Technical Service Bulletins
- A/C Compressor
- Climate Control - A/C Service Tech Tips (02-20-8)
- Filtering Refrigerant After Compressor Replacement (98-12-5)
- Identification Of Non-Ford Approved Refrigerants (99-19-6)
- A/C - R-12 To R-134A Retrofit Kit - Factory A/C Only (98-4-8)
- New Thicker O-Rings For Spring Lock Fittings (96-20-8)
- Use Of R-12 Refrigerant Substitutes (96-17-10)
- A/C System Service - List Of Bulletins To Reference (96-15-6)
- 4.6L - Squeal From FEAD At Temps Below -7 Degrees C (96-14-8)
- Ford Approved Flushing Procedures For A/C System (95-8-1)
- R-12 Refrigerant Substitutes - Service Tip (94-14-3)
- Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
- Use Of Correct Fluorescent Tracer Dye - Service Tip (93-20-6)
- FX-15 A/C Compressor Clutch: Coil/Pulley Usage (92-25-5)
- (4.6L) A/C Compressor Clutch Cycling Noise: New Line (92-20-4)
- Accessories Control Systems
- Electrical - Revised Mechanical Hood Lamp Switch To Replace Old Style Mercury Hood Lamp Switch (01-19-4)
- Temp. Gauge Reads Low - Obsolete Temperature Sender (95-13-2)
- Erratic Distance-To-Empty & Fuel Gauge Readings (95-2-3)
- 4.6L Engine Noises In Passenger Compartment (93-17-4)
- "Mil" Lamp Service Tips (92-4-4)
- Accessory Drive Belts
- Air Bag, SRS
- Anti-Lock Brakes
- Anti-Theft Systems
- Remote Keyless Entry (RKE) - Service Tips (03-18-1)
- Remote Keyless Entry Diagnostic Service Tips (97-24-13)
- Remote Keyless Entry System Service Tips (94-4-3)
- Remote Keyless Entry System - Service Information (93-4-3)
- Police Vehicle Front Fender Damage From Tire Contact (93-12-3)
- Power Door Locks Inoperative: Actuator Securing (93-2-2)
- "Mil" Lamp Service Tips (92-4-4)
- Automatic Trans
- MERCON ATF Is Being Replaced By MERCON V ATF As A Service Fluid (06-14-4)
- New Transmission Cooler Flusher - Service Tips (03-14-8)
- E4OD/4R100 - Fluid In-Line Filter Kit (00-3-8)
- Transmission Flush/Fill Tool Available From Rotunda (99-15-2)
- AODE/4R70W - Forward Clutch Service Kit (98-10-8)
- AODE/4R70W - Shudder On Acceleration In 3RD/4TH Gear (98-8-7)
- Transmission Fluid Usage Chart (98-8-8)
- AODE/4R70W - Main Control & Case Usage For Prior Mod (97-16-7)
- 4R70W/AODE - Erratic Or Prolonged 1-2 Shift (97-11-11)
- Torque Converter Replacement - Cooling SYS. Cleaning (96-26-12)
- AODE/4R70W - Shudder Under Light Acceleration (96-25-17)
- Torque Converter Leak Test Procedure - New Tool (96-24-9)
- Traction-LOK Differential - Chatter On Tight Turns (96-12-9)
- AODE/4R70W - Shift And/Or Engagement Concerns - DTC (95-3-13)
- AODE/4R70W Erratic Shifts Loose C-101/C-110 CONNECTO (95-3-6)
- AODE/4R7OW Shudder Or Vibration (95-23-4)
- New Rotunda Fluid Changer - Service Tip (95-16-10)
- AODE/4R70W Reusable Oil Pan Gasket (95-8-4)
- AODE/4R70W Loss Of Torque During/After 3-4 Upshift (95-5-15)
- AODE/4R70W Delayed Or No Forward/Reverse Engagement (94-26-9)
- AODE Intermediate One-Way Clutch Repeat Repairs (94-9-9)
- Improved One-Way Clutch For Fleet Applications (94-11-10)
- AODE Transmission Shift Busyness - Harsh 3-4 Shifts (93-20-9)
- AODE/4R70W Trans Harsh Engagement Or Firm Shifts (93-19-8)
