Technical Service Bulletins

A/C Compressor
- A/C System Diagnosis After Component Failure (L-SB-0010-15)
Accessories & Equipment
- RAPGARD Protective Film Removal (L-SB-0021-24)
- Diagnostic Tester Controller Area Network (Can) Interface Module (SS001-03)
Accessories Control Systems
- Immobilizer And Smart Key Reset (SS002-01)
- TECHSTREAM Ecu Flash Reprogramming Procedure (SS002-07)
- Navigation System Door Replacement (BO011-04)
- Diagnostic Tester Controller Area Network (Can) Interface Module (SS001-03)
Air Bag, SRS
- SRS Component Disposal As Hazardous Material Treatment (L-SB-0126-17)
- Seat Cover Replacement For Side Airbag Equipped Vehicles (L-SB-0143-11)
- SRS Precautions - Crib # 160 (T-CRIB-160)
Anti-Theft Systems
- Interior Electrical Component Precautions (L-SB-0066-11 REV2)
- Immobilizer And Smart Key Reset (SS002-01)
- Replacement RKE Key Casings (BO005-06)
- Diagnostic Tester Immobilizer Functions (SS005-01)
Automatic Trans
- Interior Electrical Component Precautions (L-SB-0066-11 REV2)
- Automatic Transmission Replacement Precautions (L-SB-0082-14)
- Torque Converter Bolt Installation (L-SB-0007-11 REV1)
- Alignment Pin Installation During Transmission/Transaxle Assembly Installation (L-SB-0026-08)
- Automatic Transmission Shipping Bag For Warranty Recovery (TC010-07)
- A650E Transmission Solenoid Identification (TC004-05)
Auxiliary Emission Control Systems
- O2S Test Results (Mode 05) (SS002-03)
- Ecu Flash Reprogramming Process (SS001-01)
Battery Management Systems
- Hybrid Information For Emergency Responders - Crib # 166 (T-CRIB-166)
Body Electrical
- Flood Damaged Vehicle Inspection & Handling (L-SB-0113-12 REV1)
- Interior Electrical Component Precautions (L-SB-0066-11 REV2)
Body Interior
- Diagnostic Tester Controller Area Network (Can) Interface Module (SS001-03)
Brakes Control Systems
- TECHSTREAM Ecu Flash Reprogramming Procedure (SS002-07)
Charging Systems
- Flood Damaged Vehicle Inspection & Handling (L-SB-0113-12 REV1)
- Battery Maintenance For In-Stock Vehicles & Pre-Delivery (PG009-02)
Communication Devices
- "Hands-Free" Sound Quality Improvement (AX001-03)
Cooling System (Mechanical)
- Keep The Cooling System Free Of Debris And Corrosion To Prevent Premature Water Pump Failure (TT002-13)
- Radiator Cap Inspection (EG007-05)
Cruise Control Systems
- Interior Electrical Component Precautions (L-SB-0066-11 REV2)
Driveshaft & Universal Joints
- Driveshaft Assembly Replacement (TC002-07)
Engine Control Systems
- GTS+ TECHSTREAM Ecu Flash Reprogramming Procedure (L-SB-0001-18 REV2)
- TECHSTREAM Ecu Flash Reprogramming Procedure (SS002-07)
- O2S Test Results (Mode 05) (SS002-03)
- Ecu Flash Reprogramming Process (SS001-01)
- Diagnostic Tester Controller Area Network (Can) Interface Module (SS001-03)
Entertainment Systems
- Audio Steering Wheel Control Abnormal Operation (L-SB-0034-08)
- Audio Quick Reference Guide (AU001-06)
- Cd Skip Verification Using LEXUS Master Cd (SS003-05)
- Audio Door Opening/Closing Effort Improvements (BO001-05)
- Audio Door Replacement (BO002-05)
Exhaust
- Sulfur Odor From Exhaust (EG001-03)
Exterior Body Panels
- Paint Stains Under RAPGARD™ (PA001-03 REV.)
