Technical Service Bulletins: Other Variant
WARNING: This page is about the Explorer 4D Utility, 4.0 E, 4WD, which is a different variant/trim than selected.
- A/C Compressor
- Accessories Control Systems
- Air Bag, SRS
- Anti-Lock Brakes
- Anti-Theft Systems
- Automatic Trans
- 5R44E / 5R55E Service Part Level Change / Compatibility (06-24-13)
- 4R70W - New Service Part - Number 5 Needle Bearing And Race Kit (03-26-1)
- 4R44E/4R55E/5R44E/5R55E - Low Line Pressure At Wot - DTC P0732, P0733, P1762 (03-22-10)
- New Transmission Cooler Flusher - Service Tips (03-14-8)
- 4R70W - Clunk Noise Heard On 2-1 Downshift (01-13-7)
- Service Procedure For Tagged Transmissions (00-16-1)
- E4OD/4R100 - Fluid In-Line Filter Kit (00-3-8)
- Auxiliary Emission Control Systems
- General Pcm Programming Procedures (04-24-14)
- 4.0L SOHC - Buzz, Rattle, Or Exhaust Noise From Under The Body (03-19-9)
- Malfunction Indicator Lamp (Mil) Illuminated - System Lean Diagnostic Trouble Codes - DTC'S - Service Tips (04-17-4)
- Streamlined Diagnostic Procedure For DTCS P0401, P0402, P1400 Or P1401 (04-3-1)
- Mil With DTC'S P0442, P0455, P0456, P0457, P1442 Or Check Fuel Cap Lamp With DTC P0457 (03-9-8)
- DRIVEABILITY - Ho2S, Catalyst & Fuel System Monitors - Service Tips - OBD II (01-9-7)
- 5.0L - DTC P0351-P0354 - No DRIVEABILITY Concerns (00-24-5)
- Hesitation On Acceleration - Lack Of Fuel Pressure (00-20-1)
- Axle Shafts
- Body Electrical
- Body Interior
- Brakes Control Systems
- Charging Systems
- Collision/Avoidance
- Communication Devices
- Cooling System (Mechanical)
- Keep The Cooling System Free Of Debris And Corrosion To Prevent Premature Water Pump Failure (TT002-13)
- Heater Core Leakage And Electrolysis (Information Only) (06-21-19)
- Ford Motor Company Position On Engine Coolant Made From Propylene Glycol (96-16-4)
- 5.0L - DTC P0351-P0354 - No DRIVEABILITY Concerns (00-24-5)
- Hesitation On Acceleration - Lack Of Fuel Pressure (00-20-1)
- Cruise Control Systems
- Differentials & Drive Axles
- 4 Wheel Drive/All Wheel Drive - With Control TRAC - Shudder On Acceleration/Deceleration Or Binding On Slow Turns (08-21-11)
- Front Axle Leaks Fluid From Vent Tube - Vehicles Equipped With 4X4 Or AWD (97-4-9)
- Squealing/Whistling From Front Axle Area At 10-40 Mph - 4X4 Vehicles Only (01-4-11)
- Vibration/Resonance Noise - Speeds Above 45 Mph (00-14-3)
- Driveshaft & Universal Joints
- Engine Control Systems
- General Pcm Programming Procedures (04-24-14)
- Malfunction Indicator Lamp (Mil) Illuminated - System Lean Diagnostic Trouble Codes - DTC'S - Service Tips (04-17-4)
- Mil With DTC'S P0442, P0455, P0456, P0457, P1442 Or Check Fuel Cap Lamp With DTC P0457 (03-9-8)
- DRIVEABILITY - Idle Air Control (IAC) Valve Diagnostic Service Tips (03-3-5)
- Whining/Buzzing - Comes Through Speakers Of Entertainment Or Two-Way Radio (02-16-4)
- 4.0L SOHC - Mil - DTC P0300/P0301 Stored In Memory (02-3-2)
- Diagnostic Trouble Codes DTC P0500, P1502 And/Or U1039 - Sticking Or Binding Ignition Lock Cylinder (01-21-13)
- DRIVEABILITY - Ho2S, Catalyst & Fuel System Monitors - Service Tips - OBD II (01-9-7)
- Buzz Coming From Center Or Right Side Of Instrument Panel At Idle/Low Speed (01-4-10)
- 5.0L - DTC P0351-P0354 - No DRIVEABILITY Concerns (00-24-5)
- Hesitation On Acceleration - Lack Of Fuel Pressure (00-20-1)
- Entertainment Systems
- Exhaust
- Exterior Body Panels
- Exterior Lights
- Front Suspension
- Fuel System
- Mil With DTC'S P0442, P0455, P0456, P0457, P1442 Or Check Fuel Cap Lamp With DTC P0457 (03-9-8)
- DRIVEABILITY - Idle Air Control (IAC) Valve Diagnostic Service Tips (03-3-5)
