Specifications Index
CATERA SPECIFICATIONS INDEX
| System | Specification/Procedure | ||
|---|---|---|---|
| Air Conditioning | |||
| Service | SPECIFICATIONS | ||
| Torque | TORQUE SPECIFICATIONS | ||
| Battery | BATTERY USAGE | ||
| Brakes | |||
| Bleeding Sequence | RR/LR/RF/LF See MANUAL BLEEDING | ||
| Disc Brakes | DISC BRAKE SPECIFICATIONS | ||
| Torque | TORQUE SPECIFICATIONS | ||
| Charging | |||
| Generator | APPLICATION & SPECIFICATIONS | ||
| Torque | TORQUE SPECIFICATIONS | ||
| Drive Belts | |||
| Adjustment | BELT ADJUSTMENT | ||
| Belt Routing | See appropriate illustration under SERPENTINE BELT ROUTING & ALIGNMENT | ||
| Engine Cooling | |||
| General Service Specifications | COOLING SYSTEM SPECIFICATIONS | ||
| Radiator Cap Pressure | 15 PSI (Or specifciation on cap) | ||
| Thermostat R & I | |||
| 3.0L | THERMOSTAT | ||
| Water Pump R & I | |||
| 3.0L | WATER PUMP | ||
| Engine Mechanical | |||
| 3.0L | |||
| Compression | Lowest compression reading should not be less than 70 percent of highest compression reading. No cylinder compression reading should be less than 100 psi (7.0 kg/cm2 ). | ||
| Oil Pressure | With engine at normal operating temperature, oil pressure at idle should be approximately 21.7 psi. (1.525 kg/cm2 ). | ||
| Overhaul | ENGINE SPECIFICATIONS | ||
| Torque | TORQUE SPECIFICATIONS | ||
| Fluid Specifications | See FLUIDS under MAINTENANCE tab. From within Manager or Service Writer, click the "30/60/90 Interval" or "Maint." button. | ||
| Flywheel/Flex Plate Torque | |||
| Step 1 | 48 Ft. Lbs. (65 N.m) | ||
| Step 2 | Additional 30 Degrees | ||
| Step 3 | Additional 15 Degrees | ||
| Fuel System | |||
| Pressure Specification (KOEO) | 40-46 psi (2.8-3.2) (kg/cm2 | ||
| Fuel Pressure Test Procedure | FUEL SYSTEM PRESSURE TEST (EXCEPT SATURN) | ||
| Fuel Filter Location & R & I | A metal in-line filter is used in the fuel feed line near the fuel tank. | ||
| Ignition | |||
| Firing Order & Cylinder Identification | See FIRING ORDER & CYLINDER IDENTIFICATION | ||
| Ignition Wires (Resistance) | Coil On Plug | ||
| Ignition Wires (Routing) | Coil On Plug | ||
| Spark Plug Bosch FLR9LTE | |||
| 3.0L | |||
| Gap | .035-.043 in. (.9-1.1 mm) | ||
| Torque | 19 Ft. Lbs. (25 N.m) | ||
| Starting | |||
| Starter | Bosch Specifications Not Available | ||
| Torque | TORQUE SPECIFICATIONS | ||
| Wheel Alignment | |||
| Adjustment Specifications | WHEEL ALIGNMENT SPECIFICATIONS | ||
| Torque | TORQUE SPECIFICATIONS | ||
| Wheel & Tire | |||
| Wheel Lug Nut Torque | 80 Ft. Lbs. (108 N.m) | ||