Technical Service Bulletins
- A/C Compressor
- Climate Control - A/C Service Tech Tips (02-20-8)
- Filtering Refrigerant After Compressor Replacement (98-12-5)
- Identification Of Non-Ford Approved Refrigerants (99-19-6)
- A/C Refrigerant Oil Refill Capacity Chart (97-15-5)
- A/C Compressor Failure Due To Insufficient Oil (97-10-5)
- Air Conditioning - O-Ring Availability/Applications (96-20-7)
- New Thicker O-Rings For Spring Lock Fittings (96-20-8)
- A/C System Service - List Of Bulletins To Reference (96-15-6)
- Accessory Drive Belt Edge Wear And/Or MISTRACKING (96-5-8)
- 4.6L - Squeal From FEAD At Temps Below -7 Degrees C (96-14-8)
- R-134A Tracer Dye Installed In The A/C System - Tip (95-21-4)
- Ford Approved Flushing Procedures For A/C System (95-8-1)
- Air Conditioning Adding Refrigerant Oil Service Tip (95-5-12)
- Release Of R-134A Fluorescent Tracer Dye (94-26-6)
- A/C - Little/No Cooling - Excessive Clutch Air Gap (94-23-9)
- Refrigerant Oil Visible At Spring Lock Couplers (94-20-6)
- Accessories Control Systems
- Electrical - Revised Mechanical Hood Lamp Switch To Replace Old Style Mercury Hood Lamp Switch (01-21-6)
- Incorrect Diagnosis Of Air Bag Code 24 - Service Tip (95-22-8)
- Temp. Gauge Reads Low - Obsolete Temperature Sender (95-13-2)
- Radio Distortion/Poor Reception From 5.0L Ignition (95-9-3)
- Air Bag DTC Retrieval Programming Change (94-26-2)
- Accessory Drive Belts
- Air Bag, SRS
- Anti-Lock Brakes
- Anti-Theft Systems
- Remote Keyless Entry (RKE) - Service Tips (03-18-1)
- Hood Requires Excessive Effort To Close (00-21-2)
- Interior Trim - Door Trim Panel Replacement (99-8-15)
- Front Window Travels Beyond UPSTOP & Out Of Run (98-25-3)
- Remote Keyless Entry Diagnostic Service Tips (97-24-13)
- Incorrect Diagnosis Of Air Bag Code 24 - Service Tip (95-22-8)
- Air Bag DTC Retrieval Programming Change (94-26-2)
- Automatic Trans
- MERCON ATF Is Being Replaced By MERCON V ATF As A Service Fluid (06-14-4)
- 4R70W - New Service Part - Number 5 Needle Bearing And Race Kit (03-26-1)
- New Transmission Cooler Flusher - Service Tips (03-14-8)
- E4OD/4R100 - Fluid In-Line Filter Kit (00-3-8)
- Transmission Flush/Fill Tool Available From Rotunda (99-15-2)
- Noise/Vibration/Harshness Diagnostic Procedure (99-11-1)
- AODE/4R70W - Forward Clutch Service Kit (98-10-8)
- AODE/4R70W - Shudder On Acceleration In 3RD/4TH Gear (98-8-7)
- Transmission Fluid Usage Chart (98-8-8)
- AODE - Extension Housing Bushing Walkout/Spin (97-19-13)
- AODE/4R70W - Main Control & Case Usage For Prior Mod (97-16-7)
- 4R70W/AODE - Erratic Or Prolonged 1-2 Shift (97-11-11)
- Torque Converter Replacement - Cooling SYS. Cleaning (96-26-12)
- AODE/4R70W - Shudder Under Light Acceleration (96-25-17)
- Torque Converter Leak Test Procedure - New Tool (96-24-9)
- Traction-LOK Differential - Chatter On Tight Turns (96-12-9)
- AODE/4R70W - Shift And/Or Engagement Concerns - DTC (95-3-13)
- AODE/4R7OW Shudder Or Vibration (95-23-4)
- New Rotunda Fluid Changer - Service Tip (95-16-10)
- AODE/4R70W Reusable Oil Pan Gasket (95-8-4)
- AODE/4R70W Loss Of Torque During/After 3-4 Upshift (95-5-15)
- Auxiliary Emission Control Systems
- DRIVEABILITY - Ho2S, Catalyst & Fuel System Monitors - Service Tips - OBD II (01-9-7)
- Reprogramming Pcm Out Of Vehicle - EEC V Only (99-4-3)
- Lean DRIVEABILITY Symptoms: MAF Sensor Contamination (98-23-10)
- Delta Pressure Feedback EGR - Diagnostic Tips (97-22-1)
- Powertrain Control Module Reprogram - Service Tip (97-9-8)