- AODE A/T Torque Converter Engagement - Module (93-12-11)
- AOD/AODE/AODE-W A/T: New Short Lip Piston Seals (92-24-10)
- Auxiliary Emission Control Systems
- Lean DRIVEABILITY Symptoms: MAF Sensor Contamination (98-23-10)
- Mil Illuminated - Diagnostic Trouble Code 332 (96-25-9)
- 4.6L - Detonation/Intermittent Mil/Code 332 (96-23-4)
- Mass Air Flow Sensor Replacement As An Assembly (96-22-5)
- Revised Ignition Control Module Connector Clip (95-10-2)
- Throttle Position Sensor Function & Diagnostic Tips (94-26-4)
- 4.6L Idle Air Bypass Valve Noise "Moan" "Hooting" (94-22-4)
- Exhaust - Heated Oxygen Sensor Application Chart (94-16-9)
- EXH Gas Oxygen Sensor Silicone Sealer Contamination (93-23-6)
- Emission Control - Part & System Names Standardized (92-11-7)
- Exhaust System Noise - Loose Muffler/Catalyst Shield (98-6-4)
- Axle Shafts
- Blowers, Superchargers & Turbochargers
- Body Interior
- A/C Musty & Mildew Type Odors - New A/C DISODORIZER (98-2-7)
- Electrical Diode Identification And Replacements (96-24-6)
- Temp. Gauge Reads Low - Obsolete Temperature Sender (95-13-2)
- Erratic Distance-To-Empty & Fuel Gauge Readings (95-2-3)
- Cold Engine Lockout/Thermal Blower Lockout Operation (94-11-5)
- 4.6L Engine Noises In Passenger Compartment (93-17-4)
- Police Vehicle Front Fender Damage From Tire Contact (93-12-3)
- Power Door Locks Inoperative: Actuator Securing (93-2-2)
- "Mil" Lamp Service Tips (92-4-4)
- Brakes Control Systems
- Charging Systems
- Clutch
- Communication Devices
- Cooling Fan
- Cooling System (Mechanical)
- Ford Motor Company Position On Engine Coolant Made From Propylene Glycol (96-16-4)
- Lean DRIVEABILITY Symptoms: MAF Sensor Contamination (98-23-10)
- Leaks Oil - New Silicone Gasket & Sealant (98-7-4)
- Mil Illuminated - Diagnostic Trouble Code 332 (96-25-9)
- Use Of Recycled Engine Coolant - Service Tip (95-18-2)
- Revised Ignition Control Module Connector Clip (95-10-2)
- Throttle Position Sensor Function & Diagnostic Tips (94-26-4)
- Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
- Engine Gasket Surface Cleaning Procedures (93-23-14)
- Cooling System - Proper Fluid Concentrations (93-1-10)
- Premature GENL Eng Wear: Grinding Disc Use Not RECMD (92-25-2)
- Cruise Control Systems
- Differentials & Drive Axles
- Driveshaft & Universal Joints
- Electronic Steering
- Electronic Suspension
- Engine Control Systems
- Whining/Buzzing - Comes Through Speakers Of Entertainment Or Two-Way Radio (02-16-4)
- Fuel Pump Whine/Buzz Noise In Radio Speakers (99-12-9)
- Volatility Related DRIVEABILITY Concerns Service Tip (98-26-2)
- Lean DRIVEABILITY Symptoms: MAF Sensor Contamination (98-23-10)
- Mil Illuminated - Diagnostic Trouble Code 332 (96-25-9)
- 4.6L - Detonation/Intermittent Mil/Code 332 (96-23-4)
- Mass Air Flow Sensor Replacement As An Assembly (96-22-5)
- Revised Ignition Control Module Connector Clip (95-10-2)
- Throttle Position Sensor Function & Diagnostic Tips (94-26-4)
- Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
- Fuel Injectors (Deposit Resistant): Identification (93-7-5)
