Technical Service Bulletins

Accessory Drive Belts
- 3.9L Accessory Drive Belt Snap Noise In Freezing Temperatures (08-16-5)
Anti-Lock Brakes
- Diagnostic Trouble Code - DTC C1145 And/Or C1155 Stored In Anti-Lock Brake System (Abs) Module (04-22-13)
Anti-Theft Systems
- Keypad Diagnostics - Dealer Installed Accessory (06-15-8)
Automatic Trans
- 5R55S/5R55N/5R55W Transmissions - Shift Concerns, Loss Of 2ND, 3RD And 5TH Gear, Incorrect Ratio DTC'S - Procedure To Inspect And Repair Servo Pin Bore Wear (09-12-12)
- 5R55S - Leak From Converter Housing - Fluid Overfilled (06-25-1)
- Delayed Or Harsh Reverse Engagements - 5R55S Transmission - Vehicles Built Prior To 09/23/2004 (05-6-12)
Auxiliary Emission Control Systems
- 3.9L V8 Unusual Engine Noise - Spark Knock Ticking Noise Under Acceleration (06-23-17)
- Wrench Light On With Both DTC P2106 And P2135 - Vehicles Built 11/29/2004 And Prior (05-9-15)
- MAF Diagnostic Service Tip - Vehicles Equipped With EGR System Module (ESM) (05-3-1)
- General Pcm Programming Procedures (04-24-14)
Body Electrical
- Wiring - Soldering And Crimping Repairs - Service Tips (05-18-7)
Brakes Control Systems
- Diagnostic Trouble Code - DTC C1145 And/Or C1155 Stored In Anti-Lock Brake System (Abs) Module (04-22-13)
Charging Systems
- Stuck High Voltage Charge Cord Information Sheet (G0000127)
Cooling System (Mechanical)
- All Chain Driven Water Pumps (TT003-13)
- Keep The Cooling System Free Of Debris And Corrosion To Prevent Premature Water Pump Failure (TT002-13)
- Heater Core Leakage And Electrolysis (Information Only) (06-21-19)
Engine Control Systems
- DTCS P0505, P0506 And/Or Engine Idle Rpm Fluctuation - Hard Start (12-8-1)
- 3.9L V8 Unusual Engine Noise - Spark Knock Ticking Noise Under Acceleration (06-23-17)
- WDS Cop Kit Diagnostic Tips - Coil On Plug (Cop) Ignition Systems - Engine Misfire Or Rough Running (05-22-8)
- 3.9L - Water/Moisture In Cop Wells - DTC P0301-P0308 (05-16-2)
- Wrench Light On With Both DTC P2106 And P2135 - Vehicles Built 11/29/2004 And Prior (05-9-15)
- General Pcm Programming Procedures (04-24-14)
Exhaust
- Various Vehicles - Catalytic Converter Concern Analysis (22-7009)
Exterior Body Panels
- Removable Roof - Minor Paint Abrasions On Rear Deck - Squeak/Creak Noise (05-12-9)
- Weld Bonding Procedure (04-26-16)
Frames, Subframes & Crossmembers
- Weld Bonding Procedure (04-26-16)
Fuel System
- DTCS P0505, P0506 And/Or Engine Idle Rpm Fluctuation - Hard Start (12-8-1)
Fuses & Circuit Breakers
- Wiring - Soldering And Crimping Repairs - Service Tips (05-18-7)
HVAC Control Systems
- Heater Core Leakage And Electrolysis (Information Only) (06-21-19)
- Blower Motor Inoperative (05-10-20)
Ignition System
- WDS Cop Kit Diagnostic Tips - Coil On Plug (Cop) Ignition Systems - Engine Misfire Or Rough Running (05-22-8)
- 3.9L - Water/Moisture In Cop Wells - DTC P0301-P0308 (05-16-2)
Interior/Exterior Trim
- Parking Brake Lever Decorative Boot Broken/Cracked (05-13-11)
- Interior Plastic Trim - Paint-To-Match And Repair - Interior Spray Paint And Adhesion Promoter Usage Instructions (05-9-3)
Manual Steering
- MERCON(R) ATF Replaced By MERCON(R) V As A Service Fluid For Some Power Steering Systems (07-1-7)
- Steering Gear Squeak When Turning The Steering Wheel During Low Speed Parking Maneuvers (06-5-16)
Mechanical
- Hydraulic Versus Mechanical TENSIONERS (TT001-13)
- DTCS P0505, P0506 And/Or Engine Idle Rpm Fluctuation - Hard Start (12-8-1)
- 3.9L Accessory Drive Belt Snap Noise In Freezing Temperatures (08-16-5)
- Identifying The Correct Replacement Head Gasket For Certain Remanufactured Engines - Service Tip (06-18-16)
Mirrors
- Various Vehicles - Rear-View Mirror Concern Analysis (23-7092)
- Ford Interior Mirror Job Aid (G0000001)
Paint & Coatings
- Interior Plastic Trim - Paint-To-Match And Repair - Interior Spray Paint And Adhesion Promoter Usage Instructions (05-9-3)
- Paint - Iron Particle Removal - Industrial Fallout - Acid Rain Neutralization (99-12-10)
Parking Brake System
- Parking Brake Lever Decorative Boot Broken/Cracked (05-13-11)
Starter
- Battery Service - Operation Of Battery Eye - Charging Service Tips (07-5-8)
- Battery Drain Diagnosis - Service Tips (05-22-9)
Steering Column
- Leather-Wrapped Steering Wheel - Leather Coming Loose (07-4-3)
Steering Control Systems
- MERCON(R) ATF Replaced By MERCON(R) V As A Service Fluid For Some Power Steering Systems (07-1-7)
- Steering Gear Squeak When Turning The Steering Wheel During Low Speed Parking Maneuvers (06-5-16)
Steering Gear
- MERCON(R) ATF Replaced By MERCON(R) V As A Service Fluid For Some Power Steering Systems (07-1-7)
- Steering Gear Squeak When Turning The Steering Wheel During Low Speed Parking Maneuvers (06-5-16)
Sun Roof/T-Top/Convertible Top
- Removable Roof - Minor Paint Abrasions On Rear Deck - Squeak/Creak Noise (05-12-9)
- Water Leaks - Removable Roof And Convertible Top - Service Tips (04-9-5)
System
- DTCS P0505, P0506 And/Or Engine Idle Rpm Fluctuation - Hard Start (12-8-1)
- 3.9L V8 Unusual Engine Noise - Spark Knock Ticking Noise Under Acceleration (06-23-17)
- WDS Cop Kit Diagnostic Tips - Coil On Plug (Cop) Ignition Systems - Engine Misfire Or Rough Running (05-22-8)
- 3.9L - Water/Moisture In Cop Wells - DTC P0301-P0308 (05-16-2)
- Wrench Light On With Both DTC P2106 And P2135 - Vehicles Built 11/29/2004 And Prior (05-9-15)
- MAF Diagnostic Service Tip - Vehicles Equipped With EGR System Module (ESM) (05-3-1)
- General Pcm Programming Procedures (04-24-14)
Transmission Control Systems
- 5R55S/5R55N/5R55W Transmissions - Shift Concerns, Loss Of 2ND, 3RD And 5TH Gear, Incorrect Ratio DTC'S - Procedure To Inspect And Repair Servo Pin Bore Wear (09-12-12)
Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)
- Wiring - Soldering And Crimping Repairs - Service Tips (05-18-7)