- Whining/Buzzing - Comes Through Speakers Of Entertainment Or Two-Way Radio (02-16-4)
- DRIVEABILITY - Ho2S, Catalyst & Fuel System Monitors - Service Tips - OBD II (01-9-7)
- 5.0L - DTC P0351-P0354 - No DRIVEABILITY Concerns (00-24-5)
- Hesitation On Acceleration - Lack Of Fuel Pressure (00-20-1)
- Fuses & Circuit Breakers
- Gauges & Instrument Panels
- Headlights
- Heated Glass/Defoggers
- HVAC Control Systems
- Heater Core Leakage And Electrolysis (Information Only) (06-21-19)
- Climate Control - A/C Service Tech Tips (02-20-8)
- Electronic Automatic Temp Control Blows Cold Air From Floor Ducts (02-8-5)
- Climate Control - Repeat Heater Core Failure (01-15-6)
- Climate Control - EATC - Blower Motor Control Service Tips (00-21-3)
- Ignition Switch/Steering Lock
- Ignition System
- Infotainment
- Interior/Exterior Trim
- Interior/Illumination Lights
- Locking Hubs
- Lubrication System
- Manual Steering
- Manual Trans
- Mechanical
- Hydraulic Versus Mechanical TENSIONERS (TT001-13)
- Identifying The Correct Replacement Head Gasket For Certain Remanufactured Engines - Service Tip (06-18-16)
- 4.0L SOHC - Rattle Noise From Primary Chain Drive Area 2000-3000 Rpm (04-15-4)
- DRIVEABILITY - Idle Air Control (IAC) Valve Diagnostic Service Tips (03-3-5)
- Engine - Straightedge Procedure For Checking Cylinder Head & Block Flatness (02-21-13)
- New Gasket Remover/Cleaner Service Tips For Aluminum Heads & Blocks (02-11-4)
- 4.0L SOHC - Mil - DTC P0300/P0301 Stored In Memory (02-3-2)
- Machining Of Aluminum Cylinder Heads Or Blocks - Warranty Information (02-2-3)
- Engine - Approved Head Gasket Replacement Service Procedures (02-1-4)
- Engine Oil - Recommended Applications For Sae 5W-20 And Sae 5W-30 Motor Oils (02-1-9)
- Engine - Engine Oil System Priming Procedures - Service Tips (01-24-6)
- DRIVEABILITY - Detecting Vacuum Leaks - Using The Rotunda VACUTEC 522 Smoke Leak Detector Machine (01-20-5)
- 5.0L - DTC P0351-P0354 - No DRIVEABILITY Concerns (00-24-5)
- Hesitation On Acceleration - Lack Of Fuel Pressure (00-20-1)
- Memory Modules
- Mirrors
- Paint & Coatings
- Passive Restraints
- Restraints Control Systems
- Seats
- Starter
- Steering Column
- Steering Control Systems
- Steering Gear
- System
- General Pcm Programming Procedures (04-24-14)
- 4.0L SOHC - Buzz, Rattle, Or Exhaust Noise From Under The Body (03-19-9)
- Malfunction Indicator Lamp (Mil) Illuminated - System Lean Diagnostic Trouble Codes - DTC'S - Service Tips (04-17-4)
- Streamlined Diagnostic Procedure For DTCS P0401, P0402, P1400 Or P1401 (04-3-1)
- Mil With DTC'S P0442, P0455, P0456, P0457, P1442 Or Check Fuel Cap Lamp With DTC P0457 (03-9-8)
- DRIVEABILITY - Idle Air Control (IAC) Valve Diagnostic Service Tips (03-3-5)
- Whining/Buzzing - Comes Through Speakers Of Entertainment Or Two-Way Radio (02-16-4)
- 4.0L SOHC - Mil - DTC P0300/P0301 Stored In Memory (02-3-2)
- Engine - Approved Head Gasket Replacement Service Procedures (02-1-4)
- Diagnostic Trouble Codes DTC P0500, P1502 And/Or U1039 - Sticking Or Binding Ignition Lock Cylinder (01-21-13)
- DRIVEABILITY - Detecting Vacuum Leaks - Using The Rotunda VACUTEC 522 Smoke Leak Detector Machine (01-20-5)
- DRIVEABILITY - Ho2S, Catalyst & Fuel System Monitors - Service Tips - OBD II (01-9-7)
- Buzz Coming From Center Or Right Side Of Instrument Panel At Idle/Low Speed (01-4-10)
- 5.0L - DTC P0351-P0354 - No DRIVEABILITY Concerns (00-24-5)
- Hesitation On Acceleration - Lack Of Fuel Pressure (00-20-1)
- Towing
- Transfer Case
- Transmission Control Systems
- Warning Systems
- Wheel Alignment
- Wheel Hubs
- Wheels & Tire System
- Window Motors & Regulators
- Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)