- Rear Luggage Lock Inoperative (EL004-04)
Front Suspension
- Suspension Ball Joint Inspection (PG012-02)
Gauges & Instrument Panels
- Audio Door Opening/Closing Effort Improvements (BO001-05)
- Navigation System Door Replacement (BO011-04)
Headlights
- Hid Headlight System - Diagnostic Tips (L-SB-0047-08)
HVAC Control Systems
- A/C System Diagnosis After Component Failure (L-SB-0010-15)
- Heater Control Panel Base Sub-Assembly Replacement (BO006-04)
Identification
- Replacement Certification Labels And VIN Plates (PG008-07)
- Engine Bank 1 And Bank 2 A/F And O2 Identification (L-SB-0188-09)
- Engine Serial Number Location (L-SB-0085-08 REV1)
- Replacement VIN Plates (PG007-07)
- 2003 My LEXUS Colors - Crib # 131 (L-CRIB-131)
Ignition Switch/Steering Lock
- Immobilizer And Smart Key Reset (SS002-01)
Infotainment
- Reception Diagnosis Using Antenna Test Kit (L-SB-0008-15)
- Repair Manual Supplement: Replacement Of Antenna Mast (L-SB-0029-13)
- Navigation System Door Replacement (BO011-04)
- Blank Map Screen In Navigation System (EL006-03)
Interior/Exterior Trim
- Interior Electrical Component Precautions (L-SB-0066-11 REV2)
- Navigation System Door Replacement (BO011-04)
- Trim Garnish Loose (BO007-03)
Lubrication System
- Cylinder Head Cover Baffle Precautions (L-SB-0021-08)
Mechanical
- Oil Leak Diagnosis And Repair (L-SB-0002-20 REV1)
- Hydraulic Versus Mechanical TENSIONERS (TT001-13)
- Engine Bank 1 And Bank 2 A/F And O2 Identification (L-SB-0188-09)
- Cylinder Head Cover Baffle Precautions (L-SB-0021-08)
- Engine Vibration (EG013-04)
- Sulfur Odor From Exhaust (EG001-03)
Mirrors
- Inner Rear View Mirror Vibration (NV003-04)
Paint & Coatings
- Iron Particle Rust Contamination Repair (L-SB-0020-24)
- New Vehicle Washing Schedule For Paint Protection (L-SB-0024-24)
- Prevention And Repair Of Acid Rain Damage (L-SB-0022-24)
- Permanent-Type Protective Wax Coatings (L-SB-0083-08)
- Paint Stains Under RAPGARD™ (PA001-03 REV.)
- Iron Particle Rust Contamination Repair (PA001-05)
- 2003 My LEXUS Colors - Crib # 131 (L-CRIB-131)
- 2003 Paint Colors (PA002-02)
Parking Brake System
- Brake Pedal Force Gauge SST For Parking Brake Inspection (L-SB-0010-13)
Passive Restraints
- SRS Component Disposal As Hazardous Material Treatment (L-SB-0126-17)
- Seat Belt Extender (BO009-04)
- Seat Belt Extender (BO012-03)
- Seat Belt Extender (BO005-02)
Procedures
- Welding Specifications & Substitutions - Crib # 181 (S-CRIB-181)
- Battery Maintenance For In-Stock Vehicles & Pre-Delivery (PG009-02)
Restraints Control Systems
- SRS Precautions - Crib # 160 (T-CRIB-160)
- TECHSTREAM Ecu Flash Reprogramming Procedure (SS002-07)
Seats
- Seat Cover Replacement For Side Airbag Equipped Vehicles (BO012-05)
- Seat Belt Extender (BO012-03)
- Seat Belt Extender (BO005-02)
Starter
- Absorbed Glass Mat (AGM) Battery Information (SS006-07)
Steering Column
- Audio Steering Wheel Control Abnormal Operation (L-SB-0034-08)
Steering Control Systems
- TECHSTREAM Ecu Flash Reprogramming Procedure (SS002-07)
Sun Roof/T-Top/Convertible Top
- Rear Glass Frame Improvement (NV005-03)
Suspension Control Systems
- TECHSTREAM Ecu Flash Reprogramming Procedure (SS002-07)
- Diagnostic Tester Controller Area Network (Can) Interface Module (SS001-03)
System
- Accelerator Pedal Sensor Assembly Service Precaution (L-SB-0059-12)
- O2S Test Results (Mode 05) (SS002-03)
- Ecu Flash Reprogramming Process (SS001-01)
- Diagnostic Tester Controller Area Network (Can) Interface Module (SS001-03)
- Sulfur Odor From Exhaust (EG001-03)
Transmission Control Systems
- Interior Electrical Component Precautions (L-SB-0066-11 REV2)
- TECHSTREAM Ecu Flash Reprogramming Procedure (SS002-07)
- A650E Transmission Solenoid Identification (TC004-05)
- ECM Reset Memory Function (TC002-03)
- Ecu Flash Reprogramming Process (SS001-01)
- Diagnostic Tester Controller Area Network (Can) Interface Module (SS001-03)
Warning Systems
- Accelerator Pedal Sensor Assembly Service Precaution (L-SB-0059-12)
Wheel Alignment
- Vehicle Pull, Steering Wheel Off Center, And Alignment Best Practices (L-SB-0023-20)
- Disconnect Battery & Perform Zero Point Calibration After Wheel Alignment Adjustment (L-SB-0015-08)
Wheels & Tire System
- Tire Inflation Pressure Compensation And Adjustment (L-SB-0154-08 REV2)
- Repair Evaluation Criteria On Run Flat Tires (PG006-02)
Window Motors & Regulators
- Interior Electrical Component Precautions (L-SB-0066-11 REV2)
- Upper/Lower Windshield Tick Noise (NV005-06)
Wiper/Washer Systems
- Windshield Wiper Blade Maintenance And Cleaning (BO004-05)
- Wiper Blade Maintenance And Cleaning (L-SB-0092-13)
Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)
- Interior Electrical Component Precautions (L-SB-0066-11 REV2)