Repair and Diagnosis (Single Page)
You are viewing the full "tree" of links on one page. This can load slowly, but is easier to search. The same page can appear multiple times under a different folder, that is why the page is so large.View "split tree" where inner folders are split out. where inner links are on separate pages.
Quick Lookups
Common Specs & Procedures
DTC Index- Anti-Lock Control DTCS
- Anti-Theft (Pats) DTCS
- Anti-Theft (Perimeter) DTCS
- Automatic Transmission DTCS - 4F50N
- Body Closures DTCS
- Brake System DTCS
- Cruise Control System DTCS
- Engine Cooling DTCS
- Four Wheel Drive Systems DTCS
- Fuel System DTCS
- Handles, Locks, Latches And Entry Systems DTCS
- Information And Message DTCS
- Instrument Cluster (Ic), Message Center, And Warning Chimes DTCS
- Instrument Cluster And Panel Illumination DTCS
- Lighting DTCS
- Module Communications Network DTCS
- MULTIFUNCTION Electronic Modules DTCS
- Parking Aid DTCS
- Power Windows DTCS
- Powertrain DTC Charts And Descriptions - Gasoline Engines DTCS
- Rear View Mirrors DTCS
- Seating DTCS
- Starting System DTCS
- Steering Column Switches DTCS
- Supplemental Restraints Systems DTCS
- Wheels And Tires DTCS
- Wiper/Washer Systems DTCS
Electrical Component Locations
Fluids
Technical Bulletins
Tire Fitment
Wiring Diagrams- OEM Connector End Views
- Connector Views
- A/C Clutch Field Coil Connector
- Crankshaft Position Sensor Connector
- Generator Connectors
- Oil Pressure Switch Connector
- Cylinder Head Temperature Sensor Connector
- Knock Sensor Connector
- Coil On Plug Connectors
- Power Steering Valve Solenoid Connector
- Brake Fluid Level Switch Connector
- Windshield Wiper Motor Connector
- Anti-Theft Hood Switch Connector
- Mass Air Flow Sensor / Intake Air Temperature Sensor Connector
- Horn Connector
- Ambient Air Temperature Sensor Connector
- Anti-Lock Brake System Module Connector
- Windshield Washer Pump Motor Connector
- Washer Fluid Level Switch Connector
- Heated Oxygen Sensor 22 Connector
- Heated Oxygen Sensor 12 Connector
- Inline Connectors
- Left Front Wheel Speed Sensor Connector
- Left Front Side Lamp Connector
- Left Front Fog Lamp Connector
- Right Front Wheel Speed Sensor Connector
- Right Front Side Lamp Connector
- Right Front Fog Lamp Connector
- 6F Automatic Transmission Vehicle Harness Connector
- Heated Oxygen Sensor 11 Connector
- Heated Oxygen Sensor 21 Connector
- Powertrain Control Module Connectors
- Fuel Injector Connectors
- Heated Positive Crankcase Ventilation Valve Connector
- Starter Motor Connectors
- Multifunction Switch Connectors
- Headlamp Switch Connector
- Driver Air Bag Module Connector
- Clockspring Connectors
- Instrument Cluster Connectors
- Steering Angle Sensor Module Connector
- DATC HVAC Module Connector
- In-Vehicle Temperature Sensor Connector
- Audio Control Module Connector
- Ignition Switch Connector
- Data Link Connector
- Passive Anti-Theft Transceiver Connector
- Passenger Air Bag Module Connectors
- Front Blower Motor Speed Controller Connector
- Speed Control Deactivation Switch Connector
- Brake Pedal Position Switch Connector
- All Wheel Drive Module Connector
- Autolamp Sensor / Sunload Sensor Connector
- Fresh/ Recirculation Door Actuator Connector
- Evaporator Discharge Air Temperature Sensor Connector
- Parking Brake Switch Connector
- Restraints Control Module Connectors
- Passenger Side Front Seat Control Switch Connector
- Passenger Seat Horizontal Motor Connector
- Right Front Seat Cushion Heater Connector
- Right Front Seat Back Heater Connector
- Driver Seat Module Connector
- Driver Seat Safety Belt Load Limiting Retractor Connector
- Driver Seat Position Sensor Connector
- Driver Side Front Seat Control Switch Connector
- Driver Seat Horizontal Motor Connector
- Driver Seat Rear Height Motor Connector
- Left Front Seat Cushion Heater Connector
- Left Front Seat Back Heater Connector
- Evaporative Emissions Canister Vent Control Solenoid Connector
- Console Power Point Connector
- Driver Seat Front Height Motor Connector
- Passenger Seat Safety Belt Load Limiting Retractor Connector
- Inertia Fuel Shutoff Switch Connector
- Rear Window Defrost Grid Connector
- Left Rear Lamp Assembly Connector
- Right Rear Lamp Assembly Connector
- Luggage Compartment Lamp Connector
- Left License Plate Lamp Connector
- Right License Plate Lamp Connector
- Subwoofer Amplifier Connector
- Rear Power Point Connector
- Rear Wiper Motor Assembly Connector
- Keypad Switch Assembly Connector
- Memory Set Switch Connector
- Master Window Adjust Switch Connector
- Driver Door Disarm Switch Connector
- Left Exterior Rear View Mirror Connector
- Left Front Speaker Connector
- Driver Side Front Power Window Motor Connector
- Left Front Door Lock Actuator Connector
- Left Front Door Ajar Switch Connector
- Exterior Rear View Mirror Switch Connector
- Driver Side Door Lock Switch Connector
- Driver 1 Side Impact Sensor Connector
- Right Front Door Ajar Switch Connector
- Right Front Door Lock Actuator Connector
- Passenger Side Window Adjust Switch Connector
- Passenger Side Door Lock Switch Connector
- Passenger Side Front Power Window Motor Connector
- Right Front Speaker Connector
- Right Exterior Rearview Mirror Connector
- Passenger 1 Side Impact Sensor Connector
- Left Rear Window Adjust Switch Connector
- Left Rear Speaker Connector
- Left Rear Power Window Motor Connector
- Left Rear Door Lock Actuator Connector
- Left Rear Door Ajar Switch Connector
- Right Rear Window Adjust Switch Connector
- Right Rear Speaker Connector
- Right Rear Power Window Motor Connector
- Right Rear Door Lock Actuator Connector
- Right Rear Door Ajar Switch Connector
- High Mounted Stoplamp Connector
- Right Vanity Mirror Lamp Connector
- Left Vanity Mirror Lamp Connector
- Electronic Compass Connector
- Auto-Dimming Interior Mirror Unit Connector
- Roof Opening Panel Module Connector
- Overhead Console Connectors
- Second Row Seat Interior Lamp / Map Lamp Assembly Connector
- Third Row Seat Interior Lamp / Map Lamp Assembly Connector
- Rear Auxiliary Function Selector Switch Assembly Connector
- Left Front High Beam Lamp Connector
- Left Front Park Lamp / Turn Lamp Connector
- Battery Junction Box Connector
- Right Front High Beam Lamp Connector
- Right Front Park Lamp / Turn Lamp Connector
- Engine Cooling Fan Motor Connector
- Battery Connectors
- Left Front Low Beam Lamp Connector
- Right Front Low Beam Lamp Connector
- Power Steering Pressure Switch Connector
- Evaporative Emissions Canister Purge Valve Connector
- A/C Pressure Transducer Sensor Connector
- Left Headlamp Connector
- Right Headlamp Connector
- Camshaft Position Sensor Connector
- Camshaft Position Sensor 2 Connector
- Electronic Throttle Control Connector
- Variable Camshaft Timing Valve 1 Connector
- Variable Camshaft Timing Valve 2 Connector
- Left Front Impact Sensor Connector
- Right Front Impact Sensor Connector
- Positive Crankcase Ventilation Heated Fitting Connector
- Universal Heated Oxygen Sensor 11 Connector
- Universal Heated Oxygen Sensor 21 Connector
- Front Blower Motor Connector
- Clock Connector
- Instrument Panel Power Point Connector
- Accelerator Pedal Position Sensor Connector
- Illumination Dimmer Connector
- Driver Temperature Blend Door Actuator Connector
- Passenger Temperature Blend Door Actuator Connector
- Center Stack Switch Assembly Connector
- Adjustable Pedal Motor Connector
- Blower Motor Resistor Connector
- Adjustable Pedal Switch Connector
- Decklid Release Switch Connector
- Mode Door Actuator Connector
- Smart Junction Box Connector
- Passenger Air Bag Deactivation Indicator Connector
- EMTC HVAC Module Connector
- Power Steering Control Module Connector
- Auxiliary Blower Motor Connector
- Auxiliary Blower Motor Resistor Connector
- Seat Pressure Sensor Connector
- Driver Safety Belt Buckle Switch Connector
- Passenger Safety Belt Buckle Switch Connector
- Stability Control Sensor Cluster Connector
- Right Rear Wheel Speed Sensor Connector
- Left Rear Wheel Speed Sensor Connector
- Left Rear Subwoofer Connector
- Right Rear Subwoofer Connector
- Fuel Tank Pressure Transducer Sensor Connector
- Fuel Pump Module Connector
- Rear Heated Seat Module Connector
- Left Rear Seat Cushion Heater Connector
- Left Rear Seat Back Heater Connector
- Right Rear Seat Cushion Heater Connector
- Right Rear Seat Back Heater Connector
- Driver Seat Recliner Motor Connector
- Passenger Seat Recliner Motor Connector
- Driver 2 Side Impact Sensor Connector
- Passenger 2 Side Impact Sensor Connector
- Driver Side Air Bag Module Connector
- Passenger Side Airbag Module Connector
- Passenger Safety Belt Tension Sensor Connector
- Passenger Seat Position Sensor Connector
- Floor Shifter Connector
- Parking Aid Module Connector
- Parking Aid Speaker Connector
- Fuel Level Sensor Connector
- Auxiliary Relay Box 1 Connector
- Auxiliary Relay Box 2 Connector
- Auxiliary Relay Box 3 Connector
- Auxiliary Mode Actuator Connector
- Auxiliary Temperature Actuator Connector
- Occupant Classification System Module Connector
- Front Heated Seat Module Connector
- Audio Input Jack Connector
- Rear Console Power Point Connector
- Left Rear Seat Heated Seat Switch Connector
- Right Rear Seat Heated Seat Switch Connector
- Accessory Protocol Interface Module Connector
- Left Second Row Seat Control Switch Connector
- Right Second Row Seat Control Switch Connector
- Left Second Row Power Fold Seat Motor Connector
- Right Second Row Power Fold Seat Motor Connector
- Outer Left Rear Parking Aid Sensor Connector
- Inner Left Rear Parking Aid Sensor Connector
- Outer Right Rear Parking Aid Sensor Connector
- Inner Right Rear Parking Aid Sensor Connector
- Left Liftgate Obstacle Detection Strip Connector
- Right Liftgate Obstacle Detection Strip Connector
- Liftgate Module / Trunk Module Connector
- Liftgate Lock Actuator Connector
- Power Liftgate Chime Connector
- Liftgate Switch Connector
- Decklid Latch Assembly Connector
- Liftgate Drive Motor Assembly Connector
- Liftgate Latch Assembly / Liftgate Unlatch Assembly Connector
- Satellite Digital Audio Receiver System Module Connector
- Active Torque Control Coupling Solenoid Connector
- License Lamps / Liftgate Release Switch Connector
- Driver Safety Canopy Module Connector
- Passenger Safety Canopy Module Connector
- Electronic Hidden Antenna Module Connector
- Rear Entertainment Module Connector
- Led High Mounted Stoplamp Connector
- Connector Views
- System Wiring Diagrams
- Using lemon2025'S Wiring Diagrams
- Air Conditioning
- Anti-Lock Brakes
- Anti-Theft
- Body Control Modules
- Computer Data Lines
- Cooling Fan
- Cruise Control
- Defoggers
- Engine Performance
- Exterior Lights
- Ground Distribution
- Headlights
- Horn
- Instrument Cluster
- Interior Lights
- Memory Systems
- Navigation
- Power Distribution
- Power Door Locks
- Power Mirrors
- Power Seats
- Power Top/Sunroof
- Power Windows
- Radio
- Shift Interlock
- Starting/Charging
- Supplemental Restraints
- Transmission
- Trunk, Tailgate, Fuel Door
- Warning Systems
- Wiper/Washer
- Using lemon2025'S System Wiring Diagrams
- OEM Connector End Views
- Accessories & Equipment
- Accessories Control Systems
- Component Testing
- Introduction
- Component Testing
- Headlamp switch, Exterior lamps
- Ignition switch
- Multifunction switch, Lamp portion
- Multifunction Switch, Wiper/Washer Portion - Front
- Multifunction Switch, Wiper/Washer Portion - Rear
- Master window adjust switch
- Window adjust switches
- Seat control switch, 6 - way driver or 2 - way passenger power seat
- Seat control switch, 8 - way driver or 4 - way passenger power seat
- Power door lock switch
- Exterior rear view mirror switch
- Illumination dimmer switch
- Roof opening panel switch
- Adjustable pedal switch
- Relay - Mini ISO
- Relay - Ultra Micro ISO
- Remote Convenience
- Component Testing
- Anti-Theft Systems
- Anti-Theft - Passive Anti-Theft System (Pats)
- Description And Operation
- Diagnostic Tests
- Anti-Theft
- Notes
- Principles of Operation
- Inspection and Verification
- DTC Tables
- Symptom Chart
- Pinpoint Tests
- Pinpoint Test A: DTC B2103 - Antenna Not Connected
- Pinpoint Test B: DTC B1600 - PATS Ignition Key Transponder Signal Is Not Received
- Pinpoint Test C: DTC B1601 - PATS Received Incorrect Key-Code From Ignition Key Transponder
- Pinpoint Test D: DTC B1602 - PATS Received Invalid Format Of Key-Code From Ignition Key Transponder
- Pinpoint Test E: DTC B1681 - PATS Transceiver Module Signal Is Not Received
- Pinpoint Test F: The Anti-Theft Indicator Is Always/Never On
- Pinpoint Test G: DTC U0100 and U2511 - CAN - Data Mis-Match (Receive Data Does Not Match Expected) & Lost Communication With ECM/PCM
- Pinpoint Test H: The Vehicle Does Not Start
- Anti-Theft
- General Procedures
- Integrated Keyhead Transmitter (IKT) Key Programming Using Diagnostic Equipment
- Key Programming Using Two Programmed Keys
- Key Programming Switch State Control
- Spare Key Programming - Unlimited Key Mode
- Spare Key Programming - Using Diagnostic Equipment
- Anti-Theft Security Access
- Passive Anti-Theft System (PATS) Parameter Reset
- Removal And Installation
- Anti-Theft System - Perimeter
- Handles, Locks, Latches And Entry Systems
- Specifications
- Description And Operation
- Handles, Locks, Latches and Entry Systems
- Notes
- Hood Latch
- Front Door
- Rear Door
- Luggage Compartment Lid
- Manual Liftgate
- Power Liftgate
- Power Lock/Unlock
- Autolock
- Auto-Unlock
- Smart Unlock
- Remote Keyless Entry (RKE)
- Remote Keyless Entry (RKE) Lock/Unlock Control - Unlock
- Remote Keyless Entry (RKE) Lock/Unlock Control - Lock
- Remote Keyless Entry (RKE) Luggage Compartment/Power Liftgate Release
- Remote Keyless Entry (RKE) Memory Seat Feature
- Panic Alarm
- Keyless Entry Keypad
- Locking the Doors with the Keyless Entry Keypad System
- Unlocking the Doors with the Keyless Entry Keypad System
- Keyless Entry Keypad Memory Seat Feature
- Anti-Scan Feature
- Perimeter Lighting Feature
- Handles, Locks, Latches and Entry Systems
- Diagnostic Tests
- Locks, Latches and Entry Systems
- Notes
- Principles of Operation
- Inspection and Verification
- DTC Tables
- Symptom Chart
- Pinpoint Tests
- Pinpoint Test A: All Door Locks Are Inoperative
- Pinpoint Test B: A Single/More Than One Door Lock Is Inoperative
- Pinpoint Test C: The Door Locks Operate Only One Way
- Pinpoint Test D: All Door Locks Are Inoperative From One Switch
- Pinpoint Test E: DTC B2A25
- Pinpoint Test F: The Luggage Compartment Lid Latch Release Is Inoperative/Does Not Operate Correctly
- Pinpoint Test G: The Liftgate Latch Release Is Inoperative/Does Not Operate Correctly
- Pinpoint Test H: The Doors Do Not Lock/Unlock Using The Keyless Entry Keypad
- Pinpoint Test I: The Keyless Entry Keypad Illumination Is Inoperative/Does Not Operate Correctly
- Pinpoint Test J: The Remote Keyless Entry (RKE) Transmitter Is Inoperative
- Pinpoint Test K: An Individual Button/Feature Is Inoperative From The Remote Keyless Entry (RKE) Transmitter
- Pinpoint Test L: The Remote Keyless Entry (RKE) Transmitter Has Poor Range Performance
- Pinpoint Test M: The Autolock Does Not Operate Correctly
- Pinpoint Test N: The Smart Unlock Does Not Operate Correctly
- Pinpoint Test O: DTC B1137
- Locks, Latches and Entry Systems
- General Procedures
- Remote Keyless Entry Transmitter Programming
- Keyless Entry Keypad Code Programming
- Remote Memory Activation
- Remote Memory Deactivation
- Autolock and Horn Chirp Programming
- Programming the Autolock Feature Using the Door Lock Control Switch
- Programming the Autolock Feature Using the Keyless Entry Keypad
- Programming the Autolock Feature Using the Instrument Cluster Message Center
- Programming the Auto-Unlock Feature Using the Door Lock Control Switch
- Programming the Auto-Unlock Feature Using the Keyless Entry Keypad
- Programming the Auto-Unlock Feature Using the Instrument Cluster Message Center
- Stepped Unlock Programming
- Perimeter Lighting Feature Programming
- Removal And Installation
- Hood Latch and Components - Exploded View
- Hood Latch
- Hood Latch Release Handle
- Front Door Handles, Locks and Latches - Exploded View
- Front Door Latch
- Interior Door Handle
- Door Lock Actuator
- Door Ajar Switch
- Exterior Front Door Handle
- Door Handle Reinforcement - Exterior, Front
- Rear Door Handles, Locks and Latches - Exploded View
- Rear Door Latch
- Exterior Rear Door Handle
- Door Handle Reinforcement - Exterior, Rear
- Liftgate Handle, Lock and Latch - Exploded View
- Liftgate Latch
- Liftgate Release Switch
- Luggage Compartment Lid Latch
- Ignition Lock Cylinder
- Door Lock Cylinder
- Door Lock Control Switch
- Keyless Entry Keypad
- Passive Anti-Theft System Job Aid
- Anti-Theft - Passive Anti-Theft System (Pats)
- Collision/Avoidance
- Parking Aid System
- Specifications
- Description And Operation
- Diagnostic Tests
- Parking Aid
- Notes
- Principles of Operation
- Inspection and Verification
- DTC Tables
- Symptom Chart
- Pinpoint Tests
- Pinpoint Test A: The Parking Aid Is Inoperative/Does Not Operate Correctly
- Pinpoint Test B: DTCs C1700, C1703, C1706, C1709 - Parking Aid Sensor Circuit Failure or Blockage
- Pinpoint Test C: DTCs C1699, C1702, C1705 and C1708 - Parking Aid Sensor Circuit Short To Vbat
- Pinpoint Test D: DTCs C1701, C1704, C1707 and C1710 - Parking Aid Sensor Circuit Fault
- Pinpoint Test E: DTC B1299 - Power Supply Sensor Circuit Short To Ground
- Pinpoint Test F: DTC C1742 and C1743 - Rear Sounder Circuit Short To Vbatt & Rear Sounder Circuit Failure
- Pinpoint Test G: DTC C1748 - Switch Input Circuit Short To Ground
- Pinpoint Test H: DTC C1920 and B2373 - LED #1 Circuit Short to Battery & LED #1 Circuit Failure
- Pinpoint Test I: DTC B1065 and B1066 - Radio Volume Cutback Circuit Failure & Radio Volume Cutback Circuit Short to Battery
- Parking Aid
- General Procedures
- Removal And Installation
- Parking Aid System
- Communication Devices
- Module Communications Network System
- Description And Operation
- Diagnostic Tests
- Communications Network
- Notes
- Principles of Operation
- Inspection and Verification
- DTC Tables
- Symptom Chart
- Pinpoint Tests
- Pinpoint Test A: The PCM Does Not Respond To The Scan Tool
- Pinpoint Test B: The ABS Module Does Not Respond To The Scan Tool
- Pinpoint Test C: The Instrument Cluster (IC) Does Not Respond To The Scan Tool
- Pinpoint Test D: The 4X4 Control Module Does Not Respond To The Scan Tool
- Pinpoint Test E: The Restraints Control Module (RCM) Does Not Respond To The Scan Tool
- Pinpoint Test F: The Occupant Classification System Module (OCSM) Does Not Respond With the Scan Tool
- Pinpoint Test G: The Steering Effort Control Module (SECM) Does Not Respond To The Scan Tool
- Pinpoint Test H: The Smart Junction Box (SJB) Does Not Respond To The Scan Tool
- Pinpoint Test I: The Audio Control Module (ACM) Does Not Respond To The Scan Tool
- Pinpoint Test J: The Driver Seat Module (DSM) Does Not Respond To The Scan Tool
- Pinpoint Test K: The Rear Entertainment Module (RETM) Does Not Respond To The Scan Tool
- Pinpoint Test L: The Liftgate/Trunk Module (LTM) Does Not Respond With The Scan Tool
- Pinpoint Test M: The Satellite Digital Audio Receiver System (SDARS) Module Does Not Respond To The Scan Tool
- Pinpoint Test N: The Heating Ventilation Air Conditioning (HVAC) Module Does Not Respond To The Scan Tool
- Pinpoint Test O: The Accessory Protocol Interface Module (APIM) Does Not Respond To The Scan Tool
- Pinpoint Test P: The Parking Aid Module (PAM) Does Not Respond To The Scan Tool
- Pinpoint Test Q: No Power To The Scan Tool
- Pinpoint Test R: Intermittent No High Speed Controller Area Network (HS-CAN) Communication, One Or More Modules Are Not Responding During Network Test
- Pinpoint Test S: No High Speed Controller Area Network (HS-CAN) Communication, All Modules Are Not Responding
- Pinpoint Test T: Intermittent No Medium Speed Controller Area Network (MS-CAN) Communication, One Or More Modules Are Not Responding During Network Test
- Pinpoint Test U: No Medium Speed Controller Area Network (MS-CAN) Communication, All Modules Are Not Responding
- Communications Network
- Module Configuration System
- MULTIFUNCTION Electronic Modules System
- Module Communications Network System
- Cruise Control Systems
- Specifications
- Description And Operation
- Diagnostic Tests
- Removal And Installation
- Information System And Entertainment Systems
- Specifications
- Description And Operation
- Diagnostic Tests
- Information and Entertainment System
- Notes
- Principles of Operation
- Notes
- Audio Control Module (ACM)
- Navigation System
- Noise Suppression Equipment
- Satellite Audio
- Antenna - AM/FM
- Antenna - Satellite Radio
- Subwoofer
- DVD Entertainment System
- Single-Play Mode
- Dual-Play Mode
- SYNC System
- Voice Recognition For Vehicles With Navigation And The SYNC System
- Steering Wheel Controls
- Audio Input Jack - Vehicles Without The SYNC System
- Audio Signals
- Network Communication
- Inspection and Verification
- DTC Tables
- Symptom Chart
- Pinpoint Tests
- Pinpoint Test A: Poor Reception - AM/FM
- Pinpoint Test B: Poor Quality/Distorted/No Sound from One or More Speakers (Not All Speakers)
- Pinpoint Test C: The Subwoofer is Inoperative/Does Not Operate Correctly - Audiophile
- Pinpoint Test D: The Audio Does Not Reduce When The Parking Aid Tone Sounds
- Pinpoint Test E: The Steering Wheel Controls Are Inoperative/Do Not Operate Correctly
- Pinpoint Test F: The Speed Sensitive Volume Does Not Operate Correctly
- Pinpoint Test G: The Video System Does Not Operate Correctly
- Pinpoint Test H: Poor Reception/No Sound - Satellite Audio
- Pinpoint Test I: The Satellite Audio Is Inoperative/Does Not Operate Correctly - Vehicles Without DVD Entertainment System
- Pinpoint Test J: The Satellite Audio Is Inoperative/Does Not Operate Correctly - Vehicles With DVD Entertainment System
- Pinpoint Test K: The Audio Input Jack Is Inoperative/Does Not Operate Correctly
- Pinpoint Test L: No Global Positioning System (GPS) Antenna Signal
- Pinpoint Test M: The Audible Switch Feedback Is Inoperative
- Pinpoint Test N: The Voice Guidance Is Inoperative/Does Not Operate Correctly
- Pinpoint Test O: The Position Cursor Is Inaccurate
- Pinpoint Test P: Voice Recognition Is Inoperative/Does Not Operate Correctly - Vehicles Without The SYNC System
- Pinpoint Test Q: The SYNC System Is Completely Inoperative
- Pinpoint Test R: Unable To Pair Bluetooth® Device
- Pinpoint Test S: The Universal Serial Bus (USB) Port Is Inoperative/Does Not Operate Correctly
- Pinpoint Test T: The SYNC System Audible Prompts Are Inoperative/Do Not Operate Correctly
- Pinpoint Test U: Poor Quality/Distorted/No Sound While In SYNC Mode
- Pinpoint Test V: Voice Recognition Is Inoperative/Does Not Operate Correctly - Vehicles With The SYNC System
- Information and Entertainment System
- General Procedures
- Removal And Installation
- Antenna
- Antenna Cable - Satellite Radio
- Antenna Lead-In Cable
- Audio Input Jack
- Audio Control Module (ACM)
- Rear Entertainment Module (RETM)
- Door Speaker
- Global Positioning System (GPS) Antenna
- Parcel Shelf Speaker
- Satellite Digital Audio Receiver System (SDARS) Module
- Speaker Enclosure
- Steering Wheel Controls
- Subwoofer Amplifier
- Subwoofer Speaker
- Accessory Protocol Interface Module (APIM)
- Universal Serial Bus (USB) Cable and Port
- Exterior Lights
- Exterior Lighting System
- Specifications
- Description And Operation
- Diagnostic Tests
- Headlamps
- Notes
- Principles of Operation
- Inspection and Verification
- DTC Tables
- Symptom Chart
- Pinpoint Tests
- Autolamps
- Stoplamps
- Turn Signal and Hazard Lamps
- Notes
- Principles of Operation
- Inspection and Verification
- DTC Tables
- Symptom Chart
- Pinpoint Tests
- Parking, Rear and License Plate Lamps
- Fog Lamps
- Notes
- Principles of Operation
- Inspection and Verification
- DTC Tables
- Symptom Chart
- Pinpoint Tests
- Reversing Lamps
- Daytime Running Lamps (DRL)
- Headlamps
- General Procedures
- Removal And Installation
- Exterior Lighting System
- Gauges & Instrument Panels
- Clock
- Information Center
- Description And Operation
- Diagnostic Tests
- Instrument Cluster (IC), Message Center and Warning Chimes
- Notes
- Principles of Operation
- Inspection and Verification
- DTC Tables
- Instrument Cluster (IC) Dealer Test Mode
- Symptom Charts
- Pinpoint Tests
- Pinpoint Test A: The Instrument Cluster (IC) Is Inoperative
- Pinpoint Test B: Incorrect Fuel Gauge Indication - Front Wheel Drive (FWD) Sedan
- Pinpoint Test C: Incorrect Fuel Gauge Indication - Wagon Or All Wheel Drive (AWD) Sedan
- Pinpoint Test D: The Temperature Gauge Is Inoperative
- Pinpoint Test E: Incorrect Temperature Gauge Indication
- Pinpoint Test F: The Speedometer Is Inoperative
- Pinpoint Test G: Incorrect Speedometer Indication
- Pinpoint Test H: The Odometer Is Inoperative
- Pinpoint Test I: The Tachometer Is Inoperative
- Pinpoint Test J: Incorrect Tachometer Indication
- Pinpoint Test K: The Low Oil Pressure Warning Indicator Is Never/Always On
- Pinpoint Test L: The Low Fuel Warning Indicator Is Never/Always On
- Pinpoint Test M: The Charging System Warning Indicator Is Never/Always On
- Pinpoint Test N: The Brake Warning Indicator is Never On
- Pinpoint Test O: The Brake Warning Indicator is Always On
- Pinpoint Test P: The ABS Warning Indicator Is Never/Always On
- Pinpoint Test Q: The Malfunction Indicator Lamp (MIL) Is Never/Always On
- Pinpoint Test R: The Safety Belt Warning Indicator Is Never/Always On
- Pinpoint Test S: The Anti-Theft Indicator Is Never/Always On
- Pinpoint Test T: The Air Bag Warning Indicator Is Never/Always On
- Pinpoint Test U: The LH/RH Turn Or High Beam Indicator Is Never/Always On
- Pinpoint Test V: The Traction Assist Indicator Is Never/Always On
- Pinpoint Test W: The Speed Control Indicator Is Never/Always On
- Pinpoint Test X: The Powertrain Malfunction (Wrench) Warning Indicator Is Never/Always On
- Pinpoint Test Y: The Check Fuel Cap Indicator Is Never/Always On
- Pinpoint Test Z: The O/D OFF Indicator Is Never/Always On
- Pinpoint Test AA: The Tire Pressure Monitoring System (TPMS) Warning Indicator Is Never/Always On
- Pinpoint Test AB: DTC B1318 - Battery Voltage Low
- Pinpoint Test AC: DTC B2A20 or U2472 - Ignition Stuck in Start or Unexpected Ignition State
- Pinpoint Test AD: DTC U0100 - Lost Communication With ECM/PCM
- Pinpoint Test AE: DTC U0114 - Lost Communication With Four Wheel Drive Clutch Control Module
- Pinpoint Test AF: DTC U0121 - Lost Communication With Anti-Lock Brake System Control Module (ABS)
- Pinpoint Test AG: DTC U0140 - Lost Communication With Body Control Module (GEM)
- Pinpoint Test AH: DTC U0151 - Lost Communication With Restraints Control Module (RCM)
- Pinpoint Test AI: DTC U0164 - Lost Communication With HVAC Control Module (EATC)
- Pinpoint Test AJ: DTC U0208 - Lost Communication With Seat Control Module (DSM)
- Pinpoint Test AK: DTC U0230 - Lost Communication With Rear Gate Module (LTM)
- Pinpoint Test AL: The Message Center Is Not Operating Correctly
- Pinpoint Test AM: The Compass Is Inoperative
- Pinpoint Test AN: The Compass Is Inaccurate
- Pinpoint Test AO: The WASHER FLUID LEVEL LOW Display Does Not Operate Correctly
- Pinpoint Test AP: The DRIVER, PASSENGER, REAR LEFT, REAR RIGHT DOOR AJAR or LIFTGATE Warning Is Inoperative/Always On
- Pinpoint Test AQ: The Chime Sounds When The Driver Door Is Ajar (No Key In Ignition And Headlamps Off)
- Pinpoint Test AR: The Key-In-Ignition Warning Chime Is Inoperative
- Pinpoint Test AS: The Headlamps On Warning Chime Is Inoperative
- Pinpoint Test AT: The Safety Belt Warning Chime Does Not Operate Correctly/The Belt-Minder® Feature Does Not Operate Correctly
- Pinpoint Test AU: The Parking Brake Warning Chime Is Inoperative
- Instrument Cluster (IC), Message Center and Warning Chimes
- General Procedures
- Removal And Installation
- Information System And Entertainment Systems
- Specifications
- Description And Operation
- Diagnostic Tests
- Information and Entertainment System
- Notes
- Principles of Operation
- Notes
- Audio Control Module (ACM)
- Navigation System
- Noise Suppression Equipment
- Satellite Audio
- Antenna - AM/FM
- Antenna - Satellite Radio
- Subwoofer
- DVD Entertainment System
- Single-Play Mode
- Dual-Play Mode
- SYNC System
- Voice Recognition For Vehicles With Navigation And The SYNC System
- Steering Wheel Controls
- Audio Input Jack - Vehicles Without The SYNC System
- Audio Signals
- Network Communication
- Inspection and Verification
- DTC Tables
- Symptom Chart
- Pinpoint Tests
- Pinpoint Test A: Poor Reception - AM/FM
- Pinpoint Test B: Poor Quality/Distorted/No Sound from One or More Speakers (Not All Speakers)
- Pinpoint Test C: The Subwoofer is Inoperative/Does Not Operate Correctly - Audiophile
- Pinpoint Test D: The Audio Does Not Reduce When The Parking Aid Tone Sounds
- Pinpoint Test E: The Steering Wheel Controls Are Inoperative/Do Not Operate Correctly
- Pinpoint Test F: The Speed Sensitive Volume Does Not Operate Correctly
- Pinpoint Test G: The Video System Does Not Operate Correctly
- Pinpoint Test H: Poor Reception/No Sound - Satellite Audio
- Pinpoint Test I: The Satellite Audio Is Inoperative/Does Not Operate Correctly - Vehicles Without DVD Entertainment System
- Pinpoint Test J: The Satellite Audio Is Inoperative/Does Not Operate Correctly - Vehicles With DVD Entertainment System
- Pinpoint Test K: The Audio Input Jack Is Inoperative/Does Not Operate Correctly
- Pinpoint Test L: No Global Positioning System (GPS) Antenna Signal
- Pinpoint Test M: The Audible Switch Feedback Is Inoperative
- Pinpoint Test N: The Voice Guidance Is Inoperative/Does Not Operate Correctly
- Pinpoint Test O: The Position Cursor Is Inaccurate
- Pinpoint Test P: Voice Recognition Is Inoperative/Does Not Operate Correctly - Vehicles Without The SYNC System
- Pinpoint Test Q: The SYNC System Is Completely Inoperative
- Pinpoint Test R: Unable To Pair Bluetooth® Device
- Pinpoint Test S: The Universal Serial Bus (USB) Port Is Inoperative/Does Not Operate Correctly
- Pinpoint Test T: The SYNC System Audible Prompts Are Inoperative/Do Not Operate Correctly
- Pinpoint Test U: Poor Quality/Distorted/No Sound While In SYNC Mode
- Pinpoint Test V: Voice Recognition Is Inoperative/Does Not Operate Correctly - Vehicles With The SYNC System
- Information and Entertainment System
- General Procedures
- Removal And Installation
- Antenna
- Antenna Cable - Satellite Radio
- Antenna Lead-In Cable
- Audio Input Jack
- Audio Control Module (ACM)
- Rear Entertainment Module (RETM)
- Door Speaker
- Global Positioning System (GPS) Antenna
- Parcel Shelf Speaker
- Satellite Digital Audio Receiver System (SDARS) Module
- Speaker Enclosure
- Steering Wheel Controls
- Subwoofer Amplifier
- Subwoofer Speaker
- Accessory Protocol Interface Module (APIM)
- Universal Serial Bus (USB) Cable and Port
- Instrument Cluster System And Panel Illumination
- Description And Operation
- Diagnostic Tests
- Instrument Cluster and Panel Illumination
- Notes
- Principles of Operation
- Inspection and Verification
- DTC Tables
- Symptom Chart
- Pinpoint Tests
- Pinpoint Test A: The Control Illumination Is Inoperative - All Hardwired Illumination
- Pinpoint Test B: The Control Illumination Is Always On - All Hardwired Illumination
- Pinpoint Test C: All The Instrument Panel Illumination Does Not Dim
- Pinpoint Test D: The Steering Wheel Control Illumination Is Inoperative
- Pinpoint Test E: The Door Lock Control Switch Illumination is Inoperative
- Pinpoint Test F: The Roof Opening Panel Switch Illumination is Inoperative
- Pinpoint Test G: The Individual Component Illumination is Inoperative
- Instrument Cluster and Panel Illumination
- Removal And Installation
- Instrument Panel And Console
- Specifications
- Removal And Installation
- Instrument Panel - Exploded View
- Instrument Panel
- Instrument Panel Upper Section
- In-Vehicle Crossbeam
- Instrument Panel Finish Panel - Center, Taurus, Sable
- Instrument Panel Finish Panel - Center, Taurus X
- Instrument Cluster Finish Panel
- Power Point
- Console - Front, Floor
- Console - Rear, Floor
- Console - Overhead
- Headlights
- Exterior Lighting System
- Specifications
