Technical Service Bulletins
- A/C Compressor
- Filtering Refrigerant After Compressor Replacement (98-12-5)
- Identification Of Non-Ford Approved Refrigerants (99-19-6)
- A/C - R-12 To R-134A Retrofit Kit - Factory A/C Only (98-4-8)
- Air Conditioning - O-Ring Availability/Applications (96-20-7)
- New Thicker O-Rings For Spring Lock Fittings (96-20-8)
- Use Of R-12 Refrigerant Substitutes (96-17-10)
- A/C System Service - List Of Bulletins To Reference (96-15-6)
- Ford Approved Flushing Procedures For A/C System (95-8-1)
- Air Conditioning Adding Refrigerant Oil Service Tip (95-5-12)
- Air Conditioning FS-10 & FX-15 Compressors (94-15-6)
- R-12 Refrigerant Substitutes - Service Tip (94-14-3)
- Noise From Loose Spring In RECIRC Door Vacuum Motor (94-8-15)
- Front End Accessory Drive (FEAD) Belt Breakage/Noise (93-25-3)
- Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
- Use Of Correct Fluorescent Tracer Dye - Service Tip (93-20-6)
- FX-15 A/C Compressor Clutch: Coil/Pulley Usage (92-25-5)
- A/C FX-15 Air Compressor Oil Recovery/Measuring (92-24-6)
- Accessories Control Systems
- Accessory Drive Belts
- Anti-Lock Brakes
- Anti-Theft Systems
- Remote Keyless Entry (RKE) - Service Tips (03-18-1)
- Remote Keyless Entry Diagnostic Service Tips (97-24-13)
- Compass Erratic - Map Lamp Erratic/Burnt Out (96-8-15)
- Anti-Theft Protection System - Recap Of TSB'S - Tips (94-25-5)
- Inside Door Handle Breaks When Opening Door (94-22-9)
- Remote Keyless Entry System Service Tips (94-4-3)
- Remote Keyless Entry System - Service Information (93-4-3)
- Power Door Locks Inoperative: Actuator Securing (93-2-2)
- "Mil" Lamp Service Tips (92-4-4)
- Automatic Trans
- MERCON ATF Is Being Replaced By MERCON V ATF As A Service Fluid (06-14-4)
- New Transmission Cooler Flusher - Service Tips (03-14-8)
- 4.0L - No Crank/Noise During Cranking - Possible Cracked FLEXPLATE (02-14-2)
- E4OD/4R100 - Fluid In-Line Filter Kit (00-3-8)
- Transmission Flush/Fill Tool Available From Rotunda (99-15-2)
- Transmission Fluid Usage Chart (98-8-8)
- 4R44E/5R55E Trans - New Service Center Support (98-1-12)
- Torque Converter Slip/DTC 628 Or P0741 In Memory (97-22-4)
- Torque Converter Replacement - Cooling SYS. Cleaning (96-26-12)
- Torque Converter Leak Test Procedure - New Tool (96-24-9)
- Traction-LOK Differential - Chatter On Tight Turns (96-12-9)
- New Rotunda Fluid Changer - Service Tip (95-16-10)
- Plastic Caged Overdrive One-Way Clutch Service Tip (94-10-13)
- A4LD Overdrive & Intermediate Servo Damage From Heat (94-6-16)
- A/T Shifter POSTION Not Matching Gear: Inspection (93-5-14)
- Auxiliary Emission Control Systems
- Lean DRIVEABILITY Symptoms: MAF Sensor Contamination (98-23-10)
- Mass Air Flow Sensor Replacement As An Assembly (96-22-5)
- Squeal/Hoot From FEAD At Temps Below -18 Degrees C (96-14-9)
- Revised Ignition Control Module Connector Clip (95-10-2)
- Throttle Position Sensor Function & Diagnostic Tips (94-26-4)
- Exhaust - Heated Oxygen Sensor Application Chart (94-16-9)
- 4.0L Engine Stalls On Cold Start: Pcm Replacement (94-2-21)
- 4.0L Eng Exhaust SULFER Odor - New ECM (93-3-17)
- EXH Gas Oxygen Sensor Silicone Sealer Contamination (93-23-6)
- Emission Control - Part & System Names Standardized (92-11-7)
- Exhaust System Noise - Loose Muffler/Catalyst Shield (98-6-4)
- Axle Shafts
- Blowers, Superchargers & Turbochargers
- Body Interior
- A/C Musty & Mildew Type Odors - New A/C DISODORIZER (98-2-7)
- Electrical Diode Identification And Replacements (96-24-6)
