Common Specifications & Procedures
COMMON SPECIFICATIONS & PROCEDURES - MUSTANG
| System | Specification/Procedure | ||
|---|---|---|---|
| Air Conditioning | |||
| Service | SPECIFICATIONS | ||
| Torque | TORQUE SPECIFICATIONS | ||
| Battery | SPECIFICATIONS | ||
| Brakes | |||
| Bleeding Sequence | RR, LR, RF, LF BRAKE SYSTEM BLEEDING |
||
| Disc Brakes w/Torque | |||
| Front | SPECIFICATIONS | ||
| Rear | SPECIFICATIONS | ||
| Charging | |||
| Generator w/Torque | SPECIFICATIONS | ||
| Drive Belts | |||
| Adjustment | ACCESSORY DRIVE | ||
| Belt Routing | ACCESSORY DRIVE BELT ROUTING | ||
| Engine Cooling | |||
| General Service Specifications | SPECIFICATIONS | ||
| Radiator Cap Pressure | 16 psi (110 kPa) | ||
| Thermostat R & I | |||
| 3.7L | THERMOSTAT -- 3.7L . | ||
| 5.0L (4V) | THERMOSTAT -- 5.0L | ||
| 5.8L (4V) | THERMOSTAT -- 5.8L (4V) | ||
| Water Pump R & I | |||
| 3.7L | COOLANT PUMP -- 3.7L | ||
| 5.0L (4V) | COOLANT PUMP -- 5.0L | ||
| 5.8L (4V) | COOLANT PUMP -- 5.8L (4V) | ||
| Engine Mechanical | |||
| 3.7L | |||
| Compression | SPECIFICATIONS | ||
| Oil Pressure (minimum at 1, 500 RPM, engine at normal operating temperature) | 30 psi (206 kPa) | ||
| Overhaul | SPECIFICATIONS | ||
| Torque | TORQUE SPECIFICATIONS | ||
| 5.0L (4V) | |||
| Compression | SPECIFICATIONS | ||
| Oil Pressure at idle (engine at normal operating temperature) Oil pressure at 2, 000 rpm (engine at normal operating temperature) |
10-15 psi (69-103 kPa) 30-40 psi (207-276 kPa) |
||
| Overhaul | SPECIFICATIONS | ||
| Torque | TORQUE SPECIFICATION | ||
| 5.8L (4V) | |||
| Compression | SPECIFICATIONS | ||
| Oil Pressure (@ 2, 000 RPM, engine at normal operating temperature) | 40-60 psi (276-414 kPa) | ||
| Overhaul | SPECIFICATIONS | ||
| Torque | TORQUE SPECIFICATIONS | ||
| Fluid Specifications | See FLUIDS under MAINTENANCE tab. From within Manager or Service Writer, click the "30/60/90 Interval" or "Maint." button. | ||
| Flywheel/Flex Plate Torque | |||
| 3.7L | FLEXPLATE or FLYWHEEL | ||
| 5.0L (4V) | FLEXPLATE or FLYWHEEL . | ||
| 5.8L (4V) | FLYWHEEL | ||
| Fuel System | |||
| Fuel Filter Location | Right rear, near fuel tank snapped in bracket. | ||
| Fuel Filter R & I | FUEL FILTER | ||
| Pressure Release Procedure | FUEL SYSTEM PRESSURE RELEASE | ||
| Pressure Specification | SPECIFICATIONS | ||
| Fuel Pressure Test Procedure | FUEL SYSTEM PRESSURE TEST | ||
| Ignition | |||
| Firing Order & Cylinder Identification | FIRING ORDER & CYLINDER IDENTIFICATION | ||
| Ignition Wire Resistance | Engine has coil-on-plug ignition. | ||
| Spark Plugs | |||
| 3.7L | |||
| Type | CYFS-12F-5 | ||
| Gap | 0.049-0.053 In. (1.25-1.35 mm) | ||
| Torque | 133 In. Lbs. (15 N.m) | ||
| 5.0L (4V) | |||
| Type | CYFS-12Y | ||
| Gap | 0.049-0.053 In. (1.25-1.35 mm) | ||
| Torque | 124 In. Lbs. (14 N.m) | ||
| 5.8L (4V) | |||
| Type | CGSF 12Y P | ||
| Gap | 0.033-0.037 In. (0.85-0.95 mm) | ||
| Torque | 159 Inch Lbs. (18 N.m) | ||
| Starting | |||
| Starter w/Torque | SPECIFICATIONS | ||
| Wheel Alignment | |||
| Adjustment Specifications | SPECIFICATIONS | ||
| Torque | TORQUE SPECIFICATIONS | ||
| Wheel & Tire | |||
| Wheel Lug Nut Torque | 100 Ft. Lbs. (135 N.m) | ||