Technical Service Bulletins
- A/C Compressor
- Climate Control - A/C Service Tech Tips (02-20-8)
- Filtering Refrigerant After Compressor Replacement (98-12-5)
- Identification Of Non-Ford Approved Refrigerants (99-19-6)
- R-134A Tracer Dye In A/C System - 3 O-Ring Couplers (97-3-5)
- A/C Refrigerant Oil Refill Capacity Chart (97-15-5)
- Heater-A/C Controls Inoperative (96-23-6)
- Air Conditioning - O-Ring Availability/Applications (96-20-7)
- New Thicker O-Rings For Spring Lock Fittings (96-20-8)
- A/C System Service - List Of Bulletins To Reference (96-15-6)
- Accessories Control Systems
- Air Bag, SRS
- Anti-Theft Systems
- Remote Keyless Entry (RKE) - Service Tips (03-18-1)
- Interior Trim - Door Trim Panel Replacement (99-8-15)
- Discharged Battery - Cooling Fan Not Turning Off (98-13-8)
- Remote Keyless Entry Diagnostic Service Tips (97-24-13)
- Remote Anti-Theft Personality Transmitter Reprogram (97-11-5)
- 2.0L - Gauges And/Or Cooling Fan Erratic Operation (96-17-11)
- Two Lock Designs Requiring Proper Key Cutter & Blank (96-17-5)
- Automatic Trans
- MERCON ATF Is Being Replaced By MERCON V ATF As A Service Fluid (06-14-4)
- New Transmission Cooler Flusher - Service Tips (03-14-8)
- Noise/Vibration/Harshness Diagnostic Procedure (99-11-1)
- Flushing Transmission Oil Cooler & Lines (98-13-12)
- Transmission Fluid Usage Chart (98-8-8)
- 4EAT - Delayed Engagement From Park To Drive/Reverse (97-15-11)
- Torque Converter Replacement - Cooling SYS. Cleaning (96-26-12)
- Torque Converter Leak Test Procedure - New Tool (96-24-9)
- Auxiliary Emission Control Systems
- General Pcm Programming Procedures (04-24-14)
- Mil With DTC'S P0442, P0455, P0456, P0457, P1442 Or Check Fuel Cap Lamp With DTC P0457 (03-9-8)
- DRIVEABILITY - Ho2S, Catalyst & Fuel System Monitors - Service Tips - OBD II (01-9-7)
- Reprogramming Pcm Out Of Vehicle - EEC V Only (99-4-3)
- Lean DRIVEABILITY Symptoms: MAF Sensor Contamination (98-23-10)
- Evaporative Emission Canister Components Available (98-15-12)
- Discharged Battery - Cooling Fan Not Turning Off (98-13-8)
- 2.0L SPI - Oil Leak From Dipstick Tube/PCV FREEZEING (98-10-5)
- 2.0L - Exhaust Noise From Behind Instrument Panel (97-4-4)
- 2.0L - DTC 0401/Mil Illuminated - EGR Hose Off (97-3-4)
- Delta Pressure Feedback EGR - Diagnostic Tips (97-22-1)
- 2.0L SPI - Hard Start/Long Crank Time (97-21-5)
- Evaporative Emissions - Workshop Manual Attachment (97-19A)
- Mil Lit/DTC P1443/No DRIVEABILITY Concerns (97-13-8)
- Powertrain Control Module Reprogram - Service Tip (97-9-8)
- Mil On/DTC P0300 Thru P0308/No DRIVEABILITY Concerns (97-8-6)
- 2.0L - Buzzing From EGR After Engine Is Shut Off (97-6-12)
- Mass Air Flow Sensor Replacement As An Assembly (96-22-5)
- Exhaust System Noise - Loose Muffler/Catalyst Shield (98-6-4)
- Axle Shafts
- Blowers, Superchargers & Turbochargers
- Body Interior
- A/C Musty & Mildew Type Odors - New A/C DISODORIZER (98-2-7)
- Discharged Battery - Cooling Fan Not Turning Off (98-13-8)
- Service Parts Return Of Obsolete A/C Pressure Switch (97-19-12)
- Electrical Diode Identification And Replacements (96-24-6)
- 2.0L - Gauges And/Or Cooling Fan Erratic Operation (96-17-11)
- Communication Devices
- Cooling System (Mechanical)
- Ford Motor Company Position On Engine Coolant Made From Propylene Glycol (96-16-4)
- Lean DRIVEABILITY Symptoms: MAF Sensor Contamination (98-23-10)
- 2.0L SPI - Oil Leak From Dipstick Tube/PCV FREEZEING (98-10-5)
