Repair and Diagnosis (Single Page)
You are viewing the full "tree" of links on one page. This can load slowly, but is easier to search. The same page can appear multiple times under a different folder, that is why the page is so large.View "split tree" where inner folders are split out. where inner links are on separate pages.
Quick Lookups
Common Specs & Procedures
DTC Index- Anti-Lock Brakes DTCS
- Anti-Theft System (Perimeter) DTCS
- Anti-Theft System (Pats) DTCS
- Automatic Transaxle / Transmission DTCS
- Charging System DTCS
- Entertainment System DTCS
- Horn DTCS
- Instrument Cluster DTCS
- Lighting DTCS
- MULTIFUNCTION Electronic Modules DTCS (A0278282)
- Power Door Locks & Remote Keyless Entry Systems DTCS
- Self-Diagnostics DTCS
- Supplemental Restraint System DTCS
- Warning Devices DTCS
- Wiper/Washers DTCS A00316593
Electrical Component Locations
Fluids
Technical Bulletins
Tire Fitment
Wiring Diagrams- OEM Connector End Views
- Connector Views
- A/C Clutch Field Coil Connector
- Crankshaft Position Sensor Connector
- Generator Connectors
- Oil Pressure Switch Connector
- Cylinder-Head Temperature Sensor Connector
- Knock Sensor Connector
- Coil On Plug Connector
- Speed Control Servo Connector
- EVAP Canister Purge Valve Connector
- Brake Fluid Level Switch Connector
- Windshield Wiper Motor Connector
- ABS Test Connector
- Engine Compartment Switch Connector
- Mass Air Flow (MAF) Sensor Connector
- Horn Connector
- Inline Connectors
- ABS Control Module Connector
- Heated Oxygen Sensor (HO2S) #12 Connector
- Turbine Shaft Speed (TSS) Sensor Connector
- Wheel Speed Sensor, Left Front Connector
- Stop Lamp, Left Front Connector
- Fog Lamp, Left Front Connector
- Air Pump Motor Connector
- Air Pump Relay Connector
- Wheel Speed Sensor, Right Front Connector
- Side Lamp, Right Front Connector
- Fog Lamp, Right Front Connector
- Transmission Range (TR) Sensor Connector
- Heated Oxygen Sensor (HO2S) #11 Connector
- Powertrain Control Module (PCM) Connector
- Forward Crash Sensor Connector
- Camshaft Position Sensor Connector
- Throttle Position Sensor (TPS) Connector
- Output Shaft Speed (OSS) Sensor Connector
- Starter Motor Connectors
- Generic Electronic Module (GEM) Connector
- Multifunction Switch Connectors
- Main Light Switch Connectors
- Ignition Switch Connector
- Data Link Connector
- Passive Anti-Theft Transceiver Module Connector
- Passenger Air Bag Module Connectors
- Clutch Pedal Position Switch Connector
- Central Junction Box (CJB) Connector
- Brake Pedal Position Switch Connector
- Inertia Fuel Shutoff (IFS) Switch Connector
- Heater Blower Motor Connector
- Passenger Safety Belt Retractor Pretensioner Connector
- Side Air Bag Sensor, Right Connector
- Side Air Bag Sensor, Left Connector
- Heated Seat Element, Driver Side Front Connector
- Seat Belt Buckle Sensor, Driver Connector
- Seat Back Position Sensor, Driver Connector
- Side Air Bag Module, Left Connector
- Heated Seat Element, Passenger Side Front Connector
- Seat Belt Buckle Sensor, Passenger Connector
- Side Air Bag Module, Light Connector
- Seat Heater Switch, Passenger Side Connector
- Driver Safety Belt Buckle Pretensioner Connector
- Seat Heater Switch, Driver Side Connector
- Seat Belt Tensioner, Passenger Seat Connector
- Speaker, Left Rear Connector
- Speaker, Right Rear Connector
- Rear Window Defrost Grid Connector
- Wheel Speed Sensor, Right Rear Connector
- Luggage Compartment Lamp Connector
- Luggage Compartment Lid Release Solenoid Connector
- Fuel Tank Unit Connector
- Fuel Tank Pressure Transducer Sensor Connector
- Wheel Speed Sensor, Left Rear Connector
- Evaporative Emission (EVAP) Canister Vent Valve Connector
- Reversing Lamp, Left Connector
- License Plate Lamp, Left Connector
- Reversing Lamp, Right Connector
- License Plate Lamp, Right Connector
- Subwoofer Amplifier Connector
- High Mounted Stoplamp Connector
- Cargo Space Lamp Connector
- Lamp Assembly, Left Rear Connector
- Lamp Assembly, Right Rear Connector
- Master Window Adjust Switch Connector
- Door Lock Switch Driver Side Connector
- Power Window Motor, Driver Side Front Connector
- Exterior Rear View Mirror, Left Connector
- Speaker, Left Front Connector
- Door Lock Unit Driver Side Front Connector
- Door Ajar Switch, Driver Side Front Connector
- Exterior Rear View Mirror Switch Connector
- One-Touch Window Relay Connector
- Door Ajar Switch, Passenger Side Front Connector
- Window Adjust Switch, Passenger Side Connector
- Door Lock Switch, Passenger Side Connector
- Door Lock Unit, Passenger Side Front Connector
- Speaker, Right Front Connector
- Exterior Rear View Mirror, Right Connector
- Power Window Motor, Passenger Side Front Connector
- Window Adjust Switch, Left Rear Connector
- Power Window Motor, Left Rear Connector
- Door Lock Unit, Left Rear Connector
- Door Ajar Switch, Driver Side Rear Connector
- Window Adjust Switch, Right Rear Connector
- Power Window Motor, Right Rear Connector
- Door Lock Unit, Right Rear Connector
- Door Ajar Switch, Passenger Side Rear Connector
- Interior Lamp, Front Connector
- A/C Clutch Relay Connector
- PCM Power Diode Connector
- Headlamp, Left Connector
- Park/Turn Lamp, Left Front Connector
- Engine Cooling Fan Resistor Connector
- BJB Relay Connector
- Headlamp, Right Connector
- Park/Turn Lamp, Right Front Connector
- Engine Cooling Fan Motor Connector
- Low Beam Relay Connector
- High Beam Relay Connector
- Fuel Pump Relay Connector
- Ignition Relay Connector
- Engine Cooling, Fan Relay Connector
- High Speed Fan Control Relay Connector
- Dual Pressure Switch Connector
- Idle Air Control (IAC) Valve Connector
- Secondary Air Injection Bypass Solenoid Connector
- A/C Compressor Cycling Switch Connector
- Vehicle Speed Sensor (VSS) Connector
- Battery Connectors
- Manifold Absolute Pressure/Intake Air Temperature (MAP/IAT) Sensor Connector
- EGR Stepper Motor Connector
- Fuel Injector Connectors
- Ignition Transformer Capacitor Connector
- Intake Manifold Runner Control (MRC) Module Connector
- Fuel Rail Pressure/Temperature Sensor Connector
- Power Steering Pressure Sensor Connector
- Inlet Manifold Runner Control (MRC) Solenoid 1 Connector
- Tow-Way Washer Pump Motor Connector
- Power Hold Relay Connector
- Second Cooling Fan Motor Connector
- Park/Neutral Position (PNP) Switch Connector
- Low Speed Engine Cooling Fan Relay A Connector
- Low Speed Engine Cooling Fan Relay B Connector
- Intake Manifold Tuning Valve (IMTV) Connector
- Heated Oxygen Sensor (HO2S) #13 Connector
- Parking Brake Switch Connector
- Rear Window Defrost Relay Connector
- Cigar Lighter, Front Connector
- Hazard Faster Switch Connector
- Restraints Control Module Connectors
- Daytime Running Lamps (DRL) Relay Connector
- Wiper/Washer Switch Connector
- Starter Relay Connector
- Driver Motor Resistor Connector
- Radio Connector
- Start Inhibit Switch Connector
- Instrument Cluster Connectors
- Recirculation Air Actuator Connector
- Heater Control Module Connector
- Radio Remote Control Switch Connector
- Heater Blower Switch Connector
- Heater Panel Illumination Lamp Connector
- Traction Control System (TCS) Disable Switch Connector
- Liftgate/Decklid Release Switch Connector
- Clock Spring Connector
- Stop/Lamp Switch Connector
- Seat Pressure Sensor Module Connector
- Seat Weight Sensor Module Connector
- Gearshift Lever Unit Connector
- Fuel Pump Driver Module Connector
- Rear Wiper Motor Assembly Connector
- Liftgate/Decklid Latch Assembly Connector
- Liftgate/Decklid Release Switch, Exterior Connector
- Liftgate/Decklid Anti-Theft Inhibit Switch Connector
- Moonroof Adjust Switch Connector
- Roof Opening Panel Unit Connector
- Heated Seats Relay Connector
- Ambient Lighting Module Connector
- Connector Views
- System Wiring Diagrams
- Using lemon2025'S Wiring Diagrams
- Air Conditioning
- Anti-Lock Brakes
- Anti-Theft
- Body Control Modules
- Computer Data Lines
- Cooling Fan
- Cruise Control
- Defoggers
- Engine Performance
- Exterior Lights
- Ground Distribution
- Headlights
- Horn
- Instrument Cluster
- Interior Lights
- Power Distribution
- Power Door Locks
- Power Mirrors
- Power Seats
- Power Top/Sunroof
- Power Windows
- Radio
- Shift Interlock
- Starting/Charging
- Supplemental Restraints
- Transmission
- Trunk, Tailgate, Fuel Door
- Warning Systems
- Wiper/Washer
- Using lemon2025'S System Wiring Diagrams
- OEM Connector End Views
- Accessories & Equipment
- Accessories Control Systems
- Component Testing
- Introduction
- Component testing
- Ignition switch (11572)
- Main light switch (11654)
- Multifunction switch (13K359)
- Wiper/washer switch (17A553)
- Power door lock switch
- Master window adjust switch (14529A), with rear power windows
- Master window adjust switch (14529A), without rear power windows
- Power window switches
- Exterior rear view mirror switch (17B676)
- Moonroof adjust switch (58519A70)
- Mini ISO
- Micro ISO
- Component Testing
- Anti-Theft Systems
- Anti-Theft System - Passive Anti-Theft System (Pats)
- Description And Operation
- Diagnostic Tests
- Anti-Theft
- Notes
- Principles of Operation
- Inspection and Verification
- Symptom Chart
- Pinpoint Tests
- Pinpoint Test A: DTC B2103 - Antenna Not Connected
- Pinpoint Test B: DTC B1600 - PATS Ignition Key Transponder Signal Is Not Received
- Pinpoint Test C: DTC B1601 - PATS Received Incorrect Key-Code From Ignition Key Transponder
- Pinpoint Test D: DTC B1602 - PATS Received Invalid Format Of Key-Code From Ignition Key Transponder
- Pinpoint Test E: DTC B1681- PATS Transceiver Module Signal Is Not Received
- Pinpoint Test F: The Anti-Theft Indicator Is Always/Never On
- Anti-Theft
- General Procedures
- Removal And Installation
- Anti-Theft System - Perimeter
- Handles, Locks, Latches And Entry Systems
- Specifications
- Description And Operation
- Diagnostic Tests
- Locks, Latches and Entry Systems
- Notes
- Principles of Operations
- Inspection and Verification
- Symptom Chart
- Pinpoint Tests
- Pinpoint Test A: A Single/More Than One Door Lock Is Inoperative
- Pinpoint Test B: The Liftgate/Luggage Compartment Lid Is Inoperative - 3-Door
- Pinpoint Test C: All Door Locks Are Inoperative From One Switch - Door Lock Cylinder
- Pinpoint Test D: All Door Locks Are Inoperative From One Switch
- Pinpoint Test E: The Doors Do Not Lock/Unlock Using The Remote Keyless Entry (RKE) Transmitter
- Pinpoint Test F: The Liftgate/Luggage Compartment Lid Release Is Inoperative Using The Remote Keyless Entry (RKE) Transmitter
- Pinpoint Test G: Panic Feature Is Inoperative/Does Not Operate Correctly
- Pinpoint Test H: The Remote Keyless Entry (RKE) Transmitter Is Out Of Synchronization
- Pinpoint Test I: The Remote Keyless Entry (RKE) Transmitter Has Poor Range Performance
- Pinpoint Test J: The Autolock Does Not Operate Correctly
- Pinpoint Test K: The Liftgate/Luggage Compartment Lid Is Inoperative - 5-Door/Sedan/Wagon
- Locks, Latches and Entry Systems
- General Procedures
- Removal And Installation
- Hood Latch and Components - Exploded View
- Hood Latch
- Front Door Handles, Locks and Latches - Exploded View
- Front Door Latch
- Exterior Front Door Handle
- Interior Door Handle - Front
- Door Lock Cylinder
- Rear Door Handles, Locks and Latches - Exploded View
- Rear Door Latch
- Exterior Rear Door Handle
- Interior Door Handle - Rear
- Liftgate Handle, Lock and Latch - Exploded View
- Liftgate Latch
- Liftgate Lock Cylinder
- Liftgate Lock Cylinder - Wagon
- Luggage Compartment Lid Latch
- Luggage Compartment Lid Lock Cylinder
- Ignition Lock Cylinder - Functional
- Ignition Lock Cylinder - Non Functional
- Passive Anti-Theft System Job Aid
- Remote Keyless Entry System [Transmitter Programming Procedures]
- Anti-Theft System - Passive Anti-Theft System (Pats)
- Communication Devices
- Module Communications Network
- Description And Operation
- Diagnostic Tests
- Communications Network
- Notes
- Principles of Operation
- Inspection and Verification
- Symptom Chart
- Pinpoint Tests
- Pinpoint Test A: The PCM Does Not Respond To The Scan Tool or No High Speed Controller Area Network (HS-CAN) Communication
- Pinpoint Test B: The Generic Electronic Module (GEM) Does Not Respond To The Scan Tool
- Pinpoint Test C: The Restraints Control Module (RCM) Does Not Respond To The Scan Tool
- Pinpoint Test D: The ABS Module Does Not Respond To The Scan Tool
- Pinpoint Test E: The Instrument Cluster (IC) Does Not Respond To The Scan Tool
- Pinpoint Test F: No International Standards Organization (ISO) 9141 Communications Network Communication
- Pinpoint Test G: No Power To The Scan Tool
- Communications Network
- Module Configuration
- MULTIFUNCTION Electronic Module
- Module Communications Network
- Cruise Control Systems
- Speed Control System
- Specifications
- Description And Operation
- Diagnostic Tests
- Speed Control
- Notes
- Principles of Operation
- Inspection and Verification
- Symptom Chart
- Pinpoint Tests
- Pinpoint Test A: The Speed Control Is Inoperative - No Flash Codes
- Pinpoint Test B: The Set Speed Fluctuates
- Pinpoint Test C: The Speed Control Does Not Disengage When The Brakes Are Applied
- Pinpoint Test D: The Speed Control Does Not Disengage When The Clutch Is Applied
- Pinpoint Test E: The Speed Control Switch Is Inoperative
- Pinpoint Test F: The Speed Control Is Inoperative - Flash With Last Switch Pressed, But No Dynamic Pull Occurs At The Throttle
- Pinpoint Test G: Flash Code 2 - Stoplamp Switch Circuit Failure
- Pinpoint Test H: Flash Code 3 - Speed Control Deactivator Switch Circuit Failure
- Pinpoint Test I: Flash Code 4 - Vehicle Speed Sensor (VSS) Circuit Failure
- Speed Control
- General Procedures
- Removal And Installation
- Speed Control System
- Entertainment Systems
- Information System And Entertainment System
- Description And Operation
- Diagnostic Tests
- Information and Entertainment System
- Notes
- Principles of Operation
- Inspection and Verification
- Symptom Chart
- Pinpoint Tests
- Pinpoint Test A: The Audio Unit Is Inoperative/Does Not Operate Correctly
- Pinpoint Test B: Poor Reception
- Pinpoint Test C: Poor Quality/Distorted/No Sound From One or More Speakers (Not All Speakers)
- Pinpoint Test D: The Subwoofer Is Inoperative
- Pinpoint Test E: Loud Popping Sound When Cycling The Ignition Switch
- Pinpoint Test F: The Auxiliary Audio Control Is Inoperative/Does Not Operate Correctly
- Information and Entertainment System
- General Procedures
- Removal And Installation
- Information System And Entertainment System
- Exterior Lights
- Exterior Lighting System
- Specifications
- Description And Operation
- Diagnostic Tests
- Headlamps
- Notes
- Principles of Operation
- Inspection and Verification
- Symptom Chart
- Pinpoint Tests
- Stoplamps
- Turn Signal and Hazard Lamps
- Notes
- Principles of Operation
- Inspection and Verification
- Symptom Chart
- Pinpoint Tests
- Parking, Rear and License Plate Lamps
- Fog Lamps
- Reversing Lamps
- Daytime Running Lamps (DRL)
- Headlamps
- General Procedures
- Removal And Installation
- Exterior Lighting System
- Gauges & Instrument Panels
- Information System And Entertainment System
- Description And Operation
- Diagnostic Tests
- Information and Entertainment System
- Notes
- Principles of Operation
- Inspection and Verification
- Symptom Chart
- Pinpoint Tests
- Pinpoint Test A: The Audio Unit Is Inoperative/Does Not Operate Correctly
- Pinpoint Test B: Poor Reception
- Pinpoint Test C: Poor Quality/Distorted/No Sound From One or More Speakers (Not All Speakers)
- Pinpoint Test D: The Subwoofer Is Inoperative
- Pinpoint Test E: Loud Popping Sound When Cycling The Ignition Switch
- Pinpoint Test F: The Auxiliary Audio Control Is Inoperative/Does Not Operate Correctly
- Information and Entertainment System
- General Procedures
- Removal And Installation
- Instrument Cluster
- Description And Operation
- Diagnostic Tests
- Instrument Cluster
- Notes
- Principles of Operation
- Notes
- Tachometer
- Speedometer
- Fuel Gauge
- Temperature Gauge
- Odometer/Trip Odometer
- Traction Control Indicator
- Check Fuel Cap Indicator
- Speed Control Indicator
- Low Fuel Warning Indicator
- Brake Warning Indicator
- Safety Belt Indicator
- ABS Warning Indicator
- Malfunction Indicator Lamp (MIL)
- PATS Indicator Lamp
- O/D OFF Indicator
- Engine Oil Pressure Warning Indicator
- Door Ajar Warning Indicator
- Air Bag Warning Indicator
- Charging System Warning Indicator
- Shift Up Indicator
- High Beam Indicator
- Turn/Hazard Indicators
- Inspection and Verification
- Symptom Chart
- Pinpoint Tests
- Pinpoint Test A: The Instrument Cluster is Inoperative
- Pinpoint Test B: Incorrect Fuel Gauge Indication
- Pinpoint Test C: Incorrect Tachometer Indication
- Pinpoint Test D: Incorrect Temperature Gauge Indication
- Pinpoint Test E: The Low Fuel Warning Indicator Is Never/Always On
- Pinpoint Test F: The Speedometer/Odometer Is Inoperative
- Pinpoint Test G: The Safety Belt Warning Indicator Is Inoperative (Chime Is Operative)/Does Not Operate Correctly
- Pinpoint Test H: The Door Ajar Warning Indicator Is Inoperative (Chime Is Operative)/Does Not Operate Correctly
- Pinpoint Test I: The Air Bag Warning Indicator Is Never/Always On
- Pinpoint Test J: The Anti-Lock Brake System (ABS) Warning Indicator Is Never/Always On
- Pinpoint Test K: The Brake Warning Indicator Is Never On
- Pinpoint Test L: The Low Oil Pressure Warning Indicator Is Never/Always On
- Pinpoint Test M: The Check Fuel Cap Indicator Is Never/Always On
- Pinpoint Test N: The Charging System Warning Indicator Is Never/Always On
- Pinpoint Test O: The Malfunction Indicator Lamp (MIL) Is Never On
- Pinpoint Test P: The LH Turn Signal Indicator Is Never/Always On
- Pinpoint Test Q: The RH Turn Signal Indicator Is Never/Always On
- Pinpoint Test R: The High Beam Indicator is Never On
- Pinpoint Test S: The Shift Up Indicator Is Never/Always On
- Pinpoint Test T: The Traction Control Indicator Is Never/Always On
- Pinpoint Test U: The Speed Control Indicator is Never/Always On
- Pinpoint Test V: The O/D Off Indicator Is Never/Always On
- Pinpoint Test W: The Passive Anti-Theft System (PATS) Indicator Is Never/Always On
- Pinpoint Test X: The Integrated Circuit Display Is Inoperative
- Pinpoint Test Y: The Brake Warning Indicator Is Always On
- Instrument Cluster
- Removal And Installation
- Instrument Cluster And Panel Illumination
- Description And Operation
- Diagnostic Tests
- Instrument Cluster and Panel Illumination
- Notes
- Principles of Operation
- Inspection and Verification
- Symptom Chart
- Pinpoint Tests
- Pinpoint Test A: The Control Illumination Is Inoperative
- Pinpoint Test B: The Instrument Cluster (IC) Illumination Is Inoperative
- Pinpoint Test C: The Climate Control Assembly Illumination Is Inoperative
- Pinpoint Test D: The Audio Control Module (ACM) Illumination Is Inoperative
- Pinpoint Test E: The Transmission Selector Lever Illumination Is Inoperative
- Pinpoint Test F: The Hazard Warning Switch Illumination Is Inoperative
- Pinpoint Test G: The Traction Control Switch Illumination Is Inoperative
- Pinpoint Test H: The Ambient Lighting Control Switch Illumination Is Inoperative
- Pinpoint Test I: The Instrument Panel Illumination Does Not Dim
- Instrument Cluster and Panel Illumination
- Instrument Panel And Console
- Information System And Entertainment System
- Headlights
- Exterior Lighting System
- Specifications
- Description And Operation
- Diagnostic Tests
- Headlamps
- Notes
- Principles of Operation
- Inspection and Verification
- Symptom Chart
- Pinpoint Tests
- Stoplamps
- Turn Signal and Hazard Lamps
- Notes
- Principles of Operation
- Inspection and Verification
- Symptom Chart
- Pinpoint Tests
- Parking, Rear and License Plate Lamps
- Fog Lamps
- Reversing Lamps
- Daytime Running Lamps (DRL)
- Headlamps
- General Procedures
- Removal And Installation
- Exterior Lighting System
- Heated Glass/Defoggers
- Windows And Glass
- Specifications
- Description And Operation
- Diagnostic Tests
- Glass, Frames and Mechanisms
- Notes
- Principles of Operation
- Inspection and Verification
- Symptom Chart
- Pinpoint Tests
- Pinpoint Test A: All Power Windows Are Inoperative - Front and Rear Power Windows
- Pinpoint Test B: A Single Window Is Inoperative - Front and Rear Power Windows - Driver Window
- Pinpoint Test C: A Single Window Is Inoperative - Front And Rear Power Windows - Passenger Window
- Pinpoint Test D: The One-Touch Down Feature Is Inoperative
- Pinpoint Test E: All Power Windows Are Inoperative - 3-Door
- Pinpoint Test F: A Single Window Is Inoperative - 3-Door - Driver Side
- Pinpoint Test G: A Single Window Is Inoperative - 3-Door - Passenger Side
- Pinpoint Test H: The Defrost System Is Inoperative
- Pinpoint Test I: The Defrost System Will Not Shut Off Automatically
- Component Test
- Glass, Frames and Mechanisms
- General Procedures
- Removal And Installation
- Windshield Glass
- Glass, Frames and Mechanisms - Exploded View, Front Door
- Window Glass - Front Door
- Window Regulator and Motor - Front Door
- Door Glass Top Run - Front
- Glass, Frames and Mechanisms - Exploded View, Rear Door
- Window Glass - Rear Door
- Window Regulator and Motor - Rear Door
- Door Glass Top Run - Rear
- Window Glass - Rear Quarter, 4-Door
- Window Glass - Rear Quarter, Wagon
- Window Glass - Rear Quarter, 3-Door/5-Door
- Window Glass - Rear
- Window Glass - Liftgate, Wagon
- Window Glass - Liftgate, 3-Door/5-Door
- Windows And Glass
- Horns
- Infotainment
- Information System And Entertainment System
- Description And Operation
- Diagnostic Tests
- Information and Entertainment System
- Notes
- Principles of Operation
- Inspection and Verification
- Symptom Chart
- Pinpoint Tests
- Pinpoint Test A: The Audio Unit Is Inoperative/Does Not Operate Correctly
- Pinpoint Test B: Poor Reception
- Pinpoint Test C: Poor Quality/Distorted/No Sound From One or More Speakers (Not All Speakers)
- Pinpoint Test D: The Subwoofer Is Inoperative
- Pinpoint Test E: Loud Popping Sound When Cycling The Ignition Switch
- Pinpoint Test F: The Auxiliary Audio Control Is Inoperative/Does Not Operate Correctly
- Information and Entertainment System
- General Procedures
- Removal And Installation
- Information System And Entertainment System
- Interior/Exterior Trim
- Interior Trim And Ornamentation
- Interior/Illumination Lights
- Instrument Cluster And Panel Illumination
- Description And Operation
- Diagnostic Tests
- Instrument Cluster and Panel Illumination
- Notes
- Principles of Operation
- Inspection and Verification
- Symptom Chart
- Pinpoint Tests
- Pinpoint Test A: The Control Illumination Is Inoperative
- Pinpoint Test B: The Instrument Cluster (IC) Illumination Is Inoperative
- Pinpoint Test C: The Climate Control Assembly Illumination Is Inoperative
- Pinpoint Test D: The Audio Control Module (ACM) Illumination Is Inoperative
- Pinpoint Test E: The Transmission Selector Lever Illumination Is Inoperative
- Pinpoint Test F: The Hazard Warning Switch Illumination Is Inoperative
- Pinpoint Test G: The Traction Control Switch Illumination Is Inoperative
