Stem-Type Valve Operation
- SCHRADER-Type Valve Operation
- Special Valve Connectors
- Manifold Gauge Set
- Connecting Gauge Set
- Purging Test Hoses
- Stabilizing A/C System
- Pressure Gauge Indications
- Pressure Gauge Readings
- Excessive Moisture Gauge Readings
- Defective Thermostatic Switch Gauge Readings
- MISADJUSTED Thermostatic Switch Gauge Readings
- Defective Clutch Cycling Switch Pressure Gauge Readings
- Low R-12 Charge Gauge Readings
- Very Low R-12 Charge Gauge Readings
- Orifice Tube Plugged Gauge Readings
- Expansion Or "H" Valve Stuck Closed
- Expansion Or "H" Valve Stuck Open Gauge Readings
- Compressor Malfunction Gauge Readings
- Condenser Malfunction Or R-12 Overcharge Gauge Readings
- Orifice Tube Replacement - AEROSTAR, Bronco, Explorer
- Spring Lock Coupling Clamp Table
- Orifice Tube R & I - E & F Series, Ranger
- Orifice Tube R & I - Crown VIC/Gran Marquis/TWN Car
- Orifice Tube Replacement - Escort, Probe, Tracer
- Orifice Tube Replacement - All Other
- Refrigerant Recovery
- Discharging A/C System
- Flushing A/C System
- Evacuating A/C System
- Charging A/C System
- Leak Testing
- A/C System Precautions
- Before Opening The System
- Discharging A/C System
- Disconnecting Lines & Fittings
- Component Replacement
- Using R-12 Refrigerant - Safety Precautions
- Using Individual R-12 Cans
- Multi-Can Dispensing Valves
- Can Tap Installation Flat Type Seal Cans
- Screw Type Seal Cans
- Connecting Lines & Fittings
- Placing System In Operation
- Compressor Removal Information - Isolation Method
- Compressor Removal Information-Discharge Method
- A/C System Specifications
- A/C Compressor Overhaul
- HVAC Control Systems
- A/C-Heater System - Automatic
- A/C-Heater System - Manual
- A/C-Heater System Trouble Shooting - Manual
- A/C Compressor Oil Checking
- Maintenance
- Procedures
- Engine - Interference Verification Check For OHC Engine
- Maintenance Information
- Model Identification
- Maintenance Service Information
- Service Point Locations
- Service Labor Times
- Wheel & Tire Specifications
- Battery Specifications
- Cautions & Warnings
- Supplemental Restraint System (Air Bag System)
- Air Conditioning Servicing
- Anti-Lock Brake System
- Replacing Blown Fuses
- Battery Warning
- Brake Pad Wear Indicator
- Catalytic Converter
- Electrostatic Discharge Sensitive (ESD) Parts
- Fuel Pump Shutoff Switch
- Fuel System Service
- Halogen Bulbs
- Radiator Cap
- Radiator Fan
- Supercharged Engines
- Warranty Information
- Fuses & Circuit Breakers
- Maintenance Reminder Light (Reset Procedures)
- A/C Filter Service Reminder
- Engine Oil Replacement Reminder
- Notes
- Engine Oil Replacement Reminder Reset - Procedure 01
- Engine Oil Replacement Reminder Reset - Procedure 02
- Engine Oil Replacement Reminder Reset - Procedure 03
- Engine Oil Replacement Reminder Reset - Procedure 04
- Engine Oil Replacement Reminder Reset - Procedure 05
- Engine Oil Replacement Reminder Reset - Procedure 06
- Engine Oil Replacement Reminder Reset - Procedure 07
- Engine Oil Replacement Reminder Reset - Procedure 08