- Leaks Oil - New Silicone Gasket & Sealant (98-7-4)
- 2.0L - DTC 0401/Mil Illuminated - EGR Hose Off (97-3-4)
- 2.0L SPI - Hard Start/Long Crank Time (97-21-5)
- Mil Lit/DTC P1443/No DRIVEABILITY Concerns (97-13-8)
- Engine Cooling Fan - Module Component Service Info. (97-10-4)
- Cruise Control Systems
- Differentials & Drive Axles
- Driveshaft & Universal Joints
- Engine Control Systems
- General Pcm Programming Procedures (04-24-14)
- 2.0L SPI - Rough Idle, Low Power And/Or Stall At Idle With DTCS P0300-P0304 (04-9-1)
- Mil With DTC'S P0442, P0455, P0456, P0457, P1442 Or Check Fuel Cap Lamp With DTC P0457 (03-9-8)
- 2.0L SPI Or ZETEC - Idle Vibration (99-6-9)
- Whining/Buzzing - Comes Through Speakers Of Entertainment Or Two-Way Radio (02-16-4)
- DRIVEABILITY - Ho2S, Catalyst & Fuel System Monitors - Service Tips - OBD II (01-9-7)
- Fuel Pump Whine/Buzz Noise In Radio Speakers (99-12-9)
- Reprogramming Pcm Out Of Vehicle - EEC V Only (99-4-3)
- Volatility Related DRIVEABILITY Concerns Service Tip (98-26-2)
- Lean DRIVEABILITY Symptoms: MAF Sensor Contamination (98-23-10)
- Discharged Battery - Cooling Fan Not Turning Off (98-13-8)
- 2.0L - DTC 0401/Mil Illuminated - EGR Hose Off (97-3-4)
- 2.0L SPI - Hard Start/Long Crank Time (97-21-5)
- Mil Lit/DTC P1443/No DRIVEABILITY Concerns (97-13-8)
- Powertrain Control Module Reprogram - Service Tip (97-9-8)
- Mil On/DTC P0300 Thru P0308/No DRIVEABILITY Concerns (97-8-6)
- Mass Air Flow Sensor Replacement As An Assembly (96-22-5)
- Entertainment Systems
- Exhaust
- DRIVEABILITY - Ho2S, Catalyst & Fuel System Monitors - Service Tips - OBD II (01-9-7)
- Lean DRIVEABILITY Symptoms: MAF Sensor Contamination (98-23-10)
- 2.0L - Exhaust Noise From Behind Instrument Panel (97-4-4)
- 2.0L - Buzzing From EGR After Engine Is Shut Off (97-6-12)
- Exhaust System Noise - Loose Muffler/Catalyst Shield (98-6-4)
- Noise - Rattling/Squeaking - Summary Of Concerns (98-20-17)
- Exterior Body Panels
- Exterior Lights
- Frames, Subframes & Crossmembers
- Front Suspension
- Fuel System
- 2.0L SPI - Rough Idle, Low Power And/Or Stall At Idle With DTCS P0300-P0304 (04-9-1)
- Mil With DTC'S P0442, P0455, P0456, P0457, P1442 Or Check Fuel Cap Lamp With DTC P0457 (03-9-8)
- Whining/Buzzing - Comes Through Speakers Of Entertainment Or Two-Way Radio (02-16-4)
- DRIVEABILITY - Ho2S, Catalyst & Fuel System Monitors - Service Tips - OBD II (01-9-7)
- Volatility Related DRIVEABILITY Concerns Service Tip (98-26-2)
- Lean DRIVEABILITY Symptoms: MAF Sensor Contamination (98-23-10)
- Discharged Battery - Cooling Fan Not Turning Off (98-13-8)
- Fuel Injector - Non Warranty Reimbursement Testing (98-9-9)
- 2.0L - DTC 0401/Mil Illuminated - EGR Hose Off (97-3-4)
- 2.0L SPI - Hard Start/Long Crank Time (97-21-5)
- Mil Lit/DTC P1443/No DRIVEABILITY Concerns (97-13-8)
- Mass Air Flow Sensor Replacement As An Assembly (96-22-5)
- Fuses & Circuit Breakers
- Wiring - Wire Harness Terminal Repair Kit (99-6-3)
- Electrical - New Terminal Grease For Service (98-24-6)
- Discharged Battery - Cooling Fan Not Turning Off (98-13-8)
- Dome Lamp Inoperative/Intermittent Operation (98-1-9)
- 2.0L SPI - Hard Start/Long Crank Time (97-21-5)
- Electrical Diode Identification And Replacements (96-24-6)
- 2.0L - Gauges And/Or Cooling Fan Erratic Operation (96-17-11)
- Pre-Delivery - Installing Fuse For Accessories (96-12-8)
- Gauges & Instrument Panels
