Technical Service Bulletins

A/C Compressor
- A/C Compressor Not Operational / Low FREON - Shaft Seal Leaks (06-4-9)
Air Bag, SRS
- RCM Fault Reporting Using DTCS And Bit-Mapped Parameter Identifiers (PIDS) - Service Tips (07-7-8)
- DTC B1342 - Restraint Control Module - Diagnostic Service Tip (04-25-15)
Anti-Lock Brakes
- Traction Control Lamp - Abs Lamp - Abs Self Activation With DTC C1288 (07-14-10)
- Advanced Traction Control System - Short Duration Activation (07-10-11)
- DTC C1991 - Anti-Lock Brake, Advanced TRAC, Interactive Vehicle Dynamics, Traction Control System (04-12-5)
Anti-Theft Systems
- Keypad Diagnostics - Dealer Installed Accessory (06-15-8)
- Power Sliding Doors And Power Liftgate Inoperative - DTC C1999 (04-25-10)
- Power Sliding Door Operation And Diagnostic Service Tips (99-25-1)
- Remote Keyless Entry (RKE) - Service Tips (03-18-1)
Automatic Trans
- Erratic Fluid Level Reading On Transaxle Dipstick - Leaks - 4F50N, Ax4N, Ax4S (06-18-13)
- Engine/Transmission DRIVEABILITY Issues (06-14-10)
- 4F50N Transaxle No 1-2 Upshift And DTC P0732 (04-17-10)
Auxiliary Emission Control Systems
- Damaged Spark Plug Electrode/Mil DTC P030X (10-3-3)
- Engine/Transmission DRIVEABILITY Issues (06-14-10)
- MAF Diagnostic Service Tip - Vehicles Equipped With EGR System Module (ESM) (05-3-1)
- General Pcm Programming Procedures (04-24-14)
- Malfunction Indicator Lamp (Mil) Illuminated - System Lean Diagnostic Trouble Codes - DTC'S - Service Tips (04-17-4)
Axle Shafts
- Outer CV Joint Broken - Vehicles Built Before 5/1/2005 (05-9-8)
Body Electrical
- Service Wiring Harness Replacement Guidelines - Service Tips (06-17-8)
- Wiring - Soldering And Crimping Repairs - Service Tips (05-18-7)
Brakes Control Systems
- Traction Control Lamp - Abs Lamp - Abs Self Activation With DTC C1288 (07-14-10)
- Advanced Traction Control System - Short Duration Activation (07-10-11)
- DTC C1991 - Anti-Lock Brake, Advanced TRAC, Interactive Vehicle Dynamics, Traction Control System (04-12-5)
Charging Systems
- Stuck High Voltage Charge Cord Information Sheet (G0000127)
- Service Wiring Harness Replacement Guidelines - Service Tips (06-17-8)
Collision/Avoidance
- False Parking Aid Warnings (99-4-10)
Cooling System (Mechanical)
- Keep The Cooling System Free Of Debris And Corrosion To Prevent Premature Water Pump Failure (TT002-13)
- Heater Core Leakage And Electrolysis (Information Only) (06-21-19)
- Engine/Transmission DRIVEABILITY Issues (06-14-10)
Cruise Control Systems
- Speed Control Diagnostic Tips - SCP (06-8-4)
Differentials & Drive Axles
- Outer CV Joint Broken - Vehicles Built Before 5/1/2005 (05-9-8)
Engine Control Systems
- Damaged Spark Plug Electrode/Mil DTC P030X (10-3-3)
- Spark Knock Under Light Load And Acceleration - 3.8L, 3.9L, And 4.2L - Split Port Intake Manifold Runner Control (IMRC) (07-16-17)
- Engine/Transmission DRIVEABILITY Issues (06-14-10)
- General Pcm Programming Procedures (04-24-14)
- Malfunction Indicator Lamp (Mil) Illuminated - System Lean Diagnostic Trouble Codes - DTC'S - Service Tips (04-17-4)
Entertainment Systems
- Rear Window Defroster Grid/Integral Antenna Diagnosis And Repair - Terminal Tab Repair (04-24-5)
Exhaust
- Various Vehicles - Catalytic Converter Concern Analysis (22-7009)
Exterior Body Panels
- Safety Recall 13S01 - Corrosion On Sheet Metal That Supports 3RD Row Seat Latch Strikers - Requests For Recall Service Action (16-0069)
- Power Sliding Door Operation And Diagnostic Service Tips (99-25-1)
Fuel System
- Spark Knock Under Light Load And Acceleration - 3.8L, 3.9L, And 4.2L - Split Port Intake Manifold Runner Control (IMRC) (07-16-17)
Fuses & Circuit Breakers
- Service Wiring Harness Replacement Guidelines - Service Tips (06-17-8)
- Wiring - Soldering And Crimping Repairs - Service Tips (05-18-7)
- Electrical - Trailer Tow Service Kit (03-24-2)
Heated Glass/Defoggers
- Rear Window Defroster Grid/Integral Antenna Diagnosis And Repair - Terminal Tab Repair (04-24-5)
HVAC Control Systems
- Heater Core Leakage And Electrolysis (Information Only) (06-21-19)
- A/C Compressor Not Operational / Low FREON - Shaft Seal Leaks (06-4-9)
- Cowl Panel Grill Breaking (04-17-6)
- Front Blower Motor Whistle Noise (04-14-8)
Ignition System
- Damaged Spark Plug Electrode/Mil DTC P030X (10-3-3)
Infotainment
- Rear Window Defroster Grid/Integral Antenna Diagnosis And Repair - Terminal Tab Repair (04-24-5)
Interior/Exterior Trim
- Glove Box Front Cover Replacement (05-16-3)
