Repair and Diagnosis (Single Page)
You are viewing the full "tree" of links on one page. This can load slowly, but is easier to search. The same page can appear multiple times under a different folder, that is why the page is so large.View "split tree" where inner folders are split out. where inner links are on separate pages.
Quick Lookups
Common Specs & Procedures
DTC Index
Electrical Component Locations
Fluids
Technical Bulletins
Tire Fitment
Wiring Diagrams- Connector End Views
- Connector Pin-Outs
- A/C Compressor Clutch (Diesel) Connector End View
- A/C Compressor Clutch (Gas) Connector End View
- A/C High Pressure Switch (Diesel) Connector End View
- A/C Low Pressure Switch Connector End View
- A/C Pressure Transducer Connector End View
- A/C Heater Control Switch Connector End View
- Accelerator Pedal Position Sensor (1.6L/Diesel) Connector End View
- Airbag Control Module (Occupant Restraint Control) (Base) Connector End View
- Airbag Control Module (Occupant Restraint Control) (Premium) Connector End View (C1)
- Airbag Control Module (Occupant Restraint Control) (Premium) Connector End View (C2)
- Ambient Temperature Sensor (Except 2.4L Base) Connector End View
- Ambient Temperature Sensor (NGC) Connector End View
- Audio Amplifier Connector End View (C1)
- Audio Amplifier Connector End View (C2)
- Antilock Brakes Module Connector End View
- Autostick Switch Connector End View
- Backup Lamp Switch (M/T Diesel) Connector End View
- Backup Lamp Switch (M/T Gas) Connector End View
- Battery Temperature Sensor (Diesel) Connector End View
- Blower Motor Connector End View
- Blower Motor Resistor Block Connector End View
- Boost Pressure Sensor (Diesel) Connector End View
- Brake Lamp Switch (Diesel) Connector End View
- Brake Lamp Switch (Gas) Connector End View
- Brake Transmission Shift Interlock Solenoid (EATX) Connector End View
- Brake Warning Indicator Switch Connector End View
- Engine Side Inline (2.4L) Connector End View (C102)
- Headlamp And Dash Side Inline (2.4L) Connector End View (C102)
- Engine Side Inline (2.4L Except Turbo) Connector End View (C103)
- Injector Harness Side Inline (2.4L Except Turbo) Connector End View (C103)
- Engine Side Inline (2.4L Turbo) Connector End View (C103)
- Injector Harness Side Inline (2.4L Turbo) Connector End View (C103)
- Inline (Headlamp And Dash Side) Connector End View (C105)
- Inline (Instrument Panel Side) Connector End View (C105)
- Inline (Headlamp And Dash Side) Connector End View (C106)
- Inline (Instrument Panel Side) Connector End View (C106)
- Headlamp And Dash Side Inline (Export) Connector End View (C107)
- Headlamp Leveling Side Inline (Export) Connector End View (C107)
- Headlamp And Dash Side Inline (Export) Connector End View (C108)
- Headlamp Leveling Side Inline (Export) Connector End View (C108)
- Headlamp And Dash Side Inline Connector End View (C110)
- Underbody Side Inline Connector End View (C110)
- Headlamp And Dash Side Inline (Except Antilock Brake System) Connector End View (C110)
- Underbody Side Inline (Except Antilock Brake System) Connector End View (C110)
- Engine Side Inline (1.6L) Connector End View (C111)
- Headlamp And Dash Side Inline (1.6L) Connector End View (C111)
- Engine Side Inline (1.6L) Connector End View (C112)
- Headlamp And Dash Side Inline (1.6L) Connector End View (C112)
- Engine Side Inline (1.6L) Connector End View (C114)
- Headlamp And Dash Side Inline (1.6L) Connector End View (C114)
- Engine Side Inline (Diesel) Connector End View (C121)
- Headlamp And Dash Side Inline (Diesel) Connector End View (C121)
- Engine Side Inline (Diesel) Connector End View (C122)
- Headlamp And Dash Side Inline (Diesel) Connector End View (C122)
- Engine Side Inline (Diesel) Connector End View (C124)
- Headlamp And Dash Side Inline (Diesel) Connector End View (C124)
- Headlamp And Dash Side Inline (Diesel) Connector End View (C125)
- Engine Side Inline (Diesel) Connector End View (C125)
- Cabin Heater Side Inline (Diesel) Connector End View (C126)
- Headlamp And Dash Side Inline (Diesel) Connector End View (C126)
- Battery Side Inline (Diesel) Connector End View (C127)
- Headlamp And Dash Side Inline (Diesel) Connector End View (C127)
- Headlamp And Dash Side Inline (Diesel) Connector End View (C128)
- Junction Post Side Inline (Diesel) Connector End View (C128)
- Instrument Panel Side Inline (Except Hands Free) Connector End View (C200)
- Left Headliner Jumper Side Inline (Except Hands Free) Connector End View (C200)
- Instrument Panel Side Inline (Hands Free) Connector End View (C200)
- Left Headliner Jumper Side Inline (Hands Free) Connector End View (C200)
- Instrument Panel Side Inline (Except Hands Free) Connector End View (C201)
- Right Headliner Jumper Side Inline (Except Hands Free) Connector End View (C201)
- Instrument Panel Side Inline (Hands Free) Connector End View (C201)
- Right Headliner Jumper Side Inline (Hands Free) Connector End View (C201)
- Instrument Panel Side Inline (LHD) Connector End View (C202)
- Left Body Side Inline (LHD) Connector End View (C202)
- Instrument Panel Side Inline (RHD) Connector End View (C202)
- Left Body Side Inline (RHD) Connector End View (C202)
- Body Side Inline (Convertible) Connector End View (C203)
- Instrument Panel Side Inline (Convertible) Connector End View (C203)
- Instrument Panel Side Inline (Hatchback) Connector End View (C203)
- Right Body Side Inline (Hatchback) Connector End View (C203)
- Instrument Panel Side Inline (Convertible) Connector End View (C204)
- Left Front Door Side Inline (Convertible) Connector End View (C204)
- Instrument Panel Side Inline (Hatchback RHD) Connector End View (C204)
- Left Front Door Side Inline (Hatchback RHD) Connector End View (C204)
- Instrument Panel Side Inline (Hatchback LHD) Connector End View (C204)
- Left Front Door Side Inline (Hatchback LHD) Connector End View (C204)
- Instrument Panel Side Inline (Hatchback LHD) Connector End View (C205)
- Right Front Door Side Inline (Hatchback LHD) Connector End View (C205)
- Instrument Panel Side Inline (Convertible) Connector End View (C205)
- Right Front Door Side Inline (Convertible) Connector End View (C205)
- Instrument Panel Side Inline (Hatchback RHD) Connector End View (C205)
- Right Front Door Side Inline (Hatchback RHD) Connector End View (C205)
- Dome Lamp Side Inline (Except Hands Free) Connector End View (C207)
- Right Headliner Jumper Side Inline (Except Hands Free) Connector End View (C207)
- Dome Lamp Side Inline (Hands Free) Connector End View (C207)
- Right Headliner Jumper Side Inline (Hands Free) Connector End View (C207)
- Dome Lamp Side Inline (Except Hands Free) Connector End View (C208)
- Left Headliner Jumper Side Inline (Except Hands Free) Connector End View (C208)
- Dome Lamp Side Inline (Hands Free) Connector End View (C208)
- Left Headliner Jumper Side Inline (Hands Free) Connector End View (C208)
- Inline (Heater Jumper Side) Connector End View (C209)
- Inline (Instrument Panel Side) Connector End View (C209)
- Dome Lamp Side Inline (Power Sunroof) Connector End View (C211)
- Sunroof Side Inline (Power Sunroof) Connector End View (C211)
- Unibody Side Inline (Satellite Radio) Connector End View (C212)
- Instrument Panel Side Inline (Satellite Radio) Connector End View (C212)
- Inline (Left Body Side) Connector End View (C300)
- Inline (Left Rear Door Side) Connector End View (C300)
- Inline (Right Body Side) Connector End View (C301)
- Inline (Right Rear Door Side) Connector End View (C301)
- Left Body Side Inline (Hatchback) Connector End View (C302)
- Liftgate Side Inline (Hatchback) Connector End View (C302)
- Inline (Left Body Side) Connector End View (C303)
- Inline (Rear Fascia Side) Connector End View (C303)
- Inline (Fuel Tank Side) Connector End View (C304)
- Underbody Side Inline Connector End View (C304)
- Airbag Side Inline Connector End View (C305)
- Unibody Side Inline Connector End View (C305)
- Airbag Side Inline Connector End View (C306)
- Unibody Side Inline Connector End View (C306)
- Inline (Passenger Seat Side) Connector End View (C307)
- Unibody Side Inline Connector End View (C307)
- Driver Seat Side Inline Connector End View (C308)
- Unibody Side Inline Connector End View (C308)
- Decklid Jumper Side Inline (Convertible) Connector End View (C343)
- Decklid Side Inline (Convertible) Connector End View (C343)
- Body Side Inline (Convertible) Connector End View (C349)
- Decklid Jumper Side Inline (Convertible) Connector End View (C349)
- Body Side Inline (Convertible) Connector End View (C362)
- Power Top Side Inline (Convertible) Connector End View (C362)
- Camshaft Position Sensor (Diesel) Connector End View
- Camshaft Position Sensor (Gas) Connector End View
- Cargo Lamp Connector End View
- Center High Mounted Stop Lamp (Convertible) Connector End View
- Center High Mounted Stop Lamp (Hatchback) Connector End View
- Center Stack Lamp Connector End View
- Cigar Lighter Connector End View
- Clockspring Connector End View
- Clutch Pedal Position Up Switch Connector End View
- Compass/Temperature Mirror Module (Convertible) Connector End View
- Crankshaft Position Sensor (Diesel) Connector End View
- Crankshaft Position Sensor (Gas) Connector End View
- Data Link Connector, Connector End View
- Decklid Cylinder Unlock Switch (Vehicle Theft Security System) (Convertible) Connector End View
- Decklid Handle Switch (Convertible) Connector End View
- Decklid Release Motor (Convertible) Connector End View
- Decklid Release Switch (Convertible) Connector End View
- Dome Lamp Connector End View
- Dome Lamp Intrusion Sensor (Export) Connector End View
- Driver Airbag Squib 1 Connector End View
- Driver Door Ajar Switch Connector End View
- Driver Door Handle Switch (Convertible) Connector End View
- Driver Door Power Lock Motor Ajar Switch Connector End View
- Driver Heated Seat Cushion Connector End View
- Driver Heated Seat Switch Connector End View
- Driver Rear Window Motor (Convertible) Connector End View
- Driver Seat Belt Switch Connector End View
- Driver Seat Belt Tensioner Connector End View
- Driver Window Regulator Module (Convertible) Connector End View
- EGR Solenoid (Diesel) Connector End View
- Electronic Throttle Control Module (1.6L) Connector End View
- Engine Control Module (Diesel) Connector End View (C1)
- Engine Control Module (Diesel) Connector End View (C2)
- Engine Coolant Temperature Sensor (Diesel) Connector End View
- Engine Coolant Temperature Sensor (Gas) Connector End View
- Engine Oil Pressure Switch Connector End View
- EVAP Purge Solenoid (Gas) Connector End View
- Front Power Window Switch Connector End View
- Front Washer Pump Motor Connector End View
- Front Wiper Motor Connector End View
- Front Wiper Switch/Washer Switch Connector End View
- Fuel Heater Module (Diesel) Connector End View
- Fuel Injector 1 (Diesel) Connector End View
- Fuel Injector 1 (Gas) Connector End View
- Fuel Injector 2 (Diesel) Connector End View
- Fuel Injector 2 (Gas) Connector End View
- Fuel Injector 3 (Diesel) Connector End View
- Fuel Injector 3 (Gas) Connector End View
- Fuel Injector 4 (Diesel) Connector End View
- Fuel Injector 4 (Gas) Connector End View
- Fuel Pressure Sensor (Diesel) Connector End View
- Fuel Pressure Solenoid (Diesel) Connector End View
- Fuel Pump Module Connector End View
- Generator (2.4L Turbo) Connector End View
- Generator (Diesel) Connector End View
- Generator (Gas Except 2.4L Turbo) Connector End View
- Hands Free Module Connector End View (C1)
- Hands Free Module (Satellite Radio) Connector End View (C2)
- Hands Free Module Connector End View (C3)
- Headlamp Leveling Switch (Export) Connector End View
- Heated Seat Module Connector End View
- High Note Horn (Export) Connector End View
- Hood Ajar Switch (Export) Connector End View
- Idle Air Control Motor (2.4L) Connector End View
- Ignition Coil (Gas) Connector End View
- Ignition Switch Connector End View (C1)
- Ignition Switch (Autostick) Connector End View (C2)
- Inlet Air Temperature Sensor (Gas) Connector End View
- Input Speed Sensor Connector End View
- Instrument Cluster Connector End View (C1)
- Instrument Cluster Connector End View (C2)
- Intake Air Temperature Sensor (Diesel) Connector End View
- Knock Sensor (Gas) Connector End View
- Left Backup Lamp Connector End View
- Left City Lamp (Export) Connector End View
- Left Cylinder Lock Switch Connector End View
- Left Dome Lamp (Convertible) Connector End View
- Left Door Lock Switch Connector End View
- Left Fog Lamp Connector End View
- Left Front Door Speaker Connector End View
- Left Front Park Turn Signal Lamp (Except Export) Connector End View
- Left Front Power Window Motor (Hatchback) Connector End View
- Left Front Side Marker (Export) Connector End View
- Left Front Turn Signal Lamp (Export) Connector End View
- Left Front Wheel Speed Sensor Connector End View
- Left Headlamp Leveling Module (Export) Connector End View
- Left High Beam Headlamp Connector End View
- Left Instrument Panel Speaker Connector End View
- Left License Lamp (Export) Connector End View
- Left Low Beam Headlamp Connector End View
- Left Power Mirror (Except Export) Connector End View
- Left Power Mirror (Export) Connector End View
- Left Rear Door Power Lock Motor Connector End View
- Left Rear Fog Lamp (LHD Export) Connector End View
- Left Rear Power Window Motor (Hatchback) Connector End View
- Left Rear Power Window Switch Connector End View
- Left Rear Speaker (Convertible Base) Connector End View
- Left Rear Speaker (Hatchback) Connector End View
- Left Rear Speaker (Convertible Premium) Connector End View (C1)
- Left Rear Speaker (Convertible Premium) Connector End View (C2)
- Left Rear Turn Signal Lamp Connector End View
- Left Rear Wheel Speed Sensor Connector End View
- Left Seat Airbag Squib (LHD) Connector End View
- Left Seat Airbag Squib (RHD) Connector End View
- Left Side Impact Sensor 1 Connector End View
- Left Tail Stop Lamp Connector End View
- Left Turn Signal Indicator Connector End View
- Left Visor Lamp/Vanity Lamp (Except Base) Connector End View
- License Lamp (Except Export) Connector End View
- Liftgate Ajar Switch Connector End View
- Liftgate Cylinder Lock Switch Connector End View
- Liftgate Handle Switch (Hatchback) Connector End View
- Liftgate Power Lock Motor Connector End View
- Liftgate Release Motor (Hatchback) Connector End View
- Low Note Horn Connector End View
- Manifold Absolute Pressure Sensor (Gas) Connector End View
- Map/Reading Lamps Connector End View
- Mass Air Flow Sensor (Diesel) Connector End View
- Multifunction Switch Connector End View
- Natural Vacuum Leak Detection Assembly (Except Export) Connector End View
- Output Speed Sensor Connector End View
- Overhead Console Module Connector End View
- Upstream Oxygen Sensor 1/1 (Gas) Connector End View
- Downstream Oxygen Sensor 1/2 (Gas) Connector End View
- Passenger Airbag Squib 1 Connector End View
- Passenger Door Ajar Switch Connector End View
- Passenger Door Handle Switch (Convertible) Connector End View
- Passenger Door Power Lock Motor Ajar Switch Connector End View
- Passenger Heated Seat Cushion Connector End View
- Passenger Heated Seat Switch Connector End View
- Passenger Rear Window Motor (Convertible) Connector End View
- Passenger Seat Belt Tensioner Connector End View
- Passenger Window Regulator Module (Convertible) Connector End View
- Positive Crankcase Ventilation Heater (Diesel) Connector End View
- Power Mirror Switch (LHD) Connector End View
- Power Mirror Switch (RHD) Connector End View
- Power Outlet Connector End View
- Power Seat Motor Connector End View
- Power Seat Switch Connector End View
- Power Steering Pressure Switch (Gas) Connector End View
- Power Sunroof Module Connector End View (C1)
- Power Sunroof Module Connector End View (C2)
- Power Top Motor (Convertible) Connector End View
- Power Top Relay (Convertible) Connector End View
- Power Top Switch (Convertible) Connector End View
- Powertrain Control Module (1.6L) Connector End View
- Powertrain Control Module (NGC) Connector End View (C1)
- Powertrain Control Module (NGC) Connector End View (C2)
- Powertrain Control Module (NGC) Connector End View (C3)
- Powertrain Control Module (NGC) Connector End View (C4)
- Radiator Fan Motor (2.4L Turbo) Connector End View
- Radiator Fan Motor (Except 2.4L Turbo) Connector End View
- Radio Connector End View (C1)
- Radio (Hands Free) Connector End View (C2)
- Radio (Satellite Radio) Connector End View (C2)
- Rear Power Outlet (Except Base) Connector End View
- Rear View Mirror Connector End View (C1)
- Rear View Mirror Connector End View (C2)
- Rear Window Defogger Switch Connector End View
- Rear Wiper Motor (Hatchback) Connector End View
- Rear Wiper Switch (Hatchback) Connector End View
- Remote Keyless Entry Module Connector End View
- Right Backup Lamp Connector End View
- Right City Lamp (Export) Connector End View
- Right Cylinder Lock Switch (Export) Connector End View
- Right Dome Lamp (Convertible) Connector End View
- Right Door Lock Switch Connector End View
- Right Fog Lamp Connector End View
- Right Front Door Speaker Connector End View
- Right Front Park Turn Signal Lamp (Except Export) Connector End View
- Right Front Power Window Motor (Hatchback) Connector End View
- Right Front Side Marker (Export) Connector End View
- Right Front Turn Signal Lamp (Export) Connector End View
- Right Front Wheel Speed Sensor Connector End View
- Right Headlamp Leveling Module (Export) Connector End View
- Right High Beam Headlamp Connector End View
- Right Instrument Panel Speaker Connector End View
- Right License Lamp (Export) Connector End View
- Right Low Beam Headlamp Connector End View
- Right Power Mirror (Except Export) Connector End View
- Right Power Mirror (Export) Connector End View
- Right Rear Door Power Lock Motor Connector End View
- Right Rear Fog Lamp (RHD) Connector End View
- Right Rear Power Window Motor (Hatchback) Connector End View
- Right Rear Power Window Switch Connector End View
- Right Rear Speaker (Convertible Base) Connector End View
- Right Rear Speaker (Hatchback) Connector End View
- Right Rear Speaker (Convertible Premium) Connector End View (C1)
- Right Rear Speaker (Convertible Premium) Connector End View (C2)
- Right Rear Turn Signal Lamp Connector End View
- Right Rear Wheel Speed Sensor Connector End View
- Right Seat Airbag Squib (LHD) Connector End View
- Right Seat Airbag Squib (RHD) Connector End View
- Right Side Impact Sensor 1 Connector End View
- Right Tail Stop Lamp Connector End View
- Right Turn Signal Indicator Connector End View
- Right Visor Lamp/Vanity Lamp (Except Base) Connector End View
- Satellite Radio Receiver Connector End View
- Sentry Key Immobilizer Module Connector End View
- Siren (Export) Connector End View
- Speed Control Servo (2.4L) Connector End View
- Speed Control Switch Connector End View
- Sunroof Motor Connector End View
- Surge Solenoid (2.4L Turbo) Connector End View
- Swirl Solenoid (Diesel) Connector End View
- Throttle Inlet Pressure Sensor (2.4L Turbo) Connector End View
- Throttle Inlet Pressure Solenoid (2.4L Turbo) Connector End View
- Throttle Position Sensor (2.4L) Connector End View
- Traction Control Switch Connector End View
- Transmission Range Indicator Illumination (PRNDL) (Autostick) Connector End View
- Transmission Range Indicator Illumination (PRNDL) (Except Autostick) Connector End View
- Transmission Range Sensor (2.4L) Connector End View
- Transmission Solenoid Pressure Switch Assembly (2.4L) Connector End View
- Vehicle Speed Sensor (Diesel) Connector End View
- Vehicle Speed Sensor (Gas M/T) Connector End View
- Wastegate Solenoid (2.4L Turbo) Connector End View
- Wastegate Solenoid (Diesel) Connector End View
- Connector Pin-Outs
- System Wiring Diagrams
- Using lemon2025'S Wiring Diagrams
- Air Conditioning
- Anti-Lock Brakes
- Anti-Theft
- Computer Data Lines
- Cooling Fan
- Cruise Control
- Defoggers
- Engine Performance
- Exterior Lights
- Ground Distribution
- Headlights
- Horn
- Instrument Cluster
- Interior Lights
- Power Distribution
- Power Door Locks
- Power Mirrors
- Power Seats
- Power Top/Sunroof
- Power Windows
- Radio
- Shift Interlock
- Starting/Charging
- Supplemental Restraints
- Transmission
- Trunk, Tailgate, Fuel Door
- Warning Systems
- Wiper/Washer
- Using lemon2025'S System Wiring Diagrams
- Wiring Diagram Information
- Wiring Diagram Information
- Description
- Warnings - General
- Diagnosis And Testing - Wiring Harness
- Standard Procedure
- Standard Procedure - Electrostatic Discharge (ESD) Sensitive Devices
- Standard Procedure - Testing Of Voltage Potential
- Standard Procedure - Testing For Continuity
- Standard Procedure - Testing For A Short To Ground
- Standard Procedure - Testing For A Short To Ground On Fuses Powering Several Loads
- Standard Procedure - Testing For A Voltage Drop
- Special Tools
- Connector
- Diode
- Terminal
- Wire
- Wiring Diagram Information
- Connector End Views
- Accessories & Equipment
- Accessories Control Systems
- Anti-Theft Systems
- Body Diagnostic Procedures
- Introduction
- Identification Of System
- System Description And Functional Operation
- Notes
- Airbag System
- Audio System
- Compass/Temperature Module (CTM)
- Compass/Temperature Mirror
- Description
- Operation
- English / Metric / Off Mode
- Calibration / Zone Mode
- Setting Compass Zone
- First Time Calibration
- Manual Calibration
- Continuous Calibration
- Self-Check Diagnostic
- Outside Temperature
- Temperature Update - Warm
- Temperature Update - Cold
- Extreme Temperature / Open Or Short Condition
- Ambient Temperature Sensor
- Ambient Temperature Sensor Diagnostics
- Instrument Cluster
- Remote Keyless Entry Module
- Sentry Key Immobilizer System (Skis)
- Communication
- Telecommunications
- Window Regulator Modules (Pt27 Only)
- Using The DRBIII®
- Disclaimers, Safety, Warnings
- Required Tools And Equipment
- Glossary Of Terms
- Diagnostic Information And Procedures
- Airbag
- Symptom List: ACCELEROMETER 1; INTERNAL 1; INTERNAL 2; INTERNAL 3; INTERNAL 4' OUTPUT DRIVER 1; OUTPUT DRIVER 2; STORED ENERGY FIRING 1
- Symptom List: AIRBAG WARNING INDICATOR DRIVER; AIRBAG WARNING INDICATOR OPEN; AIRBAG WARNING INDICATOR SHORT
- Symptom: CALIBRATION MISMATCH
- Symptom: CLUSTER MESSAGE MISMATCH
- Symptom: DRIVER SEAT BELT TENSIONER CIRCUIT OPEN
- Symptom: DRIVER SEAT BELT TENSIONER CIRCUIT SHORT
- Symptom: DRIVER SEAT BELT TENSIONER SHORT TO BATTERY
- Symptom: DRIVER SEAT BELT TENSIONER SHORT TO GROUND
- Symptom: DRIVER SQUIB 1 CIRCUIT OPEN
- Symptom: DRIVER SQUIB 1 CIRCUIT SHORT
- Symptom: DRIVER SQUIB 1 SHORT TO BATTERY
- Symptom: DRIVER SQUIB 1 SHORT TO GROUND
- Symptom: LEFT CURTAIN OR SEAT SQUIB CIRCUIT OPEN
- Symptom: LEFT CURTAIN OR SEAT SQUIB CIRCUIT SHORT
- Symptom: LEFT CURTAIN OR SEAT SQUIB SHORT TO BATTERY
- Symptom: LEFT CURTAIN OR SEAT SQUIB SHORT TO GROUND
- Symptom: LEFT SIDE IMPACT SENSOR 1 INTERNAL 1
- Symptom: LOSS OF IGNITION RUN - START
- Symptom: LOSS OF IGNITION RUN ONLY
- Symptom: NO CLUSTER MESSAGE
- Symptom: NO LEFT SIDE IMPACT SENSOR 1 COMMUNICATION
- Symptom: NO ODOMETER MESSAGE
- Symptom: NO PCI TRANSMISSION
- Symptom: NO RIGHT SIDE IMPACT SENSOR 1 COMMUNICATION
- Symptom: PASSENGER SEAT BELT TENSIONER CIRCUIT OPEN
- Symptom: PASSENGER SEAT BELT TENSIONER CIRCUIT SHORT
- Symptom: PASSENGER SEAT BELT TENSIONER SHORT TO BATTERY
- Symptom: PASSENGER SEAT BELT TENSIONER SHORT TO GROUND
- Symptom: PASSENGER SQUIB 1 CIRCUIT OPEN
- Symptom: PASSENGER SQUIB 1 CIRCUIT SHORT
- Symptom: PASSENGER SQUIB 1 SHORT TO BATTERY
- Symptom: PASSENGER SQUIB 1 SHORT TO GROUND
- Symptom: POWER SUPPLY VOLTAGE LOW
- Symptom: RIGHT CURTAIN OR SEAT SQUIB CIRCUIT OPEN
- Symptom: RIGHT CURTAIN OR SEAT SQUIB CIRCUIT SHORT
- Symptom: RIGHT CURTAIN OR SEAT SQUIB SHORT TO BATTERY
- Symptom: RIGHT CURTAIN OR SEAT SQUIB SHORT TO GROUND
- Symptom: RIGHT SIDE IMPACT SENSOR INTERNAL 1
- Symptom: VEHICLE BODY STYLE MISMATCH
- Symptom: *AIRBAG INDICATOR ON WITHOUT ACTIVE TROUBLE CODES
- Audio
- Symptom: ALL OUTPUTS SHORT
- Symptom: ANTENNA HARDWARE FAILURE - SDARS
- Symptom: ANTENNA NOT CONNECTED - SDARS
- Symptom: BUS BUSY - SDARS
- Symptom: BUS LOW - SDARS
- Symptom List: CASSETTE PLAYER INOP; CD MECHANICAL FAILURE; NO PCI TRANSMISSION; *AM/FM SWITCH INOPERATIVE; *ANY STATION PRESET SWITCH INOPERATIVE; *BALANCE INOPERATIVE; *CD EJECT SWITCH INOPERATIVE; *EQUALIZER INOPERATIVE; *FADER INOPERATIVE; *FF/RW SWITCH INOPERATIVE; *HOUR/MINUTE SWITCHES INOPERATIVE; *PAUSE/PLAY SWITCH INOPERATIVE; *PWR SWITCH INOPERATIVE; *SCAN SWITCH INOPERATIVE; *SEEK SWITCH INOPERATIVE; *SET SWITCH INOPERATIVE; *TAPE EJECT SWITCH INOPERATIVE; *TIME SWITCH INOPERATIVE; *TUNE SWITCH INOPERATIVE
- Symptom: CD PLAY FAILURE
- Symptom: CD READ FAILURE
- Symptom: CD TEMPERATURE HIGH
- Symptom: GPS ANTENNA NOT CONNECTED
- Symptom: INTERNAL FAILURE - SDARS
- Symptom: INTERNAL RECEIVER FAILURE - SDARS
- Symptom: LOW VOLTAGE LEVEL
- Symptom: NO ANTENNA CONNECTION
- Symptom: NO COMMUNICATION WITH SDARS
- Symptom: NO J1850 COMMUNICATION - SDARS
- Symptom: POWER AMP SHUTDOWN
- Symptom: RADIO AND NAV GPS ANTENNA NOT CONNECTED
- Symptom: *INOP NO FAULT CODES - SDARS
- Symptom: *POOR RECEPTION - SDARS
- Communication
- Symptom: *NO RESPONSE FROM AIRBAG CONTROL MODULE
- Symptom: *NO RESPONSE FROM AMPLIFIER
- Symptom: *NO RESPONSE FROM ANTILOCK BRAKE MODULE
- Symptom: *NO RESPONSE FROM ECM (PCI BUS) - DIESEL ONLY
- Symptom: *NO RESPONSE FROM ECM (SCI ONLY) - DIESEL ONLY
- Symptom: *NO RESPONSE FROM HANDS FREE MODULE
- Symptom: *NO RESPONSE FROM INSTRUMENT CLUSTER
- Symptom: *NO RESPONSE FROM OVERHEAD CONSOLE (COMPASS/TEMPERATURE MIRROR MODULE)
- Symptom: *NO RESPONSE FROM PCM (PCI BUS) - 1.6L
- Symptom: *NO RESPONSE FROM PCM (PCI BUS) - NGC
- Symptom: *NO RESPONSE FROM PCM (PCM SCI ONLY) - NGC
- Symptom: *NO RESPONSE FROM PCM (SCI ONLY) - 1.6L
- Symptom: *NO RESPONSE FROM RADIO
- Symptom: *NO RESPONSE FROM RKE
- Symptom: *NO RESPONSE FROM SATELLITE RADIO RECEIVER
- Symptom: *NO RESPONSE FROM SENTRY KEY IMMOBILIZER MODULE
- Symptom: *NO RESPONSE FROM TRANSMISSION CONTROL MODULE - NGC
- Symptom: *NO RESPONSE FROM WINDOW REGULATOR MODULE - PT27
- Symptom: *PCI BUS COMMUNICATION FAILURE
- Instrument Cluster
- Symptom List: ABS INDICATOR CIRCUIT OPEN; AIRBAG INDICATOR CIRCUIT OPEN
- Symptom List: ABS MESSAGE NOT RECEIVED; ACM MESSAGE NOT RECEIVED; EATX MESSAGE NOT RECEIVED; NO PCI TRANSMISSION; SBEC MESSAGE NOT RECEIVED; SKIM MESSAGE NOT RECEIVED
- Symptom: EATX MESSAGE MISMATCH
- Symptom: EEPROM CHECKSUM FAILURE
- Symptom: FUEL LEVEL SENSOR OPEN
- Symptom: FUEL LEVEL SENSOR SHORT
- Symptom: FUEL LEVEL SENSOR STUCK
- Symptom: PANEL DIMMER OPEN
- Symptom: PANEL DIMMER SHORTED
- Symptom: *ALL GAUGES INOPERATIVE
- Symptom: *ANY PCI BUS INDICATOR INOPERATIVE
- Symptom: *BRAKE WARNING INDICATOR ALWAYS ON
- Symptom: *BRAKE WARNING INDICATOR INOPERATIVE
- Symptom: *FRONT FOG LAMP INDICATOR INOPERATIVE
- Symptom: *FUEL GAUGE INACCURATE
- Symptom: *HIGH BEAM INDICATOR INOPERATIVE
- Symptom: *INSTRUMENT CLUSTER DIMMING INOPERATIVE
- Symptom: *LOW OIL PRESSURE INDICATOR ALWAYS ON
- Symptom: *LOW OIL PRESSURE INDICATOR INOPERATIVE
- Symptom: *ONE GAUGE INOPERATIVE
- Symptom: *PRND OR AUTOSTICK DISPLAY INOPERATIVE OR INACCURATE
- Symptom: *REAR FOG LAMP INDICATOR INOPERATIVE - BUX ONLY
- Symptom: *SEAT BELT INDICATOR NOT OPERATING PROPERLY
- Symptom: *VF DISPLAY INOPERATIVE
- Interior Lighting
- Overhead Console
- Power Door Locks/RKE
- Symptom: BODY STYLE MISMATCH
- Symptom: DRIVER DOOR SWITCH FAILURE
- Symptom: INCORRECT MODULE TYPE CONFIGURATION FOR PART NUMBER
- Symptom: MODULE NOT CONFIGURED FOR RKE
- Symptom: NO AIRBAG MESSAGES RECEIVED
- Symptom: NO PCM MESSAGES RECEIVED
- Symptom: NO SKIM MESSAGES RECEIVED
- Symptom: PASSENGER DOOR OR LIFTGATE SWITCH FAILURE - PT44
- Symptom:* ALL DOORS (EXCEPT DRIVER)FAIL TO LOCK
- Symptom: * ALL DOORS (EXCEPT DRIVER)FAIL TO LOCK AND UNLOCK
- Symptom:* ALL DOORS (EXCEPT DRIVER)FAIL TO UNLOCK
- Symptom: *ALL DOOR LOCKS INOPERATIVE
- Symptom: *ALL DOORS FAIL TO LOCK
- Symptom: *ALL DOORS FAIL TO UNLOCK
- Symptom: *ALL LOCKS INOPERATIVE FROM ONE LOCK SWITCH
- Symptom: *DECKLID RELEASE SWITCH INOPERATIVE - PT27
- Symptom: *DECKLID SOLENOID INOPERATIVE - PT27
- Symptom: *DOORS LOCKABLE WITH KEY IN IGNITION AND DRIVER DOOR OPEN
- Symptom: *DRIVER DOOR FAILS TO LOCK
- Symptom: *DRIVER DOOR FAILS TO LOCK AND UNLOCK
- Symptom: *DRIVER DOOR FAILS TO UNLOCK
- Symptom: *DRIVER DOOR FAILS UNLOCK - PT27
- Symptom: *LIFTGATE LOCK MOTOR FAILS TO LOCK OR UNLOCK
- Symptom: *ONE DOOR FAILS TO LOCK AND UNLOCK - PT27
- Symptom: *ONE PASSENGER DOOR FAILS TO LOCK AND UNLOCK
- Symptom: *PASSENGER DOOR FAILS TO UNLOCK - PT27
- Symptom: *RKE INOPERATIVE
- Power Top
- Symptom: AMBIENT TEMP MESSAGE NOT RECEIVED
- Symptom: POWER TOP RELAY CONTROL CIRCUIT OPEN
- Symptom: POWER TOP RELAY INOPERATIVE
- Symptom: POWER TOP SWITCH MUX CIRCUIT OPEN
- Symptom: POWER TOP SWITCH MUX CIRCUIT SHORT TO GROUND
- Symptom: POWER TOP SWITCH MUX CIRCUIT VALUE OUT OF RANGE
- Symptom: SPEED MESSAGE NOT RECEIVED
- Power Windows
- Symptom: BATTERY VOLTAGE TOO HIGH
- Symptom: BATTERY VOLTAGE TOO LOW
- Symptom: FRONT WINDOW MOTOR MALFUNCTION
- Symptom: FRONT WINDOW SWITCH MUX CIRCUIT OPEN
- Symptom: FRONT WINDOW SWITCH MUX CIRCUIT SHORT TO GROUND
- Symptom: FRONT WINDOW SWITCH MUX CIRCUIT VALUE OUT OF RANGE
- Symptom: IGNITION SWITCH OUTPUT OPEN
- Symptom: REAR WINDOW MOTOR CIRCUIT OPEN OR SHORTED
- Symptom: REAR WINDOW SWITCH MUX CIRCUIT OPEN
- Symptom: REAR WINDOW SWITCH MUX CIRCUIT SHORT TO GROUND
- Symptom: REAR WINDOW SWITCH MUX CIRCUIT VALUE OUT OF RANGE
- Symptom: WINDOW DROP SWITCH SENSE CIRCUIT OPEN
- Symptom: *DOOR AJAR CIRCUIT OPEN
- Symptom: *DOOR WINDOWS STAY IN DROP DOWN POSITION
- Symptom: *WINDOW DROPS OR JERKS DURING OPENING
- Telecommunication
- Symptom: AUDIO HARDWARE MESSAGE NOT RECEIVED
- Symptom List: BLUETOOTH ERROR; FLASH CHECKSUM ERROR; FLASH WRITE ERROR; PCI BUS INTERNAL ERROR; RAM WRITE ERROR; ROM CHECKSUM ERROR
- Symptom List: BODY STYLE MESSAGE NOT RECEIVED; INVALID BODY STYLE
- Symptom: GENERAL MICROPHONE FAULT
- Symptom: IGNITION POWER MESSAGE NOT RECEIVED
- Symptom List: LEFT AUDIO INPUT SHORT TO GROUND; LEFT AUDIO INPUT SHORT TO VOLTAGE; LEFT AUDIO OUTPUT 1 SHORT TO GROUND; LEFT AUDIO OUTPUT 1 SHORT TO VOLTAGE
- Symptom List: MIRROR POWER CIRCUIT SHORT TO GROUND; MIRROR POWER CIRCUIT SHORT TO VOLTAGE
- Symptom List: PCI BUS BUSY; PCI BUS CIRCUIT OPEN; PCI BUS CIRCUIT SHORT TO GROUND; PCI BUS CIRCUIT SHORT TO VOLTAGE
- Symptom List: PHONE SWITCH STUCK; VOICE RECOGNITION SWITCH STUCK' VOICE RECOGNITION/PHONE SWITCH CIRCUIT RATIONALITY; VOICE RECOGNITION/PHONE SWITCH CIRCUIT SHORT TO GROUND; VOICE RECOGNITION/PHONE SWITCH CIRCUIT SHORT TO VOLTAGE
- Symptom: PRNDL MESSAGE NOT RECEIVED
- Symptom: RADIO MESSAGE NOT RECEIVED
- Symptom List: RIGHT AUDIO INPUT SHORT TO GROUND; RIGHT AUDIO INPUT SHORT TO VOLTAGE; RIGHT AUDIO OUTPUT 1 SHORT TO GROUND; RIGHT AUDIO OUTPUT 1 SHORT TO VOLTAGE
- Symptom: RPM MESSAGE NOT RECEIVED
- Symptom: VIN MESSAGE NOT RECEIVED
- Symptom: VIN MISMATCH
- Vehicle Theft/Security
- Symptom: HOOD AJAR SWITCH MISSING (EXPORT ONLY)
- Symptom: MODULE PREVIOUSLY CONFIGURED FOR VTSS
- Symptom: *ALARM TRIPS ON ITS OWN
- Symptom: *HEADLAMPS FAIL TO FLASH DURING ALARM
- Symptom: *HORN FAILS TO SOUND DURING ALARM
- Symptom: *INTRUSION SENSOR CANNOT BE DISABLED (EXPORT ONLY)
- Symptom: *INTRUSION SENSOR FAILS TO TRIP VTSS (EXPORT ONLY)
- Symptom: *INTRUSION SENSOR REPEATEDLY TRIGGERS VTSS (EXPORT ONLY)
- Symptom: *OPEN DRIVER DOOR FAILS TO TRIP ALARM
- Symptom: *OPEN LIFTGATE FAILS TO TRIP ALARM
- Symptom: *OPEN PASSENGER DOOR FAILS TO TRIP ALARM
- Symptom: *PARK LAMPS FAIL TO FLASH DURING ALARM
- Symptom List: *VTSS FAILS TO ARM FROM LEFT DOOR CYLINDER LOCK SWITCH (EXPORT ONLY); *VTSS FAILS TO ARM/DISARM FROM LEFT DOOR CYLINDER LOCK SWITCH
- Symptom List: *VTSS FAILS TO ARM FROM LIFTGATE CYLINDER LOCK SWITCH (EXPORT ONLY); *VTSS FAILS TO ARM/DISARM FROM LIFTGATE CYLINDER LOCK SWITCH
- Symptom List: *VTSS FAILS TO ARM FROM RIGHT DOOR CYLINDER LOCK SWITCH (EXPORT ONLY); *VTSS FAILS TO ARM/DISARM FROM RIGHT DOOR CYLINDER LOCK SWITCH
- Symptom: *VTSS INDICATOR FAILS TO FLASH
- Symptom: *VTSS INDICATOR STAYS ON STEADY DURING ARMING
- Symptom: *VTSS SIREN INOPERATIVE (EXPORT ONLY)
- Verifications Tests
- Airbag
- Component Locations
- Connector PINOUTS
- Airbag Control Module (Orc) (Base) - Yellow 23 Way
- Airbag Control Module C1 (Orc) (Premium) - Yellow 32 Way
- Airbag Control Module C2 (Orc) (Premium) - Yellow 32 Way
- Ambient Temperature Sensor (Except 2.4L Base) - Black 2 Way
- Amplifier Audio C1 - 20 Way
- Anti-Lock Brake Module - Black 47 Way
- C203 (Pt27) - LT. Gray (Body Side)
- C203 (Pt27) - LT. Gray (Instrument Panel Side)
- C204 (Pt27) - (Instrument Panel Side)
- C204 (Pt27) - (Left Front Door Side)
- C204 (Pt44 LHP) - Natural (Instrument Panel Side)
- C204 (Pt44 LHP) - Natural (Left Front Door Side)
- C205 (Pt27) - (Instrument Panel Side)
- C205 (Pt27) - (Right Front Door Side)
- C305 - Yellow (Airbag Side)
- C305 - Yellow (UNIBODY Side)
- C306 - Yellow (Airbag Side)
- C306 - Yellow (UNIBODY Side)
- C343 (Pt27) - LT. Gray (DECKLID Jumper Side)
- C343 (Pt27) - LT. Gray (DECKLID Side)
- C349 (Pt27) - Blue (Body Side
- C349 (Pt27) - Blue (DECKLID Jumper Side)
- C362 (Pt27) - LT. Gray (Body Side)
- C362 (Pt27) - LT. Gray (Power Top Side)
- CLOCKSPRING - DK. Green 7 Way
- Compass/Temperature Mirror Module (Pt27) - Black 10 Way
- Data Link Connector - Black 16 Way
- DECKLID Cylinder Unlock Switch (Pt27) - LT. Gray 2 Way
- DECKLID Handle Switch (Pt27) - White 2 Way
- DECKLID Release Motor (Pt27) - Black 3 Way
- DECKLID Release Switch (Pt27) - Black 2 Way
- Dome Lamp - Black 3 Way
- Dome Lamp/Intrusion Sensor (Export) - White 4 Way
- Driver Airbag Squib 1 - Yellow 2 Way
- Driver Door Ajar Switch - Black 2 Way
- Driver Door Handle Switch (Pt27) - 2 Way
- Driver Door Power Lock Motor/Ajar Switch - Black 4 Way
- Driver Rear Window Motor (Pt27) - Black 2 Way
- Driver Seat Belt TENSIONER - Yellow 2 Way
- Driver Window Regulator Module (Pt27) - Black 20 Way
- Engine Control Module C1 (Diesel) - Black 81 Way
- Front Power Window Switch - Black 14 Way
- Fuel Pump Module - LT. Gray 4 Way
- Fuses (FB)
- Hands Free Module C1 - DK. Gray 22 Way
- Hands Free Module C2 (Satellite Radio) - DK. Gray 10 Way
- Hands Free Module C3 - Black 10 Way
- High Note Horn (Export) - Black 2 Way
- Hood Ajar Switch (Export) - Black 2 Way
- Ignition Switch C1 - 10 Way
- Instrument Cluster C1 - Black 26 Way
- Instrument Cluster C2 - Black 10 Way
- Left Cylinder Lock Switch - Black 2 Way
- Left Door Lock Switch - Black 3 Way
- Left Front Power Window Motor (Pt44) - Black 2 Way
- Left Instrument Panel Speaker - Black 2 Way
- Left Rear Speaker (Pt44) - Black 2 Way
- Left Seat Airbag Squib (LHP) - Yellow 2 Way
- Left Seat Airbag Squib (RHD) - Yellow 2 Way
- Left Side Impact Sensor 1 - Gray 2 Way
- Liftgate Ajar Switch - White 2 Way
- Liftgate Cylinder Lock Switch - LT. Gray 2 Way
- Liftgate Handle Switch (Pt44) - Natural 2 Way
- Liftgate Power Lock Motor - Black 4 Way
- Liftgate Release Motor (Pt44) - Black 3 Way
- Low Note Horn - Black 2 Way
- Multi-Function Switch - Gray 20 Way
- Overhead Console Module - Black 12 Way
- Passenger Airbag Squib 1 - Yellow 2 Way
- Passenger Door Ajar Switch - Black 2 Way
- Passenger Door Handle Switch (Pt27) - 2 Way
- Passenger Door Power Lock Motor/Ajar Switch - Black 4 Way
- Passenger Rear Window Motor (Pt27) - Black 2 Way
- Passenger Seat Belt TENSIONER - Yellow 2 Way
- Passenger Window Regulator Module (Pt27) - Black 20 Way
- Fuses (PDC)
- Power Top Motor (Pt27) - 2 Way
- Power Top Relay (Pt27) - Black 6 Way
- Power Top Switch (Pt27) - 3 Way
- Powertrain Control Module (1.6L) - Black 90 Way
- Powertrain Control Module C1 (NGC) - Black/Black 38 Way
- Radio C1 - White 22 Way
- Radio C2 (Hands Free) - DK. Gray 10 Way
- Rear View Mirror C1 - Black 12 Way
- Remote Keyless Entry Module - Black 26 Way
- Right Cylinder Lock Switch (Export) - Black 2 Way
- Right Door Lock Switch - Black 3 Way
- Right Front Door Speaker - 3 Way
- Right Front Power Window Motor (Pt44) - Black 2 Way
- Right Rear Power Window Motor (Pt44) - Black 2 Way
- Right Seat Airbag Squib (LHP) - Yellow 2 Way
- Right Seat Airbag Squib (RHP) - Yellow 2 Way
- Right Side Impact Sensor 1 - Gray 2 Way
- Sentry Key Immobilizer Module - Black 6 Way
- Siren (Export) - Black 4 Way
- Schematic Diagrams
- Power Door Lock System
- Power Locks
- Door Lock Switch
- Door Lock Motor
- Liftgate Lock Motor
- Remote Keyless Entry Module
- Remote Keyless Entry Transmitter
- Powertrain Diagnostic Procedures - Component Testing
- Sentry Key Immobilizer - Symptoms
- Symptom List: ANTENNA FAILURE; COP FAILURE; EEPROM FAILURE; INTERNAL FAULT; RAM FAILURE; SERIAL LINK INTERNAL FAULT; STACK OVERFLOW FAILURE
- Symptom List: PCM STATUS FAILURE; SERIAL LINK EXTERNAL FAULT
- Symptom List: ROLLING CODE FAILURE; VIN MISMATCH
- Symptom List: TRANSPONDER COMMUNICATION FAILURE; TRANSPONDER CYCLIC REDUNDANCY CHECK (CRC) FAILURE; TRANSPONDER ID MISMATCH; TRANSPONDER RESPONSE MISMATCH
- Starting - Symptoms
- Symptom: *CHECKING FUEL DELIVERY
- Symptom: *CHECKING FUEL PRESSURE LEAK DOWN
- Symptom: *CHECKING HARD START (FUEL DELIVERY SYSTEM)
- Symptom: *ENGINE CRANKS DOES NOT START - 1.6L
- Symptom: *ENGINE CRANKS DOES NOT START - 2.0L/2.4L
- Symptom: *NO CRANK CONDITION 1.6L
- Symptom: *NO CRANK CONDITION 2.0L/2.4L
- Symptom: *NO RESPONSE FROM PCM WITH A NO START CONDITION
- Symptom: *START AND STALL CONDITION 1.6L
- Symptom: *START AND STALL CONDITION 2.0L/2.4L
- Verification Test
- Component Locations
- Powertrain And Skim
- Control And Solenoids
- Throttle Body And Component Locations (2.0L/2.4L)
- Generator Location (1.6L)
- Generator and 1/1 O2 Sensor Locations (2.0L/2.4L)
- ETC Assembly And Ignition Coil Locations (1.6L)
- MAP Sensor And Ignition Coil Location (2.0L/2.4L)
- EVAP Purge Solenoid Location (2.0L/2.4L)
- NVLD Location (2.0L/2.4L)
- Speed Control Servo Locations (2.0L/2.4L)
- Speed Control Servo And Solenoids Component Locations (2.4L Turbo Only)
- Data Link Connector
- Sensors
- Battery Temperature Sensor Location (2.0L/2.4L)
- CKP Sensor Location (1.6L)
- CKP Sensor Location (2.0L/2.4L)
- CMP Sensor Location (2.0L/2.4L)
- Coolant Temperature Sensor Location (2.0L/2.4L)
- ECT Sensor Location (1.6L)
- IAT Sensor Location (2.0L/2.4L)
- Knock Sensor Location (1.6L)
- Knock Sensor Location (2.4L)
- MAP Sensor And Injectors Locations (1.6L)
- MAP Sensor Location (2.0L/2.4L)
- MAP Sensor Location (2.4L Turbo Only)
- APP Sensor Location (1.6L)
- O2 Sensors Location (1.6L)
- VSS Location
- Fuel System
- Relays
- Switches
- Connector PINOUTS
- A/C Compressor Clutch (Gas) - Black 2 Way
- A/C Low Pressure Switch - DK. Green 2 Way
- A/C Pressure Transducer - 2 Way
- Accelerator Pedal Position Sensor (1.6L/Diesel) - 10 Way
- Ambient Temperature Sensor (Except 2.4L Base) - Black 2 Way
- Ambient Temperature Sensor (NGC) - Black 2 Way
- Brake Lamp Switch (Gas) - Gray 6 Way
- Camshaft Position Sensor (Diesel) - Black 3 Way
- Camshaft Position Sensor (Gas) - Black 3 Way
- Clutch Pedal Position Switch (Up) - Black 3 Way
- Crankshaft Position Sensor (Gas) - Black 3 Way
- Data Link Connector - Black 16 Way
- EGR Solenoid (Diesel) - 2 Way
- Engine Coolant Temperature Sensor (Diesel) - Black 2 Way
- Engine Coolant Temperature Sensor (Gas) - Black 2 Way
- Engine Oil Pressure Switch - LT. Green 2 Way
- EVAP/Purge Solenoid (Gas) - Black 2 Way
- Fuel Injector No. 1 (Gas) - Black 2 Way
- Fuel Injector No. 2 (Gas) - Black 2 Way
- Fuel Injector No. 3 (Gas) - Black 2 Way
- Fuel Injector No. 4 (Gas) - Black 2 Way
- Fuel Pump Module - LT. Gray 4 Way
- Generator (2.4L Turbo) - Black 2 Way
- Generator (Gas Except 2.4L Turbo) - Black 2 Way
- Idle Air Control Motor (2.4L) - Black 2 Way
- Ignition Coil (Gas) - Black 3 Way
- Inlet Air Temperature Sensor (Gas) - Black 2 Way
- Knock Sensor (Gas) - Black 2 Way
- Manifold Absolute Pressure Sensor (Gas) - Black 3 Way
- Natural Vacuum Leak Detection Assembly (Except Export) - Black 3 Way
- Oxygen Sensor 1/1 Upstream (Gas) - Black 4 Way
- Oxygen Sensor 1/2 Downstream (Gas) - Black 4 Way
- Powertrain Control Module (1.6L) - Black 90 Way
- Powertrain Control Module C1 (NGC) - Black/Black 38 Way
- Powertrain Control Module C2 (NGC) - Black/Orange 38 Way
- Powertrain Control Module C3 (NGC) - Black/Natural 38 Way
- Powertrain Control Module C4 (NGC) - Black/Green 38 Way
- Radiator Fan Motor (2.4L Turbo) - DK. Gray 4 Way
- Radiator Fan Motor (Except 2.4L Turbo) - Black 3 Way
- Sentry Key Immobilizer Module - Black 6 Way
- Speed Control Servo (2.4L) - Black 4 Way
- Speed Control Switch - Yellow 3 Way
- Surge Solenoid (2.4L Turbo) - Black 2 Way
- Throttle Inlet Pressure Sensor (2.4L Turbo) - Natural 3 Way
- Throttle Inlet Pressure Solenoid (2.4L Turbo) - Black 2 Way
- Throttle Position Sensor (2.4L) - Black 3 Way
- Vehicle Speed Sensor (Gas MTX) - Black 3 Way
- WASTEGATE Solenoid (2.4L Turbo) - Black 2 Way
- Schematic Diagrams
- Charts And Graphs
- Vacuum Gauge Reading Examples
- Camshaft Sensor & Crankshaft Sensor Scope Pattern (Typical)
- Accelerator Pedal Position Sensor Specifications (1.6L)
- Camshaft & Crankshaft Sensor Specifications (1.6L)
- Throttle Position Sensor Specifications (1.6L)
- EVAP Tester
- Turbocharger System Circuit Diagrams
- Fuel Gauge Voltage Specifications
- Evaporative Emission System Schematic
- Sentry Key Immobilizer - Symptoms
- Powertrain Diagnostic Procedures - DRIVEABILITY - 1.6L Gas
- DRIVEABILITY - 1.6L Gas - Symptoms
- DRIVEABILITY - 1.6L Gas - Diagnostic Tests
- P0016-Crank And Cam Out-Of-Sync
- P0030-1/1 O2 Sensor Heater Circuit Open; P0036-1/1 O2 Sensor Heater Circuit Open
- P0031-1/1 O2 Sensor Heater Circuit Low; P0037-1/1 O2 Sensor Heater Circuit Low
- P0032-1/1 O2 Sensor Heater Circuit High; P0038-1/2 O2 Sensor Heater Circuit High
- P0106-BARO Pressure Out Of Range
- P0107-Map Sensor Voltage Too Low
- P0108-Map Sensor Voltage Too High
- P0112-Intake Air Temp Sensor Too Low
- P0113-Intake Air Temp Sensor Too High
- P0117-ECT Sensor Voltage Too Low
- P0118-ECT Sensor Voltage Too High
- P0122-Throttle Position Sensor Circuit #1 Low; P0222-Throttle Position Sensor Circuit #2 Low
- P0123-Throttle Position Sensor Circuit #1 High; P0223-Throttle Position Sensor Circuit #2 High
- P0125-Closed Loop Temp Not Reached
- P0128-Coolant Thermostat
- P0131-1/1 O2 Sensor Shorted To Ground; P0137-1/2 O2 Sensor Shorted To Ground
- P0132-1/1 O2 Sensor Shorted To Voltage; P0138-1/2 O2 Sensor Shorted To Voltage
- P0133-1/1 O2 Sensor Slow Response; P0139-1/2 O2 Sensor Slow Response
- P0134-1/1 O2 Sensor Stays At Center; P0140-1/2 O2 Sensor Stays At Center
- P0171-1/1 Fuel System Lean
- P0172-1/1 Fuel System Rich
- P0201-Injector #1 Control Circuit Open; P0202-Injector #2 Control Circuit Open; P0203-Injector #3 Control Circuit Open; P0204-Injector #4 Control Circuit Open
- P0261-Injector #1 Control Circuit Low; P0264-Injector #2 Control Circuit Low; P0267-Injector #3 Control Circuit Low; P0270-Injector #4 Control Circuit Low
- P0262-Injector #1 Control Circuit High; P0265-Injector #2 Control Circuit High; P0268-Injector #3 Control Circuit High; P0271-Injector #4 Control Circuit High
- P0300-Multiple Cylinder Mis-Fire; P0301-Cylinder #1 Misfire; P0302-Cylinder #2 Misfire; P0303-Cylinder #3 Misfire; P0304-Cylinder #4 Misfire
- P0315-No Crank Learned
- P0325-Knock Sensor #1 Circuit
- P0335-No Crank Signal At Pcm
- P0336-Crankshaft Position Sensor Performance
- P0340-No Cam Signal At Pcm
- P0420-1/1 Catalytic Converter Efficiency
- P0444-EVAP Purge Solenoid Circuit Open
- P0458-EVAP Purge Solenoid Low
- P0459-EVAP Purge Solenoid Circuit High
- P0461-Fuel Level Unit No Change Over Time
- P0462-Fuel Level Sending Unit Volts Too Low
- P0463-Fuel Level Sending Unit Volts Too High
- P0500-No Vehicle Speed Sensor Signal
- P0506-Idle Speed Performance Lower Than Excepted
- P0507-Idle Speed Performance Higher Than Excepted
- P0513-Invalid Skim Key
- P0551-Power Steering Switch Failure
- P0562-Charging System Voltage Too Low
- P0563-Charging System Voltage Too High
- P0572-Brake Switch Circuit Low
- P0573-Brake Switch Circuit High
- P0580-Speed Control Switch Always Low
- P0625-Generator Field Control Circuit Low
- P0626-Generator Field Control Circuit High
- P0628-Fuel Pump Relay Control Circuit Low
- P0629-Fuel Pump Relay Control Circuit High
- P0646-A/C Clutch Relay Control Circuit Low
- P0647-A/C Clutch Relay Control Circuit High
- P0686-ASD Relay Control Circuit Low
- P0687-ASD Relay Control Circuit High
- P0688-ASD Relay Output Circuit Low
- P0690-ASD Relay Output Circuit High
- P0691-Low Speed Fan Relay Control Circuit Low; P0693-High Speed Fan Relay Control Circuit Low
- P0692-Low Speed Fan Relay Control Circuit High P0694-High Speed Fan Relay Control Circuit High
- P0703-Brake Lamp Switch Circuit Performance
- P0719-Brake Lamp Switch Circuit Low
- P0724-Brake Lamp Switch Circuit High
- P0833-Clutch UPSTOP Switch Performance
- P1135-1/1 O2 Heater Element Resistance Out Of Range; P1136-1/2 Heater Element Resistance Out Of Range
- P1594-Charging System Voltage Too High
- P1616-5V Output Reference Voltage #1 Low
- P1617-5V Output Reference Voltage #1 High
- P1618-5V Output Reference Voltage Unstable
- P1626-5V Output Reference Voltage #2 Low
- P1627-5V Output Reference Voltage #2 High
- P1628-5V Output Reference Voltage #1 Unstable
- P1653-PCI Bus Shorted To Ground
- P1654-PCI Bus Shorted To Voltage
- P1656-PCI Bus Not Available
- P1686-No Skim Bus Message Received
- P1687-No Cluster Bus Message
- P2100-Electronic Throttle Control Motor Circuit
- P2101-Electronic Throttle Control Motor Performance
- P2107-Electronic Throttle Control Module Processor; P2108-Electronic Throttle Control Module Performance
- P2122-Accelerator Pedal Position Sensor # 1 Low; P2127-Accelerator Pedal Position Sensor #2 Low
- P2123-Accelerator Pedal Position Sensor #1 High; P2128-Accelerator Pedal Position Sensor #2 High
- P2135-Throttle Position Sensor #1 And #2 Voltage Correlation
- P2138-Accelerator Pedal Position Sensor #1 And #2 Voltage Correlation
- P2300-Ignition Coil #1 Circuit Low; P2303-Ignition Coil #2 Circuit Low
- P2301-Ignition Coil #1 Circuit High; P2304-Ignition Coil #2 Circuit High
- Powertrain Diagnostic Procedures - DRIVEABILITY - NGC
- DRIVEABILITY - NGC - Symptoms
- DRIVEABILITY - NGC - Diagnostic Tests
- P0016-Crankshaft/Camshaft Timing Misalignment
- P0031-O2 Sensor 1/1 Heater Circuit Low; P0037-O2 Sensor 1/2 Heater Circuit Low
- P0032-O2 Sensor 1/1 Heater Circuit High P0038-O2 Sensor 1/2 Heater Circuit High
- P0033-Surge Valve Solenoid Circuit
- P0068-Manifold Pressure/Throttle Position Correlation
- P0071-Ambient Temp Sensor Performance
- P0072-Ambient Temp Sensor Low
- P0073-Ambient Temp Sensor High
- P0107-Map Sensor Low
- P0108-Map Sensor High
- P0111-Intake Air Temperature Sensor Performance
- P0112-Intake Air Temperature Sensor Low
- P0113-Intake Air Temperature Sensor High
- P0116-Engine Coolant Temperature Performance
- P0117-Engine Coolant Temperature Sensor Low
- P0118-Engine Coolant Temperature Sensor High
- P0122-Throttle Position Sensor #1 Low
- P0123-Throttle Position Sensor #1 High
- P0125-Insufficient Coolant Temp For Closed-Loop Fuel Control
- P0128-Thermostat Rationality
- P0129-Barometric Pressure Out-Of-Range
- P0131-O2 Sensor 1/1 Voltage Low; P0137-O2 Sensor 1/2 Voltage Low
- P0132-O2 Sensor 1/1 Voltage High; P0138-O2 Sensor 1/2 Voltage High
- P0133-O2 Sensor 1/1 Slow Response; P0139-O2 Sensor 1/2 Slow Response
- P0135-O2 Sensor 1/1 Heater Performance; P0141-O2 Sensor 1/2 Heater Performance
- P0171-Fuel System 1/1 Lean
- P0172-Fuel System 1/1 Rich
- P0201-Fuel Injector #1; P0202-Fuel Injector #2; P0203-Fuel Injector #3; P0204-Fuel Injector #4
- P0234-OVERBOOST Performance; P1106-BARO Solenoid Performance; P1188 Tip Sensor Performance
- P0243-WASTEGATE Solenoid Circuit
- P0300-Multiple Cylinder Misfire; P0301-Cylinder #1 Misfire; P0302-Cylinder #2 Misfire; P0303-Cylinder #3 Misfire; P0304-Cylinder #4 Misfire
- P0315-No Crank Sensor Learned
- P0325-Knock Sensor #1 Circuit
- P0335-Crankshaft Position Sensor Circuit
- P0339-Crankshaft Position Sensor Intermittent
- P0340-Camshaft Position Sensor Circuit
- P0344-Camshaft Position Sensor Intermittent
- P0420-Catalytic 1/1 Efficiency
- P0440-General EVAP System Failure
- P0441-EVAP Purge System Performance
- P0442-EVAP System Medium Leak; P0455-EVAP System Large Leak
- P0443-EVAP Purge Solenoid Circuit
- P0452-NVLD Pressure Switch Stuck Closed
- P0453-NVLD Pressure Switch Stuck Open
- P0456-EVAP System Small Leak
- P0457-Loose Fuel Cap
- P0461-Fuel Level Sensor #1 Performance
- P0462-Fuel Level Sensor #1 Low; P0463-Fuel Level Sensor #1 High
- P0480-Cooling Fan 1 Control Circuit
- P0481-Cooling Fan 2 Control Circuit
- P0498-NVLD Canister Vent Valve Solenoid Circuit Low
- P0499-NVLD Canister Vent Valve Solenoid Circuit High
- P0501-Vehicle Speed Sensor #1 Performance (Auto Trans)
- P0501-Vehicle Speed Sensor #1 Performance (Manual Trans)
- P0506-Idle Speed Low Performance; P0507-Idle Speed High Performance
- P0508-IAC Valve Sense Circuit Low
- P0509-IAC Valve Sense Circuit High
- P0513-Invalid Skim Key
- P0516-Battery Temperature Sensor Low
- P0517-Battery Temperature Sensor High
- P0522-Oil Pressure Sensor Low
- P0551-Power Steering Switch Performance
- P0562-Battery Voltage Low
- P0563-Battery Voltage High
- P0572-Brake Switch #1 Circuit Low
- P0573-Brake Switch #1 Circuit High
- P0580-Speed Control Switch #1 Low
- P0581-Speed Control Switch #1 High
- P0582-Speed Control Vacuum Solenoid Circuit
- P0586-Speed Control Vent Solenoid Circuit
- P0594-Speed Control Servo Power Circuit
- P0600-Serial Communication Link; P0601-Internal Memory Checksum Invalid
- P0622-Generator Field Control Circuit
- P0627-Fuel Pump Relay Circuit
- P0630-VIN Not Programmed In Pcm
- P0632-Odometer Not Programmed In Pcm
- P0633-Skim Key Not Programmed In Pcm
- P0645-A/C Clutch Relay Circuit
- P0685-ASD Relay Control Circuit
- P0688-ASD Relay Sense Circuit Low
- P0700-Transmission Control System/Read Transmission DTCS On The DRBIII®
- P0850-Park/Neutral Switch Performance
- P1105-Tip Sensor Solenoid Circuit
- P1115-General Temp Sensor Performance
- P1187-THOTTLE Inlet Pressure/Map Correlation
- P1189-Tip Sensor Circuit Low
- P1190-Tip Sensor Circuit High
- P1593-Speed Control Switch Stuck
- P1603-Pcm Internal Dual-Port Ram Communication; P1604-Pcm Internal Dual-Port Ram Read/Write Integrity Failure; P1607-Pcm Internal Shutdown Timer Rationality
- P1696-EEPROM Memory Write Denied/Invalid; P1697-EMR (Sri) Mileage Not Stored
- P1854-Tip BARO Out Of Range
- P2074-Manifold Pressure/Throttle Position Correlation - High Flow/Vacuum Leak
- P2096-Down Stream Fuel System 1/2 Lean; P2097-Down Stream Fuel System 1/2 Rich
