Technical Service Bulletins: Other Variant
WARNING: This page is about the Excursion 5.4 L, 4WD, which is a different variant/trim than selected.
- A/C Compressor
- Accessories Control Systems
- Anti-Theft Systems
- Automatic Trans
- Auxiliary Emission Control Systems
- 6.0L Diesel Calibration Update - Various Issues (09-7-11)
- 6.0L - Built On Or Before 9/29/2003 DTCS P006A, P132B, P0401 Or P0402 - Lacks Power, Surge, Or Flutter After Field Service Action 06E17 (09-15-6)
- Coolant Loss - 6.0L (09-8-3)
- 6.0L - Coking Deposits Diagnostic - EGR DTCS P0401, P0402, P0404, P1335 (08-26-12)
- 5.4L 2V - Intermittent Rough Idle - Non-Commanded EGR Flow (05-4-17)
- Malfunction Indicator Lamp (Mil) Illuminated - System Lean Diagnostic Trouble Codes - DTC'S - Service Tips (04-17-4)
- Mil With DTC'S P0442, P0455, P0456, P0457, P1442 Or Check Fuel Cap Lamp With DTC P0457 (03-9-8)
- 5.4L/6.8L - Rough Idle And/Or Hesitation On Acceleration (03-9-11)
- Axle Shafts
- Blowers, Superchargers & Turbochargers
- Body Electrical
- Brakes Control Systems
- Charging Systems
- Collision/Avoidance
- Cooling System (Mechanical)
- All Chain Driven Water Pumps (TT003-13)
- Keep The Cooling System Free Of Debris And Corrosion To Prevent Premature Water Pump Failure (TT002-13)
- 6.0L/6.4L Diesel - Water Quality When Servicing Cooling System (10-12-1)
- 6.0L Diesel Fuel In Engine Coolant Diagnostics - Built On Or Before 9/30/2008 (09-26-1)
- Cooling System Diagnostics - Oil In Engine Coolant - 6.0L (09-18-12)
- Coolant Loss - 6.0L (09-8-3)
- Diesel Coolant Maintenance - Service Tips (09-8-5)
- 6.0L Diesel Cooling System Contamination Flush Procedure (08-23-1)
- Heater Core Leakage And Electrolysis (Information Only) (06-21-19)
- Cruise Control Systems
- Differentials & Drive Axles
- Engine Control Systems
- 6.0L - Runs Rough, Lacks Power, Hard Start, No Start (10-12-6)
- 6.0L Diesel Calibration Update - Various Issues (09-7-11)
- 6.0L Diesel-DRIVEABILITY-No Start/Hard Start/Long Crank/Misfire/Runs Rough/Lack Of Power/Buck/Jerk Or Excessive Exhaust Smoke Diagnosis (09-22-16)
- 6.0L Turbocharger Carbon Deposit Diagnostics And Service Tips (09-16-5)
- 6.0L - Built On Or Before 9/29/2003 DTCS P006A, P132B, P0401 Or P0402 - Lacks Power, Surge, Or Flutter After Field Service Action 06E17 (09-15-6)
- 6.0L - Coking Deposits Diagnostic - EGR DTCS P0401, P0402, P0404, P1335 (08-26-12)
- Erratic Shifts - Speeds Above 50 Mph (80 Km/H) And/Or Engagement Shudder (07-14-8)
- WDS Cop Kit Diagnostic Tips - Coil On Plug (Cop) Ignition Systems - Engine Misfire Or Rough Running (05-22-8)
- 5.4L 2V - Intermittent Rough Idle - Non-Commanded EGR Flow (05-4-17)
- Malfunction Indicator Lamp (Mil) Illuminated - System Lean Diagnostic Trouble Codes - DTC'S - Service Tips (04-17-4)
- 6.0L - Fuel Injector Combustion Seal - Installation Procedure (03-20-10)
- 6.0L Dit - Various DRIVEABILITY Conditions - Calibration Update (03-20-12)
- Mil With DTC'S P0442, P0455, P0456, P0457, P1442 Or Check Fuel Cap Lamp With DTC P0457 (03-9-8)
- Repeat Starter Failure - Sticking Or Binding Ignition Lock Cylinder (03-20-5)
- 5.4L/6.8L - Rough Idle And/Or Hesitation On Acceleration (03-9-11)
- DRIVEABILITY - "Wait To Start" Lamp Does Not Operate Properly (03-4-5)
- Entertainment Systems
- Exhaust
- Exterior Body Panels
- Exterior Lights
- Fuel System
- Adjustable Pedal - Adjustment Inoperative (11-10-11)
- 6.0L - Runs Rough, Lacks Power, Hard Start, No Start (10-12-6)
- 6.0L - Built On Or Before 9/29/2003 DTCS P006A, P132B, P0401 Or P0402 - Lacks Power, Surge, Or Flutter After Field Service Action 06E17 (09-15-6)
- 6.0L - Coking Deposits Diagnostic - EGR DTCS P0401, P0402, P0404, P1335 (08-26-12)
- 6.0L - Oil Seep Or Boost Pressure Leak At Hot Side Charge Air Cooler Duct (07-5-15)
- 6.0L - Fuel Injector Combustion Seal - Installation Procedure (03-20-10)
- Mil With DTC'S P0442, P0455, P0456, P0457, P1442 Or Check Fuel Cap Lamp With DTC P0457 (03-9-8)