- Temp. Gauge Fluctuating/Inaccurate High Readings (95-18-5)
- Temp. Gauge Reads Low - Obsolete Temperature Sender (95-13-2)
- Airflow From Heater Registers When System Is Off (95-6-14)
- 3.0L & 4.0L Engine Temperature Gauge Reads High (94-8-16)
- Power Door Locks Inoperative: Actuator Securing (93-2-2)
- "Mil" Lamp Service Tips (92-4-4)
- Charging Systems
- Clutch
- Communication Devices
- Cooling Fan
- Cooling System (Mechanical)
- Ford Motor Company Position On Engine Coolant Made From Propylene Glycol (96-16-4)
- Lean DRIVEABILITY Symptoms: MAF Sensor Contamination (98-23-10)
- Leaks Oil - New Silicone Gasket & Sealant (98-7-4)
- Use Of Recycled Coolant - Service Tip (95-18-2)
- Revised Ignition Control Module Connector Clip (95-10-2)
- 4.0L Coolant Loss - Revised Intake Manifold Gasket (95-9-10)
- Throttle Position Sensor Function & Diagnostic Tips (94-26-4)
- 4.0L Oil Leaks At Lower End/Intake Man/Rocker Covers (94-12-13)
- 4.0L Engine Stalls On Cold Start: Pcm Replacement (94-2-21)
- Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
- Engine Gasket Surface Cleaning Procedures (93-23-14)
- Cooling System - Proper Fluid Concentrations (93-1-10)
- Premature GENL Eng Wear: Grinding Disc Use Not RECMD (92-25-2)
- Cruise Control Systems
- Differentials & Drive Axles
- Driveshaft & Universal Joints
- Electronic Steering
- Electronic Suspension
- Engine Control Systems
- Whining/Buzzing - Comes Through Speakers Of Entertainment Or Two-Way Radio (02-16-4)
- Fuel Pump Whine/Buzz Noise In Radio Speakers (99-12-9)
- Volatility Related DRIVEABILITY Concerns Service Tip (98-26-2)
- Lean DRIVEABILITY Symptoms: MAF Sensor Contamination (98-23-10)
- Mass Air Flow Sensor Replacement As An Assembly (96-22-5)
- Revised Ignition Control Module Connector Clip (95-10-2)
- Throttle Position Sensor Function & Diagnostic Tips (94-26-4)
- 4.0L Engine Stalls On Cold Start: Pcm Replacement (94-2-21)
- Engine Stalls During Cold Start(A/T):Pcm Replacement (94-2-22)
- 4.0L Eng Exhaust SULFER Odor - New ECM (93-3-17)
- Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
- Fuel Injectors (Deposit Resistant): Identification (93-7-5)
- 4.0L Eng Fuel Line Knocking Noise: New Fuel Line (93-14-17)
- Entertainment Systems
- Exhaust
- Exterior Body Panels
- Accelerator Pedal Bracket - Cracks At Dash Panel (00-24-3)
- Rust Perforation On Quarter Panel (97-25-6)
- Roof Panel & Drip Rail REPACEMENT - New Seam Sealer (95-16-1)
- Front Passenger Seat Rattles When Unoccupied (94-14-10)
- Cold Air Draft From Rear Door Speaker & Door Handle (94-6-9)
- Iron Particle Removal From Paint (92-6-4)
- Exterior Lights
- Frames, Subframes & Crossmembers
- Front Suspension
- Brakes/Steering - Pull/Drift Diagnostic Procedure (98-5A-22)
- Vibration "After Shake" When Driving Over Bumps (96-4-15)
- Vibration/Shake Felt From Engine - 2-Door Model (96-4-17)
- Inner Front Radius Arm Insulator "Creak" : Replacement (94-9-10)
- Power Steering Noise: Purging Air From System (93-7-3)
- Noises From Front Underbody:Worn Radius Arm Bushings (93-22-12)
- Front/Rear Springs: Rates/Identification Information (93-8-11)
- Front Alignment Service Specifications (92-25-11)
- Fuel System
- Whining/Buzzing - Comes Through Speakers Of Entertainment Or Two-Way Radio (02-16-4)
- Accelerator Pedal Bracket - Cracks At Dash Panel (00-24-3)
- Volatility Related DRIVEABILITY Concerns Service Tip (98-26-2)
- Lean DRIVEABILITY Symptoms: MAF Sensor Contamination (98-23-10)