- P2302-Ignition Coil #1 Secondary Circuit-Insufficient Ionization; P2305-Ignition Coil #2 Secondary Circuit-Insufficient Ionization
- P2503-Charging System Voltage Low
- U0101-No Transmission Bus Message
- U0155-No Cluster Bus Message
- U0168-No Skim Bus Messages
- U110C-No Fuel Level Bus Message
- Powertrain Diagnostic Procedures - Introduction
- DTC Index
- Introduction
- Identification Of System
- System Description And Functional Operation
- General Description
- Functional Operation
- Fuel Control
- On-Board Diagnostics
- Other Controls
- Pcm Operating Modes
- Non-Monitored Circuits
- Skis Overview
- Skim On-Board Diagnostics
- Skis Operation
- Programming The Powertrain Control Module
- Programming The Sentry Key Immobilizer Module
- Programming The Ignition Keys To The Sentry Key Immobilizer Module
- Diagnostic Trouble Codes
- Using The DRBIII®
- DRBIII® Error Messages And Blank Screen
- Disclaimers, Safety, Warnings
- Required Tools And Equipment
- Glossary Of Terms
- Diagnostic Information And Procedures
- Communication - Symptoms
- Symptom: *NO RESPONSE FROM PCM (PCI BUS) - 1.6L
- Symptom: *NO RESPONSE FROM PCM (PCI BUS) - NGC
- Symptom: *NO RESPONSE FROM PCM (PCM SCI ONLY) - NGC
- Symptom: *NO RESPONSE FROM PCM (SCI ONLY) - 1.6L
- Symptom: *NO RESPONSE FROM SENTRY KEY IMMOBILIZER MODULE
- Symptom: *NO RESPONSE FROM TRANSMISSION CONTROL MODULE - NGC
- Symptom: *PCI BUS COMMUNICATION FAILURE
- Communication - Symptoms
- Vehicle Theft Security System
- Body Diagnostic Procedures
- Body Interior
- Body Diagnostic Procedures
- Introduction
- Identification Of System
- System Description And Functional Operation
- Notes
- Airbag System
- Audio System
- Compass/Temperature Module (CTM)
- Compass/Temperature Mirror
- Description
- Operation
- English / Metric / Off Mode
- Calibration / Zone Mode
- Setting Compass Zone
- First Time Calibration
- Manual Calibration
- Continuous Calibration
- Self-Check Diagnostic
- Outside Temperature
- Temperature Update - Warm
- Temperature Update - Cold
- Extreme Temperature / Open Or Short Condition
- Ambient Temperature Sensor
- Ambient Temperature Sensor Diagnostics
- Instrument Cluster
- Remote Keyless Entry Module
- Sentry Key Immobilizer System (Skis)
- Communication
- Telecommunications
- Window Regulator Modules (Pt27 Only)
- Using The DRBIII®
- Disclaimers, Safety, Warnings
- Required Tools And Equipment
- Glossary Of Terms
- Diagnostic Information And Procedures
- Airbag
- Symptom List: ACCELEROMETER 1; INTERNAL 1; INTERNAL 2; INTERNAL 3; INTERNAL 4' OUTPUT DRIVER 1; OUTPUT DRIVER 2; STORED ENERGY FIRING 1
- Symptom List: AIRBAG WARNING INDICATOR DRIVER; AIRBAG WARNING INDICATOR OPEN; AIRBAG WARNING INDICATOR SHORT
- Symptom: CALIBRATION MISMATCH
- Symptom: CLUSTER MESSAGE MISMATCH
- Symptom: DRIVER SEAT BELT TENSIONER CIRCUIT OPEN
- Symptom: DRIVER SEAT BELT TENSIONER CIRCUIT SHORT
- Symptom: DRIVER SEAT BELT TENSIONER SHORT TO BATTERY
- Symptom: DRIVER SEAT BELT TENSIONER SHORT TO GROUND
- Symptom: DRIVER SQUIB 1 CIRCUIT OPEN
- Symptom: DRIVER SQUIB 1 CIRCUIT SHORT
- Symptom: DRIVER SQUIB 1 SHORT TO BATTERY
- Symptom: DRIVER SQUIB 1 SHORT TO GROUND
- Symptom: LEFT CURTAIN OR SEAT SQUIB CIRCUIT OPEN
- Symptom: LEFT CURTAIN OR SEAT SQUIB CIRCUIT SHORT
- Symptom: LEFT CURTAIN OR SEAT SQUIB SHORT TO BATTERY
- Symptom: LEFT CURTAIN OR SEAT SQUIB SHORT TO GROUND
- Symptom: LEFT SIDE IMPACT SENSOR 1 INTERNAL 1
- Symptom: LOSS OF IGNITION RUN - START
- Symptom: LOSS OF IGNITION RUN ONLY
- Symptom: NO CLUSTER MESSAGE
- Symptom: NO LEFT SIDE IMPACT SENSOR 1 COMMUNICATION
- Symptom: NO ODOMETER MESSAGE
- Symptom: NO PCI TRANSMISSION
- Symptom: NO RIGHT SIDE IMPACT SENSOR 1 COMMUNICATION
- Symptom: PASSENGER SEAT BELT TENSIONER CIRCUIT OPEN
- Symptom: PASSENGER SEAT BELT TENSIONER CIRCUIT SHORT
- Symptom: PASSENGER SEAT BELT TENSIONER SHORT TO BATTERY
- Symptom: PASSENGER SEAT BELT TENSIONER SHORT TO GROUND
- Symptom: PASSENGER SQUIB 1 CIRCUIT OPEN
- Symptom: PASSENGER SQUIB 1 CIRCUIT SHORT
- Symptom: PASSENGER SQUIB 1 SHORT TO BATTERY
- Symptom: PASSENGER SQUIB 1 SHORT TO GROUND
- Symptom: POWER SUPPLY VOLTAGE LOW
- Symptom: RIGHT CURTAIN OR SEAT SQUIB CIRCUIT OPEN
- Symptom: RIGHT CURTAIN OR SEAT SQUIB CIRCUIT SHORT
- Symptom: RIGHT CURTAIN OR SEAT SQUIB SHORT TO BATTERY
- Symptom: RIGHT CURTAIN OR SEAT SQUIB SHORT TO GROUND
- Symptom: RIGHT SIDE IMPACT SENSOR INTERNAL 1
- Symptom: VEHICLE BODY STYLE MISMATCH
- Symptom: *AIRBAG INDICATOR ON WITHOUT ACTIVE TROUBLE CODES
- Audio
- Symptom: ALL OUTPUTS SHORT
- Symptom: ANTENNA HARDWARE FAILURE - SDARS
- Symptom: ANTENNA NOT CONNECTED - SDARS
- Symptom: BUS BUSY - SDARS
- Symptom: BUS LOW - SDARS
- Symptom List: CASSETTE PLAYER INOP; CD MECHANICAL FAILURE; NO PCI TRANSMISSION; *AM/FM SWITCH INOPERATIVE; *ANY STATION PRESET SWITCH INOPERATIVE; *BALANCE INOPERATIVE; *CD EJECT SWITCH INOPERATIVE; *EQUALIZER INOPERATIVE; *FADER INOPERATIVE; *FF/RW SWITCH INOPERATIVE; *HOUR/MINUTE SWITCHES INOPERATIVE; *PAUSE/PLAY SWITCH INOPERATIVE; *PWR SWITCH INOPERATIVE; *SCAN SWITCH INOPERATIVE; *SEEK SWITCH INOPERATIVE; *SET SWITCH INOPERATIVE; *TAPE EJECT SWITCH INOPERATIVE; *TIME SWITCH INOPERATIVE; *TUNE SWITCH INOPERATIVE
- Symptom: CD PLAY FAILURE
- Symptom: CD READ FAILURE
- Symptom: CD TEMPERATURE HIGH
- Symptom: GPS ANTENNA NOT CONNECTED
- Symptom: INTERNAL FAILURE - SDARS
- Symptom: INTERNAL RECEIVER FAILURE - SDARS
- Symptom: LOW VOLTAGE LEVEL
- Symptom: NO ANTENNA CONNECTION
- Symptom: NO COMMUNICATION WITH SDARS
- Symptom: NO J1850 COMMUNICATION - SDARS
- Symptom: POWER AMP SHUTDOWN
- Symptom: RADIO AND NAV GPS ANTENNA NOT CONNECTED
- Symptom: *INOP NO FAULT CODES - SDARS
- Symptom: *POOR RECEPTION - SDARS
- Communication
- Symptom: *NO RESPONSE FROM AIRBAG CONTROL MODULE
- Symptom: *NO RESPONSE FROM AMPLIFIER
- Symptom: *NO RESPONSE FROM ANTILOCK BRAKE MODULE
- Symptom: *NO RESPONSE FROM ECM (PCI BUS) - DIESEL ONLY
- Symptom: *NO RESPONSE FROM ECM (SCI ONLY) - DIESEL ONLY
- Symptom: *NO RESPONSE FROM HANDS FREE MODULE
- Symptom: *NO RESPONSE FROM INSTRUMENT CLUSTER
- Symptom: *NO RESPONSE FROM OVERHEAD CONSOLE (COMPASS/TEMPERATURE MIRROR MODULE)
- Symptom: *NO RESPONSE FROM PCM (PCI BUS) - 1.6L
- Symptom: *NO RESPONSE FROM PCM (PCI BUS) - NGC
- Symptom: *NO RESPONSE FROM PCM (PCM SCI ONLY) - NGC
- Symptom: *NO RESPONSE FROM PCM (SCI ONLY) - 1.6L
- Symptom: *NO RESPONSE FROM RADIO
- Symptom: *NO RESPONSE FROM RKE
- Symptom: *NO RESPONSE FROM SATELLITE RADIO RECEIVER
- Symptom: *NO RESPONSE FROM SENTRY KEY IMMOBILIZER MODULE
- Symptom: *NO RESPONSE FROM TRANSMISSION CONTROL MODULE - NGC
- Symptom: *NO RESPONSE FROM WINDOW REGULATOR MODULE - PT27
- Symptom: *PCI BUS COMMUNICATION FAILURE
- Instrument Cluster
- Symptom List: ABS INDICATOR CIRCUIT OPEN; AIRBAG INDICATOR CIRCUIT OPEN
- Symptom List: ABS MESSAGE NOT RECEIVED; ACM MESSAGE NOT RECEIVED; EATX MESSAGE NOT RECEIVED; NO PCI TRANSMISSION; SBEC MESSAGE NOT RECEIVED; SKIM MESSAGE NOT RECEIVED
- Symptom: EATX MESSAGE MISMATCH
- Symptom: EEPROM CHECKSUM FAILURE
- Symptom: FUEL LEVEL SENSOR OPEN
- Symptom: FUEL LEVEL SENSOR SHORT
- Symptom: FUEL LEVEL SENSOR STUCK
- Symptom: PANEL DIMMER OPEN
- Symptom: PANEL DIMMER SHORTED
- Symptom: *ALL GAUGES INOPERATIVE
- Symptom: *ANY PCI BUS INDICATOR INOPERATIVE
- Symptom: *BRAKE WARNING INDICATOR ALWAYS ON
- Symptom: *BRAKE WARNING INDICATOR INOPERATIVE
- Symptom: *FRONT FOG LAMP INDICATOR INOPERATIVE
- Symptom: *FUEL GAUGE INACCURATE
- Symptom: *HIGH BEAM INDICATOR INOPERATIVE
- Symptom: *INSTRUMENT CLUSTER DIMMING INOPERATIVE
- Symptom: *LOW OIL PRESSURE INDICATOR ALWAYS ON
- Symptom: *LOW OIL PRESSURE INDICATOR INOPERATIVE
- Symptom: *ONE GAUGE INOPERATIVE
- Symptom: *PRND OR AUTOSTICK DISPLAY INOPERATIVE OR INACCURATE
- Symptom: *REAR FOG LAMP INDICATOR INOPERATIVE - BUX ONLY
- Symptom: *SEAT BELT INDICATOR NOT OPERATING PROPERLY
- Symptom: *VF DISPLAY INOPERATIVE
- Interior Lighting
- Overhead Console
- Power Door Locks/RKE
- Symptom: BODY STYLE MISMATCH
- Symptom: DRIVER DOOR SWITCH FAILURE
- Symptom: INCORRECT MODULE TYPE CONFIGURATION FOR PART NUMBER
- Symptom: MODULE NOT CONFIGURED FOR RKE
- Symptom: NO AIRBAG MESSAGES RECEIVED
- Symptom: NO PCM MESSAGES RECEIVED
- Symptom: NO SKIM MESSAGES RECEIVED
- Symptom: PASSENGER DOOR OR LIFTGATE SWITCH FAILURE - PT44
- Symptom:* ALL DOORS (EXCEPT DRIVER)FAIL TO LOCK
- Symptom: * ALL DOORS (EXCEPT DRIVER)FAIL TO LOCK AND UNLOCK
- Symptom:* ALL DOORS (EXCEPT DRIVER)FAIL TO UNLOCK
- Symptom: *ALL DOOR LOCKS INOPERATIVE
- Symptom: *ALL DOORS FAIL TO LOCK
- Symptom: *ALL DOORS FAIL TO UNLOCK
- Symptom: *ALL LOCKS INOPERATIVE FROM ONE LOCK SWITCH
- Symptom: *DECKLID RELEASE SWITCH INOPERATIVE - PT27
- Symptom: *DECKLID SOLENOID INOPERATIVE - PT27
- Symptom: *DOORS LOCKABLE WITH KEY IN IGNITION AND DRIVER DOOR OPEN
- Symptom: *DRIVER DOOR FAILS TO LOCK
- Symptom: *DRIVER DOOR FAILS TO LOCK AND UNLOCK
- Symptom: *DRIVER DOOR FAILS TO UNLOCK
- Symptom: *DRIVER DOOR FAILS UNLOCK - PT27
- Symptom: *LIFTGATE LOCK MOTOR FAILS TO LOCK OR UNLOCK
- Symptom: *ONE DOOR FAILS TO LOCK AND UNLOCK - PT27
- Symptom: *ONE PASSENGER DOOR FAILS TO LOCK AND UNLOCK
- Symptom: *PASSENGER DOOR FAILS TO UNLOCK - PT27
- Symptom: *RKE INOPERATIVE
- Power Top
- Symptom: AMBIENT TEMP MESSAGE NOT RECEIVED
- Symptom: POWER TOP RELAY CONTROL CIRCUIT OPEN
- Symptom: POWER TOP RELAY INOPERATIVE
- Symptom: POWER TOP SWITCH MUX CIRCUIT OPEN
- Symptom: POWER TOP SWITCH MUX CIRCUIT SHORT TO GROUND
- Symptom: POWER TOP SWITCH MUX CIRCUIT VALUE OUT OF RANGE
- Symptom: SPEED MESSAGE NOT RECEIVED
- Power Windows
- Symptom: BATTERY VOLTAGE TOO HIGH
- Symptom: BATTERY VOLTAGE TOO LOW
- Symptom: FRONT WINDOW MOTOR MALFUNCTION
- Symptom: FRONT WINDOW SWITCH MUX CIRCUIT OPEN
- Symptom: FRONT WINDOW SWITCH MUX CIRCUIT SHORT TO GROUND
- Symptom: FRONT WINDOW SWITCH MUX CIRCUIT VALUE OUT OF RANGE
- Symptom: IGNITION SWITCH OUTPUT OPEN
- Symptom: REAR WINDOW MOTOR CIRCUIT OPEN OR SHORTED
- Symptom: REAR WINDOW SWITCH MUX CIRCUIT OPEN
- Symptom: REAR WINDOW SWITCH MUX CIRCUIT SHORT TO GROUND
- Symptom: REAR WINDOW SWITCH MUX CIRCUIT VALUE OUT OF RANGE
- Symptom: WINDOW DROP SWITCH SENSE CIRCUIT OPEN
- Symptom: *DOOR AJAR CIRCUIT OPEN
- Symptom: *DOOR WINDOWS STAY IN DROP DOWN POSITION
- Symptom: *WINDOW DROPS OR JERKS DURING OPENING
- Telecommunication
- Symptom: AUDIO HARDWARE MESSAGE NOT RECEIVED
- Symptom List: BLUETOOTH ERROR; FLASH CHECKSUM ERROR; FLASH WRITE ERROR; PCI BUS INTERNAL ERROR; RAM WRITE ERROR; ROM CHECKSUM ERROR
- Symptom List: BODY STYLE MESSAGE NOT RECEIVED; INVALID BODY STYLE
- Symptom: GENERAL MICROPHONE FAULT
- Symptom: IGNITION POWER MESSAGE NOT RECEIVED
- Symptom List: LEFT AUDIO INPUT SHORT TO GROUND; LEFT AUDIO INPUT SHORT TO VOLTAGE; LEFT AUDIO OUTPUT 1 SHORT TO GROUND; LEFT AUDIO OUTPUT 1 SHORT TO VOLTAGE
- Symptom List: MIRROR POWER CIRCUIT SHORT TO GROUND; MIRROR POWER CIRCUIT SHORT TO VOLTAGE
- Symptom List: PCI BUS BUSY; PCI BUS CIRCUIT OPEN; PCI BUS CIRCUIT SHORT TO GROUND; PCI BUS CIRCUIT SHORT TO VOLTAGE
- Symptom List: PHONE SWITCH STUCK; VOICE RECOGNITION SWITCH STUCK' VOICE RECOGNITION/PHONE SWITCH CIRCUIT RATIONALITY; VOICE RECOGNITION/PHONE SWITCH CIRCUIT SHORT TO GROUND; VOICE RECOGNITION/PHONE SWITCH CIRCUIT SHORT TO VOLTAGE
- Symptom: PRNDL MESSAGE NOT RECEIVED
- Symptom: RADIO MESSAGE NOT RECEIVED
- Symptom List: RIGHT AUDIO INPUT SHORT TO GROUND; RIGHT AUDIO INPUT SHORT TO VOLTAGE; RIGHT AUDIO OUTPUT 1 SHORT TO GROUND; RIGHT AUDIO OUTPUT 1 SHORT TO VOLTAGE
- Symptom: RPM MESSAGE NOT RECEIVED
- Symptom: VIN MESSAGE NOT RECEIVED
- Symptom: VIN MISMATCH
- Vehicle Theft/Security
- Symptom: HOOD AJAR SWITCH MISSING (EXPORT ONLY)
- Symptom: MODULE PREVIOUSLY CONFIGURED FOR VTSS
- Symptom: *ALARM TRIPS ON ITS OWN
- Symptom: *HEADLAMPS FAIL TO FLASH DURING ALARM
- Symptom: *HORN FAILS TO SOUND DURING ALARM
- Symptom: *INTRUSION SENSOR CANNOT BE DISABLED (EXPORT ONLY)
- Symptom: *INTRUSION SENSOR FAILS TO TRIP VTSS (EXPORT ONLY)
- Symptom: *INTRUSION SENSOR REPEATEDLY TRIGGERS VTSS (EXPORT ONLY)
- Symptom: *OPEN DRIVER DOOR FAILS TO TRIP ALARM
- Symptom: *OPEN LIFTGATE FAILS TO TRIP ALARM
- Symptom: *OPEN PASSENGER DOOR FAILS TO TRIP ALARM
- Symptom: *PARK LAMPS FAIL TO FLASH DURING ALARM
- Symptom List: *VTSS FAILS TO ARM FROM LEFT DOOR CYLINDER LOCK SWITCH (EXPORT ONLY); *VTSS FAILS TO ARM/DISARM FROM LEFT DOOR CYLINDER LOCK SWITCH
- Symptom List: *VTSS FAILS TO ARM FROM LIFTGATE CYLINDER LOCK SWITCH (EXPORT ONLY); *VTSS FAILS TO ARM/DISARM FROM LIFTGATE CYLINDER LOCK SWITCH
- Symptom List: *VTSS FAILS TO ARM FROM RIGHT DOOR CYLINDER LOCK SWITCH (EXPORT ONLY); *VTSS FAILS TO ARM/DISARM FROM RIGHT DOOR CYLINDER LOCK SWITCH
- Symptom: *VTSS INDICATOR FAILS TO FLASH
- Symptom: *VTSS INDICATOR STAYS ON STEADY DURING ARMING
- Symptom: *VTSS SIREN INOPERATIVE (EXPORT ONLY)
- Verifications Tests
- Airbag
- Component Locations
- Connector PINOUTS
- Airbag Control Module (Orc) (Base) - Yellow 23 Way
- Airbag Control Module C1 (Orc) (Premium) - Yellow 32 Way
- Airbag Control Module C2 (Orc) (Premium) - Yellow 32 Way
- Ambient Temperature Sensor (Except 2.4L Base) - Black 2 Way
- Amplifier Audio C1 - 20 Way
- Anti-Lock Brake Module - Black 47 Way
- C203 (Pt27) - LT. Gray (Body Side)
- C203 (Pt27) - LT. Gray (Instrument Panel Side)
- C204 (Pt27) - (Instrument Panel Side)
- C204 (Pt27) - (Left Front Door Side)
- C204 (Pt44 LHP) - Natural (Instrument Panel Side)
- C204 (Pt44 LHP) - Natural (Left Front Door Side)
- C205 (Pt27) - (Instrument Panel Side)
- C205 (Pt27) - (Right Front Door Side)
- C305 - Yellow (Airbag Side)
- C305 - Yellow (UNIBODY Side)
- C306 - Yellow (Airbag Side)
- C306 - Yellow (UNIBODY Side)
- C343 (Pt27) - LT. Gray (DECKLID Jumper Side)
- C343 (Pt27) - LT. Gray (DECKLID Side)
- C349 (Pt27) - Blue (Body Side
- C349 (Pt27) - Blue (DECKLID Jumper Side)
- C362 (Pt27) - LT. Gray (Body Side)
- C362 (Pt27) - LT. Gray (Power Top Side)
- CLOCKSPRING - DK. Green 7 Way
- Compass/Temperature Mirror Module (Pt27) - Black 10 Way
- Data Link Connector - Black 16 Way
- DECKLID Cylinder Unlock Switch (Pt27) - LT. Gray 2 Way
- DECKLID Handle Switch (Pt27) - White 2 Way
- DECKLID Release Motor (Pt27) - Black 3 Way
- DECKLID Release Switch (Pt27) - Black 2 Way
- Dome Lamp - Black 3 Way
- Dome Lamp/Intrusion Sensor (Export) - White 4 Way
- Driver Airbag Squib 1 - Yellow 2 Way
- Driver Door Ajar Switch - Black 2 Way
- Driver Door Handle Switch (Pt27) - 2 Way
- Driver Door Power Lock Motor/Ajar Switch - Black 4 Way
- Driver Rear Window Motor (Pt27) - Black 2 Way
- Driver Seat Belt TENSIONER - Yellow 2 Way
- Driver Window Regulator Module (Pt27) - Black 20 Way
- Engine Control Module C1 (Diesel) - Black 81 Way
- Front Power Window Switch - Black 14 Way
- Fuel Pump Module - LT. Gray 4 Way
- Fuses (FB)
- Hands Free Module C1 - DK. Gray 22 Way
- Hands Free Module C2 (Satellite Radio) - DK. Gray 10 Way
- Hands Free Module C3 - Black 10 Way
- High Note Horn (Export) - Black 2 Way
- Hood Ajar Switch (Export) - Black 2 Way
- Ignition Switch C1 - 10 Way
- Instrument Cluster C1 - Black 26 Way
- Instrument Cluster C2 - Black 10 Way
- Left Cylinder Lock Switch - Black 2 Way
- Left Door Lock Switch - Black 3 Way
- Left Front Power Window Motor (Pt44) - Black 2 Way
- Left Instrument Panel Speaker - Black 2 Way
- Left Rear Speaker (Pt44) - Black 2 Way
- Left Seat Airbag Squib (LHP) - Yellow 2 Way
- Left Seat Airbag Squib (RHD) - Yellow 2 Way
- Left Side Impact Sensor 1 - Gray 2 Way
- Liftgate Ajar Switch - White 2 Way
- Liftgate Cylinder Lock Switch - LT. Gray 2 Way
- Liftgate Handle Switch (Pt44) - Natural 2 Way
- Liftgate Power Lock Motor - Black 4 Way
- Liftgate Release Motor (Pt44) - Black 3 Way
- Low Note Horn - Black 2 Way
- Multi-Function Switch - Gray 20 Way
- Overhead Console Module - Black 12 Way
- Passenger Airbag Squib 1 - Yellow 2 Way
- Passenger Door Ajar Switch - Black 2 Way
- Passenger Door Handle Switch (Pt27) - 2 Way
- Passenger Door Power Lock Motor/Ajar Switch - Black 4 Way
- Passenger Rear Window Motor (Pt27) - Black 2 Way
- Passenger Seat Belt TENSIONER - Yellow 2 Way
- Passenger Window Regulator Module (Pt27) - Black 20 Way
- Fuses (PDC)
- Power Top Motor (Pt27) - 2 Way
- Power Top Relay (Pt27) - Black 6 Way
- Power Top Switch (Pt27) - 3 Way
- Powertrain Control Module (1.6L) - Black 90 Way
- Powertrain Control Module C1 (NGC) - Black/Black 38 Way
- Radio C1 - White 22 Way
- Radio C2 (Hands Free) - DK. Gray 10 Way
- Rear View Mirror C1 - Black 12 Way
- Remote Keyless Entry Module - Black 26 Way
- Right Cylinder Lock Switch (Export) - Black 2 Way
- Right Door Lock Switch - Black 3 Way
- Right Front Door Speaker - 3 Way
- Right Front Power Window Motor (Pt44) - Black 2 Way
- Right Rear Power Window Motor (Pt44) - Black 2 Way
- Right Seat Airbag Squib (LHP) - Yellow 2 Way
- Right Seat Airbag Squib (RHP) - Yellow 2 Way
- Right Side Impact Sensor 1 - Gray 2 Way
- Sentry Key Immobilizer Module - Black 6 Way
- Siren (Export) - Black 4 Way
- Schematic Diagrams
- Body Diagnostic Procedures
- Communication Devices
- Body Diagnostic Procedures
- Introduction
- Identification Of System
- System Description And Functional Operation
- Notes
- Airbag System
- Audio System
- Compass/Temperature Module (CTM)
- Compass/Temperature Mirror
- Description
- Operation
- English / Metric / Off Mode
- Calibration / Zone Mode
- Setting Compass Zone
- First Time Calibration
- Manual Calibration
- Continuous Calibration
- Self-Check Diagnostic
- Outside Temperature
- Temperature Update - Warm
- Temperature Update - Cold
- Extreme Temperature / Open Or Short Condition
- Ambient Temperature Sensor
- Ambient Temperature Sensor Diagnostics
- Instrument Cluster
- Remote Keyless Entry Module
- Sentry Key Immobilizer System (Skis)
- Communication
- Telecommunications
- Window Regulator Modules (Pt27 Only)
- Using The DRBIII®
- Disclaimers, Safety, Warnings
- Required Tools And Equipment
- Glossary Of Terms
- Diagnostic Information And Procedures
- Airbag
- Symptom List: ACCELEROMETER 1; INTERNAL 1; INTERNAL 2; INTERNAL 3; INTERNAL 4' OUTPUT DRIVER 1; OUTPUT DRIVER 2; STORED ENERGY FIRING 1
- Symptom List: AIRBAG WARNING INDICATOR DRIVER; AIRBAG WARNING INDICATOR OPEN; AIRBAG WARNING INDICATOR SHORT
- Symptom: CALIBRATION MISMATCH
- Symptom: CLUSTER MESSAGE MISMATCH
- Symptom: DRIVER SEAT BELT TENSIONER CIRCUIT OPEN
- Symptom: DRIVER SEAT BELT TENSIONER CIRCUIT SHORT
- Symptom: DRIVER SEAT BELT TENSIONER SHORT TO BATTERY
- Symptom: DRIVER SEAT BELT TENSIONER SHORT TO GROUND
- Symptom: DRIVER SQUIB 1 CIRCUIT OPEN
- Symptom: DRIVER SQUIB 1 CIRCUIT SHORT
- Symptom: DRIVER SQUIB 1 SHORT TO BATTERY
- Symptom: DRIVER SQUIB 1 SHORT TO GROUND
- Symptom: LEFT CURTAIN OR SEAT SQUIB CIRCUIT OPEN
- Symptom: LEFT CURTAIN OR SEAT SQUIB CIRCUIT SHORT
- Symptom: LEFT CURTAIN OR SEAT SQUIB SHORT TO BATTERY
- Symptom: LEFT CURTAIN OR SEAT SQUIB SHORT TO GROUND
- Symptom: LEFT SIDE IMPACT SENSOR 1 INTERNAL 1
- Symptom: LOSS OF IGNITION RUN - START
- Symptom: LOSS OF IGNITION RUN ONLY
- Symptom: NO CLUSTER MESSAGE
- Symptom: NO LEFT SIDE IMPACT SENSOR 1 COMMUNICATION
- Symptom: NO ODOMETER MESSAGE
- Symptom: NO PCI TRANSMISSION
- Symptom: NO RIGHT SIDE IMPACT SENSOR 1 COMMUNICATION
- Symptom: PASSENGER SEAT BELT TENSIONER CIRCUIT OPEN
- Symptom: PASSENGER SEAT BELT TENSIONER CIRCUIT SHORT
- Symptom: PASSENGER SEAT BELT TENSIONER SHORT TO BATTERY
- Symptom: PASSENGER SEAT BELT TENSIONER SHORT TO GROUND
- Symptom: PASSENGER SQUIB 1 CIRCUIT OPEN
- Symptom: PASSENGER SQUIB 1 CIRCUIT SHORT
- Symptom: PASSENGER SQUIB 1 SHORT TO BATTERY
- Symptom: PASSENGER SQUIB 1 SHORT TO GROUND
- Symptom: POWER SUPPLY VOLTAGE LOW
- Symptom: RIGHT CURTAIN OR SEAT SQUIB CIRCUIT OPEN
- Symptom: RIGHT CURTAIN OR SEAT SQUIB CIRCUIT SHORT
- Symptom: RIGHT CURTAIN OR SEAT SQUIB SHORT TO BATTERY
- Symptom: RIGHT CURTAIN OR SEAT SQUIB SHORT TO GROUND
- Symptom: RIGHT SIDE IMPACT SENSOR INTERNAL 1
- Symptom: VEHICLE BODY STYLE MISMATCH
- Symptom: *AIRBAG INDICATOR ON WITHOUT ACTIVE TROUBLE CODES
- Audio
- Symptom: ALL OUTPUTS SHORT
- Symptom: ANTENNA HARDWARE FAILURE - SDARS
- Symptom: ANTENNA NOT CONNECTED - SDARS
- Symptom: BUS BUSY - SDARS
- Symptom: BUS LOW - SDARS
- Symptom List: CASSETTE PLAYER INOP; CD MECHANICAL FAILURE; NO PCI TRANSMISSION; *AM/FM SWITCH INOPERATIVE; *ANY STATION PRESET SWITCH INOPERATIVE; *BALANCE INOPERATIVE; *CD EJECT SWITCH INOPERATIVE; *EQUALIZER INOPERATIVE; *FADER INOPERATIVE; *FF/RW SWITCH INOPERATIVE; *HOUR/MINUTE SWITCHES INOPERATIVE; *PAUSE/PLAY SWITCH INOPERATIVE; *PWR SWITCH INOPERATIVE; *SCAN SWITCH INOPERATIVE; *SEEK SWITCH INOPERATIVE; *SET SWITCH INOPERATIVE; *TAPE EJECT SWITCH INOPERATIVE; *TIME SWITCH INOPERATIVE; *TUNE SWITCH INOPERATIVE
- Symptom: CD PLAY FAILURE
- Symptom: CD READ FAILURE
- Symptom: CD TEMPERATURE HIGH
- Symptom: GPS ANTENNA NOT CONNECTED
- Symptom: INTERNAL FAILURE - SDARS
- Symptom: INTERNAL RECEIVER FAILURE - SDARS
- Symptom: LOW VOLTAGE LEVEL
- Symptom: NO ANTENNA CONNECTION
- Symptom: NO COMMUNICATION WITH SDARS
- Symptom: NO J1850 COMMUNICATION - SDARS
- Symptom: POWER AMP SHUTDOWN
- Symptom: RADIO AND NAV GPS ANTENNA NOT CONNECTED
- Symptom: *INOP NO FAULT CODES - SDARS
- Symptom: *POOR RECEPTION - SDARS
- Communication
- Symptom: *NO RESPONSE FROM AIRBAG CONTROL MODULE
- Symptom: *NO RESPONSE FROM AMPLIFIER
- Symptom: *NO RESPONSE FROM ANTILOCK BRAKE MODULE
- Symptom: *NO RESPONSE FROM ECM (PCI BUS) - DIESEL ONLY
- Symptom: *NO RESPONSE FROM ECM (SCI ONLY) - DIESEL ONLY
- Symptom: *NO RESPONSE FROM HANDS FREE MODULE
- Symptom: *NO RESPONSE FROM INSTRUMENT CLUSTER
- Symptom: *NO RESPONSE FROM OVERHEAD CONSOLE (COMPASS/TEMPERATURE MIRROR MODULE)
- Symptom: *NO RESPONSE FROM PCM (PCI BUS) - 1.6L
- Symptom: *NO RESPONSE FROM PCM (PCI BUS) - NGC
- Symptom: *NO RESPONSE FROM PCM (PCM SCI ONLY) - NGC
- Symptom: *NO RESPONSE FROM PCM (SCI ONLY) - 1.6L
- Symptom: *NO RESPONSE FROM RADIO
- Symptom: *NO RESPONSE FROM RKE
- Symptom: *NO RESPONSE FROM SATELLITE RADIO RECEIVER
- Symptom: *NO RESPONSE FROM SENTRY KEY IMMOBILIZER MODULE
- Symptom: *NO RESPONSE FROM TRANSMISSION CONTROL MODULE - NGC
- Symptom: *NO RESPONSE FROM WINDOW REGULATOR MODULE - PT27
- Symptom: *PCI BUS COMMUNICATION FAILURE
- Instrument Cluster
- Symptom List: ABS INDICATOR CIRCUIT OPEN; AIRBAG INDICATOR CIRCUIT OPEN
- Symptom List: ABS MESSAGE NOT RECEIVED; ACM MESSAGE NOT RECEIVED; EATX MESSAGE NOT RECEIVED; NO PCI TRANSMISSION; SBEC MESSAGE NOT RECEIVED; SKIM MESSAGE NOT RECEIVED
- Symptom: EATX MESSAGE MISMATCH
- Symptom: EEPROM CHECKSUM FAILURE
- Symptom: FUEL LEVEL SENSOR OPEN
- Symptom: FUEL LEVEL SENSOR SHORT
- Symptom: FUEL LEVEL SENSOR STUCK
- Symptom: PANEL DIMMER OPEN
- Symptom: PANEL DIMMER SHORTED
- Symptom: *ALL GAUGES INOPERATIVE
- Symptom: *ANY PCI BUS INDICATOR INOPERATIVE
- Symptom: *BRAKE WARNING INDICATOR ALWAYS ON
- Symptom: *BRAKE WARNING INDICATOR INOPERATIVE
- Symptom: *FRONT FOG LAMP INDICATOR INOPERATIVE
- Symptom: *FUEL GAUGE INACCURATE
- Symptom: *HIGH BEAM INDICATOR INOPERATIVE
- Symptom: *INSTRUMENT CLUSTER DIMMING INOPERATIVE
- Symptom: *LOW OIL PRESSURE INDICATOR ALWAYS ON
- Symptom: *LOW OIL PRESSURE INDICATOR INOPERATIVE
- Symptom: *ONE GAUGE INOPERATIVE
- Symptom: *PRND OR AUTOSTICK DISPLAY INOPERATIVE OR INACCURATE
- Symptom: *REAR FOG LAMP INDICATOR INOPERATIVE - BUX ONLY
- Symptom: *SEAT BELT INDICATOR NOT OPERATING PROPERLY
- Symptom: *VF DISPLAY INOPERATIVE
- Interior Lighting
- Overhead Console
- Power Door Locks/RKE
- Symptom: BODY STYLE MISMATCH
- Symptom: DRIVER DOOR SWITCH FAILURE
- Symptom: INCORRECT MODULE TYPE CONFIGURATION FOR PART NUMBER
- Symptom: MODULE NOT CONFIGURED FOR RKE
- Symptom: NO AIRBAG MESSAGES RECEIVED
- Symptom: NO PCM MESSAGES RECEIVED
- Symptom: NO SKIM MESSAGES RECEIVED
- Symptom: PASSENGER DOOR OR LIFTGATE SWITCH FAILURE - PT44
- Symptom:* ALL DOORS (EXCEPT DRIVER)FAIL TO LOCK
- Symptom: * ALL DOORS (EXCEPT DRIVER)FAIL TO LOCK AND UNLOCK
- Symptom:* ALL DOORS (EXCEPT DRIVER)FAIL TO UNLOCK
- Symptom: *ALL DOOR LOCKS INOPERATIVE
- Symptom: *ALL DOORS FAIL TO LOCK
- Symptom: *ALL DOORS FAIL TO UNLOCK
- Symptom: *ALL LOCKS INOPERATIVE FROM ONE LOCK SWITCH
- Symptom: *DECKLID RELEASE SWITCH INOPERATIVE - PT27
- Symptom: *DECKLID SOLENOID INOPERATIVE - PT27
- Symptom: *DOORS LOCKABLE WITH KEY IN IGNITION AND DRIVER DOOR OPEN
- Symptom: *DRIVER DOOR FAILS TO LOCK
- Symptom: *DRIVER DOOR FAILS TO LOCK AND UNLOCK
- Symptom: *DRIVER DOOR FAILS TO UNLOCK
- Symptom: *DRIVER DOOR FAILS UNLOCK - PT27
- Symptom: *LIFTGATE LOCK MOTOR FAILS TO LOCK OR UNLOCK
- Symptom: *ONE DOOR FAILS TO LOCK AND UNLOCK - PT27
- Symptom: *ONE PASSENGER DOOR FAILS TO LOCK AND UNLOCK
- Symptom: *PASSENGER DOOR FAILS TO UNLOCK - PT27
- Symptom: *RKE INOPERATIVE
- Power Top
- Symptom: AMBIENT TEMP MESSAGE NOT RECEIVED
- Symptom: POWER TOP RELAY CONTROL CIRCUIT OPEN
- Symptom: POWER TOP RELAY INOPERATIVE
- Symptom: POWER TOP SWITCH MUX CIRCUIT OPEN
- Symptom: POWER TOP SWITCH MUX CIRCUIT SHORT TO GROUND
- Symptom: POWER TOP SWITCH MUX CIRCUIT VALUE OUT OF RANGE
- Symptom: SPEED MESSAGE NOT RECEIVED
- Power Windows
- Symptom: BATTERY VOLTAGE TOO HIGH
- Symptom: BATTERY VOLTAGE TOO LOW
- Symptom: FRONT WINDOW MOTOR MALFUNCTION
- Symptom: FRONT WINDOW SWITCH MUX CIRCUIT OPEN
- Symptom: FRONT WINDOW SWITCH MUX CIRCUIT SHORT TO GROUND
- Symptom: FRONT WINDOW SWITCH MUX CIRCUIT VALUE OUT OF RANGE
- Symptom: IGNITION SWITCH OUTPUT OPEN
- Symptom: REAR WINDOW MOTOR CIRCUIT OPEN OR SHORTED
- Symptom: REAR WINDOW SWITCH MUX CIRCUIT OPEN
- Symptom: REAR WINDOW SWITCH MUX CIRCUIT SHORT TO GROUND
- Symptom: REAR WINDOW SWITCH MUX CIRCUIT VALUE OUT OF RANGE
- Symptom: WINDOW DROP SWITCH SENSE CIRCUIT OPEN
- Symptom: *DOOR AJAR CIRCUIT OPEN
- Symptom: *DOOR WINDOWS STAY IN DROP DOWN POSITION
- Symptom: *WINDOW DROPS OR JERKS DURING OPENING
- Telecommunication
- Symptom: AUDIO HARDWARE MESSAGE NOT RECEIVED
- Symptom List: BLUETOOTH ERROR; FLASH CHECKSUM ERROR; FLASH WRITE ERROR; PCI BUS INTERNAL ERROR; RAM WRITE ERROR; ROM CHECKSUM ERROR
- Symptom List: BODY STYLE MESSAGE NOT RECEIVED; INVALID BODY STYLE
- Symptom: GENERAL MICROPHONE FAULT
- Symptom: IGNITION POWER MESSAGE NOT RECEIVED
- Symptom List: LEFT AUDIO INPUT SHORT TO GROUND; LEFT AUDIO INPUT SHORT TO VOLTAGE; LEFT AUDIO OUTPUT 1 SHORT TO GROUND; LEFT AUDIO OUTPUT 1 SHORT TO VOLTAGE
- Symptom List: MIRROR POWER CIRCUIT SHORT TO GROUND; MIRROR POWER CIRCUIT SHORT TO VOLTAGE
- Symptom List: PCI BUS BUSY; PCI BUS CIRCUIT OPEN; PCI BUS CIRCUIT SHORT TO GROUND; PCI BUS CIRCUIT SHORT TO VOLTAGE
- Symptom List: PHONE SWITCH STUCK; VOICE RECOGNITION SWITCH STUCK' VOICE RECOGNITION/PHONE SWITCH CIRCUIT RATIONALITY; VOICE RECOGNITION/PHONE SWITCH CIRCUIT SHORT TO GROUND; VOICE RECOGNITION/PHONE SWITCH CIRCUIT SHORT TO VOLTAGE
- Symptom: PRNDL MESSAGE NOT RECEIVED
- Symptom: RADIO MESSAGE NOT RECEIVED
- Symptom List: RIGHT AUDIO INPUT SHORT TO GROUND; RIGHT AUDIO INPUT SHORT TO VOLTAGE; RIGHT AUDIO OUTPUT 1 SHORT TO GROUND; RIGHT AUDIO OUTPUT 1 SHORT TO VOLTAGE
- Symptom: RPM MESSAGE NOT RECEIVED
- Symptom: VIN MESSAGE NOT RECEIVED
- Symptom: VIN MISMATCH
- Vehicle Theft/Security
- Symptom: HOOD AJAR SWITCH MISSING (EXPORT ONLY)
- Symptom: MODULE PREVIOUSLY CONFIGURED FOR VTSS
- Symptom: *ALARM TRIPS ON ITS OWN
- Symptom: *HEADLAMPS FAIL TO FLASH DURING ALARM
- Symptom: *HORN FAILS TO SOUND DURING ALARM
- Symptom: *INTRUSION SENSOR CANNOT BE DISABLED (EXPORT ONLY)
- Symptom: *INTRUSION SENSOR FAILS TO TRIP VTSS (EXPORT ONLY)
- Symptom: *INTRUSION SENSOR REPEATEDLY TRIGGERS VTSS (EXPORT ONLY)
- Symptom: *OPEN DRIVER DOOR FAILS TO TRIP ALARM
- Symptom: *OPEN LIFTGATE FAILS TO TRIP ALARM
- Symptom: *OPEN PASSENGER DOOR FAILS TO TRIP ALARM
- Symptom: *PARK LAMPS FAIL TO FLASH DURING ALARM
- Symptom List: *VTSS FAILS TO ARM FROM LEFT DOOR CYLINDER LOCK SWITCH (EXPORT ONLY); *VTSS FAILS TO ARM/DISARM FROM LEFT DOOR CYLINDER LOCK SWITCH
- Symptom List: *VTSS FAILS TO ARM FROM LIFTGATE CYLINDER LOCK SWITCH (EXPORT ONLY); *VTSS FAILS TO ARM/DISARM FROM LIFTGATE CYLINDER LOCK SWITCH
- Symptom List: *VTSS FAILS TO ARM FROM RIGHT DOOR CYLINDER LOCK SWITCH (EXPORT ONLY); *VTSS FAILS TO ARM/DISARM FROM RIGHT DOOR CYLINDER LOCK SWITCH
- Symptom: *VTSS INDICATOR FAILS TO FLASH
- Symptom: *VTSS INDICATOR STAYS ON STEADY DURING ARMING
- Symptom: *VTSS SIREN INOPERATIVE (EXPORT ONLY)
- Verifications Tests
- Airbag
- Component Locations
- Connector PINOUTS
- Airbag Control Module (Orc) (Base) - Yellow 23 Way
- Airbag Control Module C1 (Orc) (Premium) - Yellow 32 Way
- Airbag Control Module C2 (Orc) (Premium) - Yellow 32 Way
- Ambient Temperature Sensor (Except 2.4L Base) - Black 2 Way
- Amplifier Audio C1 - 20 Way
- Anti-Lock Brake Module - Black 47 Way
- C203 (Pt27) - LT. Gray (Body Side)
- C203 (Pt27) - LT. Gray (Instrument Panel Side)
- C204 (Pt27) - (Instrument Panel Side)
- C204 (Pt27) - (Left Front Door Side)
- C204 (Pt44 LHP) - Natural (Instrument Panel Side)
- C204 (Pt44 LHP) - Natural (Left Front Door Side)
- C205 (Pt27) - (Instrument Panel Side)
- C205 (Pt27) - (Right Front Door Side)
- C305 - Yellow (Airbag Side)
- C305 - Yellow (UNIBODY Side)
- C306 - Yellow (Airbag Side)
- C306 - Yellow (UNIBODY Side)
- C343 (Pt27) - LT. Gray (DECKLID Jumper Side)
- C343 (Pt27) - LT. Gray (DECKLID Side)
- C349 (Pt27) - Blue (Body Side
- C349 (Pt27) - Blue (DECKLID Jumper Side)
- C362 (Pt27) - LT. Gray (Body Side)
- C362 (Pt27) - LT. Gray (Power Top Side)
- CLOCKSPRING - DK. Green 7 Way
- Compass/Temperature Mirror Module (Pt27) - Black 10 Way
- Data Link Connector - Black 16 Way
- DECKLID Cylinder Unlock Switch (Pt27) - LT. Gray 2 Way
- DECKLID Handle Switch (Pt27) - White 2 Way
- DECKLID Release Motor (Pt27) - Black 3 Way
- DECKLID Release Switch (Pt27) - Black 2 Way
- Dome Lamp - Black 3 Way
- Dome Lamp/Intrusion Sensor (Export) - White 4 Way
- Driver Airbag Squib 1 - Yellow 2 Way
- Driver Door Ajar Switch - Black 2 Way
- Driver Door Handle Switch (Pt27) - 2 Way
- Driver Door Power Lock Motor/Ajar Switch - Black 4 Way
- Driver Rear Window Motor (Pt27) - Black 2 Way
- Driver Seat Belt TENSIONER - Yellow 2 Way
- Driver Window Regulator Module (Pt27) - Black 20 Way
- Engine Control Module C1 (Diesel) - Black 81 Way
- Front Power Window Switch - Black 14 Way
- Fuel Pump Module - LT. Gray 4 Way
- Fuses (FB)
- Hands Free Module C1 - DK. Gray 22 Way
- Hands Free Module C2 (Satellite Radio) - DK. Gray 10 Way
- Hands Free Module C3 - Black 10 Way
- High Note Horn (Export) - Black 2 Way
- Hood Ajar Switch (Export) - Black 2 Way
- Ignition Switch C1 - 10 Way
- Instrument Cluster C1 - Black 26 Way
- Instrument Cluster C2 - Black 10 Way
- Left Cylinder Lock Switch - Black 2 Way
- Left Door Lock Switch - Black 3 Way
- Left Front Power Window Motor (Pt44) - Black 2 Way
- Left Instrument Panel Speaker - Black 2 Way
- Left Rear Speaker (Pt44) - Black 2 Way
- Left Seat Airbag Squib (LHP) - Yellow 2 Way
- Left Seat Airbag Squib (RHD) - Yellow 2 Way
- Left Side Impact Sensor 1 - Gray 2 Way
- Liftgate Ajar Switch - White 2 Way
- Liftgate Cylinder Lock Switch - LT. Gray 2 Way
- Liftgate Handle Switch (Pt44) - Natural 2 Way
- Liftgate Power Lock Motor - Black 4 Way
- Liftgate Release Motor (Pt44) - Black 3 Way
- Low Note Horn - Black 2 Way
- Multi-Function Switch - Gray 20 Way
- Overhead Console Module - Black 12 Way
- Passenger Airbag Squib 1 - Yellow 2 Way
- Passenger Door Ajar Switch - Black 2 Way
- Passenger Door Handle Switch (Pt27) - 2 Way
- Passenger Door Power Lock Motor/Ajar Switch - Black 4 Way
- Passenger Rear Window Motor (Pt27) - Black 2 Way
- Passenger Seat Belt TENSIONER - Yellow 2 Way
- Passenger Window Regulator Module (Pt27) - Black 20 Way
- Fuses (PDC)
- Power Top Motor (Pt27) - 2 Way
- Power Top Relay (Pt27) - Black 6 Way
- Power Top Switch (Pt27) - 3 Way
- Powertrain Control Module (1.6L) - Black 90 Way
- Powertrain Control Module C1 (NGC) - Black/Black 38 Way
- Radio C1 - White 22 Way
- Radio C2 (Hands Free) - DK. Gray 10 Way
- Rear View Mirror C1 - Black 12 Way
- Remote Keyless Entry Module - Black 26 Way
- Right Cylinder Lock Switch (Export) - Black 2 Way
- Right Door Lock Switch - Black 3 Way
- Right Front Door Speaker - 3 Way
- Right Front Power Window Motor (Pt44) - Black 2 Way
- Right Rear Power Window Motor (Pt44) - Black 2 Way
- Right Seat Airbag Squib (LHP) - Yellow 2 Way
- Right Seat Airbag Squib (RHP) - Yellow 2 Way
- Right Side Impact Sensor 1 - Gray 2 Way
- Sentry Key Immobilizer Module - Black 6 Way
- Siren (Export) - Black 4 Way
- Schematic Diagrams
- Electronic Control Modules
- HOMELINK Universal Transmitter
- Message Systems
- Body Diagnostic Procedures
- Cruise Control Systems
- Entertainment Systems
- Audio System
- Body Diagnostic Procedures
- Introduction
- Identification Of System
- System Description And Functional Operation
- Notes
- Airbag System
- Audio System
- Compass/Temperature Module (CTM)
- Compass/Temperature Mirror
- Description
- Operation
- English / Metric / Off Mode
- Calibration / Zone Mode
- Setting Compass Zone
- First Time Calibration
- Manual Calibration
- Continuous Calibration
- Self-Check Diagnostic
- Outside Temperature
- Temperature Update - Warm
- Temperature Update - Cold
- Extreme Temperature / Open Or Short Condition
- Ambient Temperature Sensor
- Ambient Temperature Sensor Diagnostics
- Instrument Cluster
- Remote Keyless Entry Module
- Sentry Key Immobilizer System (Skis)
- Communication
- Telecommunications
- Window Regulator Modules (Pt27 Only)
- Using The DRBIII®
- Disclaimers, Safety, Warnings
- Required Tools And Equipment
- Glossary Of Terms
- Diagnostic Information And Procedures
- Airbag
- Symptom List: ACCELEROMETER 1; INTERNAL 1; INTERNAL 2; INTERNAL 3; INTERNAL 4' OUTPUT DRIVER 1; OUTPUT DRIVER 2; STORED ENERGY FIRING 1
- Symptom List: AIRBAG WARNING INDICATOR DRIVER; AIRBAG WARNING INDICATOR OPEN; AIRBAG WARNING INDICATOR SHORT
- Symptom: CALIBRATION MISMATCH
- Symptom: CLUSTER MESSAGE MISMATCH
- Symptom: DRIVER SEAT BELT TENSIONER CIRCUIT OPEN
- Symptom: DRIVER SEAT BELT TENSIONER CIRCUIT SHORT
- Symptom: DRIVER SEAT BELT TENSIONER SHORT TO BATTERY
- Symptom: DRIVER SEAT BELT TENSIONER SHORT TO GROUND
- Symptom: DRIVER SQUIB 1 CIRCUIT OPEN
- Symptom: DRIVER SQUIB 1 CIRCUIT SHORT
- Symptom: DRIVER SQUIB 1 SHORT TO BATTERY
- Symptom: DRIVER SQUIB 1 SHORT TO GROUND
- Symptom: LEFT CURTAIN OR SEAT SQUIB CIRCUIT OPEN
- Symptom: LEFT CURTAIN OR SEAT SQUIB CIRCUIT SHORT
- Symptom: LEFT CURTAIN OR SEAT SQUIB SHORT TO BATTERY
- Symptom: LEFT CURTAIN OR SEAT SQUIB SHORT TO GROUND
- Symptom: LEFT SIDE IMPACT SENSOR 1 INTERNAL 1
- Symptom: LOSS OF IGNITION RUN - START
- Symptom: LOSS OF IGNITION RUN ONLY
- Symptom: NO CLUSTER MESSAGE
- Symptom: NO LEFT SIDE IMPACT SENSOR 1 COMMUNICATION
- Symptom: NO ODOMETER MESSAGE
- Symptom: NO PCI TRANSMISSION
- Symptom: NO RIGHT SIDE IMPACT SENSOR 1 COMMUNICATION
- Symptom: PASSENGER SEAT BELT TENSIONER CIRCUIT OPEN
- Symptom: PASSENGER SEAT BELT TENSIONER CIRCUIT SHORT
- Symptom: PASSENGER SEAT BELT TENSIONER SHORT TO BATTERY
- Symptom: PASSENGER SEAT BELT TENSIONER SHORT TO GROUND
- Symptom: PASSENGER SQUIB 1 CIRCUIT OPEN
- Symptom: PASSENGER SQUIB 1 CIRCUIT SHORT
- Symptom: PASSENGER SQUIB 1 SHORT TO BATTERY
- Symptom: PASSENGER SQUIB 1 SHORT TO GROUND
- Symptom: POWER SUPPLY VOLTAGE LOW
- Symptom: RIGHT CURTAIN OR SEAT SQUIB CIRCUIT OPEN
- Symptom: RIGHT CURTAIN OR SEAT SQUIB CIRCUIT SHORT
- Symptom: RIGHT CURTAIN OR SEAT SQUIB SHORT TO BATTERY
- Symptom: RIGHT CURTAIN OR SEAT SQUIB SHORT TO GROUND
- Symptom: RIGHT SIDE IMPACT SENSOR INTERNAL 1
- Symptom: VEHICLE BODY STYLE MISMATCH
- Symptom: *AIRBAG INDICATOR ON WITHOUT ACTIVE TROUBLE CODES
- Audio
- Symptom: ALL OUTPUTS SHORT
- Symptom: ANTENNA HARDWARE FAILURE - SDARS
- Symptom: ANTENNA NOT CONNECTED - SDARS
- Symptom: BUS BUSY - SDARS
- Symptom: BUS LOW - SDARS
- Symptom List: CASSETTE PLAYER INOP; CD MECHANICAL FAILURE; NO PCI TRANSMISSION; *AM/FM SWITCH INOPERATIVE; *ANY STATION PRESET SWITCH INOPERATIVE; *BALANCE INOPERATIVE; *CD EJECT SWITCH INOPERATIVE; *EQUALIZER INOPERATIVE; *FADER INOPERATIVE; *FF/RW SWITCH INOPERATIVE; *HOUR/MINUTE SWITCHES INOPERATIVE; *PAUSE/PLAY SWITCH INOPERATIVE; *PWR SWITCH INOPERATIVE; *SCAN SWITCH INOPERATIVE; *SEEK SWITCH INOPERATIVE; *SET SWITCH INOPERATIVE; *TAPE EJECT SWITCH INOPERATIVE; *TIME SWITCH INOPERATIVE; *TUNE SWITCH INOPERATIVE
- Symptom: CD PLAY FAILURE
- Symptom: CD READ FAILURE
- Symptom: CD TEMPERATURE HIGH
- Symptom: GPS ANTENNA NOT CONNECTED
- Symptom: INTERNAL FAILURE - SDARS
- Symptom: INTERNAL RECEIVER FAILURE - SDARS
- Symptom: LOW VOLTAGE LEVEL
- Symptom: NO ANTENNA CONNECTION
- Symptom: NO COMMUNICATION WITH SDARS
- Symptom: NO J1850 COMMUNICATION - SDARS
- Symptom: POWER AMP SHUTDOWN
- Symptom: RADIO AND NAV GPS ANTENNA NOT CONNECTED
- Symptom: *INOP NO FAULT CODES - SDARS
- Symptom: *POOR RECEPTION - SDARS
- Communication
- Symptom: *NO RESPONSE FROM AIRBAG CONTROL MODULE
- Symptom: *NO RESPONSE FROM AMPLIFIER
- Symptom: *NO RESPONSE FROM ANTILOCK BRAKE MODULE
- Symptom: *NO RESPONSE FROM ECM (PCI BUS) - DIESEL ONLY
- Symptom: *NO RESPONSE FROM ECM (SCI ONLY) - DIESEL ONLY
- Symptom: *NO RESPONSE FROM HANDS FREE MODULE
- Symptom: *NO RESPONSE FROM INSTRUMENT CLUSTER
- Symptom: *NO RESPONSE FROM OVERHEAD CONSOLE (COMPASS/TEMPERATURE MIRROR MODULE)
- Symptom: *NO RESPONSE FROM PCM (PCI BUS) - 1.6L
- Symptom: *NO RESPONSE FROM PCM (PCI BUS) - NGC
- Symptom: *NO RESPONSE FROM PCM (PCM SCI ONLY) - NGC
- Symptom: *NO RESPONSE FROM PCM (SCI ONLY) - 1.6L
- Symptom: *NO RESPONSE FROM RADIO
- Symptom: *NO RESPONSE FROM RKE
- Symptom: *NO RESPONSE FROM SATELLITE RADIO RECEIVER
- Symptom: *NO RESPONSE FROM SENTRY KEY IMMOBILIZER MODULE
- Symptom: *NO RESPONSE FROM TRANSMISSION CONTROL MODULE - NGC
- Symptom: *NO RESPONSE FROM WINDOW REGULATOR MODULE - PT27
- Symptom: *PCI BUS COMMUNICATION FAILURE
- Instrument Cluster
- Symptom List: ABS INDICATOR CIRCUIT OPEN; AIRBAG INDICATOR CIRCUIT OPEN
- Symptom List: ABS MESSAGE NOT RECEIVED; ACM MESSAGE NOT RECEIVED; EATX MESSAGE NOT RECEIVED; NO PCI TRANSMISSION; SBEC MESSAGE NOT RECEIVED; SKIM MESSAGE NOT RECEIVED
- Symptom: EATX MESSAGE MISMATCH
- Symptom: EEPROM CHECKSUM FAILURE
- Symptom: FUEL LEVEL SENSOR OPEN
- Symptom: FUEL LEVEL SENSOR SHORT
- Symptom: FUEL LEVEL SENSOR STUCK
- Symptom: PANEL DIMMER OPEN
- Symptom: PANEL DIMMER SHORTED
- Symptom: *ALL GAUGES INOPERATIVE
- Symptom: *ANY PCI BUS INDICATOR INOPERATIVE
- Symptom: *BRAKE WARNING INDICATOR ALWAYS ON
- Symptom: *BRAKE WARNING INDICATOR INOPERATIVE
- Symptom: *FRONT FOG LAMP INDICATOR INOPERATIVE
- Symptom: *FUEL GAUGE INACCURATE
- Symptom: *HIGH BEAM INDICATOR INOPERATIVE
- Symptom: *INSTRUMENT CLUSTER DIMMING INOPERATIVE
- Symptom: *LOW OIL PRESSURE INDICATOR ALWAYS ON
- Symptom: *LOW OIL PRESSURE INDICATOR INOPERATIVE
- Symptom: *ONE GAUGE INOPERATIVE
- Symptom: *PRND OR AUTOSTICK DISPLAY INOPERATIVE OR INACCURATE
- Symptom: *REAR FOG LAMP INDICATOR INOPERATIVE - BUX ONLY
- Symptom: *SEAT BELT INDICATOR NOT OPERATING PROPERLY
- Symptom: *VF DISPLAY INOPERATIVE
- Interior Lighting
- Overhead Console
- Power Door Locks/RKE
- Symptom: BODY STYLE MISMATCH
- Symptom: DRIVER DOOR SWITCH FAILURE
- Symptom: INCORRECT MODULE TYPE CONFIGURATION FOR PART NUMBER
- Symptom: MODULE NOT CONFIGURED FOR RKE
- Symptom: NO AIRBAG MESSAGES RECEIVED
- Symptom: NO PCM MESSAGES RECEIVED
- Symptom: NO SKIM MESSAGES RECEIVED
- Symptom: PASSENGER DOOR OR LIFTGATE SWITCH FAILURE - PT44
- Symptom:* ALL DOORS (EXCEPT DRIVER)FAIL TO LOCK
- Symptom: * ALL DOORS (EXCEPT DRIVER)FAIL TO LOCK AND UNLOCK
- Symptom:* ALL DOORS (EXCEPT DRIVER)FAIL TO UNLOCK
- Symptom: *ALL DOOR LOCKS INOPERATIVE
- Symptom: *ALL DOORS FAIL TO LOCK
- Symptom: *ALL DOORS FAIL TO UNLOCK
- Symptom: *ALL LOCKS INOPERATIVE FROM ONE LOCK SWITCH
- Symptom: *DECKLID RELEASE SWITCH INOPERATIVE - PT27
- Symptom: *DECKLID SOLENOID INOPERATIVE - PT27
- Symptom: *DOORS LOCKABLE WITH KEY IN IGNITION AND DRIVER DOOR OPEN
- Symptom: *DRIVER DOOR FAILS TO LOCK
- Symptom: *DRIVER DOOR FAILS TO LOCK AND UNLOCK
- Symptom: *DRIVER DOOR FAILS TO UNLOCK
- Symptom: *DRIVER DOOR FAILS UNLOCK - PT27
- Symptom: *LIFTGATE LOCK MOTOR FAILS TO LOCK OR UNLOCK
- Symptom: *ONE DOOR FAILS TO LOCK AND UNLOCK - PT27
- Symptom: *ONE PASSENGER DOOR FAILS TO LOCK AND UNLOCK
- Symptom: *PASSENGER DOOR FAILS TO UNLOCK - PT27
- Symptom: *RKE INOPERATIVE
- Power Top
- Symptom: AMBIENT TEMP MESSAGE NOT RECEIVED
- Symptom: POWER TOP RELAY CONTROL CIRCUIT OPEN
- Symptom: POWER TOP RELAY INOPERATIVE
- Symptom: POWER TOP SWITCH MUX CIRCUIT OPEN
- Symptom: POWER TOP SWITCH MUX CIRCUIT SHORT TO GROUND
- Symptom: POWER TOP SWITCH MUX CIRCUIT VALUE OUT OF RANGE
- Symptom: SPEED MESSAGE NOT RECEIVED
- Power Windows
- Symptom: BATTERY VOLTAGE TOO HIGH
- Symptom: BATTERY VOLTAGE TOO LOW
- Symptom: FRONT WINDOW MOTOR MALFUNCTION
- Symptom: FRONT WINDOW SWITCH MUX CIRCUIT OPEN
- Symptom: FRONT WINDOW SWITCH MUX CIRCUIT SHORT TO GROUND
- Symptom: FRONT WINDOW SWITCH MUX CIRCUIT VALUE OUT OF RANGE
- Symptom: IGNITION SWITCH OUTPUT OPEN
- Symptom: REAR WINDOW MOTOR CIRCUIT OPEN OR SHORTED
- Symptom: REAR WINDOW SWITCH MUX CIRCUIT OPEN
- Symptom: REAR WINDOW SWITCH MUX CIRCUIT SHORT TO GROUND
- Symptom: REAR WINDOW SWITCH MUX CIRCUIT VALUE OUT OF RANGE
- Symptom: WINDOW DROP SWITCH SENSE CIRCUIT OPEN
- Symptom: *DOOR AJAR CIRCUIT OPEN
- Symptom: *DOOR WINDOWS STAY IN DROP DOWN POSITION
- Symptom: *WINDOW DROPS OR JERKS DURING OPENING
- Telecommunication
- Symptom: AUDIO HARDWARE MESSAGE NOT RECEIVED
- Symptom List: BLUETOOTH ERROR; FLASH CHECKSUM ERROR; FLASH WRITE ERROR; PCI BUS INTERNAL ERROR; RAM WRITE ERROR; ROM CHECKSUM ERROR
- Symptom List: BODY STYLE MESSAGE NOT RECEIVED; INVALID BODY STYLE
- Symptom: GENERAL MICROPHONE FAULT
- Symptom: IGNITION POWER MESSAGE NOT RECEIVED
- Symptom List: LEFT AUDIO INPUT SHORT TO GROUND; LEFT AUDIO INPUT SHORT TO VOLTAGE; LEFT AUDIO OUTPUT 1 SHORT TO GROUND; LEFT AUDIO OUTPUT 1 SHORT TO VOLTAGE
- Symptom List: MIRROR POWER CIRCUIT SHORT TO GROUND; MIRROR POWER CIRCUIT SHORT TO VOLTAGE
- Symptom List: PCI BUS BUSY; PCI BUS CIRCUIT OPEN; PCI BUS CIRCUIT SHORT TO GROUND; PCI BUS CIRCUIT SHORT TO VOLTAGE
- Symptom List: PHONE SWITCH STUCK; VOICE RECOGNITION SWITCH STUCK' VOICE RECOGNITION/PHONE SWITCH CIRCUIT RATIONALITY; VOICE RECOGNITION/PHONE SWITCH CIRCUIT SHORT TO GROUND; VOICE RECOGNITION/PHONE SWITCH CIRCUIT SHORT TO VOLTAGE
- Symptom: PRNDL MESSAGE NOT RECEIVED
- Symptom: RADIO MESSAGE NOT RECEIVED
- Symptom List: RIGHT AUDIO INPUT SHORT TO GROUND; RIGHT AUDIO INPUT SHORT TO VOLTAGE; RIGHT AUDIO OUTPUT 1 SHORT TO GROUND; RIGHT AUDIO OUTPUT 1 SHORT TO VOLTAGE
- Symptom: RPM MESSAGE NOT RECEIVED
- Symptom: VIN MESSAGE NOT RECEIVED
- Symptom: VIN MISMATCH
- Vehicle Theft/Security
- Symptom: HOOD AJAR SWITCH MISSING (EXPORT ONLY)
- Symptom: MODULE PREVIOUSLY CONFIGURED FOR VTSS
- Symptom: *ALARM TRIPS ON ITS OWN
- Symptom: *HEADLAMPS FAIL TO FLASH DURING ALARM
- Symptom: *HORN FAILS TO SOUND DURING ALARM
- Symptom: *INTRUSION SENSOR CANNOT BE DISABLED (EXPORT ONLY)
- Symptom: *INTRUSION SENSOR FAILS TO TRIP VTSS (EXPORT ONLY)
- Symptom: *INTRUSION SENSOR REPEATEDLY TRIGGERS VTSS (EXPORT ONLY)
- Symptom: *OPEN DRIVER DOOR FAILS TO TRIP ALARM
- Symptom: *OPEN LIFTGATE FAILS TO TRIP ALARM
- Symptom: *OPEN PASSENGER DOOR FAILS TO TRIP ALARM
- Symptom: *PARK LAMPS FAIL TO FLASH DURING ALARM
- Symptom List: *VTSS FAILS TO ARM FROM LEFT DOOR CYLINDER LOCK SWITCH (EXPORT ONLY); *VTSS FAILS TO ARM/DISARM FROM LEFT DOOR CYLINDER LOCK SWITCH
- Symptom List: *VTSS FAILS TO ARM FROM LIFTGATE CYLINDER LOCK SWITCH (EXPORT ONLY); *VTSS FAILS TO ARM/DISARM FROM LIFTGATE CYLINDER LOCK SWITCH
- Symptom List: *VTSS FAILS TO ARM FROM RIGHT DOOR CYLINDER LOCK SWITCH (EXPORT ONLY); *VTSS FAILS TO ARM/DISARM FROM RIGHT DOOR CYLINDER LOCK SWITCH
- Symptom: *VTSS INDICATOR FAILS TO FLASH
- Symptom: *VTSS INDICATOR STAYS ON STEADY DURING ARMING
- Symptom: *VTSS SIREN INOPERATIVE (EXPORT ONLY)
- Verifications Tests
- Airbag
- Component Locations
- Connector PINOUTS
- Airbag Control Module (Orc) (Base) - Yellow 23 Way
- Airbag Control Module C1 (Orc) (Premium) - Yellow 32 Way
- Airbag Control Module C2 (Orc) (Premium) - Yellow 32 Way
- Ambient Temperature Sensor (Except 2.4L Base) - Black 2 Way
- Amplifier Audio C1 - 20 Way
- Anti-Lock Brake Module - Black 47 Way
- C203 (Pt27) - LT. Gray (Body Side)
- C203 (Pt27) - LT. Gray (Instrument Panel Side)
- C204 (Pt27) - (Instrument Panel Side)
- C204 (Pt27) - (Left Front Door Side)
- C204 (Pt44 LHP) - Natural (Instrument Panel Side)
- C204 (Pt44 LHP) - Natural (Left Front Door Side)
- C205 (Pt27) - (Instrument Panel Side)
- C205 (Pt27) - (Right Front Door Side)
- C305 - Yellow (Airbag Side)
- C305 - Yellow (UNIBODY Side)
- C306 - Yellow (Airbag Side)
- C306 - Yellow (UNIBODY Side)
- C343 (Pt27) - LT. Gray (DECKLID Jumper Side)
- C343 (Pt27) - LT. Gray (DECKLID Side)
- C349 (Pt27) - Blue (Body Side
- C349 (Pt27) - Blue (DECKLID Jumper Side)
- C362 (Pt27) - LT. Gray (Body Side)
- C362 (Pt27) - LT. Gray (Power Top Side)
- CLOCKSPRING - DK. Green 7 Way
- Compass/Temperature Mirror Module (Pt27) - Black 10 Way
- Data Link Connector - Black 16 Way
- DECKLID Cylinder Unlock Switch (Pt27) - LT. Gray 2 Way
- DECKLID Handle Switch (Pt27) - White 2 Way
- DECKLID Release Motor (Pt27) - Black 3 Way
- DECKLID Release Switch (Pt27) - Black 2 Way
- Dome Lamp - Black 3 Way
- Dome Lamp/Intrusion Sensor (Export) - White 4 Way
- Driver Airbag Squib 1 - Yellow 2 Way
- Driver Door Ajar Switch - Black 2 Way
- Driver Door Handle Switch (Pt27) - 2 Way
- Driver Door Power Lock Motor/Ajar Switch - Black 4 Way
- Driver Rear Window Motor (Pt27) - Black 2 Way
- Driver Seat Belt TENSIONER - Yellow 2 Way
- Driver Window Regulator Module (Pt27) - Black 20 Way
- Engine Control Module C1 (Diesel) - Black 81 Way
- Front Power Window Switch - Black 14 Way
- Fuel Pump Module - LT. Gray 4 Way
- Fuses (FB)
- Hands Free Module C1 - DK. Gray 22 Way
- Hands Free Module C2 (Satellite Radio) - DK. Gray 10 Way
- Hands Free Module C3 - Black 10 Way
- High Note Horn (Export) - Black 2 Way
- Hood Ajar Switch (Export) - Black 2 Way
- Ignition Switch C1 - 10 Way
- Instrument Cluster C1 - Black 26 Way
- Instrument Cluster C2 - Black 10 Way
- Left Cylinder Lock Switch - Black 2 Way
- Left Door Lock Switch - Black 3 Way
- Left Front Power Window Motor (Pt44) - Black 2 Way
- Left Instrument Panel Speaker - Black 2 Way
- Left Rear Speaker (Pt44) - Black 2 Way
- Left Seat Airbag Squib (LHP) - Yellow 2 Way
- Left Seat Airbag Squib (RHD) - Yellow 2 Way
- Left Side Impact Sensor 1 - Gray 2 Way
- Liftgate Ajar Switch - White 2 Way
- Liftgate Cylinder Lock Switch - LT. Gray 2 Way
- Liftgate Handle Switch (Pt44) - Natural 2 Way
- Liftgate Power Lock Motor - Black 4 Way
- Liftgate Release Motor (Pt44) - Black 3 Way
- Low Note Horn - Black 2 Way
- Multi-Function Switch - Gray 20 Way
- Overhead Console Module - Black 12 Way
- Passenger Airbag Squib 1 - Yellow 2 Way
- Passenger Door Ajar Switch - Black 2 Way
- Passenger Door Handle Switch (Pt27) - 2 Way
- Passenger Door Power Lock Motor/Ajar Switch - Black 4 Way
- Passenger Rear Window Motor (Pt27) - Black 2 Way
- Passenger Seat Belt TENSIONER - Yellow 2 Way
- Passenger Window Regulator Module (Pt27) - Black 20 Way
- Fuses (PDC)
- Power Top Motor (Pt27) - 2 Way
- Power Top Relay (Pt27) - Black 6 Way
- Power Top Switch (Pt27) - 3 Way
- Powertrain Control Module (1.6L) - Black 90 Way
- Powertrain Control Module C1 (NGC) - Black/Black 38 Way
- Radio C1 - White 22 Way
- Radio C2 (Hands Free) - DK. Gray 10 Way
- Rear View Mirror C1 - Black 12 Way
- Remote Keyless Entry Module - Black 26 Way
- Right Cylinder Lock Switch (Export) - Black 2 Way
- Right Door Lock Switch - Black 3 Way
- Right Front Door Speaker - 3 Way
- Right Front Power Window Motor (Pt44) - Black 2 Way
- Right Rear Power Window Motor (Pt44) - Black 2 Way
- Right Seat Airbag Squib (LHP) - Yellow 2 Way
- Right Seat Airbag Squib (RHP) - Yellow 2 Way
- Right Side Impact Sensor 1 - Gray 2 Way
- Sentry Key Immobilizer Module - Black 6 Way
- Siren (Export) - Black 4 Way
- Schematic Diagrams
- Exterior Lights
- Body Diagnostic Procedures
- Introduction
- Identification Of System
- System Description And Functional Operation
- Notes
- Airbag System
- Audio System
- Compass/Temperature Module (CTM)
- Compass/Temperature Mirror
- Description
- Operation
- English / Metric / Off Mode
- Calibration / Zone Mode
- Setting Compass Zone
- First Time Calibration
- Manual Calibration
- Continuous Calibration
- Self-Check Diagnostic
- Outside Temperature
- Temperature Update - Warm
- Temperature Update - Cold
- Extreme Temperature / Open Or Short Condition
- Ambient Temperature Sensor
- Ambient Temperature Sensor Diagnostics
- Instrument Cluster
- Remote Keyless Entry Module
- Sentry Key Immobilizer System (Skis)
- Communication
- Telecommunications
- Window Regulator Modules (Pt27 Only)
- Using The DRBIII®
- Disclaimers, Safety, Warnings
- Required Tools And Equipment
- Glossary Of Terms
- Diagnostic Information And Procedures
- Airbag
- Symptom List: ACCELEROMETER 1; INTERNAL 1; INTERNAL 2; INTERNAL 3; INTERNAL 4' OUTPUT DRIVER 1; OUTPUT DRIVER 2; STORED ENERGY FIRING 1
- Symptom List: AIRBAG WARNING INDICATOR DRIVER; AIRBAG WARNING INDICATOR OPEN; AIRBAG WARNING INDICATOR SHORT
- Symptom: CALIBRATION MISMATCH
- Symptom: CLUSTER MESSAGE MISMATCH
- Symptom: DRIVER SEAT BELT TENSIONER CIRCUIT OPEN
- Symptom: DRIVER SEAT BELT TENSIONER CIRCUIT SHORT
- Symptom: DRIVER SEAT BELT TENSIONER SHORT TO BATTERY
- Symptom: DRIVER SEAT BELT TENSIONER SHORT TO GROUND
- Symptom: DRIVER SQUIB 1 CIRCUIT OPEN
- Symptom: DRIVER SQUIB 1 CIRCUIT SHORT
- Symptom: DRIVER SQUIB 1 SHORT TO BATTERY
- Symptom: DRIVER SQUIB 1 SHORT TO GROUND
- Symptom: LEFT CURTAIN OR SEAT SQUIB CIRCUIT OPEN
- Symptom: LEFT CURTAIN OR SEAT SQUIB CIRCUIT SHORT
- Symptom: LEFT CURTAIN OR SEAT SQUIB SHORT TO BATTERY
- Symptom: LEFT CURTAIN OR SEAT SQUIB SHORT TO GROUND
- Symptom: LEFT SIDE IMPACT SENSOR 1 INTERNAL 1
- Symptom: LOSS OF IGNITION RUN - START
- Symptom: LOSS OF IGNITION RUN ONLY
- Symptom: NO CLUSTER MESSAGE
- Symptom: NO LEFT SIDE IMPACT SENSOR 1 COMMUNICATION
- Symptom: NO ODOMETER MESSAGE
- Symptom: NO PCI TRANSMISSION
- Symptom: NO RIGHT SIDE IMPACT SENSOR 1 COMMUNICATION
- Symptom: PASSENGER SEAT BELT TENSIONER CIRCUIT OPEN
- Symptom: PASSENGER SEAT BELT TENSIONER CIRCUIT SHORT
- Symptom: PASSENGER SEAT BELT TENSIONER SHORT TO BATTERY
- Symptom: PASSENGER SEAT BELT TENSIONER SHORT TO GROUND
- Symptom: PASSENGER SQUIB 1 CIRCUIT OPEN
- Symptom: PASSENGER SQUIB 1 CIRCUIT SHORT
- Symptom: PASSENGER SQUIB 1 SHORT TO BATTERY
- Symptom: PASSENGER SQUIB 1 SHORT TO GROUND
- Symptom: POWER SUPPLY VOLTAGE LOW
- Symptom: RIGHT CURTAIN OR SEAT SQUIB CIRCUIT OPEN
- Symptom: RIGHT CURTAIN OR SEAT SQUIB CIRCUIT SHORT
- Symptom: RIGHT CURTAIN OR SEAT SQUIB SHORT TO BATTERY
- Symptom: RIGHT CURTAIN OR SEAT SQUIB SHORT TO GROUND