- Pinpoint Test H: The Ambient Lighting Control Switch Illumination Is Inoperative
- Pinpoint Test I: The Instrument Panel Illumination Does Not Dim
- Instrument Cluster and Panel Illumination
- Interior Lighting System
- Description And Operation
- Diagnostic Tests
- Interior Lighting
- Notes
- Principles of Operation
- Inspection and Verification
- Symptom Chart
- Pinpoint Tests
- Pinpoint Test A: The Front Interior Lamp Is Inoperative
- Pinpoint Test B: The Cargo Lamp Is Inoperative
- Pinpoint Test C: The Interior Lamps Stay On Continuously
- Pinpoint Test D: The Interior Lamps Do Not Turn On With One Door Open
- Pinpoint Test E: The Illuminated Entry Is Inoperative Using The Remote Transmitter/Keypad
- Pinpoint Test F: The Demand Lighting Is Inoperative
- Pinpoint Test G: The Battery Saver Does Not Deactivate After Timeout
- Pinpoint Test H: The Luggage Compartment Lamp Is Inoperative
- Pinpoint Test I: The Ambient Lighting Is Inoperative
- Pinpoint Test J: The Ambient Lighting Does Not Operate Correctly - Does Not Cycle Through Color Variations
- Interior Lighting
- Removal And Installation
- Instrument Cluster And Panel Illumination
- Rear View Mirrors System
- Specifications
- Description And Operation
- Diagnostic Tests
- Rear View Mirrors
- Removal And Installation
- Seats
- Seat System
- Specifications
- Description And Operation
- Diagnostic Tests
- Removal And Installation
- Disassembly And Assembly
- Seat System
- Steering Column Switches
- Specifications
- Description And Operation
- Diagnostic Tests
- Removal And Installation
- Warning Systems
- Description And Operation
- Diagnostic Tests
- Warning Devices
- Notes
- Principles of Operation
- Inspection and Verification
- Symptom Chart
- Pinpoint Tests
- Pinpoint Test A: The Safety Belt Warning Chime Is Inoperative/Does Not Operate Correctly
- Pinpoint Test B: The Key-In-Ignition Warning Chime Is Inoperative/Does Not Operate Correctly
- Pinpoint Test C: The Headlamps On Reminder Chime Is Inoperative/Does Not Operate Correctly
- Pinpoint Test D: DTC B2369 - Tone Request Circuit Short To Ground
- Pinpoint Test E: The Turn Signal Chime is Inoperative/Does Not Operate Correctly
- Warning Devices
- General Procedures
- Window Motors & Regulators
- Windows And Glass
- Specifications
- Description And Operation
- Diagnostic Tests
- Glass, Frames and Mechanisms
- Notes
- Principles of Operation
- Inspection and Verification
- Symptom Chart
- Pinpoint Tests
- Pinpoint Test A: All Power Windows Are Inoperative - Front and Rear Power Windows
- Pinpoint Test B: A Single Window Is Inoperative - Front and Rear Power Windows - Driver Window
- Pinpoint Test C: A Single Window Is Inoperative - Front And Rear Power Windows - Passenger Window
- Pinpoint Test D: The One-Touch Down Feature Is Inoperative
- Pinpoint Test E: All Power Windows Are Inoperative - 3-Door
- Pinpoint Test F: A Single Window Is Inoperative - 3-Door - Driver Side
- Pinpoint Test G: A Single Window Is Inoperative - 3-Door - Passenger Side
- Pinpoint Test H: The Defrost System Is Inoperative
- Pinpoint Test I: The Defrost System Will Not Shut Off Automatically
- Component Test
- Glass, Frames and Mechanisms
- General Procedures
- Removal And Installation
- Windshield Glass
- Glass, Frames and Mechanisms - Exploded View, Front Door
- Window Glass - Front Door
- Window Regulator and Motor - Front Door
- Door Glass Top Run - Front
- Glass, Frames and Mechanisms - Exploded View, Rear Door
- Window Glass - Rear Door
- Window Regulator and Motor - Rear Door
- Door Glass Top Run - Rear
- Window Glass - Rear Quarter, 4-Door
- Window Glass - Rear Quarter, Wagon
- Window Glass - Rear Quarter, 3-Door/5-Door
- Window Glass - Rear
- Window Glass - Liftgate, Wagon
- Window Glass - Liftgate, 3-Door/5-Door
- Windows And Glass
- Wiper/Washer Systems
- Wiper System And Washer System
- Specifications
- Description And Operation
- Diagnostic Tests
- Wipers and Washers
- Notes
- Inspection and Verification
- Symptom Chart
- Pinpoint Tests
- Pinpoint Test A: The Wipers Are Inoperative
- Pinpoint Test B: The Wipers Stay On Continuously
- Pinpoint Test C: The High/Low Wiper Speeds Do Not Operate Correctly (Intermittent Wiper Mode OK)
- Pinpoint Test D: The Wash And Wipe Function Is Inoperative
- Pinpoint Test E: The Rear Window Wiper Stays On Continuously
- Pinpoint Test F: The Rear Window Wiper Is Inoperative
- Pinpoint Test G: The Wipers Will Not Park At The Correct Position
- Pinpoint Test H: The Intermittent Wiper Speed Does Not Operate Correctly (High/Low Speeds OK)
- Pinpoint Test I: The Washer Pump Is Inoperative
- Component Tests
- Wipers and Washers
- Removal And Installation
- Wiper System And Washer System
- Accessories Control Systems
- Body & Frame
- Door Locks
- Anti-Theft System - Passive Anti-Theft System (Pats)
- Description And Operation
- Diagnostic Tests
- Anti-Theft
- Notes
- Principles of Operation
- Inspection and Verification
- Symptom Chart
- Pinpoint Tests
- Pinpoint Test A: DTC B2103 - Antenna Not Connected
- Pinpoint Test B: DTC B1600 - PATS Ignition Key Transponder Signal Is Not Received
- Pinpoint Test C: DTC B1601 - PATS Received Incorrect Key-Code From Ignition Key Transponder
- Pinpoint Test D: DTC B1602 - PATS Received Invalid Format Of Key-Code From Ignition Key Transponder
- Pinpoint Test E: DTC B1681- PATS Transceiver Module Signal Is Not Received
- Pinpoint Test F: The Anti-Theft Indicator Is Always/Never On
- Anti-Theft
- General Procedures
- Removal And Installation
- Anti-Theft System - Perimeter
- Handles, Locks, Latches And Entry Systems
- Specifications
- Description And Operation
- Diagnostic Tests
- Locks, Latches and Entry Systems
- Notes
- Principles of Operations
- Inspection and Verification
- Symptom Chart
- Pinpoint Tests
- Pinpoint Test A: A Single/More Than One Door Lock Is Inoperative
- Pinpoint Test B: The Liftgate/Luggage Compartment Lid Is Inoperative - 3-Door
- Pinpoint Test C: All Door Locks Are Inoperative From One Switch - Door Lock Cylinder
- Pinpoint Test D: All Door Locks Are Inoperative From One Switch
- Pinpoint Test E: The Doors Do Not Lock/Unlock Using The Remote Keyless Entry (RKE) Transmitter
- Pinpoint Test F: The Liftgate/Luggage Compartment Lid Release Is Inoperative Using The Remote Keyless Entry (RKE) Transmitter
- Pinpoint Test G: Panic Feature Is Inoperative/Does Not Operate Correctly
- Pinpoint Test H: The Remote Keyless Entry (RKE) Transmitter Is Out Of Synchronization
- Pinpoint Test I: The Remote Keyless Entry (RKE) Transmitter Has Poor Range Performance
- Pinpoint Test J: The Autolock Does Not Operate Correctly
- Pinpoint Test K: The Liftgate/Luggage Compartment Lid Is Inoperative - 5-Door/Sedan/Wagon
- Locks, Latches and Entry Systems
- General Procedures
- Removal And Installation
- Hood Latch and Components - Exploded View
- Hood Latch
- Front Door Handles, Locks and Latches - Exploded View
- Front Door Latch
- Exterior Front Door Handle
- Interior Door Handle - Front
- Door Lock Cylinder
- Rear Door Handles, Locks and Latches - Exploded View
- Rear Door Latch
- Exterior Rear Door Handle
- Interior Door Handle - Rear
- Liftgate Handle, Lock and Latch - Exploded View
- Liftgate Latch
- Liftgate Lock Cylinder
- Liftgate Lock Cylinder - Wagon
- Luggage Compartment Lid Latch
- Luggage Compartment Lid Lock Cylinder
- Ignition Lock Cylinder - Functional
- Ignition Lock Cylinder - Non Functional
- Passive Anti-Theft System Job Aid
- Remote Keyless Entry System [Transmitter Programming Procedures]
- Anti-Theft System - Passive Anti-Theft System (Pats)
- Exterior Body Panels
- Exterior/Interior Trim
- Interior Trim And Ornamentation
- Frames, Subframes & Crossmembers
- Rear View Mirrors System
- Specifications
- Description And Operation
- Diagnostic Tests
- Rear View Mirrors
- Removal And Installation
- Seats
- Seat System
- Specifications
- Description And Operation
- Diagnostic Tests
- Removal And Installation
- Disassembly And Assembly
- Seat System
- Sun Roof/T-Top/Convertible Top
- Sunroof
- Specifications
- Description And Operation
- Diagnostic Tests
- Roof Opening Panel
- General Procedures
- Removal And Installation
- Roof Opening Panel - Exploded View
- Air Deflector
- Roof Opening Panel
- Roof Opening Panel Glass
- Roof Opening Panel Weatherstrip
- Roof Opening Panel Shield
- Roof Opening Panel Motor
- Roof Opening Panel Front Drain Hose
- Roof Opening Panel Rear Drain Hose - 3-Door
- Roof Opening Panel Rear Drain Hose - 4-Door/5-Door/Wagon
- Sunroof
- Windows And Glass
- Specifications
- Description And Operation
- Diagnostic Tests
- Glass, Frames and Mechanisms
- Notes
- Principles of Operation
- Inspection and Verification
- Symptom Chart
- Pinpoint Tests
- Pinpoint Test A: All Power Windows Are Inoperative - Front and Rear Power Windows
- Pinpoint Test B: A Single Window Is Inoperative - Front and Rear Power Windows - Driver Window
- Pinpoint Test C: A Single Window Is Inoperative - Front And Rear Power Windows - Passenger Window
- Pinpoint Test D: The One-Touch Down Feature Is Inoperative
- Pinpoint Test E: All Power Windows Are Inoperative - 3-Door
- Pinpoint Test F: A Single Window Is Inoperative - 3-Door - Driver Side
- Pinpoint Test G: A Single Window Is Inoperative - 3-Door - Passenger Side
- Pinpoint Test H: The Defrost System Is Inoperative
- Pinpoint Test I: The Defrost System Will Not Shut Off Automatically
- Component Test
- Glass, Frames and Mechanisms
- General Procedures
- Removal And Installation
- Windshield Glass
- Glass, Frames and Mechanisms - Exploded View, Front Door
- Window Glass - Front Door
- Window Regulator and Motor - Front Door
- Door Glass Top Run - Front
- Glass, Frames and Mechanisms - Exploded View, Rear Door
- Window Glass - Rear Door
- Window Regulator and Motor - Rear Door
- Door Glass Top Run - Rear
- Window Glass - Rear Quarter, 4-Door
- Window Glass - Rear Quarter, Wagon
- Window Glass - Rear Quarter, 3-Door/5-Door
- Window Glass - Rear
- Window Glass - Liftgate, Wagon
- Window Glass - Liftgate, 3-Door/5-Door
- Door Locks
- Brakes
- Anti-Lock Brakes
- Brake System - General Information
- Vehicle Dynamic Systems
- Specifications
- Description And Operation
- Diagnostic Tests
- Anti-Lock Control
- Notes
- Principles of Operation
- Inspection and Verification
- Symptom Chart
- Pinpoint Tests
- Pinpoint Test A: Brake Switch Circuit Failure
- Pinpoint Test B: Battery Voltage High/Low
- Pinpoint Test C: Anti-Lock (ABS) Hydraulic Pump Motor Circuit Failure
- Pinpoint Test D: DTC C1145 (RF), DTC C1155 (LF), DTC C1165 (RR), DTC C1175 (LR) - Wheel Speed Sensor Input Circuit Failure
- Pinpoint Test E: DTC C1233 (LF), C1234 (RF), C1235 (RR), C1236 (LR), Speed Wheel Input Signal Missing
- Pinpoint Test F: DTC C1267 - ABS Functions Temporarily Disabled
- Pinpoint Test G: The Traction Control Is Inoperative
- Pinpoint Test H: The Traction Control System Cannot Be Disabled
- Anti-Lock Control
- Removal And Installation
- Mechanical - Hydraulic
- Brake System - General Information
- Drum Brake System
- Front Disc Brake System
- Hydraulic Brake System Actuation
- Power Brake Actuation -- Brake Booster
- Rear Disc Brake System
- Parking Brake System And Actuation
- Traction Control
- Brake System - General Information
- Vehicle Dynamic Systems
- Specifications
- Description And Operation
- Diagnostic Tests
- Anti-Lock Control
- Notes
- Principles of Operation
- Inspection and Verification
- Symptom Chart
- Pinpoint Tests
- Pinpoint Test A: Brake Switch Circuit Failure
- Pinpoint Test B: Battery Voltage High/Low
- Pinpoint Test C: Anti-Lock (ABS) Hydraulic Pump Motor Circuit Failure
- Pinpoint Test D: DTC C1145 (RF), DTC C1155 (LF), DTC C1165 (RR), DTC C1175 (LR) - Wheel Speed Sensor Input Circuit Failure
- Pinpoint Test E: DTC C1233 (LF), C1234 (RF), C1235 (RR), C1236 (LR), Speed Wheel Input Signal Missing
- Pinpoint Test F: DTC C1267 - ABS Functions Temporarily Disabled
- Pinpoint Test G: The Traction Control Is Inoperative
- Pinpoint Test H: The Traction Control System Cannot Be Disabled
- Anti-Lock Control
- Removal And Installation
- Anti-Lock Brakes
- Drivelines & Axles
- Electrical
- Body Electrical
- Fuse And Relay Location
- OEM Connector End Views
- Connector Views
- A/C Clutch Field Coil Connector
- Crankshaft Position Sensor Connector
- Generator Connectors
- Oil Pressure Switch Connector
- Cylinder-Head Temperature Sensor Connector
- Knock Sensor Connector
- Coil On Plug Connector
- Speed Control Servo Connector
- EVAP Canister Purge Valve Connector
- Brake Fluid Level Switch Connector
- Windshield Wiper Motor Connector
- ABS Test Connector
- Engine Compartment Switch Connector
- Mass Air Flow (MAF) Sensor Connector
- Horn Connector
- Inline Connectors
- ABS Control Module Connector
- Heated Oxygen Sensor (HO2S) #12 Connector
- Turbine Shaft Speed (TSS) Sensor Connector
- Wheel Speed Sensor, Left Front Connector
- Stop Lamp, Left Front Connector
- Fog Lamp, Left Front Connector
- Air Pump Motor Connector
- Air Pump Relay Connector
- Wheel Speed Sensor, Right Front Connector
- Side Lamp, Right Front Connector
- Fog Lamp, Right Front Connector
- Transmission Range (TR) Sensor Connector
- Heated Oxygen Sensor (HO2S) #11 Connector
- Powertrain Control Module (PCM) Connector
- Forward Crash Sensor Connector
- Camshaft Position Sensor Connector
- Throttle Position Sensor (TPS) Connector
- Output Shaft Speed (OSS) Sensor Connector
- Starter Motor Connectors
- Generic Electronic Module (GEM) Connector
- Multifunction Switch Connectors
- Main Light Switch Connectors
- Ignition Switch Connector
- Data Link Connector
- Passive Anti-Theft Transceiver Module Connector
- Passenger Air Bag Module Connectors
- Clutch Pedal Position Switch Connector
- Central Junction Box (CJB) Connector
- Brake Pedal Position Switch Connector
- Inertia Fuel Shutoff (IFS) Switch Connector
- Heater Blower Motor Connector
- Passenger Safety Belt Retractor Pretensioner Connector
- Side Air Bag Sensor, Right Connector
- Side Air Bag Sensor, Left Connector
- Heated Seat Element, Driver Side Front Connector
- Seat Belt Buckle Sensor, Driver Connector
- Seat Back Position Sensor, Driver Connector
- Side Air Bag Module, Left Connector
- Heated Seat Element, Passenger Side Front Connector
- Seat Belt Buckle Sensor, Passenger Connector
- Side Air Bag Module, Light Connector
- Seat Heater Switch, Passenger Side Connector
- Driver Safety Belt Buckle Pretensioner Connector
- Seat Heater Switch, Driver Side Connector
- Seat Belt Tensioner, Passenger Seat Connector
- Speaker, Left Rear Connector
- Speaker, Right Rear Connector
- Rear Window Defrost Grid Connector
- Wheel Speed Sensor, Right Rear Connector
- Luggage Compartment Lamp Connector
- Luggage Compartment Lid Release Solenoid Connector
- Fuel Tank Unit Connector
- Fuel Tank Pressure Transducer Sensor Connector
- Wheel Speed Sensor, Left Rear Connector
- Evaporative Emission (EVAP) Canister Vent Valve Connector
- Reversing Lamp, Left Connector
- License Plate Lamp, Left Connector
- Reversing Lamp, Right Connector
- License Plate Lamp, Right Connector
- Subwoofer Amplifier Connector
- High Mounted Stoplamp Connector
- Cargo Space Lamp Connector
- Lamp Assembly, Left Rear Connector
- Lamp Assembly, Right Rear Connector
- Master Window Adjust Switch Connector
- Door Lock Switch Driver Side Connector
- Power Window Motor, Driver Side Front Connector
- Exterior Rear View Mirror, Left Connector
- Speaker, Left Front Connector
- Door Lock Unit Driver Side Front Connector
- Door Ajar Switch, Driver Side Front Connector
- Exterior Rear View Mirror Switch Connector
- One-Touch Window Relay Connector
- Door Ajar Switch, Passenger Side Front Connector
- Window Adjust Switch, Passenger Side Connector
- Door Lock Switch, Passenger Side Connector
- Door Lock Unit, Passenger Side Front Connector
- Speaker, Right Front Connector
- Exterior Rear View Mirror, Right Connector
- Power Window Motor, Passenger Side Front Connector
- Window Adjust Switch, Left Rear Connector
- Power Window Motor, Left Rear Connector
- Door Lock Unit, Left Rear Connector
- Door Ajar Switch, Driver Side Rear Connector
- Window Adjust Switch, Right Rear Connector
- Power Window Motor, Right Rear Connector
- Door Lock Unit, Right Rear Connector
- Door Ajar Switch, Passenger Side Rear Connector
- Interior Lamp, Front Connector
- A/C Clutch Relay Connector
- PCM Power Diode Connector
- Headlamp, Left Connector
- Park/Turn Lamp, Left Front Connector
- Engine Cooling Fan Resistor Connector
- BJB Relay Connector
- Headlamp, Right Connector
- Park/Turn Lamp, Right Front Connector
- Engine Cooling Fan Motor Connector
- Low Beam Relay Connector
- High Beam Relay Connector
- Fuel Pump Relay Connector
- Ignition Relay Connector
- Engine Cooling, Fan Relay Connector
- High Speed Fan Control Relay Connector
- Dual Pressure Switch Connector
- Idle Air Control (IAC) Valve Connector
- Secondary Air Injection Bypass Solenoid Connector
- A/C Compressor Cycling Switch Connector
- Vehicle Speed Sensor (VSS) Connector
- Battery Connectors
- Manifold Absolute Pressure/Intake Air Temperature (MAP/IAT) Sensor Connector
- EGR Stepper Motor Connector
- Fuel Injector Connectors
- Ignition Transformer Capacitor Connector
- Intake Manifold Runner Control (MRC) Module Connector
- Fuel Rail Pressure/Temperature Sensor Connector
- Power Steering Pressure Sensor Connector
- Inlet Manifold Runner Control (MRC) Solenoid 1 Connector
- Tow-Way Washer Pump Motor Connector
- Power Hold Relay Connector
- Second Cooling Fan Motor Connector
- Park/Neutral Position (PNP) Switch Connector
- Low Speed Engine Cooling Fan Relay A Connector
- Low Speed Engine Cooling Fan Relay B Connector
- Intake Manifold Tuning Valve (IMTV) Connector
- Heated Oxygen Sensor (HO2S) #13 Connector
- Parking Brake Switch Connector
- Rear Window Defrost Relay Connector
- Cigar Lighter, Front Connector
- Hazard Faster Switch Connector
- Restraints Control Module Connectors
- Daytime Running Lamps (DRL) Relay Connector
- Wiper/Washer Switch Connector
- Starter Relay Connector
- Driver Motor Resistor Connector
- Radio Connector
- Start Inhibit Switch Connector
- Instrument Cluster Connectors
- Recirculation Air Actuator Connector
- Heater Control Module Connector
- Radio Remote Control Switch Connector
- Heater Blower Switch Connector
- Heater Panel Illumination Lamp Connector
- Traction Control System (TCS) Disable Switch Connector
- Liftgate/Decklid Release Switch Connector
- Clock Spring Connector
- Stop/Lamp Switch Connector
- Seat Pressure Sensor Module Connector
- Seat Weight Sensor Module Connector
- Gearshift Lever Unit Connector
- Fuel Pump Driver Module Connector
- Rear Wiper Motor Assembly Connector
- Liftgate/Decklid Latch Assembly Connector
- Liftgate/Decklid Release Switch, Exterior Connector
- Liftgate/Decklid Anti-Theft Inhibit Switch Connector
- Moonroof Adjust Switch Connector
- Roof Opening Panel Unit Connector
- Heated Seats Relay Connector
- Ambient Lighting Module Connector
- Connector Views
- Charging Systems
- Charging System - General Information
- Specifications
- Description And Operation
- Diagnostic Tests
- Charging System
- Notes
- Principles of Operation
- Circuit Description
- Inspection and Verification
- Symptom Chart
- Pinpoint Tests
- Pinpoint Test A: The Battery is Discharged or Battery Voltage is Low
- Pinpoint Test B: The Charging System Warning Indicator is ON With the Engine Running (The Charging System Voltage Does Not Increase)
- Pinpoint Test C: The Charging System Overcharges (Battery Voltage Is Greater Than 15.5 Volts)
- Pinpoint Test D: The Charging System Warning Indicator is On with the Engine Running and the Battery Increases Voltage
- Pinpoint Test E: The Charging System Warning Indicator is Off With the Ignition Switch in the RUN Position and the Engine Off
- Pinpoint Test F: The Generator is Noisy
- Pinpoint Test G: Radio Interference
- Component Tests
- Charging System
- Charging System - Generators & Regulators
- Charging System (Battery, Mounting And Cables)
- Charging System - General Information
- Component Locations
- Fuses & Circuit Breakers
- Gauges
- Information System And Entertainment System
- Description And Operation
- Diagnostic Tests
- Information and Entertainment System
- Notes
- Principles of Operation
- Inspection and Verification
- Symptom Chart
- Pinpoint Tests
- Pinpoint Test A: The Audio Unit Is Inoperative/Does Not Operate Correctly
- Pinpoint Test B: Poor Reception
- Pinpoint Test C: Poor Quality/Distorted/No Sound From One or More Speakers (Not All Speakers)
- Pinpoint Test D: The Subwoofer Is Inoperative
- Pinpoint Test E: Loud Popping Sound When Cycling The Ignition Switch
- Pinpoint Test F: The Auxiliary Audio Control Is Inoperative/Does Not Operate Correctly
- Information and Entertainment System
- General Procedures
- Removal And Installation
- Instrument Cluster
- Description And Operation
- Diagnostic Tests
- Instrument Cluster
- Notes
- Principles of Operation
- Notes
- Tachometer
- Speedometer
- Fuel Gauge
- Temperature Gauge
- Odometer/Trip Odometer
- Traction Control Indicator
- Check Fuel Cap Indicator
- Speed Control Indicator
- Low Fuel Warning Indicator
- Brake Warning Indicator
- Safety Belt Indicator
- ABS Warning Indicator
- Malfunction Indicator Lamp (MIL)
- PATS Indicator Lamp
- O/D OFF Indicator
- Engine Oil Pressure Warning Indicator
- Door Ajar Warning Indicator
- Air Bag Warning Indicator
- Charging System Warning Indicator
- Shift Up Indicator
- High Beam Indicator
- Turn/Hazard Indicators
- Inspection and Verification
- Symptom Chart
- Pinpoint Tests
- Pinpoint Test A: The Instrument Cluster is Inoperative
- Pinpoint Test B: Incorrect Fuel Gauge Indication
- Pinpoint Test C: Incorrect Tachometer Indication
- Pinpoint Test D: Incorrect Temperature Gauge Indication
- Pinpoint Test E: The Low Fuel Warning Indicator Is Never/Always On
- Pinpoint Test F: The Speedometer/Odometer Is Inoperative
- Pinpoint Test G: The Safety Belt Warning Indicator Is Inoperative (Chime Is Operative)/Does Not Operate Correctly
- Pinpoint Test H: The Door Ajar Warning Indicator Is Inoperative (Chime Is Operative)/Does Not Operate Correctly
- Pinpoint Test I: The Air Bag Warning Indicator Is Never/Always On
- Pinpoint Test J: The Anti-Lock Brake System (ABS) Warning Indicator Is Never/Always On
- Pinpoint Test K: The Brake Warning Indicator Is Never On
- Pinpoint Test L: The Low Oil Pressure Warning Indicator Is Never/Always On
- Pinpoint Test M: The Check Fuel Cap Indicator Is Never/Always On
- Pinpoint Test N: The Charging System Warning Indicator Is Never/Always On
- Pinpoint Test O: The Malfunction Indicator Lamp (MIL) Is Never On
- Pinpoint Test P: The LH Turn Signal Indicator Is Never/Always On
- Pinpoint Test Q: The RH Turn Signal Indicator Is Never/Always On
- Pinpoint Test R: The High Beam Indicator is Never On
- Pinpoint Test S: The Shift Up Indicator Is Never/Always On
- Pinpoint Test T: The Traction Control Indicator Is Never/Always On
- Pinpoint Test U: The Speed Control Indicator is Never/Always On
