Repair and Diagnosis (Single Page)
You are viewing the full "tree" of links on one page. This can load slowly, but is easier to search. The same page can appear multiple times under a different folder, that is why the page is so large.View "split tree" where inner folders are split out. where inner links are on separate pages.
Quick Lookups
Common Specs & Procedures
DTC Index
Electrical Component Locations
Fluids
Technical Bulletins
Tire Fitment
Wiring Diagrams- System Wiring Diagrams
- Air Conditioning
- Anti-Lock Brakes
- Anti-Theft
- Computer Data Lines
- Cooling Fan
- Cruise Control
- Defoggers
- Electronic Power Steering
- Electronic Suspension
- Engine Performance
- Exterior Lights
- Ground Distribution
- Headlights
- Horn
- Instrument Cluster
- Interior Lights
- Power Distribution
- Power Door Locks
- Power Mirrors
- Power Seats
- Power Windows
- Radio
- Shift Interlocks
- Starting/Charging
- Supplemental Restraints
- Transmission
- Trunk, Tailgate, Fuel Door
- Warning Systems
- Wiper/Washer
- Using lemon2025'S System Wiring Diagrams
- System Wiring Diagrams
- Accessories & Equipment
- Anti-Theft Systems
- Anti-Theft Systems - Passive
- Description
- Operation
- On-Vehicle Service
- Self-Diagnostic System
- Diagnostic Tests
- Notes
- DTC B1213: Anti-Theft Number Of Programmed Keys Is Below Minimum
- DTC B1232: Pats Transceiver Antenna Not Connected
- DTC B1600: Pats Ignition Key Transponder Signal Not Received/Damaged Encoded Ignition Key Or Use Of Non-Pats Key
- DTC B1601: Pats - Wrong Key Code From IGN. Key Transponder
- DTC B1602: Invalid Key Code Format From IGN. Key Transponder
- DTC B1681: Pats Transceiver Module Signal Is Not Received
- DTC B2139: Security I.D. Does Not Match Between Pats & Pcm
- DTC B2141: No Security I.D. Exchange Between Pats & Pcm
- DTC U1147: Invalid Or Missing Data For Vehicle Security
- System Tests
- Removal & Installation
- Wiring Diagrams
- Passive Anti-Theft System Job Aid
- Power Door Lock System & Trunk Release System
- Description & Operation
- Trouble Shooting
- Component Testing
- Self-Diagnostic System
- Diagnostic Testing
- DTC B1342: Ecu Defective
- DTC B1396: Power Door Lock Short To Battery (DDM)
- DTC B1396: Power Door Lock Short To Battery (LCM)
- DTC B1397: Power Door Unlock Short To Battery
- DTC B1517: Seat Occupied Switch Short To Battery
- DTC B1553: DECKLID Release Short To Battery
- DTC B1751: Park/Neutral Switch Short To Battery
- System Testing
- Test A: No Communication With DDM
- Test B: No Communication With LCM
- Test C: One Door Lock Inoperative
- Test D: All Door Locks Inoperative
- Test E: All Door Locks Operate From One Switch Only
- Test F: Door Locks Operate In One Direction Only
- Test G: Door Locks Operate Only With Engine Running
- Test H: Door Locks Operate Intermittently
- Test J: DECKLID Lock Is Inoperative
- Test K: DECKLID Release Switch Inoperative
- Removal & Installation
- Wiring Diagrams
- Remote Keyless Entry System
- Description & Operation
- Programming
- Trouble Shooting
- Self-Diagnostic System
- Diagnostic Testing
- System Testing
- Notes
- Test A: No Communication With DDM
- Test B: No Communication With LCM
- Test C: Door Locks Are Inoperative Using Keypad
- Test D: Door Locks Inoperative
- Test E: Illuminated Entry Does Not Operate Using Keypad
- Test F: Interior Lights Do Not Turn Off If Left On
- Test G: AUTOLOCK Does Not Operate Properly
- Test H: DECKLID Will Not Unlock
- Test J: Door Locks Are Inoperative Using Remote Transmitter
- Removal & Installation
- Wiring Diagrams
- Anti-Theft Systems - Passive
- Communication Devices
- Module Communications Network System
- Description & Operation
- Repairing Bus Wiring
- Communication Network Diagnostics
- Testing
- Notes
- Test A: Anti-Lock Brake System (Abs) Module Does Not Respond To NGS Tester
- Test B: Driver's Door Module (DDM) Does Not Respond To NGS Tester
- Test C: Natural Gas Vehicle (NGV) Module Does Not Respond To NGS Tester
- Test D: Electronic Automatic Temperature Control (EATC) Module Does Not Respond To NGS Tester
- Test E: Electronic Crash Sensor (ESC) Module Does Not Respond To NGS Tester
- Test F: Lighting Control Module (LCM) Does Not Respond To NGS Tester
- Test G: Passive Anti-Theft System (Pats) Module Does Not Respond To NGS Tester
- Test H: Powertrain Control Module (Pcm) Does Not Respond To NGS Tester
- Test J: No Module/Network Communications - ISO 9141 Link
- Test K: No Module/Network Communications - Bus Link
- Test L: No Module/Network Communication
- Wiring Diagrams
- Module Communications Network System
- Cruise Control Systems
- Description & Operation
- Adjustments
- System Testing
- Test A: Speed Control Is Inoperative
- Test B: Set Speed Fluctuates
- Test C: Speed Control Does Not Disengage When Brakes Are
- Test D: Speed Control Indicator Does Not Turn On
- Test E: Speed Control Indicator Does Not Turn Off
- Test F: Coast Switch Inoperative
- Test G: Set/ACCEL Switch Inoperative
- Test H: Resume Switch Inoperative
- Test J: Off Switch Inoperative
- Trouble Shooting
- Removal & Installation
- Wiring Diagrams
- Exterior Lights
- AUTOLAMP Systems
- Description
- System Operation
- Adjustments
- Trouble Shooting
- Component Tests
- Self-Diagnostics
- Diagnostic Trouble Code Tests
- DTC B1312: Headlight Input Short To Battery
- DTC B1317: Battery Voltage High
- DTC B1318: Battery Voltage Low
- DTC B1342: Ecu Internal Failure
- DTC B1689: AUTOLAMP Delay Circuit Failure
- DTC B1692: AUTOLAMP Delay Short To Ground
- DTC B1693: AUTOLAMP On Circuit Failure
- DTC B1695: AUTOLAMP On Short To Battery
- DTC B1873: Turn Signal/Hazard Power Feed Short To Ground
- Symptom Tests
- Removal & Installation
- Wiring Diagrams
- AUTOLAMP Systems
- Gauges & Instrument Panels
- Instrument Panels - Analog
- Description & Operation
- Testing
- Notes
- Inspection & Verification
- Test A: No Communication With Lighting Control Module (LCM)
- Test B: Integrated Circuit Display(S) Inoperative Or Erratic
- Test C: Fuel Gauge Inaccurate
- Test D: Coolant Temperature Gauge Inaccurate
- Test E: Oil Pressure Inaccurate
- Test F: Charge Indication Inaccurate
- Test G: Speedometer/Odometer Inaccurate
- Test H: Brake Warning Never/Always On
- Test J: Left Turn Indicator Never/Always On
- Test K: Right Turn Indicator Never/Always On
- Test L: High Beam Warning Never/Always On
- Test M: Safety Belt Warning Never/Always On
- Test N: Air Suspension Indicator Never/Always On
- Test P: Cooling System Indicator Never/Always On
- Removal & Installation
- Wiring Diagrams
- Instrument Panels - Electronic
- Description
- Operation
- Trouble Shooting
- Symptom Testing
- No Communication With Lighting Control Module
- Display Not Illuminated, Too Dim Or Blank But Backlighted
- Display Scrambled, Segments Half Lit, Segments Blinking Or Missing, Display Incorrect, Display Stuck With All Segments On
- Display Does Not Respond To Buttons Or No Beep When Buttons Pressed Or Driver Alert Given
- Co Displayed, Top 2 & Bottom 2 Diagnostic Bars Displayed
- Cs Displayed, Top 2 & Bottom 2 Diagnostic Bars Displayed
- Inaccurate Fuel Gauge Indication
- Temperature Gauge Displays Top 2 & Bottom 2 Diagnostic Bars
- Temperature Gauge Always Reads Hot Or Cold Temperature
- No Warning Tone When Thermometer Symbol Is Blinking
- Speedometer Indicates Zero Mph At All Speeds
- Speedometer Constantly Reads Too High Or Too Low
- Speed Indication Varies Erratically
- Speed Control Indicator Always On
- Speed Control Indicator Does Not Come On When Speed Control Engaged
- Display Has "S" Illuminated
- Mileage Constantly Reads Too High Or Too Low
- Odometer Does Not Accumulate Mileage Or Counts One Mile & Then Jumps Backward
- Instantaneous Or Average Fuel Economy Always Reads Zero Miles/Gal Or 99 Miles/Gal
- DTE Does Not Go Below 200 Miles With Fuel Tank Empty, Or DTE Always Indicates Zero
- Door Ajar Warning Never/Always On
- Trunk Ajar Warning Never/Always On
- Charge System Warning Never/Always On
- Air Suspension Warning Always On
- Low Washer Fluid Warning Never/Always On
- Left Turn Indicator Never/Always On
- Right Turn Indicator Never/Always On
- High Beam Warning Never/Always On
- Safety Belt Warning Never/Always On
- Low Oil Pressure Warning Never/Always On
- Air Bag Warning Indicator Never/Always On
- Overdrive Off Indicator Never/Always On
- Transmission Range Indicator Never/Always On
- Fail Safe Cooling System Indicator Never/Always On
- Removal & Installation
- Wiring Diagrams
- Instrument Panels - Analog
- Heated Glass/Defoggers
- Mirrors
- Seats
- Steering Column Switches
- Window Motors & Regulators
- Wiper/Washer Systems
- Wiper System & Washer System
- Description & Operation
- Adjustments
- Component Testing
- System Testing
- Notes
- Trouble Shooting
- Test A: Washer Inoperative
- Test B: Washer Runs Continuously
- Test C: Wipers Inoperative
- Test D: Wipers Inoperative At High Speed
- Test E: Wipers Inoperative At Low Speed
- Test F: Intermittent Speed Does Not Operate Properly
- Test G: Wipers Will Not Park Properly
- Test H: Wipers Continue To Run When Switch Is Off
- Removal & Installation
- Wiring Diagrams
- Wiper System & Washer System
- Anti-Theft Systems
- Body & Frame
- Door Locks
- Anti-Theft Systems - Passive
- Description
- Operation
- On-Vehicle Service
- Self-Diagnostic System
- Diagnostic Tests
- Notes
- DTC B1213: Anti-Theft Number Of Programmed Keys Is Below Minimum
- DTC B1232: Pats Transceiver Antenna Not Connected
- DTC B1600: Pats Ignition Key Transponder Signal Not Received/Damaged Encoded Ignition Key Or Use Of Non-Pats Key
- DTC B1601: Pats - Wrong Key Code From IGN. Key Transponder
- DTC B1602: Invalid Key Code Format From IGN. Key Transponder
- DTC B1681: Pats Transceiver Module Signal Is Not Received
- DTC B2139: Security I.D. Does Not Match Between Pats & Pcm
- DTC B2141: No Security I.D. Exchange Between Pats & Pcm
- DTC U1147: Invalid Or Missing Data For Vehicle Security
- System Tests
- Removal & Installation
- Wiring Diagrams
- Passive Anti-Theft System Job Aid
- Power Door Lock System & Trunk Release System