- Symptom: RIGHT SIDE IMPACT SENSOR INTERNAL 1
- Symptom: VEHICLE BODY STYLE MISMATCH
- Symptom: *AIRBAG INDICATOR ON WITHOUT ACTIVE TROUBLE CODES
- Audio
- Symptom: ALL OUTPUTS SHORT
- Symptom: ANTENNA HARDWARE FAILURE - SDARS
- Symptom: ANTENNA NOT CONNECTED - SDARS
- Symptom: BUS BUSY - SDARS
- Symptom: BUS LOW - SDARS
- Symptom List: CASSETTE PLAYER INOP; CD MECHANICAL FAILURE; NO PCI TRANSMISSION; *AM/FM SWITCH INOPERATIVE; *ANY STATION PRESET SWITCH INOPERATIVE; *BALANCE INOPERATIVE; *CD EJECT SWITCH INOPERATIVE; *EQUALIZER INOPERATIVE; *FADER INOPERATIVE; *FF/RW SWITCH INOPERATIVE; *HOUR/MINUTE SWITCHES INOPERATIVE; *PAUSE/PLAY SWITCH INOPERATIVE; *PWR SWITCH INOPERATIVE; *SCAN SWITCH INOPERATIVE; *SEEK SWITCH INOPERATIVE; *SET SWITCH INOPERATIVE; *TAPE EJECT SWITCH INOPERATIVE; *TIME SWITCH INOPERATIVE; *TUNE SWITCH INOPERATIVE
- Symptom: CD PLAY FAILURE
- Symptom: CD READ FAILURE
- Symptom: CD TEMPERATURE HIGH
- Symptom: GPS ANTENNA NOT CONNECTED
- Symptom: INTERNAL FAILURE - SDARS
- Symptom: INTERNAL RECEIVER FAILURE - SDARS
- Symptom: LOW VOLTAGE LEVEL
- Symptom: NO ANTENNA CONNECTION
- Symptom: NO COMMUNICATION WITH SDARS
- Symptom: NO J1850 COMMUNICATION - SDARS
- Symptom: POWER AMP SHUTDOWN
- Symptom: RADIO AND NAV GPS ANTENNA NOT CONNECTED
- Symptom: *INOP NO FAULT CODES - SDARS
- Symptom: *POOR RECEPTION - SDARS
- Communication
- Symptom: *NO RESPONSE FROM AIRBAG CONTROL MODULE
- Symptom: *NO RESPONSE FROM AMPLIFIER
- Symptom: *NO RESPONSE FROM ANTILOCK BRAKE MODULE
- Symptom: *NO RESPONSE FROM ECM (PCI BUS) - DIESEL ONLY
- Symptom: *NO RESPONSE FROM ECM (SCI ONLY) - DIESEL ONLY
- Symptom: *NO RESPONSE FROM HANDS FREE MODULE
- Symptom: *NO RESPONSE FROM INSTRUMENT CLUSTER
- Symptom: *NO RESPONSE FROM OVERHEAD CONSOLE (COMPASS/TEMPERATURE MIRROR MODULE)
- Symptom: *NO RESPONSE FROM PCM (PCI BUS) - 1.6L
- Symptom: *NO RESPONSE FROM PCM (PCI BUS) - NGC
- Symptom: *NO RESPONSE FROM PCM (PCM SCI ONLY) - NGC
- Symptom: *NO RESPONSE FROM PCM (SCI ONLY) - 1.6L
- Symptom: *NO RESPONSE FROM RADIO
- Symptom: *NO RESPONSE FROM RKE
- Symptom: *NO RESPONSE FROM SATELLITE RADIO RECEIVER
- Symptom: *NO RESPONSE FROM SENTRY KEY IMMOBILIZER MODULE
- Symptom: *NO RESPONSE FROM TRANSMISSION CONTROL MODULE - NGC
- Symptom: *NO RESPONSE FROM WINDOW REGULATOR MODULE - PT27
- Symptom: *PCI BUS COMMUNICATION FAILURE
- Instrument Cluster
- Symptom List: ABS INDICATOR CIRCUIT OPEN; AIRBAG INDICATOR CIRCUIT OPEN
- Symptom List: ABS MESSAGE NOT RECEIVED; ACM MESSAGE NOT RECEIVED; EATX MESSAGE NOT RECEIVED; NO PCI TRANSMISSION; SBEC MESSAGE NOT RECEIVED; SKIM MESSAGE NOT RECEIVED
- Symptom: EATX MESSAGE MISMATCH
- Symptom: EEPROM CHECKSUM FAILURE
- Symptom: FUEL LEVEL SENSOR OPEN
- Symptom: FUEL LEVEL SENSOR SHORT
- Symptom: FUEL LEVEL SENSOR STUCK
- Symptom: PANEL DIMMER OPEN
- Symptom: PANEL DIMMER SHORTED
- Symptom: *ALL GAUGES INOPERATIVE
- Symptom: *ANY PCI BUS INDICATOR INOPERATIVE
- Symptom: *BRAKE WARNING INDICATOR ALWAYS ON
- Symptom: *BRAKE WARNING INDICATOR INOPERATIVE
- Symptom: *FRONT FOG LAMP INDICATOR INOPERATIVE
- Symptom: *FUEL GAUGE INACCURATE
- Symptom: *HIGH BEAM INDICATOR INOPERATIVE
- Symptom: *INSTRUMENT CLUSTER DIMMING INOPERATIVE
- Symptom: *LOW OIL PRESSURE INDICATOR ALWAYS ON
- Symptom: *LOW OIL PRESSURE INDICATOR INOPERATIVE
- Symptom: *ONE GAUGE INOPERATIVE
- Symptom: *PRND OR AUTOSTICK DISPLAY INOPERATIVE OR INACCURATE
- Symptom: *REAR FOG LAMP INDICATOR INOPERATIVE - BUX ONLY
- Symptom: *SEAT BELT INDICATOR NOT OPERATING PROPERLY
- Symptom: *VF DISPLAY INOPERATIVE
- Interior Lighting
- Overhead Console
- Power Door Locks/RKE
- Symptom: BODY STYLE MISMATCH
- Symptom: DRIVER DOOR SWITCH FAILURE
- Symptom: INCORRECT MODULE TYPE CONFIGURATION FOR PART NUMBER
- Symptom: MODULE NOT CONFIGURED FOR RKE
- Symptom: NO AIRBAG MESSAGES RECEIVED
- Symptom: NO PCM MESSAGES RECEIVED
- Symptom: NO SKIM MESSAGES RECEIVED
- Symptom: PASSENGER DOOR OR LIFTGATE SWITCH FAILURE - PT44
- Symptom:* ALL DOORS (EXCEPT DRIVER)FAIL TO LOCK
- Symptom: * ALL DOORS (EXCEPT DRIVER)FAIL TO LOCK AND UNLOCK
- Symptom:* ALL DOORS (EXCEPT DRIVER)FAIL TO UNLOCK
- Symptom: *ALL DOOR LOCKS INOPERATIVE
- Symptom: *ALL DOORS FAIL TO LOCK
- Symptom: *ALL DOORS FAIL TO UNLOCK
- Symptom: *ALL LOCKS INOPERATIVE FROM ONE LOCK SWITCH
- Symptom: *DECKLID RELEASE SWITCH INOPERATIVE - PT27
- Symptom: *DECKLID SOLENOID INOPERATIVE - PT27
- Symptom: *DOORS LOCKABLE WITH KEY IN IGNITION AND DRIVER DOOR OPEN
- Symptom: *DRIVER DOOR FAILS TO LOCK
- Symptom: *DRIVER DOOR FAILS TO LOCK AND UNLOCK
- Symptom: *DRIVER DOOR FAILS TO UNLOCK
- Symptom: *DRIVER DOOR FAILS UNLOCK - PT27
- Symptom: *LIFTGATE LOCK MOTOR FAILS TO LOCK OR UNLOCK
- Symptom: *ONE DOOR FAILS TO LOCK AND UNLOCK - PT27
- Symptom: *ONE PASSENGER DOOR FAILS TO LOCK AND UNLOCK
- Symptom: *PASSENGER DOOR FAILS TO UNLOCK - PT27
- Symptom: *RKE INOPERATIVE
- Power Top
- Symptom: AMBIENT TEMP MESSAGE NOT RECEIVED
- Symptom: POWER TOP RELAY CONTROL CIRCUIT OPEN
- Symptom: POWER TOP RELAY INOPERATIVE
- Symptom: POWER TOP SWITCH MUX CIRCUIT OPEN
- Symptom: POWER TOP SWITCH MUX CIRCUIT SHORT TO GROUND
- Symptom: POWER TOP SWITCH MUX CIRCUIT VALUE OUT OF RANGE
- Symptom: SPEED MESSAGE NOT RECEIVED
- Power Windows
- Symptom: BATTERY VOLTAGE TOO HIGH
- Symptom: BATTERY VOLTAGE TOO LOW
- Symptom: FRONT WINDOW MOTOR MALFUNCTION
- Symptom: FRONT WINDOW SWITCH MUX CIRCUIT OPEN
- Symptom: FRONT WINDOW SWITCH MUX CIRCUIT SHORT TO GROUND
- Symptom: FRONT WINDOW SWITCH MUX CIRCUIT VALUE OUT OF RANGE
- Symptom: IGNITION SWITCH OUTPUT OPEN
- Symptom: REAR WINDOW MOTOR CIRCUIT OPEN OR SHORTED
- Symptom: REAR WINDOW SWITCH MUX CIRCUIT OPEN
- Symptom: REAR WINDOW SWITCH MUX CIRCUIT SHORT TO GROUND
- Symptom: REAR WINDOW SWITCH MUX CIRCUIT VALUE OUT OF RANGE
- Symptom: WINDOW DROP SWITCH SENSE CIRCUIT OPEN
- Symptom: *DOOR AJAR CIRCUIT OPEN
- Symptom: *DOOR WINDOWS STAY IN DROP DOWN POSITION
- Symptom: *WINDOW DROPS OR JERKS DURING OPENING
- Telecommunication
- Symptom: AUDIO HARDWARE MESSAGE NOT RECEIVED
- Symptom List: BLUETOOTH ERROR; FLASH CHECKSUM ERROR; FLASH WRITE ERROR; PCI BUS INTERNAL ERROR; RAM WRITE ERROR; ROM CHECKSUM ERROR
- Symptom List: BODY STYLE MESSAGE NOT RECEIVED; INVALID BODY STYLE
- Symptom: GENERAL MICROPHONE FAULT
- Symptom: IGNITION POWER MESSAGE NOT RECEIVED
- Symptom List: LEFT AUDIO INPUT SHORT TO GROUND; LEFT AUDIO INPUT SHORT TO VOLTAGE; LEFT AUDIO OUTPUT 1 SHORT TO GROUND; LEFT AUDIO OUTPUT 1 SHORT TO VOLTAGE
- Symptom List: MIRROR POWER CIRCUIT SHORT TO GROUND; MIRROR POWER CIRCUIT SHORT TO VOLTAGE
- Symptom List: PCI BUS BUSY; PCI BUS CIRCUIT OPEN; PCI BUS CIRCUIT SHORT TO GROUND; PCI BUS CIRCUIT SHORT TO VOLTAGE
- Symptom List: PHONE SWITCH STUCK; VOICE RECOGNITION SWITCH STUCK' VOICE RECOGNITION/PHONE SWITCH CIRCUIT RATIONALITY; VOICE RECOGNITION/PHONE SWITCH CIRCUIT SHORT TO GROUND; VOICE RECOGNITION/PHONE SWITCH CIRCUIT SHORT TO VOLTAGE
- Symptom: PRNDL MESSAGE NOT RECEIVED
- Symptom: RADIO MESSAGE NOT RECEIVED
- Symptom List: RIGHT AUDIO INPUT SHORT TO GROUND; RIGHT AUDIO INPUT SHORT TO VOLTAGE; RIGHT AUDIO OUTPUT 1 SHORT TO GROUND; RIGHT AUDIO OUTPUT 1 SHORT TO VOLTAGE
- Symptom: RPM MESSAGE NOT RECEIVED
- Symptom: VIN MESSAGE NOT RECEIVED
- Symptom: VIN MISMATCH
- Vehicle Theft/Security
- Symptom: HOOD AJAR SWITCH MISSING (EXPORT ONLY)
- Symptom: MODULE PREVIOUSLY CONFIGURED FOR VTSS
- Symptom: *ALARM TRIPS ON ITS OWN
- Symptom: *HEADLAMPS FAIL TO FLASH DURING ALARM
- Symptom: *HORN FAILS TO SOUND DURING ALARM
- Symptom: *INTRUSION SENSOR CANNOT BE DISABLED (EXPORT ONLY)
- Symptom: *INTRUSION SENSOR FAILS TO TRIP VTSS (EXPORT ONLY)
- Symptom: *INTRUSION SENSOR REPEATEDLY TRIGGERS VTSS (EXPORT ONLY)
- Symptom: *OPEN DRIVER DOOR FAILS TO TRIP ALARM
- Symptom: *OPEN LIFTGATE FAILS TO TRIP ALARM
- Symptom: *OPEN PASSENGER DOOR FAILS TO TRIP ALARM
- Symptom: *PARK LAMPS FAIL TO FLASH DURING ALARM
- Symptom List: *VTSS FAILS TO ARM FROM LEFT DOOR CYLINDER LOCK SWITCH (EXPORT ONLY); *VTSS FAILS TO ARM/DISARM FROM LEFT DOOR CYLINDER LOCK SWITCH
- Symptom List: *VTSS FAILS TO ARM FROM LIFTGATE CYLINDER LOCK SWITCH (EXPORT ONLY); *VTSS FAILS TO ARM/DISARM FROM LIFTGATE CYLINDER LOCK SWITCH
- Symptom List: *VTSS FAILS TO ARM FROM RIGHT DOOR CYLINDER LOCK SWITCH (EXPORT ONLY); *VTSS FAILS TO ARM/DISARM FROM RIGHT DOOR CYLINDER LOCK SWITCH
- Symptom: *VTSS INDICATOR FAILS TO FLASH
- Symptom: *VTSS INDICATOR STAYS ON STEADY DURING ARMING
- Symptom: *VTSS SIREN INOPERATIVE (EXPORT ONLY)
- Verifications Tests
- Airbag
- Component Locations
- Connector PINOUTS
- Airbag Control Module (Orc) (Base) - Yellow 23 Way
- Airbag Control Module C1 (Orc) (Premium) - Yellow 32 Way
- Airbag Control Module C2 (Orc) (Premium) - Yellow 32 Way
- Ambient Temperature Sensor (Except 2.4L Base) - Black 2 Way
- Amplifier Audio C1 - 20 Way
- Anti-Lock Brake Module - Black 47 Way
- C203 (Pt27) - LT. Gray (Body Side)
- C203 (Pt27) - LT. Gray (Instrument Panel Side)
- C204 (Pt27) - (Instrument Panel Side)
- C204 (Pt27) - (Left Front Door Side)
- C204 (Pt44 LHP) - Natural (Instrument Panel Side)
- C204 (Pt44 LHP) - Natural (Left Front Door Side)
- C205 (Pt27) - (Instrument Panel Side)
- C205 (Pt27) - (Right Front Door Side)
- C305 - Yellow (Airbag Side)
- C305 - Yellow (UNIBODY Side)
- C306 - Yellow (Airbag Side)
- C306 - Yellow (UNIBODY Side)
- C343 (Pt27) - LT. Gray (DECKLID Jumper Side)
- C343 (Pt27) - LT. Gray (DECKLID Side)
- C349 (Pt27) - Blue (Body Side
- C349 (Pt27) - Blue (DECKLID Jumper Side)
- C362 (Pt27) - LT. Gray (Body Side)
- C362 (Pt27) - LT. Gray (Power Top Side)
- CLOCKSPRING - DK. Green 7 Way
- Compass/Temperature Mirror Module (Pt27) - Black 10 Way
- Data Link Connector - Black 16 Way
- DECKLID Cylinder Unlock Switch (Pt27) - LT. Gray 2 Way
- DECKLID Handle Switch (Pt27) - White 2 Way
- DECKLID Release Motor (Pt27) - Black 3 Way
- DECKLID Release Switch (Pt27) - Black 2 Way
- Dome Lamp - Black 3 Way
- Dome Lamp/Intrusion Sensor (Export) - White 4 Way
- Driver Airbag Squib 1 - Yellow 2 Way
- Driver Door Ajar Switch - Black 2 Way
- Driver Door Handle Switch (Pt27) - 2 Way
- Driver Door Power Lock Motor/Ajar Switch - Black 4 Way
- Driver Rear Window Motor (Pt27) - Black 2 Way
- Driver Seat Belt TENSIONER - Yellow 2 Way
- Driver Window Regulator Module (Pt27) - Black 20 Way
- Engine Control Module C1 (Diesel) - Black 81 Way
- Front Power Window Switch - Black 14 Way
- Fuel Pump Module - LT. Gray 4 Way
- Fuses (FB)
- Hands Free Module C1 - DK. Gray 22 Way
- Hands Free Module C2 (Satellite Radio) - DK. Gray 10 Way
- Hands Free Module C3 - Black 10 Way
- High Note Horn (Export) - Black 2 Way
- Hood Ajar Switch (Export) - Black 2 Way
- Ignition Switch C1 - 10 Way
- Instrument Cluster C1 - Black 26 Way
- Instrument Cluster C2 - Black 10 Way
- Left Cylinder Lock Switch - Black 2 Way
- Left Door Lock Switch - Black 3 Way
- Left Front Power Window Motor (Pt44) - Black 2 Way
- Left Instrument Panel Speaker - Black 2 Way
- Left Rear Speaker (Pt44) - Black 2 Way
- Left Seat Airbag Squib (LHP) - Yellow 2 Way
- Left Seat Airbag Squib (RHD) - Yellow 2 Way
- Left Side Impact Sensor 1 - Gray 2 Way
- Liftgate Ajar Switch - White 2 Way
- Liftgate Cylinder Lock Switch - LT. Gray 2 Way
- Liftgate Handle Switch (Pt44) - Natural 2 Way
- Liftgate Power Lock Motor - Black 4 Way
- Liftgate Release Motor (Pt44) - Black 3 Way
- Low Note Horn - Black 2 Way
- Multi-Function Switch - Gray 20 Way
- Overhead Console Module - Black 12 Way
- Passenger Airbag Squib 1 - Yellow 2 Way
- Passenger Door Ajar Switch - Black 2 Way
- Passenger Door Handle Switch (Pt27) - 2 Way
- Passenger Door Power Lock Motor/Ajar Switch - Black 4 Way
- Passenger Rear Window Motor (Pt27) - Black 2 Way
- Passenger Seat Belt TENSIONER - Yellow 2 Way
- Passenger Window Regulator Module (Pt27) - Black 20 Way
- Fuses (PDC)
- Power Top Motor (Pt27) - 2 Way
- Power Top Relay (Pt27) - Black 6 Way
- Power Top Switch (Pt27) - 3 Way
- Powertrain Control Module (1.6L) - Black 90 Way
- Powertrain Control Module C1 (NGC) - Black/Black 38 Way
- Radio C1 - White 22 Way
- Radio C2 (Hands Free) - DK. Gray 10 Way
- Rear View Mirror C1 - Black 12 Way
- Remote Keyless Entry Module - Black 26 Way
- Right Cylinder Lock Switch (Export) - Black 2 Way
- Right Door Lock Switch - Black 3 Way
- Right Front Door Speaker - 3 Way
- Right Front Power Window Motor (Pt44) - Black 2 Way
- Right Rear Power Window Motor (Pt44) - Black 2 Way
- Right Seat Airbag Squib (LHP) - Yellow 2 Way
- Right Seat Airbag Squib (RHP) - Yellow 2 Way
- Right Side Impact Sensor 1 - Gray 2 Way
- Sentry Key Immobilizer Module - Black 6 Way
- Siren (Export) - Black 4 Way
- Schematic Diagrams
- Lighting Systems - Exterior
- Lamps/Lighting - Exterior
- Back-Up Lamp
- Back-Up Lamp Unit
- Brake Lamp Switch
- Center High Mounted Stop Lamp
- Center High Mounted Stop Lamp Unit
- Center High Mounted Stop Lamp Unit - Pt27
- Combination Flasher
- Daytime Running Lamp Module
- Fog Lamp
- Fog Lamp Unit
- Headlamp
- Headlamp Unit
- Headlamp Switch
- License Plate Lamp
- License Plate Lamp Unit
- Multi-Function Switch
- Park/Turn Signal Lamp
- Rear Fog Lamp Switch - Export
- Tail Lamp
- Tail Lamp Unit
- Body Diagnostic Procedures
- Gauges & Instrument Panels
- Body Diagnostic Procedures
- Introduction
- Identification Of System
- System Description And Functional Operation
- Notes
- Airbag System
- Audio System
- Compass/Temperature Module (CTM)
- Compass/Temperature Mirror
- Description
- Operation
- English / Metric / Off Mode
- Calibration / Zone Mode
- Setting Compass Zone
- First Time Calibration
- Manual Calibration
- Continuous Calibration
- Self-Check Diagnostic
- Outside Temperature
- Temperature Update - Warm
- Temperature Update - Cold
- Extreme Temperature / Open Or Short Condition
- Ambient Temperature Sensor
- Ambient Temperature Sensor Diagnostics
- Instrument Cluster
- Remote Keyless Entry Module
- Sentry Key Immobilizer System (Skis)
- Communication
- Telecommunications
- Window Regulator Modules (Pt27 Only)
- Using The DRBIII®
- Disclaimers, Safety, Warnings
- Required Tools And Equipment
- Glossary Of Terms
- Diagnostic Information And Procedures
- Airbag
- Symptom List: ACCELEROMETER 1; INTERNAL 1; INTERNAL 2; INTERNAL 3; INTERNAL 4' OUTPUT DRIVER 1; OUTPUT DRIVER 2; STORED ENERGY FIRING 1
- Symptom List: AIRBAG WARNING INDICATOR DRIVER; AIRBAG WARNING INDICATOR OPEN; AIRBAG WARNING INDICATOR SHORT
- Symptom: CALIBRATION MISMATCH
- Symptom: CLUSTER MESSAGE MISMATCH
- Symptom: DRIVER SEAT BELT TENSIONER CIRCUIT OPEN
- Symptom: DRIVER SEAT BELT TENSIONER CIRCUIT SHORT
- Symptom: DRIVER SEAT BELT TENSIONER SHORT TO BATTERY
- Symptom: DRIVER SEAT BELT TENSIONER SHORT TO GROUND
- Symptom: DRIVER SQUIB 1 CIRCUIT OPEN
- Symptom: DRIVER SQUIB 1 CIRCUIT SHORT
- Symptom: DRIVER SQUIB 1 SHORT TO BATTERY
- Symptom: DRIVER SQUIB 1 SHORT TO GROUND
- Symptom: LEFT CURTAIN OR SEAT SQUIB CIRCUIT OPEN
- Symptom: LEFT CURTAIN OR SEAT SQUIB CIRCUIT SHORT
- Symptom: LEFT CURTAIN OR SEAT SQUIB SHORT TO BATTERY
- Symptom: LEFT CURTAIN OR SEAT SQUIB SHORT TO GROUND
- Symptom: LEFT SIDE IMPACT SENSOR 1 INTERNAL 1
- Symptom: LOSS OF IGNITION RUN - START
- Symptom: LOSS OF IGNITION RUN ONLY
- Symptom: NO CLUSTER MESSAGE
- Symptom: NO LEFT SIDE IMPACT SENSOR 1 COMMUNICATION
- Symptom: NO ODOMETER MESSAGE
- Symptom: NO PCI TRANSMISSION
- Symptom: NO RIGHT SIDE IMPACT SENSOR 1 COMMUNICATION
- Symptom: PASSENGER SEAT BELT TENSIONER CIRCUIT OPEN
- Symptom: PASSENGER SEAT BELT TENSIONER CIRCUIT SHORT
- Symptom: PASSENGER SEAT BELT TENSIONER SHORT TO BATTERY
- Symptom: PASSENGER SEAT BELT TENSIONER SHORT TO GROUND
- Symptom: PASSENGER SQUIB 1 CIRCUIT OPEN
- Symptom: PASSENGER SQUIB 1 CIRCUIT SHORT
- Symptom: PASSENGER SQUIB 1 SHORT TO BATTERY
- Symptom: PASSENGER SQUIB 1 SHORT TO GROUND
- Symptom: POWER SUPPLY VOLTAGE LOW
- Symptom: RIGHT CURTAIN OR SEAT SQUIB CIRCUIT OPEN
- Symptom: RIGHT CURTAIN OR SEAT SQUIB CIRCUIT SHORT
- Symptom: RIGHT CURTAIN OR SEAT SQUIB SHORT TO BATTERY
- Symptom: RIGHT CURTAIN OR SEAT SQUIB SHORT TO GROUND
- Symptom: RIGHT SIDE IMPACT SENSOR INTERNAL 1
- Symptom: VEHICLE BODY STYLE MISMATCH
- Symptom: *AIRBAG INDICATOR ON WITHOUT ACTIVE TROUBLE CODES
- Audio
- Symptom: ALL OUTPUTS SHORT
- Symptom: ANTENNA HARDWARE FAILURE - SDARS
- Symptom: ANTENNA NOT CONNECTED - SDARS
- Symptom: BUS BUSY - SDARS
- Symptom: BUS LOW - SDARS
- Symptom List: CASSETTE PLAYER INOP; CD MECHANICAL FAILURE; NO PCI TRANSMISSION; *AM/FM SWITCH INOPERATIVE; *ANY STATION PRESET SWITCH INOPERATIVE; *BALANCE INOPERATIVE; *CD EJECT SWITCH INOPERATIVE; *EQUALIZER INOPERATIVE; *FADER INOPERATIVE; *FF/RW SWITCH INOPERATIVE; *HOUR/MINUTE SWITCHES INOPERATIVE; *PAUSE/PLAY SWITCH INOPERATIVE; *PWR SWITCH INOPERATIVE; *SCAN SWITCH INOPERATIVE; *SEEK SWITCH INOPERATIVE; *SET SWITCH INOPERATIVE; *TAPE EJECT SWITCH INOPERATIVE; *TIME SWITCH INOPERATIVE; *TUNE SWITCH INOPERATIVE
- Symptom: CD PLAY FAILURE
- Symptom: CD READ FAILURE
- Symptom: CD TEMPERATURE HIGH
- Symptom: GPS ANTENNA NOT CONNECTED
- Symptom: INTERNAL FAILURE - SDARS
- Symptom: INTERNAL RECEIVER FAILURE - SDARS
- Symptom: LOW VOLTAGE LEVEL
- Symptom: NO ANTENNA CONNECTION
- Symptom: NO COMMUNICATION WITH SDARS
- Symptom: NO J1850 COMMUNICATION - SDARS
- Symptom: POWER AMP SHUTDOWN
- Symptom: RADIO AND NAV GPS ANTENNA NOT CONNECTED
- Symptom: *INOP NO FAULT CODES - SDARS
- Symptom: *POOR RECEPTION - SDARS
- Communication
- Symptom: *NO RESPONSE FROM AIRBAG CONTROL MODULE
- Symptom: *NO RESPONSE FROM AMPLIFIER
- Symptom: *NO RESPONSE FROM ANTILOCK BRAKE MODULE
- Symptom: *NO RESPONSE FROM ECM (PCI BUS) - DIESEL ONLY
- Symptom: *NO RESPONSE FROM ECM (SCI ONLY) - DIESEL ONLY
- Symptom: *NO RESPONSE FROM HANDS FREE MODULE
- Symptom: *NO RESPONSE FROM INSTRUMENT CLUSTER
- Symptom: *NO RESPONSE FROM OVERHEAD CONSOLE (COMPASS/TEMPERATURE MIRROR MODULE)
- Symptom: *NO RESPONSE FROM PCM (PCI BUS) - 1.6L
- Symptom: *NO RESPONSE FROM PCM (PCI BUS) - NGC
- Symptom: *NO RESPONSE FROM PCM (PCM SCI ONLY) - NGC
- Symptom: *NO RESPONSE FROM PCM (SCI ONLY) - 1.6L
- Symptom: *NO RESPONSE FROM RADIO
- Symptom: *NO RESPONSE FROM RKE
- Symptom: *NO RESPONSE FROM SATELLITE RADIO RECEIVER
- Symptom: *NO RESPONSE FROM SENTRY KEY IMMOBILIZER MODULE
- Symptom: *NO RESPONSE FROM TRANSMISSION CONTROL MODULE - NGC
- Symptom: *NO RESPONSE FROM WINDOW REGULATOR MODULE - PT27
- Symptom: *PCI BUS COMMUNICATION FAILURE
- Instrument Cluster
- Symptom List: ABS INDICATOR CIRCUIT OPEN; AIRBAG INDICATOR CIRCUIT OPEN
- Symptom List: ABS MESSAGE NOT RECEIVED; ACM MESSAGE NOT RECEIVED; EATX MESSAGE NOT RECEIVED; NO PCI TRANSMISSION; SBEC MESSAGE NOT RECEIVED; SKIM MESSAGE NOT RECEIVED
- Symptom: EATX MESSAGE MISMATCH
- Symptom: EEPROM CHECKSUM FAILURE
- Symptom: FUEL LEVEL SENSOR OPEN
- Symptom: FUEL LEVEL SENSOR SHORT
- Symptom: FUEL LEVEL SENSOR STUCK
- Symptom: PANEL DIMMER OPEN
- Symptom: PANEL DIMMER SHORTED
- Symptom: *ALL GAUGES INOPERATIVE
- Symptom: *ANY PCI BUS INDICATOR INOPERATIVE
- Symptom: *BRAKE WARNING INDICATOR ALWAYS ON
- Symptom: *BRAKE WARNING INDICATOR INOPERATIVE
- Symptom: *FRONT FOG LAMP INDICATOR INOPERATIVE
- Symptom: *FUEL GAUGE INACCURATE
- Symptom: *HIGH BEAM INDICATOR INOPERATIVE
- Symptom: *INSTRUMENT CLUSTER DIMMING INOPERATIVE
- Symptom: *LOW OIL PRESSURE INDICATOR ALWAYS ON
- Symptom: *LOW OIL PRESSURE INDICATOR INOPERATIVE
- Symptom: *ONE GAUGE INOPERATIVE
- Symptom: *PRND OR AUTOSTICK DISPLAY INOPERATIVE OR INACCURATE
- Symptom: *REAR FOG LAMP INDICATOR INOPERATIVE - BUX ONLY
- Symptom: *SEAT BELT INDICATOR NOT OPERATING PROPERLY
- Symptom: *VF DISPLAY INOPERATIVE
- Interior Lighting
- Overhead Console
- Power Door Locks/RKE
- Symptom: BODY STYLE MISMATCH
- Symptom: DRIVER DOOR SWITCH FAILURE
- Symptom: INCORRECT MODULE TYPE CONFIGURATION FOR PART NUMBER
- Symptom: MODULE NOT CONFIGURED FOR RKE
- Symptom: NO AIRBAG MESSAGES RECEIVED
- Symptom: NO PCM MESSAGES RECEIVED
- Symptom: NO SKIM MESSAGES RECEIVED
- Symptom: PASSENGER DOOR OR LIFTGATE SWITCH FAILURE - PT44
- Symptom:* ALL DOORS (EXCEPT DRIVER)FAIL TO LOCK
- Symptom: * ALL DOORS (EXCEPT DRIVER)FAIL TO LOCK AND UNLOCK
- Symptom:* ALL DOORS (EXCEPT DRIVER)FAIL TO UNLOCK
- Symptom: *ALL DOOR LOCKS INOPERATIVE
- Symptom: *ALL DOORS FAIL TO LOCK
- Symptom: *ALL DOORS FAIL TO UNLOCK
- Symptom: *ALL LOCKS INOPERATIVE FROM ONE LOCK SWITCH
- Symptom: *DECKLID RELEASE SWITCH INOPERATIVE - PT27
- Symptom: *DECKLID SOLENOID INOPERATIVE - PT27
- Symptom: *DOORS LOCKABLE WITH KEY IN IGNITION AND DRIVER DOOR OPEN
- Symptom: *DRIVER DOOR FAILS TO LOCK
- Symptom: *DRIVER DOOR FAILS TO LOCK AND UNLOCK
- Symptom: *DRIVER DOOR FAILS TO UNLOCK
- Symptom: *DRIVER DOOR FAILS UNLOCK - PT27
- Symptom: *LIFTGATE LOCK MOTOR FAILS TO LOCK OR UNLOCK
- Symptom: *ONE DOOR FAILS TO LOCK AND UNLOCK - PT27
- Symptom: *ONE PASSENGER DOOR FAILS TO LOCK AND UNLOCK
- Symptom: *PASSENGER DOOR FAILS TO UNLOCK - PT27
- Symptom: *RKE INOPERATIVE
- Power Top
- Symptom: AMBIENT TEMP MESSAGE NOT RECEIVED
- Symptom: POWER TOP RELAY CONTROL CIRCUIT OPEN
- Symptom: POWER TOP RELAY INOPERATIVE
- Symptom: POWER TOP SWITCH MUX CIRCUIT OPEN
- Symptom: POWER TOP SWITCH MUX CIRCUIT SHORT TO GROUND
- Symptom: POWER TOP SWITCH MUX CIRCUIT VALUE OUT OF RANGE
- Symptom: SPEED MESSAGE NOT RECEIVED
- Power Windows
- Symptom: BATTERY VOLTAGE TOO HIGH
- Symptom: BATTERY VOLTAGE TOO LOW
- Symptom: FRONT WINDOW MOTOR MALFUNCTION
- Symptom: FRONT WINDOW SWITCH MUX CIRCUIT OPEN
- Symptom: FRONT WINDOW SWITCH MUX CIRCUIT SHORT TO GROUND
- Symptom: FRONT WINDOW SWITCH MUX CIRCUIT VALUE OUT OF RANGE
- Symptom: IGNITION SWITCH OUTPUT OPEN
- Symptom: REAR WINDOW MOTOR CIRCUIT OPEN OR SHORTED
- Symptom: REAR WINDOW SWITCH MUX CIRCUIT OPEN
- Symptom: REAR WINDOW SWITCH MUX CIRCUIT SHORT TO GROUND
- Symptom: REAR WINDOW SWITCH MUX CIRCUIT VALUE OUT OF RANGE
- Symptom: WINDOW DROP SWITCH SENSE CIRCUIT OPEN
- Symptom: *DOOR AJAR CIRCUIT OPEN
- Symptom: *DOOR WINDOWS STAY IN DROP DOWN POSITION
- Symptom: *WINDOW DROPS OR JERKS DURING OPENING
- Telecommunication
- Symptom: AUDIO HARDWARE MESSAGE NOT RECEIVED
- Symptom List: BLUETOOTH ERROR; FLASH CHECKSUM ERROR; FLASH WRITE ERROR; PCI BUS INTERNAL ERROR; RAM WRITE ERROR; ROM CHECKSUM ERROR
- Symptom List: BODY STYLE MESSAGE NOT RECEIVED; INVALID BODY STYLE
- Symptom: GENERAL MICROPHONE FAULT
- Symptom: IGNITION POWER MESSAGE NOT RECEIVED
- Symptom List: LEFT AUDIO INPUT SHORT TO GROUND; LEFT AUDIO INPUT SHORT TO VOLTAGE; LEFT AUDIO OUTPUT 1 SHORT TO GROUND; LEFT AUDIO OUTPUT 1 SHORT TO VOLTAGE
- Symptom List: MIRROR POWER CIRCUIT SHORT TO GROUND; MIRROR POWER CIRCUIT SHORT TO VOLTAGE
- Symptom List: PCI BUS BUSY; PCI BUS CIRCUIT OPEN; PCI BUS CIRCUIT SHORT TO GROUND; PCI BUS CIRCUIT SHORT TO VOLTAGE
- Symptom List: PHONE SWITCH STUCK; VOICE RECOGNITION SWITCH STUCK' VOICE RECOGNITION/PHONE SWITCH CIRCUIT RATIONALITY; VOICE RECOGNITION/PHONE SWITCH CIRCUIT SHORT TO GROUND; VOICE RECOGNITION/PHONE SWITCH CIRCUIT SHORT TO VOLTAGE
- Symptom: PRNDL MESSAGE NOT RECEIVED
- Symptom: RADIO MESSAGE NOT RECEIVED
- Symptom List: RIGHT AUDIO INPUT SHORT TO GROUND; RIGHT AUDIO INPUT SHORT TO VOLTAGE; RIGHT AUDIO OUTPUT 1 SHORT TO GROUND; RIGHT AUDIO OUTPUT 1 SHORT TO VOLTAGE
- Symptom: RPM MESSAGE NOT RECEIVED
- Symptom: VIN MESSAGE NOT RECEIVED
- Symptom: VIN MISMATCH
- Vehicle Theft/Security
- Symptom: HOOD AJAR SWITCH MISSING (EXPORT ONLY)
- Symptom: MODULE PREVIOUSLY CONFIGURED FOR VTSS
- Symptom: *ALARM TRIPS ON ITS OWN
- Symptom: *HEADLAMPS FAIL TO FLASH DURING ALARM
- Symptom: *HORN FAILS TO SOUND DURING ALARM
- Symptom: *INTRUSION SENSOR CANNOT BE DISABLED (EXPORT ONLY)
- Symptom: *INTRUSION SENSOR FAILS TO TRIP VTSS (EXPORT ONLY)
- Symptom: *INTRUSION SENSOR REPEATEDLY TRIGGERS VTSS (EXPORT ONLY)
- Symptom: *OPEN DRIVER DOOR FAILS TO TRIP ALARM
- Symptom: *OPEN LIFTGATE FAILS TO TRIP ALARM
- Symptom: *OPEN PASSENGER DOOR FAILS TO TRIP ALARM
- Symptom: *PARK LAMPS FAIL TO FLASH DURING ALARM
- Symptom List: *VTSS FAILS TO ARM FROM LEFT DOOR CYLINDER LOCK SWITCH (EXPORT ONLY); *VTSS FAILS TO ARM/DISARM FROM LEFT DOOR CYLINDER LOCK SWITCH
- Symptom List: *VTSS FAILS TO ARM FROM LIFTGATE CYLINDER LOCK SWITCH (EXPORT ONLY); *VTSS FAILS TO ARM/DISARM FROM LIFTGATE CYLINDER LOCK SWITCH
- Symptom List: *VTSS FAILS TO ARM FROM RIGHT DOOR CYLINDER LOCK SWITCH (EXPORT ONLY); *VTSS FAILS TO ARM/DISARM FROM RIGHT DOOR CYLINDER LOCK SWITCH
- Symptom: *VTSS INDICATOR FAILS TO FLASH
- Symptom: *VTSS INDICATOR STAYS ON STEADY DURING ARMING
- Symptom: *VTSS SIREN INOPERATIVE (EXPORT ONLY)
- Verifications Tests
- Airbag
- Component Locations
- Connector PINOUTS
- Airbag Control Module (Orc) (Base) - Yellow 23 Way
- Airbag Control Module C1 (Orc) (Premium) - Yellow 32 Way
- Airbag Control Module C2 (Orc) (Premium) - Yellow 32 Way
- Ambient Temperature Sensor (Except 2.4L Base) - Black 2 Way
- Amplifier Audio C1 - 20 Way
- Anti-Lock Brake Module - Black 47 Way
- C203 (Pt27) - LT. Gray (Body Side)
- C203 (Pt27) - LT. Gray (Instrument Panel Side)
- C204 (Pt27) - (Instrument Panel Side)
- C204 (Pt27) - (Left Front Door Side)
- C204 (Pt44 LHP) - Natural (Instrument Panel Side)
- C204 (Pt44 LHP) - Natural (Left Front Door Side)
- C205 (Pt27) - (Instrument Panel Side)
- C205 (Pt27) - (Right Front Door Side)
- C305 - Yellow (Airbag Side)
- C305 - Yellow (UNIBODY Side)
- C306 - Yellow (Airbag Side)
- C306 - Yellow (UNIBODY Side)
- C343 (Pt27) - LT. Gray (DECKLID Jumper Side)
- C343 (Pt27) - LT. Gray (DECKLID Side)
- C349 (Pt27) - Blue (Body Side
- C349 (Pt27) - Blue (DECKLID Jumper Side)
- C362 (Pt27) - LT. Gray (Body Side)
- C362 (Pt27) - LT. Gray (Power Top Side)
- CLOCKSPRING - DK. Green 7 Way
- Compass/Temperature Mirror Module (Pt27) - Black 10 Way
- Data Link Connector - Black 16 Way
- DECKLID Cylinder Unlock Switch (Pt27) - LT. Gray 2 Way
- DECKLID Handle Switch (Pt27) - White 2 Way
- DECKLID Release Motor (Pt27) - Black 3 Way
- DECKLID Release Switch (Pt27) - Black 2 Way
- Dome Lamp - Black 3 Way
- Dome Lamp/Intrusion Sensor (Export) - White 4 Way
- Driver Airbag Squib 1 - Yellow 2 Way
- Driver Door Ajar Switch - Black 2 Way
- Driver Door Handle Switch (Pt27) - 2 Way
- Driver Door Power Lock Motor/Ajar Switch - Black 4 Way
- Driver Rear Window Motor (Pt27) - Black 2 Way
- Driver Seat Belt TENSIONER - Yellow 2 Way
- Driver Window Regulator Module (Pt27) - Black 20 Way
- Engine Control Module C1 (Diesel) - Black 81 Way
- Front Power Window Switch - Black 14 Way
- Fuel Pump Module - LT. Gray 4 Way
- Fuses (FB)
- Hands Free Module C1 - DK. Gray 22 Way
- Hands Free Module C2 (Satellite Radio) - DK. Gray 10 Way
- Hands Free Module C3 - Black 10 Way
- High Note Horn (Export) - Black 2 Way
- Hood Ajar Switch (Export) - Black 2 Way
- Ignition Switch C1 - 10 Way
- Instrument Cluster C1 - Black 26 Way
- Instrument Cluster C2 - Black 10 Way
- Left Cylinder Lock Switch - Black 2 Way
- Left Door Lock Switch - Black 3 Way
- Left Front Power Window Motor (Pt44) - Black 2 Way
- Left Instrument Panel Speaker - Black 2 Way
- Left Rear Speaker (Pt44) - Black 2 Way
- Left Seat Airbag Squib (LHP) - Yellow 2 Way
- Left Seat Airbag Squib (RHD) - Yellow 2 Way
- Left Side Impact Sensor 1 - Gray 2 Way
- Liftgate Ajar Switch - White 2 Way
- Liftgate Cylinder Lock Switch - LT. Gray 2 Way
- Liftgate Handle Switch (Pt44) - Natural 2 Way
- Liftgate Power Lock Motor - Black 4 Way
- Liftgate Release Motor (Pt44) - Black 3 Way
- Low Note Horn - Black 2 Way
- Multi-Function Switch - Gray 20 Way
- Overhead Console Module - Black 12 Way
- Passenger Airbag Squib 1 - Yellow 2 Way
- Passenger Door Ajar Switch - Black 2 Way
- Passenger Door Handle Switch (Pt27) - 2 Way
- Passenger Door Power Lock Motor/Ajar Switch - Black 4 Way
- Passenger Rear Window Motor (Pt27) - Black 2 Way
- Passenger Seat Belt TENSIONER - Yellow 2 Way
- Passenger Window Regulator Module (Pt27) - Black 20 Way
- Fuses (PDC)
- Power Top Motor (Pt27) - 2 Way
- Power Top Relay (Pt27) - Black 6 Way
- Power Top Switch (Pt27) - 3 Way
- Powertrain Control Module (1.6L) - Black 90 Way
- Powertrain Control Module C1 (NGC) - Black/Black 38 Way
- Radio C1 - White 22 Way
- Radio C2 (Hands Free) - DK. Gray 10 Way
- Rear View Mirror C1 - Black 12 Way
- Remote Keyless Entry Module - Black 26 Way
- Right Cylinder Lock Switch (Export) - Black 2 Way
- Right Door Lock Switch - Black 3 Way
- Right Front Door Speaker - 3 Way
- Right Front Power Window Motor (Pt44) - Black 2 Way
- Right Rear Power Window Motor (Pt44) - Black 2 Way
- Right Seat Airbag Squib (LHP) - Yellow 2 Way
- Right Seat Airbag Squib (RHP) - Yellow 2 Way
- Right Side Impact Sensor 1 - Gray 2 Way
- Sentry Key Immobilizer Module - Black 6 Way
- Siren (Export) - Black 4 Way
- Schematic Diagrams
- Instrument Cluster
- Interior & Exterior
- Body
- Description
- Warning
- Diagnosis And Testing
- Standard Procedure
- Standard Procedure - Plastic Body Panel Repair
- Notes
- Rigid Plastics:
- Semi-Rigid Plastics:
- Flexible Plastics:
- Repair Procedure:
- Adhesion Promoter/Surface Modifier:
- Safety Precaution And Warnings
- Rigid, Semi-Rigid, And Flexible Plastic Parts Types
- Panel Sectioning
- Panel Reinforcement
- Visual Inspection
- Panel Surface Preparation
- Patching Panels
- Panel Patch Fabrications
- Panel Patch Installation
- Patched Panel Surfacing
- Standard Procedure - Heat Staking
- Standard Procedure - Plastic Body Panel Repair
- Specifications
- Special Tools
- Convertible Top
- DECKLID - Pt-27
- Door - Front
- Front Door Applique
- Front Door Check Strap
- Front Door
- Front Door Glass
- Removal
- Installation
- Adjustment - Pt-27 Only
- Front Door Adjustment
- Quarter Glass Adjustment
- Notes
- Up-Stop Adjustments
- Bottom Of Glass - Inboard/Outboard Adjustments
- Top Of Glass - Inboard/Outboard Adjustments
- Glass - Front/Rear Adjustment
- Quarter Glass Alignment Verification
- Condition - Height Mismatch Between Door Glass And Quarter Glass With Top Down
- Condition - Door Glass Noise Along A-Pillar When Closing Door And/Or Door Glass Touching Quarter Glass Metal Seal Retainer And/Or Wind Noise/Water Leak Along Quarter Glass Seal.
- Condition - Door Glass Not Driving Into The Top In Full Up Position
- Condition - Quarter Glass Not Driving Into The Top In Full Up Position
- Condition - Slapping Noise Between The Door And Quarter Glass With The Top Down During Driving Of The Vehicle
- Condition - Non-Parallel Gap Between Door And Quarter Glasses
- Condition - Quarter Glass Seal Fold Over During Travel With Door Glass Full Up And Top Up Or Down
- Condition - Intermediate Rear Of Door Glass Not Driving Into The Top Seal And/Or Noise At Rear Bottom Of The Door
- Front Door Outside Handle
- Front Door Hinge
- Front Door Inside Handle Actuator
- Front Door Latch
- Front Door Latch Striker
- Front Door Lock Cylinder
- Front Door Vertical Guide Bar
- Front Door Side View Mirror Flag - Pt-27
- Front Door Trim Panel
- Front Door Water Dam
- Front Door Window Regulator
- Door Glass Inner Belt Stabilizer - Pt-27
- Rear Rail Assembly - Pt-27
- Door - Rear
- Exterior
- Body Side Moldings
- Cowl Grille Screen
- Deck Upper Belt Molding - Pt-27
- Engine Compartment Lower Silencer
- Exterior Name Plates
- Front Fender
- Front Side Rail Access Pulley Splash Shield
- Front Wheelhouse Splash Shields
- Fuel Fill Door
- Grille
- Header Molding - Pt-27
- Luggage Rack Crossbar
- Luggage Rack Side Rail
- Radiator Closure Panel
- Side View Mirror
- Side View Mirror Glass
- Windshield A-Pillar Trim Molding - Pt-27
- Wood Grain/Flame Decals
- Grille - Lower Radiator
- Hood
- Instrument Panel
- Interior
- A-Pillar Trim
- B-Pillar Trim
- Body Vent
- DECKLID Sill Scuff Plate
- Door Sill Trim
- Floor Carpet
- Cargo Area Floor Carpet - Pt-27
- Front Floor Carpet Right/Left Side -Pt-27
- Rear Carpet - Pt-27
- Upper D-Pillar Trim
- Header Latch Retainer - Pt-27
- Headliner
- Inside Rear View Mirror
- Lower Quarter Trim Panel
- Rear Quarter Panel Trim - Pt-27
- Seat Back Support Bracket - Pt-27
- Side Cowl Trim Panel
- Sport Bar - Pt-27
- Sport Bar Inner Covers - Pt-27
- Sport Bar Outer Cover - Pt-27
- Sun Visor
- Trunk Trim Panel - Pt-27
- Trunk Welt - Pt-27
- Upper C-Pillar Trim
- Windshield Header Molding -Pt-27
- Liftgate
- Paint
- Quarter Glass - Pt-27
- Seats
- Child Seat Tether Anchor Bezel
- Front Seat
- Front Seat Back - With Front Seat Back Panel
- Front Seat Back
- Front Seat Back Cover/Foam
- Front Seat Back Cover - Without Front Seat Back Panel
- Front Seat Cushion
- Front Seat Cushion Cover
- Headrest - Front/Rear
- Rear Seat
- Rear Seat Back
- Rear Seat Back Cover/Foam
- Rear Seat Back Cushion Cover/Foam - Pt-27
- Rear Seat Bolster - Pt-27
- Rear Seat Bolster Cover - Pt-27
- Rear Seat Cushion
- Rear Seat Back Cushion / Cover
- Rear Seat Latch Cover
- Under Seat Storage Bin
- Stationary Glass
- Sunroof
- Weatherstrip/Seals
- A-Pillar Weatherstrip Retainer - Pt-27
- Deck Lid Opening Weatherstrip - Pt-27
- Front And Rear Door Opening Weatherstrip
- Front And Rear Door Upper Secondary Weatherstrip
- Front Door Glass Run Weatherstrip
- Front Door Inner Belt Weatherstrip
- Front Door Outer Belt Weatherstrip
- Header Weatherstrip Seal Retainer - Pt-27
- Liftgate Weatherstrip
- Quarter Panel Outer Belt Weatherstrip - Pt-27
- Rear Door Glass Run Weatherstrip
- Rear Door Inner Belt Weatherstrip
- Sill Secondary Weatherstrip
- Header / A-Pillar Weatherstrip -Pt-27
- Front Door Sill Weatherstrip - Pt-27
- Body Structure
- Body
- Message Systems
- Navigation System & Telecommunication System
- Body Diagnostic Procedures
- Headlights
- Lighting Systems - Exterior
- Lamps/Lighting - Exterior
- Back-Up Lamp
- Back-Up Lamp Unit
- Brake Lamp Switch
- Center High Mounted Stop Lamp
- Center High Mounted Stop Lamp Unit
- Center High Mounted Stop Lamp Unit - Pt27
- Combination Flasher
- Daytime Running Lamp Module
- Fog Lamp
- Fog Lamp Unit
- Headlamp
- Headlamp Unit
- Headlamp Switch
- License Plate Lamp
- License Plate Lamp Unit
- Multi-Function Switch
- Park/Turn Signal Lamp
- Rear Fog Lamp Switch - Export
- Tail Lamp
- Tail Lamp Unit
- Lighting Systems - Exterior
- Heated Glass/Defoggers
- Horns
- Infotainment
- Audio System
- Body Diagnostic Procedures
- Introduction
- Identification Of System
- System Description And Functional Operation
- Notes
- Airbag System
- Audio System
- Compass/Temperature Module (CTM)
- Compass/Temperature Mirror
- Description
- Operation
- English / Metric / Off Mode
- Calibration / Zone Mode
- Setting Compass Zone
- First Time Calibration
- Manual Calibration
- Continuous Calibration
- Self-Check Diagnostic
- Outside Temperature
- Temperature Update - Warm
- Temperature Update - Cold
- Extreme Temperature / Open Or Short Condition
- Ambient Temperature Sensor
- Ambient Temperature Sensor Diagnostics
- Instrument Cluster
- Remote Keyless Entry Module
- Sentry Key Immobilizer System (Skis)
- Communication
- Telecommunications
- Window Regulator Modules (Pt27 Only)
- Using The DRBIII®
- Disclaimers, Safety, Warnings
- Required Tools And Equipment
- Glossary Of Terms
- Diagnostic Information And Procedures
- Airbag
- Symptom List: ACCELEROMETER 1; INTERNAL 1; INTERNAL 2; INTERNAL 3; INTERNAL 4' OUTPUT DRIVER 1; OUTPUT DRIVER 2; STORED ENERGY FIRING 1
- Symptom List: AIRBAG WARNING INDICATOR DRIVER; AIRBAG WARNING INDICATOR OPEN; AIRBAG WARNING INDICATOR SHORT
- Symptom: CALIBRATION MISMATCH
- Symptom: CLUSTER MESSAGE MISMATCH
- Symptom: DRIVER SEAT BELT TENSIONER CIRCUIT OPEN
- Symptom: DRIVER SEAT BELT TENSIONER CIRCUIT SHORT
- Symptom: DRIVER SEAT BELT TENSIONER SHORT TO BATTERY
- Symptom: DRIVER SEAT BELT TENSIONER SHORT TO GROUND
- Symptom: DRIVER SQUIB 1 CIRCUIT OPEN
- Symptom: DRIVER SQUIB 1 CIRCUIT SHORT
- Symptom: DRIVER SQUIB 1 SHORT TO BATTERY
- Symptom: DRIVER SQUIB 1 SHORT TO GROUND
- Symptom: LEFT CURTAIN OR SEAT SQUIB CIRCUIT OPEN
- Symptom: LEFT CURTAIN OR SEAT SQUIB CIRCUIT SHORT
- Symptom: LEFT CURTAIN OR SEAT SQUIB SHORT TO BATTERY
- Symptom: LEFT CURTAIN OR SEAT SQUIB SHORT TO GROUND
- Symptom: LEFT SIDE IMPACT SENSOR 1 INTERNAL 1
- Symptom: LOSS OF IGNITION RUN - START
- Symptom: LOSS OF IGNITION RUN ONLY
- Symptom: NO CLUSTER MESSAGE
- Symptom: NO LEFT SIDE IMPACT SENSOR 1 COMMUNICATION
- Symptom: NO ODOMETER MESSAGE
- Symptom: NO PCI TRANSMISSION
- Symptom: NO RIGHT SIDE IMPACT SENSOR 1 COMMUNICATION
- Symptom: PASSENGER SEAT BELT TENSIONER CIRCUIT OPEN
- Symptom: PASSENGER SEAT BELT TENSIONER CIRCUIT SHORT
- Symptom: PASSENGER SEAT BELT TENSIONER SHORT TO BATTERY
- Symptom: PASSENGER SEAT BELT TENSIONER SHORT TO GROUND
- Symptom: PASSENGER SQUIB 1 CIRCUIT OPEN
- Symptom: PASSENGER SQUIB 1 CIRCUIT SHORT
- Symptom: PASSENGER SQUIB 1 SHORT TO BATTERY
- Symptom: PASSENGER SQUIB 1 SHORT TO GROUND
- Symptom: POWER SUPPLY VOLTAGE LOW
- Symptom: RIGHT CURTAIN OR SEAT SQUIB CIRCUIT OPEN
- Symptom: RIGHT CURTAIN OR SEAT SQUIB CIRCUIT SHORT
- Symptom: RIGHT CURTAIN OR SEAT SQUIB SHORT TO BATTERY
- Symptom: RIGHT CURTAIN OR SEAT SQUIB SHORT TO GROUND
- Symptom: RIGHT SIDE IMPACT SENSOR INTERNAL 1
- Symptom: VEHICLE BODY STYLE MISMATCH
- Symptom: *AIRBAG INDICATOR ON WITHOUT ACTIVE TROUBLE CODES
- Audio
- Symptom: ALL OUTPUTS SHORT
- Symptom: ANTENNA HARDWARE FAILURE - SDARS
- Symptom: ANTENNA NOT CONNECTED - SDARS
- Symptom: BUS BUSY - SDARS
- Symptom: BUS LOW - SDARS
- Symptom List: CASSETTE PLAYER INOP; CD MECHANICAL FAILURE; NO PCI TRANSMISSION; *AM/FM SWITCH INOPERATIVE; *ANY STATION PRESET SWITCH INOPERATIVE; *BALANCE INOPERATIVE; *CD EJECT SWITCH INOPERATIVE; *EQUALIZER INOPERATIVE; *FADER INOPERATIVE; *FF/RW SWITCH INOPERATIVE; *HOUR/MINUTE SWITCHES INOPERATIVE; *PAUSE/PLAY SWITCH INOPERATIVE; *PWR SWITCH INOPERATIVE; *SCAN SWITCH INOPERATIVE; *SEEK SWITCH INOPERATIVE; *SET SWITCH INOPERATIVE; *TAPE EJECT SWITCH INOPERATIVE; *TIME SWITCH INOPERATIVE; *TUNE SWITCH INOPERATIVE
- Symptom: CD PLAY FAILURE
- Symptom: CD READ FAILURE
- Symptom: CD TEMPERATURE HIGH
- Symptom: GPS ANTENNA NOT CONNECTED
- Symptom: INTERNAL FAILURE - SDARS
- Symptom: INTERNAL RECEIVER FAILURE - SDARS
- Symptom: LOW VOLTAGE LEVEL
- Symptom: NO ANTENNA CONNECTION
- Symptom: NO COMMUNICATION WITH SDARS
- Symptom: NO J1850 COMMUNICATION - SDARS
- Symptom: POWER AMP SHUTDOWN
- Symptom: RADIO AND NAV GPS ANTENNA NOT CONNECTED
- Symptom: *INOP NO FAULT CODES - SDARS
- Symptom: *POOR RECEPTION - SDARS
- Communication
- Symptom: *NO RESPONSE FROM AIRBAG CONTROL MODULE
- Symptom: *NO RESPONSE FROM AMPLIFIER
- Symptom: *NO RESPONSE FROM ANTILOCK BRAKE MODULE
- Symptom: *NO RESPONSE FROM ECM (PCI BUS) - DIESEL ONLY
- Symptom: *NO RESPONSE FROM ECM (SCI ONLY) - DIESEL ONLY
- Symptom: *NO RESPONSE FROM HANDS FREE MODULE
- Symptom: *NO RESPONSE FROM INSTRUMENT CLUSTER
- Symptom: *NO RESPONSE FROM OVERHEAD CONSOLE (COMPASS/TEMPERATURE MIRROR MODULE)
- Symptom: *NO RESPONSE FROM PCM (PCI BUS) - 1.6L
- Symptom: *NO RESPONSE FROM PCM (PCI BUS) - NGC
- Symptom: *NO RESPONSE FROM PCM (PCM SCI ONLY) - NGC
- Symptom: *NO RESPONSE FROM PCM (SCI ONLY) - 1.6L
- Symptom: *NO RESPONSE FROM RADIO
- Symptom: *NO RESPONSE FROM RKE
- Symptom: *NO RESPONSE FROM SATELLITE RADIO RECEIVER
- Symptom: *NO RESPONSE FROM SENTRY KEY IMMOBILIZER MODULE
- Symptom: *NO RESPONSE FROM TRANSMISSION CONTROL MODULE - NGC
- Symptom: *NO RESPONSE FROM WINDOW REGULATOR MODULE - PT27
- Symptom: *PCI BUS COMMUNICATION FAILURE
- Instrument Cluster
- Symptom List: ABS INDICATOR CIRCUIT OPEN; AIRBAG INDICATOR CIRCUIT OPEN
- Symptom List: ABS MESSAGE NOT RECEIVED; ACM MESSAGE NOT RECEIVED; EATX MESSAGE NOT RECEIVED; NO PCI TRANSMISSION; SBEC MESSAGE NOT RECEIVED; SKIM MESSAGE NOT RECEIVED
- Symptom: EATX MESSAGE MISMATCH
- Symptom: EEPROM CHECKSUM FAILURE
- Symptom: FUEL LEVEL SENSOR OPEN
- Symptom: FUEL LEVEL SENSOR SHORT
- Symptom: FUEL LEVEL SENSOR STUCK
- Symptom: PANEL DIMMER OPEN
- Symptom: PANEL DIMMER SHORTED
- Symptom: *ALL GAUGES INOPERATIVE
- Symptom: *ANY PCI BUS INDICATOR INOPERATIVE
- Symptom: *BRAKE WARNING INDICATOR ALWAYS ON
- Symptom: *BRAKE WARNING INDICATOR INOPERATIVE
- Symptom: *FRONT FOG LAMP INDICATOR INOPERATIVE
- Symptom: *FUEL GAUGE INACCURATE
- Symptom: *HIGH BEAM INDICATOR INOPERATIVE
- Symptom: *INSTRUMENT CLUSTER DIMMING INOPERATIVE
- Symptom: *LOW OIL PRESSURE INDICATOR ALWAYS ON
- Symptom: *LOW OIL PRESSURE INDICATOR INOPERATIVE
- Symptom: *ONE GAUGE INOPERATIVE
- Symptom: *PRND OR AUTOSTICK DISPLAY INOPERATIVE OR INACCURATE
- Symptom: *REAR FOG LAMP INDICATOR INOPERATIVE - BUX ONLY
- Symptom: *SEAT BELT INDICATOR NOT OPERATING PROPERLY
- Symptom: *VF DISPLAY INOPERATIVE
- Interior Lighting
- Overhead Console
- Power Door Locks/RKE
- Symptom: BODY STYLE MISMATCH
- Symptom: DRIVER DOOR SWITCH FAILURE
- Symptom: INCORRECT MODULE TYPE CONFIGURATION FOR PART NUMBER
- Symptom: MODULE NOT CONFIGURED FOR RKE
- Symptom: NO AIRBAG MESSAGES RECEIVED
- Symptom: NO PCM MESSAGES RECEIVED
- Symptom: NO SKIM MESSAGES RECEIVED
- Symptom: PASSENGER DOOR OR LIFTGATE SWITCH FAILURE - PT44
- Symptom:* ALL DOORS (EXCEPT DRIVER)FAIL TO LOCK
- Symptom: * ALL DOORS (EXCEPT DRIVER)FAIL TO LOCK AND UNLOCK
- Symptom:* ALL DOORS (EXCEPT DRIVER)FAIL TO UNLOCK
- Symptom: *ALL DOOR LOCKS INOPERATIVE
- Symptom: *ALL DOORS FAIL TO LOCK
- Symptom: *ALL DOORS FAIL TO UNLOCK
- Symptom: *ALL LOCKS INOPERATIVE FROM ONE LOCK SWITCH
- Symptom: *DECKLID RELEASE SWITCH INOPERATIVE - PT27
- Symptom: *DECKLID SOLENOID INOPERATIVE - PT27
- Symptom: *DOORS LOCKABLE WITH KEY IN IGNITION AND DRIVER DOOR OPEN
- Symptom: *DRIVER DOOR FAILS TO LOCK
- Symptom: *DRIVER DOOR FAILS TO LOCK AND UNLOCK
- Symptom: *DRIVER DOOR FAILS TO UNLOCK
- Symptom: *DRIVER DOOR FAILS UNLOCK - PT27
- Symptom: *LIFTGATE LOCK MOTOR FAILS TO LOCK OR UNLOCK
- Symptom: *ONE DOOR FAILS TO LOCK AND UNLOCK - PT27
- Symptom: *ONE PASSENGER DOOR FAILS TO LOCK AND UNLOCK
- Symptom: *PASSENGER DOOR FAILS TO UNLOCK - PT27
- Symptom: *RKE INOPERATIVE
- Power Top
- Symptom: AMBIENT TEMP MESSAGE NOT RECEIVED
- Symptom: POWER TOP RELAY CONTROL CIRCUIT OPEN
- Symptom: POWER TOP RELAY INOPERATIVE
- Symptom: POWER TOP SWITCH MUX CIRCUIT OPEN
- Symptom: POWER TOP SWITCH MUX CIRCUIT SHORT TO GROUND
- Symptom: POWER TOP SWITCH MUX CIRCUIT VALUE OUT OF RANGE
- Symptom: SPEED MESSAGE NOT RECEIVED
- Power Windows
- Symptom: BATTERY VOLTAGE TOO HIGH
- Symptom: BATTERY VOLTAGE TOO LOW
- Symptom: FRONT WINDOW MOTOR MALFUNCTION
- Symptom: FRONT WINDOW SWITCH MUX CIRCUIT OPEN
- Symptom: FRONT WINDOW SWITCH MUX CIRCUIT SHORT TO GROUND
- Symptom: FRONT WINDOW SWITCH MUX CIRCUIT VALUE OUT OF RANGE
- Symptom: IGNITION SWITCH OUTPUT OPEN
- Symptom: REAR WINDOW MOTOR CIRCUIT OPEN OR SHORTED
- Symptom: REAR WINDOW SWITCH MUX CIRCUIT OPEN
- Symptom: REAR WINDOW SWITCH MUX CIRCUIT SHORT TO GROUND
- Symptom: REAR WINDOW SWITCH MUX CIRCUIT VALUE OUT OF RANGE
- Symptom: WINDOW DROP SWITCH SENSE CIRCUIT OPEN
- Symptom: *DOOR AJAR CIRCUIT OPEN
- Symptom: *DOOR WINDOWS STAY IN DROP DOWN POSITION
- Symptom: *WINDOW DROPS OR JERKS DURING OPENING
- Telecommunication
- Symptom: AUDIO HARDWARE MESSAGE NOT RECEIVED
- Symptom List: BLUETOOTH ERROR; FLASH CHECKSUM ERROR; FLASH WRITE ERROR; PCI BUS INTERNAL ERROR; RAM WRITE ERROR; ROM CHECKSUM ERROR
- Symptom List: BODY STYLE MESSAGE NOT RECEIVED; INVALID BODY STYLE
- Symptom: GENERAL MICROPHONE FAULT
- Symptom: IGNITION POWER MESSAGE NOT RECEIVED
- Symptom List: LEFT AUDIO INPUT SHORT TO GROUND; LEFT AUDIO INPUT SHORT TO VOLTAGE; LEFT AUDIO OUTPUT 1 SHORT TO GROUND; LEFT AUDIO OUTPUT 1 SHORT TO VOLTAGE
- Symptom List: MIRROR POWER CIRCUIT SHORT TO GROUND; MIRROR POWER CIRCUIT SHORT TO VOLTAGE
- Symptom List: PCI BUS BUSY; PCI BUS CIRCUIT OPEN; PCI BUS CIRCUIT SHORT TO GROUND; PCI BUS CIRCUIT SHORT TO VOLTAGE
- Symptom List: PHONE SWITCH STUCK; VOICE RECOGNITION SWITCH STUCK' VOICE RECOGNITION/PHONE SWITCH CIRCUIT RATIONALITY; VOICE RECOGNITION/PHONE SWITCH CIRCUIT SHORT TO GROUND; VOICE RECOGNITION/PHONE SWITCH CIRCUIT SHORT TO VOLTAGE
- Symptom: PRNDL MESSAGE NOT RECEIVED
- Symptom: RADIO MESSAGE NOT RECEIVED
- Symptom List: RIGHT AUDIO INPUT SHORT TO GROUND; RIGHT AUDIO INPUT SHORT TO VOLTAGE; RIGHT AUDIO OUTPUT 1 SHORT TO GROUND; RIGHT AUDIO OUTPUT 1 SHORT TO VOLTAGE
- Symptom: RPM MESSAGE NOT RECEIVED
- Symptom: VIN MESSAGE NOT RECEIVED
- Symptom: VIN MISMATCH
- Vehicle Theft/Security
- Symptom: HOOD AJAR SWITCH MISSING (EXPORT ONLY)
- Symptom: MODULE PREVIOUSLY CONFIGURED FOR VTSS
- Symptom: *ALARM TRIPS ON ITS OWN
- Symptom: *HEADLAMPS FAIL TO FLASH DURING ALARM
- Symptom: *HORN FAILS TO SOUND DURING ALARM
- Symptom: *INTRUSION SENSOR CANNOT BE DISABLED (EXPORT ONLY)
- Symptom: *INTRUSION SENSOR FAILS TO TRIP VTSS (EXPORT ONLY)
- Symptom: *INTRUSION SENSOR REPEATEDLY TRIGGERS VTSS (EXPORT ONLY)
- Symptom: *OPEN DRIVER DOOR FAILS TO TRIP ALARM
- Symptom: *OPEN LIFTGATE FAILS TO TRIP ALARM
- Symptom: *OPEN PASSENGER DOOR FAILS TO TRIP ALARM
- Symptom: *PARK LAMPS FAIL TO FLASH DURING ALARM
- Symptom List: *VTSS FAILS TO ARM FROM LEFT DOOR CYLINDER LOCK SWITCH (EXPORT ONLY); *VTSS FAILS TO ARM/DISARM FROM LEFT DOOR CYLINDER LOCK SWITCH
- Symptom List: *VTSS FAILS TO ARM FROM LIFTGATE CYLINDER LOCK SWITCH (EXPORT ONLY); *VTSS FAILS TO ARM/DISARM FROM LIFTGATE CYLINDER LOCK SWITCH
- Symptom List: *VTSS FAILS TO ARM FROM RIGHT DOOR CYLINDER LOCK SWITCH (EXPORT ONLY); *VTSS FAILS TO ARM/DISARM FROM RIGHT DOOR CYLINDER LOCK SWITCH
- Symptom: *VTSS INDICATOR FAILS TO FLASH
- Symptom: *VTSS INDICATOR STAYS ON STEADY DURING ARMING
- Symptom: *VTSS SIREN INOPERATIVE (EXPORT ONLY)
- Verifications Tests
- Airbag
- Component Locations
- Connector PINOUTS
- Airbag Control Module (Orc) (Base) - Yellow 23 Way
- Airbag Control Module C1 (Orc) (Premium) - Yellow 32 Way
- Airbag Control Module C2 (Orc) (Premium) - Yellow 32 Way
- Ambient Temperature Sensor (Except 2.4L Base) - Black 2 Way
- Amplifier Audio C1 - 20 Way
- Anti-Lock Brake Module - Black 47 Way
- C203 (Pt27) - LT. Gray (Body Side)
- C203 (Pt27) - LT. Gray (Instrument Panel Side)
- C204 (Pt27) - (Instrument Panel Side)
- C204 (Pt27) - (Left Front Door Side)
- C204 (Pt44 LHP) - Natural (Instrument Panel Side)
- C204 (Pt44 LHP) - Natural (Left Front Door Side)
- C205 (Pt27) - (Instrument Panel Side)
- C205 (Pt27) - (Right Front Door Side)
- C305 - Yellow (Airbag Side)
- C305 - Yellow (UNIBODY Side)
- C306 - Yellow (Airbag Side)
- C306 - Yellow (UNIBODY Side)
- C343 (Pt27) - LT. Gray (DECKLID Jumper Side)
- C343 (Pt27) - LT. Gray (DECKLID Side)
- C349 (Pt27) - Blue (Body Side
- C349 (Pt27) - Blue (DECKLID Jumper Side)
- C362 (Pt27) - LT. Gray (Body Side)
- C362 (Pt27) - LT. Gray (Power Top Side)
- CLOCKSPRING - DK. Green 7 Way
- Compass/Temperature Mirror Module (Pt27) - Black 10 Way
- Data Link Connector - Black 16 Way
- DECKLID Cylinder Unlock Switch (Pt27) - LT. Gray 2 Way
- DECKLID Handle Switch (Pt27) - White 2 Way
- DECKLID Release Motor (Pt27) - Black 3 Way
- DECKLID Release Switch (Pt27) - Black 2 Way
- Dome Lamp - Black 3 Way
- Dome Lamp/Intrusion Sensor (Export) - White 4 Way
- Driver Airbag Squib 1 - Yellow 2 Way
- Driver Door Ajar Switch - Black 2 Way
- Driver Door Handle Switch (Pt27) - 2 Way
- Driver Door Power Lock Motor/Ajar Switch - Black 4 Way
- Driver Rear Window Motor (Pt27) - Black 2 Way
- Driver Seat Belt TENSIONER - Yellow 2 Way
- Driver Window Regulator Module (Pt27) - Black 20 Way
- Engine Control Module C1 (Diesel) - Black 81 Way
- Front Power Window Switch - Black 14 Way
- Fuel Pump Module - LT. Gray 4 Way
- Fuses (FB)
- Hands Free Module C1 - DK. Gray 22 Way
- Hands Free Module C2 (Satellite Radio) - DK. Gray 10 Way
- Hands Free Module C3 - Black 10 Way
- High Note Horn (Export) - Black 2 Way
- Hood Ajar Switch (Export) - Black 2 Way
- Ignition Switch C1 - 10 Way
- Instrument Cluster C1 - Black 26 Way
- Instrument Cluster C2 - Black 10 Way
- Left Cylinder Lock Switch - Black 2 Way
- Left Door Lock Switch - Black 3 Way
- Left Front Power Window Motor (Pt44) - Black 2 Way
- Left Instrument Panel Speaker - Black 2 Way
- Left Rear Speaker (Pt44) - Black 2 Way
- Left Seat Airbag Squib (LHP) - Yellow 2 Way
- Left Seat Airbag Squib (RHD) - Yellow 2 Way
- Left Side Impact Sensor 1 - Gray 2 Way
- Liftgate Ajar Switch - White 2 Way
- Liftgate Cylinder Lock Switch - LT. Gray 2 Way
- Liftgate Handle Switch (Pt44) - Natural 2 Way
- Liftgate Power Lock Motor - Black 4 Way
- Liftgate Release Motor (Pt44) - Black 3 Way
- Low Note Horn - Black 2 Way
- Multi-Function Switch - Gray 20 Way
- Overhead Console Module - Black 12 Way
- Passenger Airbag Squib 1 - Yellow 2 Way
- Passenger Door Ajar Switch - Black 2 Way
- Passenger Door Handle Switch (Pt27) - 2 Way
- Passenger Door Power Lock Motor/Ajar Switch - Black 4 Way
- Passenger Rear Window Motor (Pt27) - Black 2 Way
- Passenger Seat Belt TENSIONER - Yellow 2 Way
- Passenger Window Regulator Module (Pt27) - Black 20 Way
- Fuses (PDC)
- Power Top Motor (Pt27) - 2 Way
- Power Top Relay (Pt27) - Black 6 Way
- Power Top Switch (Pt27) - 3 Way
- Powertrain Control Module (1.6L) - Black 90 Way
- Powertrain Control Module C1 (NGC) - Black/Black 38 Way
- Radio C1 - White 22 Way
- Radio C2 (Hands Free) - DK. Gray 10 Way
- Rear View Mirror C1 - Black 12 Way
- Remote Keyless Entry Module - Black 26 Way
- Right Cylinder Lock Switch (Export) - Black 2 Way
- Right Door Lock Switch - Black 3 Way
- Right Front Door Speaker - 3 Way
- Right Front Power Window Motor (Pt44) - Black 2 Way
- Right Rear Power Window Motor (Pt44) - Black 2 Way
- Right Seat Airbag Squib (LHP) - Yellow 2 Way
- Right Seat Airbag Squib (RHP) - Yellow 2 Way
- Right Side Impact Sensor 1 - Gray 2 Way
- Sentry Key Immobilizer Module - Black 6 Way
- Siren (Export) - Black 4 Way
- Schematic Diagrams
- Message Systems
- Navigation System & Telecommunication System
- Interior/Exterior Trim
- Interior & Exterior
- Body
- Description
- Warning
- Diagnosis And Testing
- Standard Procedure
- Standard Procedure - Plastic Body Panel Repair
- Notes
- Rigid Plastics:
- Semi-Rigid Plastics:
- Flexible Plastics:
- Repair Procedure:
- Adhesion Promoter/Surface Modifier:
- Safety Precaution And Warnings
- Rigid, Semi-Rigid, And Flexible Plastic Parts Types
- Panel Sectioning
- Panel Reinforcement
- Visual Inspection
- Panel Surface Preparation
- Patching Panels
- Panel Patch Fabrications
- Panel Patch Installation
- Patched Panel Surfacing
- Standard Procedure - Heat Staking
- Standard Procedure - Plastic Body Panel Repair
- Specifications
- Special Tools
- Convertible Top
- DECKLID - Pt-27
- Door - Front
- Front Door Applique
- Front Door Check Strap
- Front Door
- Front Door Glass
- Removal
- Installation
- Adjustment - Pt-27 Only
- Front Door Adjustment
- Quarter Glass Adjustment
- Notes
- Up-Stop Adjustments
- Bottom Of Glass - Inboard/Outboard Adjustments
- Top Of Glass - Inboard/Outboard Adjustments
- Glass - Front/Rear Adjustment
- Quarter Glass Alignment Verification
- Condition - Height Mismatch Between Door Glass And Quarter Glass With Top Down
- Condition - Door Glass Noise Along A-Pillar When Closing Door And/Or Door Glass Touching Quarter Glass Metal Seal Retainer And/Or Wind Noise/Water Leak Along Quarter Glass Seal.
