Common Specs & Procedures Index
ELR COMMON SPECS & PROCEDURES
| System | Specification/Procedure | ||
|---|---|---|---|
| Air Conditioning | |||
| Service | APPROXIMATE FLUID CAPACITIES | ||
| Torque | FASTENER SPECIFICATIONS | ||
| Axle Nut/Hub Nut | |||
| Tighten | First Pass 150 N.m (111 lb. ft.) Second Pass Release 45 degrees Final Pass 250 N.m (184 lb ft) |
||
| Battery | NA | ||
| Brakes | |||
| Bleeding Sequence | RIGHT REAR, LEFT REAR, RIGHT FRONT, LEFT FRONT HYDRAULIC BRAKE SYSTEM BLEEDING |
||
| Disc Brakes | |||
| Service Specifications | DISC BRAKE COMPONENT SPECIFICATIONS | ||
| Torque | FASTENER SPECIFICATIONS | ||
| Engine Cooling | |||
| General Service Specifications | N/A | ||
| Radiator Cap Pressure | Pressure Stamped On Cap | ||
| Thermostat R & I | |||
| 1.4L | ENGINE COOLANT THERMOSTAT HOUSING REMOVAL | ||
| Water Pump R & I | |||
| 1.4L | WATER PUMP REPLACEMENT | ||
| Engine Mechanical | |||
| 1.4L | |||
| Compression | ENGINE COMPRESSION TEST | ||
| Oil Pressure | 1.6L Minimum - @ Idle Speed - 150 kPa (22 psi) @ 3000-3500 rpm - 380-650 kpa (55-94 psi) |
||
| Overhaul | 1.4L ENGINE MECHANICAL SPECIFICATIONS | ||
| Torque | 1.4L FASTENER SPECIFICATIONS | ||
| Fluid Specifications | See FLUIDS under MAINTENANCE/FLUIDS tab. From within Manager or Service Writer, click the "30/60/90 Interval" or "Maint." button. | ||
| Flywheel/Flex Plate/Drive Plate Torque | First Pass - 35 N.m (26 lb ft) Second Pass - 30 degrees Final Pass - additional 15 degrees |
||
| Fuel System | |||
| Pressure Specification - 1.4L | Ignition ON, Engine OFF - 379-427 kPa (55-62 psi) | ||
| Fuel Pressure Test Procedure | CIRCUIT/SYSTEM VERIFICATION | ||
| Fuel Filter Location - 1.4L | Fuel Filter is Part of the Fuel Tank Fuel Pump Module | ||
| Fuel Filter Location - 1.4L | Fuel Filter is Part of the Fuel Tank Fuel Pump Module | ||
| Fuel Filter R & I | FUEL TANK FUEL PUMP MODULE REPLACEMENT | ||
| Ignition | |||
| Firing Order & Cylinder Identification | FIRING ORDER & CYLINDER IDENTIFICATION | ||
| Ignition Wires (Resistance) | Coil On Plug | ||
| Ignition Wires (Routing) | |||
| 1.4L | Coil On Plug | ||
| Spark Plug | |||
| 1.4L See Parts Catalog for Application | |||
| Gap | 0.7 mm (0.028 in) | ||
| Torque | 25 N.m (18 lb ft) | ||
| Starting | |||
| Wheel Alignment | |||
| Adjustment Specifications | WHEEL ALIGNMENT SPECIFICATIONS | ||
| Torque | FASTENER SPECIFICATIONS | ||
| Wheel & Tire | |||
| Wheel Lug Nut Torque | 140 N.m (103 lb ft) For Tightening Sequence, Please see the Figure Under INSTALLATION PROCEDURE |
||