- Description & Operation
- Trouble Shooting
- Component Testing
- Self-Diagnostic System
- Diagnostic Testing
- DTC B1342: Ecu Defective
- DTC B1396: Power Door Lock Short To Battery (DDM)
- DTC B1396: Power Door Lock Short To Battery (LCM)
- DTC B1397: Power Door Unlock Short To Battery
- DTC B1517: Seat Occupied Switch Short To Battery
- DTC B1553: DECKLID Release Short To Battery
- DTC B1751: Park/Neutral Switch Short To Battery
- System Testing
- Test A: No Communication With DDM
- Test B: No Communication With LCM
- Test C: One Door Lock Inoperative
- Test D: All Door Locks Inoperative
- Test E: All Door Locks Operate From One Switch Only
- Test F: Door Locks Operate In One Direction Only
- Test G: Door Locks Operate Only With Engine Running
- Test H: Door Locks Operate Intermittently
- Test J: DECKLID Lock Is Inoperative
- Test K: DECKLID Release Switch Inoperative
- Removal & Installation
- Wiring Diagrams
- Remote Keyless Entry System
- Description & Operation
- Programming
- Trouble Shooting
- Self-Diagnostic System
- Diagnostic Testing
- System Testing
- Notes
- Test A: No Communication With DDM
- Test B: No Communication With LCM
- Test C: Door Locks Are Inoperative Using Keypad
- Test D: Door Locks Inoperative
- Test E: Illuminated Entry Does Not Operate Using Keypad
- Test F: Interior Lights Do Not Turn Off If Left On
- Test G: AUTOLOCK Does Not Operate Properly
- Test H: DECKLID Will Not Unlock
- Test J: Door Locks Are Inoperative Using Remote Transmitter
- Removal & Installation
- Wiring Diagrams
- Anti-Theft Systems - Passive
- Mirrors
- Seats
- Windows
- Door Locks
- Brakes
- Anti-Lock Brakes
- Anti-Lock Brake System - Traction Control
- Description
- Operation
- Bleeding Brake System
- Diagnosis & Testing
- Diagnostic Tests
- Test A: No Communications With ABCM
- Test B: Anti-Lock Light On With Brake Light Off
- Test C: LF Abs Sensor & Circuit Check
- Test D: RF Abs Sensor & Circuit Check
- Test E: RR Sensor & Circuit Check
- Test F: LR Sensor & Circuit Check
- Test G: No Abs Warning Light When Ignition Is On
- Test H: Spongy Brake Pedal, No Warning Light With/Without Anti-Lock Function
- Test J: Poor Vehicle Tracking During Anti-Lock Function, Warning Light Off
- Test K: Anti-Lock Light Normal, Traction Assist Inoperative
- Test L: Hydraulic Pump Motor
- Test M: Traction Control Off Indicator Is Inoperative
- Test N: Traction Control Indicator Is Always On
- Removal & Installation
- Torque Specifications
- Wiring Diagrams
- Anti-Lock Brake System - Traction Control
- Mechanical - Hydraulic
- Disc Brakes & Drum Brakes
- Description & Operation
- Bleeding Brake System
- Adjustments
- Removal & Installation
- Overhaul
- Disc Brake Specifications
- Drum Brake Specifications
- Torque Specifications
- Disc Brakes & Drum Brakes
- Anti-Lock Brake System - Traction Control
- Description
- Operation
- Bleeding Brake System
- Diagnosis & Testing
- Diagnostic Tests
- Test A: No Communications With ABCM
- Test B: Anti-Lock Light On With Brake Light Off
- Test C: LF Abs Sensor & Circuit Check
- Test D: RF Abs Sensor & Circuit Check
- Test E: RR Sensor & Circuit Check
- Test F: LR Sensor & Circuit Check
- Test G: No Abs Warning Light When Ignition Is On
- Test H: Spongy Brake Pedal, No Warning Light With/Without Anti-Lock Function
- Test J: Poor Vehicle Tracking During Anti-Lock Function, Warning Light Off
- Test K: Anti-Lock Light Normal, Traction Assist Inoperative
- Test L: Hydraulic Pump Motor
- Test M: Traction Control Off Indicator Is Inoperative
- Test N: Traction Control Indicator Is Always On
- Removal & Installation
- Torque Specifications
- Wiring Diagrams
- Anti-Lock Brakes
- Drivelines & Axles
- Differentials & Drive Axles
- Driveshaft & Universal Joints
- Electrical
- Charging Systems
- Component Locations
- Fuses & Circuit Breakers
- Gauges
- Instrument Panels - Analog
- Description & Operation
- Testing
- Notes
- Inspection & Verification
- Test A: No Communication With Lighting Control Module (LCM)
- Test B: Integrated Circuit Display(S) Inoperative Or Erratic
- Test C: Fuel Gauge Inaccurate
- Test D: Coolant Temperature Gauge Inaccurate
- Test E: Oil Pressure Inaccurate
- Test F: Charge Indication Inaccurate
- Test G: Speedometer/Odometer Inaccurate
- Test H: Brake Warning Never/Always On
- Test J: Left Turn Indicator Never/Always On
- Test K: Right Turn Indicator Never/Always On
- Test L: High Beam Warning Never/Always On
- Test M: Safety Belt Warning Never/Always On
- Test N: Air Suspension Indicator Never/Always On
- Test P: Cooling System Indicator Never/Always On
- Removal & Installation
- Wiring Diagrams
- Instrument Panels - Electronic
- Description
- Operation
- Trouble Shooting
- Symptom Testing
- No Communication With Lighting Control Module
- Display Not Illuminated, Too Dim Or Blank But Backlighted
- Display Scrambled, Segments Half Lit, Segments Blinking Or Missing, Display Incorrect, Display Stuck With All Segments On
- Display Does Not Respond To Buttons Or No Beep When Buttons Pressed Or Driver Alert Given
- Co Displayed, Top 2 & Bottom 2 Diagnostic Bars Displayed
- Cs Displayed, Top 2 & Bottom 2 Diagnostic Bars Displayed
- Inaccurate Fuel Gauge Indication
- Temperature Gauge Displays Top 2 & Bottom 2 Diagnostic Bars
- Temperature Gauge Always Reads Hot Or Cold Temperature
- No Warning Tone When Thermometer Symbol Is Blinking
- Speedometer Indicates Zero Mph At All Speeds
- Speedometer Constantly Reads Too High Or Too Low
- Speed Indication Varies Erratically
- Speed Control Indicator Always On
- Speed Control Indicator Does Not Come On When Speed Control Engaged
- Display Has "S" Illuminated
- Mileage Constantly Reads Too High Or Too Low
- Odometer Does Not Accumulate Mileage Or Counts One Mile & Then Jumps Backward
- Instantaneous Or Average Fuel Economy Always Reads Zero Miles/Gal Or 99 Miles/Gal
- DTE Does Not Go Below 200 Miles With Fuel Tank Empty, Or DTE Always Indicates Zero
- Door Ajar Warning Never/Always On
- Trunk Ajar Warning Never/Always On
- Charge System Warning Never/Always On
- Air Suspension Warning Always On
- Low Washer Fluid Warning Never/Always On
- Left Turn Indicator Never/Always On
- Right Turn Indicator Never/Always On
- High Beam Warning Never/Always On
- Safety Belt Warning Never/Always On
- Low Oil Pressure Warning Never/Always On
- Air Bag Warning Indicator Never/Always On
- Overdrive Off Indicator Never/Always On
- Transmission Range Indicator Never/Always On
- Fail Safe Cooling System Indicator Never/Always On
- Removal & Installation
- Wiring Diagrams
- Instrument Panels - Analog
- Starter
- Wiring Diagrams
- System Wiring Diagrams
- Air Conditioning
- Anti-Lock Brakes
- Anti-Theft
- Computer Data Lines
- Cooling Fan
- Cruise Control
- Defoggers
- Electronic Power Steering
- Electronic Suspension
- Engine Performance
- Exterior Lights
- Ground Distribution
- Headlights
- Horn
- Instrument Cluster
- Interior Lights
- Power Distribution
- Power Door Locks
- Power Mirrors
- Power Seats
- Power Windows
- Radio
- Shift Interlocks
- Starting/Charging
- Supplemental Restraints
- Transmission
- Trunk, Tailgate, Fuel Door
- Warning Systems
- Wiper/Washer
- Using lemon2025'S System Wiring Diagrams
- System Wiring Diagrams
- Engine Mechanical
- Accessory Drive Belts
- Engine Cooling System Specifications & Drive Belt Routing
- Bleeding
- Belt Adjustment
- Notes
- Drive Belt TENSIONER Wear Indicator Location (Escort)
- Drive Belt TENSIONER Wear Indicator Location (3.0L V6 VIN "U")
- Drive Belt TENSIONER Wear Indicator Location (3.0L V6 VIN "S")
- Drive Belt TENSIONER Wear Indicator Location (3.4L V8 SHO)
- Drive Belt TENSIONER Wear Indicator Location (3.8L V6)
- Drive Belt TENSIONER Wear Indicator Location (4.6L V8)
- Drive Belt Routing
- Drive Belt Routing (Escort 2.0L 4-CYL. VIN "P")
- Drive Belt Routing (Escort, ZX2 2.0L VIN 3)
- Drive Belt Routing (Contour, Cougar & Mystique - 2.0L 4-CYL. VIN 3)
- Drive Belt Routing (2.5L - Contour & Mystique)
- Drive Belt Routing (2.5L - Cougar)
- Drive Belt Routing (2.5L)
- Drive Belt Routing (3.0L V6 VIN "S")
- Drive Belt Routing (3.0L V6 VIN "U")
- Drive Belt Routing (3.4L V8 SHO)
- Drive Belt Routing (3.8L V6)
- Drive Belt Routing (4.6L V8 VIN "V")
- Drive Belt Routing (4.6L V8 VIN "X")
- Specifications
- Engine Cooling System Specifications & Drive Belt Routing
- Auxiliary Emission Control Systems
- Emission Control System Visual Inspection Procedures - General Information
- * Please Read This First *
- Emission Control Labels
- Emission Control Visual Inspection
- Notes
- Positive Crankcase Ventilation (PCV)
- Thermostatic Air Cleaner (TAC)
- Fuel Evaporative System (EVAP)
- Catalytic Converters
- Fill Pipe RESTRICTOR (Fr)
- Exhaust Gas RECIRCULATION (EGR) System
- Spark Controls (SPK)
- Air Injection System (AIS)
- Oxygen Sensor (O2)
- Computerized Engine Controls (CEC)
- Early Fuel Evaporation (EFE)
- Emission Maintenance Reminder Light (EMR) (If Equipped)
- Malfunction Indicator Light (Mil)
- Emission Control System Visual Inspection Procedures - General Information
- Electric Cooling Fan - EEC-V
- Cooling System (Mechanical)
- Engine Cooling System Specifications & Drive Belt Routing
- Bleeding
- Belt Adjustment
- Notes
- Drive Belt TENSIONER Wear Indicator Location (Escort)
- Drive Belt TENSIONER Wear Indicator Location (3.0L V6 VIN "U")
- Drive Belt TENSIONER Wear Indicator Location (3.0L V6 VIN "S")
- Drive Belt TENSIONER Wear Indicator Location (3.4L V8 SHO)
- Drive Belt TENSIONER Wear Indicator Location (3.8L V6)
- Drive Belt TENSIONER Wear Indicator Location (4.6L V8)
- Drive Belt Routing
- Drive Belt Routing (Escort 2.0L 4-CYL. VIN "P")
- Drive Belt Routing (Escort, ZX2 2.0L VIN 3)
- Drive Belt Routing (Contour, Cougar & Mystique - 2.0L 4-CYL. VIN 3)
- Drive Belt Routing (2.5L - Contour & Mystique)
- Drive Belt Routing (2.5L - Cougar)
- Drive Belt Routing (2.5L)
- Drive Belt Routing (3.0L V6 VIN "S")
- Drive Belt Routing (3.0L V6 VIN "U")
- Drive Belt Routing (3.4L V8 SHO)
- Drive Belt Routing (3.8L V6)
- Drive Belt Routing (4.6L V8 VIN "V")