- Description And Operation
- Diagnostic Tests
- Headlamps
- Notes
- Principles of Operation
- Inspection and Verification
- DTC Tables
- Symptom Chart
- Pinpoint Tests
- Autolamps
- Stoplamps
- Turn Signal and Hazard Lamps
- Notes
- Principles of Operation
- Inspection and Verification
- DTC Tables
- Symptom Chart
- Pinpoint Tests
- Parking, Rear and License Plate Lamps
- Fog Lamps
- Notes
- Principles of Operation
- Inspection and Verification
- DTC Tables
- Symptom Chart
- Pinpoint Tests
- Reversing Lamps
- Daytime Running Lamps (DRL)
- Headlamps
- General Procedures
- Removal And Installation
- Exterior Lighting System
- Heated Glass/Defoggers
- Windows And Glass
- Specifications
- Description And Operation
- Diagnostic Tests
- Glass, Frames and Mechanisms
- Notes
- Principles of Operation
- Inspection and Verification
- DTC Table
- Symptom Chart
- Pinpoint Tests
- Pinpoint Test A: All Power Windows are Inoperative
- Pinpoint Test B: A Single Power Window is Inoperative - LH Front
- Pinpoint Test C: A Single Power Window is Inoperative - RH Front
- Pinpoint Test D: A Single Power Window is Inoperative - LH or RH Rear
- Pinpoint Test E: The One-Touch Up/Down Feature is Inoperative - LH Front Window Only
- Pinpoint Test F: The Defrost System is Inoperative
- Pinpoint Test G: The Defrost System Will Not Shut Off Automatically
- Pinpoint Test H: The Delayed Accessory is Inoperative
- Pinpoint Test I: The Delayed Accessory Does Not Turn Off
- Component Test
- Glass, Frames and Mechanisms
- General Procedures
- Removal And Installation
- Glass, Frames and Mechanisms - Exploded View, Front Door
- Window Glass - Front Door
- Window Regulator Motor
- Window Regulator and Motor - Front Door
- Door Glass Top Run - Front
- Glass, Frames and Mechanisms - Exploded View, Rear Door
- Window Glass - Rear Door
- Window Regulator Motor - Rear Door
- Door Glass Run and Bracket - Rear
- Window Control Switch
- Window Glass - Rear
- Window Glass - Rear Quarter, Taurus, Sable
- Window Glass - Fixed, Rear Door
- Window Glass - Liftgate
- Window Glass - Rear Quarter, Taurus X
- Windshield Glass
- Windows And Glass
- Horns
- Infotainment
- Information System And Entertainment Systems
- Specifications
- Description And Operation
- Diagnostic Tests
- Information and Entertainment System
- Notes
- Principles of Operation
- Notes
- Audio Control Module (ACM)
- Navigation System
- Noise Suppression Equipment
- Satellite Audio
- Antenna - AM/FM
- Antenna - Satellite Radio
- Subwoofer
- DVD Entertainment System
- Single-Play Mode
- Dual-Play Mode
- SYNC System
- Voice Recognition For Vehicles With Navigation And The SYNC System
- Steering Wheel Controls
- Audio Input Jack - Vehicles Without The SYNC System
- Audio Signals
- Network Communication
- Inspection and Verification
- DTC Tables
- Symptom Chart
- Pinpoint Tests
- Pinpoint Test A: Poor Reception - AM/FM
- Pinpoint Test B: Poor Quality/Distorted/No Sound from One or More Speakers (Not All Speakers)
- Pinpoint Test C: The Subwoofer is Inoperative/Does Not Operate Correctly - Audiophile
- Pinpoint Test D: The Audio Does Not Reduce When The Parking Aid Tone Sounds
- Pinpoint Test E: The Steering Wheel Controls Are Inoperative/Do Not Operate Correctly
- Pinpoint Test F: The Speed Sensitive Volume Does Not Operate Correctly
- Pinpoint Test G: The Video System Does Not Operate Correctly
- Pinpoint Test H: Poor Reception/No Sound - Satellite Audio
- Pinpoint Test I: The Satellite Audio Is Inoperative/Does Not Operate Correctly - Vehicles Without DVD Entertainment System
- Pinpoint Test J: The Satellite Audio Is Inoperative/Does Not Operate Correctly - Vehicles With DVD Entertainment System
- Pinpoint Test K: The Audio Input Jack Is Inoperative/Does Not Operate Correctly
- Pinpoint Test L: No Global Positioning System (GPS) Antenna Signal
- Pinpoint Test M: The Audible Switch Feedback Is Inoperative
- Pinpoint Test N: The Voice Guidance Is Inoperative/Does Not Operate Correctly
- Pinpoint Test O: The Position Cursor Is Inaccurate
- Pinpoint Test P: Voice Recognition Is Inoperative/Does Not Operate Correctly - Vehicles Without The SYNC System
- Pinpoint Test Q: The SYNC System Is Completely Inoperative
- Pinpoint Test R: Unable To Pair Bluetooth® Device
- Pinpoint Test S: The Universal Serial Bus (USB) Port Is Inoperative/Does Not Operate Correctly
- Pinpoint Test T: The SYNC System Audible Prompts Are Inoperative/Do Not Operate Correctly
- Pinpoint Test U: Poor Quality/Distorted/No Sound While In SYNC Mode
- Pinpoint Test V: Voice Recognition Is Inoperative/Does Not Operate Correctly - Vehicles With The SYNC System
- Information and Entertainment System
- General Procedures
- Removal And Installation
- Antenna
- Antenna Cable - Satellite Radio
- Antenna Lead-In Cable
- Audio Input Jack
- Audio Control Module (ACM)
- Rear Entertainment Module (RETM)
- Door Speaker
- Global Positioning System (GPS) Antenna
- Parcel Shelf Speaker
- Satellite Digital Audio Receiver System (SDARS) Module
- Speaker Enclosure
- Steering Wheel Controls
- Subwoofer Amplifier
- Subwoofer Speaker
- Accessory Protocol Interface Module (APIM)
- Universal Serial Bus (USB) Cable and Port
- Information System And Entertainment Systems
- Interior/Exterior Trim
- Exterior Trim And Ornamentation
- Interior Trim And Ornamentation
- Specifications
- Removal And Installation
- Interior Trim - Exploded View
- Scuff Plate Trim Panel
- A-Pillar Trim Panel
- B-Pillar Trim Panel
- C-Pillar Trim Panel - Taurus, Sable
- C-Pillar Trim Panel - Taurus X
- D-Pillar Trim Panel - Taurus, Sable
- D-Pillar Trim Panel - Taurus X
- Quarter Trim Panel
- Door Trim Panel - Front
- Door Trim Panel - Rear
- Liftgate Trim Panel
- Parcel Shelf
- Sunshade - Rear
- Headliner - Taurus, Sable
- Headliner - Taurus X
- Power Point
- Interior/Illumination Lights
- Interior Lighting System
- Description And Operation
- Diagnostic Tests
- Interior Lighting
- Notes
- Principles of Operation
- Inspection and Verification
- DTC Tables
- Symptom Chart
- Pinpoint Tests
- Pinpoint Test A: The Courtesy Lamps Are Inoperative
- Pinpoint Test B: The Courtesy Lamps Stay On Continuously
- Pinpoint Test C: An Individual Courtesy Lamp Is Inoperative
- Pinpoint Test D: The Courtesy Lamps Do Not Turn On With One Door Open
- Pinpoint Test E: The Courtesy Lamps Do Not Turn On With the Liftgate Open
- Pinpoint Test F: The Courtesy Lamps Are Inoperative - From The Dimmer Switch
- Pinpoint Test G: The Puddle Lamp(s) are Inoperative
- Pinpoint Test H: The Puddle Lamps Stay On Continuously
- Pinpoint Test I: The Demand Lamps Are Inoperative
- Pinpoint Test J: An Individual Demand Lamp Is Inoperative
- Pinpoint Test K: The Luggage Compartment Lamp Is Inoperative/Does Not Operate Correctly
- Pinpoint Test L: The Battery Saver Does Not Deactivate After Time-Out
- Interior Lighting
- Removal And Installation
- Interior Lighting System
- Mirrors
- Rear View Mirror System
- Specifications
- Description And Operation
- Diagnostic Tests
- Rear View Mirrors
- Notes
- Principles of Operation
- Inspection and Verification
- Symptom Chart
- Pinpoint Tests
- Pinpoint Test A: The Mirrors are Inoperative - Non-Memory Mirrors
- Pinpoint Test B: A Single Mirror is Inoperative - Non-Memory Mirrors
- Pinpoint Test C: A Single Mirror Does Not Function with Switch Logic - Non-Memory Mirrors
- Pinpoint Test D: The Auto-Dimming Mirror Does Not Operate Correctly
- Pinpoint Test E: The Heated Exterior Mirror is Inoperative
- Pinpoint Test F: The Memory Mirror is Inoperative
- Rear View Mirrors
- Removal And Installation
- Rear View Mirror System
- Seats
- Seat System
- Specifications
- Description And Operation
- Diagnostic Tests
- Seats
- Notes
- Principles of Operation
- Inspection and Verification
- Driver Seat Module (DSM) DTC Table
- Smart Junction Box (SJB) DTC Table
- Symptom Chart
- Pinpoint Tests
- Notes
- Pinpoint Test A: The Power Seat is Inoperative - Driver, With Power Recliner
- Pinpoint Test B: The Power Seat is Inoperative - Driver, Without Power Recliner
- Pinpoint Test C: The Power Seat is Inoperative - Passenger, With Power Recliner
- Pinpoint Test D: The Power Seat is Inoperative - Passenger, Without Power Recliner
- Pinpoint Test E: The Power Seat Does Not Move Horizontally/Vertically/Recline - Driver, With Power Recliner
- Pinpoint Test F: The Power Seat Does Not Move Horizontally/Vertically - Driver, Without Power Recliner
- Pinpoint Test G: The Power Seat Does Not Move Horizontally/Recline - Passenger
- Pinpoint Test H: The Power Seat Moves but is Noisy
- Pinpoint Test I: The Power Seat Moves but is Loose
- Pinpoint Test J: The Power Seat Does Not Make Full Travel
- Pinpoint Test K: The Memory Seat is Inoperative/Does Not Operate Correctly - Does Not Operate Horizontally/Vertically/Recline
- Pinpoint Test L: The Memory Seat Does Not Operate Correctly - Does Not Operate Using the Memory SET Switch
- Pinpoint Test M: The Heated Seats are Inoperative - Driver and Front Passenger
- Pinpoint Test N: The Heated Seat is Inoperative/Does Not Operate Correctly - Driver
- Pinpoint Test O: The Heated Seat is Inoperative/Does Not Operate Correctly - Front Passenger
- Pinpoint Test P: The Heated Seat Does Not Operate Correctly - Driver Seat Does Heat but the Heated Seat Indicator Does Not Illuminate
- Pinpoint Test Q: The Heated Seat Does Not Operate Correctly - Front Passenger Seat Does Heat but the Heated Seat Indicator Does Not Illuminate
- Pinpoint Test R: The Power Seat is Inoperative/Does Not Operate Correctly - Second Row, Power-Fold
- Pinpoint Test S: The Power Seat is Inoperative - Second Row, Power-Fold Seat Does Not Latch to the Floor
- Pinpoint Test T: The Heated Seats are Inoperative - Rear
- Pinpoint Test U: The Heated Seat is Inoperative/Does Not Operate Correctly - Left Rear
- Pinpoint Test V: The Heated Seat is Inoperative/Does Not Operate Correctly - Right Rear
- Pinpoint Test W: The Heated Seat Does Not Operate Correctly - Left Rear Seat Does Heat but the Heated Seat Indicator Does Not Illuminate When Pressed
- Pinpoint Test X: The Heated Seat Does Not Operate Correctly - Right Rear Seat Does Heat but the Heated Seat Indicator Does Not Illuminate When Pressed
- Pinpoint Test Y: The Heated Seat Does Not Operate Correctly - Left Rear Seat Does Heat but the Heated Seat Indicator is On All the Time
- Pinpoint Test Z: The Heated Seat Does Not Operate Correctly - Right Rear Seat Does Heat but the Heated Seat Indicator is On All the Time
- Pinpoint Test AA: Easy Exit/Easy Entry is Inoperative/Does Not Operate Correctly
- Pinpoint Test AB: The Seat Backrest Will Not Fold Upright - Second Row, 60 Percent
- Pinpoint Test AC: The Seat Backrest Will Not Fold Down - Second Row, 60 Percent
- Pinpoint Test AD: The Seat Backrest Will Not Fold Down/Fold Upright - Second Row, 40 Percent (RH or LH)
- Seats
- General Procedures
- Removal And Installation
- Seat - Front
- Seat - Exploded View, Front
- Seat Backrest - Front
- Seat Backrest Cover - Front
- Seat Cushion Cover - Front
- Heated Seat Module - Front
- Lumbar Assembly
- Seat Control Switch - Front
- Seat Recliner - Front
- Seat Track - Front
- Seat Backrest - Rear, Taurus, Sable
- Seat Bolster - Rear, Taurus, Sable
- Seat Cushion - Rear, Taurus, Sable
- Seat - Exploded View, Second Row, Taurus, Sable
- Seat Backrest Cover - Rear, 60 Percent, Taurus, Sable
- Seat Backrest Cover - Rear, 40 Percent, Taurus, Sable
- Seat - Rear, Second Row, Taurus X
- Seat - Exploded View, Second Row, Taurus X
- Seat Backrest - Second Row, 60 Percent, Taurus X
- Seat Backrest - Second Row, 40 Percent, Taurus X
- Seat Backrest Cover - Second Row, 60 Percent, Taurus X
- Seat Backrest Cover - Second Row, 40 Percent, Taurus X
- Seat Cushion Cover - Second Row, 60 Percent, Taurus X
- Seat Cushion Cover - Second Row, 40 Percent, Taurus X
- Seat Recliner - Inboard, Second Row, 60 Percent, Taurus X
- Seat Recliner - Outboard, Second Row, 60 Percent, Taurus X
- Seat Recliner - Second Row, 40 Percent, Taurus X
- Seat Track - Second Row, 40 Percent, Taurus X
- Heated Seat Switch - Rear
- Heated Seat Module - Rear
- Power-Fold Seat Motor
- Seat - Third Row
- Seat - Exploded View, Third Row
- Seat Backrest Cover - Third Row
- Seat Cushion Cover - Third Row
- Seat Backrest - Third Row, Bench
- Seat Backrest - Third Row, 50 Percent
- Disassembly And Assembly
- Seat Backrest - Front
- Seat Cushion - Driver
- Seat Cushion - Front, Passenger Side
- Seat Backrest - Rear, 40 Percent, Taurus, Sable
- Seat Backrest - Rear, 60 Percent, Taurus, Sable
- Seat Cushion - Second Row, Power-Fold
- Seat Backrest - Second Row, 40 Percent, Taurus X
- Seat Backrest - Second Row, 60 Percent, Taurus X
- Seat Cushion - Second Row, 40 Percent, Taurus X
- Seat Cushion - Second Row, 60 Percent, Taurus X
- Seat Backrest - Third Row
- Seat Cushion - Third Row, Bench
- Seat Cushion - Third Row, 50 Percent
- Seat System
- Steering Column Switches
- Specifications
- Description And Operation
- Diagnostic Tests
- Steering Column Switches
- Notes
- Principles of Operation
- Inspection and Verification
- Symptom Chart
- Pinpoint Tests
- Component Tests
- Steering Column Switches
- Removal And Installation
- Window Motors & Regulators
- Windows And Glass
- Specifications
- Description And Operation
- Diagnostic Tests
- Glass, Frames and Mechanisms
- Notes
- Principles of Operation
- Inspection and Verification
- DTC Table
- Symptom Chart
- Pinpoint Tests
- Pinpoint Test A: All Power Windows are Inoperative
- Pinpoint Test B: A Single Power Window is Inoperative - LH Front
- Pinpoint Test C: A Single Power Window is Inoperative - RH Front
- Pinpoint Test D: A Single Power Window is Inoperative - LH or RH Rear
- Pinpoint Test E: The One-Touch Up/Down Feature is Inoperative - LH Front Window Only
- Pinpoint Test F: The Defrost System is Inoperative
- Pinpoint Test G: The Defrost System Will Not Shut Off Automatically
- Pinpoint Test H: The Delayed Accessory is Inoperative
- Pinpoint Test I: The Delayed Accessory Does Not Turn Off
- Component Test
- Glass, Frames and Mechanisms
- General Procedures
- Removal And Installation
- Glass, Frames and Mechanisms - Exploded View, Front Door
- Window Glass - Front Door
- Window Regulator Motor
- Window Regulator and Motor - Front Door
- Door Glass Top Run - Front
- Glass, Frames and Mechanisms - Exploded View, Rear Door
- Window Glass - Rear Door
- Window Regulator Motor - Rear Door
- Door Glass Run and Bracket - Rear
- Window Control Switch
- Window Glass - Rear
- Window Glass - Rear Quarter, Taurus, Sable
- Window Glass - Fixed, Rear Door
- Window Glass - Liftgate
- Window Glass - Rear Quarter, Taurus X
- Windshield Glass
- Windows And Glass
- Wiper/Washer Systems
- Wiper System And Washer System
- Specifications
- Description And Operation
- Diagnostic Tests
- Wipers and Washers
- Notes
- Principles of Operation
- Inspection and Verification
- Symptom Chart
- Pinpoint Tests
- Pinpoint Test A: The Wipers are Inoperative - Windshield
- Pinpoint Test B: The Wipers are Inoperative - Rear Window
- Pinpoint Test C: The Wipers Stay On Continuously - Windshield
- Pinpoint Test D: The Wipers Stay On Continuously - Rear Window
- Pinpoint Test E: The High/Low Wiper Speeds Do Not Operate Correctly - Windshield
- Pinpoint Test F: The Intermittent Wiper Speed Does Not Operate Correctly - Rear Window
- Pinpoint Test G: The Intermittent Wiper Speed Does Not Operate Correctly - Windshield
- Pinpoint Test H: The Washer Pump is Inoperative - Taurus or Sable
- Pinpoint Test I: The Washer Pump is Inoperative - Taurus X
- Pinpoint Test J: The Headlamps Do Not Illuminate When the Wipers are On
- Wipers and Washers
- General Procedures
- Removal And Installation
- Wiper System And Washer System
- Accessories Control Systems
- Body & Frame
- Door Locks
- Anti-Theft - Passive Anti-Theft System (Pats)
- Description And Operation
- Diagnostic Tests
- Anti-Theft
- Notes
- Principles of Operation
- Inspection and Verification
- DTC Tables
- Symptom Chart
- Pinpoint Tests
- Pinpoint Test A: DTC B2103 - Antenna Not Connected
- Pinpoint Test B: DTC B1600 - PATS Ignition Key Transponder Signal Is Not Received
- Pinpoint Test C: DTC B1601 - PATS Received Incorrect Key-Code From Ignition Key Transponder
- Pinpoint Test D: DTC B1602 - PATS Received Invalid Format Of Key-Code From Ignition Key Transponder
- Pinpoint Test E: DTC B1681 - PATS Transceiver Module Signal Is Not Received
- Pinpoint Test F: The Anti-Theft Indicator Is Always/Never On
- Pinpoint Test G: DTC U0100 and U2511 - CAN - Data Mis-Match (Receive Data Does Not Match Expected) & Lost Communication With ECM/PCM
- Pinpoint Test H: The Vehicle Does Not Start
- Anti-Theft
- General Procedures
- Integrated Keyhead Transmitter (IKT) Key Programming Using Diagnostic Equipment
- Key Programming Using Two Programmed Keys
- Key Programming Switch State Control
- Spare Key Programming - Unlimited Key Mode
- Spare Key Programming - Using Diagnostic Equipment
- Anti-Theft Security Access
- Passive Anti-Theft System (PATS) Parameter Reset
- Removal And Installation
- Anti-Theft System - Perimeter
- Handles, Locks, Latches And Entry Systems
- Specifications
- Description And Operation
- Handles, Locks, Latches and Entry Systems
- Notes
- Hood Latch
- Front Door
- Rear Door
- Luggage Compartment Lid
- Manual Liftgate
- Power Liftgate
- Power Lock/Unlock
- Autolock
- Auto-Unlock
- Smart Unlock
- Remote Keyless Entry (RKE)
- Remote Keyless Entry (RKE) Lock/Unlock Control - Unlock
- Remote Keyless Entry (RKE) Lock/Unlock Control - Lock
- Remote Keyless Entry (RKE) Luggage Compartment/Power Liftgate Release
- Remote Keyless Entry (RKE) Memory Seat Feature
- Panic Alarm
- Keyless Entry Keypad
- Locking the Doors with the Keyless Entry Keypad System
- Unlocking the Doors with the Keyless Entry Keypad System
- Keyless Entry Keypad Memory Seat Feature
- Anti-Scan Feature
- Perimeter Lighting Feature
- Handles, Locks, Latches and Entry Systems
- Diagnostic Tests
- Locks, Latches and Entry Systems
- Notes
- Principles of Operation
- Inspection and Verification
- DTC Tables
- Symptom Chart
- Pinpoint Tests
- Pinpoint Test A: All Door Locks Are Inoperative
- Pinpoint Test B: A Single/More Than One Door Lock Is Inoperative
- Pinpoint Test C: The Door Locks Operate Only One Way
- Pinpoint Test D: All Door Locks Are Inoperative From One Switch
- Pinpoint Test E: DTC B2A25
- Pinpoint Test F: The Luggage Compartment Lid Latch Release Is Inoperative/Does Not Operate Correctly
- Pinpoint Test G: The Liftgate Latch Release Is Inoperative/Does Not Operate Correctly
- Pinpoint Test H: The Doors Do Not Lock/Unlock Using The Keyless Entry Keypad
- Pinpoint Test I: The Keyless Entry Keypad Illumination Is Inoperative/Does Not Operate Correctly
- Pinpoint Test J: The Remote Keyless Entry (RKE) Transmitter Is Inoperative
- Pinpoint Test K: An Individual Button/Feature Is Inoperative From The Remote Keyless Entry (RKE) Transmitter
- Pinpoint Test L: The Remote Keyless Entry (RKE) Transmitter Has Poor Range Performance
- Pinpoint Test M: The Autolock Does Not Operate Correctly
- Pinpoint Test N: The Smart Unlock Does Not Operate Correctly
- Pinpoint Test O: DTC B1137
- Locks, Latches and Entry Systems
- General Procedures
- Remote Keyless Entry Transmitter Programming
- Keyless Entry Keypad Code Programming
- Remote Memory Activation
- Remote Memory Deactivation
- Autolock and Horn Chirp Programming
- Programming the Autolock Feature Using the Door Lock Control Switch
- Programming the Autolock Feature Using the Keyless Entry Keypad
- Programming the Autolock Feature Using the Instrument Cluster Message Center
- Programming the Auto-Unlock Feature Using the Door Lock Control Switch
- Programming the Auto-Unlock Feature Using the Keyless Entry Keypad
- Programming the Auto-Unlock Feature Using the Instrument Cluster Message Center
- Stepped Unlock Programming
- Perimeter Lighting Feature Programming
- Removal And Installation
- Hood Latch and Components - Exploded View
- Hood Latch
- Hood Latch Release Handle
- Front Door Handles, Locks and Latches - Exploded View
- Front Door Latch
- Interior Door Handle
- Door Lock Actuator
- Door Ajar Switch
- Exterior Front Door Handle
- Door Handle Reinforcement - Exterior, Front
- Rear Door Handles, Locks and Latches - Exploded View
- Rear Door Latch
- Exterior Rear Door Handle
- Door Handle Reinforcement - Exterior, Rear
- Liftgate Handle, Lock and Latch - Exploded View
- Liftgate Latch
- Liftgate Release Switch
- Luggage Compartment Lid Latch
- Ignition Lock Cylinder
- Door Lock Cylinder
- Door Lock Control Switch
- Keyless Entry Keypad
- Passive Anti-Theft System Job Aid
- Anti-Theft - Passive Anti-Theft System (Pats)
- Exterior Body Panels
- Body Panel System - Body Closures
- Specifications
- Description And Operation
- Diagnostic Tests
- Power Liftgate
- Notes
- Principles Of Operation
- Power and Ground Requirements
- Power Liftgate Detent Switch, Forkbolt Primary Switch and Forkbolt Secondary Switch
- Manual Latch Release for Power Liftgate
- Unlatch/Cinching Motor
- Sector Gear Switches
- Power Liftgate Control Switch - Instrument Panel
- Power Liftgate Rear Control Switch - Quarter Trim Panel
- Exterior Handle Switch
- Remote Keyless Entry (RKE) Operation
- Power Liftgate Interface
- Power Liftgate Operation
- Power Liftgate Chime
- Power Liftgate Initialization Procedure
- Power Liftgate Awake/Sleep Status
- Inspection and Verification
- DTC Tables
- Symptom Chart
- Pinpoint Tests
- Pinpoint Test A: The Power Liftgate is Inoperative - Does Not Open or Close
- Pinpoint Test B: The Power Liftgate is Inoperative From an Individual Switch
- Pinpoint Test C: The Power Liftgate Does Not Operate Correctly - Stops in Secondary Latch Position (Does Not Pull into Primary Latch Position)
- Pinpoint Test D: The Power Liftgate Does Not Operate Correctly - Reverses During the Power Close Operation
- Pinpoint Test E: The Power Liftgate Chime is Inoperative
- Pinpoint Test F: The Power Liftgate Does Not Operate Correctly - Pinch Strip Does Not Stop/Reverse the Liftgate
- Pinpoint Test G: The Power Liftgate Does Not Power Close (Power Open OK)
- Pinpoint Test H: The Power Liftgate Does Not Power Open (Power Close OK)
- Pinpoint Test I: Power Liftgate DTC B117C - Latch Centering Switch Invalid
- Pinpoint Test J: DTC B1317/B1318 - Battery Voltage High/Battery Voltage Low
- Pinpoint Test K: The Power Liftgate Does Not Operate Correctly - Closes (With a Continuous Chime) Immediately After a Power Open
- Power Liftgate
- General Procedures
- Removal And Installation
- Body Panel System - Front End Body Panels
- Bumper System
- Body Panel System - Body Closures
- Exterior/Interior Trim
- Exterior Trim And Ornamentation
- Interior Trim And Ornamentation
- Specifications
- Removal And Installation
- Interior Trim - Exploded View
- Scuff Plate Trim Panel
- A-Pillar Trim Panel
- B-Pillar Trim Panel
- C-Pillar Trim Panel - Taurus, Sable
- C-Pillar Trim Panel - Taurus X
- D-Pillar Trim Panel - Taurus, Sable
- D-Pillar Trim Panel - Taurus X
- Quarter Trim Panel
- Door Trim Panel - Front
- Door Trim Panel - Rear
- Liftgate Trim Panel
- Parcel Shelf
- Sunshade - Rear
- Headliner - Taurus, Sable
- Headliner - Taurus X
- Power Point
- Frames, Subframes & Crossmembers
- Mirrors
- Rear View Mirror System
- Specifications
- Description And Operation
- Diagnostic Tests
- Rear View Mirrors
- Notes
- Principles of Operation
- Inspection and Verification
- Symptom Chart
- Pinpoint Tests
- Pinpoint Test A: The Mirrors are Inoperative - Non-Memory Mirrors
- Pinpoint Test B: A Single Mirror is Inoperative - Non-Memory Mirrors
- Pinpoint Test C: A Single Mirror Does Not Function with Switch Logic - Non-Memory Mirrors
- Pinpoint Test D: The Auto-Dimming Mirror Does Not Operate Correctly
- Pinpoint Test E: The Heated Exterior Mirror is Inoperative
- Pinpoint Test F: The Memory Mirror is Inoperative
- Rear View Mirrors
- Removal And Installation
- Rear View Mirror System
- Seats
- Seat System
- Specifications
- Description And Operation
- Diagnostic Tests
- Seats
- Notes
- Principles of Operation
- Inspection and Verification
- Driver Seat Module (DSM) DTC Table
- Smart Junction Box (SJB) DTC Table
- Symptom Chart
- Pinpoint Tests
- Notes
- Pinpoint Test A: The Power Seat is Inoperative - Driver, With Power Recliner
- Pinpoint Test B: The Power Seat is Inoperative - Driver, Without Power Recliner
- Pinpoint Test C: The Power Seat is Inoperative - Passenger, With Power Recliner
- Pinpoint Test D: The Power Seat is Inoperative - Passenger, Without Power Recliner
- Pinpoint Test E: The Power Seat Does Not Move Horizontally/Vertically/Recline - Driver, With Power Recliner
- Pinpoint Test F: The Power Seat Does Not Move Horizontally/Vertically - Driver, Without Power Recliner
- Pinpoint Test G: The Power Seat Does Not Move Horizontally/Recline - Passenger
- Pinpoint Test H: The Power Seat Moves but is Noisy
- Pinpoint Test I: The Power Seat Moves but is Loose
- Pinpoint Test J: The Power Seat Does Not Make Full Travel
- Pinpoint Test K: The Memory Seat is Inoperative/Does Not Operate Correctly - Does Not Operate Horizontally/Vertically/Recline
- Pinpoint Test L: The Memory Seat Does Not Operate Correctly - Does Not Operate Using the Memory SET Switch
- Pinpoint Test M: The Heated Seats are Inoperative - Driver and Front Passenger
- Pinpoint Test N: The Heated Seat is Inoperative/Does Not Operate Correctly - Driver
- Pinpoint Test O: The Heated Seat is Inoperative/Does Not Operate Correctly - Front Passenger
- Pinpoint Test P: The Heated Seat Does Not Operate Correctly - Driver Seat Does Heat but the Heated Seat Indicator Does Not Illuminate
- Pinpoint Test Q: The Heated Seat Does Not Operate Correctly - Front Passenger Seat Does Heat but the Heated Seat Indicator Does Not Illuminate
- Pinpoint Test R: The Power Seat is Inoperative/Does Not Operate Correctly - Second Row, Power-Fold
- Pinpoint Test S: The Power Seat is Inoperative - Second Row, Power-Fold Seat Does Not Latch to the Floor
- Pinpoint Test T: The Heated Seats are Inoperative - Rear
- Pinpoint Test U: The Heated Seat is Inoperative/Does Not Operate Correctly - Left Rear
- Pinpoint Test V: The Heated Seat is Inoperative/Does Not Operate Correctly - Right Rear
- Pinpoint Test W: The Heated Seat Does Not Operate Correctly - Left Rear Seat Does Heat but the Heated Seat Indicator Does Not Illuminate When Pressed
- Pinpoint Test X: The Heated Seat Does Not Operate Correctly - Right Rear Seat Does Heat but the Heated Seat Indicator Does Not Illuminate When Pressed
- Pinpoint Test Y: The Heated Seat Does Not Operate Correctly - Left Rear Seat Does Heat but the Heated Seat Indicator is On All the Time
- Pinpoint Test Z: The Heated Seat Does Not Operate Correctly - Right Rear Seat Does Heat but the Heated Seat Indicator is On All the Time
- Pinpoint Test AA: Easy Exit/Easy Entry is Inoperative/Does Not Operate Correctly
- Pinpoint Test AB: The Seat Backrest Will Not Fold Upright - Second Row, 60 Percent
- Pinpoint Test AC: The Seat Backrest Will Not Fold Down - Second Row, 60 Percent
- Pinpoint Test AD: The Seat Backrest Will Not Fold Down/Fold Upright - Second Row, 40 Percent (RH or LH)
- Seats
- General Procedures
- Removal And Installation
- Seat - Front
- Seat - Exploded View, Front
- Seat Backrest - Front
- Seat Backrest Cover - Front
- Seat Cushion Cover - Front
- Heated Seat Module - Front
- Lumbar Assembly
- Seat Control Switch - Front
- Seat Recliner - Front
- Seat Track - Front
- Seat Backrest - Rear, Taurus, Sable
- Seat Bolster - Rear, Taurus, Sable
- Seat Cushion - Rear, Taurus, Sable
- Seat - Exploded View, Second Row, Taurus, Sable
- Seat Backrest Cover - Rear, 60 Percent, Taurus, Sable
- Seat Backrest Cover - Rear, 40 Percent, Taurus, Sable
- Seat - Rear, Second Row, Taurus X
- Seat - Exploded View, Second Row, Taurus X
- Seat Backrest - Second Row, 60 Percent, Taurus X
- Seat Backrest - Second Row, 40 Percent, Taurus X
- Seat Backrest Cover - Second Row, 60 Percent, Taurus X
- Seat Backrest Cover - Second Row, 40 Percent, Taurus X
- Seat Cushion Cover - Second Row, 60 Percent, Taurus X
- Seat Cushion Cover - Second Row, 40 Percent, Taurus X
- Seat Recliner - Inboard, Second Row, 60 Percent, Taurus X
- Seat Recliner - Outboard, Second Row, 60 Percent, Taurus X
- Seat Recliner - Second Row, 40 Percent, Taurus X
- Seat Track - Second Row, 40 Percent, Taurus X
- Heated Seat Switch - Rear
- Heated Seat Module - Rear
- Power-Fold Seat Motor
- Seat - Third Row
- Seat - Exploded View, Third Row
- Seat Backrest Cover - Third Row
- Seat Cushion Cover - Third Row
- Seat Backrest - Third Row, Bench
- Seat Backrest - Third Row, 50 Percent
- Disassembly And Assembly
- Seat Backrest - Front
- Seat Cushion - Driver
- Seat Cushion - Front, Passenger Side
- Seat Backrest - Rear, 40 Percent, Taurus, Sable
- Seat Backrest - Rear, 60 Percent, Taurus, Sable
- Seat Cushion - Second Row, Power-Fold
- Seat Backrest - Second Row, 40 Percent, Taurus X
- Seat Backrest - Second Row, 60 Percent, Taurus X
- Seat Cushion - Second Row, 40 Percent, Taurus X
- Seat Cushion - Second Row, 60 Percent, Taurus X
- Seat Backrest - Third Row
- Seat Cushion - Third Row, Bench
- Seat Cushion - Third Row, 50 Percent
- Seat System
- Sun Roof/T-Top/Convertible Top
- Sunroof
- Specifications
- Description And Operation
- Diagnostic Tests
- Roof Opening Panel
- Notes
- Principles of Operation
- Inspection and Verification
- Symptom Chart - Roof Opening Panel
- Symptom Chart - Noise, Vibration and Harshness (NVH)
- Pinpoint Tests
- Pinpoint Test A: The Roof Opening Panel Has Excessive Wind Noise
- Pinpoint Test B: The Roof Opening Panel Leaks
- Pinpoint Test C: The Roof Opening Panel Rattles
- This pinpoint test is intended to diagnose the following:
- Pinpoint Test D: The Roof Opening Panel is Noisy During Operation
- Pinpoint Test E: The Roof Opening Panel Does Not Open or Close
- Pinpoint Test F: The Roof Opening Panel Does Not Open or Close in VENT Position
- Roof Opening Panel
- General Procedures
- Removal And Installation
- Sunroof
- Windows And Glass
- Specifications
- Description And Operation
- Diagnostic Tests
- Glass, Frames and Mechanisms
- Notes
- Principles of Operation
- Inspection and Verification
- DTC Table
- Symptom Chart
- Pinpoint Tests
- Pinpoint Test A: All Power Windows are Inoperative
- Pinpoint Test B: A Single Power Window is Inoperative - LH Front
- Pinpoint Test C: A Single Power Window is Inoperative - RH Front
- Pinpoint Test D: A Single Power Window is Inoperative - LH or RH Rear
- Pinpoint Test E: The One-Touch Up/Down Feature is Inoperative - LH Front Window Only
- Pinpoint Test F: The Defrost System is Inoperative
- Pinpoint Test G: The Defrost System Will Not Shut Off Automatically
- Pinpoint Test H: The Delayed Accessory is Inoperative
- Pinpoint Test I: The Delayed Accessory Does Not Turn Off
- Component Test
- Glass, Frames and Mechanisms
- General Procedures
- Removal And Installation
- Glass, Frames and Mechanisms - Exploded View, Front Door
- Window Glass - Front Door
- Window Regulator Motor
- Window Regulator and Motor - Front Door
- Door Glass Top Run - Front
- Glass, Frames and Mechanisms - Exploded View, Rear Door
- Window Glass - Rear Door
- Window Regulator Motor - Rear Door
- Door Glass Run and Bracket - Rear
- Window Control Switch
- Window Glass - Rear
- Window Glass - Rear Quarter, Taurus, Sable
- Window Glass - Fixed, Rear Door
- Window Glass - Liftgate
- Window Glass - Rear Quarter, Taurus X
- Windshield Glass
- Door Locks
- Brakes
- Anti-Lock Brakes
- Anti-Lock Brake System
- Specifications
- Description And Operation
- Diagnostic Tests
- Anti-Lock Control
- Notes
- Principles of Operations
- Inspection and Verification
- Symptom Chart
- Pinpoint Tests
- Pinpoint Test A: DTC B1676 - Battery Pack Voltage Out of Range
- Pinpoint Test B: DTCs C1145, C1155, C1165 and C1175 - Wheel Speed Sensor Input Circuit Failure
- Pinpoint Test C: DTCs C1222, C1296, C1297, C1298 and C1299 - Wheel Speed Sensor Signal Fault
- Pinpoint Test D: DTC C1266 - ABS Valve Power Relay Circuit Failure
- Pinpoint Test E: DTC C1300 - ABS Hydraulic Pump Motor Circuit Failure
- Pinpoint Test F: Poor Vehicle Tracking During Anti-lock Function
- Pinpoint Test G: The Traction Control System is Inoperative or Cannot be Disabled
- Pinpoint Test H: DTCs C1278 and C1956 - Steering Angle Sensor Circuit Fault
