Section 139 (Engine Controls - System & Component Testing - 7.3L Diesel)
WARNING: This page does not describe the selected car, but rather 9 other vehicles, including the 2003 Ford RV Cutaway, 2003 Ford Pickup, 2003 Ford F550 Super Duty, 2003 Ford F450 Super Duty, and 2003 Ford Excursion. However, it is still accessible from the selected car via links, so may be relevant.
- Introduction
- Air Induction Systems
- Hard Start/No-Start Diagnostic Procedures
- Notes
- Test 1: Visual Engine/Chassis Inspection
- Test 2: Check Engine Oil Level
- Test 3: Intake/Exhaust Restriction
- Test 4: Sufficient Clean Fuel
- Test 5: Electric Fuel Pump Pressure
- Test 6: Perform KOEO On-Demand Self-Test
- Test 7: Retrieve/Clear Continuous Memory DTCS
- Test 8: KOEO Injector Electrical Self-Test
- Test 9A: Check VPWR While Cranking
- Test 9B: Check Rpm Signal While Cranking
- Test 9C: Monitor ICP PID While Cranking
- Injection Control Pressure Leak Test
- Test 9D: Check Fuel Pulse Width While Cranking
- Test 10: Glow Plug System Operation
- Engine Performance Diagnostic Procedures
- Notes
- Test 1: Visual Engine/Chassis Inspection
- Test 2: Sufficient Clean Fuel
- Test 3: Check Engine Oil Level
- Test 4: Intake Restriction
- Test 5: Perform KOEO On-Demand Self-Test
- Test 6: Retrieve/Clear Continuous Memory DTCS
- Test 7: KOEO Injector Electrical Self-Test
- Test 8A: Fuel Pressure Test
- Test 8B: Fuel Pressure Test
- Test 8C: Electric Fuel Pump Pressure Test
- Test 8D: Electric Fuel Pump Inlet Restriction
- Test 9: Perform KOER On-Demand Self-Test
- Test 10A: Injection Control Pressure Test (Oil Aeration/Poor Idle)
- Test 10B: Low Idle Stability (ICP Pressure)
- Test 11: Crankcase Pressure Test
- Test 12: Cylinder Contribution Test
- Test 13: Exhaust Restriction
- Test 14: Boost Pressure Test
- Turbocharger