Specifications Index
DEVILLE SPECIFICATIONS INDEX
| System | Specification/Procedure | |
|---|---|---|
| Air Conditioning | ||
| Service | SPECIFICATIONS | |
| Torque | TORQUE SPECIFICATIONS | |
| Axle Nut/Hub Nut | ||
| Front | 159 Ft. Lbs. (216 N.m) | |
| Battery | BATTERY USAGE | |
| Brakes | ||
| Bleeding Sequence | RR/LR/RF/LF. See BLEEDING BRAKE SYSTEM | |
| Disc Brakes | DISC BRAKE SPECIFICATIONS | |
| Torque | TORQUE SPECIFICATIONS | |
| Charging | ||
| Generator | ON-VEHICLE TESTING | |
| Torque | TORQUE SPECIFICATIONS | |
| Drive Belts | ||
| Adjustment | BELT ADJUSTMENT | |
| Belt Routing | See appropriate illustration under SERPENTINE BELT ROUTING & ALIGNMENT | |
| Engine Cooling | ||
| Service | COOLING SYSTEM SPECIFICATIONS | |
| Radiator Pressure Cap | 15 psi (Or specification on cap.) | |
| Thermostat R&I | NA | |
| Water Pump R&I | WATER PUMP | |
| Engine Mechanical | ||
| Compression | Lowest compression reading should not be less than 70 percent of highest compression reading. No cylinder compression reading should be less than 140 psi (9.8 kg/cm2 ). | |
| Oil Pressure | Minimum oil pressure is 5 psi (.4 kg/cm2 ) at idle, and 35 psi (2.5 kg/cm2 ) at 2000 RPM. | |
| Overhaul | ENGINE SPECIFICATIONS | |
| Torque | TORQUE SPECIFICATIONS | |
| Fluid Specifications | See FLUIDS under MAINTENANCE tab. From within Manager or Service Writer, click the "30/60/90 Interval" or "Maint." button. | |
| Flywheel/Flex Plate Torque | ||
| Step 1 | 11 Ft. Lbs. (15 N.m) | |
| Step 2 | Additional 50 Degrees | |
| Fuel System | ||
| Pressure (Key On Engine Off) | 41-47 psi (2.9-3.3 (kg/cm2 ) | |
| Testing Procedure | FUEL SYSTEM PRESSURE TEST (EXCEPT SATURN) | |
| Fuel Filter Location and R & I | REMOVAL PROCEDURE (DEVILLE) | |
| Ignition | ||
| Firing Order & Cylinder Identification | See FIRING ORDER & CYLINDER IDENTIFICATION | |
| Ignition Wires (Resistance) | Replace wire if resistance exceeds 600 ohms per ft. | |
| Ignition Wires (Routing) | See appropriate illustration under FIRING ORDER | |
| Spark Plugs Type | GM Part No. 12561466 | |
| Spark Plug Gap | .050 in. (1.27 mm) | |
| Spark Plug Torque | 15 Ft. Lbs. (20 N.m) | |
| Starting | ||
| Starter | ON-VEHICLE TESTING | |
| Torque | TORQUE SPECIFICATIONS | |
| Wheel Alignment | ||
| Adjustment | WHEEL ALIGNMENT SPECIFICATIONS | |
| Torque | TORQUE SPECIFICATIONS | |
| Wheel & Tire | ||
| Lug Nut Torque | 100 Ft. Lbs. (136 N.m) | |