- Drive Belt Routing (4.6L V8 VIN "X")
- Specifications
- Engine Cooling System Specifications & Drive Belt Routing
- Mechanical
- Engine - 4.6L V8 - VIN [W & 9]
- Engine Identification
- Adjustments
- Trouble Shooting
- Removal & Installation
- Overhaul
- Engine Oiling
- Torque Specifications
- Engine Specifications
- General Specifications
- Crankshaft, Main Bearings & Connecting Rod Bearings Specifications
- Connecting Rods Specifications
- Cylinder Head Specifications
- Valve Lash Adjuster Specifications
- Pistons, Piston Pins & Piston Rings Specifications
- Engine Valves & Valve Springs Specifications
- Cylinder Block Specifications
- Camshaft Specifications
- Engine - 4.6L V8 - VIN [W & 9]
- Starter
- Accessory Drive Belts
- Engine Performance
- Engine Controls - Adjustments 4.6L
- Application
- Emissions
- EGR Function Testing - Ford - Cars
- EGR Function Testing - Ford - Trucks
- Emission Applications
- Emission Control Abbreviations
- State Emission Standards - Diesel
- State Emission Standards - Gas
- ALASKA
- ARIZONA
- CALIFORNIA
- Colorado
- CONNECTICUT
- DELAWARE
- District Of COLUMBIA
- GEORGIA
- IDAHO
- ILLINOIS
- INDIANA
- KENTUCKY
- MARYLAND
- MASSACHUSETTS
- MISSOURI
- NEVADA
- New Jersey
- New MEXICO
- New YORK
- North CAROLINA
- OHIO
- OREGON
- PENNSYLVANIA
- RHODE Island
- TENNESSEE
- TEXAS
- UTAH
- VIRGINIA
- WASHINGTON
- WISCONSIN
- U. S. EPA ASM2525 & ASM5015 Start-Up Emission Standards
- U. S. EPA Revised Final ASM Emission Standards (ASM5015 & ASM2525)
- U.S. EPA Im240 Emission Standards
- Mode 6 - 1998 Ford - Except Diesel
- Engine Controls - Pin Voltage Charts - CNG
- Remove, Overhaul & Install
- Sensor Range Charts
- Specifications
- System
- Engine Controls - Basic Testing - CNG
- Engine Controls - System/Component Tests - 4.6L - CNG
- Engine Controls - Tests W/Codes - CNG 4.6L
- Introduction
- Self-Diagnostic System
- Quick Test
- Additional System Functions
- Notes
- Parameter Identification (PID)
- On-Board System Readiness (OSR) Test Mode
- Freeze Frame Data Mode
- Output Test Mode
- Failure Mode Effects Management (FMEM)
- Hardware Limited Operational Strategy (HLOS)
- Drive Cycles
- OBD-II Drive Cycle Description
- Vehicle Preparation For OBD-II Or Monitor Repair Verification Drive Cycle
- OBD-II Drive Cycle
- Comprehensive Component Monitor Repair Verification Drive Cycle
- EGR Monitor Repair Verification Drive Cycle
- EVAP Running Loss System Repair Verification Drive Cycle
- Catalyst Monitor Repair Verification Drive Cycle
- Fuel Monitor Or HO2S Monitor Repair Verification Drive Cycle
- Misfire Monitor Repair Verification Drive Cycle
- Secondary Air Monitor Repair Verification Drive Cycle
- Summary
- Diagnostic Trouble Code (DTC) Reference Chart
- Circuit Tests
- Notes
- How To Use Circuit Tests
- Circuit Test A - No Start/Vehicle Will Not Start
- Circuit Test B - EEC-V Power Relay
- Circuit Test C - Reference Voltage
- Circuit Test DA - Temperature Sensor Test (IAT & ECT)
- Circuit Test Db - Engine Fuel Temperature (Eft) Sensor
- Circuit Test Dc - Mass Airflow (MAF) Sensor
- Circuit Test Dd - Fuel Rail Pressure (FRP) Sensor
- Circuit Test DH - Throttle Position (TP) Sensor
- Circuit Test DL - Cylinder Head Temperature (CHT) Sensor
- Circuit Test DP - Vehicle Speed Sensor (VSS)
- Circuit Test Dr - Camshaft Position (CMP) Sensor
- Circuit Test DT - Power Steering Pressure (PSP) Sensor
- Circuit Test FB - Power Take Off (PTO)
- Circuit Test FD - Brake Pedal Position (BPP) Switch
- Circuit Test Ff - Power Steering Pressure (PSP) Switch
- Circuit Test FG - Octane Adjust
- Circuit Test H - Fuel Control
- Circuit Test Ha - Natural Gas Fuel Control
- Circuit Test HB - Natural Gas Fuel Delivery System
- Circuit Test HC - Gasoline Fuel Delivery System
- Circuit Test Hd - Misfire Detection Monitor
- Circuit Test He - EGR System
- Circuit Test Hf - Catalyst Efficiency Monitor & Exhaust Systems
- Circuit Test Hg - PCV System
- Circuit Test HK - Variable Cam Timing (VCT)
- Circuit Test HM - Secondary Air Injection (Air) System
- Circuit Test HU - Air Intake System
- Circuit Test HW - Evaporative Emission Purge Flow System
- Circuit Test HX - Evaporative Emission (EVAP) Monitor & System
- Circuit Test JB - Secondary Ignition
- Circuit Test JD - Crankshaft Position (CKP) Sensor
- Circuit Test JF - Integrated Ignition Coil On Plug Failure
- Circuit Test JH - Tachometer Output Failure
- Circuit Test KA - Fuel Pump Relay
- Circuit Test Kc - Fuel Shutoff Valve Relay
- Circuit Test KE - Idle Air Control (IAC) Valve
- Circuit Test KF - Fan Control (FC) Relay
- Circuit Test MB - Output Test Mode Not Functioning
- Circuit Test NB - Malfunction Indicator Light (Mil)
- Circuit Test NC - Ignition Diagnostic Monitor (IDM)
- Circuit Test ND - Engine Rpm/Vehicle Speed Limiter
- Circuit Test QA - Unable To Activate Self-Test/SCP Communication Error DTC Not Listed
- Circuit Test QB - Diagnostic Trouble Code P0603 Or P1605
- Circuit Test QC - OBD-II Monitor Testing Not Complete; Diagnostic Trouble Code P1000
- Circuit Test QD - Diagnostic Trouble Code P1260
- Circuit Test Ta - Park & Neutral Position (PNP) Switch, Clutch Pedal Position (CPP) Switch
- Circuit Test Tb - Transmission Control Switch (TCS)/ Transmission Control Indicator Lamp (TCIL)
- Circuit Test Z - Intermittent
- Engine Controls - Tests W/O Codes - CNG 4.6L
- Introduction
- Symptoms
- Notes
- Symptom Diagnosis
- No Crank
- Hard Start/Long Crank
- No Start/Normal Crank
- Slow Return To Idle
- High Idle (Diesels/Runs On)
- Low Idle (Stalls On Deceleration)
- Rough Idle, Stalls, Misses, Hesitation Or Surge
- Backfires
- Loss Of Power
- Spark Knock
- Poor Fuel Economy
- Emissions Compliance
- Warning Indicator Lights
- Improper Automatic Transmission Shift
- Tachometer, Speedometer Or Fuel Gauge Inoperative
- High Oil Consumption
- Electric Cooling Fan Does Not Run At Low/& Or High Speed
- Electric Cooling Fan Always On
- Exhaust Smoke
- Fuel Smell
- Engine Noise
- Climate Control (Lack Of Cooling)
- Climate Control (A/C Always On)
- A/C Does Not Go Off During Wot
- BRAKELIGHTS Always On Or Off
- Sulfur Smell
- Fuel Pump Always On
- INTERMITTENTS
- Testing & Diagnosis
- Engine Controls - Basic Testing - CNG
- Engine Controls - System/Component Tests - 4.6L - CNG
- Engine Controls - Tests W/Codes - CNG 4.6L
- Introduction
- Self-Diagnostic System
- Quick Test
- Additional System Functions
- Notes
- Parameter Identification (PID)
- On-Board System Readiness (OSR) Test Mode
- Freeze Frame Data Mode
- Output Test Mode
- Failure Mode Effects Management (FMEM)
- Hardware Limited Operational Strategy (HLOS)
- Drive Cycles
- OBD-II Drive Cycle Description
- Vehicle Preparation For OBD-II Or Monitor Repair Verification Drive Cycle
- OBD-II Drive Cycle
- Comprehensive Component Monitor Repair Verification Drive Cycle
- EGR Monitor Repair Verification Drive Cycle
- EVAP Running Loss System Repair Verification Drive Cycle
- Catalyst Monitor Repair Verification Drive Cycle
- Fuel Monitor Or HO2S Monitor Repair Verification Drive Cycle
- Misfire Monitor Repair Verification Drive Cycle
- Secondary Air Monitor Repair Verification Drive Cycle
- Summary
- Diagnostic Trouble Code (DTC) Reference Chart
- Circuit Tests
- Notes
- How To Use Circuit Tests
- Circuit Test A - No Start/Vehicle Will Not Start
- Circuit Test B - EEC-V Power Relay
- Circuit Test C - Reference Voltage
- Circuit Test DA - Temperature Sensor Test (IAT & ECT)
- Circuit Test Db - Engine Fuel Temperature (Eft) Sensor
- Circuit Test Dc - Mass Airflow (MAF) Sensor
- Circuit Test Dd - Fuel Rail Pressure (FRP) Sensor
- Circuit Test DH - Throttle Position (TP) Sensor
- Circuit Test DL - Cylinder Head Temperature (CHT) Sensor
- Circuit Test DP - Vehicle Speed Sensor (VSS)
- Circuit Test Dr - Camshaft Position (CMP) Sensor
- Circuit Test DT - Power Steering Pressure (PSP) Sensor
- Circuit Test FB - Power Take Off (PTO)
- Circuit Test FD - Brake Pedal Position (BPP) Switch
- Circuit Test Ff - Power Steering Pressure (PSP) Switch
- Circuit Test FG - Octane Adjust
- Circuit Test H - Fuel Control
- Circuit Test Ha - Natural Gas Fuel Control
- Circuit Test HB - Natural Gas Fuel Delivery System
- Circuit Test HC - Gasoline Fuel Delivery System
- Circuit Test Hd - Misfire Detection Monitor
- Circuit Test He - EGR System
- Circuit Test Hf - Catalyst Efficiency Monitor & Exhaust Systems
- Circuit Test Hg - PCV System
- Circuit Test HK - Variable Cam Timing (VCT)
- Circuit Test HM - Secondary Air Injection (Air) System
- Circuit Test HU - Air Intake System
- Circuit Test HW - Evaporative Emission Purge Flow System
- Circuit Test HX - Evaporative Emission (EVAP) Monitor & System
- Circuit Test JB - Secondary Ignition
- Circuit Test JD - Crankshaft Position (CKP) Sensor
- Circuit Test JF - Integrated Ignition Coil On Plug Failure
- Circuit Test JH - Tachometer Output Failure
- Circuit Test KA - Fuel Pump Relay
- Circuit Test Kc - Fuel Shutoff Valve Relay
- Circuit Test KE - Idle Air Control (IAC) Valve
- Circuit Test KF - Fan Control (FC) Relay
- Circuit Test MB - Output Test Mode Not Functioning
- Circuit Test NB - Malfunction Indicator Light (Mil)
- Circuit Test NC - Ignition Diagnostic Monitor (IDM)
- Circuit Test ND - Engine Rpm/Vehicle Speed Limiter
- Circuit Test QA - Unable To Activate Self-Test/SCP Communication Error DTC Not Listed
- Circuit Test QB - Diagnostic Trouble Code P0603 Or P1605
- Circuit Test QC - OBD-II Monitor Testing Not Complete; Diagnostic Trouble Code P1000
- Circuit Test QD - Diagnostic Trouble Code P1260
- Circuit Test Ta - Park & Neutral Position (PNP) Switch, Clutch Pedal Position (CPP) Switch
- Circuit Test Tb - Transmission Control Switch (TCS)/ Transmission Control Indicator Lamp (TCIL)
- Circuit Test Z - Intermittent
- Engine Controls - Tests W/O Codes - CNG 4.6L
- Introduction
- Symptoms
- Notes
- Symptom Diagnosis
- No Crank
- Hard Start/Long Crank
- No Start/Normal Crank
- Slow Return To Idle
- High Idle (Diesels/Runs On)
- Low Idle (Stalls On Deceleration)
- Rough Idle, Stalls, Misses, Hesitation Or Surge
- Backfires