- Fuel Injector - Non Warranty Reimbursement Testing (98-9-9)
- Mass Air Flow Sensor Replacement As An Assembly (96-22-5)
- CALIFORNIA Reformulated Gasoline - Service Tip (96-10-7)
- Revised Ignition Control Module Connector Clip (95-10-2)
- Accelerator Cable Diagnostic Procedures (94-15-16)
- Internal Engine Damage: Water Entry Thru Air Intake (94-3-8)
- 4.0L Engine Stalls On Cold Start: Pcm Replacement (94-2-21)
- Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
- Fuel Injectors (Deposit Resistant): Identification (93-7-5)
- 4.0L Eng Fuel Line Knocking Noise: New Fuel Line (93-14-17)
- Fuses & Circuit Breakers
- Wiring - Wire Harness Terminal Repair Kit (99-6-3)
- Electrical - New Terminal Grease For Service (98-24-6)
- Electrical Diode Identification And Replacements (96-24-6)
- Revised Ignition Control Module Connector Clip (95-10-2)
- 4.0L No Start Wires & Cables Damaged By Battery Acid (94-8-14)
- Rear Wiper Motor Inoperative: Arm Adjustment (92-24-12)
- Gauges & Instrument Panels
- Accelerator Pedal Bracket - Cracks At Dash Panel (00-24-3)
- Compass Erratic - Map Lamp Erratic/Burnt Out (96-8-15)
- Temp. Gauge Fluctuating/Inaccurate High Readings (95-18-5)
- Temp. Gauge Reads Low - Obsolete Temperature Sender (95-13-2)
- Front Seat Center Armrest Loose And Wobbles (94-24-10)
- Front Passenger Seat Rattles When Unoccupied (94-14-10)
- 3.0L & 4.0L Engine Temperature Gauge Reads High (94-8-16)
- Armrest Plastic Mounting Bracket Breaks (93-23-19)
- Headlights
- Heated Glass/Defoggers
- HVAC Control Systems
- Climate Control - Repeat Heater Core Failure (01-15-6)
- A/C - Burning Odor/Rustling Noise When Blower Is On (99-20-6)
- A/C Musty & Mildew Type Odors - New A/C DISODORIZER (98-2-7)
- Filtering Refrigerant After Compressor Replacement (98-12-5)
- Identification Of Non-Ford Approved Refrigerants (99-19-6)
- A/C - R-12 To R-134A Retrofit Kit - Factory A/C Only (98-4-8)
- On-Vehicle Pressure Test Required For Warranty Claim (97-19-11)
- A/C Poor PERF. Insufficient Air Flow Thru Condenser (97-16-12)
- Air Conditioning - O-Ring Availability/Applications (96-20-7)
- New Thicker O-Rings For Spring Lock Fittings (96-20-8)
- Use Of R-12 Refrigerant Substitutes (96-17-10)
- A/C System Service - List Of Bulletins To Reference (96-15-6)
- Ford Approved Flushing Procedures For A/C System (95-8-1)
- A/C Evaporator Core On-Vehicle Leak Test Procedure (95-13-1)
- Airflow From Heater Registers When System Is Off (95-6-14)
- Air Conditioning Adding Refrigerant Oil Service Tip (95-5-12)
- A/C "O" Ring Removal From Spring Lock Coupling (95-2-2)
- Air Conditioning FS-10 & FX-15 Compressors (94-15-6)
- R-12 Refrigerant Substitutes - Service Tip (94-14-3)
- Noise From Loose Spring In RECIRC Door Vacuum Motor (94-8-15)
- Front End Accessory Drive (FEAD) Belt Breakage/Noise (93-25-3)
- A/C Suction Hose - New Availability/Installation (93-24-18)
- Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
- Service Parts Return Of Obsolete A/C Filter Kits (93-22-6)
- Use Of Correct Fluorescent Tracer Dye - Service Tip (93-20-6)
- A/C FX-15 Air Compressor Oil Recovery/Measuring (92-24-6)
- A/C FX-15 Compressor Air Gap Specification (92-20-5)
- Ignition Switch/Steering Lock
- Ignition System
- Infotainment
- Interior/Exterior Trim
- Frame - Rivet Replacement With Bolts - Service Tips (97-4-7)
- Noise At Running Board - Incorrectly Installed (95-8-6)
- Inside Door Handle Breaks When Opening Door (94-22-9)
- Front Passenger Seat Rattles When Unoccupied (94-14-10)