- Condition - Door Glass Not Driving Into The Top In Full Up Position
- Condition - Quarter Glass Not Driving Into The Top In Full Up Position
- Condition - Slapping Noise Between The Door And Quarter Glass With The Top Down During Driving Of The Vehicle
- Condition - Non-Parallel Gap Between Door And Quarter Glasses
- Condition - Quarter Glass Seal Fold Over During Travel With Door Glass Full Up And Top Up Or Down
- Condition - Intermediate Rear Of Door Glass Not Driving Into The Top Seal And/Or Noise At Rear Bottom Of The Door
- Front Door Outside Handle
- Front Door Hinge
- Front Door Inside Handle Actuator
- Front Door Latch
- Front Door Latch Striker
- Front Door Lock Cylinder
- Front Door Vertical Guide Bar
- Front Door Side View Mirror Flag - Pt-27
- Front Door Trim Panel
- Front Door Water Dam
- Front Door Window Regulator
- Door Glass Inner Belt Stabilizer - Pt-27
- Rear Rail Assembly - Pt-27
- Door - Rear
- Exterior
- Body Side Moldings
- Cowl Grille Screen
- Deck Upper Belt Molding - Pt-27
- Engine Compartment Lower Silencer
- Exterior Name Plates
- Front Fender
- Front Side Rail Access Pulley Splash Shield
- Front Wheelhouse Splash Shields
- Fuel Fill Door
- Grille
- Header Molding - Pt-27
- Luggage Rack Crossbar
- Luggage Rack Side Rail
- Radiator Closure Panel
- Side View Mirror
- Side View Mirror Glass
- Windshield A-Pillar Trim Molding - Pt-27
- Wood Grain/Flame Decals
- Grille - Lower Radiator
- Hood
- Instrument Panel
- Interior
- A-Pillar Trim
- B-Pillar Trim
- Body Vent
- DECKLID Sill Scuff Plate
- Door Sill Trim
- Floor Carpet
- Cargo Area Floor Carpet - Pt-27
- Front Floor Carpet Right/Left Side -Pt-27
- Rear Carpet - Pt-27
- Upper D-Pillar Trim
- Header Latch Retainer - Pt-27
- Headliner
- Inside Rear View Mirror
- Lower Quarter Trim Panel
- Rear Quarter Panel Trim - Pt-27
- Seat Back Support Bracket - Pt-27
- Side Cowl Trim Panel
- Sport Bar - Pt-27
- Sport Bar Inner Covers - Pt-27
- Sport Bar Outer Cover - Pt-27
- Sun Visor
- Trunk Trim Panel - Pt-27
- Trunk Welt - Pt-27
- Upper C-Pillar Trim
- Windshield Header Molding -Pt-27
- Liftgate
- Paint
- Quarter Glass - Pt-27
- Seats
- Child Seat Tether Anchor Bezel
- Front Seat
- Front Seat Back - With Front Seat Back Panel
- Front Seat Back
- Front Seat Back Cover/Foam
- Front Seat Back Cover - Without Front Seat Back Panel
- Front Seat Cushion
- Front Seat Cushion Cover
- Headrest - Front/Rear
- Rear Seat
- Rear Seat Back
- Rear Seat Back Cover/Foam
- Rear Seat Back Cushion Cover/Foam - Pt-27
- Rear Seat Bolster - Pt-27
- Rear Seat Bolster Cover - Pt-27
- Rear Seat Cushion
- Rear Seat Back Cushion / Cover
- Rear Seat Latch Cover
- Under Seat Storage Bin
- Stationary Glass
- Sunroof
- Weatherstrip/Seals
- A-Pillar Weatherstrip Retainer - Pt-27
- Deck Lid Opening Weatherstrip - Pt-27
- Front And Rear Door Opening Weatherstrip
- Front And Rear Door Upper Secondary Weatherstrip
- Front Door Glass Run Weatherstrip
- Front Door Inner Belt Weatherstrip
- Front Door Outer Belt Weatherstrip
- Header Weatherstrip Seal Retainer - Pt-27
- Liftgate Weatherstrip
- Quarter Panel Outer Belt Weatherstrip - Pt-27
- Rear Door Glass Run Weatherstrip
- Rear Door Inner Belt Weatherstrip
- Sill Secondary Weatherstrip
- Header / A-Pillar Weatherstrip -Pt-27
- Front Door Sill Weatherstrip - Pt-27
- Body Structure
- Body
- Interior & Exterior
- Interior/Illumination Lights
- Mirrors
- Seats
- Body Diagnostic Procedures
- Introduction
- Identification Of System
- System Description And Functional Operation
- Notes
- Airbag System
- Audio System
- Compass/Temperature Module (CTM)
- Compass/Temperature Mirror
- Description
- Operation
- English / Metric / Off Mode
- Calibration / Zone Mode
- Setting Compass Zone
- First Time Calibration
- Manual Calibration
- Continuous Calibration
- Self-Check Diagnostic
- Outside Temperature
- Temperature Update - Warm
- Temperature Update - Cold
- Extreme Temperature / Open Or Short Condition
- Ambient Temperature Sensor
- Ambient Temperature Sensor Diagnostics
- Instrument Cluster
- Remote Keyless Entry Module
- Sentry Key Immobilizer System (Skis)
- Communication
- Telecommunications
- Window Regulator Modules (Pt27 Only)
- Using The DRBIII®
- Disclaimers, Safety, Warnings
- Required Tools And Equipment
- Glossary Of Terms
- Diagnostic Information And Procedures
- Airbag
- Symptom List: ACCELEROMETER 1; INTERNAL 1; INTERNAL 2; INTERNAL 3; INTERNAL 4' OUTPUT DRIVER 1; OUTPUT DRIVER 2; STORED ENERGY FIRING 1
- Symptom List: AIRBAG WARNING INDICATOR DRIVER; AIRBAG WARNING INDICATOR OPEN; AIRBAG WARNING INDICATOR SHORT
- Symptom: CALIBRATION MISMATCH
- Symptom: CLUSTER MESSAGE MISMATCH
- Symptom: DRIVER SEAT BELT TENSIONER CIRCUIT OPEN
- Symptom: DRIVER SEAT BELT TENSIONER CIRCUIT SHORT
- Symptom: DRIVER SEAT BELT TENSIONER SHORT TO BATTERY
- Symptom: DRIVER SEAT BELT TENSIONER SHORT TO GROUND
- Symptom: DRIVER SQUIB 1 CIRCUIT OPEN
- Symptom: DRIVER SQUIB 1 CIRCUIT SHORT
- Symptom: DRIVER SQUIB 1 SHORT TO BATTERY
- Symptom: DRIVER SQUIB 1 SHORT TO GROUND
- Symptom: LEFT CURTAIN OR SEAT SQUIB CIRCUIT OPEN
- Symptom: LEFT CURTAIN OR SEAT SQUIB CIRCUIT SHORT
- Symptom: LEFT CURTAIN OR SEAT SQUIB SHORT TO BATTERY
- Symptom: LEFT CURTAIN OR SEAT SQUIB SHORT TO GROUND
- Symptom: LEFT SIDE IMPACT SENSOR 1 INTERNAL 1
- Symptom: LOSS OF IGNITION RUN - START
- Symptom: LOSS OF IGNITION RUN ONLY
- Symptom: NO CLUSTER MESSAGE
- Symptom: NO LEFT SIDE IMPACT SENSOR 1 COMMUNICATION
- Symptom: NO ODOMETER MESSAGE
- Symptom: NO PCI TRANSMISSION
- Symptom: NO RIGHT SIDE IMPACT SENSOR 1 COMMUNICATION
- Symptom: PASSENGER SEAT BELT TENSIONER CIRCUIT OPEN
- Symptom: PASSENGER SEAT BELT TENSIONER CIRCUIT SHORT
- Symptom: PASSENGER SEAT BELT TENSIONER SHORT TO BATTERY
- Symptom: PASSENGER SEAT BELT TENSIONER SHORT TO GROUND
- Symptom: PASSENGER SQUIB 1 CIRCUIT OPEN
- Symptom: PASSENGER SQUIB 1 CIRCUIT SHORT
- Symptom: PASSENGER SQUIB 1 SHORT TO BATTERY
- Symptom: PASSENGER SQUIB 1 SHORT TO GROUND
- Symptom: POWER SUPPLY VOLTAGE LOW
- Symptom: RIGHT CURTAIN OR SEAT SQUIB CIRCUIT OPEN
- Symptom: RIGHT CURTAIN OR SEAT SQUIB CIRCUIT SHORT
- Symptom: RIGHT CURTAIN OR SEAT SQUIB SHORT TO BATTERY
- Symptom: RIGHT CURTAIN OR SEAT SQUIB SHORT TO GROUND
- Symptom: RIGHT SIDE IMPACT SENSOR INTERNAL 1
- Symptom: VEHICLE BODY STYLE MISMATCH
- Symptom: *AIRBAG INDICATOR ON WITHOUT ACTIVE TROUBLE CODES
- Audio
- Symptom: ALL OUTPUTS SHORT
- Symptom: ANTENNA HARDWARE FAILURE - SDARS
- Symptom: ANTENNA NOT CONNECTED - SDARS
- Symptom: BUS BUSY - SDARS
- Symptom: BUS LOW - SDARS
- Symptom List: CASSETTE PLAYER INOP; CD MECHANICAL FAILURE; NO PCI TRANSMISSION; *AM/FM SWITCH INOPERATIVE; *ANY STATION PRESET SWITCH INOPERATIVE; *BALANCE INOPERATIVE; *CD EJECT SWITCH INOPERATIVE; *EQUALIZER INOPERATIVE; *FADER INOPERATIVE; *FF/RW SWITCH INOPERATIVE; *HOUR/MINUTE SWITCHES INOPERATIVE; *PAUSE/PLAY SWITCH INOPERATIVE; *PWR SWITCH INOPERATIVE; *SCAN SWITCH INOPERATIVE; *SEEK SWITCH INOPERATIVE; *SET SWITCH INOPERATIVE; *TAPE EJECT SWITCH INOPERATIVE; *TIME SWITCH INOPERATIVE; *TUNE SWITCH INOPERATIVE
- Symptom: CD PLAY FAILURE
- Symptom: CD READ FAILURE
- Symptom: CD TEMPERATURE HIGH
- Symptom: GPS ANTENNA NOT CONNECTED
- Symptom: INTERNAL FAILURE - SDARS
- Symptom: INTERNAL RECEIVER FAILURE - SDARS
- Symptom: LOW VOLTAGE LEVEL
- Symptom: NO ANTENNA CONNECTION
- Symptom: NO COMMUNICATION WITH SDARS
- Symptom: NO J1850 COMMUNICATION - SDARS
- Symptom: POWER AMP SHUTDOWN
- Symptom: RADIO AND NAV GPS ANTENNA NOT CONNECTED
- Symptom: *INOP NO FAULT CODES - SDARS
- Symptom: *POOR RECEPTION - SDARS
- Communication
- Symptom: *NO RESPONSE FROM AIRBAG CONTROL MODULE
- Symptom: *NO RESPONSE FROM AMPLIFIER
- Symptom: *NO RESPONSE FROM ANTILOCK BRAKE MODULE
- Symptom: *NO RESPONSE FROM ECM (PCI BUS) - DIESEL ONLY
- Symptom: *NO RESPONSE FROM ECM (SCI ONLY) - DIESEL ONLY
- Symptom: *NO RESPONSE FROM HANDS FREE MODULE
- Symptom: *NO RESPONSE FROM INSTRUMENT CLUSTER
- Symptom: *NO RESPONSE FROM OVERHEAD CONSOLE (COMPASS/TEMPERATURE MIRROR MODULE)
- Symptom: *NO RESPONSE FROM PCM (PCI BUS) - 1.6L
- Symptom: *NO RESPONSE FROM PCM (PCI BUS) - NGC
- Symptom: *NO RESPONSE FROM PCM (PCM SCI ONLY) - NGC
- Symptom: *NO RESPONSE FROM PCM (SCI ONLY) - 1.6L
- Symptom: *NO RESPONSE FROM RADIO
- Symptom: *NO RESPONSE FROM RKE
- Symptom: *NO RESPONSE FROM SATELLITE RADIO RECEIVER
- Symptom: *NO RESPONSE FROM SENTRY KEY IMMOBILIZER MODULE
- Symptom: *NO RESPONSE FROM TRANSMISSION CONTROL MODULE - NGC
- Symptom: *NO RESPONSE FROM WINDOW REGULATOR MODULE - PT27
- Symptom: *PCI BUS COMMUNICATION FAILURE
- Instrument Cluster
- Symptom List: ABS INDICATOR CIRCUIT OPEN; AIRBAG INDICATOR CIRCUIT OPEN
- Symptom List: ABS MESSAGE NOT RECEIVED; ACM MESSAGE NOT RECEIVED; EATX MESSAGE NOT RECEIVED; NO PCI TRANSMISSION; SBEC MESSAGE NOT RECEIVED; SKIM MESSAGE NOT RECEIVED
- Symptom: EATX MESSAGE MISMATCH
- Symptom: EEPROM CHECKSUM FAILURE
- Symptom: FUEL LEVEL SENSOR OPEN
- Symptom: FUEL LEVEL SENSOR SHORT
- Symptom: FUEL LEVEL SENSOR STUCK
- Symptom: PANEL DIMMER OPEN
- Symptom: PANEL DIMMER SHORTED
- Symptom: *ALL GAUGES INOPERATIVE
- Symptom: *ANY PCI BUS INDICATOR INOPERATIVE
- Symptom: *BRAKE WARNING INDICATOR ALWAYS ON
- Symptom: *BRAKE WARNING INDICATOR INOPERATIVE
- Symptom: *FRONT FOG LAMP INDICATOR INOPERATIVE
- Symptom: *FUEL GAUGE INACCURATE
- Symptom: *HIGH BEAM INDICATOR INOPERATIVE
- Symptom: *INSTRUMENT CLUSTER DIMMING INOPERATIVE
- Symptom: *LOW OIL PRESSURE INDICATOR ALWAYS ON
- Symptom: *LOW OIL PRESSURE INDICATOR INOPERATIVE
- Symptom: *ONE GAUGE INOPERATIVE
- Symptom: *PRND OR AUTOSTICK DISPLAY INOPERATIVE OR INACCURATE
- Symptom: *REAR FOG LAMP INDICATOR INOPERATIVE - BUX ONLY
- Symptom: *SEAT BELT INDICATOR NOT OPERATING PROPERLY
- Symptom: *VF DISPLAY INOPERATIVE
- Interior Lighting
- Overhead Console
- Power Door Locks/RKE
- Symptom: BODY STYLE MISMATCH
- Symptom: DRIVER DOOR SWITCH FAILURE
- Symptom: INCORRECT MODULE TYPE CONFIGURATION FOR PART NUMBER
- Symptom: MODULE NOT CONFIGURED FOR RKE
- Symptom: NO AIRBAG MESSAGES RECEIVED
- Symptom: NO PCM MESSAGES RECEIVED
- Symptom: NO SKIM MESSAGES RECEIVED
- Symptom: PASSENGER DOOR OR LIFTGATE SWITCH FAILURE - PT44
- Symptom:* ALL DOORS (EXCEPT DRIVER)FAIL TO LOCK
- Symptom: * ALL DOORS (EXCEPT DRIVER)FAIL TO LOCK AND UNLOCK
- Symptom:* ALL DOORS (EXCEPT DRIVER)FAIL TO UNLOCK
- Symptom: *ALL DOOR LOCKS INOPERATIVE
- Symptom: *ALL DOORS FAIL TO LOCK
- Symptom: *ALL DOORS FAIL TO UNLOCK
- Symptom: *ALL LOCKS INOPERATIVE FROM ONE LOCK SWITCH
- Symptom: *DECKLID RELEASE SWITCH INOPERATIVE - PT27
- Symptom: *DECKLID SOLENOID INOPERATIVE - PT27
- Symptom: *DOORS LOCKABLE WITH KEY IN IGNITION AND DRIVER DOOR OPEN
- Symptom: *DRIVER DOOR FAILS TO LOCK
- Symptom: *DRIVER DOOR FAILS TO LOCK AND UNLOCK
- Symptom: *DRIVER DOOR FAILS TO UNLOCK
- Symptom: *DRIVER DOOR FAILS UNLOCK - PT27
- Symptom: *LIFTGATE LOCK MOTOR FAILS TO LOCK OR UNLOCK
- Symptom: *ONE DOOR FAILS TO LOCK AND UNLOCK - PT27
- Symptom: *ONE PASSENGER DOOR FAILS TO LOCK AND UNLOCK
- Symptom: *PASSENGER DOOR FAILS TO UNLOCK - PT27
- Symptom: *RKE INOPERATIVE
- Power Top
- Symptom: AMBIENT TEMP MESSAGE NOT RECEIVED
- Symptom: POWER TOP RELAY CONTROL CIRCUIT OPEN
- Symptom: POWER TOP RELAY INOPERATIVE
- Symptom: POWER TOP SWITCH MUX CIRCUIT OPEN
- Symptom: POWER TOP SWITCH MUX CIRCUIT SHORT TO GROUND
- Symptom: POWER TOP SWITCH MUX CIRCUIT VALUE OUT OF RANGE
- Symptom: SPEED MESSAGE NOT RECEIVED
- Power Windows
- Symptom: BATTERY VOLTAGE TOO HIGH
- Symptom: BATTERY VOLTAGE TOO LOW
- Symptom: FRONT WINDOW MOTOR MALFUNCTION
- Symptom: FRONT WINDOW SWITCH MUX CIRCUIT OPEN
- Symptom: FRONT WINDOW SWITCH MUX CIRCUIT SHORT TO GROUND
- Symptom: FRONT WINDOW SWITCH MUX CIRCUIT VALUE OUT OF RANGE
- Symptom: IGNITION SWITCH OUTPUT OPEN
- Symptom: REAR WINDOW MOTOR CIRCUIT OPEN OR SHORTED
- Symptom: REAR WINDOW SWITCH MUX CIRCUIT OPEN
- Symptom: REAR WINDOW SWITCH MUX CIRCUIT SHORT TO GROUND
- Symptom: REAR WINDOW SWITCH MUX CIRCUIT VALUE OUT OF RANGE
- Symptom: WINDOW DROP SWITCH SENSE CIRCUIT OPEN
- Symptom: *DOOR AJAR CIRCUIT OPEN
- Symptom: *DOOR WINDOWS STAY IN DROP DOWN POSITION
- Symptom: *WINDOW DROPS OR JERKS DURING OPENING
- Telecommunication
- Symptom: AUDIO HARDWARE MESSAGE NOT RECEIVED
- Symptom List: BLUETOOTH ERROR; FLASH CHECKSUM ERROR; FLASH WRITE ERROR; PCI BUS INTERNAL ERROR; RAM WRITE ERROR; ROM CHECKSUM ERROR
- Symptom List: BODY STYLE MESSAGE NOT RECEIVED; INVALID BODY STYLE
- Symptom: GENERAL MICROPHONE FAULT
- Symptom: IGNITION POWER MESSAGE NOT RECEIVED
- Symptom List: LEFT AUDIO INPUT SHORT TO GROUND; LEFT AUDIO INPUT SHORT TO VOLTAGE; LEFT AUDIO OUTPUT 1 SHORT TO GROUND; LEFT AUDIO OUTPUT 1 SHORT TO VOLTAGE
- Symptom List: MIRROR POWER CIRCUIT SHORT TO GROUND; MIRROR POWER CIRCUIT SHORT TO VOLTAGE
- Symptom List: PCI BUS BUSY; PCI BUS CIRCUIT OPEN; PCI BUS CIRCUIT SHORT TO GROUND; PCI BUS CIRCUIT SHORT TO VOLTAGE
- Symptom List: PHONE SWITCH STUCK; VOICE RECOGNITION SWITCH STUCK' VOICE RECOGNITION/PHONE SWITCH CIRCUIT RATIONALITY; VOICE RECOGNITION/PHONE SWITCH CIRCUIT SHORT TO GROUND; VOICE RECOGNITION/PHONE SWITCH CIRCUIT SHORT TO VOLTAGE
- Symptom: PRNDL MESSAGE NOT RECEIVED
- Symptom: RADIO MESSAGE NOT RECEIVED
- Symptom List: RIGHT AUDIO INPUT SHORT TO GROUND; RIGHT AUDIO INPUT SHORT TO VOLTAGE; RIGHT AUDIO OUTPUT 1 SHORT TO GROUND; RIGHT AUDIO OUTPUT 1 SHORT TO VOLTAGE
- Symptom: RPM MESSAGE NOT RECEIVED
- Symptom: VIN MESSAGE NOT RECEIVED
- Symptom: VIN MISMATCH
- Vehicle Theft/Security
- Symptom: HOOD AJAR SWITCH MISSING (EXPORT ONLY)
- Symptom: MODULE PREVIOUSLY CONFIGURED FOR VTSS
- Symptom: *ALARM TRIPS ON ITS OWN
- Symptom: *HEADLAMPS FAIL TO FLASH DURING ALARM
- Symptom: *HORN FAILS TO SOUND DURING ALARM
- Symptom: *INTRUSION SENSOR CANNOT BE DISABLED (EXPORT ONLY)
- Symptom: *INTRUSION SENSOR FAILS TO TRIP VTSS (EXPORT ONLY)
- Symptom: *INTRUSION SENSOR REPEATEDLY TRIGGERS VTSS (EXPORT ONLY)
- Symptom: *OPEN DRIVER DOOR FAILS TO TRIP ALARM
- Symptom: *OPEN LIFTGATE FAILS TO TRIP ALARM
- Symptom: *OPEN PASSENGER DOOR FAILS TO TRIP ALARM
- Symptom: *PARK LAMPS FAIL TO FLASH DURING ALARM
- Symptom List: *VTSS FAILS TO ARM FROM LEFT DOOR CYLINDER LOCK SWITCH (EXPORT ONLY); *VTSS FAILS TO ARM/DISARM FROM LEFT DOOR CYLINDER LOCK SWITCH
- Symptom List: *VTSS FAILS TO ARM FROM LIFTGATE CYLINDER LOCK SWITCH (EXPORT ONLY); *VTSS FAILS TO ARM/DISARM FROM LIFTGATE CYLINDER LOCK SWITCH
- Symptom List: *VTSS FAILS TO ARM FROM RIGHT DOOR CYLINDER LOCK SWITCH (EXPORT ONLY); *VTSS FAILS TO ARM/DISARM FROM RIGHT DOOR CYLINDER LOCK SWITCH
- Symptom: *VTSS INDICATOR FAILS TO FLASH
- Symptom: *VTSS INDICATOR STAYS ON STEADY DURING ARMING
- Symptom: *VTSS SIREN INOPERATIVE (EXPORT ONLY)
- Verifications Tests
- Airbag
- Component Locations
- Connector PINOUTS
- Airbag Control Module (Orc) (Base) - Yellow 23 Way
- Airbag Control Module C1 (Orc) (Premium) - Yellow 32 Way
- Airbag Control Module C2 (Orc) (Premium) - Yellow 32 Way
- Ambient Temperature Sensor (Except 2.4L Base) - Black 2 Way
- Amplifier Audio C1 - 20 Way
- Anti-Lock Brake Module - Black 47 Way
- C203 (Pt27) - LT. Gray (Body Side)
- C203 (Pt27) - LT. Gray (Instrument Panel Side)
- C204 (Pt27) - (Instrument Panel Side)
- C204 (Pt27) - (Left Front Door Side)
- C204 (Pt44 LHP) - Natural (Instrument Panel Side)
- C204 (Pt44 LHP) - Natural (Left Front Door Side)
- C205 (Pt27) - (Instrument Panel Side)
- C205 (Pt27) - (Right Front Door Side)
- C305 - Yellow (Airbag Side)
- C305 - Yellow (UNIBODY Side)
- C306 - Yellow (Airbag Side)
- C306 - Yellow (UNIBODY Side)
- C343 (Pt27) - LT. Gray (DECKLID Jumper Side)
- C343 (Pt27) - LT. Gray (DECKLID Side)
- C349 (Pt27) - Blue (Body Side
- C349 (Pt27) - Blue (DECKLID Jumper Side)
- C362 (Pt27) - LT. Gray (Body Side)
- C362 (Pt27) - LT. Gray (Power Top Side)
- CLOCKSPRING - DK. Green 7 Way
- Compass/Temperature Mirror Module (Pt27) - Black 10 Way
- Data Link Connector - Black 16 Way
- DECKLID Cylinder Unlock Switch (Pt27) - LT. Gray 2 Way
- DECKLID Handle Switch (Pt27) - White 2 Way
- DECKLID Release Motor (Pt27) - Black 3 Way
- DECKLID Release Switch (Pt27) - Black 2 Way
- Dome Lamp - Black 3 Way
- Dome Lamp/Intrusion Sensor (Export) - White 4 Way
- Driver Airbag Squib 1 - Yellow 2 Way
- Driver Door Ajar Switch - Black 2 Way
- Driver Door Handle Switch (Pt27) - 2 Way
- Driver Door Power Lock Motor/Ajar Switch - Black 4 Way
- Driver Rear Window Motor (Pt27) - Black 2 Way
- Driver Seat Belt TENSIONER - Yellow 2 Way
- Driver Window Regulator Module (Pt27) - Black 20 Way
- Engine Control Module C1 (Diesel) - Black 81 Way
- Front Power Window Switch - Black 14 Way
- Fuel Pump Module - LT. Gray 4 Way
- Fuses (FB)
- Hands Free Module C1 - DK. Gray 22 Way
- Hands Free Module C2 (Satellite Radio) - DK. Gray 10 Way
- Hands Free Module C3 - Black 10 Way
- High Note Horn (Export) - Black 2 Way
- Hood Ajar Switch (Export) - Black 2 Way
- Ignition Switch C1 - 10 Way
- Instrument Cluster C1 - Black 26 Way
- Instrument Cluster C2 - Black 10 Way
- Left Cylinder Lock Switch - Black 2 Way
- Left Door Lock Switch - Black 3 Way
- Left Front Power Window Motor (Pt44) - Black 2 Way
- Left Instrument Panel Speaker - Black 2 Way
- Left Rear Speaker (Pt44) - Black 2 Way
- Left Seat Airbag Squib (LHP) - Yellow 2 Way
- Left Seat Airbag Squib (RHD) - Yellow 2 Way
- Left Side Impact Sensor 1 - Gray 2 Way
- Liftgate Ajar Switch - White 2 Way
- Liftgate Cylinder Lock Switch - LT. Gray 2 Way
- Liftgate Handle Switch (Pt44) - Natural 2 Way
- Liftgate Power Lock Motor - Black 4 Way
- Liftgate Release Motor (Pt44) - Black 3 Way
- Low Note Horn - Black 2 Way
- Multi-Function Switch - Gray 20 Way
- Overhead Console Module - Black 12 Way
- Passenger Airbag Squib 1 - Yellow 2 Way
- Passenger Door Ajar Switch - Black 2 Way
- Passenger Door Handle Switch (Pt27) - 2 Way
- Passenger Door Power Lock Motor/Ajar Switch - Black 4 Way
- Passenger Rear Window Motor (Pt27) - Black 2 Way
- Passenger Seat Belt TENSIONER - Yellow 2 Way
- Passenger Window Regulator Module (Pt27) - Black 20 Way
- Fuses (PDC)
- Power Top Motor (Pt27) - 2 Way
- Power Top Relay (Pt27) - Black 6 Way
- Power Top Switch (Pt27) - 3 Way
- Powertrain Control Module (1.6L) - Black 90 Way
- Powertrain Control Module C1 (NGC) - Black/Black 38 Way
- Radio C1 - White 22 Way
- Radio C2 (Hands Free) - DK. Gray 10 Way
- Rear View Mirror C1 - Black 12 Way
- Remote Keyless Entry Module - Black 26 Way
- Right Cylinder Lock Switch (Export) - Black 2 Way
- Right Door Lock Switch - Black 3 Way
- Right Front Door Speaker - 3 Way
- Right Front Power Window Motor (Pt44) - Black 2 Way
- Right Rear Power Window Motor (Pt44) - Black 2 Way
- Right Seat Airbag Squib (LHP) - Yellow 2 Way
- Right Seat Airbag Squib (RHP) - Yellow 2 Way
- Right Side Impact Sensor 1 - Gray 2 Way
- Sentry Key Immobilizer Module - Black 6 Way
- Siren (Export) - Black 4 Way
- Schematic Diagrams
- Heated Seat System
- Interior & Exterior
- Body
- Description
- Warning
- Diagnosis And Testing
- Standard Procedure
- Standard Procedure - Plastic Body Panel Repair
- Notes
- Rigid Plastics:
- Semi-Rigid Plastics:
- Flexible Plastics:
- Repair Procedure:
- Adhesion Promoter/Surface Modifier:
- Safety Precaution And Warnings
- Rigid, Semi-Rigid, And Flexible Plastic Parts Types
- Panel Sectioning
- Panel Reinforcement
- Visual Inspection
- Panel Surface Preparation
- Patching Panels
- Panel Patch Fabrications
- Panel Patch Installation
- Patched Panel Surfacing
- Standard Procedure - Heat Staking
- Standard Procedure - Plastic Body Panel Repair
- Specifications
- Special Tools
- Convertible Top
- DECKLID - Pt-27
- Door - Front
- Front Door Applique
- Front Door Check Strap
- Front Door
- Front Door Glass
- Removal
- Installation
- Adjustment - Pt-27 Only
- Front Door Adjustment
- Quarter Glass Adjustment
- Notes
- Up-Stop Adjustments
- Bottom Of Glass - Inboard/Outboard Adjustments
- Top Of Glass - Inboard/Outboard Adjustments
- Glass - Front/Rear Adjustment
- Quarter Glass Alignment Verification
- Condition - Height Mismatch Between Door Glass And Quarter Glass With Top Down
- Condition - Door Glass Noise Along A-Pillar When Closing Door And/Or Door Glass Touching Quarter Glass Metal Seal Retainer And/Or Wind Noise/Water Leak Along Quarter Glass Seal.
- Condition - Door Glass Not Driving Into The Top In Full Up Position
- Condition - Quarter Glass Not Driving Into The Top In Full Up Position
- Condition - Slapping Noise Between The Door And Quarter Glass With The Top Down During Driving Of The Vehicle
- Condition - Non-Parallel Gap Between Door And Quarter Glasses
- Condition - Quarter Glass Seal Fold Over During Travel With Door Glass Full Up And Top Up Or Down
- Condition - Intermediate Rear Of Door Glass Not Driving Into The Top Seal And/Or Noise At Rear Bottom Of The Door
- Front Door Outside Handle
- Front Door Hinge
- Front Door Inside Handle Actuator
- Front Door Latch
- Front Door Latch Striker
- Front Door Lock Cylinder
- Front Door Vertical Guide Bar
- Front Door Side View Mirror Flag - Pt-27
- Front Door Trim Panel
- Front Door Water Dam
- Front Door Window Regulator
- Door Glass Inner Belt Stabilizer - Pt-27
- Rear Rail Assembly - Pt-27
- Door - Rear
- Exterior
- Body Side Moldings
- Cowl Grille Screen
- Deck Upper Belt Molding - Pt-27
- Engine Compartment Lower Silencer
- Exterior Name Plates
- Front Fender
- Front Side Rail Access Pulley Splash Shield
- Front Wheelhouse Splash Shields
- Fuel Fill Door
- Grille
- Header Molding - Pt-27
- Luggage Rack Crossbar
- Luggage Rack Side Rail
- Radiator Closure Panel
- Side View Mirror
- Side View Mirror Glass
- Windshield A-Pillar Trim Molding - Pt-27
- Wood Grain/Flame Decals
- Grille - Lower Radiator
- Hood
- Instrument Panel
- Interior
- A-Pillar Trim
- B-Pillar Trim
- Body Vent
- DECKLID Sill Scuff Plate
- Door Sill Trim
- Floor Carpet
- Cargo Area Floor Carpet - Pt-27
- Front Floor Carpet Right/Left Side -Pt-27
- Rear Carpet - Pt-27
- Upper D-Pillar Trim
- Header Latch Retainer - Pt-27
- Headliner
- Inside Rear View Mirror
- Lower Quarter Trim Panel
- Rear Quarter Panel Trim - Pt-27
- Seat Back Support Bracket - Pt-27
- Side Cowl Trim Panel
- Sport Bar - Pt-27
- Sport Bar Inner Covers - Pt-27
- Sport Bar Outer Cover - Pt-27
- Sun Visor
- Trunk Trim Panel - Pt-27
- Trunk Welt - Pt-27
- Upper C-Pillar Trim
- Windshield Header Molding -Pt-27
- Liftgate
- Paint
- Quarter Glass - Pt-27
- Seats
- Child Seat Tether Anchor Bezel
- Front Seat
- Front Seat Back - With Front Seat Back Panel
- Front Seat Back
- Front Seat Back Cover/Foam
- Front Seat Back Cover - Without Front Seat Back Panel
- Front Seat Cushion
- Front Seat Cushion Cover
- Headrest - Front/Rear
- Rear Seat
- Rear Seat Back
- Rear Seat Back Cover/Foam
- Rear Seat Back Cushion Cover/Foam - Pt-27
- Rear Seat Bolster - Pt-27
- Rear Seat Bolster Cover - Pt-27
- Rear Seat Cushion
- Rear Seat Back Cushion / Cover
- Rear Seat Latch Cover
- Under Seat Storage Bin
- Stationary Glass
- Sunroof
- Weatherstrip/Seals
- A-Pillar Weatherstrip Retainer - Pt-27
- Deck Lid Opening Weatherstrip - Pt-27
- Front And Rear Door Opening Weatherstrip
- Front And Rear Door Upper Secondary Weatherstrip
- Front Door Glass Run Weatherstrip
- Front Door Inner Belt Weatherstrip
- Front Door Outer Belt Weatherstrip
- Header Weatherstrip Seal Retainer - Pt-27
- Liftgate Weatherstrip
- Quarter Panel Outer Belt Weatherstrip - Pt-27
- Rear Door Glass Run Weatherstrip
- Rear Door Inner Belt Weatherstrip
- Sill Secondary Weatherstrip
- Header / A-Pillar Weatherstrip -Pt-27
- Front Door Sill Weatherstrip - Pt-27
- Body Structure
- Body
- Power Seat System
- Body Diagnostic Procedures
- Warning Systems
- Window Motors & Regulators
- Body Diagnostic Procedures
- Introduction
- Identification Of System
- System Description And Functional Operation
- Notes
- Airbag System
- Audio System
- Compass/Temperature Module (CTM)
- Compass/Temperature Mirror
- Description
- Operation
- English / Metric / Off Mode
- Calibration / Zone Mode
- Setting Compass Zone
- First Time Calibration
- Manual Calibration
- Continuous Calibration
- Self-Check Diagnostic
- Outside Temperature
- Temperature Update - Warm
- Temperature Update - Cold
- Extreme Temperature / Open Or Short Condition
- Ambient Temperature Sensor
- Ambient Temperature Sensor Diagnostics
- Instrument Cluster
- Remote Keyless Entry Module
- Sentry Key Immobilizer System (Skis)
- Communication
- Telecommunications
- Window Regulator Modules (Pt27 Only)
- Using The DRBIII®
- Disclaimers, Safety, Warnings
- Required Tools And Equipment
- Glossary Of Terms
- Diagnostic Information And Procedures
- Airbag
- Symptom List: ACCELEROMETER 1; INTERNAL 1; INTERNAL 2; INTERNAL 3; INTERNAL 4' OUTPUT DRIVER 1; OUTPUT DRIVER 2; STORED ENERGY FIRING 1
- Symptom List: AIRBAG WARNING INDICATOR DRIVER; AIRBAG WARNING INDICATOR OPEN; AIRBAG WARNING INDICATOR SHORT
- Symptom: CALIBRATION MISMATCH
- Symptom: CLUSTER MESSAGE MISMATCH
- Symptom: DRIVER SEAT BELT TENSIONER CIRCUIT OPEN
- Symptom: DRIVER SEAT BELT TENSIONER CIRCUIT SHORT
- Symptom: DRIVER SEAT BELT TENSIONER SHORT TO BATTERY
- Symptom: DRIVER SEAT BELT TENSIONER SHORT TO GROUND
- Symptom: DRIVER SQUIB 1 CIRCUIT OPEN
- Symptom: DRIVER SQUIB 1 CIRCUIT SHORT
- Symptom: DRIVER SQUIB 1 SHORT TO BATTERY
- Symptom: DRIVER SQUIB 1 SHORT TO GROUND
- Symptom: LEFT CURTAIN OR SEAT SQUIB CIRCUIT OPEN
- Symptom: LEFT CURTAIN OR SEAT SQUIB CIRCUIT SHORT
- Symptom: LEFT CURTAIN OR SEAT SQUIB SHORT TO BATTERY
- Symptom: LEFT CURTAIN OR SEAT SQUIB SHORT TO GROUND
- Symptom: LEFT SIDE IMPACT SENSOR 1 INTERNAL 1
- Symptom: LOSS OF IGNITION RUN - START
- Symptom: LOSS OF IGNITION RUN ONLY
- Symptom: NO CLUSTER MESSAGE
- Symptom: NO LEFT SIDE IMPACT SENSOR 1 COMMUNICATION
- Symptom: NO ODOMETER MESSAGE
- Symptom: NO PCI TRANSMISSION
- Symptom: NO RIGHT SIDE IMPACT SENSOR 1 COMMUNICATION
- Symptom: PASSENGER SEAT BELT TENSIONER CIRCUIT OPEN
- Symptom: PASSENGER SEAT BELT TENSIONER CIRCUIT SHORT
- Symptom: PASSENGER SEAT BELT TENSIONER SHORT TO BATTERY
- Symptom: PASSENGER SEAT BELT TENSIONER SHORT TO GROUND
- Symptom: PASSENGER SQUIB 1 CIRCUIT OPEN
- Symptom: PASSENGER SQUIB 1 CIRCUIT SHORT
- Symptom: PASSENGER SQUIB 1 SHORT TO BATTERY
- Symptom: PASSENGER SQUIB 1 SHORT TO GROUND
- Symptom: POWER SUPPLY VOLTAGE LOW
- Symptom: RIGHT CURTAIN OR SEAT SQUIB CIRCUIT OPEN
- Symptom: RIGHT CURTAIN OR SEAT SQUIB CIRCUIT SHORT
- Symptom: RIGHT CURTAIN OR SEAT SQUIB SHORT TO BATTERY
- Symptom: RIGHT CURTAIN OR SEAT SQUIB SHORT TO GROUND
- Symptom: RIGHT SIDE IMPACT SENSOR INTERNAL 1
- Symptom: VEHICLE BODY STYLE MISMATCH
- Symptom: *AIRBAG INDICATOR ON WITHOUT ACTIVE TROUBLE CODES
- Audio
- Symptom: ALL OUTPUTS SHORT
- Symptom: ANTENNA HARDWARE FAILURE - SDARS
- Symptom: ANTENNA NOT CONNECTED - SDARS
- Symptom: BUS BUSY - SDARS
- Symptom: BUS LOW - SDARS
- Symptom List: CASSETTE PLAYER INOP; CD MECHANICAL FAILURE; NO PCI TRANSMISSION; *AM/FM SWITCH INOPERATIVE; *ANY STATION PRESET SWITCH INOPERATIVE; *BALANCE INOPERATIVE; *CD EJECT SWITCH INOPERATIVE; *EQUALIZER INOPERATIVE; *FADER INOPERATIVE; *FF/RW SWITCH INOPERATIVE; *HOUR/MINUTE SWITCHES INOPERATIVE; *PAUSE/PLAY SWITCH INOPERATIVE; *PWR SWITCH INOPERATIVE; *SCAN SWITCH INOPERATIVE; *SEEK SWITCH INOPERATIVE; *SET SWITCH INOPERATIVE; *TAPE EJECT SWITCH INOPERATIVE; *TIME SWITCH INOPERATIVE; *TUNE SWITCH INOPERATIVE
- Symptom: CD PLAY FAILURE
- Symptom: CD READ FAILURE
- Symptom: CD TEMPERATURE HIGH
- Symptom: GPS ANTENNA NOT CONNECTED
- Symptom: INTERNAL FAILURE - SDARS
- Symptom: INTERNAL RECEIVER FAILURE - SDARS
- Symptom: LOW VOLTAGE LEVEL
- Symptom: NO ANTENNA CONNECTION
- Symptom: NO COMMUNICATION WITH SDARS
- Symptom: NO J1850 COMMUNICATION - SDARS
- Symptom: POWER AMP SHUTDOWN
- Symptom: RADIO AND NAV GPS ANTENNA NOT CONNECTED
- Symptom: *INOP NO FAULT CODES - SDARS
- Symptom: *POOR RECEPTION - SDARS
- Communication
- Symptom: *NO RESPONSE FROM AIRBAG CONTROL MODULE
- Symptom: *NO RESPONSE FROM AMPLIFIER
- Symptom: *NO RESPONSE FROM ANTILOCK BRAKE MODULE
- Symptom: *NO RESPONSE FROM ECM (PCI BUS) - DIESEL ONLY
- Symptom: *NO RESPONSE FROM ECM (SCI ONLY) - DIESEL ONLY
- Symptom: *NO RESPONSE FROM HANDS FREE MODULE
- Symptom: *NO RESPONSE FROM INSTRUMENT CLUSTER
- Symptom: *NO RESPONSE FROM OVERHEAD CONSOLE (COMPASS/TEMPERATURE MIRROR MODULE)
- Symptom: *NO RESPONSE FROM PCM (PCI BUS) - 1.6L
- Symptom: *NO RESPONSE FROM PCM (PCI BUS) - NGC
- Symptom: *NO RESPONSE FROM PCM (PCM SCI ONLY) - NGC
- Symptom: *NO RESPONSE FROM PCM (SCI ONLY) - 1.6L
- Symptom: *NO RESPONSE FROM RADIO
- Symptom: *NO RESPONSE FROM RKE
- Symptom: *NO RESPONSE FROM SATELLITE RADIO RECEIVER
- Symptom: *NO RESPONSE FROM SENTRY KEY IMMOBILIZER MODULE
- Symptom: *NO RESPONSE FROM TRANSMISSION CONTROL MODULE - NGC
- Symptom: *NO RESPONSE FROM WINDOW REGULATOR MODULE - PT27
- Symptom: *PCI BUS COMMUNICATION FAILURE
- Instrument Cluster
- Symptom List: ABS INDICATOR CIRCUIT OPEN; AIRBAG INDICATOR CIRCUIT OPEN
- Symptom List: ABS MESSAGE NOT RECEIVED; ACM MESSAGE NOT RECEIVED; EATX MESSAGE NOT RECEIVED; NO PCI TRANSMISSION; SBEC MESSAGE NOT RECEIVED; SKIM MESSAGE NOT RECEIVED
- Symptom: EATX MESSAGE MISMATCH
- Symptom: EEPROM CHECKSUM FAILURE
- Symptom: FUEL LEVEL SENSOR OPEN
- Symptom: FUEL LEVEL SENSOR SHORT
- Symptom: FUEL LEVEL SENSOR STUCK
- Symptom: PANEL DIMMER OPEN
- Symptom: PANEL DIMMER SHORTED
- Symptom: *ALL GAUGES INOPERATIVE
- Symptom: *ANY PCI BUS INDICATOR INOPERATIVE
- Symptom: *BRAKE WARNING INDICATOR ALWAYS ON
- Symptom: *BRAKE WARNING INDICATOR INOPERATIVE
- Symptom: *FRONT FOG LAMP INDICATOR INOPERATIVE
- Symptom: *FUEL GAUGE INACCURATE
- Symptom: *HIGH BEAM INDICATOR INOPERATIVE
- Symptom: *INSTRUMENT CLUSTER DIMMING INOPERATIVE
- Symptom: *LOW OIL PRESSURE INDICATOR ALWAYS ON
- Symptom: *LOW OIL PRESSURE INDICATOR INOPERATIVE
- Symptom: *ONE GAUGE INOPERATIVE
- Symptom: *PRND OR AUTOSTICK DISPLAY INOPERATIVE OR INACCURATE
- Symptom: *REAR FOG LAMP INDICATOR INOPERATIVE - BUX ONLY
- Symptom: *SEAT BELT INDICATOR NOT OPERATING PROPERLY
- Symptom: *VF DISPLAY INOPERATIVE
- Interior Lighting
- Overhead Console
- Power Door Locks/RKE
- Symptom: BODY STYLE MISMATCH
- Symptom: DRIVER DOOR SWITCH FAILURE
- Symptom: INCORRECT MODULE TYPE CONFIGURATION FOR PART NUMBER
- Symptom: MODULE NOT CONFIGURED FOR RKE
- Symptom: NO AIRBAG MESSAGES RECEIVED
- Symptom: NO PCM MESSAGES RECEIVED
- Symptom: NO SKIM MESSAGES RECEIVED
- Symptom: PASSENGER DOOR OR LIFTGATE SWITCH FAILURE - PT44
- Symptom:* ALL DOORS (EXCEPT DRIVER)FAIL TO LOCK
- Symptom: * ALL DOORS (EXCEPT DRIVER)FAIL TO LOCK AND UNLOCK
- Symptom:* ALL DOORS (EXCEPT DRIVER)FAIL TO UNLOCK
- Symptom: *ALL DOOR LOCKS INOPERATIVE
- Symptom: *ALL DOORS FAIL TO LOCK
- Symptom: *ALL DOORS FAIL TO UNLOCK
- Symptom: *ALL LOCKS INOPERATIVE FROM ONE LOCK SWITCH
- Symptom: *DECKLID RELEASE SWITCH INOPERATIVE - PT27
- Symptom: *DECKLID SOLENOID INOPERATIVE - PT27
- Symptom: *DOORS LOCKABLE WITH KEY IN IGNITION AND DRIVER DOOR OPEN
- Symptom: *DRIVER DOOR FAILS TO LOCK
- Symptom: *DRIVER DOOR FAILS TO LOCK AND UNLOCK
- Symptom: *DRIVER DOOR FAILS TO UNLOCK
- Symptom: *DRIVER DOOR FAILS UNLOCK - PT27
- Symptom: *LIFTGATE LOCK MOTOR FAILS TO LOCK OR UNLOCK
- Symptom: *ONE DOOR FAILS TO LOCK AND UNLOCK - PT27
- Symptom: *ONE PASSENGER DOOR FAILS TO LOCK AND UNLOCK
- Symptom: *PASSENGER DOOR FAILS TO UNLOCK - PT27
- Symptom: *RKE INOPERATIVE
- Power Top
- Symptom: AMBIENT TEMP MESSAGE NOT RECEIVED
- Symptom: POWER TOP RELAY CONTROL CIRCUIT OPEN
- Symptom: POWER TOP RELAY INOPERATIVE
- Symptom: POWER TOP SWITCH MUX CIRCUIT OPEN
- Symptom: POWER TOP SWITCH MUX CIRCUIT SHORT TO GROUND
- Symptom: POWER TOP SWITCH MUX CIRCUIT VALUE OUT OF RANGE
- Symptom: SPEED MESSAGE NOT RECEIVED
- Power Windows
- Symptom: BATTERY VOLTAGE TOO HIGH
- Symptom: BATTERY VOLTAGE TOO LOW
- Symptom: FRONT WINDOW MOTOR MALFUNCTION
- Symptom: FRONT WINDOW SWITCH MUX CIRCUIT OPEN
- Symptom: FRONT WINDOW SWITCH MUX CIRCUIT SHORT TO GROUND
- Symptom: FRONT WINDOW SWITCH MUX CIRCUIT VALUE OUT OF RANGE
- Symptom: IGNITION SWITCH OUTPUT OPEN
- Symptom: REAR WINDOW MOTOR CIRCUIT OPEN OR SHORTED
- Symptom: REAR WINDOW SWITCH MUX CIRCUIT OPEN
- Symptom: REAR WINDOW SWITCH MUX CIRCUIT SHORT TO GROUND
- Symptom: REAR WINDOW SWITCH MUX CIRCUIT VALUE OUT OF RANGE
- Symptom: WINDOW DROP SWITCH SENSE CIRCUIT OPEN
- Symptom: *DOOR AJAR CIRCUIT OPEN
- Symptom: *DOOR WINDOWS STAY IN DROP DOWN POSITION
- Symptom: *WINDOW DROPS OR JERKS DURING OPENING
- Telecommunication
- Symptom: AUDIO HARDWARE MESSAGE NOT RECEIVED
- Symptom List: BLUETOOTH ERROR; FLASH CHECKSUM ERROR; FLASH WRITE ERROR; PCI BUS INTERNAL ERROR; RAM WRITE ERROR; ROM CHECKSUM ERROR
- Symptom List: BODY STYLE MESSAGE NOT RECEIVED; INVALID BODY STYLE
- Symptom: GENERAL MICROPHONE FAULT
- Symptom: IGNITION POWER MESSAGE NOT RECEIVED
- Symptom List: LEFT AUDIO INPUT SHORT TO GROUND; LEFT AUDIO INPUT SHORT TO VOLTAGE; LEFT AUDIO OUTPUT 1 SHORT TO GROUND; LEFT AUDIO OUTPUT 1 SHORT TO VOLTAGE
- Symptom List: MIRROR POWER CIRCUIT SHORT TO GROUND; MIRROR POWER CIRCUIT SHORT TO VOLTAGE
- Symptom List: PCI BUS BUSY; PCI BUS CIRCUIT OPEN; PCI BUS CIRCUIT SHORT TO GROUND; PCI BUS CIRCUIT SHORT TO VOLTAGE
- Symptom List: PHONE SWITCH STUCK; VOICE RECOGNITION SWITCH STUCK' VOICE RECOGNITION/PHONE SWITCH CIRCUIT RATIONALITY; VOICE RECOGNITION/PHONE SWITCH CIRCUIT SHORT TO GROUND; VOICE RECOGNITION/PHONE SWITCH CIRCUIT SHORT TO VOLTAGE
- Symptom: PRNDL MESSAGE NOT RECEIVED
- Symptom: RADIO MESSAGE NOT RECEIVED
- Symptom List: RIGHT AUDIO INPUT SHORT TO GROUND; RIGHT AUDIO INPUT SHORT TO VOLTAGE; RIGHT AUDIO OUTPUT 1 SHORT TO GROUND; RIGHT AUDIO OUTPUT 1 SHORT TO VOLTAGE
- Symptom: RPM MESSAGE NOT RECEIVED
- Symptom: VIN MESSAGE NOT RECEIVED
- Symptom: VIN MISMATCH
- Vehicle Theft/Security
- Symptom: HOOD AJAR SWITCH MISSING (EXPORT ONLY)
- Symptom: MODULE PREVIOUSLY CONFIGURED FOR VTSS
- Symptom: *ALARM TRIPS ON ITS OWN
- Symptom: *HEADLAMPS FAIL TO FLASH DURING ALARM
- Symptom: *HORN FAILS TO SOUND DURING ALARM
- Symptom: *INTRUSION SENSOR CANNOT BE DISABLED (EXPORT ONLY)
- Symptom: *INTRUSION SENSOR FAILS TO TRIP VTSS (EXPORT ONLY)
- Symptom: *INTRUSION SENSOR REPEATEDLY TRIGGERS VTSS (EXPORT ONLY)
- Symptom: *OPEN DRIVER DOOR FAILS TO TRIP ALARM
- Symptom: *OPEN LIFTGATE FAILS TO TRIP ALARM
- Symptom: *OPEN PASSENGER DOOR FAILS TO TRIP ALARM
- Symptom: *PARK LAMPS FAIL TO FLASH DURING ALARM
- Symptom List: *VTSS FAILS TO ARM FROM LEFT DOOR CYLINDER LOCK SWITCH (EXPORT ONLY); *VTSS FAILS TO ARM/DISARM FROM LEFT DOOR CYLINDER LOCK SWITCH
- Symptom List: *VTSS FAILS TO ARM FROM LIFTGATE CYLINDER LOCK SWITCH (EXPORT ONLY); *VTSS FAILS TO ARM/DISARM FROM LIFTGATE CYLINDER LOCK SWITCH
- Symptom List: *VTSS FAILS TO ARM FROM RIGHT DOOR CYLINDER LOCK SWITCH (EXPORT ONLY); *VTSS FAILS TO ARM/DISARM FROM RIGHT DOOR CYLINDER LOCK SWITCH
- Symptom: *VTSS INDICATOR FAILS TO FLASH
- Symptom: *VTSS INDICATOR STAYS ON STEADY DURING ARMING
- Symptom: *VTSS SIREN INOPERATIVE (EXPORT ONLY)
- Verifications Tests
- Airbag
- Component Locations
- Connector PINOUTS
- Airbag Control Module (Orc) (Base) - Yellow 23 Way
- Airbag Control Module C1 (Orc) (Premium) - Yellow 32 Way
- Airbag Control Module C2 (Orc) (Premium) - Yellow 32 Way
- Ambient Temperature Sensor (Except 2.4L Base) - Black 2 Way
- Amplifier Audio C1 - 20 Way
- Anti-Lock Brake Module - Black 47 Way
- C203 (Pt27) - LT. Gray (Body Side)
- C203 (Pt27) - LT. Gray (Instrument Panel Side)
- C204 (Pt27) - (Instrument Panel Side)
- C204 (Pt27) - (Left Front Door Side)
- C204 (Pt44 LHP) - Natural (Instrument Panel Side)
- C204 (Pt44 LHP) - Natural (Left Front Door Side)
- C205 (Pt27) - (Instrument Panel Side)
- C205 (Pt27) - (Right Front Door Side)
- C305 - Yellow (Airbag Side)
- C305 - Yellow (UNIBODY Side)
- C306 - Yellow (Airbag Side)
- C306 - Yellow (UNIBODY Side)
- C343 (Pt27) - LT. Gray (DECKLID Jumper Side)
- C343 (Pt27) - LT. Gray (DECKLID Side)
- C349 (Pt27) - Blue (Body Side
- C349 (Pt27) - Blue (DECKLID Jumper Side)
- C362 (Pt27) - LT. Gray (Body Side)
- C362 (Pt27) - LT. Gray (Power Top Side)
- CLOCKSPRING - DK. Green 7 Way
- Compass/Temperature Mirror Module (Pt27) - Black 10 Way
- Data Link Connector - Black 16 Way
- DECKLID Cylinder Unlock Switch (Pt27) - LT. Gray 2 Way
- DECKLID Handle Switch (Pt27) - White 2 Way
- DECKLID Release Motor (Pt27) - Black 3 Way
- DECKLID Release Switch (Pt27) - Black 2 Way
- Dome Lamp - Black 3 Way
- Dome Lamp/Intrusion Sensor (Export) - White 4 Way
- Driver Airbag Squib 1 - Yellow 2 Way
- Driver Door Ajar Switch - Black 2 Way
- Driver Door Handle Switch (Pt27) - 2 Way
- Driver Door Power Lock Motor/Ajar Switch - Black 4 Way
- Driver Rear Window Motor (Pt27) - Black 2 Way
- Driver Seat Belt TENSIONER - Yellow 2 Way
- Driver Window Regulator Module (Pt27) - Black 20 Way
- Engine Control Module C1 (Diesel) - Black 81 Way
- Front Power Window Switch - Black 14 Way
- Fuel Pump Module - LT. Gray 4 Way
- Fuses (FB)
- Hands Free Module C1 - DK. Gray 22 Way
- Hands Free Module C2 (Satellite Radio) - DK. Gray 10 Way
- Hands Free Module C3 - Black 10 Way
- High Note Horn (Export) - Black 2 Way
- Hood Ajar Switch (Export) - Black 2 Way
- Ignition Switch C1 - 10 Way
- Instrument Cluster C1 - Black 26 Way
- Instrument Cluster C2 - Black 10 Way
- Left Cylinder Lock Switch - Black 2 Way
- Left Door Lock Switch - Black 3 Way
- Left Front Power Window Motor (Pt44) - Black 2 Way
- Left Instrument Panel Speaker - Black 2 Way
- Left Rear Speaker (Pt44) - Black 2 Way
- Left Seat Airbag Squib (LHP) - Yellow 2 Way
- Left Seat Airbag Squib (RHD) - Yellow 2 Way
- Left Side Impact Sensor 1 - Gray 2 Way
- Liftgate Ajar Switch - White 2 Way
- Liftgate Cylinder Lock Switch - LT. Gray 2 Way
- Liftgate Handle Switch (Pt44) - Natural 2 Way
- Liftgate Power Lock Motor - Black 4 Way
- Liftgate Release Motor (Pt44) - Black 3 Way
- Low Note Horn - Black 2 Way
- Multi-Function Switch - Gray 20 Way
- Overhead Console Module - Black 12 Way
- Passenger Airbag Squib 1 - Yellow 2 Way
- Passenger Door Ajar Switch - Black 2 Way
- Passenger Door Handle Switch (Pt27) - 2 Way
- Passenger Door Power Lock Motor/Ajar Switch - Black 4 Way
- Passenger Rear Window Motor (Pt27) - Black 2 Way
- Passenger Seat Belt TENSIONER - Yellow 2 Way
- Passenger Window Regulator Module (Pt27) - Black 20 Way
- Fuses (PDC)
- Power Top Motor (Pt27) - 2 Way
- Power Top Relay (Pt27) - Black 6 Way
- Power Top Switch (Pt27) - 3 Way
- Powertrain Control Module (1.6L) - Black 90 Way
- Powertrain Control Module C1 (NGC) - Black/Black 38 Way
- Radio C1 - White 22 Way
- Radio C2 (Hands Free) - DK. Gray 10 Way
- Rear View Mirror C1 - Black 12 Way
- Remote Keyless Entry Module - Black 26 Way
- Right Cylinder Lock Switch (Export) - Black 2 Way
- Right Door Lock Switch - Black 3 Way
- Right Front Door Speaker - 3 Way
- Right Front Power Window Motor (Pt44) - Black 2 Way
- Right Rear Power Window Motor (Pt44) - Black 2 Way
- Right Seat Airbag Squib (LHP) - Yellow 2 Way
- Right Seat Airbag Squib (RHP) - Yellow 2 Way
- Right Side Impact Sensor 1 - Gray 2 Way
- Sentry Key Immobilizer Module - Black 6 Way
- Siren (Export) - Black 4 Way
- Schematic Diagrams
- Interior & Exterior
- Body
- Description
- Warning
- Diagnosis And Testing
- Standard Procedure
- Standard Procedure - Plastic Body Panel Repair
- Notes
- Rigid Plastics:
- Semi-Rigid Plastics:
- Flexible Plastics:
- Repair Procedure:
- Adhesion Promoter/Surface Modifier:
- Safety Precaution And Warnings
- Rigid, Semi-Rigid, And Flexible Plastic Parts Types
- Panel Sectioning
- Panel Reinforcement
- Visual Inspection
- Panel Surface Preparation
- Patching Panels
- Panel Patch Fabrications
- Panel Patch Installation
- Patched Panel Surfacing
- Standard Procedure - Heat Staking
- Standard Procedure - Plastic Body Panel Repair
- Specifications
- Special Tools
- Convertible Top
- DECKLID - Pt-27
- Door - Front
- Front Door Applique
- Front Door Check Strap
- Front Door
- Front Door Glass
- Removal
- Installation
- Adjustment - Pt-27 Only
- Front Door Adjustment
- Quarter Glass Adjustment
- Notes
- Up-Stop Adjustments
- Bottom Of Glass - Inboard/Outboard Adjustments
- Top Of Glass - Inboard/Outboard Adjustments
- Glass - Front/Rear Adjustment
- Quarter Glass Alignment Verification
- Condition - Height Mismatch Between Door Glass And Quarter Glass With Top Down
- Condition - Door Glass Noise Along A-Pillar When Closing Door And/Or Door Glass Touching Quarter Glass Metal Seal Retainer And/Or Wind Noise/Water Leak Along Quarter Glass Seal.
- Condition - Door Glass Not Driving Into The Top In Full Up Position
- Condition - Quarter Glass Not Driving Into The Top In Full Up Position
- Condition - Slapping Noise Between The Door And Quarter Glass With The Top Down During Driving Of The Vehicle
- Condition - Non-Parallel Gap Between Door And Quarter Glasses
- Condition - Quarter Glass Seal Fold Over During Travel With Door Glass Full Up And Top Up Or Down
- Condition - Intermediate Rear Of Door Glass Not Driving Into The Top Seal And/Or Noise At Rear Bottom Of The Door
- Front Door Outside Handle
- Front Door Hinge
- Front Door Inside Handle Actuator
- Front Door Latch
- Front Door Latch Striker
- Front Door Lock Cylinder
- Front Door Vertical Guide Bar
- Front Door Side View Mirror Flag - Pt-27
- Front Door Trim Panel
- Front Door Water Dam
- Front Door Window Regulator
- Door Glass Inner Belt Stabilizer - Pt-27
- Rear Rail Assembly - Pt-27
- Door - Rear
- Exterior
- Body Side Moldings
- Cowl Grille Screen
- Deck Upper Belt Molding - Pt-27
- Engine Compartment Lower Silencer
- Exterior Name Plates
- Front Fender
- Front Side Rail Access Pulley Splash Shield
- Front Wheelhouse Splash Shields
- Fuel Fill Door
- Grille
- Header Molding - Pt-27
- Luggage Rack Crossbar
- Luggage Rack Side Rail
- Radiator Closure Panel
- Side View Mirror
- Side View Mirror Glass
- Windshield A-Pillar Trim Molding - Pt-27
- Wood Grain/Flame Decals
- Grille - Lower Radiator
- Hood
- Instrument Panel
- Interior
- A-Pillar Trim
- B-Pillar Trim
- Body Vent
- DECKLID Sill Scuff Plate
- Door Sill Trim
- Floor Carpet
- Cargo Area Floor Carpet - Pt-27
- Front Floor Carpet Right/Left Side -Pt-27
- Rear Carpet - Pt-27
- Upper D-Pillar Trim
- Header Latch Retainer - Pt-27
- Headliner
- Inside Rear View Mirror
- Lower Quarter Trim Panel
- Rear Quarter Panel Trim - Pt-27
- Seat Back Support Bracket - Pt-27
- Side Cowl Trim Panel
- Sport Bar - Pt-27
- Sport Bar Inner Covers - Pt-27
- Sport Bar Outer Cover - Pt-27
- Sun Visor
- Trunk Trim Panel - Pt-27
- Trunk Welt - Pt-27
- Upper C-Pillar Trim
- Windshield Header Molding -Pt-27
- Liftgate
- Paint
- Quarter Glass - Pt-27
- Seats
- Child Seat Tether Anchor Bezel
- Front Seat
- Front Seat Back - With Front Seat Back Panel
- Front Seat Back
- Front Seat Back Cover/Foam
- Front Seat Back Cover - Without Front Seat Back Panel
- Front Seat Cushion
- Front Seat Cushion Cover
- Headrest - Front/Rear
- Rear Seat
- Rear Seat Back
- Rear Seat Back Cover/Foam
- Rear Seat Back Cushion Cover/Foam - Pt-27
- Rear Seat Bolster - Pt-27
- Rear Seat Bolster Cover - Pt-27
- Rear Seat Cushion
- Rear Seat Back Cushion / Cover
- Rear Seat Latch Cover
- Under Seat Storage Bin
- Stationary Glass
- Sunroof
- Weatherstrip/Seals
- A-Pillar Weatherstrip Retainer - Pt-27
- Deck Lid Opening Weatherstrip - Pt-27
- Front And Rear Door Opening Weatherstrip
- Front And Rear Door Upper Secondary Weatherstrip
- Front Door Glass Run Weatherstrip
- Front Door Inner Belt Weatherstrip
- Front Door Outer Belt Weatherstrip
- Header Weatherstrip Seal Retainer - Pt-27
- Liftgate Weatherstrip
- Quarter Panel Outer Belt Weatherstrip - Pt-27
- Rear Door Glass Run Weatherstrip
- Rear Door Inner Belt Weatherstrip
- Sill Secondary Weatherstrip
- Header / A-Pillar Weatherstrip -Pt-27
- Front Door Sill Weatherstrip - Pt-27
- Body Structure
- Body
- Power Windows
- Body Diagnostic Procedures
- Wiper/Washer Systems
- Wiper System & Washer System
- Wipers/Washers
- Description
- Operation
- Diagnosis And Testing
- Diagnosis And Testing - Front Wiper Conditions
- Notes
- Motor Will Not Operate All Switch Positions
- Motor Operates Slowly At All Speeds
- Wipers Run At High Speed With Switch In Low Speed Position Or Wipers Run At Low Speed With Switch In High Speed Position.
- Wipers Will Operate Continuously With The Switch In The Intermittent Position - When Wiper Switch Is Turned Off, Wipers Stop Wherever They Are Without Returning To Park Position.
- Wipers Do Not Operate When Washer Motor Is Engaged (Pulse Wipe) Or Wipers Do Operate In Intermittent Position.