- Headlights
- HVAC Control Systems
- Climate Control - A/C Service Tech Tips (02-20-8)
- Air Conditioning - Musty And Mildew Type Odors - Service Procedure (99-19-5)
- Climate Control - Repeat Heater Core Failure (01-15-6)
- A/C Musty & Mildew Type Odors - New A/C DISODORIZER (98-2-7)
- Filtering Refrigerant After Compressor Replacement (98-12-5)
- Identification Of Non-Ford Approved Refrigerants (99-19-6)
- Blower Motor Chirp Or Squeak At Low Speeds (97-6-10)
- R-134A Tracer Dye In A/C System - 3 O-Ring Couplers (97-3-5)
- On-Vehicle Pressure Test Required For Warranty Claim (97-19-11)
- A/C Refrigerant Oil Refill Capacity Chart (97-15-5)
- A/C Clutch Cycling Pressure Switch Readings (97-8-7)
- Heater-A/C Controls Inoperative (96-23-6)
- Air Conditioning - O-Ring Availability/Applications (96-20-7)
- New Thicker O-Rings For Spring Lock Fittings (96-20-8)
- A/C System Service - List Of Bulletins To Reference (96-15-6)
- Ignition Switch/Steering Lock
- Ignition System
- Infotainment
- Interior/Exterior Trim
- Interior Trim - Door Trim Panel Replacement (99-8-15)
- WINDNOISE Around Side Doors (99-6-5)
- Interior Trim - Repairs To Vinyl Covered Surfaces (98-3-1)
- Whistling/Hooting At Upper A-Pillar Area (96-21-1)
- Wheel Covers - Bolt-On Wheel Covers - Service Tip (96-12-1)
- Foam Tape Visible At WIMDSHIELD & Instrument Panel (98-20-4)
- Noise - Rattling/Squeaking - Summary Of Concerns (98-20-17)
- Interior/Illumination Lights
- Lubrication System
- Engine Oil - Recommended Applications For Sae 5W-20 And Sae 5W-30 Motor Oils (02-1-9)
- Engine - Engine Oil System Priming Procedures - Service Tips (01-24-6)
- Motor Oil - Sae Viscosity Grade Recommendation (99-8-16)
- 2.0L SPI - Oil Leak From Dipstick Tube/PCV FREEZEING (98-10-5)
- Leaks Oil - New Silicone Gasket & Sealant (98-7-4)
- Manual Trans
- Mechanical
- Hydraulic Versus Mechanical TENSIONERS (TT001-13)
- 2.0L SPI - Rough Idle, Low Power And/Or Stall At Idle With DTCS P0300-P0304 (04-9-1)
- 2.0L SPI Or ZETEC - Idle Vibration (99-6-9)
- Engine - Straightedge Procedure For Checking Cylinder Head & Block Flatness (02-21-13)
- New Gasket Remover/Cleaner Service Tips For Aluminum Heads & Blocks (02-11-4)
- Machining Of Aluminum Cylinder Heads Or Blocks - Warranty Information (02-2-3)
- Engine - Approved Head Gasket Replacement Service Procedures (02-1-4)
- Engine Oil - Recommended Applications For Sae 5W-20 And Sae 5W-30 Motor Oils (02-1-9)
- Engine - Engine Oil System Priming Procedures - Service Tips (01-24-6)
- DRIVEABILITY - Detecting Vacuum Leaks - Using The Rotunda VACUTEC 522 Smoke Leak Detector Machine (01-20-5)
- Noise/Vibration/Harshness Diagnostic Procedure (99-11-1)
- Lean DRIVEABILITY Symptoms: MAF Sensor Contamination (98-23-10)
- Discharged Battery - Cooling Fan Not Turning Off (98-13-8)
- 2.0L SPI - Oil Leak From Dipstick Tube/PCV FREEZEING (98-10-5)
- Leaks Oil - New Silicone Gasket & Sealant (98-7-4)
- 2.0L - DTC 0401/Mil Illuminated - EGR Hose Off (97-3-4)
- 2.0L SPI - Hard Start/Long Crank Time (97-21-5)
- Mil Lit/DTC P1443/No DRIVEABILITY Concerns (97-13-8)
- Fuel Economy - Customer Expectations (99-26-9)
- Mechanical - Hydraulic
- Brakes Grind/PU Ll/Uneven Wear: Vehicles In Rust Belt (00-6-9)
- Brakes Grinding/Roughness After New Pad Installation (99-25-9)
- Noise/Vibration/Harshness Diagnostic Procedure (99-11-1)
- Clicking From Brakes After Vehicle Direction Change (99-8-10)
