Specifications Index
EXPEDITION & NAVIGATOR SPECIFICATIONS INDEX
| System | Specification/Procedure | ||||
|---|---|---|---|---|---|
| Air Conditioning | |||||
| Service | GENERAL SPECIFICATIONS | ||||
| Torque | TORQUE SPECIFICATIONS | ||||
| Axle Nut/Hub Nut | |||||
| Front (4WD) | |||||
| Axle Nut | 20 Ft. Lbs. (27 N.m) | ||||
| Hub Bolt | 148 Ft. Lbs. (200 N.m) | ||||
| Rear | |||||
| Axle Nut | 254 Ft. Lbs. (345 N.m) | ||||
| Hub Bolt | 136 Ft. Lbs. (185 N.m) | ||||
| Brakes | |||||
| Bleeding Sequence | BRAKE SYSTEM BLEEDING | ||||
| Disc Brakes | GENERAL SPECIFICATIONS | ||||
| Torque | TORQUE SPECIFICATIONS | ||||
| Charging | |||||
| Generator | GENERAL SPECIFICATIONS | ||||
| Torque | TORQUE SPECIFICATIONS | ||||
| Drive Belts | |||||
| Adjustment | COMPONENT TESTS | ||||
| Belt Routing | ACCESSORY DRIVE | ||||
| Engine Cooling | |||||
| General Service Specifications | GENERAL SPECIFICATIONS | ||||
| Radiator Cap Pressure | 16 psi (110 kPa) | ||||
| Thermostat R & I | |||||
| 5.4L (3V) | THERMOSTAT AND THERMOSTAT HOUSING | ||||
| Water Pump R & I | COOLANT PUMP | ||||
| Engine Mechanical | |||||
| 5.4L (3V) | |||||
| Compression | COMPRESSION TEST -- COMPRESSION GAUGE CHECK | ||||
| Oil Pressure | 40-75 psi (276-517 kPa) @ 2000 RPM | ||||
| Overhaul | GENERAL SPECIFICATIONS | ||||
| Torque | TORQUE SPECIFICATIONS | ||||
| Fluid Specifications | See FLUIDS under MAINTENANCE tab. From within Manager or Service Writer, click the "30/60/90 Interval" or "Maint." button. | ||||
| Flywheel/Flex Plate Torque | |||||
| 5.4L (3V) | 59 Ft. Lbs (80 N.m). | ||||
| Fuel System | |||||
| Fuel Filter Location | Located on the fuel tank assembly on left side of vehicle, mounted in worm clamp. | ||||
| Fuel Filter R & I | REMOVAL AND INSTALLATION | ||||
| Pressure Release Procedure | FUEL SYSTEM PRESSURE RELEASE | ||||
| Pressure Specification | FUEL SYSTEM SPECIFICATIONS | ||||
| Fuel Pressure Test Procedure | A: No Start STEP A10 CHECK THE FUEL PRESSURE | ||||
| Ignition | |||||
| Firing Order & Cylinder Identification | FIRING ORDER & CYLINDER IDENTIFICATION | ||||
| Ignition Coil (Cylinder Identification) | Coil On Plug | ||||
| Ignition Wires (Routing) | N/A | ||||
| Spark Plugs (1)SEE FOOTNOTE | |||||
| 5.4L (3V) | |||||
| Type | Motorcraft PZT-2F | ||||
| Gap | .040-.050 In. (1.15+/-0.13 mm) | ||||
| Torque | 25 Ft. Lbs. (34 N.m) | ||||
| Starting | |||||
| Starter | GENERAL SPECIFICATIONS | ||||
| Torque | TORQUE SPECIFICATIONS | ||||
| Wheel Alignment | |||||
| Adjustment Specifications | ALIGNMENT SPECIFICATIONS | ||||
| Torque | TORQUE SPECIFICATIONS | ||||
| Wheel & Tire | |||||
| Wheel Lug Nut Torque | 150 Ft. Lbs. (204 N.m) | ||||
|
|||||