Technical Service Bulletins

Accessories Control Systems
- Rattle/Buzz/Vibration - Transmission Cross-Member Exhaust Mount - Built Before 12/3/2007 (08-3-4)
- Discharged Batteries - Vehicles In Storage/Limited Usage (07-5-13)
Accessory Drive Belts
- Cold Start FEAD Hoot - Whistle Noise (09-9-7)
Aerodynamic Devices
- Spoiler/Deck Lid Contact (07-6-7)
Air Bag, SRS
- Air Bag Warning Lamp On - DTC B2295 In Restraints Control Module (10-23-8)
- RCM Fault Reporting Using DTCS And Bit-Mapped Parameter Identifiers (PIDS) - Service Tips (07-7-8)
Anti-Theft Systems
- Exterior Door Handle Not Flush In The Closed Position (07-16-7)
Automatic Trans
- 5R55S/5R55N/5R55W Transmissions - Shift Concerns, Loss Of 2ND, 3RD And 5TH Gear, Incorrect Ratio DTC'S - Procedure To Inspect And Repair Servo Pin Bore Wear (09-12-12)
- Shudder On ACCEL - Possible Wrong Trans CROSSMEMBER Assembly Installed (Excludes Gt 500) (08-23-4)
Auxiliary Emission Control Systems
- DTCS P0505, P0506 And/Or Engine Idle Rpm Fluctuation - Hard Start (12-7-4)
Axle Shafts
- Axle Whine (09-20-4)
Body Electrical
- Service Wiring Harness Replacement Guidelines - Service Tips (06-17-8)
Charging Systems
- Stuck High Voltage Charge Cord Information Sheet (G0000127)
- Service Wiring Harness Replacement Guidelines - Service Tips (06-17-8)
Clutch
- 4.0L With Manual Transmission - 4TH Gear Rattle/Knock Noise On Acceleration - 1800-2200 Rpm Approximately 45 Mph (72 Km/H) (08-8-5)
Cooling System (Mechanical)
- Keep The Cooling System Free Of Debris And Corrosion To Prevent Premature Water Pump Failure (TT002-13)
- Heater Core Leakage And Electrolysis (Information Only) (06-21-19)
Differentials & Drive Axles
- Rear Drive Axle Vent - Oil Leak (12-5-8)
- Axle Whine (09-20-4)
- 8.8 Limited Slip Axle Moan/Groan Noise During Low Speed Turning Maneuvers (08-5-10)
Engine Control Systems
- DTCS P0505, P0506 And/Or Engine Idle Rpm Fluctuation - Hard Start (12-7-4)
- Fuel Fill Slow, Or Difficult To Fill (07-21-12)
- Discharged Batteries - Vehicles In Storage/Limited Usage (07-5-13)
Entertainment Systems
- Buzz/Rattle From Door Panel When Operating Audio System - Vehicles Built Before 8/2/2007 (07-17-6)
- Pioneer Navigation Radio - Seek Function Inoperative - Service Tip (06-25-3)
- Audio / Navigation Service And Ordering Procedures (06-21-7)
Exhaust
- Various Vehicles - Catalytic Converter Concern Analysis (22-7009)
- Rattle/Buzz/Vibration - Transmission Cross-Member Exhaust Mount - Built Before 12/3/2007 (08-3-4)
Exterior Body Panels
- Aluminum Panel Corrosion (17-0062)
- Luggage Compartment Lid Solenoid Stuck Open (10-5-9)
- Fuel Fill Slow, Or Difficult To Fill (07-21-12)
- Spoiler/Deck Lid Contact (07-6-7)
Exterior Lights
- Un-Commanded Perimeter Lighting (08-9-2)
Frames, Subframes & Crossmembers
- Aluminum Panel Corrosion (17-0062)
Front Suspension
- Grunt/Creak/Squeak/Chirp Noise From The Lower Control Arm Bushing Over Bumps - Built On Or Before 8/3/2009 (09-24-16)
- Grunt/Creak/Squeak/Chirp Noise From The Lower Control Arm Bushing Over Bumps - Built Before 2/28/2007 (07-23-1)
- 4.0L And 4.6L Coupe - Front End Noise Over Bumps (07-18-2)
Fuel System
- DTCS P0505, P0506 And/Or Engine Idle Rpm Fluctuation - Hard Start (12-7-4)
- Fuel Fill Slow, Or Difficult To Fill (07-21-12)
Fuses & Circuit Breakers
- Service Wiring Harness Replacement Guidelines - Service Tips (06-17-8)
Gauges & Instrument Panels
- A-Pillar Rattle Noise (08-24-10)
- Rattle/Buzz/Vibration - Transmission Cross-Member Exhaust Mount - Built Before 12/3/2007 (08-3-4)
Headlights
- Un-Commanded Perimeter Lighting (08-9-2)
HVAC Control Systems
- Heater Core Leakage And Electrolysis (Information Only) (06-21-19)
Ignition System
- 4.0L - Buzz Noise - Upper Engine (10-5-7)
- Spark Plug Removal Instructions - 4.6L 3V/5.4L 3V/6.8L 3V (08-7-6)
Infotainment
- Audio / Navigation Service And Ordering Procedures (06-21-7)
Interior/Exterior Trim
