Technical Service Bulletins

Accessories Control Systems
- Power Lift Gate Inoperative - All Functional Switches, Remote Keyless Entry, With Power Lift Gate Trunk Module DTC B117B (08-14-5)
- Inaccurate Fuel Gauge Indicator - Vehicle Built Before 11/1/2007 (08-1-7)
Accessory Drive Belts
- Power Steering Belt Chirp/Squeal - Cold (07-23-18)
Aerodynamic Devices
- Rear Liftgate Spoiler - Foam Gasket Sliding Out (09-6-3)
Anti-Lock Brakes
- Abs Lamp On C1165/C1175 And/Or C1235/C1236 (07-17-2)
Anti-Theft Systems
- Power Lift Gate Inoperative - All Functional Switches, Remote Keyless Entry, With Power Lift Gate Trunk Module DTC B117B (08-14-5)
Automatic Trans
- 6F50 Transaxle Built On Or Before 3/15/2008 - No Reverse Engagement, No 3RD Or 5TH Gear - DTC P0733, P0735, P0756 (08-9-4)
- 6F50 Transaxle - Diagnosis And Repair Procedures (07-5-2)
- 6F50 Transaxles Built Prior To 10/21/2007 - DTC P0715, P0717, P0718, P0720, P0721, P0722 And/Or Harsh Engagement, No Upshift, Fifth Gear Only (07-3-11)
Auxiliary Emission Control Systems
- Rough / Rolling Idle / Idle Speed Drops Below Specification / Light Throttle With Cruise Engaged / Low Speed Tip In Clunk (09-11-15)
- Mil On DTC P0451 (07-19-5)
Axle Shafts
- Howl Or Growl Type-Noise From Rear Wheel Area (14-0098)
- Noise Cold - Front Half Shafts - Ratcheting/Clicking/Creaking - Cold Ambient Temperatures - Below 15 Degrees F (-9 C) Built Before 5/1/2007 (07-25-8)
Body Interior
- Power Lift Gate Inoperative - All Functional Switches, Remote Keyless Entry, With Power Lift Gate Trunk Module DTC B117B (08-14-5)
- Inaccurate Fuel Gauge Indicator - Vehicle Built Before 11/1/2007 (08-1-7)
Brakes Control Systems
- Abs Lamp On C1165/C1175 And/Or C1235/C1236 (07-17-2)
- Brake Drag (07-11-9)
Charging Systems
- Stuck High Voltage Charge Cord Information Sheet (G0000127)
Cooling System (Mechanical)
- Keep The Cooling System Free Of Debris And Corrosion To Prevent Premature Water Pump Failure (TT002-13)
Differentials & Drive Axles
- Howl Or Growl Type-Noise From Rear Wheel Area (14-0098)
- Noise Cold - Front Half Shafts - Ratcheting/Clicking/Creaking - Cold Ambient Temperatures - Below 15 Degrees F (-9 C) Built Before 5/1/2007 (07-25-8)
Driveshaft & Universal Joints
- Harsh Driveline Clunk/Low Speed Below 10 Mph (16 Km/H) On Tip-In Or Vehicle Rolls On Incline While Stopped Without Brake Applied-In Drive Or Reverse (08-26-8)
- Noise Cold - Front Half Shafts - Ratcheting/Clicking/Creaking - Cold Ambient Temperatures - Below 15 Degrees F (-9 C) Built Before 5/1/2007 (07-25-8)
Engine Control Systems
- Mil On With DTCS - P0351, P0352, P0353, P0354, P0355, And/Or P0356 - Built On Or Before 3/1/2008 (14-0059)
- 3.5L / 3.7L Engine - VCT Codes P0011, P0012, P0016, P0018, P0021, P0022 - Runs Rough Or Misses - Vehicles Built On Or Before 12/15/2008 (11-6-1)
- Pcm - Battery Junction Box (BJB)- Possible Mil On With Multiple DTCS, No Crank/No Start, DRIVEABILITY Symptoms (10-1-8)
- Rough / Rolling Idle / Idle Speed Drops Below Specification / Light Throttle With Cruise Engaged / Low Speed Tip In Clunk (09-11-15)
- Harsh Driveline Clunk/Low Speed Below 10 Mph (16 Km/H) On Tip-In Or Vehicle Rolls On Incline While Stopped Without Brake Applied-In Drive Or Reverse (08-26-8)
- Mil On DTC P0451 (07-19-5)
- Ignition Diagnostics (06-18-15)
Entertainment Systems
- Pioneer Navigation Radio - Seek Function Inoperative - Service Tip (06-25-3)
- Audio / Navigation Service And Ordering Procedures (06-21-7)
Exhaust
- Various Vehicles - Catalytic Converter Concern Analysis (22-7009)
Exterior Body Panels
- Rear Liftgate Spoiler - Foam Gasket Sliding Out (09-6-3)
- Inaccurate Fuel Gauge Indicator - Vehicle Built Before 11/1/2007 (08-1-7)
Front Suspension
- Pull/Drift (08-7-3)
Fuses & Circuit Breakers
- Pcm - Battery Junction Box (BJB)- Possible Mil On With Multiple DTCS, No Crank/No Start, DRIVEABILITY Symptoms (10-1-8)
Gauges & Instrument Panels