- Engine Oil Replacement Reminder Reset - Procedure 09
- Engine Oil Replacement Reminder Reset - Procedure 10
- Engine Oil Replacement Reminder Reset - Procedure 11
- Engine Oil Replacement Reminder Reset - Procedure 12
- Engine Oil Replacement Reminder Reset - Procedure 13
- Engine Oil Replacement Reminder Reset - Procedure 14
- Engine Oil Replacement Reminder Reset - Procedure 15
- Engine Oil Replacement Reminder Reset - Procedure 16
- Engine Oil Replacement Reminder Reset - Procedure 17
- Engine Oil Replacement Reminder Reset - Procedure 18
- Engine Oil Replacement Reminder Reset - Procedure 19
- Engine Oil Replacement Reminder Reset - Procedure 20
- Engine Oil Replacement Reminder Reset - Procedure 21
- Engine Oil Replacement Reminder Reset - Procedure 22
- Engine Oil Replacement Reminder Reset - Procedure 23
- Engine Oil Replacement Reminder Reset - Procedure 24
- Engine Oil Replacement Reminder Reset - Procedure 25
- Engine Oil Replacement Reminder Reset - Procedure 26
- Engine Oil Replacement Reminder Reset - Procedure 27
- Engine Oil Replacement Reminder Reset - Procedure 28
- Maintenance Service Reminder (Overhead Warning Lights)
- Maintenance Service Reminder (Sri)
- Maintenance Service Reminder (VMM)
- Tire Pressure Monitor System Reminder
- Notes
- Tire Pressure Sensor Types
- TPMS Reminder Reset - Procedure 01
- TPMS Reminder Reset - Procedure 02
- TPMS Reminder Reset - Procedure 03
- TPMS Reminder Reset - Procedure 04
- TPMS Reminder Reset - Procedure 05
- TPMS Reminder Reset - Procedure 07
- TPMS Reminder Reset - Procedure 08
- TPMS Reminder Reset - Procedure 09
- TPMS Reminder Reset - Procedure 10
- Service Indicator & Warning Lights
- Service Indicator & Warning Lights
- Notes
- Check Engine Warning Light
- Engine Coolant Temperature Gauge
- Check Gauge Warning Light
- Engine Oil Pressure Gauge
- Engine Oil Pressure Warning Light
- Brake Warning Light
- Charging System Warning Light
- Vehicle Maintenance Monitor (If Equipped)
- Anti-Lock Brake System Light (If Equipped)
- Safety Belt Light
- Turbo Boost Gauge
- Service Interval Reminder
- Service Indicator & Warning Lights
- Procedures
- Restraints
- Steering
- Manual Steering
- Power Steering
- Steering Column
- Description
- Trouble Shooting
- Removal & Installation
- Overhaul
- Torque Specifications
- Steering Gear - Variable
- Description & Operation
- Component Location
- Lubrication
- Adjustments
- Trouble Shooting
- Testing
- Quick Tests
- Quick Test A0: Check Connections
- Quick Test A1: Control Module Check
- Quick Test A2: Actuator Output Circuit Check
- Quick Test A3: Steering Wheel Sensor Check
- Quick Test A4: Vehicle Speed Sensor Check
- Quick Test A4.1: Vehicle Speed Sensor Check (Cont.)
- Quick Test A5: Service Power Steering
- Quick Test B1: "Code 6" Activated During Actuator Check
- Quick Test B2: Actuator Valve Resistance
- Quick Test B3: Wiring Continuity Check
- Quick Test B4: EVO Actuator Valve Resistance
- Quick Test B5: Check Wiring Harness Shorts
- Quick Test B5.1: Check Wiring Harness Shorts (Cont.)
- Quick Test B5.2: Check Wiring Harness Shorts (Cont.)