- Pinpoint Test V: The O/D Off Indicator Is Never/Always On
- Pinpoint Test W: The Passive Anti-Theft System (PATS) Indicator Is Never/Always On
- Pinpoint Test X: The Integrated Circuit Display Is Inoperative
- Pinpoint Test Y: The Brake Warning Indicator Is Always On
- Instrument Cluster
- Removal And Installation
- Instrument Cluster And Panel Illumination
- Description And Operation
- Diagnostic Tests
- Instrument Cluster and Panel Illumination
- Notes
- Principles of Operation
- Inspection and Verification
- Symptom Chart
- Pinpoint Tests
- Pinpoint Test A: The Control Illumination Is Inoperative
- Pinpoint Test B: The Instrument Cluster (IC) Illumination Is Inoperative
- Pinpoint Test C: The Climate Control Assembly Illumination Is Inoperative
- Pinpoint Test D: The Audio Control Module (ACM) Illumination Is Inoperative
- Pinpoint Test E: The Transmission Selector Lever Illumination Is Inoperative
- Pinpoint Test F: The Hazard Warning Switch Illumination Is Inoperative
- Pinpoint Test G: The Traction Control Switch Illumination Is Inoperative
- Pinpoint Test H: The Ambient Lighting Control Switch Illumination Is Inoperative
- Pinpoint Test I: The Instrument Panel Illumination Does Not Dim
- Instrument Cluster and Panel Illumination
- Instrument Panel And Console
- Information System And Entertainment System
- Horns
- Motors, Switches, Relays
- Fuse And Relay Location
- OEM Connector End Views
- Connector Views
- A/C Clutch Field Coil Connector
- Crankshaft Position Sensor Connector
- Generator Connectors
- Oil Pressure Switch Connector
- Cylinder-Head Temperature Sensor Connector
- Knock Sensor Connector
- Coil On Plug Connector
- Speed Control Servo Connector
- EVAP Canister Purge Valve Connector
- Brake Fluid Level Switch Connector
- Windshield Wiper Motor Connector
- ABS Test Connector
- Engine Compartment Switch Connector
- Mass Air Flow (MAF) Sensor Connector
- Horn Connector
- Inline Connectors
- ABS Control Module Connector
- Heated Oxygen Sensor (HO2S) #12 Connector
- Turbine Shaft Speed (TSS) Sensor Connector
- Wheel Speed Sensor, Left Front Connector
- Stop Lamp, Left Front Connector
- Fog Lamp, Left Front Connector
- Air Pump Motor Connector
- Air Pump Relay Connector
- Wheel Speed Sensor, Right Front Connector
- Side Lamp, Right Front Connector
- Fog Lamp, Right Front Connector
- Transmission Range (TR) Sensor Connector
- Heated Oxygen Sensor (HO2S) #11 Connector
- Powertrain Control Module (PCM) Connector
- Forward Crash Sensor Connector
- Camshaft Position Sensor Connector
- Throttle Position Sensor (TPS) Connector
- Output Shaft Speed (OSS) Sensor Connector
- Starter Motor Connectors
- Generic Electronic Module (GEM) Connector
- Multifunction Switch Connectors
- Main Light Switch Connectors
- Ignition Switch Connector
- Data Link Connector
- Passive Anti-Theft Transceiver Module Connector
- Passenger Air Bag Module Connectors
- Clutch Pedal Position Switch Connector
- Central Junction Box (CJB) Connector
- Brake Pedal Position Switch Connector
- Inertia Fuel Shutoff (IFS) Switch Connector
- Heater Blower Motor Connector
- Passenger Safety Belt Retractor Pretensioner Connector
- Side Air Bag Sensor, Right Connector
- Side Air Bag Sensor, Left Connector
- Heated Seat Element, Driver Side Front Connector
- Seat Belt Buckle Sensor, Driver Connector
- Seat Back Position Sensor, Driver Connector
- Side Air Bag Module, Left Connector
- Heated Seat Element, Passenger Side Front Connector
- Seat Belt Buckle Sensor, Passenger Connector
- Side Air Bag Module, Light Connector
- Seat Heater Switch, Passenger Side Connector
- Driver Safety Belt Buckle Pretensioner Connector
- Seat Heater Switch, Driver Side Connector
- Seat Belt Tensioner, Passenger Seat Connector
- Speaker, Left Rear Connector
- Speaker, Right Rear Connector
- Rear Window Defrost Grid Connector
- Wheel Speed Sensor, Right Rear Connector
- Luggage Compartment Lamp Connector
- Luggage Compartment Lid Release Solenoid Connector
- Fuel Tank Unit Connector
- Fuel Tank Pressure Transducer Sensor Connector
- Wheel Speed Sensor, Left Rear Connector
- Evaporative Emission (EVAP) Canister Vent Valve Connector
- Reversing Lamp, Left Connector
- License Plate Lamp, Left Connector
- Reversing Lamp, Right Connector
- License Plate Lamp, Right Connector
- Subwoofer Amplifier Connector
- High Mounted Stoplamp Connector
- Cargo Space Lamp Connector
- Lamp Assembly, Left Rear Connector
- Lamp Assembly, Right Rear Connector
- Master Window Adjust Switch Connector
- Door Lock Switch Driver Side Connector
- Power Window Motor, Driver Side Front Connector
- Exterior Rear View Mirror, Left Connector
- Speaker, Left Front Connector
- Door Lock Unit Driver Side Front Connector
- Door Ajar Switch, Driver Side Front Connector
- Exterior Rear View Mirror Switch Connector
- One-Touch Window Relay Connector
- Door Ajar Switch, Passenger Side Front Connector
- Window Adjust Switch, Passenger Side Connector
- Door Lock Switch, Passenger Side Connector
- Door Lock Unit, Passenger Side Front Connector
- Speaker, Right Front Connector
- Exterior Rear View Mirror, Right Connector
- Power Window Motor, Passenger Side Front Connector
- Window Adjust Switch, Left Rear Connector
- Power Window Motor, Left Rear Connector
- Door Lock Unit, Left Rear Connector
- Door Ajar Switch, Driver Side Rear Connector
- Window Adjust Switch, Right Rear Connector
- Power Window Motor, Right Rear Connector
- Door Lock Unit, Right Rear Connector
- Door Ajar Switch, Passenger Side Rear Connector
- Interior Lamp, Front Connector
- A/C Clutch Relay Connector
- PCM Power Diode Connector
- Headlamp, Left Connector
- Park/Turn Lamp, Left Front Connector
- Engine Cooling Fan Resistor Connector
- BJB Relay Connector
- Headlamp, Right Connector
- Park/Turn Lamp, Right Front Connector
- Engine Cooling Fan Motor Connector
- Low Beam Relay Connector
- High Beam Relay Connector
- Fuel Pump Relay Connector
- Ignition Relay Connector
- Engine Cooling, Fan Relay Connector
- High Speed Fan Control Relay Connector
- Dual Pressure Switch Connector
- Idle Air Control (IAC) Valve Connector
- Secondary Air Injection Bypass Solenoid Connector
- A/C Compressor Cycling Switch Connector
- Vehicle Speed Sensor (VSS) Connector
- Battery Connectors
- Manifold Absolute Pressure/Intake Air Temperature (MAP/IAT) Sensor Connector
- EGR Stepper Motor Connector
- Fuel Injector Connectors
- Ignition Transformer Capacitor Connector
- Intake Manifold Runner Control (MRC) Module Connector
- Fuel Rail Pressure/Temperature Sensor Connector
- Power Steering Pressure Sensor Connector
- Inlet Manifold Runner Control (MRC) Solenoid 1 Connector
- Tow-Way Washer Pump Motor Connector
- Power Hold Relay Connector
- Second Cooling Fan Motor Connector
- Park/Neutral Position (PNP) Switch Connector
- Low Speed Engine Cooling Fan Relay A Connector
- Low Speed Engine Cooling Fan Relay B Connector
- Intake Manifold Tuning Valve (IMTV) Connector
- Heated Oxygen Sensor (HO2S) #13 Connector
- Parking Brake Switch Connector
- Rear Window Defrost Relay Connector
- Cigar Lighter, Front Connector
- Hazard Faster Switch Connector
- Restraints Control Module Connectors
- Daytime Running Lamps (DRL) Relay Connector
- Wiper/Washer Switch Connector
- Starter Relay Connector
- Driver Motor Resistor Connector
- Radio Connector
- Start Inhibit Switch Connector
- Instrument Cluster Connectors
- Recirculation Air Actuator Connector
- Heater Control Module Connector
- Radio Remote Control Switch Connector
- Heater Blower Switch Connector
- Heater Panel Illumination Lamp Connector
- Traction Control System (TCS) Disable Switch Connector
- Liftgate/Decklid Release Switch Connector
- Clock Spring Connector
- Stop/Lamp Switch Connector
- Seat Pressure Sensor Module Connector
- Seat Weight Sensor Module Connector
- Gearshift Lever Unit Connector
- Fuel Pump Driver Module Connector
- Rear Wiper Motor Assembly Connector
- Liftgate/Decklid Latch Assembly Connector
- Liftgate/Decklid Release Switch, Exterior Connector
- Liftgate/Decklid Anti-Theft Inhibit Switch Connector
- Moonroof Adjust Switch Connector
- Roof Opening Panel Unit Connector
- Heated Seats Relay Connector
- Ambient Lighting Module Connector
- Connector Views
- Starter
- Starting System
- Specifications
- Description And Operation
- Diagnostic Tests
- Removal And Installation
- Starting System
- Wiring Diagrams
- OEM Connector End Views
- Connector Views
- A/C Clutch Field Coil Connector
- Crankshaft Position Sensor Connector
- Generator Connectors
- Oil Pressure Switch Connector
- Cylinder-Head Temperature Sensor Connector
- Knock Sensor Connector
- Coil On Plug Connector
- Speed Control Servo Connector
- EVAP Canister Purge Valve Connector
- Brake Fluid Level Switch Connector
- Windshield Wiper Motor Connector
- ABS Test Connector
- Engine Compartment Switch Connector
- Mass Air Flow (MAF) Sensor Connector
- Horn Connector
- Inline Connectors
- ABS Control Module Connector
- Heated Oxygen Sensor (HO2S) #12 Connector
- Turbine Shaft Speed (TSS) Sensor Connector
- Wheel Speed Sensor, Left Front Connector
- Stop Lamp, Left Front Connector
- Fog Lamp, Left Front Connector
- Air Pump Motor Connector
- Air Pump Relay Connector
- Wheel Speed Sensor, Right Front Connector
- Side Lamp, Right Front Connector
- Fog Lamp, Right Front Connector
- Transmission Range (TR) Sensor Connector
- Heated Oxygen Sensor (HO2S) #11 Connector
- Powertrain Control Module (PCM) Connector
- Forward Crash Sensor Connector
- Camshaft Position Sensor Connector
- Throttle Position Sensor (TPS) Connector
- Output Shaft Speed (OSS) Sensor Connector
- Starter Motor Connectors
- Generic Electronic Module (GEM) Connector
- Multifunction Switch Connectors
- Main Light Switch Connectors
- Ignition Switch Connector
- Data Link Connector
- Passive Anti-Theft Transceiver Module Connector
- Passenger Air Bag Module Connectors
- Clutch Pedal Position Switch Connector
- Central Junction Box (CJB) Connector
- Brake Pedal Position Switch Connector
- Inertia Fuel Shutoff (IFS) Switch Connector
- Heater Blower Motor Connector
- Passenger Safety Belt Retractor Pretensioner Connector
- Side Air Bag Sensor, Right Connector
- Side Air Bag Sensor, Left Connector
- Heated Seat Element, Driver Side Front Connector
- Seat Belt Buckle Sensor, Driver Connector
- Seat Back Position Sensor, Driver Connector
- Side Air Bag Module, Left Connector
- Heated Seat Element, Passenger Side Front Connector
- Seat Belt Buckle Sensor, Passenger Connector
- Side Air Bag Module, Light Connector
- Seat Heater Switch, Passenger Side Connector
- Driver Safety Belt Buckle Pretensioner Connector
- Seat Heater Switch, Driver Side Connector
- Seat Belt Tensioner, Passenger Seat Connector
- Speaker, Left Rear Connector
- Speaker, Right Rear Connector
- Rear Window Defrost Grid Connector
- Wheel Speed Sensor, Right Rear Connector
- Luggage Compartment Lamp Connector
- Luggage Compartment Lid Release Solenoid Connector
- Fuel Tank Unit Connector
- Fuel Tank Pressure Transducer Sensor Connector
- Wheel Speed Sensor, Left Rear Connector
- Evaporative Emission (EVAP) Canister Vent Valve Connector
- Reversing Lamp, Left Connector
- License Plate Lamp, Left Connector
- Reversing Lamp, Right Connector
- License Plate Lamp, Right Connector
- Subwoofer Amplifier Connector
- High Mounted Stoplamp Connector
- Cargo Space Lamp Connector
- Lamp Assembly, Left Rear Connector
- Lamp Assembly, Right Rear Connector
- Master Window Adjust Switch Connector
- Door Lock Switch Driver Side Connector
- Power Window Motor, Driver Side Front Connector
- Exterior Rear View Mirror, Left Connector
- Speaker, Left Front Connector
- Door Lock Unit Driver Side Front Connector
- Door Ajar Switch, Driver Side Front Connector
- Exterior Rear View Mirror Switch Connector
- One-Touch Window Relay Connector
- Door Ajar Switch, Passenger Side Front Connector
- Window Adjust Switch, Passenger Side Connector
- Door Lock Switch, Passenger Side Connector
- Door Lock Unit, Passenger Side Front Connector
- Speaker, Right Front Connector
- Exterior Rear View Mirror, Right Connector
- Power Window Motor, Passenger Side Front Connector
- Window Adjust Switch, Left Rear Connector
- Power Window Motor, Left Rear Connector
- Door Lock Unit, Left Rear Connector
- Door Ajar Switch, Driver Side Rear Connector
- Window Adjust Switch, Right Rear Connector
- Power Window Motor, Right Rear Connector
- Door Lock Unit, Right Rear Connector
- Door Ajar Switch, Passenger Side Rear Connector
- Interior Lamp, Front Connector
- A/C Clutch Relay Connector
- PCM Power Diode Connector
- Headlamp, Left Connector
- Park/Turn Lamp, Left Front Connector
- Engine Cooling Fan Resistor Connector
- BJB Relay Connector
- Headlamp, Right Connector
- Park/Turn Lamp, Right Front Connector
- Engine Cooling Fan Motor Connector
- Low Beam Relay Connector
- High Beam Relay Connector
- Fuel Pump Relay Connector
- Ignition Relay Connector
- Engine Cooling, Fan Relay Connector
- High Speed Fan Control Relay Connector
- Dual Pressure Switch Connector
- Idle Air Control (IAC) Valve Connector
- Secondary Air Injection Bypass Solenoid Connector
- A/C Compressor Cycling Switch Connector
- Vehicle Speed Sensor (VSS) Connector
- Battery Connectors
- Manifold Absolute Pressure/Intake Air Temperature (MAP/IAT) Sensor Connector
- EGR Stepper Motor Connector
- Fuel Injector Connectors
- Ignition Transformer Capacitor Connector
- Intake Manifold Runner Control (MRC) Module Connector
- Fuel Rail Pressure/Temperature Sensor Connector
- Power Steering Pressure Sensor Connector
- Inlet Manifold Runner Control (MRC) Solenoid 1 Connector
- Tow-Way Washer Pump Motor Connector
- Power Hold Relay Connector
- Second Cooling Fan Motor Connector
- Park/Neutral Position (PNP) Switch Connector
- Low Speed Engine Cooling Fan Relay A Connector
- Low Speed Engine Cooling Fan Relay B Connector
- Intake Manifold Tuning Valve (IMTV) Connector
- Heated Oxygen Sensor (HO2S) #13 Connector
- Parking Brake Switch Connector
- Rear Window Defrost Relay Connector
- Cigar Lighter, Front Connector
- Hazard Faster Switch Connector
- Restraints Control Module Connectors
- Daytime Running Lamps (DRL) Relay Connector
- Wiper/Washer Switch Connector
- Starter Relay Connector
- Driver Motor Resistor Connector
- Radio Connector
- Start Inhibit Switch Connector
- Instrument Cluster Connectors
- Recirculation Air Actuator Connector
- Heater Control Module Connector
- Radio Remote Control Switch Connector
- Heater Blower Switch Connector
- Heater Panel Illumination Lamp Connector
- Traction Control System (TCS) Disable Switch Connector
- Liftgate/Decklid Release Switch Connector
- Clock Spring Connector
- Stop/Lamp Switch Connector
- Seat Pressure Sensor Module Connector
- Seat Weight Sensor Module Connector
- Gearshift Lever Unit Connector
- Fuel Pump Driver Module Connector
- Rear Wiper Motor Assembly Connector
- Liftgate/Decklid Latch Assembly Connector
- Liftgate/Decklid Release Switch, Exterior Connector
- Liftgate/Decklid Anti-Theft Inhibit Switch Connector
- Moonroof Adjust Switch Connector
- Roof Opening Panel Unit Connector
- Heated Seats Relay Connector
- Ambient Lighting Module Connector
- Connector Views
- System Wiring Diagrams
- Using lemon2025'S Wiring Diagrams
- Air Conditioning
- Anti-Lock Brakes
- Anti-Theft
- Body Control Modules
- Computer Data Lines
- Cooling Fan
- Cruise Control
- Defoggers
- Engine Performance
- Exterior Lights
- Ground Distribution
- Headlights
- Horn
- Instrument Cluster
- Interior Lights
- Power Distribution
- Power Door Locks
- Power Mirrors
- Power Seats
- Power Top/Sunroof
- Power Windows
- Radio
- Shift Interlock
- Starting/Charging
- Supplemental Restraints
- Transmission
- Trunk, Tailgate, Fuel Door
- Warning Systems
- Wiper/Washer
- Using lemon2025'S System Wiring Diagrams
- OEM Connector End Views
- Body Electrical
- Engine Mechanical
- Accessory Drive Belts
- Auxiliary Emission Control Systems
- Engine Emission Control
- Specifications
- Description And Operation
- Diagnostic Tests
- Removal And Installation
- Exhaust Gas Recirculation (EGR) Valve
- Positive Crankcase Ventilation (PCV) System Components - Exploded View
- Positive Crankcase Ventilation (PCV) Valve
- Crankcase Vent Oil Separator
- Secondary Air Injection System (AIR) Components - Exploded View
- Secondary Air Injection (AIR) Pump - 2.0L
- Secondary Air Injection (AIR) Valve - 2.0L
- Evaporative Emissions System
- Specifications
- Description And Operation
- Diagnostic Tests
- General Procedures
- Removal And Installation
- Engine Emission Control
- Cooling System (Mechanical)
- Accessory Drive System
- Engine Cooling System
- Specifications
- Description And Operation
- Diagnostic Tests
- General Procedures
- Removal And Installation
- Exhaust System
- Fuel System
- Fuel Charging And Controls
- Fuel System - General Information
- Fuel Tank And Fuel Lines
- Mechanical
- Engine
- Specifications
- Description And Operation
- Diagnostic Tests
- General Procedures
- In-Vehicle Servicing
- Intake Manifold
- Valve Cover
- Lower End Components - Exploded View
- Crankshaft Pulley
- Crankshaft Front Seal
- Flexplate
- Flywheel
- Crankshaft Rear Seal with Retainer Plate
- Engine Front Cover
- Timing Drive Components
- Camshafts
- Valve Train Components - Exploded View
- Valve Springs
- Valve Seals
- Valve Tappets
- Cylinder Head
- Engine Lubrication Components - Exploded View
- Oil Filter Adapter
- Engine Oil Pressure (EOP) Switch
- Oil Pan
- Oil Pump Screen and Pickup Tube
- Oil Pump
- Oil Level Indicator and Tube
- Engine Mount
- Removal
- Disassembly
- Disassembly And Assembly Of Subassemblies
- Assembly
- Installation
- Engine System - General Information
- Specifications
- Description And Operation
- Diagnostic Tests
- Engine
- Notes
- Inspection and Verification
- Symptom Chart
- Component Tests
- Compression Test - Compression Gauge Check
- Cylinder Leakage Detection
- Excessive Engine Oil Consumption
- Intake Manifold Vacuum Test
- Excessive Engine Oil Consumption
- Valve Train Analysis - Engine Off, Valve Cover Removed
- Notes
- Valve Train Analysis - Engine Off
- Valve Train Analysis - Engine Off, Camshaft - Engines
- Valve Train Analysis - Valve Springs
- Valve Train Analysis - Engine Off, Valve Spring Retainer and Valve Spring Retainer Keys
- Valve Train Analysis - Engine Off, Valves and Cylinder Head
- Valve Train Analysis - Engine Off, Camshaft Lobe Lift - OHC Engines
- Valve Train Analysis - Engine Off, Valve Tappet
- Engine
- General Procedures
- Sprockets
- Camshaft Bearing Journal Diameter
- Camshaft End Play - OHC Engines
- Camshaft Surface Inspection
- Camshaft Lobe Lift
- Camshaft Runout
- Crankshaft End Play
- Valve Stem Diameter
- Valve Inspection
- Valve Guide Inner Diameter
- Valve Spring Free Length
- Valve Spring Squareness
- Valve Spring Strength
- Valve Seat Inspection
- Flywheel Inspection
- Cylinder Head Distortion
- Cylinder Block Distortion
- Exhaust Manifold Cleaning and Inspection
- Cylinder Block Core Plug Replacement
- Spark Plug Inspection
- Valve Tappet Inspection
- Engine
- Starter
- Starting System
- Specifications
- Description And Operation
- Diagnostic Tests
- Removal And Installation
- Starting System
- Engine Performance
- Emissions
- EGR Function Testing - Ford - Cars
- Emission Applications
- Emission Control Abbreviations
- State Emission Standards - Diesel
- State Emission Standards - Gas
- ALASKA
- ARIZONA
- CALIFORNIA
- Colorado
- CONNECTICUT
- DELAWARE
- District Of COLUMBIA
- GEORGIA
- IDAHO
- ILLINOIS
- INDIANA
- KENTUCKY
- MARYLAND
- MASSACHUSETTS
- MISSOURI
- NEVADA
- New Jersey
- New MEXICO
- New YORK
- North CAROLINA
- OHIO
- OREGON
- PENNSYLVANIA
- RHODE Island
- TENNESSEE
- TEXAS
- UTAH
- VIRGINIA
- WASHINGTON
- WISCONSIN
- U. S. EPA ASM2525 & ASM5015 Start-Up Emission Standards
- U. S. EPA Revised Final ASM Emission Standards (ASM5015 & ASM2525)
- U.S. EPA Im240 Emission Standards
- Engine Control Systems
- Fuel Delivery
- Fuel Charging And Controls
- Fuel System - General Information
- Fuel Tank And Fuel Lines
- Engine Ignition System
- Mode 6 - 2007 Ford - Except Diesel
- Pin Voltage Charts
- Engine Controls - Reference Values (Except Diesel & Hybrid)
- Reference Value Symptom Chart
- Reference Value Parameter Identification (PID)/Measured Signal Chart
- Typical Diagnostic Reference Values
- 2.0L 4V Focus
- 2.3L 4V Focus
- 2.3L 4V Fusion/Milan
- 3.0L 4V Fusion/Milan
- 3.0L 4V Five Hundred/Freestyle/Montego
- 3.0L 2V Taurus
- 3.5L 4V MKZ
- 4.0L Mustang
- 4.6L 3V Mustang
- 5.4L 4V Mustang
- 4.6L 2V Crown Victoria/Grand Marquis
- 4.6L 2V Town Car
- 2.3L 4V Escape/Mariner
- 3.0L 4V Escape/Mariner
- 2.3L Ranger
- 3.0L Ranger
- 4.0L Ranger
- 3.5L 4V Edge/MKX
- 3.9L Freestar
- 4.2L Freestar/Monterey
- 4.0L Explorer/Explorer Sport Trac/Mountaineer
- 4.6L 3V Explorer/Explorer Sport Trac/Mountaineer
- 4.2L F-150
- 4.6L 2V F-150
- 5.4L 3V F-150/Mark LT
- 4.6L 2V E-Series
- 5.4L 2V E-Series
- 6.8L 2V E-Series
- 5.4L 3V Expedition/Navigator
- 5.4L 3V F-Super Duty
- 6.8L 3V F-Super Duty
- Engine Controls - Reference Values (Except Diesel & Hybrid)
- Remove, Overhaul & Install
- Acceleration Control System
- Electronic Engine Control System
- Specifications
- Description And Operation
- Diagnostic Tests
- Removal And Installation
- Camshaft Position (CMP) Sensor
- Crankshaft Position (CKP) Sensor
- Power Steering Pressure (PSP) Switch
- Powertrain Control Module (PCM)
- Idle Air Control (IAC) Valve
- Fuel Rail Pressure and Temperature Sensor
- Mass Air Flow (MAF) Sensor
- Heated Oxygen Sensor (HO2S) and Catalyst Monitor Sensor - Exploded View
- Heated Oxygen Sensor (HO2S)
- Catalyst Monitor Sensor
- Knock Sensor (KS)
- Cylinder Head Temperature (CHT) Sensor
- Throttle Position (TP) Sensor
- Intake Air Distribution System And Filtering System
- Specifications
- System
- Engine Controls - Description And Operation (Except Diesel & Hybrid)
- Vehicle Emission Control Information (VECI)
- Vehicle Certification Label
- Vehicle Emission Control Information (VECI) Acronym Definitions
- Engine Control Components
- Notes
- Accelerator Pedal Position (APP) Sensor
- Air Conditioning (A/C) Clutch Relay (A/CCR)
- Air Conditioning (A/C) Cycling Switch
- Air Conditioning Evaporator Temperature (ACET) Sensor
- Air Conditioning (A/C) High Pressure Switch
- Air Conditioning Pressure (ACP) Transducer Sensor
- Brake Pedal Position (BPP) Switch
- Brake Pedal Switch (BPS)/Brake Deactivator Switch
- Camshaft Position (CMP) Sensor
- Canister Vent (CV) Solenoid
- Check Fuel Cap Indicator
- Clutch Pedal Position (CPP) Switch
- Coil On Plug (COP)
- Coil Pack
- Cooling Fan Clutch
- Crankshaft Position (CKP) Sensor
- Cylinder Head Temperature (CHT) Sensor
- Differential Pressure Feedback Exhaust Gas Recirculation (EGR) Sensor
- Differential Pressure Feedback Exhaust Gas Recirculation (EGR) Sensor - Tube Mounted
- Electric Exhaust Gas Recirculation (EEGR) Valve
- Electronic Throttle Actuator Control (TAC)
- Electronic Throttle Body (ETB) Position Sensor
- Engine Coolant Temperature (ECT) Sensor