- Diagnosis And Testing - Rear Wiper System
- Diagnosis And Testing - Washer System
- Diagnosis And Testing - Front Wiper Conditions
- Front Washer Nozzle
- Front Wiper Arms
- Front Wiper Blades
- Front Wiper Blade Elements
- Front Wiper Module
- Front Wiper Motor
- Front Wiper Switch
- Rear Washer Nozzle
- Rear Wiper Arms
- Rear Wiper Blade
- Rear Wiper Motor
- Rear Wiper Switch
- Washer Hoses
- Washer Pump Motor
- Washer Reservoir
- Wipers/Washers
- Wiper System & Washer System
- Body & Frame
- Body, Cab Control Systems
- Body Diagnostic Procedures
- Introduction
- Identification Of System
- System Description And Functional Operation
- Notes
- Airbag System
- Audio System
- Compass/Temperature Module (CTM)
- Compass/Temperature Mirror
- Description
- Operation
- English / Metric / Off Mode
- Calibration / Zone Mode
- Setting Compass Zone
- First Time Calibration
- Manual Calibration
- Continuous Calibration
- Self-Check Diagnostic
- Outside Temperature
- Temperature Update - Warm
- Temperature Update - Cold
- Extreme Temperature / Open Or Short Condition
- Ambient Temperature Sensor
- Ambient Temperature Sensor Diagnostics
- Instrument Cluster
- Remote Keyless Entry Module
- Sentry Key Immobilizer System (Skis)
- Communication
- Telecommunications
- Window Regulator Modules (Pt27 Only)
- Using The DRBIII®
- Disclaimers, Safety, Warnings
- Required Tools And Equipment
- Glossary Of Terms
- Diagnostic Information And Procedures
- Airbag
- Symptom List: ACCELEROMETER 1; INTERNAL 1; INTERNAL 2; INTERNAL 3; INTERNAL 4' OUTPUT DRIVER 1; OUTPUT DRIVER 2; STORED ENERGY FIRING 1
- Symptom List: AIRBAG WARNING INDICATOR DRIVER; AIRBAG WARNING INDICATOR OPEN; AIRBAG WARNING INDICATOR SHORT
- Symptom: CALIBRATION MISMATCH
- Symptom: CLUSTER MESSAGE MISMATCH
- Symptom: DRIVER SEAT BELT TENSIONER CIRCUIT OPEN
- Symptom: DRIVER SEAT BELT TENSIONER CIRCUIT SHORT
- Symptom: DRIVER SEAT BELT TENSIONER SHORT TO BATTERY
- Symptom: DRIVER SEAT BELT TENSIONER SHORT TO GROUND
- Symptom: DRIVER SQUIB 1 CIRCUIT OPEN
- Symptom: DRIVER SQUIB 1 CIRCUIT SHORT
- Symptom: DRIVER SQUIB 1 SHORT TO BATTERY
- Symptom: DRIVER SQUIB 1 SHORT TO GROUND
- Symptom: LEFT CURTAIN OR SEAT SQUIB CIRCUIT OPEN
- Symptom: LEFT CURTAIN OR SEAT SQUIB CIRCUIT SHORT
- Symptom: LEFT CURTAIN OR SEAT SQUIB SHORT TO BATTERY
- Symptom: LEFT CURTAIN OR SEAT SQUIB SHORT TO GROUND
- Symptom: LEFT SIDE IMPACT SENSOR 1 INTERNAL 1
- Symptom: LOSS OF IGNITION RUN - START
- Symptom: LOSS OF IGNITION RUN ONLY
- Symptom: NO CLUSTER MESSAGE
- Symptom: NO LEFT SIDE IMPACT SENSOR 1 COMMUNICATION
- Symptom: NO ODOMETER MESSAGE
- Symptom: NO PCI TRANSMISSION
- Symptom: NO RIGHT SIDE IMPACT SENSOR 1 COMMUNICATION
- Symptom: PASSENGER SEAT BELT TENSIONER CIRCUIT OPEN
- Symptom: PASSENGER SEAT BELT TENSIONER CIRCUIT SHORT
- Symptom: PASSENGER SEAT BELT TENSIONER SHORT TO BATTERY
- Symptom: PASSENGER SEAT BELT TENSIONER SHORT TO GROUND
- Symptom: PASSENGER SQUIB 1 CIRCUIT OPEN
- Symptom: PASSENGER SQUIB 1 CIRCUIT SHORT
- Symptom: PASSENGER SQUIB 1 SHORT TO BATTERY
- Symptom: PASSENGER SQUIB 1 SHORT TO GROUND
- Symptom: POWER SUPPLY VOLTAGE LOW
- Symptom: RIGHT CURTAIN OR SEAT SQUIB CIRCUIT OPEN
- Symptom: RIGHT CURTAIN OR SEAT SQUIB CIRCUIT SHORT
- Symptom: RIGHT CURTAIN OR SEAT SQUIB SHORT TO BATTERY
- Symptom: RIGHT CURTAIN OR SEAT SQUIB SHORT TO GROUND
- Symptom: RIGHT SIDE IMPACT SENSOR INTERNAL 1
- Symptom: VEHICLE BODY STYLE MISMATCH
- Symptom: *AIRBAG INDICATOR ON WITHOUT ACTIVE TROUBLE CODES
- Audio
- Symptom: ALL OUTPUTS SHORT
- Symptom: ANTENNA HARDWARE FAILURE - SDARS
- Symptom: ANTENNA NOT CONNECTED - SDARS
- Symptom: BUS BUSY - SDARS
- Symptom: BUS LOW - SDARS
- Symptom List: CASSETTE PLAYER INOP; CD MECHANICAL FAILURE; NO PCI TRANSMISSION; *AM/FM SWITCH INOPERATIVE; *ANY STATION PRESET SWITCH INOPERATIVE; *BALANCE INOPERATIVE; *CD EJECT SWITCH INOPERATIVE; *EQUALIZER INOPERATIVE; *FADER INOPERATIVE; *FF/RW SWITCH INOPERATIVE; *HOUR/MINUTE SWITCHES INOPERATIVE; *PAUSE/PLAY SWITCH INOPERATIVE; *PWR SWITCH INOPERATIVE; *SCAN SWITCH INOPERATIVE; *SEEK SWITCH INOPERATIVE; *SET SWITCH INOPERATIVE; *TAPE EJECT SWITCH INOPERATIVE; *TIME SWITCH INOPERATIVE; *TUNE SWITCH INOPERATIVE
- Symptom: CD PLAY FAILURE
- Symptom: CD READ FAILURE
- Symptom: CD TEMPERATURE HIGH
- Symptom: GPS ANTENNA NOT CONNECTED
- Symptom: INTERNAL FAILURE - SDARS
- Symptom: INTERNAL RECEIVER FAILURE - SDARS
- Symptom: LOW VOLTAGE LEVEL
- Symptom: NO ANTENNA CONNECTION
- Symptom: NO COMMUNICATION WITH SDARS
- Symptom: NO J1850 COMMUNICATION - SDARS
- Symptom: POWER AMP SHUTDOWN
- Symptom: RADIO AND NAV GPS ANTENNA NOT CONNECTED
- Symptom: *INOP NO FAULT CODES - SDARS
- Symptom: *POOR RECEPTION - SDARS
- Communication
- Symptom: *NO RESPONSE FROM AIRBAG CONTROL MODULE
- Symptom: *NO RESPONSE FROM AMPLIFIER
- Symptom: *NO RESPONSE FROM ANTILOCK BRAKE MODULE
- Symptom: *NO RESPONSE FROM ECM (PCI BUS) - DIESEL ONLY
- Symptom: *NO RESPONSE FROM ECM (SCI ONLY) - DIESEL ONLY
- Symptom: *NO RESPONSE FROM HANDS FREE MODULE
- Symptom: *NO RESPONSE FROM INSTRUMENT CLUSTER
- Symptom: *NO RESPONSE FROM OVERHEAD CONSOLE (COMPASS/TEMPERATURE MIRROR MODULE)
- Symptom: *NO RESPONSE FROM PCM (PCI BUS) - 1.6L
- Symptom: *NO RESPONSE FROM PCM (PCI BUS) - NGC
- Symptom: *NO RESPONSE FROM PCM (PCM SCI ONLY) - NGC
- Symptom: *NO RESPONSE FROM PCM (SCI ONLY) - 1.6L
- Symptom: *NO RESPONSE FROM RADIO
- Symptom: *NO RESPONSE FROM RKE
- Symptom: *NO RESPONSE FROM SATELLITE RADIO RECEIVER
- Symptom: *NO RESPONSE FROM SENTRY KEY IMMOBILIZER MODULE
- Symptom: *NO RESPONSE FROM TRANSMISSION CONTROL MODULE - NGC
- Symptom: *NO RESPONSE FROM WINDOW REGULATOR MODULE - PT27
- Symptom: *PCI BUS COMMUNICATION FAILURE
- Instrument Cluster
- Symptom List: ABS INDICATOR CIRCUIT OPEN; AIRBAG INDICATOR CIRCUIT OPEN
- Symptom List: ABS MESSAGE NOT RECEIVED; ACM MESSAGE NOT RECEIVED; EATX MESSAGE NOT RECEIVED; NO PCI TRANSMISSION; SBEC MESSAGE NOT RECEIVED; SKIM MESSAGE NOT RECEIVED
- Symptom: EATX MESSAGE MISMATCH
- Symptom: EEPROM CHECKSUM FAILURE
- Symptom: FUEL LEVEL SENSOR OPEN
- Symptom: FUEL LEVEL SENSOR SHORT
- Symptom: FUEL LEVEL SENSOR STUCK
- Symptom: PANEL DIMMER OPEN
- Symptom: PANEL DIMMER SHORTED
- Symptom: *ALL GAUGES INOPERATIVE
- Symptom: *ANY PCI BUS INDICATOR INOPERATIVE
- Symptom: *BRAKE WARNING INDICATOR ALWAYS ON
- Symptom: *BRAKE WARNING INDICATOR INOPERATIVE
- Symptom: *FRONT FOG LAMP INDICATOR INOPERATIVE
- Symptom: *FUEL GAUGE INACCURATE
- Symptom: *HIGH BEAM INDICATOR INOPERATIVE
- Symptom: *INSTRUMENT CLUSTER DIMMING INOPERATIVE
- Symptom: *LOW OIL PRESSURE INDICATOR ALWAYS ON
- Symptom: *LOW OIL PRESSURE INDICATOR INOPERATIVE
- Symptom: *ONE GAUGE INOPERATIVE
- Symptom: *PRND OR AUTOSTICK DISPLAY INOPERATIVE OR INACCURATE
- Symptom: *REAR FOG LAMP INDICATOR INOPERATIVE - BUX ONLY
- Symptom: *SEAT BELT INDICATOR NOT OPERATING PROPERLY
- Symptom: *VF DISPLAY INOPERATIVE
- Interior Lighting
- Overhead Console
- Power Door Locks/RKE
- Symptom: BODY STYLE MISMATCH
- Symptom: DRIVER DOOR SWITCH FAILURE
- Symptom: INCORRECT MODULE TYPE CONFIGURATION FOR PART NUMBER
- Symptom: MODULE NOT CONFIGURED FOR RKE
- Symptom: NO AIRBAG MESSAGES RECEIVED
- Symptom: NO PCM MESSAGES RECEIVED
- Symptom: NO SKIM MESSAGES RECEIVED
- Symptom: PASSENGER DOOR OR LIFTGATE SWITCH FAILURE - PT44
- Symptom:* ALL DOORS (EXCEPT DRIVER)FAIL TO LOCK
- Symptom: * ALL DOORS (EXCEPT DRIVER)FAIL TO LOCK AND UNLOCK
- Symptom:* ALL DOORS (EXCEPT DRIVER)FAIL TO UNLOCK
- Symptom: *ALL DOOR LOCKS INOPERATIVE
- Symptom: *ALL DOORS FAIL TO LOCK
- Symptom: *ALL DOORS FAIL TO UNLOCK
- Symptom: *ALL LOCKS INOPERATIVE FROM ONE LOCK SWITCH
- Symptom: *DECKLID RELEASE SWITCH INOPERATIVE - PT27
- Symptom: *DECKLID SOLENOID INOPERATIVE - PT27
- Symptom: *DOORS LOCKABLE WITH KEY IN IGNITION AND DRIVER DOOR OPEN
- Symptom: *DRIVER DOOR FAILS TO LOCK
- Symptom: *DRIVER DOOR FAILS TO LOCK AND UNLOCK
- Symptom: *DRIVER DOOR FAILS TO UNLOCK
- Symptom: *DRIVER DOOR FAILS UNLOCK - PT27
- Symptom: *LIFTGATE LOCK MOTOR FAILS TO LOCK OR UNLOCK
- Symptom: *ONE DOOR FAILS TO LOCK AND UNLOCK - PT27
- Symptom: *ONE PASSENGER DOOR FAILS TO LOCK AND UNLOCK
- Symptom: *PASSENGER DOOR FAILS TO UNLOCK - PT27
- Symptom: *RKE INOPERATIVE
- Power Top
- Symptom: AMBIENT TEMP MESSAGE NOT RECEIVED
- Symptom: POWER TOP RELAY CONTROL CIRCUIT OPEN
- Symptom: POWER TOP RELAY INOPERATIVE
- Symptom: POWER TOP SWITCH MUX CIRCUIT OPEN
- Symptom: POWER TOP SWITCH MUX CIRCUIT SHORT TO GROUND
- Symptom: POWER TOP SWITCH MUX CIRCUIT VALUE OUT OF RANGE
- Symptom: SPEED MESSAGE NOT RECEIVED
- Power Windows
- Symptom: BATTERY VOLTAGE TOO HIGH
- Symptom: BATTERY VOLTAGE TOO LOW
- Symptom: FRONT WINDOW MOTOR MALFUNCTION
- Symptom: FRONT WINDOW SWITCH MUX CIRCUIT OPEN
- Symptom: FRONT WINDOW SWITCH MUX CIRCUIT SHORT TO GROUND
- Symptom: FRONT WINDOW SWITCH MUX CIRCUIT VALUE OUT OF RANGE
- Symptom: IGNITION SWITCH OUTPUT OPEN
- Symptom: REAR WINDOW MOTOR CIRCUIT OPEN OR SHORTED
- Symptom: REAR WINDOW SWITCH MUX CIRCUIT OPEN
- Symptom: REAR WINDOW SWITCH MUX CIRCUIT SHORT TO GROUND
- Symptom: REAR WINDOW SWITCH MUX CIRCUIT VALUE OUT OF RANGE
- Symptom: WINDOW DROP SWITCH SENSE CIRCUIT OPEN
- Symptom: *DOOR AJAR CIRCUIT OPEN
- Symptom: *DOOR WINDOWS STAY IN DROP DOWN POSITION
- Symptom: *WINDOW DROPS OR JERKS DURING OPENING
- Telecommunication
- Symptom: AUDIO HARDWARE MESSAGE NOT RECEIVED
- Symptom List: BLUETOOTH ERROR; FLASH CHECKSUM ERROR; FLASH WRITE ERROR; PCI BUS INTERNAL ERROR; RAM WRITE ERROR; ROM CHECKSUM ERROR
- Symptom List: BODY STYLE MESSAGE NOT RECEIVED; INVALID BODY STYLE
- Symptom: GENERAL MICROPHONE FAULT
- Symptom: IGNITION POWER MESSAGE NOT RECEIVED
- Symptom List: LEFT AUDIO INPUT SHORT TO GROUND; LEFT AUDIO INPUT SHORT TO VOLTAGE; LEFT AUDIO OUTPUT 1 SHORT TO GROUND; LEFT AUDIO OUTPUT 1 SHORT TO VOLTAGE
- Symptom List: MIRROR POWER CIRCUIT SHORT TO GROUND; MIRROR POWER CIRCUIT SHORT TO VOLTAGE
- Symptom List: PCI BUS BUSY; PCI BUS CIRCUIT OPEN; PCI BUS CIRCUIT SHORT TO GROUND; PCI BUS CIRCUIT SHORT TO VOLTAGE
- Symptom List: PHONE SWITCH STUCK; VOICE RECOGNITION SWITCH STUCK' VOICE RECOGNITION/PHONE SWITCH CIRCUIT RATIONALITY; VOICE RECOGNITION/PHONE SWITCH CIRCUIT SHORT TO GROUND; VOICE RECOGNITION/PHONE SWITCH CIRCUIT SHORT TO VOLTAGE
- Symptom: PRNDL MESSAGE NOT RECEIVED
- Symptom: RADIO MESSAGE NOT RECEIVED
- Symptom List: RIGHT AUDIO INPUT SHORT TO GROUND; RIGHT AUDIO INPUT SHORT TO VOLTAGE; RIGHT AUDIO OUTPUT 1 SHORT TO GROUND; RIGHT AUDIO OUTPUT 1 SHORT TO VOLTAGE
- Symptom: RPM MESSAGE NOT RECEIVED
- Symptom: VIN MESSAGE NOT RECEIVED
- Symptom: VIN MISMATCH
- Vehicle Theft/Security
- Symptom: HOOD AJAR SWITCH MISSING (EXPORT ONLY)
- Symptom: MODULE PREVIOUSLY CONFIGURED FOR VTSS
- Symptom: *ALARM TRIPS ON ITS OWN
- Symptom: *HEADLAMPS FAIL TO FLASH DURING ALARM
- Symptom: *HORN FAILS TO SOUND DURING ALARM
- Symptom: *INTRUSION SENSOR CANNOT BE DISABLED (EXPORT ONLY)
- Symptom: *INTRUSION SENSOR FAILS TO TRIP VTSS (EXPORT ONLY)
- Symptom: *INTRUSION SENSOR REPEATEDLY TRIGGERS VTSS (EXPORT ONLY)
- Symptom: *OPEN DRIVER DOOR FAILS TO TRIP ALARM
- Symptom: *OPEN LIFTGATE FAILS TO TRIP ALARM
- Symptom: *OPEN PASSENGER DOOR FAILS TO TRIP ALARM
- Symptom: *PARK LAMPS FAIL TO FLASH DURING ALARM
- Symptom List: *VTSS FAILS TO ARM FROM LEFT DOOR CYLINDER LOCK SWITCH (EXPORT ONLY); *VTSS FAILS TO ARM/DISARM FROM LEFT DOOR CYLINDER LOCK SWITCH
- Symptom List: *VTSS FAILS TO ARM FROM LIFTGATE CYLINDER LOCK SWITCH (EXPORT ONLY); *VTSS FAILS TO ARM/DISARM FROM LIFTGATE CYLINDER LOCK SWITCH
- Symptom List: *VTSS FAILS TO ARM FROM RIGHT DOOR CYLINDER LOCK SWITCH (EXPORT ONLY); *VTSS FAILS TO ARM/DISARM FROM RIGHT DOOR CYLINDER LOCK SWITCH
- Symptom: *VTSS INDICATOR FAILS TO FLASH
- Symptom: *VTSS INDICATOR STAYS ON STEADY DURING ARMING
- Symptom: *VTSS SIREN INOPERATIVE (EXPORT ONLY)
- Verifications Tests
- Airbag
- Component Locations
- Connector PINOUTS
- Airbag Control Module (Orc) (Base) - Yellow 23 Way
- Airbag Control Module C1 (Orc) (Premium) - Yellow 32 Way
- Airbag Control Module C2 (Orc) (Premium) - Yellow 32 Way
- Ambient Temperature Sensor (Except 2.4L Base) - Black 2 Way
- Amplifier Audio C1 - 20 Way
- Anti-Lock Brake Module - Black 47 Way
- C203 (Pt27) - LT. Gray (Body Side)
- C203 (Pt27) - LT. Gray (Instrument Panel Side)
- C204 (Pt27) - (Instrument Panel Side)
- C204 (Pt27) - (Left Front Door Side)
- C204 (Pt44 LHP) - Natural (Instrument Panel Side)
- C204 (Pt44 LHP) - Natural (Left Front Door Side)
- C205 (Pt27) - (Instrument Panel Side)
- C205 (Pt27) - (Right Front Door Side)
- C305 - Yellow (Airbag Side)
- C305 - Yellow (UNIBODY Side)
- C306 - Yellow (Airbag Side)
- C306 - Yellow (UNIBODY Side)
- C343 (Pt27) - LT. Gray (DECKLID Jumper Side)
- C343 (Pt27) - LT. Gray (DECKLID Side)
- C349 (Pt27) - Blue (Body Side
- C349 (Pt27) - Blue (DECKLID Jumper Side)
- C362 (Pt27) - LT. Gray (Body Side)
- C362 (Pt27) - LT. Gray (Power Top Side)
- CLOCKSPRING - DK. Green 7 Way
- Compass/Temperature Mirror Module (Pt27) - Black 10 Way
- Data Link Connector - Black 16 Way
- DECKLID Cylinder Unlock Switch (Pt27) - LT. Gray 2 Way
- DECKLID Handle Switch (Pt27) - White 2 Way
- DECKLID Release Motor (Pt27) - Black 3 Way
- DECKLID Release Switch (Pt27) - Black 2 Way
- Dome Lamp - Black 3 Way
- Dome Lamp/Intrusion Sensor (Export) - White 4 Way
- Driver Airbag Squib 1 - Yellow 2 Way
- Driver Door Ajar Switch - Black 2 Way
- Driver Door Handle Switch (Pt27) - 2 Way
- Driver Door Power Lock Motor/Ajar Switch - Black 4 Way
- Driver Rear Window Motor (Pt27) - Black 2 Way
- Driver Seat Belt TENSIONER - Yellow 2 Way
- Driver Window Regulator Module (Pt27) - Black 20 Way
- Engine Control Module C1 (Diesel) - Black 81 Way
- Front Power Window Switch - Black 14 Way
- Fuel Pump Module - LT. Gray 4 Way
- Fuses (FB)
- Hands Free Module C1 - DK. Gray 22 Way
- Hands Free Module C2 (Satellite Radio) - DK. Gray 10 Way
- Hands Free Module C3 - Black 10 Way
- High Note Horn (Export) - Black 2 Way
- Hood Ajar Switch (Export) - Black 2 Way
- Ignition Switch C1 - 10 Way
- Instrument Cluster C1 - Black 26 Way
- Instrument Cluster C2 - Black 10 Way
- Left Cylinder Lock Switch - Black 2 Way
- Left Door Lock Switch - Black 3 Way
- Left Front Power Window Motor (Pt44) - Black 2 Way
- Left Instrument Panel Speaker - Black 2 Way
- Left Rear Speaker (Pt44) - Black 2 Way
- Left Seat Airbag Squib (LHP) - Yellow 2 Way
- Left Seat Airbag Squib (RHD) - Yellow 2 Way
- Left Side Impact Sensor 1 - Gray 2 Way
- Liftgate Ajar Switch - White 2 Way
- Liftgate Cylinder Lock Switch - LT. Gray 2 Way
- Liftgate Handle Switch (Pt44) - Natural 2 Way
- Liftgate Power Lock Motor - Black 4 Way
- Liftgate Release Motor (Pt44) - Black 3 Way
- Low Note Horn - Black 2 Way
- Multi-Function Switch - Gray 20 Way
- Overhead Console Module - Black 12 Way
- Passenger Airbag Squib 1 - Yellow 2 Way
- Passenger Door Ajar Switch - Black 2 Way
- Passenger Door Handle Switch (Pt27) - 2 Way
- Passenger Door Power Lock Motor/Ajar Switch - Black 4 Way
- Passenger Rear Window Motor (Pt27) - Black 2 Way
- Passenger Seat Belt TENSIONER - Yellow 2 Way
- Passenger Window Regulator Module (Pt27) - Black 20 Way
- Fuses (PDC)
- Power Top Motor (Pt27) - 2 Way
- Power Top Relay (Pt27) - Black 6 Way
- Power Top Switch (Pt27) - 3 Way
- Powertrain Control Module (1.6L) - Black 90 Way
- Powertrain Control Module C1 (NGC) - Black/Black 38 Way
- Radio C1 - White 22 Way
- Radio C2 (Hands Free) - DK. Gray 10 Way
- Rear View Mirror C1 - Black 12 Way
- Remote Keyless Entry Module - Black 26 Way
- Right Cylinder Lock Switch (Export) - Black 2 Way
- Right Door Lock Switch - Black 3 Way
- Right Front Door Speaker - 3 Way
- Right Front Power Window Motor (Pt44) - Black 2 Way
- Right Rear Power Window Motor (Pt44) - Black 2 Way
- Right Seat Airbag Squib (LHP) - Yellow 2 Way
- Right Seat Airbag Squib (RHP) - Yellow 2 Way
- Right Side Impact Sensor 1 - Gray 2 Way
- Sentry Key Immobilizer Module - Black 6 Way
- Siren (Export) - Black 4 Way
- Schematic Diagrams
- Body Diagnostic Procedures
- Door Locks
- Body Diagnostic Procedures
- Introduction
- Identification Of System
- System Description And Functional Operation
- Notes
- Airbag System
- Audio System
- Compass/Temperature Module (CTM)
- Compass/Temperature Mirror
- Description
- Operation
- English / Metric / Off Mode
- Calibration / Zone Mode
- Setting Compass Zone
- First Time Calibration
- Manual Calibration
- Continuous Calibration
- Self-Check Diagnostic
- Outside Temperature
- Temperature Update - Warm
- Temperature Update - Cold
- Extreme Temperature / Open Or Short Condition
- Ambient Temperature Sensor
- Ambient Temperature Sensor Diagnostics
- Instrument Cluster
- Remote Keyless Entry Module
- Sentry Key Immobilizer System (Skis)
- Communication
- Telecommunications
- Window Regulator Modules (Pt27 Only)
- Using The DRBIII®
- Disclaimers, Safety, Warnings
- Required Tools And Equipment
- Glossary Of Terms
- Diagnostic Information And Procedures
- Airbag
- Symptom List: ACCELEROMETER 1; INTERNAL 1; INTERNAL 2; INTERNAL 3; INTERNAL 4' OUTPUT DRIVER 1; OUTPUT DRIVER 2; STORED ENERGY FIRING 1
- Symptom List: AIRBAG WARNING INDICATOR DRIVER; AIRBAG WARNING INDICATOR OPEN; AIRBAG WARNING INDICATOR SHORT
- Symptom: CALIBRATION MISMATCH
- Symptom: CLUSTER MESSAGE MISMATCH
- Symptom: DRIVER SEAT BELT TENSIONER CIRCUIT OPEN
- Symptom: DRIVER SEAT BELT TENSIONER CIRCUIT SHORT
- Symptom: DRIVER SEAT BELT TENSIONER SHORT TO BATTERY
- Symptom: DRIVER SEAT BELT TENSIONER SHORT TO GROUND
- Symptom: DRIVER SQUIB 1 CIRCUIT OPEN
- Symptom: DRIVER SQUIB 1 CIRCUIT SHORT
- Symptom: DRIVER SQUIB 1 SHORT TO BATTERY
- Symptom: DRIVER SQUIB 1 SHORT TO GROUND
- Symptom: LEFT CURTAIN OR SEAT SQUIB CIRCUIT OPEN
- Symptom: LEFT CURTAIN OR SEAT SQUIB CIRCUIT SHORT
- Symptom: LEFT CURTAIN OR SEAT SQUIB SHORT TO BATTERY
- Symptom: LEFT CURTAIN OR SEAT SQUIB SHORT TO GROUND
- Symptom: LEFT SIDE IMPACT SENSOR 1 INTERNAL 1
- Symptom: LOSS OF IGNITION RUN - START
- Symptom: LOSS OF IGNITION RUN ONLY
- Symptom: NO CLUSTER MESSAGE
- Symptom: NO LEFT SIDE IMPACT SENSOR 1 COMMUNICATION
- Symptom: NO ODOMETER MESSAGE
- Symptom: NO PCI TRANSMISSION
- Symptom: NO RIGHT SIDE IMPACT SENSOR 1 COMMUNICATION
- Symptom: PASSENGER SEAT BELT TENSIONER CIRCUIT OPEN
- Symptom: PASSENGER SEAT BELT TENSIONER CIRCUIT SHORT
- Symptom: PASSENGER SEAT BELT TENSIONER SHORT TO BATTERY
- Symptom: PASSENGER SEAT BELT TENSIONER SHORT TO GROUND
- Symptom: PASSENGER SQUIB 1 CIRCUIT OPEN
- Symptom: PASSENGER SQUIB 1 CIRCUIT SHORT
- Symptom: PASSENGER SQUIB 1 SHORT TO BATTERY
- Symptom: PASSENGER SQUIB 1 SHORT TO GROUND
- Symptom: POWER SUPPLY VOLTAGE LOW
- Symptom: RIGHT CURTAIN OR SEAT SQUIB CIRCUIT OPEN
- Symptom: RIGHT CURTAIN OR SEAT SQUIB CIRCUIT SHORT
- Symptom: RIGHT CURTAIN OR SEAT SQUIB SHORT TO BATTERY
- Symptom: RIGHT CURTAIN OR SEAT SQUIB SHORT TO GROUND
- Symptom: RIGHT SIDE IMPACT SENSOR INTERNAL 1
- Symptom: VEHICLE BODY STYLE MISMATCH
- Symptom: *AIRBAG INDICATOR ON WITHOUT ACTIVE TROUBLE CODES
- Audio
- Symptom: ALL OUTPUTS SHORT
- Symptom: ANTENNA HARDWARE FAILURE - SDARS
- Symptom: ANTENNA NOT CONNECTED - SDARS
- Symptom: BUS BUSY - SDARS
- Symptom: BUS LOW - SDARS
- Symptom List: CASSETTE PLAYER INOP; CD MECHANICAL FAILURE; NO PCI TRANSMISSION; *AM/FM SWITCH INOPERATIVE; *ANY STATION PRESET SWITCH INOPERATIVE; *BALANCE INOPERATIVE; *CD EJECT SWITCH INOPERATIVE; *EQUALIZER INOPERATIVE; *FADER INOPERATIVE; *FF/RW SWITCH INOPERATIVE; *HOUR/MINUTE SWITCHES INOPERATIVE; *PAUSE/PLAY SWITCH INOPERATIVE; *PWR SWITCH INOPERATIVE; *SCAN SWITCH INOPERATIVE; *SEEK SWITCH INOPERATIVE; *SET SWITCH INOPERATIVE; *TAPE EJECT SWITCH INOPERATIVE; *TIME SWITCH INOPERATIVE; *TUNE SWITCH INOPERATIVE
- Symptom: CD PLAY FAILURE
- Symptom: CD READ FAILURE
- Symptom: CD TEMPERATURE HIGH
- Symptom: GPS ANTENNA NOT CONNECTED
- Symptom: INTERNAL FAILURE - SDARS
- Symptom: INTERNAL RECEIVER FAILURE - SDARS
- Symptom: LOW VOLTAGE LEVEL
- Symptom: NO ANTENNA CONNECTION
- Symptom: NO COMMUNICATION WITH SDARS
- Symptom: NO J1850 COMMUNICATION - SDARS
- Symptom: POWER AMP SHUTDOWN
- Symptom: RADIO AND NAV GPS ANTENNA NOT CONNECTED
- Symptom: *INOP NO FAULT CODES - SDARS
- Symptom: *POOR RECEPTION - SDARS
- Communication
- Symptom: *NO RESPONSE FROM AIRBAG CONTROL MODULE
- Symptom: *NO RESPONSE FROM AMPLIFIER
- Symptom: *NO RESPONSE FROM ANTILOCK BRAKE MODULE
- Symptom: *NO RESPONSE FROM ECM (PCI BUS) - DIESEL ONLY
- Symptom: *NO RESPONSE FROM ECM (SCI ONLY) - DIESEL ONLY
- Symptom: *NO RESPONSE FROM HANDS FREE MODULE
- Symptom: *NO RESPONSE FROM INSTRUMENT CLUSTER
- Symptom: *NO RESPONSE FROM OVERHEAD CONSOLE (COMPASS/TEMPERATURE MIRROR MODULE)
- Symptom: *NO RESPONSE FROM PCM (PCI BUS) - 1.6L
- Symptom: *NO RESPONSE FROM PCM (PCI BUS) - NGC
- Symptom: *NO RESPONSE FROM PCM (PCM SCI ONLY) - NGC
- Symptom: *NO RESPONSE FROM PCM (SCI ONLY) - 1.6L
- Symptom: *NO RESPONSE FROM RADIO
- Symptom: *NO RESPONSE FROM RKE
- Symptom: *NO RESPONSE FROM SATELLITE RADIO RECEIVER
- Symptom: *NO RESPONSE FROM SENTRY KEY IMMOBILIZER MODULE
- Symptom: *NO RESPONSE FROM TRANSMISSION CONTROL MODULE - NGC
- Symptom: *NO RESPONSE FROM WINDOW REGULATOR MODULE - PT27
- Symptom: *PCI BUS COMMUNICATION FAILURE
- Instrument Cluster
- Symptom List: ABS INDICATOR CIRCUIT OPEN; AIRBAG INDICATOR CIRCUIT OPEN
- Symptom List: ABS MESSAGE NOT RECEIVED; ACM MESSAGE NOT RECEIVED; EATX MESSAGE NOT RECEIVED; NO PCI TRANSMISSION; SBEC MESSAGE NOT RECEIVED; SKIM MESSAGE NOT RECEIVED
- Symptom: EATX MESSAGE MISMATCH
- Symptom: EEPROM CHECKSUM FAILURE
- Symptom: FUEL LEVEL SENSOR OPEN
- Symptom: FUEL LEVEL SENSOR SHORT
- Symptom: FUEL LEVEL SENSOR STUCK
- Symptom: PANEL DIMMER OPEN
- Symptom: PANEL DIMMER SHORTED
- Symptom: *ALL GAUGES INOPERATIVE
- Symptom: *ANY PCI BUS INDICATOR INOPERATIVE
- Symptom: *BRAKE WARNING INDICATOR ALWAYS ON
- Symptom: *BRAKE WARNING INDICATOR INOPERATIVE
- Symptom: *FRONT FOG LAMP INDICATOR INOPERATIVE
- Symptom: *FUEL GAUGE INACCURATE
- Symptom: *HIGH BEAM INDICATOR INOPERATIVE
- Symptom: *INSTRUMENT CLUSTER DIMMING INOPERATIVE
- Symptom: *LOW OIL PRESSURE INDICATOR ALWAYS ON
- Symptom: *LOW OIL PRESSURE INDICATOR INOPERATIVE
- Symptom: *ONE GAUGE INOPERATIVE
- Symptom: *PRND OR AUTOSTICK DISPLAY INOPERATIVE OR INACCURATE
- Symptom: *REAR FOG LAMP INDICATOR INOPERATIVE - BUX ONLY
- Symptom: *SEAT BELT INDICATOR NOT OPERATING PROPERLY
- Symptom: *VF DISPLAY INOPERATIVE
- Interior Lighting
- Overhead Console
- Power Door Locks/RKE
- Symptom: BODY STYLE MISMATCH
- Symptom: DRIVER DOOR SWITCH FAILURE
- Symptom: INCORRECT MODULE TYPE CONFIGURATION FOR PART NUMBER
- Symptom: MODULE NOT CONFIGURED FOR RKE
- Symptom: NO AIRBAG MESSAGES RECEIVED
- Symptom: NO PCM MESSAGES RECEIVED
- Symptom: NO SKIM MESSAGES RECEIVED
- Symptom: PASSENGER DOOR OR LIFTGATE SWITCH FAILURE - PT44
- Symptom:* ALL DOORS (EXCEPT DRIVER)FAIL TO LOCK
- Symptom: * ALL DOORS (EXCEPT DRIVER)FAIL TO LOCK AND UNLOCK
- Symptom:* ALL DOORS (EXCEPT DRIVER)FAIL TO UNLOCK
- Symptom: *ALL DOOR LOCKS INOPERATIVE
- Symptom: *ALL DOORS FAIL TO LOCK
- Symptom: *ALL DOORS FAIL TO UNLOCK
- Symptom: *ALL LOCKS INOPERATIVE FROM ONE LOCK SWITCH
- Symptom: *DECKLID RELEASE SWITCH INOPERATIVE - PT27
- Symptom: *DECKLID SOLENOID INOPERATIVE - PT27
- Symptom: *DOORS LOCKABLE WITH KEY IN IGNITION AND DRIVER DOOR OPEN
- Symptom: *DRIVER DOOR FAILS TO LOCK
- Symptom: *DRIVER DOOR FAILS TO LOCK AND UNLOCK
- Symptom: *DRIVER DOOR FAILS TO UNLOCK
- Symptom: *DRIVER DOOR FAILS UNLOCK - PT27
- Symptom: *LIFTGATE LOCK MOTOR FAILS TO LOCK OR UNLOCK
- Symptom: *ONE DOOR FAILS TO LOCK AND UNLOCK - PT27
- Symptom: *ONE PASSENGER DOOR FAILS TO LOCK AND UNLOCK
- Symptom: *PASSENGER DOOR FAILS TO UNLOCK - PT27
- Symptom: *RKE INOPERATIVE
- Power Top
- Symptom: AMBIENT TEMP MESSAGE NOT RECEIVED
- Symptom: POWER TOP RELAY CONTROL CIRCUIT OPEN
- Symptom: POWER TOP RELAY INOPERATIVE
- Symptom: POWER TOP SWITCH MUX CIRCUIT OPEN
- Symptom: POWER TOP SWITCH MUX CIRCUIT SHORT TO GROUND
- Symptom: POWER TOP SWITCH MUX CIRCUIT VALUE OUT OF RANGE
- Symptom: SPEED MESSAGE NOT RECEIVED
- Power Windows
- Symptom: BATTERY VOLTAGE TOO HIGH
- Symptom: BATTERY VOLTAGE TOO LOW
- Symptom: FRONT WINDOW MOTOR MALFUNCTION
- Symptom: FRONT WINDOW SWITCH MUX CIRCUIT OPEN
- Symptom: FRONT WINDOW SWITCH MUX CIRCUIT SHORT TO GROUND
- Symptom: FRONT WINDOW SWITCH MUX CIRCUIT VALUE OUT OF RANGE
- Symptom: IGNITION SWITCH OUTPUT OPEN
- Symptom: REAR WINDOW MOTOR CIRCUIT OPEN OR SHORTED
- Symptom: REAR WINDOW SWITCH MUX CIRCUIT OPEN
- Symptom: REAR WINDOW SWITCH MUX CIRCUIT SHORT TO GROUND
- Symptom: REAR WINDOW SWITCH MUX CIRCUIT VALUE OUT OF RANGE
- Symptom: WINDOW DROP SWITCH SENSE CIRCUIT OPEN
- Symptom: *DOOR AJAR CIRCUIT OPEN
- Symptom: *DOOR WINDOWS STAY IN DROP DOWN POSITION
- Symptom: *WINDOW DROPS OR JERKS DURING OPENING
- Telecommunication
- Symptom: AUDIO HARDWARE MESSAGE NOT RECEIVED
- Symptom List: BLUETOOTH ERROR; FLASH CHECKSUM ERROR; FLASH WRITE ERROR; PCI BUS INTERNAL ERROR; RAM WRITE ERROR; ROM CHECKSUM ERROR
- Symptom List: BODY STYLE MESSAGE NOT RECEIVED; INVALID BODY STYLE
- Symptom: GENERAL MICROPHONE FAULT
- Symptom: IGNITION POWER MESSAGE NOT RECEIVED
- Symptom List: LEFT AUDIO INPUT SHORT TO GROUND; LEFT AUDIO INPUT SHORT TO VOLTAGE; LEFT AUDIO OUTPUT 1 SHORT TO GROUND; LEFT AUDIO OUTPUT 1 SHORT TO VOLTAGE
- Symptom List: MIRROR POWER CIRCUIT SHORT TO GROUND; MIRROR POWER CIRCUIT SHORT TO VOLTAGE
- Symptom List: PCI BUS BUSY; PCI BUS CIRCUIT OPEN; PCI BUS CIRCUIT SHORT TO GROUND; PCI BUS CIRCUIT SHORT TO VOLTAGE
- Symptom List: PHONE SWITCH STUCK; VOICE RECOGNITION SWITCH STUCK' VOICE RECOGNITION/PHONE SWITCH CIRCUIT RATIONALITY; VOICE RECOGNITION/PHONE SWITCH CIRCUIT SHORT TO GROUND; VOICE RECOGNITION/PHONE SWITCH CIRCUIT SHORT TO VOLTAGE
- Symptom: PRNDL MESSAGE NOT RECEIVED
- Symptom: RADIO MESSAGE NOT RECEIVED
- Symptom List: RIGHT AUDIO INPUT SHORT TO GROUND; RIGHT AUDIO INPUT SHORT TO VOLTAGE; RIGHT AUDIO OUTPUT 1 SHORT TO GROUND; RIGHT AUDIO OUTPUT 1 SHORT TO VOLTAGE
- Symptom: RPM MESSAGE NOT RECEIVED
- Symptom: VIN MESSAGE NOT RECEIVED
- Symptom: VIN MISMATCH
- Vehicle Theft/Security
- Symptom: HOOD AJAR SWITCH MISSING (EXPORT ONLY)
- Symptom: MODULE PREVIOUSLY CONFIGURED FOR VTSS
- Symptom: *ALARM TRIPS ON ITS OWN
- Symptom: *HEADLAMPS FAIL TO FLASH DURING ALARM
- Symptom: *HORN FAILS TO SOUND DURING ALARM
- Symptom: *INTRUSION SENSOR CANNOT BE DISABLED (EXPORT ONLY)
- Symptom: *INTRUSION SENSOR FAILS TO TRIP VTSS (EXPORT ONLY)
- Symptom: *INTRUSION SENSOR REPEATEDLY TRIGGERS VTSS (EXPORT ONLY)
- Symptom: *OPEN DRIVER DOOR FAILS TO TRIP ALARM
- Symptom: *OPEN LIFTGATE FAILS TO TRIP ALARM
- Symptom: *OPEN PASSENGER DOOR FAILS TO TRIP ALARM
- Symptom: *PARK LAMPS FAIL TO FLASH DURING ALARM
- Symptom List: *VTSS FAILS TO ARM FROM LEFT DOOR CYLINDER LOCK SWITCH (EXPORT ONLY); *VTSS FAILS TO ARM/DISARM FROM LEFT DOOR CYLINDER LOCK SWITCH
- Symptom List: *VTSS FAILS TO ARM FROM LIFTGATE CYLINDER LOCK SWITCH (EXPORT ONLY); *VTSS FAILS TO ARM/DISARM FROM LIFTGATE CYLINDER LOCK SWITCH
- Symptom List: *VTSS FAILS TO ARM FROM RIGHT DOOR CYLINDER LOCK SWITCH (EXPORT ONLY); *VTSS FAILS TO ARM/DISARM FROM RIGHT DOOR CYLINDER LOCK SWITCH
- Symptom: *VTSS INDICATOR FAILS TO FLASH
- Symptom: *VTSS INDICATOR STAYS ON STEADY DURING ARMING
- Symptom: *VTSS SIREN INOPERATIVE (EXPORT ONLY)
- Verifications Tests
- Airbag
- Component Locations
- Connector PINOUTS
- Airbag Control Module (Orc) (Base) - Yellow 23 Way
- Airbag Control Module C1 (Orc) (Premium) - Yellow 32 Way
- Airbag Control Module C2 (Orc) (Premium) - Yellow 32 Way
- Ambient Temperature Sensor (Except 2.4L Base) - Black 2 Way
- Amplifier Audio C1 - 20 Way
- Anti-Lock Brake Module - Black 47 Way
- C203 (Pt27) - LT. Gray (Body Side)
- C203 (Pt27) - LT. Gray (Instrument Panel Side)
- C204 (Pt27) - (Instrument Panel Side)
- C204 (Pt27) - (Left Front Door Side)
- C204 (Pt44 LHP) - Natural (Instrument Panel Side)
- C204 (Pt44 LHP) - Natural (Left Front Door Side)
- C205 (Pt27) - (Instrument Panel Side)
- C205 (Pt27) - (Right Front Door Side)
- C305 - Yellow (Airbag Side)
- C305 - Yellow (UNIBODY Side)
- C306 - Yellow (Airbag Side)
- C306 - Yellow (UNIBODY Side)
- C343 (Pt27) - LT. Gray (DECKLID Jumper Side)
- C343 (Pt27) - LT. Gray (DECKLID Side)
- C349 (Pt27) - Blue (Body Side
- C349 (Pt27) - Blue (DECKLID Jumper Side)
- C362 (Pt27) - LT. Gray (Body Side)
- C362 (Pt27) - LT. Gray (Power Top Side)
- CLOCKSPRING - DK. Green 7 Way
- Compass/Temperature Mirror Module (Pt27) - Black 10 Way
- Data Link Connector - Black 16 Way
- DECKLID Cylinder Unlock Switch (Pt27) - LT. Gray 2 Way
- DECKLID Handle Switch (Pt27) - White 2 Way
- DECKLID Release Motor (Pt27) - Black 3 Way
- DECKLID Release Switch (Pt27) - Black 2 Way
- Dome Lamp - Black 3 Way
- Dome Lamp/Intrusion Sensor (Export) - White 4 Way
- Driver Airbag Squib 1 - Yellow 2 Way
- Driver Door Ajar Switch - Black 2 Way
- Driver Door Handle Switch (Pt27) - 2 Way
- Driver Door Power Lock Motor/Ajar Switch - Black 4 Way
- Driver Rear Window Motor (Pt27) - Black 2 Way
- Driver Seat Belt TENSIONER - Yellow 2 Way
- Driver Window Regulator Module (Pt27) - Black 20 Way
- Engine Control Module C1 (Diesel) - Black 81 Way
- Front Power Window Switch - Black 14 Way
- Fuel Pump Module - LT. Gray 4 Way
- Fuses (FB)
- Hands Free Module C1 - DK. Gray 22 Way
- Hands Free Module C2 (Satellite Radio) - DK. Gray 10 Way
- Hands Free Module C3 - Black 10 Way
- High Note Horn (Export) - Black 2 Way
- Hood Ajar Switch (Export) - Black 2 Way
- Ignition Switch C1 - 10 Way
- Instrument Cluster C1 - Black 26 Way
- Instrument Cluster C2 - Black 10 Way
- Left Cylinder Lock Switch - Black 2 Way
- Left Door Lock Switch - Black 3 Way
- Left Front Power Window Motor (Pt44) - Black 2 Way
- Left Instrument Panel Speaker - Black 2 Way
- Left Rear Speaker (Pt44) - Black 2 Way
- Left Seat Airbag Squib (LHP) - Yellow 2 Way
- Left Seat Airbag Squib (RHD) - Yellow 2 Way
- Left Side Impact Sensor 1 - Gray 2 Way
- Liftgate Ajar Switch - White 2 Way
- Liftgate Cylinder Lock Switch - LT. Gray 2 Way
- Liftgate Handle Switch (Pt44) - Natural 2 Way
- Liftgate Power Lock Motor - Black 4 Way
- Liftgate Release Motor (Pt44) - Black 3 Way
- Low Note Horn - Black 2 Way
- Multi-Function Switch - Gray 20 Way
- Overhead Console Module - Black 12 Way
- Passenger Airbag Squib 1 - Yellow 2 Way
- Passenger Door Ajar Switch - Black 2 Way
- Passenger Door Handle Switch (Pt27) - 2 Way
- Passenger Door Power Lock Motor/Ajar Switch - Black 4 Way
- Passenger Rear Window Motor (Pt27) - Black 2 Way
- Passenger Seat Belt TENSIONER - Yellow 2 Way
- Passenger Window Regulator Module (Pt27) - Black 20 Way
- Fuses (PDC)
- Power Top Motor (Pt27) - 2 Way
- Power Top Relay (Pt27) - Black 6 Way
- Power Top Switch (Pt27) - 3 Way
- Powertrain Control Module (1.6L) - Black 90 Way
- Powertrain Control Module C1 (NGC) - Black/Black 38 Way
- Radio C1 - White 22 Way
- Radio C2 (Hands Free) - DK. Gray 10 Way
- Rear View Mirror C1 - Black 12 Way
- Remote Keyless Entry Module - Black 26 Way
- Right Cylinder Lock Switch (Export) - Black 2 Way
- Right Door Lock Switch - Black 3 Way
- Right Front Door Speaker - 3 Way
- Right Front Power Window Motor (Pt44) - Black 2 Way
- Right Rear Power Window Motor (Pt44) - Black 2 Way
- Right Seat Airbag Squib (LHP) - Yellow 2 Way
- Right Seat Airbag Squib (RHP) - Yellow 2 Way
- Right Side Impact Sensor 1 - Gray 2 Way
- Sentry Key Immobilizer Module - Black 6 Way
- Siren (Export) - Black 4 Way
- Schematic Diagrams
- Power Door Lock System
- Power Locks
- Door Lock Switch
- Door Lock Motor
- Liftgate Lock Motor
- Remote Keyless Entry Module
- Remote Keyless Entry Transmitter
- Powertrain Diagnostic Procedures - Component Testing
- Sentry Key Immobilizer - Symptoms
- Symptom List: ANTENNA FAILURE; COP FAILURE; EEPROM FAILURE; INTERNAL FAULT; RAM FAILURE; SERIAL LINK INTERNAL FAULT; STACK OVERFLOW FAILURE
- Symptom List: PCM STATUS FAILURE; SERIAL LINK EXTERNAL FAULT
- Symptom List: ROLLING CODE FAILURE; VIN MISMATCH
- Symptom List: TRANSPONDER COMMUNICATION FAILURE; TRANSPONDER CYCLIC REDUNDANCY CHECK (CRC) FAILURE; TRANSPONDER ID MISMATCH; TRANSPONDER RESPONSE MISMATCH
- Starting - Symptoms
- Symptom: *CHECKING FUEL DELIVERY
- Symptom: *CHECKING FUEL PRESSURE LEAK DOWN
- Symptom: *CHECKING HARD START (FUEL DELIVERY SYSTEM)
- Symptom: *ENGINE CRANKS DOES NOT START - 1.6L
- Symptom: *ENGINE CRANKS DOES NOT START - 2.0L/2.4L
- Symptom: *NO CRANK CONDITION 1.6L
- Symptom: *NO CRANK CONDITION 2.0L/2.4L
- Symptom: *NO RESPONSE FROM PCM WITH A NO START CONDITION
- Symptom: *START AND STALL CONDITION 1.6L
- Symptom: *START AND STALL CONDITION 2.0L/2.4L
- Verification Test
- Component Locations
- Powertrain And Skim
- Control And Solenoids
- Throttle Body And Component Locations (2.0L/2.4L)
- Generator Location (1.6L)
- Generator and 1/1 O2 Sensor Locations (2.0L/2.4L)
- ETC Assembly And Ignition Coil Locations (1.6L)
- MAP Sensor And Ignition Coil Location (2.0L/2.4L)
- EVAP Purge Solenoid Location (2.0L/2.4L)
- NVLD Location (2.0L/2.4L)
- Speed Control Servo Locations (2.0L/2.4L)
- Speed Control Servo And Solenoids Component Locations (2.4L Turbo Only)
- Data Link Connector
- Sensors
- Battery Temperature Sensor Location (2.0L/2.4L)
- CKP Sensor Location (1.6L)
- CKP Sensor Location (2.0L/2.4L)
- CMP Sensor Location (2.0L/2.4L)
- Coolant Temperature Sensor Location (2.0L/2.4L)
- ECT Sensor Location (1.6L)
- IAT Sensor Location (2.0L/2.4L)
- Knock Sensor Location (1.6L)
- Knock Sensor Location (2.4L)
- MAP Sensor And Injectors Locations (1.6L)
- MAP Sensor Location (2.0L/2.4L)
- MAP Sensor Location (2.4L Turbo Only)
- APP Sensor Location (1.6L)
- O2 Sensors Location (1.6L)
- VSS Location
- Fuel System
- Relays
- Switches
- Connector PINOUTS
- A/C Compressor Clutch (Gas) - Black 2 Way
- A/C Low Pressure Switch - DK. Green 2 Way
- A/C Pressure Transducer - 2 Way
- Accelerator Pedal Position Sensor (1.6L/Diesel) - 10 Way
- Ambient Temperature Sensor (Except 2.4L Base) - Black 2 Way
- Ambient Temperature Sensor (NGC) - Black 2 Way
- Brake Lamp Switch (Gas) - Gray 6 Way
- Camshaft Position Sensor (Diesel) - Black 3 Way
- Camshaft Position Sensor (Gas) - Black 3 Way
- Clutch Pedal Position Switch (Up) - Black 3 Way
- Crankshaft Position Sensor (Gas) - Black 3 Way
- Data Link Connector - Black 16 Way
- EGR Solenoid (Diesel) - 2 Way
- Engine Coolant Temperature Sensor (Diesel) - Black 2 Way
- Engine Coolant Temperature Sensor (Gas) - Black 2 Way
- Engine Oil Pressure Switch - LT. Green 2 Way
- EVAP/Purge Solenoid (Gas) - Black 2 Way
- Fuel Injector No. 1 (Gas) - Black 2 Way
- Fuel Injector No. 2 (Gas) - Black 2 Way
- Fuel Injector No. 3 (Gas) - Black 2 Way
- Fuel Injector No. 4 (Gas) - Black 2 Way
- Fuel Pump Module - LT. Gray 4 Way
- Generator (2.4L Turbo) - Black 2 Way
- Generator (Gas Except 2.4L Turbo) - Black 2 Way
- Idle Air Control Motor (2.4L) - Black 2 Way
- Ignition Coil (Gas) - Black 3 Way
- Inlet Air Temperature Sensor (Gas) - Black 2 Way
- Knock Sensor (Gas) - Black 2 Way
- Manifold Absolute Pressure Sensor (Gas) - Black 3 Way
- Natural Vacuum Leak Detection Assembly (Except Export) - Black 3 Way
- Oxygen Sensor 1/1 Upstream (Gas) - Black 4 Way
- Oxygen Sensor 1/2 Downstream (Gas) - Black 4 Way
- Powertrain Control Module (1.6L) - Black 90 Way
- Powertrain Control Module C1 (NGC) - Black/Black 38 Way
- Powertrain Control Module C2 (NGC) - Black/Orange 38 Way
- Powertrain Control Module C3 (NGC) - Black/Natural 38 Way
- Powertrain Control Module C4 (NGC) - Black/Green 38 Way
- Radiator Fan Motor (2.4L Turbo) - DK. Gray 4 Way
- Radiator Fan Motor (Except 2.4L Turbo) - Black 3 Way
- Sentry Key Immobilizer Module - Black 6 Way
- Speed Control Servo (2.4L) - Black 4 Way
- Speed Control Switch - Yellow 3 Way
- Surge Solenoid (2.4L Turbo) - Black 2 Way
- Throttle Inlet Pressure Sensor (2.4L Turbo) - Natural 3 Way
- Throttle Inlet Pressure Solenoid (2.4L Turbo) - Black 2 Way
- Throttle Position Sensor (2.4L) - Black 3 Way
- Vehicle Speed Sensor (Gas MTX) - Black 3 Way
- WASTEGATE Solenoid (2.4L Turbo) - Black 2 Way
- Schematic Diagrams
- Charts And Graphs
- Vacuum Gauge Reading Examples
- Camshaft Sensor & Crankshaft Sensor Scope Pattern (Typical)
- Accelerator Pedal Position Sensor Specifications (1.6L)
- Camshaft & Crankshaft Sensor Specifications (1.6L)
- Throttle Position Sensor Specifications (1.6L)
- EVAP Tester
- Turbocharger System Circuit Diagrams
- Fuel Gauge Voltage Specifications
- Evaporative Emission System Schematic
- Sentry Key Immobilizer - Symptoms
- Powertrain Diagnostic Procedures - DRIVEABILITY - 1.6L Gas
- DRIVEABILITY - 1.6L Gas - Symptoms
- DRIVEABILITY - 1.6L Gas - Diagnostic Tests
- P0016-Crank And Cam Out-Of-Sync
- P0030-1/1 O2 Sensor Heater Circuit Open; P0036-1/1 O2 Sensor Heater Circuit Open
- P0031-1/1 O2 Sensor Heater Circuit Low; P0037-1/1 O2 Sensor Heater Circuit Low
- P0032-1/1 O2 Sensor Heater Circuit High; P0038-1/2 O2 Sensor Heater Circuit High
- P0106-BARO Pressure Out Of Range
- P0107-Map Sensor Voltage Too Low
- P0108-Map Sensor Voltage Too High
- P0112-Intake Air Temp Sensor Too Low
- P0113-Intake Air Temp Sensor Too High
- P0117-ECT Sensor Voltage Too Low
- P0118-ECT Sensor Voltage Too High
- P0122-Throttle Position Sensor Circuit #1 Low; P0222-Throttle Position Sensor Circuit #2 Low
- P0123-Throttle Position Sensor Circuit #1 High; P0223-Throttle Position Sensor Circuit #2 High
- P0125-Closed Loop Temp Not Reached
- P0128-Coolant Thermostat
- P0131-1/1 O2 Sensor Shorted To Ground; P0137-1/2 O2 Sensor Shorted To Ground
- P0132-1/1 O2 Sensor Shorted To Voltage; P0138-1/2 O2 Sensor Shorted To Voltage
- P0133-1/1 O2 Sensor Slow Response; P0139-1/2 O2 Sensor Slow Response
- P0134-1/1 O2 Sensor Stays At Center; P0140-1/2 O2 Sensor Stays At Center
- P0171-1/1 Fuel System Lean
- P0172-1/1 Fuel System Rich
- P0201-Injector #1 Control Circuit Open; P0202-Injector #2 Control Circuit Open; P0203-Injector #3 Control Circuit Open; P0204-Injector #4 Control Circuit Open
- P0261-Injector #1 Control Circuit Low; P0264-Injector #2 Control Circuit Low; P0267-Injector #3 Control Circuit Low; P0270-Injector #4 Control Circuit Low
- P0262-Injector #1 Control Circuit High; P0265-Injector #2 Control Circuit High; P0268-Injector #3 Control Circuit High; P0271-Injector #4 Control Circuit High
- P0300-Multiple Cylinder Mis-Fire; P0301-Cylinder #1 Misfire; P0302-Cylinder #2 Misfire; P0303-Cylinder #3 Misfire; P0304-Cylinder #4 Misfire
- P0315-No Crank Learned
- P0325-Knock Sensor #1 Circuit
- P0335-No Crank Signal At Pcm
- P0336-Crankshaft Position Sensor Performance
- P0340-No Cam Signal At Pcm
- P0420-1/1 Catalytic Converter Efficiency
- P0444-EVAP Purge Solenoid Circuit Open
- P0458-EVAP Purge Solenoid Low
- P0459-EVAP Purge Solenoid Circuit High
- P0461-Fuel Level Unit No Change Over Time
- P0462-Fuel Level Sending Unit Volts Too Low
- P0463-Fuel Level Sending Unit Volts Too High
- P0500-No Vehicle Speed Sensor Signal
- P0506-Idle Speed Performance Lower Than Excepted
- P0507-Idle Speed Performance Higher Than Excepted
- P0513-Invalid Skim Key
- P0551-Power Steering Switch Failure
- P0562-Charging System Voltage Too Low
- P0563-Charging System Voltage Too High
- P0572-Brake Switch Circuit Low
- P0573-Brake Switch Circuit High
- P0580-Speed Control Switch Always Low
- P0625-Generator Field Control Circuit Low
- P0626-Generator Field Control Circuit High
- P0628-Fuel Pump Relay Control Circuit Low
- P0629-Fuel Pump Relay Control Circuit High
- P0646-A/C Clutch Relay Control Circuit Low
- P0647-A/C Clutch Relay Control Circuit High
- P0686-ASD Relay Control Circuit Low
- P0687-ASD Relay Control Circuit High
- P0688-ASD Relay Output Circuit Low
- P0690-ASD Relay Output Circuit High
- P0691-Low Speed Fan Relay Control Circuit Low; P0693-High Speed Fan Relay Control Circuit Low
- P0692-Low Speed Fan Relay Control Circuit High P0694-High Speed Fan Relay Control Circuit High
- P0703-Brake Lamp Switch Circuit Performance
- P0719-Brake Lamp Switch Circuit Low
- P0724-Brake Lamp Switch Circuit High
- P0833-Clutch UPSTOP Switch Performance
- P1135-1/1 O2 Heater Element Resistance Out Of Range; P1136-1/2 Heater Element Resistance Out Of Range
- P1594-Charging System Voltage Too High
- P1616-5V Output Reference Voltage #1 Low
- P1617-5V Output Reference Voltage #1 High
- P1618-5V Output Reference Voltage Unstable
- P1626-5V Output Reference Voltage #2 Low
- P1627-5V Output Reference Voltage #2 High
- P1628-5V Output Reference Voltage #1 Unstable
- P1653-PCI Bus Shorted To Ground
- P1654-PCI Bus Shorted To Voltage
- P1656-PCI Bus Not Available
- P1686-No Skim Bus Message Received
- P1687-No Cluster Bus Message
- P2100-Electronic Throttle Control Motor Circuit
- P2101-Electronic Throttle Control Motor Performance
- P2107-Electronic Throttle Control Module Processor; P2108-Electronic Throttle Control Module Performance
- P2122-Accelerator Pedal Position Sensor # 1 Low; P2127-Accelerator Pedal Position Sensor #2 Low
- P2123-Accelerator Pedal Position Sensor #1 High; P2128-Accelerator Pedal Position Sensor #2 High
- P2135-Throttle Position Sensor #1 And #2 Voltage Correlation
- P2138-Accelerator Pedal Position Sensor #1 And #2 Voltage Correlation
- P2300-Ignition Coil #1 Circuit Low; P2303-Ignition Coil #2 Circuit Low
- P2301-Ignition Coil #1 Circuit High; P2304-Ignition Coil #2 Circuit High
- Powertrain Diagnostic Procedures - DRIVEABILITY - NGC
- DRIVEABILITY - NGC - Symptoms
- DRIVEABILITY - NGC - Diagnostic Tests
- P0016-Crankshaft/Camshaft Timing Misalignment
- P0031-O2 Sensor 1/1 Heater Circuit Low; P0037-O2 Sensor 1/2 Heater Circuit Low
- P0032-O2 Sensor 1/1 Heater Circuit High P0038-O2 Sensor 1/2 Heater Circuit High
- P0033-Surge Valve Solenoid Circuit
- P0068-Manifold Pressure/Throttle Position Correlation
- P0071-Ambient Temp Sensor Performance
- P0072-Ambient Temp Sensor Low
- P0073-Ambient Temp Sensor High
- P0107-Map Sensor Low
- P0108-Map Sensor High
- P0111-Intake Air Temperature Sensor Performance
- P0112-Intake Air Temperature Sensor Low
- P0113-Intake Air Temperature Sensor High
- P0116-Engine Coolant Temperature Performance
- P0117-Engine Coolant Temperature Sensor Low
- P0118-Engine Coolant Temperature Sensor High
- P0122-Throttle Position Sensor #1 Low
- P0123-Throttle Position Sensor #1 High
- P0125-Insufficient Coolant Temp For Closed-Loop Fuel Control
- P0128-Thermostat Rationality
- P0129-Barometric Pressure Out-Of-Range
- P0131-O2 Sensor 1/1 Voltage Low; P0137-O2 Sensor 1/2 Voltage Low
- P0132-O2 Sensor 1/1 Voltage High; P0138-O2 Sensor 1/2 Voltage High
- P0133-O2 Sensor 1/1 Slow Response; P0139-O2 Sensor 1/2 Slow Response
- P0135-O2 Sensor 1/1 Heater Performance; P0141-O2 Sensor 1/2 Heater Performance
- P0171-Fuel System 1/1 Lean
- P0172-Fuel System 1/1 Rich
- P0201-Fuel Injector #1; P0202-Fuel Injector #2; P0203-Fuel Injector #3; P0204-Fuel Injector #4
- P0234-OVERBOOST Performance; P1106-BARO Solenoid Performance; P1188 Tip Sensor Performance
- P0243-WASTEGATE Solenoid Circuit
- P0300-Multiple Cylinder Misfire; P0301-Cylinder #1 Misfire; P0302-Cylinder #2 Misfire; P0303-Cylinder #3 Misfire; P0304-Cylinder #4 Misfire
- P0315-No Crank Sensor Learned
- P0325-Knock Sensor #1 Circuit
- P0335-Crankshaft Position Sensor Circuit
- P0339-Crankshaft Position Sensor Intermittent
- P0340-Camshaft Position Sensor Circuit
- P0344-Camshaft Position Sensor Intermittent
- P0420-Catalytic 1/1 Efficiency
- P0440-General EVAP System Failure
- P0441-EVAP Purge System Performance
- P0442-EVAP System Medium Leak; P0455-EVAP System Large Leak
- P0443-EVAP Purge Solenoid Circuit
- P0452-NVLD Pressure Switch Stuck Closed
- P0453-NVLD Pressure Switch Stuck Open
- P0456-EVAP System Small Leak
- P0457-Loose Fuel Cap
- P0461-Fuel Level Sensor #1 Performance
- P0462-Fuel Level Sensor #1 Low; P0463-Fuel Level Sensor #1 High
- P0480-Cooling Fan 1 Control Circuit
- P0481-Cooling Fan 2 Control Circuit
- P0498-NVLD Canister Vent Valve Solenoid Circuit Low
- P0499-NVLD Canister Vent Valve Solenoid Circuit High
- P0501-Vehicle Speed Sensor #1 Performance (Auto Trans)
- P0501-Vehicle Speed Sensor #1 Performance (Manual Trans)
- P0506-Idle Speed Low Performance; P0507-Idle Speed High Performance
- P0508-IAC Valve Sense Circuit Low
- P0509-IAC Valve Sense Circuit High
- P0513-Invalid Skim Key
- P0516-Battery Temperature Sensor Low
- P0517-Battery Temperature Sensor High
- P0522-Oil Pressure Sensor Low
- P0551-Power Steering Switch Performance
- P0562-Battery Voltage Low
- P0563-Battery Voltage High
- P0572-Brake Switch #1 Circuit Low
- P0573-Brake Switch #1 Circuit High
- P0580-Speed Control Switch #1 Low
- P0581-Speed Control Switch #1 High
- P0582-Speed Control Vacuum Solenoid Circuit
- P0586-Speed Control Vent Solenoid Circuit
- P0594-Speed Control Servo Power Circuit
- P0600-Serial Communication Link; P0601-Internal Memory Checksum Invalid
- P0622-Generator Field Control Circuit
- P0627-Fuel Pump Relay Circuit
- P0630-VIN Not Programmed In Pcm
- P0632-Odometer Not Programmed In Pcm
- P0633-Skim Key Not Programmed In Pcm
- P0645-A/C Clutch Relay Circuit
- P0685-ASD Relay Control Circuit
- P0688-ASD Relay Sense Circuit Low
- P0700-Transmission Control System/Read Transmission DTCS On The DRBIII®
- P0850-Park/Neutral Switch Performance
- P1105-Tip Sensor Solenoid Circuit
- P1115-General Temp Sensor Performance
- P1187-THOTTLE Inlet Pressure/Map Correlation
- P1189-Tip Sensor Circuit Low
- P1190-Tip Sensor Circuit High
- P1593-Speed Control Switch Stuck
- P1603-Pcm Internal Dual-Port Ram Communication; P1604-Pcm Internal Dual-Port Ram Read/Write Integrity Failure; P1607-Pcm Internal Shutdown Timer Rationality
- P1696-EEPROM Memory Write Denied/Invalid; P1697-EMR (Sri) Mileage Not Stored
- P1854-Tip BARO Out Of Range
- P2074-Manifold Pressure/Throttle Position Correlation - High Flow/Vacuum Leak
- P2096-Down Stream Fuel System 1/2 Lean; P2097-Down Stream Fuel System 1/2 Rich
- P2302-Ignition Coil #1 Secondary Circuit-Insufficient Ionization; P2305-Ignition Coil #2 Secondary Circuit-Insufficient Ionization
- P2503-Charging System Voltage Low
- U0101-No Transmission Bus Message
- U0155-No Cluster Bus Message
- U0168-No Skim Bus Messages
- U110C-No Fuel Level Bus Message
- Powertrain Diagnostic Procedures - Introduction
- DTC Index
- Introduction
- Identification Of System
- System Description And Functional Operation
- General Description
- Functional Operation
- Fuel Control
- On-Board Diagnostics
- Other Controls
- Pcm Operating Modes
- Non-Monitored Circuits
- Skis Overview
- Skim On-Board Diagnostics
- Skis Operation
- Programming The Powertrain Control Module
- Programming The Sentry Key Immobilizer Module
- Programming The Ignition Keys To The Sentry Key Immobilizer Module
- Diagnostic Trouble Codes
- Using The DRBIII®
- DRBIII® Error Messages And Blank Screen
- Disclaimers, Safety, Warnings
- Required Tools And Equipment
- Glossary Of Terms
- Diagnostic Information And Procedures
- Communication - Symptoms
- Symptom: *NO RESPONSE FROM PCM (PCI BUS) - 1.6L
- Symptom: *NO RESPONSE FROM PCM (PCI BUS) - NGC
- Symptom: *NO RESPONSE FROM PCM (PCM SCI ONLY) - NGC
- Symptom: *NO RESPONSE FROM PCM (SCI ONLY) - 1.6L
- Symptom: *NO RESPONSE FROM SENTRY KEY IMMOBILIZER MODULE
- Symptom: *NO RESPONSE FROM TRANSMISSION CONTROL MODULE - NGC
- Symptom: *PCI BUS COMMUNICATION FAILURE
- Communication - Symptoms
- Vehicle Theft Security System
- Body Diagnostic Procedures
- Exterior Body Panels
- Frames & Bumpers
- Interior & Exterior
- Body
- Description
- Warning
- Diagnosis And Testing
- Standard Procedure
- Standard Procedure - Plastic Body Panel Repair
- Notes
- Rigid Plastics:
- Semi-Rigid Plastics:
- Flexible Plastics:
- Repair Procedure:
- Adhesion Promoter/Surface Modifier:
- Safety Precaution And Warnings
- Rigid, Semi-Rigid, And Flexible Plastic Parts Types
- Panel Sectioning
- Panel Reinforcement
- Visual Inspection
- Panel Surface Preparation
- Patching Panels
- Panel Patch Fabrications
- Panel Patch Installation
- Patched Panel Surfacing
- Standard Procedure - Heat Staking
- Standard Procedure - Plastic Body Panel Repair
- Specifications
- Special Tools
- Convertible Top
- DECKLID - Pt-27
- Door - Front
- Front Door Applique
- Front Door Check Strap
- Front Door
- Front Door Glass
- Removal
- Installation
- Adjustment - Pt-27 Only
- Front Door Adjustment
- Quarter Glass Adjustment
- Notes
- Up-Stop Adjustments
- Bottom Of Glass - Inboard/Outboard Adjustments
- Top Of Glass - Inboard/Outboard Adjustments
- Glass - Front/Rear Adjustment
- Quarter Glass Alignment Verification
- Condition - Height Mismatch Between Door Glass And Quarter Glass With Top Down
- Condition - Door Glass Noise Along A-Pillar When Closing Door And/Or Door Glass Touching Quarter Glass Metal Seal Retainer And/Or Wind Noise/Water Leak Along Quarter Glass Seal.
- Condition - Door Glass Not Driving Into The Top In Full Up Position
- Condition - Quarter Glass Not Driving Into The Top In Full Up Position
- Condition - Slapping Noise Between The Door And Quarter Glass With The Top Down During Driving Of The Vehicle
- Condition - Non-Parallel Gap Between Door And Quarter Glasses
- Condition - Quarter Glass Seal Fold Over During Travel With Door Glass Full Up And Top Up Or Down
- Condition - Intermediate Rear Of Door Glass Not Driving Into The Top Seal And/Or Noise At Rear Bottom Of The Door
- Front Door Outside Handle
- Front Door Hinge
- Front Door Inside Handle Actuator
- Front Door Latch
- Front Door Latch Striker
- Front Door Lock Cylinder
- Front Door Vertical Guide Bar
- Front Door Side View Mirror Flag - Pt-27
- Front Door Trim Panel
- Front Door Water Dam
- Front Door Window Regulator
- Door Glass Inner Belt Stabilizer - Pt-27
- Rear Rail Assembly - Pt-27
- Door - Rear
- Exterior
- Body Side Moldings
- Cowl Grille Screen
- Deck Upper Belt Molding - Pt-27
- Engine Compartment Lower Silencer
- Exterior Name Plates
- Front Fender
- Front Side Rail Access Pulley Splash Shield
- Front Wheelhouse Splash Shields
- Fuel Fill Door
- Grille
- Header Molding - Pt-27
- Luggage Rack Crossbar
- Luggage Rack Side Rail
- Radiator Closure Panel
- Side View Mirror
- Side View Mirror Glass
- Windshield A-Pillar Trim Molding - Pt-27
- Wood Grain/Flame Decals
- Grille - Lower Radiator
- Hood
- Instrument Panel
- Interior
- A-Pillar Trim
- B-Pillar Trim
- Body Vent
- DECKLID Sill Scuff Plate
- Door Sill Trim
- Floor Carpet
- Cargo Area Floor Carpet - Pt-27
- Front Floor Carpet Right/Left Side -Pt-27
- Rear Carpet - Pt-27
- Upper D-Pillar Trim
- Header Latch Retainer - Pt-27
- Headliner
- Inside Rear View Mirror
- Lower Quarter Trim Panel
- Rear Quarter Panel Trim - Pt-27
- Seat Back Support Bracket - Pt-27
- Side Cowl Trim Panel
- Sport Bar - Pt-27
- Sport Bar Inner Covers - Pt-27
- Sport Bar Outer Cover - Pt-27
- Sun Visor
- Trunk Trim Panel - Pt-27
- Trunk Welt - Pt-27
- Upper C-Pillar Trim
- Windshield Header Molding -Pt-27
- Liftgate
- Paint
- Quarter Glass - Pt-27
- Seats
- Child Seat Tether Anchor Bezel
- Front Seat
- Front Seat Back - With Front Seat Back Panel
- Front Seat Back
- Front Seat Back Cover/Foam
- Front Seat Back Cover - Without Front Seat Back Panel
- Front Seat Cushion
- Front Seat Cushion Cover
- Headrest - Front/Rear
- Rear Seat
- Rear Seat Back
- Rear Seat Back Cover/Foam
- Rear Seat Back Cushion Cover/Foam - Pt-27
- Rear Seat Bolster - Pt-27
- Rear Seat Bolster Cover - Pt-27
- Rear Seat Cushion
- Rear Seat Back Cushion / Cover
- Rear Seat Latch Cover
- Under Seat Storage Bin
- Stationary Glass
- Sunroof
- Weatherstrip/Seals
- A-Pillar Weatherstrip Retainer - Pt-27
- Deck Lid Opening Weatherstrip - Pt-27
- Front And Rear Door Opening Weatherstrip
- Front And Rear Door Upper Secondary Weatherstrip
- Front Door Glass Run Weatherstrip
- Front Door Inner Belt Weatherstrip
- Front Door Outer Belt Weatherstrip
- Header Weatherstrip Seal Retainer - Pt-27
- Liftgate Weatherstrip
- Quarter Panel Outer Belt Weatherstrip - Pt-27
- Rear Door Glass Run Weatherstrip
- Rear Door Inner Belt Weatherstrip
- Sill Secondary Weatherstrip
- Header / A-Pillar Weatherstrip -Pt-27
- Front Door Sill Weatherstrip - Pt-27
- Body Structure
- Body
- Exterior/Interior Trim
- Interior & Exterior
- Body
- Description
- Warning
- Diagnosis And Testing
- Standard Procedure
- Standard Procedure - Plastic Body Panel Repair
- Notes
- Rigid Plastics:
- Semi-Rigid Plastics:
- Flexible Plastics:
- Repair Procedure:
- Adhesion Promoter/Surface Modifier:
- Safety Precaution And Warnings
- Rigid, Semi-Rigid, And Flexible Plastic Parts Types
- Panel Sectioning
- Panel Reinforcement
- Visual Inspection
- Panel Surface Preparation
- Patching Panels
- Panel Patch Fabrications
- Panel Patch Installation
- Patched Panel Surfacing
- Standard Procedure - Heat Staking
- Standard Procedure - Plastic Body Panel Repair
- Specifications
- Special Tools
- Convertible Top
- DECKLID - Pt-27
- Door - Front
- Front Door Applique
- Front Door Check Strap
- Front Door
- Front Door Glass
- Removal
- Installation
- Adjustment - Pt-27 Only
- Front Door Adjustment
- Quarter Glass Adjustment
- Notes
- Up-Stop Adjustments
- Bottom Of Glass - Inboard/Outboard Adjustments
- Top Of Glass - Inboard/Outboard Adjustments
- Glass - Front/Rear Adjustment
- Quarter Glass Alignment Verification
- Condition - Height Mismatch Between Door Glass And Quarter Glass With Top Down
- Condition - Door Glass Noise Along A-Pillar When Closing Door And/Or Door Glass Touching Quarter Glass Metal Seal Retainer And/Or Wind Noise/Water Leak Along Quarter Glass Seal.
- Condition - Door Glass Not Driving Into The Top In Full Up Position
- Condition - Quarter Glass Not Driving Into The Top In Full Up Position
- Condition - Slapping Noise Between The Door And Quarter Glass With The Top Down During Driving Of The Vehicle
- Condition - Non-Parallel Gap Between Door And Quarter Glasses
- Condition - Quarter Glass Seal Fold Over During Travel With Door Glass Full Up And Top Up Or Down
- Condition - Intermediate Rear Of Door Glass Not Driving Into The Top Seal And/Or Noise At Rear Bottom Of The Door
- Front Door Outside Handle
- Front Door Hinge
- Front Door Inside Handle Actuator
- Front Door Latch
- Front Door Latch Striker
- Front Door Lock Cylinder
- Front Door Vertical Guide Bar
- Front Door Side View Mirror Flag - Pt-27
- Front Door Trim Panel
- Front Door Water Dam
- Front Door Window Regulator
- Door Glass Inner Belt Stabilizer - Pt-27
- Rear Rail Assembly - Pt-27
- Door - Rear
- Exterior
- Body Side Moldings
- Cowl Grille Screen
- Deck Upper Belt Molding - Pt-27
- Engine Compartment Lower Silencer
- Exterior Name Plates
- Front Fender
- Front Side Rail Access Pulley Splash Shield
- Front Wheelhouse Splash Shields
- Fuel Fill Door
- Grille
- Header Molding - Pt-27
- Luggage Rack Crossbar
- Luggage Rack Side Rail
- Radiator Closure Panel
- Side View Mirror
- Side View Mirror Glass
- Windshield A-Pillar Trim Molding - Pt-27
- Wood Grain/Flame Decals
- Grille - Lower Radiator
- Hood
- Instrument Panel
- Interior
- A-Pillar Trim
- B-Pillar Trim
- Body Vent
- DECKLID Sill Scuff Plate
- Door Sill Trim
- Floor Carpet
- Cargo Area Floor Carpet - Pt-27
- Front Floor Carpet Right/Left Side -Pt-27
- Rear Carpet - Pt-27
- Upper D-Pillar Trim
- Header Latch Retainer - Pt-27
- Headliner
- Inside Rear View Mirror
- Lower Quarter Trim Panel
- Rear Quarter Panel Trim - Pt-27
- Seat Back Support Bracket - Pt-27
- Side Cowl Trim Panel
- Sport Bar - Pt-27
- Sport Bar Inner Covers - Pt-27
- Sport Bar Outer Cover - Pt-27
- Sun Visor
- Trunk Trim Panel - Pt-27
- Trunk Welt - Pt-27
- Upper C-Pillar Trim
- Windshield Header Molding -Pt-27
- Liftgate
- Paint
- Quarter Glass - Pt-27
- Seats
- Child Seat Tether Anchor Bezel
- Front Seat
- Front Seat Back - With Front Seat Back Panel
- Front Seat Back
- Front Seat Back Cover/Foam
- Front Seat Back Cover - Without Front Seat Back Panel
- Front Seat Cushion
- Front Seat Cushion Cover
- Headrest - Front/Rear
- Rear Seat
- Rear Seat Back
- Rear Seat Back Cover/Foam
- Rear Seat Back Cushion Cover/Foam - Pt-27
- Rear Seat Bolster - Pt-27
- Rear Seat Bolster Cover - Pt-27
- Rear Seat Cushion
- Rear Seat Back Cushion / Cover
- Rear Seat Latch Cover
- Under Seat Storage Bin
- Stationary Glass
- Sunroof
- Weatherstrip/Seals
- A-Pillar Weatherstrip Retainer - Pt-27
- Deck Lid Opening Weatherstrip - Pt-27
- Front And Rear Door Opening Weatherstrip
- Front And Rear Door Upper Secondary Weatherstrip
- Front Door Glass Run Weatherstrip
- Front Door Inner Belt Weatherstrip
- Front Door Outer Belt Weatherstrip
- Header Weatherstrip Seal Retainer - Pt-27
- Liftgate Weatherstrip
- Quarter Panel Outer Belt Weatherstrip - Pt-27
- Rear Door Glass Run Weatherstrip
- Rear Door Inner Belt Weatherstrip
- Sill Secondary Weatherstrip
- Header / A-Pillar Weatherstrip -Pt-27
- Front Door Sill Weatherstrip - Pt-27
- Body Structure
- Body
- Interior & Exterior
- Frames, Subframes & Crossmembers
- Mirrors
- Seats
- Body Diagnostic Procedures
- Introduction
- Identification Of System
- System Description And Functional Operation
- Notes
- Airbag System
- Audio System
- Compass/Temperature Module (CTM)
- Compass/Temperature Mirror
- Description
- Operation
- English / Metric / Off Mode
- Calibration / Zone Mode
- Setting Compass Zone
- First Time Calibration
- Manual Calibration
- Continuous Calibration
- Self-Check Diagnostic
- Outside Temperature
- Temperature Update - Warm
- Temperature Update - Cold
- Extreme Temperature / Open Or Short Condition
- Ambient Temperature Sensor
- Ambient Temperature Sensor Diagnostics
- Instrument Cluster
- Remote Keyless Entry Module
- Sentry Key Immobilizer System (Skis)
- Communication
- Telecommunications
- Window Regulator Modules (Pt27 Only)
- Using The DRBIII®
- Disclaimers, Safety, Warnings
- Required Tools And Equipment
- Glossary Of Terms
- Diagnostic Information And Procedures
- Airbag
- Symptom List: ACCELEROMETER 1; INTERNAL 1; INTERNAL 2; INTERNAL 3; INTERNAL 4' OUTPUT DRIVER 1; OUTPUT DRIVER 2; STORED ENERGY FIRING 1
- Symptom List: AIRBAG WARNING INDICATOR DRIVER; AIRBAG WARNING INDICATOR OPEN; AIRBAG WARNING INDICATOR SHORT
- Symptom: CALIBRATION MISMATCH
- Symptom: CLUSTER MESSAGE MISMATCH
- Symptom: DRIVER SEAT BELT TENSIONER CIRCUIT OPEN
- Symptom: DRIVER SEAT BELT TENSIONER CIRCUIT SHORT
- Symptom: DRIVER SEAT BELT TENSIONER SHORT TO BATTERY
- Symptom: DRIVER SEAT BELT TENSIONER SHORT TO GROUND
- Symptom: DRIVER SQUIB 1 CIRCUIT OPEN
- Symptom: DRIVER SQUIB 1 CIRCUIT SHORT
- Symptom: DRIVER SQUIB 1 SHORT TO BATTERY
- Symptom: DRIVER SQUIB 1 SHORT TO GROUND
- Symptom: LEFT CURTAIN OR SEAT SQUIB CIRCUIT OPEN
- Symptom: LEFT CURTAIN OR SEAT SQUIB CIRCUIT SHORT
- Symptom: LEFT CURTAIN OR SEAT SQUIB SHORT TO BATTERY
- Symptom: LEFT CURTAIN OR SEAT SQUIB SHORT TO GROUND
- Symptom: LEFT SIDE IMPACT SENSOR 1 INTERNAL 1
- Symptom: LOSS OF IGNITION RUN - START
- Symptom: LOSS OF IGNITION RUN ONLY
- Symptom: NO CLUSTER MESSAGE
- Symptom: NO LEFT SIDE IMPACT SENSOR 1 COMMUNICATION
- Symptom: NO ODOMETER MESSAGE
- Symptom: NO PCI TRANSMISSION
- Symptom: NO RIGHT SIDE IMPACT SENSOR 1 COMMUNICATION
- Symptom: PASSENGER SEAT BELT TENSIONER CIRCUIT OPEN
- Symptom: PASSENGER SEAT BELT TENSIONER CIRCUIT SHORT
- Symptom: PASSENGER SEAT BELT TENSIONER SHORT TO BATTERY
- Symptom: PASSENGER SEAT BELT TENSIONER SHORT TO GROUND
- Symptom: PASSENGER SQUIB 1 CIRCUIT OPEN
- Symptom: PASSENGER SQUIB 1 CIRCUIT SHORT
- Symptom: PASSENGER SQUIB 1 SHORT TO BATTERY
- Symptom: PASSENGER SQUIB 1 SHORT TO GROUND
- Symptom: POWER SUPPLY VOLTAGE LOW
- Symptom: RIGHT CURTAIN OR SEAT SQUIB CIRCUIT OPEN
- Symptom: RIGHT CURTAIN OR SEAT SQUIB CIRCUIT SHORT
- Symptom: RIGHT CURTAIN OR SEAT SQUIB SHORT TO BATTERY
- Symptom: RIGHT CURTAIN OR SEAT SQUIB SHORT TO GROUND
- Symptom: RIGHT SIDE IMPACT SENSOR INTERNAL 1
- Symptom: VEHICLE BODY STYLE MISMATCH
- Symptom: *AIRBAG INDICATOR ON WITHOUT ACTIVE TROUBLE CODES
- Audio
- Symptom: ALL OUTPUTS SHORT
- Symptom: ANTENNA HARDWARE FAILURE - SDARS
- Symptom: ANTENNA NOT CONNECTED - SDARS
- Symptom: BUS BUSY - SDARS
- Symptom: BUS LOW - SDARS
- Symptom List: CASSETTE PLAYER INOP; CD MECHANICAL FAILURE; NO PCI TRANSMISSION; *AM/FM SWITCH INOPERATIVE; *ANY STATION PRESET SWITCH INOPERATIVE; *BALANCE INOPERATIVE; *CD EJECT SWITCH INOPERATIVE; *EQUALIZER INOPERATIVE; *FADER INOPERATIVE; *FF/RW SWITCH INOPERATIVE; *HOUR/MINUTE SWITCHES INOPERATIVE; *PAUSE/PLAY SWITCH INOPERATIVE; *PWR SWITCH INOPERATIVE; *SCAN SWITCH INOPERATIVE; *SEEK SWITCH INOPERATIVE; *SET SWITCH INOPERATIVE; *TAPE EJECT SWITCH INOPERATIVE; *TIME SWITCH INOPERATIVE; *TUNE SWITCH INOPERATIVE
- Symptom: CD PLAY FAILURE
- Symptom: CD READ FAILURE
- Symptom: CD TEMPERATURE HIGH
- Symptom: GPS ANTENNA NOT CONNECTED
- Symptom: INTERNAL FAILURE - SDARS
- Symptom: INTERNAL RECEIVER FAILURE - SDARS
- Symptom: LOW VOLTAGE LEVEL
- Symptom: NO ANTENNA CONNECTION
- Symptom: NO COMMUNICATION WITH SDARS
- Symptom: NO J1850 COMMUNICATION - SDARS
- Symptom: POWER AMP SHUTDOWN
- Symptom: RADIO AND NAV GPS ANTENNA NOT CONNECTED
- Symptom: *INOP NO FAULT CODES - SDARS
- Symptom: *POOR RECEPTION - SDARS
- Communication
- Symptom: *NO RESPONSE FROM AIRBAG CONTROL MODULE
- Symptom: *NO RESPONSE FROM AMPLIFIER
- Symptom: *NO RESPONSE FROM ANTILOCK BRAKE MODULE
- Symptom: *NO RESPONSE FROM ECM (PCI BUS) - DIESEL ONLY
- Symptom: *NO RESPONSE FROM ECM (SCI ONLY) - DIESEL ONLY
- Symptom: *NO RESPONSE FROM HANDS FREE MODULE
- Symptom: *NO RESPONSE FROM INSTRUMENT CLUSTER
- Symptom: *NO RESPONSE FROM OVERHEAD CONSOLE (COMPASS/TEMPERATURE MIRROR MODULE)
- Symptom: *NO RESPONSE FROM PCM (PCI BUS) - 1.6L
- Symptom: *NO RESPONSE FROM PCM (PCI BUS) - NGC
- Symptom: *NO RESPONSE FROM PCM (PCM SCI ONLY) - NGC
- Symptom: *NO RESPONSE FROM PCM (SCI ONLY) - 1.6L
- Symptom: *NO RESPONSE FROM RADIO
- Symptom: *NO RESPONSE FROM RKE
- Symptom: *NO RESPONSE FROM SATELLITE RADIO RECEIVER
- Symptom: *NO RESPONSE FROM SENTRY KEY IMMOBILIZER MODULE
- Symptom: *NO RESPONSE FROM TRANSMISSION CONTROL MODULE - NGC
- Symptom: *NO RESPONSE FROM WINDOW REGULATOR MODULE - PT27
- Symptom: *PCI BUS COMMUNICATION FAILURE
- Instrument Cluster
- Symptom List: ABS INDICATOR CIRCUIT OPEN; AIRBAG INDICATOR CIRCUIT OPEN
- Symptom List: ABS MESSAGE NOT RECEIVED; ACM MESSAGE NOT RECEIVED; EATX MESSAGE NOT RECEIVED; NO PCI TRANSMISSION; SBEC MESSAGE NOT RECEIVED; SKIM MESSAGE NOT RECEIVED
- Symptom: EATX MESSAGE MISMATCH
- Symptom: EEPROM CHECKSUM FAILURE
- Symptom: FUEL LEVEL SENSOR OPEN
- Symptom: FUEL LEVEL SENSOR SHORT
- Symptom: FUEL LEVEL SENSOR STUCK
- Symptom: PANEL DIMMER OPEN
- Symptom: PANEL DIMMER SHORTED
- Symptom: *ALL GAUGES INOPERATIVE
- Symptom: *ANY PCI BUS INDICATOR INOPERATIVE
- Symptom: *BRAKE WARNING INDICATOR ALWAYS ON
- Symptom: *BRAKE WARNING INDICATOR INOPERATIVE
- Symptom: *FRONT FOG LAMP INDICATOR INOPERATIVE
- Symptom: *FUEL GAUGE INACCURATE
- Symptom: *HIGH BEAM INDICATOR INOPERATIVE
- Symptom: *INSTRUMENT CLUSTER DIMMING INOPERATIVE
- Symptom: *LOW OIL PRESSURE INDICATOR ALWAYS ON
- Symptom: *LOW OIL PRESSURE INDICATOR INOPERATIVE
- Symptom: *ONE GAUGE INOPERATIVE
- Symptom: *PRND OR AUTOSTICK DISPLAY INOPERATIVE OR INACCURATE
- Symptom: *REAR FOG LAMP INDICATOR INOPERATIVE - BUX ONLY
- Symptom: *SEAT BELT INDICATOR NOT OPERATING PROPERLY
- Symptom: *VF DISPLAY INOPERATIVE
- Interior Lighting
- Overhead Console
- Power Door Locks/RKE
- Symptom: BODY STYLE MISMATCH
- Symptom: DRIVER DOOR SWITCH FAILURE
- Symptom: INCORRECT MODULE TYPE CONFIGURATION FOR PART NUMBER
- Symptom: MODULE NOT CONFIGURED FOR RKE
- Symptom: NO AIRBAG MESSAGES RECEIVED
- Symptom: NO PCM MESSAGES RECEIVED
- Symptom: NO SKIM MESSAGES RECEIVED
- Symptom: PASSENGER DOOR OR LIFTGATE SWITCH FAILURE - PT44
- Symptom:* ALL DOORS (EXCEPT DRIVER)FAIL TO LOCK
- Symptom: * ALL DOORS (EXCEPT DRIVER)FAIL TO LOCK AND UNLOCK
- Symptom:* ALL DOORS (EXCEPT DRIVER)FAIL TO UNLOCK
- Symptom: *ALL DOOR LOCKS INOPERATIVE
- Symptom: *ALL DOORS FAIL TO LOCK
- Symptom: *ALL DOORS FAIL TO UNLOCK
- Symptom: *ALL LOCKS INOPERATIVE FROM ONE LOCK SWITCH
- Symptom: *DECKLID RELEASE SWITCH INOPERATIVE - PT27
- Symptom: *DECKLID SOLENOID INOPERATIVE - PT27
- Symptom: *DOORS LOCKABLE WITH KEY IN IGNITION AND DRIVER DOOR OPEN
- Symptom: *DRIVER DOOR FAILS TO LOCK
- Symptom: *DRIVER DOOR FAILS TO LOCK AND UNLOCK
- Symptom: *DRIVER DOOR FAILS TO UNLOCK
- Symptom: *DRIVER DOOR FAILS UNLOCK - PT27
- Symptom: *LIFTGATE LOCK MOTOR FAILS TO LOCK OR UNLOCK
- Symptom: *ONE DOOR FAILS TO LOCK AND UNLOCK - PT27
- Symptom: *ONE PASSENGER DOOR FAILS TO LOCK AND UNLOCK
- Symptom: *PASSENGER DOOR FAILS TO UNLOCK - PT27
- Symptom: *RKE INOPERATIVE
- Power Top
- Symptom: AMBIENT TEMP MESSAGE NOT RECEIVED
- Symptom: POWER TOP RELAY CONTROL CIRCUIT OPEN
- Symptom: POWER TOP RELAY INOPERATIVE
- Symptom: POWER TOP SWITCH MUX CIRCUIT OPEN
- Symptom: POWER TOP SWITCH MUX CIRCUIT SHORT TO GROUND
- Symptom: POWER TOP SWITCH MUX CIRCUIT VALUE OUT OF RANGE
- Symptom: SPEED MESSAGE NOT RECEIVED
- Power Windows
- Symptom: BATTERY VOLTAGE TOO HIGH
- Symptom: BATTERY VOLTAGE TOO LOW
- Symptom: FRONT WINDOW MOTOR MALFUNCTION
- Symptom: FRONT WINDOW SWITCH MUX CIRCUIT OPEN
- Symptom: FRONT WINDOW SWITCH MUX CIRCUIT SHORT TO GROUND
- Symptom: FRONT WINDOW SWITCH MUX CIRCUIT VALUE OUT OF RANGE
- Symptom: IGNITION SWITCH OUTPUT OPEN
- Symptom: REAR WINDOW MOTOR CIRCUIT OPEN OR SHORTED
- Symptom: REAR WINDOW SWITCH MUX CIRCUIT OPEN
- Symptom: REAR WINDOW SWITCH MUX CIRCUIT SHORT TO GROUND
- Symptom: REAR WINDOW SWITCH MUX CIRCUIT VALUE OUT OF RANGE
- Symptom: WINDOW DROP SWITCH SENSE CIRCUIT OPEN
- Symptom: *DOOR AJAR CIRCUIT OPEN
- Symptom: *DOOR WINDOWS STAY IN DROP DOWN POSITION
- Symptom: *WINDOW DROPS OR JERKS DURING OPENING
- Telecommunication
- Symptom: AUDIO HARDWARE MESSAGE NOT RECEIVED
- Symptom List: BLUETOOTH ERROR; FLASH CHECKSUM ERROR; FLASH WRITE ERROR; PCI BUS INTERNAL ERROR; RAM WRITE ERROR; ROM CHECKSUM ERROR
- Symptom List: BODY STYLE MESSAGE NOT RECEIVED; INVALID BODY STYLE
- Symptom: GENERAL MICROPHONE FAULT
- Symptom: IGNITION POWER MESSAGE NOT RECEIVED
- Symptom List: LEFT AUDIO INPUT SHORT TO GROUND; LEFT AUDIO INPUT SHORT TO VOLTAGE; LEFT AUDIO OUTPUT 1 SHORT TO GROUND; LEFT AUDIO OUTPUT 1 SHORT TO VOLTAGE
- Symptom List: MIRROR POWER CIRCUIT SHORT TO GROUND; MIRROR POWER CIRCUIT SHORT TO VOLTAGE
- Symptom List: PCI BUS BUSY; PCI BUS CIRCUIT OPEN; PCI BUS CIRCUIT SHORT TO GROUND; PCI BUS CIRCUIT SHORT TO VOLTAGE
- Symptom List: PHONE SWITCH STUCK; VOICE RECOGNITION SWITCH STUCK' VOICE RECOGNITION/PHONE SWITCH CIRCUIT RATIONALITY; VOICE RECOGNITION/PHONE SWITCH CIRCUIT SHORT TO GROUND; VOICE RECOGNITION/PHONE SWITCH CIRCUIT SHORT TO VOLTAGE
- Symptom: PRNDL MESSAGE NOT RECEIVED
- Symptom: RADIO MESSAGE NOT RECEIVED
- Symptom List: RIGHT AUDIO INPUT SHORT TO GROUND; RIGHT AUDIO INPUT SHORT TO VOLTAGE; RIGHT AUDIO OUTPUT 1 SHORT TO GROUND; RIGHT AUDIO OUTPUT 1 SHORT TO VOLTAGE
- Symptom: RPM MESSAGE NOT RECEIVED
- Symptom: VIN MESSAGE NOT RECEIVED
- Symptom: VIN MISMATCH
- Vehicle Theft/Security
- Symptom: HOOD AJAR SWITCH MISSING (EXPORT ONLY)
- Symptom: MODULE PREVIOUSLY CONFIGURED FOR VTSS
- Symptom: *ALARM TRIPS ON ITS OWN
- Symptom: *HEADLAMPS FAIL TO FLASH DURING ALARM
- Symptom: *HORN FAILS TO SOUND DURING ALARM
- Symptom: *INTRUSION SENSOR CANNOT BE DISABLED (EXPORT ONLY)
- Symptom: *INTRUSION SENSOR FAILS TO TRIP VTSS (EXPORT ONLY)
- Symptom: *INTRUSION SENSOR REPEATEDLY TRIGGERS VTSS (EXPORT ONLY)
- Symptom: *OPEN DRIVER DOOR FAILS TO TRIP ALARM
- Symptom: *OPEN LIFTGATE FAILS TO TRIP ALARM
- Symptom: *OPEN PASSENGER DOOR FAILS TO TRIP ALARM
- Symptom: *PARK LAMPS FAIL TO FLASH DURING ALARM
- Symptom List: *VTSS FAILS TO ARM FROM LEFT DOOR CYLINDER LOCK SWITCH (EXPORT ONLY); *VTSS FAILS TO ARM/DISARM FROM LEFT DOOR CYLINDER LOCK SWITCH
- Symptom List: *VTSS FAILS TO ARM FROM LIFTGATE CYLINDER LOCK SWITCH (EXPORT ONLY); *VTSS FAILS TO ARM/DISARM FROM LIFTGATE CYLINDER LOCK SWITCH
- Symptom List: *VTSS FAILS TO ARM FROM RIGHT DOOR CYLINDER LOCK SWITCH (EXPORT ONLY); *VTSS FAILS TO ARM/DISARM FROM RIGHT DOOR CYLINDER LOCK SWITCH
- Symptom: *VTSS INDICATOR FAILS TO FLASH
- Symptom: *VTSS INDICATOR STAYS ON STEADY DURING ARMING
- Symptom: *VTSS SIREN INOPERATIVE (EXPORT ONLY)
- Verifications Tests
- Airbag
- Component Locations
- Connector PINOUTS
- Airbag Control Module (Orc) (Base) - Yellow 23 Way
- Airbag Control Module C1 (Orc) (Premium) - Yellow 32 Way
- Airbag Control Module C2 (Orc) (Premium) - Yellow 32 Way
- Ambient Temperature Sensor (Except 2.4L Base) - Black 2 Way
- Amplifier Audio C1 - 20 Way
- Anti-Lock Brake Module - Black 47 Way
- C203 (Pt27) - LT. Gray (Body Side)
- C203 (Pt27) - LT. Gray (Instrument Panel Side)
- C204 (Pt27) - (Instrument Panel Side)
- C204 (Pt27) - (Left Front Door Side)
- C204 (Pt44 LHP) - Natural (Instrument Panel Side)
- C204 (Pt44 LHP) - Natural (Left Front Door Side)
- C205 (Pt27) - (Instrument Panel Side)
- C205 (Pt27) - (Right Front Door Side)
- C305 - Yellow (Airbag Side)
- C305 - Yellow (UNIBODY Side)
- C306 - Yellow (Airbag Side)
- C306 - Yellow (UNIBODY Side)
- C343 (Pt27) - LT. Gray (DECKLID Jumper Side)
- C343 (Pt27) - LT. Gray (DECKLID Side)
- C349 (Pt27) - Blue (Body Side
- C349 (Pt27) - Blue (DECKLID Jumper Side)
- C362 (Pt27) - LT. Gray (Body Side)
- C362 (Pt27) - LT. Gray (Power Top Side)
- CLOCKSPRING - DK. Green 7 Way
- Compass/Temperature Mirror Module (Pt27) - Black 10 Way
- Data Link Connector - Black 16 Way
- DECKLID Cylinder Unlock Switch (Pt27) - LT. Gray 2 Way
- DECKLID Handle Switch (Pt27) - White 2 Way
- DECKLID Release Motor (Pt27) - Black 3 Way
- DECKLID Release Switch (Pt27) - Black 2 Way
- Dome Lamp - Black 3 Way
- Dome Lamp/Intrusion Sensor (Export) - White 4 Way
- Driver Airbag Squib 1 - Yellow 2 Way
- Driver Door Ajar Switch - Black 2 Way
- Driver Door Handle Switch (Pt27) - 2 Way
- Driver Door Power Lock Motor/Ajar Switch - Black 4 Way
- Driver Rear Window Motor (Pt27) - Black 2 Way
- Driver Seat Belt TENSIONER - Yellow 2 Way
- Driver Window Regulator Module (Pt27) - Black 20 Way
- Engine Control Module C1 (Diesel) - Black 81 Way
- Front Power Window Switch - Black 14 Way
- Fuel Pump Module - LT. Gray 4 Way
- Fuses (FB)
- Hands Free Module C1 - DK. Gray 22 Way
- Hands Free Module C2 (Satellite Radio) - DK. Gray 10 Way
- Hands Free Module C3 - Black 10 Way
- High Note Horn (Export) - Black 2 Way
- Hood Ajar Switch (Export) - Black 2 Way
- Ignition Switch C1 - 10 Way
- Instrument Cluster C1 - Black 26 Way
- Instrument Cluster C2 - Black 10 Way
- Left Cylinder Lock Switch - Black 2 Way
- Left Door Lock Switch - Black 3 Way
- Left Front Power Window Motor (Pt44) - Black 2 Way
- Left Instrument Panel Speaker - Black 2 Way
- Left Rear Speaker (Pt44) - Black 2 Way
- Left Seat Airbag Squib (LHP) - Yellow 2 Way
- Left Seat Airbag Squib (RHD) - Yellow 2 Way
- Left Side Impact Sensor 1 - Gray 2 Way
- Liftgate Ajar Switch - White 2 Way
- Liftgate Cylinder Lock Switch - LT. Gray 2 Way
- Liftgate Handle Switch (Pt44) - Natural 2 Way
- Liftgate Power Lock Motor - Black 4 Way
- Liftgate Release Motor (Pt44) - Black 3 Way
- Low Note Horn - Black 2 Way
- Multi-Function Switch - Gray 20 Way
- Overhead Console Module - Black 12 Way
- Passenger Airbag Squib 1 - Yellow 2 Way
- Passenger Door Ajar Switch - Black 2 Way
- Passenger Door Handle Switch (Pt27) - 2 Way
- Passenger Door Power Lock Motor/Ajar Switch - Black 4 Way
- Passenger Rear Window Motor (Pt27) - Black 2 Way
- Passenger Seat Belt TENSIONER - Yellow 2 Way
- Passenger Window Regulator Module (Pt27) - Black 20 Way
- Fuses (PDC)
- Power Top Motor (Pt27) - 2 Way
- Power Top Relay (Pt27) - Black 6 Way
- Power Top Switch (Pt27) - 3 Way
- Powertrain Control Module (1.6L) - Black 90 Way
- Powertrain Control Module C1 (NGC) - Black/Black 38 Way
- Radio C1 - White 22 Way
- Radio C2 (Hands Free) - DK. Gray 10 Way
- Rear View Mirror C1 - Black 12 Way
- Remote Keyless Entry Module - Black 26 Way
- Right Cylinder Lock Switch (Export) - Black 2 Way
- Right Door Lock Switch - Black 3 Way
- Right Front Door Speaker - 3 Way
- Right Front Power Window Motor (Pt44) - Black 2 Way
- Right Rear Power Window Motor (Pt44) - Black 2 Way
- Right Seat Airbag Squib (LHP) - Yellow 2 Way
- Right Seat Airbag Squib (RHP) - Yellow 2 Way
- Right Side Impact Sensor 1 - Gray 2 Way
- Sentry Key Immobilizer Module - Black 6 Way
- Siren (Export) - Black 4 Way
- Schematic Diagrams
- Heated Seat System
- Interior & Exterior
- Body
- Description
- Warning
- Diagnosis And Testing
- Standard Procedure
- Standard Procedure - Plastic Body Panel Repair
- Notes
- Rigid Plastics:
- Semi-Rigid Plastics:
- Flexible Plastics:
- Repair Procedure:
- Adhesion Promoter/Surface Modifier:
- Safety Precaution And Warnings
- Rigid, Semi-Rigid, And Flexible Plastic Parts Types
- Panel Sectioning
- Panel Reinforcement
- Visual Inspection
- Panel Surface Preparation
- Patching Panels
- Panel Patch Fabrications
- Panel Patch Installation
- Patched Panel Surfacing
- Standard Procedure - Heat Staking
- Standard Procedure - Plastic Body Panel Repair
- Specifications
- Special Tools
- Convertible Top
- DECKLID - Pt-27
- Door - Front
- Front Door Applique
- Front Door Check Strap
- Front Door
- Front Door Glass
- Removal
- Installation
- Adjustment - Pt-27 Only
- Front Door Adjustment
- Quarter Glass Adjustment
- Notes
- Up-Stop Adjustments
- Bottom Of Glass - Inboard/Outboard Adjustments
- Top Of Glass - Inboard/Outboard Adjustments
- Glass - Front/Rear Adjustment
- Quarter Glass Alignment Verification
- Condition - Height Mismatch Between Door Glass And Quarter Glass With Top Down
- Condition - Door Glass Noise Along A-Pillar When Closing Door And/Or Door Glass Touching Quarter Glass Metal Seal Retainer And/Or Wind Noise/Water Leak Along Quarter Glass Seal.