- 6.0L Diesel - Air Filter Service, Removal Or Replacement - Service Tips (03-1-9)
- Fuses & Circuit Breakers
- Gauges & Instrument Panels
- Heated Glass/Defoggers
- HVAC Control Systems
- Coolant Loss - 6.0L (09-8-3)
- Heater Core Leakage And Electrolysis (Information Only) (06-21-19)
- A/C Compressor Not Operational / Low FREON - Shaft Seal Leaks (06-4-9)
- Vacuum Pump Inoperative Or Runs Continuously - Climate Control Defaults To Defrost Mode (05-17-4)
- Vacuum Pump Inoperative Or Runs Continuously - Climate Control Defaults To Defrost (04-16-8)
- Climate Control - A/C Service Tech Tips (02-20-8)
- Identification
- Ignition Switch/Steering Lock
- Ignition System
- Infotainment
- Locking Hubs
- Lubrication System
- Manual Steering
- Mechanical
- Hydraulic Versus Mechanical TENSIONERS (TT001-13)
- 6.0L Diesel Fuel In Engine Coolant Diagnostics - Built On Or Before 9/30/2008 (09-26-1)
- 4.5L, 6.0L And 6.4L Diesel Head Gasket Cleaning And Cylinder Head Inspection Procedures (09-22-1)
- 6.0L - Built On Or Before 9/29/2003 DTCS P006A, P132B, P0401 Or P0402 - Lacks Power, Surge, Or Flutter After Field Service Action 06E17 (09-15-6)
- Coolant Loss - 6.0L (09-8-3)
- 4.6L 2V, 5.4L 2V, Or 6.8L 2V - Spark Plug Thread Repair Procedure - Not Covered Under New Vehicle Limited Warranty (07-21-2)
- 6.0L - Oil Seep Or Boost Pressure Leak At Hot Side Charge Air Cooler Duct (07-5-15)
- Identifying The Correct Replacement Head Gasket For Certain Remanufactured Engines - Service Tip (06-18-16)
- 7.3L Or 6.0L - Oil Pan Corrosion (05-20-3)
- Engine Oil Level Indicator Markings - Reports Of Low Oil Level (03-8-3)
- 6.0L Diesel - Air Filter Service, Removal Or Replacement - Service Tips (03-1-9)
- Engine - Straightedge Procedure For Checking Cylinder Head & Block Flatness (02-21-13)
- Mechanical - Hydraulic
- Mirrors
- Paint & Coatings
- Passive Restraints
- Procedures
- Seats
- Starter
- Steering Column
- Steering Control Systems
- Steering Gear
- Steering Linkage
- System
- Adjustable Pedal - Adjustment Inoperative (11-10-11)
- 6.0L - Runs Rough, Lacks Power, Hard Start, No Start (10-12-6)
- 6.0L Diesel Calibration Update - Various Issues (09-7-11)
- 6.0L Diesel-DRIVEABILITY-No Start/Hard Start/Long Crank/Misfire/Runs Rough/Lack Of Power/Buck/Jerk Or Excessive Exhaust Smoke Diagnosis (09-22-16)
- 6.0L Turbocharger Carbon Deposit Diagnostics And Service Tips (09-16-5)
- 6.0L - Built On Or Before 9/29/2003 DTCS P006A, P132B, P0401 Or P0402 - Lacks Power, Surge, Or Flutter After Field Service Action 06E17 (09-15-6)
- Coolant Loss - 6.0L (09-8-3)
- 6.0L - Coking Deposits Diagnostic - EGR DTCS P0401, P0402, P0404, P1335 (08-26-12)
- 4.6L 2V, 5.4L 2V, Or 6.8L 2V - Spark Plug Thread Repair Procedure - Not Covered Under New Vehicle Limited Warranty (07-21-2)
- Erratic Shifts - Speeds Above 50 Mph (80 Km/H) And/Or Engagement Shudder (07-14-8)
- 6.0L - Oil Seep Or Boost Pressure Leak At Hot Side Charge Air Cooler Duct (07-5-15)
- WDS Cop Kit Diagnostic Tips - Coil On Plug (Cop) Ignition Systems - Engine Misfire Or Rough Running (05-22-8)
- 5.4L 2V - Intermittent Rough Idle - Non-Commanded EGR Flow (05-4-17)
- Malfunction Indicator Lamp (Mil) Illuminated - System Lean Diagnostic Trouble Codes - DTC'S - Service Tips (04-17-4)
- 6.0L - Fuel Injector Combustion Seal - Installation Procedure (03-20-10)
- 6.0L Dit - Various DRIVEABILITY Conditions - Calibration Update (03-20-12)
- Mil With DTC'S P0442, P0455, P0456, P0457, P1442 Or Check Fuel Cap Lamp With DTC P0457 (03-9-8)
- Repeat Starter Failure - Sticking Or Binding Ignition Lock Cylinder (03-20-5)
- 5.4L/6.8L - Rough Idle And/Or Hesitation On Acceleration (03-9-11)
- DRIVEABILITY - "Wait To Start" Lamp Does Not Operate Properly (03-4-5)
- Transmission Control Systems
- Vacuum Pumps/Lines/Tanks/Water Trap
- Wheel Hubs
- Wheels & Tire System
- Wiper/Washer Systems
- Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)