- Engine Oil Temperature (EOT) Sensor
- Evaporative Emission (EVAP) Canister Purge Valve
- Exhaust Gas Recirculation (EGR) Orifice Tube Assembly
- Exhaust Gas Recirculation (EGR) System Module (ESM)
- Exhaust Gas Recirculation (EGR) Vacuum Regulator Solenoid
- Exhaust Gas Recirculation (EGR) Valve
- Fan Control
- Fan Speed Sensor (FSS)
- Fuel Injectors
- Fuel Level Input (FLI)
- Fuel Pump (FP) Module
- Fuel Pump (FP) Module and Reservoir
- Fuel Rail Pressure (FRP) Sensor
- Fuel Rail Pressure Temperature (FRPT) Sensor
- Fuel Rail Pulse Damper
- Fuel Tank Pressure (FTP) Sensor
- Heated Oxygen Sensor (HO2S)
- Idle Air Control (IAC) Valve
- Inertia Fuel Shutoff (IFS) Switch
- Intake Air Temperature (IAT) Sensor
- Intake Manifold Tuning Valve (IMTV)
- Knock Sensor (KS)
- Manifold Absolute Pressure (MAP) Sensor
- Mass Air Flow (MAF) Sensor
- Output Shaft Speed (OSS) Sensor
- Power Steering Pressure (PSP) Sensor
- Power Steering Pressure (PSP) Switch
- Power Take-Off (PTO) Switch and Circuits
- Powertrain Control Module - Vehicle Speed Output (PCM-VSO)
- Secondary Air Injection (AIR) Bypass Solenoid
- Secondary AIR Diverter Valve
- Secondary AIR Pump
- Starter Motor Request (SMR) Circuit
- Throttle Position (TP) Sensor
- Transmission Control Indicator Lamp (TCIL)
- Transmission Control Switch (TCS)
- Vapor Management Valve (VMV)
- Vehicle Speed Sensor (VSS)
- Electronic Engine Control (EEC) System
- Powertrain Control Hardware
- Powertrain Control Module (PCM)
- PCM Locations
- 104-Pin PCM
- 140-Pin PCM
- 150-Pin PCM
- 170-Pin PCM
- 190-Pin PCM
- Fuel Pump Driver Module (FPDM)
- Keep Alive Memory (KAM)
- Hardware Limited Operation Strategy (HLOS)
- Integrated Electronic Ignition System
- Power and Ground Signals
- Electronic Throttle Control Reference Voltage (ETCREF)
- Electronic Throttle Control Return (ETCRTN)
- Gold Plated Pins
- Keep Alive Power (KAPWR)
- Mass Air Flow (MAF) Return
- Power Ground (PWR GND)
- Signal Return (SIG RTN)
- Variable Reluctance Sensor Return (VRSRTN)
- Vehicle Buffered Power (VBPWR)
- Vehicle Power (VPWR)
- Vehicle Reference Voltage (VREF)
- Powertrain Control Software
- Adaptive Airflow
- Computer Controlled Shutdown
- Engine RPM/Vehicle Speed Limiter
- Fail-Safe Cooling Strategy
- Failure Mode Effects Management
- Flash Electrically Erasable Programmable Read Only Memory (EEPROM)
- Fuel Trim
- High Speed Controller Area Network (CAN)
- Idle Air Trim
- Idle Speed Control Closed Throttle Determination - Applications Without Electronic Throttle Control (ETC)
- Multiplexing
- Multiplexing Implementation
- Malfunction Indicator Lamp (MIL)
- Catalyst and Exhaust Systems
- Evaporative Emission (EVAP) Systems
- Exhaust Gas Recirculation (EGR) Systems
- Fuel Systems
- Ignition Systems
- Intake Air Systems
- Overview
- Throttle Body System Overview
- Overview of the Intake Manifold Runner Control (IMRC) and Intake Manifold Tuning Valve (IMTV) Systems
- Intake Manifold Runner Control (IMRC) Electric Actuated System
- Intake Manifold Runner Control (IMRC) Vacuum Actuated System
- Intake Manifold Tuning Valve (IMTV) System
- Positive Crankcase Ventilation (PCV) System
- Powertrain Control Module (PCM) Controlled Charging System
- Secondary Air Injection (AIR) System
- Supercharger and Charge Air Cooler (CAC) Systems
- (Torque Based) Electronic Throttle Control (ETC)
- Variable Camshaft Timing (VCT) System
- On Board Diagnostics (OBD) Monitors
- Catalyst Efficiency Monitor
- Cold Start Emission Reduction Monitor
- Comprehensive Component Monitor (CCM)
- Electric Exhaust Gas Recirculation (EEGR) System Monitor
- Evaporative Emission (EVAP) Leak Check Monitor
- Exhaust Gas Recirculation (EGR) System Monitor - Differential Pressure Feedback EGR and EGR System Module (ESM)
- Fuel System Monitor
- Heated Oxygen Sensor (HO2S) Monitor
- Misfire Detection Monitor
- Positive Crankcase Ventilation (PCV) System Monitor
- Secondary Air Injection (AIR) System Monitor
- Thermostat Monitor
- Variable Camshaft Timing (VCT) Monitor
- Engine Controls - Pinpoint Test A: No Start Through Pinpoint Test DJ: Air Conditioning Evaporator Temperature (ACET) Sensor - (Except Diesel & Hybrid)
- PINPOINT TEST A: No Start
- PINPOINT TEST B: Powertrain Control Module (PCM) Power Relay
- PINPOINT TEST C: Reference Voltage (VREF)
- PINPOINT TEST DA: Intake Air Temperature (IAT) Sensor
- PINPOINT TEST DC: Mass Air Flow (MAF) Sensor
- PINPOINT TEST DD: Fuel Rail Pressure (FRP) and Fuel Rail Pressure Temperature (FRPT) Sensors
- PINPOINT TEST DF: Vehicle Speed Circuit (VSC) Check
- PINPOINT TEST DG: Knock Sensor
- PINPOINT TEST DH: Throttle Position (TP) Sensor
- PINPOINT TEST DJ: Air Conditioning Evaporator Temperature (ACET) Sensor
- Engine Controls - Pinpoint Test DK: Accelerator Pedal Position (App) Sensor Through Pinpoint Test DW: Heated Oxygen Sensor (Ho2S) - (Except Diesel & Hybrid)
- PINPOINT TEST DK: Accelerator Pedal Position (APP) Sensor
- PINPOINT TEST DL: Cylinder Head Temperature (CHT) Sensor
- PINPOINT TEST DM: Manifold Absolute Pressure (MAP) Sensor
- PINPOINT TEST DP: Output Shaft Speed (OSS) Sensor/Vehicle Speed Sensor (VSS)/Transfer Case Speed Sensor (TCSS)
- PINPOINT TEST DR: Camshaft Position (CMP) Sensor
- PINPOINT TEST DS: Air Conditioning Pressure (ACP) Transducer Sensor
- PINPOINT TEST DT: Power Steering Pressure (PSP) Sensor
- PINPOINT TEST DU: Intake Air Temperature 2 (IAT2) Sensor
- PINPOINT TEST DV: Throttle Body Assembly Electronic Throttle Control (ETC)
- PINPOINT TEST DW: Heated Oxygen Sensor (HO2S)
- Engine Controls - Pinpoint Test DX: Engine Coolant Temperature (ECT) Sensor Through Pinpoint Test Hf: Catalyst Efficiency Monitor And Exhaust Systems - (Except Diesel & Hybrid)
- PINPOINT TEST DX: Engine Coolant Temperature (ECT) Sensor
- PINPOINT TEST DY: Engine Oil Temperature (EOT) Sensor
- PINPOINT TEST EM: Emission Compliance
- PINPOINT TEST FB: Power Take Off (PTO)
- PINPOINT TEST FD: Brake Pedal Inputs
- PINPOINT TEST FF: Power Steering Pressure (PSP) Switch
- PINPOINT TEST H: Fuel Control
- PINPOINT TEST HC: Fuel Delivery System
- PINPOINT TEST HD: Misfire Detection Monitor
- PINPOINT TEST HE: Exhaust Gas Recirculation (EGR) Systems
- PINPOINT TEST HF: Catalyst Efficiency Monitor and Exhaust Systems
- Engine Controls - Pinpoint Test Hg: Positive Crankcase Ventilation (PCV) System Through Pinpoint Test JD: Crankshaft Position (CKP) Sensor - (Except Diesel & Hybrid)
- PINPOINT TEST HG: Positive Crankcase Ventilation (PCV) System
- PINPOINT TEST HH: Exhaust Gas Recirculation System Module (ESM)
- PINPOINT TEST HK: Variable Camshaft Timing (VCT)
- PINPOINT TEST HM: Secondary Air Injection (AIR) System
- PINPOINT TEST HU: Intake Air Systems
- PINPOINT TEST HV: Cooling Fan Clutch
- PINPOINT TEST HX: Evaporative Emission (EVAP) System and Monitor
- PINPOINT TEST HY: Generator/Regulator System
- PINPOINT TEST JB: Secondary Ignition (COP)
- PINPOINT TEST JC: Secondary Ignition (Coil Pack)
- PINPOINT TEST JD: Crankshaft Position (CKP) Sensor
- Engine Controls - Pinpoint Test Index - (Except Diesel & Hybrid)
- Engine Controls - Pinpoint Test JE: Integrated Ignition Coil Pack A, B, Or C Failure Through Pinpoint Test Kn: Variable Speed Electric Cooling Fan - (Except Diesel & Hybrid)
- PINPOINT TEST JE: Integrated Ignition Coil Pack A, B, or C Failure
- PINPOINT TEST JF: Integrated Ignition Coil On Plug Coil A Through J Failure
- PINPOINT TEST KA: Fuel Pump (FP) Relay
- PINPOINT TEST KB: Fuel Pump Driver Module
- PINPOINT TEST KD: Electric Exhaust Gas Recirculation (EEGR) System
- PINPOINT TEST KE: Idle Air Control (IAC) Valve
- PINPOINT TEST KF: Fan Control (FC) Relays
- PINPOINT TEST KG: Fuel Injector
- PINPOINT TEST KJ: Supercharger Bypass Control
- PINPOINT TEST KM: Air Conditioning Clutch Relay (A/CCR) Circuit
- PINPOINT TEST KN: Variable Speed Electric Cooling Fan
- Engine Controls - Pinpoint Test KP: Charge Air Cooler (CAC) Pump Through Pinpoint Test Z: Intermittent - (Except Diesel & Hybrid)
- PINPOINT TEST KP: Charge Air Cooler (CAC) Pump
- PINPOINT TEST NC: Ignition Engine Speed Input Circuit
- PINPOINT TEST ND: Engine RPM\Vehicle Speed Limiter Reached
- PINPOINT TEST QA: Unable to Activate Self-Test/Network Communication Error
- PINPOINT TEST QB: DTCs P0603 or P1633: Keep Alive Power (KAPWR)
- PINPOINT TEST QC: DTC P1000: On-Board Diagnostic (OBD) Systems Readiness Test Not Complete
- PINPOINT TEST QD: DTC P1260: Passive Anti-Theft System
- PINPOINT TEST QE: Electronic Throttle Control (ETC) System
- PINPOINT TEST TA: Clutch Pedal Position (CPP) Switch
- PINPOINT TEST TB: Transmission Control Switch (TCS)/ Transmission Control Indicator Lamp (TCIL)
- PINPOINT TEST Z: Intermittent
- Engine Controls - Powertrain DTC Charts And Descriptions (Except Diesel & Hybrid)
- Diagnostic Trouble Code (DTC) Charts And Descriptions
- DTC Diagnosis
- Notes
- P0010 - Intake Camshaft Position Actuator Circuit/Open (Bank 1)
- P0011 - Intake Camshaft Position Timing - Over-Advanced (Bank 1)
- P0012 - Intake Camshaft Position Timing - Over-Retarded (Bank 1)
- P0016 - Crankshaft Position - Camshaft Position Correlation - Bank 1 Sensor A
- P0018 - Crankshaft Position - Camshaft Position Correlation - Bank 2 Sensor A
- P0020 - Intake Camshaft Position Actuator Circuit/Open (Bank 2)
- P0021 - Intake Camshaft Position Timing - Over-Advanced (Bank 2)
- P0022 - Intake Camshaft Position Timing - Over-Retarded (Bank 2)
- P0040 - Oxygen Sensor Signals Swapped Bank 1 Sensor 1/Bank 2 Sensor 1
- P0041 - Oxygen Sensor Signals Swapped Bank 1 Sensor 2/Bank 2 Sensor 2
- P0053 - Ho2S Heater Resistance (Bank 1, Sensor 1)
- P0054 - Ho2S Heater Resistance (Bank 1, Sensor 2)
- P0055 - Ho2S Heater Resistance (Bank 1, Sensor 3)
- P0059 - Ho2S Heater Resistance (Bank 2, Sensor 1)
- P0060 - Ho2S Heater Resistance (Bank 2, Sensor 2)
- P0068 - Manifold Absolute Pressure (Map)/Mass Air Flow (MAF) - Throttle Position Correlation
- P0097 - Intake Air Temperature Sensor 2 Circuit Low
- P0098 - Intake Air Temperature Sensor 2 Circuit High
- P0102 - Mass Or Volume Air Flow A Circuit Low
- P0103 - Mass Or Volume Air Flow A Circuit High
- P0104 - Mass Or Volume Air Flow A Circuit Intermittent/Erratic
- P0106 - Manifold Absolute Pressure (Map/BARO) Sensor Range/Performance
- P0107 - Manifold Absolute Pressure (Map)/Barometric Pressure (BARO) Sensor Low
- P0108 - Manifold Absolute Pressure (Map)/Barometric Pressure (BARO) Sensor High
- P0109 - Manifold Absolute Pressure (Map)/Barometric Pressure (BARO) Sensor Intermittent
- P0111 - Intake Air Temperature (IAT) Sensor 1 Circuit Range/Performance
- P0112 - Intake Air Temperature (IAT) Sensor 1 Circuit Low
- P0113 - Intake Air Temperature (IAT) Sensor 1 Circuit High
- P0114 - Intake Air Temperature (IAT) Sensor 1 Intermittent/Erratic
- P0116 - Engine Coolant Temperature (ECT) Sensor 1 Circuit Range/Performance
- P0117 - Engine Coolant Temperature (ECT) Sensor 1 Circuit Low
- P0118 - Engine Coolant Temperature (ECT) Sensor 1 Circuit High
- P0119 - Engine Coolant Temperature (ECT) Sensor 1 Circuit Intermittent/Erratic
- P0121 - Throttle/Pedal Position Sensor A Circuit Range/Performance
- P0122 - Throttle/Pedal Position Sensor A Circuit Low
- P0123 - Throttle/Pedal Position Sensor A Circuit High
- P0125 - Insufficient Coolant Temperature For Closed Loop Fuel Control
- P0127 - Intake Air Temperature (IAT) Too High
- P0128 - Coolant Thermostat (Coolant Temperature Below Thermostat Regulating Temperature)
- P012B - Turbocharger/Supercharger Inlet Pressure Sensor Circuit Range/Performance
- P012C - Turbocharger/Supercharger Inlet Pressure Sensor Circuit Low
- P012D - Turbocharger/Supercharger Inlet Pressure Sensor Circuit High
- P012E - Turbocharger/Supercharger Inlet Pressure Sensor Circuit Intermittent/Erratic
- P0132 - O2 Circuit High Voltage (Bank 1, Sensor 1)
- P0133 - O2 Circuit Slow Response (Bank 1, Sensor 1)
- P0135 - O2 Heater Circuit (Bank 1, Sensor 1)
- P0138 - O2 Circuit High Voltage (Bank 1, Sensor 2)
- P0139 - O2 Circuit Slow Response (Bank 1, Sensor 2)
- P0141 - O2 Heater Circuit (Bank 1, Sensor 2)
- P0144 - O2 Circuit High Voltage (Bank 1, Sensor 3)
- P0147 - O2 Heater Circuit (Bank 1, Sensor 3)
- P0148 - Fuel Delivery Error
- P0152 - O2 Circuit High Voltage (Bank 2, Sensor 1)
- P0153 - O2 Circuit Slow Response (Bank 2, Sensor 1)
- P0155 - O2 Heater Circuit (Bank 2, Sensor 1)
- P0158 - O2 Circuit High Voltage (Bank 2, Sensor 2)
- P0159 - O2 Circuit Slow Response (Bank 2, Sensor 2)
- P0161 - O2 Heater Circuit (Bank 2, Sensor 2)
- P0171 - System Too Lean (Bank 1)
- P0172 - System Too Rich (Bank 1)
- P0174 - System Too Lean (Bank 2)
- P0175 - System Too Rich (Bank 2)
- P0180 - Fuel Temperature Sensor A Circuit
- P0181 - Fuel Temperature Sensor A Circuit Range/Performance
- P0182 - Fuel Temperature Sensor A Circuit Low
- P0183 - Fuel Temperature Sensor A Circuit High
- P0190 - Fuel Rail Pressure Sensor A Circuit
- P0191 - Fuel Rail Pressure Sensor A Circuit Range/Performance
- P0192 - Fuel Rail Pressure Sensor A Circuit Low
- P0193 - Fuel Rail Pressure Sensor A Circuit High
- P0196 - Engine Oil Temperature (EOT) Sensor Circuit Range/Performance
- P0197 - Engine Oil Temperature (EOT) Sensor Circuit Low
- P0198 - Engine Oil Temperature (EOT) Sensor Circuit High
- P020X - Injector Circuit/Open - Cylinder X
- P0210 - Injector Circuit/Open - Cylinder 10
- P0217 - Engine Coolant Over-Temperature Condition
- P0218 - Transmission Fluid Temperature Over-Temperature Condition
- P0219 - Engine Over Speed Condition
- P0221 - Throttle/Pedal Position Sensor/Switch B Circuit Range/Performance
- P0222 - Throttle/Pedal Position Sensor/Switch B Circuit Low
- P0223 - Throttle/Pedal Position Sensor/Switch B Circuit High
- P0230 - Fuel Pump Primary Circuit
- P0231 - Fuel Pump Secondary Circuit Low
- P0232 - Fuel Pump Secondary Circuit High
- P0297 - Vehicle Over Speed Condition
- P0298 - Engine Oil Over Temperature Condition
- P0300 - Random Misfire Detected
- P0301 - P0309 - Cylinder X Misfire Detected
- P0310 - Cylinder 10 Misfire Detected
- P0315 - Crankshaft Position System Variation Not Learned.
- P0316 - Misfire Detected On Startup (First 1000 Revolutions)
- P0320 - Ignition/Distributor Engine Speed Input Circuit
- P0325 - Knock Sensor 1 Circuit (Bank 1)
- P0326 - Knock Sensor 1 Circuit Range/Performance (Bank 1)
- P0330 - Knock Sensor 2 Circuit (Bank 2)
- P0331 - Knock Sensor 2 Circuit Range/Performance (Bank 2)
- P0340 - Camshaft Position Sensor A Circuit (Bank 1 Or Single Sensor)
- P0344 - Camshaft Position Sensor A Circuit Intermittent (Bank 1 Or Single Sensor)
- P0345 - Camshaft Position Sensor A Circuit (Bank 2)
- P0349 - Camshaft Position Sensor A Circuit Intermittent (Bank 2)
- P0350 - Ignition Coil Primary/Secondary Circuit
- P0351 - Ignition Coil A Primary/Secondary Circuit
- P0352 - Ignition Coil B Primary/Secondary Circuit
- P0353 - Ignition Coil C Primary/Secondary Circuit
- P0354 - Ignition Coil D Primary/Secondary Circuit
- P0355 - Ignition Coil E Primary/Secondary Circuit
- P0356 - Ignition Coil F Primary/Secondary Circuit
- P0357 - Ignition Coil G Primary/Secondary Circuit
- P0358 - Ignition Coil H Primary/Secondary Circuit
- P0359 - Ignition Coil I Primary/Secondary Circuit
- P0360 - Ignition Coil J Primary/Secondary Circuit
- P0400 - Exhaust Gas RECIRCULATION (EGR) Flow
- P0401 - Exhaust Gas RECIRCULATION (EGR) Flow Insufficient Detected
- P0402 - Exhaust Gas RECIRCULATION (EGR) Flow Excessive Detected
- P0403 - Exhaust Gas RECIRCULATION (EGR) Control Circuit
- P0405 - Exhaust Gas RECIRCULATION (EGR) Sensor A Circuit Low
- P0406 - Exhaust Gas RECIRCULATION (EGR) Sensor A Circuit High
- P0410 - Secondary Air Injection (Air) System
- P0412 - Secondary Air Injection (Air) System - Switching Valve A Circuit
- P0420 - Catalyst System Efficiency Below Threshold (Bank 1)
- P0430 - Catalyst System Efficiency Below Threshold (Bank 2)
- P0442 - Evaporative Emission System Leak Detected (Small Leak)
- P0443 - Evaporative Emission System Purge Control Valve Circuit
- P0446 - Evaporative Emission System Vent Control Circuit
- P0451 - Evaporative Emission System Pressure Sensor/Switch Range/Performance
- P0452 - Evaporative Emission System Pressure Sensor/Switch Low
- P0453 - Evaporative Emission System Pressure Sensor/Switch High
- P0454 - Evaporative Emission System Pressure Sensor/Switch Intermittent
- P0455 - Evaporative Emission System Leak Detected (Gross Leak/No Flow)
- P0456 - Evaporative Emission System Leak Detected (Very Small Leak)
- P0457 - Evaporative Emission System Leak Detected (Fuel Cap Loose/Off)
- P0460 - Fuel Level Sensor A Circuit
- P0461 - Fuel Level Sensor A Circuit Range/Performance
- P0462 - Fuel Level Sensor A Circuit Low
- P0463 - Fuel Level Sensor A Circuit High
- P0480 - Fan 1 Control Circuit
- P0481 - Fan 2 Control Circuit
- P0482 - Fan 3 Control Circuit
- P0483 - Fan Performance
- P0491 - Secondary Air Injection (Air) System Insufficient Flow (Bank 1)
- P0500 - Vehicle Speed Sensor (VSS) A
- P0503 - Vehicle Speed Sensor (VSS) A Intermittent/Erratic/High
- P0505 - Idle Air Control (IAC) System
- P0506 - Idle Air Control (IAC) System Rpm Lower Than Expected
- P0507 - Idle Air Control (IAC) System Rpm Higher Than Expected
- P050A - Cold Start Idle Air Control Performance
- P050B - Cold Start Ignition Timing Performance
- P050E - Cold Start Engine Exhaust Temperature Out Of Range
- P0511 - Idle Air Control (IAC) Circuit
- P0512 - Starter Request Circuit
- P0528 - Fan Speed Sensor Circuit No Signal
- P0532 - A/C Pressure Refrigerant Sensor A Circuit Low
- P0533 - A/C Refrigerant Pressure Sensor A Circuit High
- P0534 - A/C Refrigerant Charge Loss
- P0537 - A/C Evaporator Temperature Sensor Circuit Low
- P0538 - A/C Evaporator Temperature Sensor Circuit High
- P053A - Positive Crankcase Ventilation (PCV) Heater Control Circuit / Open
- P0552 - Power Steering Pressure (PSP) Sensor/Switch Circuit Low
- P0553 - Power Steering Pressure (PSP) Sensor Circuit High Input
- P0563 - System Voltage High
- P0579 - Cruise Control MULTIFUNCTION Input A Circuit Range / Performance
- P0581 - Cruise Control MULTIFUNCTION Input A Circuit High
- P0600 - Serial Communication Link
- P0602 - Powertrain Control Module (Pcm) Programming Error
- P0603 - Internal Control Module Keep Alive Memory (KAM) Error
- P0604 - Internal Control Module Random Access Memory (Ram) Error
- P0605 - Internal Control Module Read Only Memory (ROM) Error
- P0606 - Control Module Processor
- P0607 - Control Module Performance
- P060A - Internal Control Module Monitoring Processor Performance
- P060B - Internal Control Module A/D Processing Performance
- P060C - Internal Control Module Main Processor Performance
- P0610 - Control Module Vehicle Options Error
- P061B - Internal Control Module Torque Calculation Performance
- P061C - Internal Control Module Engine Rpm Performance
- P061D - Internal Control Module Engine Air Mass Performance
- P061F - Internal Control Module Throttle Actuator Controller Performance
- P0620 - Generator Control Circuit
- P0622 - Generator Field Terminal Circuit
- P0625 - Generator Field Terminal Circuit Low
- P0626 - Generator Field Terminal Circuit High
- P062C - Internal Control Module Vehicle Speed Performance
- P062F - Internal Control Module EEPROM Error
- P0642 - Sensor Reference Voltage A Circuit Low
- P0643 - Sensor Reference Voltage A Circuit High
- P0645 - Air Conditioning Clutch Relay (A/CCR) Control Circuit
- P0657 - Actuator Supply Voltage A Circuit/Open
- P0660 - Intake Manifold Tuning Valve (IMTV) Control Circuit Open - Bank 1
- P0663 - Intake Manifold Tuning Valve (IMTV) Control Circuit Open - Bank 2
- P0685 - Electronic Control Module (ECM)/Powertrain Control Module (Pcm) Power Relay Control Circuit/Open
- P0689 - Electronic Control Module (ECM)/Powertrain Control Module (Pcm) Power Relay Sense Circuit Low
- P0690 - Electronic Control Module (ECM)/Powertrain Control Module (Pcm) Power Relay Sense Circuit High
- P0703 - Brake Switch B Input Circuit
- P0704 - Clutch Switch Input Circuit
- P0705 - Transmission Range Sensor A Circuit (PRNDL) Input
- P0707 - Transmission Range Sensor A Circuit Low
- P0708 - Transmission Range Sensor A Circuit High
- P071X - Transmission Code
- P0720 - Output Shaft Speed (OSS) Sensor Circuit
- P0721 - Output Shaft Speed (OSS) Sensor Circuit Range/Performance
- P0722 - Output Shaft Speed (OSS) Sensor Circuit No Signal
- P0723 - Output Shaft Speed (OSS) Sensor Circuit Intermittent
- P073X - Transmission Code
- P074X - Transmission Code
- P075X - Transmission Code
- P076X - Transmission Code
- P077X - Transmission Code
- P078X - Transmission Code
- P079X - Transmission Code
- P0815 - Upshift Switch Circuit
- P0830 - Clutch Pedal Switch A Circuit
- P0833 - Clutch Pedal Switch B Circuit
- P0840 - Transmission Fluid Pressure Sensor/Switch A Circuit
- P09XX - Transmission Code
- P1000 - On-Board Diagnostic (OBD) Systems Readiness Test Not Complete
- P1001 - Key On Engine Running (KOER) Not Able To Complete, KOER Aborted
- P1100 - Mass Air Flow (MAF) Sensor Circuit Intermittent
- P1101 - Mass Air Flow (MAF) Sensor Out Of Self-Test Range
- P1112 - Intake Air Temperature (IAT) Circuit Intermittent
- P1114 - Intake Air Temperature 2 (IAT2) Circuit Low (Supercharged/Turbocharged Engines)
- P1115 - Intake Air Temperature 2 (IAT2) Circuit High (Supercharged/Turbocharged Engines)
- P1116 - Engine Coolant Temperature (ECT) Sensor Out Of Self-Test Range
- P1117 - Engine Coolant Temperature (ECT) Sensor Circuit Intermittent
- P1120 - Throttle Position Sensor A Out Of Range Low (RATCH Too Low)
- P1124 - Throttle Position Sensor A Out Of Self-Test Range
- P1127 - Exhaust Temperature Out Of Range, O2 Sensor Tests Not Completed
- P115E - Throttle Actuator Control (TAC) Throttle Body Air Flow Trim At Max Limit
- P117A - Engine Oil Over Temperature - Forced Limited Power
- P1184 - Engine Oil Temperature (EOT) Sensor Out Of Self-Test Range
- P1227 - WASTEGATE Failed Closed (Over Pressure)
- P1228 - WASTEGATE Failed Open (Under Pressure)
- P1229 - Charge Air Cooler (CAC) Pump Driver
- P1233 - Fuel Pump Driver Module Disabled Or Off Line
- P1234 - Fuel Pump Driver Module Disabled Or Off Line
- P1235 - Fuel Pump Control Out Of Range
- P1236 - Fuel Pump Control Out Of Range
- P1237 - Fuel Pump Secondary Circuit
- P1238 - Fuel Pump Secondary Circuit
- P1244 - Alternator Load High Input
- P1245 - Alternator Load Low Input
- P1246 - Alternator Load Input
- P1260 - Theft Detected, Vehicle Immobilized
- P1270 - Engine Rpm Or Vehicle Speed Limiter Reached
- P1285 - Cylinder Head Over Temperature Condition
- P1288 - Cylinder Head Temperature (CHT) Sensor Out Of Self-Test Range
- P1289 - Cylinder Head Temperature (CHT) Sensor Circuit High
- P128A - Cylinder Head Temperature (CHT) Sensor Circuit Intermittent/Erratic
- P1290 - Cylinder Head Temperature (CHT) Sensor Circuit Low
- P1299 - Cylinder Head Over Temperature Protection Active
- P1336 - Crankshaft/Camshaft Sensor Range/Performance
- P1397 - System Voltage Out Of Self -Test Range
- P1405 - Differential Pressure Feedback Sensor Upstream Hose Off Or Plugged