- Condition - Door Glass Not Driving Into The Top In Full Up Position
- Condition - Quarter Glass Not Driving Into The Top In Full Up Position
- Condition - Slapping Noise Between The Door And Quarter Glass With The Top Down During Driving Of The Vehicle
- Condition - Non-Parallel Gap Between Door And Quarter Glasses
- Condition - Quarter Glass Seal Fold Over During Travel With Door Glass Full Up And Top Up Or Down
- Condition - Intermediate Rear Of Door Glass Not Driving Into The Top Seal And/Or Noise At Rear Bottom Of The Door
- Front Door Outside Handle
- Front Door Hinge
- Front Door Inside Handle Actuator
- Front Door Latch
- Front Door Latch Striker
- Front Door Lock Cylinder
- Front Door Vertical Guide Bar
- Front Door Side View Mirror Flag - Pt-27
- Front Door Trim Panel
- Front Door Water Dam
- Front Door Window Regulator
- Door Glass Inner Belt Stabilizer - Pt-27
- Rear Rail Assembly - Pt-27
- Door - Rear
- Exterior
- Body Side Moldings
- Cowl Grille Screen
- Deck Upper Belt Molding - Pt-27
- Engine Compartment Lower Silencer
- Exterior Name Plates
- Front Fender
- Front Side Rail Access Pulley Splash Shield
- Front Wheelhouse Splash Shields
- Fuel Fill Door
- Grille
- Header Molding - Pt-27
- Luggage Rack Crossbar
- Luggage Rack Side Rail
- Radiator Closure Panel
- Side View Mirror
- Side View Mirror Glass
- Windshield A-Pillar Trim Molding - Pt-27
- Wood Grain/Flame Decals
- Grille - Lower Radiator
- Hood
- Instrument Panel
- Interior
- A-Pillar Trim
- B-Pillar Trim
- Body Vent
- DECKLID Sill Scuff Plate
- Door Sill Trim
- Floor Carpet
- Cargo Area Floor Carpet - Pt-27
- Front Floor Carpet Right/Left Side -Pt-27
- Rear Carpet - Pt-27
- Upper D-Pillar Trim
- Header Latch Retainer - Pt-27
- Headliner
- Inside Rear View Mirror
- Lower Quarter Trim Panel
- Rear Quarter Panel Trim - Pt-27
- Seat Back Support Bracket - Pt-27
- Side Cowl Trim Panel
- Sport Bar - Pt-27
- Sport Bar Inner Covers - Pt-27
- Sport Bar Outer Cover - Pt-27
- Sun Visor
- Trunk Trim Panel - Pt-27
- Trunk Welt - Pt-27
- Upper C-Pillar Trim
- Windshield Header Molding -Pt-27
- Liftgate
- Paint
- Quarter Glass - Pt-27
- Seats
- Child Seat Tether Anchor Bezel
- Front Seat
- Front Seat Back - With Front Seat Back Panel
- Front Seat Back
- Front Seat Back Cover/Foam
- Front Seat Back Cover - Without Front Seat Back Panel
- Front Seat Cushion
- Front Seat Cushion Cover
- Headrest - Front/Rear
- Rear Seat
- Rear Seat Back
- Rear Seat Back Cover/Foam
- Rear Seat Back Cushion Cover/Foam - Pt-27
- Rear Seat Bolster - Pt-27
- Rear Seat Bolster Cover - Pt-27
- Rear Seat Cushion
- Rear Seat Back Cushion / Cover
- Rear Seat Latch Cover
- Under Seat Storage Bin
- Stationary Glass
- Sunroof
- Weatherstrip/Seals
- A-Pillar Weatherstrip Retainer - Pt-27
- Deck Lid Opening Weatherstrip - Pt-27
- Front And Rear Door Opening Weatherstrip
- Front And Rear Door Upper Secondary Weatherstrip
- Front Door Glass Run Weatherstrip
- Front Door Inner Belt Weatherstrip
- Front Door Outer Belt Weatherstrip
- Header Weatherstrip Seal Retainer - Pt-27
- Liftgate Weatherstrip
- Quarter Panel Outer Belt Weatherstrip - Pt-27
- Rear Door Glass Run Weatherstrip
- Rear Door Inner Belt Weatherstrip
- Sill Secondary Weatherstrip
- Header / A-Pillar Weatherstrip -Pt-27
- Front Door Sill Weatherstrip - Pt-27
- Body Structure
- Body
- Power Seat System
- Body Diagnostic Procedures
- Sun Roof/T-Top/Convertible Top
- Body Diagnostic Procedures
- Introduction
- Identification Of System
- System Description And Functional Operation
- Notes
- Airbag System
- Audio System
- Compass/Temperature Module (CTM)
- Compass/Temperature Mirror
- Description
- Operation
- English / Metric / Off Mode
- Calibration / Zone Mode
- Setting Compass Zone
- First Time Calibration
- Manual Calibration
- Continuous Calibration
- Self-Check Diagnostic
- Outside Temperature
- Temperature Update - Warm
- Temperature Update - Cold
- Extreme Temperature / Open Or Short Condition
- Ambient Temperature Sensor
- Ambient Temperature Sensor Diagnostics
- Instrument Cluster
- Remote Keyless Entry Module
- Sentry Key Immobilizer System (Skis)
- Communication
- Telecommunications
- Window Regulator Modules (Pt27 Only)
- Using The DRBIII®
- Disclaimers, Safety, Warnings
- Required Tools And Equipment
- Glossary Of Terms
- Diagnostic Information And Procedures
- Airbag
- Symptom List: ACCELEROMETER 1; INTERNAL 1; INTERNAL 2; INTERNAL 3; INTERNAL 4' OUTPUT DRIVER 1; OUTPUT DRIVER 2; STORED ENERGY FIRING 1
- Symptom List: AIRBAG WARNING INDICATOR DRIVER; AIRBAG WARNING INDICATOR OPEN; AIRBAG WARNING INDICATOR SHORT
- Symptom: CALIBRATION MISMATCH
- Symptom: CLUSTER MESSAGE MISMATCH
- Symptom: DRIVER SEAT BELT TENSIONER CIRCUIT OPEN
- Symptom: DRIVER SEAT BELT TENSIONER CIRCUIT SHORT
- Symptom: DRIVER SEAT BELT TENSIONER SHORT TO BATTERY
- Symptom: DRIVER SEAT BELT TENSIONER SHORT TO GROUND
- Symptom: DRIVER SQUIB 1 CIRCUIT OPEN
- Symptom: DRIVER SQUIB 1 CIRCUIT SHORT
- Symptom: DRIVER SQUIB 1 SHORT TO BATTERY
- Symptom: DRIVER SQUIB 1 SHORT TO GROUND
- Symptom: LEFT CURTAIN OR SEAT SQUIB CIRCUIT OPEN
- Symptom: LEFT CURTAIN OR SEAT SQUIB CIRCUIT SHORT
- Symptom: LEFT CURTAIN OR SEAT SQUIB SHORT TO BATTERY
- Symptom: LEFT CURTAIN OR SEAT SQUIB SHORT TO GROUND
- Symptom: LEFT SIDE IMPACT SENSOR 1 INTERNAL 1
- Symptom: LOSS OF IGNITION RUN - START
- Symptom: LOSS OF IGNITION RUN ONLY
- Symptom: NO CLUSTER MESSAGE
- Symptom: NO LEFT SIDE IMPACT SENSOR 1 COMMUNICATION
- Symptom: NO ODOMETER MESSAGE
- Symptom: NO PCI TRANSMISSION
- Symptom: NO RIGHT SIDE IMPACT SENSOR 1 COMMUNICATION
- Symptom: PASSENGER SEAT BELT TENSIONER CIRCUIT OPEN
- Symptom: PASSENGER SEAT BELT TENSIONER CIRCUIT SHORT
- Symptom: PASSENGER SEAT BELT TENSIONER SHORT TO BATTERY
- Symptom: PASSENGER SEAT BELT TENSIONER SHORT TO GROUND
- Symptom: PASSENGER SQUIB 1 CIRCUIT OPEN
- Symptom: PASSENGER SQUIB 1 CIRCUIT SHORT
- Symptom: PASSENGER SQUIB 1 SHORT TO BATTERY
- Symptom: PASSENGER SQUIB 1 SHORT TO GROUND
- Symptom: POWER SUPPLY VOLTAGE LOW
- Symptom: RIGHT CURTAIN OR SEAT SQUIB CIRCUIT OPEN
- Symptom: RIGHT CURTAIN OR SEAT SQUIB CIRCUIT SHORT
- Symptom: RIGHT CURTAIN OR SEAT SQUIB SHORT TO BATTERY
- Symptom: RIGHT CURTAIN OR SEAT SQUIB SHORT TO GROUND
- Symptom: RIGHT SIDE IMPACT SENSOR INTERNAL 1
- Symptom: VEHICLE BODY STYLE MISMATCH
- Symptom: *AIRBAG INDICATOR ON WITHOUT ACTIVE TROUBLE CODES
- Audio
- Symptom: ALL OUTPUTS SHORT
- Symptom: ANTENNA HARDWARE FAILURE - SDARS
- Symptom: ANTENNA NOT CONNECTED - SDARS
- Symptom: BUS BUSY - SDARS
- Symptom: BUS LOW - SDARS
- Symptom List: CASSETTE PLAYER INOP; CD MECHANICAL FAILURE; NO PCI TRANSMISSION; *AM/FM SWITCH INOPERATIVE; *ANY STATION PRESET SWITCH INOPERATIVE; *BALANCE INOPERATIVE; *CD EJECT SWITCH INOPERATIVE; *EQUALIZER INOPERATIVE; *FADER INOPERATIVE; *FF/RW SWITCH INOPERATIVE; *HOUR/MINUTE SWITCHES INOPERATIVE; *PAUSE/PLAY SWITCH INOPERATIVE; *PWR SWITCH INOPERATIVE; *SCAN SWITCH INOPERATIVE; *SEEK SWITCH INOPERATIVE; *SET SWITCH INOPERATIVE; *TAPE EJECT SWITCH INOPERATIVE; *TIME SWITCH INOPERATIVE; *TUNE SWITCH INOPERATIVE
- Symptom: CD PLAY FAILURE
- Symptom: CD READ FAILURE
- Symptom: CD TEMPERATURE HIGH
- Symptom: GPS ANTENNA NOT CONNECTED
- Symptom: INTERNAL FAILURE - SDARS
- Symptom: INTERNAL RECEIVER FAILURE - SDARS
- Symptom: LOW VOLTAGE LEVEL
- Symptom: NO ANTENNA CONNECTION
- Symptom: NO COMMUNICATION WITH SDARS
- Symptom: NO J1850 COMMUNICATION - SDARS
- Symptom: POWER AMP SHUTDOWN
- Symptom: RADIO AND NAV GPS ANTENNA NOT CONNECTED
- Symptom: *INOP NO FAULT CODES - SDARS
- Symptom: *POOR RECEPTION - SDARS
- Communication
- Symptom: *NO RESPONSE FROM AIRBAG CONTROL MODULE
- Symptom: *NO RESPONSE FROM AMPLIFIER
- Symptom: *NO RESPONSE FROM ANTILOCK BRAKE MODULE
- Symptom: *NO RESPONSE FROM ECM (PCI BUS) - DIESEL ONLY
- Symptom: *NO RESPONSE FROM ECM (SCI ONLY) - DIESEL ONLY
- Symptom: *NO RESPONSE FROM HANDS FREE MODULE
- Symptom: *NO RESPONSE FROM INSTRUMENT CLUSTER
- Symptom: *NO RESPONSE FROM OVERHEAD CONSOLE (COMPASS/TEMPERATURE MIRROR MODULE)
- Symptom: *NO RESPONSE FROM PCM (PCI BUS) - 1.6L
- Symptom: *NO RESPONSE FROM PCM (PCI BUS) - NGC
- Symptom: *NO RESPONSE FROM PCM (PCM SCI ONLY) - NGC
- Symptom: *NO RESPONSE FROM PCM (SCI ONLY) - 1.6L
- Symptom: *NO RESPONSE FROM RADIO
- Symptom: *NO RESPONSE FROM RKE
- Symptom: *NO RESPONSE FROM SATELLITE RADIO RECEIVER
- Symptom: *NO RESPONSE FROM SENTRY KEY IMMOBILIZER MODULE
- Symptom: *NO RESPONSE FROM TRANSMISSION CONTROL MODULE - NGC
- Symptom: *NO RESPONSE FROM WINDOW REGULATOR MODULE - PT27
- Symptom: *PCI BUS COMMUNICATION FAILURE
- Instrument Cluster
- Symptom List: ABS INDICATOR CIRCUIT OPEN; AIRBAG INDICATOR CIRCUIT OPEN
- Symptom List: ABS MESSAGE NOT RECEIVED; ACM MESSAGE NOT RECEIVED; EATX MESSAGE NOT RECEIVED; NO PCI TRANSMISSION; SBEC MESSAGE NOT RECEIVED; SKIM MESSAGE NOT RECEIVED
- Symptom: EATX MESSAGE MISMATCH
- Symptom: EEPROM CHECKSUM FAILURE
- Symptom: FUEL LEVEL SENSOR OPEN
- Symptom: FUEL LEVEL SENSOR SHORT
- Symptom: FUEL LEVEL SENSOR STUCK
- Symptom: PANEL DIMMER OPEN
- Symptom: PANEL DIMMER SHORTED
- Symptom: *ALL GAUGES INOPERATIVE
- Symptom: *ANY PCI BUS INDICATOR INOPERATIVE
- Symptom: *BRAKE WARNING INDICATOR ALWAYS ON
- Symptom: *BRAKE WARNING INDICATOR INOPERATIVE
- Symptom: *FRONT FOG LAMP INDICATOR INOPERATIVE
- Symptom: *FUEL GAUGE INACCURATE
- Symptom: *HIGH BEAM INDICATOR INOPERATIVE
- Symptom: *INSTRUMENT CLUSTER DIMMING INOPERATIVE
- Symptom: *LOW OIL PRESSURE INDICATOR ALWAYS ON
- Symptom: *LOW OIL PRESSURE INDICATOR INOPERATIVE
- Symptom: *ONE GAUGE INOPERATIVE
- Symptom: *PRND OR AUTOSTICK DISPLAY INOPERATIVE OR INACCURATE
- Symptom: *REAR FOG LAMP INDICATOR INOPERATIVE - BUX ONLY
- Symptom: *SEAT BELT INDICATOR NOT OPERATING PROPERLY
- Symptom: *VF DISPLAY INOPERATIVE
- Interior Lighting
- Overhead Console
- Power Door Locks/RKE
- Symptom: BODY STYLE MISMATCH
- Symptom: DRIVER DOOR SWITCH FAILURE
- Symptom: INCORRECT MODULE TYPE CONFIGURATION FOR PART NUMBER
- Symptom: MODULE NOT CONFIGURED FOR RKE
- Symptom: NO AIRBAG MESSAGES RECEIVED
- Symptom: NO PCM MESSAGES RECEIVED
- Symptom: NO SKIM MESSAGES RECEIVED
- Symptom: PASSENGER DOOR OR LIFTGATE SWITCH FAILURE - PT44
- Symptom:* ALL DOORS (EXCEPT DRIVER)FAIL TO LOCK
- Symptom: * ALL DOORS (EXCEPT DRIVER)FAIL TO LOCK AND UNLOCK
- Symptom:* ALL DOORS (EXCEPT DRIVER)FAIL TO UNLOCK
- Symptom: *ALL DOOR LOCKS INOPERATIVE
- Symptom: *ALL DOORS FAIL TO LOCK
- Symptom: *ALL DOORS FAIL TO UNLOCK
- Symptom: *ALL LOCKS INOPERATIVE FROM ONE LOCK SWITCH
- Symptom: *DECKLID RELEASE SWITCH INOPERATIVE - PT27
- Symptom: *DECKLID SOLENOID INOPERATIVE - PT27
- Symptom: *DOORS LOCKABLE WITH KEY IN IGNITION AND DRIVER DOOR OPEN
- Symptom: *DRIVER DOOR FAILS TO LOCK
- Symptom: *DRIVER DOOR FAILS TO LOCK AND UNLOCK
- Symptom: *DRIVER DOOR FAILS TO UNLOCK
- Symptom: *DRIVER DOOR FAILS UNLOCK - PT27
- Symptom: *LIFTGATE LOCK MOTOR FAILS TO LOCK OR UNLOCK
- Symptom: *ONE DOOR FAILS TO LOCK AND UNLOCK - PT27
- Symptom: *ONE PASSENGER DOOR FAILS TO LOCK AND UNLOCK
- Symptom: *PASSENGER DOOR FAILS TO UNLOCK - PT27
- Symptom: *RKE INOPERATIVE
- Power Top
- Symptom: AMBIENT TEMP MESSAGE NOT RECEIVED
- Symptom: POWER TOP RELAY CONTROL CIRCUIT OPEN
- Symptom: POWER TOP RELAY INOPERATIVE
- Symptom: POWER TOP SWITCH MUX CIRCUIT OPEN
- Symptom: POWER TOP SWITCH MUX CIRCUIT SHORT TO GROUND
- Symptom: POWER TOP SWITCH MUX CIRCUIT VALUE OUT OF RANGE
- Symptom: SPEED MESSAGE NOT RECEIVED
- Power Windows
- Symptom: BATTERY VOLTAGE TOO HIGH
- Symptom: BATTERY VOLTAGE TOO LOW
- Symptom: FRONT WINDOW MOTOR MALFUNCTION
- Symptom: FRONT WINDOW SWITCH MUX CIRCUIT OPEN
- Symptom: FRONT WINDOW SWITCH MUX CIRCUIT SHORT TO GROUND
- Symptom: FRONT WINDOW SWITCH MUX CIRCUIT VALUE OUT OF RANGE
- Symptom: IGNITION SWITCH OUTPUT OPEN
- Symptom: REAR WINDOW MOTOR CIRCUIT OPEN OR SHORTED
- Symptom: REAR WINDOW SWITCH MUX CIRCUIT OPEN
- Symptom: REAR WINDOW SWITCH MUX CIRCUIT SHORT TO GROUND
- Symptom: REAR WINDOW SWITCH MUX CIRCUIT VALUE OUT OF RANGE
- Symptom: WINDOW DROP SWITCH SENSE CIRCUIT OPEN
- Symptom: *DOOR AJAR CIRCUIT OPEN
- Symptom: *DOOR WINDOWS STAY IN DROP DOWN POSITION
- Symptom: *WINDOW DROPS OR JERKS DURING OPENING
- Telecommunication
- Symptom: AUDIO HARDWARE MESSAGE NOT RECEIVED
- Symptom List: BLUETOOTH ERROR; FLASH CHECKSUM ERROR; FLASH WRITE ERROR; PCI BUS INTERNAL ERROR; RAM WRITE ERROR; ROM CHECKSUM ERROR
- Symptom List: BODY STYLE MESSAGE NOT RECEIVED; INVALID BODY STYLE
- Symptom: GENERAL MICROPHONE FAULT
- Symptom: IGNITION POWER MESSAGE NOT RECEIVED
- Symptom List: LEFT AUDIO INPUT SHORT TO GROUND; LEFT AUDIO INPUT SHORT TO VOLTAGE; LEFT AUDIO OUTPUT 1 SHORT TO GROUND; LEFT AUDIO OUTPUT 1 SHORT TO VOLTAGE
- Symptom List: MIRROR POWER CIRCUIT SHORT TO GROUND; MIRROR POWER CIRCUIT SHORT TO VOLTAGE
- Symptom List: PCI BUS BUSY; PCI BUS CIRCUIT OPEN; PCI BUS CIRCUIT SHORT TO GROUND; PCI BUS CIRCUIT SHORT TO VOLTAGE
- Symptom List: PHONE SWITCH STUCK; VOICE RECOGNITION SWITCH STUCK' VOICE RECOGNITION/PHONE SWITCH CIRCUIT RATIONALITY; VOICE RECOGNITION/PHONE SWITCH CIRCUIT SHORT TO GROUND; VOICE RECOGNITION/PHONE SWITCH CIRCUIT SHORT TO VOLTAGE
- Symptom: PRNDL MESSAGE NOT RECEIVED
- Symptom: RADIO MESSAGE NOT RECEIVED
- Symptom List: RIGHT AUDIO INPUT SHORT TO GROUND; RIGHT AUDIO INPUT SHORT TO VOLTAGE; RIGHT AUDIO OUTPUT 1 SHORT TO GROUND; RIGHT AUDIO OUTPUT 1 SHORT TO VOLTAGE
- Symptom: RPM MESSAGE NOT RECEIVED
- Symptom: VIN MESSAGE NOT RECEIVED
- Symptom: VIN MISMATCH
- Vehicle Theft/Security
- Symptom: HOOD AJAR SWITCH MISSING (EXPORT ONLY)
- Symptom: MODULE PREVIOUSLY CONFIGURED FOR VTSS
- Symptom: *ALARM TRIPS ON ITS OWN
- Symptom: *HEADLAMPS FAIL TO FLASH DURING ALARM
- Symptom: *HORN FAILS TO SOUND DURING ALARM
- Symptom: *INTRUSION SENSOR CANNOT BE DISABLED (EXPORT ONLY)
- Symptom: *INTRUSION SENSOR FAILS TO TRIP VTSS (EXPORT ONLY)
- Symptom: *INTRUSION SENSOR REPEATEDLY TRIGGERS VTSS (EXPORT ONLY)
- Symptom: *OPEN DRIVER DOOR FAILS TO TRIP ALARM
- Symptom: *OPEN LIFTGATE FAILS TO TRIP ALARM
- Symptom: *OPEN PASSENGER DOOR FAILS TO TRIP ALARM
- Symptom: *PARK LAMPS FAIL TO FLASH DURING ALARM
- Symptom List: *VTSS FAILS TO ARM FROM LEFT DOOR CYLINDER LOCK SWITCH (EXPORT ONLY); *VTSS FAILS TO ARM/DISARM FROM LEFT DOOR CYLINDER LOCK SWITCH
- Symptom List: *VTSS FAILS TO ARM FROM LIFTGATE CYLINDER LOCK SWITCH (EXPORT ONLY); *VTSS FAILS TO ARM/DISARM FROM LIFTGATE CYLINDER LOCK SWITCH
- Symptom List: *VTSS FAILS TO ARM FROM RIGHT DOOR CYLINDER LOCK SWITCH (EXPORT ONLY); *VTSS FAILS TO ARM/DISARM FROM RIGHT DOOR CYLINDER LOCK SWITCH
- Symptom: *VTSS INDICATOR FAILS TO FLASH
- Symptom: *VTSS INDICATOR STAYS ON STEADY DURING ARMING
- Symptom: *VTSS SIREN INOPERATIVE (EXPORT ONLY)
- Verifications Tests
- Airbag
- Component Locations
- Connector PINOUTS
- Airbag Control Module (Orc) (Base) - Yellow 23 Way
- Airbag Control Module C1 (Orc) (Premium) - Yellow 32 Way
- Airbag Control Module C2 (Orc) (Premium) - Yellow 32 Way
- Ambient Temperature Sensor (Except 2.4L Base) - Black 2 Way
- Amplifier Audio C1 - 20 Way
- Anti-Lock Brake Module - Black 47 Way
- C203 (Pt27) - LT. Gray (Body Side)
- C203 (Pt27) - LT. Gray (Instrument Panel Side)
- C204 (Pt27) - (Instrument Panel Side)
- C204 (Pt27) - (Left Front Door Side)
- C204 (Pt44 LHP) - Natural (Instrument Panel Side)
- C204 (Pt44 LHP) - Natural (Left Front Door Side)
- C205 (Pt27) - (Instrument Panel Side)
- C205 (Pt27) - (Right Front Door Side)
- C305 - Yellow (Airbag Side)
- C305 - Yellow (UNIBODY Side)
- C306 - Yellow (Airbag Side)
- C306 - Yellow (UNIBODY Side)
- C343 (Pt27) - LT. Gray (DECKLID Jumper Side)
- C343 (Pt27) - LT. Gray (DECKLID Side)
- C349 (Pt27) - Blue (Body Side
- C349 (Pt27) - Blue (DECKLID Jumper Side)
- C362 (Pt27) - LT. Gray (Body Side)
- C362 (Pt27) - LT. Gray (Power Top Side)
- CLOCKSPRING - DK. Green 7 Way
- Compass/Temperature Mirror Module (Pt27) - Black 10 Way
- Data Link Connector - Black 16 Way
- DECKLID Cylinder Unlock Switch (Pt27) - LT. Gray 2 Way
- DECKLID Handle Switch (Pt27) - White 2 Way
- DECKLID Release Motor (Pt27) - Black 3 Way
- DECKLID Release Switch (Pt27) - Black 2 Way
- Dome Lamp - Black 3 Way
- Dome Lamp/Intrusion Sensor (Export) - White 4 Way
- Driver Airbag Squib 1 - Yellow 2 Way
- Driver Door Ajar Switch - Black 2 Way
- Driver Door Handle Switch (Pt27) - 2 Way
- Driver Door Power Lock Motor/Ajar Switch - Black 4 Way
- Driver Rear Window Motor (Pt27) - Black 2 Way
- Driver Seat Belt TENSIONER - Yellow 2 Way
- Driver Window Regulator Module (Pt27) - Black 20 Way
- Engine Control Module C1 (Diesel) - Black 81 Way
- Front Power Window Switch - Black 14 Way
- Fuel Pump Module - LT. Gray 4 Way
- Fuses (FB)
- Hands Free Module C1 - DK. Gray 22 Way
- Hands Free Module C2 (Satellite Radio) - DK. Gray 10 Way
- Hands Free Module C3 - Black 10 Way
- High Note Horn (Export) - Black 2 Way
- Hood Ajar Switch (Export) - Black 2 Way
- Ignition Switch C1 - 10 Way
- Instrument Cluster C1 - Black 26 Way
- Instrument Cluster C2 - Black 10 Way
- Left Cylinder Lock Switch - Black 2 Way
- Left Door Lock Switch - Black 3 Way
- Left Front Power Window Motor (Pt44) - Black 2 Way
- Left Instrument Panel Speaker - Black 2 Way
- Left Rear Speaker (Pt44) - Black 2 Way
- Left Seat Airbag Squib (LHP) - Yellow 2 Way
- Left Seat Airbag Squib (RHD) - Yellow 2 Way
- Left Side Impact Sensor 1 - Gray 2 Way
- Liftgate Ajar Switch - White 2 Way
- Liftgate Cylinder Lock Switch - LT. Gray 2 Way
- Liftgate Handle Switch (Pt44) - Natural 2 Way
- Liftgate Power Lock Motor - Black 4 Way
- Liftgate Release Motor (Pt44) - Black 3 Way
- Low Note Horn - Black 2 Way
- Multi-Function Switch - Gray 20 Way
- Overhead Console Module - Black 12 Way
- Passenger Airbag Squib 1 - Yellow 2 Way
- Passenger Door Ajar Switch - Black 2 Way
- Passenger Door Handle Switch (Pt27) - 2 Way
- Passenger Door Power Lock Motor/Ajar Switch - Black 4 Way
- Passenger Rear Window Motor (Pt27) - Black 2 Way
- Passenger Seat Belt TENSIONER - Yellow 2 Way
- Passenger Window Regulator Module (Pt27) - Black 20 Way
- Fuses (PDC)
- Power Top Motor (Pt27) - 2 Way
- Power Top Relay (Pt27) - Black 6 Way
- Power Top Switch (Pt27) - 3 Way
- Powertrain Control Module (1.6L) - Black 90 Way
- Powertrain Control Module C1 (NGC) - Black/Black 38 Way
- Radio C1 - White 22 Way
- Radio C2 (Hands Free) - DK. Gray 10 Way
- Rear View Mirror C1 - Black 12 Way
- Remote Keyless Entry Module - Black 26 Way
- Right Cylinder Lock Switch (Export) - Black 2 Way
- Right Door Lock Switch - Black 3 Way
- Right Front Door Speaker - 3 Way
- Right Front Power Window Motor (Pt44) - Black 2 Way
- Right Rear Power Window Motor (Pt44) - Black 2 Way
- Right Seat Airbag Squib (LHP) - Yellow 2 Way
- Right Seat Airbag Squib (RHP) - Yellow 2 Way
- Right Side Impact Sensor 1 - Gray 2 Way
- Sentry Key Immobilizer Module - Black 6 Way
- Siren (Export) - Black 4 Way
- Schematic Diagrams
- Interior & Exterior
- Body
- Description
- Warning
- Diagnosis And Testing
- Standard Procedure
- Standard Procedure - Plastic Body Panel Repair
- Notes
- Rigid Plastics:
- Semi-Rigid Plastics:
- Flexible Plastics:
- Repair Procedure:
- Adhesion Promoter/Surface Modifier:
- Safety Precaution And Warnings
- Rigid, Semi-Rigid, And Flexible Plastic Parts Types
- Panel Sectioning
- Panel Reinforcement
- Visual Inspection
- Panel Surface Preparation
- Patching Panels
- Panel Patch Fabrications
- Panel Patch Installation
- Patched Panel Surfacing
- Standard Procedure - Heat Staking
- Standard Procedure - Plastic Body Panel Repair
- Specifications
- Special Tools
- Convertible Top
- DECKLID - Pt-27
- Door - Front
- Front Door Applique
- Front Door Check Strap
- Front Door
- Front Door Glass
- Removal
- Installation
- Adjustment - Pt-27 Only
- Front Door Adjustment
- Quarter Glass Adjustment
- Notes
- Up-Stop Adjustments
- Bottom Of Glass - Inboard/Outboard Adjustments
- Top Of Glass - Inboard/Outboard Adjustments
- Glass - Front/Rear Adjustment
- Quarter Glass Alignment Verification
- Condition - Height Mismatch Between Door Glass And Quarter Glass With Top Down
- Condition - Door Glass Noise Along A-Pillar When Closing Door And/Or Door Glass Touching Quarter Glass Metal Seal Retainer And/Or Wind Noise/Water Leak Along Quarter Glass Seal.
- Condition - Door Glass Not Driving Into The Top In Full Up Position
- Condition - Quarter Glass Not Driving Into The Top In Full Up Position
- Condition - Slapping Noise Between The Door And Quarter Glass With The Top Down During Driving Of The Vehicle
- Condition - Non-Parallel Gap Between Door And Quarter Glasses
- Condition - Quarter Glass Seal Fold Over During Travel With Door Glass Full Up And Top Up Or Down
- Condition - Intermediate Rear Of Door Glass Not Driving Into The Top Seal And/Or Noise At Rear Bottom Of The Door
- Front Door Outside Handle
- Front Door Hinge
- Front Door Inside Handle Actuator
- Front Door Latch
- Front Door Latch Striker
- Front Door Lock Cylinder
- Front Door Vertical Guide Bar
- Front Door Side View Mirror Flag - Pt-27
- Front Door Trim Panel
- Front Door Water Dam
- Front Door Window Regulator
- Door Glass Inner Belt Stabilizer - Pt-27
- Rear Rail Assembly - Pt-27
- Door - Rear
- Exterior
- Body Side Moldings
- Cowl Grille Screen
- Deck Upper Belt Molding - Pt-27
- Engine Compartment Lower Silencer
- Exterior Name Plates
- Front Fender
- Front Side Rail Access Pulley Splash Shield
- Front Wheelhouse Splash Shields
- Fuel Fill Door
- Grille
- Header Molding - Pt-27
- Luggage Rack Crossbar
- Luggage Rack Side Rail
- Radiator Closure Panel
- Side View Mirror
- Side View Mirror Glass
- Windshield A-Pillar Trim Molding - Pt-27
- Wood Grain/Flame Decals
- Grille - Lower Radiator
- Hood
- Instrument Panel
- Interior
- A-Pillar Trim
- B-Pillar Trim
- Body Vent
- DECKLID Sill Scuff Plate
- Door Sill Trim
- Floor Carpet
- Cargo Area Floor Carpet - Pt-27
- Front Floor Carpet Right/Left Side -Pt-27
- Rear Carpet - Pt-27
- Upper D-Pillar Trim
- Header Latch Retainer - Pt-27
- Headliner
- Inside Rear View Mirror
- Lower Quarter Trim Panel
- Rear Quarter Panel Trim - Pt-27
- Seat Back Support Bracket - Pt-27
- Side Cowl Trim Panel
- Sport Bar - Pt-27
- Sport Bar Inner Covers - Pt-27
- Sport Bar Outer Cover - Pt-27
- Sun Visor
- Trunk Trim Panel - Pt-27
- Trunk Welt - Pt-27
- Upper C-Pillar Trim
- Windshield Header Molding -Pt-27
- Liftgate
- Paint
- Quarter Glass - Pt-27
- Seats
- Child Seat Tether Anchor Bezel
- Front Seat
- Front Seat Back - With Front Seat Back Panel
- Front Seat Back
- Front Seat Back Cover/Foam
- Front Seat Back Cover - Without Front Seat Back Panel
- Front Seat Cushion
- Front Seat Cushion Cover
- Headrest - Front/Rear
- Rear Seat
- Rear Seat Back
- Rear Seat Back Cover/Foam
- Rear Seat Back Cushion Cover/Foam - Pt-27
- Rear Seat Bolster - Pt-27
- Rear Seat Bolster Cover - Pt-27
- Rear Seat Cushion
- Rear Seat Back Cushion / Cover
- Rear Seat Latch Cover
- Under Seat Storage Bin
- Stationary Glass
- Sunroof
- Weatherstrip/Seals
- A-Pillar Weatherstrip Retainer - Pt-27
- Deck Lid Opening Weatherstrip - Pt-27
- Front And Rear Door Opening Weatherstrip
- Front And Rear Door Upper Secondary Weatherstrip
- Front Door Glass Run Weatherstrip
- Front Door Inner Belt Weatherstrip
- Front Door Outer Belt Weatherstrip
- Header Weatherstrip Seal Retainer - Pt-27
- Liftgate Weatherstrip
- Quarter Panel Outer Belt Weatherstrip - Pt-27
- Rear Door Glass Run Weatherstrip
- Rear Door Inner Belt Weatherstrip
- Sill Secondary Weatherstrip
- Header / A-Pillar Weatherstrip -Pt-27
- Front Door Sill Weatherstrip - Pt-27
- Body Structure
- Body
- Message Systems
- Power Top & Sunroof
- Body Diagnostic Procedures
- Windows
- Body Diagnostic Procedures
- Introduction
- Identification Of System
- System Description And Functional Operation
- Notes
- Airbag System
- Audio System
- Compass/Temperature Module (CTM)
- Compass/Temperature Mirror
- Description
- Operation
- English / Metric / Off Mode
- Calibration / Zone Mode
- Setting Compass Zone
- First Time Calibration
- Manual Calibration
- Continuous Calibration
- Self-Check Diagnostic
- Outside Temperature
- Temperature Update - Warm
- Temperature Update - Cold
- Extreme Temperature / Open Or Short Condition
- Ambient Temperature Sensor
- Ambient Temperature Sensor Diagnostics
- Instrument Cluster
- Remote Keyless Entry Module
- Sentry Key Immobilizer System (Skis)
- Communication
- Telecommunications
- Window Regulator Modules (Pt27 Only)
- Using The DRBIII®
- Disclaimers, Safety, Warnings
- Required Tools And Equipment
- Glossary Of Terms
- Diagnostic Information And Procedures
- Airbag
- Symptom List: ACCELEROMETER 1; INTERNAL 1; INTERNAL 2; INTERNAL 3; INTERNAL 4' OUTPUT DRIVER 1; OUTPUT DRIVER 2; STORED ENERGY FIRING 1
- Symptom List: AIRBAG WARNING INDICATOR DRIVER; AIRBAG WARNING INDICATOR OPEN; AIRBAG WARNING INDICATOR SHORT
- Symptom: CALIBRATION MISMATCH
- Symptom: CLUSTER MESSAGE MISMATCH
- Symptom: DRIVER SEAT BELT TENSIONER CIRCUIT OPEN
- Symptom: DRIVER SEAT BELT TENSIONER CIRCUIT SHORT
- Symptom: DRIVER SEAT BELT TENSIONER SHORT TO BATTERY
- Symptom: DRIVER SEAT BELT TENSIONER SHORT TO GROUND
- Symptom: DRIVER SQUIB 1 CIRCUIT OPEN
- Symptom: DRIVER SQUIB 1 CIRCUIT SHORT
- Symptom: DRIVER SQUIB 1 SHORT TO BATTERY
- Symptom: DRIVER SQUIB 1 SHORT TO GROUND
- Symptom: LEFT CURTAIN OR SEAT SQUIB CIRCUIT OPEN
- Symptom: LEFT CURTAIN OR SEAT SQUIB CIRCUIT SHORT
- Symptom: LEFT CURTAIN OR SEAT SQUIB SHORT TO BATTERY
- Symptom: LEFT CURTAIN OR SEAT SQUIB SHORT TO GROUND
- Symptom: LEFT SIDE IMPACT SENSOR 1 INTERNAL 1
- Symptom: LOSS OF IGNITION RUN - START
- Symptom: LOSS OF IGNITION RUN ONLY
- Symptom: NO CLUSTER MESSAGE
- Symptom: NO LEFT SIDE IMPACT SENSOR 1 COMMUNICATION
- Symptom: NO ODOMETER MESSAGE
- Symptom: NO PCI TRANSMISSION
- Symptom: NO RIGHT SIDE IMPACT SENSOR 1 COMMUNICATION
- Symptom: PASSENGER SEAT BELT TENSIONER CIRCUIT OPEN
- Symptom: PASSENGER SEAT BELT TENSIONER CIRCUIT SHORT
- Symptom: PASSENGER SEAT BELT TENSIONER SHORT TO BATTERY
- Symptom: PASSENGER SEAT BELT TENSIONER SHORT TO GROUND
- Symptom: PASSENGER SQUIB 1 CIRCUIT OPEN
- Symptom: PASSENGER SQUIB 1 CIRCUIT SHORT
- Symptom: PASSENGER SQUIB 1 SHORT TO BATTERY
- Symptom: PASSENGER SQUIB 1 SHORT TO GROUND
- Symptom: POWER SUPPLY VOLTAGE LOW
- Symptom: RIGHT CURTAIN OR SEAT SQUIB CIRCUIT OPEN
- Symptom: RIGHT CURTAIN OR SEAT SQUIB CIRCUIT SHORT
- Symptom: RIGHT CURTAIN OR SEAT SQUIB SHORT TO BATTERY
- Symptom: RIGHT CURTAIN OR SEAT SQUIB SHORT TO GROUND
- Symptom: RIGHT SIDE IMPACT SENSOR INTERNAL 1
- Symptom: VEHICLE BODY STYLE MISMATCH
- Symptom: *AIRBAG INDICATOR ON WITHOUT ACTIVE TROUBLE CODES
- Audio
- Symptom: ALL OUTPUTS SHORT
- Symptom: ANTENNA HARDWARE FAILURE - SDARS
- Symptom: ANTENNA NOT CONNECTED - SDARS
- Symptom: BUS BUSY - SDARS
- Symptom: BUS LOW - SDARS
- Symptom List: CASSETTE PLAYER INOP; CD MECHANICAL FAILURE; NO PCI TRANSMISSION; *AM/FM SWITCH INOPERATIVE; *ANY STATION PRESET SWITCH INOPERATIVE; *BALANCE INOPERATIVE; *CD EJECT SWITCH INOPERATIVE; *EQUALIZER INOPERATIVE; *FADER INOPERATIVE; *FF/RW SWITCH INOPERATIVE; *HOUR/MINUTE SWITCHES INOPERATIVE; *PAUSE/PLAY SWITCH INOPERATIVE; *PWR SWITCH INOPERATIVE; *SCAN SWITCH INOPERATIVE; *SEEK SWITCH INOPERATIVE; *SET SWITCH INOPERATIVE; *TAPE EJECT SWITCH INOPERATIVE; *TIME SWITCH INOPERATIVE; *TUNE SWITCH INOPERATIVE
- Symptom: CD PLAY FAILURE
- Symptom: CD READ FAILURE
- Symptom: CD TEMPERATURE HIGH
- Symptom: GPS ANTENNA NOT CONNECTED
- Symptom: INTERNAL FAILURE - SDARS
- Symptom: INTERNAL RECEIVER FAILURE - SDARS
- Symptom: LOW VOLTAGE LEVEL
- Symptom: NO ANTENNA CONNECTION
- Symptom: NO COMMUNICATION WITH SDARS
- Symptom: NO J1850 COMMUNICATION - SDARS
- Symptom: POWER AMP SHUTDOWN
- Symptom: RADIO AND NAV GPS ANTENNA NOT CONNECTED
- Symptom: *INOP NO FAULT CODES - SDARS
- Symptom: *POOR RECEPTION - SDARS
- Communication
- Symptom: *NO RESPONSE FROM AIRBAG CONTROL MODULE
- Symptom: *NO RESPONSE FROM AMPLIFIER
- Symptom: *NO RESPONSE FROM ANTILOCK BRAKE MODULE
- Symptom: *NO RESPONSE FROM ECM (PCI BUS) - DIESEL ONLY
- Symptom: *NO RESPONSE FROM ECM (SCI ONLY) - DIESEL ONLY
- Symptom: *NO RESPONSE FROM HANDS FREE MODULE
- Symptom: *NO RESPONSE FROM INSTRUMENT CLUSTER
- Symptom: *NO RESPONSE FROM OVERHEAD CONSOLE (COMPASS/TEMPERATURE MIRROR MODULE)
- Symptom: *NO RESPONSE FROM PCM (PCI BUS) - 1.6L
- Symptom: *NO RESPONSE FROM PCM (PCI BUS) - NGC
- Symptom: *NO RESPONSE FROM PCM (PCM SCI ONLY) - NGC
- Symptom: *NO RESPONSE FROM PCM (SCI ONLY) - 1.6L
- Symptom: *NO RESPONSE FROM RADIO
- Symptom: *NO RESPONSE FROM RKE
- Symptom: *NO RESPONSE FROM SATELLITE RADIO RECEIVER
- Symptom: *NO RESPONSE FROM SENTRY KEY IMMOBILIZER MODULE
- Symptom: *NO RESPONSE FROM TRANSMISSION CONTROL MODULE - NGC
- Symptom: *NO RESPONSE FROM WINDOW REGULATOR MODULE - PT27
- Symptom: *PCI BUS COMMUNICATION FAILURE
- Instrument Cluster
- Symptom List: ABS INDICATOR CIRCUIT OPEN; AIRBAG INDICATOR CIRCUIT OPEN
- Symptom List: ABS MESSAGE NOT RECEIVED; ACM MESSAGE NOT RECEIVED; EATX MESSAGE NOT RECEIVED; NO PCI TRANSMISSION; SBEC MESSAGE NOT RECEIVED; SKIM MESSAGE NOT RECEIVED
- Symptom: EATX MESSAGE MISMATCH
- Symptom: EEPROM CHECKSUM FAILURE
- Symptom: FUEL LEVEL SENSOR OPEN
- Symptom: FUEL LEVEL SENSOR SHORT
- Symptom: FUEL LEVEL SENSOR STUCK
- Symptom: PANEL DIMMER OPEN
- Symptom: PANEL DIMMER SHORTED
- Symptom: *ALL GAUGES INOPERATIVE
- Symptom: *ANY PCI BUS INDICATOR INOPERATIVE
- Symptom: *BRAKE WARNING INDICATOR ALWAYS ON
- Symptom: *BRAKE WARNING INDICATOR INOPERATIVE
- Symptom: *FRONT FOG LAMP INDICATOR INOPERATIVE
- Symptom: *FUEL GAUGE INACCURATE
- Symptom: *HIGH BEAM INDICATOR INOPERATIVE
- Symptom: *INSTRUMENT CLUSTER DIMMING INOPERATIVE
- Symptom: *LOW OIL PRESSURE INDICATOR ALWAYS ON
- Symptom: *LOW OIL PRESSURE INDICATOR INOPERATIVE
- Symptom: *ONE GAUGE INOPERATIVE
- Symptom: *PRND OR AUTOSTICK DISPLAY INOPERATIVE OR INACCURATE
- Symptom: *REAR FOG LAMP INDICATOR INOPERATIVE - BUX ONLY
- Symptom: *SEAT BELT INDICATOR NOT OPERATING PROPERLY
- Symptom: *VF DISPLAY INOPERATIVE
- Interior Lighting
- Overhead Console
- Power Door Locks/RKE
- Symptom: BODY STYLE MISMATCH
- Symptom: DRIVER DOOR SWITCH FAILURE
- Symptom: INCORRECT MODULE TYPE CONFIGURATION FOR PART NUMBER
- Symptom: MODULE NOT CONFIGURED FOR RKE
- Symptom: NO AIRBAG MESSAGES RECEIVED
- Symptom: NO PCM MESSAGES RECEIVED
- Symptom: NO SKIM MESSAGES RECEIVED
- Symptom: PASSENGER DOOR OR LIFTGATE SWITCH FAILURE - PT44
- Symptom:* ALL DOORS (EXCEPT DRIVER)FAIL TO LOCK
- Symptom: * ALL DOORS (EXCEPT DRIVER)FAIL TO LOCK AND UNLOCK
- Symptom:* ALL DOORS (EXCEPT DRIVER)FAIL TO UNLOCK
- Symptom: *ALL DOOR LOCKS INOPERATIVE
- Symptom: *ALL DOORS FAIL TO LOCK
- Symptom: *ALL DOORS FAIL TO UNLOCK
- Symptom: *ALL LOCKS INOPERATIVE FROM ONE LOCK SWITCH
- Symptom: *DECKLID RELEASE SWITCH INOPERATIVE - PT27
- Symptom: *DECKLID SOLENOID INOPERATIVE - PT27
- Symptom: *DOORS LOCKABLE WITH KEY IN IGNITION AND DRIVER DOOR OPEN
- Symptom: *DRIVER DOOR FAILS TO LOCK
- Symptom: *DRIVER DOOR FAILS TO LOCK AND UNLOCK
- Symptom: *DRIVER DOOR FAILS TO UNLOCK
- Symptom: *DRIVER DOOR FAILS UNLOCK - PT27
- Symptom: *LIFTGATE LOCK MOTOR FAILS TO LOCK OR UNLOCK
- Symptom: *ONE DOOR FAILS TO LOCK AND UNLOCK - PT27
- Symptom: *ONE PASSENGER DOOR FAILS TO LOCK AND UNLOCK
- Symptom: *PASSENGER DOOR FAILS TO UNLOCK - PT27
- Symptom: *RKE INOPERATIVE
- Power Top
- Symptom: AMBIENT TEMP MESSAGE NOT RECEIVED
- Symptom: POWER TOP RELAY CONTROL CIRCUIT OPEN
- Symptom: POWER TOP RELAY INOPERATIVE
- Symptom: POWER TOP SWITCH MUX CIRCUIT OPEN
- Symptom: POWER TOP SWITCH MUX CIRCUIT SHORT TO GROUND
- Symptom: POWER TOP SWITCH MUX CIRCUIT VALUE OUT OF RANGE
- Symptom: SPEED MESSAGE NOT RECEIVED
- Power Windows
- Symptom: BATTERY VOLTAGE TOO HIGH
- Symptom: BATTERY VOLTAGE TOO LOW
- Symptom: FRONT WINDOW MOTOR MALFUNCTION
- Symptom: FRONT WINDOW SWITCH MUX CIRCUIT OPEN
- Symptom: FRONT WINDOW SWITCH MUX CIRCUIT SHORT TO GROUND
- Symptom: FRONT WINDOW SWITCH MUX CIRCUIT VALUE OUT OF RANGE
- Symptom: IGNITION SWITCH OUTPUT OPEN
- Symptom: REAR WINDOW MOTOR CIRCUIT OPEN OR SHORTED
- Symptom: REAR WINDOW SWITCH MUX CIRCUIT OPEN
- Symptom: REAR WINDOW SWITCH MUX CIRCUIT SHORT TO GROUND
- Symptom: REAR WINDOW SWITCH MUX CIRCUIT VALUE OUT OF RANGE
- Symptom: WINDOW DROP SWITCH SENSE CIRCUIT OPEN
- Symptom: *DOOR AJAR CIRCUIT OPEN
- Symptom: *DOOR WINDOWS STAY IN DROP DOWN POSITION
- Symptom: *WINDOW DROPS OR JERKS DURING OPENING
- Telecommunication
- Symptom: AUDIO HARDWARE MESSAGE NOT RECEIVED
- Symptom List: BLUETOOTH ERROR; FLASH CHECKSUM ERROR; FLASH WRITE ERROR; PCI BUS INTERNAL ERROR; RAM WRITE ERROR; ROM CHECKSUM ERROR
- Symptom List: BODY STYLE MESSAGE NOT RECEIVED; INVALID BODY STYLE
- Symptom: GENERAL MICROPHONE FAULT
- Symptom: IGNITION POWER MESSAGE NOT RECEIVED
- Symptom List: LEFT AUDIO INPUT SHORT TO GROUND; LEFT AUDIO INPUT SHORT TO VOLTAGE; LEFT AUDIO OUTPUT 1 SHORT TO GROUND; LEFT AUDIO OUTPUT 1 SHORT TO VOLTAGE
- Symptom List: MIRROR POWER CIRCUIT SHORT TO GROUND; MIRROR POWER CIRCUIT SHORT TO VOLTAGE
- Symptom List: PCI BUS BUSY; PCI BUS CIRCUIT OPEN; PCI BUS CIRCUIT SHORT TO GROUND; PCI BUS CIRCUIT SHORT TO VOLTAGE
- Symptom List: PHONE SWITCH STUCK; VOICE RECOGNITION SWITCH STUCK' VOICE RECOGNITION/PHONE SWITCH CIRCUIT RATIONALITY; VOICE RECOGNITION/PHONE SWITCH CIRCUIT SHORT TO GROUND; VOICE RECOGNITION/PHONE SWITCH CIRCUIT SHORT TO VOLTAGE
- Symptom: PRNDL MESSAGE NOT RECEIVED
- Symptom: RADIO MESSAGE NOT RECEIVED
- Symptom List: RIGHT AUDIO INPUT SHORT TO GROUND; RIGHT AUDIO INPUT SHORT TO VOLTAGE; RIGHT AUDIO OUTPUT 1 SHORT TO GROUND; RIGHT AUDIO OUTPUT 1 SHORT TO VOLTAGE
- Symptom: RPM MESSAGE NOT RECEIVED
- Symptom: VIN MESSAGE NOT RECEIVED
- Symptom: VIN MISMATCH
- Vehicle Theft/Security
- Symptom: HOOD AJAR SWITCH MISSING (EXPORT ONLY)
- Symptom: MODULE PREVIOUSLY CONFIGURED FOR VTSS
- Symptom: *ALARM TRIPS ON ITS OWN
- Symptom: *HEADLAMPS FAIL TO FLASH DURING ALARM
- Symptom: *HORN FAILS TO SOUND DURING ALARM
- Symptom: *INTRUSION SENSOR CANNOT BE DISABLED (EXPORT ONLY)
- Symptom: *INTRUSION SENSOR FAILS TO TRIP VTSS (EXPORT ONLY)
- Symptom: *INTRUSION SENSOR REPEATEDLY TRIGGERS VTSS (EXPORT ONLY)
- Symptom: *OPEN DRIVER DOOR FAILS TO TRIP ALARM
- Symptom: *OPEN LIFTGATE FAILS TO TRIP ALARM
- Symptom: *OPEN PASSENGER DOOR FAILS TO TRIP ALARM
- Symptom: *PARK LAMPS FAIL TO FLASH DURING ALARM
- Symptom List: *VTSS FAILS TO ARM FROM LEFT DOOR CYLINDER LOCK SWITCH (EXPORT ONLY); *VTSS FAILS TO ARM/DISARM FROM LEFT DOOR CYLINDER LOCK SWITCH
- Symptom List: *VTSS FAILS TO ARM FROM LIFTGATE CYLINDER LOCK SWITCH (EXPORT ONLY); *VTSS FAILS TO ARM/DISARM FROM LIFTGATE CYLINDER LOCK SWITCH
- Symptom List: *VTSS FAILS TO ARM FROM RIGHT DOOR CYLINDER LOCK SWITCH (EXPORT ONLY); *VTSS FAILS TO ARM/DISARM FROM RIGHT DOOR CYLINDER LOCK SWITCH
- Symptom: *VTSS INDICATOR FAILS TO FLASH
- Symptom: *VTSS INDICATOR STAYS ON STEADY DURING ARMING
- Symptom: *VTSS SIREN INOPERATIVE (EXPORT ONLY)
- Verifications Tests
- Airbag
- Component Locations
- Connector PINOUTS
- Airbag Control Module (Orc) (Base) - Yellow 23 Way
- Airbag Control Module C1 (Orc) (Premium) - Yellow 32 Way
- Airbag Control Module C2 (Orc) (Premium) - Yellow 32 Way
- Ambient Temperature Sensor (Except 2.4L Base) - Black 2 Way
- Amplifier Audio C1 - 20 Way
- Anti-Lock Brake Module - Black 47 Way
- C203 (Pt27) - LT. Gray (Body Side)
- C203 (Pt27) - LT. Gray (Instrument Panel Side)
- C204 (Pt27) - (Instrument Panel Side)
- C204 (Pt27) - (Left Front Door Side)
- C204 (Pt44 LHP) - Natural (Instrument Panel Side)
- C204 (Pt44 LHP) - Natural (Left Front Door Side)
- C205 (Pt27) - (Instrument Panel Side)
- C205 (Pt27) - (Right Front Door Side)
- C305 - Yellow (Airbag Side)
- C305 - Yellow (UNIBODY Side)
- C306 - Yellow (Airbag Side)
- C306 - Yellow (UNIBODY Side)
- C343 (Pt27) - LT. Gray (DECKLID Jumper Side)
- C343 (Pt27) - LT. Gray (DECKLID Side)
- C349 (Pt27) - Blue (Body Side
- C349 (Pt27) - Blue (DECKLID Jumper Side)
- C362 (Pt27) - LT. Gray (Body Side)
- C362 (Pt27) - LT. Gray (Power Top Side)
- CLOCKSPRING - DK. Green 7 Way
- Compass/Temperature Mirror Module (Pt27) - Black 10 Way
- Data Link Connector - Black 16 Way
- DECKLID Cylinder Unlock Switch (Pt27) - LT. Gray 2 Way
- DECKLID Handle Switch (Pt27) - White 2 Way
- DECKLID Release Motor (Pt27) - Black 3 Way
- DECKLID Release Switch (Pt27) - Black 2 Way
- Dome Lamp - Black 3 Way
- Dome Lamp/Intrusion Sensor (Export) - White 4 Way
- Driver Airbag Squib 1 - Yellow 2 Way
- Driver Door Ajar Switch - Black 2 Way
- Driver Door Handle Switch (Pt27) - 2 Way
- Driver Door Power Lock Motor/Ajar Switch - Black 4 Way
- Driver Rear Window Motor (Pt27) - Black 2 Way
- Driver Seat Belt TENSIONER - Yellow 2 Way
- Driver Window Regulator Module (Pt27) - Black 20 Way
- Engine Control Module C1 (Diesel) - Black 81 Way
- Front Power Window Switch - Black 14 Way
- Fuel Pump Module - LT. Gray 4 Way
- Fuses (FB)
- Hands Free Module C1 - DK. Gray 22 Way
- Hands Free Module C2 (Satellite Radio) - DK. Gray 10 Way
- Hands Free Module C3 - Black 10 Way
- High Note Horn (Export) - Black 2 Way
- Hood Ajar Switch (Export) - Black 2 Way
- Ignition Switch C1 - 10 Way
- Instrument Cluster C1 - Black 26 Way
- Instrument Cluster C2 - Black 10 Way
- Left Cylinder Lock Switch - Black 2 Way
- Left Door Lock Switch - Black 3 Way
- Left Front Power Window Motor (Pt44) - Black 2 Way
- Left Instrument Panel Speaker - Black 2 Way
- Left Rear Speaker (Pt44) - Black 2 Way
- Left Seat Airbag Squib (LHP) - Yellow 2 Way
- Left Seat Airbag Squib (RHD) - Yellow 2 Way
- Left Side Impact Sensor 1 - Gray 2 Way
- Liftgate Ajar Switch - White 2 Way
- Liftgate Cylinder Lock Switch - LT. Gray 2 Way
- Liftgate Handle Switch (Pt44) - Natural 2 Way
- Liftgate Power Lock Motor - Black 4 Way
- Liftgate Release Motor (Pt44) - Black 3 Way
- Low Note Horn - Black 2 Way
- Multi-Function Switch - Gray 20 Way
- Overhead Console Module - Black 12 Way
- Passenger Airbag Squib 1 - Yellow 2 Way
- Passenger Door Ajar Switch - Black 2 Way
- Passenger Door Handle Switch (Pt27) - 2 Way
- Passenger Door Power Lock Motor/Ajar Switch - Black 4 Way
- Passenger Rear Window Motor (Pt27) - Black 2 Way
- Passenger Seat Belt TENSIONER - Yellow 2 Way
- Passenger Window Regulator Module (Pt27) - Black 20 Way
- Fuses (PDC)
- Power Top Motor (Pt27) - 2 Way
- Power Top Relay (Pt27) - Black 6 Way
- Power Top Switch (Pt27) - 3 Way
- Powertrain Control Module (1.6L) - Black 90 Way
- Powertrain Control Module C1 (NGC) - Black/Black 38 Way
- Radio C1 - White 22 Way
- Radio C2 (Hands Free) - DK. Gray 10 Way
- Rear View Mirror C1 - Black 12 Way
- Remote Keyless Entry Module - Black 26 Way
- Right Cylinder Lock Switch (Export) - Black 2 Way
- Right Door Lock Switch - Black 3 Way
- Right Front Door Speaker - 3 Way
- Right Front Power Window Motor (Pt44) - Black 2 Way
- Right Rear Power Window Motor (Pt44) - Black 2 Way
- Right Seat Airbag Squib (LHP) - Yellow 2 Way
- Right Seat Airbag Squib (RHP) - Yellow 2 Way
- Right Side Impact Sensor 1 - Gray 2 Way
- Sentry Key Immobilizer Module - Black 6 Way
- Siren (Export) - Black 4 Way
- Schematic Diagrams
- Interior & Exterior
- Body
- Description
- Warning
- Diagnosis And Testing
- Standard Procedure
- Standard Procedure - Plastic Body Panel Repair
- Notes
- Rigid Plastics:
- Semi-Rigid Plastics:
- Flexible Plastics:
- Repair Procedure:
- Adhesion Promoter/Surface Modifier:
- Safety Precaution And Warnings
- Rigid, Semi-Rigid, And Flexible Plastic Parts Types
- Panel Sectioning
- Panel Reinforcement
- Visual Inspection
- Panel Surface Preparation
- Patching Panels
- Panel Patch Fabrications
- Panel Patch Installation
- Patched Panel Surfacing
- Standard Procedure - Heat Staking
- Standard Procedure - Plastic Body Panel Repair
- Specifications
- Special Tools
- Convertible Top
- DECKLID - Pt-27
- Door - Front
- Front Door Applique
- Front Door Check Strap
- Front Door
- Front Door Glass
- Removal
- Installation
- Adjustment - Pt-27 Only
- Front Door Adjustment
- Quarter Glass Adjustment
- Notes
- Up-Stop Adjustments
- Bottom Of Glass - Inboard/Outboard Adjustments
- Top Of Glass - Inboard/Outboard Adjustments
- Glass - Front/Rear Adjustment
- Quarter Glass Alignment Verification
- Condition - Height Mismatch Between Door Glass And Quarter Glass With Top Down
- Condition - Door Glass Noise Along A-Pillar When Closing Door And/Or Door Glass Touching Quarter Glass Metal Seal Retainer And/Or Wind Noise/Water Leak Along Quarter Glass Seal.