- Brakes - Elimination Of Sanding Rotors & Drums (98-5A-11)
- Brakes - Hub-Mount Brake Rotor Machining Equipment (98-5A-5)
- Wheels - Proper Lug Torque Procedures - Service Tip (98-5A-4)
- Brake & Rotor Service Tips (97-19-4)
- Guidelines For Brake Vibration Repair & Replacement (99-19-4)
- Noise - Rattling/Squeaking - Summary Of Concerns (98-20-17)
- Memory Modules
- Mirrors
- Paint & Coatings
- Passive Restraints
- Rear Suspension
- Restraints Control Systems
- Seats
- Solar Ventilation
- Starter
- Steering Column Switches
- Steering Linkage
- Sun Roof/T-Top/Convertible Top
- System
- General Pcm Programming Procedures (04-24-14)
- 2.0L SPI - Rough Idle, Low Power And/Or Stall At Idle With DTCS P0300-P0304 (04-9-1)
- Mil With DTC'S P0442, P0455, P0456, P0457, P1442 Or Check Fuel Cap Lamp With DTC P0457 (03-9-8)
- 2.0L SPI Or ZETEC - Idle Vibration (99-6-9)
- Whining/Buzzing - Comes Through Speakers Of Entertainment Or Two-Way Radio (02-16-4)
- Engine - Approved Head Gasket Replacement Service Procedures (02-1-4)
- DRIVEABILITY - Detecting Vacuum Leaks - Using The Rotunda VACUTEC 522 Smoke Leak Detector Machine (01-20-5)
- DRIVEABILITY - Ho2S, Catalyst & Fuel System Monitors - Service Tips - OBD II (01-9-7)
- Fuel Pump Whine/Buzz Noise In Radio Speakers (99-12-9)
- Reprogramming Pcm Out Of Vehicle - EEC V Only (99-4-3)
- Volatility Related DRIVEABILITY Concerns Service Tip (98-26-2)
- Lean DRIVEABILITY Symptoms: MAF Sensor Contamination (98-23-10)
- Evaporative Emission Canister Components Available (98-15-12)
- Discharged Battery - Cooling Fan Not Turning Off (98-13-8)
- 2.0L SPI - Oil Leak From Dipstick Tube/PCV FREEZEING (98-10-5)
- Fuel Injector - Non Warranty Reimbursement Testing (98-9-9)
- Leaks Oil - New Silicone Gasket & Sealant (98-7-4)
- 2.0L - Exhaust Noise From Behind Instrument Panel (97-4-4)
- 2.0L - DTC 0401/Mil Illuminated - EGR Hose Off (97-3-4)
- Delta Pressure Feedback EGR - Diagnostic Tips (97-22-1)
- 2.0L SPI - Hard Start/Long Crank Time (97-21-5)
- Evaporative Emissions - Workshop Manual Attachment (97-19A)
- Mil Lit/DTC P1443/No DRIVEABILITY Concerns (97-13-8)
- Powertrain Control Module Reprogram - Service Tip (97-9-8)
- Mil On/DTC P0300 Thru P0308/No DRIVEABILITY Concerns (97-8-6)
- 2.0L - Buzzing From EGR After Engine Is Shut Off (97-6-12)
- Fuel Economy - Customer Expectations (99-26-9)
- Mass Air Flow Sensor Replacement As An Assembly (96-22-5)
- Exhaust System Noise - Loose Muffler/Catalyst Shield (98-6-4)
- Towing
- Transmission Control Systems
- Vacuum Pumps/Lines/Tanks/Water Trap
- Warning Systems
- Wheel Hubs
- Wheels & Tire System
- Wheel - Road Force Measurement Equipment Hunter GSP9700 - Service Tips (02-1-6)
- Wheels - Proper Lug Torque Procedures - Service Tip (98-5A-4)
- Tire Company Phone Numbers For Customer Assistance (98-5-2)
- Clicking Noise When Shifting Transaxle (97-8-10)
- Wheel Covers - Bolt-On Wheel Covers - Service Tip (96-12-1)
- Window Motors & Regulators
- Wiper/Washer Systems
- Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)
- Wiring - Wire Harness Terminal Repair Kit (99-6-3)
- Electrical - New Terminal Grease For Service (98-24-6)
- Discharged Battery - Cooling Fan Not Turning Off (98-13-8)
- Dome Lamp Inoperative/Intermittent Operation (98-1-9)
- 2.0L SPI - Hard Start/Long Crank Time (97-21-5)
- Electrical Diode Identification And Replacements (96-24-6)
- 2.0L - Gauges And/Or Cooling Fan Erratic Operation (96-17-11)