- Rear License Plate Housing Cracking (05-12-7)
- Interior Plastic Trim - Paint-To-Match And Repair - Interior Spray Paint And Adhesion Promoter Usage Instructions (05-9-3)
- Glove Box Latch Replacement (05-2-1)
- Access Door Warped Or Breaking Off From The Underside Of The Steering Wheel Shroud (04-22-9)
- Exterior Door Trim Moldings/CLADDINGS Loose Or Not Attached (04-7-3)
- Cowl Panel Grill Breaking (04-17-6)
- Roof Rack Side Rail Cover - Installation Instructions (03-20-13)
Manual Steering
- MERCON(R) ATF Replaced By MERCON(R) V As A Service Fluid For Some Power Steering Systems (07-1-7)
- Power Steering Hose Leak Near Cooler - Extreme Cold Climate Areas Only -4°F (-20 °C) And Colder (07-1-2)
- Outer CV Joint Broken - Vehicles Built Before 5/1/2005 (05-9-8)
Mechanical
- Hydraulic Versus Mechanical TENSIONERS (TT001-13)
- Spark Knock Under Light Load And Acceleration - 3.8L, 3.9L, And 4.2L - Split Port Intake Manifold Runner Control (IMRC) (07-16-17)
- Identifying The Correct Replacement Head Gasket For Certain Remanufactured Engines - Service Tip (06-18-16)
Mechanical - Hydraulic
- Rear Brake Caliper Leaks (Vehicles Sold In MEXICO Only) - Service Tip (06-14-11)
- Front Brake Squeal/Squeak Noise - Vehicles Built 8/1/2003 Through 5/30/2005 (05-14-1)
- Rear Brake Lining Accelerated Wear (04-26-10)
Mirrors
- Various Vehicles - Rear-View Mirror Concern Analysis (23-7092)
- Ford Interior Mirror Job Aid (G0000001)
- Exterior Mirror Glass And Motor Replacement (98-9-14)
Paint & Coatings
- Interior Plastic Trim - Paint-To-Match And Repair - Interior Spray Paint And Adhesion Promoter Usage Instructions (05-9-3)
- Paint - Iron Particle Removal - Industrial Fallout - Acid Rain Neutralization (99-12-10)
Passive Restraints
- Safety Recall 13S01 - Corrosion On Sheet Metal That Supports 3RD Row Seat Latch Strikers - Requests For Recall Service Action (16-0069)
- Safety Belt Retraction Speed (05-16-11)
- Safety Belt Web Stop Button Service (05-3-10)
- 3RD Row Seat Strap Breaking (04-21-17)
Restraints Control Systems
- RCM Fault Reporting Using DTCS And Bit-Mapped Parameter Identifiers (PIDS) - Service Tips (07-7-8)
- DTC B1342 - Restraint Control Module - Diagnostic Service Tip (04-25-15)
Seats
- Safety Recall 13S01 - Corrosion On Sheet Metal That Supports 3RD Row Seat Latch Strikers - Requests For Recall Service Action (16-0069)
- Safety Belt Retraction Speed (05-16-11)
- Safety Belt Web Stop Button Service (05-3-10)
- 3RD Row Seat Strap Breaking (04-21-17)
Starter
- Battery Service - Operation Of Battery Eye - Charging Service Tips (07-5-8)
Steering Column
- Leather-Wrapped Steering Wheel - Leather Coming Loose (07-4-3)
- Steering Wheel And/Or Vehicle Vibration - Vehicles Equipped With GOODYEAR Integrity 16 Inch Tires Only (05-9-20)
Steering Control Systems
- MERCON(R) ATF Replaced By MERCON(R) V As A Service Fluid For Some Power Steering Systems (07-1-7)
- Power Steering Hose Leak Near Cooler - Extreme Cold Climate Areas Only -4°F (-20 °C) And Colder (07-1-2)
Steering Gear
- MERCON(R) ATF Replaced By MERCON(R) V As A Service Fluid For Some Power Steering Systems (07-1-7)
- Power Steering Hose Leak Near Cooler - Extreme Cold Climate Areas Only -4°F (-20 °C) And Colder (07-1-2)
- Outer CV Joint Broken - Vehicles Built Before 5/1/2005 (05-9-8)
System
- Damaged Spark Plug Electrode/Mil DTC P030X (10-3-3)
- Spark Knock Under Light Load And Acceleration - 3.8L, 3.9L, And 4.2L - Split Port Intake Manifold Runner Control (IMRC) (07-16-17)
- Engine/Transmission DRIVEABILITY Issues (06-14-10)
- MAF Diagnostic Service Tip - Vehicles Equipped With EGR System Module (ESM) (05-3-1)
- General Pcm Programming Procedures (04-24-14)
- Malfunction Indicator Lamp (Mil) Illuminated - System Lean Diagnostic Trouble Codes - DTC'S - Service Tips (04-17-4)
Towing
- Electrical - Trailer Tow Service Kit (03-24-2)
Transmission Control Systems
- Engine/Transmission DRIVEABILITY Issues (06-14-10)
- 4F50N Transaxle No 1-2 Upshift And DTC P0732 (04-17-10)
Wheels & Tire System
- Steering Wheel And/Or Vehicle Vibration - Vehicles Equipped With GOODYEAR Integrity 16 Inch Tires Only (05-9-20)
- Noise From Front Wheel Hub Bearing (04-16-13)
Window Motors & Regulators
- Door Window - Click/Snap Noise At End Of Upward Glass Travel (04-13-5)
Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)
- Service Wiring Harness Replacement Guidelines - Service Tips (06-17-8)
- Wiring - Soldering And Crimping Repairs - Service Tips (05-18-7)
- Electrical - Trailer Tow Service Kit (03-24-2)