- Pinpoint Test I: DTCs C1279, C1280, C1282 and U0074 - Sensor Cluster Fault
- Pinpoint Test J: DTC C1288 and C1440 - Pressure Transducer Main/Primary Input Circuit Failure and Signal Faulted
- Pinpoint Test K: DTC C1446 and C1484 - BOO Plausibility Fault(s) and Electrical Fault
- Anti-Lock Control
- Removal And Installation
- Brake System - General Information
- Specifications
- Description And Operation
- Diagnostic Tests
- Brake System
- Notes
- Principles of Operation
- Inspection and Verification - Hydraulic Brake System
- Symptom Chart - Hydraulic Brake System
- Symptom Chart - Noise, Vibration and Harshness (NVH)
- Inspection and Verification - Adjustable Pedals Without Memory Feature
- Symptom Chart - Adjustable Pedals Without Memory Feature
- Inspection and Verification - Adjustable Pedals With Memory Feature
- Symptom Chart - Adjustable Pedals With Memory Feature
- Pinpoint Tests
- Pinpoint Test A: Adjustable Brake Pedal is Inoperative/Does Not Operate Correctly (System Without Memory Feature)
- Pinpoint Test B: Adjustable Brake Pedal is Inoperative/Does Not Operate Correctly - Using the Adjustable Pedal Switch (System With Memory Feature)
- Pinpoint Test C: Adjustable Brake Pedal Does Not Operate Correctly - Using the Memory SET Switch or the Remote Transmitter
- Pinpoint Test D: Vibration When the Brakes are Applied
- Component Tests
- Brake System
- General Procedures
- Anti-Lock Brake System
- Mechanical - Hydraulic
- Brake System - General Information
- Specifications
- Description And Operation
- Diagnostic Tests
- Brake System
- Notes
- Principles of Operation
- Inspection and Verification - Hydraulic Brake System
- Symptom Chart - Hydraulic Brake System
- Symptom Chart - Noise, Vibration and Harshness (NVH)
- Inspection and Verification - Adjustable Pedals Without Memory Feature
- Symptom Chart - Adjustable Pedals Without Memory Feature
- Inspection and Verification - Adjustable Pedals With Memory Feature
- Symptom Chart - Adjustable Pedals With Memory Feature
- Pinpoint Tests
- Pinpoint Test A: Adjustable Brake Pedal is Inoperative/Does Not Operate Correctly (System Without Memory Feature)
- Pinpoint Test B: Adjustable Brake Pedal is Inoperative/Does Not Operate Correctly - Using the Adjustable Pedal Switch (System With Memory Feature)
- Pinpoint Test C: Adjustable Brake Pedal Does Not Operate Correctly - Using the Memory SET Switch or the Remote Transmitter
- Pinpoint Test D: Vibration When the Brakes are Applied
- Component Tests
- Brake System
- General Procedures
- Front Disc Brake System
- Hydraulic Brake System Actuation
- Power Brake Actuation -- Brake Booster
- Rear Disc Brake System
- Brake System - General Information
- Parking Brake System And Actuation
- Traction Control
- Anti-Lock Brake System
- Specifications
- Description And Operation
- Diagnostic Tests
- Anti-Lock Control
- Notes
- Principles of Operations
- Inspection and Verification
- Symptom Chart
- Pinpoint Tests
- Pinpoint Test A: DTC B1676 - Battery Pack Voltage Out of Range
- Pinpoint Test B: DTCs C1145, C1155, C1165 and C1175 - Wheel Speed Sensor Input Circuit Failure
- Pinpoint Test C: DTCs C1222, C1296, C1297, C1298 and C1299 - Wheel Speed Sensor Signal Fault
- Pinpoint Test D: DTC C1266 - ABS Valve Power Relay Circuit Failure
- Pinpoint Test E: DTC C1300 - ABS Hydraulic Pump Motor Circuit Failure
- Pinpoint Test F: Poor Vehicle Tracking During Anti-lock Function
- Pinpoint Test G: The Traction Control System is Inoperative or Cannot be Disabled
- Pinpoint Test H: DTCs C1278 and C1956 - Steering Angle Sensor Circuit Fault
- Pinpoint Test I: DTCs C1279, C1280, C1282 and U0074 - Sensor Cluster Fault
- Pinpoint Test J: DTC C1288 and C1440 - Pressure Transducer Main/Primary Input Circuit Failure and Signal Faulted
- Pinpoint Test K: DTC C1446 and C1484 - BOO Plausibility Fault(s) and Electrical Fault
- Anti-Lock Control
- Removal And Installation
- Brake System - General Information
- Specifications
- Description And Operation
- Diagnostic Tests
- Brake System
- Notes
- Principles of Operation
- Inspection and Verification - Hydraulic Brake System
- Symptom Chart - Hydraulic Brake System
- Symptom Chart - Noise, Vibration and Harshness (NVH)
- Inspection and Verification - Adjustable Pedals Without Memory Feature
- Symptom Chart - Adjustable Pedals Without Memory Feature
- Inspection and Verification - Adjustable Pedals With Memory Feature
- Symptom Chart - Adjustable Pedals With Memory Feature
- Pinpoint Tests
- Pinpoint Test A: Adjustable Brake Pedal is Inoperative/Does Not Operate Correctly (System Without Memory Feature)
- Pinpoint Test B: Adjustable Brake Pedal is Inoperative/Does Not Operate Correctly - Using the Adjustable Pedal Switch (System With Memory Feature)
- Pinpoint Test C: Adjustable Brake Pedal Does Not Operate Correctly - Using the Memory SET Switch or the Remote Transmitter
- Pinpoint Test D: Vibration When the Brakes are Applied
- Component Tests
- Brake System
- General Procedures
- Anti-Lock Brake System
- Anti-Lock Brakes
- Drivelines & Axles
- Axle Shafts
- Differentials & Drive Axles
- Driveshaft & Universal Joints
- Electrical
- Body Electrical
- Charging System (Battery, Mounting And Cables)
- Fuse And Relay Location
- OEM Connector End Views
- Connector Views
- A/C Clutch Field Coil Connector
- Crankshaft Position Sensor Connector
- Generator Connectors
- Oil Pressure Switch Connector
- Cylinder Head Temperature Sensor Connector
- Knock Sensor Connector
- Coil On Plug Connectors
- Power Steering Valve Solenoid Connector
- Brake Fluid Level Switch Connector
- Windshield Wiper Motor Connector
- Anti-Theft Hood Switch Connector
- Mass Air Flow Sensor / Intake Air Temperature Sensor Connector
- Horn Connector
- Ambient Air Temperature Sensor Connector
- Anti-Lock Brake System Module Connector
- Windshield Washer Pump Motor Connector
- Washer Fluid Level Switch Connector
- Heated Oxygen Sensor 22 Connector
- Heated Oxygen Sensor 12 Connector
- Inline Connectors
- Left Front Wheel Speed Sensor Connector
- Left Front Side Lamp Connector
- Left Front Fog Lamp Connector
- Right Front Wheel Speed Sensor Connector
- Right Front Side Lamp Connector
- Right Front Fog Lamp Connector
- 6F Automatic Transmission Vehicle Harness Connector
- Heated Oxygen Sensor 11 Connector
- Heated Oxygen Sensor 21 Connector
- Powertrain Control Module Connectors
- Fuel Injector Connectors
- Heated Positive Crankcase Ventilation Valve Connector
- Starter Motor Connectors
- Multifunction Switch Connectors
- Headlamp Switch Connector
- Driver Air Bag Module Connector
- Clockspring Connectors
- Instrument Cluster Connectors
- Steering Angle Sensor Module Connector
- DATC HVAC Module Connector
- In-Vehicle Temperature Sensor Connector
- Audio Control Module Connector
- Ignition Switch Connector
- Data Link Connector
- Passive Anti-Theft Transceiver Connector
- Passenger Air Bag Module Connectors
- Front Blower Motor Speed Controller Connector
- Speed Control Deactivation Switch Connector
- Brake Pedal Position Switch Connector
- All Wheel Drive Module Connector
- Autolamp Sensor / Sunload Sensor Connector
- Fresh/ Recirculation Door Actuator Connector
- Evaporator Discharge Air Temperature Sensor Connector
- Parking Brake Switch Connector
- Restraints Control Module Connectors
- Passenger Side Front Seat Control Switch Connector
- Passenger Seat Horizontal Motor Connector
- Right Front Seat Cushion Heater Connector
- Right Front Seat Back Heater Connector
- Driver Seat Module Connector
- Driver Seat Safety Belt Load Limiting Retractor Connector
- Driver Seat Position Sensor Connector
- Driver Side Front Seat Control Switch Connector
- Driver Seat Horizontal Motor Connector
- Driver Seat Rear Height Motor Connector
- Left Front Seat Cushion Heater Connector
- Left Front Seat Back Heater Connector
- Evaporative Emissions Canister Vent Control Solenoid Connector
- Console Power Point Connector
- Driver Seat Front Height Motor Connector
- Passenger Seat Safety Belt Load Limiting Retractor Connector
- Inertia Fuel Shutoff Switch Connector
- Rear Window Defrost Grid Connector
- Left Rear Lamp Assembly Connector
- Right Rear Lamp Assembly Connector
- Luggage Compartment Lamp Connector
- Left License Plate Lamp Connector
- Right License Plate Lamp Connector
- Subwoofer Amplifier Connector
- Rear Power Point Connector
- Rear Wiper Motor Assembly Connector
- Keypad Switch Assembly Connector
- Memory Set Switch Connector
- Master Window Adjust Switch Connector
- Driver Door Disarm Switch Connector
- Left Exterior Rear View Mirror Connector
- Left Front Speaker Connector
- Driver Side Front Power Window Motor Connector
- Left Front Door Lock Actuator Connector
- Left Front Door Ajar Switch Connector
- Exterior Rear View Mirror Switch Connector
- Driver Side Door Lock Switch Connector
- Driver 1 Side Impact Sensor Connector
- Right Front Door Ajar Switch Connector
- Right Front Door Lock Actuator Connector
- Passenger Side Window Adjust Switch Connector
- Passenger Side Door Lock Switch Connector
- Passenger Side Front Power Window Motor Connector
- Right Front Speaker Connector
- Right Exterior Rearview Mirror Connector
- Passenger 1 Side Impact Sensor Connector
- Left Rear Window Adjust Switch Connector
- Left Rear Speaker Connector
- Left Rear Power Window Motor Connector
- Left Rear Door Lock Actuator Connector
- Left Rear Door Ajar Switch Connector
- Right Rear Window Adjust Switch Connector
- Right Rear Speaker Connector
- Right Rear Power Window Motor Connector
- Right Rear Door Lock Actuator Connector
- Right Rear Door Ajar Switch Connector
- High Mounted Stoplamp Connector
- Right Vanity Mirror Lamp Connector
- Left Vanity Mirror Lamp Connector
- Electronic Compass Connector
- Auto-Dimming Interior Mirror Unit Connector
- Roof Opening Panel Module Connector
- Overhead Console Connectors
- Second Row Seat Interior Lamp / Map Lamp Assembly Connector
- Third Row Seat Interior Lamp / Map Lamp Assembly Connector
- Rear Auxiliary Function Selector Switch Assembly Connector
- Left Front High Beam Lamp Connector
- Left Front Park Lamp / Turn Lamp Connector
- Battery Junction Box Connector
- Right Front High Beam Lamp Connector
- Right Front Park Lamp / Turn Lamp Connector
- Engine Cooling Fan Motor Connector
- Battery Connectors
- Left Front Low Beam Lamp Connector
- Right Front Low Beam Lamp Connector
- Power Steering Pressure Switch Connector
- Evaporative Emissions Canister Purge Valve Connector
- A/C Pressure Transducer Sensor Connector
- Left Headlamp Connector
- Right Headlamp Connector
- Camshaft Position Sensor Connector
- Camshaft Position Sensor 2 Connector
- Electronic Throttle Control Connector
- Variable Camshaft Timing Valve 1 Connector
- Variable Camshaft Timing Valve 2 Connector
- Left Front Impact Sensor Connector
- Right Front Impact Sensor Connector
- Positive Crankcase Ventilation Heated Fitting Connector
- Universal Heated Oxygen Sensor 11 Connector
- Universal Heated Oxygen Sensor 21 Connector
- Front Blower Motor Connector
- Clock Connector
- Instrument Panel Power Point Connector
- Accelerator Pedal Position Sensor Connector
- Illumination Dimmer Connector
- Driver Temperature Blend Door Actuator Connector
- Passenger Temperature Blend Door Actuator Connector
- Center Stack Switch Assembly Connector
- Adjustable Pedal Motor Connector
- Blower Motor Resistor Connector
- Adjustable Pedal Switch Connector
- Decklid Release Switch Connector
- Mode Door Actuator Connector
- Smart Junction Box Connector
- Passenger Air Bag Deactivation Indicator Connector
- EMTC HVAC Module Connector
- Power Steering Control Module Connector
- Auxiliary Blower Motor Connector
- Auxiliary Blower Motor Resistor Connector
- Seat Pressure Sensor Connector
- Driver Safety Belt Buckle Switch Connector
- Passenger Safety Belt Buckle Switch Connector
- Stability Control Sensor Cluster Connector
- Right Rear Wheel Speed Sensor Connector
- Left Rear Wheel Speed Sensor Connector
- Left Rear Subwoofer Connector
- Right Rear Subwoofer Connector
- Fuel Tank Pressure Transducer Sensor Connector
- Fuel Pump Module Connector
- Rear Heated Seat Module Connector
- Left Rear Seat Cushion Heater Connector
- Left Rear Seat Back Heater Connector
- Right Rear Seat Cushion Heater Connector
- Right Rear Seat Back Heater Connector
- Driver Seat Recliner Motor Connector
- Passenger Seat Recliner Motor Connector
- Driver 2 Side Impact Sensor Connector
- Passenger 2 Side Impact Sensor Connector
- Driver Side Air Bag Module Connector
- Passenger Side Airbag Module Connector
- Passenger Safety Belt Tension Sensor Connector
- Passenger Seat Position Sensor Connector
- Floor Shifter Connector
- Parking Aid Module Connector
- Parking Aid Speaker Connector
- Fuel Level Sensor Connector
- Auxiliary Relay Box 1 Connector
- Auxiliary Relay Box 2 Connector
- Auxiliary Relay Box 3 Connector
- Auxiliary Mode Actuator Connector
- Auxiliary Temperature Actuator Connector
- Occupant Classification System Module Connector
- Front Heated Seat Module Connector
- Audio Input Jack Connector
- Rear Console Power Point Connector
- Left Rear Seat Heated Seat Switch Connector
- Right Rear Seat Heated Seat Switch Connector
- Accessory Protocol Interface Module Connector
- Left Second Row Seat Control Switch Connector
- Right Second Row Seat Control Switch Connector
- Left Second Row Power Fold Seat Motor Connector
- Right Second Row Power Fold Seat Motor Connector
- Outer Left Rear Parking Aid Sensor Connector
- Inner Left Rear Parking Aid Sensor Connector
- Outer Right Rear Parking Aid Sensor Connector
- Inner Right Rear Parking Aid Sensor Connector
- Left Liftgate Obstacle Detection Strip Connector
- Right Liftgate Obstacle Detection Strip Connector
- Liftgate Module / Trunk Module Connector
- Liftgate Lock Actuator Connector
- Power Liftgate Chime Connector
- Liftgate Switch Connector
- Decklid Latch Assembly Connector
- Liftgate Drive Motor Assembly Connector
- Liftgate Latch Assembly / Liftgate Unlatch Assembly Connector
- Satellite Digital Audio Receiver System Module Connector
- Active Torque Control Coupling Solenoid Connector
- License Lamps / Liftgate Release Switch Connector
- Driver Safety Canopy Module Connector
- Passenger Safety Canopy Module Connector
- Electronic Hidden Antenna Module Connector
- Rear Entertainment Module Connector
- Led High Mounted Stoplamp Connector
- Connector Views
- Charging Systems
- Charging System - (Generator & Regulator)
- Charging System - General Information
- Specifications
- Description And Operation
- Diagnostic Tests
- Charging System
- Notes
- Principles of Operation
- Inspection and Verification
- Symptom Chart
- Pinpoint Tests
- Notes
- Pinpoint Test A: The Battery is Discharged or Battery Voltage is Low
- Pinpoint Test B: The Charging System Warning Indicator is On and Any Charging System DTC is Stored
- Pinpoint Test C: The Charging System Warning Indicator is On With the Engine Running and No Charging System DTCs Present
- Pinpoint Test D: The Generator is Noisy
- Pinpoint Test E: Radio Interference
- Pinpoint Test F: DTC B1318 or B1676 - Battery Voltage Low or Battery Voltage Out of Range
- Component Tests
- Charging System
- Charging System (Battery, Mounting And Cables)
- Component Locations
- Fuses & Circuit Breakers
- Gauges
- Clock
- Information Center
- Description And Operation
- Diagnostic Tests
- Instrument Cluster (IC), Message Center and Warning Chimes
- Notes
- Principles of Operation
- Inspection and Verification
- DTC Tables
- Instrument Cluster (IC) Dealer Test Mode
- Symptom Charts
- Pinpoint Tests
- Pinpoint Test A: The Instrument Cluster (IC) Is Inoperative
- Pinpoint Test B: Incorrect Fuel Gauge Indication - Front Wheel Drive (FWD) Sedan
- Pinpoint Test C: Incorrect Fuel Gauge Indication - Wagon Or All Wheel Drive (AWD) Sedan
- Pinpoint Test D: The Temperature Gauge Is Inoperative
- Pinpoint Test E: Incorrect Temperature Gauge Indication
- Pinpoint Test F: The Speedometer Is Inoperative
- Pinpoint Test G: Incorrect Speedometer Indication
- Pinpoint Test H: The Odometer Is Inoperative
- Pinpoint Test I: The Tachometer Is Inoperative
- Pinpoint Test J: Incorrect Tachometer Indication
- Pinpoint Test K: The Low Oil Pressure Warning Indicator Is Never/Always On
- Pinpoint Test L: The Low Fuel Warning Indicator Is Never/Always On
- Pinpoint Test M: The Charging System Warning Indicator Is Never/Always On
- Pinpoint Test N: The Brake Warning Indicator is Never On
- Pinpoint Test O: The Brake Warning Indicator is Always On
- Pinpoint Test P: The ABS Warning Indicator Is Never/Always On
- Pinpoint Test Q: The Malfunction Indicator Lamp (MIL) Is Never/Always On
- Pinpoint Test R: The Safety Belt Warning Indicator Is Never/Always On
- Pinpoint Test S: The Anti-Theft Indicator Is Never/Always On
- Pinpoint Test T: The Air Bag Warning Indicator Is Never/Always On
- Pinpoint Test U: The LH/RH Turn Or High Beam Indicator Is Never/Always On
- Pinpoint Test V: The Traction Assist Indicator Is Never/Always On
- Pinpoint Test W: The Speed Control Indicator Is Never/Always On
- Pinpoint Test X: The Powertrain Malfunction (Wrench) Warning Indicator Is Never/Always On
- Pinpoint Test Y: The Check Fuel Cap Indicator Is Never/Always On
- Pinpoint Test Z: The O/D OFF Indicator Is Never/Always On
- Pinpoint Test AA: The Tire Pressure Monitoring System (TPMS) Warning Indicator Is Never/Always On
- Pinpoint Test AB: DTC B1318 - Battery Voltage Low
- Pinpoint Test AC: DTC B2A20 or U2472 - Ignition Stuck in Start or Unexpected Ignition State
- Pinpoint Test AD: DTC U0100 - Lost Communication With ECM/PCM
- Pinpoint Test AE: DTC U0114 - Lost Communication With Four Wheel Drive Clutch Control Module
- Pinpoint Test AF: DTC U0121 - Lost Communication With Anti-Lock Brake System Control Module (ABS)
- Pinpoint Test AG: DTC U0140 - Lost Communication With Body Control Module (GEM)
- Pinpoint Test AH: DTC U0151 - Lost Communication With Restraints Control Module (RCM)
- Pinpoint Test AI: DTC U0164 - Lost Communication With HVAC Control Module (EATC)
- Pinpoint Test AJ: DTC U0208 - Lost Communication With Seat Control Module (DSM)
- Pinpoint Test AK: DTC U0230 - Lost Communication With Rear Gate Module (LTM)
- Pinpoint Test AL: The Message Center Is Not Operating Correctly
- Pinpoint Test AM: The Compass Is Inoperative
- Pinpoint Test AN: The Compass Is Inaccurate
- Pinpoint Test AO: The WASHER FLUID LEVEL LOW Display Does Not Operate Correctly
- Pinpoint Test AP: The DRIVER, PASSENGER, REAR LEFT, REAR RIGHT DOOR AJAR or LIFTGATE Warning Is Inoperative/Always On
- Pinpoint Test AQ: The Chime Sounds When The Driver Door Is Ajar (No Key In Ignition And Headlamps Off)
- Pinpoint Test AR: The Key-In-Ignition Warning Chime Is Inoperative
- Pinpoint Test AS: The Headlamps On Warning Chime Is Inoperative
- Pinpoint Test AT: The Safety Belt Warning Chime Does Not Operate Correctly/The Belt-Minder® Feature Does Not Operate Correctly
- Pinpoint Test AU: The Parking Brake Warning Chime Is Inoperative
- Instrument Cluster (IC), Message Center and Warning Chimes
- General Procedures
- Removal And Installation
- Information System And Entertainment Systems
- Specifications
- Description And Operation
- Diagnostic Tests
- Information and Entertainment System
- Notes
- Principles of Operation
- Notes
- Audio Control Module (ACM)
- Navigation System
- Noise Suppression Equipment
- Satellite Audio
- Antenna - AM/FM
- Antenna - Satellite Radio
- Subwoofer
- DVD Entertainment System
- Single-Play Mode
- Dual-Play Mode
- SYNC System
- Voice Recognition For Vehicles With Navigation And The SYNC System
- Steering Wheel Controls
- Audio Input Jack - Vehicles Without The SYNC System
- Audio Signals
- Network Communication
- Inspection and Verification
- DTC Tables
- Symptom Chart
- Pinpoint Tests
- Pinpoint Test A: Poor Reception - AM/FM
- Pinpoint Test B: Poor Quality/Distorted/No Sound from One or More Speakers (Not All Speakers)
- Pinpoint Test C: The Subwoofer is Inoperative/Does Not Operate Correctly - Audiophile
- Pinpoint Test D: The Audio Does Not Reduce When The Parking Aid Tone Sounds
- Pinpoint Test E: The Steering Wheel Controls Are Inoperative/Do Not Operate Correctly
- Pinpoint Test F: The Speed Sensitive Volume Does Not Operate Correctly
- Pinpoint Test G: The Video System Does Not Operate Correctly
- Pinpoint Test H: Poor Reception/No Sound - Satellite Audio
- Pinpoint Test I: The Satellite Audio Is Inoperative/Does Not Operate Correctly - Vehicles Without DVD Entertainment System
- Pinpoint Test J: The Satellite Audio Is Inoperative/Does Not Operate Correctly - Vehicles With DVD Entertainment System
- Pinpoint Test K: The Audio Input Jack Is Inoperative/Does Not Operate Correctly
- Pinpoint Test L: No Global Positioning System (GPS) Antenna Signal
- Pinpoint Test M: The Audible Switch Feedback Is Inoperative
- Pinpoint Test N: The Voice Guidance Is Inoperative/Does Not Operate Correctly
- Pinpoint Test O: The Position Cursor Is Inaccurate
- Pinpoint Test P: Voice Recognition Is Inoperative/Does Not Operate Correctly - Vehicles Without The SYNC System
- Pinpoint Test Q: The SYNC System Is Completely Inoperative
- Pinpoint Test R: Unable To Pair Bluetooth® Device
- Pinpoint Test S: The Universal Serial Bus (USB) Port Is Inoperative/Does Not Operate Correctly
- Pinpoint Test T: The SYNC System Audible Prompts Are Inoperative/Do Not Operate Correctly
- Pinpoint Test U: Poor Quality/Distorted/No Sound While In SYNC Mode
- Pinpoint Test V: Voice Recognition Is Inoperative/Does Not Operate Correctly - Vehicles With The SYNC System
- Information and Entertainment System
- General Procedures
- Removal And Installation
- Antenna
- Antenna Cable - Satellite Radio
- Antenna Lead-In Cable
- Audio Input Jack
- Audio Control Module (ACM)
- Rear Entertainment Module (RETM)
- Door Speaker
- Global Positioning System (GPS) Antenna
- Parcel Shelf Speaker
- Satellite Digital Audio Receiver System (SDARS) Module
- Speaker Enclosure
- Steering Wheel Controls
- Subwoofer Amplifier
- Subwoofer Speaker
- Accessory Protocol Interface Module (APIM)
- Universal Serial Bus (USB) Cable and Port
- Instrument Cluster System And Panel Illumination
- Description And Operation
- Diagnostic Tests
- Instrument Cluster and Panel Illumination
- Notes
- Principles of Operation
- Inspection and Verification
- DTC Tables
- Symptom Chart
- Pinpoint Tests
- Pinpoint Test A: The Control Illumination Is Inoperative - All Hardwired Illumination
- Pinpoint Test B: The Control Illumination Is Always On - All Hardwired Illumination
- Pinpoint Test C: All The Instrument Panel Illumination Does Not Dim
- Pinpoint Test D: The Steering Wheel Control Illumination Is Inoperative
- Pinpoint Test E: The Door Lock Control Switch Illumination is Inoperative
- Pinpoint Test F: The Roof Opening Panel Switch Illumination is Inoperative
- Pinpoint Test G: The Individual Component Illumination is Inoperative
- Instrument Cluster and Panel Illumination
- Removal And Installation
- Instrument Panel And Console
- Specifications
- Removal And Installation
- Instrument Panel - Exploded View
- Instrument Panel
- Instrument Panel Upper Section
- In-Vehicle Crossbeam
- Instrument Panel Finish Panel - Center, Taurus, Sable
- Instrument Panel Finish Panel - Center, Taurus X
- Instrument Cluster Finish Panel
- Power Point
- Console - Front, Floor
- Console - Rear, Floor
- Console - Overhead
- Horns
- Motors, Switches, Relays
- Charging System (Battery, Mounting And Cables)
- Fuse And Relay Location
- OEM Connector End Views
- Connector Views
- A/C Clutch Field Coil Connector
- Crankshaft Position Sensor Connector
- Generator Connectors
- Oil Pressure Switch Connector
- Cylinder Head Temperature Sensor Connector
- Knock Sensor Connector
- Coil On Plug Connectors
- Power Steering Valve Solenoid Connector
- Brake Fluid Level Switch Connector
- Windshield Wiper Motor Connector
- Anti-Theft Hood Switch Connector
- Mass Air Flow Sensor / Intake Air Temperature Sensor Connector
- Horn Connector
- Ambient Air Temperature Sensor Connector
- Anti-Lock Brake System Module Connector
- Windshield Washer Pump Motor Connector
- Washer Fluid Level Switch Connector
- Heated Oxygen Sensor 22 Connector
- Heated Oxygen Sensor 12 Connector
- Inline Connectors
- Left Front Wheel Speed Sensor Connector
- Left Front Side Lamp Connector
- Left Front Fog Lamp Connector
- Right Front Wheel Speed Sensor Connector
- Right Front Side Lamp Connector
- Right Front Fog Lamp Connector
- 6F Automatic Transmission Vehicle Harness Connector
- Heated Oxygen Sensor 11 Connector
- Heated Oxygen Sensor 21 Connector
- Powertrain Control Module Connectors
- Fuel Injector Connectors
- Heated Positive Crankcase Ventilation Valve Connector
- Starter Motor Connectors
- Multifunction Switch Connectors
- Headlamp Switch Connector
- Driver Air Bag Module Connector
- Clockspring Connectors
- Instrument Cluster Connectors
- Steering Angle Sensor Module Connector
- DATC HVAC Module Connector
- In-Vehicle Temperature Sensor Connector
- Audio Control Module Connector
- Ignition Switch Connector
- Data Link Connector
- Passive Anti-Theft Transceiver Connector
- Passenger Air Bag Module Connectors
- Front Blower Motor Speed Controller Connector
- Speed Control Deactivation Switch Connector
- Brake Pedal Position Switch Connector
- All Wheel Drive Module Connector
- Autolamp Sensor / Sunload Sensor Connector
- Fresh/ Recirculation Door Actuator Connector
- Evaporator Discharge Air Temperature Sensor Connector
- Parking Brake Switch Connector
- Restraints Control Module Connectors
- Passenger Side Front Seat Control Switch Connector
- Passenger Seat Horizontal Motor Connector
- Right Front Seat Cushion Heater Connector
- Right Front Seat Back Heater Connector
- Driver Seat Module Connector
- Driver Seat Safety Belt Load Limiting Retractor Connector
- Driver Seat Position Sensor Connector
- Driver Side Front Seat Control Switch Connector
- Driver Seat Horizontal Motor Connector
- Driver Seat Rear Height Motor Connector
- Left Front Seat Cushion Heater Connector
- Left Front Seat Back Heater Connector
- Evaporative Emissions Canister Vent Control Solenoid Connector
- Console Power Point Connector
- Driver Seat Front Height Motor Connector
- Passenger Seat Safety Belt Load Limiting Retractor Connector
- Inertia Fuel Shutoff Switch Connector
- Rear Window Defrost Grid Connector
- Left Rear Lamp Assembly Connector
- Right Rear Lamp Assembly Connector
- Luggage Compartment Lamp Connector
- Left License Plate Lamp Connector
- Right License Plate Lamp Connector
- Subwoofer Amplifier Connector
- Rear Power Point Connector
- Rear Wiper Motor Assembly Connector
- Keypad Switch Assembly Connector
- Memory Set Switch Connector
- Master Window Adjust Switch Connector
- Driver Door Disarm Switch Connector
- Left Exterior Rear View Mirror Connector
- Left Front Speaker Connector
- Driver Side Front Power Window Motor Connector
- Left Front Door Lock Actuator Connector
- Left Front Door Ajar Switch Connector
- Exterior Rear View Mirror Switch Connector
- Driver Side Door Lock Switch Connector
- Driver 1 Side Impact Sensor Connector
- Right Front Door Ajar Switch Connector
- Right Front Door Lock Actuator Connector
- Passenger Side Window Adjust Switch Connector
- Passenger Side Door Lock Switch Connector
- Passenger Side Front Power Window Motor Connector
- Right Front Speaker Connector
- Right Exterior Rearview Mirror Connector
- Passenger 1 Side Impact Sensor Connector
- Left Rear Window Adjust Switch Connector
- Left Rear Speaker Connector
- Left Rear Power Window Motor Connector
- Left Rear Door Lock Actuator Connector
- Left Rear Door Ajar Switch Connector
- Right Rear Window Adjust Switch Connector
- Right Rear Speaker Connector
- Right Rear Power Window Motor Connector
- Right Rear Door Lock Actuator Connector
- Right Rear Door Ajar Switch Connector
- High Mounted Stoplamp Connector
- Right Vanity Mirror Lamp Connector
- Left Vanity Mirror Lamp Connector
- Electronic Compass Connector
- Auto-Dimming Interior Mirror Unit Connector
- Roof Opening Panel Module Connector
- Overhead Console Connectors
- Second Row Seat Interior Lamp / Map Lamp Assembly Connector
- Third Row Seat Interior Lamp / Map Lamp Assembly Connector
- Rear Auxiliary Function Selector Switch Assembly Connector
- Left Front High Beam Lamp Connector
- Left Front Park Lamp / Turn Lamp Connector
- Battery Junction Box Connector
- Right Front High Beam Lamp Connector
- Right Front Park Lamp / Turn Lamp Connector
- Engine Cooling Fan Motor Connector
- Battery Connectors
- Left Front Low Beam Lamp Connector
- Right Front Low Beam Lamp Connector
- Power Steering Pressure Switch Connector
- Evaporative Emissions Canister Purge Valve Connector
- A/C Pressure Transducer Sensor Connector
- Left Headlamp Connector
- Right Headlamp Connector
- Camshaft Position Sensor Connector
- Camshaft Position Sensor 2 Connector
- Electronic Throttle Control Connector
- Variable Camshaft Timing Valve 1 Connector
- Variable Camshaft Timing Valve 2 Connector
- Left Front Impact Sensor Connector
- Right Front Impact Sensor Connector
- Positive Crankcase Ventilation Heated Fitting Connector
- Universal Heated Oxygen Sensor 11 Connector
- Universal Heated Oxygen Sensor 21 Connector
- Front Blower Motor Connector
- Clock Connector
- Instrument Panel Power Point Connector
- Accelerator Pedal Position Sensor Connector
- Illumination Dimmer Connector
- Driver Temperature Blend Door Actuator Connector
- Passenger Temperature Blend Door Actuator Connector
- Center Stack Switch Assembly Connector
- Adjustable Pedal Motor Connector
- Blower Motor Resistor Connector
- Adjustable Pedal Switch Connector
- Decklid Release Switch Connector
- Mode Door Actuator Connector
- Smart Junction Box Connector
- Passenger Air Bag Deactivation Indicator Connector
- EMTC HVAC Module Connector
- Power Steering Control Module Connector
- Auxiliary Blower Motor Connector
- Auxiliary Blower Motor Resistor Connector
- Seat Pressure Sensor Connector
- Driver Safety Belt Buckle Switch Connector
- Passenger Safety Belt Buckle Switch Connector
- Stability Control Sensor Cluster Connector
- Right Rear Wheel Speed Sensor Connector
- Left Rear Wheel Speed Sensor Connector
- Left Rear Subwoofer Connector
- Right Rear Subwoofer Connector
- Fuel Tank Pressure Transducer Sensor Connector
- Fuel Pump Module Connector
- Rear Heated Seat Module Connector
- Left Rear Seat Cushion Heater Connector
- Left Rear Seat Back Heater Connector
- Right Rear Seat Cushion Heater Connector
- Right Rear Seat Back Heater Connector
- Driver Seat Recliner Motor Connector
- Passenger Seat Recliner Motor Connector
- Driver 2 Side Impact Sensor Connector
- Passenger 2 Side Impact Sensor Connector
- Driver Side Air Bag Module Connector
- Passenger Side Airbag Module Connector
- Passenger Safety Belt Tension Sensor Connector
- Passenger Seat Position Sensor Connector
- Floor Shifter Connector
- Parking Aid Module Connector
- Parking Aid Speaker Connector
- Fuel Level Sensor Connector
- Auxiliary Relay Box 1 Connector
- Auxiliary Relay Box 2 Connector
- Auxiliary Relay Box 3 Connector
- Auxiliary Mode Actuator Connector
- Auxiliary Temperature Actuator Connector
- Occupant Classification System Module Connector
- Front Heated Seat Module Connector
- Audio Input Jack Connector
- Rear Console Power Point Connector
- Left Rear Seat Heated Seat Switch Connector
- Right Rear Seat Heated Seat Switch Connector
- Accessory Protocol Interface Module Connector
- Left Second Row Seat Control Switch Connector
- Right Second Row Seat Control Switch Connector
- Left Second Row Power Fold Seat Motor Connector
- Right Second Row Power Fold Seat Motor Connector
- Outer Left Rear Parking Aid Sensor Connector
- Inner Left Rear Parking Aid Sensor Connector
- Outer Right Rear Parking Aid Sensor Connector
- Inner Right Rear Parking Aid Sensor Connector
- Left Liftgate Obstacle Detection Strip Connector
- Right Liftgate Obstacle Detection Strip Connector
- Liftgate Module / Trunk Module Connector
- Liftgate Lock Actuator Connector
- Power Liftgate Chime Connector
- Liftgate Switch Connector
- Decklid Latch Assembly Connector
- Liftgate Drive Motor Assembly Connector
- Liftgate Latch Assembly / Liftgate Unlatch Assembly Connector