- Condition - Door Glass Not Driving Into The Top In Full Up Position
- Condition - Quarter Glass Not Driving Into The Top In Full Up Position
- Condition - Slapping Noise Between The Door And Quarter Glass With The Top Down During Driving Of The Vehicle
- Condition - Non-Parallel Gap Between Door And Quarter Glasses
- Condition - Quarter Glass Seal Fold Over During Travel With Door Glass Full Up And Top Up Or Down
- Condition - Intermediate Rear Of Door Glass Not Driving Into The Top Seal And/Or Noise At Rear Bottom Of The Door
- Front Door Outside Handle
- Front Door Hinge
- Front Door Inside Handle Actuator
- Front Door Latch
- Front Door Latch Striker
- Front Door Lock Cylinder
- Front Door Vertical Guide Bar
- Front Door Side View Mirror Flag - Pt-27
- Front Door Trim Panel
- Front Door Water Dam
- Front Door Window Regulator
- Door Glass Inner Belt Stabilizer - Pt-27
- Rear Rail Assembly - Pt-27
- Door - Rear
- Exterior
- Body Side Moldings
- Cowl Grille Screen
- Deck Upper Belt Molding - Pt-27
- Engine Compartment Lower Silencer
- Exterior Name Plates
- Front Fender
- Front Side Rail Access Pulley Splash Shield
- Front Wheelhouse Splash Shields
- Fuel Fill Door
- Grille
- Header Molding - Pt-27
- Luggage Rack Crossbar
- Luggage Rack Side Rail
- Radiator Closure Panel
- Side View Mirror
- Side View Mirror Glass
- Windshield A-Pillar Trim Molding - Pt-27
- Wood Grain/Flame Decals
- Grille - Lower Radiator
- Hood
- Instrument Panel
- Interior
- A-Pillar Trim
- B-Pillar Trim
- Body Vent
- DECKLID Sill Scuff Plate
- Door Sill Trim
- Floor Carpet
- Cargo Area Floor Carpet - Pt-27
- Front Floor Carpet Right/Left Side -Pt-27
- Rear Carpet - Pt-27
- Upper D-Pillar Trim
- Header Latch Retainer - Pt-27
- Headliner
- Inside Rear View Mirror
- Lower Quarter Trim Panel
- Rear Quarter Panel Trim - Pt-27
- Seat Back Support Bracket - Pt-27
- Side Cowl Trim Panel
- Sport Bar - Pt-27
- Sport Bar Inner Covers - Pt-27
- Sport Bar Outer Cover - Pt-27
- Sun Visor
- Trunk Trim Panel - Pt-27
- Trunk Welt - Pt-27
- Upper C-Pillar Trim
- Windshield Header Molding -Pt-27
- Liftgate
- Paint
- Quarter Glass - Pt-27
- Seats
- Child Seat Tether Anchor Bezel
- Front Seat
- Front Seat Back - With Front Seat Back Panel
- Front Seat Back
- Front Seat Back Cover/Foam
- Front Seat Back Cover - Without Front Seat Back Panel
- Front Seat Cushion
- Front Seat Cushion Cover
- Headrest - Front/Rear
- Rear Seat
- Rear Seat Back
- Rear Seat Back Cover/Foam
- Rear Seat Back Cushion Cover/Foam - Pt-27
- Rear Seat Bolster - Pt-27
- Rear Seat Bolster Cover - Pt-27
- Rear Seat Cushion
- Rear Seat Back Cushion / Cover
- Rear Seat Latch Cover
- Under Seat Storage Bin
- Stationary Glass
- Sunroof
- Weatherstrip/Seals
- A-Pillar Weatherstrip Retainer - Pt-27
- Deck Lid Opening Weatherstrip - Pt-27
- Front And Rear Door Opening Weatherstrip
- Front And Rear Door Upper Secondary Weatherstrip
- Front Door Glass Run Weatherstrip
- Front Door Inner Belt Weatherstrip
- Front Door Outer Belt Weatherstrip
- Header Weatherstrip Seal Retainer - Pt-27
- Liftgate Weatherstrip
- Quarter Panel Outer Belt Weatherstrip - Pt-27
- Rear Door Glass Run Weatherstrip
- Rear Door Inner Belt Weatherstrip
- Sill Secondary Weatherstrip
- Header / A-Pillar Weatherstrip -Pt-27
- Front Door Sill Weatherstrip - Pt-27
- Body Structure
- Body
- Power Windows
- Body Diagnostic Procedures
- Body, Cab Control Systems
- Brakes
- Anti-Lock Brakes
- Anti-Lock Brake System
- Brakes - Abs
- Front Wheel Speed Sensor
- Rear Wheel Speed Sensor
- Tone Wheel
- Traction Control Switch
- Hydraulic Control Unit (HCU)
- Description
- Operation
- Operation - Hydraulic Circuits And Valves
- Notes
- Normal Braking Hydraulic Circuit And Solenoid Valve Function (Abs Without Traction Control)
- Abs Hydraulic Circuit And Solenoid Valve Function (Abs Without Traction Control)
- Normal Braking Hydraulic Circuit, Solenoid Valve, And Shuttle Valve Function (Abs With Traction Control)
- Abs Braking Hydraulic Circuit, Solenoid Valve, And Shuttle Valve Function (Abs With Traction Control)
- Abs Traction Control Hydraulic Circuit, Solenoid Valve, And Shuttle Valve Function (Abs With Traction Control)
- Operation - Hydraulic Circuits And Valves
- Integrated Control Unit (ICU) - MK20E
- Integrated Control Unit (ICU) - MK25E
- Chassis Diagnostic Procedures - Anti-Lock Brake System
- Introduction
- Identification Of System
- System Description And Functional Operation
- Disclaimers, Safety, Warnings
- Required Tools And Equipment
- Glossary Of Terms
- Diagnostic Information And Procedures
- Brakes (25E) - Symptoms
- Symptom: ABM INTERNAL
- Symptom: BATTERY VOLTAGE OUT OF RANGE
- Symptom: BCM MESSAGES NOT RECEIVED
- Symptom: INSTRUMENT CLUSTER BULB
- Symptom List: LEFT FRONT WHEEL SPEED SENSOR CIRCUIT; LEFT REAR WHEEL SPEED SENSOR CIRCUIT; RIGHT FRONT WHEEL SPEED SENSOR CIRCUIT; RIGHT REAR WHEEL SPEED SENSOR CIRCUIT
- Symptom List: LEFT FRONT WHEEL SPEED SENSOR SIGNAL; LEFT REAR WHEEL SPEED SENSOR SIGNAL; RIGHT FRONT WHEEL SPEED SENSOR SIGNAL; RIGHT REAR WHEEL SPEED SENSOR SIGNAL
- Symptom: MIC MESSAGES NOT RECEIVED
- Symptom: PCI BUS COMMUNICATION
- Symptom: PCI BUS LOOPBACK
- Symptom: PCI BUS SHORTED TO GROUND
- Symptom: PCI BUS SHORTED TO VOLTAGE
- Symptom: PCI HARDWARE
- Symptom: PCM MESSAGES NOT RECEIVED
- Symptom: PUMP MOTOR CIRCUIT
- Symptom: TCM MESSAGES NOT RECEIVED
- Verification Tests
- Brakes (25E) - Symptoms
- Component Locations
- Connector PINOUTS
- Anti-Lock Brake Module - Black 47 Way
- Brake Lamp Switch (Diesel) - Gray 6 Way
- Brake Lamp Switch (Gas) - Gray 6 Way
- Fuses (FB)
- Fuses (PDC)
- Left Front Wheel Speed Sensor - Gray 2 Way
- Left Rear Wheel Speed Sensor - Gray 2 Way
- Right Front Wheel Speed Sensor - Gray 2 Way
- Right Rear Wheel Speed Sensor - Gray 2 Way
- Traction Control Switch - 4 Way
- Schematic Diagrams
- Anti-Lock Brake System
- Mechanical - Hydraulic
- Mechanical Brake System - Base (Service Information)
- Brakes - Base
- Brake Fluid Level Switch
- Hydraulic/Mechanical
- Brake Lines
- Brake Pads/Shoes - Front
- Brake Pads/Shoes - Rear Disc
- Brake Pads/Shoes - Rear Drum
- Disc Brake Caliper - Front
- Disc Brake Caliper - Rear
- Disc Brake Caliper Adapter - Front
- Disc Brake Caliper Guide Pins
- Drum
- Fluid
- Fluid Reservoir
- Master Cylinder
- Pedal - With Automatic Transaxle
- Pedal - With Manual Transaxle
- Power Brake Booster
- Proportioning Valve
- Rotor
- Support Plate - Drum Brakes
- Wheel Cylinder - Drum Brake
- Parking Brake
- Cable - Parking Brake
- Lever - Parking Brake
- Shoes - Parking Brake
- Mechanical Brake System - Base (Service Information)
- Parking Brake System
- Mechanical Brake System - Base (Service Information)
- Brakes - Base
- Brake Fluid Level Switch
- Hydraulic/Mechanical
- Brake Lines
- Brake Pads/Shoes - Front
- Brake Pads/Shoes - Rear Disc
- Brake Pads/Shoes - Rear Drum
- Disc Brake Caliper - Front
- Disc Brake Caliper - Rear
- Disc Brake Caliper Adapter - Front
- Disc Brake Caliper Guide Pins
- Drum
- Fluid
- Fluid Reservoir
- Master Cylinder
- Pedal - With Automatic Transaxle
- Pedal - With Manual Transaxle
- Power Brake Booster
- Proportioning Valve
- Rotor
- Support Plate - Drum Brakes
- Wheel Cylinder - Drum Brake
- Parking Brake
- Cable - Parking Brake
- Lever - Parking Brake
- Shoes - Parking Brake
- Mechanical Brake System - Base (Service Information)
- Traction Control
- Anti-Lock Brake System
- Brakes - Abs
- Front Wheel Speed Sensor
- Rear Wheel Speed Sensor
- Tone Wheel
- Traction Control Switch
- Hydraulic Control Unit (HCU)
- Description
- Operation
- Operation - Hydraulic Circuits And Valves
- Notes
- Normal Braking Hydraulic Circuit And Solenoid Valve Function (Abs Without Traction Control)
- Abs Hydraulic Circuit And Solenoid Valve Function (Abs Without Traction Control)
- Normal Braking Hydraulic Circuit, Solenoid Valve, And Shuttle Valve Function (Abs With Traction Control)
- Abs Braking Hydraulic Circuit, Solenoid Valve, And Shuttle Valve Function (Abs With Traction Control)
- Abs Traction Control Hydraulic Circuit, Solenoid Valve, And Shuttle Valve Function (Abs With Traction Control)
- Operation - Hydraulic Circuits And Valves
- Integrated Control Unit (ICU) - MK20E
- Integrated Control Unit (ICU) - MK25E
- Chassis Diagnostic Procedures - Anti-Lock Brake System
- Introduction
- Identification Of System
- System Description And Functional Operation
- Disclaimers, Safety, Warnings
- Required Tools And Equipment
- Glossary Of Terms
- Diagnostic Information And Procedures
- Brakes (25E) - Symptoms
- Symptom: ABM INTERNAL
- Symptom: BATTERY VOLTAGE OUT OF RANGE
- Symptom: BCM MESSAGES NOT RECEIVED
- Symptom: INSTRUMENT CLUSTER BULB
- Symptom List: LEFT FRONT WHEEL SPEED SENSOR CIRCUIT; LEFT REAR WHEEL SPEED SENSOR CIRCUIT; RIGHT FRONT WHEEL SPEED SENSOR CIRCUIT; RIGHT REAR WHEEL SPEED SENSOR CIRCUIT
- Symptom List: LEFT FRONT WHEEL SPEED SENSOR SIGNAL; LEFT REAR WHEEL SPEED SENSOR SIGNAL; RIGHT FRONT WHEEL SPEED SENSOR SIGNAL; RIGHT REAR WHEEL SPEED SENSOR SIGNAL
- Symptom: MIC MESSAGES NOT RECEIVED
- Symptom: PCI BUS COMMUNICATION
- Symptom: PCI BUS LOOPBACK
- Symptom: PCI BUS SHORTED TO GROUND
- Symptom: PCI BUS SHORTED TO VOLTAGE
- Symptom: PCI HARDWARE
- Symptom: PCM MESSAGES NOT RECEIVED
- Symptom: PUMP MOTOR CIRCUIT
- Symptom: TCM MESSAGES NOT RECEIVED
- Verification Tests
- Brakes (25E) - Symptoms
- Component Locations
- Connector PINOUTS
- Anti-Lock Brake Module - Black 47 Way
- Brake Lamp Switch (Diesel) - Gray 6 Way
- Brake Lamp Switch (Gas) - Gray 6 Way
- Fuses (FB)
- Fuses (PDC)
- Left Front Wheel Speed Sensor - Gray 2 Way
- Left Rear Wheel Speed Sensor - Gray 2 Way
- Right Front Wheel Speed Sensor - Gray 2 Way
- Right Rear Wheel Speed Sensor - Gray 2 Way
- Traction Control Switch - 4 Way
- Schematic Diagrams
- Anti-Lock Brake System
- Anti-Lock Brakes
- Drivelines & Axles
- Axle Shafts
- Differentials & Drive Axles
- Electrical
- Body Electrical
- Connector & Ground & Splice Location
- Connector End Views
- Connector Pin-Outs
- A/C Compressor Clutch (Diesel) Connector End View
- A/C Compressor Clutch (Gas) Connector End View
- A/C High Pressure Switch (Diesel) Connector End View
- A/C Low Pressure Switch Connector End View
- A/C Pressure Transducer Connector End View
- A/C Heater Control Switch Connector End View
- Accelerator Pedal Position Sensor (1.6L/Diesel) Connector End View
- Airbag Control Module (Occupant Restraint Control) (Base) Connector End View
- Airbag Control Module (Occupant Restraint Control) (Premium) Connector End View (C1)
- Airbag Control Module (Occupant Restraint Control) (Premium) Connector End View (C2)
- Ambient Temperature Sensor (Except 2.4L Base) Connector End View
- Ambient Temperature Sensor (NGC) Connector End View
- Audio Amplifier Connector End View (C1)
- Audio Amplifier Connector End View (C2)
- Antilock Brakes Module Connector End View
- Autostick Switch Connector End View
- Backup Lamp Switch (M/T Diesel) Connector End View
- Backup Lamp Switch (M/T Gas) Connector End View
- Battery Temperature Sensor (Diesel) Connector End View
- Blower Motor Connector End View
- Blower Motor Resistor Block Connector End View
- Boost Pressure Sensor (Diesel) Connector End View
- Brake Lamp Switch (Diesel) Connector End View
- Brake Lamp Switch (Gas) Connector End View
- Brake Transmission Shift Interlock Solenoid (EATX) Connector End View
- Brake Warning Indicator Switch Connector End View
- Engine Side Inline (2.4L) Connector End View (C102)
- Headlamp And Dash Side Inline (2.4L) Connector End View (C102)
- Engine Side Inline (2.4L Except Turbo) Connector End View (C103)
- Injector Harness Side Inline (2.4L Except Turbo) Connector End View (C103)
- Engine Side Inline (2.4L Turbo) Connector End View (C103)
- Injector Harness Side Inline (2.4L Turbo) Connector End View (C103)
- Inline (Headlamp And Dash Side) Connector End View (C105)
- Inline (Instrument Panel Side) Connector End View (C105)
- Inline (Headlamp And Dash Side) Connector End View (C106)
- Inline (Instrument Panel Side) Connector End View (C106)
- Headlamp And Dash Side Inline (Export) Connector End View (C107)
- Headlamp Leveling Side Inline (Export) Connector End View (C107)
- Headlamp And Dash Side Inline (Export) Connector End View (C108)
- Headlamp Leveling Side Inline (Export) Connector End View (C108)
- Headlamp And Dash Side Inline Connector End View (C110)
- Underbody Side Inline Connector End View (C110)
- Headlamp And Dash Side Inline (Except Antilock Brake System) Connector End View (C110)
- Underbody Side Inline (Except Antilock Brake System) Connector End View (C110)
- Engine Side Inline (1.6L) Connector End View (C111)
- Headlamp And Dash Side Inline (1.6L) Connector End View (C111)
- Engine Side Inline (1.6L) Connector End View (C112)
- Headlamp And Dash Side Inline (1.6L) Connector End View (C112)
- Engine Side Inline (1.6L) Connector End View (C114)
- Headlamp And Dash Side Inline (1.6L) Connector End View (C114)
- Engine Side Inline (Diesel) Connector End View (C121)
- Headlamp And Dash Side Inline (Diesel) Connector End View (C121)
- Engine Side Inline (Diesel) Connector End View (C122)
- Headlamp And Dash Side Inline (Diesel) Connector End View (C122)
- Engine Side Inline (Diesel) Connector End View (C124)
- Headlamp And Dash Side Inline (Diesel) Connector End View (C124)
- Headlamp And Dash Side Inline (Diesel) Connector End View (C125)
- Engine Side Inline (Diesel) Connector End View (C125)
- Cabin Heater Side Inline (Diesel) Connector End View (C126)
- Headlamp And Dash Side Inline (Diesel) Connector End View (C126)
- Battery Side Inline (Diesel) Connector End View (C127)
- Headlamp And Dash Side Inline (Diesel) Connector End View (C127)
- Headlamp And Dash Side Inline (Diesel) Connector End View (C128)
- Junction Post Side Inline (Diesel) Connector End View (C128)
- Instrument Panel Side Inline (Except Hands Free) Connector End View (C200)
- Left Headliner Jumper Side Inline (Except Hands Free) Connector End View (C200)
- Instrument Panel Side Inline (Hands Free) Connector End View (C200)
- Left Headliner Jumper Side Inline (Hands Free) Connector End View (C200)
- Instrument Panel Side Inline (Except Hands Free) Connector End View (C201)
- Right Headliner Jumper Side Inline (Except Hands Free) Connector End View (C201)
- Instrument Panel Side Inline (Hands Free) Connector End View (C201)
- Right Headliner Jumper Side Inline (Hands Free) Connector End View (C201)
- Instrument Panel Side Inline (LHD) Connector End View (C202)
- Left Body Side Inline (LHD) Connector End View (C202)
- Instrument Panel Side Inline (RHD) Connector End View (C202)
- Left Body Side Inline (RHD) Connector End View (C202)
- Body Side Inline (Convertible) Connector End View (C203)
- Instrument Panel Side Inline (Convertible) Connector End View (C203)
- Instrument Panel Side Inline (Hatchback) Connector End View (C203)
- Right Body Side Inline (Hatchback) Connector End View (C203)
- Instrument Panel Side Inline (Convertible) Connector End View (C204)
- Left Front Door Side Inline (Convertible) Connector End View (C204)
- Instrument Panel Side Inline (Hatchback RHD) Connector End View (C204)
- Left Front Door Side Inline (Hatchback RHD) Connector End View (C204)
- Instrument Panel Side Inline (Hatchback LHD) Connector End View (C204)
- Left Front Door Side Inline (Hatchback LHD) Connector End View (C204)
- Instrument Panel Side Inline (Hatchback LHD) Connector End View (C205)
- Right Front Door Side Inline (Hatchback LHD) Connector End View (C205)
- Instrument Panel Side Inline (Convertible) Connector End View (C205)
- Right Front Door Side Inline (Convertible) Connector End View (C205)
- Instrument Panel Side Inline (Hatchback RHD) Connector End View (C205)
- Right Front Door Side Inline (Hatchback RHD) Connector End View (C205)
- Dome Lamp Side Inline (Except Hands Free) Connector End View (C207)
- Right Headliner Jumper Side Inline (Except Hands Free) Connector End View (C207)
- Dome Lamp Side Inline (Hands Free) Connector End View (C207)
- Right Headliner Jumper Side Inline (Hands Free) Connector End View (C207)
- Dome Lamp Side Inline (Except Hands Free) Connector End View (C208)
- Left Headliner Jumper Side Inline (Except Hands Free) Connector End View (C208)
- Dome Lamp Side Inline (Hands Free) Connector End View (C208)
- Left Headliner Jumper Side Inline (Hands Free) Connector End View (C208)
- Inline (Heater Jumper Side) Connector End View (C209)
- Inline (Instrument Panel Side) Connector End View (C209)
- Dome Lamp Side Inline (Power Sunroof) Connector End View (C211)
- Sunroof Side Inline (Power Sunroof) Connector End View (C211)
- Unibody Side Inline (Satellite Radio) Connector End View (C212)
- Instrument Panel Side Inline (Satellite Radio) Connector End View (C212)
- Inline (Left Body Side) Connector End View (C300)
- Inline (Left Rear Door Side) Connector End View (C300)
- Inline (Right Body Side) Connector End View (C301)
- Inline (Right Rear Door Side) Connector End View (C301)
- Left Body Side Inline (Hatchback) Connector End View (C302)
- Liftgate Side Inline (Hatchback) Connector End View (C302)
- Inline (Left Body Side) Connector End View (C303)
- Inline (Rear Fascia Side) Connector End View (C303)
- Inline (Fuel Tank Side) Connector End View (C304)
- Underbody Side Inline Connector End View (C304)
- Airbag Side Inline Connector End View (C305)
- Unibody Side Inline Connector End View (C305)
- Airbag Side Inline Connector End View (C306)
- Unibody Side Inline Connector End View (C306)
- Inline (Passenger Seat Side) Connector End View (C307)
- Unibody Side Inline Connector End View (C307)
- Driver Seat Side Inline Connector End View (C308)
- Unibody Side Inline Connector End View (C308)
- Decklid Jumper Side Inline (Convertible) Connector End View (C343)
- Decklid Side Inline (Convertible) Connector End View (C343)
- Body Side Inline (Convertible) Connector End View (C349)
- Decklid Jumper Side Inline (Convertible) Connector End View (C349)
- Body Side Inline (Convertible) Connector End View (C362)
- Power Top Side Inline (Convertible) Connector End View (C362)
- Camshaft Position Sensor (Diesel) Connector End View
- Camshaft Position Sensor (Gas) Connector End View
- Cargo Lamp Connector End View
- Center High Mounted Stop Lamp (Convertible) Connector End View
- Center High Mounted Stop Lamp (Hatchback) Connector End View
- Center Stack Lamp Connector End View
- Cigar Lighter Connector End View
- Clockspring Connector End View
- Clutch Pedal Position Up Switch Connector End View
- Compass/Temperature Mirror Module (Convertible) Connector End View
- Crankshaft Position Sensor (Diesel) Connector End View
- Crankshaft Position Sensor (Gas) Connector End View
- Data Link Connector, Connector End View
- Decklid Cylinder Unlock Switch (Vehicle Theft Security System) (Convertible) Connector End View
- Decklid Handle Switch (Convertible) Connector End View
- Decklid Release Motor (Convertible) Connector End View
- Decklid Release Switch (Convertible) Connector End View
- Dome Lamp Connector End View
- Dome Lamp Intrusion Sensor (Export) Connector End View
- Driver Airbag Squib 1 Connector End View
- Driver Door Ajar Switch Connector End View
- Driver Door Handle Switch (Convertible) Connector End View
- Driver Door Power Lock Motor Ajar Switch Connector End View
- Driver Heated Seat Cushion Connector End View
- Driver Heated Seat Switch Connector End View
- Driver Rear Window Motor (Convertible) Connector End View
- Driver Seat Belt Switch Connector End View
- Driver Seat Belt Tensioner Connector End View
- Driver Window Regulator Module (Convertible) Connector End View
- EGR Solenoid (Diesel) Connector End View
- Electronic Throttle Control Module (1.6L) Connector End View
- Engine Control Module (Diesel) Connector End View (C1)
- Engine Control Module (Diesel) Connector End View (C2)
- Engine Coolant Temperature Sensor (Diesel) Connector End View
- Engine Coolant Temperature Sensor (Gas) Connector End View
- Engine Oil Pressure Switch Connector End View
- EVAP Purge Solenoid (Gas) Connector End View
- Front Power Window Switch Connector End View
- Front Washer Pump Motor Connector End View
- Front Wiper Motor Connector End View
- Front Wiper Switch/Washer Switch Connector End View
- Fuel Heater Module (Diesel) Connector End View
- Fuel Injector 1 (Diesel) Connector End View
- Fuel Injector 1 (Gas) Connector End View
- Fuel Injector 2 (Diesel) Connector End View
- Fuel Injector 2 (Gas) Connector End View
- Fuel Injector 3 (Diesel) Connector End View
- Fuel Injector 3 (Gas) Connector End View
- Fuel Injector 4 (Diesel) Connector End View
- Fuel Injector 4 (Gas) Connector End View
- Fuel Pressure Sensor (Diesel) Connector End View
- Fuel Pressure Solenoid (Diesel) Connector End View
- Fuel Pump Module Connector End View
- Generator (2.4L Turbo) Connector End View
- Generator (Diesel) Connector End View
- Generator (Gas Except 2.4L Turbo) Connector End View
- Hands Free Module Connector End View (C1)
- Hands Free Module (Satellite Radio) Connector End View (C2)
- Hands Free Module Connector End View (C3)
- Headlamp Leveling Switch (Export) Connector End View
- Heated Seat Module Connector End View
- High Note Horn (Export) Connector End View
- Hood Ajar Switch (Export) Connector End View
- Idle Air Control Motor (2.4L) Connector End View
- Ignition Coil (Gas) Connector End View
- Ignition Switch Connector End View (C1)
- Ignition Switch (Autostick) Connector End View (C2)
- Inlet Air Temperature Sensor (Gas) Connector End View
- Input Speed Sensor Connector End View
- Instrument Cluster Connector End View (C1)
- Instrument Cluster Connector End View (C2)
- Intake Air Temperature Sensor (Diesel) Connector End View
- Knock Sensor (Gas) Connector End View
- Left Backup Lamp Connector End View
- Left City Lamp (Export) Connector End View
- Left Cylinder Lock Switch Connector End View
- Left Dome Lamp (Convertible) Connector End View
- Left Door Lock Switch Connector End View
- Left Fog Lamp Connector End View
- Left Front Door Speaker Connector End View
- Left Front Park Turn Signal Lamp (Except Export) Connector End View
- Left Front Power Window Motor (Hatchback) Connector End View
- Left Front Side Marker (Export) Connector End View
- Left Front Turn Signal Lamp (Export) Connector End View
- Left Front Wheel Speed Sensor Connector End View
- Left Headlamp Leveling Module (Export) Connector End View
- Left High Beam Headlamp Connector End View
- Left Instrument Panel Speaker Connector End View
- Left License Lamp (Export) Connector End View
- Left Low Beam Headlamp Connector End View
- Left Power Mirror (Except Export) Connector End View
- Left Power Mirror (Export) Connector End View
- Left Rear Door Power Lock Motor Connector End View
- Left Rear Fog Lamp (LHD Export) Connector End View
- Left Rear Power Window Motor (Hatchback) Connector End View
- Left Rear Power Window Switch Connector End View
- Left Rear Speaker (Convertible Base) Connector End View
- Left Rear Speaker (Hatchback) Connector End View
- Left Rear Speaker (Convertible Premium) Connector End View (C1)
- Left Rear Speaker (Convertible Premium) Connector End View (C2)
- Left Rear Turn Signal Lamp Connector End View
- Left Rear Wheel Speed Sensor Connector End View
- Left Seat Airbag Squib (LHD) Connector End View
- Left Seat Airbag Squib (RHD) Connector End View
- Left Side Impact Sensor 1 Connector End View
- Left Tail Stop Lamp Connector End View
- Left Turn Signal Indicator Connector End View
- Left Visor Lamp/Vanity Lamp (Except Base) Connector End View
- License Lamp (Except Export) Connector End View
- Liftgate Ajar Switch Connector End View
- Liftgate Cylinder Lock Switch Connector End View
- Liftgate Handle Switch (Hatchback) Connector End View
- Liftgate Power Lock Motor Connector End View
- Liftgate Release Motor (Hatchback) Connector End View
- Low Note Horn Connector End View
- Manifold Absolute Pressure Sensor (Gas) Connector End View
- Map/Reading Lamps Connector End View
- Mass Air Flow Sensor (Diesel) Connector End View
- Multifunction Switch Connector End View
- Natural Vacuum Leak Detection Assembly (Except Export) Connector End View
- Output Speed Sensor Connector End View
- Overhead Console Module Connector End View
- Upstream Oxygen Sensor 1/1 (Gas) Connector End View
- Downstream Oxygen Sensor 1/2 (Gas) Connector End View
- Passenger Airbag Squib 1 Connector End View
- Passenger Door Ajar Switch Connector End View
- Passenger Door Handle Switch (Convertible) Connector End View
- Passenger Door Power Lock Motor Ajar Switch Connector End View
- Passenger Heated Seat Cushion Connector End View
- Passenger Heated Seat Switch Connector End View
- Passenger Rear Window Motor (Convertible) Connector End View
- Passenger Seat Belt Tensioner Connector End View
- Passenger Window Regulator Module (Convertible) Connector End View
- Positive Crankcase Ventilation Heater (Diesel) Connector End View
- Power Mirror Switch (LHD) Connector End View
- Power Mirror Switch (RHD) Connector End View
- Power Outlet Connector End View
- Power Seat Motor Connector End View
- Power Seat Switch Connector End View
- Power Steering Pressure Switch (Gas) Connector End View
- Power Sunroof Module Connector End View (C1)
- Power Sunroof Module Connector End View (C2)
- Power Top Motor (Convertible) Connector End View
- Power Top Relay (Convertible) Connector End View
- Power Top Switch (Convertible) Connector End View
- Powertrain Control Module (1.6L) Connector End View
- Powertrain Control Module (NGC) Connector End View (C1)
- Powertrain Control Module (NGC) Connector End View (C2)
- Powertrain Control Module (NGC) Connector End View (C3)
- Powertrain Control Module (NGC) Connector End View (C4)
- Radiator Fan Motor (2.4L Turbo) Connector End View
- Radiator Fan Motor (Except 2.4L Turbo) Connector End View
- Radio Connector End View (C1)
- Radio (Hands Free) Connector End View (C2)
- Radio (Satellite Radio) Connector End View (C2)
- Rear Power Outlet (Except Base) Connector End View
- Rear View Mirror Connector End View (C1)
- Rear View Mirror Connector End View (C2)
- Rear Window Defogger Switch Connector End View
- Rear Wiper Motor (Hatchback) Connector End View
- Rear Wiper Switch (Hatchback) Connector End View
- Remote Keyless Entry Module Connector End View
- Right Backup Lamp Connector End View
- Right City Lamp (Export) Connector End View
- Right Cylinder Lock Switch (Export) Connector End View
- Right Dome Lamp (Convertible) Connector End View
- Right Door Lock Switch Connector End View
- Right Fog Lamp Connector End View
- Right Front Door Speaker Connector End View
- Right Front Park Turn Signal Lamp (Except Export) Connector End View
- Right Front Power Window Motor (Hatchback) Connector End View
- Right Front Side Marker (Export) Connector End View
- Right Front Turn Signal Lamp (Export) Connector End View
- Right Front Wheel Speed Sensor Connector End View
- Right Headlamp Leveling Module (Export) Connector End View
- Right High Beam Headlamp Connector End View
- Right Instrument Panel Speaker Connector End View
- Right License Lamp (Export) Connector End View
- Right Low Beam Headlamp Connector End View
- Right Power Mirror (Except Export) Connector End View
- Right Power Mirror (Export) Connector End View
- Right Rear Door Power Lock Motor Connector End View
- Right Rear Fog Lamp (RHD) Connector End View
- Right Rear Power Window Motor (Hatchback) Connector End View
- Right Rear Power Window Switch Connector End View
- Right Rear Speaker (Convertible Base) Connector End View
- Right Rear Speaker (Hatchback) Connector End View
- Right Rear Speaker (Convertible Premium) Connector End View (C1)
- Right Rear Speaker (Convertible Premium) Connector End View (C2)
- Right Rear Turn Signal Lamp Connector End View
- Right Rear Wheel Speed Sensor Connector End View
- Right Seat Airbag Squib (LHD) Connector End View
- Right Seat Airbag Squib (RHD) Connector End View
- Right Side Impact Sensor 1 Connector End View
- Right Tail Stop Lamp Connector End View
- Right Turn Signal Indicator Connector End View
- Right Visor Lamp/Vanity Lamp (Except Base) Connector End View
- Satellite Radio Receiver Connector End View
- Sentry Key Immobilizer Module Connector End View
- Siren (Export) Connector End View
- Speed Control Servo (2.4L) Connector End View
- Speed Control Switch Connector End View
- Sunroof Motor Connector End View
- Surge Solenoid (2.4L Turbo) Connector End View
- Swirl Solenoid (Diesel) Connector End View
- Throttle Inlet Pressure Sensor (2.4L Turbo) Connector End View
- Throttle Inlet Pressure Solenoid (2.4L Turbo) Connector End View
- Throttle Position Sensor (2.4L) Connector End View
- Traction Control Switch Connector End View
- Transmission Range Indicator Illumination (PRNDL) (Autostick) Connector End View
- Transmission Range Indicator Illumination (PRNDL) (Except Autostick) Connector End View
- Transmission Range Sensor (2.4L) Connector End View
- Transmission Solenoid Pressure Switch Assembly (2.4L) Connector End View
- Vehicle Speed Sensor (Diesel) Connector End View
- Vehicle Speed Sensor (Gas M/T) Connector End View
- Wastegate Solenoid (2.4L Turbo) Connector End View
- Wastegate Solenoid (Diesel) Connector End View
- Connector Pin-Outs
- Power Distribution
- Charging Systems
- Battery System
- Battery System
- Battery
- Description
- Operation
- Diagnosis And Testing
- Standard Procedure
- Removal
- Installation
- Battery HOLDDOWN
- Battery Cables
- Battery Tray
- Battery Thermal Guard
- Battery Tray Support Bracket
- Charging System
- Battery System
- Component Locations
- Fuses & Circuit Breakers
- Gauges
- Body Diagnostic Procedures
- Introduction
- Identification Of System
- System Description And Functional Operation
- Notes
- Airbag System
- Audio System
- Compass/Temperature Module (CTM)
- Compass/Temperature Mirror
- Description
- Operation
- English / Metric / Off Mode
- Calibration / Zone Mode
- Setting Compass Zone
- First Time Calibration
- Manual Calibration
- Continuous Calibration
- Self-Check Diagnostic
- Outside Temperature
- Temperature Update - Warm
- Temperature Update - Cold
- Extreme Temperature / Open Or Short Condition
- Ambient Temperature Sensor
- Ambient Temperature Sensor Diagnostics
- Instrument Cluster
- Remote Keyless Entry Module
- Sentry Key Immobilizer System (Skis)
- Communication
- Telecommunications
- Window Regulator Modules (Pt27 Only)
- Using The DRBIII®
- Disclaimers, Safety, Warnings
- Required Tools And Equipment
- Glossary Of Terms
- Diagnostic Information And Procedures
- Airbag
- Symptom List: ACCELEROMETER 1; INTERNAL 1; INTERNAL 2; INTERNAL 3; INTERNAL 4' OUTPUT DRIVER 1; OUTPUT DRIVER 2; STORED ENERGY FIRING 1
- Symptom List: AIRBAG WARNING INDICATOR DRIVER; AIRBAG WARNING INDICATOR OPEN; AIRBAG WARNING INDICATOR SHORT
- Symptom: CALIBRATION MISMATCH
- Symptom: CLUSTER MESSAGE MISMATCH
- Symptom: DRIVER SEAT BELT TENSIONER CIRCUIT OPEN
- Symptom: DRIVER SEAT BELT TENSIONER CIRCUIT SHORT
- Symptom: DRIVER SEAT BELT TENSIONER SHORT TO BATTERY
- Symptom: DRIVER SEAT BELT TENSIONER SHORT TO GROUND
- Symptom: DRIVER SQUIB 1 CIRCUIT OPEN
- Symptom: DRIVER SQUIB 1 CIRCUIT SHORT
- Symptom: DRIVER SQUIB 1 SHORT TO BATTERY
- Symptom: DRIVER SQUIB 1 SHORT TO GROUND
- Symptom: LEFT CURTAIN OR SEAT SQUIB CIRCUIT OPEN
- Symptom: LEFT CURTAIN OR SEAT SQUIB CIRCUIT SHORT
- Symptom: LEFT CURTAIN OR SEAT SQUIB SHORT TO BATTERY
- Symptom: LEFT CURTAIN OR SEAT SQUIB SHORT TO GROUND
- Symptom: LEFT SIDE IMPACT SENSOR 1 INTERNAL 1
- Symptom: LOSS OF IGNITION RUN - START
- Symptom: LOSS OF IGNITION RUN ONLY
- Symptom: NO CLUSTER MESSAGE
- Symptom: NO LEFT SIDE IMPACT SENSOR 1 COMMUNICATION
- Symptom: NO ODOMETER MESSAGE
- Symptom: NO PCI TRANSMISSION
- Symptom: NO RIGHT SIDE IMPACT SENSOR 1 COMMUNICATION
- Symptom: PASSENGER SEAT BELT TENSIONER CIRCUIT OPEN
- Symptom: PASSENGER SEAT BELT TENSIONER CIRCUIT SHORT
- Symptom: PASSENGER SEAT BELT TENSIONER SHORT TO BATTERY
- Symptom: PASSENGER SEAT BELT TENSIONER SHORT TO GROUND
- Symptom: PASSENGER SQUIB 1 CIRCUIT OPEN
- Symptom: PASSENGER SQUIB 1 CIRCUIT SHORT
- Symptom: PASSENGER SQUIB 1 SHORT TO BATTERY
- Symptom: PASSENGER SQUIB 1 SHORT TO GROUND
- Symptom: POWER SUPPLY VOLTAGE LOW
- Symptom: RIGHT CURTAIN OR SEAT SQUIB CIRCUIT OPEN
- Symptom: RIGHT CURTAIN OR SEAT SQUIB CIRCUIT SHORT
- Symptom: RIGHT CURTAIN OR SEAT SQUIB SHORT TO BATTERY
- Symptom: RIGHT CURTAIN OR SEAT SQUIB SHORT TO GROUND
- Symptom: RIGHT SIDE IMPACT SENSOR INTERNAL 1
- Symptom: VEHICLE BODY STYLE MISMATCH
- Symptom: *AIRBAG INDICATOR ON WITHOUT ACTIVE TROUBLE CODES
- Audio
- Symptom: ALL OUTPUTS SHORT
- Symptom: ANTENNA HARDWARE FAILURE - SDARS
- Symptom: ANTENNA NOT CONNECTED - SDARS
- Symptom: BUS BUSY - SDARS
- Symptom: BUS LOW - SDARS
- Symptom List: CASSETTE PLAYER INOP; CD MECHANICAL FAILURE; NO PCI TRANSMISSION; *AM/FM SWITCH INOPERATIVE; *ANY STATION PRESET SWITCH INOPERATIVE; *BALANCE INOPERATIVE; *CD EJECT SWITCH INOPERATIVE; *EQUALIZER INOPERATIVE; *FADER INOPERATIVE; *FF/RW SWITCH INOPERATIVE; *HOUR/MINUTE SWITCHES INOPERATIVE; *PAUSE/PLAY SWITCH INOPERATIVE; *PWR SWITCH INOPERATIVE; *SCAN SWITCH INOPERATIVE; *SEEK SWITCH INOPERATIVE; *SET SWITCH INOPERATIVE; *TAPE EJECT SWITCH INOPERATIVE; *TIME SWITCH INOPERATIVE; *TUNE SWITCH INOPERATIVE
- Symptom: CD PLAY FAILURE
- Symptom: CD READ FAILURE
- Symptom: CD TEMPERATURE HIGH
- Symptom: GPS ANTENNA NOT CONNECTED
- Symptom: INTERNAL FAILURE - SDARS
- Symptom: INTERNAL RECEIVER FAILURE - SDARS
- Symptom: LOW VOLTAGE LEVEL
- Symptom: NO ANTENNA CONNECTION
- Symptom: NO COMMUNICATION WITH SDARS
- Symptom: NO J1850 COMMUNICATION - SDARS
- Symptom: POWER AMP SHUTDOWN
- Symptom: RADIO AND NAV GPS ANTENNA NOT CONNECTED
- Symptom: *INOP NO FAULT CODES - SDARS
- Symptom: *POOR RECEPTION - SDARS
- Communication
- Symptom: *NO RESPONSE FROM AIRBAG CONTROL MODULE
- Symptom: *NO RESPONSE FROM AMPLIFIER
- Symptom: *NO RESPONSE FROM ANTILOCK BRAKE MODULE
- Symptom: *NO RESPONSE FROM ECM (PCI BUS) - DIESEL ONLY
- Symptom: *NO RESPONSE FROM ECM (SCI ONLY) - DIESEL ONLY
- Symptom: *NO RESPONSE FROM HANDS FREE MODULE
- Symptom: *NO RESPONSE FROM INSTRUMENT CLUSTER
- Symptom: *NO RESPONSE FROM OVERHEAD CONSOLE (COMPASS/TEMPERATURE MIRROR MODULE)
- Symptom: *NO RESPONSE FROM PCM (PCI BUS) - 1.6L
- Symptom: *NO RESPONSE FROM PCM (PCI BUS) - NGC
- Symptom: *NO RESPONSE FROM PCM (PCM SCI ONLY) - NGC
- Symptom: *NO RESPONSE FROM PCM (SCI ONLY) - 1.6L
- Symptom: *NO RESPONSE FROM RADIO
- Symptom: *NO RESPONSE FROM RKE
- Symptom: *NO RESPONSE FROM SATELLITE RADIO RECEIVER
- Symptom: *NO RESPONSE FROM SENTRY KEY IMMOBILIZER MODULE
- Symptom: *NO RESPONSE FROM TRANSMISSION CONTROL MODULE - NGC
- Symptom: *NO RESPONSE FROM WINDOW REGULATOR MODULE - PT27
- Symptom: *PCI BUS COMMUNICATION FAILURE
- Instrument Cluster
- Symptom List: ABS INDICATOR CIRCUIT OPEN; AIRBAG INDICATOR CIRCUIT OPEN
- Symptom List: ABS MESSAGE NOT RECEIVED; ACM MESSAGE NOT RECEIVED; EATX MESSAGE NOT RECEIVED; NO PCI TRANSMISSION; SBEC MESSAGE NOT RECEIVED; SKIM MESSAGE NOT RECEIVED
- Symptom: EATX MESSAGE MISMATCH
- Symptom: EEPROM CHECKSUM FAILURE
- Symptom: FUEL LEVEL SENSOR OPEN
- Symptom: FUEL LEVEL SENSOR SHORT
- Symptom: FUEL LEVEL SENSOR STUCK
- Symptom: PANEL DIMMER OPEN
- Symptom: PANEL DIMMER SHORTED
- Symptom: *ALL GAUGES INOPERATIVE
- Symptom: *ANY PCI BUS INDICATOR INOPERATIVE
- Symptom: *BRAKE WARNING INDICATOR ALWAYS ON
- Symptom: *BRAKE WARNING INDICATOR INOPERATIVE
- Symptom: *FRONT FOG LAMP INDICATOR INOPERATIVE
- Symptom: *FUEL GAUGE INACCURATE
- Symptom: *HIGH BEAM INDICATOR INOPERATIVE
- Symptom: *INSTRUMENT CLUSTER DIMMING INOPERATIVE
- Symptom: *LOW OIL PRESSURE INDICATOR ALWAYS ON
- Symptom: *LOW OIL PRESSURE INDICATOR INOPERATIVE
- Symptom: *ONE GAUGE INOPERATIVE
- Symptom: *PRND OR AUTOSTICK DISPLAY INOPERATIVE OR INACCURATE
- Symptom: *REAR FOG LAMP INDICATOR INOPERATIVE - BUX ONLY
- Symptom: *SEAT BELT INDICATOR NOT OPERATING PROPERLY
- Symptom: *VF DISPLAY INOPERATIVE
- Interior Lighting
- Overhead Console
- Power Door Locks/RKE
- Symptom: BODY STYLE MISMATCH
- Symptom: DRIVER DOOR SWITCH FAILURE
- Symptom: INCORRECT MODULE TYPE CONFIGURATION FOR PART NUMBER
- Symptom: MODULE NOT CONFIGURED FOR RKE
- Symptom: NO AIRBAG MESSAGES RECEIVED
- Symptom: NO PCM MESSAGES RECEIVED
- Symptom: NO SKIM MESSAGES RECEIVED
- Symptom: PASSENGER DOOR OR LIFTGATE SWITCH FAILURE - PT44
- Symptom:* ALL DOORS (EXCEPT DRIVER)FAIL TO LOCK
- Symptom: * ALL DOORS (EXCEPT DRIVER)FAIL TO LOCK AND UNLOCK
- Symptom:* ALL DOORS (EXCEPT DRIVER)FAIL TO UNLOCK
- Symptom: *ALL DOOR LOCKS INOPERATIVE
- Symptom: *ALL DOORS FAIL TO LOCK
- Symptom: *ALL DOORS FAIL TO UNLOCK
- Symptom: *ALL LOCKS INOPERATIVE FROM ONE LOCK SWITCH
- Symptom: *DECKLID RELEASE SWITCH INOPERATIVE - PT27
- Symptom: *DECKLID SOLENOID INOPERATIVE - PT27
- Symptom: *DOORS LOCKABLE WITH KEY IN IGNITION AND DRIVER DOOR OPEN
- Symptom: *DRIVER DOOR FAILS TO LOCK
- Symptom: *DRIVER DOOR FAILS TO LOCK AND UNLOCK
- Symptom: *DRIVER DOOR FAILS TO UNLOCK
- Symptom: *DRIVER DOOR FAILS UNLOCK - PT27
- Symptom: *LIFTGATE LOCK MOTOR FAILS TO LOCK OR UNLOCK
- Symptom: *ONE DOOR FAILS TO LOCK AND UNLOCK - PT27
- Symptom: *ONE PASSENGER DOOR FAILS TO LOCK AND UNLOCK
- Symptom: *PASSENGER DOOR FAILS TO UNLOCK - PT27
- Symptom: *RKE INOPERATIVE
- Power Top
- Symptom: AMBIENT TEMP MESSAGE NOT RECEIVED
- Symptom: POWER TOP RELAY CONTROL CIRCUIT OPEN
- Symptom: POWER TOP RELAY INOPERATIVE
- Symptom: POWER TOP SWITCH MUX CIRCUIT OPEN
- Symptom: POWER TOP SWITCH MUX CIRCUIT SHORT TO GROUND
- Symptom: POWER TOP SWITCH MUX CIRCUIT VALUE OUT OF RANGE
- Symptom: SPEED MESSAGE NOT RECEIVED
- Power Windows
- Symptom: BATTERY VOLTAGE TOO HIGH
- Symptom: BATTERY VOLTAGE TOO LOW
- Symptom: FRONT WINDOW MOTOR MALFUNCTION
- Symptom: FRONT WINDOW SWITCH MUX CIRCUIT OPEN
- Symptom: FRONT WINDOW SWITCH MUX CIRCUIT SHORT TO GROUND
- Symptom: FRONT WINDOW SWITCH MUX CIRCUIT VALUE OUT OF RANGE
- Symptom: IGNITION SWITCH OUTPUT OPEN
- Symptom: REAR WINDOW MOTOR CIRCUIT OPEN OR SHORTED
- Symptom: REAR WINDOW SWITCH MUX CIRCUIT OPEN
- Symptom: REAR WINDOW SWITCH MUX CIRCUIT SHORT TO GROUND
- Symptom: REAR WINDOW SWITCH MUX CIRCUIT VALUE OUT OF RANGE
- Symptom: WINDOW DROP SWITCH SENSE CIRCUIT OPEN
- Symptom: *DOOR AJAR CIRCUIT OPEN
- Symptom: *DOOR WINDOWS STAY IN DROP DOWN POSITION
- Symptom: *WINDOW DROPS OR JERKS DURING OPENING
- Telecommunication
- Symptom: AUDIO HARDWARE MESSAGE NOT RECEIVED
- Symptom List: BLUETOOTH ERROR; FLASH CHECKSUM ERROR; FLASH WRITE ERROR; PCI BUS INTERNAL ERROR; RAM WRITE ERROR; ROM CHECKSUM ERROR
- Symptom List: BODY STYLE MESSAGE NOT RECEIVED; INVALID BODY STYLE
- Symptom: GENERAL MICROPHONE FAULT
- Symptom: IGNITION POWER MESSAGE NOT RECEIVED
- Symptom List: LEFT AUDIO INPUT SHORT TO GROUND; LEFT AUDIO INPUT SHORT TO VOLTAGE; LEFT AUDIO OUTPUT 1 SHORT TO GROUND; LEFT AUDIO OUTPUT 1 SHORT TO VOLTAGE
- Symptom List: MIRROR POWER CIRCUIT SHORT TO GROUND; MIRROR POWER CIRCUIT SHORT TO VOLTAGE
- Symptom List: PCI BUS BUSY; PCI BUS CIRCUIT OPEN; PCI BUS CIRCUIT SHORT TO GROUND; PCI BUS CIRCUIT SHORT TO VOLTAGE
- Symptom List: PHONE SWITCH STUCK; VOICE RECOGNITION SWITCH STUCK' VOICE RECOGNITION/PHONE SWITCH CIRCUIT RATIONALITY; VOICE RECOGNITION/PHONE SWITCH CIRCUIT SHORT TO GROUND; VOICE RECOGNITION/PHONE SWITCH CIRCUIT SHORT TO VOLTAGE
- Symptom: PRNDL MESSAGE NOT RECEIVED
- Symptom: RADIO MESSAGE NOT RECEIVED
- Symptom List: RIGHT AUDIO INPUT SHORT TO GROUND; RIGHT AUDIO INPUT SHORT TO VOLTAGE; RIGHT AUDIO OUTPUT 1 SHORT TO GROUND; RIGHT AUDIO OUTPUT 1 SHORT TO VOLTAGE
- Symptom: RPM MESSAGE NOT RECEIVED
- Symptom: VIN MESSAGE NOT RECEIVED
- Symptom: VIN MISMATCH
- Vehicle Theft/Security
- Symptom: HOOD AJAR SWITCH MISSING (EXPORT ONLY)
- Symptom: MODULE PREVIOUSLY CONFIGURED FOR VTSS
- Symptom: *ALARM TRIPS ON ITS OWN
- Symptom: *HEADLAMPS FAIL TO FLASH DURING ALARM
- Symptom: *HORN FAILS TO SOUND DURING ALARM
- Symptom: *INTRUSION SENSOR CANNOT BE DISABLED (EXPORT ONLY)
- Symptom: *INTRUSION SENSOR FAILS TO TRIP VTSS (EXPORT ONLY)
- Symptom: *INTRUSION SENSOR REPEATEDLY TRIGGERS VTSS (EXPORT ONLY)
- Symptom: *OPEN DRIVER DOOR FAILS TO TRIP ALARM
- Symptom: *OPEN LIFTGATE FAILS TO TRIP ALARM
- Symptom: *OPEN PASSENGER DOOR FAILS TO TRIP ALARM
- Symptom: *PARK LAMPS FAIL TO FLASH DURING ALARM
- Symptom List: *VTSS FAILS TO ARM FROM LEFT DOOR CYLINDER LOCK SWITCH (EXPORT ONLY); *VTSS FAILS TO ARM/DISARM FROM LEFT DOOR CYLINDER LOCK SWITCH
- Symptom List: *VTSS FAILS TO ARM FROM LIFTGATE CYLINDER LOCK SWITCH (EXPORT ONLY); *VTSS FAILS TO ARM/DISARM FROM LIFTGATE CYLINDER LOCK SWITCH
- Symptom List: *VTSS FAILS TO ARM FROM RIGHT DOOR CYLINDER LOCK SWITCH (EXPORT ONLY); *VTSS FAILS TO ARM/DISARM FROM RIGHT DOOR CYLINDER LOCK SWITCH
- Symptom: *VTSS INDICATOR FAILS TO FLASH
- Symptom: *VTSS INDICATOR STAYS ON STEADY DURING ARMING
- Symptom: *VTSS SIREN INOPERATIVE (EXPORT ONLY)
- Verifications Tests
- Airbag
- Component Locations
- Connector PINOUTS
- Airbag Control Module (Orc) (Base) - Yellow 23 Way
- Airbag Control Module C1 (Orc) (Premium) - Yellow 32 Way
- Airbag Control Module C2 (Orc) (Premium) - Yellow 32 Way
- Ambient Temperature Sensor (Except 2.4L Base) - Black 2 Way
- Amplifier Audio C1 - 20 Way
- Anti-Lock Brake Module - Black 47 Way
- C203 (Pt27) - LT. Gray (Body Side)
- C203 (Pt27) - LT. Gray (Instrument Panel Side)
- C204 (Pt27) - (Instrument Panel Side)
- C204 (Pt27) - (Left Front Door Side)
- C204 (Pt44 LHP) - Natural (Instrument Panel Side)
- C204 (Pt44 LHP) - Natural (Left Front Door Side)
- C205 (Pt27) - (Instrument Panel Side)
- C205 (Pt27) - (Right Front Door Side)
- C305 - Yellow (Airbag Side)
- C305 - Yellow (UNIBODY Side)
- C306 - Yellow (Airbag Side)
- C306 - Yellow (UNIBODY Side)
- C343 (Pt27) - LT. Gray (DECKLID Jumper Side)
- C343 (Pt27) - LT. Gray (DECKLID Side)
- C349 (Pt27) - Blue (Body Side
- C349 (Pt27) - Blue (DECKLID Jumper Side)
- C362 (Pt27) - LT. Gray (Body Side)
- C362 (Pt27) - LT. Gray (Power Top Side)
- CLOCKSPRING - DK. Green 7 Way
- Compass/Temperature Mirror Module (Pt27) - Black 10 Way
- Data Link Connector - Black 16 Way
- DECKLID Cylinder Unlock Switch (Pt27) - LT. Gray 2 Way
- DECKLID Handle Switch (Pt27) - White 2 Way
- DECKLID Release Motor (Pt27) - Black 3 Way
- DECKLID Release Switch (Pt27) - Black 2 Way
- Dome Lamp - Black 3 Way
- Dome Lamp/Intrusion Sensor (Export) - White 4 Way
- Driver Airbag Squib 1 - Yellow 2 Way
- Driver Door Ajar Switch - Black 2 Way
- Driver Door Handle Switch (Pt27) - 2 Way
- Driver Door Power Lock Motor/Ajar Switch - Black 4 Way
- Driver Rear Window Motor (Pt27) - Black 2 Way
- Driver Seat Belt TENSIONER - Yellow 2 Way
- Driver Window Regulator Module (Pt27) - Black 20 Way
- Engine Control Module C1 (Diesel) - Black 81 Way
- Front Power Window Switch - Black 14 Way
- Fuel Pump Module - LT. Gray 4 Way
- Fuses (FB)
- Hands Free Module C1 - DK. Gray 22 Way
- Hands Free Module C2 (Satellite Radio) - DK. Gray 10 Way
- Hands Free Module C3 - Black 10 Way
- High Note Horn (Export) - Black 2 Way
- Hood Ajar Switch (Export) - Black 2 Way
- Ignition Switch C1 - 10 Way
- Instrument Cluster C1 - Black 26 Way
- Instrument Cluster C2 - Black 10 Way
- Left Cylinder Lock Switch - Black 2 Way
- Left Door Lock Switch - Black 3 Way
- Left Front Power Window Motor (Pt44) - Black 2 Way
- Left Instrument Panel Speaker - Black 2 Way
- Left Rear Speaker (Pt44) - Black 2 Way
- Left Seat Airbag Squib (LHP) - Yellow 2 Way
- Left Seat Airbag Squib (RHD) - Yellow 2 Way
- Left Side Impact Sensor 1 - Gray 2 Way
- Liftgate Ajar Switch - White 2 Way
- Liftgate Cylinder Lock Switch - LT. Gray 2 Way
- Liftgate Handle Switch (Pt44) - Natural 2 Way
- Liftgate Power Lock Motor - Black 4 Way
- Liftgate Release Motor (Pt44) - Black 3 Way
- Low Note Horn - Black 2 Way
- Multi-Function Switch - Gray 20 Way
- Overhead Console Module - Black 12 Way
- Passenger Airbag Squib 1 - Yellow 2 Way
- Passenger Door Ajar Switch - Black 2 Way
- Passenger Door Handle Switch (Pt27) - 2 Way
- Passenger Door Power Lock Motor/Ajar Switch - Black 4 Way
- Passenger Rear Window Motor (Pt27) - Black 2 Way
- Passenger Seat Belt TENSIONER - Yellow 2 Way
- Passenger Window Regulator Module (Pt27) - Black 20 Way
- Fuses (PDC)
- Power Top Motor (Pt27) - 2 Way
- Power Top Relay (Pt27) - Black 6 Way
- Power Top Switch (Pt27) - 3 Way
- Powertrain Control Module (1.6L) - Black 90 Way
- Powertrain Control Module C1 (NGC) - Black/Black 38 Way
- Radio C1 - White 22 Way
- Radio C2 (Hands Free) - DK. Gray 10 Way
- Rear View Mirror C1 - Black 12 Way
- Remote Keyless Entry Module - Black 26 Way
- Right Cylinder Lock Switch (Export) - Black 2 Way
- Right Door Lock Switch - Black 3 Way
- Right Front Door Speaker - 3 Way
- Right Front Power Window Motor (Pt44) - Black 2 Way
- Right Rear Power Window Motor (Pt44) - Black 2 Way
- Right Seat Airbag Squib (LHP) - Yellow 2 Way
- Right Seat Airbag Squib (RHP) - Yellow 2 Way
- Right Side Impact Sensor 1 - Gray 2 Way
- Sentry Key Immobilizer Module - Black 6 Way
- Siren (Export) - Black 4 Way
- Schematic Diagrams
- Instrument Cluster
- Interior & Exterior
- Body
- Description
- Warning
- Diagnosis And Testing
- Standard Procedure
- Standard Procedure - Plastic Body Panel Repair
- Notes
- Rigid Plastics:
- Semi-Rigid Plastics:
- Flexible Plastics:
- Repair Procedure:
- Adhesion Promoter/Surface Modifier:
- Safety Precaution And Warnings
- Rigid, Semi-Rigid, And Flexible Plastic Parts Types
- Panel Sectioning
- Panel Reinforcement
- Visual Inspection
- Panel Surface Preparation
- Patching Panels
- Panel Patch Fabrications
- Panel Patch Installation
- Patched Panel Surfacing
- Standard Procedure - Heat Staking
- Standard Procedure - Plastic Body Panel Repair
- Specifications
- Special Tools
- Convertible Top
- DECKLID - Pt-27
- Door - Front
- Front Door Applique
- Front Door Check Strap
- Front Door
- Front Door Glass
- Removal
- Installation
- Adjustment - Pt-27 Only
- Front Door Adjustment
- Quarter Glass Adjustment
- Notes
- Up-Stop Adjustments
- Bottom Of Glass - Inboard/Outboard Adjustments
- Top Of Glass - Inboard/Outboard Adjustments
- Glass - Front/Rear Adjustment
- Quarter Glass Alignment Verification
- Condition - Height Mismatch Between Door Glass And Quarter Glass With Top Down
- Condition - Door Glass Noise Along A-Pillar When Closing Door And/Or Door Glass Touching Quarter Glass Metal Seal Retainer And/Or Wind Noise/Water Leak Along Quarter Glass Seal.
- Condition - Door Glass Not Driving Into The Top In Full Up Position
- Condition - Quarter Glass Not Driving Into The Top In Full Up Position
- Condition - Slapping Noise Between The Door And Quarter Glass With The Top Down During Driving Of The Vehicle
- Condition - Non-Parallel Gap Between Door And Quarter Glasses
- Condition - Quarter Glass Seal Fold Over During Travel With Door Glass Full Up And Top Up Or Down
- Condition - Intermediate Rear Of Door Glass Not Driving Into The Top Seal And/Or Noise At Rear Bottom Of The Door
- Front Door Outside Handle
- Front Door Hinge
- Front Door Inside Handle Actuator
- Front Door Latch
- Front Door Latch Striker
- Front Door Lock Cylinder
- Front Door Vertical Guide Bar
- Front Door Side View Mirror Flag - Pt-27
- Front Door Trim Panel
- Front Door Water Dam
- Front Door Window Regulator
- Door Glass Inner Belt Stabilizer - Pt-27
- Rear Rail Assembly - Pt-27
- Door - Rear
- Exterior
- Body Side Moldings
- Cowl Grille Screen
- Deck Upper Belt Molding - Pt-27
- Engine Compartment Lower Silencer
- Exterior Name Plates
- Front Fender
- Front Side Rail Access Pulley Splash Shield
- Front Wheelhouse Splash Shields
- Fuel Fill Door
- Grille
- Header Molding - Pt-27
- Luggage Rack Crossbar
- Luggage Rack Side Rail
- Radiator Closure Panel
- Side View Mirror
- Side View Mirror Glass
- Windshield A-Pillar Trim Molding - Pt-27
- Wood Grain/Flame Decals
- Grille - Lower Radiator
- Hood
- Instrument Panel
- Interior
- A-Pillar Trim
- B-Pillar Trim
- Body Vent
- DECKLID Sill Scuff Plate
- Door Sill Trim
- Floor Carpet
- Cargo Area Floor Carpet - Pt-27
- Front Floor Carpet Right/Left Side -Pt-27
- Rear Carpet - Pt-27
- Upper D-Pillar Trim
- Header Latch Retainer - Pt-27
- Headliner
- Inside Rear View Mirror
- Lower Quarter Trim Panel
- Rear Quarter Panel Trim - Pt-27
- Seat Back Support Bracket - Pt-27
- Side Cowl Trim Panel
- Sport Bar - Pt-27
- Sport Bar Inner Covers - Pt-27
- Sport Bar Outer Cover - Pt-27
- Sun Visor
- Trunk Trim Panel - Pt-27
- Trunk Welt - Pt-27
- Upper C-Pillar Trim
- Windshield Header Molding -Pt-27
- Liftgate
- Paint
- Quarter Glass - Pt-27
- Seats
- Child Seat Tether Anchor Bezel
- Front Seat
- Front Seat Back - With Front Seat Back Panel
- Front Seat Back
- Front Seat Back Cover/Foam
- Front Seat Back Cover - Without Front Seat Back Panel
- Front Seat Cushion
- Front Seat Cushion Cover
- Headrest - Front/Rear
- Rear Seat
- Rear Seat Back
- Rear Seat Back Cover/Foam
- Rear Seat Back Cushion Cover/Foam - Pt-27
- Rear Seat Bolster - Pt-27
- Rear Seat Bolster Cover - Pt-27
- Rear Seat Cushion
- Rear Seat Back Cushion / Cover
- Rear Seat Latch Cover
- Under Seat Storage Bin
- Stationary Glass
- Sunroof
- Weatherstrip/Seals
- A-Pillar Weatherstrip Retainer - Pt-27
- Deck Lid Opening Weatherstrip - Pt-27
- Front And Rear Door Opening Weatherstrip
- Front And Rear Door Upper Secondary Weatherstrip
- Front Door Glass Run Weatherstrip
- Front Door Inner Belt Weatherstrip
- Front Door Outer Belt Weatherstrip
- Header Weatherstrip Seal Retainer - Pt-27
- Liftgate Weatherstrip
- Quarter Panel Outer Belt Weatherstrip - Pt-27
- Rear Door Glass Run Weatherstrip
- Rear Door Inner Belt Weatherstrip
- Sill Secondary Weatherstrip
- Header / A-Pillar Weatherstrip -Pt-27
- Front Door Sill Weatherstrip - Pt-27
- Body Structure
- Body
- Message Systems
- Navigation System & Telecommunication System
- Body Diagnostic Procedures
- Horns
- Motors, Switches, Relays
- Connector & Ground & Splice Location
- Connector End Views
- Connector Pin-Outs
- A/C Compressor Clutch (Diesel) Connector End View
- A/C Compressor Clutch (Gas) Connector End View
- A/C High Pressure Switch (Diesel) Connector End View
- A/C Low Pressure Switch Connector End View
- A/C Pressure Transducer Connector End View
- A/C Heater Control Switch Connector End View
- Accelerator Pedal Position Sensor (1.6L/Diesel) Connector End View
- Airbag Control Module (Occupant Restraint Control) (Base) Connector End View
- Airbag Control Module (Occupant Restraint Control) (Premium) Connector End View (C1)
- Airbag Control Module (Occupant Restraint Control) (Premium) Connector End View (C2)
- Ambient Temperature Sensor (Except 2.4L Base) Connector End View
- Ambient Temperature Sensor (NGC) Connector End View
- Audio Amplifier Connector End View (C1)
- Audio Amplifier Connector End View (C2)
- Antilock Brakes Module Connector End View
- Autostick Switch Connector End View
- Backup Lamp Switch (M/T Diesel) Connector End View
- Backup Lamp Switch (M/T Gas) Connector End View
- Battery Temperature Sensor (Diesel) Connector End View
- Blower Motor Connector End View
- Blower Motor Resistor Block Connector End View
- Boost Pressure Sensor (Diesel) Connector End View
- Brake Lamp Switch (Diesel) Connector End View
- Brake Lamp Switch (Gas) Connector End View
- Brake Transmission Shift Interlock Solenoid (EATX) Connector End View
- Brake Warning Indicator Switch Connector End View
- Engine Side Inline (2.4L) Connector End View (C102)
- Headlamp And Dash Side Inline (2.4L) Connector End View (C102)
- Engine Side Inline (2.4L Except Turbo) Connector End View (C103)
- Injector Harness Side Inline (2.4L Except Turbo) Connector End View (C103)
- Engine Side Inline (2.4L Turbo) Connector End View (C103)
- Injector Harness Side Inline (2.4L Turbo) Connector End View (C103)
- Inline (Headlamp And Dash Side) Connector End View (C105)
- Inline (Instrument Panel Side) Connector End View (C105)
- Inline (Headlamp And Dash Side) Connector End View (C106)
- Inline (Instrument Panel Side) Connector End View (C106)
- Headlamp And Dash Side Inline (Export) Connector End View (C107)
- Headlamp Leveling Side Inline (Export) Connector End View (C107)
- Headlamp And Dash Side Inline (Export) Connector End View (C108)
- Headlamp Leveling Side Inline (Export) Connector End View (C108)
- Headlamp And Dash Side Inline Connector End View (C110)
- Underbody Side Inline Connector End View (C110)
- Headlamp And Dash Side Inline (Except Antilock Brake System) Connector End View (C110)
- Underbody Side Inline (Except Antilock Brake System) Connector End View (C110)
- Engine Side Inline (1.6L) Connector End View (C111)
- Headlamp And Dash Side Inline (1.6L) Connector End View (C111)
- Engine Side Inline (1.6L) Connector End View (C112)
- Headlamp And Dash Side Inline (1.6L) Connector End View (C112)
- Engine Side Inline (1.6L) Connector End View (C114)
- Headlamp And Dash Side Inline (1.6L) Connector End View (C114)
- Engine Side Inline (Diesel) Connector End View (C121)
- Headlamp And Dash Side Inline (Diesel) Connector End View (C121)
- Engine Side Inline (Diesel) Connector End View (C122)
- Headlamp And Dash Side Inline (Diesel) Connector End View (C122)
- Engine Side Inline (Diesel) Connector End View (C124)
- Headlamp And Dash Side Inline (Diesel) Connector End View (C124)
- Headlamp And Dash Side Inline (Diesel) Connector End View (C125)
- Engine Side Inline (Diesel) Connector End View (C125)
- Cabin Heater Side Inline (Diesel) Connector End View (C126)
- Headlamp And Dash Side Inline (Diesel) Connector End View (C126)
- Battery Side Inline (Diesel) Connector End View (C127)
- Headlamp And Dash Side Inline (Diesel) Connector End View (C127)
- Headlamp And Dash Side Inline (Diesel) Connector End View (C128)
- Junction Post Side Inline (Diesel) Connector End View (C128)
- Instrument Panel Side Inline (Except Hands Free) Connector End View (C200)
- Left Headliner Jumper Side Inline (Except Hands Free) Connector End View (C200)
- Instrument Panel Side Inline (Hands Free) Connector End View (C200)
- Left Headliner Jumper Side Inline (Hands Free) Connector End View (C200)
- Instrument Panel Side Inline (Except Hands Free) Connector End View (C201)
- Right Headliner Jumper Side Inline (Except Hands Free) Connector End View (C201)
- Instrument Panel Side Inline (Hands Free) Connector End View (C201)
- Right Headliner Jumper Side Inline (Hands Free) Connector End View (C201)
- Instrument Panel Side Inline (LHD) Connector End View (C202)
- Left Body Side Inline (LHD) Connector End View (C202)
- Instrument Panel Side Inline (RHD) Connector End View (C202)
- Left Body Side Inline (RHD) Connector End View (C202)
- Body Side Inline (Convertible) Connector End View (C203)
- Instrument Panel Side Inline (Convertible) Connector End View (C203)
- Instrument Panel Side Inline (Hatchback) Connector End View (C203)
- Right Body Side Inline (Hatchback) Connector End View (C203)
- Instrument Panel Side Inline (Convertible) Connector End View (C204)
- Left Front Door Side Inline (Convertible) Connector End View (C204)
- Instrument Panel Side Inline (Hatchback RHD) Connector End View (C204)
- Left Front Door Side Inline (Hatchback RHD) Connector End View (C204)
- Instrument Panel Side Inline (Hatchback LHD) Connector End View (C204)
- Left Front Door Side Inline (Hatchback LHD) Connector End View (C204)
- Instrument Panel Side Inline (Hatchback LHD) Connector End View (C205)
- Right Front Door Side Inline (Hatchback LHD) Connector End View (C205)
- Instrument Panel Side Inline (Convertible) Connector End View (C205)
- Right Front Door Side Inline (Convertible) Connector End View (C205)
- Instrument Panel Side Inline (Hatchback RHD) Connector End View (C205)
- Right Front Door Side Inline (Hatchback RHD) Connector End View (C205)
- Dome Lamp Side Inline (Except Hands Free) Connector End View (C207)
- Right Headliner Jumper Side Inline (Except Hands Free) Connector End View (C207)
- Dome Lamp Side Inline (Hands Free) Connector End View (C207)
- Right Headliner Jumper Side Inline (Hands Free) Connector End View (C207)
- Dome Lamp Side Inline (Except Hands Free) Connector End View (C208)
- Left Headliner Jumper Side Inline (Except Hands Free) Connector End View (C208)
- Dome Lamp Side Inline (Hands Free) Connector End View (C208)
- Left Headliner Jumper Side Inline (Hands Free) Connector End View (C208)
- Inline (Heater Jumper Side) Connector End View (C209)
- Inline (Instrument Panel Side) Connector End View (C209)
- Dome Lamp Side Inline (Power Sunroof) Connector End View (C211)
- Sunroof Side Inline (Power Sunroof) Connector End View (C211)
- Unibody Side Inline (Satellite Radio) Connector End View (C212)
- Instrument Panel Side Inline (Satellite Radio) Connector End View (C212)
- Inline (Left Body Side) Connector End View (C300)
- Inline (Left Rear Door Side) Connector End View (C300)
- Inline (Right Body Side) Connector End View (C301)
- Inline (Right Rear Door Side) Connector End View (C301)
- Left Body Side Inline (Hatchback) Connector End View (C302)
- Liftgate Side Inline (Hatchback) Connector End View (C302)
- Inline (Left Body Side) Connector End View (C303)
- Inline (Rear Fascia Side) Connector End View (C303)
- Inline (Fuel Tank Side) Connector End View (C304)
- Underbody Side Inline Connector End View (C304)
- Airbag Side Inline Connector End View (C305)
- Unibody Side Inline Connector End View (C305)
- Airbag Side Inline Connector End View (C306)
- Unibody Side Inline Connector End View (C306)
- Inline (Passenger Seat Side) Connector End View (C307)
- Unibody Side Inline Connector End View (C307)
- Driver Seat Side Inline Connector End View (C308)
- Unibody Side Inline Connector End View (C308)
- Decklid Jumper Side Inline (Convertible) Connector End View (C343)
- Decklid Side Inline (Convertible) Connector End View (C343)
- Body Side Inline (Convertible) Connector End View (C349)
- Decklid Jumper Side Inline (Convertible) Connector End View (C349)
- Body Side Inline (Convertible) Connector End View (C362)
- Power Top Side Inline (Convertible) Connector End View (C362)
- Camshaft Position Sensor (Diesel) Connector End View
- Camshaft Position Sensor (Gas) Connector End View
- Cargo Lamp Connector End View
- Center High Mounted Stop Lamp (Convertible) Connector End View
- Center High Mounted Stop Lamp (Hatchback) Connector End View
- Center Stack Lamp Connector End View
- Cigar Lighter Connector End View
- Clockspring Connector End View
- Clutch Pedal Position Up Switch Connector End View
- Compass/Temperature Mirror Module (Convertible) Connector End View
- Crankshaft Position Sensor (Diesel) Connector End View
- Crankshaft Position Sensor (Gas) Connector End View
- Data Link Connector, Connector End View
- Decklid Cylinder Unlock Switch (Vehicle Theft Security System) (Convertible) Connector End View
- Decklid Handle Switch (Convertible) Connector End View
- Decklid Release Motor (Convertible) Connector End View
- Decklid Release Switch (Convertible) Connector End View
- Dome Lamp Connector End View
- Dome Lamp Intrusion Sensor (Export) Connector End View
- Driver Airbag Squib 1 Connector End View
- Driver Door Ajar Switch Connector End View
- Driver Door Handle Switch (Convertible) Connector End View
- Driver Door Power Lock Motor Ajar Switch Connector End View
- Driver Heated Seat Cushion Connector End View
- Driver Heated Seat Switch Connector End View
- Driver Rear Window Motor (Convertible) Connector End View
- Driver Seat Belt Switch Connector End View
- Driver Seat Belt Tensioner Connector End View
- Driver Window Regulator Module (Convertible) Connector End View
- EGR Solenoid (Diesel) Connector End View
- Electronic Throttle Control Module (1.6L) Connector End View
- Engine Control Module (Diesel) Connector End View (C1)
- Engine Control Module (Diesel) Connector End View (C2)
- Engine Coolant Temperature Sensor (Diesel) Connector End View
- Engine Coolant Temperature Sensor (Gas) Connector End View
- Engine Oil Pressure Switch Connector End View
- EVAP Purge Solenoid (Gas) Connector End View
- Front Power Window Switch Connector End View
- Front Washer Pump Motor Connector End View
- Front Wiper Motor Connector End View
- Front Wiper Switch/Washer Switch Connector End View
- Fuel Heater Module (Diesel) Connector End View
- Fuel Injector 1 (Diesel) Connector End View
- Fuel Injector 1 (Gas) Connector End View
- Fuel Injector 2 (Diesel) Connector End View
- Fuel Injector 2 (Gas) Connector End View
- Fuel Injector 3 (Diesel) Connector End View
- Fuel Injector 3 (Gas) Connector End View
- Fuel Injector 4 (Diesel) Connector End View
- Fuel Injector 4 (Gas) Connector End View
- Fuel Pressure Sensor (Diesel) Connector End View
- Fuel Pressure Solenoid (Diesel) Connector End View
- Fuel Pump Module Connector End View
- Generator (2.4L Turbo) Connector End View
- Generator (Diesel) Connector End View
- Generator (Gas Except 2.4L Turbo) Connector End View
- Hands Free Module Connector End View (C1)
- Hands Free Module (Satellite Radio) Connector End View (C2)
- Hands Free Module Connector End View (C3)
- Headlamp Leveling Switch (Export) Connector End View
- Heated Seat Module Connector End View
- High Note Horn (Export) Connector End View
- Hood Ajar Switch (Export) Connector End View
- Idle Air Control Motor (2.4L) Connector End View
- Ignition Coil (Gas) Connector End View
- Ignition Switch Connector End View (C1)
- Ignition Switch (Autostick) Connector End View (C2)
- Inlet Air Temperature Sensor (Gas) Connector End View
- Input Speed Sensor Connector End View
- Instrument Cluster Connector End View (C1)
- Instrument Cluster Connector End View (C2)
- Intake Air Temperature Sensor (Diesel) Connector End View
- Knock Sensor (Gas) Connector End View
- Left Backup Lamp Connector End View
- Left City Lamp (Export) Connector End View
- Left Cylinder Lock Switch Connector End View
- Left Dome Lamp (Convertible) Connector End View
- Left Door Lock Switch Connector End View
- Left Fog Lamp Connector End View
- Left Front Door Speaker Connector End View
- Left Front Park Turn Signal Lamp (Except Export) Connector End View
- Left Front Power Window Motor (Hatchback) Connector End View
- Left Front Side Marker (Export) Connector End View
- Left Front Turn Signal Lamp (Export) Connector End View
- Left Front Wheel Speed Sensor Connector End View
- Left Headlamp Leveling Module (Export) Connector End View
- Left High Beam Headlamp Connector End View
- Left Instrument Panel Speaker Connector End View
- Left License Lamp (Export) Connector End View
- Left Low Beam Headlamp Connector End View
- Left Power Mirror (Except Export) Connector End View
- Left Power Mirror (Export) Connector End View
- Left Rear Door Power Lock Motor Connector End View
- Left Rear Fog Lamp (LHD Export) Connector End View
- Left Rear Power Window Motor (Hatchback) Connector End View
- Left Rear Power Window Switch Connector End View
- Left Rear Speaker (Convertible Base) Connector End View
- Left Rear Speaker (Hatchback) Connector End View
- Left Rear Speaker (Convertible Premium) Connector End View (C1)
- Left Rear Speaker (Convertible Premium) Connector End View (C2)
- Left Rear Turn Signal Lamp Connector End View
- Left Rear Wheel Speed Sensor Connector End View
- Left Seat Airbag Squib (LHD) Connector End View
- Left Seat Airbag Squib (RHD) Connector End View
- Left Side Impact Sensor 1 Connector End View
- Left Tail Stop Lamp Connector End View
- Left Turn Signal Indicator Connector End View
- Left Visor Lamp/Vanity Lamp (Except Base) Connector End View
- License Lamp (Except Export) Connector End View
- Liftgate Ajar Switch Connector End View
- Liftgate Cylinder Lock Switch Connector End View
- Liftgate Handle Switch (Hatchback) Connector End View
- Liftgate Power Lock Motor Connector End View
- Liftgate Release Motor (Hatchback) Connector End View
- Low Note Horn Connector End View
- Manifold Absolute Pressure Sensor (Gas) Connector End View
- Map/Reading Lamps Connector End View
- Mass Air Flow Sensor (Diesel) Connector End View
- Multifunction Switch Connector End View
- Natural Vacuum Leak Detection Assembly (Except Export) Connector End View
- Output Speed Sensor Connector End View
- Overhead Console Module Connector End View
- Upstream Oxygen Sensor 1/1 (Gas) Connector End View
- Downstream Oxygen Sensor 1/2 (Gas) Connector End View
- Passenger Airbag Squib 1 Connector End View
- Passenger Door Ajar Switch Connector End View
- Passenger Door Handle Switch (Convertible) Connector End View
- Passenger Door Power Lock Motor Ajar Switch Connector End View
- Passenger Heated Seat Cushion Connector End View
- Passenger Heated Seat Switch Connector End View
- Passenger Rear Window Motor (Convertible) Connector End View
- Passenger Seat Belt Tensioner Connector End View
- Passenger Window Regulator Module (Convertible) Connector End View
- Positive Crankcase Ventilation Heater (Diesel) Connector End View
- Power Mirror Switch (LHD) Connector End View
- Power Mirror Switch (RHD) Connector End View
- Power Outlet Connector End View
- Power Seat Motor Connector End View
- Power Seat Switch Connector End View
- Power Steering Pressure Switch (Gas) Connector End View
- Power Sunroof Module Connector End View (C1)
- Power Sunroof Module Connector End View (C2)
- Power Top Motor (Convertible) Connector End View
- Power Top Relay (Convertible) Connector End View
- Power Top Switch (Convertible) Connector End View
- Powertrain Control Module (1.6L) Connector End View