- Loss Of Power
- Spark Knock
- Poor Fuel Economy
- Emissions Compliance
- Warning Indicator Lights
- Improper Automatic Transmission Shift
- Tachometer, Speedometer Or Fuel Gauge Inoperative
- High Oil Consumption
- Electric Cooling Fan Does Not Run At Low/& Or High Speed
- Electric Cooling Fan Always On
- Exhaust Smoke
- Fuel Smell
- Engine Noise
- Climate Control (Lack Of Cooling)
- Climate Control (A/C Always On)
- A/C Does Not Go Off During Wot
- BRAKELIGHTS Always On Or Off
- Sulfur Smell
- Fuel Pump Always On
- INTERMITTENTS
- Theory and Operation
- Engine Controls - Theory & Operation - CNG 4.6L
- Introduction
- Computerized Engine Controls
- Engine Controls - Theory & Operation - CNG 4.6L
- Natural Gas (NG) Vehicle Module
- Input Devices
- Notes
- A/C Cycling Switch (ACCS)
- A/C Pressure Sensor
- A/C High Pressure Switch
- Brake Pedal Position (BPP) Switch
- Camshaft Position (CMP) Sensor
- Clutch Pedal Position (CPP) Switch
- Coolant Temperature Sensor
- Crankshaft Position (CKP) Sensor
- Cylinder Head Temperature (CHT) Sensor
- Differential Pressure Feedback EGR (DPFE) Sensor
- Engine Coolant Temperature (ECT) Sensor
- Engine Fuel Temperature (EFT) Sensor
- Flexible Fuel (FF) Sensor
- Fuel Pump Monitor (Models Without Fuel Pump Driver Module)
- Fuel Pump Monitor (Models With Fuel Pump Driver Module)
- Fuel Rail Pressure (FRP) Sensor
- Heated Oxygen Sensor (HO2S)
- Intake Air Temperature (IAT) Sensor
- Mass Airflow (MAF) Sensor
- Octane Adjust Shorting Bar
- Park/Neutral Position (PNP) Switch
- Power Steering Pressure (PSP) Sensor
- Power Steering Pressure (PSP) Switch
- Power Take-Off (PTO) Switch
- Throttle Position (TP) Sensor
- Transmission Control Switch (TCS)
- Transmission Fluid Temperature (TFT) Sensor
- Vehicle Speed Sensor (VSS)
- Output Signals
- Fuel System (Natural Gas)
- Ignition System
- Emission Systems
- Self-Diagnostic System
- Engine Controls - Theory & Operation - CNG 4.6L
- Vacuum Diagrams
- Wiring Diagrams - CNG
- General Information
- Abbreviations
- Basic Trouble Shooting
- Basic Trouble Shooting - General Information
- Commonly Used Abbreviations - General Information
- Emission Control Abbreviations
- Engine Performance - Trouble Shooting - General Information
- Brakes
- Anti-Lock Brake Safety Precautions - General Information
- Map - Brake Systems
- Brake Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Accelerometers
- Accumulators
- Anchor Pins
- Anti-Lock Brake Control Assembly(Module)
- Anti-Lock Brake Controller
- Anti-Lock Brake Systems
- Axle Seal
- Backing Plates
- Bleeder Screw
- Brake Abs Active Light (Blue)
- Brake Fluid
- Brake Friction Material
- Brake On - Off Switch
- Brake Pads
- Brake Pedals
- Brake Shoe Hardware
- Brake Shoes
- Brake Stoplight Switches
- Brake Warning Light (Amber)
- Brake Warning Light (Red)
- Bulb Sockets
- Bulbs And LEDS
- Caliper Hardware
- Caliper Mounting Pin
- Caliper Piston
- Caliper Shim
- Caliper Slider Pin (Bolt) Dust Boot
- Caliper Slider Pin (Bolt)
- Calipers
- Combination Valve
- Controllers
- Digital Ratio Axle Controllers And Buffers (Drab And Dram)
- Disable Switches
- Drums
- Electrical Brake Pumps
- Electrical Park Motor
- Electrical Pumps And Motors
- Electro-Magnetic Interference
- Electronic Brake Control Modulator
- Electronic Brake Distribution
- Electronic Brake Traction Control Module
- Electronic Controllers
- Electronic Traction Control
- External Brake Cable
- Flow Control Valve
- Fluid Level Sensor Switches
- Fluid
- Four Wheel Drive Switches
- Friction Material
- G Sensors
- Gaskets
- Gravitational Switches
- Grease Seal
- Height Sensing Proportioning Valve
- High Pressure Accumulator
- Hoses
- Hub
- Hydraulic Control Unit
- Hydraulic Modulators
- Hydro-Boosters
- Hydro-Electric Boosters (POWERMASTER)
- Ignition Disable Switches
- Lamp Driver Relay
- Lateral Acceleration Switches
- LEDS
- Lenses
- Low Pressure Accumulator
- Lug Nut
- Master Cylinder Cover Gasket
- Master Cylinders
- Modulators
- Motor Pack
- Motors
- Pads
- Parking Brake Cable
- Parking Brake Mechanism
- Parking Brake Shoes
- Parking Brake Switches
- Parking Brake Systems
- Pedal Travel Switches
- Pedals
- Power Distribution Center
- POWERMASTER
- Pressure Differential Switches
- Pressure Switches
- Pressure Transducers
- Proportioning Valve
- Pumps
- Relays
- RELUCTOR (Speed) Ring
- Rotors
- Self-Adjusting Systems
- Shoe Hardware
- Shoes
- Sockets
- Speed Sensor (RELUCTOR) Ring
- Speed Sensors (Electronic Wheel And Vehicle)
- Star Wheel
- Steel Brake Lines
- Stoplight Switches
- Stroke Sensor
- Switches
- Tires
- Tone Ring
- Toothed Rings (Tone Wheel)
- Traction Control System (TCS)
- Transfer Tubes
- Vacuum Boosters
- Vacuum Hoses
- Valves
- Wear Indicator
- Wheel Attachment Hardware
- Wheel Bearings, Races And Seals
- Wheel Cylinders
- Wiring Harnesses
- Yaw Rate Sensor
- Brake System CHECKSHEET
- Reason Code Explanation
- Automotive Terminology & Definitions
- Brake Systems
- Map - Routine Inspection Reference Guide
- Routine Inspection Reference Guide
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Maintenance Overview
- Antifreeze/Coolant
- Visual Inspection
- Radiator Cap Test
- Engine Fan
- Cooling System Power Flush And Refill
- Belts (Except Timing Belts)
- Belt TENSIONER
- Automatic Transmission Fluid
- Automatic Transmission Fluid Exchange & Filter Replacement
- Engine Oil
- Air Filters
- Cabin Air Filter
- Brake Fluid
- Battery
- Battery Cables
- Power Steering
- Power Steering Fluid
- Wiper Blades
- Routine Inspection CHECKSHEET
- Routine Inspection - UICS
- Brake Systems
- Drivetrain And Transmission
- Notes
- Automatic Transmission Fluid
- Clutch Master Cylinders
- Cooler Lines
- Coolers
- Differential Fluid
- Drain Plugs And Gaskets
- Filters And Screens
- Fluids And Lubricants
- Hoses, Lines, And Tubes
- Hydraulic Fluid
- Lubricants
- Manual Transmission Fluid
- Mounts (Engine, Transaxle And Transmission)
- Transfer Case Fluid
- Vacuum Hoses
- Electrical Systems
- Engine Performance And Maintenance
- Notes
- Accessory Belts
- Air Filter Elements
- Air Filter Gaskets
- Air Filter Housings And Gaskets
- Air Pump Belts
- Batteries
- Battery Connectors
- Belt Idler Assemblies (Accessory And Cam Belts)
- Belt TENSIONERS (Accessory And Cam Belt)
- Chemical Engine DECARBONIZATION
- Combustion Chamber Cleaning
- Coolant Recovery Tanks
- Coolant
- Distributor Caps
- Distributor Rotors
- Engine Cooling Systems
- Engine DECARBONIZATION
- Engine Oil Drain Plugs And Gaskets
- Engine Oil Filters And Canisters
- Engine Oil
- Fuel Filters
- Fuel Injector Cleaning
- Fuel Injectors
- Fuel System Cleaning Service
- Hose Clamps
- Hose Connectors
- Hose Couplers
- Hoses And Tubes (Fuel Lines, Radiator, Vacuum, By-Pass, Heater, Recovery Tank And Oil Coolers)
- Ignition Wires (Secondary)
- Intake Cleaning
- O2 Sensors
- PCV Breather Elements
- PCV Valves
- Radiator Caps And Pressurized Expansion Tank Caps
- Spark Plugs
- Thermostats And Housings
- Throttle Body Cleaning
- Timing Belts
- Vacuum Hoses, Tubes And Connections (Non-Metallic)
- Exhaust Systems
- Heating, Ventilation And Air Conditioning Systems
- Steering And Suspension, Wheel Alignment, Wheels And Tires
- Wheel & Tire Supplement
- Reason Code Explanation
- Automotive Terminology & Definitions
- Routine Inspection Reference Guide
- Check Lists
- Computer Relearn Procedures
- Driveline/Axles
- Drive Axle Noise Diagnosis - General Information
- Gear Tooth Contact Patterns - General Information
- Map - Drive Train & Transmission
- Drive Train & Transmission Systems
- Drivetrain And Transmission
- Notes
- Actuators (Electrical)
- Actuators (Vacuum)
- Automatic Transmission / Transaxle Assemblies/CVTS
- Automatic Transmission Fluid
- Axles
- Bearings And Races
- Bell Cranks
- Bell Housings
- Bushings (External)
- Cables (Speedometer)
- Cables (TV, Detent And Shift)
- Carrier Bearings
- Clutch Cables And Cable Housings
- Clutch Discs (Manual Transmissions)
- Clutch Forks
- Clutch Linkages (Mechanical)
- Clutch Master Cylinders
- Clutch Pedals
- Clutch Pivots
- Clutch Pressure Plates
- Clutch Release Bearings
- Clutch Slave Cylinders (Concentric)
- Clutch Slave Cylinders (Conventional Or External)
- Companion Flanges
- Connectors
- Cooler Bypass Valves
- Cooler Lines
- Coolers
- CV Joints
- Differential And Final Drive Assemblies
- Differential Fluid
- Dip Stick Tubes
- Dip Sticks (Fluid Level Indicators)
- Dowel Pins, Guides And Pilot Holes
- Drain Plugs And Gaskets
- Drive Shaft Flanges
- Drive Shafts And Half Shafts
- Dust Boots
- Engine Mounts
- Exciter Rings
- Filler Tubes
- Filters And Screens
- Flanges
- Flex Plates
- Fluid Level Indicators
- Fluids And Lubricants
- Flywheels
- Force Motors
- Gaskets
- Guides
- Half Shafts
- Hoses, Lines, And Tubes
- Housings (Bell, Case, Tail(Extension) And Auxiliary)
- Hydraulic Fluid
- Intermediate Shaft Support Bearings
- Key Interlock Systems
- Limited Slips
- Lines
- Linkages (External)
- Locking Hub Assemblies
- Locking Hub Control Knobs
- Lubricants
- Manual Transmission Fluid
- Manual Transmission/Transaxle Assemblies
- Metal Clad Seals
- METALASTIC Joints
- Modulator Pins
- Modulators
- Mounts (Engine, Transaxle And Transmission)
- Odometer Drives (Mechanical)
- Odometer Heads (Mechanical)
- Oil Pans
- Pans
- Pilot Holes
- Pressure Plates
- Pressure Switches
- Races
- Rubber Joints (METALASTIC)
- Screens
- Seals (Metal Clad)
- Seals
- Selector Interlock Systems
- Sensors
- Servos
- Shift Interlock Systems (Selector And Key Interlock Systems)
- Side Covers
- Slip Yokes
- Solenoids
- Speed Sensors (Electronic Wheel And Vehicle)
- Speedometer- Driven Gear Housing
- Speedometer/Odometer Drives (Mechanical)
- Speedometer/Odometer Heads (Mechanical)
- Speedometers/Odometers (Electronic)
- Switches
- Tone Wheels
- Toothed Rings (Tone Wheel)
- Torque Converters
- Transaxle Mounts
- Transducers (Transmission)
- Transfer Case Assemblies
- Transfer Case Fluid
- Transmission Coolers
- Transmission Mounts
- Transmission Pans
- Transmission Range Indicators (PRNDL)
- Tubes
- Universal Joints (CARDAN Or Cross Type)