- Quick Test B6: Check Harness Short To B+
- Quick Test B7: Short Across Circuits No. 330 & No. 353
- Quick Test C1: Steering Wheel Rotation Sensor Connector Check
- Quick Test C2: Steering Wheel Rotation Sensor Check
- Quick Test C3: Steering Wheel Rotation Sensor Signal Check
- Quick Test C4: Steering Wheel Rotation Sensor Wire Check
- Quick Test C5: Check Shorts Across CKTS No. 834 And No. 835
- Quick Test C6: Testing Steering Wheel Rotation Sensor Power
- Quick Test C7: Testing Steering Wheel Rotation Sens PWR CKT
- Quick Test D1: Vehicle Speed Sensor Connector Check
- Quick Test D2: Speed Sensor Check
- Quick Test D3: Testing Speed Sensor Ground Circuit
- Quick Test D4: Testing Speed Sensor
- Quick Test D4.1: Check Speed Control
- Quick Test D4.2: Check Wiring
- Quick Test D4.3: Verify Speed Signal
- Quick Test D4.4: Check Speedometer Fuse
- Quick Test D4.5: Instrument Cluster Resistance & Voltage
- Quick Test D4.6: Cluster Circuit Check
- Quick Test E1: Diagnostic Light Check
- Quick Test E2: Control Module Retest
- Quick Test F1: EVO Control Module Check
- Quick Test F2: Control Module Power Feed Check
- Removal & Installation
- Overhaul
- Wheel Alignment
- Torque Specifications
- Wiring Diagrams
- Suspension
- Electronic Suspension
- Suspension - Automatic Ride Control
- Description
- Operation
- Automatic Ride Control Component Location
- Testing & Diagnosis
- Test Equipment
- Arc Trouble Codes
- Test A1: Entering Diagnostics
- Test A2: Checking Steering Sensor
- Test A3: Checking Speed Sensor
- Test A4: Prepare For Remaining Tests
- Test A5: Checking Ride Control Switch
- Test A6: Checking Brake Sensor
- Test A7: Checking Acceleration Signal
- Test A8: Checking Dimming Function
- Test B1: Checking Actuator Wiring
- Test B2: Checking For Signal Return Continuity
- Test B3: Energize Hard Relay
- Test B4: Do Position Switches Open?
- Test B5: Energize Soft Relay
- Test B6: Do Position Switches Close?
- Test B7: Reconnect Module
- Test B8: Checking Actuator Wiring
- Test B9: Preparation For Actuator Rotation Test
- Test B10: Do Actuators Return To Hard (Firm) Position?
- Test B11: Does Actuator Rotate?
- Test B12: Actuator Resistance
- Test B13: Actuator Shorted Internally
- Test B14: Signal Return Circuit Continuity
- Test B15: Disconnect Module Connector
- Test B16: Position Sense Circuit Continuity
- Test B17: Relays Power Circuit
- Test B18: Hard Relay Power Feed
- Test B19: Relays-To-Actuator Circuit Continuity
- Test B20: Crossed Relay Circuits
- Test B20A: Perform Quick Test A1
- Test B21: Disconnect Module Connector
- Test B22: Relay Control Circuit Short
- Test B23: Disconnect Problem Relay
- Test B24: Retest Relay Control Circuit
- Test B25: Disconnect Module Connector
- Test B26: Energize Hard Relay
- Test B27: Do Position Switches Open?
- Test B28: Energize Soft Relay
- Test B29: Do Position Switches Close?
- Test B30: Disconnect Problem Relay
- Test B31: Coil Power Feed
- Test B32: Relay Control Circuit
- Test B33: Attach Problem Actuator
- Test B34: Energize Hard Relay
- Test B35: Does Position Switch Open?
- Test B36: Energize Soft Relay
- Test B37: Does Position Switch Close?
- Test C1: Observe Key On Sequence
- Test C2: Disconnect Module Connector
- Test C3: Firm Ride Light Operation
- Test C4: Module Power Circuit
- Test C5: Firm Ride Light Circuit
- Test C6: Check Firm Ride Light Dimming
- Test C7: Disconnect Module Connector
- Test C8: Check Headlight Wiring
- Test C9: Disconnect Module Connector
- Test C10: Firm Ride Light Circuit Short
- Test D1: Enter Diagnostics Again
- Test D2: Testing Signal Return Wire Continuity
- Test D3: Disconnect Module Connector
- Test D4: Check Diagnostic Circuit For Short To Ground
- Test D5: Check Diagnostic Circuit
- Test D6: Check Switch Positions
- Test D7: Disconnect Module Connector
- Test D8: Check Brake Circuit For Short To Ground
- Test D9: Brake Circuit Always Closed?
- Test D10: Ride Control Switch Circuit Closed
- Test D11: Acceleration Signal Always Closed?
