Technical Service Bulletins
- A/C Compressor
- Filtering Refrigerant After Compressor Replacement (98-12-5)
- Identification Of Non-Ford Approved Refrigerants (99-19-6)
- A/C - R-12 To R-134A Retrofit Kit - Factory A/C Only (98-4-8)
- Air Conditioning - O-Ring Availability/Applications (96-20-7)
- New Thicker O-Rings For Spring Lock Fittings (96-20-8)
- Use Of R-12 Refrigerant Substitutes (96-17-10)
- A/C System Service - List Of Bulletins To Reference (96-15-6)
- Ford Approved Flushing Procedures For A/C System (95-8-1)
- Air Conditioning Adding Refrigerant Oil Service Tip (95-5-12)
- R-12 Refrigerant Substitutes - Service Tip (94-14-3)
- Use Of Correct Fluorescent Tracer Dye - Service Tip (93-20-6)
- Accessories Control Systems
- Aerodynamic Devices
- Air Bag, SRS
- Anti-Lock Brakes
- Anti-Theft Systems
- Remote Keyless Entry (RKE) - Service Tips (03-18-1)
- Remote Keyless Entry Diagnostic Service Tips (97-24-13)
- Service Procedure Modification For Door Replacement (97-11-1)
- Air Bag Diagnostic Light Flashing - Fault Code 51 (96-25-4)
- Improved Lock Assembly For Glove Compartment (95-17-4)
- Anti-Theft Protection System - Recap Of TSB'S - Tips (94-25-5)
- Remote Keyless Entry System Service Tips (94-4-3)
- Remote Keyless Entry System - Service Information (93-4-3)
- "Mil" Lamp Service Tips (92-4-4)
- Door Lock Inoperative At Temperatures Below Freezing (94-8-6)
- Automatic Trans
- MERCON ATF Is Being Replaced By MERCON V ATF As A Service Fluid (06-14-4)
- New Transmission Cooler Flusher - Service Tips (03-14-8)
- Transmission Flush/Fill Tool Available From Rotunda (99-15-2)
- Transmission Fluid Usage Chart (98-8-8)
- 4EAT With 2.0L/2.5L - Harsh Shift From 1ST To 2ND (97-7-4)
- Torque Converter Replacement - Cooling SYS. Cleaning (96-26-12)
- Fluid Leakage From Outer CV Joint Boot (96-25-16)
- Torque Converter Leak Test Procedure - New Tool (96-24-9)
- New Rotunda Fluid Changer - Service Tip (95-16-10)
- 4EAT A/T (2.0L) Harsh Downshift: New Pcm (92-24-9)
- Auxiliary Emission Control Systems
- 2.0L - Hard/No Start - New Distributor Stator (00-17-1)
- Lean DRIVEABILITY Symptoms: MAF Sensor Contamination (98-23-10)
- DTC 181 Or P0171/Hesitation/Rough Idle/Power Loss (97-3-3)
- 2.0L - Reduced Power During ACCELERATON (96-23-2)
- Mass Air Flow Sensor Replacement As An Assembly (96-22-5)
- 2.5L - Revised Wiring For EGR Valve (95-5-7)
- EXH Gas Oxygen Sensor Silicone Sealer Contamination (93-23-6)
- Electronic Diagnostic Tools/Adapters Availability (93-5-5)
- New Generation "Star Tester": Proper Connection (93-2-4)
- Emission Control - Part & System Names Standardized (92-11-7)
- Exhaust System Noise - Loose Muffler/Catalyst Shield (98-6-4)
- Axle Shafts
- Blowers, Superchargers & Turbochargers
- Body Interior
- A/C Musty & Mildew Type Odors - New A/C DISODORIZER (98-2-7)
- Air Bag Diagnostic Light Flashing - Fault Code 51 (96-25-4)
- Electrical Diode Identification And Replacements (96-24-6)
- Erratic Distance-To-Empty & Fuel Gauge Readings (95-2-3)
- Oil Pressure Gauge Reads In Low Range (93-20-8)
- Electronic Diagnostic Tools/Adapters Availability (93-5-5)
- "Mil" Lamp Service Tips (92-4-4)
- Door Lock Inoperative At Temperatures Below Freezing (94-8-6)
- Brakes Control Systems
- Charging Systems
- Clutch
- Communication Devices
- Cooling Fan
- Cooling System (Mechanical)
- Ford Motor Company Position On Engine Coolant Made From Propylene Glycol (96-16-4)
- 2.0L - Hard/No Start - New Distributor Stator (00-17-1)
- Lean DRIVEABILITY Symptoms: MAF Sensor Contamination (98-23-10)
- Leaks Oil - New Silicone Gasket & Sealant (98-7-4)