- Fishy Or Musty Odor From Headliner (94-4-1)
- Paint Wears Off Inside Door Trim Panel Pull Handles (94-7-12)
- Cold Air Draft From Rear Door Speaker & Door Handle (94-6-9)
- Adhesive BODYSIDE Mouldings & Nameplates Replacement (88-10-4)
- Interior/Illumination Lights
- Locking Hubs
- Lubrication System
- Motor Oil - Sae Viscosity Grade Recommendation (99-8-16)
- Leaks Oil - New Silicone Gasket & Sealant (98-7-4)
- 4.0L Coolant Loss - Revised Intake Manifold Gasket (95-9-10)
- 4.0L Oil Leaks At Lower End/Intake Man/Rocker Covers (94-12-13)
- Engine Gasket Surface Cleaning Procedures (93-23-14)
- Premature GENL Eng Wear: Grinding Disc Use Not RECMD (92-25-2)
- Manual Steering
- Manual Trans
- Mechanical
- 4.0L - No Crank/Noise During Cranking - Possible Cracked FLEXPLATE (02-14-2)
- Engine 4.0L OHV - Carbon Knock On Acceleration (01-19-7)
- Lean DRIVEABILITY Symptoms: MAF Sensor Contamination (98-23-10)
- Leaks Oil - New Silicone Gasket & Sealant (98-7-4)
- Block Heater Removal When Replacing Motor Mounts (97-9-19)
- Fuel Economy - Customer Expectations (99-26-9)
- Squeal/Hoot From FEAD At Temps Below -18 Degrees C (96-14-9)
- Vibration "After Shake" When Driving Over Bumps (96-4-15)
- Vibration/Shake Felt From Engine - 2-Door Model (96-4-17)
- Revised Ignition Control Module Connector Clip (95-10-2)
- 4.0L Coolant Loss - Revised Intake Manifold Gasket (95-9-10)
- 4.0L Revised Torque Procedures And Specifications (94-18-10)
- 4.0L Oil Leaks At Lower End/Intake Man/Rocker Covers (94-12-13)
- Internal Engine Damage: Water Entry Thru Air Intake (94-3-8)
- 4.0L Engine Stalls On Cold Start: Pcm Replacement (94-2-21)
- 4.0L Rear Main Oil Seal Replacement - New Tool (95-1-8)
- Front End Accessory Drive (FEAD) Belt Breakage/Noise (93-25-3)
- Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
- Engine Gasket Surface Cleaning Procedures (93-23-14)
- 4.0L Eng Fuel Line Knocking Noise: New Fuel Line (93-14-17)
- Premature GENL Eng Wear: Grinding Disc Use Not RECMD (92-25-2)
- Mechanical - Hydraulic
- Parking Brake Goes To Floor With Minimal Effort (00-1-1)
- Procedure For Servicing Parking Brake (00-1-3)
- Brakes - Elimination Of Sanding Rotors & Drums (98-5A-11)
- Brakes - Hub-Mount Brake Rotor Machining Equipment (98-5A-5)
- Brakes Grab/Stick After Rainfall Or When Cold (98-5A-36)
- Brakes/Steering - Pull/Drift Diagnostic Procedure (98-5A-22)
- Silicone Brake Caliper Grease Requirement (98-5A-13)
- Wheels - Proper Lug Torque Procedures - Service Tip (98-5A-4)
- On-Vehicle Caliper Mounted Brake Rotor Machining EQP (94-25-2)
- Guidelines For Brake Vibration Repair & Replacement (99-19-4)
- Memory Modules
- Mirrors
- Various Vehicles - Rear-View Mirror Concern Analysis (23-7092)
- Rear View Mirror - Preferred Reattachment Method (97-17-2)
- Compass Erratic - Map Lamp Erratic/Burnt Out (96-8-15)
- Rear View Mirror Detaches From Windshield (94-17-2)
- Interior Rear View Mirror Description Of Function (93-22-11)
- "Mil" Lamp Service Tips (92-4-4)
- Paint & Coatings
- Roof Panel & Drip Rail REPACEMENT - New Seam Sealer (95-16-1)
- Paint Iron Particle Removal/Acid Rain Neutralization (95-6-1)
- Primed Sheet Metal Prep Procedure & MSDS Information (94-23-4)
- Rear View Mirror Detaches From Windshield (94-17-2)
- Exterior CLEARCOAT MICROCHECKING, Hazing Or Peeling (93-8-4)
- 1993 Ford, LINCOLN-Mercury Paint Codes (92-20-1)
- Iron Particle Removal From Paint (92-6-4)
- Parking Brake System
- Passive Restraints
- Rear Suspension