- Entertainment Systems
- Whining/Buzzing - Comes Through Speakers Of Entertainment Or Two-Way Radio (02-16-4)
- Fuel Pump Whine/Buzz Noise In Radio Speakers (99-12-9)
- Antenna Bowed Condition Only Warranty Man. Revision (95-9-1)
- 4.6L Engine Noises In Passenger Compartment (93-17-4)
- Poor Bass Response: Reversed Speaker Wires (93-2-6)
- Exhaust
- Exterior Body Panels
- Body - Parts And Procedure To Reduce The Potential Of Fuel Tank Punctures During Rare And Extremely High-Speed Rear Impacts (01-21-14)
- Front Seat Loose/Clunks When Accelerating Or Braking (94-18-12)
- Police Vehicle Front Fender Damage From Tire Contact (93-12-3)
- Iron Particle Removal From Paint (92-6-4)
- Exterior Lights
- Frames, Subframes & Crossmembers
- Front Suspension
- Ball Joint Replacement Procedure - Service Tip (95-14-4)
- Hum Noise From Air Suspension Compressor (94-21-2)
- Steering Drift/Wander: Front Lower Arm Shim (94-9-2)
- Power Steering Noise: Purging Air From System (93-7-3)
- Noise From Power Steering On Right Hand Turns (93-19-3)
- Police Vehicle Front Fender Damage From Tire Contact (93-12-3)
- Steering Column Noise At Acceleration/Braking (93-5-4)
- Fuel System
- Whining/Buzzing - Comes Through Speakers Of Entertainment Or Two-Way Radio (02-16-4)
- Volatility Related DRIVEABILITY Concerns Service Tip (98-26-2)
- Lean DRIVEABILITY Symptoms: MAF Sensor Contamination (98-23-10)
- Fuel Injector - Non Warranty Reimbursement Testing (98-9-9)
- Mil Illuminated - Diagnostic Trouble Code 332 (96-25-9)
- 4.6L - Detonation/Intermittent Mil/Code 332 (96-23-4)
- Mass Air Flow Sensor Replacement As An Assembly (96-22-5)
- CALIFORNIA Reformulated Gasoline - Service Tip (96-10-7)
- Revised Ignition Control Module Connector Clip (95-10-2)
- Accelerator Cable Diagnostic Procedure (95-1-2)
- 4.6L Idle Air Bypass Valve Noise "Moan" "Hooting" (94-22-4)
- Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
- Fuel Injectors (Deposit Resistant): Identification (93-7-5)
- Fuses & Circuit Breakers
- Wiring - Wire Harness Terminal Repair Kit (99-6-3)
- Electrical - New Terminal Grease For Service (98-24-6)
- Electrical Diode Identification And Replacements (96-24-6)
- Revised Ignition Control Module Connector Clip (95-10-2)
- 4.6L No Crank: Starter SOLENIOD Connector Corroded (94-18-3)
- 4.6L Engine Noises In Passenger Compartment (93-17-4)
- Police Vehicle Front Fender Damage From Tire Contact (93-12-3)
- Alb Light Remains On: Exposed Wire Harness Repair (93-10-1)
- Poor Bass Response: Reversed Speaker Wires (93-2-6)
- Gauges & Instrument Panels
- Temp. Gauge Reads Low - Obsolete Temperature Sender (95-13-2)
- Erratic Distance-To-Empty & Fuel Gauge Readings (95-2-3)
- Front Seat Loose/Clunks When Accelerating Or Braking (94-18-12)
- Police Vehicle Front Fender Damage From Tire Contact (93-12-3)
- SPEEDOMTR Modules/Cluster-PSOM Replacement Available (93-12-9)
- CUPHOLDER Ashtray Installation Procedure (93-7-1)
- Headlights
- Heated Glass/Defoggers
- HVAC Control Systems
- Climate Control - A/C Service Tech Tips (02-20-8)
- Climate Control - Repeat Heater Core Failure (01-15-6)