- Satellite Digital Audio Receiver System Module Connector
- Active Torque Control Coupling Solenoid Connector
- License Lamps / Liftgate Release Switch Connector
- Driver Safety Canopy Module Connector
- Passenger Safety Canopy Module Connector
- Electronic Hidden Antenna Module Connector
- Rear Entertainment Module Connector
- Led High Mounted Stoplamp Connector
- Connector Views
- Starter
- Starting System
- Specifications
- Description And Operation
- Diagnostic Tests
- General Procedures
- Removal And Installation
- Starting System
- Wiring Diagrams
- OEM Connector End Views
- Connector Views
- A/C Clutch Field Coil Connector
- Crankshaft Position Sensor Connector
- Generator Connectors
- Oil Pressure Switch Connector
- Cylinder Head Temperature Sensor Connector
- Knock Sensor Connector
- Coil On Plug Connectors
- Power Steering Valve Solenoid Connector
- Brake Fluid Level Switch Connector
- Windshield Wiper Motor Connector
- Anti-Theft Hood Switch Connector
- Mass Air Flow Sensor / Intake Air Temperature Sensor Connector
- Horn Connector
- Ambient Air Temperature Sensor Connector
- Anti-Lock Brake System Module Connector
- Windshield Washer Pump Motor Connector
- Washer Fluid Level Switch Connector
- Heated Oxygen Sensor 22 Connector
- Heated Oxygen Sensor 12 Connector
- Inline Connectors
- Left Front Wheel Speed Sensor Connector
- Left Front Side Lamp Connector
- Left Front Fog Lamp Connector
- Right Front Wheel Speed Sensor Connector
- Right Front Side Lamp Connector
- Right Front Fog Lamp Connector
- 6F Automatic Transmission Vehicle Harness Connector
- Heated Oxygen Sensor 11 Connector
- Heated Oxygen Sensor 21 Connector
- Powertrain Control Module Connectors
- Fuel Injector Connectors
- Heated Positive Crankcase Ventilation Valve Connector
- Starter Motor Connectors
- Multifunction Switch Connectors
- Headlamp Switch Connector
- Driver Air Bag Module Connector
- Clockspring Connectors
- Instrument Cluster Connectors
- Steering Angle Sensor Module Connector
- DATC HVAC Module Connector
- In-Vehicle Temperature Sensor Connector
- Audio Control Module Connector
- Ignition Switch Connector
- Data Link Connector
- Passive Anti-Theft Transceiver Connector
- Passenger Air Bag Module Connectors
- Front Blower Motor Speed Controller Connector
- Speed Control Deactivation Switch Connector
- Brake Pedal Position Switch Connector
- All Wheel Drive Module Connector
- Autolamp Sensor / Sunload Sensor Connector
- Fresh/ Recirculation Door Actuator Connector
- Evaporator Discharge Air Temperature Sensor Connector
- Parking Brake Switch Connector
- Restraints Control Module Connectors
- Passenger Side Front Seat Control Switch Connector
- Passenger Seat Horizontal Motor Connector
- Right Front Seat Cushion Heater Connector
- Right Front Seat Back Heater Connector
- Driver Seat Module Connector
- Driver Seat Safety Belt Load Limiting Retractor Connector
- Driver Seat Position Sensor Connector
- Driver Side Front Seat Control Switch Connector
- Driver Seat Horizontal Motor Connector
- Driver Seat Rear Height Motor Connector
- Left Front Seat Cushion Heater Connector
- Left Front Seat Back Heater Connector
- Evaporative Emissions Canister Vent Control Solenoid Connector
- Console Power Point Connector
- Driver Seat Front Height Motor Connector
- Passenger Seat Safety Belt Load Limiting Retractor Connector
- Inertia Fuel Shutoff Switch Connector
- Rear Window Defrost Grid Connector
- Left Rear Lamp Assembly Connector
- Right Rear Lamp Assembly Connector
- Luggage Compartment Lamp Connector
- Left License Plate Lamp Connector
- Right License Plate Lamp Connector
- Subwoofer Amplifier Connector
- Rear Power Point Connector
- Rear Wiper Motor Assembly Connector
- Keypad Switch Assembly Connector
- Memory Set Switch Connector
- Master Window Adjust Switch Connector
- Driver Door Disarm Switch Connector
- Left Exterior Rear View Mirror Connector
- Left Front Speaker Connector
- Driver Side Front Power Window Motor Connector
- Left Front Door Lock Actuator Connector
- Left Front Door Ajar Switch Connector
- Exterior Rear View Mirror Switch Connector
- Driver Side Door Lock Switch Connector
- Driver 1 Side Impact Sensor Connector
- Right Front Door Ajar Switch Connector
- Right Front Door Lock Actuator Connector
- Passenger Side Window Adjust Switch Connector
- Passenger Side Door Lock Switch Connector
- Passenger Side Front Power Window Motor Connector
- Right Front Speaker Connector
- Right Exterior Rearview Mirror Connector
- Passenger 1 Side Impact Sensor Connector
- Left Rear Window Adjust Switch Connector
- Left Rear Speaker Connector
- Left Rear Power Window Motor Connector
- Left Rear Door Lock Actuator Connector
- Left Rear Door Ajar Switch Connector
- Right Rear Window Adjust Switch Connector
- Right Rear Speaker Connector
- Right Rear Power Window Motor Connector
- Right Rear Door Lock Actuator Connector
- Right Rear Door Ajar Switch Connector
- High Mounted Stoplamp Connector
- Right Vanity Mirror Lamp Connector
- Left Vanity Mirror Lamp Connector
- Electronic Compass Connector
- Auto-Dimming Interior Mirror Unit Connector
- Roof Opening Panel Module Connector
- Overhead Console Connectors
- Second Row Seat Interior Lamp / Map Lamp Assembly Connector
- Third Row Seat Interior Lamp / Map Lamp Assembly Connector
- Rear Auxiliary Function Selector Switch Assembly Connector
- Left Front High Beam Lamp Connector
- Left Front Park Lamp / Turn Lamp Connector
- Battery Junction Box Connector
- Right Front High Beam Lamp Connector
- Right Front Park Lamp / Turn Lamp Connector
- Engine Cooling Fan Motor Connector
- Battery Connectors
- Left Front Low Beam Lamp Connector
- Right Front Low Beam Lamp Connector
- Power Steering Pressure Switch Connector
- Evaporative Emissions Canister Purge Valve Connector
- A/C Pressure Transducer Sensor Connector
- Left Headlamp Connector
- Right Headlamp Connector
- Camshaft Position Sensor Connector
- Camshaft Position Sensor 2 Connector
- Electronic Throttle Control Connector
- Variable Camshaft Timing Valve 1 Connector
- Variable Camshaft Timing Valve 2 Connector
- Left Front Impact Sensor Connector
- Right Front Impact Sensor Connector
- Positive Crankcase Ventilation Heated Fitting Connector
- Universal Heated Oxygen Sensor 11 Connector
- Universal Heated Oxygen Sensor 21 Connector
- Front Blower Motor Connector
- Clock Connector
- Instrument Panel Power Point Connector
- Accelerator Pedal Position Sensor Connector
- Illumination Dimmer Connector
- Driver Temperature Blend Door Actuator Connector
- Passenger Temperature Blend Door Actuator Connector
- Center Stack Switch Assembly Connector
- Adjustable Pedal Motor Connector
- Blower Motor Resistor Connector
- Adjustable Pedal Switch Connector
- Decklid Release Switch Connector
- Mode Door Actuator Connector
- Smart Junction Box Connector
- Passenger Air Bag Deactivation Indicator Connector
- EMTC HVAC Module Connector
- Power Steering Control Module Connector
- Auxiliary Blower Motor Connector
- Auxiliary Blower Motor Resistor Connector
- Seat Pressure Sensor Connector
- Driver Safety Belt Buckle Switch Connector
- Passenger Safety Belt Buckle Switch Connector
- Stability Control Sensor Cluster Connector
- Right Rear Wheel Speed Sensor Connector
- Left Rear Wheel Speed Sensor Connector
- Left Rear Subwoofer Connector
- Right Rear Subwoofer Connector
- Fuel Tank Pressure Transducer Sensor Connector
- Fuel Pump Module Connector
- Rear Heated Seat Module Connector
- Left Rear Seat Cushion Heater Connector
- Left Rear Seat Back Heater Connector
- Right Rear Seat Cushion Heater Connector
- Right Rear Seat Back Heater Connector
- Driver Seat Recliner Motor Connector
- Passenger Seat Recliner Motor Connector
- Driver 2 Side Impact Sensor Connector
- Passenger 2 Side Impact Sensor Connector
- Driver Side Air Bag Module Connector
- Passenger Side Airbag Module Connector
- Passenger Safety Belt Tension Sensor Connector
- Passenger Seat Position Sensor Connector
- Floor Shifter Connector
- Parking Aid Module Connector
- Parking Aid Speaker Connector
- Fuel Level Sensor Connector
- Auxiliary Relay Box 1 Connector
- Auxiliary Relay Box 2 Connector
- Auxiliary Relay Box 3 Connector
- Auxiliary Mode Actuator Connector
- Auxiliary Temperature Actuator Connector
- Occupant Classification System Module Connector
- Front Heated Seat Module Connector
- Audio Input Jack Connector
- Rear Console Power Point Connector
- Left Rear Seat Heated Seat Switch Connector
- Right Rear Seat Heated Seat Switch Connector
- Accessory Protocol Interface Module Connector
- Left Second Row Seat Control Switch Connector
- Right Second Row Seat Control Switch Connector
- Left Second Row Power Fold Seat Motor Connector
- Right Second Row Power Fold Seat Motor Connector
- Outer Left Rear Parking Aid Sensor Connector
- Inner Left Rear Parking Aid Sensor Connector
- Outer Right Rear Parking Aid Sensor Connector
- Inner Right Rear Parking Aid Sensor Connector
- Left Liftgate Obstacle Detection Strip Connector
- Right Liftgate Obstacle Detection Strip Connector
- Liftgate Module / Trunk Module Connector
- Liftgate Lock Actuator Connector
- Power Liftgate Chime Connector
- Liftgate Switch Connector
- Decklid Latch Assembly Connector
- Liftgate Drive Motor Assembly Connector
- Liftgate Latch Assembly / Liftgate Unlatch Assembly Connector
- Satellite Digital Audio Receiver System Module Connector
- Active Torque Control Coupling Solenoid Connector
- License Lamps / Liftgate Release Switch Connector
- Driver Safety Canopy Module Connector
- Passenger Safety Canopy Module Connector
- Electronic Hidden Antenna Module Connector
- Rear Entertainment Module Connector
- Led High Mounted Stoplamp Connector
- Connector Views
- System Wiring Diagrams
- Using lemon2025'S Wiring Diagrams
- Air Conditioning
- Anti-Lock Brakes
- Anti-Theft
- Body Control Modules
- Computer Data Lines
- Cooling Fan
- Cruise Control
- Defoggers
- Engine Performance
- Exterior Lights
- Ground Distribution
- Headlights
- Horn
- Instrument Cluster
- Interior Lights
- Memory Systems
- Navigation
- Power Distribution
- Power Door Locks
- Power Mirrors
- Power Seats
- Power Top/Sunroof
- Power Windows
- Radio
- Shift Interlock
- Starting/Charging
- Supplemental Restraints
- Transmission
- Trunk, Tailgate, Fuel Door
- Warning Systems
- Wiper/Washer
- Using lemon2025'S System Wiring Diagrams
- OEM Connector End Views
- Body Electrical
- Engine Mechanical
- Accessory Drive Belts
- Auxiliary Emission Control Systems
- Emission Control System
- Evaporative Emissions System
- Specifications
- Description And Operation
- Diagnostic Tests
- General Procedures
- Removal And Installation
- Cooling System (Mechanical)
- Accessory Drive System
- Engine Cooling System
- Specifications
- Description And Operation
- Diagnostic Tests
- General Procedures
- Removal And Installation
- Exhaust System
- Fuel System
- Fuel Charging And Controls
- Fuel System - General Information
- Fuel Tank And Fuel Lines
- Mechanical
- Engine
- Specifications
- Description And Operation
- Diagnostic Tests
- General Procedures
- In-Vehicle Servicing
- Upper Intake Manifold
- Lower Intake Manifold
- Valve Cover - LH
- Valve Cover - RH
- Lower End Components - Exploded View, Crankshaft Pulley and Crankshaft Front Seal
- Crankshaft Pulley
- Crankshaft Front Seal
- Lower End Components - Exploded View, Flexplate and Crankshaft Rear Seal
- Flexplate
- Crankshaft Rear Seal
- Engine Front Cover
- Timing Drive Components
- Oil Filter Adapter
- Engine Oil Pressure (EOP) Switch
- Exhaust Manifold - LH
- Exhaust Manifold - RH
- Engine Mount
- Oil Pump
- Removal
- Disassembly
- Disassembly And Assembly Of Subassemblies
- Assembly
- Installation
- Engine System - General Information
- Specifications
- Description And Operation
- Diagnostic Tests
- Engine
- Notes
- Inspection and Verification - Engine Performance
- Inspection and Verification - NVH
- Symptom Chart - Engine Performance
- Symptom Chart - NVH
- Component Tests
- Engine Oil Leaks
- Compression Test
- Cylinder Leakage Detection
- Excessive Engine Oil Consumption
- Intake Manifold Vacuum Test
- Oil Pressure Test
- Valve Train Analysis
- Notes
- Valve Train Analysis - Engine Off, Valve Cover Removed
- Valve Train Analysis - Camshafts and Valve Tappets
- Valve Train Analysis - Valve Springs, Valve Tappets Removed
- Valve Train Analysis - Valve Spring Retainer and Valve Spring Retainer Keys, Valve Tappets Removed
- Valve Train Analysis - Valves and Cylinder Head, Valve Tappets Removed
- Valve Train Analysis - Camshaft Lobe Lift
- Engine
- General Procedures
- Sprockets
- Camshaft Bearing Journal Diameter
- Camshaft Journal to Bearing Clearance - OHC Engines
- Camshaft End Play - OHC Engines
- Camshaft Surface Inspection
- Camshaft Lobe Lift
- Camshaft Runout
- Crankshaft End Play
- Valve Stem Diameter
- Valve Inspection
- Valve Guide Inner Diameter
- Valve Stem to Valve Guide Clearance
- Valve Spring Installed Length
- Valve Spring Free Length
- Valve Spring Squareness
- Valve Spring Strength
- Valve Seat Inspection
- Valve Seat Width
- Valve Seat Runout
- Flexplate Inspection
- Cylinder Head Distortion
- Cylinder Block Distortion
- Exhaust Manifold Cleaning and Inspection
- Spark Plug Inspection
- Valve Tappet Inspection
- Powertrain/Drivetrain Mount Neutralizing
- Engine
- Starter
- Starting System
- Specifications
- Description And Operation
- Diagnostic Tests
- General Procedures
- Removal And Installation
- Starting System
- Engine Performance
- Emissions
- Emission Applications
- Emission Control Abbreviations
- State Emission Standards - Diesel
- State Emission Standards - Gas
- ALASKA
- ARIZONA
- CALIFORNIA
- Colorado
- CONNECTICUT
- DELAWARE
- District Of COLUMBIA
- GEORGIA
- IDAHO
- ILLINOIS
- INDIANA
- KENTUCKY
- MARYLAND
- MASSACHUSETTS
- MISSOURI
- NEVADA
- New Jersey
- New MEXICO
- New YORK
- North CAROLINA
- OHIO
- OREGON
- PENNSYLVANIA
- RHODE Island
- TENNESSEE
- TEXAS
- UTAH
- VIRGINIA
- WASHINGTON
- WISCONSIN
- U. S. EPA ASM2525 & ASM5015 Start-Up Emission Standards
- U. S. EPA Revised Final ASM Emission Standards (ASM5015 & ASM2525)
- U.S. EPA Im240 Emission Standards
- Engine Control Systems
- Fuel Delivery
- Fuel Charging And Controls
- Fuel System - General Information
- Fuel Tank And Fuel Lines
- Engine Ignition System
- Mode 6 - 2008 Ford - Except Diesel
- Pin Voltage Charts
- Engine Controls - Reference Values (Except Diesel & Hybrid)
- Reference Value Symptom Chart
- Reference Value Parameter Identification (PID)/Measured Signal Chart
- Typical Diagnostic Reference Values
- 2.0L 4V Focus
- 2.3L 4V Fusion/Milan
- 3.0L 4V Fusion/Milan
- 3.5L 4V Edge/MKX
- 3.5L 4V MKZ
- 3.5L 4V Taurus/Taurus X/Sable
- 4.0L Mustang
- 4.6L 3V Mustang
- 5.4L 4V Mustang
- 4.6L 2V Crown Victoria/Grand Marquis
- 4.6L 2V Town Car
- 2.3L 4V Escape/Mariner
- 3.0L 4V Escape/Mariner
- 2.3L Ranger
- 3.0L Ranger
- 4.0L Ranger
- 4.0L Explorer/Explorer Sport Trac/Mountaineer
- 4.6L 3V Explorer/Explorer Sport Trac/Mountaineer
- 4.2L F-150
- 4.6L 2V F-150
- 5.4L 3V F-150/Mark LT
- 4.6L 2V E-Series
- 5.4L 2V E-Series
- 6.8L 2V E-Series
- 5.4L 3V Expedition/Navigator
- 5.4L 3V F-Super Duty
- 6.8L 3V F-Super Duty
- Engine Controls - Reference Values (Except Diesel & Hybrid)
- Remove, Overhaul & Install
- Acceleration Control System
- Electronic Engine Control System
- Specifications
- Description And Operation
- Diagnostic Tests
- Removal And Installation
- Camshaft Position (CMP) Sensor
- Crankshaft Position (CKP) Sensor
- Powertrain Control Module (PCM)
- Mass Air Flow (MAF) Sensor
- Cylinder Head Temperature (CHT) Sensor
- Heated Oxygen Sensor (HO2S) and Catalyst Monitor Sensor - Exploded View
- Heated Oxygen Sensor (HO2S)
- Catalyst Monitor Sensor
- Variable Camshaft Timing (VCT) Oil Control Solenoid
- Knock Sensor (KS)
- Intake Air Distribution System And Filtering System
- Specifications
- System
- Engine Controls - Description And Operation (Except Diesel & Hybrid)
- Vehicle Emission Control Information (VECI)
- Vehicle Certification Label
- Vehicle Emission Control Information (VECI) Acronym Definitions
- Engine Control Components
- Notes
- Accelerator Pedal Position (APP) Sensor
- Air Conditioning (A/C) Clutch Relay (A/CCR)
- Air Conditioning (A/C) Cycling Switch
- Air Conditioning Evaporator Temperature (ACET) Sensor
- Air Conditioning (A/C) High Pressure Switch
- Air Conditioning Pressure (ACP) Transducer Sensor
- Brake Pedal Position (BPP) Switch
- Brake Pedal Switch (BPS)/Brake Deactivator Switch
- Camshaft Position (CMP) Sensor
- Canister Vent (CV) Solenoid
- Check Fuel Cap Indicator
- Clutch Pedal Position (CPP) Switch
- Coil On Plug (COP)
- Coil Pack
- Cooling Fan Clutch
- Crankshaft Position (CKP) Sensor
- Cylinder Head Temperature (CHT) Sensor
- Differential Pressure Feedback Exhaust Gas Recirculation (EGR) Sensor
- Electric Exhaust Gas Recirculation (EEGR) Valve
- Electronic Throttle Actuator Control (TAC)
- Electronic Throttle Body (ETB) Throttle Position Sensor
- Engine Coolant Temperature (ECT) Sensor
- Engine Oil Temperature (EOT) Sensor
- Evaporative Emission (EVAP) Canister Purge Valve
- Exhaust Gas Recirculation (EGR) Orifice Tube Assembly
- Exhaust Gas Recirculation (EGR) System Module (ESM)
- Exhaust Gas Recirculation (EGR) Vacuum Regulator Solenoid
- Exhaust Gas Recirculation (EGR) Valve
- Fan Control
- Fan Speed Sensor (FSS)
- Fuel Injectors
- Fuel Level Input (FLI)
- Fuel Pump (FP) Module
- Fuel Pump (FP) Module and Reservoir
- Fuel Rail Pressure Temperature (FRPT) Sensor
- Fuel Rail Pulse Damper
- Fuel Tank Pressure (FTP) Sensor
- Heated Oxygen Sensor (HO2S)
- Idle Air Control (IAC) Valve
- Inertia Fuel Shutoff (IFS) Switch
- Intake Air Temperature (IAT) Sensor
- Intake Manifold Tuning Valve (IMTV)
- Knock Sensor (KS)
- Manifold Absolute Pressure (MAP) Sensor
- Mass Air Flow (MAF) Sensor
- Output Shaft Speed (OSS) Sensor
- Power Steering Pressure (PSP) Sensor
- Power Steering Pressure (PSP) Switch
- Power Take-Off (PTO) Switch and Circuits
- Powertrain Control Module - Vehicle Speed Output (PCM-VSO)
- Secondary Air Injection (AIR) Bypass Solenoid
- Secondary AIR Diverter Valve
- Secondary AIR Pump
- Starter Motor Request (SMR) Circuit
- Throttle Position (TP) Sensor
- Transmission Control Indicator Lamp (TCIL)
- Transmission Control Switch (TCS)
- Universal HO2S
- Vehicle Speed Sensor (VSS)
- Electronic Engine Control (EEC) System
- Powertrain Control Hardware
- Powertrain Control Module (PCM)
- PCM Locations
- 140-Pin PCM - Expedition/Navigator
- 140-Pin PCM - All Others
- 150-Pin PCM
- 170-Pin PCM
- 190-Pin PCM
- Fuel Pump Driver Module (FPDM)
- Keep Alive Memory (KAM)
- Integrated Electronic Ignition System
- Power and Ground Signals
- Electronic Throttle Control Reference Voltage (ETCREF)
- Electronic Throttle Control Return (ETCRTN)
- Gold Plated Pins
- Keep Alive Power (KAPWR)
- Mass Air Flow (MAF) Return
- Power Ground (PWR GND)
- Signal Return (SIG RTN)
- Variable Reluctance Sensor Return (VRSRTN)
- Vehicle Buffered Power (VBPWR)
- Vehicle Power (VPWR)
- Vehicle Reference Voltage (VREF)
- Powertrain Control Software
- Adaptive Airflow
- Computer Controlled Shutdown
- Engine RPM/Vehicle Speed Limiter
- Fail-Safe Cooling Strategy
- Failure Mode Effects Management (FMEM)
- Flash Electrically Erasable Programmable Read Only Memory (EEPROM)
- Fuel Trim
- High Speed Controller Area Network (CAN)
- Idle Air Trim
- Idle Speed Control Closed Throttle Determination - Applications Without Electronic Throttle Control (ETC)
- International Standards Organization (ISO) 14229 Diagnostic Trouble Code (DTC) Descriptions
- Multiplexing
- Multiplexing Implementation
- Malfunction Indicator Lamp (MIL)
- Catalyst and Exhaust Systems
- Evaporative Emission (EVAP) Systems
- Exhaust Gas Recirculation (EGR) Systems
- Fuel Systems
- Ignition Systems
- Intake Air Systems
- Overview
- Throttle Body System Overview
- Overview of the Intake Manifold Runner Control (IMRC) and Intake Manifold Tuning Valve (IMTV) Systems
- Intake Manifold Runner Control (IMRC) Electric Actuated System
- Intake Manifold Runner Control (IMRC) Vacuum Actuated System
- Intake Manifold Tuning Valve (IMTV) System
- Positive Crankcase Ventilation (PCV) System
- Powertrain Control Module (PCM) Controlled Charging System
- Secondary Air Injection (AIR) System
- Supercharger and Charge Air Cooler (CAC) Systems
- (Torque Based) Electronic Throttle Control (ETC)
- Variable Camshaft Timing (VCT) System
- On Board Diagnostics (OBD) Monitors
- Catalyst Efficiency Monitor
- Cold Start Emission Reduction Monitor
- Comprehensive Component Monitor (CCM)
- Electric Exhaust Gas Recirculation (EEGR) System Monitor
- Evaporative Emission (EVAP) Leak Check Monitor
- Exhaust Gas Recirculation (EGR) System Monitor - Differential Pressure Feedback EGR and EGR System Module (ESM)
- Fuel System Monitor
- Heated Oxygen Sensor (HO2S) Monitor
- Misfire Detection Monitor
- Positive Crankcase Ventilation (PCV) System Monitor
- Secondary Air Injection (AIR) System Monitor
- Thermostat Monitor
- Variable Camshaft Timing (VCT) Monitor
- Engine Controls - Diagnostic Methods (Except Diesel & Hybrid)
- Diagnostic Methods
- Diagnostic Tools
- Scan Tool Setup and Functionality
- Vehicle Check/Preparation
- Quick Test Description
- Clear the Continuous Diagnostic Trouble Codes (DTCs) and Reset the Emission Monitors Information in the Powertrain Control Module (PCM)
- Resetting The Keep Alive Memory (KAM)
- On-Board System Readiness (OSR) Test
- Output State Control (OSC)
- Output Test Mode (OTM)
- Parameter Identification (PID)
- Freeze Frame Data
- Flash Electrically Erasable Programmable Read Only Memory (EEPROM)
- Diagnostic Monitoring Test Results - Mode 6
- On Board Diagnostic (OBD) Drive Cycle
- Intermittent Diagnostic Techniques
- Adaptive Fuel Diagnostic Trouble Code (DTC) Diagnostic Techniques
- Engine Controls - Introduction (Except Diesel & Hybrid)
- Engine Controls - Pinpoint Test A: No Start Through Pinpoint Test DK: Accelerator Pedal Position (App) Sensor - (Except Diesel & Hybrid)
- PINPOINT TEST A: No Start
- PINPOINT TEST B: Powertrain Control Module (PCM) Power Relay
- PINPOINT TEST C: Reference Voltage (VREF)
- PINPOINT TEST DA: Intake Air Temperature (IAT) Sensor
- PINPOINT TEST DC: Mass Air Flow (MAF) Sensor
- PINPOINT TEST DD: Fuel Rail Pressure Temperature (FRPT) Sensor
- PINPOINT TEST DF: Vehicle Speed Circuit (VSC) Check
- PINPOINT TEST DG: Knock Sensor (KS)
- PINPOINT TEST DH: Throttle Position (TP) Sensor
- PINPOINT TEST DJ: Air Conditioning Evaporator Temperature (ACET) Sensor
- PINPOINT TEST DK: Accelerator Pedal Position (APP) Sensor
- Engine Controls - Pinpoint Test DL: Cylinder Head Temperature (CHT) Sensor Through Pinpoint Test DX: Engine Coolant Temperature (ECT) Sensor - (Except Diesel & Hybrid)
- PINPOINT TEST DL: Cylinder Head Temperature (CHT) Sensor
- PINPOINT TEST DM: Manifold Absolute Pressure (MAP) Sensor
- PINPOINT TEST DP: Output Shaft Speed (OSS) Sensor/Vehicle Speed Sensor (VSS)/Transfer Case Speed Sensor (TCSS)
- PINPOINT TEST DR: Camshaft Position (CMP) Sensor
- PINPOINT TEST DS: Air Conditioning Pressure (ACP) Transducer Sensor
- PINPOINT TEST DT: Power Steering Pressure (PSP) Sensor
- PINPOINT TEST DU: Intake Air Temperature 2 (IAT2) Sensor
- PINPOINT TEST DV: Throttle Body Assembly Electronic Throttle Control (ETC)
- PINPOINT TEST DW: Heated Oxygen Sensor (HO2S)
- PINPOINT TEST DX: Engine Coolant Temperature (ECT) Sensor
- Engine Controls - Pinpoint Test DY: Engine Oil Temperature (EOT) Sensor Through Pinpoint Test Hf: Catalyst Efficiency Monitor And Exhaust Systems - (Except Diesel & Hybrid)
- PINPOINT TEST DY: Engine Oil Temperature (EOT) Sensor
- PINPOINT TEST DZ: Universal Heated Oxygen Sensor (HO2S)
- PINPOINT TEST EM: Emission Compliance
- PINPOINT TEST FB: Power Take Off (PTO)
- PINPOINT TEST FD: Brake Pedal Inputs
- PINPOINT TEST FF: Power Steering Pressure (PSP) Switch
- PINPOINT TEST H: Fuel Control
- PINPOINT TEST HC: Fuel Delivery System
- PINPOINT TEST HD: Misfire Detection Monitor
- PINPOINT TEST HE: Exhaust Gas Recirculation (EGR) Systems
- PINPOINT TEST HF: Catalyst Efficiency Monitor and Exhaust Systems
- Engine Controls - Pinpoint Test Hg: Positive Crankcase Ventilation (PCV) System Through Pinpoint Test JD: Crankshaft Position (CKP) Sensor - (Except Diesel & Hybrid)
- PINPOINT TEST HG: Positive Crankcase Ventilation (PCV) System
- PINPOINT TEST HH: Exhaust Gas Recirculation System Module (ESM)
- PINPOINT TEST HK: Variable Camshaft Timing (VCT)
- PINPOINT TEST HM: Secondary Air Injection (AIR) System
- PINPOINT TEST HU: Intake Air Systems
- PINPOINT TEST HV: Cooling Fan Clutch
- PINPOINT TEST HX: Evaporative Emission (EVAP) System and Monitor
- PINPOINT TEST HY: Generator/Regulator System
- PINPOINT TEST JB: Secondary Ignition (COP)
- PINPOINT TEST JC: Secondary Ignition (Coil Pack)
- PINPOINT TEST JD: Crankshaft Position (CKP) Sensor
- Engine Controls - Pinpoint Test Index - (Except Diesel & Hybrid)
- Engine Controls - Pinpoint Test JE: Integrated Ignition Coil Pack A, B, Or C Failure Through Pinpoint Test Kn: Variable Speed Electric Cooling Fan - (Except Diesel & Hybrid)
- PINPOINT TEST JE: Integrated Ignition Coil Pack A, B, or C Failure
- PINPOINT TEST JF: Integrated Ignition Coil On Plug Coil A Through J Failure
- PINPOINT TEST KA: Fuel Pump (FP) Relay
- PINPOINT TEST KB: Fuel Pump Driver Module
- PINPOINT TEST KD: Electric Exhaust Gas Recirculation (EEGR) System
- PINPOINT TEST KE: Idle Air Control (IAC) Valve
- PINPOINT TEST KF: Fan Control (FC) Relays
- PINPOINT TEST KG: Fuel Injector
- PINPOINT TEST KJ: Supercharger Bypass Control
- PINPOINT TEST KM: Air Conditioning Clutch (A/CC) Relay Circuit
- PINPOINT TEST KN: Variable Speed Electric Cooling Fan
- Engine Controls - Pinpoint Test KP: Charge Air Cooler (CAC) Pump Through Pinpoint Test Z: Intermittent - (Except Diesel & Hybrid)
- PINPOINT TEST KP: Charge Air Cooler (CAC) Pump
- PINPOINT TEST NC: Ignition Engine Speed Input Circuit
- PINPOINT TEST ND: Engine RPM\Vehicle Speed Limiter Reached
- PINPOINT TEST QA: Unable to Activate Self-Test/Network Communication Error
- PINPOINT TEST QB: DTCs P0603 or P1633: Keep Alive Power (KAPWR)
- PINPOINT TEST QC: DTC P1000: On-Board Diagnostic (OBD) Systems Readiness Test Not Complete
- PINPOINT TEST QD: DTC P1260: Passive Anti-Theft System
- PINPOINT TEST QE: Electronic Throttle Control (ETC) System
- PINPOINT TEST TA: Clutch Pedal Position (CPP) Switch
- PINPOINT TEST TB: Transmission Control Switch (TCS)/ Transmission Control Indicator Lamp (TCIL)
- PINPOINT TEST Z: Intermittent
- Engine Controls - Powertrain DTC Charts And Descriptions (Except Diesel & Hybrid)
- Diagnostic Trouble Code (DTC) Charts And Descriptions
- DTC Diagnosis
- Notes
- P0010 - Intake Camshaft Position Actuator Circuit/Open (Bank 1)
- P0011 - Intake Camshaft Position Timing - Over-Advanced (Bank 1)
- P0012 - Intake Camshaft Position Timing - Over-Retarded (Bank 1)
- P0016 - Crankshaft Position - Camshaft Position Correlation - Bank 1 Sensor A
- P0018 - Crankshaft Position - Camshaft Position Correlation - Bank 2 Sensor A
- P0020 - Intake Camshaft Position Actuator Circuit/Open (Bank 2)
- P0021 - Intake Camshaft Position Timing - Over-Advanced (Bank 2)
- P0022 - Intake Camshaft Position Timing - Over-Retarded (Bank 2)
- P0030 - Ho2S Heater Control Circuit (Bank 1, Sensor 1)
- P0040 - Oxygen Sensor Signals Swapped Bank 1 Sensor 1/Bank 2 Sensor 1
- P0041 - Oxygen Sensor Signals Swapped Bank 1 Sensor 2/Bank 2 Sensor 2
- P0050 - Ho2S Heater Control Circuit (Bank 2, Sensor 1)
- P0053 - Ho2S Heater Resistance (Bank 1, Sensor 1)
- P0054 - Ho2S Heater Resistance (Bank 1, Sensor 2)
- P0055 - Ho2S Heater Resistance (Bank 1, Sensor 3)
- P0059 - Ho2S Heater Resistance (Bank 2, Sensor 1)
- P0060 - Ho2S Heater Resistance (Bank 2, Sensor 2)
- P0068 - Manifold Absolute Pressure (Map)/Mass Air Flow (MAF) - Throttle Position Correlation
- P0097 - Intake Air Temperature Sensor 2 Circuit Low
- P0098 - Intake Air Temperature Sensor 2 Circuit High
- P00BA - Low Fuel Pressure Forced Limited Power
- P0102 - Mass Or Volume Air Flow A Circuit Low
- P0103 - Mass Or Volume Air Flow A Circuit High
- P0104 - Mass Or Volume Air Flow A Circuit Intermittent/Erratic
- P0106 - Manifold Absolute Pressure (Map/BARO) Sensor Range/Performance
- P0107 - Manifold Absolute Pressure (Map)/Barometric Pressure (BARO) Sensor Low
- P0108 - Manifold Absolute Pressure (Map)/Barometric Pressure (BARO) Sensor High
- P0109 - Manifold Absolute Pressure (Map)/Barometric Pressure (BARO) Sensor Intermittent
- P0111 - Intake Air Temperature (IAT) Sensor 1 Circuit Range/Performance
- P0112 - Intake Air Temperature (IAT) Sensor 1 Circuit Low
- P0113 - Intake Air Temperature (IAT) Sensor 1 Circuit High
- P0114 - Intake Air Temperature (IAT) Sensor 1 Intermittent/Erratic
- P0116 - Engine Coolant Temperature (ECT) Sensor 1 Circuit Range/Performance
- P0117 - Engine Coolant Temperature (ECT) Sensor 1 Circuit Low
- P0118 - Engine Coolant Temperature (ECT) Sensor 1 Circuit High
- P0119 - Engine Coolant Temperature (ECT) Sensor 1 Circuit Intermittent/Erratic
- P0121 - Throttle/Pedal Position Sensor A Circuit Range/Performance
- P0122 - Throttle/Pedal Position Sensor A Circuit Low
- P0123 - Throttle/Pedal Position Sensor A Circuit High
- P0125 - Insufficient Coolant Temperature For Closed Loop Fuel Control
- P0127 - Intake Air Temperature (IAT) Too High
- P0128 - Coolant Thermostat (Coolant Temperature Below Thermostat Regulating Temperature)
- P012B - Turbocharger/Supercharger Inlet Pressure Sensor Circuit Range/Performance
- P012C - Turbocharger/Supercharger Inlet Pressure Sensor Circuit Low
- P012D - Turbocharger/Supercharger Inlet Pressure Sensor Circuit High
- P012E - Turbocharger/Supercharger Inlet Pressure Sensor Circuit Intermittent/Erratic
- P0130 - O2 Circuit (Bank 1, Sensor 1)
- P0132 - O2 Circuit High Voltage (Bank 1, Sensor 1)
- P0133 - O2 Circuit Slow Response (Bank 1, Sensor 1)
- P0134 - O2 Circuit No Activity Detected (Bank 1, Sensor 1)
- P0135 - O2 Heater Circuit (Bank 1, Sensor 1)
- P0138 - O2 Circuit High Voltage (Bank 1, Sensor 2)
- P0139 - O2 Circuit Slow Response (Bank 1, Sensor 2)
- P0141 - O2 Heater Circuit (Bank 1, Sensor 2)
- P0144 - O2 Circuit High Voltage (Bank 1, Sensor 3)
- P0147 - O2 Heater Circuit (Bank 1, Sensor 3)
- P0148 - Fuel Delivery Error
- P0150 - O2 Circuit (Bank 2, Sensor 1)
- P0152 - O2 Circuit High Voltage (Bank 2, Sensor 1)
- P0153 - O2 Circuit Slow Response (Bank 2, Sensor 1)
- P0154 - O2 Circuit No Activity Detected (Bank 2, Sensor 1)
- P0155 - O2 Heater Circuit (Bank 2, Sensor 1)
- P0158 - O2 Circuit High Voltage (Bank 2, Sensor 2)
- P0159 - O2 Circuit Slow Response (Bank 2, Sensor 2)
- P0161 - O2 Heater Circuit (Bank 2, Sensor 2)
- P0171 - System Too Lean (Bank 1)
- P0172 - System Too Rich (Bank 1)
- P0174 - System Too Lean (Bank 2)
- P0175 - System Too Rich (Bank 2)
- P0180 - Fuel Temperature Sensor A Circuit
- P0181 - Fuel Temperature Sensor A Circuit Range/Performance
- P0182 - Fuel Temperature Sensor A Circuit Low
- P0183 - Fuel Temperature Sensor A Circuit High
- P0190 - Fuel Rail Pressure Sensor A Circuit
- P0191 - Fuel Rail Pressure Sensor A Circuit Range/Performance
- P0192 - Fuel Rail Pressure Sensor A Circuit Low
- P0193 - Fuel Rail Pressure Sensor A Circuit High
- P0196 - Engine Oil Temperature (EOT) Sensor Circuit Range/Performance
- P0197 - Engine Oil Temperature (EOT) Sensor Circuit Low
- P0198 - Engine Oil Temperature (EOT) Sensor Circuit High
- P0201 - P0209 Injector Circuit/Open - Cylinder X
- P0210 - Injector Circuit/Open - Cylinder 10
- P0217 - Engine Coolant Over-Temperature Condition
- P0218 - Transmission Fluid Temperature Over-Temperature Condition
- P0219 - Engine Over Speed Condition
- P0221 - Throttle/Pedal Position Sensor/Switch B Circuit Range/Performance
- P0222 - Throttle/Pedal Position Sensor/Switch B Circuit Low
- P0223 - Throttle/Pedal Position Sensor/Switch B Circuit High
- P0230 - Fuel Pump Primary Circuit
- P0231 - Fuel Pump Secondary Circuit Low
- P0232 - Fuel Pump Secondary Circuit High
- P0297 - Vehicle Over Speed Condition
- P0298 - Engine Oil Over Temperature Condition
- P0300 - Random Misfire Detected
- P0301 - P0309 - Cylinder X Misfire Detected
- P0310 - Cylinder 10 Misfire Detected
- P0315 - Crankshaft Position System Variation Not Learned.
