Technical Service Bulletins
- A/C Compressor
- Accessories Control Systems
- Anti-Theft Systems
- Automatic Trans
- Auxiliary Emission Control Systems
- 2.0L SPI - EGR Tube Installation Procedure Update (07-1-12)
- Manifold Or Catalytic Converter Heat Shields Loose/Missing (06-2-7)
- Catalytic Converter Mounting Bracket Broken (05-14-12)
- General Pcm Programming Procedures (04-24-14)
- Malfunction Indicator Lamp (Mil) Illuminated - System Lean Diagnostic Trouble Codes - DTC'S - Service Tips (04-17-4)
- Streamlined Diagnostic Procedure For DTCS P0401, P0402, P1400 Or P1401 (04-3-1)
- Mil With DTC'S P0442, P0455, P0456, P0457, P1442 Or Check Fuel Cap Lamp With DTC P0457 (03-9-8)
- DTC P0402 &/Or P0403 Or Runs Rough In Wet Weather Conditions (03-15-2)
- 2.0L - Ticking From Delta Pressure Feedback EGR Sensor &/Or DTC P0401/0402 (02-13-1)
- Axle Shafts
- Body Electrical
- Charging Systems
- Clutch
- Cooling System (Mechanical)
- Keep The Cooling System Free Of Debris And Corrosion To Prevent Premature Water Pump Failure (TT002-13)
- Heater Core Leakage And Electrolysis (Information Only) (06-21-19)
- Cooling System - MOTORCRAFT Premium Gold Engine Coolant - Service Tips (02-3-4)
- Ford Motor Company Position On Engine Coolant Made From Propylene Glycol (96-16-4)
- Cruise Control Systems
- Differentials & Drive Axles
- Engine Control Systems
- General Pcm Programming Procedures (04-24-14)
- Malfunction Indicator Lamp (Mil) Illuminated - System Lean Diagnostic Trouble Codes - DTC'S - Service Tips (04-17-4)
- 2.0L SPI - Rough Idle, Low Power And/Or Stall At Idle With DTCS P0300-P0304 (04-9-1)
- Fuel System - Fuel Delivery Module (FDM) - Replacement Procedure (04-5-6)
- Mil With DTC'S P0442, P0455, P0456, P0457, P1442 Or Check Fuel Cap Lamp With DTC P0457 (03-9-8)
- Various DRIVEABILITY Conditions - Hard Start/No Start - Battery Lamp Flicker (03-19-11)
- DTC P0402 &/Or P0403 Or Runs Rough In Wet Weather Conditions (03-15-2)
- DTC - P1635 And/Or P1639 Present After Powertrain Control Module Pcm Or Instrument Cluster Replacement (02-5-8)
- 2.0L - Fuel Pressure Relief Valve Discontinued (02-21-2)
- 2.0L - Ticking From Delta Pressure Feedback EGR Sensor &/Or DTC P0401/0402 (02-13-1)
- Entertainment Systems
- Exhaust
- Exterior Body Panels
- Water Leaks And/Or A/C Condensation Leaks At Front Floor Area (05-13-3)
- Fuel System - Fuel Delivery Module (FDM) - Replacement Procedure (04-5-6)
- Hood Difficult To Open Or Unable To Open - Vehicles With 2.0L Engine Only (03-22-5)
- Mil With DTC'S P0442, P0455, P0456, P0457, P1442 Or Check Fuel Cap Lamp With DTC P0457 (03-9-8)
- Plastic Bumper/Fascia Parts - Preparation Procedures - Service Tips (03-10-1)
- Sheet Metal - Primed Service Parts - Prep Procedure & MSDS Information (02-5-6)
- Body - Rear Liftgate Spoiler - Removal And Installation Tips - ZX3 Models Only (01-18-3)
- Exterior Lights
- Frames, Subframes & Crossmembers
- Front Suspension
- Fuel System
- 2.0L SPI - Rough Idle, Low Power And/Or Stall At Idle With DTCS P0300-P0304 (04-9-1)
- Fuel System - Fuel Delivery Module (FDM) - Replacement Procedure (04-5-6)
- Mil With DTC'S P0442, P0455, P0456, P0457, P1442 Or Check Fuel Cap Lamp With DTC P0457 (03-9-8)
- 2.0L - Fuel Pressure Relief Valve Discontinued (02-21-2)
- Fuses & Circuit Breakers
- Gauges & Instrument Panels
- Heated Glass/Defoggers
- Horns
- HVAC Control Systems