- Vacuum Controls
- Vacuum Hoses
- Vacuum Motors
- Vacuum-Operated Switches
- Vehicle Speed Sensors
- Vents
- Vibration Dampers
- Wheel Attachment Hardware
- Wheel Speed Sensors
- Wiring Harnesses And Connectors
- Yokes And Slip Yokes
- Reason Code Explanation
- Automotive Terminology & Definitions
- Trouble Shooting - Clutches - General Information
- DTC Index
- Electrical
- Map - Electrical Systems
- Electrical Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Actuator Motors (Electric)
- Actuator Motors (Vacuum)
- Air Bags
- Alternators And Generators
- Amplifiers
- Antennas
- Batteries
- Battery Cables, Wires And Connectors
- Battery Cables
- Battery Trays And Hold Down Hardware
- Battery Wires
- Belts
- Bulb Sockets
- Bulbs, Sealed Beams And LEDS
- Cd Players
- Cigarette Lighter Assemblies
- Circuit Breakers
- Clutch Switches
- Connectors
- Control Modules
- Cruise Control Brake Switches
- Cruise Control Cables
- Cruise Control Clutch Switches
- Cruise Control Linkages And Cables
- Cruise Control Reservoirs
- Cruise Control Tubes
- Cruise Control Vacuum Dump Release Valves
- Cruise Control Vacuum Hoses, Tubes And
- Cruise Control Vehicle Speed Sensors
- Defoggers
- Defrosters
- Delays
- Dimmers
- Electric Heaters
- Equalizers
- Fuse Blocks
- Fuse Boxes And Blocks
- Fuses, Fusible Links And Circuit Breakers
- Fusible Links
- Gauges
- Generators
- Ground Cables And Straps
- Ground Straps
- Headlight Adjusters
- Heating Elements (Defrosters, Defoggers, Electric Heaters And Seats)
- Horns And Sirens
- Ignition Switches
- Indicator Lights
- Keyless Entry Keypads And Transmitters
- Keyless Entry Transmitters
- LEDS
- Lenses
- Microphones
- Mirrors (ELECTROCHROMATIC And Heated)
- Motors
- Neutral Safety Switches
- Odometers, Speedometers And Tachometers (Cable Driven)
- Odometers
- Power Distribution Center
- Pulleys
- Receivers, Amplifiers, Equalizers And Sub-Woofer Volume Controls
- Relay Boxes
- Relays
- Sealed Beams
- Seat Heaters
- Security Alarm Sensors
- Sirens
- Solenoids
- Speakers And Microphones
- Speedometer And Tachometer Linkages And Cables
- Speedometer Cables
- Speedometers
- Starters
- Sub-Woofer Volume Control
- Switches
- Tachometer Cables
- Tachometers
- Tape Players And Cd Players
- TENSIONERS
- Timers
- Transceivers
- Transducers
- Vacuum Accumulators (Reservoirs)
- Voltage Regulators
- Washer Fluid Level Senders
- Washer Pumps
- Wiper Arms And Blades
- Wiper Blades
- Wiper Hoses And Nozzles
- Wiper Linkages
- Wiper Nozzles
- Wiper Pump Reservoirs
- Wiring Harnesses And Connectors
- Battery, Starting & Charging System CHECKSHEET
- Reason Code Explanation
- Automotive Terminology & Definitions
- Electrical Systems
- Using lemon2025'S System Wiring Diagrams
- Map - Electrical Systems
- Engine
- Engine Overhaul Procedures - General Information
- * Please Read This First *
- Description
- Engine Identification
- Inspection Procedures
- Cleaning Procedures
- Component Cleaning
- Cylinder Head Replacement
- Cylinder Head Overhaul
- Pistons, Connecting Rods & Bearings
- Crankshaft & Main Bearings
- Camshaft
- Timing Chains & Belts
- Timing Gears
- Oil Pump
- Break-In Procedure
- General Cooling System Service - General Information
- Engine Overhaul Procedures - General Information
- Engine Performance
- Compressed Natural Gas Safety Precautions
- Electrostatic Discharge Warning - General Information
- Engine Performance Diagnostic Routine Outline - General Information
- Engine Performance Safety Precautions
- Map - Engine Performance & Maintenance
- Engine Performance And Maintenance (Including Exhaust Systems)
- Engine Performance & Maintenance CHECKSHEET
- Engine Performance And Maintenance
- Notes
- Accelerator Pedal Position Sensor
- Accessory Belts
- Accessory Pulleys
- Air Conditioning Cycling Switches
- Air Conditioning Pressure Sensors
- Air Ducts And Tubes
- Air Filter Elements
- Air Filter Gaskets
- Air Filter Housings And Gaskets
- Air Fuel Ratio Sensors
- Air Injection Control Solenoids
- Air Plenums
- Air Pump Belts
- Air Pumps (Electric Driven)
- Air Tubes
- Aspirator, Check And DECEL Valves
- Baffles
- Ballast Primary Supply Resistor Wires
- Ballast Resistors And Primary Supply Resistors
- Barometric Pressure Sensors
- Batteries
- Battery Cables, Wires And Connectors
- Battery Connectors
- Battery Trays And Hold Down Hardware
- Battery Wires
- Belt Idler Assemblies (Accessory And Cam Belts)
- Belt TENSIONERS (Accessory And Cam Belt)
- Belt-Driven Air Pumps
- Boost Control Mechanism
- Camshaft Position Sensors
- Carburetors And Chokes
- Casting Core Plugs And Expansion Plugs
- Charge Air Coolers ""INTERCOOLERS"" (CAC)
- Check Valves
- Chemical Engine DECARBONIZATION
- Chokes
- Clutch Pedal Position Switches
- Cold Start Injectors
- Combustion Chamber Cleaning
- Connectors
- Coolant Recovery Tanks
- Coolant
- Cooling Fan Motor Modules
- Cooling Fan Motor Relays And Modules
- Cooling Fan Motor Resistors
- Cooling Fan Motor Sensors And Switches
- Cooling Fan Motor Switches
- Cooling Fan Motors
- Crankshaft Position Sensors
- Cylinder Deactivation Solenoid
- Cylinder Head Assemblies
- DECEL Valves
- Deflectors
- Dip Stick Tubes
- Dip Sticks And Tubes
- Distributor Advances And Retarders (Mechanical And Vacuum)
- Distributor Boots And Shields
- Distributor Caps
- Distributor Retarders (Mechanical And Vacuum)
- Distributor Rotors
- Distributor Shields
- Distributors
- Early Fuel Evaporation Valves (Heat Riser Assemblies)
- EGR Coolers
- EGR Exhaust Manifold Passages
- EGR Intake And Exhaust Manifold Passages
- EGR Plates And Coolers
- Electronic Spark Control Modules
- Electronic Transmission Control Devices
- Electronic Transmission Feedback Devices
- Engine Coolant Temperature Sensors
- Engine Cooling Systems
- Engine Covers (Oil Pan, Valve Cover, Timing Cover)
- Engine DECARBONIZATION
- Engine Oil Canisters
- Engine Oil Coolers (External)
- Engine Oil Drain Plugs And Gaskets
- Engine Oil Filters And Canisters
- Engine Oil Gaskets
- Engine Oil Pressure Gauges (Mechanical)
- Engine Oil
- Evaporative Emissions (EVAP) Canister Filters
- Evaporative Emissions (EVAP) Canister Purge Devices
- Evaporative Emissions (EVAP) Canisters
- Evaporative Emissions (EVAP) Feedback Devices
- Exhaust Gas RECIRCULATION Devices
- Exhaust Gas RECIRCULATION Feedback Devices
- Expansion Plugs
- Fan Control Sensor
- Fuel Accumulators And Dampers
- Fuel And Cold Start Injectors
- Fuel Caps
- Fuel Dampers
- Fuel Delivery Check Valves
- Fuel Distributors (BOSCH Cis)
- Fuel Filler Necks And RESTRICTORS
- Fuel Filters
- Fuel Injector Cleaning
- Fuel Injectors
- Fuel Level Senders
- Fuel Pressure Regulators
- Fuel Pumps (In-Tank, External, Electrical Or Mechanical)
- Fuel Rails
- Fuel RESTRICTORS
- Fuel System Cleaning Service
- Fuel Tanks
- Fuel
- Gaskets
- Grommets (Valve Cover)
- Harmonic Dampers
- Heater Control Valves
- Heater Cores
- Hose Clamps
- Hose Connectors
- Hose Couplers
- Hoses And Tube Couplers, Connectors And Clamps
- Hoses And Tubes (Fuel Lines, Radiator, Vacuum, By-Pass, Heater, Recovery Tank And Oil Coolers)
- Housings
- Idle Air Controls
- Idle Speed Control Actuators
- Ignition Boots
- Ignition Coil Towers
- Ignition Coils
- Ignition Control Modules (ICM)
- Ignition Switches
- Ignition Terminals
- Ignition Wires (Secondary)
- Inertia Fuel Shut-Off Switches
- Intake Air Temperature Sensors
- Intake Cleaning
- Intake Manifolds
- In-Tank Fuel Strainers
- INTERCOOLERS
- Knock Sensors
- Liquid Vapor Separators
- Long Block Assemblies
- Manifold Absolute Pressure (Map) Sensors
- Mass Air Flow (MAF) Sensors
- Metal Air Manifolds And Pipes
- Metal Air Pipes
- Mix Control Solenoids
- Motor Mounts
- O2 Sensors
- Oil Pans
- Oil Pressure Sending Units
- Oil Pump Pick-Up Screens
- Oil Pumps
- O-Rings, Gaskets, Seals And Spring Locks
- Park Neutral Position Switches
- PCV Breather Elements
- PCV Orifices
- PCV Valves
- Pick-Up Assemblies (Includes Magnetic, Hall Effect And Optical)
- Power Steering Pressure Sensors
- Powertrain Control Modules (Pcm) And Prom
- Powertrain Control Prom
- Pressurized Expansion Tank Caps
- Radiator / Cooling Fan Blades
- Radiator / Cooling Fan Clutches
- Radiator Caps And Pressurized Expansion Tank Caps
- Radiators
- Roll Over Valves
- Sealing Compounds
- Seals
- Secondary Air Injection System Management Devices
- Sensors
- Short Block Assemblies
- Shrouds, Baffles And Deflectors
- Spark Plugs
- Spring Locks
- Super Chargers
- Switches
- Thermal Vacuum Valves
- Thermostatic Air Door Assemblies
- Thermostats And Housings
- Throttle Bodies
- Throttle Body Cleaning
- Throttle Cables
- Throttle Linkages And Cables
- Throttle Position Sensors
- Throttle Position Switches
- Timing Belt Sprockets
- Timing Belts
- Timing Covers
- Torque Struts
- Transmission Range Switches
- Tube Clamps
- Tube Connectors
- Tube Couplers
- Tubes
- Turbo Chargers
- Vacuum Connections
- Vacuum Hoses, Tubes And Connections (Non-Metallic)
- Vacuum Regulator Solenoids
- Vacuum Tubes
- Valve Covers
- Vehicle Speed Senors
- Volume Air Flow Sensors
- Waste Gate And Boost Control Mechanisms
- Waste Gate Control Solenoids
- Water Pumps (Electric)
- Water Pumps (Non-Electric)
- Wiring Harnesses And Connectors
- Reason Code Explanation
- Automotive Terminology & Definitions
- Parasitic Load Explanation & Test Procedures - General Information
- State Emission Standards - Diesel
- State Emission Standards - Gas
- ALASKA
- ARIZONA
- CALIFORNIA
- Colorado
- CONNECTICUT
- DELAWARE
- District Of COLUMBIA
- GEORGIA
- IDAHO
- ILLINOIS
- INDIANA
- KENTUCKY
- MARYLAND
- MASSACHUSETTS
- MISSOURI
- NEVADA
- New Jersey
- New MEXICO
- New YORK
- North CAROLINA
- OHIO
- OREGON
- PENNSYLVANIA
- RHODE Island
- TENNESSEE
- TEXAS
- UTAH
- VIRGINIA
- WASHINGTON
- WISCONSIN
- U. S. EPA ASM2525 & ASM5015 Start-Up Emission Standards
- U. S. EPA Revised Final ASM Emission Standards (ASM5015 & ASM2525)
- U.S. EPA Im240 Emission Standards
- Waveforms - Injector Pattern Tutorial - General Information
- * Please Read This First *
- Purpose Of This Article
- Is A Lab Scope Necessary?