- P1406 - Differential Pressure Feedback Sensor Downstream Hose Off Or Plugged
- P1408 - Exhaust Gas RECIRCULATION (EGR) Flow Out Of Self-Test Range (Non-Mil)
- P1409 - Exhaust Gas RECIRCULATION (EGR) Vacuum Regulator Solenoid Circuit
- P1436 - A/C Evaporator Air Temperature Circuit Low
- P1437 - A/C Evaporator Air Temperature Circuit High
- P1443 - Evaporative Emission System Control Valve (Low/No Flow)
- P1450 - Unable To Bleed Up Fuel Tank Vacuum
- P1451 - Evaporative Emission System Vent Control Circuit
- P145E - PCV Heater Control B Circuit
- P1460 - Wide Open Throttle A/C Cutout Circuit
- P1461 - A/C Pressure Sensor Circuit High
- P1462 - Air Conditioning Pressure (A/Cp) Sensor Low Voltage Detected
- P1463 - Air Conditioning Pressure Sensor (A/Cp) Insufficient Pressure Change
- P1464 - A/C Demand Out Of Self-Test Range
- P1469 - Rapid A/C Cycling
- P1474 - Fan Control Primary Circuit
- P1477 - Additional Fan Relay Circuit
- P1479 - High Fan Control Primary Circuit
- P1489 - PCV Heater Control Circuit
- P1500 - Vehicle Speed Sensor (VSS)
- P1501 - Vehicle Speed Sensor (VSS) Out Of Self-Test Range
- P1502 - Vehicle Speed Sensor (VSS) Intermittent
- P1504 - Idle Air Control (IAC) Circuit
- P1506 - Idle Air Control (IAC) OVERSPEED Error
- P1507 - Idle Air Control (IAC) UNDERSPEED Error
- P1512 - Intake Manifold Runner Control (IMRC) Stuck Closed (Bank 1)
- P1513 - Intake Manifold Runner Control (IMRC) Stuck Closed (Bank 2)
- P1516 - Intake Manifold Runner Control (IMRC) Input Error (Bank 1)
- P1517 - Intake Manifold Runner Control (IMRC) Input Error (Bank 2)
- P1518 - Intake Manifold Runner Control (IMRC) Stuck Open Bank 1
- P1519 - Intake Manifold Runner Control (IMRC) Stuck Closed Bank 1
- P151A - Intake Manifold Runner Controller Performance
- P1520 - Intake Manifold Runner Control (IMRC) Circuit
- P1537 - Intake Manifold Runner Control (IMRC) Stuck Open (Bank 1)
- P1538 - Intake Manifold Runner Control (IMRC) Stuck Open (Bank 2)
- P1548 - Engine Air Filter Restriction
- P1549 - Intake Manifold Communication Control (IMCC) Circuit (Bank 1)
- P1550 - Power Steering Pressure (PSP) Sensor Out Of Self-Test Range
- P1572 - Brake Pedal Switch Circuit
- P1576 - Pedal Position Not Available
- P1582 - Electronic Throttle Monitor Data Available
- P1633 - Keep Alive Power (KAPWR) Voltage Too Low
- P1635 - Tire/Axle Ratio Out Of Acceptable Range
- P1636 - Inductive Signature Chip Communication Error
- P1639 - Vehicle Id (VID) Block Corrupted, Not Programmed
- P1640 - Powertrain DTCS Available In Another Module
- P1641 - Fuel Pump Primary Circuit
- P1650 - Power Steering Pressure (PSP) Switch Out Of Self-Test Range
- P1651 - Power Steering Pressure (PSP) Switch Input
- P1674 - Control Module Software Corrupted
- P1703 - Brake Switch Out Of Self-Test Range
- P1705 - Transmission Range Sensor Out Of Self-Test Range
- P1709 - Park/Neutral Position (PNP) Switch Out Of Self-Test Range
- P1729 - 4X4L Switch
- P1780 - Transmission Control Switch (TCS) Out Of Self-Test Range
- P1781 - 4X4L Switch Out Of Self-Test Range
- P17XX -
- P18XX -
- P1900 - Output Shaft Speed (OSS) Sensor Circuit Intermittent
- P1901 - Turbine Shaft Speed (TSS) Sensor Circuit Intermittent
- P2004 - Intake Manifold Runner Control (IMRC) Stuck Open (Bank 1)
- P2005 - Intake Manifold Runner Control (IMRC) Stuck Open (Bank 2)
- P2006 - Intake Manifold Runner Control (IMRC) Stuck Closed (Bank 1)
- P2007 - Intake Manifold Runner Control (IMRC) Stuck Closed (Bank 2)
- P2008 - Intake Manifold Runner Control (IMRC) Circuit Open (Bank 1)
- P2014 - Intake Manifold Runner Position Sensor/Switch Circuit (Bank 1)
- P2015 - Intake Manifold Runner Position Sensor/Switch Circuit Range/Performance (Bank 1)
- P2019 - Intake Manifold Runner Position Sensor/Switch Circuit (Bank 2)
- P2020 - Intake Manifold Runner Position Sensor/Switch Circuit Range/Performance (Bank 2)
- P2065 - Fuel Level Sensor B Circuit
- P2066 - Fuel Level Sensor B Circuit Range/Performance
- P2067 - Fuel Level Sensor B Circuit Low
- P2068 - Fuel Level Sensor B Circuit High
- P2070 - Intake Manifold Tuning Valve (IMTV) Stuck Open Bank 1
- P2071 - Intake Manifold Tuning Valve (IMTV) Stuck Closed Bank 1
- P2072 - Throttle Actuator Control (TAC) System - Ice Breakage
- P2100 - Throttle Actuator Control (TAC) Motor Circuit/Open
- P2101 - Throttle Actuator Control (TAC) Motor Range/Performance
- P2104 - Throttle Actuator Control (TAC) System - Forced Idle
- P2105 - Throttle Actuator Control (TAC) System - Forced Engine Shutdown
- P2106 - Throttle Actuator Control (TAC) System - Forced Limited Power
- P2107 - Throttle Actuator Control (TAC) Module Processor
- P2110 - Throttle Actuator Control (TAC) System - Forced Limited Rpm
- P2111 - Throttle Actuator Control (TAC) System - Stuck Open
- P2112 - Throttle Actuator Control (TAC) System - Stuck Closed
- P2121 - Throttle/Pedal Position Sensor/Switch D Circuit Range/Performance
- P2122 - Throttle/Pedal Position Sensor/Switch D Circuit Low
- P2123 - Throttle/Pedal Position Sensor/Switch D Circuit High
- P2126 - Throttle/Pedal Position Sensor/Switch E Circuit Range/Performance
- P2127 - Throttle/Pedal Position Sensor/Switch E Circuit Low
- P2128 - Throttle/Pedal Position Sensor/Switch E Circuit High
- P2131 - Throttle/Pedal Position Sensor/Switch F Circuit Range/Performance
- P2132 - Throttle/Pedal Position Sensor/Switch F Circuit Low
- P2133 - Throttle/Pedal Position Sensor/Switch F Circuit High
- P2135 - Throttle/Pedal Position Sensor/Switch A/B Voltage Correlation
- P2195 - O2 Sensor Signal Biased/Stuck Lean - Bank 1, Sensor 1
- P2196 - O2 Sensor Signal Biased/Stuck Rich - Bank 1, Sensor 1
- P2197 - O2 Sensor Signal Biased/Stuck Lean - Bank 2, Sensor 1
- P2198 - O2 Sensor Signal Biased/Stuck Rich - Bank 2, Sensor 1
- P2257 - Secondary Air Injection (Air) System Control A Circuit Low
- P2258 - Secondary Air Injection (Air) System Control A Circuit High
- P2270 - O2 Sensor Signal Stuck Lean - Bank 1, Sensor 2
- P2271 - O2 Sensor Signal Stuck Rich - Bank 1, Sensor 2
- P2272 - O2 Sensor Signal Stuck Lean - Bank 2, Sensor 2
- P2273 - O2 Sensor Signal Stuck Rich - Bank 2, Sensor 2
- P2274 - O2 Sensor Signal Stuck Lean - Bank 1, Sensor 3
- P2275 - O2 Sensor Signal Stuck Rich - Bank 1, Sensor 3
- P2448 - Secondary Air Injection System High Airflow (Bank 1)
- P260F - Evaporative System Monitoring Processor Performance
- PXXXX -
- U0101 - Lost Communication With Transaxle Control Module (TCM)
- U0121 - Lost Communication With The Anti-Lock Brake System (Abs) Control Module
- U0155 - Lost Communication With Instrument Panel Cluster Control Module
- U0300 - Internal Control Module Software Incompatibility
- U1039 - SCP (J1850) Invalid Or Missing Data For Vehicle Speed
- UXXXX - Network Communication Diagnostic Trouble Code (DTC)
- Engine Controls - Reference Values (Except Diesel & Hybrid)
- Reference Value Symptom Chart
- Reference Value Parameter Identification (PID)/Measured Signal Chart
- Typical Diagnostic Reference Values
- 2.0L 4V Focus
- 2.3L 4V Focus
- 2.3L 4V Fusion/Milan
- 3.0L 4V Fusion/Milan
- 3.0L 4V Five Hundred/Freestyle/Montego
- 3.0L 2V Taurus
- 3.5L 4V MKZ
- 4.0L Mustang
- 4.6L 3V Mustang
- 5.4L 4V Mustang
- 4.6L 2V Crown Victoria/Grand Marquis
- 4.6L 2V Town Car
- 2.3L 4V Escape/Mariner
- 3.0L 4V Escape/Mariner
- 2.3L Ranger
- 3.0L Ranger
- 4.0L Ranger
- 3.5L 4V Edge/MKX
- 3.9L Freestar
- 4.2L Freestar/Monterey
- 4.0L Explorer/Explorer Sport Trac/Mountaineer
- 4.6L 3V Explorer/Explorer Sport Trac/Mountaineer
- 4.2L F-150
- 4.6L 2V F-150
- 5.4L 3V F-150/Mark LT
- 4.6L 2V E-Series
- 5.4L 2V E-Series
- 6.8L 2V E-Series
- 5.4L 3V Expedition/Navigator
- 5.4L 3V F-Super Duty
- 6.8L 3V F-Super Duty
- Engine Controls - Description And Operation (Except Diesel & Hybrid)
- Testing & Diagnosis
- Engine Controls - Description And Operation (Except Diesel & Hybrid)
- Vehicle Emission Control Information (VECI)
- Vehicle Certification Label
- Vehicle Emission Control Information (VECI) Acronym Definitions
- Engine Control Components
- Notes
- Accelerator Pedal Position (APP) Sensor
- Air Conditioning (A/C) Clutch Relay (A/CCR)
- Air Conditioning (A/C) Cycling Switch
- Air Conditioning Evaporator Temperature (ACET) Sensor
- Air Conditioning (A/C) High Pressure Switch
- Air Conditioning Pressure (ACP) Transducer Sensor
- Brake Pedal Position (BPP) Switch
- Brake Pedal Switch (BPS)/Brake Deactivator Switch
- Camshaft Position (CMP) Sensor
- Canister Vent (CV) Solenoid
- Check Fuel Cap Indicator
- Clutch Pedal Position (CPP) Switch
- Coil On Plug (COP)
- Coil Pack
- Cooling Fan Clutch
- Crankshaft Position (CKP) Sensor
- Cylinder Head Temperature (CHT) Sensor
- Differential Pressure Feedback Exhaust Gas Recirculation (EGR) Sensor
- Differential Pressure Feedback Exhaust Gas Recirculation (EGR) Sensor - Tube Mounted
- Electric Exhaust Gas Recirculation (EEGR) Valve
- Electronic Throttle Actuator Control (TAC)
- Electronic Throttle Body (ETB) Position Sensor
- Engine Coolant Temperature (ECT) Sensor
- Engine Oil Temperature (EOT) Sensor
- Evaporative Emission (EVAP) Canister Purge Valve
- Exhaust Gas Recirculation (EGR) Orifice Tube Assembly
- Exhaust Gas Recirculation (EGR) System Module (ESM)
- Exhaust Gas Recirculation (EGR) Vacuum Regulator Solenoid
- Exhaust Gas Recirculation (EGR) Valve
- Fan Control
- Fan Speed Sensor (FSS)
- Fuel Injectors
- Fuel Level Input (FLI)
- Fuel Pump (FP) Module
- Fuel Pump (FP) Module and Reservoir
- Fuel Rail Pressure (FRP) Sensor
- Fuel Rail Pressure Temperature (FRPT) Sensor
- Fuel Rail Pulse Damper
- Fuel Tank Pressure (FTP) Sensor
- Heated Oxygen Sensor (HO2S)
- Idle Air Control (IAC) Valve
- Inertia Fuel Shutoff (IFS) Switch
- Intake Air Temperature (IAT) Sensor
- Intake Manifold Tuning Valve (IMTV)
- Knock Sensor (KS)
- Manifold Absolute Pressure (MAP) Sensor
- Mass Air Flow (MAF) Sensor
- Output Shaft Speed (OSS) Sensor
- Power Steering Pressure (PSP) Sensor
- Power Steering Pressure (PSP) Switch
- Power Take-Off (PTO) Switch and Circuits
- Powertrain Control Module - Vehicle Speed Output (PCM-VSO)
- Secondary Air Injection (AIR) Bypass Solenoid
- Secondary AIR Diverter Valve
- Secondary AIR Pump
- Starter Motor Request (SMR) Circuit
- Throttle Position (TP) Sensor
- Transmission Control Indicator Lamp (TCIL)
- Transmission Control Switch (TCS)
- Vapor Management Valve (VMV)
- Vehicle Speed Sensor (VSS)
- Electronic Engine Control (EEC) System
- Powertrain Control Hardware
- Powertrain Control Module (PCM)
- PCM Locations
- 104-Pin PCM
- 140-Pin PCM
- 150-Pin PCM
- 170-Pin PCM
- 190-Pin PCM
- Fuel Pump Driver Module (FPDM)
- Keep Alive Memory (KAM)
- Hardware Limited Operation Strategy (HLOS)
- Integrated Electronic Ignition System
- Power and Ground Signals
- Electronic Throttle Control Reference Voltage (ETCREF)
- Electronic Throttle Control Return (ETCRTN)
- Gold Plated Pins
- Keep Alive Power (KAPWR)
- Mass Air Flow (MAF) Return
- Power Ground (PWR GND)
- Signal Return (SIG RTN)
- Variable Reluctance Sensor Return (VRSRTN)
- Vehicle Buffered Power (VBPWR)
- Vehicle Power (VPWR)
- Vehicle Reference Voltage (VREF)
- Powertrain Control Software
- Adaptive Airflow
- Computer Controlled Shutdown
- Engine RPM/Vehicle Speed Limiter
- Fail-Safe Cooling Strategy
- Failure Mode Effects Management
- Flash Electrically Erasable Programmable Read Only Memory (EEPROM)
- Fuel Trim
- High Speed Controller Area Network (CAN)
- Idle Air Trim
- Idle Speed Control Closed Throttle Determination - Applications Without Electronic Throttle Control (ETC)
- Multiplexing
- Multiplexing Implementation
- Malfunction Indicator Lamp (MIL)
- Catalyst and Exhaust Systems
- Evaporative Emission (EVAP) Systems
- Exhaust Gas Recirculation (EGR) Systems
- Fuel Systems
- Ignition Systems
- Intake Air Systems
- Overview
- Throttle Body System Overview
- Overview of the Intake Manifold Runner Control (IMRC) and Intake Manifold Tuning Valve (IMTV) Systems
- Intake Manifold Runner Control (IMRC) Electric Actuated System
- Intake Manifold Runner Control (IMRC) Vacuum Actuated System
- Intake Manifold Tuning Valve (IMTV) System
- Positive Crankcase Ventilation (PCV) System
- Powertrain Control Module (PCM) Controlled Charging System
- Secondary Air Injection (AIR) System
- Supercharger and Charge Air Cooler (CAC) Systems
- (Torque Based) Electronic Throttle Control (ETC)
- Variable Camshaft Timing (VCT) System
- On Board Diagnostics (OBD) Monitors
- Catalyst Efficiency Monitor
- Cold Start Emission Reduction Monitor
- Comprehensive Component Monitor (CCM)
- Electric Exhaust Gas Recirculation (EEGR) System Monitor
- Evaporative Emission (EVAP) Leak Check Monitor
- Exhaust Gas Recirculation (EGR) System Monitor - Differential Pressure Feedback EGR and EGR System Module (ESM)
- Fuel System Monitor
- Heated Oxygen Sensor (HO2S) Monitor
- Misfire Detection Monitor
- Positive Crankcase Ventilation (PCV) System Monitor
- Secondary Air Injection (AIR) System Monitor
- Thermostat Monitor
- Variable Camshaft Timing (VCT) Monitor
- Engine Controls - Pinpoint Test A: No Start Through Pinpoint Test DJ: Air Conditioning Evaporator Temperature (ACET) Sensor - (Except Diesel & Hybrid)
- PINPOINT TEST A: No Start
- PINPOINT TEST B: Powertrain Control Module (PCM) Power Relay
- PINPOINT TEST C: Reference Voltage (VREF)
- PINPOINT TEST DA: Intake Air Temperature (IAT) Sensor
- PINPOINT TEST DC: Mass Air Flow (MAF) Sensor
- PINPOINT TEST DD: Fuel Rail Pressure (FRP) and Fuel Rail Pressure Temperature (FRPT) Sensors
- PINPOINT TEST DF: Vehicle Speed Circuit (VSC) Check
- PINPOINT TEST DG: Knock Sensor
- PINPOINT TEST DH: Throttle Position (TP) Sensor
- PINPOINT TEST DJ: Air Conditioning Evaporator Temperature (ACET) Sensor
- Engine Controls - Pinpoint Test DK: Accelerator Pedal Position (App) Sensor Through Pinpoint Test DW: Heated Oxygen Sensor (Ho2S) - (Except Diesel & Hybrid)
- PINPOINT TEST DK: Accelerator Pedal Position (APP) Sensor
- PINPOINT TEST DL: Cylinder Head Temperature (CHT) Sensor
- PINPOINT TEST DM: Manifold Absolute Pressure (MAP) Sensor
- PINPOINT TEST DP: Output Shaft Speed (OSS) Sensor/Vehicle Speed Sensor (VSS)/Transfer Case Speed Sensor (TCSS)
- PINPOINT TEST DR: Camshaft Position (CMP) Sensor
- PINPOINT TEST DS: Air Conditioning Pressure (ACP) Transducer Sensor
- PINPOINT TEST DT: Power Steering Pressure (PSP) Sensor
- PINPOINT TEST DU: Intake Air Temperature 2 (IAT2) Sensor
- PINPOINT TEST DV: Throttle Body Assembly Electronic Throttle Control (ETC)
- PINPOINT TEST DW: Heated Oxygen Sensor (HO2S)
- Engine Controls - Pinpoint Test DX: Engine Coolant Temperature (ECT) Sensor Through Pinpoint Test Hf: Catalyst Efficiency Monitor And Exhaust Systems - (Except Diesel & Hybrid)
- PINPOINT TEST DX: Engine Coolant Temperature (ECT) Sensor
- PINPOINT TEST DY: Engine Oil Temperature (EOT) Sensor
- PINPOINT TEST EM: Emission Compliance
- PINPOINT TEST FB: Power Take Off (PTO)
- PINPOINT TEST FD: Brake Pedal Inputs
- PINPOINT TEST FF: Power Steering Pressure (PSP) Switch
- PINPOINT TEST H: Fuel Control
- PINPOINT TEST HC: Fuel Delivery System
- PINPOINT TEST HD: Misfire Detection Monitor
- PINPOINT TEST HE: Exhaust Gas Recirculation (EGR) Systems
- PINPOINT TEST HF: Catalyst Efficiency Monitor and Exhaust Systems
- Engine Controls - Pinpoint Test Hg: Positive Crankcase Ventilation (PCV) System Through Pinpoint Test JD: Crankshaft Position (CKP) Sensor - (Except Diesel & Hybrid)
- PINPOINT TEST HG: Positive Crankcase Ventilation (PCV) System
- PINPOINT TEST HH: Exhaust Gas Recirculation System Module (ESM)
- PINPOINT TEST HK: Variable Camshaft Timing (VCT)
- PINPOINT TEST HM: Secondary Air Injection (AIR) System
- PINPOINT TEST HU: Intake Air Systems
- PINPOINT TEST HV: Cooling Fan Clutch
- PINPOINT TEST HX: Evaporative Emission (EVAP) System and Monitor
- PINPOINT TEST HY: Generator/Regulator System
- PINPOINT TEST JB: Secondary Ignition (COP)
- PINPOINT TEST JC: Secondary Ignition (Coil Pack)
- PINPOINT TEST JD: Crankshaft Position (CKP) Sensor
- Engine Controls - Pinpoint Test Index - (Except Diesel & Hybrid)
- Engine Controls - Pinpoint Test JE: Integrated Ignition Coil Pack A, B, Or C Failure Through Pinpoint Test Kn: Variable Speed Electric Cooling Fan - (Except Diesel & Hybrid)
- PINPOINT TEST JE: Integrated Ignition Coil Pack A, B, or C Failure
- PINPOINT TEST JF: Integrated Ignition Coil On Plug Coil A Through J Failure
- PINPOINT TEST KA: Fuel Pump (FP) Relay
- PINPOINT TEST KB: Fuel Pump Driver Module
- PINPOINT TEST KD: Electric Exhaust Gas Recirculation (EEGR) System
- PINPOINT TEST KE: Idle Air Control (IAC) Valve
- PINPOINT TEST KF: Fan Control (FC) Relays
- PINPOINT TEST KG: Fuel Injector
- PINPOINT TEST KJ: Supercharger Bypass Control
- PINPOINT TEST KM: Air Conditioning Clutch Relay (A/CCR) Circuit
- PINPOINT TEST KN: Variable Speed Electric Cooling Fan
- Engine Controls - Pinpoint Test KP: Charge Air Cooler (CAC) Pump Through Pinpoint Test Z: Intermittent - (Except Diesel & Hybrid)
- PINPOINT TEST KP: Charge Air Cooler (CAC) Pump
- PINPOINT TEST NC: Ignition Engine Speed Input Circuit
- PINPOINT TEST ND: Engine RPM\Vehicle Speed Limiter Reached
- PINPOINT TEST QA: Unable to Activate Self-Test/Network Communication Error
- PINPOINT TEST QB: DTCs P0603 or P1633: Keep Alive Power (KAPWR)
- PINPOINT TEST QC: DTC P1000: On-Board Diagnostic (OBD) Systems Readiness Test Not Complete
- PINPOINT TEST QD: DTC P1260: Passive Anti-Theft System
- PINPOINT TEST QE: Electronic Throttle Control (ETC) System
- PINPOINT TEST TA: Clutch Pedal Position (CPP) Switch
- PINPOINT TEST TB: Transmission Control Switch (TCS)/ Transmission Control Indicator Lamp (TCIL)
- PINPOINT TEST Z: Intermittent
- Engine Controls - Powertrain DTC Charts And Descriptions (Except Diesel & Hybrid)
- Diagnostic Trouble Code (DTC) Charts And Descriptions
- DTC Diagnosis
- Notes
- P0010 - Intake Camshaft Position Actuator Circuit/Open (Bank 1)
- P0011 - Intake Camshaft Position Timing - Over-Advanced (Bank 1)
- P0012 - Intake Camshaft Position Timing - Over-Retarded (Bank 1)
- P0016 - Crankshaft Position - Camshaft Position Correlation - Bank 1 Sensor A
- P0018 - Crankshaft Position - Camshaft Position Correlation - Bank 2 Sensor A
- P0020 - Intake Camshaft Position Actuator Circuit/Open (Bank 2)
- P0021 - Intake Camshaft Position Timing - Over-Advanced (Bank 2)
- P0022 - Intake Camshaft Position Timing - Over-Retarded (Bank 2)
- P0040 - Oxygen Sensor Signals Swapped Bank 1 Sensor 1/Bank 2 Sensor 1
- P0041 - Oxygen Sensor Signals Swapped Bank 1 Sensor 2/Bank 2 Sensor 2
- P0053 - Ho2S Heater Resistance (Bank 1, Sensor 1)
- P0054 - Ho2S Heater Resistance (Bank 1, Sensor 2)
- P0055 - Ho2S Heater Resistance (Bank 1, Sensor 3)
- P0059 - Ho2S Heater Resistance (Bank 2, Sensor 1)
- P0060 - Ho2S Heater Resistance (Bank 2, Sensor 2)
- P0068 - Manifold Absolute Pressure (Map)/Mass Air Flow (MAF) - Throttle Position Correlation
- P0097 - Intake Air Temperature Sensor 2 Circuit Low
- P0098 - Intake Air Temperature Sensor 2 Circuit High
- P0102 - Mass Or Volume Air Flow A Circuit Low
- P0103 - Mass Or Volume Air Flow A Circuit High
- P0104 - Mass Or Volume Air Flow A Circuit Intermittent/Erratic
- P0106 - Manifold Absolute Pressure (Map/BARO) Sensor Range/Performance
- P0107 - Manifold Absolute Pressure (Map)/Barometric Pressure (BARO) Sensor Low
- P0108 - Manifold Absolute Pressure (Map)/Barometric Pressure (BARO) Sensor High
- P0109 - Manifold Absolute Pressure (Map)/Barometric Pressure (BARO) Sensor Intermittent
- P0111 - Intake Air Temperature (IAT) Sensor 1 Circuit Range/Performance
- P0112 - Intake Air Temperature (IAT) Sensor 1 Circuit Low
- P0113 - Intake Air Temperature (IAT) Sensor 1 Circuit High
- P0114 - Intake Air Temperature (IAT) Sensor 1 Intermittent/Erratic
- P0116 - Engine Coolant Temperature (ECT) Sensor 1 Circuit Range/Performance
- P0117 - Engine Coolant Temperature (ECT) Sensor 1 Circuit Low
- P0118 - Engine Coolant Temperature (ECT) Sensor 1 Circuit High
- P0119 - Engine Coolant Temperature (ECT) Sensor 1 Circuit Intermittent/Erratic
- P0121 - Throttle/Pedal Position Sensor A Circuit Range/Performance
- P0122 - Throttle/Pedal Position Sensor A Circuit Low
- P0123 - Throttle/Pedal Position Sensor A Circuit High
- P0125 - Insufficient Coolant Temperature For Closed Loop Fuel Control
- P0127 - Intake Air Temperature (IAT) Too High
- P0128 - Coolant Thermostat (Coolant Temperature Below Thermostat Regulating Temperature)
- P012B - Turbocharger/Supercharger Inlet Pressure Sensor Circuit Range/Performance
- P012C - Turbocharger/Supercharger Inlet Pressure Sensor Circuit Low
- P012D - Turbocharger/Supercharger Inlet Pressure Sensor Circuit High
- P012E - Turbocharger/Supercharger Inlet Pressure Sensor Circuit Intermittent/Erratic
- P0132 - O2 Circuit High Voltage (Bank 1, Sensor 1)
- P0133 - O2 Circuit Slow Response (Bank 1, Sensor 1)
- P0135 - O2 Heater Circuit (Bank 1, Sensor 1)
- P0138 - O2 Circuit High Voltage (Bank 1, Sensor 2)
- P0139 - O2 Circuit Slow Response (Bank 1, Sensor 2)
- P0141 - O2 Heater Circuit (Bank 1, Sensor 2)
- P0144 - O2 Circuit High Voltage (Bank 1, Sensor 3)
- P0147 - O2 Heater Circuit (Bank 1, Sensor 3)
- P0148 - Fuel Delivery Error
- P0152 - O2 Circuit High Voltage (Bank 2, Sensor 1)
- P0153 - O2 Circuit Slow Response (Bank 2, Sensor 1)
- P0155 - O2 Heater Circuit (Bank 2, Sensor 1)
- P0158 - O2 Circuit High Voltage (Bank 2, Sensor 2)
- P0159 - O2 Circuit Slow Response (Bank 2, Sensor 2)
- P0161 - O2 Heater Circuit (Bank 2, Sensor 2)
- P0171 - System Too Lean (Bank 1)
- P0172 - System Too Rich (Bank 1)
- P0174 - System Too Lean (Bank 2)
- P0175 - System Too Rich (Bank 2)
- P0180 - Fuel Temperature Sensor A Circuit
- P0181 - Fuel Temperature Sensor A Circuit Range/Performance
- P0182 - Fuel Temperature Sensor A Circuit Low
- P0183 - Fuel Temperature Sensor A Circuit High
- P0190 - Fuel Rail Pressure Sensor A Circuit
- P0191 - Fuel Rail Pressure Sensor A Circuit Range/Performance
- P0192 - Fuel Rail Pressure Sensor A Circuit Low
- P0193 - Fuel Rail Pressure Sensor A Circuit High
- P0196 - Engine Oil Temperature (EOT) Sensor Circuit Range/Performance
- P0197 - Engine Oil Temperature (EOT) Sensor Circuit Low
- P0198 - Engine Oil Temperature (EOT) Sensor Circuit High
- P020X - Injector Circuit/Open - Cylinder X
- P0210 - Injector Circuit/Open - Cylinder 10
- P0217 - Engine Coolant Over-Temperature Condition
- P0218 - Transmission Fluid Temperature Over-Temperature Condition
- P0219 - Engine Over Speed Condition
- P0221 - Throttle/Pedal Position Sensor/Switch B Circuit Range/Performance
- P0222 - Throttle/Pedal Position Sensor/Switch B Circuit Low
- P0223 - Throttle/Pedal Position Sensor/Switch B Circuit High
- P0230 - Fuel Pump Primary Circuit
- P0231 - Fuel Pump Secondary Circuit Low
- P0232 - Fuel Pump Secondary Circuit High
- P0297 - Vehicle Over Speed Condition
- P0298 - Engine Oil Over Temperature Condition
- P0300 - Random Misfire Detected
- P0301 - P0309 - Cylinder X Misfire Detected
- P0310 - Cylinder 10 Misfire Detected
- P0315 - Crankshaft Position System Variation Not Learned.