- Mass Air Flow Sensor Replacement As An Assembly (96-22-5)
- Squeal/Hoot From FEAD At Temps Below -18 Degrees C (96-14-9)
- NGS Tester Displays Incorrect Info. During Test (96-10-6)
- Throttle Position Sensor Function & Diagnostic Tips (94-26-4)
- Exhaust System Noise - Loose Muffler/Catalyst Shield (98-6-4)
- Axle Shafts
- Blowers, Superchargers & Turbochargers
- Body Interior
- A/C Musty & Mildew Type Odors - New A/C DISODORIZER (98-2-7)
- Service Parts Return Of Obsolete A/C Pressure Switch (97-19-12)
- Electrical Diode Identification And Replacements (96-24-6)
- Incorrect Diagnosis Of Air Bag Code 24 - Service Tip (95-22-8)
- Temp. Gauge Reads Low - Obsolete Temperature Sender (95-13-2)
- Radio Distortion/Poor Reception From 5.0L Ignition (95-9-3)
- Air Bag DTC Retrieval Programming Change (94-26-2)
- Brakes Control Systems
- Charging Systems
- Clutch
- Communication Devices
- Cooling System (Mechanical)
- Ford Motor Company Position On Engine Coolant Made From Propylene Glycol (96-16-4)
- Lean DRIVEABILITY Symptoms: MAF Sensor Contamination (98-23-10)
- Leaks Oil - New Silicone Gasket & Sealant (98-7-4)
- Engine Cooling Fan - Module Component Service Info. (97-10-4)
- Use Of Recycled Engine Coolant - Service Tip (95-18-2)
- 5.0L - Revised Oil Pan Gasket Replacement Procedure (95-6-8)
- Throttle Position Sensor Function & Diagnostic Tips (94-26-4)
- Cooling System - Radiator - New Manufacturing PROCES (95-2-4)
- Cruise Control Systems
- Differentials & Drive Axles
- Driveshaft & Universal Joints
- Engine Control Systems
- Whining/Buzzing - Comes Through Speakers Of Entertainment Or Two-Way Radio (02-16-4)
- DRIVEABILITY - Ho2S, Catalyst & Fuel System Monitors - Service Tips - OBD II (01-9-7)
- Fuel Pump Whine/Buzz Noise In Radio Speakers (99-12-9)
- Reprogramming Pcm Out Of Vehicle - EEC V Only (99-4-3)
- Volatility Related DRIVEABILITY Concerns Service Tip (98-26-2)
- Lean DRIVEABILITY Symptoms: MAF Sensor Contamination (98-23-10)
- Powertrain Control Module Reprogram - Service Tip (97-9-8)
- Mass Air Flow Sensor Replacement As An Assembly (96-22-5)
- NGS Tester Displays Incorrect Info. During Test (96-10-6)
- Throttle Position Sensor Function & Diagnostic Tips (94-26-4)
- Fuel Pressure Specifications Revised - Manual Update (94-24B-1)
- Entertainment Systems
- Exhaust
- Exterior Body Panels
- Exterior Lights
- Front Suspension
- Fuel System
- Whining/Buzzing - Comes Through Speakers Of Entertainment Or Two-Way Radio (02-16-4)
- DRIVEABILITY - Ho2S, Catalyst & Fuel System Monitors - Service Tips - OBD II (01-9-7)
- Volatility Related DRIVEABILITY Concerns Service Tip (98-26-2)
- Lean DRIVEABILITY Symptoms: MAF Sensor Contamination (98-23-10)
- Fuel Injector - Non Warranty Reimbursement Testing (98-9-9)
- Mass Air Flow Sensor Replacement As An Assembly (96-22-5)
- CALIFORNIA Reformulated Gasoline - Service Tip (96-10-7)
- Accelerator Cable Diagnostic Procedure (95-1-2)
- Fuel Pressure Specifications Revised - Manual Update (94-24B-1)
- Fuses & Circuit Breakers
- Gauges & Instrument Panels
- Headlights
- HVAC Control Systems
- Climate Control - A/C Service Tech Tips (02-20-8)
- Air Conditioning - Musty And Mildew Type Odors - Service Procedure (99-19-5)
- Climate Control - Repeat Heater Core Failure (01-15-6)
- A/C Musty & Mildew Type Odors - New A/C DISODORIZER (98-2-7)
- Filtering Refrigerant After Compressor Replacement (98-12-5)
- Identification Of Non-Ford Approved Refrigerants (99-19-6)