- P0316 - Misfire Detected On Startup (First 1000 Revolutions)
- P0320 - Ignition/Distributor Engine Speed Input Circuit
- P0325 - Knock Sensor 1 Circuit (Bank 1)
- P0326 - Knock Sensor 1 Circuit Range/Performance (Bank 1)
- P0330 - Knock Sensor 2 Circuit (Bank 2)
- P0331 - Knock Sensor 2 Circuit Range/Performance (Bank 2)
- P0340 - Camshaft Position Sensor A Circuit (Bank 1 Or Single Sensor)
- P0344 - Camshaft Position Sensor A Circuit Intermittent (Bank 1 Or Single Sensor)
- P0345 - Camshaft Position Sensor A Circuit (Bank 2)
- P0349 - Camshaft Position Sensor A Circuit Intermittent (Bank 2)
- P0350 - Ignition Coil Primary/Secondary Circuit
- P0351 - Ignition Coil A Primary/Secondary Circuit
- P0352 - Ignition Coil B Primary/Secondary Circuit
- P0353 - Ignition Coil C Primary/Secondary Circuit
- P0354 - Ignition Coil D Primary/Secondary Circuit
- P0355 - Ignition Coil E Primary/Secondary Circuit
- P0356 - Ignition Coil F Primary/Secondary Circuit
- P0357 - Ignition Coil G Primary/Secondary Circuit
- P0358 - Ignition Coil H Primary/Secondary Circuit
- P0359 - Ignition Coil I Primary/Secondary Circuit
- P0360 - Ignition Coil J Primary/Secondary Circuit
- P0400 - Exhaust Gas RECIRCULATION (EGR) Flow
- P0401 - Exhaust Gas RECIRCULATION (EGR) Flow Insufficient Detected
- P0402 - Exhaust Gas RECIRCULATION (EGR) Flow Excessive Detected
- P0403 - Exhaust Gas RECIRCULATION (EGR) Control Circuit
- P0405 - Exhaust Gas RECIRCULATION (EGR) Sensor A Circuit Low
- P0406 - Exhaust Gas RECIRCULATION (EGR) Sensor A Circuit High
- P0410 - Secondary Air Injection (Air) System
- P0412 - Secondary Air Injection (Air) System - Switching Valve A Circuit
- P0420 - Catalyst System Efficiency Below Threshold (Bank 1)
- P0430 - Catalyst System Efficiency Below Threshold (Bank 2)
- P0442 - Evaporative Emission System Leak Detected (Small Leak)
- P0443 - Evaporative Emission System Purge Control Valve Circuit
- P0446 - Evaporative Emission System Vent Control Circuit
- P0451 - Evaporative Emission System Pressure Sensor/Switch Range/Performance
- P0452 - Evaporative Emission System Pressure Sensor/Switch Low
- P0453 - Evaporative Emission System Pressure Sensor/Switch High
- P0454 - Evaporative Emission System Pressure Sensor/Switch Intermittent
- P0455 - Evaporative Emission System Leak Detected (Gross Leak/No Flow)
- P0456 - Evaporative Emission System Leak Detected (Very Small Leak)
- P0457 - Evaporative Emission System Leak Detected (Fuel Cap Loose/Off)
- P0460 - Fuel Level Sensor A Circuit
- P0461 - Fuel Level Sensor A Circuit Range/Performance
- P0462 - Fuel Level Sensor A Circuit Low
- P0463 - Fuel Level Sensor A Circuit High
- P0480 - Fan 1 Control Circuit
- P0481 - Fan 2 Control Circuit
- P0482 - Fan 3 Control Circuit
- P0483 - Fan Performance
- P0491 - Secondary Air Injection (Air) System Insufficient Flow (Bank 1)
- P0500 - Vehicle Speed Sensor (VSS) A
- P0503 - Vehicle Speed Sensor (VSS) A Intermittent/Erratic/High
- P0504 - Brake Switch Correlation
- P0505 - Idle Air Control (IAC) System
- P0506 - Idle Air Control (IAC) System Rpm Lower Than Expected
- P0507 - Idle Air Control (IAC) System Rpm Higher Than Expected
- P050A - Cold Start Idle Air Control Performance
- P050B - Cold Start Ignition Timing Performance
- P050E - Cold Start Engine Exhaust Temperature Out Of Range
- P0511 - Idle Air Control (IAC) Circuit
- P0512 - Starter Request Circuit
- P0528 - Fan Speed Sensor Circuit No Signal
- P052A - Cold Start Camshaft Position Timing Over-Advanced (Bank 1)
- P052B - Cold Start Camshaft Position Timing Over-Retarded (Bank 1)
- P052C - Cold Start Camshaft Position Timing Over-Advanced (Bank 2)
- P052D - Cold Start Camshaft Position Timing Over-Retarded (Bank 2)
- P0532 - A/C Pressure Refrigerant Sensor A Circuit Low
- P0533 - A/C Refrigerant Pressure Sensor A Circuit High
- P0534 - A/C Refrigerant Charge Loss
- P0537 - A/C Evaporator Temperature Sensor Circuit Low
- P0538 - A/C Evaporator Temperature Sensor Circuit High
- P053A - Positive Crankcase Ventilation (PCV) Heater Control Circuit / Open
- P0552 - Power Steering Pressure (PSP) Sensor/Switch Circuit Low
- P0553 - Power Steering Pressure (PSP) Sensor Circuit High Input
- P0563 - System Voltage High
- P0571 - Brake Switch A Circuit
- P0572 - Brake Switch A Circuit Low
- P0573 - Brake Switch A Circuit High
- P0579 - Cruise Control MULTIFUNCTION Input A Circuit Range / Performance
- P0581 - Cruise Control MULTIFUNCTION Input A Circuit High
- P0600 - Serial Communication Link
- P0602 - Powertrain Control Module (Pcm) Programming Error
- P0603 - Internal Control Module Keep Alive Memory (KAM) Error
- P0604 - Internal Control Module Random Access Memory (Ram) Error
- P0605 - Internal Control Module Read Only Memory (ROM) Error
- P0606 - Control Module Processor
- P0607 - Control Module Performance
- P060A - Internal Control Module Monitoring Processor Performance
- P060B - Internal Control Module A/D Processing Performance
- P060C - Internal Control Module Main Processor Performance
- P060D - Internal Control Module Accelerator Pedal Position Performance
- P0610 - Control Module Vehicle Options Error
- P061B - Internal Control Module Torque Calculation Performance
- P061C - Internal Control Module Engine Rpm Performance
- P061D - Internal Control Module Engine Air Mass Performance
- P061F - Internal Control Module Throttle Actuator Controller Performance
- P0620 - Generator Control Circuit
- P0622 - Generator Field Terminal Circuit
- P0625 - Generator Field Terminal Circuit Low
- P0626 - Generator Field Terminal Circuit High
- P062C - Internal Control Module Vehicle Speed Performance
- P0642 - Sensor Reference Voltage A Circuit Low
- P0643 - Sensor Reference Voltage A Circuit High
- P0645 - Air Conditioning Clutch Relay (A/CCR) Control Circuit
- P064D - Internal Control Module O2 Sensor Processor Performance - Bank 1
- P064E - Internal Control Module O2 Sensor Processor Performance - Bank 2
- P0657 - Actuator Supply Voltage A Circuit/Open
- P065B - Generator Control Circuit Range/Performance
- P0660 - Intake Manifold Tuning Valve (IMTV) Control Circuit Open - Bank 1
- P0663 - Intake Manifold Tuning Valve (IMTV) Control Circuit Open - Bank 2
- P0685 - Electronic Control Module (ECM)/Powertrain Control Module (Pcm) Power Relay Control Circuit/Open
- P0689 - Electronic Control Module (ECM)/Powertrain Control Module (Pcm) Power Relay Sense Circuit Low
- P0690 - Electronic Control Module (ECM)/Powertrain Control Module (Pcm) Power Relay Sense Circuit High
- P0703 - Brake Switch B Input Circuit
- P0704 - Clutch Switch Input Circuit
- P0705 - Transmission Range Sensor A Circuit (PRNDL) Input
- P0707 - Transmission Range Sensor A Circuit Low
- P0708 - Transmission Range Sensor A Circuit High
- P071X - Transmission Code
- P0720 - Output Shaft Speed (OSS) Sensor Circuit
- P0721 - Output Shaft Speed (OSS) Sensor Circuit Range/Performance
- P0722 - Output Shaft Speed (OSS) Sensor Circuit No Signal
- P0723 - Output Shaft Speed (OSS) Sensor Circuit Intermittent
- P073X - Transmission Code
- P074X - Transmission Code
- P075X - Transmission Code
- P076X - Transmission Code
- P077X - Transmission Code
- P078X - Transmission Code
- P079X - Transmission Code
- P0815 - Upshift Switch Circuit
- P0830 - Clutch Pedal Switch A Circuit
- P0833 - Clutch Pedal Switch B Circuit
- P0840 - Transmission Fluid Pressure Sensor/Switch A Circuit
- P09XX - Transmission Code
- P1000 - On-Board Diagnostic (OBD) Systems Readiness Test Not Complete
- P1001 - Key On Engine Running (KOER) Not Able To Complete, KOER Aborted
- P1100 - Mass Air Flow (MAF) Sensor Circuit Intermittent
- P1101 - Mass Air Flow (MAF) Sensor Out Of Self-Test Range
- P1112 - Intake Air Temperature (IAT) Circuit Intermittent
- P1114 - Intake Air Temperature 2 (IAT2) Circuit Low (Supercharged/Turbocharged Engines)
- P1115 - Intake Air Temperature 2 (IAT2) Circuit High (Supercharged/Turbocharged Engines)
- P1116 - Engine Coolant Temperature (ECT) Sensor Out Of Self-Test Range
- P1117 - Engine Coolant Temperature (ECT) Sensor Circuit Intermittent
- P1120 - Throttle Position Sensor A Out Of Range Low (RATCH Too Low)
- P1124 - Throttle Position Sensor A Out Of Self-Test Range
- P1127 - Exhaust Temperature Out Of Range, O2 Sensor Tests Not Completed
- P115E - Throttle Actuator Control (TAC) Throttle Body Air Flow Trim At Max Limit
- P117A - Engine Oil Over Temperature - Forced Limited Power
- P1184 - Engine Oil Temperature (EOT) Sensor Out Of Self-Test Range
- P1227 - WASTEGATE Failed Closed (Over Pressure)
- P1228 - WASTEGATE Failed Open (Under Pressure)
- P1229 - Charge Air Cooler (CAC) Pump Driver
- P1233 - Fuel Pump Driver Module Disabled Or Off Line
- P1234 - Fuel Pump Driver Module Disabled Or Off Line
- P1235 - Fuel Pump Control Out Of Range
- P1236 - Fuel Pump Control Out Of Range
- P1237 - Fuel Pump Secondary Circuit
- P1238 - Fuel Pump Secondary Circuit
- P1244 - Alternator Load High Input
- P1245 - Alternator Load Low Input
- P1246 - Alternator Load Input
- P1260 - Theft Detected, Vehicle Immobilized
- P1270 - Engine Rpm Or Vehicle Speed Limiter Reached
- P1285 - Cylinder Head Over Temperature Condition
- P1288 - Cylinder Head Temperature (CHT) Sensor Out Of Self-Test Range
- P1289 - Cylinder Head Temperature (CHT) Sensor Circuit High
- P128A - Cylinder Head Temperature (CHT) Sensor Circuit Intermittent/Erratic
- P1290 - Cylinder Head Temperature (CHT) Sensor Circuit Low
- P1299 - Cylinder Head Over Temperature Protection Active
- P1336 - Crankshaft/Camshaft Sensor Range/Performance
- P1397 - System Voltage Out Of Self -Test Range
- P1405 - Differential Pressure Feedback Sensor Upstream Hose Off Or Plugged
- P1406 - Differential Pressure Feedback Sensor Downstream Hose Off Or Plugged
- P1408 - Exhaust Gas RECIRCULATION (EGR) Flow Out Of Self-Test Range (Non-Mil)
- P1409 - Exhaust Gas RECIRCULATION (EGR) Vacuum Regulator Solenoid Circuit
- P1436 - A/C Evaporator Air Temperature Circuit Low
- P1437 - A/C Evaporator Air Temperature Circuit High
- P144A - Evaporative Emission System Purge Vapor Line Restricted/Blocked
- P1450 - Unable To Bleed Up Fuel Tank Vacuum
- P1451 - Evaporative Emission System Vent Control Circuit
- P145E - PCV Heater Control B Circuit
- P1460 - Wide Open Throttle A/C Cutout Circuit
- P1461 - A/C Pressure Sensor Circuit High
- P1462 - Air Conditioning Pressure (A/Cp) Sensor Low Voltage Detected
- P1463 - Air Conditioning Pressure Sensor (A/Cp) Insufficient Pressure Change
- P1464 - A/C Demand Out Of Self-Test Range
- P1469 - Rapid A/C Cycling
- P1474 - Fan Control Primary Circuit
- P1477 - Additional Fan Relay Circuit
- P1479 - High Fan Control Primary Circuit
- P1489 - PCV Heater Control Circuit
- P1500 - Vehicle Speed Sensor (VSS)
- P1501 - Vehicle Speed Sensor (VSS) Out Of Self-Test Range
- P1502 - Vehicle Speed Sensor (VSS) Intermittent
- P1504 - Idle Air Control (IAC) Circuit
- P1506 - Idle Air Control (IAC) OVERSPEED Error
- P1507 - Idle Air Control (IAC) Under Speed Error
- P1512 - Intake Manifold Runner Control (IMRC) Stuck Closed (Bank 1)
- P1513 - Intake Manifold Runner Control (IMRC) Stuck Closed (Bank 2)
- P1516 - Intake Manifold Runner Control (IMRC) Input Error (Bank 1)
- P1517 - Intake Manifold Runner Control (IMRC) Input Error (Bank 2)
- P1518 - Intake Manifold Runner Control (IMRC) Stuck Open Bank 1
- P1519 - Intake Manifold Runner Control (IMRC) Stuck Closed Bank 1
- P151A - Intake Manifold Runner Controller Performance
- P1520 - Intake Manifold Runner Control (IMRC) Circuit
- P1537 - Intake Manifold Runner Control (IMRC) Stuck Open (Bank 1)
- P1538 - Intake Manifold Runner Control (IMRC) Stuck Open (Bank 2)
- P1548 - Engine Air Filter Restriction
- P1549 - Intake Manifold Communication Control (IMCC) Circuit (Bank 1)
- P1550 - Power Steering Pressure (PSP) Sensor Out Of Self-Test Range
- P1572 - Brake Pedal Switch Circuit
- P1575 - Pedal Position Out Of Self Test Range
- P1633 - Keep Alive Power (KAPWR) Voltage Too Low
- P1635 - Tire/Axle Ratio Out Of Acceptable Range
- P1636 - Inductive Signature Chip Communication Error
- P1639 - Vehicle Id (VID) Block Corrupted, Not Programmed
- P1640 - Powertrain DTCS Available In Another Module
- P1641 - Fuel Pump Primary Circuit
- P1646 - Linear O2 Sensor Control Chip (Bank 1)
- P1647 - Linear O2 Sensor Control Chip (Bank 2)
- P1650 - Power Steering Pressure (PSP) Switch Out Of Self-Test Range
- P1651 - Power Steering Pressure (PSP) Switch Input
- P1674 - Control Module Software Corrupted
- P1703 - Brake Switch Out Of Self-Test Range
- P1705 - Transmission Range Sensor Out Of Self-Test Range
- P1709 - Park/Neutral Position (PNP) Switch Out Of Self-Test Range
- P1729 - 4X4L Switch
- P1780 - Transmission Control Switch (TCS) Out Of Self-Test Range
- P1781 - 4X4L Switch Out Of Self-Test Range
- P17XX -
- P18XX -
- P1900 - Output Shaft Speed (OSS) Sensor Circuit Intermittent
- P1901 - Turbine Shaft Speed (TSS) Sensor Circuit Intermittent
- P2004 - Intake Manifold Runner Control (IMRC) Stuck Open (Bank 1)
- P2005 - Intake Manifold Runner Control (IMRC) Stuck Open (Bank 2)
- P2006 - Intake Manifold Runner Control (IMRC) Stuck Closed (Bank 1)
- P2007 - Intake Manifold Runner Control (IMRC) Stuck Closed (Bank 2)
- P2008 - Intake Manifold Runner Control (IMRC) Circuit Open (Bank 1)
- P2014 - Intake Manifold Runner Position Sensor/Switch Circuit (Bank 1)
- P2015 - Intake Manifold Runner Position Sensor/Switch Circuit Range/Performance (Bank 1)
- P2019 - Intake Manifold Runner Position Sensor/Switch Circuit (Bank 2)
- P2020 - Intake Manifold Runner Position Sensor/Switch Circuit Range/Performance (Bank 2)
- P2065 - Fuel Level Sensor B Circuit
- P2066 - Fuel Level Sensor B Circuit Range/Performance
- P2067 - Fuel Level Sensor B Circuit Low
- P2068 - Fuel Level Sensor B Circuit High
- P2070 - Intake Manifold Tuning Valve (IMTV) Stuck Open Bank 1
- P2071 - Intake Manifold Tuning Valve (IMTV) Stuck Closed Bank 1
- P2072 - Throttle Actuator Control (TAC) System - Ice Breakage
- P2096 - Post Catalyst Fuel Trim System Too Lean Bank 1
- P2097 - Post Catalyst Fuel Trim System Too Rich Bank 1
- P2098 - Post Catalyst Fuel Trim System Too Lean Bank 2
- P2099 - Post Catalyst Fuel Trim System Too Rich Bank 2
- P2100 - Throttle Actuator Control (TAC) Motor Circuit/Open
- P2101 - Throttle Actuator Control (TAC) Motor Range/Performance
- P2104 - Throttle Actuator Control (TAC) System - Forced Idle
- P2105 - Throttle Actuator Control (TAC) System - Forced Engine Shutdown
- P2107 - Throttle Actuator Control (TAC) Module Processor
- P2110 - Throttle Actuator Control (TAC) System - Forced Limited Rpm
- P2111 - Throttle Actuator Control (TAC) System - Stuck Open
- P2112 - Throttle Actuator Control (TAC) System - Stuck Closed
- P2119 - Throttle Actuator A Control Throttle Body Range/Performance
- P2121 - Throttle/Pedal Position Sensor/Switch D Circuit Range/Performance
- P2122 - Throttle/Pedal Position Sensor/Switch D Circuit Low
- P2123 - Throttle/Pedal Position Sensor/Switch D Circuit High
- P2126 - Throttle/Pedal Position Sensor/Switch E Circuit Range/Performance
- P2127 - Throttle/Pedal Position Sensor/Switch E Circuit Low
- P2128 - Throttle/Pedal Position Sensor/Switch E Circuit High
- P2131 - Throttle/Pedal Position Sensor/Switch F Circuit Range/Performance
- P2132 - Throttle/Pedal Position Sensor/Switch F Circuit Low
- P2133 - Throttle/Pedal Position Sensor/Switch F Circuit High
- P2135 - Throttle/Pedal Position Sensor/Switch A/B Voltage Correlation
- P2138 - Throttle/Pedal Position Sensor/Switch D/E Voltage Correlation
- P2195 - O2 Sensor Signal Biased/Stuck Lean - Bank 1, Sensor 1
- P2196 - O2 Sensor Signal Biased/Stuck Rich - Bank 1, Sensor 1
- P2197 - O2 Sensor Signal Biased/Stuck Lean - Bank 2, Sensor 1
- P2198 - O2 Sensor Signal Biased/Stuck Rich - Bank 2, Sensor 1
- P2257 - Secondary Air Injection (Air) System Control A Circuit Low
- P2258 - Secondary Air Injection (Air) System Control A Circuit High
- P2270 - O2 Sensor Signal Stuck Lean - Bank 1, Sensor 2
- P2271 - O2 Sensor Signal Stuck Rich - Bank 1, Sensor 2
- P2272 - O2 Sensor Signal Stuck Lean - Bank 2, Sensor 2
- P2273 - O2 Sensor Signal Stuck Rich - Bank 2, Sensor 2
- P2274 - O2 Sensor Signal Stuck Lean - Bank 1, Sensor 3
- P2275 - O2 Sensor Signal Stuck Rich - Bank 1, Sensor 3
- P2448 - Secondary Air Injection System High Airflow (Bank 1)
- P260F - Evaporative System Monitoring Processor Performance
- PXXXX -
- U0101 - Lost Communication With Transaxle Control Module (TCM)
- U0121 - Lost Communication With The Antilock Braking System (Abs) Control Module
- U0155 - Lost Communication With Instrument Panel Cluster Control Module
- U0300 - Internal Control Module Software Incompatibility
- U1039 - SCP (J1850) Invalid Or Missing Data For Vehicle Speed
- UXXXX - Network Communication Diagnostic Trouble Code (DTC)
- Engine Controls - Reference Values (Except Diesel & Hybrid)
- Reference Value Symptom Chart
- Reference Value Parameter Identification (PID)/Measured Signal Chart
- Typical Diagnostic Reference Values
- 2.0L 4V Focus
- 2.3L 4V Fusion/Milan
- 3.0L 4V Fusion/Milan
- 3.5L 4V Edge/MKX
- 3.5L 4V MKZ
- 3.5L 4V Taurus/Taurus X/Sable
- 4.0L Mustang
- 4.6L 3V Mustang
- 5.4L 4V Mustang
- 4.6L 2V Crown Victoria/Grand Marquis
- 4.6L 2V Town Car
- 2.3L 4V Escape/Mariner
- 3.0L 4V Escape/Mariner
- 2.3L Ranger
- 3.0L Ranger
- 4.0L Ranger
- 4.0L Explorer/Explorer Sport Trac/Mountaineer
- 4.6L 3V Explorer/Explorer Sport Trac/Mountaineer
- 4.2L F-150
- 4.6L 2V F-150
- 5.4L 3V F-150/Mark LT
- 4.6L 2V E-Series
- 5.4L 2V E-Series
- 6.8L 2V E-Series
- 5.4L 3V Expedition/Navigator
- 5.4L 3V F-Super Duty
- 6.8L 3V F-Super Duty
- Engine Controls - Symptom Charts (Except Diesel & Hybrid)
- Engine Controls - Description And Operation (Except Diesel & Hybrid)
- Testing & Diagnosis
- Engine Controls - Description And Operation (Except Diesel & Hybrid)
- Vehicle Emission Control Information (VECI)
- Vehicle Certification Label
- Vehicle Emission Control Information (VECI) Acronym Definitions
- Engine Control Components
- Notes
- Accelerator Pedal Position (APP) Sensor
- Air Conditioning (A/C) Clutch Relay (A/CCR)
- Air Conditioning (A/C) Cycling Switch
- Air Conditioning Evaporator Temperature (ACET) Sensor
- Air Conditioning (A/C) High Pressure Switch
- Air Conditioning Pressure (ACP) Transducer Sensor
- Brake Pedal Position (BPP) Switch
- Brake Pedal Switch (BPS)/Brake Deactivator Switch
- Camshaft Position (CMP) Sensor
- Canister Vent (CV) Solenoid
- Check Fuel Cap Indicator
- Clutch Pedal Position (CPP) Switch
- Coil On Plug (COP)
- Coil Pack
- Cooling Fan Clutch
- Crankshaft Position (CKP) Sensor
- Cylinder Head Temperature (CHT) Sensor
- Differential Pressure Feedback Exhaust Gas Recirculation (EGR) Sensor
- Electric Exhaust Gas Recirculation (EEGR) Valve
- Electronic Throttle Actuator Control (TAC)
- Electronic Throttle Body (ETB) Throttle Position Sensor
- Engine Coolant Temperature (ECT) Sensor
- Engine Oil Temperature (EOT) Sensor
- Evaporative Emission (EVAP) Canister Purge Valve
- Exhaust Gas Recirculation (EGR) Orifice Tube Assembly
- Exhaust Gas Recirculation (EGR) System Module (ESM)
- Exhaust Gas Recirculation (EGR) Vacuum Regulator Solenoid
- Exhaust Gas Recirculation (EGR) Valve
- Fan Control
- Fan Speed Sensor (FSS)
- Fuel Injectors
- Fuel Level Input (FLI)
- Fuel Pump (FP) Module
- Fuel Pump (FP) Module and Reservoir
- Fuel Rail Pressure Temperature (FRPT) Sensor
- Fuel Rail Pulse Damper
- Fuel Tank Pressure (FTP) Sensor
- Heated Oxygen Sensor (HO2S)
- Idle Air Control (IAC) Valve
- Inertia Fuel Shutoff (IFS) Switch
- Intake Air Temperature (IAT) Sensor
- Intake Manifold Tuning Valve (IMTV)
- Knock Sensor (KS)
- Manifold Absolute Pressure (MAP) Sensor
- Mass Air Flow (MAF) Sensor
- Output Shaft Speed (OSS) Sensor
- Power Steering Pressure (PSP) Sensor
- Power Steering Pressure (PSP) Switch
- Power Take-Off (PTO) Switch and Circuits
- Powertrain Control Module - Vehicle Speed Output (PCM-VSO)
- Secondary Air Injection (AIR) Bypass Solenoid
- Secondary AIR Diverter Valve
- Secondary AIR Pump
- Starter Motor Request (SMR) Circuit
- Throttle Position (TP) Sensor
- Transmission Control Indicator Lamp (TCIL)
- Transmission Control Switch (TCS)
- Universal HO2S
- Vehicle Speed Sensor (VSS)
- Electronic Engine Control (EEC) System
- Powertrain Control Hardware
- Powertrain Control Module (PCM)
- PCM Locations
- 140-Pin PCM - Expedition/Navigator
- 140-Pin PCM - All Others
- 150-Pin PCM
- 170-Pin PCM
- 190-Pin PCM
- Fuel Pump Driver Module (FPDM)
- Keep Alive Memory (KAM)
- Integrated Electronic Ignition System
- Power and Ground Signals
- Electronic Throttle Control Reference Voltage (ETCREF)
- Electronic Throttle Control Return (ETCRTN)
- Gold Plated Pins
- Keep Alive Power (KAPWR)
- Mass Air Flow (MAF) Return
- Power Ground (PWR GND)
- Signal Return (SIG RTN)
- Variable Reluctance Sensor Return (VRSRTN)
- Vehicle Buffered Power (VBPWR)
- Vehicle Power (VPWR)
- Vehicle Reference Voltage (VREF)
- Powertrain Control Software
- Adaptive Airflow
- Computer Controlled Shutdown
- Engine RPM/Vehicle Speed Limiter
- Fail-Safe Cooling Strategy
- Failure Mode Effects Management (FMEM)
- Flash Electrically Erasable Programmable Read Only Memory (EEPROM)
- Fuel Trim
- High Speed Controller Area Network (CAN)
- Idle Air Trim
- Idle Speed Control Closed Throttle Determination - Applications Without Electronic Throttle Control (ETC)
- International Standards Organization (ISO) 14229 Diagnostic Trouble Code (DTC) Descriptions
- Multiplexing
- Multiplexing Implementation
- Malfunction Indicator Lamp (MIL)
- Catalyst and Exhaust Systems
- Evaporative Emission (EVAP) Systems
- Exhaust Gas Recirculation (EGR) Systems
- Fuel Systems
- Ignition Systems
- Intake Air Systems
- Overview
- Throttle Body System Overview
- Overview of the Intake Manifold Runner Control (IMRC) and Intake Manifold Tuning Valve (IMTV) Systems
- Intake Manifold Runner Control (IMRC) Electric Actuated System
- Intake Manifold Runner Control (IMRC) Vacuum Actuated System
- Intake Manifold Tuning Valve (IMTV) System
- Positive Crankcase Ventilation (PCV) System
- Powertrain Control Module (PCM) Controlled Charging System
- Secondary Air Injection (AIR) System
- Supercharger and Charge Air Cooler (CAC) Systems
- (Torque Based) Electronic Throttle Control (ETC)
- Variable Camshaft Timing (VCT) System
- On Board Diagnostics (OBD) Monitors
- Catalyst Efficiency Monitor
- Cold Start Emission Reduction Monitor
- Comprehensive Component Monitor (CCM)
- Electric Exhaust Gas Recirculation (EEGR) System Monitor
- Evaporative Emission (EVAP) Leak Check Monitor
- Exhaust Gas Recirculation (EGR) System Monitor - Differential Pressure Feedback EGR and EGR System Module (ESM)
- Fuel System Monitor
- Heated Oxygen Sensor (HO2S) Monitor
- Misfire Detection Monitor
- Positive Crankcase Ventilation (PCV) System Monitor
- Secondary Air Injection (AIR) System Monitor
- Thermostat Monitor
- Variable Camshaft Timing (VCT) Monitor
- Engine Controls - Diagnostic Methods (Except Diesel & Hybrid)
- Diagnostic Methods
- Diagnostic Tools
- Scan Tool Setup and Functionality
- Vehicle Check/Preparation
- Quick Test Description
- Clear the Continuous Diagnostic Trouble Codes (DTCs) and Reset the Emission Monitors Information in the Powertrain Control Module (PCM)
- Resetting The Keep Alive Memory (KAM)
- On-Board System Readiness (OSR) Test
- Output State Control (OSC)
- Output Test Mode (OTM)
- Parameter Identification (PID)
- Freeze Frame Data
- Flash Electrically Erasable Programmable Read Only Memory (EEPROM)
- Diagnostic Monitoring Test Results - Mode 6
- On Board Diagnostic (OBD) Drive Cycle
- Intermittent Diagnostic Techniques
- Adaptive Fuel Diagnostic Trouble Code (DTC) Diagnostic Techniques