- P0316 - Misfire Detected On Startup (First 1000 Revolutions)
- P0320 - Ignition/Distributor Engine Speed Input Circuit
- P0325 - Knock Sensor 1 Circuit (Bank 1)
- P0326 - Knock Sensor 1 Circuit Range/Performance (Bank 1)
- P0330 - Knock Sensor 2 Circuit (Bank 2)
- P0331 - Knock Sensor 2 Circuit Range/Performance (Bank 2)
- P0340 - Camshaft Position Sensor A Circuit (Bank 1 Or Single Sensor)
- P0344 - Camshaft Position Sensor A Circuit Intermittent (Bank 1 Or Single Sensor)
- P0345 - Camshaft Position Sensor A Circuit (Bank 2)
- P0349 - Camshaft Position Sensor A Circuit Intermittent (Bank 2)
- P0350 - Ignition Coil Primary/Secondary Circuit
- P0351 - Ignition Coil A Primary/Secondary Circuit
- P0352 - Ignition Coil B Primary/Secondary Circuit
- P0353 - Ignition Coil C Primary/Secondary Circuit
- P0354 - Ignition Coil D Primary/Secondary Circuit
- P0355 - Ignition Coil E Primary/Secondary Circuit
- P0356 - Ignition Coil F Primary/Secondary Circuit
- P0357 - Ignition Coil G Primary/Secondary Circuit
- P0358 - Ignition Coil H Primary/Secondary Circuit
- P0359 - Ignition Coil I Primary/Secondary Circuit
- P0360 - Ignition Coil J Primary/Secondary Circuit
- P0400 - Exhaust Gas RECIRCULATION (EGR) Flow
- P0401 - Exhaust Gas RECIRCULATION (EGR) Flow Insufficient Detected
- P0402 - Exhaust Gas RECIRCULATION (EGR) Flow Excessive Detected
- P0403 - Exhaust Gas RECIRCULATION (EGR) Control Circuit
- P0405 - Exhaust Gas RECIRCULATION (EGR) Sensor A Circuit Low
- P0406 - Exhaust Gas RECIRCULATION (EGR) Sensor A Circuit High
- P0410 - Secondary Air Injection (Air) System
- P0412 - Secondary Air Injection (Air) System - Switching Valve A Circuit
- P0420 - Catalyst System Efficiency Below Threshold (Bank 1)
- P0430 - Catalyst System Efficiency Below Threshold (Bank 2)
- P0442 - Evaporative Emission System Leak Detected (Small Leak)
- P0443 - Evaporative Emission System Purge Control Valve Circuit
- P0446 - Evaporative Emission System Vent Control Circuit
- P0451 - Evaporative Emission System Pressure Sensor/Switch Range/Performance
- P0452 - Evaporative Emission System Pressure Sensor/Switch Low
- P0453 - Evaporative Emission System Pressure Sensor/Switch High
- P0454 - Evaporative Emission System Pressure Sensor/Switch Intermittent
- P0455 - Evaporative Emission System Leak Detected (Gross Leak/No Flow)
- P0456 - Evaporative Emission System Leak Detected (Very Small Leak)
- P0457 - Evaporative Emission System Leak Detected (Fuel Cap Loose/Off)
- P0460 - Fuel Level Sensor A Circuit
- P0461 - Fuel Level Sensor A Circuit Range/Performance
- P0462 - Fuel Level Sensor A Circuit Low
- P0463 - Fuel Level Sensor A Circuit High
- P0480 - Fan 1 Control Circuit
- P0481 - Fan 2 Control Circuit
- P0482 - Fan 3 Control Circuit
- P0483 - Fan Performance
- P0491 - Secondary Air Injection (Air) System Insufficient Flow (Bank 1)
- P0500 - Vehicle Speed Sensor (VSS) A
- P0503 - Vehicle Speed Sensor (VSS) A Intermittent/Erratic/High
- P0505 - Idle Air Control (IAC) System
- P0506 - Idle Air Control (IAC) System Rpm Lower Than Expected
- P0507 - Idle Air Control (IAC) System Rpm Higher Than Expected
- P050A - Cold Start Idle Air Control Performance
- P050B - Cold Start Ignition Timing Performance
- P050E - Cold Start Engine Exhaust Temperature Out Of Range
- P0511 - Idle Air Control (IAC) Circuit
- P0512 - Starter Request Circuit
- P0528 - Fan Speed Sensor Circuit No Signal
- P0532 - A/C Pressure Refrigerant Sensor A Circuit Low
- P0533 - A/C Refrigerant Pressure Sensor A Circuit High
- P0534 - A/C Refrigerant Charge Loss
- P0537 - A/C Evaporator Temperature Sensor Circuit Low
- P0538 - A/C Evaporator Temperature Sensor Circuit High
- P053A - Positive Crankcase Ventilation (PCV) Heater Control Circuit / Open
- P0552 - Power Steering Pressure (PSP) Sensor/Switch Circuit Low
- P0553 - Power Steering Pressure (PSP) Sensor Circuit High Input
- P0563 - System Voltage High
- P0579 - Cruise Control MULTIFUNCTION Input A Circuit Range / Performance
- P0581 - Cruise Control MULTIFUNCTION Input A Circuit High
- P0600 - Serial Communication Link
- P0602 - Powertrain Control Module (Pcm) Programming Error
- P0603 - Internal Control Module Keep Alive Memory (KAM) Error
- P0604 - Internal Control Module Random Access Memory (Ram) Error
- P0605 - Internal Control Module Read Only Memory (ROM) Error
- P0606 - Control Module Processor
- P0607 - Control Module Performance
- P060A - Internal Control Module Monitoring Processor Performance
- P060B - Internal Control Module A/D Processing Performance
- P060C - Internal Control Module Main Processor Performance
- P0610 - Control Module Vehicle Options Error
- P061B - Internal Control Module Torque Calculation Performance
- P061C - Internal Control Module Engine Rpm Performance
- P061D - Internal Control Module Engine Air Mass Performance
- P061F - Internal Control Module Throttle Actuator Controller Performance
- P0620 - Generator Control Circuit
- P0622 - Generator Field Terminal Circuit
- P0625 - Generator Field Terminal Circuit Low
- P0626 - Generator Field Terminal Circuit High
- P062C - Internal Control Module Vehicle Speed Performance
- P062F - Internal Control Module EEPROM Error
- P0642 - Sensor Reference Voltage A Circuit Low
- P0643 - Sensor Reference Voltage A Circuit High
- P0645 - Air Conditioning Clutch Relay (A/CCR) Control Circuit
- P0657 - Actuator Supply Voltage A Circuit/Open
- P0660 - Intake Manifold Tuning Valve (IMTV) Control Circuit Open - Bank 1
- P0663 - Intake Manifold Tuning Valve (IMTV) Control Circuit Open - Bank 2
- P0685 - Electronic Control Module (ECM)/Powertrain Control Module (Pcm) Power Relay Control Circuit/Open
- P0689 - Electronic Control Module (ECM)/Powertrain Control Module (Pcm) Power Relay Sense Circuit Low
- P0690 - Electronic Control Module (ECM)/Powertrain Control Module (Pcm) Power Relay Sense Circuit High
- P0703 - Brake Switch B Input Circuit
- P0704 - Clutch Switch Input Circuit
- P0705 - Transmission Range Sensor A Circuit (PRNDL) Input
- P0707 - Transmission Range Sensor A Circuit Low
- P0708 - Transmission Range Sensor A Circuit High
- P071X - Transmission Code
- P0720 - Output Shaft Speed (OSS) Sensor Circuit
- P0721 - Output Shaft Speed (OSS) Sensor Circuit Range/Performance
- P0722 - Output Shaft Speed (OSS) Sensor Circuit No Signal
- P0723 - Output Shaft Speed (OSS) Sensor Circuit Intermittent
- P073X - Transmission Code
- P074X - Transmission Code
- P075X - Transmission Code
- P076X - Transmission Code
- P077X - Transmission Code
- P078X - Transmission Code
- P079X - Transmission Code
- P0815 - Upshift Switch Circuit
- P0830 - Clutch Pedal Switch A Circuit
- P0833 - Clutch Pedal Switch B Circuit
- P0840 - Transmission Fluid Pressure Sensor/Switch A Circuit
- P09XX - Transmission Code
- P1000 - On-Board Diagnostic (OBD) Systems Readiness Test Not Complete
- P1001 - Key On Engine Running (KOER) Not Able To Complete, KOER Aborted
- P1100 - Mass Air Flow (MAF) Sensor Circuit Intermittent
- P1101 - Mass Air Flow (MAF) Sensor Out Of Self-Test Range
- P1112 - Intake Air Temperature (IAT) Circuit Intermittent
- P1114 - Intake Air Temperature 2 (IAT2) Circuit Low (Supercharged/Turbocharged Engines)
- P1115 - Intake Air Temperature 2 (IAT2) Circuit High (Supercharged/Turbocharged Engines)
- P1116 - Engine Coolant Temperature (ECT) Sensor Out Of Self-Test Range
- P1117 - Engine Coolant Temperature (ECT) Sensor Circuit Intermittent
- P1120 - Throttle Position Sensor A Out Of Range Low (RATCH Too Low)
- P1124 - Throttle Position Sensor A Out Of Self-Test Range
- P1127 - Exhaust Temperature Out Of Range, O2 Sensor Tests Not Completed
- P115E - Throttle Actuator Control (TAC) Throttle Body Air Flow Trim At Max Limit
- P117A - Engine Oil Over Temperature - Forced Limited Power
- P1184 - Engine Oil Temperature (EOT) Sensor Out Of Self-Test Range
- P1227 - WASTEGATE Failed Closed (Over Pressure)
- P1228 - WASTEGATE Failed Open (Under Pressure)
- P1229 - Charge Air Cooler (CAC) Pump Driver
- P1233 - Fuel Pump Driver Module Disabled Or Off Line
- P1234 - Fuel Pump Driver Module Disabled Or Off Line
- P1235 - Fuel Pump Control Out Of Range
- P1236 - Fuel Pump Control Out Of Range
- P1237 - Fuel Pump Secondary Circuit
- P1238 - Fuel Pump Secondary Circuit
- P1244 - Alternator Load High Input
- P1245 - Alternator Load Low Input
- P1246 - Alternator Load Input
- P1260 - Theft Detected, Vehicle Immobilized
- P1270 - Engine Rpm Or Vehicle Speed Limiter Reached
- P1285 - Cylinder Head Over Temperature Condition
- P1288 - Cylinder Head Temperature (CHT) Sensor Out Of Self-Test Range
- P1289 - Cylinder Head Temperature (CHT) Sensor Circuit High
- P128A - Cylinder Head Temperature (CHT) Sensor Circuit Intermittent/Erratic
- P1290 - Cylinder Head Temperature (CHT) Sensor Circuit Low
- P1299 - Cylinder Head Over Temperature Protection Active
- P1336 - Crankshaft/Camshaft Sensor Range/Performance
- P1397 - System Voltage Out Of Self -Test Range
- P1405 - Differential Pressure Feedback Sensor Upstream Hose Off Or Plugged
- P1406 - Differential Pressure Feedback Sensor Downstream Hose Off Or Plugged
- P1408 - Exhaust Gas RECIRCULATION (EGR) Flow Out Of Self-Test Range (Non-Mil)
- P1409 - Exhaust Gas RECIRCULATION (EGR) Vacuum Regulator Solenoid Circuit
- P1436 - A/C Evaporator Air Temperature Circuit Low
- P1437 - A/C Evaporator Air Temperature Circuit High
- P1443 - Evaporative Emission System Control Valve (Low/No Flow)
- P1450 - Unable To Bleed Up Fuel Tank Vacuum
- P1451 - Evaporative Emission System Vent Control Circuit
- P145E - PCV Heater Control B Circuit
- P1460 - Wide Open Throttle A/C Cutout Circuit
- P1461 - A/C Pressure Sensor Circuit High
- P1462 - Air Conditioning Pressure (A/Cp) Sensor Low Voltage Detected
- P1463 - Air Conditioning Pressure Sensor (A/Cp) Insufficient Pressure Change
- P1464 - A/C Demand Out Of Self-Test Range
- P1469 - Rapid A/C Cycling
- P1474 - Fan Control Primary Circuit
- P1477 - Additional Fan Relay Circuit
- P1479 - High Fan Control Primary Circuit
- P1489 - PCV Heater Control Circuit
- P1500 - Vehicle Speed Sensor (VSS)
- P1501 - Vehicle Speed Sensor (VSS) Out Of Self-Test Range
- P1502 - Vehicle Speed Sensor (VSS) Intermittent
- P1504 - Idle Air Control (IAC) Circuit
- P1506 - Idle Air Control (IAC) OVERSPEED Error
- P1507 - Idle Air Control (IAC) UNDERSPEED Error
- P1512 - Intake Manifold Runner Control (IMRC) Stuck Closed (Bank 1)
- P1513 - Intake Manifold Runner Control (IMRC) Stuck Closed (Bank 2)
- P1516 - Intake Manifold Runner Control (IMRC) Input Error (Bank 1)
- P1517 - Intake Manifold Runner Control (IMRC) Input Error (Bank 2)
- P1518 - Intake Manifold Runner Control (IMRC) Stuck Open Bank 1
- P1519 - Intake Manifold Runner Control (IMRC) Stuck Closed Bank 1
- P151A - Intake Manifold Runner Controller Performance
- P1520 - Intake Manifold Runner Control (IMRC) Circuit
- P1537 - Intake Manifold Runner Control (IMRC) Stuck Open (Bank 1)
- P1538 - Intake Manifold Runner Control (IMRC) Stuck Open (Bank 2)
- P1548 - Engine Air Filter Restriction
- P1549 - Intake Manifold Communication Control (IMCC) Circuit (Bank 1)
- P1550 - Power Steering Pressure (PSP) Sensor Out Of Self-Test Range
- P1572 - Brake Pedal Switch Circuit
- P1576 - Pedal Position Not Available
- P1582 - Electronic Throttle Monitor Data Available
- P1633 - Keep Alive Power (KAPWR) Voltage Too Low
- P1635 - Tire/Axle Ratio Out Of Acceptable Range
- P1636 - Inductive Signature Chip Communication Error
- P1639 - Vehicle Id (VID) Block Corrupted, Not Programmed
- P1640 - Powertrain DTCS Available In Another Module
- P1641 - Fuel Pump Primary Circuit
- P1650 - Power Steering Pressure (PSP) Switch Out Of Self-Test Range
- P1651 - Power Steering Pressure (PSP) Switch Input
- P1674 - Control Module Software Corrupted
- P1703 - Brake Switch Out Of Self-Test Range
- P1705 - Transmission Range Sensor Out Of Self-Test Range
- P1709 - Park/Neutral Position (PNP) Switch Out Of Self-Test Range
- P1729 - 4X4L Switch
- P1780 - Transmission Control Switch (TCS) Out Of Self-Test Range
- P1781 - 4X4L Switch Out Of Self-Test Range
- P17XX -
- P18XX -
- P1900 - Output Shaft Speed (OSS) Sensor Circuit Intermittent
- P1901 - Turbine Shaft Speed (TSS) Sensor Circuit Intermittent
- P2004 - Intake Manifold Runner Control (IMRC) Stuck Open (Bank 1)
- P2005 - Intake Manifold Runner Control (IMRC) Stuck Open (Bank 2)
- P2006 - Intake Manifold Runner Control (IMRC) Stuck Closed (Bank 1)
- P2007 - Intake Manifold Runner Control (IMRC) Stuck Closed (Bank 2)
- P2008 - Intake Manifold Runner Control (IMRC) Circuit Open (Bank 1)
- P2014 - Intake Manifold Runner Position Sensor/Switch Circuit (Bank 1)
- P2015 - Intake Manifold Runner Position Sensor/Switch Circuit Range/Performance (Bank 1)
- P2019 - Intake Manifold Runner Position Sensor/Switch Circuit (Bank 2)
- P2020 - Intake Manifold Runner Position Sensor/Switch Circuit Range/Performance (Bank 2)
- P2065 - Fuel Level Sensor B Circuit
- P2066 - Fuel Level Sensor B Circuit Range/Performance
- P2067 - Fuel Level Sensor B Circuit Low
- P2068 - Fuel Level Sensor B Circuit High
- P2070 - Intake Manifold Tuning Valve (IMTV) Stuck Open Bank 1
- P2071 - Intake Manifold Tuning Valve (IMTV) Stuck Closed Bank 1
- P2072 - Throttle Actuator Control (TAC) System - Ice Breakage
- P2100 - Throttle Actuator Control (TAC) Motor Circuit/Open
- P2101 - Throttle Actuator Control (TAC) Motor Range/Performance
- P2104 - Throttle Actuator Control (TAC) System - Forced Idle
- P2105 - Throttle Actuator Control (TAC) System - Forced Engine Shutdown
- P2106 - Throttle Actuator Control (TAC) System - Forced Limited Power
- P2107 - Throttle Actuator Control (TAC) Module Processor
- P2110 - Throttle Actuator Control (TAC) System - Forced Limited Rpm
- P2111 - Throttle Actuator Control (TAC) System - Stuck Open
- P2112 - Throttle Actuator Control (TAC) System - Stuck Closed
- P2121 - Throttle/Pedal Position Sensor/Switch D Circuit Range/Performance
- P2122 - Throttle/Pedal Position Sensor/Switch D Circuit Low
- P2123 - Throttle/Pedal Position Sensor/Switch D Circuit High
- P2126 - Throttle/Pedal Position Sensor/Switch E Circuit Range/Performance
- P2127 - Throttle/Pedal Position Sensor/Switch E Circuit Low
- P2128 - Throttle/Pedal Position Sensor/Switch E Circuit High
- P2131 - Throttle/Pedal Position Sensor/Switch F Circuit Range/Performance
- P2132 - Throttle/Pedal Position Sensor/Switch F Circuit Low
- P2133 - Throttle/Pedal Position Sensor/Switch F Circuit High
- P2135 - Throttle/Pedal Position Sensor/Switch A/B Voltage Correlation
- P2195 - O2 Sensor Signal Biased/Stuck Lean - Bank 1, Sensor 1
- P2196 - O2 Sensor Signal Biased/Stuck Rich - Bank 1, Sensor 1
- P2197 - O2 Sensor Signal Biased/Stuck Lean - Bank 2, Sensor 1
- P2198 - O2 Sensor Signal Biased/Stuck Rich - Bank 2, Sensor 1
- P2257 - Secondary Air Injection (Air) System Control A Circuit Low
- P2258 - Secondary Air Injection (Air) System Control A Circuit High
- P2270 - O2 Sensor Signal Stuck Lean - Bank 1, Sensor 2
- P2271 - O2 Sensor Signal Stuck Rich - Bank 1, Sensor 2
- P2272 - O2 Sensor Signal Stuck Lean - Bank 2, Sensor 2
- P2273 - O2 Sensor Signal Stuck Rich - Bank 2, Sensor 2
- P2274 - O2 Sensor Signal Stuck Lean - Bank 1, Sensor 3
- P2275 - O2 Sensor Signal Stuck Rich - Bank 1, Sensor 3
- P2448 - Secondary Air Injection System High Airflow (Bank 1)
- P260F - Evaporative System Monitoring Processor Performance
- PXXXX -
- U0101 - Lost Communication With Transaxle Control Module (TCM)
- U0121 - Lost Communication With The Anti-Lock Brake System (Abs) Control Module
- U0155 - Lost Communication With Instrument Panel Cluster Control Module
- U0300 - Internal Control Module Software Incompatibility
- U1039 - SCP (J1850) Invalid Or Missing Data For Vehicle Speed
- UXXXX - Network Communication Diagnostic Trouble Code (DTC)
- Engine Controls - Reference Values (Except Diesel & Hybrid)
- Reference Value Symptom Chart
- Reference Value Parameter Identification (PID)/Measured Signal Chart
- Typical Diagnostic Reference Values
- 2.0L 4V Focus
- 2.3L 4V Focus
- 2.3L 4V Fusion/Milan
- 3.0L 4V Fusion/Milan
- 3.0L 4V Five Hundred/Freestyle/Montego
- 3.0L 2V Taurus
- 3.5L 4V MKZ
- 4.0L Mustang
- 4.6L 3V Mustang
- 5.4L 4V Mustang
- 4.6L 2V Crown Victoria/Grand Marquis
- 4.6L 2V Town Car
- 2.3L 4V Escape/Mariner
- 3.0L 4V Escape/Mariner
- 2.3L Ranger
- 3.0L Ranger
- 4.0L Ranger
- 3.5L 4V Edge/MKX
- 3.9L Freestar
- 4.2L Freestar/Monterey
- 4.0L Explorer/Explorer Sport Trac/Mountaineer
- 4.6L 3V Explorer/Explorer Sport Trac/Mountaineer
- 4.2L F-150
- 4.6L 2V F-150
- 5.4L 3V F-150/Mark LT
- 4.6L 2V E-Series
- 5.4L 2V E-Series
- 6.8L 2V E-Series
- 5.4L 3V Expedition/Navigator
- 5.4L 3V F-Super Duty
- 6.8L 3V F-Super Duty
- Engine Controls - Description And Operation (Except Diesel & Hybrid)
- Tune-Up
- Emissions
- General Information
- Abbreviations
- Basic Trouble Shooting
- Basic Trouble Shooting - General Information
- Commonly Used Abbreviations - General Information
- Emission Control Abbreviations
- Engine Performance - Trouble Shooting - General Information
- Brakes
- Anti-Lock Brake Safety Precautions - General Information
- Map - Brake Systems
- Brake Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Accelerometers
- Accumulators
- Anchor Pins
- Anti-Lock Brake Control Assembly(Module)
- Anti-Lock Brake Controller
- Anti-Lock Brake Systems
- Axle Seal
- Backing Plates
- Bleeder Screw
- Brake Abs Active Light (Blue)
- Brake Fluid
- Brake Friction Material
- Brake On - Off Switch
- Brake Pads
- Brake Pedals
- Brake Shoe Hardware
- Brake Shoes
- Brake Stoplight Switches
- Brake Warning Light (Amber)
- Brake Warning Light (Red)
- Bulb Sockets
- Bulbs And LEDS
- Caliper Hardware
- Caliper Mounting Pin
- Caliper Piston
- Caliper Shim
- Caliper Slider Pin (Bolt) Dust Boot
- Caliper Slider Pin (Bolt)
- Calipers
- Combination Valve