- DTC 181 Or P0171/Hesitation/Rough Idle/Power Loss (97-3-3)
- 2.0L - Reduced Power During ACCELERATON (96-23-2)
- Use Of Recycled Engine Coolant - Service Tip (95-18-2)
- 2.5L - Water Pump & Pulley Modification (95-2-5)
- Engine Gasket Surface Cleaning Procedures (93-23-14)
- Cooling System - Proper Fluid Concentrations (93-1-10)
- Premature GENL Eng Wear: Grinding Disc Use Not RECMD (92-25-2)
- Cruise Control Systems
- Differentials & Drive Axles
- Driveshaft & Universal Joints
- Electronic Steering
- Electronic Suspension
- Engine Control Systems
- Whining/Buzzing - Comes Through Speakers Of Entertainment Or Two-Way Radio (02-16-4)
- 2.0L - Hard/No Start - New Distributor Stator (00-17-1)
- Fuel Pump Whine/Buzz Noise In Radio Speakers (99-12-9)
- Volatility Related DRIVEABILITY Concerns Service Tip (98-26-2)
- Lean DRIVEABILITY Symptoms: MAF Sensor Contamination (98-23-10)
- DTC 181 Or P0171/Hesitation/Rough Idle/Power Loss (97-3-3)
- 2.0L - Reduced Power During ACCELERATON (96-23-2)
- Mass Air Flow Sensor Replacement As An Assembly (96-22-5)
- 2.0L- Stalls/Runs Rough/Ticking From Lash Adjusters (96-21-3)
- Intermittent Check Engine Light With Codes 17 & 24 (95-21-5)
- 2.0L - Hard/No Start - Fuel Shutoff Lamp Illuminated (95-5-8)
- 3.0L Eng Fuel Pump "Gurgling" When Hot:New Check VLV (93-11-3)
- Electronic Diagnostic Tools/Adapters Availability (93-5-5)
- New Generation "Star Tester": Proper Connection (93-2-4)
- Entertainment Systems
- Exhaust
- Exterior Body Panels
- Exterior Lights
- Front Suspension
- Fuel System
- Whining/Buzzing - Comes Through Speakers Of Entertainment Or Two-Way Radio (02-16-4)
- 2.0L - Hard/No Start - New Distributor Stator (00-17-1)
- Volatility Related DRIVEABILITY Concerns Service Tip (98-26-2)
- Lean DRIVEABILITY Symptoms: MAF Sensor Contamination (98-23-10)
- Fuel Injector - Non Warranty Reimbursement Testing (98-9-9)
- DTC 181 Or P0171/Hesitation/Rough Idle/Power Loss (97-3-3)
- 2.0L - Reduced Power During ACCELERATON (96-23-2)
- Mass Air Flow Sensor Replacement As An Assembly (96-22-5)
- CALIFORNIA Reformulated Gasoline - Service Tip (96-10-7)
- 2.0L - Hard/No Start - Fuel Shutoff Lamp Illuminated (95-5-8)
- Obsolete Fuel Pump & Bracket: Returning Parts (94-2-15)
- 3.0L Eng Fuel Pump "Gurgling" When Hot:New Check VLV (93-11-3)
- Fuses & Circuit Breakers
- Wiring - Wire Harness Terminal Repair Kit (99-6-3)
- Electrical - New Terminal Grease For Service (98-24-6)
- Air Bag Diagnostic Light Flashing - Fault Code 51 (96-25-4)
- Electrical Diode Identification And Replacements (96-24-6)
- 2.0L - Hard/No Start - Fuel Shutoff Lamp Illuminated (95-5-8)
- Inoperative Power Door Locks Due To Wiring Corrosion (94-16-8)
- 2.5L - Revised Wiring For EGR Valve (95-5-7)
- Air Bag Light Comes On - Module Displays Code 34 (93-17-3)
- Gauges & Instrument Panels
- Headlights
- Heated Glass/Defoggers
- HVAC Control Systems
- Climate Control - Repeat Heater Core Failure (01-15-6)
- A/C Musty & Mildew Type Odors - New A/C DISODORIZER (98-2-7)
- Filtering Refrigerant After Compressor Replacement (98-12-5)
- Identification Of Non-Ford Approved Refrigerants (99-19-6)
- A/C - R-12 To R-134A Retrofit Kit - Factory A/C Only (98-4-8)
- On-Vehicle Pressure Test Required For Warranty Claim (97-19-11)
- Air Conditioning - O-Ring Availability/Applications (96-20-7)
- New Thicker O-Rings For Spring Lock Fittings (96-20-8)
- Use Of R-12 Refrigerant Substitutes (96-17-10)
- A/C System Service - List Of Bulletins To Reference (96-15-6)
- Ford Approved Flushing Procedures For A/C System (95-8-1)
