October 30: LEMON manuals on a temporary server, it is slow and having issues, download the manuals you need! Later in November we will switch back to the fast server.
2.2L/2.5L SPFI Tests/Code Expand All (for easy ctrl-f) Collapse All Description Operation Removal & Installation Testing & Diagnosis Diagnostic Trouble Code (DTC) Identification No Start Tests NS-1, Checking Spark & Fuel At Throttle Body NS-2, Checking Injector Flow & Fuel Control Faults NS-3, Checking SMEC, Wet Plugs & Timing NS-4, Checking IGN. Coil Driver, Open Circuits & SMEC NS-5, Checking Coil Primary & Coil NS-6, Checking Fuel Pressure, TPS & Circuits NS-7, Checking Injector Driver Circuits & Injectors NS-8, Checking INJ. Interface Fault & Control Circuit NS-9, Flooding Injector Check, CTRL. CKT. & Press. Regulator NS-10, Checking System Faults NS-11, SYS. Power, Ground, Map, SMEC & Distributor Pick-Up Check NS-12, Checking Distributor Pick-Up & Circuits NS-13, Checking ASD Relay & Pull In Coil Circuits NS-14, Power CKT. To Pull In Coil & ASD Relay Check NS-15, Power Feed CKTS. To ASD Relay & Relay Check NS-VER, Verification Of No Start DRIVEABILITY Tests Dr-1, Checking System For Faults Dr-2, Checking Output Circuits Of SMEC Dr-3, Intermittent Test For Solenoids & Relays Dr-4, Intermittent Test For Map Sensor Signal Dr-5, Intermittent Test For Sensor Voltages Dr-6, Intermittent Test For Injectors & AIS Motor Dr-7, Checking For Fault Message "Map Pneumatic Signal" Dr-8, Checking For Fault Message "Map Pneumatic Change" Dr-9, Checking For Fault Message "Map Voltage Low" Dr-10, Checking For Fault Message "Map Voltage Too High" Dr-11, Checking For Fault Message "Vehicle Speed Signal" Dr-12, Checking For Fault Message "Oxygen Sensor Signal" Dr-13, Checking For Fault Message "Coolant Voltage Low" Dr-14, Checking For Fault Message "Coolant Voltage High" Dr-15, Checking For Fault Message "T/B Temp. Voltage Low" Dr-16, Checking For Fault Message "T/B Temp. Voltage High" Dr-17, Checking For Fault Message "TPS Voltage Low" Dr-18, Checking For Fault Message "TPS Voltage High" Dr-19, For Fault Message "AIS Motor Circuits" Check Dr-20, Checking For Fault Message "Purge Solenoid Circuits" Dr-21, Checking For Fault Message "EGR Solenoid Circuit Dr-22, Fault Message "EGR System Failure" Check Dr-23, Checking For Fault Message "A/C Clutch Relay Circuit" Dr-24, Checking Radiator & A/C Fan Relays Dr-25, Checking For Fault Message "Radiator Fan Relay" Dr-26, Checking For Fault Message "PTU Solenoid Circuit" Dr-27, Checking For Fault Message "FJ2 Voltage Sense" Dr-28, Fault Message "EMR Mileage ACCUM & Ee Prom Write Denied" Check Dr-29, Checking Sensor Calibrations With Engine Cold Dr-30, Sensor Calibrations With Engine Warm (1 Of 3) Check Dr-31, EGR Valve With Engine Warm Check Dr-32, Checking Secondary Ignition System Dr-33, Checking Basic Timing & Fuel System Dr-34, Checking Oxygen Sensor Dr-35, Checking Throttle Body Minimum Airflow Dr-36 - Other Possible Causes Of DRIVEABILITY Related Problems DRIVEABILITY Verification Tests Speed Control System Tests Charging System Tests Wiring Diagrams