Section 1679 (HVAC Control System - General Information & Diagnostics)
WARNING: This page is about a different car, the 2006 Mercury Montego, 2006 Ford Freestyle, and 2006 Ford Five Hundred. However, it is still accessible from the selected car via links, so may be relevant.
- Specifications
- Description And Operation
- Diagnosis And Testing
- Climate Control System
- Notes
- Inspection and Verification
- Electronic Automatic Temperature Control Module - Diagnostic Methods
- Diagnostic Trouble Code Index
- Symptom Table
- Pinpoint Tests
- Pinpoint Test A: DTC B1251 or DTC B1253 - A/C In-Vehicle Temperature Sensor Open Circuit or Short to Ground
- Pinpoint Test B: DTC B1255 or DTC B1257 - A/C Ambient Temperature Sensor Open Circuit or Short to Ground
- Pinpoint Test C: DTC B2796 or DTC B2795 - Solar Radiation Sensor Open Circuit or Short to Ground
- Pinpoint Test D: DTC B1242 Air Inlet Door Short/Failure
- Pinpoint Test E: Incorrect/Erratic Direction of Airflow From Outlet(s)
- Pinpoint Test F: No Communication With the Electronic Automatic Temperature Control (EATC) Module
- Pinpoint Test G: The EATC System is Inoperative, Intermittent or Incorrect Operation
- Pinpoint Test H: Insufficient, Erratic or No Heat
- Pinpoint Test I: The Air Conditioning is Inoperative (A/C) Does Not Operate Correctly
- Pinpoint Test J: The Air Conditioning (A/C) is Always On
- Pinpoint Test K: Temperature Control is Inoperative/Does Not Operate Correctly
- Pinpoint Test L: The Blower Motor Is Inoperative - EMTC
- Pinpoint Test M: The Blower Motor Does Not Operate Correctly - EMTC
- Pinpoint Test N: The Blower Motor is Inoperative - EATC
- Pinpoint Test O: The Blower Motor Does Not Operate Correctly - EATC
- Pinpoint Test P: The Auxiliary Blower Motor Is Inoperative
- Pinpoint Test Q: The Auxiliary Blower Motor Does Not Operate Correctly
- Pinpoint Test R: The Temperature Control is Inoperative/Does Not Operate Correctly Using the Front/Rear Auxiliary Climate Controls
- Pinpoint Test S: The Panel/Floor Control is Inoperative/Does Not Operate Correctly Using the Front/Rear Auxiliary Climate Controls
- Pinpoint Test T: The Temperature, Panel/Floor and Blower Motor Controls are Inoperative/Do Not Operate Correctly Using the Front/Rear Auxiliary Climate Controls
- Component Tests
- Heater Core
- Evaporator/Condenser Core - On-Vehicle Leak Test
- A/C Compressor - External Leak Test
- Climate Control System
- General Procedures
- Air Conditioning Line (Peanut) Fitting
- Air Conditioning (A/C) Clutch Air Gap Adjustment
- Fluorescent Dye Leak Detection
- Electronic Leak Detection
- Air Conditioning (A/C) System Flushing
- Refrigerant System Filtering Following Air Conditioning (A/C) Compressor Installation
- Air Conditioning (A/C) System Recovery, Evacuation and Charging
- Refrigerant Oil Adding
- Refrigerant Identification Testing
- Air Conditioning (A/C) Odor Treatment