- Controllers
- Digital Ratio Axle Controllers And Buffers (Drab And Dram)
- Disable Switches
- Drums
- Electrical Brake Pumps
- Electrical Park Motor
- Electrical Pumps And Motors
- Electro-Magnetic Interference
- Electronic Brake Control Modulator
- Electronic Brake Distribution
- Electronic Brake Traction Control Module
- Electronic Controllers
- Electronic Traction Control
- External Brake Cable
- Flow Control Valve
- Fluid Level Sensor Switches
- Fluid
- Four Wheel Drive Switches
- Friction Material
- G Sensors
- Gaskets
- Gravitational Switches
- Grease Seal
- Height Sensing Proportioning Valve
- High Pressure Accumulator
- Hoses
- Hub
- Hydraulic Control Unit
- Hydraulic Modulators
- Hydro-Boosters
- Hydro-Electric Boosters (POWERMASTER)
- Ignition Disable Switches
- Lamp Driver Relay
- Lateral Acceleration Switches
- LEDS
- Lenses
- Low Pressure Accumulator
- Lug Nut
- Master Cylinder Cover Gasket
- Master Cylinders
- Modulators
- Motor Pack
- Motors
- Pads
- Parking Brake Cable
- Parking Brake Mechanism
- Parking Brake Shoes
- Parking Brake Switches
- Parking Brake Systems
- Pedal Travel Switches
- Pedals
- Power Distribution Center
- POWERMASTER
- Pressure Differential Switches
- Pressure Switches
- Pressure Transducers
- Proportioning Valve
- Pumps
- Relays
- RELUCTOR (Speed) Ring
- Rotors
- Self-Adjusting Systems
- Shoe Hardware
- Shoes
- Sockets
- Speed Sensor (RELUCTOR) Ring
- Speed Sensors (Electronic Wheel And Vehicle)
- Star Wheel
- Steel Brake Lines
- Stoplight Switches
- Stroke Sensor
- Switches
- Tires
- Tone Ring
- Toothed Rings (Tone Wheel)
- Traction Control System (TCS)
- Transfer Tubes
- Vacuum Boosters
- Vacuum Hoses
- Valves
- Wear Indicator
- Wheel Attachment Hardware
- Wheel Bearings, Races And Seals
- Wheel Cylinders
- Wiring Harnesses
- Yaw Rate Sensor
- Brake System CHECKSHEET
- Reason Code Explanation
- Automotive Terminology & Definitions
- Brake Systems
- Map - Routine Inspection Reference Guide
- Routine Inspection Reference Guide
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Maintenance Overview
- Antifreeze/Coolant
- Visual Inspection
- Radiator Cap Test
- Engine Fan
- Cooling System Power Flush And Refill
- Belts (Except Timing Belts)
- Belt TENSIONER
- Automatic Transmission Fluid
- Automatic Transmission Fluid Exchange & Filter Replacement
- Engine Oil
- Air Filters
- Cabin Air Filter
- Brake Fluid
- Battery
- Battery Cables
- Power Steering
- Power Steering Fluid
- Wiper Blades
- Routine Inspection CHECKSHEET
- Routine Inspection - UICS
- Brake Systems
- Drivetrain And Transmission
- Notes
- Automatic Transmission Fluid
- Clutch Master Cylinders
- Cooler Lines
- Coolers
- Differential Fluid
- Drain Plugs And Gaskets
- Filters And Screens
- Fluids And Lubricants
- Hoses, Lines, And Tubes
- Hydraulic Fluid
- Lubricants
- Manual Transmission Fluid
- Mounts (Engine, Transaxle And Transmission)
- Transfer Case Fluid
- Vacuum Hoses
- Electrical Systems
- Engine Performance And Maintenance
- Notes
- Accessory Belts
- Air Filter Elements
- Air Filter Gaskets
- Air Filter Housings And Gaskets
- Air Pump Belts
- Batteries
- Battery Connectors
- Belt Idler Assemblies (Accessory And Cam Belts)
- Belt TENSIONERS (Accessory And Cam Belt)
- Chemical Engine DECARBONIZATION
- Combustion Chamber Cleaning
- Coolant Recovery Tanks
- Coolant
- Distributor Caps
- Distributor Rotors
- Engine Cooling Systems
- Engine DECARBONIZATION
- Engine Oil Drain Plugs And Gaskets
- Engine Oil Filters And Canisters
- Engine Oil
- Fuel Filters
- Fuel Injector Cleaning
- Fuel Injectors
- Fuel System Cleaning Service
- Hose Clamps
- Hose Connectors
- Hose Couplers
- Hoses And Tubes (Fuel Lines, Radiator, Vacuum, By-Pass, Heater, Recovery Tank And Oil Coolers)
- Ignition Wires (Secondary)
- Intake Cleaning
- O2 Sensors
- PCV Breather Elements
- PCV Valves
- Radiator Caps And Pressurized Expansion Tank Caps
- Spark Plugs
- Thermostats And Housings
- Throttle Body Cleaning
- Timing Belts
- Vacuum Hoses, Tubes And Connections (Non-Metallic)
- Exhaust Systems
- Heating, Ventilation And Air Conditioning Systems
- Steering And Suspension, Wheel Alignment, Wheels And Tires
- Wheel & Tire Supplement
- Reason Code Explanation
- Automotive Terminology & Definitions
- Routine Inspection Reference Guide
- Check Lists
- OBD-II Drive Cycles
- 1996-99 Gasoline Models (Except Villager)
- 1996 Villager
- 1997-99 Villager
- 2000-04 Gasoline Models
- 2005-09 Gasoline Models
- 2010-12 Gasoline Models (Except Fiesta)
- 2011-12 Fiesta
- 2003-07 6.0L Diesel
- 2008-10 6.4L Diesel
- 2011-12 6.7L Diesel
- 1996-03 7.3L Diesel
- 2005-09 Hybrid
- 2005-12 Escape Hybrid
- 2011-12 Fusion Hybrid
- Driveline/Axles
- Drive Axle Noise Diagnosis - General Information
- Gear Tooth Contact Patterns - General Information
- Map - Drive Train & Transmission
- Drive Train & Transmission Systems
- Drivetrain And Transmission
- Notes
- Actuators (Electrical)
- Actuators (Vacuum)
- Automatic Transmission / Transaxle Assemblies/CVTS
- Automatic Transmission Fluid
- Axles
- Bearings And Races
- Bell Cranks
- Bell Housings
- Bushings (External)
- Cables (Speedometer)
- Cables (TV, Detent And Shift)
- Carrier Bearings
- Clutch Cables And Cable Housings
- Clutch Discs (Manual Transmissions)
- Clutch Forks
- Clutch Linkages (Mechanical)
- Clutch Master Cylinders
- Clutch Pedals
- Clutch Pivots
- Clutch Pressure Plates
- Clutch Release Bearings
- Clutch Slave Cylinders (Concentric)
- Clutch Slave Cylinders (Conventional Or External)
- Companion Flanges
- Connectors
- Cooler Bypass Valves
- Cooler Lines
- Coolers
- CV Joints
- Differential And Final Drive Assemblies
- Differential Fluid
- Dip Stick Tubes
- Dip Sticks (Fluid Level Indicators)
- Dowel Pins, Guides And Pilot Holes
- Drain Plugs And Gaskets
- Drive Shaft Flanges
- Drive Shafts And Half Shafts
- Dust Boots
- Engine Mounts
- Exciter Rings
- Filler Tubes
- Filters And Screens
- Flanges
- Flex Plates
- Fluid Level Indicators
- Fluids And Lubricants
- Flywheels
- Force Motors
- Gaskets
- Guides
- Half Shafts
- Hoses, Lines, And Tubes
- Housings (Bell, Case, Tail(Extension) And Auxiliary)
- Hydraulic Fluid
- Intermediate Shaft Support Bearings
- Key Interlock Systems
- Limited Slips
- Lines
- Linkages (External)
- Locking Hub Assemblies
- Locking Hub Control Knobs
- Lubricants
- Manual Transmission Fluid
- Manual Transmission/Transaxle Assemblies
- Metal Clad Seals
- METALASTIC Joints
- Modulator Pins
- Modulators
- Mounts (Engine, Transaxle And Transmission)
- Odometer Drives (Mechanical)
- Odometer Heads (Mechanical)
- Oil Pans
- Pans
- Pilot Holes
- Pressure Plates
- Pressure Switches
- Races
- Rubber Joints (METALASTIC)
- Screens
- Seals (Metal Clad)
- Seals
- Selector Interlock Systems
- Sensors
- Servos
- Shift Interlock Systems (Selector And Key Interlock Systems)
- Side Covers
- Slip Yokes
- Solenoids
- Speed Sensors (Electronic Wheel And Vehicle)
- Speedometer- Driven Gear Housing
- Speedometer/Odometer Drives (Mechanical)
- Speedometer/Odometer Heads (Mechanical)
- Speedometers/Odometers (Electronic)
- Switches
- Tone Wheels
- Toothed Rings (Tone Wheel)
- Torque Converters
- Transaxle Mounts
- Transducers (Transmission)
- Transfer Case Assemblies
- Transfer Case Fluid
- Transmission Coolers
- Transmission Mounts
- Transmission Pans
- Transmission Range Indicators (PRNDL)
- Tubes
- Universal Joints (CARDAN Or Cross Type)
- Vacuum Controls
- Vacuum Hoses
- Vacuum Motors
- Vacuum-Operated Switches
- Vehicle Speed Sensors
- Vents
- Vibration Dampers
- Wheel Attachment Hardware
- Wheel Speed Sensors
- Wiring Harnesses And Connectors
- Yokes And Slip Yokes
- Reason Code Explanation
- Automotive Terminology & Definitions
- Trouble Shooting - Clutches - General Information
- DTC Index
- Anti-Lock Brakes DTCS
- Anti-Theft System (Perimeter) DTCS
- Anti-Theft System (Pats) DTCS
- Automatic Transaxle / Transmission DTCS
- Charging System DTCS
- Entertainment System DTCS
- Horn DTCS
- Instrument Cluster DTCS
- Lighting DTCS
- MULTIFUNCTION Electronic Modules DTCS (A0278282)
- Power Door Locks & Remote Keyless Entry Systems DTCS
- Self-Diagnostics DTCS
- Supplemental Restraint System DTCS
- Warning Devices DTCS
- Wiper/Washers DTCS A00316593
- Electrical
- Map - Electrical Systems
- Electrical Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Actuator Motors (Electric)
- Actuator Motors (Vacuum)
- Air Bags
- Alternators And Generators
- Amplifiers
- Antennas
- Batteries
- Battery Cables, Wires And Connectors
- Battery Cables
- Battery Trays And Hold Down Hardware
- Battery Wires
- Belts
- Bulb Sockets
- Bulbs, Sealed Beams And LEDS
- Cd Players
- Cigarette Lighter Assemblies
- Circuit Breakers
- Clutch Switches
- Connectors
- Control Modules
- Cruise Control Brake Switches
- Cruise Control Cables
- Cruise Control Clutch Switches
- Cruise Control Linkages And Cables
- Cruise Control Reservoirs
- Cruise Control Tubes
- Cruise Control Vacuum Dump Release Valves
- Cruise Control Vacuum Hoses, Tubes And
- Cruise Control Vehicle Speed Sensors
- Defoggers
- Defrosters
- Delays
- Dimmers
- Electric Heaters
- Equalizers
- Fuse Blocks
- Fuse Boxes And Blocks
- Fuses, Fusible Links And Circuit Breakers
- Fusible Links
- Gauges
- Generators
- Ground Cables And Straps
- Ground Straps
- Headlight Adjusters
- Heating Elements (Defrosters, Defoggers, Electric Heaters And Seats)
- Horns And Sirens
- Ignition Switches
- Indicator Lights
- Keyless Entry Keypads And Transmitters
- Keyless Entry Transmitters
- LEDS
- Lenses
- Microphones
- Mirrors (ELECTROCHROMATIC And Heated)
- Motors
- Neutral Safety Switches
- Odometers, Speedometers And Tachometers (Cable Driven)
- Odometers
- Power Distribution Center
- Pulleys
- Receivers, Amplifiers, Equalizers And Sub-Woofer Volume Controls
- Relay Boxes
- Relays
- Sealed Beams
- Seat Heaters
- Security Alarm Sensors
- Sirens
- Solenoids
- Speakers And Microphones
- Speedometer And Tachometer Linkages And Cables
- Speedometer Cables
- Speedometers
- Starters
- Sub-Woofer Volume Control
- Switches
- Tachometer Cables
- Tachometers
- Tape Players And Cd Players
- TENSIONERS
- Timers
- Transceivers
- Transducers
- Vacuum Accumulators (Reservoirs)
- Voltage Regulators
- Washer Fluid Level Senders
- Washer Pumps
- Wiper Arms And Blades
- Wiper Blades
- Wiper Hoses And Nozzles
- Wiper Linkages
- Wiper Nozzles
- Wiper Pump Reservoirs
- Wiring Harnesses And Connectors
- Battery, Starting & Charging System CHECKSHEET
- Reason Code Explanation
- Automotive Terminology & Definitions
- Electrical Systems
- Using lemon2025'S System Wiring Diagrams
- Map - Electrical Systems
- Engine
- Engine Overhaul Procedures - General Information
- * Please Read This First *
- Description
- Engine Identification
- Inspection Procedures
- Cleaning Procedures
- Component Cleaning
- Cylinder Head Replacement
- Cylinder Head Overhaul
- Pistons, Connecting Rods & Bearings
- Crankshaft & Main Bearings
- Camshaft
- Timing Chains & Belts
- Timing Gears
- Oil Pump
- Break-In Procedure
- General Cooling System Service - General Information
- Engine Overhaul Procedures - General Information
- Engine Performance
- Electrostatic Discharge Warning - General Information
- Engine Performance Diagnostic Routine Outline - General Information
- Engine Performance Safety Precautions
- Map - Engine Performance & Maintenance
- Engine Performance And Maintenance (Including Exhaust Systems)
- Engine Performance & Maintenance CHECKSHEET
- Engine Performance And Maintenance
- Notes
- Accelerator Pedal Position Sensor
- Accessory Belts
- Accessory Pulleys
- Air Conditioning Cycling Switches
- Air Conditioning Pressure Sensors
- Air Ducts And Tubes
- Air Filter Elements
- Air Filter Gaskets
- Air Filter Housings And Gaskets
- Air Fuel Ratio Sensors
- Air Injection Control Solenoids
- Air Plenums
- Air Pump Belts
- Air Pumps (Electric Driven)
- Air Tubes
- Aspirator, Check And DECEL Valves
- Baffles
- Ballast Primary Supply Resistor Wires
- Ballast Resistors And Primary Supply Resistors
- Barometric Pressure Sensors
- Batteries
- Battery Cables, Wires And Connectors
- Battery Connectors
- Battery Trays And Hold Down Hardware
- Battery Wires
- Belt Idler Assemblies (Accessory And Cam Belts)
- Belt TENSIONERS (Accessory And Cam Belt)
- Belt-Driven Air Pumps
- Boost Control Mechanism
- Camshaft Position Sensors
- Carburetors And Chokes
- Casting Core Plugs And Expansion Plugs
- Charge Air Coolers ""INTERCOOLERS"" (CAC)
- Check Valves
- Chemical Engine DECARBONIZATION
- Chokes
- Clutch Pedal Position Switches
- Cold Start Injectors
- Combustion Chamber Cleaning
- Connectors
- Coolant Recovery Tanks
- Coolant
- Cooling Fan Motor Modules
- Cooling Fan Motor Relays And Modules
- Cooling Fan Motor Resistors
- Cooling Fan Motor Sensors And Switches
- Cooling Fan Motor Switches
- Cooling Fan Motors
- Crankshaft Position Sensors
- Cylinder Deactivation Solenoid
- Cylinder Head Assemblies
- DECEL Valves
- Deflectors
- Dip Stick Tubes
- Dip Sticks And Tubes
- Distributor Advances And Retarders (Mechanical And Vacuum)
- Distributor Boots And Shields
- Distributor Caps
- Distributor Retarders (Mechanical And Vacuum)
- Distributor Rotors
- Distributor Shields
- Distributors
- Early Fuel Evaporation Valves (Heat Riser Assemblies)
- EGR Coolers
- EGR Exhaust Manifold Passages
- EGR Intake And Exhaust Manifold Passages
- EGR Plates And Coolers
- Electronic Spark Control Modules
- Electronic Transmission Control Devices
- Electronic Transmission Feedback Devices
- Engine Coolant Temperature Sensors
- Engine Cooling Systems
- Engine Covers (Oil Pan, Valve Cover, Timing Cover)
- Engine DECARBONIZATION
- Engine Oil Canisters
- Engine Oil Coolers (External)
- Engine Oil Drain Plugs And Gaskets
- Engine Oil Filters And Canisters
- Engine Oil Gaskets
- Engine Oil Pressure Gauges (Mechanical)
- Engine Oil
- Evaporative Emissions (EVAP) Canister Filters
- Evaporative Emissions (EVAP) Canister Purge Devices
- Evaporative Emissions (EVAP) Canisters
- Evaporative Emissions (EVAP) Feedback Devices
- Exhaust Gas RECIRCULATION Devices
- Exhaust Gas RECIRCULATION Feedback Devices
- Expansion Plugs
- Fan Control Sensor
- Fuel Accumulators And Dampers
- Fuel And Cold Start Injectors
- Fuel Caps
- Fuel Dampers
- Fuel Delivery Check Valves
- Fuel Distributors (BOSCH Cis)
- Fuel Filler Necks And RESTRICTORS
- Fuel Filters
- Fuel Injector Cleaning
- Fuel Injectors
- Fuel Level Senders
- Fuel Pressure Regulators
- Fuel Pumps (In-Tank, External, Electrical Or Mechanical)
- Fuel Rails
- Fuel RESTRICTORS
- Fuel System Cleaning Service
- Fuel Tanks
- Fuel
- Gaskets
- Grommets (Valve Cover)
- Harmonic Dampers
- Heater Control Valves
- Heater Cores
- Hose Clamps
- Hose Connectors
- Hose Couplers
- Hoses And Tube Couplers, Connectors And Clamps
- Hoses And Tubes (Fuel Lines, Radiator, Vacuum, By-Pass, Heater, Recovery Tank And Oil Coolers)
- Housings
- Idle Air Controls
- Idle Speed Control Actuators
- Ignition Boots
- Ignition Coil Towers
- Ignition Coils
- Ignition Control Modules (ICM)
- Ignition Switches
- Ignition Terminals
- Ignition Wires (Secondary)
- Inertia Fuel Shut-Off Switches
- Intake Air Temperature Sensors
- Intake Cleaning
- Intake Manifolds
- In-Tank Fuel Strainers
- INTERCOOLERS
- Knock Sensors
- Liquid Vapor Separators
- Long Block Assemblies
- Manifold Absolute Pressure (Map) Sensors
- Mass Air Flow (MAF) Sensors
- Metal Air Manifolds And Pipes
- Metal Air Pipes
- Mix Control Solenoids
- Motor Mounts
- O2 Sensors
- Oil Pans
- Oil Pressure Sending Units
- Oil Pump Pick-Up Screens
- Oil Pumps
- O-Rings, Gaskets, Seals And Spring Locks
- Park Neutral Position Switches
- PCV Breather Elements
- PCV Orifices
- PCV Valves
- Pick-Up Assemblies (Includes Magnetic, Hall Effect And Optical)
- Power Steering Pressure Sensors
- Powertrain Control Modules (Pcm) And Prom
- Powertrain Control Prom
- Pressurized Expansion Tank Caps
- Radiator / Cooling Fan Blades
- Radiator / Cooling Fan Clutches
- Radiator Caps And Pressurized Expansion Tank Caps
- Radiators
- Roll Over Valves
- Sealing Compounds
- Seals
- Secondary Air Injection System Management Devices
- Sensors
- Short Block Assemblies
- Shrouds, Baffles And Deflectors
- Spark Plugs
- Spring Locks
- Super Chargers
- Switches
- Thermal Vacuum Valves
- Thermostatic Air Door Assemblies
- Thermostats And Housings
- Throttle Bodies
- Throttle Body Cleaning
- Throttle Cables
- Throttle Linkages And Cables
- Throttle Position Sensors
- Throttle Position Switches
- Timing Belt Sprockets
- Timing Belts
- Timing Covers
- Torque Struts
- Transmission Range Switches
- Tube Clamps
- Tube Connectors
- Tube Couplers
- Tubes
- Turbo Chargers
- Vacuum Connections
- Vacuum Hoses, Tubes And Connections (Non-Metallic)
- Vacuum Regulator Solenoids
- Vacuum Tubes
- Valve Covers
- Vehicle Speed Senors
- Volume Air Flow Sensors
- Waste Gate And Boost Control Mechanisms
- Waste Gate Control Solenoids
- Water Pumps (Electric)
- Water Pumps (Non-Electric)
- Wiring Harnesses And Connectors
- Reason Code Explanation
- Automotive Terminology & Definitions
- Parasitic Load Explanation & Test Procedures - General Information
- State Emission Standards - Diesel
- State Emission Standards - Gas
- ALASKA
- ARIZONA
- CALIFORNIA
- Colorado
- CONNECTICUT
- DELAWARE
- District Of COLUMBIA
- GEORGIA
- IDAHO
- ILLINOIS
- INDIANA
- KENTUCKY
- MARYLAND
- MASSACHUSETTS
- MISSOURI
- NEVADA
- New Jersey
- New MEXICO
- New YORK
- North CAROLINA
- OHIO
- OREGON
- PENNSYLVANIA
- RHODE Island
- TENNESSEE
- TEXAS
- UTAH
- VIRGINIA
- WASHINGTON
- WISCONSIN
- U. S. EPA ASM2525 & ASM5015 Start-Up Emission Standards
- U. S. EPA Revised Final ASM Emission Standards (ASM5015 & ASM2525)
- U.S. EPA Im240 Emission Standards
- Waveforms - Injector Pattern Tutorial - General Information
- * Please Read This First *
- Purpose Of This Article
- Is A Lab Scope Necessary?
