Technical Service Bulletins

Accessory Drive Belts
- 2.3L/2.0L DURATEC - No Start/Possible Engine Damage - Install Special Service Tools Prior To Removing Crankshaft Pulley Bolt (06-21-4)
Air Bag, SRS
- Instrument Panel Warped Around Passenger Air Bag Trim Cover (16-0026)
- RCM Fault Reporting Using DTCS And Bit-Mapped Parameter Identifiers (PIDS) - Service Tips (07-7-8)
Anti-Theft Systems
- Intermittent Crank-No-Start With Various DTCS Stored In Memory (06-20-9)
Automatic Trans
- FNR5 Transmission With DTC P0706 - Transmission Range Sensor Circuit Failure (09-13-7)
- AISIN Transmission Harsh Shifting - No DTC Mileage Above 20,000 Miles (32,200 Km) (08-24-1)
- Key Stuck In Ignition / Shifter Binding Condition (07-2-1)
- Automatic Transmission Whine Between 40-60 Mph (64-97 Km/H) - 3.0L Engine (06-23-12)
- Low Idle Rpm With Mil Off And No DTC With 2.3L Engine - Engine Noise Associated With Delayed Transmission Up-Shift With Mil Off And No DTC With 2.3L Engine And Automatic Transmission (06-16-8)
Auxiliary Emission Control Systems
- Mil On - DTC P2100 And P2110 In Memory - 3.0L (07-23-15)
- Vibration Or Buzzing Noise - Bulkhead/Dash Area - Vehicles Built On Or Before 4/30/2007 (07-17-5)
- 2.3L High Idle At Start Up - Approximately 2000 Rpm (07-10-1)
- Mil On DTC P0606 In Memory (07-5-3)
- Various DRIVEABILITY/Transmission Symptoms - Pcm/TCM Calibration Updates - 3.0L - AISIN F21 Auto Trans (07-2-3)
- Low Idle Rpm With Mil Off And No DTC With 2.3L Engine - Engine Noise Associated With Delayed Transmission Up-Shift With Mil Off And No DTC With 2.3L Engine And Automatic Transmission (06-16-8)
Axle Shafts
- Single Wheel Stud Fracture On Rear Hub (12-2-9)
- Half Shafts - Ratcheting/Clicking/Creaking Noise - Cold (07-18-6)
Charging Systems
- Stuck High Voltage Charge Cord Information Sheet (G0000127)
Cooling System (Mechanical)
- Keep The Cooling System Free Of Debris And Corrosion To Prevent Premature Water Pump Failure (TT002-13)
- Heater Core Leakage And Electrolysis (Information Only) (06-21-19)
Differentials & Drive Axles
- Half Shafts - Ratcheting/Clicking/Creaking Noise - Cold (07-18-6)
Driveshaft & Universal Joints
- Half Shafts - Ratcheting/Clicking/Creaking Noise - Cold (07-18-6)
Engine Control Systems
- Mil On With DTCS - P0351, P0352, P0353, P0354, P0355, And/Or P0356 - Built On Or Before 3/1/2008 (14-0059)
- DTCS P0505, P0506 And/Or Engine Idle Rpm Fluctuation - Hard Start (12-8-1)
- Mil On - DTC P2100 And P2110 In Memory - 3.0L (07-23-15)
- 2.3L High Idle At Start Up - Approximately 2000 Rpm (07-10-1)
- Mil On DTC P0606 In Memory (07-5-3)
- Various DRIVEABILITY/Transmission Symptoms - Pcm/TCM Calibration Updates - 3.0L - AISIN F21 Auto Trans (07-2-3)
- 2.3L/2.0L DURATEC - No Start/Possible Engine Damage - Install Special Service Tools Prior To Removing Crankshaft Pulley Bolt (06-21-4)
- Intermittent Crank-No-Start With Various DTCS Stored In Memory (06-20-9)
- Ignition Diagnostics (06-18-15)
- Low Idle Rpm With Mil Off And No DTC With 2.3L Engine - Engine Noise Associated With Delayed Transmission Up-Shift With Mil Off And No DTC With 2.3L Engine And Automatic Transmission (06-16-8)
Entertainment Systems
- Speaker Pop Noise With Audiophile (Non Navigation) Sound System - Built Before 10/31/2007 (08-8-8)
- Pioneer Navigation Radio - Seek Function Inoperative - Service Tip (06-25-3)
- Audio / Navigation Service And Ordering Procedures (06-21-7)
Exhaust
- Various Vehicles - Catalytic Converter Concern Analysis (22-7009)
- Rattle Noise Under Vehicle - Heat Shield Contact To Floor Pan - Vehicles Built On Or Before 8/7/2007 (07-17-7)
Exterior Body Panels
- Luggage Compartment Lid Solenoid Stuck Open (10-5-9)
Front Suspension
- Front Strut Noise (08-18-4)
Fuel System
- DTCS P0505, P0506 And/Or Engine Idle Rpm Fluctuation - Hard Start (12-8-1)
HVAC Control Systems
- Electronic Automatic Temperature Control (EATC) - Extreme Cold Temperature Blank Screen Or Stays In Off Position After Engine Starts (09-20-1)
- Intermittent/High Blower Motor Operation - EMTC, DATC And/Or EATC Climate Control Systems (08-6-1)
- Electronic Automatic Climate Control (EATC) Unintended Temperature Change And/Or Fan Speed (07-19-10)
- Heater Core Leakage And Electrolysis (Information Only) (06-21-19)
Ignition Switch/Steering Lock
- Key Stuck In Ignition / Shifter Binding Condition (07-2-1)
Ignition System
- Mil On With DTCS - P0351, P0352, P0353, P0354, P0355, And/Or P0356 - Built On Or Before 3/1/2008 (14-0059)