- Convertible Top-Headliner Pulled Out From Number 1 Bow (13-8-12)
- Water Leak - Front Floor Area (08-26-7)
- A-Pillar Rattle Noise (08-24-10)
- Rattle/Buzz/Vibration - Transmission Cross-Member Exhaust Mount - Built Before 12/3/2007 (08-3-4)
- Buzz/Rattle From Door Panel When Operating Audio System - Vehicles Built Before 8/2/2007 (07-17-6)
- Carpet Remove And Replace (06-26-2)
Manual Steering
- 8.8 Limited Slip Axle Moan/Groan Noise During Low Speed Turning Maneuvers (08-5-10)
- MERCON(R) ATF Replaced By MERCON(R) V As A Service Fluid For Some Power Steering Systems (07-1-7)
Manual Trans
- 4.6L With Tr3650 Manual Transmission - Clash Or Raspy Feel - Shifting Into 2ND And/Or 3RD Gear (09-9-6)
- 4.6L Manual Transmission - Separator Plate Buzz - Built Before 4/5/2009 (09-18-16)
- Manual Transmission Shifter Boot Noise - Built Before 12/6/2007 (08-2-4)
- MERCON ATF Is Being Replaced By MERCON V As A Service Fluid For Some Manual Transmissions (06-26-1)
Mechanical
- Hydraulic Versus Mechanical TENSIONERS (TT001-13)
- DTCS P0505, P0506 And/Or Engine Idle Rpm Fluctuation - Hard Start (12-7-4)
- 4.0L - Buzz Noise - Upper Engine (10-5-7)
- 4.6L Manual Transmission - Separator Plate Buzz - Built Before 4/5/2009 (09-18-16)
- Cold Start FEAD Hoot - Whistle Noise (09-9-7)
- 4.0L With Manual Transmission - 4TH Gear Rattle/Knock Noise On Acceleration - 1800-2200 Rpm Approximately 45 Mph (72 Km/H) (08-8-5)
- Spark Plug Removal Instructions - 4.6L 3V/5.4L 3V/6.8L 3V (08-7-6)
Mechanical - Hydraulic
- 8.8 Limited Slip Axle Moan/Groan Noise During Low Speed Turning Maneuvers (08-5-10)
Mirrors
- Various Vehicles - Rear-View Mirror Concern Analysis (23-7092)
- Ford Interior Mirror Job Aid (G0000001)
Paint & Coatings
- Aluminum Panel Corrosion (17-0062)
Passive Restraints
- Rattle/Buzz/Vibration - Transmission Cross-Member Exhaust Mount - Built Before 12/3/2007 (08-3-4)
Restraints Control Systems
- Air Bag Warning Lamp On - DTC B2295 In Restraints Control Module (10-23-8)
- RCM Fault Reporting Using DTCS And Bit-Mapped Parameter Identifiers (PIDS) - Service Tips (07-7-8)
Seats
- Rattle/Buzz/Vibration - Transmission Cross-Member Exhaust Mount - Built Before 12/3/2007 (08-3-4)
Starter
- Battery Service - Operation Of Battery Eye - Charging Service Tips (07-5-8)
- Discharged Batteries - Vehicles In Storage/Limited Usage (07-5-13)
Steering Column
- Rattle/Buzz/Vibration - Transmission Cross-Member Exhaust Mount - Built Before 12/3/2007 (08-3-4)
- Leather-Wrapped Steering Wheel - Leather Coming Loose (07-4-3)
Steering Control Systems
- MERCON(R) ATF Replaced By MERCON(R) V As A Service Fluid For Some Power Steering Systems (07-1-7)
Steering Gear
- MERCON(R) ATF Replaced By MERCON(R) V As A Service Fluid For Some Power Steering Systems (07-1-7)
Sun Roof/T-Top/Convertible Top
- Convertible Top-Headliner Pulled Out From Number 1 Bow (13-8-12)
- Convertible Top - Tension Cable Noise - Built Before 12/1/2006 (07-20-3)
- Convertible Top Wear - Built Before 10/11/2006 (07-19-1)
- Convertible System Concerns (07-17-8)
System
- DTCS P0505, P0506 And/Or Engine Idle Rpm Fluctuation - Hard Start (12-7-4)
- 4.0L - Buzz Noise - Upper Engine (10-5-7)
- Spark Plug Removal Instructions - 4.6L 3V/5.4L 3V/6.8L 3V (08-7-6)
- Fuel Fill Slow, Or Difficult To Fill (07-21-12)
- Discharged Batteries - Vehicles In Storage/Limited Usage (07-5-13)
Transmission Control Systems
- 5R55S/5R55N/5R55W Transmissions - Shift Concerns, Loss Of 2ND, 3RD And 5TH Gear, Incorrect Ratio DTC'S - Procedure To Inspect And Repair Servo Pin Bore Wear (09-12-12)
Window Motors & Regulators
- Water Leak - Front Floor Area (08-26-7)
- Power Window Feature - Bounce Back Diagnostics (08-21-7)
- Convertible - Rear Quarter Glass - Torn/Separating Quarter Glass Division Bar (08-17-3)
Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)
- Service Wiring Harness Replacement Guidelines - Service Tips (06-17-8)