- The Two Types Of Injector Drivers
- The Two Ways Injector Circuits Are Wired
- Interpreting Injector Waveforms
- Current Waveform Samples
- Notes
- Example #1 - Voltage Controlled Driver
- Example #2 - Voltage Controlled Driver
- Example #3 - Voltage Controlled Driver
- Example #4 - Current Controlled Driver
- Example #5 - Current Controlled Driver
- Example #6 - Current Controlled Driver
- Example #7 - Current Controlled Driver
- Example #8 - Current Controlled Driver
- Voltage Waveform Samples
- Notes
- Example #1 - Voltage Controlled Driver
- Example #2 - Voltage Controlled Driver
- Example #3 - Voltage Controlled Driver
- Example #4 - Current Controlled Driver
- Example #5 - Current Controlled Driver
- Example #6 - Current Controlled Driver
- Example #7 - Current Controlled Driver
- Example #8 - Current Controlled Driver
- Map - Exhaust Systems
- Exhaust Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Catalytic Converters
- Exhaust And Tail Pipes
- Exhaust Connections
- Hangers
- Heat Risers (Mechanical EFE Devices)
- Heat Shields
- Manifolds (Cast And Tube Type)
- Mechanical EFE Devices
- Muffler Valve
- Mufflers And Resonators
- Reason Code Explanation
- Exhaust Systems
- Heating, Ventilation & A/C (HVAC)
- Map - Heating, Ventilation, & Air Conditioning
- Heating, Ventilation & Air Conditioning Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Accumulators
- Actuators (Electrical)
- Actuators (Vacuum)
- Air Conditioning Fittings
- Air Conditioning Hoses
- Air Conditioning Metal Lines
- Air Control Doors
- Air Dams (External)
- Air Distribution System
- Belts
- Blend Doors
- Blower Fans (Blower Wheel Or Squirrel Cage)
- Blower Motors
- Blower Resistors
- Blower Switches
- Cabin Air Filters
- Circuit Breakers
- Compressor Clutch Assemblies
- Compressors
- Condenser Air Seals
- Condenser Fan Motors
- Condensers
- Connectors
- Control Cables
- Control Heads (Function Selectors)
- Control Linkages
- Control Modules
- Coolant
- Cooling Fan Blades
- Cooling Fan Clutches
- Cooling Fan Motors
- Evaporator Drain Tubes
- Evaporator Filters
- Evaporator Pressure Regulators (EPRS)
- Evaporators
- Expansion Valves
- Function Selectors
- Fuses, Fusible Links And Circuit Breakers
- Fusible Links
- Gaskets
- Heater Cases
- Heater Control Valves
- Heater Cores
- Heater Hoses
- High Pressure Relief Valves (HPRV)
- Idlers
- In-Line Filters
- Metal Fittings
- Metal Lines
- Mix And Air Control Doors (Blend Doors)
- ORIFACE Tubes
- O-Rings
- Pilot-Operated Absolutes (POAS)
- Plenums
- Pressure Control Valves
- Pressure Sensors
- Pulleys
- Radiators
- Receiver-DRIERS
- Refrigerant Oil
- Refrigerant
- Relays
- Seals
- Service Ports
- Spring Lock Couplings
- Suction Throttling Valves (STVS)
- Switches (Electrical)
- TENSIONERS
- Thermistors And Pressure Sensors
- Thermostats And Housings
- Vacuum Hoses And Tubes
- Vacuum Reservoirs
- Vacuum Tubes
- Valves In Receiver (VIRS)
- Water Pumps (Electric Auxiliary)
- Wiring Harnesses And Connectors
- Heating, Ventilation & Air Conditioning System CHECKSHEET
- Reason Code Explanation
- Automotive Terminology & Definitions
- Heating, Ventilation & Air Conditioning Systems
- Map - Heating, Ventilation, & Air Conditioning
- Identification
- Metric Conversions
- OEM General Information
- How To Use The Engine Performance Section
- Maintenance Reminder Light (Reset Procedures)
- A/C Filter Service Reminder
- Engine Oil Replacement Reminder
- Notes
- Engine Oil Replacement Reminder Reset - Procedure 01
- Engine Oil Replacement Reminder Reset - Procedure 02
- Engine Oil Replacement Reminder Reset - Procedure 03
- Engine Oil Replacement Reminder Reset - Procedure 04
- Engine Oil Replacement Reminder Reset - Procedure 05
- Engine Oil Replacement Reminder Reset - Procedure 06
- Engine Oil Replacement Reminder Reset - Procedure 07
- Engine Oil Replacement Reminder Reset - Procedure 08
- Engine Oil Replacement Reminder Reset - Procedure 09
- Engine Oil Replacement Reminder Reset - Procedure 10
- Engine Oil Replacement Reminder Reset - Procedure 11
- Engine Oil Replacement Reminder Reset - Procedure 12
- Engine Oil Replacement Reminder Reset - Procedure 13
- Engine Oil Replacement Reminder Reset - Procedure 14
- Engine Oil Replacement Reminder Reset - Procedure 15
- Engine Oil Replacement Reminder Reset - Procedure 16
- Engine Oil Replacement Reminder Reset - Procedure 17
- Engine Oil Replacement Reminder Reset - Procedure 18
- Engine Oil Replacement Reminder Reset - Procedure 19
- Engine Oil Replacement Reminder Reset - Procedure 20
- Engine Oil Replacement Reminder Reset - Procedure 21
- Engine Oil Replacement Reminder Reset - Procedure 22
- Engine Oil Replacement Reminder Reset - Procedure 23
- Engine Oil Replacement Reminder Reset - Procedure 24
- Engine Oil Replacement Reminder Reset - Procedure 25
- Engine Oil Replacement Reminder Reset - Procedure 26
- Engine Oil Replacement Reminder Reset - Procedure 27
- Engine Oil Replacement Reminder Reset - Procedure 28
- Maintenance Service Reminder (Overhead Warning Lights)
- Maintenance Service Reminder (Sri)
- Maintenance Service Reminder (VMM)
- Tire Pressure Monitor System Reminder
- Notes
- Tire Pressure Sensor Types
- TPMS Reminder Reset - Procedure 01
- TPMS Reminder Reset - Procedure 02
- TPMS Reminder Reset - Procedure 03
- TPMS Reminder Reset - Procedure 04
- TPMS Reminder Reset - Procedure 05
- TPMS Reminder Reset - Procedure 07
- TPMS Reminder Reset - Procedure 08
- TPMS Reminder Reset - Procedure 09
- TPMS Reminder Reset - Procedure 10
- Restraints
- Supplemental Inflatable Restraint System Deactivation Procedures
- Special Care During Mechanical Repairs
- CHRYSLER Corp.
- Ford Motor Co.