- Engine Controls - Introduction (Except Diesel & Hybrid)
- Engine Controls - Pinpoint Test A: No Start Through Pinpoint Test DK: Accelerator Pedal Position (App) Sensor - (Except Diesel & Hybrid)
- PINPOINT TEST A: No Start
- PINPOINT TEST B: Powertrain Control Module (PCM) Power Relay
- PINPOINT TEST C: Reference Voltage (VREF)
- PINPOINT TEST DA: Intake Air Temperature (IAT) Sensor
- PINPOINT TEST DC: Mass Air Flow (MAF) Sensor
- PINPOINT TEST DD: Fuel Rail Pressure Temperature (FRPT) Sensor
- PINPOINT TEST DF: Vehicle Speed Circuit (VSC) Check
- PINPOINT TEST DG: Knock Sensor (KS)
- PINPOINT TEST DH: Throttle Position (TP) Sensor
- PINPOINT TEST DJ: Air Conditioning Evaporator Temperature (ACET) Sensor
- PINPOINT TEST DK: Accelerator Pedal Position (APP) Sensor
- Engine Controls - Pinpoint Test DL: Cylinder Head Temperature (CHT) Sensor Through Pinpoint Test DX: Engine Coolant Temperature (ECT) Sensor - (Except Diesel & Hybrid)
- PINPOINT TEST DL: Cylinder Head Temperature (CHT) Sensor
- PINPOINT TEST DM: Manifold Absolute Pressure (MAP) Sensor
- PINPOINT TEST DP: Output Shaft Speed (OSS) Sensor/Vehicle Speed Sensor (VSS)/Transfer Case Speed Sensor (TCSS)
- PINPOINT TEST DR: Camshaft Position (CMP) Sensor
- PINPOINT TEST DS: Air Conditioning Pressure (ACP) Transducer Sensor
- PINPOINT TEST DT: Power Steering Pressure (PSP) Sensor
- PINPOINT TEST DU: Intake Air Temperature 2 (IAT2) Sensor
- PINPOINT TEST DV: Throttle Body Assembly Electronic Throttle Control (ETC)
- PINPOINT TEST DW: Heated Oxygen Sensor (HO2S)
- PINPOINT TEST DX: Engine Coolant Temperature (ECT) Sensor
- Engine Controls - Pinpoint Test DY: Engine Oil Temperature (EOT) Sensor Through Pinpoint Test Hf: Catalyst Efficiency Monitor And Exhaust Systems - (Except Diesel & Hybrid)
- PINPOINT TEST DY: Engine Oil Temperature (EOT) Sensor
- PINPOINT TEST DZ: Universal Heated Oxygen Sensor (HO2S)
- PINPOINT TEST EM: Emission Compliance
- PINPOINT TEST FB: Power Take Off (PTO)
- PINPOINT TEST FD: Brake Pedal Inputs
- PINPOINT TEST FF: Power Steering Pressure (PSP) Switch
- PINPOINT TEST H: Fuel Control
- PINPOINT TEST HC: Fuel Delivery System
- PINPOINT TEST HD: Misfire Detection Monitor
- PINPOINT TEST HE: Exhaust Gas Recirculation (EGR) Systems
- PINPOINT TEST HF: Catalyst Efficiency Monitor and Exhaust Systems
- Engine Controls - Pinpoint Test Hg: Positive Crankcase Ventilation (PCV) System Through Pinpoint Test JD: Crankshaft Position (CKP) Sensor - (Except Diesel & Hybrid)
- PINPOINT TEST HG: Positive Crankcase Ventilation (PCV) System
- PINPOINT TEST HH: Exhaust Gas Recirculation System Module (ESM)
- PINPOINT TEST HK: Variable Camshaft Timing (VCT)
- PINPOINT TEST HM: Secondary Air Injection (AIR) System
- PINPOINT TEST HU: Intake Air Systems
- PINPOINT TEST HV: Cooling Fan Clutch
- PINPOINT TEST HX: Evaporative Emission (EVAP) System and Monitor
- PINPOINT TEST HY: Generator/Regulator System
- PINPOINT TEST JB: Secondary Ignition (COP)
- PINPOINT TEST JC: Secondary Ignition (Coil Pack)
- PINPOINT TEST JD: Crankshaft Position (CKP) Sensor
- Engine Controls - Pinpoint Test Index - (Except Diesel & Hybrid)
- Engine Controls - Pinpoint Test JE: Integrated Ignition Coil Pack A, B, Or C Failure Through Pinpoint Test Kn: Variable Speed Electric Cooling Fan - (Except Diesel & Hybrid)
- PINPOINT TEST JE: Integrated Ignition Coil Pack A, B, or C Failure
- PINPOINT TEST JF: Integrated Ignition Coil On Plug Coil A Through J Failure
- PINPOINT TEST KA: Fuel Pump (FP) Relay
- PINPOINT TEST KB: Fuel Pump Driver Module
- PINPOINT TEST KD: Electric Exhaust Gas Recirculation (EEGR) System
- PINPOINT TEST KE: Idle Air Control (IAC) Valve
- PINPOINT TEST KF: Fan Control (FC) Relays
- PINPOINT TEST KG: Fuel Injector
- PINPOINT TEST KJ: Supercharger Bypass Control
- PINPOINT TEST KM: Air Conditioning Clutch (A/CC) Relay Circuit
- PINPOINT TEST KN: Variable Speed Electric Cooling Fan
- Engine Controls - Pinpoint Test KP: Charge Air Cooler (CAC) Pump Through Pinpoint Test Z: Intermittent - (Except Diesel & Hybrid)
- PINPOINT TEST KP: Charge Air Cooler (CAC) Pump
- PINPOINT TEST NC: Ignition Engine Speed Input Circuit
- PINPOINT TEST ND: Engine RPM\Vehicle Speed Limiter Reached
- PINPOINT TEST QA: Unable to Activate Self-Test/Network Communication Error
- PINPOINT TEST QB: DTCs P0603 or P1633: Keep Alive Power (KAPWR)
- PINPOINT TEST QC: DTC P1000: On-Board Diagnostic (OBD) Systems Readiness Test Not Complete
- PINPOINT TEST QD: DTC P1260: Passive Anti-Theft System
- PINPOINT TEST QE: Electronic Throttle Control (ETC) System
- PINPOINT TEST TA: Clutch Pedal Position (CPP) Switch
- PINPOINT TEST TB: Transmission Control Switch (TCS)/ Transmission Control Indicator Lamp (TCIL)
- PINPOINT TEST Z: Intermittent
- Engine Controls - Powertrain DTC Charts And Descriptions (Except Diesel & Hybrid)
- Diagnostic Trouble Code (DTC) Charts And Descriptions
- DTC Diagnosis
- Notes
- P0010 - Intake Camshaft Position Actuator Circuit/Open (Bank 1)
- P0011 - Intake Camshaft Position Timing - Over-Advanced (Bank 1)
- P0012 - Intake Camshaft Position Timing - Over-Retarded (Bank 1)
- P0016 - Crankshaft Position - Camshaft Position Correlation - Bank 1 Sensor A
- P0018 - Crankshaft Position - Camshaft Position Correlation - Bank 2 Sensor A
- P0020 - Intake Camshaft Position Actuator Circuit/Open (Bank 2)
- P0021 - Intake Camshaft Position Timing - Over-Advanced (Bank 2)
- P0022 - Intake Camshaft Position Timing - Over-Retarded (Bank 2)
- P0030 - Ho2S Heater Control Circuit (Bank 1, Sensor 1)
- P0040 - Oxygen Sensor Signals Swapped Bank 1 Sensor 1/Bank 2 Sensor 1
- P0041 - Oxygen Sensor Signals Swapped Bank 1 Sensor 2/Bank 2 Sensor 2
- P0050 - Ho2S Heater Control Circuit (Bank 2, Sensor 1)
- P0053 - Ho2S Heater Resistance (Bank 1, Sensor 1)
- P0054 - Ho2S Heater Resistance (Bank 1, Sensor 2)
- P0055 - Ho2S Heater Resistance (Bank 1, Sensor 3)
- P0059 - Ho2S Heater Resistance (Bank 2, Sensor 1)
- P0060 - Ho2S Heater Resistance (Bank 2, Sensor 2)
- P0068 - Manifold Absolute Pressure (Map)/Mass Air Flow (MAF) - Throttle Position Correlation
- P0097 - Intake Air Temperature Sensor 2 Circuit Low
- P0098 - Intake Air Temperature Sensor 2 Circuit High
- P00BA - Low Fuel Pressure Forced Limited Power
- P0102 - Mass Or Volume Air Flow A Circuit Low
- P0103 - Mass Or Volume Air Flow A Circuit High
- P0104 - Mass Or Volume Air Flow A Circuit Intermittent/Erratic
- P0106 - Manifold Absolute Pressure (Map/BARO) Sensor Range/Performance
- P0107 - Manifold Absolute Pressure (Map)/Barometric Pressure (BARO) Sensor Low
- P0108 - Manifold Absolute Pressure (Map)/Barometric Pressure (BARO) Sensor High
- P0109 - Manifold Absolute Pressure (Map)/Barometric Pressure (BARO) Sensor Intermittent
- P0111 - Intake Air Temperature (IAT) Sensor 1 Circuit Range/Performance
- P0112 - Intake Air Temperature (IAT) Sensor 1 Circuit Low
- P0113 - Intake Air Temperature (IAT) Sensor 1 Circuit High
- P0114 - Intake Air Temperature (IAT) Sensor 1 Intermittent/Erratic
- P0116 - Engine Coolant Temperature (ECT) Sensor 1 Circuit Range/Performance
- P0117 - Engine Coolant Temperature (ECT) Sensor 1 Circuit Low
- P0118 - Engine Coolant Temperature (ECT) Sensor 1 Circuit High
- P0119 - Engine Coolant Temperature (ECT) Sensor 1 Circuit Intermittent/Erratic
- P0121 - Throttle/Pedal Position Sensor A Circuit Range/Performance
- P0122 - Throttle/Pedal Position Sensor A Circuit Low
- P0123 - Throttle/Pedal Position Sensor A Circuit High
- P0125 - Insufficient Coolant Temperature For Closed Loop Fuel Control
- P0127 - Intake Air Temperature (IAT) Too High
- P0128 - Coolant Thermostat (Coolant Temperature Below Thermostat Regulating Temperature)
- P012B - Turbocharger/Supercharger Inlet Pressure Sensor Circuit Range/Performance
- P012C - Turbocharger/Supercharger Inlet Pressure Sensor Circuit Low
- P012D - Turbocharger/Supercharger Inlet Pressure Sensor Circuit High
- P012E - Turbocharger/Supercharger Inlet Pressure Sensor Circuit Intermittent/Erratic
- P0130 - O2 Circuit (Bank 1, Sensor 1)
- P0132 - O2 Circuit High Voltage (Bank 1, Sensor 1)
- P0133 - O2 Circuit Slow Response (Bank 1, Sensor 1)
- P0134 - O2 Circuit No Activity Detected (Bank 1, Sensor 1)
- P0135 - O2 Heater Circuit (Bank 1, Sensor 1)
- P0138 - O2 Circuit High Voltage (Bank 1, Sensor 2)
- P0139 - O2 Circuit Slow Response (Bank 1, Sensor 2)
- P0141 - O2 Heater Circuit (Bank 1, Sensor 2)
- P0144 - O2 Circuit High Voltage (Bank 1, Sensor 3)
- P0147 - O2 Heater Circuit (Bank 1, Sensor 3)
- P0148 - Fuel Delivery Error
- P0150 - O2 Circuit (Bank 2, Sensor 1)
- P0152 - O2 Circuit High Voltage (Bank 2, Sensor 1)
- P0153 - O2 Circuit Slow Response (Bank 2, Sensor 1)
- P0154 - O2 Circuit No Activity Detected (Bank 2, Sensor 1)
- P0155 - O2 Heater Circuit (Bank 2, Sensor 1)
- P0158 - O2 Circuit High Voltage (Bank 2, Sensor 2)
- P0159 - O2 Circuit Slow Response (Bank 2, Sensor 2)
- P0161 - O2 Heater Circuit (Bank 2, Sensor 2)
- P0171 - System Too Lean (Bank 1)
- P0172 - System Too Rich (Bank 1)
- P0174 - System Too Lean (Bank 2)
- P0175 - System Too Rich (Bank 2)
- P0180 - Fuel Temperature Sensor A Circuit
- P0181 - Fuel Temperature Sensor A Circuit Range/Performance
- P0182 - Fuel Temperature Sensor A Circuit Low
- P0183 - Fuel Temperature Sensor A Circuit High
- P0190 - Fuel Rail Pressure Sensor A Circuit
- P0191 - Fuel Rail Pressure Sensor A Circuit Range/Performance
- P0192 - Fuel Rail Pressure Sensor A Circuit Low
- P0193 - Fuel Rail Pressure Sensor A Circuit High
- P0196 - Engine Oil Temperature (EOT) Sensor Circuit Range/Performance
- P0197 - Engine Oil Temperature (EOT) Sensor Circuit Low
- P0198 - Engine Oil Temperature (EOT) Sensor Circuit High
- P0201 - P0209 Injector Circuit/Open - Cylinder X
- P0210 - Injector Circuit/Open - Cylinder 10
- P0217 - Engine Coolant Over-Temperature Condition
- P0218 - Transmission Fluid Temperature Over-Temperature Condition
- P0219 - Engine Over Speed Condition
- P0221 - Throttle/Pedal Position Sensor/Switch B Circuit Range/Performance
- P0222 - Throttle/Pedal Position Sensor/Switch B Circuit Low
- P0223 - Throttle/Pedal Position Sensor/Switch B Circuit High
- P0230 - Fuel Pump Primary Circuit
- P0231 - Fuel Pump Secondary Circuit Low
- P0232 - Fuel Pump Secondary Circuit High
- P0297 - Vehicle Over Speed Condition
- P0298 - Engine Oil Over Temperature Condition
- P0300 - Random Misfire Detected
- P0301 - P0309 - Cylinder X Misfire Detected
- P0310 - Cylinder 10 Misfire Detected
- P0315 - Crankshaft Position System Variation Not Learned.
- P0316 - Misfire Detected On Startup (First 1000 Revolutions)
- P0320 - Ignition/Distributor Engine Speed Input Circuit
- P0325 - Knock Sensor 1 Circuit (Bank 1)
- P0326 - Knock Sensor 1 Circuit Range/Performance (Bank 1)
- P0330 - Knock Sensor 2 Circuit (Bank 2)
- P0331 - Knock Sensor 2 Circuit Range/Performance (Bank 2)
- P0340 - Camshaft Position Sensor A Circuit (Bank 1 Or Single Sensor)
- P0344 - Camshaft Position Sensor A Circuit Intermittent (Bank 1 Or Single Sensor)
- P0345 - Camshaft Position Sensor A Circuit (Bank 2)
- P0349 - Camshaft Position Sensor A Circuit Intermittent (Bank 2)
- P0350 - Ignition Coil Primary/Secondary Circuit
- P0351 - Ignition Coil A Primary/Secondary Circuit
- P0352 - Ignition Coil B Primary/Secondary Circuit
- P0353 - Ignition Coil C Primary/Secondary Circuit
- P0354 - Ignition Coil D Primary/Secondary Circuit
- P0355 - Ignition Coil E Primary/Secondary Circuit
- P0356 - Ignition Coil F Primary/Secondary Circuit
- P0357 - Ignition Coil G Primary/Secondary Circuit
- P0358 - Ignition Coil H Primary/Secondary Circuit
- P0359 - Ignition Coil I Primary/Secondary Circuit
- P0360 - Ignition Coil J Primary/Secondary Circuit
- P0400 - Exhaust Gas RECIRCULATION (EGR) Flow
- P0401 - Exhaust Gas RECIRCULATION (EGR) Flow Insufficient Detected
- P0402 - Exhaust Gas RECIRCULATION (EGR) Flow Excessive Detected
- P0403 - Exhaust Gas RECIRCULATION (EGR) Control Circuit
- P0405 - Exhaust Gas RECIRCULATION (EGR) Sensor A Circuit Low
- P0406 - Exhaust Gas RECIRCULATION (EGR) Sensor A Circuit High
- P0410 - Secondary Air Injection (Air) System
- P0412 - Secondary Air Injection (Air) System - Switching Valve A Circuit
- P0420 - Catalyst System Efficiency Below Threshold (Bank 1)
- P0430 - Catalyst System Efficiency Below Threshold (Bank 2)
- P0442 - Evaporative Emission System Leak Detected (Small Leak)
- P0443 - Evaporative Emission System Purge Control Valve Circuit
- P0446 - Evaporative Emission System Vent Control Circuit
- P0451 - Evaporative Emission System Pressure Sensor/Switch Range/Performance
- P0452 - Evaporative Emission System Pressure Sensor/Switch Low
- P0453 - Evaporative Emission System Pressure Sensor/Switch High
- P0454 - Evaporative Emission System Pressure Sensor/Switch Intermittent
- P0455 - Evaporative Emission System Leak Detected (Gross Leak/No Flow)
- P0456 - Evaporative Emission System Leak Detected (Very Small Leak)
- P0457 - Evaporative Emission System Leak Detected (Fuel Cap Loose/Off)
- P0460 - Fuel Level Sensor A Circuit
- P0461 - Fuel Level Sensor A Circuit Range/Performance
- P0462 - Fuel Level Sensor A Circuit Low
- P0463 - Fuel Level Sensor A Circuit High
- P0480 - Fan 1 Control Circuit
- P0481 - Fan 2 Control Circuit
- P0482 - Fan 3 Control Circuit
- P0483 - Fan Performance
- P0491 - Secondary Air Injection (Air) System Insufficient Flow (Bank 1)
- P0500 - Vehicle Speed Sensor (VSS) A
- P0503 - Vehicle Speed Sensor (VSS) A Intermittent/Erratic/High
- P0504 - Brake Switch Correlation
- P0505 - Idle Air Control (IAC) System
- P0506 - Idle Air Control (IAC) System Rpm Lower Than Expected
- P0507 - Idle Air Control (IAC) System Rpm Higher Than Expected
- P050A - Cold Start Idle Air Control Performance
- P050B - Cold Start Ignition Timing Performance
- P050E - Cold Start Engine Exhaust Temperature Out Of Range
- P0511 - Idle Air Control (IAC) Circuit
- P0512 - Starter Request Circuit
- P0528 - Fan Speed Sensor Circuit No Signal
- P052A - Cold Start Camshaft Position Timing Over-Advanced (Bank 1)
- P052B - Cold Start Camshaft Position Timing Over-Retarded (Bank 1)
- P052C - Cold Start Camshaft Position Timing Over-Advanced (Bank 2)
- P052D - Cold Start Camshaft Position Timing Over-Retarded (Bank 2)
- P0532 - A/C Pressure Refrigerant Sensor A Circuit Low
- P0533 - A/C Refrigerant Pressure Sensor A Circuit High
- P0534 - A/C Refrigerant Charge Loss
- P0537 - A/C Evaporator Temperature Sensor Circuit Low
- P0538 - A/C Evaporator Temperature Sensor Circuit High
- P053A - Positive Crankcase Ventilation (PCV) Heater Control Circuit / Open
- P0552 - Power Steering Pressure (PSP) Sensor/Switch Circuit Low
- P0553 - Power Steering Pressure (PSP) Sensor Circuit High Input
- P0563 - System Voltage High
- P0571 - Brake Switch A Circuit
- P0572 - Brake Switch A Circuit Low
- P0573 - Brake Switch A Circuit High
- P0579 - Cruise Control MULTIFUNCTION Input A Circuit Range / Performance
- P0581 - Cruise Control MULTIFUNCTION Input A Circuit High
- P0600 - Serial Communication Link
- P0602 - Powertrain Control Module (Pcm) Programming Error
- P0603 - Internal Control Module Keep Alive Memory (KAM) Error
- P0604 - Internal Control Module Random Access Memory (Ram) Error
- P0605 - Internal Control Module Read Only Memory (ROM) Error
- P0606 - Control Module Processor
- P0607 - Control Module Performance
- P060A - Internal Control Module Monitoring Processor Performance
- P060B - Internal Control Module A/D Processing Performance
- P060C - Internal Control Module Main Processor Performance
- P060D - Internal Control Module Accelerator Pedal Position Performance
- P0610 - Control Module Vehicle Options Error
- P061B - Internal Control Module Torque Calculation Performance
- P061C - Internal Control Module Engine Rpm Performance
- P061D - Internal Control Module Engine Air Mass Performance
- P061F - Internal Control Module Throttle Actuator Controller Performance
- P0620 - Generator Control Circuit
- P0622 - Generator Field Terminal Circuit
- P0625 - Generator Field Terminal Circuit Low
- P0626 - Generator Field Terminal Circuit High
- P062C - Internal Control Module Vehicle Speed Performance
- P0642 - Sensor Reference Voltage A Circuit Low
- P0643 - Sensor Reference Voltage A Circuit High
- P0645 - Air Conditioning Clutch Relay (A/CCR) Control Circuit
- P064D - Internal Control Module O2 Sensor Processor Performance - Bank 1
- P064E - Internal Control Module O2 Sensor Processor Performance - Bank 2
- P0657 - Actuator Supply Voltage A Circuit/Open
- P065B - Generator Control Circuit Range/Performance
- P0660 - Intake Manifold Tuning Valve (IMTV) Control Circuit Open - Bank 1
- P0663 - Intake Manifold Tuning Valve (IMTV) Control Circuit Open - Bank 2
- P0685 - Electronic Control Module (ECM)/Powertrain Control Module (Pcm) Power Relay Control Circuit/Open
- P0689 - Electronic Control Module (ECM)/Powertrain Control Module (Pcm) Power Relay Sense Circuit Low
- P0690 - Electronic Control Module (ECM)/Powertrain Control Module (Pcm) Power Relay Sense Circuit High
- P0703 - Brake Switch B Input Circuit
- P0704 - Clutch Switch Input Circuit
- P0705 - Transmission Range Sensor A Circuit (PRNDL) Input
- P0707 - Transmission Range Sensor A Circuit Low
- P0708 - Transmission Range Sensor A Circuit High
- P071X - Transmission Code
- P0720 - Output Shaft Speed (OSS) Sensor Circuit
- P0721 - Output Shaft Speed (OSS) Sensor Circuit Range/Performance
- P0722 - Output Shaft Speed (OSS) Sensor Circuit No Signal
- P0723 - Output Shaft Speed (OSS) Sensor Circuit Intermittent
- P073X - Transmission Code
- P074X - Transmission Code
- P075X - Transmission Code
- P076X - Transmission Code
- P077X - Transmission Code
- P078X - Transmission Code
- P079X - Transmission Code
- P0815 - Upshift Switch Circuit
- P0830 - Clutch Pedal Switch A Circuit
- P0833 - Clutch Pedal Switch B Circuit
- P0840 - Transmission Fluid Pressure Sensor/Switch A Circuit
- P09XX - Transmission Code
- P1000 - On-Board Diagnostic (OBD) Systems Readiness Test Not Complete
- P1001 - Key On Engine Running (KOER) Not Able To Complete, KOER Aborted
- P1100 - Mass Air Flow (MAF) Sensor Circuit Intermittent
- P1101 - Mass Air Flow (MAF) Sensor Out Of Self-Test Range
- P1112 - Intake Air Temperature (IAT) Circuit Intermittent
- P1114 - Intake Air Temperature 2 (IAT2) Circuit Low (Supercharged/Turbocharged Engines)
- P1115 - Intake Air Temperature 2 (IAT2) Circuit High (Supercharged/Turbocharged Engines)
- P1116 - Engine Coolant Temperature (ECT) Sensor Out Of Self-Test Range
- P1117 - Engine Coolant Temperature (ECT) Sensor Circuit Intermittent
- P1120 - Throttle Position Sensor A Out Of Range Low (RATCH Too Low)
- P1124 - Throttle Position Sensor A Out Of Self-Test Range
- P1127 - Exhaust Temperature Out Of Range, O2 Sensor Tests Not Completed
- P115E - Throttle Actuator Control (TAC) Throttle Body Air Flow Trim At Max Limit
- P117A - Engine Oil Over Temperature - Forced Limited Power
- P1184 - Engine Oil Temperature (EOT) Sensor Out Of Self-Test Range
- P1227 - WASTEGATE Failed Closed (Over Pressure)
- P1228 - WASTEGATE Failed Open (Under Pressure)
- P1229 - Charge Air Cooler (CAC) Pump Driver
- P1233 - Fuel Pump Driver Module Disabled Or Off Line
- P1234 - Fuel Pump Driver Module Disabled Or Off Line
- P1235 - Fuel Pump Control Out Of Range
- P1236 - Fuel Pump Control Out Of Range
- P1237 - Fuel Pump Secondary Circuit
- P1238 - Fuel Pump Secondary Circuit
- P1244 - Alternator Load High Input
- P1245 - Alternator Load Low Input
- P1246 - Alternator Load Input
- P1260 - Theft Detected, Vehicle Immobilized
- P1270 - Engine Rpm Or Vehicle Speed Limiter Reached
- P1285 - Cylinder Head Over Temperature Condition
- P1288 - Cylinder Head Temperature (CHT) Sensor Out Of Self-Test Range
- P1289 - Cylinder Head Temperature (CHT) Sensor Circuit High
- P128A - Cylinder Head Temperature (CHT) Sensor Circuit Intermittent/Erratic
- P1290 - Cylinder Head Temperature (CHT) Sensor Circuit Low
- P1299 - Cylinder Head Over Temperature Protection Active
- P1336 - Crankshaft/Camshaft Sensor Range/Performance
- P1397 - System Voltage Out Of Self -Test Range
- P1405 - Differential Pressure Feedback Sensor Upstream Hose Off Or Plugged
- P1406 - Differential Pressure Feedback Sensor Downstream Hose Off Or Plugged
- P1408 - Exhaust Gas RECIRCULATION (EGR) Flow Out Of Self-Test Range (Non-Mil)
- P1409 - Exhaust Gas RECIRCULATION (EGR) Vacuum Regulator Solenoid Circuit
- P1436 - A/C Evaporator Air Temperature Circuit Low
- P1437 - A/C Evaporator Air Temperature Circuit High
- P144A - Evaporative Emission System Purge Vapor Line Restricted/Blocked
- P1450 - Unable To Bleed Up Fuel Tank Vacuum
- P1451 - Evaporative Emission System Vent Control Circuit
- P145E - PCV Heater Control B Circuit
- P1460 - Wide Open Throttle A/C Cutout Circuit
- P1461 - A/C Pressure Sensor Circuit High
- P1462 - Air Conditioning Pressure (A/Cp) Sensor Low Voltage Detected
- P1463 - Air Conditioning Pressure Sensor (A/Cp) Insufficient Pressure Change
- P1464 - A/C Demand Out Of Self-Test Range
- P1469 - Rapid A/C Cycling
- P1474 - Fan Control Primary Circuit
- P1477 - Additional Fan Relay Circuit
- P1479 - High Fan Control Primary Circuit
- P1489 - PCV Heater Control Circuit
- P1500 - Vehicle Speed Sensor (VSS)
- P1501 - Vehicle Speed Sensor (VSS) Out Of Self-Test Range
- P1502 - Vehicle Speed Sensor (VSS) Intermittent
- P1504 - Idle Air Control (IAC) Circuit
- P1506 - Idle Air Control (IAC) OVERSPEED Error
- P1507 - Idle Air Control (IAC) Under Speed Error
- P1512 - Intake Manifold Runner Control (IMRC) Stuck Closed (Bank 1)
- P1513 - Intake Manifold Runner Control (IMRC) Stuck Closed (Bank 2)
- P1516 - Intake Manifold Runner Control (IMRC) Input Error (Bank 1)
- P1517 - Intake Manifold Runner Control (IMRC) Input Error (Bank 2)
- P1518 - Intake Manifold Runner Control (IMRC) Stuck Open Bank 1
- P1519 - Intake Manifold Runner Control (IMRC) Stuck Closed Bank 1
- P151A - Intake Manifold Runner Controller Performance
- P1520 - Intake Manifold Runner Control (IMRC) Circuit
- P1537 - Intake Manifold Runner Control (IMRC) Stuck Open (Bank 1)
- P1538 - Intake Manifold Runner Control (IMRC) Stuck Open (Bank 2)
- P1548 - Engine Air Filter Restriction
- P1549 - Intake Manifold Communication Control (IMCC) Circuit (Bank 1)
- P1550 - Power Steering Pressure (PSP) Sensor Out Of Self-Test Range
- P1572 - Brake Pedal Switch Circuit
- P1575 - Pedal Position Out Of Self Test Range
- P1633 - Keep Alive Power (KAPWR) Voltage Too Low
- P1635 - Tire/Axle Ratio Out Of Acceptable Range
- P1636 - Inductive Signature Chip Communication Error
- P1639 - Vehicle Id (VID) Block Corrupted, Not Programmed
- P1640 - Powertrain DTCS Available In Another Module
- P1641 - Fuel Pump Primary Circuit
- P1646 - Linear O2 Sensor Control Chip (Bank 1)
- P1647 - Linear O2 Sensor Control Chip (Bank 2)
- P1650 - Power Steering Pressure (PSP) Switch Out Of Self-Test Range
- P1651 - Power Steering Pressure (PSP) Switch Input
- P1674 - Control Module Software Corrupted
- P1703 - Brake Switch Out Of Self-Test Range
- P1705 - Transmission Range Sensor Out Of Self-Test Range
- P1709 - Park/Neutral Position (PNP) Switch Out Of Self-Test Range
- P1729 - 4X4L Switch
- P1780 - Transmission Control Switch (TCS) Out Of Self-Test Range
- P1781 - 4X4L Switch Out Of Self-Test Range
- P17XX -
- P18XX -
- P1900 - Output Shaft Speed (OSS) Sensor Circuit Intermittent
- P1901 - Turbine Shaft Speed (TSS) Sensor Circuit Intermittent
- P2004 - Intake Manifold Runner Control (IMRC) Stuck Open (Bank 1)
- P2005 - Intake Manifold Runner Control (IMRC) Stuck Open (Bank 2)
- P2006 - Intake Manifold Runner Control (IMRC) Stuck Closed (Bank 1)
- P2007 - Intake Manifold Runner Control (IMRC) Stuck Closed (Bank 2)
- P2008 - Intake Manifold Runner Control (IMRC) Circuit Open (Bank 1)