- A/C Evaporator Core On-Vehicle Leak Test Procedure (95-13-1)
- Air Conditioning Adding Refrigerant Oil Service Tip (95-5-12)
- A/C "O" Ring Removal From Spring Lock Coupling (95-2-2)
- R-12 Refrigerant Substitutes - Service Tip (94-14-3)
- Use Of Correct Fluorescent Tracer Dye - Service Tip (93-20-6)
- Ignition Switch/Steering Lock
- Ignition System
- 2.0L - Hard/No Start - New Distributor Stator (00-17-1)
- Lean DRIVEABILITY Symptoms: MAF Sensor Contamination (98-23-10)
- 2.5L - Hard Start/Stall After Hot Soak (98-7-1)
- DTC 181 Or P0171/Hesitation/Rough Idle/Power Loss (97-3-3)
- Fuel Economy - Customer Expectations (99-26-9)
- 2.0L - Reduced Power During ACCELERATON (96-23-2)
- Infotainment
- Interior/Exterior Trim
- Interior/Illumination Lights
- Locking Hubs
- Lubrication System
- Motor Oil - Sae Viscosity Grade Recommendation (99-8-16)
- Leaks Oil - New Silicone Gasket & Sealant (98-7-4)
- 2.0L- Stalls/Runs Rough/Ticking From Lash Adjusters (96-21-3)
- Engine Gasket Surface Cleaning Procedures (93-23-14)
- 2.0L & 2.5L Ticking Noise Due To Oil Contamination (93-22-7)
- Premature GENL Eng Wear: Grinding Disc Use Not RECMD (92-25-2)
- Manual Steering
- Manual Trans
- Mechanical
- 2.0L - Hard/No Start - New Distributor Stator (00-17-1)
- Lean DRIVEABILITY Symptoms: MAF Sensor Contamination (98-23-10)
- Leaks Oil - New Silicone Gasket & Sealant (98-7-4)
- DTC 181 Or P0171/Hesitation/Rough Idle/Power Loss (97-3-3)
- 2.5L - Tapping Noise From Rear Cylinder Head (97-17-13)
- 2.5L - Upper Engine Noises - Clatter/Tick/Tap/Knock (97-17-14)
- Fuel Economy - Customer Expectations (99-26-9)
- 2.0L - Reduced Power During ACCELERATON (96-23-2)
- 2.0L- Stalls/Runs Rough/Ticking From Lash Adjusters (96-21-3)
- 2.5L - Cylinder Head And Piston Modification (95-10-4)
- 2.5L Engine Seal Plate Modification Revised Hardware (94-21-4)
- 2.0L Valve Spring Retainer & Upper Seat Part Changes (94-16-10)
- 2.5L MTX Drone Noise From No. 1 Engine Mount (94-9-8)
- Engine Gasket Surface Cleaning Procedures (93-23-14)
- 2.0L & 2.5L Ticking Noise Due To Oil Contamination (93-22-7)
- 2.0L Eng Idle Vibration/Resonance: Mount Clearance (93-18-8)
- Premature GENL Eng Wear: Grinding Disc Use Not RECMD (92-25-2)
- Mechanical - Hydraulic
- Brakes - Elimination Of Sanding Rotors & Drums (98-5A-11)
- Brakes - Hub-Mount Brake Rotor Machining Equipment (98-5A-5)
- Silicone Brake Caliper Grease Requirement (98-5A-13)
- Wheels - Proper Lug Torque Procedures - Service Tip (98-5A-4)
- Brake & Rotor Service Tips (97-19-4)
- Brakes - Roughness Concern During Brake Application (95-6-2)
- On-Vehicle Caliper Mounted Brake Rotor Machining EQP (94-25-2)
- Front Brakes Grinding On Moderate To Heavy Braking (93-23-5)
- Guidelines For Brake Vibration Repair & Replacement (99-19-4)
- Memory Modules
- Mirrors
- Various Vehicles - Rear-View Mirror Concern Analysis (23-7092)
- Rear View Mirror - Preferred Reattachment Method (97-17-2)
- Air Bag Diagnostic Light Flashing - Fault Code 51 (96-25-4)
- Headlamp Door Operates Intermittent Or Continuously (95-14-3)
- Rear View Mirror Detaches From Windshield (94-17-2)
- Inoperative Power Door Locks Due To Wiring Corrosion (94-16-8)
- Service Parts Return Of Obsolete Power Window Switch (94-12-5)
- "Mil" Lamp Service Tips (92-4-4)
- Overdrive Unit
- Paint & Coatings
- Urethane Mounted Glass Material Usage Procedure (95-12-1)
- Paint Iron Particle Removal/Acid Rain Neutralization (95-6-1)
- Primed Sheet Metal Prep Procedure & MSDS Information (94-23-4)
- Rear View Mirror Detaches From Windshield (94-17-2)
- Exterior CLEARCOAT MICROCHECKING, Hazing Or Peeling (93-8-4)
