LEMON Manuals: Even more car manuals for everyone: 1960-2025
Home >> Ford >> 2000 >> ZX2 Standard >> Repair and Diagnosis >> External Pages >> Different car >> Section 1731 (Engine) >> Specifications >> Torque Specifications
April 5, 2026: LEMON Manuals is launched! Read the announcement.

Torque Specifications

WARNING: This page is about a different car, the 2006 Mercury Montego, 2006 Ford Freestyle, and 2006 Ford Five Hundred. However, it is still accessible from the selected car via links, so may be relevant.
TORQUE SPECIFICATIONS

Description N.m lb-ft lb-in
Accessory drive belt tensioner bolt 45 33 -
Air conditioning compressor bolts and nuts 25 18 -
Air conditioning compressor bracket bolts 25 18 -
Battery B+ nut 5 - 44
Block heater 14 10 -
Camshaft journal cap bolts 10 - 89
Camshaft oil seal retainer bolts 10 - 89
Camshaft position (CMP) sensor bolt 10 - 89
Coolant bypass tube bolts 10 - 89
Coolant pump bolts(1) - - -
Crankshaft position (CKP) sensor bolt 10 - 89
Crankshaft damper bolt(1) - - -
Crankcase vent cover bolts 10 - 89
Cylinder head bolts(1) - - -
Driveshaft bolts 25 18 -
Exhaust gas recirculation (EGR) system module bolts 25 18 -
EGR system module tube nuts 40 30 -
Engine front cover bolts and stud(1) - - -
Engine support insulator nuts 70 52 -
Exhaust manifold heat shield bolts 11 8 -
Exhaust manifold nuts 20 15 -
Exhaust manifold stud 12 9 -
Exhaust manifold-to-catalytic converter bolts 40 30 -
Flexplate bolts 80 59 -
Front transaxle stabilizer mount nut and bolt 40 30 -
Fuel rail bolts 10 - 89
Generator bolts and nuts 48 35 -
Generator-to-engine front cover studs 8 - 71
Generator B+ terminal nut (W705790-S901) 8 - 71
Ground strap bolts 10 - 89
Ground cable-to-transaxle housing bolt 12 9 -
Halfshaft support bracket bolts 48 35 -
Ignition coil-on-plug bolts 6 - 53
Intermediate shaft-to-steering gear bolt (N808349-S439) 23 17 -
Knock sensor (KS) bolt 20 15 -
Oil filter adapter bolts(1) - - -
Oil filter 16 12 -
Oil level indicator and tube stud bolt 9 - 80
Oil pan baffle nuts(1) - - -
Oil pan bolts 25 18 -
Oil pan drain plug 26 19 -
Oil pan-to-oil filter adapter bolt 25 18 -
Oil pan-to-transaxle bolts 40 30 -
Oil pressure sender 14 10 -
Oil pump bolts 10 - 89
Oil pump screen and pickup tube bolts 10 - 89
Outer tie-rod end nuts 90 66 -
Power steering fluid reservoir nuts 9 - 80
Power steering fluid reservoir bracket nut 9 - 80
Power steering pump nuts 25 18 -
Power steering pump bracket bolts 25 18 -
Power steering pressure (PSP) tube bracket-to-cylinder head bolts 7 - 62
PSP tube bracket-to-fluid reservoir bracket bolt 7 - 62
PSP tube bracket-to-crossmember bolt 25 18 -
Power steering tube-to-steering gear bolt 25 18 -
Radio ignition interference capacitor bolt 8 - 71
Rear transaxle mount bracket-to- transaxle bolts(2) 55 41 -
RH engine support insulator bracket bolts(2) 55 41 -
RH valve cover-to power steering fluid reservoir stud bolts 7 - 62
Shifter cable bracket bolts 25 18 -
Spark plugs 15 11 -
Stabilizer bar link nuts 55 41 -
Starter motor ground cable bolt 25 18 -
Starter cable positive nut 12 9 -
Thermostat housing-to-coolant pump bolts 10 - 89
Timing chain guide bolts 25 18 -
Timing chain tensioner bolts 25 18 -
Torque converter-to-flexplate nuts 36 27 -
Transaxle-to-engine bolts 40 30 -
Transaxle roll restrictor cross brace-to-body bolts(2) 55 41 -
Transaxle roll restrictor cross brace-to-roll restrictor bolt(2) 48 35 -
Transaxle roll restrictor bracket-to-roll restrictor bolts(2) 55 41  
Transaxle roll restrictor-to-transaxle bolts(2) 55 41 -
Upper and lower intake manifold bolts 10 - 89
Valve cover bolts and stud bolts 10 - 89
Wiring harness shield-to-valve cover stud bolt nuts 6 - 53
(1) Refer to the appropriate procedure.

(2) When reinstalling fasteners originally coated with threadlock, clean with a wire brush prior to applying new threadlock. Apply threadlock to the threads of the bolt(s).
scientia non olet · About LEMON Manuals