- Blower Motor Chirp Or Squeak At Low Speeds (97-6-10)
- On-Vehicle Pressure Test Required For Warranty Claim (97-19-11)
- A/C Refrigerant Oil Refill Capacity Chart (97-15-5)
- A/C Compressor Failure Due To Insufficient Oil (97-10-5)
- Blower Motor Inoperative Below 32 Degrees F (96-26-8)
- Air Conditioning - O-Ring Availability/Applications (96-20-7)
- New Thicker O-Rings For Spring Lock Fittings (96-20-8)
- A/C System Service - List Of Bulletins To Reference (96-15-6)
- R-134A Tracer Dye Installed In The A/C System - Tip (95-21-4)
- Ford Approved Flushing Procedures For A/C System (95-8-1)
- A/C Evaporator Core On-Vehicle Leak Test Procedure (95-13-1)
- Air Conditioning Adding Refrigerant Oil Service Tip (95-5-12)
- A/C "O" Ring Removal From Spring Lock Coupling (95-2-2)
- Release Of R-134A Fluorescent Tracer Dye (94-26-6)
- A/C - Little/No Cooling - Excessive Clutch Air Gap (94-23-9)
- Temp Control Knob Does Not Reach Full Cold Position (94-22-6)
- Refrigerant Oil Visible At Spring Lock Couplers (94-20-6)
- Ignition System
- Infotainment
- Interior/Exterior Trim
- Interior/Illumination Lights
- Locking Hubs
- Lubrication System
- Engine Oil - Recommended Applications For Sae 5W-20 And Sae 5W-30 Motor Oils (02-1-9)
- Engine - Engine Oil System Priming Procedures - Service Tips (01-24-6)
- Motor Oil - Sae Viscosity Grade Recommendation (99-8-16)
- Leaks Oil - New Silicone Gasket & Sealant (98-7-4)
- 5.0L - Revised Oil Pan Gasket Replacement Procedure (95-6-8)
- 5.0L/5.8L - Revised Oil Fill Procedure - Service Tip (95-5-14)
- Manual Steering
- Manual Trans
- Mechanical
- Hydraulic Versus Mechanical TENSIONERS (TT001-13)
- New Gasket Remover/Cleaner Service Tips For Aluminum Heads & Blocks (02-11-4)
- Machining Of Aluminum Cylinder Heads Or Blocks - Warranty Information (02-2-3)
- Engine - Approved Head Gasket Replacement Service Procedures (02-1-4)
- Engine Oil - Recommended Applications For Sae 5W-20 And Sae 5W-30 Motor Oils (02-1-9)
- Engine - Engine Oil System Priming Procedures - Service Tips (01-24-6)
- Noise/Vibration/Harshness Diagnostic Procedure (99-11-1)
- Lean DRIVEABILITY Symptoms: MAF Sensor Contamination (98-23-10)
- Leaks Oil - New Silicone Gasket & Sealant (98-7-4)
- Fuel Economy - Customer Expectations (99-26-9)
- Accessory Drive Belt Edge Wear And/Or MISTRACKING (96-5-8)
- 4.6L - Squeal From FEAD At Temps Below -7 Degrees C (96-14-8)
- Squeal/Hoot From FEAD At Temps Below -18 Degrees C (96-14-9)
- 3.8L Low Pitched Squeak/Chirp/Knock From Rocker Arms (95-24-3)
- 5.0L - Revised Oil Pan Gasket Replacement Procedure (95-6-8)
- 5.0L - New Torque-To-YEILD Cylinder Head Bolts (95-3-10)
- Mechanical - Hydraulic
- Noise/Vibration/Harshness Diagnostic Procedure (99-11-1)
- Brakes - Elimination Of Sanding Rotors & Drums (98-5A-11)
- Brakes - Hub-Mount Brake Rotor Machining Equipment (98-5A-5)
- Rear Brakes Squeak - New Brake Pads (98-5A-10)
- Silicone Brake Caliper Grease Requirement (98-5A-13)
- Wheels - Proper Lug Torque Procedures - Service Tip (98-5A-4)
- Brake & Rotor Service Tips (97-19-4)
- Brakes - Roughness Concern During Brake Application (95-6-2)
- On-Vehicle Caliper Mounted Brake Rotor Machining EQP (94-25-2)
- Front Disc Thumping/Clacking While Braking (94-23-5)
- Guidelines For Brake Vibration Repair & Replacement (99-19-4)
- Memory Modules
- Mirrors
- Various Vehicles - Rear-View Mirror Concern Analysis (23-7092)
- Exterior Mirror Glass And Motor Replacement (98-9-14)
- Rear View Mirror - Preferred Reattachment Method (97-17-2)