- Climate Control - EATC - Blower Motor Control Service Tips (00-21-3)
- A/C Musty & Mildew Type Odors - New A/C DISODORIZER (98-2-7)
- Filtering Refrigerant After Compressor Replacement (98-12-5)
- Identification Of Non-Ford Approved Refrigerants (99-19-6)
- A/C - R-12 To R-134A Retrofit Kit - Factory A/C Only (98-4-8)
- On-Vehicle Pressure Test Required For Warranty Claim (97-19-11)
- New Thicker O-Rings For Spring Lock Fittings (96-20-8)
- Use Of R-12 Refrigerant Substitutes (96-17-10)
- A/C System Service - List Of Bulletins To Reference (96-15-6)
- Ford Approved Flushing Procedures For A/C System (95-8-1)
- A/C Evaporator Core On-Vehicle Leak Test Procedure (95-13-1)
- A/C "O" Ring Removal From Spring Lock Coupling (95-2-2)
- R-12 Refrigerant Substitutes - Service Tip (94-14-3)
- Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
- Use Of Correct Fluorescent Tracer Dye - Service Tip (93-20-6)
- (4.6L) A/C Compressor Clutch Cycling Noise: New Line (92-20-4)
- Ignition Switch/Steering Lock
- Ignition System
- Infotainment
- Interior/Exterior Trim
- Interior/Illumination Lights
- Locking Hubs
- Lubrication System
- Engine Oil - Recommended Applications For Sae 5W-20 And Sae 5W-30 Motor Oils (02-1-9)
- Motor Oil - Sae Viscosity Grade Recommendation (99-8-16)
- Leaks Oil - New Silicone Gasket & Sealant (98-7-4)
- 4.6L Oil Filter Balloons And Leaks:Incorrect Oil (94-11-7)
- Engine Gasket Surface Cleaning Procedures (93-23-14)
- Premature GENL Eng Wear: Grinding Disc Use Not RECMD (92-25-2)
- Manual Steering
- Manual Trans
- Mechanical
- Engine - Straightedge Procedure For Checking Cylinder Head & Block Flatness (02-21-13)
- New Gasket Remover/Cleaner Service Tips For Aluminum Heads & Blocks (02-11-4)
- Machining Of Aluminum Cylinder Heads Or Blocks - Warranty Information (02-2-3)
- Engine - Approved Head Gasket Replacement Service Procedures (02-1-4)
- Engine Oil - Recommended Applications For Sae 5W-20 And Sae 5W-30 Motor Oils (02-1-9)
- Lean DRIVEABILITY Symptoms: MAF Sensor Contamination (98-23-10)
- Leaks Oil - New Silicone Gasket & Sealant (98-7-4)
- Fuel Economy - Customer Expectations (99-26-9)
- Mil Illuminated - Diagnostic Trouble Code 332 (96-25-9)
- 4.6L - Detonation/Intermittent Mil/Code 332 (96-23-4)
- 4.6L - Squeal From FEAD At Temps Below -7 Degrees C (96-14-8)
- Revised Ignition Control Module Connector Clip (95-10-2)
- 4.6L Idle Air Bypass Valve Noise "Moan" "Hooting" (94-22-4)
- 4.6L Oil Filter Balloons And Leaks:Incorrect Oil (94-11-7)
- Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
- Engine Gasket Surface Cleaning Procedures (93-23-14)
- Premature GENL Eng Wear: Grinding Disc Use Not RECMD (92-25-2)
- Mechanical - Hydraulic
- Brake Pedal Noise/Vibration Or Slip/Stick Condition (98-5A-7)
- Brakes - Elimination Of Sanding Rotors & Drums (98-5A-11)
- Brakes - Hub-Mount Brake Rotor Machining Equipment (98-5A-5)
- Silicone Brake Caliper Grease Requirement (98-5A-13)
- Wheels - Proper Lug Torque Procedures - Service Tip (98-5A-4)
- Brake & Rotor Service Tips (97-19-4)
- Brakes - Roughness Concern During Brake Application (95-6-2)