- Ignition Diagnostics (06-18-15)
Infotainment
- Audio / Navigation Service And Ordering Procedures (06-21-7)
Interior/Exterior Trim
- Instrument Panel Warped Around Passenger Air Bag Trim Cover (16-0026)
- Rattle Noise Under Vehicle - Heat Shield Contact To Floor Pan - Vehicles Built On Or Before 8/7/2007 (07-17-7)
Manual Steering
- Power Steering Fluid Leaks From Steering Rack And Pump Attachment Joints (07-25-14)
- MERCON(R) ATF Replaced By MERCON(R) V As A Service Fluid For Some Power Steering Systems (07-1-7)
- Steering Grunt Noise On Left Hand Turns (06-20-14)
Mechanical
- Hydraulic Versus Mechanical TENSIONERS (TT001-13)
- DTCS P0505, P0506 And/Or Engine Idle Rpm Fluctuation - Hard Start (12-8-1)
- Camshaft Tick Noise - 3.0L 4V Engine Only With Exhaust Camshaft Driven Water Pumps (08-3-10)
- 2.3L/2.0L DURATEC - No Start/Possible Engine Damage - Install Special Service Tools Prior To Removing Crankshaft Pulley Bolt (06-21-4)
Mechanical - Hydraulic
- Single Wheel Stud Fracture On Rear Hub (12-2-9)
Mirrors
- Various Vehicles - Rear-View Mirror Concern Analysis (23-7092)
- Ford Interior Mirror Job Aid (G0000001)
Passive Restraints
- Front Seats Squeak/Rattle (07-13-9)
- Front Seat Manual Lumbar Inoperative (07-7-3)
Restraints Control Systems
- RCM Fault Reporting Using DTCS And Bit-Mapped Parameter Identifiers (PIDS) - Service Tips (07-7-8)
Seats
- Front Seats Squeak/Rattle (07-13-9)
- Front Seat Manual Lumbar Inoperative (07-7-3)
Starter
- Battery Service - Operation Of Battery Eye - Charging Service Tips (07-5-8)
Steering Column
- Key Stuck In Ignition / Shifter Binding Condition (07-2-1)
- Leather-Wrapped Steering Wheel - Leather Coming Loose (07-4-3)
Steering Control Systems
- Power Steering Fluid Leaks From Steering Rack And Pump Attachment Joints (07-25-14)
- MERCON(R) ATF Replaced By MERCON(R) V As A Service Fluid For Some Power Steering Systems (07-1-7)
- Steering Grunt Noise On Left Hand Turns (06-20-14)
Steering Gear
- Power Steering Fluid Leaks From Steering Rack And Pump Attachment Joints (07-25-14)
- MERCON(R) ATF Replaced By MERCON(R) V As A Service Fluid For Some Power Steering Systems (07-1-7)
- Steering Grunt Noise On Left Hand Turns (06-20-14)
Sun Roof/T-Top/Convertible Top
- Water Leak - Roof Opening Panel Area - Built On Or Before 11/18/2006 (07-16-16)
Suspension Control Systems
- Front Strut Noise (08-18-4)
System
- Mil On With DTCS - P0351, P0352, P0353, P0354, P0355, And/Or P0356 - Built On Or Before 3/1/2008 (14-0059)
- DTCS P0505, P0506 And/Or Engine Idle Rpm Fluctuation - Hard Start (12-8-1)
- Mil On - DTC P2100 And P2110 In Memory - 3.0L (07-23-15)
- Vibration Or Buzzing Noise - Bulkhead/Dash Area - Vehicles Built On Or Before 4/30/2007 (07-17-5)
- 2.3L High Idle At Start Up - Approximately 2000 Rpm (07-10-1)
- Mil On DTC P0606 In Memory (07-5-3)
- Various DRIVEABILITY/Transmission Symptoms - Pcm/TCM Calibration Updates - 3.0L - AISIN F21 Auto Trans (07-2-3)
- 2.3L/2.0L DURATEC - No Start/Possible Engine Damage - Install Special Service Tools Prior To Removing Crankshaft Pulley Bolt (06-21-4)
- Intermittent Crank-No-Start With Various DTCS Stored In Memory (06-20-9)
- Ignition Diagnostics (06-18-15)
- Low Idle Rpm With Mil Off And No DTC With 2.3L Engine - Engine Noise Associated With Delayed Transmission Up-Shift With Mil Off And No DTC With 2.3L Engine And Automatic Transmission (06-16-8)
Transmission Control Systems
- FNR5 Transmission With DTC P0706 - Transmission Range Sensor Circuit Failure (09-13-7)
- AISIN Transmission Harsh Shifting - No DTC Mileage Above 20,000 Miles (32,200 Km) (08-24-1)
- Key Stuck In Ignition / Shifter Binding Condition (07-2-1)
- Various DRIVEABILITY/Transmission Symptoms - Pcm/TCM Calibration Updates - 3.0L - AISIN F21 Auto Trans (07-2-3)
- Automatic Transmission Whine Between 40-60 Mph (64-97 Km/H) - 3.0L Engine (06-23-12)
- Low Idle Rpm With Mil Off And No DTC With 2.3L Engine - Engine Noise Associated With Delayed Transmission Up-Shift With Mil Off And No DTC With 2.3L Engine And Automatic Transmission (06-16-8)
Wheel Hubs
- Single Wheel Stud Fracture On Rear Hub (12-2-9)
Wheels & Tire System
- Single Wheel Stud Fracture On Rear Hub (12-2-9)
Window Motors & Regulators
- Door Glass Slow Movement - Glass Scratches - Window Regulator Noise (09-12-4)
- B-Pillar/Window Run Seal Wind Noise - Vehicles Built Before 12/1/2006 (07-5-10)