Section 2010 (Automatic Transmission - Cd4E)
WARNING: This page is about a different car, the 2007 Mercury Mariner and 2007 Ford Escape. However, it is still accessible from the selected car via links, so may be relevant.
- Specifications
- General Specifications
- End Play Specifications
- Band And Clutch Application Chart A
- Band And Clutch Application Chart B
- Line Pressure Chart
- Forward/Coast Clutch Pack
- Reverse Clutch Pack
- Direct Clutch Pack
- Low/Reverse Clutch Pack
- Intermediate And Overdrive Servo
- Intermediate/Overdrive Servo Apply Rod
- Reverse/Overdrive Carrier Assembly Pinion Gear
- Gear Ratios - 3.0L Engines
- Gear Ratios - 2.3L Engines
- Pump Gear End
- Drive Sprocket Alignment No. 10 Thrust Washer
- Driven Sprocket Alignment No. 11 Shim
- Differential End Play No. 14 Shim
- Pump Assembly Rotating Torque
- Torque Specifications
- Description And Operation
- Transaxle Description
- Identification Tags
- Range Selection
- Shift Patterns
- Bushings, Bearing and Thrust Washer Locator
- Torque Converter
- Geartrain
- Apply Components
- Hydraulic System
- Transaxle Electronic Control System
- Notes
- Air Conditioning (A/C) Clutch
- Brake Pedal Position (BPP) Switch
- Engine Coolant Temperature (ECT) Sensor
- Electronic Ignition (EI) System
- Mass Air Flow (MAF) Sensor
- Transmission Control Switch (TCS)
- Transmission Control Indicator Lamp (TCIL)
- Throttle Position (TP) Sensor
- Transmission Fluid Temperature (TFT) Sensor
- Transmission Range (TR) Sensor
- Turbine Shaft Speed (TSS) Sensor
- Output Shaft Speed (OSS) Sensor
- Solenoid Valve Body Assembly
- Powertrain Control Module (PCM)
- Electronic Pressure Control (EPC) Solenoid
- Torque Converter Clutch (TCC) Solenoid
- 3-2 Timing/Coast Clutch Solenoid (3-2 T/CCS)
- Shift Solenoid Assembly (SSA, SSB)
- Diagnostic Tests
- Diagnostic Strategy
- Diagnostic Flow Chart
- Preliminary Inspection
- Road Testing Vehicle
- Shift Point Road Test
- Torque Converter Diagnosis
- Visual Inspection
- Diagnostics
- Output State Control (OSC) Mode
- Transaxle Drive Cycle Test
- Diagnostic Trouble Code (DTC) Charts
- Transaxle Connector Layouts
- Pinpoint Tests - Non OSC Equipped Vehicle
- Notes
- Shift Solenoid Failure Mode Chart "Always OFF"
- Shift Solenoid Failure Mode Chart "Always ON"
- Pinpoint Tests
- Pinpoint Test A: Shift Solenoids
- Pinpoint Test B: Transmission Fluid Temperature (TFT) Sensor
- Pinpoint Test C: Torque Converter Clutch (TCC) Solenoid
- Pinpoint Test D: Transmission Range (Tr) Sensor
- Pinpoint Test E: Electronic Pressure Control (EPC) Solenoid
- Pinpoint Test F: Turbine Shaft Speed (TSS) Sensor And Output Shaft Speed (OSS) Sensor
- Pinpoint Test G: Timing/Coast Clutch Solenoid (3-2T/CCS)
- Pinpoint Test H: Solenoid Mechanical Failure
- Special Testing Procedures
- Leakage Inspection
- Transmission Fluid Cooler
- Diagnosis By Symptom
- General Procedures
- In-Vehicle Servicing
- Main Control Cover
- Main Control Valve Body
- Turbine Shaft Speed (TSS) Sensor
- Output Shaft Speed (OSS) Sensor
- Differential Seals - LH
- Differential Seals - RH
- Transmission Range (TR) Sensor
- Overdrive Servo
- Transaxle Support Insulator - Lower, Front
- Transaxle Support Insulator - Lower, Rear, 3.0L DOHC
- Transaxle Support Insulator - Lower, Rear, 2.3L
- Transaxle Support Insulator - LH
- Removal
- Disassembly
- Disassembly And Assembly Of Subassemblies
- Chain Sprockets
- Torque Converter Housing
- Final Drive Carrier and Differential Assembly
- Forward One-Way Clutch - Sprag Type
- Low One-Way Clutch - Mechanical Diode Type
- Forward/Coast/Direct Clutch Cylinder and Reverse Clutch Drum - Disassembly
- Forward/Coast/Direct Clutches
- Forward/Coast/Direct Clutch Cylinder and Reverse Clutch Drum - Assembly
- Low/Reverse Piston
- Main Control Valve Body
- Transaxle Case
- Pump Assembly
- Reverse Clutch
- Planetary Gearsets And Chain Drive Parts
- Assembly
- Installation