- Test D12: Acceleration Circuit Shorted
- Test D13: Disconnect Module Connector
- Test D14: Checking Steering Sensor Wires
- Test D15: Testing Steering Sensor Signals
- Test D16: Disconnect Steering Sensor
- Test D17: Steering Sensor Power
- Test D18: Steering Sensor Circuit
- Test D19: Disconnect Module Connector
- Test D20: Speed Sensor Signal
- Test D21: Speed Sensor Ground
- Test D22: Speed Sensor
- Test D23: Disconnect Module Connector
- Test D24: Check Firm Signal
- Test D25: Ride Control Switch
- Test D26: Ride Control Switch Power Feed
- Test D27: Disconnect Module Connector
- Test D28: Does Brake Switch Close?
- Test D29: Disconnect Brake Pressure Switch
- Test D30: Brake Switch Ground
- Test D31: Disconnect Module Connector
- Test D32: Check Module Connector
- Test D33: Check EEC-IV Connector
- Test D34: Acceleration Circuit Continuity
- Test E1: Check Connector Wires
- Test E2: Check EVO Steering
- Test E3: Check EVO Wiring Continuity
- Test E4: Check EVO Valve On Steering Pump
- Test E5: Check Wire Harness Ground Short
- Test E6: Check EVO Wire Harness Short
- Removal & Installation
- Torque Specifications
- Wiring Diagram
- Suspension - Automatic Ride Control
- Front Suspension
- Suspension - Front
- Description
- Adjustments & Inspection
- Lower Ball Joint Checking
- Removal & Installation
- Torque Specifications
- Suspension - Front
- Rear Suspension
- Wheel Alignment
- Electronic Suspension
- Transmission
- Automatic Trans
- Overhaul - AOD
- Application
- Identification
- Description
- Lubrication & Adjustments
- On-Vehicle Service
- Trouble Shooting
- Notes
- Symptoms
- Slow Initial Engagement
- Rough Initial Engagement
- Delayed Or No Forward Engagement, Reverse Okay
- Delayed Or No Reverse Engagement, Forward Okay
- Delayed Or No Reverse Engagement And/Or No Engine Braking In Manual Low
- No Engine Braking In Manual 2nd
- Forward Engagement Slips, Shudders Or Chatters On Engagement
- Reverse Engagement Slips, Shudders Or Chatters On Engagement
- Starts Up In 2nd Or 3rd
- Incorrect Shift Points, Harsh Or No Upshift
- Early, Mushy, Soft Or Slipping Upshift
- Erratic Shifts
- No Forced Downshift
- Transmission Overheats
- Transmission Clunk Or Squawk During Upshift
- Transmission Noisy (Valve Resonance)
- Harsh Initial Engagement Into Drive
- Delayed Reverse Engagement
- Slips & Chatters When Hot, Delayed Drive & Reverse
- No Forward After A Stop
- No Reverse
- No 2nd, 4th Or Reverse
- No 2nd Or 4th, Reverse Okay
- No 3-4 Upshift
- No 3rd Or 4th
- 2-3 Squawk
- Clacking Noise Or Squawk, Intermediate Buck On Deceleration
- 3-4 Slip
- Neutral Condition On 3-4 Upshift
- Bucking On Deceleration & Kills Engine When Stopping
- Chatters Or Bucks On Acceleration Or Deceleration In 4th Gear
- No 3-4 Upshift Until 50 MPH, Or Until Accelerator Pedal Is Released Slightly
- Harsh 4-3 Or 4-2 Downshift
- Bearing Whine In All Gear Positions Except 3rd & 4th
- Clutch & Band Application Chart
- Testing
- Road Test
- Control Pressure Test
- Control Pressure Test Results
- Direct Clutch Pressure Test
- Shift Speed Specifications (Mph)
- Governor Check
- Stall Speed Test
- Stall Speed Test Results
- Air Pressure Tests
- Flushing Converter
- Leak Test
- End Play Check
- Stator One-Way Clutch Check
- Damper & Hub Assembly
- Stator Interference Check
- Removal & Installation
- Disassembly
- Component Disassembly & Reassembly
- Reassembly
- Torque Specifications
- Removal & Installation - A/T
- Servicing - A/T
- Overhaul - AOD
- Clutches
- Hydraulic Diagrams - AOD
- Automatic Trans
- External Pages