- Heater Core Leakage And Electrolysis (Information Only) (06-21-19)
- Water Leaks And/Or A/C Condensation Leaks At Front Floor Area (05-13-3)
- Water Leak - Climate Control - Water In Heater Blower Motor Case (03-18-2)
- Climate Control - A/C Service Tech Tips (02-20-8)
- Climate Control - Repeat Heater Core Failure (01-15-6)
- Ignition Switch/Steering Lock
- Infotainment
- Interior/Exterior Trim
- Center Console Arm Rest Pivot Loose (07-6-4)
- Water Leaks And/Or A/C Condensation Leaks At Front Floor Area (05-13-3)
- Interior Trim - Carpet Pulling From Under Right Front Cowl Side Kick Panel (05-9-9)
- Body - Corrosion Damage From Chrome Liftgate/Deck Lid Handle Applique (02-25-4)
- DTC - P1635 And/Or P1639 Present After Powertrain Control Module Pcm Or Instrument Cluster Replacement (02-5-8)
- Lubrication System
- Manual Steering
- Manual Trans
- Mechanical
- Hydraulic Versus Mechanical TENSIONERS (TT001-13)
- Engine Vibration At Idle (11-3-24)
- 2.0L SPI - Rough Idle, Low Power And/Or Stall At Idle With DTCS P0300-P0304 (04-9-1)
- Engine Oil Level Indicator Markings - Reports Of Low Oil Level (03-8-3)
- Engine - Straightedge Procedure For Checking Cylinder Head & Block Flatness (02-21-13)
- New Gasket Remover/Cleaner Service Tips For Aluminum Heads & Blocks (02-11-4)
- Machining Of Aluminum Cylinder Heads Or Blocks - Warranty Information (02-2-3)
- Engine - Approved Head Gasket Replacement Service Procedures (02-1-4)
- Engine Oil - Recommended Applications For Sae 5W-20 And Sae 5W-30 Motor Oils (02-1-9)
- Engine - Engine Oil System Priming Procedures - Service Tips (01-24-6)
- DRIVEABILITY - Detecting Vacuum Leaks - Using The Rotunda VACUTEC 522 Smoke Leak Detector Machine (01-20-5)
- Mechanical - Hydraulic
- Mirrors
- Paint & Coatings
- Passive Restraints
- Rear Suspension
- Seats
- Starter
- Steering Column
- Steering Control Systems
- Steering Gear
- Sun Roof/T-Top/Convertible Top
- System
- 2.0L SPI - EGR Tube Installation Procedure Update (07-1-12)
- Manifold Or Catalytic Converter Heat Shields Loose/Missing (06-2-7)
- Catalytic Converter Mounting Bracket Broken (05-14-12)
- General Pcm Programming Procedures (04-24-14)
- Malfunction Indicator Lamp (Mil) Illuminated - System Lean Diagnostic Trouble Codes - DTC'S - Service Tips (04-17-4)
- Streamlined Diagnostic Procedure For DTCS P0401, P0402, P1400 Or P1401 (04-3-1)
- 2.0L SPI - Rough Idle, Low Power And/Or Stall At Idle With DTCS P0300-P0304 (04-9-1)
- Fuel System - Fuel Delivery Module (FDM) - Replacement Procedure (04-5-6)
- Mil With DTC'S P0442, P0455, P0456, P0457, P1442 Or Check Fuel Cap Lamp With DTC P0457 (03-9-8)
- Various DRIVEABILITY Conditions - Hard Start/No Start - Battery Lamp Flicker (03-19-11)
- DTC P0402 &/Or P0403 Or Runs Rough In Wet Weather Conditions (03-15-2)
- DTC - P1635 And/Or P1639 Present After Powertrain Control Module Pcm Or Instrument Cluster Replacement (02-5-8)
- 2.0L - Fuel Pressure Relief Valve Discontinued (02-21-2)
- 2.0L - Ticking From Delta Pressure Feedback EGR Sensor &/Or DTC P0401/0402 (02-13-1)
- Engine - Approved Head Gasket Replacement Service Procedures (02-1-4)
- DRIVEABILITY - Detecting Vacuum Leaks - Using The Rotunda VACUTEC 522 Smoke Leak Detector Machine (01-20-5)
- Transmission Control Systems
- Warning Systems
- Wheel Alignment
- Wheels & Tire System
- Wiper/Washer Systems
- Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)