- The Two Types Of Injector Drivers
- The Two Ways Injector Circuits Are Wired
- Interpreting Injector Waveforms
- Current Waveform Samples
- Notes
- Example #1 - Voltage Controlled Driver
- Example #2 - Voltage Controlled Driver
- Example #3 - Voltage Controlled Driver
- Example #4 - Current Controlled Driver
- Example #5 - Current Controlled Driver
- Example #6 - Current Controlled Driver
- Example #7 - Current Controlled Driver
- Example #8 - Current Controlled Driver
- Voltage Waveform Samples
- Notes
- Example #1 - Voltage Controlled Driver
- Example #2 - Voltage Controlled Driver
- Example #3 - Voltage Controlled Driver
- Example #4 - Current Controlled Driver
- Example #5 - Current Controlled Driver
- Example #6 - Current Controlled Driver
- Example #7 - Current Controlled Driver
- Example #8 - Current Controlled Driver
- Map - Exhaust Systems
- Exhaust Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Catalytic Converters
- Exhaust And Tail Pipes
- Exhaust Connections
- Hangers
- Heat Risers (Mechanical EFE Devices)
- Heat Shields
- Manifolds (Cast And Tube Type)
- Mechanical EFE Devices
- Muffler Valve
- Mufflers And Resonators
- Reason Code Explanation
- Exhaust Systems
- Heating, Ventilation & A/C (HVAC)
- Map - Heating, Ventilation, & Air Conditioning
- Heating, Ventilation & Air Conditioning Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Accumulators
- Actuators (Electrical)
- Actuators (Vacuum)
- Air Conditioning Fittings
- Air Conditioning Hoses
- Air Conditioning Metal Lines
- Air Control Doors
- Air Dams (External)
- Air Distribution System
- Belts
- Blend Doors
- Blower Fans (Blower Wheel Or Squirrel Cage)
- Blower Motors
- Blower Resistors
- Blower Switches
- Cabin Air Filters
- Circuit Breakers
- Compressor Clutch Assemblies
- Compressors
- Condenser Air Seals
- Condenser Fan Motors
- Condensers
- Connectors
- Control Cables
- Control Heads (Function Selectors)
- Control Linkages
- Control Modules
- Coolant
- Cooling Fan Blades
- Cooling Fan Clutches
- Cooling Fan Motors
- Evaporator Drain Tubes
- Evaporator Filters
- Evaporator Pressure Regulators (EPRS)
- Evaporators
- Expansion Valves
- Function Selectors
- Fuses, Fusible Links And Circuit Breakers
- Fusible Links
- Gaskets
- Heater Cases
- Heater Control Valves
- Heater Cores
- Heater Hoses
- High Pressure Relief Valves (HPRV)
- Idlers
- In-Line Filters
- Metal Fittings
- Metal Lines
- Mix And Air Control Doors (Blend Doors)
- ORIFACE Tubes
- O-Rings
- Pilot-Operated Absolutes (POAS)
- Plenums
- Pressure Control Valves
- Pressure Sensors
- Pulleys
- Radiators
- Receiver-DRIERS
- Refrigerant Oil
- Refrigerant
- Relays
- Seals
- Service Ports
- Spring Lock Couplings
- Suction Throttling Valves (STVS)
- Switches (Electrical)
- TENSIONERS
- Thermistors And Pressure Sensors
- Thermostats And Housings
- Vacuum Hoses And Tubes
- Vacuum Reservoirs
- Vacuum Tubes
- Valves In Receiver (VIRS)
- Water Pumps (Electric Auxiliary)
- Wiring Harnesses And Connectors
- Heating, Ventilation & Air Conditioning System CHECKSHEET
- Reason Code Explanation
- Automotive Terminology & Definitions
- Heating, Ventilation & Air Conditioning Systems
- Map - Heating, Ventilation, & Air Conditioning
- Hoist/Jack
- Identification
- Metric Conversions
- OEM General Information
- Automatic Stop/Start Disable
- Identification Codes
- Jacking And Lifting
- Noise, Vibration And Harshness
- Description And Operation
- Diagnostic Tests
- Noise, Vibration and Harshness (NVH)
- Notes
- 1: Customer Interview
- 2: Pre-Drive Check
- 3: Preparing for the Road Test
- 4: Verify the Customer Concern
- 5: Road Test
- 6: Check OASIS/TSBs/Repair History
- 7: Diagnostic Procedure
- NVH Condition and Symptom Categories
- Symptom Charts
- Pinpoint Tests
- Notes
- Pinpoint Test A: Brake Vibration/Shudder
- Pinpoint Test B: Engine Ticking Noise
- Pinpoint Test C: Accessory Drive Bearing Hoot
- Pinpoint Test D: Power Steering Moan
- Pinpoint Test E: Engine Driven Cooling Fan Moan
- Pinpoint Test F: Drumming Noise
- Pinpoint Test G: Engine Ticking, Knocking Or Continuous Rattle Diagnosis
- Pinpoint Test H: Front Suspension Noise
- Pinpoint Test I: Rear Suspension Noise
- Pinpoint Test J: Wheel And Tire Vibration
- Pinpoint Test K: High Speed Shake Or Shimmy
- Pinpoint Test L: Clutch Vibration
- Component Tests
- Noise, Vibration and Harshness (NVH)
- General Procedures
- Reset Procedures
- BARTEC TPMS Reset Procedure
- Maintenance Reminder Light (Reset Procedures)
- A/C Filter Service Reminder
- Engine Oil Replacement Reminder
- Notes
- Engine Oil Replacement Reminder Reset - Procedure 01
- Engine Oil Replacement Reminder Reset - Procedure 02
- Engine Oil Replacement Reminder Reset - Procedure 03
- Engine Oil Replacement Reminder Reset - Procedure 04
- Engine Oil Replacement Reminder Reset - Procedure 05
- Engine Oil Replacement Reminder Reset - Procedure 06
- Engine Oil Replacement Reminder Reset - Procedure 07
- Engine Oil Replacement Reminder Reset - Procedure 08
- Engine Oil Replacement Reminder Reset - Procedure 09
- Engine Oil Replacement Reminder Reset - Procedure 10
- Engine Oil Replacement Reminder Reset - Procedure 11
- Engine Oil Replacement Reminder Reset - Procedure 12
- Engine Oil Replacement Reminder Reset - Procedure 13
- Engine Oil Replacement Reminder Reset - Procedure 14
- Engine Oil Replacement Reminder Reset - Procedure 15
- Engine Oil Replacement Reminder Reset - Procedure 16
- Engine Oil Replacement Reminder Reset - Procedure 17
- Engine Oil Replacement Reminder Reset - Procedure 18
- Engine Oil Replacement Reminder Reset - Procedure 19
- Engine Oil Replacement Reminder Reset - Procedure 20
- Engine Oil Replacement Reminder Reset - Procedure 21
- Engine Oil Replacement Reminder Reset - Procedure 22
- Engine Oil Replacement Reminder Reset - Procedure 23
- Engine Oil Replacement Reminder Reset - Procedure 24
- Engine Oil Replacement Reminder Reset - Procedure 25
- Engine Oil Replacement Reminder Reset - Procedure 26
- Engine Oil Replacement Reminder Reset - Procedure 27
- Engine Oil Replacement Reminder Reset - Procedure 28
- Maintenance Service Reminder (Overhead Warning Lights)
- Maintenance Service Reminder (Sri)
- Maintenance Service Reminder (VMM)
- Tire Pressure Monitor System Reminder
- Notes
- Tire Pressure Sensor Types
- TPMS Reminder Reset - Procedure 01
- TPMS Reminder Reset - Procedure 02
- TPMS Reminder Reset - Procedure 03
- TPMS Reminder Reset - Procedure 04
- TPMS Reminder Reset - Procedure 05
- TPMS Reminder Reset - Procedure 07
- TPMS Reminder Reset - Procedure 08
- TPMS Reminder Reset - Procedure 09
- TPMS Reminder Reset - Procedure 10
- Specifications Index
- Steering
- Map - Steering, Suspension, Wheel Alignment, Wheels & Tires
- Steering & Suspension Systems
- Wheel And Tire
- Steering & Suspension CHECKSHEET
- Wheels & Tires CHECKSHEET
- Steering And Suspension, Wheel Alignment, Wheels And Tires
- Notes
- Active Handling
- Active Suspension Control Modules
- Active Variable Ratio Steering
- Active Yaw Control
- Adaptive Cruise Control
- Advance TRAC
- Air Bags
- Air Ride Control Modules
- Air Ride Suspension Torsion Springs (Counter Balancing)
- Air Ride Suspension
- Air Ride Tubes
- Air Shocks And Air Struts
- Air Spring Valves
- Air Springs
- Air Suspension Control Valves
- Air Suspension DRIERS
- Axle Acceleration Sensor
- Ball Joints
- Body Acceleration Sensor
- Bushings
- Center Links
- Compressors
- Continuous Damping Control
- Control Arm Shafts
- Control Arms
- Control Modules
- Distance Regulation Control Module
- Distance Regulation Sensor
- Drag Links
- Dynamic Stability Control
- Dynamic Stability Traction Control
- Electronic Ride Control Shocks And Struts
- Electronic Stability Control
- Electronic Suspension System
- Flex Couplers
- Gaskets
- Height Sensors
- Hydraulic Hoses
- Hydraulic Power Steering Pumps
- Hydraulic Suspension Hoses
- Hydraulic Suspension Pumps
- Idler Arms
- Intermediate Shaft U-Joints
- King Pins
- Modules
- Pitman Arms
- Power Steering Belts
- Power Steering Coolers
- Power Steering Fluid
- Power Steering Hoses
- Power Steering Lines (Steel)
- Power Steering Pumps - Electric
- Power Steering Pumps
- Radar Sensor
- Radius Arms
- Relay Rods
- Relays
- Sensors
- Shock Absorbers, Strut Cartridges And Strut Assemblies
- Spindles
- Springs, Coil, Leaf And Torsion Bars
- STABILITRAC
- Stability Management System
- Steering Angle Sensor
- Steering Arms
- Steering Couplers
- Steering Dampers
- Steering Gears (Except Rack And Pinion)
- Steering Gears, Rack And Pinion
- Steering Knuckles
- Strike Out Bumpers
- Strut Bearing Plate Assemblies
- Strut Rods
- Suspension Pumps (Hydraulic)
- Sway Bar Links
- Sway Bar Mounting Bushings
- Sway Bars
- Switches
- Tie Rod Ends (Inner And Outer)
- Tire Pressure Monitoring System
- Tire Pressure Sensors
- Tires
- Torque Sensor
- Torsion Springs
- Track Bar Bushings
- Track Bars
- Trailing Arm Bushings
- Trailing Arms
- Valve Stems
- Vehicle Dynamics Control
- Vehicle Speed Sensor
- Vehicle Stability Assist
- Vehicle Stability/Skid Control
- Warning Lamps
- Wheel Alignment
- Wheel Attachment Hardware
- Wheel Bearings, Races And Seals
- Wheels (Rims)
- Wiring Harnesses And Connectors
- Reason Code Explanation
- Automotive Terminology & Definitions
- Wheel Alignment Theory & Operation - General Information
- Map - Steering, Suspension, Wheel Alignment, Wheels & Tires
- Traction Control Disable Procedures
- Trouble Shooting - Manual Transmission - General Information
- Heating, Ventilation & A/C (HVAC)
- General Servicing
- HVAC Control Systems
- Climate Control
- Specifications
- Description And Operation
- Removal And Installation
- Air Conditioning (A/C) Compressor
- Air Conditioning (A/C) Compressor Shaft Seal
- Air Inlet Duct
- Blower Motor
- Blower Motor Resistor
- Blower Motor Switch
- Climate Control Assembly
- Clutch and Clutch Field Coil
- Compressor Manifold and Tube Assembly
- Condenser Core
- Condenser to Evaporator Line
- Evaporator Core Orifice
- Function Selector Switch
- Heater Core
- Heater Core And Evaporator Core Housing
- Mode Door Actuator - Air Inlet Door
- Register - Driver Side
- Suction Accumulator
- Temperature Control Switch
- Climate Control System - General Information And Diagnostics
- Specifications
- Description And Operation
- Diagnostic Tests
- Climate Control System
- Notes
- Inspection and Verification
- Symptom Chart
- Pinpoint Tests
- Pinpoint Test A: The Blower Motor Is Inoperative
- Pinpoint Test B: The Blower Motor Does Not Operate Correctly
- Pinpoint Test C: The Air Conditioning (A/C) Is Inoperative/Does Not Operate Correctly
- Pinpoint Test D: The Air Conditioning (A/C) Is Inoperative - Defrost And Floor/Defrost Modes Only
- Pinpoint Test E: The Air Conditioning (A/C) Is Always On
- Pinpoint Test F: The Air Inlet Door Is Inoperative
- Pinpoint Test G: Air Conditioning (A/C) and Recirc Modes Are Inoperative
- Pinpoint Test H: Temperature Control/Function Selector Is Inoperative
- Component Tests
- Climate Control System
- General Procedures
- Spring Lock Coupling
- Air Conditioning Line (Peanut) Fitting
- Refrigerant System Tests
- Air Conditioning (A/C) Clutch Air Gap Adjustment
- Manifold Gauge Set Connection
- Electronic Leak Detection
- Fluorescent Dye Leak Detection
- Air Conditioning (A/C) System Flushing
- Air Conditioning (A/C) System Recovery, Evacuation and Charging
- Refrigerant System Filtering Following Air Conditioning (A/C) Compressor Installation
- Refrigerant Oil Adding
- Refrigerant Identification Testing
- Air Conditioning (A/C) Odor Treatment
- Climate Control
- Maintenance
- Procedures
- Maintenance Reminder Light (Reset Procedures)
- A/C Filter Service Reminder
- Engine Oil Replacement Reminder
- Notes
- Engine Oil Replacement Reminder Reset - Procedure 01
- Engine Oil Replacement Reminder Reset - Procedure 02
- Engine Oil Replacement Reminder Reset - Procedure 03
- Engine Oil Replacement Reminder Reset - Procedure 04
- Engine Oil Replacement Reminder Reset - Procedure 05
- Engine Oil Replacement Reminder Reset - Procedure 06
- Engine Oil Replacement Reminder Reset - Procedure 07
- Engine Oil Replacement Reminder Reset - Procedure 08
- Engine Oil Replacement Reminder Reset - Procedure 09
- Engine Oil Replacement Reminder Reset - Procedure 10
- Engine Oil Replacement Reminder Reset - Procedure 11
- Engine Oil Replacement Reminder Reset - Procedure 12
- Engine Oil Replacement Reminder Reset - Procedure 13
- Engine Oil Replacement Reminder Reset - Procedure 14
- Engine Oil Replacement Reminder Reset - Procedure 15
- Engine Oil Replacement Reminder Reset - Procedure 16
- Engine Oil Replacement Reminder Reset - Procedure 17
- Engine Oil Replacement Reminder Reset - Procedure 18
- Engine Oil Replacement Reminder Reset - Procedure 19
- Engine Oil Replacement Reminder Reset - Procedure 20
- Engine Oil Replacement Reminder Reset - Procedure 21
- Engine Oil Replacement Reminder Reset - Procedure 22
- Engine Oil Replacement Reminder Reset - Procedure 23
- Engine Oil Replacement Reminder Reset - Procedure 24
- Engine Oil Replacement Reminder Reset - Procedure 25
- Engine Oil Replacement Reminder Reset - Procedure 26
- Engine Oil Replacement Reminder Reset - Procedure 27
- Engine Oil Replacement Reminder Reset - Procedure 28
- Maintenance Service Reminder (Overhead Warning Lights)
- Maintenance Service Reminder (Sri)
- Maintenance Service Reminder (VMM)
- Tire Pressure Monitor System Reminder
- Notes
- Tire Pressure Sensor Types
- TPMS Reminder Reset - Procedure 01
- TPMS Reminder Reset - Procedure 02
- TPMS Reminder Reset - Procedure 03
- TPMS Reminder Reset - Procedure 04
- TPMS Reminder Reset - Procedure 05
- TPMS Reminder Reset - Procedure 07
- TPMS Reminder Reset - Procedure 08
- TPMS Reminder Reset - Procedure 09
- TPMS Reminder Reset - Procedure 10
- Maintenance Schedule
- Description And Operation
- Maintenance Schedule - Gasoline Engines
- Notes
- General Maintenance Information
- Special Operating Condition Requirements
- Checks and Services
- Multi-Point Inspection
- In-Line, Service-Installed Transmission Fluid Filter
- Normal Schedule
- Notes
- 8,000 Km (5,000 Miles)
- 16,000 Km (10,000 Miles)
- 24,000 Km (15,000 Miles)
- 32,000 Km (20,000 Miles)
- 40,000 Km (25,000 Miles)
- 48,000 Km (30,000 Miles)
- 56,000 Km (35,000 Miles)
- 64,000 Km (40,000 Miles)
- 72,000 Km (45,000 Miles)
- 80,000 Km (50,000 Miles)
- 88,000 Km (55,000 Miles)
- 96,000 Km (60,000 Miles)
- 104,000 Km (65,000 Miles)
- 112,000 Km (70,000 Miles)
- 120,000 Km (75,000 Miles)
- 128,000 Km (80,000 Miles)
- 136,000 Km (85,000 Miles)
- 144,000 Km (90,000 Miles)
- 152,000 Km (95,000 Miles)
- 160,000 Km (100,000 Miles)
- 168,000 Km (105,000 Miles)
- 176,000 Km (110,000 Miles)
- 184,000 Km (115,000 Miles)
- 192,000 Km (120,000 Miles)
- 200,000 Km (125,000 Miles)
- 208,000 Km (130,000 Miles)
- 216,000 Km (135,000 Miles)
- 224,000 Km (140,000 Miles)
- 232,000 Km (145,000 Miles)
- 240,000 Km (150,000 Miles)
- Exceptions To Normal Schedule
- Maintenance Schedule - Gasoline Engines
- Description And Operation
- Maintenance Reminder Light (Reset Procedures)
- Procedures
- Restraints
- Air Bag, SRS
- Supplemental Inflatable Restraint System
- Specifications
- Description And Operation
- Air Bag and Safety Belt Pretensioner Supplemental Restraint System (SRS)
- Notes
- Clockspring
- Driver Air Bag Module
- Electrical System
- High Speed Controller Area Network (HS-CAN)
- Occupant Classification Sensor
- Passenger Air Bag Deactivation (PAD) Indicator
- Passenger Air Bag Module
- Restraints Control Module (RCM)
- Safety Belt Buckle Switches
- Safety Belt Pretensioners
- Safety Belt Tension Sensor
- Seat Track Position Sensor
- Impact Sensors
- Air Bag and Safety Belt Pretensioner Supplemental Restraint System (SRS)
- Diagnostic Tests
- Air Bag and Safety Belt Pretensioner Supplemental Restraint System (SRS)
- Notes
- Restraint System Diagnostic Tool Warning
- Air Bag Module Second Stage Deployment Check
- Diagnosing Customer Concerns With Continuous Memory Diagnostic Trouble Codes (DTCs)
- Diagnosing Customer Concerns With On-Demand Diagnostic Trouble Codes (DTCs)
- Prove Out Procedure
- Glossary
- Secondary Air Bag Warning
- Air Bag/Pretensioner Restraint System Diagnostic Tools
- Disconnect the Component
- Deactivate the Supplemental Restraint System (SRS)
- Depower the Supplemental Restraint System (SRS)
- Prove Out the System
- Reactivate the Supplemental Restraint System (SRS)
- Repower the Supplemental Restraint System (SRS)
- Reconnect the System
- Install a New Component
- Verify the System
- Air Bag Reconnect Checklist
- Diagnostic Instructions - Air Bag and Safety Belt Pretensioner Supplemental Restraint System (SRS)
- Pinpoint Tests - Air Bag and Safety Belt Pretensioner Supplemental Restraint System (SRS)
- Notes
- Restraint System Diagnostic Tool Warning
- Pinpoint Tests
- Pinpoint Test A: The Air Bag Warning Indicator is Illuminated Continuously - RCM Disconnected or Inoperative, Loss of Battery Feed or Loss of Signal Ground
- Pinpoint Test B: DTC B104B - Driver Side Crash Sensor Cross Link to Another Sensor, B104C - Passenger Side Crash Sensor Cross Link to Another Sensor or B104D - Front Crash Sensor Cross Link to Another Sensor
- Pinpoint Test C: DTC B104E - Driver Side Crash Sensor Short to Gnd/VBatt
- Pinpoint Test D: DTC B1047 - Driver Side, Side Mount Air Bag Cross Link to Another Firing Loop
- Pinpoint Test E: DTC B1048 - Passenger Side Air Bag Cross Link to Another Firing Loop
- Pinpoint Test F: DTC B1049 - Passenger Seat Belt Pretensioner Cross Link to Another Firing Loop
- Pinpoint Test G: DTC B1050 - Passenger Side Crash Sensor Short to Gnd/VBatt Fault
- Pinpoint Test H: DTC B1052 - Passenger Seat Belt Buckle Switch Cross Link to Another Sensor
- Pinpoint Test I: DTC B1053 - Driver Seat Belt Buckle Switch Cross Link to Another Sensor
- Pinpoint Test J: DTC B1054 - Driver Seat Belt Pretensioner Cross Link to Another Firing Loop
- Pinpoint Test K: DTC B1055 - Passenger Side, Side Mount Air Bag Cross Link to Another Firing Loop
- Pinpoint Test L: DTC B1057 - Driver Air Bag Cross Link to Another Firing Loop
- Pinpoint Test M: DTC B1058 - Driver Air Bag Cross Link to Another Firing Loop - Loop #2
- Pinpoint Test N: DTC B1059 - Passenger Air Bag Cross Link to Another Firing Loop - Loop #2
- Pinpoint Test O: DTC B1868 - Lamp Air Bag Warning Indicator Circuit Failure
- Pinpoint Test P: DTC B1877/B1885 - Seat Belt Driver Pretensioner Circuit Open Fault/Seat Belt Driver Pretensioner Circuit Resistance Low On Squib Fault
- Pinpoint Test Q: DTC B1878 - Seat Belt Driver Pretensioner Circuit Short to Battery Fault
- Pinpoint Test R: DTC B1879 - Seat Belt Driver Pretensioner Circuit Short to Ground Fault
- Pinpoint Test S: DTC B1881/B1886 - Seat Belt Passenger Pretensioner Circuit Open Fault/Seat Belt Passenger Pretensioner Circuit Resistance Low On Squib Fault
- Pinpoint Test T: DTC B1882 - Seat Belt Passenger Pretensioner Circuit Short to Battery Fault
- Pinpoint Test U: DTC B1883 - Seat Belt Passenger Pretensioner Circuit Short to Ground Fault
- Pinpoint Test V: DTC B1884 - PAD Warning Lamp Circuit Fault
- Pinpoint Test W: DTC B1890 - PAD Warning Lamp Circuit Short to Battery Fault
- Pinpoint Test X: DTC B1916 - Air Bag Driver Circuit Short to Battery Fault
- Pinpoint Test Y: DTC B1921 - Air Bag Diagnostic Monitor Ground Circuit Open
- Pinpoint Test Z: DTC B1925 - Air Bag Passenger Circuit Short to Battery Fault
- Pinpoint Test AA: DTC B1932/B1934 - Air Bag Driver Circuit Open Fault/Air Bag Driver Inflator Circuit Resistance Low On Squib Fault
- Pinpoint Test AB: DTC B1933/ B1935 - Air Bag Passenger Circuit Open Fault/Air Bag Passenger Inflator Circuit Resistance Low On Squib Fault
- Pinpoint Test AC: DTC B1936 - Air Bag Driver Circuit Short to Ground Fault
- Pinpoint Test AD: DTC B1938 - Air Bag Passenger Circuit Short to Ground Fault
- Pinpoint Test AE: DTC B1992 - Driver Side, Side Mount Air Bag Circuit Short to VBatt Fault
- Pinpoint Test AF: DTC B1993 - Driver Side, Side Mount Air Bag Circuit Short to Ground Fault
- Pinpoint Test AG: DTC B1994/B1995 - Driver Side, Side Mount Air Bag Circuit Open Fault/Driver Side, Side Mount Air Bag Circuit Low Resistance On Squib Fault
- Pinpoint Test AH: DTC B1996 - Passenger Side, Side Mount Air Bag Circuit Short to VBatt Fault
- Pinpoint Test AI: DTC B1997 - Passenger Side, Side Mount Air Bag Circuit Short to Ground Fault
- Pinpoint Test AJ: DTC B1998/B1999 - Passenger Side, Side Mount Air Bag Circuit Open Fault/Passenger Side, Side Mount Air Bag Circuit Low Resistance On Squib Fault
- Pinpoint Test AK: DTC B2227 - Front Crash Sensor Driver Communications Fault
- Pinpoint Test AL: DTC B2228 - Air Bag Driver Circuit Short to Ground Loop #2 Fault
- Pinpoint Test AM: DTC B2229 - Air Bag Passenger Circuit Short to Ground Loop #2 Fault
- Pinpoint Test AN: DTC B2230 - Air Bag Driver Circuit Short to Battery Loop #2 Fault
- Pinpoint Test AO: DTC B2231 - Air Bag Passenger Circuit Short to Battery Loop #2 Fault
- Pinpoint Test AP: DTC B2232/ B2234 - Air Bag Driver Circuit Open Fault/Air Bag Driver Inflator Circuit Resistance Low On Squib Loop #2 Fault
- Pinpoint Test AQ: DTC B2233/ B2235 - Air Bag Passenger Circuit Open Fault/Air Bag Inflator Passenger Circuit Resistance Low On Squib Loop #2 Fault
- Pinpoint Test AR: DTC B2290 - Occupant Classification System (OCS) Fault
- Pinpoint Test AS: DTC B2432 - Drivers Seat Belt Buckle Switch Circuit Open Fault
- Pinpoint Test AT: DTC B2433 - Drivers Seat Belt Buckle Switch Circuit Short to Battery Fault
- Pinpoint Test AU: DTC B2434 - Drivers Seat Belt Buckle Switch Circuit Short to Ground Fault
- Pinpoint Test AV: DTC B2435 - Drivers Seat Belt Buckle Switch Resistance Out of Range Fault
- Pinpoint Test AW: DTC B2436 - Passengers Seat Belt Buckle Switch Circuit Open Fault
- Pinpoint Test AX: DTC B2437 - Passengers Seat Belt Buckle Switch Circuit Short to Battery Fault
- Pinpoint Test AY: DTC B2438 - Passengers Seat Belt Buckle Switch Circuit Short to Ground Fault
- Pinpoint Test AZ: DTC B2439 - Passengers Seat Belt Buckle Switch Resistance Out of Range Fault
- Pinpoint Test BA: DTC B2855 - Front Crash Sensor Circuit Short to Gnd/VBatt Fault
- Pinpoint Test BB: DTC B2856 - Front Crash Sensor ID Fault
- Pinpoint Test BC: DTC B2886 - Passenger Side Crash Sensor ID Fault
- Pinpoint Test BD: DTC B2887 - Driver Side Crash Sensor ID Fault
- Pinpoint Test BE: DTC B2909 - Belt Tension Sensor Fault
- Pinpoint Test BF: DTC C1946 - Driver Seat Track Position Sensor Circuit Open Fault
- Pinpoint Test BG: DTC C1947 - Driver Seat Track Position Sensor Circuit Short to Ground Fault
- Pinpoint Test BH: DTC C1948 - Driver Seat Track Position Sensor Circuit Resistance Out of Range Fault
- Pinpoint Test BI: DTC C1981 - Driver Seat Track Position Switch Circuit Fault
- Pinpoint Test BJ: DTC C1982 - Driver Seat Track Position Switch Circuit Short to VBatt Fault
- Pinpoint Test BK: DTC U0073 - Control Module Communication Bus Off
- Pinpoint Test BL: DTC U1900 - CAN Communication Bus Fault - Receive Error
- Pinpoint Test BM: DTC U2017 - Driver Side Crash Sensor Communication Fault
- Pinpoint Test BN: DTC U2018 - Passenger Side Crash Sensor Communication Fault
- Air Bag and Safety Belt Pretensioner Supplemental Restraint System (SRS)
- General Procedures
- Supplemental Restraint System (SRS) Depowering and Repowering
- Supplemental Restraint System (SRS) Deactivation and Reactivation
- Inspection and Repair After a Supplemental Restraint System (SRS) Deployment
- Pyrotechnic Device Disposal
- Disposal of Deployable Devices and Pyrotechnic Devices That are Undeployed/Inoperative
- Disposal of Deployable Devices and Pyrotechnic Devices That Are Deployed
- Disposal of Deployable Devices and Pyrotechnic Devices That Require Manual Deployment
- Driver Air Bag Module, Passenger Air Bag Module and Seat Side Air Bag Modules - Remote Deployment
- Safety Belt Buckle Pretensioners, Safety Belt Retractor Pretensioners and Adaptive Load Limiting Safety Belt Retractors - Remote Deployment
- Safety Belt Buckle Pretensioners, Safety Belt Retractor Pretensioners and Load Limiting Safety Belt Retractors - In-Vehicle Deployment
- Safety Canopy Modules and Side Air Curtain Modules - In-Vehicle Deployment
- Deployable Steering Column - In-Vehicle Deployment
- Removal And Installation
- Supplemental Inflatable Restraint System
- Restraints Control Systems
- Safety Belt System
- Specifications
- Description And Operation
- Safety Belt System
- Notes
- Safety Belt Pretensioners
- Safety Belt Tension Sensor
- Dual Locking Mode Retractors
- Energy Management Retractor
- Child Safety Seat Tether Anchors
- Lower Anchors and Tethers for Children (LATCH)
- Fastening Safety Belts
- Safety Belt Extension Assembly
- Safety Belt Warning System - Driver Safety Belt
- Belt Minder
- Safety Belt System
- Diagnostic Tests
- General Procedures
- Removal And Installation
- Safety Belt Buckle - Front
- Safety Belt Retractor - Rear, Center, 3-Door/5-Door/Wagon
- Safety Belt Retractor - Rear, Center, 4-Door
- Safety Belt Buckle - Rear
- Safety Belt Retractor - Rear, 3-Door/5-Door
- Safety Belt Retractor - Rear, 4-Door
- Safety Belt Retractor - Rear, Wagon
- Safety Belt Retractor and Pretensioner
- Safety Belt Shoulder Height Adjuster
- Child Safety Seat Tether Anchor - 4-Door
- Child Safety Seat Tether Anchor - LATCH
- Safety Belt System
- Seat Belts
- Safety Belt System
- Specifications
- Description And Operation
- Safety Belt System
- Notes
- Safety Belt Pretensioners
- Safety Belt Tension Sensor
- Dual Locking Mode Retractors
- Energy Management Retractor
- Child Safety Seat Tether Anchors
- Lower Anchors and Tethers for Children (LATCH)
- Fastening Safety Belts
- Safety Belt Extension Assembly
- Safety Belt Warning System - Driver Safety Belt
- Belt Minder
- Safety Belt System
- Diagnostic Tests
- General Procedures
- Removal And Installation
- Safety Belt Buckle - Front
- Safety Belt Retractor - Rear, Center, 3-Door/5-Door/Wagon
- Safety Belt Retractor - Rear, Center, 4-Door
- Safety Belt Buckle - Rear
- Safety Belt Retractor - Rear, 3-Door/5-Door
- Safety Belt Retractor - Rear, 4-Door
- Safety Belt Retractor - Rear, Wagon
- Safety Belt Retractor and Pretensioner
- Safety Belt Shoulder Height Adjuster
- Child Safety Seat Tether Anchor - 4-Door
- Child Safety Seat Tether Anchor - LATCH
- Safety Belt System
- Air Bag, SRS
- Steering
- Manual Steering
- Power Steering System
- Steering System - General Information
- Specifications
- Description And Operation
- Diagnostic Tests
- Steering System
- Notes
- Principles of Operation
- Inspection and Verification
- Symptom Charts
- Pinpoint Tests
- Component Tests
- Steering System
- General Procedures
- Power Steering
- Power Steering System
- Steering System - General Information
- Specifications
- Description And Operation
- Diagnostic Tests
- Steering System
- Notes
- Principles of Operation
- Inspection and Verification
- Symptom Charts
- Pinpoint Tests
- Component Tests
- Steering System
- General Procedures
- Steering Column
- Steering Linkage
- Manual Steering
- Suspension
- Front Suspension
- Front Suspension
- Suspension System - General Information
- Specifications
- Front Wheel Alignment (At Curb Weight) - Caster And Camber
- Front Wheel Alignment (At Curb Weight) - Total Toe Setting - All Variants (Except 2.0L DURATEC St)
- Rear Wheel Alignment (At Curb Weight) - Camber
- Rear Wheel Alignment (At Curb Weight) - Total Toe Setting - All Variants
- Ball Joint Deflection
- Torque Specifications
- Description And Operation
- Diagnostic Tests
- General Procedures
- Specifications
- Rear Suspension
- Rear Suspension
- Specifications
- Description And Operation
- Diagnostic Tests
- Removal And Installation
- Suspension System - General Information
- Specifications
- Front Wheel Alignment (At Curb Weight) - Caster And Camber
- Front Wheel Alignment (At Curb Weight) - Total Toe Setting - All Variants (Except 2.0L DURATEC St)
- Rear Wheel Alignment (At Curb Weight) - Camber
- Rear Wheel Alignment (At Curb Weight) - Total Toe Setting - All Variants
- Ball Joint Deflection
- Torque Specifications
- Description And Operation
- Diagnostic Tests
- General Procedures
- Specifications
- Rear Suspension
- Wheel Alignment
- Suspension System - General Information
- Specifications
- Front Wheel Alignment (At Curb Weight) - Caster And Camber
- Front Wheel Alignment (At Curb Weight) - Total Toe Setting - All Variants (Except 2.0L DURATEC St)
- Rear Wheel Alignment (At Curb Weight) - Camber
- Rear Wheel Alignment (At Curb Weight) - Total Toe Setting - All Variants
- Ball Joint Deflection
- Torque Specifications
- Description And Operation
- Diagnostic Tests
- General Procedures
- Specifications
- Suspension System - General Information
- Wheels & Tire System
- Front Suspension
- Transmission
- Clutch
- Clutch Control System
- Clutch System
- Manual Transaxle/Transmission And Clutch - General Information - General Information
- Manual Trans
- Manual Transaxle/Transmission And Clutch - General Information - General Information
- Manual Transaxle/Transmission External Controls
- Manual Transmission
- Clutch
- External Pages