- Incorrect Diagnosis Of Air Bag Code 24 - Service Tip (95-22-8)
- Air Bag DTC Retrieval Programming Change (94-26-2)
- Rear View Mirror Detaches From Windshield (94-17-2)
- Overdrive Unit
- Paint & Coatings
- Water Leaks - Windshield Sealing - Service Tip (99-2-3)
- Urethane Mounted Glass Material Usage Procedure (95-12-1)
- 1995 Paint Color Chart - Aftermarket Supplier List (95-7-2)
- Paint Iron Particle Removal/Acid Rain Neutralization (95-6-1)
- Primed Sheet Metal Prep Procedure & MSDS Information (94-23-4)
- Rear View Mirror Detaches From Windshield (94-17-2)
- Parking Brake System
- Passive Restraints
- Rear Suspension
- Restraints Control Systems
- Seats
- Solar Ventilation
- Starter
- Steering Gear
- Steering Linkage
- Sun Roof/T-Top/Convertible Top
- Hood Requires Excessive Effort To Close (00-21-2)
- Water Leaks - Windshield Sealing - Service Tip (99-2-3)
- Convertible Top Boot Fits Improperly (99-22-5)
- Noise/Vibration/Harshness Diagnostic Procedure (99-11-1)
- Front Window Travels Beyond UPSTOP & Out Of Run (98-25-3)
- Convertible Top Leaks Water (97-24-1)
- Replacement Convertible Top Different From Original (96-4-1)
- Rear View Mirror Detaches From Windshield (94-17-2)
- System
- Whining/Buzzing - Comes Through Speakers Of Entertainment Or Two-Way Radio (02-16-4)
- Engine - Approved Head Gasket Replacement Service Procedures (02-1-4)
- DRIVEABILITY - Ho2S, Catalyst & Fuel System Monitors - Service Tips - OBD II (01-9-7)
- Fuel Pump Whine/Buzz Noise In Radio Speakers (99-12-9)
- Reprogramming Pcm Out Of Vehicle - EEC V Only (99-4-3)
- Volatility Related DRIVEABILITY Concerns Service Tip (98-26-2)
- Lean DRIVEABILITY Symptoms: MAF Sensor Contamination (98-23-10)
- Fuel Injector - Non Warranty Reimbursement Testing (98-9-9)
- Leaks Oil - New Silicone Gasket & Sealant (98-7-4)
- Delta Pressure Feedback EGR - Diagnostic Tips (97-22-1)
- Powertrain Control Module Reprogram - Service Tip (97-9-8)
- Fuel Economy - Customer Expectations (99-26-9)
- Mass Air Flow Sensor Replacement As An Assembly (96-22-5)
- CALIFORNIA Reformulated Gasoline - Service Tip (96-10-7)
- NGS Tester Displays Incorrect Info. During Test (96-10-6)
- 5.0L - Revised Oil Pan Gasket Replacement Procedure (95-6-8)
- Accelerator Cable Diagnostic Procedure (95-1-2)
- Throttle Position Sensor Function & Diagnostic Tips (94-26-4)
- Fuel Pressure Specifications Revised - Manual Update (94-24B-1)
- Exhaust System Noise - Loose Muffler/Catalyst Shield (98-6-4)
- Transfer Case
- Transmission Control Systems
- Inadvertent Disabling Of Brake Shift Interlock (99-13-9)
- AODE/4R70W - Shudder On Acceleration In 3RD/4TH Gear (98-8-7)
- Powertrain Control Module Reprogram - Service Tip (97-9-8)
- AODE/4R70W - Shudder Under Light Acceleration (96-25-17)
- AODE/4R70W - Shift And/Or Engagement Concerns - DTC (95-3-13)
- AODE/4R7OW Shudder Or Vibration (95-23-4)
- Vacuum Pumps/Lines/Tanks/Water Trap
- Warning Systems
- Wheels & Tire System
- Window Motors & Regulators
- Hood Requires Excessive Effort To Close (00-21-2)
- Water Leaks - Windshield Sealing - Service Tip (99-2-3)
- Noise/Vibration/Harshness Diagnostic Procedure (99-11-1)
- Front Window Travels Beyond UPSTOP & Out Of Run (98-25-3)
- Convertible Top Leaks Water (97-24-1)
- Windshield And Interior Glass - Fog/Film (96-22-1)
- Urethane Mounted Glass Material Usage Procedure (95-12-1)
- Rear View Mirror Detaches From Windshield (94-17-2)
- Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)