- On-Vehicle Caliper Mounted Brake Rotor Machining EQP (94-25-2)
- Excessive Rear Brake Lining Wear:Brake Shield Kit (93-18-3)
- Premature Front Brake Rotor Wear: New Components (93-16-2)
- Guidelines For Brake Vibration Repair & Replacement (99-19-4)
- Memory Modules
- Mirrors
- Various Vehicles - Rear-View Mirror Concern Analysis (23-7092)
- Rear View Mirror - Preferred Reattachment Method (97-17-2)
- Rear View Mirror Detaches From Windshield (94-17-2)
- Driver's Seat Sensor Switch Causes Doors To Lock (94-10-2)
- Police Vehicle Front Fender Damage From Tire Contact (93-12-3)
- "Mil" Lamp Service Tips (92-4-4)
- Overdrive Unit
- Paint & Coatings
- Urethane Mounted Glass Material Usage Procedure (95-12-1)
- Paint Iron Particle Removal/Acid Rain Neutralization (95-6-1)
- Primed Sheet Metal Prep Procedure & MSDS Information (94-23-4)
- Rear View Mirror Detaches From Windshield (94-17-2)
- Exterior CLEARCOAT MICROCHECKING, Hazing Or Peeling (93-8-4)
- 1993 Ford, LINCOLN-Mercury Paint Codes (92-20-1)
- Lower Body Side Stone Protection (92-8-3)
- Iron Particle Removal From Paint (92-6-4)
- Parking Brake System
- Passive Restraints
- Rear Suspension
- Ball Joint Replacement Procedure - Service Tip (95-14-4)
- Hum Noise From Air Suspension Compressor (94-21-2)
- Power Steering Noise: Purging Air From System (93-7-3)
- Noise From Power Steering On Right Hand Turns (93-19-3)
- Police Vehicle Front Fender Damage From Tire Contact (93-12-3)
- Steering Column Noise At Acceleration/Braking (93-5-4)
- Restraints Control Systems
- Seats
- Front Seat Feels Loose - Reinforcement Bracket Crack (98-24-5)
- Leather Seat Cleaning Procedure - Service Tip (98-17-1)
- Front Seat Track Covers Come Off (94-20-1)
- Front Seat Loose/Clunks When Accelerating Or Braking (94-18-12)
- Driver's Seat Sensor Switch Causes Doors To Lock (94-10-2)
- Police Vehicle Front Fender Damage From Tire Contact (93-12-3)
- Split-Bench Seats Cushion Sag Or Discomfort (93-11-1)
- "Mil" Lamp Service Tips (92-4-4)
- Starter
- Steering Column
- Steering Gear
- Steering Linkage
- Hum Noise From Air Suspension Compressor (94-21-2)
- Steering Drift/Wander: Front Lower Arm Shim (94-9-2)
- Power Steering Noise: Purging Air From System (93-7-3)
- Noise From Power Steering On Right Hand Turns (93-19-3)
- Police Vehicle Front Fender Damage From Tire Contact (93-12-3)
- Steering Column Noise At Acceleration/Braking (93-5-4)
- Sun Roof/T-Top/Convertible Top
- Suspension Control Systems
- System
- Whining/Buzzing - Comes Through Speakers Of Entertainment Or Two-Way Radio (02-16-4)
- Engine - Approved Head Gasket Replacement Service Procedures (02-1-4)
- Fuel Pump Whine/Buzz Noise In Radio Speakers (99-12-9)
- Volatility Related DRIVEABILITY Concerns Service Tip (98-26-2)
- Lean DRIVEABILITY Symptoms: MAF Sensor Contamination (98-23-10)
- Fuel Injector - Non Warranty Reimbursement Testing (98-9-9)
- Leaks Oil - New Silicone Gasket & Sealant (98-7-4)
- Fuel Economy - Customer Expectations (99-26-9)
- Mil Illuminated - Diagnostic Trouble Code 332 (96-25-9)
- 4.6L - Detonation/Intermittent Mil/Code 332 (96-23-4)