- P2014 - Intake Manifold Runner Position Sensor/Switch Circuit (Bank 1)
- P2015 - Intake Manifold Runner Position Sensor/Switch Circuit Range/Performance (Bank 1)
- P2019 - Intake Manifold Runner Position Sensor/Switch Circuit (Bank 2)
- P2020 - Intake Manifold Runner Position Sensor/Switch Circuit Range/Performance (Bank 2)
- P2065 - Fuel Level Sensor B Circuit
- P2066 - Fuel Level Sensor B Circuit Range/Performance
- P2067 - Fuel Level Sensor B Circuit Low
- P2068 - Fuel Level Sensor B Circuit High
- P2070 - Intake Manifold Tuning Valve (IMTV) Stuck Open Bank 1
- P2071 - Intake Manifold Tuning Valve (IMTV) Stuck Closed Bank 1
- P2072 - Throttle Actuator Control (TAC) System - Ice Breakage
- P2096 - Post Catalyst Fuel Trim System Too Lean Bank 1
- P2097 - Post Catalyst Fuel Trim System Too Rich Bank 1
- P2098 - Post Catalyst Fuel Trim System Too Lean Bank 2
- P2099 - Post Catalyst Fuel Trim System Too Rich Bank 2
- P2100 - Throttle Actuator Control (TAC) Motor Circuit/Open
- P2101 - Throttle Actuator Control (TAC) Motor Range/Performance
- P2104 - Throttle Actuator Control (TAC) System - Forced Idle
- P2105 - Throttle Actuator Control (TAC) System - Forced Engine Shutdown
- P2107 - Throttle Actuator Control (TAC) Module Processor
- P2110 - Throttle Actuator Control (TAC) System - Forced Limited Rpm
- P2111 - Throttle Actuator Control (TAC) System - Stuck Open
- P2112 - Throttle Actuator Control (TAC) System - Stuck Closed
- P2119 - Throttle Actuator A Control Throttle Body Range/Performance
- P2121 - Throttle/Pedal Position Sensor/Switch D Circuit Range/Performance
- P2122 - Throttle/Pedal Position Sensor/Switch D Circuit Low
- P2123 - Throttle/Pedal Position Sensor/Switch D Circuit High
- P2126 - Throttle/Pedal Position Sensor/Switch E Circuit Range/Performance
- P2127 - Throttle/Pedal Position Sensor/Switch E Circuit Low
- P2128 - Throttle/Pedal Position Sensor/Switch E Circuit High
- P2131 - Throttle/Pedal Position Sensor/Switch F Circuit Range/Performance
- P2132 - Throttle/Pedal Position Sensor/Switch F Circuit Low
- P2133 - Throttle/Pedal Position Sensor/Switch F Circuit High
- P2135 - Throttle/Pedal Position Sensor/Switch A/B Voltage Correlation
- P2138 - Throttle/Pedal Position Sensor/Switch D/E Voltage Correlation
- P2195 - O2 Sensor Signal Biased/Stuck Lean - Bank 1, Sensor 1
- P2196 - O2 Sensor Signal Biased/Stuck Rich - Bank 1, Sensor 1
- P2197 - O2 Sensor Signal Biased/Stuck Lean - Bank 2, Sensor 1
- P2198 - O2 Sensor Signal Biased/Stuck Rich - Bank 2, Sensor 1
- P2257 - Secondary Air Injection (Air) System Control A Circuit Low
- P2258 - Secondary Air Injection (Air) System Control A Circuit High
- P2270 - O2 Sensor Signal Stuck Lean - Bank 1, Sensor 2
- P2271 - O2 Sensor Signal Stuck Rich - Bank 1, Sensor 2
- P2272 - O2 Sensor Signal Stuck Lean - Bank 2, Sensor 2
- P2273 - O2 Sensor Signal Stuck Rich - Bank 2, Sensor 2
- P2274 - O2 Sensor Signal Stuck Lean - Bank 1, Sensor 3
- P2275 - O2 Sensor Signal Stuck Rich - Bank 1, Sensor 3
- P2448 - Secondary Air Injection System High Airflow (Bank 1)
- P260F - Evaporative System Monitoring Processor Performance
- PXXXX -
- U0101 - Lost Communication With Transaxle Control Module (TCM)
- U0121 - Lost Communication With The Antilock Braking System (Abs) Control Module
- U0155 - Lost Communication With Instrument Panel Cluster Control Module
- U0300 - Internal Control Module Software Incompatibility
- U1039 - SCP (J1850) Invalid Or Missing Data For Vehicle Speed
- UXXXX - Network Communication Diagnostic Trouble Code (DTC)
- Engine Controls - Reference Values (Except Diesel & Hybrid)
- Reference Value Symptom Chart
- Reference Value Parameter Identification (PID)/Measured Signal Chart
- Typical Diagnostic Reference Values
- 2.0L 4V Focus
- 2.3L 4V Fusion/Milan
- 3.0L 4V Fusion/Milan
- 3.5L 4V Edge/MKX
- 3.5L 4V MKZ
- 3.5L 4V Taurus/Taurus X/Sable
- 4.0L Mustang
- 4.6L 3V Mustang
- 5.4L 4V Mustang
- 4.6L 2V Crown Victoria/Grand Marquis
- 4.6L 2V Town Car
- 2.3L 4V Escape/Mariner
- 3.0L 4V Escape/Mariner
- 2.3L Ranger
- 3.0L Ranger
- 4.0L Ranger
- 4.0L Explorer/Explorer Sport Trac/Mountaineer
- 4.6L 3V Explorer/Explorer Sport Trac/Mountaineer
- 4.2L F-150
- 4.6L 2V F-150
- 5.4L 3V F-150/Mark LT
- 4.6L 2V E-Series
- 5.4L 2V E-Series
- 6.8L 2V E-Series
- 5.4L 3V Expedition/Navigator
- 5.4L 3V F-Super Duty
- 6.8L 3V F-Super Duty
- Engine Controls - Symptom Charts (Except Diesel & Hybrid)
- Engine Controls - Description And Operation (Except Diesel & Hybrid)
- Tune-Up
- Emissions
- General Information
- Abbreviations
- Basic Trouble Shooting
- Basic Trouble Shooting - General Information
- Commonly Used Abbreviations - General Information
- Emission Control Abbreviations
- Engine Performance - Trouble Shooting - General Information
- Brakes
- Anti-Lock Brake Safety Precautions - General Information
- Map - Brake Systems
- Brake Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Accelerometers
- Accumulators
- Anchor Pins
- Anti-Lock Brake Control Assembly(Module)
- Anti-Lock Brake Controller
- Anti-Lock Brake Systems
- Axle Seal
- Backing Plates
- Bleeder Screw
- Brake Abs Active Light (Blue)
- Brake Fluid
- Brake Friction Material
- Brake On - Off Switch
- Brake Pads
- Brake Pedals
- Brake Shoe Hardware
- Brake Shoes
- Brake Stoplight Switches
- Brake Warning Light (Amber)
- Brake Warning Light (Red)
- Bulb Sockets
- Bulbs And LEDS
- Caliper Hardware
- Caliper Mounting Pin
- Caliper Piston
- Caliper Shim
- Caliper Slider Pin (Bolt) Dust Boot
- Caliper Slider Pin (Bolt)
- Calipers
- Combination Valve
- Controllers
- Digital Ratio Axle Controllers And Buffers (Drab And Dram)
- Disable Switches
- Drums
- Electrical Brake Pumps
- Electrical Park Motor
- Electrical Pumps And Motors
- Electro-Magnetic Interference
- Electronic Brake Control Modulator
- Electronic Brake Distribution
- Electronic Brake Traction Control Module
- Electronic Controllers
- Electronic Traction Control
- External Brake Cable
- Flow Control Valve
- Fluid Level Sensor Switches
- Fluid
- Four Wheel Drive Switches
- Friction Material
- G Sensors
- Gaskets
- Gravitational Switches
- Grease Seal
- Height Sensing Proportioning Valve
- High Pressure Accumulator
- Hoses
- Hub
- Hydraulic Control Unit
- Hydraulic Modulators
- Hydro-Boosters
- Hydro-Electric Boosters (POWERMASTER)
- Ignition Disable Switches
- Lamp Driver Relay
- Lateral Acceleration Switches
- LEDS
- Lenses
- Low Pressure Accumulator
- Lug Nut
- Master Cylinder Cover Gasket
- Master Cylinders
- Modulators
- Motor Pack
- Motors
- Pads
- Parking Brake Cable
- Parking Brake Mechanism
- Parking Brake Shoes
- Parking Brake Switches
- Parking Brake Systems
- Pedal Travel Switches
- Pedals
- Power Distribution Center
- POWERMASTER
- Pressure Differential Switches
- Pressure Switches
- Pressure Transducers
- Proportioning Valve
- Pumps
- Relays
- RELUCTOR (Speed) Ring
- Rotors
- Self-Adjusting Systems
- Shoe Hardware
- Shoes
- Sockets
- Speed Sensor (RELUCTOR) Ring
- Speed Sensors (Electronic Wheel And Vehicle)
- Star Wheel
- Steel Brake Lines
- Stoplight Switches
- Stroke Sensor
- Switches
- Tires
- Tone Ring
- Toothed Rings (Tone Wheel)
- Traction Control System (TCS)
- Transfer Tubes
- Vacuum Boosters
- Vacuum Hoses
- Valves
- Wear Indicator
- Wheel Attachment Hardware
- Wheel Bearings, Races And Seals
- Wheel Cylinders
- Wiring Harnesses
- Yaw Rate Sensor
- Brake System CHECKSHEET
- Reason Code Explanation
- Automotive Terminology & Definitions
- Brake Systems
- Map - Routine Inspection Reference Guide
- Routine Inspection Reference Guide
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Maintenance Overview
- Antifreeze/Coolant
- Visual Inspection
- Radiator Cap Test
- Engine Fan
- Cooling System Power Flush And Refill
- Belts (Except Timing Belts)
- Belt TENSIONER
- Automatic Transmission Fluid
- Automatic Transmission Fluid Exchange & Filter Replacement
- Engine Oil
- Air Filters
- Cabin Air Filter
- Brake Fluid
- Battery
- Battery Cables
- Power Steering
- Power Steering Fluid
- Wiper Blades
- Routine Inspection CHECKSHEET
- Routine Inspection - UICS
- Brake Systems
- Drivetrain And Transmission
- Notes
- Automatic Transmission Fluid
- Clutch Master Cylinders
- Cooler Lines
- Coolers
- Differential Fluid
- Drain Plugs And Gaskets
- Filters And Screens
- Fluids And Lubricants
- Hoses, Lines, And Tubes
- Hydraulic Fluid
- Lubricants
- Manual Transmission Fluid
- Mounts (Engine, Transaxle And Transmission)
- Transfer Case Fluid
- Vacuum Hoses
- Electrical Systems
- Engine Performance And Maintenance
- Notes
- Accessory Belts
- Air Filter Elements
- Air Filter Gaskets
- Air Filter Housings And Gaskets
- Air Pump Belts
- Batteries
- Battery Connectors
- Belt Idler Assemblies (Accessory And Cam Belts)
- Belt TENSIONERS (Accessory And Cam Belt)
- Chemical Engine DECARBONIZATION
- Combustion Chamber Cleaning
- Coolant Recovery Tanks
- Coolant
- Distributor Caps
- Distributor Rotors
- Engine Cooling Systems
- Engine DECARBONIZATION
- Engine Oil Drain Plugs And Gaskets
- Engine Oil Filters And Canisters
- Engine Oil
- Fuel Filters
- Fuel Injector Cleaning
- Fuel Injectors
- Fuel System Cleaning Service
- Hose Clamps
- Hose Connectors
- Hose Couplers
- Hoses And Tubes (Fuel Lines, Radiator, Vacuum, By-Pass, Heater, Recovery Tank And Oil Coolers)
- Ignition Wires (Secondary)
- Intake Cleaning
- O2 Sensors
- PCV Breather Elements
- PCV Valves
- Radiator Caps And Pressurized Expansion Tank Caps
- Spark Plugs
- Thermostats And Housings
- Throttle Body Cleaning
- Timing Belts
- Vacuum Hoses, Tubes And Connections (Non-Metallic)
- Exhaust Systems
- Heating, Ventilation And Air Conditioning Systems
- Steering And Suspension, Wheel Alignment, Wheels And Tires
- Wheel & Tire Supplement
- Reason Code Explanation
- Automotive Terminology & Definitions
- Routine Inspection Reference Guide
- Check Lists
- OBD-II Drive Cycles
- 1996-99 Gasoline Models (Except Villager)
- 1996 Villager
- 1997-99 Villager
- 2000-04 Gasoline Models
- 2005-09 Gasoline Models
- 2010-12 Gasoline Models (Except Fiesta)
- 2011-12 Fiesta
- 2003-07 6.0L Diesel
- 2008-10 6.4L Diesel
- 2011-12 6.7L Diesel
- 1996-03 7.3L Diesel
- 2005-09 Hybrid
- 2005-12 Escape Hybrid
- 2011-12 Fusion Hybrid
- Driveline/Axles
- Drive Axle Noise Diagnosis - General Information
- Gear Tooth Contact Patterns - General Information
- Map - Drive Train & Transmission
- Drive Train & Transmission Systems
- Drivetrain And Transmission
- Notes
- Actuators (Electrical)
- Actuators (Vacuum)
- Automatic Transmission / Transaxle Assemblies/CVTS
- Automatic Transmission Fluid
- Axles
- Bearings And Races
- Bell Cranks
- Bell Housings
- Bushings (External)
- Cables (Speedometer)
- Cables (TV, Detent And Shift)
- Carrier Bearings
- Clutch Cables And Cable Housings
- Clutch Discs (Manual Transmissions)
- Clutch Forks
- Clutch Linkages (Mechanical)
- Clutch Master Cylinders
- Clutch Pedals
- Clutch Pivots
- Clutch Pressure Plates
- Clutch Release Bearings
- Clutch Slave Cylinders (Concentric)
- Clutch Slave Cylinders (Conventional Or External)
- Companion Flanges
- Connectors
- Cooler Bypass Valves
- Cooler Lines
- Coolers
- CV Joints
- Differential And Final Drive Assemblies
- Differential Fluid
- Dip Stick Tubes
- Dip Sticks (Fluid Level Indicators)
- Dowel Pins, Guides And Pilot Holes
- Drain Plugs And Gaskets
- Drive Shaft Flanges
- Drive Shafts And Half Shafts
- Dust Boots
- Engine Mounts
- Exciter Rings
- Filler Tubes
- Filters And Screens
- Flanges
- Flex Plates
- Fluid Level Indicators
- Fluids And Lubricants
- Flywheels
- Force Motors
- Gaskets
- Guides
- Half Shafts
- Hoses, Lines, And Tubes
- Housings (Bell, Case, Tail(Extension) And Auxiliary)
- Hydraulic Fluid
- Intermediate Shaft Support Bearings
- Key Interlock Systems
- Limited Slips
- Lines
- Linkages (External)
- Locking Hub Assemblies
- Locking Hub Control Knobs
- Lubricants
- Manual Transmission Fluid
- Manual Transmission/Transaxle Assemblies
- Metal Clad Seals
- METALASTIC Joints
- Modulator Pins
- Modulators
- Mounts (Engine, Transaxle And Transmission)
- Odometer Drives (Mechanical)
- Odometer Heads (Mechanical)
- Oil Pans
- Pans
- Pilot Holes
- Pressure Plates
- Pressure Switches
- Races
- Rubber Joints (METALASTIC)
- Screens
- Seals (Metal Clad)
- Seals
- Selector Interlock Systems
- Sensors
- Servos
- Shift Interlock Systems (Selector And Key Interlock Systems)
- Side Covers
- Slip Yokes
- Solenoids
- Speed Sensors (Electronic Wheel And Vehicle)
- Speedometer- Driven Gear Housing
- Speedometer/Odometer Drives (Mechanical)
- Speedometer/Odometer Heads (Mechanical)
- Speedometers/Odometers (Electronic)
- Switches
- Tone Wheels
- Toothed Rings (Tone Wheel)
- Torque Converters
- Transaxle Mounts
- Transducers (Transmission)
- Transfer Case Assemblies
- Transfer Case Fluid
- Transmission Coolers
- Transmission Mounts
- Transmission Pans
- Transmission Range Indicators (PRNDL)
- Tubes
- Universal Joints (CARDAN Or Cross Type)
- Vacuum Controls
- Vacuum Hoses
- Vacuum Motors
- Vacuum-Operated Switches
- Vehicle Speed Sensors
- Vents
- Vibration Dampers
- Wheel Attachment Hardware
- Wheel Speed Sensors
- Wiring Harnesses And Connectors
- Yokes And Slip Yokes
- Reason Code Explanation
- Automotive Terminology & Definitions
- Trouble Shooting - Clutches - General Information
- DTC Index
- Anti-Lock Control DTCS
- Anti-Theft (Pats) DTCS
- Anti-Theft (Perimeter) DTCS
- Automatic Transmission DTCS - 4F50N
- Body Closures DTCS
- Brake System DTCS
- Cruise Control System DTCS
- Engine Cooling DTCS
- Four Wheel Drive Systems DTCS
- Fuel System DTCS
- Handles, Locks, Latches And Entry Systems DTCS
- Information And Message DTCS
- Instrument Cluster (Ic), Message Center, And Warning Chimes DTCS
- Instrument Cluster And Panel Illumination DTCS
- Lighting DTCS
- Module Communications Network DTCS
- MULTIFUNCTION Electronic Modules DTCS
- Parking Aid DTCS
- Power Windows DTCS
- Powertrain DTC Charts And Descriptions - Gasoline Engines DTCS
- Rear View Mirrors DTCS
- Seating DTCS
- Starting System DTCS
- Steering Column Switches DTCS
- Supplemental Restraints Systems DTCS
- Wheels And Tires DTCS
- Wiper/Washer Systems DTCS
- Electrical
- Map - Electrical Systems
- Electrical Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Actuator Motors (Electric)
- Actuator Motors (Vacuum)
- Air Bags
- Alternators And Generators
- Amplifiers
- Antennas
- Batteries
- Battery Cables, Wires And Connectors
- Battery Cables
- Battery Trays And Hold Down Hardware
- Battery Wires
- Belts
- Bulb Sockets
- Bulbs, Sealed Beams And LEDS
- Cd Players
- Cigarette Lighter Assemblies
- Circuit Breakers
- Clutch Switches
- Connectors
- Control Modules
- Cruise Control Brake Switches
- Cruise Control Cables
- Cruise Control Clutch Switches
- Cruise Control Linkages And Cables
- Cruise Control Reservoirs
- Cruise Control Tubes
- Cruise Control Vacuum Dump Release Valves
- Cruise Control Vacuum Hoses, Tubes And
- Cruise Control Vehicle Speed Sensors
- Defoggers
- Defrosters
- Delays
- Dimmers
- Electric Heaters
- Equalizers
- Fuse Blocks
- Fuse Boxes And Blocks
- Fuses, Fusible Links And Circuit Breakers
- Fusible Links
- Gauges
- Generators
- Ground Cables And Straps
- Ground Straps
- Headlight Adjusters
- Heating Elements (Defrosters, Defoggers, Electric Heaters And Seats)
- Horns And Sirens
- Ignition Switches
- Indicator Lights
- Keyless Entry Keypads And Transmitters
- Keyless Entry Transmitters
- LEDS
- Lenses
- Microphones
- Mirrors (ELECTROCHROMATIC And Heated)
- Motors
- Neutral Safety Switches
- Odometers, Speedometers And Tachometers (Cable Driven)
- Odometers
- Power Distribution Center
- Pulleys
- Receivers, Amplifiers, Equalizers And Sub-Woofer Volume Controls
- Relay Boxes
- Relays
- Sealed Beams
- Seat Heaters
- Security Alarm Sensors
- Sirens
- Solenoids
- Speakers And Microphones
- Speedometer And Tachometer Linkages And Cables
- Speedometer Cables
- Speedometers
- Starters
- Sub-Woofer Volume Control
- Switches
- Tachometer Cables
- Tachometers
- Tape Players And Cd Players
- TENSIONERS
- Timers
- Transceivers
- Transducers
- Vacuum Accumulators (Reservoirs)
- Voltage Regulators
- Washer Fluid Level Senders
- Washer Pumps
- Wiper Arms And Blades
- Wiper Blades
- Wiper Hoses And Nozzles
- Wiper Linkages
- Wiper Nozzles
- Wiper Pump Reservoirs
- Wiring Harnesses And Connectors
- Battery, Starting & Charging System CHECKSHEET
- Reason Code Explanation
- Automotive Terminology & Definitions
- Electrical Systems
- Using lemon2025'S System Wiring Diagrams
- Map - Electrical Systems
- Engine
- Engine Overhaul Procedures - General Information
- * Please Read This First *
- Description
- Engine Identification
- Inspection Procedures
- Cleaning Procedures
- Component Cleaning
- Cylinder Head Replacement
- Cylinder Head Overhaul
- Pistons, Connecting Rods & Bearings
- Crankshaft & Main Bearings
- Camshaft
- Timing Chains & Belts
- Timing Gears
- Oil Pump
- Break-In Procedure
- General Cooling System Service - General Information
- Engine Overhaul Procedures - General Information
- Engine Performance
- Electrostatic Discharge Warning - General Information
- Engine Performance Diagnostic Routine Outline - General Information
- Engine Performance Safety Precautions
- Map - Engine Performance & Maintenance
- Engine Performance And Maintenance (Including Exhaust Systems)
- Engine Performance & Maintenance CHECKSHEET
- Engine Performance And Maintenance
- Notes
- Accelerator Pedal Position Sensor
- Accessory Belts
- Accessory Pulleys
- Air Conditioning Cycling Switches
- Air Conditioning Pressure Sensors
- Air Ducts And Tubes
- Air Filter Elements
- Air Filter Gaskets
- Air Filter Housings And Gaskets
- Air Fuel Ratio Sensors
- Air Injection Control Solenoids
- Air Plenums
- Air Pump Belts
- Air Pumps (Electric Driven)
- Air Tubes
- Aspirator, Check And DECEL Valves
- Baffles
- Ballast Primary Supply Resistor Wires
- Ballast Resistors And Primary Supply Resistors
- Barometric Pressure Sensors
- Batteries
- Battery Cables, Wires And Connectors
- Battery Connectors
- Battery Trays And Hold Down Hardware
- Battery Wires
- Belt Idler Assemblies (Accessory And Cam Belts)
- Belt TENSIONERS (Accessory And Cam Belt)
- Belt-Driven Air Pumps
- Boost Control Mechanism
- Camshaft Position Sensors
- Carburetors And Chokes
- Casting Core Plugs And Expansion Plugs
- Charge Air Coolers ""INTERCOOLERS"" (CAC)
- Check Valves
- Chemical Engine DECARBONIZATION
- Chokes
- Clutch Pedal Position Switches
- Cold Start Injectors
- Combustion Chamber Cleaning
- Connectors
- Coolant Recovery Tanks
- Coolant
- Cooling Fan Motor Modules
- Cooling Fan Motor Relays And Modules
- Cooling Fan Motor Resistors
- Cooling Fan Motor Sensors And Switches
- Cooling Fan Motor Switches
- Cooling Fan Motors
- Crankshaft Position Sensors
- Cylinder Deactivation Solenoid
- Cylinder Head Assemblies
- DECEL Valves
- Deflectors
- Dip Stick Tubes
- Dip Sticks And Tubes
- Distributor Advances And Retarders (Mechanical And Vacuum)
- Distributor Boots And Shields
- Distributor Caps
- Distributor Retarders (Mechanical And Vacuum)
- Distributor Rotors
- Distributor Shields
- Distributors
- Early Fuel Evaporation Valves (Heat Riser Assemblies)
- EGR Coolers
- EGR Exhaust Manifold Passages
- EGR Intake And Exhaust Manifold Passages
- EGR Plates And Coolers
- Electronic Spark Control Modules
- Electronic Transmission Control Devices
- Electronic Transmission Feedback Devices
- Engine Coolant Temperature Sensors
- Engine Cooling Systems
- Engine Covers (Oil Pan, Valve Cover, Timing Cover)
- Engine DECARBONIZATION
- Engine Oil Canisters
- Engine Oil Coolers (External)
- Engine Oil Drain Plugs And Gaskets
- Engine Oil Filters And Canisters
- Engine Oil Gaskets
- Engine Oil Pressure Gauges (Mechanical)
- Engine Oil
- Evaporative Emissions (EVAP) Canister Filters
- Evaporative Emissions (EVAP) Canister Purge Devices
- Evaporative Emissions (EVAP) Canisters
- Evaporative Emissions (EVAP) Feedback Devices
- Exhaust Gas RECIRCULATION Devices
- Exhaust Gas RECIRCULATION Feedback Devices
- Expansion Plugs
- Fan Control Sensor
- Fuel Accumulators And Dampers
- Fuel And Cold Start Injectors
- Fuel Caps
- Fuel Dampers
- Fuel Delivery Check Valves
- Fuel Distributors (BOSCH Cis)
- Fuel Filler Necks And RESTRICTORS
- Fuel Filters
- Fuel Injector Cleaning
- Fuel Injectors
- Fuel Level Senders
- Fuel Pressure Regulators
- Fuel Pumps (In-Tank, External, Electrical Or Mechanical)
- Fuel Rails
- Fuel RESTRICTORS
- Fuel System Cleaning Service
- Fuel Tanks
- Fuel
- Gaskets
- Grommets (Valve Cover)
- Harmonic Dampers
- Heater Control Valves
- Heater Cores
- Hose Clamps
- Hose Connectors
- Hose Couplers
- Hoses And Tube Couplers, Connectors And Clamps
- Hoses And Tubes (Fuel Lines, Radiator, Vacuum, By-Pass, Heater, Recovery Tank And Oil Coolers)
- Housings
- Idle Air Controls
- Idle Speed Control Actuators
- Ignition Boots
- Ignition Coil Towers
- Ignition Coils
- Ignition Control Modules (ICM)
- Ignition Switches
- Ignition Terminals
- Ignition Wires (Secondary)
- Inertia Fuel Shut-Off Switches
- Intake Air Temperature Sensors
- Intake Cleaning
- Intake Manifolds
- In-Tank Fuel Strainers
- INTERCOOLERS
- Knock Sensors
- Liquid Vapor Separators
- Long Block Assemblies
- Manifold Absolute Pressure (Map) Sensors
- Mass Air Flow (MAF) Sensors
- Metal Air Manifolds And Pipes
- Metal Air Pipes
- Mix Control Solenoids
- Motor Mounts
- O2 Sensors
- Oil Pans
- Oil Pressure Sending Units
- Oil Pump Pick-Up Screens
- Oil Pumps
- O-Rings, Gaskets, Seals And Spring Locks
- Park Neutral Position Switches
- PCV Breather Elements
- PCV Orifices
- PCV Valves
- Pick-Up Assemblies (Includes Magnetic, Hall Effect And Optical)
- Power Steering Pressure Sensors
- Powertrain Control Modules (Pcm) And Prom
- Powertrain Control Prom
- Pressurized Expansion Tank Caps
- Radiator / Cooling Fan Blades
- Radiator / Cooling Fan Clutches
- Radiator Caps And Pressurized Expansion Tank Caps
- Radiators
- Roll Over Valves
- Sealing Compounds
- Seals
- Secondary Air Injection System Management Devices
- Sensors
- Short Block Assemblies
- Shrouds, Baffles And Deflectors
- Spark Plugs
- Spring Locks
- Super Chargers
- Switches
- Thermal Vacuum Valves
- Thermostatic Air Door Assemblies
- Thermostats And Housings
- Throttle Bodies
- Throttle Body Cleaning
- Throttle Cables
- Throttle Linkages And Cables
- Throttle Position Sensors
- Throttle Position Switches
- Timing Belt Sprockets
- Timing Belts
- Timing Covers
- Torque Struts
- Transmission Range Switches
- Tube Clamps
- Tube Connectors
- Tube Couplers
- Tubes
- Turbo Chargers
- Vacuum Connections
- Vacuum Hoses, Tubes And Connections (Non-Metallic)
- Vacuum Regulator Solenoids
- Vacuum Tubes
- Valve Covers
- Vehicle Speed Senors
- Volume Air Flow Sensors
- Waste Gate And Boost Control Mechanisms
- Waste Gate Control Solenoids
- Water Pumps (Electric)
- Water Pumps (Non-Electric)
- Wiring Harnesses And Connectors
- Reason Code Explanation
- Automotive Terminology & Definitions
- Parasitic Load Explanation & Test Procedures - General Information
- State Emission Standards - Diesel
- State Emission Standards - Gas
- ALASKA
- ARIZONA
- CALIFORNIA
- Colorado
- CONNECTICUT
- DELAWARE
- District Of COLUMBIA
- GEORGIA
- IDAHO
- ILLINOIS
- INDIANA
- KENTUCKY
- MARYLAND
- MASSACHUSETTS
- MISSOURI
- NEVADA
- New Jersey
- New MEXICO
- New YORK
- North CAROLINA
- OHIO
- OREGON
- PENNSYLVANIA
- RHODE Island
- TENNESSEE
- TEXAS
- UTAH
- VIRGINIA
- WASHINGTON
- WISCONSIN
- U. S. EPA ASM2525 & ASM5015 Start-Up Emission Standards
- U. S. EPA Revised Final ASM Emission Standards (ASM5015 & ASM2525)
- U.S. EPA Im240 Emission Standards
- Waveforms - Injector Pattern Tutorial - General Information
- * Please Read This First *
- Purpose Of This Article
- Is A Lab Scope Necessary?
