Fastener Specifications
Single Use Non-Threaded Fasteners/Components
|
NOTE:
All fasteners/components listed in this table MUST BE DISCARDED and replaced with NEW after removal. |
|---|
| Application |
| Fuel Injector O-Ring Seal |
| Fuel Injector Seal Ring |
| Fuel Injector Spacer |
| Fuel Pump Gasket |
| Fuel Sender Assembly Seal |
| Fuel Tank Module Seal |
| Manifold Absolute Pressure Sensor Seal Ring |
Single Use Threaded Fastener/Component Tightening Specifications
|
NOTE:
All fasteners/components listed in this table MUST BE DISCARDED and replaced with NEW after removal. |
|
|---|---|
| Application | Specification |
| Metric (English) | |
| Fuel Feed Intermediate Pipe | |
|
15 N.m (11 lb ft) |
|
30 N.m (22 lb ft) |
| Fuel Feed Pipe Fitting | |
|
15 N.m (11 lb ft) |
|
30 N.m (22 lb ft) |
Reusable Threaded Fastener Tightening Specifications
|
NOTE:
All fasteners listed in this table can be reused after removal. |
|
|---|---|
| Application | Specification |
| Metric (English) | |
| Accelerator Pedal Position Sensor Fastener | 9 N.m (80 lb in) |
| Air Cleaner Assembly Fastener | 2.3 N.m (20 lb in) |
| Air Cleaner Outlet Duct Clamp | 4 N.m (35 lb in) |
| Camshaft Position Actuator Solenoid Valve Fastener | 10 N.m (89 lb in) |
| Camshaft Position Sensor Fastener | 10 N.m (89 lb in) |
| Charge Air Cooler Inlet Air Tube Bolt | 10 N.m (89 lb in) |
| Charge Air Cooler Radiator Bolt | 10 N.m (89 lb in) |
| Chassis Control Module Fastener | 7 N.m (62 lb in) |
| Crankshaft Position Sensor Fastener | 10 N.m (89 lb in) |
| Engine Control Module Bracket Bolt | 4.5 N.m (40 lb in) |
| Engine Control Module Bracket Nut | 4.5 N.m (40 lb in) |
| Engine Oil Pressure Sensor | 35 N.m (26 lb ft) |
| Fuel Feed Pipe Bracket Fastener | 10 N.m (89 lb in) |
| Fuel Injection Fuel Rail Fuel Pressure Sensor | 33 N.m (24 lb ft) |
| Fuel Pump Cover Fastener | 10 N.m (89 lb in) |
| Fuel Pump Fastener | |
|
8 N.m (71 lb in) |
|
50 degrees |
| Fuel Rail Bolt | 25 N.m (18 lb ft) |
| Fuel Tank Filler Pipe Bolt | 2.5 N.m (22 lb in) |
| Fuel Tank Filler Pipe Ground Bolt | 9 N.m (80 lb in) |
| Fuel Tank Strap Bolt-Front | 22 N.m (16 lb ft) |
| Fuel Tank Strap Bolt-Rear | 27 N.m (20 lb ft) |
| Heated Oxygen Sensor | 42 N.m (31 lb ft) |
| Ignition Coil Fastener | 10 N.m (89 lb in) |
| Knock Sensor Fastener | 25 N.m (18 lb ft) |
| Manifold Absolute Pressure Sensor Bolt | 5 N.m (44 lb in) |
| Oil Pump Flow Control Valve Electrical Wiring Harness Connector Bracket Fastener | 9 N.m (80 lb in) |
| Oil Pump Flow Control Valve Fastener | 10 N.m (89 lb in) |
| Oil Pump Flow Control Valve Heat Shield Fastener | 9 N.m (80 lb in) |
| Spark Plug | 20 N.m (15 lb ft) |
| Throttle Body Assembly Fastener | 10 N.m (89 lb in) |
| Turbocharger Bypass Valve Solenoid Fastener | 7.8 N.m (69 lb in) |
| Turbocharger Wastegate Actuator Fastener | 20 N.m (15 lb ft) |
| Turbocharger Wastegate Regulator Solenoid Valve Fastener | 7.8 N.m (69 lb in) |
| Vacuum Pump Fastener | 10 N.m (89 lb in) |