- Mass Air Flow Sensor Replacement As An Assembly (96-22-5)
- CALIFORNIA Reformulated Gasoline - Service Tip (96-10-7)
- Revised Ignition Control Module Connector Clip (95-10-2)
- Accelerator Cable Diagnostic Procedure (95-1-2)
- Throttle Position Sensor Function & Diagnostic Tips (94-26-4)
- 4.6L Idle Air Bypass Valve Noise "Moan" "Hooting" (94-22-4)
- Exhaust - Heated Oxygen Sensor Application Chart (94-16-9)
- Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
- Engine Gasket Surface Cleaning Procedures (93-23-14)
- EXH Gas Oxygen Sensor Silicone Sealer Contamination (93-23-6)
- Fuel Injectors (Deposit Resistant): Identification (93-7-5)
- Premature GENL Eng Wear: Grinding Disc Use Not RECMD (92-25-2)
- Emission Control - Part & System Names Standardized (92-11-7)
- Exhaust System Noise - Loose Muffler/Catalyst Shield (98-6-4)
- Transfer Case
- Transmission Control Systems
- Inadvertent Disabling Of Brake Shift Interlock (99-13-9)
- INADVERTANT Disabling Of Shift Interlock - Police (99-9-10)
- AODE/4R70W - Shudder On Acceleration In 3RD/4TH Gear (98-8-7)
- AODE/4R70W - Shudder Under Light Acceleration (96-25-17)
- AODE/4R70W - Shift And/Or Engagement Concerns - DTC (95-3-13)
- AODE/4R70W Erratic Shifts Loose C-101/C-110 CONNECTO (95-3-6)
- AODE/4R7OW Shudder Or Vibration (95-23-4)
- AODE Intermediate One-Way Clutch Repeat Repairs (94-9-9)
- A/T EPC Solenoid Contamination From Solvent (93-12-12)
- Vacuum Pumps/Lines/Tanks/Water Trap
- Warning Systems
- Wheel Alignment
- Wheels & Tire System
- Wheels - Proper Lug Torque Procedures - Service Tip (98-5A-4)
- Tire Company Phone Numbers For Customer Assistance (98-5-2)
- Center Wheel Ornament Falls Off - Installation Tips (94-26-1)
- Hum Noise From Air Suspension Compressor (94-21-2)
- Power Steering Noise: Purging Air From System (93-7-3)
- Noise From Power Steering On Right Hand Turns (93-19-3)
- Police Vehicle Front Fender Damage From Tire Contact (93-12-3)
- Steering Column Noise At Acceleration/Braking (93-5-4)
- Window Motors & Regulators
- Windshield And Interior Glass - Fog/Film (96-22-1)
- Urethane Mounted Glass Material Usage Procedure (95-12-1)
- Front Seat Loose/Clunks When Accelerating Or Braking (94-18-12)
- Rear View Mirror Detaches From Windshield (94-17-2)
- Driver's Seat Sensor Switch Causes Doors To Lock (94-10-2)
- "Iridescence" Or "Mottling" In Tempered Glass (93-21-1)
- Police Vehicle Front Fender Damage From Tire Contact (93-12-3)
- Wiper/Washer Systems
- Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)
- Wiring - Wire Harness Terminal Repair Kit (99-6-3)
- Electrical - New Terminal Grease For Service (98-24-6)
- Electrical Diode Identification And Replacements (96-24-6)
- Temp. Gauge Reads Low - Obsolete Temperature Sender (95-13-2)
- Revised Ignition Control Module Connector Clip (95-10-2)
- Erratic Distance-To-Empty & Fuel Gauge Readings (95-2-3)
- 4.6L No Crank: Starter SOLENIOD Connector Corroded (94-18-3)
- Police Vehicle Front Fender Damage From Tire Contact (93-12-3)
- Alb Light Remains On: Exposed Wire Harness Repair (93-10-1)
- Poor Bass Response: Reversed Speaker Wires (93-2-6)