- The Two Types Of Injector Drivers
- The Two Ways Injector Circuits Are Wired
- Interpreting Injector Waveforms
- Current Waveform Samples
- Notes
- Example #1 - Voltage Controlled Driver
- Example #2 - Voltage Controlled Driver
- Example #3 - Voltage Controlled Driver
- Example #4 - Current Controlled Driver
- Example #5 - Current Controlled Driver
- Example #6 - Current Controlled Driver
- Example #7 - Current Controlled Driver
- Example #8 - Current Controlled Driver
- Voltage Waveform Samples
- Notes
- Example #1 - Voltage Controlled Driver
- Example #2 - Voltage Controlled Driver
- Example #3 - Voltage Controlled Driver
- Example #4 - Current Controlled Driver
- Example #5 - Current Controlled Driver
- Example #6 - Current Controlled Driver
- Example #7 - Current Controlled Driver
- Example #8 - Current Controlled Driver
- Map - Exhaust Systems
- Exhaust Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Catalytic Converters
- Exhaust And Tail Pipes
- Exhaust Connections
- Hangers
- Heat Risers (Mechanical EFE Devices)
- Heat Shields
- Manifolds (Cast And Tube Type)
- Mechanical EFE Devices
- Muffler Valve
- Mufflers And Resonators
- Reason Code Explanation
- Exhaust Systems
- Heating, Ventilation & A/C (HVAC)
- Map - Heating, Ventilation, & Air Conditioning
- Heating, Ventilation & Air Conditioning Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Accumulators
- Actuators (Electrical)
- Actuators (Vacuum)
- Air Conditioning Fittings
- Air Conditioning Hoses
- Air Conditioning Metal Lines
- Air Control Doors
- Air Dams (External)
- Air Distribution System
- Belts
- Blend Doors
- Blower Fans (Blower Wheel Or Squirrel Cage)
- Blower Motors
- Blower Resistors
- Blower Switches
- Cabin Air Filters
- Circuit Breakers
- Compressor Clutch Assemblies
- Compressors
- Condenser Air Seals
- Condenser Fan Motors
- Condensers
- Connectors
- Control Cables
- Control Heads (Function Selectors)
- Control Linkages
- Control Modules
- Coolant
- Cooling Fan Blades
- Cooling Fan Clutches
- Cooling Fan Motors
- Evaporator Drain Tubes
- Evaporator Filters
- Evaporator Pressure Regulators (EPRS)
- Evaporators
- Expansion Valves
- Function Selectors
- Fuses, Fusible Links And Circuit Breakers
- Fusible Links
- Gaskets
- Heater Cases
- Heater Control Valves
- Heater Cores
- Heater Hoses
- High Pressure Relief Valves (HPRV)
- Idlers
- In-Line Filters
- Metal Fittings
- Metal Lines
- Mix And Air Control Doors (Blend Doors)
- ORIFACE Tubes
- O-Rings
- Pilot-Operated Absolutes (POAS)
- Plenums
- Pressure Control Valves
- Pressure Sensors
- Pulleys
- Radiators
- Receiver-DRIERS
- Refrigerant Oil
- Refrigerant
- Relays
- Seals
- Service Ports
- Spring Lock Couplings
- Suction Throttling Valves (STVS)
- Switches (Electrical)
- TENSIONERS
- Thermistors And Pressure Sensors
- Thermostats And Housings
- Vacuum Hoses And Tubes
- Vacuum Reservoirs
- Vacuum Tubes
- Valves In Receiver (VIRS)
- Water Pumps (Electric Auxiliary)
- Wiring Harnesses And Connectors
- Heating, Ventilation & Air Conditioning System CHECKSHEET
- Reason Code Explanation
- Automotive Terminology & Definitions
- Heating, Ventilation & Air Conditioning Systems
- Map - Heating, Ventilation, & Air Conditioning
- Hoist/Jack
- Identification
- CANADIAN Model Cross-Reference
- Identification Codes
- Metric Conversions
- OEM General Information
- Automatic Stop/Start Disable
- Identification Codes
- Jacking And Lifting
- Noise, Vibration And Harshness
- Description And Operation
- Diagnostic Tests
- Noise, Vibration and Harshness (NVH)
- Notes
- Diagnostic Theory
- Diagnostic Procedure Overview
- Tools and Techniques
- Write-Up Job Aid
- 1: Customer Interview
- 2: Pre-Drive Check
- 3: Preparing for the Road Test
- 4: Verify the Customer Concern
- 5: Road Test
- Classify NVH Symptom
- Noise Symptoms
- Vibration Symptoms
- Order of Vibration
- Relationship of Vibration Frequency to Order of Vibration
- Frequency Calculations
- Harshness Symptoms
- NVH Symptom Chart Categories
- Vehicle-Speed Related Vibrations
- Symptom Chart - Tire-Speed Related Vibrations
- Symptom Chart - Driveshaft-Speed Related Vibrations
- Symptom Chart - Engine-Speed Related Vibrations
- Symptom Chart - Noise, Air Leaks or Water Leaks
- Symptom Chart - Harshness
- Noise, Vibration and Harshness (NVH)
- Reset Procedures
- ATEQ TPMS Reset Procedure
- BARTEC TPMS Reset Procedure
- Maintenance Reminder Light (Reset Procedures)
- A/C Filter Service Reminder
- Engine Oil Replacement Reminder
- Notes
- Engine Oil Replacement Reminder Reset - Procedure 01
- Engine Oil Replacement Reminder Reset - Procedure 02
- Engine Oil Replacement Reminder Reset - Procedure 03
- Engine Oil Replacement Reminder Reset - Procedure 04
- Engine Oil Replacement Reminder Reset - Procedure 05
- Engine Oil Replacement Reminder Reset - Procedure 06
- Engine Oil Replacement Reminder Reset - Procedure 07
- Engine Oil Replacement Reminder Reset - Procedure 08
- Engine Oil Replacement Reminder Reset - Procedure 09
- Engine Oil Replacement Reminder Reset - Procedure 10
- Engine Oil Replacement Reminder Reset - Procedure 11
- Engine Oil Replacement Reminder Reset - Procedure 12
- Engine Oil Replacement Reminder Reset - Procedure 13
- Engine Oil Replacement Reminder Reset - Procedure 14
- Engine Oil Replacement Reminder Reset - Procedure 15
- Engine Oil Replacement Reminder Reset - Procedure 16
- Engine Oil Replacement Reminder Reset - Procedure 17
- Engine Oil Replacement Reminder Reset - Procedure 18
- Engine Oil Replacement Reminder Reset - Procedure 19
- Engine Oil Replacement Reminder Reset - Procedure 20
- Engine Oil Replacement Reminder Reset - Procedure 21
- Engine Oil Replacement Reminder Reset - Procedure 22
- Engine Oil Replacement Reminder Reset - Procedure 23
- Engine Oil Replacement Reminder Reset - Procedure 24
- Engine Oil Replacement Reminder Reset - Procedure 25
- Engine Oil Replacement Reminder Reset - Procedure 26
- Engine Oil Replacement Reminder Reset - Procedure 27
- Engine Oil Replacement Reminder Reset - Procedure 28
- Maintenance Service Reminder (Overhead Warning Lights)
- Maintenance Service Reminder (Sri)
- Maintenance Service Reminder (VMM)
- Tire Pressure Monitor System Reminder
- Notes
- Tire Pressure Sensor Types
- TPMS Reminder Reset - Procedure 01
- TPMS Reminder Reset - Procedure 02
- TPMS Reminder Reset - Procedure 03
- TPMS Reminder Reset - Procedure 04
- TPMS Reminder Reset - Procedure 05
- TPMS Reminder Reset - Procedure 07
- TPMS Reminder Reset - Procedure 08
- TPMS Reminder Reset - Procedure 09
- TPMS Reminder Reset - Procedure 10
- Tire Pressure Monitor Systems
- Specifications Index
- Steering
- Map - Steering, Suspension, Wheel Alignment, Wheels & Tires
- Steering & Suspension Systems
- Wheel And Tire
- Steering & Suspension CHECKSHEET
- Wheels & Tires CHECKSHEET
- Steering And Suspension, Wheel Alignment, Wheels And Tires
- Notes
- Active Handling
- Active Suspension Control Modules
- Active Variable Ratio Steering
- Active Yaw Control
- Adaptive Cruise Control
- Advance TRAC
- Air Bags
- Air Ride Control Modules
- Air Ride Suspension Torsion Springs (Counter Balancing)
- Air Ride Suspension
- Air Ride Tubes
- Air Shocks And Air Struts
- Air Spring Valves
- Air Springs
- Air Suspension Control Valves
- Air Suspension DRIERS
- Axle Acceleration Sensor
- Ball Joints
- Body Acceleration Sensor
- Bushings
- Center Links
- Compressors
- Continuous Damping Control
- Control Arm Shafts
- Control Arms
- Control Modules
- Distance Regulation Control Module
- Distance Regulation Sensor
- Drag Links
- Dynamic Stability Control
- Dynamic Stability Traction Control
- Electronic Ride Control Shocks And Struts
- Electronic Stability Control
- Electronic Suspension System
- Flex Couplers
- Gaskets
- Height Sensors
- Hydraulic Hoses
- Hydraulic Power Steering Pumps
- Hydraulic Suspension Hoses
- Hydraulic Suspension Pumps
- Idler Arms
- Intermediate Shaft U-Joints
- King Pins
- Modules
- Pitman Arms
- Power Steering Belts
- Power Steering Coolers
- Power Steering Fluid
- Power Steering Hoses
- Power Steering Lines (Steel)
- Power Steering Pumps - Electric
- Power Steering Pumps
- Radar Sensor
- Radius Arms
- Relay Rods
- Relays
- Sensors
- Shock Absorbers, Strut Cartridges And Strut Assemblies
- Spindles
- Springs, Coil, Leaf And Torsion Bars
- STABILITRAC
- Stability Management System
- Steering Angle Sensor
- Steering Arms
- Steering Couplers
- Steering Dampers
- Steering Gears (Except Rack And Pinion)
- Steering Gears, Rack And Pinion
- Steering Knuckles
- Strike Out Bumpers
- Strut Bearing Plate Assemblies
- Strut Rods
- Suspension Pumps (Hydraulic)
- Sway Bar Links
- Sway Bar Mounting Bushings
- Sway Bars
- Switches
- Tie Rod Ends (Inner And Outer)
- Tire Pressure Monitoring System
- Tire Pressure Sensors
- Tires
- Torque Sensor
- Torsion Springs
- Track Bar Bushings
- Track Bars
- Trailing Arm Bushings
- Trailing Arms
- Valve Stems
- Vehicle Dynamics Control
- Vehicle Speed Sensor
- Vehicle Stability Assist
- Vehicle Stability/Skid Control
- Warning Lamps
- Wheel Alignment
- Wheel Attachment Hardware
- Wheel Bearings, Races And Seals
- Wheels (Rims)
- Wiring Harnesses And Connectors
- Reason Code Explanation
- Automotive Terminology & Definitions
- Wheel Alignment Theory & Operation - General Information
- Map - Steering, Suspension, Wheel Alignment, Wheels & Tires
- Traction Control Disable Procedures
- Trouble Shooting - Manual Transmission - General Information
- Heating, Ventilation & A/C (HVAC)
- General Servicing
- HVAC Control Systems
- HVAC Auxiliary Control System
- Specifications
- Description And Operation
- Removal And Installation
- HVAC Control System
- Specifications
- Description And Operation
- Removal And Installation
- Air Conditioning (A/C) Compressor
- Air Conditioning (A/C) Pressure Relief Valve
- Air Inlet Duct
- Blower Motor
- Blower Motor Resistor
- Blower Motor Speed Control
- Clutch and Clutch Field Coil
- Compressor to Condenser Discharge Line
- Condenser Core
- Evaporator Core
- Heater Core
- Heater Core And Evaporator Core Housing
- Heating Ventilation Air Conditioning (HVAC) Module
- In-Vehicle Temperature Sensor
- Mode Door Actuator - Air Inlet Door
- Mode Door Actuator - Defrost/Panel/Floor Door
- Plenum Chamber
- Receiver Drier
- Register - Center, Taurus, Sable
- Register - Driver Side, Taurus, Sable
- Register - Passenger Side, Taurus, Sable
- Temperature Blend Door Actuator - LH
- Temperature Blend Door Actuator - RH
- Thermostatic Expansion Valve
- Thermostatic Expansion Valve Manifold and Tube Assembly
- HVAC Control System - General Information And Diagnostics
- Specifications
- Description And Operation
- Climate Control System
- Diagnostic Tests
- Climate Control System
- Notes
- Principles of Operation
- Compressor Anti-Slugging Strategy (CASS)
- The Refrigerant Cycle
- Inspection and Verification
- Alternate Diagnostic Methods - HVAC Module - Dual Automatic Temperature Control (DATC) Only
- HVAC Module Cold Boot Process
- PCM DTC Table
- HVAC Module DTC Table
- Symptom Chart - Climate Control Systems
- Symptom Chart - NVH
- Pinpoint Tests
- Notes
- Pinpoint Test A: DTC P0532 or P0533
- Pinpoint Test B: DTC P0645
- Pinpoint Test C: DTC B1251 or B1253
- Pinpoint Test D: DTC B1255 or B1257
- Pinpoint Test E: DTC B2426, B2427, B2795 or B2796
- Pinpoint Test F: DTC B2826 or B2827
- Pinpoint Test G: HVAC Functions Verification
- Pinpoint Test H: The Air Inlet Door is Inoperative
- Pinpoint Test I: Incorrect/Erratic Direction of Airflow From Outlets
- Pinpoint Test J: Insufficient, Erratic or No Heat
- Pinpoint Test K: The Air Conditioning (A/C) is Inoperative
- Pinpoint Test L: The Air Conditioning (A/C) is Always On - A/C Compressor Does Not Cycle
- Pinpoint Test M: The Air Conditioning (A/C) is Always On - A/C Mode Always Commanded ON
- Pinpoint Test N: Temperature Control is Inoperative/Does Not Operate Correctly
- Pinpoint Test O: The Blower Motor is Inoperative - EMTC
- Pinpoint Test P: The Blower Motor Does Not Operate Correctly - EMTC
- Pinpoint Test Q: The Blower Motor is Inoperative - DATC
- Pinpoint Test R: The Blower Motor Does Not Operate Correctly - DATC
- Pinpoint Test S: The Auxiliary Blower Motor is Inoperative
- Pinpoint Test T: The Auxiliary Blower Motor Does Not Operate Correctly
- Pinpoint Test U: The Auxiliary Temperature Control is Inoperative/Does Not Operate Correctly Using the Front/Rear Auxiliary Climate Controls
- Pinpoint Test V: The Auxiliary Panel/Floor Control is Inoperative/Does Not Operate Correctly Using the Front/Rear Auxiliary Climate Controls
- Pinpoint Test W: The Auxiliary Temperature, Panel/Floor and Blower Motor Controls are Inoperative/Do Not Operate Correctly Using the Front/Rear Auxiliary Climate Controls
- Pinpoint Test X: DTC B1317 or B1318
- Component Tests
- Resistor - Blower Motor
- Resistor - Auxiliary Blower Motor
- Temperature Sensor - In-Vehicle
- Temperature Sensor - Ambient
- Temperature Sensor - Evaporator Discharge
- Air Inlet Door Actuator
- Floor/Defrost/Panel Door Actuator
- Blend Door Actuator - Electronic Manual Temperature Control (EMTC)
- Blend Door Actuator - Dual Automatic Temperature Control (DATC)
- Auxiliary Temperature Door Actuator
- Auxiliary Panel/Floor Door Actuator
- Heater Core
- Heater Core - Plugged
- Heater Core - Pressure Test
- Heater Core - Bench Test
- Evaporator/Condenser Core - On-Vehicle Leak Test
- A/C Compressor - External Leak Test
- Climate Control System
- General Procedures
- Air Conditioning (A/C) Clutch Air Gap Adjustment
- Fluorescent Dye Leak Detection
- Electronic Leak Detection
- Air Conditioning (A/C) System Flushing
- Air Conditioning (A/C) System Recovery, Evacuation and Charging
- Notes
- Refrigerant System Recovery
- Refrigerant System Evacuation Using an R-134a Refrigerant Management Machine
- Refrigerant System Evacuation Using an R-134a Manifold Gauge Set
- Refrigerant System Charging Using an R-134a Refrigerant Management Machine
- Refrigerant System Charging Using an R-134a Manifold Gauge Set and Automatic Refrigerant Charging Motor
- Refrigerant Oil Adding
- Refrigerant Identification Testing
- Air Conditioning (A/C) Odor Treatment
- HVAC Auxiliary Control System
- Maintenance
- Procedures
- Maintenance Reminder Light (Reset Procedures)
- A/C Filter Service Reminder
- Engine Oil Replacement Reminder
- Notes
- Engine Oil Replacement Reminder Reset - Procedure 01
- Engine Oil Replacement Reminder Reset - Procedure 02
- Engine Oil Replacement Reminder Reset - Procedure 03
- Engine Oil Replacement Reminder Reset - Procedure 04
- Engine Oil Replacement Reminder Reset - Procedure 05
- Engine Oil Replacement Reminder Reset - Procedure 06
- Engine Oil Replacement Reminder Reset - Procedure 07
- Engine Oil Replacement Reminder Reset - Procedure 08
- Engine Oil Replacement Reminder Reset - Procedure 09
- Engine Oil Replacement Reminder Reset - Procedure 10
- Engine Oil Replacement Reminder Reset - Procedure 11
- Engine Oil Replacement Reminder Reset - Procedure 12
- Engine Oil Replacement Reminder Reset - Procedure 13
- Engine Oil Replacement Reminder Reset - Procedure 14
- Engine Oil Replacement Reminder Reset - Procedure 15
- Engine Oil Replacement Reminder Reset - Procedure 16
- Engine Oil Replacement Reminder Reset - Procedure 17
- Engine Oil Replacement Reminder Reset - Procedure 18
- Engine Oil Replacement Reminder Reset - Procedure 19
- Engine Oil Replacement Reminder Reset - Procedure 20
- Engine Oil Replacement Reminder Reset - Procedure 21
- Engine Oil Replacement Reminder Reset - Procedure 22
- Engine Oil Replacement Reminder Reset - Procedure 23
- Engine Oil Replacement Reminder Reset - Procedure 24
- Engine Oil Replacement Reminder Reset - Procedure 25
- Engine Oil Replacement Reminder Reset - Procedure 26
- Engine Oil Replacement Reminder Reset - Procedure 27
- Engine Oil Replacement Reminder Reset - Procedure 28
- Maintenance Service Reminder (Overhead Warning Lights)
- Maintenance Service Reminder (Sri)
- Maintenance Service Reminder (VMM)
- Tire Pressure Monitor System Reminder
- Notes
- Tire Pressure Sensor Types
- TPMS Reminder Reset - Procedure 01
- TPMS Reminder Reset - Procedure 02
- TPMS Reminder Reset - Procedure 03
- TPMS Reminder Reset - Procedure 04
- TPMS Reminder Reset - Procedure 05
- TPMS Reminder Reset - Procedure 07
- TPMS Reminder Reset - Procedure 08
- TPMS Reminder Reset - Procedure 09
- TPMS Reminder Reset - Procedure 10
- Maintenance Schedule
- Description And Operation
- Maintenance Schedules - Gasoline Engines
- Notes
- General Maintenance Information
- Special Operating Condition Requirements
- Checks and Services
- Multi-Point Inspection
- In-Line, Service-Installed Transmission Fluid Filter
- Normal Schedule
- Notes
- 12,000 Km (7,500 Mi)
- 24,000 Km (15,000 Mi)
- 36,000 Km (22,500 Mi)
- 48,000 Km (30,000 Mi)
- 60,000 Km (37,500 Mi)
- 72,000 Km (45,000 Mi)
- 84,000 Km (52,500 Mi)
- 96,000 Km (60,000 Mi)
- 108,000 Km (67,500 Mi)
- 120,000 Km (75,000 Mi)
- 132,000 Km (82,500 Mi)
- 144,000 Km (90,000 Mi)
- 156,000 Km (97,500 Mi)
- 168,000 Km (105,000 Mi)
- 180,000 Km (112,500 Mi)
- 192,000 Km (120,000 Mi)
- 204,000 Km (127,500 Mi)
- 216,000 Km (135,000 Mi)
- 228,000 Km (142,500 Mi)
- 240,000 Km (150,000 Mi)
- Exceptions To Normal Schedule
- Maintenance Schedules - Gasoline Engines
- Description And Operation
- Maintenance Reminder Light (Reset Procedures)
- Procedures
- Restraints
- Air Bag, SRS
- Supplemental Inflatable Restraint System
- Specifications
- Description And Operation
- Diagnostic Tests
- Air Bag and Safety Belt Pretensioner Supplemental Restraint System (SRS)
- Notes
- Principles of Operation
- Notes
- Air Bag Warning Indicator
- Air Bag Module Second Stage Deployment Check
- Clockspring
- Driver Air Bag Module
- Electrical System
- High-Speed Controller Area Network (HS-CAN)
- Impact Sensors
- Loops/Squibs
- Occupant Classification Sensor (OCS) System
- Occupant Classification System Module (OCSM)
- Passenger Air Bag Deactivation (PAD) Indicator
- Passenger Air Bag Module
- Restraints Control Module (RCM)
- Safety Belt Buckle Pretensioners
- Safety Belt Buckle Switches
- Safety Belt (Adaptive Load Limiting) Retractor
- Safety Belt Tension Sensor
- Safety Canopy Module
- Seat Track Position Sensors
- Secondary Air Bag Warning (Chime)
- Side Air Bag Module
- Diagnostic Instructions
- Air Bag Reconnect Checklist
- Air Bag Module Second Stage Deployment Check
- Glossary
- Disconnect the Component
- Notes
- Deactivate the Supplemental Restraint System (SRS)
- Depower the Supplemental Restraint System (SRS)
- Deployment Loop
- Install a New Component
- Prove Out the Supplemental Restraint System (SRS)
- Reactivate the Supplemental Restraint System (SRS)
- Reconnect the Supplemental Restraint System (SRS)
- Repower the Supplemental Restraint System (SRS)
- Secondary Air Bag Warning
- Squib
- Verify the System
- Disconnect the Component
- Inspection and Verification
- Supplemental Restraint System (SRS) DTC Table
- Symptom Chart
- Pinpoint Tests
- Pinpoint Test A: The Air Bag Warning Indicator is Illuminated Continuously
- Pinpoint Test B: DTC B1046, B1047, B1048, B1049, B1054, B1055, B1056, B1057, B1058, B1059, B2A3F and/or B2A40 - Cross Link to Another Firing Loop Fault(s)
- Pinpoint Test C: LFC 38 or 39 DTC B1085 - Restraint System - Seatbelt Load Limiter Status
- Pinpoint Test D: LFC 18 DTC B1884 - PAD Warning Lamp Circuit Failure
- Pinpoint Test E: LFC 18 DTC B1890 - PAD Warning Lamp Circuit Short to Battery
- Pinpoint Test F: DTC B2290 - Occupant Classification Sensor (OCS) System Fault
- Pinpoint Test G: LFC 33 or 34 DTC B2292 - Restraint System - Seatbelt Pretensioner Fault
- Pinpoint Test H: LFC 19 or 21 DTC B2293 - Restraint System - Air Bag Fault
- Pinpoint Test I: LFC 24 or 25 DTC B2294 - Restraint System - Curtain Fault
- Pinpoint Test J: LFC 22 or 23 DTC B2295 - Restraint System - Side Air Bag Fault
- Pinpoint Test K: LFC 42, 43, 44, 45 or 46 DTC B2296 - Restraint System - Impact Sensor Fault
- Pinpoint Test L: LFC 51 DTC B2434 - Drivers Seat Belt Buckle Switch Circuit Short to Ground
- Pinpoint Test M: LFC 51 DTC B2435 - Drivers Seat Belt Buckle Switch Resistance Out of Range
- Pinpoint Test N: LFC 52 DTC B2438 - Passengers Seat Belt Buckle Switch Circuit Short to Ground
- Pinpoint Test O: LFC 52 DTC B2439 - Passengers Seat Belt Buckle Switch Resistance Out of Range
- Pinpoint Test P: LFC 51 DTC B2691 - Seat Belt Buckle Switch Circuit Fault, Front Driver's Side
- Pinpoint Test Q: LFC 52 DTC B2692 - Front Passenger's Seat Belt Buckle Switch Circuit Fault
- Pinpoint Test R: LFC 16 DTC B2909 - Belt Tension Sensor Fault
- Pinpoint Test S: LFC 15 DTC C1414 - Incorrect Module Design Level
- Pinpoint Test T: LFC 49 DTC C1947 - Front Driver's Seat Track Position Switch Circuit Short to Ground
- Pinpoint Test U: LFC 49 DTC C1948 - Front Driver's Seat Track Position Switch Circuit Resistance Out of Range
- Pinpoint Test V: LFC 49 DTC C1981 - Front Driver's Seat Track Position Switch Circuit Fault
- Pinpoint Test W: LFC 55 DTC C2200 - Front Passenger's Seat Track Position Switch Circuit Fault
- Pinpoint Test X: LFC 55 DTC C2202 - Front Passenger's Seat Track Position Switch Circuit Short to Ground
- Pinpoint Test Y: LFC 55 DTC C2204 - Front Passenger's Seat Track Position Switch Circuit Resistance Out of Range
- Air Bag and Safety Belt Pretensioner Supplemental Restraint System (SRS)
- General Procedures
- Supplemental Restraint System (SRS) Depowering and Repowering
- Supplemental Restraint System (SRS) Deactivation and Reactivation
- Inspection and Repair After a Supplemental Restraint System (SRS) Deployment
- Pyrotechnic Device Disposal
- Disposal of Deployable Devices and Pyrotechnic Devices That are Undeployed/Inoperative
- Disposal of Deployable Devices and Pyrotechnic Devices That Are Deployed
- Disposal of Deployable Devices and Pyrotechnic Devices That Require Manual Deployment
- Driver Air Bag Module, Passenger Air Bag Module and Seat Side Air Bag Modules - Remote Deployment
- Safety Belt Buckle Pretensioners, Safety Belt Retractor Pretensioners and Adaptive Load Limiting Safety Belt Retractors - Remote Deployment
- Safety Belt Buckle Pretensioners, Safety Belt Retractor Pretensioners and Load Limiting Safety Belt Retractors - In-Vehicle Deployment
- Safety Canopy Modules and Side Air Curtain Modules - In-Vehicle Deployment
- Deployable Steering Column - In-Vehicle Deployment
- Removal And Installation
- Air Bag Trim Cover - Passenger, Taurus X
- Clockspring
- Driver Air Bag Module
- Front Impact Severity Sensor
- Passenger Air Bag Module - Taurus X
- Passenger Air Bag Module - Taurus, Sable
- Passenger Air Bag Deactivation (PAD) Indicator - Taurus X
- Passenger Air Bag Deactivation (PAD) Indicator - Taurus, Sable
- Occupant Classification Sensor - Original Equipment
- Occupant Classification Sensor - Service Kit
- Restraints Control Module (RCM)
- Safety Canopy Module - Taurus X
- Safety Canopy Module - Taurus, Sable
- Side Air Bag Module
- Side Impact Sensor - Front Door
- Side Impact Sensor - Taurus X, Second Row, C-Pillar
- Side Impact Sensor - Taurus, Sable, Second Row, C-Pillar
- Seat Position Sensor
- Supplemental Inflatable Restraint System
- Restraints Control Systems
- Safety Belt System
- Specifications
- Description And Operation
- Diagnostic Tests
- General Procedures
- Removal And Installation
- Safety Belt Retractor - Front
- Safety Belt Retractor - Rear, Center, Taurus, Sable
- Safety Belt Retractor - Rear, Center, Taurus X
- Safety Belt Retractor - Rear, Outboard, Taurus, Sable
- Safety Belt Retractor - Second Row, Outboard, Taurus X
- Safety Belt Retractor - Third Row, Outboard, Taurus X
- Safety Belt Shoulder Height Adjuster
- Safety Belt Buckle and Pretensioner
- Safety Belt Buckle - Second Row, Taurus X
- Safety Belt Buckle - Rear, Taurus, Sable
- Safety Belt Buckle - Third Row, Bench
- Safety Belt Buckle - Third Row, 50 Percent
- Child Safety Seat Tether Anchor - LATCH, Taurus, Sable
- Safety Belt System
- Seat Belts
- Safety Belt System
- Specifications
- Description And Operation
- Diagnostic Tests
- General Procedures
- Removal And Installation
- Safety Belt Retractor - Front
- Safety Belt Retractor - Rear, Center, Taurus, Sable
- Safety Belt Retractor - Rear, Center, Taurus X
- Safety Belt Retractor - Rear, Outboard, Taurus, Sable
- Safety Belt Retractor - Second Row, Outboard, Taurus X
- Safety Belt Retractor - Third Row, Outboard, Taurus X
- Safety Belt Shoulder Height Adjuster
- Safety Belt Buckle and Pretensioner
- Safety Belt Buckle - Second Row, Taurus X
- Safety Belt Buckle - Rear, Taurus, Sable
- Safety Belt Buckle - Third Row, Bench
- Safety Belt Buckle - Third Row, 50 Percent
- Child Safety Seat Tether Anchor - LATCH, Taurus, Sable
- Safety Belt System
- Air Bag, SRS
- Steering
- Manual Steering
- Power Steering System
- Specifications
- Description And Operation
- Diagnostic Tests
- Removal And Installation
- Steering System - General Information
- Specifications
- Description And Operation
- Diagnostic Tests
- Steering System
- Notes
- Principles of Operation
- Inspection and Verification
- Symptom Chart - Steering System
- Symptom Chart - Noise, Vibration and Harshness (NVH)
- Pinpoint Tests
- Pinpoint Test A: DTCs B1317/B1318 - Battery Voltage High/Low
- Pinpoint Test B: DTCs C192A, C192B, C192C, C192D and C1933 - Solenoid Actuator Circuit Fault
- Pinpoint Test C: DTCs C195A, C195B, C1955 and C1956 - Steering Angle Sensor Circuit Failure
- Pinpoint Test D: Steering Has Lack of Assist or Inconsistent Assist
- Pinpoint Test E: Excessive Steering Wheel Play
- Pinpoint Test F: Steering System Drift/Pull/Wander
- Component Tests
- Steering System
- General Procedures
- Power Steering System
- Power Steering
- Power Steering System
- Specifications
- Description And Operation
- Diagnostic Tests
- Removal And Installation
- Steering System - General Information
- Specifications
- Description And Operation
- Diagnostic Tests
- Steering System
- Notes
- Principles of Operation
- Inspection and Verification
- Symptom Chart - Steering System
- Symptom Chart - Noise, Vibration and Harshness (NVH)
- Pinpoint Tests
- Pinpoint Test A: DTCs B1317/B1318 - Battery Voltage High/Low
- Pinpoint Test B: DTCs C192A, C192B, C192C, C192D and C1933 - Solenoid Actuator Circuit Fault
- Pinpoint Test C: DTCs C195A, C195B, C1955 and C1956 - Steering Angle Sensor Circuit Failure
- Pinpoint Test D: Steering Has Lack of Assist or Inconsistent Assist
- Pinpoint Test E: Excessive Steering Wheel Play
- Pinpoint Test F: Steering System Drift/Pull/Wander
- Component Tests
- Steering System
- General Procedures
- Power Steering System
- Steering Column
- Manual Steering
- Suspension
- Front Suspension
- Front Suspension
- Suspension System - General Information
- Rear Suspension
- Rear Suspension
- Specifications
- Description And Operation
- Diagnostic Tests
- Removal And Installation
- Wheel Bearing and Wheel Hub
- Wheel Studs
- Upper Arm
- Lower Arm
- Toe Link
- Trailing Arm
- Stabilizer Bar - Front Wheel Drive (FWD)
- Stabilizer Bar - All Wheel Drive (AWD)
- Stabilizer Bar Link
- Wheel Knuckle - Front Wheel Drive (FWD)
- Wheel Knuckle - All Wheel Drive (AWD)
- Shock Absorber and Spring Assembly - Front Wheel Drive (FWD)
- Shock Absorber and Spring Assembly - All Wheel Drive (AWD)
- Suspension System - General Information
- Rear Suspension
- Wheel Alignment
- Wheels & Tire System
- Wheels & Tires
- Specifications
- Description And Operation
- Diagnostic Tests
- Wheels And Tires
- Tire Pressure Monitoring System
- Notes
- Principles of Operation
- Inspection and Verification
- Symptom Chart
- Pinpoint Tests
- Pinpoint Test D: Tire Pressure Monitoring System (TPMS) Indicator ON Solid and Message Center (if equipped) Displays LOW TIRE PRESSURE
- Pinpoint Test E: Smart Junction Box (SJB) Will Not Enter Sensor Training Mode When Using the Tire Pressure Monitoring System (TPMS) Sensor Training Procedure
- Pinpoint Test F: Tire Pressure Monitoring System (TPMS) Indicator FLASHES for 70 Seconds and Then Remains ON Solid When the Ignition Key is Turned to the ON Position, the Message Center (if equipped) Displays TIRE PRESSURE SENSOR or MONITOR FAULT and DTC B2872 or B287A is Present
- Pinpoint Test G: DTC B106A - Pressure Sensor Range Bit Incorrect State
- Pinpoint Test H: DTC B106B - Tire Pressure Sensor Low Battery
- General Procedures
- Removal And Installation
- Disassembly And Assembly
- Disassembly And Assembly Of Subassemblies
- Wheels & Tires
- Front Suspension
- Transmission
- Automatic Trans
- Automatic Transmission
- Specifications
- Diagnostic Tests
- Diagnostic Strategy
- Diagnostic Flow Chart
- Preliminary Inspection
- Solenoid Body Strategy
- Road Testing Vehicle
- Shift Point Road Test
- Torque Converter Diagnosis
- Visual Inspection
- Diagnostics
- Output State Control (OSC) Mode
- Diagnostic Parameters Identification (PID) Chart
- Transaxle Drive Cycle Test
- Diagnostic Trouble Code (DTC) Charts
- Transaxle Connector Layouts
- Pinpoint Tests - OSC Equipped Vehicle
- Special Testing Procedures
- Leakage Inspection
- Transmission Fluid Cooler
- Diagnosis By Symptom
- General Procedures
- In-Vehicle Servicing
- Main Control
- Turbine Shaft Speed (TSS) Sensor
- Output Shaft Speed (OSS) Sensor
- Halfshaft Seal - RH, Front Wheel Drive (FWD)
- Halfshaft Seal - RH, All Wheel Drive (AWD)
- Halfshaft Seal - LH
- Digital Transmission Range (TR) Sensor
- Transaxle Support Insulator
- Solenoid Body Assembly
- Main Control Cover
- Transaxle Filler Tube
- Manual Control Lever Shaft Seal
- Removal
- Installation
- Automatic Transmission - Theory & Operation, & Disassembly & Assembly
- Specifications
- Theory And Operation
- Transaxle Description
- Identification Tags
- Major Components
- Gear Ratios
- Torque Converter
- Shift Patterns
- Mechanical Components and Functions
- Planetary Gearset
- Input Shaft
- Front Planetary Carrier Hub (Output Hub)
- Final Drive Gearset
- Differential
- Direct (3, 5, R) Clutch
- Overdrive (O/D) (4, 5, 6) Clutch
- Forward (1, 2, 3, 4) Clutch
- Low/Reverse Clutch
- Intermediate (2, 6) Clutch
- Low One-Way Clutch (OWC)
- External sealing
- Bushings, Bearings and Thrust Washer Locations
- Lubrication
- Park
- Hydraulic System
- Hydraulic Circuits
- Hydraulic Circuit Identification and Function
- Line Pressure Hydraulic Circuits
- Lubrication Hydraulic Circuits
- Torque Converter Hydraulic Circuits
- Solenoid Hydraulic Circuits
- Forward Clutch Hydraulic Circuits
- Direct (3, 5, R) Clutch Hydraulic Circuits
- Intermediate (2, 6) Clutch Hydraulic Circuits
- Low/Reverse Clutch Hydraulic Circuits
- Overdrive Clutch Hydraulic Circuits
- Transaxle Electronic Control System
- Electronic System Description
- Electronic Ignition (EI)
- Accelerator Pedal Position (APP)
- Throttle Position (TP) Sensor
- Pcm
- Transmission Range (TR) Sensor
- Brake Pedal Position (BPP) Switch
- Turbine Shaft Speed (TSS) Sensor
- Output Shaft Speed (OSS) Sensor
- Solenoid Body
- Shift Solenoid A (SSA), Shift Solenoid B (SSB), Shift Solenoid C (SSC), Shift Solenoid D (SSD) and Shift Solenoid E (SSE)
- Transmission Fluid Temperature (TFT) Sensor
- Line Pressure Control (LPC) Solenoid
- Torque Converter Clutch (TCC) Solenoid
- Mass Air Flow (MAF) Sensor
- Intake Air Temperature (IAT) Sensor
- A/C Clutch
- Cylinder Head Temperature (CHT) Sensor
- Transaxle Operation
- Transaxle Operation Overview
- Park Position
- Reverse Position
- Neutral Position
- 1st Gear Above 5 km/h (3 mph)
- 2nd Gear
- 3rd Gear Torque Converter Clutch (TCC) Released
- 3rd Gear TCC Applied
- 4th Gear Torque Converter Clutch (TCC) Released
- 4th Gear Torque Converter Clutch (TCC) Applied
- 5th Gear Torque Converter Clutch (TCC) Released
- 5th Gear Torque Converter Clutch (TCC) Applied
- 6th Gear Torque Converter Clutch (TCC) Released
- 6th Gear Torque Converter Clutch (TCC) Applied
- Manual LOW Position and 1st Gear Below 5 km/h (3 mph)
- Disassembly
- Disassembly And Assembly Of Subassemblies
- Assembly
- Automatic Transmission Cooling
- Automatic Transmission External Controls
- Automatic Transmission
- Transfer Case
- Transfer Case - Four Wheel Drive (4WD) Systems
- Specifications
- Description And Operation
- Diagnostic Tests
- Four Wheel Drive (4WD) Systems
- Notes
- Principles of Operation
- Inspection and Verification
- DTC Tables
- Symptom Chart - Four Wheel Drive System
- Pinpoint Tests
- Pinpoint Test A: All-Wheel Drive (AWD) System Functional Test
- Pinpoint Test B: DTC B1317/B1318 - Battery Voltage is High/Low (4X4 Control Module)
- Pinpoint Test C: DTC U0415 - 4X4 Control Module Received No/Invalid Data From ABS Module
- Pinpoint Test D: DTCs P1824/P1825 - 4-Wheel Drive Clutch Relay Circuit Failure/4-Wheel Drive Clutch Relay Open Circuit
- Pinpoint Test E: Vehicle Binds in a Turn or Resists Turning/Pulsates or Shudders in a Straight Line
- Pinpoint Test F: DTC P1635 - Tire/Axle Out of Acceptable Range
- Four Wheel Drive (4WD) Systems
- Removal And Installation
- Transfer Case - Power Transfer Unit (PTU)
- Transfer Case - Four Wheel Drive (4WD) Systems
- Automatic Trans
- External Pages