- 1993 Ford, LINCOLN-Mercury Paint Codes (92-20-1)
- Iron Particle Removal From Paint (92-6-4)
- Passive Restraints
- Rear Suspension
- Restraints Control Systems
- Seats
- Leather Seat Cleaning Procedure - Service Tip (98-17-1)
- Air Bag Diagnostic Light Flashing - Fault Code 51 (96-25-4)
- Headlamp Door Operates Intermittent Or Continuously (95-14-3)
- Inoperative Power Door Locks Due To Wiring Corrosion (94-16-8)
- Service Parts Return Of Obsolete Power Window Switch (94-12-5)
- "Mil" Lamp Service Tips (92-4-4)
- Starter
- Steering Column
- Steering Control Systems
- Steering Gear
- Steering Linkage
- Sun Roof/T-Top/Convertible Top
- Suspension Control Systems
- System
- Whining/Buzzing - Comes Through Speakers Of Entertainment Or Two-Way Radio (02-16-4)
- 2.0L - Hard/No Start - New Distributor Stator (00-17-1)
- Fuel Pump Whine/Buzz Noise In Radio Speakers (99-12-9)
- Volatility Related DRIVEABILITY Concerns Service Tip (98-26-2)
- Lean DRIVEABILITY Symptoms: MAF Sensor Contamination (98-23-10)
- Fuel Injector - Non Warranty Reimbursement Testing (98-9-9)
- 2.5L - Hard Start/Stall After Hot Soak (98-7-1)
- Leaks Oil - New Silicone Gasket & Sealant (98-7-4)
- DTC 181 Or P0171/Hesitation/Rough Idle/Power Loss (97-3-3)
- Fuel Economy - Customer Expectations (99-26-9)
- 2.0L - Reduced Power During ACCELERATON (96-23-2)
- Mass Air Flow Sensor Replacement As An Assembly (96-22-5)
- 2.0L- Stalls/Runs Rough/Ticking From Lash Adjusters (96-21-3)
- CALIFORNIA Reformulated Gasoline - Service Tip (96-10-7)
- Intermittent Check Engine Light With Codes 17 & 24 (95-21-5)
- 2.0L - Hard/No Start - Fuel Shutoff Lamp Illuminated (95-5-8)
- Obsolete Fuel Pump & Bracket: Returning Parts (94-2-15)
- 2.5L - Revised Wiring For EGR Valve (95-5-7)
- Engine Gasket Surface Cleaning Procedures (93-23-14)
- EXH Gas Oxygen Sensor Silicone Sealer Contamination (93-23-6)
- 3.0L Eng Fuel Pump "Gurgling" When Hot:New Check VLV (93-11-3)
- Electronic Diagnostic Tools/Adapters Availability (93-5-5)
- New Generation "Star Tester": Proper Connection (93-2-4)
- Premature GENL Eng Wear: Grinding Disc Use Not RECMD (92-25-2)
- Emission Control - Part & System Names Standardized (92-11-7)
- Exhaust System Noise - Loose Muffler/Catalyst Shield (98-6-4)
- Towing
- Transfer Case
- Transmission Control Systems
- Vacuum Pumps/Lines/Tanks/Water Trap
- Warning Systems
- Wheel Alignment
- Wheels & Tire System
- Window Motors & Regulators
- Front Door Glass Adjustment Procedure For WINDNOISE (97-19-1)
- Windshield And Interior Glass - Fog/Film (96-22-1)
- Headlamp Door Operates Intermittent Or Continuously (95-14-3)
- Urethane Mounted Glass Material Usage Procedure (95-12-1)
- Rear View Mirror Detaches From Windshield (94-17-2)
- Inoperative Power Door Locks Due To Wiring Corrosion (94-16-8)
- Service Parts Return Of Obsolete Power Window Switch (94-12-5)
- Front Door Glass Adjustment Procedure (93-3-2)
- Wiper/Washer Systems
- Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)
- Wiring - Wire Harness Terminal Repair Kit (99-6-3)
- Electrical - New Terminal Grease For Service (98-24-6)
- Air Bag Diagnostic Light Flashing - Fault Code 51 (96-25-4)
- Electrical Diode Identification And Replacements (96-24-6)
- 2.0L - Hard/No Start - Fuel Shutoff Lamp Illuminated (95-5-8)
- Erratic Distance-To-Empty & Fuel Gauge Readings (95-2-3)
- Inoperative Power Door Locks Due To Wiring Corrosion (94-16-8)
- 2.5L - Revised Wiring For EGR Valve (95-5-7)
- Oil Pressure Gauge Reads In Low Range (93-20-8)
- Air Bag Light Comes On - Module Displays Code 34 (93-17-3)