- Notes
- System Operation Check
- Service Precautions
- Disabling & Activating Air Bag System
- Notes
- Disabling System (Continental, Crown Victoria, Grand Marquis & Town Car)
- Activating System
- Disabling System (Contour, Mystique & Windstar)
- Disabling System (Escort, Escort Coupe, "F" Series Pickups & Tracer)
- Disabling System ("E" Series Vans With One Battery)
- Disabling System ("E" Series Vans With Dual Batteries)
- Disabling System (Explorer, Expedition, Mountaineer, Navigator & Ranger)
- Disabling System (Mark VIII, Mustang, Sable & Taurus)
- Disabling System (Villager)
- Driver-Side Air Bag Module
- Removal & Installation (Expedition, Explorer, "E" Series Vans, "F" Series Pickups, Mountaineer, Navigator & Ranger)
- Removal & Installation (Continental, Crown Victoria, Grand Marquis, Mark VIII, Mustang, Sable, Taurus & Town Car)
- Removal & Installation (Contour & Mystique)
- Removal & Installation (Escort, Escort Coupe & Tracer)
- Removal & Installation (Windstar)
- Passenger-Side Air Bag Module
- Removal & Installation (Continental, Crown Victoria, Grand Marquis & Town Car)
- Removal & Installation (Contour & Mystique)
- Removal & Installation ("E" Series Vans)
- Removal & Installation (Expedition, "F" Series Pickups & Navigator)
- Removal & Installation (Explorer & Mountaineer)
- Removal & Installation (Escort, Escort Coupe & Tracer)
- Removal & Installation (Mark VIII)
- Removal & Installation (Mustang & Ranger)
- Removal & Installation (Sable & Taurus)
- Removal & Installation (Windstar)
- Torque Specifications
- General Motors
- Notes
- System Operation Check
- Service Precautions
- Disabling & Activating Air Bag System
- Notes
- Disabling & Activating System (Corvette)
- Disabling & Activating System (Catera)
- Disabling & Activating System (Concours, DeVille, Eldorado & Seville)
- Disabling & Activating System (Cutlass & Malibu)
- Disabling & Activating System (Grand Prix)
- Disabling & Activating System (Lumina & Monte Carlo)
- Disabling & Activating System (Metro, Firefly (Canadian) & Tracker)
- Disabling & Activating System (Prizm)
- Disabling & Activating System (Saturn)
- Disabling & Activating System (Silhouette, Trans Sport & Venture)
- Disabling & Activating System (All Other Models)
- Jeep
- Supplemental Inflatable Restraint System Deactivation Procedures
- Specifications Index
- Steering
- Map - Steering, Suspension, Wheel Alignment, Wheels & Tires
- Steering & Suspension Systems
- Wheel And Tire
- Steering & Suspension CHECKSHEET
- Wheels & Tires CHECKSHEET
- Steering And Suspension, Wheel Alignment, Wheels And Tires
- Notes
- Active Handling
- Active Suspension Control Modules
- Active Variable Ratio Steering
- Active Yaw Control
- Adaptive Cruise Control
- Advance TRAC
- Air Bags
- Air Ride Control Modules
- Air Ride Suspension Torsion Springs (Counter Balancing)
- Air Ride Suspension
- Air Ride Tubes
- Air Shocks And Air Struts
- Air Spring Valves
- Air Springs
- Air Suspension Control Valves
- Air Suspension DRIERS
- Axle Acceleration Sensor
- Ball Joints
- Body Acceleration Sensor
- Bushings
- Center Links
- Compressors
- Continuous Damping Control
- Control Arm Shafts
- Control Arms
- Control Modules
- Distance Regulation Control Module
- Distance Regulation Sensor
- Drag Links
- Dynamic Stability Control
- Dynamic Stability Traction Control
- Electronic Ride Control Shocks And Struts
- Electronic Stability Control
- Electronic Suspension System
- Flex Couplers
- Gaskets
- Height Sensors
- Hydraulic Hoses
- Hydraulic Power Steering Pumps
- Hydraulic Suspension Hoses
- Hydraulic Suspension Pumps
- Idler Arms
- Intermediate Shaft U-Joints
- King Pins
- Modules
- Pitman Arms
- Power Steering Belts
- Power Steering Coolers
- Power Steering Fluid
- Power Steering Hoses
- Power Steering Lines (Steel)
- Power Steering Pumps - Electric
- Power Steering Pumps
- Radar Sensor
- Radius Arms
- Relay Rods
- Relays
- Sensors
- Shock Absorbers, Strut Cartridges And Strut Assemblies
- Spindles
- Springs, Coil, Leaf And Torsion Bars
- STABILITRAC
- Stability Management System
- Steering Angle Sensor
- Steering Arms
- Steering Couplers
- Steering Dampers
- Steering Gears (Except Rack And Pinion)
- Steering Gears, Rack And Pinion
- Steering Knuckles
- Strike Out Bumpers
- Strut Bearing Plate Assemblies
- Strut Rods
- Suspension Pumps (Hydraulic)
- Sway Bar Links
- Sway Bar Mounting Bushings
- Sway Bars
- Switches
- Tie Rod Ends (Inner And Outer)
- Tire Pressure Monitoring System
- Tire Pressure Sensors
- Tires
- Torque Sensor
- Torsion Springs
- Track Bar Bushings
- Track Bars
- Trailing Arm Bushings
- Trailing Arms
- Valve Stems
- Vehicle Dynamics Control
- Vehicle Speed Sensor
- Vehicle Stability Assist
- Vehicle Stability/Skid Control
- Warning Lamps
- Wheel Alignment
- Wheel Attachment Hardware
- Wheel Bearings, Races And Seals
- Wheels (Rims)
- Wiring Harnesses And Connectors
- Reason Code Explanation
- Automotive Terminology & Definitions
- Wheel Alignment Theory & Operation - General Information
- Map - Steering, Suspension, Wheel Alignment, Wheels & Tires
- Traction Control Disable Procedures
- Trouble Shooting - Manual Transmission - General Information
- Heating, Ventilation & A/C (HVAC)
- General Servicing
- Cabin Air Filter (Special Applications) - General Information
- HVAC System General Servicing
- Refrigerant Oil & Refrigerant Capacity Specifications
- USING R-134a REFRIGERANT
- System Service Valves
- Service Equipment
- Manifold Gauge Set
- Pressure-Temperature Relationship
- Pressure Gauge Readings
- Orifice Tube Replacement
- Refrigerant Recovery/Recycling
- Flushing A/C System
- Evacuating A/C System
- Charging A/C System
- Leak Testing
- HVAC System - Compressor Servicing
- HVAC System - Specifications
- HVAC System Compressor Refrigerant Oil Checking
- HVAC Control Systems
- HVAC System - Automatic
- A/C System Specifications
- Description
- Operation
- Trouble Shooting
- Self-Diagnostics
- Notes
- Entering Self-Diagnostics
- Exiting Self-Diagnostics
- Symptom Diagnosis
- Test P1464: A/C Demand Out Of Self-Test Range
- Test B1249: Electronic Blend Door Actuator Failure
- Test B1251/B1253: In-Car Temperature Sensor Circuit Inoperative
- DTC B1255/B1257 Test: Ambient Temperature Sensor Circuit Inoperative
- Test B1260/B1261: SUNLOAD Sensor Inoperative
- Test A: No Communication With EATC Module
- Test B: EATC System Does Not Operate Or Operates Improperly
- Test C: Blower Motor Does Not Operate
- Test D: Blower Motor Operates Continuously In High Speed
- Test E: Blower Motor Does Not Operate At High Speed
- Test F: Blower Motor Does Not Operate At Lower Speeds
- Test G: A/C Does Not Operate Or Does Not Operate Properly
- Test H: A/C Is Always On
- Test J: Temperature Set Point Does Not Repeat After Turning Ignition Off
- Test K: Temperature Display Will Not Switch Between °F & °C
- Testing
- Removal & Installation
- Notes
- A/C Compressor
- A/C Condenser
- Suction Accumulator-Drier
- A/C Clutch Cycling Switch
- Evaporator Housing
- Fixed Orifice Tube
- Electronic Automatic Temperature Control (EATC) Module
- Ambient Temperature Sensor
- SUNLOAD Sensor
- Instrument Panel
- Plenum & Heater Core
- Blower Motor
- Blower Motor Speed Controller
- Electronic Blend Door Actuator
- Vacuum Reservoir
- Torque Specifications
- Vacuum Hose Diagram(S)
- Wiring Diagram
- HVAC System - Manual
- A/C System Specifications
- Description
- Operation
- Trouble Shooting
- Preliminary Inspection
- Symptom Diagnosis
- DTC 1464 Test: A/C Demand Out Of Self-Test Range
- Test A: Improper/Erratic Airflow
- Test B: Insufficient, Erratic Or No Heat
- Test C: Electronic Blend Door Actuator Inoperative, Intermittent Or Improper Operation
- Test D: A/C Does Not Operate Or Does Not Operate Properly
- Test E: A/C Is Always On
- Test F: No Operation In All Blower Settings
- Test G: Blower Does Not Operate In High Speed
- Test H: Blower Operates In High Speed Only
- Testing
- Removal & Installation
- Torque Specifications
- Vacuum Hose Diagram(S)
- Wiring Diagram
- HVAC System - Automatic
- General Servicing
- Maintenance
- Procedures
- Maintenance Information
- Model Identification
- Maintenance Service Information
- Service Point Locations
- Lubrication Specifications
- Fluid Capacities
- Wheel & Tire Specifications
- Battery Specifications
- Cautions & Warnings
- Supplemental Restraint System (Air Bag System)
- Air Conditioning Servicing
- Air Suspension System
- Anti-Lock Brake System
- Replacing Blown Fuses
- Brake Pad Wear Indicator
- Catalytic Converter
- Coolant
- Electrostatic Discharge Sensitive (ESD) Parts
- Fuel Pump Shutoff Switch
- Fuel System Service
- Halogen Bulbs
- Methanol Gasoline
- Radiator Cap
- Radiator Fan
- Spark Plugs
- Warranty Information
- Fuses & Circuit Breakers
- Maintenance Reminder Light (Reset Procedures)
- A/C Filter Service Reminder
- Engine Oil Replacement Reminder
- Notes
- Engine Oil Replacement Reminder Reset - Procedure 01
- Engine Oil Replacement Reminder Reset - Procedure 02
- Engine Oil Replacement Reminder Reset - Procedure 03
- Engine Oil Replacement Reminder Reset - Procedure 04
- Engine Oil Replacement Reminder Reset - Procedure 05
- Engine Oil Replacement Reminder Reset - Procedure 06
- Engine Oil Replacement Reminder Reset - Procedure 07
- Engine Oil Replacement Reminder Reset - Procedure 08
- Engine Oil Replacement Reminder Reset - Procedure 09
- Engine Oil Replacement Reminder Reset - Procedure 10
- Engine Oil Replacement Reminder Reset - Procedure 11
- Engine Oil Replacement Reminder Reset - Procedure 12
- Engine Oil Replacement Reminder Reset - Procedure 13
- Engine Oil Replacement Reminder Reset - Procedure 14
- Engine Oil Replacement Reminder Reset - Procedure 15
- Engine Oil Replacement Reminder Reset - Procedure 16
- Engine Oil Replacement Reminder Reset - Procedure 17
- Engine Oil Replacement Reminder Reset - Procedure 18
- Engine Oil Replacement Reminder Reset - Procedure 19
- Engine Oil Replacement Reminder Reset - Procedure 20
- Engine Oil Replacement Reminder Reset - Procedure 21
- Engine Oil Replacement Reminder Reset - Procedure 22
- Engine Oil Replacement Reminder Reset - Procedure 23
- Engine Oil Replacement Reminder Reset - Procedure 24
- Engine Oil Replacement Reminder Reset - Procedure 25
- Engine Oil Replacement Reminder Reset - Procedure 26
- Engine Oil Replacement Reminder Reset - Procedure 27
- Engine Oil Replacement Reminder Reset - Procedure 28
- Maintenance Service Reminder (Overhead Warning Lights)
- Maintenance Service Reminder (Sri)
- Maintenance Service Reminder (VMM)
