Section 6 (Engine Controls - 6.5L)
WARNING: This page is about a different variant/trim than selected.
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Engine Controls
- Diagnostic System Check - Engine Controls
- Scan Tool Data List
- Scan Tool Data Definitions
- Diagnostic Trouble Code (DTC) List
- DTC P0112
- DTC P0113
- DTC P0117
- DTC P0118
- DTC P0121
- DTC P0122
- DTC P0123
- DTC P0126
- DTC P0182
- DTC P0183
- DTC P0215
- DTC P0216
- DTC P0219
- DTC P0220
- DTC P0221
- DTC P0222
- DTC P0223
- DTC P0225
- DTC P0226
- DTC P0227
- DTC P0228
- DTC P0231
- DTC P0236
- DTC P0237
- DTC P0238
- DTC P0251
- DTC P0263, P0266, P0269, P0272, P0275, P0278, P0281, or P0284
- DTC P0300
- DTC P0301, P302, P303, P304, P305, P306, P307, P0308
- DTC P0335
- DTC P0370
- DTC P0380 (Federal & CALIFORNAIA)
- DTC P0601, P0602, P0603, P0604, P0605, P0606, P0607, P1600, P1621, P1627, P1680, P1681, or P1683
- DTC P1125
- DTC P1214
- DTC P1216
- DTC P1217
- DTC P1218
- DTC P1627
- DTC P1635
- DTC P1641
- DTC P1643
- DTC P1654
- DTC P1656
- Symptoms - Engine Controls
- Intermittent Conditions
- Hard Start
- Surges/Chuggles
- Lack of Power, Sluggishness, or Sponginess
- Fuel Knock/Combustion Noise
- Hesitation, Sag, Stumble
- Cuts Out, Misses
- Poor Fuel Economy
- Excessive Smoke
- Malfunction Indicator Lamp (MIL) Inoperative
- Malfunction Indicator Lamp (MIL) Always On
- Water-in-Fuel Lamp Inoperative
- Water-in-Fuel Lamp Always On
- Engine Cranks but Does Not Run
- Fuel Pump Electrical Circuit Diagnosis
- Fuel System Diagnosis
- Fuel Tank Leak Test
- Fuel Injection Nozzle Diagnosis
- Fuel Specific Gravity Testing
- Contaminants-in-Fuel Diagnosis
- Fuel Heater Inoperative
- Glow Plug System Diagnosis
- Repair Instructions
- Powertrain Control Module (PCM) Replacement
- Powertrain Control Module (PCM) Programming
- Glow Plug System Relearn Procedure
- Engine Coolant Temperature (ECT) Sensor Replacement
- Intake Air Temperature (IAT) Sensor Replacement
- Boost Sensor Replacement
- Accelerator Pedal Position (APP) Sensor Replacement
- Quick Connect Fitting(s) Service (Metal Collar)
- Quick Connect Fitting(s) Service (Plastic Collar)
- Fuel Filter Replacement
- Fuel Heater Element Replacement
- Water-in-Fuel Sensor Replacement
- Water-in-Fuel Draining Procedure
- Fuel Filter/Heater Element Housing Replacement
- Fuel Tank Draining Procedure
- Fuel Tank Inspection
- Fuel Tank Replacement (Extended Cab Side Tank)
- Fuel Tank Replacement (Pickup Side Tank)
- Fuel Tank Replacement (Cab and Chassis Rear Tank)
- Fuel Tank Replacement (Cab and Chassis Side Tank)
- Fuel Pump Replacement
- Fuel Balance Pump Replacement
- Fuel Sender Assembly Replacement
- Fuel System Cleaning
- Fuel Feed and Fuel Return Pipe Purge Procedure
- Fuel Solenoid Driver Replacement
- Engine Shutdown Solenoid Replacement
- Fuel Injection Line(s) Replacement
- Fuel Injection Pump Replacement
- Fuel Injection Pump TDC Offset Adjustment
- Fuel Injection Pump Timing Adjustment
- Fuel Injector Replacement
- Glow Plug Replacement - Bank 1
- Glow Plug Replacement - Bank 2
- Glow Plug Relay Replacement (Federal)
- Glow Plug Relay Replacement (California)
- Crankshaft Position (CKP) Sensor Replacement
- Wastegate Solenoid Replacement
- Air Cleaner Element Replacement
- Air Cleaner Assembly Replacement
- Description and Operation
- Special Tools and Equipment