- Inaccurate Fuel Gauge Indicator - Vehicle Built Before 11/1/2007 (08-1-7)
HVAC Control Systems
- White Flakes Or Powder Coming From A/C Vents (11-9-6)
Ignition System
- Mil On With DTCS - P0351, P0352, P0353, P0354, P0355, And/Or P0356 - Built On Or Before 3/1/2008 (14-0059)
- Ignition Diagnostics (06-18-15)
Infotainment
- Audio / Navigation Service And Ordering Procedures (06-21-7)
Interior/Exterior Trim
- Interior Trim - Carpet Pulling From Under Front Scuff Plate Trim Panel - Built On Or Before 7/31/2011 (12-2-11)
- Foam Seal Sliding Out Between Instrument Panel And Windshield (10-4-6)
- Popping/Snapping Noise - Front Or Rear 18 Inch Wheels - Turning At Slow Speed Below 10 Mph (16 Km/H) (09-4-3)
Manual Steering
- Power Steering Fluid Leaks From Steering Rack And Pump Attachment Joints (07-25-14)
- Power Steering Belt Chirp/Squeal - Cold (07-23-18)
Mechanical
- Hydraulic Versus Mechanical TENSIONERS (TT001-13)
- 3.5L / 3.7L Engine - VCT Codes P0011, P0012, P0016, P0018, P0021, P0022 - Runs Rough Or Misses - Vehicles Built On Or Before 12/15/2008 (11-6-1)
- Power Steering Belt Chirp/Squeal - Cold (07-23-18)
Mechanical - Hydraulic
- Brake Drag (07-11-9)
Mirrors
- Various Vehicles - Rear-View Mirror Concern Analysis (23-7092)
- Ford Interior Mirror Job Aid (G0000001)
Parking Brake System
- Brake Drag (07-11-9)
Starter
- Pcm - Battery Junction Box (BJB)- Possible Mil On With Multiple DTCS, No Crank/No Start, DRIVEABILITY Symptoms (10-1-8)
- Battery Service - Operation Of Battery Eye - Charging Service Tips (07-5-8)
Steering Column
- Leather-Wrapped Steering Wheel - Leather Coming Loose (07-4-3)
Steering Control Systems
- Power Steering Fluid Leaks From Steering Rack And Pump Attachment Joints (07-25-14)
Steering Gear
- Power Steering Fluid Leaks From Steering Rack And Pump Attachment Joints (07-25-14)
Sun Roof/T-Top/Convertible Top
- Roof Opening Panel Slow Or Sticking/Binding Operation (07-25-4)
- Roof Opening Panel Squeak/Rattle (07-16-11)
Suspension Control Systems
- Pull/Drift (08-7-3)
System
- Mil On With DTCS - P0351, P0352, P0353, P0354, P0355, And/Or P0356 - Built On Or Before 3/1/2008 (14-0059)
- 3.5L / 3.7L Engine - VCT Codes P0011, P0012, P0016, P0018, P0021, P0022 - Runs Rough Or Misses - Vehicles Built On Or Before 12/15/2008 (11-6-1)
- Pcm - Battery Junction Box (BJB)- Possible Mil On With Multiple DTCS, No Crank/No Start, DRIVEABILITY Symptoms (10-1-8)
- Rough / Rolling Idle / Idle Speed Drops Below Specification / Light Throttle With Cruise Engaged / Low Speed Tip In Clunk (09-11-15)
- Harsh Driveline Clunk/Low Speed Below 10 Mph (16 Km/H) On Tip-In Or Vehicle Rolls On Incline While Stopped Without Brake Applied-In Drive Or Reverse (08-26-8)
- Mil On DTC P0451 (07-19-5)
- Ignition Diagnostics (06-18-15)
Transfer Case
- Service Tip - Power Transfer Unit (PTU) - Right Hand Intermediate Shaft Seal Leaks (09-8-10)
- Power Transfer Unit (PTU) Vent Leak (07-16-10)
- Whine/Hoot Noise - Speed 50-60 Mph (80-97 Km/H) (07-11-13)
Transmission Control Systems
- Harsh Driveline Clunk/Low Speed Below 10 Mph (16 Km/H) On Tip-In Or Vehicle Rolls On Incline While Stopped Without Brake Applied-In Drive Or Reverse (08-26-8)
- 6F50 Transaxle Built On Or Before 3/15/2008 - No Reverse Engagement, No 3RD Or 5TH Gear - DTC P0733, P0735, P0756 (08-9-4)
- 6F50 Transaxles Built Prior To 10/21/2007 - DTC P0715, P0717, P0718, P0720, P0721, P0722 And/Or Harsh Engagement, No Upshift, Fifth Gear Only (07-3-11)
Wheel Alignment
- Pull/Drift (08-7-3)
Wheel Hubs
- Howl Or Growl Type-Noise From Rear Wheel Area (14-0098)
Wheels & Tire System
- Howl Or Growl Type-Noise From Rear Wheel Area (14-0098)
- 18 Inch Chrome-Clad Aluminum Wheel Outboard Rim Flange Corrosion (12-3-18)
- Popping/Snapping Noise - Front Or Rear 18 Inch Wheels - Turning At Slow Speed Below 10 Mph (16 Km/H) (09-4-3)
Window Motors & Regulators
- Foam Seal Sliding Out Between Instrument Panel And Windshield (10-4-6)