- Tire Pressure Monitor System Reminder
- Notes
- Tire Pressure Sensor Types
- TPMS Reminder Reset - Procedure 01
- TPMS Reminder Reset - Procedure 02
- TPMS Reminder Reset - Procedure 03
- TPMS Reminder Reset - Procedure 04
- TPMS Reminder Reset - Procedure 05
- TPMS Reminder Reset - Procedure 07
- TPMS Reminder Reset - Procedure 08
- TPMS Reminder Reset - Procedure 09
- TPMS Reminder Reset - Procedure 10
- Maintenance Information
- Procedures
- Restraints
- Air Bag, SRS
- Supplemental Inflatable Restraint System
- Description & Operation
- System Operation Check
- Post-Collision Inspection
- Service Precautions
- Disabling & Activating Air Bag System
- Adjustments
- Disposal Procedures
- Removal & Installation
- Diagnosis & Testing
- Diagnostic Tests
- Notes
- Test A: Air Bag Warning Light On Continuously - ECS Module
- Test B: ECS Module Internal Fault (DTC B1342)
- Test C: Crash Data Memory Full (DTC B1231)
- Test D: Ground Resistance Too High Or ECS Module Not Mounted
- Test E: Low Battery Voltage (DTC B1318)
- Test F: Incorrect Module Design Level (DTC C1414)
- Test G: Driver Air Bag Circuit Short To Ground (DTC B1887)
- Test H: Driver Air Bag Circuit Short To Battery Or Ignition
- Test I: Passenger Air Bag Circuit Short To Ground (DTC B1888)
- Test J: Passenger Air Bag Circuit Short To Battery Or Ignition (DTC B1925)
- Test K: Driver Air Bag Resistance High (DTC B1932)
- Test L: Passenger Air Bag Resistance High (DTC B1933)
- Test M: Driver Air Bag Low Resistance (DTC B1934)
- Test N: Passenger Air Bag Resistance Low (DTC B1935)
- Test O: Impact Sensor Open Or Short To Battery (DTC B1941)
- Test P: Impact Sensor Short To Ground (DTC B1901)
- Test Q: Air Bag Tone Warning Indicator Circuit Short To Ground Or Open (DTC B1892)
- Test R: Air Bag Tone Warning Indicator Circuit Short To Battery Or Ignition (DTC B1891)
- Test S: Non-Volatile Memory Configuration (DTC B2141)
- Test T: Air Bag Warning Light Inoperative (DTC B1869)
- Test U: Air Bag Warning Light CKT Short To Battery (DTC B1870)
- Test V: Unexpected Feature Present (DTC B1871, B1877, B1878, B1879, B1881, B1882, B1883, B1884, B1885, B1886, B1889, B1890)
- Test W: No Communication With ECS Module
- Wire Repair
- Torque Specifications
- Wiring Diagrams
- Supplemental Inflatable Restraint System -- Air Bag/SRS Component Inspection & Replacement Tables
- Supplemental Inflatable Restraint System
- Restraints Control Systems
- Seat Belts
- Air Bag, SRS
- Steering
- Steering Column
- Description & Operation
- Safety Precautions
- Disabling & Activating Air Bag System
- Removal & Installation
- Overhaul
- Torque Specifications
- Steering Gear
- Electronic Variable Orifice (EVO) Steering System
- Description & Operation
- Lubrication
- Adjustments
- Diagnosis & Testing
- Diagnostic Tests
- Notes
- Test A: Actuator Circuit Open
- Test B: Actuator Circuit Shorted
- Test C: Actuator High Side Shorted To Ground
- Test D: Actuator Circuit Shorted To Battery
- Test E: Actuator Circuit Low Side Shorted To Ground
- Test F: Steering Wheel Rotation Not Detected
- Test G: Vehicle Speed Greater Than 15 Mph Not Detected
- Test H: Steering Does Not Vary With Vehicle Speed (1998 Models)
- Test J: Steering Wheel Rotation Not Detected
- Test K: Steering Diagnostics Cannot Be Entered (1998 Models)
- Test L: Steering Very Difficult/Very Easy (1998 Models)
- Removal & Installation
- Overhaul
- Torque Specifications
- Wiring Diagrams
- Electronic Variable Orifice (EVO) Steering System
- Steering Column
- Suspension
- Rear Electronic Suspension System
- Description
- Operation
- Adjustments
- Trouble Shooting
- Diagnosis & Testing
- Diagnostic Tests
- Notes
- Test A: No Communication With Module (1999 Models)
- Test B: Unable To Enter Auto Test (1998 Models)
- Test B: Unable To Enter Self-Test (1999 Models)
- Test C: DTC 39 - Compressor Relay Circuit Short To Power (1998 Models)
- Test C: DTC 39 - Compressor Relay Circuit Short To Power (1999 Models)
- Test D: DTC 40 - Compressor Relay Control Circuit Failure (1998 Models)
- Test D: DTC 40 - Compressor Relay Control Circuit Failure (1999 Models)
- Test E: DTC 42 - Air Spring Solenoid Short To Ground (1998 Models)
- Test E: DTC 42 - Air Spring Solenoid Short To Ground (1999 Models)
- Test F: DTC 43 - Air Spring Solenoid Short To Power (1998 Models)
- Test F: DTC 43 - Air Spring Solenoid Short To Power (1999 Models)
- Test G: DTC 44 - Vent Solenoid Valve Short To Power (1998 Models)
- Test G: DTC 44 - Vent Solenoid Valve Short To Power (1999 Models)
- Test H: DTC 45 - Vent Solenoid Circuit Short (1998 Models)
- Test H: DTC 45 - Vent Solenoid Circuit Short (1999 Models)
- Test I: DTC 46 - Height Sensor Shorted (All Models)
- Test J: DTC 51 - Lowering Not Detected (All Models)
- Test K: DTC 54 - Unable To Detect Rear Raising (1998 Models)
- Test K: DTC 54 - Unable To Detect Rear Raising (1999 Models)
- Test L: DTC 55 - Speed Greater Than 15 Mph Not Detected (All Models)
- Test M: DTC 60 - Service Switch Short To Voltage (1998 Models)
- Test M: DTC 60 - Service Switch Short To Voltage (1999 Models)
- Test N: DTC 61 - Service Switch Short Or Open (1998 Models)
- Test N: DTC 61 - Service Switch Short Or Open (1999 Models)
- Test O: DTC 68 - Height Sensor Output Shorted (All Models)
- Test P: DTC 71 - Height Sensor Circuit Open (All Models)
- Test Q: DTC 72 - Door Close Signals Not Detected (All Models)
- Test R: DTC 80 - Battery Voltage Low (1998 Models)
- Test R: DTC 80 - Battery Voltage Low (1999 Models)
- Relay Test
- Removal & Installation
- Torque Specifications
- Wiring Diagrams
- Front Suspension
- Rear Suspension
- Wheel Alignment Specifications & Procedures
- Rear Electronic Suspension System
- Transmission
- Automatic Trans
- Automatic Transmission Removal & Installation
- Automatic Transmission Servicing
- Application
- Identification
- Lubrication
- Service Intervals
- Checking Fluid Level
- Recommended Fluids
- Fluid Capacities
- Draining & Refilling
- Notes
- AX4N & AX4S (Continental, Sable, Taurus & Windstar)
- CD4E (Contour, Cougar & Mystique)
- E4OD & 4R100 (Expedition, Navigator, Pickup & Van)
- F4E III /F4E Type "F" (Escort & Tracer)
- 4F20E (Villager)
- 4R44E & 5R55E (Explorer, Mountaineer & Ranger)
- 4R70W & 4R100 (Expedition, Crown Victoria, Grand Marquis, Mark VIII, Mountaineer, Mustang, Navigator, Pickup, Town Car & Van)
- Adjustments
- Notes
- Band
- Shift Cable/Linkage
- Shift Indicator Cable
- Transmission Range (Tr) Sensor/Switch
- AX4N & AX4S (Continental, Sable, Taurus & Windstar)
- CD4E & E4OD (Contour, Cougar, Expedition, Mystique, Pickup & Van)
- F4E III (Escort & Tracer)
- 4F20E (Villager)
- 4R44E & 5R55E (Aerostar & Ranger)
- 4R70W (Crown Victoria, Cougar, Expedition, Explorer, Grand Marquis, Mark VIII, Mountaineer, Mustang, Pickup, Town Car & Van)
- 4R100 (Expedition, Navigator, Pickup & Van)
- Torque Specifications
- Diagnosis - 4R70W Automatic Transmission
- Description & Operation
- Notes
- Input Sensors
- Notes
- Air Conditioning Clutch (ACC)
- Brake On/Off (BOO) Switch
- Electronic Ignition (EI)
- Engine Coolant Temperature (ECT) Sensor
- Mass Airflow (MAF) Sensor
- Transmission Range (TR) Sensor
- Output Shaft Speed (OSS) Sensor
- Programmable Speedometer/Odometer Module (PSOM)
- Throttle Position (TP) Sensor
- Transmission Control Switch (TCS)
- Transmission Fluid Temperature (TFT) Sensor
- Vehicle Speed Sensor (VSS)
- Output Devices
- Trouble Shooting
- Self-Diagnostic System
- Diagnostic Procedure
- Diagnostic Trouble Codes (DTC)
- Retrieving Codes
- Reading Codes
- Clearing Codes
- Quick Test
- Output State Control (OSC) Modes
- Additional System Functions
- Symptom Diagnosis
- Harsh Reverse Only Engagement
- Harsh Forward Only Engagement
- Some Or All Shifts Missing
- Some Or All Shifts Early Or Late
- Erratic Or Hunting Shifts
- Soft Or Slipping Shifts
- Harsh Shifts
- No Manual 1st Or 2nd Gear
- No 1st Gear
- No 1-2, 2-3 Or 3-4 Upshift (Automatic)
- No TCC Engagement
- TCC Always Engaged
- TCC Cycling Or Shuddering
- Poor Vehicle Performance Only
- Incorrect Gear Ratio In "D", "2" Or "1" Positions
- Engine Will Not Crank
- Transmission Drive Cycle Test
- Pinpoint Tests: 1997 Models
- Pinpoint Tests: 1998 Models
- Notes
- How To Use Circuit Tests & Pinpoint Tests
- Test A: Shift Solenoid & TCC Solenoid Electrical Circuit
- Test B: TFT Sensor Circuit
- Test D: Transmission Range (Tr) Sensor
- Test E: EPC Solenoid
- Test F: Output Shaft Speed (OSS) Sensor
- Test H: Solenoid Mechanical Failure
- Test Tb: Transmission Control Switch (TCS), Transmission Control Indicator Lamp (TCIL)
- Test TG: 4WD Low Range Switch
- Wiring Diagrams
- Description & Operation
- Overhaul - 4R70W Automatic Transmission
- Application
- Identification
- Description
- Lubrication & Adjustments
- On-Vehicle Service
- Trouble Shooting
- Notes
- Symptom Diagnosis
- No Forward Engagement
- No Reverse Engagement
- Harsh Reverse Engagement
- Harsh Forward Engagement
- Delayed/Soft Reverse Engagement
- Delayed/Soft Forward Engagement
- Some Or All Shifts Missing
- Early/Late Shift Speeds
- Erratic/Hunting Shifting
- Soft/Slipping Shift Feel
- Harsh Shift Feel
- No 1st Gear In Drive, Engages In Higher Gear
- No Manual Low Gear
- No Manual 2nd Gear
- No 1-2 Automatic Shift
- No 2-3 Automatic Shift
- No 3-4 Automatic Shift
- No 4-3 Automatic Downshift
- No 3-2 Automatic Downshift
- No 2-1 Automatic Downshift
- No Torque Converter Clutch Application
- Torque Converter Clutch Always Applied
- Torque Converter Clutch Cycling/Shudder/Chatter
- Miscellaneous Faults
- Clutch & Band Application Chart
- Testing
- Torque Converter
- Removal & Installation
- Transmission Disassembly
- Component Disassembly & Reassembly
- Transmission Reassembly
- Transmission Specifications
- Torque Specifications
- Shift Interlock Systems
- Description & Operation
- Trouble Shooting
- Diagnosis & Testing
- Removal & Installation
- Gearshift Lever Assembly
- Removal & Installation (Aspire)
- Removal & Installation (Continental & Town Car)
- Removal & Installation (Contour & Mystique)
- Removal & Installation (Cougar, Mustang & Thunderbird)
- Removal & Installation (Escort & Tracer)
- Removal & Installation (Mark VIII)
- Removal & Installation (Probe)
- Removal & Installation (Sable & Taurus)
- Removal & Installation (Light Duty Trucks & Vans)
- Shift Interlock Actuator
- Shift Interlock Cable
- Steering Column/Ignition/Lighting Control (SCIL) Module
- Gearshift Lever Assembly
- Torque Specifications
- Wiring Diagrams
- Automatic Transmission - Hydraulic Diagrams - 4R70W
- Automatic Trans
- External Pages