- Restraints Control Systems
- Seats
- Starter
- Steering Column
- Steering Column Switches
- Steering Gear
- Steering Linkage
- Sun Roof/T-Top/Convertible Top
- Suspension Control Systems
- System
- Whining/Buzzing - Comes Through Speakers Of Entertainment Or Two-Way Radio (02-16-4)
- Engine 4.0L OHV - Carbon Knock On Acceleration (01-19-7)
- Accelerator Pedal Bracket - Cracks At Dash Panel (00-24-3)
- Fuel Pump Whine/Buzz Noise In Radio Speakers (99-12-9)
- Volatility Related DRIVEABILITY Concerns Service Tip (98-26-2)
- Lean DRIVEABILITY Symptoms: MAF Sensor Contamination (98-23-10)
- Fuel Injector - Non Warranty Reimbursement Testing (98-9-9)
- Leaks Oil - New Silicone Gasket & Sealant (98-7-4)
- Fuel Economy - Customer Expectations (99-26-9)
- Mass Air Flow Sensor Replacement As An Assembly (96-22-5)
- CALIFORNIA Reformulated Gasoline - Service Tip (96-10-7)
- Revised Ignition Control Module Connector Clip (95-10-2)
- 4.0L Coolant Loss - Revised Intake Manifold Gasket (95-9-10)
- Throttle Position Sensor Function & Diagnostic Tips (94-26-4)
- Exhaust - Heated Oxygen Sensor Application Chart (94-16-9)
- Accelerator Cable Diagnostic Procedures (94-15-16)
- 4.0L Oil Leaks At Lower End/Intake Man/Rocker Covers (94-12-13)
- 4.0L No Start Wires & Cables Damaged By Battery Acid (94-8-14)
- Internal Engine Damage: Water Entry Thru Air Intake (94-3-8)
- 4.0L Engine Stalls On Cold Start: Pcm Replacement (94-2-21)
- Engine Stalls During Cold Start(A/T):Pcm Replacement (94-2-22)
- 4.0L Eng Exhaust SULFER Odor - New ECM (93-3-17)
- Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
- Engine Gasket Surface Cleaning Procedures (93-23-14)
- EXH Gas Oxygen Sensor Silicone Sealer Contamination (93-23-6)
- Fuel Injectors (Deposit Resistant): Identification (93-7-5)
- 4.0L Eng Fuel Line Knocking Noise: New Fuel Line (93-14-17)
- Premature GENL Eng Wear: Grinding Disc Use Not RECMD (92-25-2)
- Emission Control - Part & System Names Standardized (92-11-7)
- Exhaust System Noise - Loose Muffler/Catalyst Shield (98-6-4)
- Towing
- Transfer Case
- Transmission Control Systems
- Vacuum Pumps/Lines/Tanks/Water Trap
- Warning Systems
- Wheel Alignment
- Wheel Hubs
- Wheels & Tire System
- Wheels - Proper Lug Torque Procedures - Service Tip (98-5A-4)
- Tire Company Phone Numbers For Customer Assistance (98-5-2)
- Inner Front Radius Arm Insulator "Creak" : Replacement (94-9-10)
- Power Steering Noise: Purging Air From System (93-7-3)
- Noises From Front Underbody:Worn Radius Arm Bushings (93-22-12)
- Window Motors & Regulators
- Windshield And Interior Glass - Fog/Film (96-22-1)
- Inside Door Handle Breaks When Opening Door (94-22-9)
- Rear View Mirror Detaches From Windshield (94-17-2)
- Front Passenger Seat Rattles When Unoccupied (94-14-10)
- Cold Air Draft From Rear Door Speaker & Door Handle (94-6-9)
- "Iridescence" Or "Mottling" In Tempered Glass (93-21-1)
- Wiper/Washer Systems
- Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)
- Wiring - Wire Harness Terminal Repair Kit (99-6-3)
- Procedure For Servicing Parking Brake (00-1-3)
- Electrical - New Terminal Grease For Service (98-24-6)
- Electrical Diode Identification And Replacements (96-24-6)
- Compass Erratic - Map Lamp Erratic/Burnt Out (96-8-15)
- Temp. Gauge Reads Low - Obsolete Temperature Sender (95-13-2)
- Revised Ignition Control Module Connector Clip (95-10-2)
- 3.0L & 4.0L Engine Temperature Gauge Reads High (94-8-16)
- 4.0L No Start Wires & Cables Damaged By Battery Acid (94-8-14)