- Powertrain Control Module (NGC) Connector End View (C1)
- Powertrain Control Module (NGC) Connector End View (C2)
- Powertrain Control Module (NGC) Connector End View (C3)
- Powertrain Control Module (NGC) Connector End View (C4)
- Radiator Fan Motor (2.4L Turbo) Connector End View
- Radiator Fan Motor (Except 2.4L Turbo) Connector End View
- Radio Connector End View (C1)
- Radio (Hands Free) Connector End View (C2)
- Radio (Satellite Radio) Connector End View (C2)
- Rear Power Outlet (Except Base) Connector End View
- Rear View Mirror Connector End View (C1)
- Rear View Mirror Connector End View (C2)
- Rear Window Defogger Switch Connector End View
- Rear Wiper Motor (Hatchback) Connector End View
- Rear Wiper Switch (Hatchback) Connector End View
- Remote Keyless Entry Module Connector End View
- Right Backup Lamp Connector End View
- Right City Lamp (Export) Connector End View
- Right Cylinder Lock Switch (Export) Connector End View
- Right Dome Lamp (Convertible) Connector End View
- Right Door Lock Switch Connector End View
- Right Fog Lamp Connector End View
- Right Front Door Speaker Connector End View
- Right Front Park Turn Signal Lamp (Except Export) Connector End View
- Right Front Power Window Motor (Hatchback) Connector End View
- Right Front Side Marker (Export) Connector End View
- Right Front Turn Signal Lamp (Export) Connector End View
- Right Front Wheel Speed Sensor Connector End View
- Right Headlamp Leveling Module (Export) Connector End View
- Right High Beam Headlamp Connector End View
- Right Instrument Panel Speaker Connector End View
- Right License Lamp (Export) Connector End View
- Right Low Beam Headlamp Connector End View
- Right Power Mirror (Except Export) Connector End View
- Right Power Mirror (Export) Connector End View
- Right Rear Door Power Lock Motor Connector End View
- Right Rear Fog Lamp (RHD) Connector End View
- Right Rear Power Window Motor (Hatchback) Connector End View
- Right Rear Power Window Switch Connector End View
- Right Rear Speaker (Convertible Base) Connector End View
- Right Rear Speaker (Hatchback) Connector End View
- Right Rear Speaker (Convertible Premium) Connector End View (C1)
- Right Rear Speaker (Convertible Premium) Connector End View (C2)
- Right Rear Turn Signal Lamp Connector End View
- Right Rear Wheel Speed Sensor Connector End View
- Right Seat Airbag Squib (LHD) Connector End View
- Right Seat Airbag Squib (RHD) Connector End View
- Right Side Impact Sensor 1 Connector End View
- Right Tail Stop Lamp Connector End View
- Right Turn Signal Indicator Connector End View
- Right Visor Lamp/Vanity Lamp (Except Base) Connector End View
- Satellite Radio Receiver Connector End View
- Sentry Key Immobilizer Module Connector End View
- Siren (Export) Connector End View
- Speed Control Servo (2.4L) Connector End View
- Speed Control Switch Connector End View
- Sunroof Motor Connector End View
- Surge Solenoid (2.4L Turbo) Connector End View
- Swirl Solenoid (Diesel) Connector End View
- Throttle Inlet Pressure Sensor (2.4L Turbo) Connector End View
- Throttle Inlet Pressure Solenoid (2.4L Turbo) Connector End View
- Throttle Position Sensor (2.4L) Connector End View
- Traction Control Switch Connector End View
- Transmission Range Indicator Illumination (PRNDL) (Autostick) Connector End View
- Transmission Range Indicator Illumination (PRNDL) (Except Autostick) Connector End View
- Transmission Range Sensor (2.4L) Connector End View
- Transmission Solenoid Pressure Switch Assembly (2.4L) Connector End View
- Vehicle Speed Sensor (Diesel) Connector End View
- Vehicle Speed Sensor (Gas M/T) Connector End View
- Wastegate Solenoid (2.4L Turbo) Connector End View
- Wastegate Solenoid (Diesel) Connector End View
- Connector Pin-Outs
- Power Distribution
- Starter
- Powertrain Diagnostic Procedures - Component Testing
- Sentry Key Immobilizer - Symptoms
- Symptom List: ANTENNA FAILURE; COP FAILURE; EEPROM FAILURE; INTERNAL FAULT; RAM FAILURE; SERIAL LINK INTERNAL FAULT; STACK OVERFLOW FAILURE
- Symptom List: PCM STATUS FAILURE; SERIAL LINK EXTERNAL FAULT
- Symptom List: ROLLING CODE FAILURE; VIN MISMATCH
- Symptom List: TRANSPONDER COMMUNICATION FAILURE; TRANSPONDER CYCLIC REDUNDANCY CHECK (CRC) FAILURE; TRANSPONDER ID MISMATCH; TRANSPONDER RESPONSE MISMATCH
- Starting - Symptoms
- Symptom: *CHECKING FUEL DELIVERY
- Symptom: *CHECKING FUEL PRESSURE LEAK DOWN
- Symptom: *CHECKING HARD START (FUEL DELIVERY SYSTEM)
- Symptom: *ENGINE CRANKS DOES NOT START - 1.6L
- Symptom: *ENGINE CRANKS DOES NOT START - 2.0L/2.4L
- Symptom: *NO CRANK CONDITION 1.6L
- Symptom: *NO CRANK CONDITION 2.0L/2.4L
- Symptom: *NO RESPONSE FROM PCM WITH A NO START CONDITION
- Symptom: *START AND STALL CONDITION 1.6L
- Symptom: *START AND STALL CONDITION 2.0L/2.4L
- Verification Test
- Component Locations
- Powertrain And Skim
- Control And Solenoids
- Throttle Body And Component Locations (2.0L/2.4L)
- Generator Location (1.6L)
- Generator and 1/1 O2 Sensor Locations (2.0L/2.4L)
- ETC Assembly And Ignition Coil Locations (1.6L)
- MAP Sensor And Ignition Coil Location (2.0L/2.4L)
- EVAP Purge Solenoid Location (2.0L/2.4L)
- NVLD Location (2.0L/2.4L)
- Speed Control Servo Locations (2.0L/2.4L)
- Speed Control Servo And Solenoids Component Locations (2.4L Turbo Only)
- Data Link Connector
- Sensors
- Battery Temperature Sensor Location (2.0L/2.4L)
- CKP Sensor Location (1.6L)
- CKP Sensor Location (2.0L/2.4L)
- CMP Sensor Location (2.0L/2.4L)
- Coolant Temperature Sensor Location (2.0L/2.4L)
- ECT Sensor Location (1.6L)
- IAT Sensor Location (2.0L/2.4L)
- Knock Sensor Location (1.6L)
- Knock Sensor Location (2.4L)
- MAP Sensor And Injectors Locations (1.6L)
- MAP Sensor Location (2.0L/2.4L)
- MAP Sensor Location (2.4L Turbo Only)
- APP Sensor Location (1.6L)
- O2 Sensors Location (1.6L)
- VSS Location
- Fuel System
- Relays
- Switches
- Connector PINOUTS
- A/C Compressor Clutch (Gas) - Black 2 Way
- A/C Low Pressure Switch - DK. Green 2 Way
- A/C Pressure Transducer - 2 Way
- Accelerator Pedal Position Sensor (1.6L/Diesel) - 10 Way
- Ambient Temperature Sensor (Except 2.4L Base) - Black 2 Way
- Ambient Temperature Sensor (NGC) - Black 2 Way
- Brake Lamp Switch (Gas) - Gray 6 Way
- Camshaft Position Sensor (Diesel) - Black 3 Way
- Camshaft Position Sensor (Gas) - Black 3 Way
- Clutch Pedal Position Switch (Up) - Black 3 Way
- Crankshaft Position Sensor (Gas) - Black 3 Way
- Data Link Connector - Black 16 Way
- EGR Solenoid (Diesel) - 2 Way
- Engine Coolant Temperature Sensor (Diesel) - Black 2 Way
- Engine Coolant Temperature Sensor (Gas) - Black 2 Way
- Engine Oil Pressure Switch - LT. Green 2 Way
- EVAP/Purge Solenoid (Gas) - Black 2 Way
- Fuel Injector No. 1 (Gas) - Black 2 Way
- Fuel Injector No. 2 (Gas) - Black 2 Way
- Fuel Injector No. 3 (Gas) - Black 2 Way
- Fuel Injector No. 4 (Gas) - Black 2 Way
- Fuel Pump Module - LT. Gray 4 Way
- Generator (2.4L Turbo) - Black 2 Way
- Generator (Gas Except 2.4L Turbo) - Black 2 Way
- Idle Air Control Motor (2.4L) - Black 2 Way
- Ignition Coil (Gas) - Black 3 Way
- Inlet Air Temperature Sensor (Gas) - Black 2 Way
- Knock Sensor (Gas) - Black 2 Way
- Manifold Absolute Pressure Sensor (Gas) - Black 3 Way
- Natural Vacuum Leak Detection Assembly (Except Export) - Black 3 Way
- Oxygen Sensor 1/1 Upstream (Gas) - Black 4 Way
- Oxygen Sensor 1/2 Downstream (Gas) - Black 4 Way
- Powertrain Control Module (1.6L) - Black 90 Way
- Powertrain Control Module C1 (NGC) - Black/Black 38 Way
- Powertrain Control Module C2 (NGC) - Black/Orange 38 Way
- Powertrain Control Module C3 (NGC) - Black/Natural 38 Way
- Powertrain Control Module C4 (NGC) - Black/Green 38 Way
- Radiator Fan Motor (2.4L Turbo) - DK. Gray 4 Way
- Radiator Fan Motor (Except 2.4L Turbo) - Black 3 Way
- Sentry Key Immobilizer Module - Black 6 Way
- Speed Control Servo (2.4L) - Black 4 Way
- Speed Control Switch - Yellow 3 Way
- Surge Solenoid (2.4L Turbo) - Black 2 Way
- Throttle Inlet Pressure Sensor (2.4L Turbo) - Natural 3 Way
- Throttle Inlet Pressure Solenoid (2.4L Turbo) - Black 2 Way
- Throttle Position Sensor (2.4L) - Black 3 Way
- Vehicle Speed Sensor (Gas MTX) - Black 3 Way
- WASTEGATE Solenoid (2.4L Turbo) - Black 2 Way
- Schematic Diagrams
- Charts And Graphs
- Vacuum Gauge Reading Examples
- Camshaft Sensor & Crankshaft Sensor Scope Pattern (Typical)
- Accelerator Pedal Position Sensor Specifications (1.6L)
- Camshaft & Crankshaft Sensor Specifications (1.6L)
- Throttle Position Sensor Specifications (1.6L)
- EVAP Tester
- Turbocharger System Circuit Diagrams
- Fuel Gauge Voltage Specifications
- Evaporative Emission System Schematic
- Sentry Key Immobilizer - Symptoms
- Powertrain Diagnostic Procedures - DRIVEABILITY - 1.6L Gas
- DRIVEABILITY - 1.6L Gas - Symptoms
- DRIVEABILITY - 1.6L Gas - Diagnostic Tests
- P0016-Crank And Cam Out-Of-Sync
- P0030-1/1 O2 Sensor Heater Circuit Open; P0036-1/1 O2 Sensor Heater Circuit Open
- P0031-1/1 O2 Sensor Heater Circuit Low; P0037-1/1 O2 Sensor Heater Circuit Low
- P0032-1/1 O2 Sensor Heater Circuit High; P0038-1/2 O2 Sensor Heater Circuit High
- P0106-BARO Pressure Out Of Range
- P0107-Map Sensor Voltage Too Low
- P0108-Map Sensor Voltage Too High
- P0112-Intake Air Temp Sensor Too Low
- P0113-Intake Air Temp Sensor Too High
- P0117-ECT Sensor Voltage Too Low
- P0118-ECT Sensor Voltage Too High
- P0122-Throttle Position Sensor Circuit #1 Low; P0222-Throttle Position Sensor Circuit #2 Low
- P0123-Throttle Position Sensor Circuit #1 High; P0223-Throttle Position Sensor Circuit #2 High
- P0125-Closed Loop Temp Not Reached
- P0128-Coolant Thermostat
- P0131-1/1 O2 Sensor Shorted To Ground; P0137-1/2 O2 Sensor Shorted To Ground
- P0132-1/1 O2 Sensor Shorted To Voltage; P0138-1/2 O2 Sensor Shorted To Voltage
- P0133-1/1 O2 Sensor Slow Response; P0139-1/2 O2 Sensor Slow Response
- P0134-1/1 O2 Sensor Stays At Center; P0140-1/2 O2 Sensor Stays At Center
- P0171-1/1 Fuel System Lean
- P0172-1/1 Fuel System Rich
- P0201-Injector #1 Control Circuit Open; P0202-Injector #2 Control Circuit Open; P0203-Injector #3 Control Circuit Open; P0204-Injector #4 Control Circuit Open
- P0261-Injector #1 Control Circuit Low; P0264-Injector #2 Control Circuit Low; P0267-Injector #3 Control Circuit Low; P0270-Injector #4 Control Circuit Low
- P0262-Injector #1 Control Circuit High; P0265-Injector #2 Control Circuit High; P0268-Injector #3 Control Circuit High; P0271-Injector #4 Control Circuit High
- P0300-Multiple Cylinder Mis-Fire; P0301-Cylinder #1 Misfire; P0302-Cylinder #2 Misfire; P0303-Cylinder #3 Misfire; P0304-Cylinder #4 Misfire
- P0315-No Crank Learned
- P0325-Knock Sensor #1 Circuit
- P0335-No Crank Signal At Pcm
- P0336-Crankshaft Position Sensor Performance
- P0340-No Cam Signal At Pcm
- P0420-1/1 Catalytic Converter Efficiency
- P0444-EVAP Purge Solenoid Circuit Open
- P0458-EVAP Purge Solenoid Low
- P0459-EVAP Purge Solenoid Circuit High
- P0461-Fuel Level Unit No Change Over Time
- P0462-Fuel Level Sending Unit Volts Too Low
- P0463-Fuel Level Sending Unit Volts Too High
- P0500-No Vehicle Speed Sensor Signal
- P0506-Idle Speed Performance Lower Than Excepted
- P0507-Idle Speed Performance Higher Than Excepted
- P0513-Invalid Skim Key
- P0551-Power Steering Switch Failure
- P0562-Charging System Voltage Too Low
- P0563-Charging System Voltage Too High
- P0572-Brake Switch Circuit Low
- P0573-Brake Switch Circuit High
- P0580-Speed Control Switch Always Low
- P0625-Generator Field Control Circuit Low
- P0626-Generator Field Control Circuit High
- P0628-Fuel Pump Relay Control Circuit Low
- P0629-Fuel Pump Relay Control Circuit High
- P0646-A/C Clutch Relay Control Circuit Low
- P0647-A/C Clutch Relay Control Circuit High
- P0686-ASD Relay Control Circuit Low
- P0687-ASD Relay Control Circuit High
- P0688-ASD Relay Output Circuit Low
- P0690-ASD Relay Output Circuit High
- P0691-Low Speed Fan Relay Control Circuit Low; P0693-High Speed Fan Relay Control Circuit Low
- P0692-Low Speed Fan Relay Control Circuit High P0694-High Speed Fan Relay Control Circuit High
- P0703-Brake Lamp Switch Circuit Performance
- P0719-Brake Lamp Switch Circuit Low
- P0724-Brake Lamp Switch Circuit High
- P0833-Clutch UPSTOP Switch Performance
- P1135-1/1 O2 Heater Element Resistance Out Of Range; P1136-1/2 Heater Element Resistance Out Of Range
- P1594-Charging System Voltage Too High
- P1616-5V Output Reference Voltage #1 Low
- P1617-5V Output Reference Voltage #1 High
- P1618-5V Output Reference Voltage Unstable
- P1626-5V Output Reference Voltage #2 Low
- P1627-5V Output Reference Voltage #2 High
- P1628-5V Output Reference Voltage #1 Unstable
- P1653-PCI Bus Shorted To Ground
- P1654-PCI Bus Shorted To Voltage
- P1656-PCI Bus Not Available
- P1686-No Skim Bus Message Received
- P1687-No Cluster Bus Message
- P2100-Electronic Throttle Control Motor Circuit
- P2101-Electronic Throttle Control Motor Performance
- P2107-Electronic Throttle Control Module Processor; P2108-Electronic Throttle Control Module Performance
- P2122-Accelerator Pedal Position Sensor # 1 Low; P2127-Accelerator Pedal Position Sensor #2 Low
- P2123-Accelerator Pedal Position Sensor #1 High; P2128-Accelerator Pedal Position Sensor #2 High
- P2135-Throttle Position Sensor #1 And #2 Voltage Correlation
- P2138-Accelerator Pedal Position Sensor #1 And #2 Voltage Correlation
- P2300-Ignition Coil #1 Circuit Low; P2303-Ignition Coil #2 Circuit Low
- P2301-Ignition Coil #1 Circuit High; P2304-Ignition Coil #2 Circuit High
- Powertrain Diagnostic Procedures - DRIVEABILITY - NGC
- DRIVEABILITY - NGC - Symptoms
- DRIVEABILITY - NGC - Diagnostic Tests
- P0016-Crankshaft/Camshaft Timing Misalignment
- P0031-O2 Sensor 1/1 Heater Circuit Low; P0037-O2 Sensor 1/2 Heater Circuit Low
- P0032-O2 Sensor 1/1 Heater Circuit High P0038-O2 Sensor 1/2 Heater Circuit High
- P0033-Surge Valve Solenoid Circuit
- P0068-Manifold Pressure/Throttle Position Correlation
- P0071-Ambient Temp Sensor Performance
- P0072-Ambient Temp Sensor Low
- P0073-Ambient Temp Sensor High
- P0107-Map Sensor Low
- P0108-Map Sensor High
- P0111-Intake Air Temperature Sensor Performance
- P0112-Intake Air Temperature Sensor Low
- P0113-Intake Air Temperature Sensor High
- P0116-Engine Coolant Temperature Performance
- P0117-Engine Coolant Temperature Sensor Low
- P0118-Engine Coolant Temperature Sensor High
- P0122-Throttle Position Sensor #1 Low
- P0123-Throttle Position Sensor #1 High
- P0125-Insufficient Coolant Temp For Closed-Loop Fuel Control
- P0128-Thermostat Rationality
- P0129-Barometric Pressure Out-Of-Range
- P0131-O2 Sensor 1/1 Voltage Low; P0137-O2 Sensor 1/2 Voltage Low
- P0132-O2 Sensor 1/1 Voltage High; P0138-O2 Sensor 1/2 Voltage High
- P0133-O2 Sensor 1/1 Slow Response; P0139-O2 Sensor 1/2 Slow Response
- P0135-O2 Sensor 1/1 Heater Performance; P0141-O2 Sensor 1/2 Heater Performance
- P0171-Fuel System 1/1 Lean
- P0172-Fuel System 1/1 Rich
- P0201-Fuel Injector #1; P0202-Fuel Injector #2; P0203-Fuel Injector #3; P0204-Fuel Injector #4
- P0234-OVERBOOST Performance; P1106-BARO Solenoid Performance; P1188 Tip Sensor Performance
- P0243-WASTEGATE Solenoid Circuit
- P0300-Multiple Cylinder Misfire; P0301-Cylinder #1 Misfire; P0302-Cylinder #2 Misfire; P0303-Cylinder #3 Misfire; P0304-Cylinder #4 Misfire
- P0315-No Crank Sensor Learned
- P0325-Knock Sensor #1 Circuit
- P0335-Crankshaft Position Sensor Circuit
- P0339-Crankshaft Position Sensor Intermittent
- P0340-Camshaft Position Sensor Circuit
- P0344-Camshaft Position Sensor Intermittent
- P0420-Catalytic 1/1 Efficiency
- P0440-General EVAP System Failure
- P0441-EVAP Purge System Performance
- P0442-EVAP System Medium Leak; P0455-EVAP System Large Leak
- P0443-EVAP Purge Solenoid Circuit
- P0452-NVLD Pressure Switch Stuck Closed
- P0453-NVLD Pressure Switch Stuck Open
- P0456-EVAP System Small Leak
- P0457-Loose Fuel Cap
- P0461-Fuel Level Sensor #1 Performance
- P0462-Fuel Level Sensor #1 Low; P0463-Fuel Level Sensor #1 High
- P0480-Cooling Fan 1 Control Circuit
- P0481-Cooling Fan 2 Control Circuit
- P0498-NVLD Canister Vent Valve Solenoid Circuit Low
- P0499-NVLD Canister Vent Valve Solenoid Circuit High
- P0501-Vehicle Speed Sensor #1 Performance (Auto Trans)
- P0501-Vehicle Speed Sensor #1 Performance (Manual Trans)
- P0506-Idle Speed Low Performance; P0507-Idle Speed High Performance
- P0508-IAC Valve Sense Circuit Low
- P0509-IAC Valve Sense Circuit High
- P0513-Invalid Skim Key
- P0516-Battery Temperature Sensor Low
- P0517-Battery Temperature Sensor High
- P0522-Oil Pressure Sensor Low
- P0551-Power Steering Switch Performance
- P0562-Battery Voltage Low
- P0563-Battery Voltage High
- P0572-Brake Switch #1 Circuit Low
- P0573-Brake Switch #1 Circuit High
- P0580-Speed Control Switch #1 Low
- P0581-Speed Control Switch #1 High
- P0582-Speed Control Vacuum Solenoid Circuit
- P0586-Speed Control Vent Solenoid Circuit
- P0594-Speed Control Servo Power Circuit
- P0600-Serial Communication Link; P0601-Internal Memory Checksum Invalid
- P0622-Generator Field Control Circuit
- P0627-Fuel Pump Relay Circuit
- P0630-VIN Not Programmed In Pcm
- P0632-Odometer Not Programmed In Pcm
- P0633-Skim Key Not Programmed In Pcm
- P0645-A/C Clutch Relay Circuit
- P0685-ASD Relay Control Circuit
- P0688-ASD Relay Sense Circuit Low
- P0700-Transmission Control System/Read Transmission DTCS On The DRBIII®
- P0850-Park/Neutral Switch Performance
- P1105-Tip Sensor Solenoid Circuit
- P1115-General Temp Sensor Performance
- P1187-THOTTLE Inlet Pressure/Map Correlation
- P1189-Tip Sensor Circuit Low
- P1190-Tip Sensor Circuit High
- P1593-Speed Control Switch Stuck
- P1603-Pcm Internal Dual-Port Ram Communication; P1604-Pcm Internal Dual-Port Ram Read/Write Integrity Failure; P1607-Pcm Internal Shutdown Timer Rationality
- P1696-EEPROM Memory Write Denied/Invalid; P1697-EMR (Sri) Mileage Not Stored
- P1854-Tip BARO Out Of Range
- P2074-Manifold Pressure/Throttle Position Correlation - High Flow/Vacuum Leak
- P2096-Down Stream Fuel System 1/2 Lean; P2097-Down Stream Fuel System 1/2 Rich
- P2302-Ignition Coil #1 Secondary Circuit-Insufficient Ionization; P2305-Ignition Coil #2 Secondary Circuit-Insufficient Ionization
- P2503-Charging System Voltage Low
- U0101-No Transmission Bus Message
- U0155-No Cluster Bus Message
- U0168-No Skim Bus Messages
- U110C-No Fuel Level Bus Message
- Powertrain Diagnostic Procedures - Introduction
- DTC Index
- Introduction
- Identification Of System
- System Description And Functional Operation
- General Description
- Functional Operation
- Fuel Control
- On-Board Diagnostics
- Other Controls
- Pcm Operating Modes
- Non-Monitored Circuits
- Skis Overview
- Skim On-Board Diagnostics
- Skis Operation
- Programming The Powertrain Control Module
- Programming The Sentry Key Immobilizer Module
- Programming The Ignition Keys To The Sentry Key Immobilizer Module
- Diagnostic Trouble Codes
- Using The DRBIII®
- DRBIII® Error Messages And Blank Screen
- Disclaimers, Safety, Warnings
- Required Tools And Equipment
- Glossary Of Terms
- Diagnostic Information And Procedures
- Communication - Symptoms
- Symptom: *NO RESPONSE FROM PCM (PCI BUS) - 1.6L
- Symptom: *NO RESPONSE FROM PCM (PCI BUS) - NGC
- Symptom: *NO RESPONSE FROM PCM (PCM SCI ONLY) - NGC
- Symptom: *NO RESPONSE FROM PCM (SCI ONLY) - 1.6L
- Symptom: *NO RESPONSE FROM SENTRY KEY IMMOBILIZER MODULE
- Symptom: *NO RESPONSE FROM TRANSMISSION CONTROL MODULE - NGC
- Symptom: *PCI BUS COMMUNICATION FAILURE
- Communication - Symptoms
- Starting System
- Powertrain Diagnostic Procedures - Component Testing
- Wiring Diagrams
- Connector End Views
- Connector Pin-Outs
- A/C Compressor Clutch (Diesel) Connector End View
- A/C Compressor Clutch (Gas) Connector End View
- A/C High Pressure Switch (Diesel) Connector End View
- A/C Low Pressure Switch Connector End View
- A/C Pressure Transducer Connector End View
- A/C Heater Control Switch Connector End View
- Accelerator Pedal Position Sensor (1.6L/Diesel) Connector End View
- Airbag Control Module (Occupant Restraint Control) (Base) Connector End View
- Airbag Control Module (Occupant Restraint Control) (Premium) Connector End View (C1)
- Airbag Control Module (Occupant Restraint Control) (Premium) Connector End View (C2)
- Ambient Temperature Sensor (Except 2.4L Base) Connector End View
- Ambient Temperature Sensor (NGC) Connector End View
- Audio Amplifier Connector End View (C1)
- Audio Amplifier Connector End View (C2)
- Antilock Brakes Module Connector End View
- Autostick Switch Connector End View
- Backup Lamp Switch (M/T Diesel) Connector End View
- Backup Lamp Switch (M/T Gas) Connector End View
- Battery Temperature Sensor (Diesel) Connector End View
- Blower Motor Connector End View
- Blower Motor Resistor Block Connector End View
- Boost Pressure Sensor (Diesel) Connector End View
- Brake Lamp Switch (Diesel) Connector End View
- Brake Lamp Switch (Gas) Connector End View
- Brake Transmission Shift Interlock Solenoid (EATX) Connector End View
- Brake Warning Indicator Switch Connector End View
- Engine Side Inline (2.4L) Connector End View (C102)
- Headlamp And Dash Side Inline (2.4L) Connector End View (C102)
- Engine Side Inline (2.4L Except Turbo) Connector End View (C103)
- Injector Harness Side Inline (2.4L Except Turbo) Connector End View (C103)
- Engine Side Inline (2.4L Turbo) Connector End View (C103)
- Injector Harness Side Inline (2.4L Turbo) Connector End View (C103)
- Inline (Headlamp And Dash Side) Connector End View (C105)
- Inline (Instrument Panel Side) Connector End View (C105)
- Inline (Headlamp And Dash Side) Connector End View (C106)
- Inline (Instrument Panel Side) Connector End View (C106)
- Headlamp And Dash Side Inline (Export) Connector End View (C107)
- Headlamp Leveling Side Inline (Export) Connector End View (C107)
- Headlamp And Dash Side Inline (Export) Connector End View (C108)
- Headlamp Leveling Side Inline (Export) Connector End View (C108)
- Headlamp And Dash Side Inline Connector End View (C110)
- Underbody Side Inline Connector End View (C110)
- Headlamp And Dash Side Inline (Except Antilock Brake System) Connector End View (C110)
- Underbody Side Inline (Except Antilock Brake System) Connector End View (C110)
- Engine Side Inline (1.6L) Connector End View (C111)
- Headlamp And Dash Side Inline (1.6L) Connector End View (C111)
- Engine Side Inline (1.6L) Connector End View (C112)
- Headlamp And Dash Side Inline (1.6L) Connector End View (C112)
- Engine Side Inline (1.6L) Connector End View (C114)
- Headlamp And Dash Side Inline (1.6L) Connector End View (C114)
- Engine Side Inline (Diesel) Connector End View (C121)
- Headlamp And Dash Side Inline (Diesel) Connector End View (C121)
- Engine Side Inline (Diesel) Connector End View (C122)
- Headlamp And Dash Side Inline (Diesel) Connector End View (C122)
- Engine Side Inline (Diesel) Connector End View (C124)
- Headlamp And Dash Side Inline (Diesel) Connector End View (C124)
- Headlamp And Dash Side Inline (Diesel) Connector End View (C125)
- Engine Side Inline (Diesel) Connector End View (C125)
- Cabin Heater Side Inline (Diesel) Connector End View (C126)
- Headlamp And Dash Side Inline (Diesel) Connector End View (C126)
- Battery Side Inline (Diesel) Connector End View (C127)
- Headlamp And Dash Side Inline (Diesel) Connector End View (C127)
- Headlamp And Dash Side Inline (Diesel) Connector End View (C128)
- Junction Post Side Inline (Diesel) Connector End View (C128)
- Instrument Panel Side Inline (Except Hands Free) Connector End View (C200)
- Left Headliner Jumper Side Inline (Except Hands Free) Connector End View (C200)
- Instrument Panel Side Inline (Hands Free) Connector End View (C200)
- Left Headliner Jumper Side Inline (Hands Free) Connector End View (C200)
- Instrument Panel Side Inline (Except Hands Free) Connector End View (C201)
- Right Headliner Jumper Side Inline (Except Hands Free) Connector End View (C201)
- Instrument Panel Side Inline (Hands Free) Connector End View (C201)
- Right Headliner Jumper Side Inline (Hands Free) Connector End View (C201)
- Instrument Panel Side Inline (LHD) Connector End View (C202)
- Left Body Side Inline (LHD) Connector End View (C202)
- Instrument Panel Side Inline (RHD) Connector End View (C202)
- Left Body Side Inline (RHD) Connector End View (C202)
- Body Side Inline (Convertible) Connector End View (C203)
- Instrument Panel Side Inline (Convertible) Connector End View (C203)
- Instrument Panel Side Inline (Hatchback) Connector End View (C203)
- Right Body Side Inline (Hatchback) Connector End View (C203)
- Instrument Panel Side Inline (Convertible) Connector End View (C204)
- Left Front Door Side Inline (Convertible) Connector End View (C204)
- Instrument Panel Side Inline (Hatchback RHD) Connector End View (C204)
- Left Front Door Side Inline (Hatchback RHD) Connector End View (C204)
- Instrument Panel Side Inline (Hatchback LHD) Connector End View (C204)
- Left Front Door Side Inline (Hatchback LHD) Connector End View (C204)
- Instrument Panel Side Inline (Hatchback LHD) Connector End View (C205)
- Right Front Door Side Inline (Hatchback LHD) Connector End View (C205)
- Instrument Panel Side Inline (Convertible) Connector End View (C205)
- Right Front Door Side Inline (Convertible) Connector End View (C205)
- Instrument Panel Side Inline (Hatchback RHD) Connector End View (C205)
- Right Front Door Side Inline (Hatchback RHD) Connector End View (C205)
- Dome Lamp Side Inline (Except Hands Free) Connector End View (C207)
- Right Headliner Jumper Side Inline (Except Hands Free) Connector End View (C207)
- Dome Lamp Side Inline (Hands Free) Connector End View (C207)
- Right Headliner Jumper Side Inline (Hands Free) Connector End View (C207)
- Dome Lamp Side Inline (Except Hands Free) Connector End View (C208)
- Left Headliner Jumper Side Inline (Except Hands Free) Connector End View (C208)
- Dome Lamp Side Inline (Hands Free) Connector End View (C208)
- Left Headliner Jumper Side Inline (Hands Free) Connector End View (C208)
- Inline (Heater Jumper Side) Connector End View (C209)
- Inline (Instrument Panel Side) Connector End View (C209)
- Dome Lamp Side Inline (Power Sunroof) Connector End View (C211)
- Sunroof Side Inline (Power Sunroof) Connector End View (C211)
- Unibody Side Inline (Satellite Radio) Connector End View (C212)
- Instrument Panel Side Inline (Satellite Radio) Connector End View (C212)
- Inline (Left Body Side) Connector End View (C300)
- Inline (Left Rear Door Side) Connector End View (C300)
- Inline (Right Body Side) Connector End View (C301)
- Inline (Right Rear Door Side) Connector End View (C301)
- Left Body Side Inline (Hatchback) Connector End View (C302)
- Liftgate Side Inline (Hatchback) Connector End View (C302)
- Inline (Left Body Side) Connector End View (C303)
- Inline (Rear Fascia Side) Connector End View (C303)
- Inline (Fuel Tank Side) Connector End View (C304)
- Underbody Side Inline Connector End View (C304)
- Airbag Side Inline Connector End View (C305)
- Unibody Side Inline Connector End View (C305)
- Airbag Side Inline Connector End View (C306)
- Unibody Side Inline Connector End View (C306)
- Inline (Passenger Seat Side) Connector End View (C307)
- Unibody Side Inline Connector End View (C307)
- Driver Seat Side Inline Connector End View (C308)
- Unibody Side Inline Connector End View (C308)
- Decklid Jumper Side Inline (Convertible) Connector End View (C343)
- Decklid Side Inline (Convertible) Connector End View (C343)
- Body Side Inline (Convertible) Connector End View (C349)
- Decklid Jumper Side Inline (Convertible) Connector End View (C349)
- Body Side Inline (Convertible) Connector End View (C362)
- Power Top Side Inline (Convertible) Connector End View (C362)
- Camshaft Position Sensor (Diesel) Connector End View
- Camshaft Position Sensor (Gas) Connector End View
- Cargo Lamp Connector End View
- Center High Mounted Stop Lamp (Convertible) Connector End View
- Center High Mounted Stop Lamp (Hatchback) Connector End View
- Center Stack Lamp Connector End View
- Cigar Lighter Connector End View
- Clockspring Connector End View
- Clutch Pedal Position Up Switch Connector End View
- Compass/Temperature Mirror Module (Convertible) Connector End View
- Crankshaft Position Sensor (Diesel) Connector End View
- Crankshaft Position Sensor (Gas) Connector End View
- Data Link Connector, Connector End View
- Decklid Cylinder Unlock Switch (Vehicle Theft Security System) (Convertible) Connector End View
- Decklid Handle Switch (Convertible) Connector End View
- Decklid Release Motor (Convertible) Connector End View
- Decklid Release Switch (Convertible) Connector End View
- Dome Lamp Connector End View
- Dome Lamp Intrusion Sensor (Export) Connector End View
- Driver Airbag Squib 1 Connector End View
- Driver Door Ajar Switch Connector End View
- Driver Door Handle Switch (Convertible) Connector End View
- Driver Door Power Lock Motor Ajar Switch Connector End View
- Driver Heated Seat Cushion Connector End View
- Driver Heated Seat Switch Connector End View
- Driver Rear Window Motor (Convertible) Connector End View
- Driver Seat Belt Switch Connector End View
- Driver Seat Belt Tensioner Connector End View
- Driver Window Regulator Module (Convertible) Connector End View
- EGR Solenoid (Diesel) Connector End View
- Electronic Throttle Control Module (1.6L) Connector End View
- Engine Control Module (Diesel) Connector End View (C1)
- Engine Control Module (Diesel) Connector End View (C2)
- Engine Coolant Temperature Sensor (Diesel) Connector End View
- Engine Coolant Temperature Sensor (Gas) Connector End View
- Engine Oil Pressure Switch Connector End View
- EVAP Purge Solenoid (Gas) Connector End View
- Front Power Window Switch Connector End View
- Front Washer Pump Motor Connector End View
- Front Wiper Motor Connector End View
- Front Wiper Switch/Washer Switch Connector End View
- Fuel Heater Module (Diesel) Connector End View
- Fuel Injector 1 (Diesel) Connector End View
- Fuel Injector 1 (Gas) Connector End View
- Fuel Injector 2 (Diesel) Connector End View
- Fuel Injector 2 (Gas) Connector End View
- Fuel Injector 3 (Diesel) Connector End View
- Fuel Injector 3 (Gas) Connector End View
- Fuel Injector 4 (Diesel) Connector End View
- Fuel Injector 4 (Gas) Connector End View
- Fuel Pressure Sensor (Diesel) Connector End View
- Fuel Pressure Solenoid (Diesel) Connector End View
- Fuel Pump Module Connector End View
- Generator (2.4L Turbo) Connector End View
- Generator (Diesel) Connector End View
- Generator (Gas Except 2.4L Turbo) Connector End View
- Hands Free Module Connector End View (C1)
- Hands Free Module (Satellite Radio) Connector End View (C2)
- Hands Free Module Connector End View (C3)
- Headlamp Leveling Switch (Export) Connector End View
- Heated Seat Module Connector End View
- High Note Horn (Export) Connector End View
- Hood Ajar Switch (Export) Connector End View
- Idle Air Control Motor (2.4L) Connector End View
- Ignition Coil (Gas) Connector End View
- Ignition Switch Connector End View (C1)
- Ignition Switch (Autostick) Connector End View (C2)
- Inlet Air Temperature Sensor (Gas) Connector End View
- Input Speed Sensor Connector End View
- Instrument Cluster Connector End View (C1)
- Instrument Cluster Connector End View (C2)
- Intake Air Temperature Sensor (Diesel) Connector End View
- Knock Sensor (Gas) Connector End View
- Left Backup Lamp Connector End View
- Left City Lamp (Export) Connector End View
- Left Cylinder Lock Switch Connector End View
- Left Dome Lamp (Convertible) Connector End View
- Left Door Lock Switch Connector End View
- Left Fog Lamp Connector End View
- Left Front Door Speaker Connector End View
- Left Front Park Turn Signal Lamp (Except Export) Connector End View
- Left Front Power Window Motor (Hatchback) Connector End View
- Left Front Side Marker (Export) Connector End View
- Left Front Turn Signal Lamp (Export) Connector End View
- Left Front Wheel Speed Sensor Connector End View
- Left Headlamp Leveling Module (Export) Connector End View
- Left High Beam Headlamp Connector End View
- Left Instrument Panel Speaker Connector End View
- Left License Lamp (Export) Connector End View
- Left Low Beam Headlamp Connector End View
- Left Power Mirror (Except Export) Connector End View
- Left Power Mirror (Export) Connector End View
- Left Rear Door Power Lock Motor Connector End View
- Left Rear Fog Lamp (LHD Export) Connector End View
- Left Rear Power Window Motor (Hatchback) Connector End View
- Left Rear Power Window Switch Connector End View
- Left Rear Speaker (Convertible Base) Connector End View
- Left Rear Speaker (Hatchback) Connector End View
- Left Rear Speaker (Convertible Premium) Connector End View (C1)
- Left Rear Speaker (Convertible Premium) Connector End View (C2)
- Left Rear Turn Signal Lamp Connector End View
- Left Rear Wheel Speed Sensor Connector End View
- Left Seat Airbag Squib (LHD) Connector End View
- Left Seat Airbag Squib (RHD) Connector End View
- Left Side Impact Sensor 1 Connector End View
- Left Tail Stop Lamp Connector End View
- Left Turn Signal Indicator Connector End View
- Left Visor Lamp/Vanity Lamp (Except Base) Connector End View
- License Lamp (Except Export) Connector End View
- Liftgate Ajar Switch Connector End View
- Liftgate Cylinder Lock Switch Connector End View
- Liftgate Handle Switch (Hatchback) Connector End View
- Liftgate Power Lock Motor Connector End View
- Liftgate Release Motor (Hatchback) Connector End View
- Low Note Horn Connector End View
- Manifold Absolute Pressure Sensor (Gas) Connector End View
- Map/Reading Lamps Connector End View
- Mass Air Flow Sensor (Diesel) Connector End View
- Multifunction Switch Connector End View
- Natural Vacuum Leak Detection Assembly (Except Export) Connector End View
- Output Speed Sensor Connector End View
- Overhead Console Module Connector End View
- Upstream Oxygen Sensor 1/1 (Gas) Connector End View
- Downstream Oxygen Sensor 1/2 (Gas) Connector End View
- Passenger Airbag Squib 1 Connector End View
- Passenger Door Ajar Switch Connector End View
- Passenger Door Handle Switch (Convertible) Connector End View
- Passenger Door Power Lock Motor Ajar Switch Connector End View
- Passenger Heated Seat Cushion Connector End View
- Passenger Heated Seat Switch Connector End View
- Passenger Rear Window Motor (Convertible) Connector End View
- Passenger Seat Belt Tensioner Connector End View
- Passenger Window Regulator Module (Convertible) Connector End View
- Positive Crankcase Ventilation Heater (Diesel) Connector End View
- Power Mirror Switch (LHD) Connector End View
- Power Mirror Switch (RHD) Connector End View
- Power Outlet Connector End View
- Power Seat Motor Connector End View
- Power Seat Switch Connector End View
- Power Steering Pressure Switch (Gas) Connector End View
- Power Sunroof Module Connector End View (C1)
- Power Sunroof Module Connector End View (C2)
- Power Top Motor (Convertible) Connector End View
- Power Top Relay (Convertible) Connector End View
- Power Top Switch (Convertible) Connector End View
- Powertrain Control Module (1.6L) Connector End View
- Powertrain Control Module (NGC) Connector End View (C1)
- Powertrain Control Module (NGC) Connector End View (C2)
- Powertrain Control Module (NGC) Connector End View (C3)
- Powertrain Control Module (NGC) Connector End View (C4)
- Radiator Fan Motor (2.4L Turbo) Connector End View
- Radiator Fan Motor (Except 2.4L Turbo) Connector End View
- Radio Connector End View (C1)
- Radio (Hands Free) Connector End View (C2)
- Radio (Satellite Radio) Connector End View (C2)
- Rear Power Outlet (Except Base) Connector End View
- Rear View Mirror Connector End View (C1)
- Rear View Mirror Connector End View (C2)
- Rear Window Defogger Switch Connector End View
- Rear Wiper Motor (Hatchback) Connector End View
- Rear Wiper Switch (Hatchback) Connector End View
- Remote Keyless Entry Module Connector End View
- Right Backup Lamp Connector End View
- Right City Lamp (Export) Connector End View
- Right Cylinder Lock Switch (Export) Connector End View
- Right Dome Lamp (Convertible) Connector End View
- Right Door Lock Switch Connector End View
- Right Fog Lamp Connector End View
- Right Front Door Speaker Connector End View
- Right Front Park Turn Signal Lamp (Except Export) Connector End View
- Right Front Power Window Motor (Hatchback) Connector End View
- Right Front Side Marker (Export) Connector End View
- Right Front Turn Signal Lamp (Export) Connector End View
- Right Front Wheel Speed Sensor Connector End View
- Right Headlamp Leveling Module (Export) Connector End View
- Right High Beam Headlamp Connector End View
- Right Instrument Panel Speaker Connector End View
- Right License Lamp (Export) Connector End View
- Right Low Beam Headlamp Connector End View
- Right Power Mirror (Except Export) Connector End View
- Right Power Mirror (Export) Connector End View
- Right Rear Door Power Lock Motor Connector End View
- Right Rear Fog Lamp (RHD) Connector End View
- Right Rear Power Window Motor (Hatchback) Connector End View
- Right Rear Power Window Switch Connector End View
- Right Rear Speaker (Convertible Base) Connector End View
- Right Rear Speaker (Hatchback) Connector End View
- Right Rear Speaker (Convertible Premium) Connector End View (C1)
- Right Rear Speaker (Convertible Premium) Connector End View (C2)
- Right Rear Turn Signal Lamp Connector End View
- Right Rear Wheel Speed Sensor Connector End View
- Right Seat Airbag Squib (LHD) Connector End View
- Right Seat Airbag Squib (RHD) Connector End View
- Right Side Impact Sensor 1 Connector End View
- Right Tail Stop Lamp Connector End View
- Right Turn Signal Indicator Connector End View
- Right Visor Lamp/Vanity Lamp (Except Base) Connector End View
- Satellite Radio Receiver Connector End View
- Sentry Key Immobilizer Module Connector End View
- Siren (Export) Connector End View
- Speed Control Servo (2.4L) Connector End View
- Speed Control Switch Connector End View
- Sunroof Motor Connector End View
- Surge Solenoid (2.4L Turbo) Connector End View
- Swirl Solenoid (Diesel) Connector End View
- Throttle Inlet Pressure Sensor (2.4L Turbo) Connector End View
- Throttle Inlet Pressure Solenoid (2.4L Turbo) Connector End View
- Throttle Position Sensor (2.4L) Connector End View
- Traction Control Switch Connector End View
- Transmission Range Indicator Illumination (PRNDL) (Autostick) Connector End View
- Transmission Range Indicator Illumination (PRNDL) (Except Autostick) Connector End View
- Transmission Range Sensor (2.4L) Connector End View
- Transmission Solenoid Pressure Switch Assembly (2.4L) Connector End View
- Vehicle Speed Sensor (Diesel) Connector End View
- Vehicle Speed Sensor (Gas M/T) Connector End View
- Wastegate Solenoid (2.4L Turbo) Connector End View
- Wastegate Solenoid (Diesel) Connector End View
- Connector Pin-Outs
- System Wiring Diagrams
- Using lemon2025'S Wiring Diagrams
- Air Conditioning
- Anti-Lock Brakes
- Anti-Theft
- Computer Data Lines
- Cooling Fan
- Cruise Control
- Defoggers
- Engine Performance
- Exterior Lights
- Ground Distribution
- Headlights
- Horn
- Instrument Cluster
- Interior Lights
- Power Distribution
- Power Door Locks
- Power Mirrors
- Power Seats
- Power Top/Sunroof
- Power Windows
- Radio
- Shift Interlock
- Starting/Charging
- Supplemental Restraints
- Transmission
- Trunk, Tailgate, Fuel Door
- Warning Systems
- Wiper/Washer
- Using lemon2025'S System Wiring Diagrams
- Wiring Diagram Information
- Wiring Diagram Information
- Description
- Warnings - General
- Diagnosis And Testing - Wiring Harness
- Standard Procedure
- Standard Procedure - Electrostatic Discharge (ESD) Sensitive Devices
- Standard Procedure - Testing Of Voltage Potential
- Standard Procedure - Testing For Continuity
- Standard Procedure - Testing For A Short To Ground
- Standard Procedure - Testing For A Short To Ground On Fuses Powering Several Loads
- Standard Procedure - Testing For A Voltage Drop
- Special Tools
- Connector
- Diode
- Terminal
- Wire
- Wiring Diagram Information
- Connector End Views
- Body Electrical
- Engine Mechanical
- Accessory Drive Belts
- Engine Cooling System & Automatic Transmission Cooling System
- Cooling
- Accessory Drive - 1.6L SOHC
- Accessory Drive - 2.0/2.4L DOHC
- Engine - 1.6L SOHC
- Engine - 1.6L SOHC
- Coolant
- Hose Clamps
- Coolant Recovery Container
- Engine Block Heater
- Engine Coolant Temp Sensor
- Engine Coolant Thermostat And Housing
- Radiator Pressure Cap
- Radiator DRAINCOCK
- Radiator Fan
- Radiator
- Heater Return Tube
- Water Pump/Power Steering Pump Assembly
- Engine - 2.0/2.4L DOHC
- Engine - 2.0/2.4L DOHC
- Coolant
- Coolant Recovery Container
- Cooling System Pressure Cap
- Engine Block Heater
- Engine Coolant Temperature Sensor
- Engine Coolant Thermostat
- Hose Clamps
- Radiator Fan
- Radiator
- Radiator DRAINCOCK
- Thermostat Housing
- Water Pump
- Water Pump Inlet Tube
- Transmission
- Engine Cooling System & Automatic Transmission Cooling System
- Blowers, Superchargers & Turbochargers
- Exhaust System & Turbocharger
- Exhaust System And Turbocharger
- Muffler
- Intermediate Pipe
- Catalytic Converter
- Support Brackets And Isolators
- Heat Shields
- Turbocharger System
- Turbocharger
- Charge Air Cooler And Hoses
- Lines And Hoses
- Solenoids And Vacuum Harness
- Exhaust System & Turbocharger
- Cooling Fan
- Engine Cooling System & Automatic Transmission Cooling System
- Cooling
- Accessory Drive - 1.6L SOHC
- Accessory Drive - 2.0/2.4L DOHC
- Engine - 1.6L SOHC
- Engine - 1.6L SOHC
- Coolant
- Hose Clamps
- Coolant Recovery Container
- Engine Block Heater
- Engine Coolant Temp Sensor
- Engine Coolant Thermostat And Housing
- Radiator Pressure Cap
- Radiator DRAINCOCK
- Radiator Fan
- Radiator
- Heater Return Tube
- Water Pump/Power Steering Pump Assembly
- Engine - 2.0/2.4L DOHC
- Engine - 2.0/2.4L DOHC
- Coolant
- Coolant Recovery Container
- Cooling System Pressure Cap
- Engine Block Heater
- Engine Coolant Temperature Sensor
- Engine Coolant Thermostat
- Hose Clamps
- Radiator Fan
- Radiator
- Radiator DRAINCOCK
- Thermostat Housing
- Water Pump
- Water Pump Inlet Tube
- Transmission
- Engine Cooling System & Automatic Transmission Cooling System
- Cooling System (Mechanical)
- Engine Cooling System & Automatic Transmission Cooling System
- Cooling
- Accessory Drive - 1.6L SOHC
- Accessory Drive - 2.0/2.4L DOHC
- Engine - 1.6L SOHC
- Engine - 1.6L SOHC
- Coolant
- Hose Clamps
- Coolant Recovery Container
- Engine Block Heater
- Engine Coolant Temp Sensor
- Engine Coolant Thermostat And Housing
- Radiator Pressure Cap
- Radiator DRAINCOCK
- Radiator Fan
- Radiator
- Heater Return Tube
- Water Pump/Power Steering Pump Assembly
- Engine - 2.0/2.4L DOHC
- Engine - 2.0/2.4L DOHC
- Coolant
- Coolant Recovery Container
- Cooling System Pressure Cap
- Engine Block Heater
- Engine Coolant Temperature Sensor
- Engine Coolant Thermostat
- Hose Clamps
- Radiator Fan
- Radiator
- Radiator DRAINCOCK
- Thermostat Housing
- Water Pump
- Water Pump Inlet Tube
- Transmission
- Engine Cooling System & Automatic Transmission Cooling System
- Exhaust System & Turbocharger
- Exhaust System And Turbocharger
- Muffler
- Intermediate Pipe
- Catalytic Converter
- Support Brackets And Isolators
- Heat Shields
- Turbocharger System
- Turbocharger
- Charge Air Cooler And Hoses
- Lines And Hoses
- Solenoids And Vacuum Harness
- Fuel System
- Fuel Delivery
- Fuel Injection
- Fuel Injection
- Accelerator Pedal
- Accelerator Pedal Position Sensor - 1.6L
- Crankshaft Position Sensor
- Fuel Injector
- Fuel Pump Relay
- Idle Air Control Motor
- Inlet Air Temperature Sensor
- Map Sensor
- O2 Sensor
- Throttle Body
- Throttle Control Cable
- Throttle Position Sensor
- Mechanical
- 1.6L SOHC Engine
- Engine 1.6L SOHC
- Air Cleaner Element
- Air Cleaner Housing
- Cylinder Head
- Cylinder Head Cover
- Spark Plug Tube Seal
- Spark Plug Tube
- Rocker Arm Shaft / Rocker Arm / Lash Adjuster
- Camshaft
- Valve Springs And Seals (On Vehicle Service)
- Valve Springs And Seals (Cylinder Head Removed)
- Intake/Exhaust Valves & Seats
- Engine Block
- Crankshaft Main Bearings
- Crankshaft
- Crankshaft Oil Seal - Front
- Crankshaft Oil Seal - Rear
- Piston & Connecting Rod
- Piston Rings
- Vibration Damper
- Engine Mounting
- Torque Struts
- Right Engine Mount Bracket
- Right Mount
- Left Mount
- Lubrication
- Oil Filter Cartridge
- Oil Filter Cartridge Housing
- Oil Pan
- Oil Pump
- Oil Pump Pick-Up
- Intake Manifold
- Exhaust Manifold
- Valve Timing
- Timing Chain Cover
- Timing Chain/Guides/Sprockets
- 2.4L DOHC Engine
- Engine 2.4L DOHC
- Air Cleaner Element
- Air Cleaner Housing
- Cylinder Head
- Camshaft Oil Seal(S)
- Camshaft(S)
- Cylinder Head Cover
- Hydraulic Lash Adjusters
- Intake/Exhaust Valves & Seats
- Rocker Arms
- Valve Springs & Seals
- Engine Block
- Crankshaft
- Crankshaft Oil Seal - Front
- Crankshaft Oil Seal - Rear
- Piston & Connecting Rod
- Connecting Rod Bearings
- Piston Rings
- Structural Collar
- Vibration Damper
- Engine Mounting
- Left Mount
- Right Mount
- Torque Strut
- Lubrication
- Oil
- Oil Filter
- Oil Filter Adapter
- Oil Pan
- Oil Pressure Sensor/Switch
- Oil Pump
- Oil Jet - 2.4L Turbo
- Oil Cooler & Lines - 2.4L Turbo
- Intake Manifold
- Exhaust Manifold
- Timing Belt Cover(S)
- Timing Belt And Sprockets
- Timing Belt TENSIONER & Pulley
- Balance Shafts And Carrier Assembly
- 1.6L SOHC Engine
- Starter
- Powertrain Diagnostic Procedures - Component Testing
- Sentry Key Immobilizer - Symptoms
- Symptom List: ANTENNA FAILURE; COP FAILURE; EEPROM FAILURE; INTERNAL FAULT; RAM FAILURE; SERIAL LINK INTERNAL FAULT; STACK OVERFLOW FAILURE
- Symptom List: PCM STATUS FAILURE; SERIAL LINK EXTERNAL FAULT
- Symptom List: ROLLING CODE FAILURE; VIN MISMATCH
- Symptom List: TRANSPONDER COMMUNICATION FAILURE; TRANSPONDER CYCLIC REDUNDANCY CHECK (CRC) FAILURE; TRANSPONDER ID MISMATCH; TRANSPONDER RESPONSE MISMATCH
- Starting - Symptoms
- Symptom: *CHECKING FUEL DELIVERY
- Symptom: *CHECKING FUEL PRESSURE LEAK DOWN
- Symptom: *CHECKING HARD START (FUEL DELIVERY SYSTEM)
- Symptom: *ENGINE CRANKS DOES NOT START - 1.6L
- Symptom: *ENGINE CRANKS DOES NOT START - 2.0L/2.4L
- Symptom: *NO CRANK CONDITION 1.6L
- Symptom: *NO CRANK CONDITION 2.0L/2.4L
- Symptom: *NO RESPONSE FROM PCM WITH A NO START CONDITION
- Symptom: *START AND STALL CONDITION 1.6L
- Symptom: *START AND STALL CONDITION 2.0L/2.4L
- Verification Test
- Component Locations
- Powertrain And Skim
- Control And Solenoids
- Throttle Body And Component Locations (2.0L/2.4L)
- Generator Location (1.6L)
- Generator and 1/1 O2 Sensor Locations (2.0L/2.4L)
- ETC Assembly And Ignition Coil Locations (1.6L)
- MAP Sensor And Ignition Coil Location (2.0L/2.4L)
- EVAP Purge Solenoid Location (2.0L/2.4L)
- NVLD Location (2.0L/2.4L)
- Speed Control Servo Locations (2.0L/2.4L)
- Speed Control Servo And Solenoids Component Locations (2.4L Turbo Only)
- Data Link Connector
- Sensors
- Battery Temperature Sensor Location (2.0L/2.4L)
- CKP Sensor Location (1.6L)
- CKP Sensor Location (2.0L/2.4L)
- CMP Sensor Location (2.0L/2.4L)
- Coolant Temperature Sensor Location (2.0L/2.4L)
- ECT Sensor Location (1.6L)
- IAT Sensor Location (2.0L/2.4L)
- Knock Sensor Location (1.6L)
- Knock Sensor Location (2.4L)
- MAP Sensor And Injectors Locations (1.6L)
- MAP Sensor Location (2.0L/2.4L)
- MAP Sensor Location (2.4L Turbo Only)
- APP Sensor Location (1.6L)
- O2 Sensors Location (1.6L)
- VSS Location
- Fuel System
- Relays
- Switches
- Connector PINOUTS
- A/C Compressor Clutch (Gas) - Black 2 Way
- A/C Low Pressure Switch - DK. Green 2 Way
- A/C Pressure Transducer - 2 Way
- Accelerator Pedal Position Sensor (1.6L/Diesel) - 10 Way
- Ambient Temperature Sensor (Except 2.4L Base) - Black 2 Way
- Ambient Temperature Sensor (NGC) - Black 2 Way
- Brake Lamp Switch (Gas) - Gray 6 Way
- Camshaft Position Sensor (Diesel) - Black 3 Way
- Camshaft Position Sensor (Gas) - Black 3 Way
- Clutch Pedal Position Switch (Up) - Black 3 Way
- Crankshaft Position Sensor (Gas) - Black 3 Way
- Data Link Connector - Black 16 Way
- EGR Solenoid (Diesel) - 2 Way
- Engine Coolant Temperature Sensor (Diesel) - Black 2 Way
- Engine Coolant Temperature Sensor (Gas) - Black 2 Way
- Engine Oil Pressure Switch - LT. Green 2 Way
- EVAP/Purge Solenoid (Gas) - Black 2 Way
- Fuel Injector No. 1 (Gas) - Black 2 Way
- Fuel Injector No. 2 (Gas) - Black 2 Way
- Fuel Injector No. 3 (Gas) - Black 2 Way
- Fuel Injector No. 4 (Gas) - Black 2 Way
- Fuel Pump Module - LT. Gray 4 Way
- Generator (2.4L Turbo) - Black 2 Way
- Generator (Gas Except 2.4L Turbo) - Black 2 Way
- Idle Air Control Motor (2.4L) - Black 2 Way
- Ignition Coil (Gas) - Black 3 Way
- Inlet Air Temperature Sensor (Gas) - Black 2 Way
- Knock Sensor (Gas) - Black 2 Way
- Manifold Absolute Pressure Sensor (Gas) - Black 3 Way
- Natural Vacuum Leak Detection Assembly (Except Export) - Black 3 Way
- Oxygen Sensor 1/1 Upstream (Gas) - Black 4 Way
- Oxygen Sensor 1/2 Downstream (Gas) - Black 4 Way
- Powertrain Control Module (1.6L) - Black 90 Way
- Powertrain Control Module C1 (NGC) - Black/Black 38 Way
- Powertrain Control Module C2 (NGC) - Black/Orange 38 Way
- Powertrain Control Module C3 (NGC) - Black/Natural 38 Way
- Powertrain Control Module C4 (NGC) - Black/Green 38 Way
- Radiator Fan Motor (2.4L Turbo) - DK. Gray 4 Way
- Radiator Fan Motor (Except 2.4L Turbo) - Black 3 Way
- Sentry Key Immobilizer Module - Black 6 Way
- Speed Control Servo (2.4L) - Black 4 Way
- Speed Control Switch - Yellow 3 Way
- Surge Solenoid (2.4L Turbo) - Black 2 Way
- Throttle Inlet Pressure Sensor (2.4L Turbo) - Natural 3 Way
- Throttle Inlet Pressure Solenoid (2.4L Turbo) - Black 2 Way
- Throttle Position Sensor (2.4L) - Black 3 Way
- Vehicle Speed Sensor (Gas MTX) - Black 3 Way
- WASTEGATE Solenoid (2.4L Turbo) - Black 2 Way
- Schematic Diagrams
- Charts And Graphs
- Vacuum Gauge Reading Examples
- Camshaft Sensor & Crankshaft Sensor Scope Pattern (Typical)
- Accelerator Pedal Position Sensor Specifications (1.6L)
- Camshaft & Crankshaft Sensor Specifications (1.6L)
- Throttle Position Sensor Specifications (1.6L)
- EVAP Tester
- Turbocharger System Circuit Diagrams
- Fuel Gauge Voltage Specifications
- Evaporative Emission System Schematic
- Sentry Key Immobilizer - Symptoms
- Powertrain Diagnostic Procedures - DRIVEABILITY - 1.6L Gas
- DRIVEABILITY - 1.6L Gas - Symptoms
- DRIVEABILITY - 1.6L Gas - Diagnostic Tests
- P0016-Crank And Cam Out-Of-Sync
- P0030-1/1 O2 Sensor Heater Circuit Open; P0036-1/1 O2 Sensor Heater Circuit Open
- P0031-1/1 O2 Sensor Heater Circuit Low; P0037-1/1 O2 Sensor Heater Circuit Low
- P0032-1/1 O2 Sensor Heater Circuit High; P0038-1/2 O2 Sensor Heater Circuit High
- P0106-BARO Pressure Out Of Range
- P0107-Map Sensor Voltage Too Low
- P0108-Map Sensor Voltage Too High
- P0112-Intake Air Temp Sensor Too Low
- P0113-Intake Air Temp Sensor Too High
- P0117-ECT Sensor Voltage Too Low
- P0118-ECT Sensor Voltage Too High
- P0122-Throttle Position Sensor Circuit #1 Low; P0222-Throttle Position Sensor Circuit #2 Low
- P0123-Throttle Position Sensor Circuit #1 High; P0223-Throttle Position Sensor Circuit #2 High
- P0125-Closed Loop Temp Not Reached
- P0128-Coolant Thermostat
- P0131-1/1 O2 Sensor Shorted To Ground; P0137-1/2 O2 Sensor Shorted To Ground
- P0132-1/1 O2 Sensor Shorted To Voltage; P0138-1/2 O2 Sensor Shorted To Voltage
- P0133-1/1 O2 Sensor Slow Response; P0139-1/2 O2 Sensor Slow Response
- P0134-1/1 O2 Sensor Stays At Center; P0140-1/2 O2 Sensor Stays At Center
- P0171-1/1 Fuel System Lean
- P0172-1/1 Fuel System Rich
- P0201-Injector #1 Control Circuit Open; P0202-Injector #2 Control Circuit Open; P0203-Injector #3 Control Circuit Open; P0204-Injector #4 Control Circuit Open
- P0261-Injector #1 Control Circuit Low; P0264-Injector #2 Control Circuit Low; P0267-Injector #3 Control Circuit Low; P0270-Injector #4 Control Circuit Low
- P0262-Injector #1 Control Circuit High; P0265-Injector #2 Control Circuit High; P0268-Injector #3 Control Circuit High; P0271-Injector #4 Control Circuit High
- P0300-Multiple Cylinder Mis-Fire; P0301-Cylinder #1 Misfire; P0302-Cylinder #2 Misfire; P0303-Cylinder #3 Misfire; P0304-Cylinder #4 Misfire
- P0315-No Crank Learned
- P0325-Knock Sensor #1 Circuit
- P0335-No Crank Signal At Pcm
- P0336-Crankshaft Position Sensor Performance
- P0340-No Cam Signal At Pcm
- P0420-1/1 Catalytic Converter Efficiency
- P0444-EVAP Purge Solenoid Circuit Open
- P0458-EVAP Purge Solenoid Low
- P0459-EVAP Purge Solenoid Circuit High
- P0461-Fuel Level Unit No Change Over Time
- P0462-Fuel Level Sending Unit Volts Too Low
- P0463-Fuel Level Sending Unit Volts Too High
- P0500-No Vehicle Speed Sensor Signal
- P0506-Idle Speed Performance Lower Than Excepted
- P0507-Idle Speed Performance Higher Than Excepted
- P0513-Invalid Skim Key
- P0551-Power Steering Switch Failure
- P0562-Charging System Voltage Too Low
- P0563-Charging System Voltage Too High
- P0572-Brake Switch Circuit Low
- P0573-Brake Switch Circuit High
- P0580-Speed Control Switch Always Low
- P0625-Generator Field Control Circuit Low
- P0626-Generator Field Control Circuit High
- P0628-Fuel Pump Relay Control Circuit Low
- P0629-Fuel Pump Relay Control Circuit High
- P0646-A/C Clutch Relay Control Circuit Low
- P0647-A/C Clutch Relay Control Circuit High
- P0686-ASD Relay Control Circuit Low
- P0687-ASD Relay Control Circuit High
- P0688-ASD Relay Output Circuit Low
- P0690-ASD Relay Output Circuit High
- P0691-Low Speed Fan Relay Control Circuit Low; P0693-High Speed Fan Relay Control Circuit Low
- P0692-Low Speed Fan Relay Control Circuit High P0694-High Speed Fan Relay Control Circuit High
- P0703-Brake Lamp Switch Circuit Performance
- P0719-Brake Lamp Switch Circuit Low
- P0724-Brake Lamp Switch Circuit High
- P0833-Clutch UPSTOP Switch Performance
- P1135-1/1 O2 Heater Element Resistance Out Of Range; P1136-1/2 Heater Element Resistance Out Of Range
- P1594-Charging System Voltage Too High
- P1616-5V Output Reference Voltage #1 Low
- P1617-5V Output Reference Voltage #1 High
- P1618-5V Output Reference Voltage Unstable
- P1626-5V Output Reference Voltage #2 Low
- P1627-5V Output Reference Voltage #2 High
- P1628-5V Output Reference Voltage #1 Unstable
- P1653-PCI Bus Shorted To Ground
- P1654-PCI Bus Shorted To Voltage
- P1656-PCI Bus Not Available
- P1686-No Skim Bus Message Received
- P1687-No Cluster Bus Message
- P2100-Electronic Throttle Control Motor Circuit
- P2101-Electronic Throttle Control Motor Performance
- P2107-Electronic Throttle Control Module Processor; P2108-Electronic Throttle Control Module Performance
- P2122-Accelerator Pedal Position Sensor # 1 Low; P2127-Accelerator Pedal Position Sensor #2 Low
- P2123-Accelerator Pedal Position Sensor #1 High; P2128-Accelerator Pedal Position Sensor #2 High
- P2135-Throttle Position Sensor #1 And #2 Voltage Correlation
- P2138-Accelerator Pedal Position Sensor #1 And #2 Voltage Correlation
- P2300-Ignition Coil #1 Circuit Low; P2303-Ignition Coil #2 Circuit Low
- P2301-Ignition Coil #1 Circuit High; P2304-Ignition Coil #2 Circuit High
- Powertrain Diagnostic Procedures - DRIVEABILITY - NGC
- DRIVEABILITY - NGC - Symptoms
- DRIVEABILITY - NGC - Diagnostic Tests
- P0016-Crankshaft/Camshaft Timing Misalignment
- P0031-O2 Sensor 1/1 Heater Circuit Low; P0037-O2 Sensor 1/2 Heater Circuit Low
- P0032-O2 Sensor 1/1 Heater Circuit High P0038-O2 Sensor 1/2 Heater Circuit High
- P0033-Surge Valve Solenoid Circuit
- P0068-Manifold Pressure/Throttle Position Correlation
- P0071-Ambient Temp Sensor Performance
- P0072-Ambient Temp Sensor Low
- P0073-Ambient Temp Sensor High
- P0107-Map Sensor Low
- P0108-Map Sensor High
- P0111-Intake Air Temperature Sensor Performance
- P0112-Intake Air Temperature Sensor Low
- P0113-Intake Air Temperature Sensor High
- P0116-Engine Coolant Temperature Performance
- P0117-Engine Coolant Temperature Sensor Low
- P0118-Engine Coolant Temperature Sensor High
- P0122-Throttle Position Sensor #1 Low
- P0123-Throttle Position Sensor #1 High
- P0125-Insufficient Coolant Temp For Closed-Loop Fuel Control
- P0128-Thermostat Rationality
- P0129-Barometric Pressure Out-Of-Range
- P0131-O2 Sensor 1/1 Voltage Low; P0137-O2 Sensor 1/2 Voltage Low
- P0132-O2 Sensor 1/1 Voltage High; P0138-O2 Sensor 1/2 Voltage High
- P0133-O2 Sensor 1/1 Slow Response; P0139-O2 Sensor 1/2 Slow Response
- P0135-O2 Sensor 1/1 Heater Performance; P0141-O2 Sensor 1/2 Heater Performance
- P0171-Fuel System 1/1 Lean
- P0172-Fuel System 1/1 Rich
- P0201-Fuel Injector #1; P0202-Fuel Injector #2; P0203-Fuel Injector #3; P0204-Fuel Injector #4
- P0234-OVERBOOST Performance; P1106-BARO Solenoid Performance; P1188 Tip Sensor Performance
- P0243-WASTEGATE Solenoid Circuit
- P0300-Multiple Cylinder Misfire; P0301-Cylinder #1 Misfire; P0302-Cylinder #2 Misfire; P0303-Cylinder #3 Misfire; P0304-Cylinder #4 Misfire
- P0315-No Crank Sensor Learned
- P0325-Knock Sensor #1 Circuit
- P0335-Crankshaft Position Sensor Circuit
- P0339-Crankshaft Position Sensor Intermittent
- P0340-Camshaft Position Sensor Circuit
- P0344-Camshaft Position Sensor Intermittent
- P0420-Catalytic 1/1 Efficiency
- P0440-General EVAP System Failure
- P0441-EVAP Purge System Performance
- P0442-EVAP System Medium Leak; P0455-EVAP System Large Leak
- P0443-EVAP Purge Solenoid Circuit
- P0452-NVLD Pressure Switch Stuck Closed
- P0453-NVLD Pressure Switch Stuck Open
- P0456-EVAP System Small Leak
- P0457-Loose Fuel Cap
- P0461-Fuel Level Sensor #1 Performance
- P0462-Fuel Level Sensor #1 Low; P0463-Fuel Level Sensor #1 High
- P0480-Cooling Fan 1 Control Circuit
- P0481-Cooling Fan 2 Control Circuit
- P0498-NVLD Canister Vent Valve Solenoid Circuit Low
- P0499-NVLD Canister Vent Valve Solenoid Circuit High
- P0501-Vehicle Speed Sensor #1 Performance (Auto Trans)
- P0501-Vehicle Speed Sensor #1 Performance (Manual Trans)
- P0506-Idle Speed Low Performance; P0507-Idle Speed High Performance
- P0508-IAC Valve Sense Circuit Low
- P0509-IAC Valve Sense Circuit High
- P0513-Invalid Skim Key
- P0516-Battery Temperature Sensor Low
- P0517-Battery Temperature Sensor High
- P0522-Oil Pressure Sensor Low
- P0551-Power Steering Switch Performance
- P0562-Battery Voltage Low
- P0563-Battery Voltage High
- P0572-Brake Switch #1 Circuit Low
- P0573-Brake Switch #1 Circuit High
- P0580-Speed Control Switch #1 Low
- P0581-Speed Control Switch #1 High
- P0582-Speed Control Vacuum Solenoid Circuit
- P0586-Speed Control Vent Solenoid Circuit
- P0594-Speed Control Servo Power Circuit
- P0600-Serial Communication Link; P0601-Internal Memory Checksum Invalid
- P0622-Generator Field Control Circuit
- P0627-Fuel Pump Relay Circuit
- P0630-VIN Not Programmed In Pcm
- P0632-Odometer Not Programmed In Pcm
- P0633-Skim Key Not Programmed In Pcm
- P0645-A/C Clutch Relay Circuit
- P0685-ASD Relay Control Circuit
- P0688-ASD Relay Sense Circuit Low
- P0700-Transmission Control System/Read Transmission DTCS On The DRBIII®
- P0850-Park/Neutral Switch Performance
- P1105-Tip Sensor Solenoid Circuit
- P1115-General Temp Sensor Performance
- P1187-THOTTLE Inlet Pressure/Map Correlation
- P1189-Tip Sensor Circuit Low
- P1190-Tip Sensor Circuit High
- P1593-Speed Control Switch Stuck
- P1603-Pcm Internal Dual-Port Ram Communication; P1604-Pcm Internal Dual-Port Ram Read/Write Integrity Failure; P1607-Pcm Internal Shutdown Timer Rationality
- P1696-EEPROM Memory Write Denied/Invalid; P1697-EMR (Sri) Mileage Not Stored
- P1854-Tip BARO Out Of Range
- P2074-Manifold Pressure/Throttle Position Correlation - High Flow/Vacuum Leak
- P2096-Down Stream Fuel System 1/2 Lean; P2097-Down Stream Fuel System 1/2 Rich
- P2302-Ignition Coil #1 Secondary Circuit-Insufficient Ionization; P2305-Ignition Coil #2 Secondary Circuit-Insufficient Ionization
- P2503-Charging System Voltage Low
- U0101-No Transmission Bus Message
- U0155-No Cluster Bus Message
- U0168-No Skim Bus Messages
- U110C-No Fuel Level Bus Message
- Powertrain Diagnostic Procedures - Introduction
- DTC Index
- Introduction
- Identification Of System
- System Description And Functional Operation
- General Description
- Functional Operation
- Fuel Control
- On-Board Diagnostics
- Other Controls
- Pcm Operating Modes
- Non-Monitored Circuits
- Skis Overview
- Skim On-Board Diagnostics
- Skis Operation
- Programming The Powertrain Control Module
- Programming The Sentry Key Immobilizer Module
- Programming The Ignition Keys To The Sentry Key Immobilizer Module
- Diagnostic Trouble Codes
- Using The DRBIII®
- DRBIII® Error Messages And Blank Screen
- Disclaimers, Safety, Warnings
- Required Tools And Equipment
- Glossary Of Terms
- Diagnostic Information And Procedures
- Communication - Symptoms
- Symptom: *NO RESPONSE FROM PCM (PCI BUS) - 1.6L
- Symptom: *NO RESPONSE FROM PCM (PCI BUS) - NGC
- Symptom: *NO RESPONSE FROM PCM (PCM SCI ONLY) - NGC
- Symptom: *NO RESPONSE FROM PCM (SCI ONLY) - 1.6L
- Symptom: *NO RESPONSE FROM SENTRY KEY IMMOBILIZER MODULE
- Symptom: *NO RESPONSE FROM TRANSMISSION CONTROL MODULE - NGC
- Symptom: *PCI BUS COMMUNICATION FAILURE
- Communication - Symptoms
- Starting System
- Powertrain Diagnostic Procedures - Component Testing
- Accessory Drive Belts
- Engine Performance
- Emissions
- Emission Applications
- Emission Control Abbreviations
- State Emission Standards - Diesel
- State Emission Standards - Gas
- ALASKA
- ARIZONA
- CALIFORNIA
- Colorado
- CONNECTICUT
- DELAWARE
- District Of COLUMBIA
- GEORGIA
- IDAHO
- ILLINOIS
- INDIANA
- KENTUCKY
- MARYLAND
- MASSACHUSETTS
- MISSOURI
- NEVADA
- New Jersey
- New MEXICO
- New YORK
- North CAROLINA
- OHIO
- OREGON
- PENNSYLVANIA
- RHODE Island
- TENNESSEE
- TEXAS
- UTAH
- VIRGINIA
- WASHINGTON
- WISCONSIN
- U. S. EPA ASM2525 & ASM5015 Start-Up Emission Standards
- U. S. EPA Revised Final ASM Emission Standards (ASM5015 & ASM2525)
- U.S. EPA Im240 Emission Standards
- Fuel Delivery
- Fuel System
- Fuel Delivery
- Fuel Injection
- Fuel Injection
- Accelerator Pedal
- Accelerator Pedal Position Sensor - 1.6L
- Crankshaft Position Sensor
- Fuel Injector
- Fuel Pump Relay
- Idle Air Control Motor
- Inlet Air Temperature Sensor
- Map Sensor
- O2 Sensor
- Throttle Body
- Throttle Control Cable
- Throttle Position Sensor
- Fuel System
- Ignition System
- Mode 6 - CHRYSLER
- Introduction
- 1996
- 1997-1998
- 1999
- 2000
- 2001
- 2002
- 2003-2004
- 2005
- 2006
- 2007
- 2007-09 Diesel Engines
- 2008
- 2008-10 Viper
- 2009-10 Pt Cruiser
- 2009 - All Vehicles With V6 Or V8 Engines
- 2009 Vehicles With The "World I4" 4 Cylinder Engine
- 2010 Vehicles
- 2011 Vehicles
- 2012 Vehicles
- Specifications
- System
- Emission Control System
- Emissions Control
- Evaporative Emissions
- Exhaust Gas RECIRCULATION (EGR) System
- On-Board Diagnostics
- O2 Sensor Location & Identification
- Powertrain Diagnostic Procedures - Component Testing
- Sentry Key Immobilizer - Symptoms
- Symptom List: ANTENNA FAILURE; COP FAILURE; EEPROM FAILURE; INTERNAL FAULT; RAM FAILURE; SERIAL LINK INTERNAL FAULT; STACK OVERFLOW FAILURE
- Symptom List: PCM STATUS FAILURE; SERIAL LINK EXTERNAL FAULT
- Symptom List: ROLLING CODE FAILURE; VIN MISMATCH
- Symptom List: TRANSPONDER COMMUNICATION FAILURE; TRANSPONDER CYCLIC REDUNDANCY CHECK (CRC) FAILURE; TRANSPONDER ID MISMATCH; TRANSPONDER RESPONSE MISMATCH
- Starting - Symptoms
- Symptom: *CHECKING FUEL DELIVERY
- Symptom: *CHECKING FUEL PRESSURE LEAK DOWN
- Symptom: *CHECKING HARD START (FUEL DELIVERY SYSTEM)
- Symptom: *ENGINE CRANKS DOES NOT START - 1.6L
- Symptom: *ENGINE CRANKS DOES NOT START - 2.0L/2.4L
- Symptom: *NO CRANK CONDITION 1.6L
- Symptom: *NO CRANK CONDITION 2.0L/2.4L
- Symptom: *NO RESPONSE FROM PCM WITH A NO START CONDITION
- Symptom: *START AND STALL CONDITION 1.6L
- Symptom: *START AND STALL CONDITION 2.0L/2.4L
- Verification Test
- Component Locations
- Powertrain And Skim
- Control And Solenoids
- Throttle Body And Component Locations (2.0L/2.4L)
- Generator Location (1.6L)
- Generator and 1/1 O2 Sensor Locations (2.0L/2.4L)
- ETC Assembly And Ignition Coil Locations (1.6L)
- MAP Sensor And Ignition Coil Location (2.0L/2.4L)
- EVAP Purge Solenoid Location (2.0L/2.4L)
- NVLD Location (2.0L/2.4L)
- Speed Control Servo Locations (2.0L/2.4L)
- Speed Control Servo And Solenoids Component Locations (2.4L Turbo Only)
- Data Link Connector
- Sensors
- Battery Temperature Sensor Location (2.0L/2.4L)
- CKP Sensor Location (1.6L)
- CKP Sensor Location (2.0L/2.4L)
- CMP Sensor Location (2.0L/2.4L)
- Coolant Temperature Sensor Location (2.0L/2.4L)
- ECT Sensor Location (1.6L)
- IAT Sensor Location (2.0L/2.4L)
- Knock Sensor Location (1.6L)
- Knock Sensor Location (2.4L)
- MAP Sensor And Injectors Locations (1.6L)
- MAP Sensor Location (2.0L/2.4L)
- MAP Sensor Location (2.4L Turbo Only)
- APP Sensor Location (1.6L)
- O2 Sensors Location (1.6L)
- VSS Location
- Fuel System
- Relays
- Switches
- Connector PINOUTS
- A/C Compressor Clutch (Gas) - Black 2 Way
- A/C Low Pressure Switch - DK. Green 2 Way
- A/C Pressure Transducer - 2 Way
- Accelerator Pedal Position Sensor (1.6L/Diesel) - 10 Way
- Ambient Temperature Sensor (Except 2.4L Base) - Black 2 Way
- Ambient Temperature Sensor (NGC) - Black 2 Way
- Brake Lamp Switch (Gas) - Gray 6 Way
- Camshaft Position Sensor (Diesel) - Black 3 Way
- Camshaft Position Sensor (Gas) - Black 3 Way
- Clutch Pedal Position Switch (Up) - Black 3 Way
- Crankshaft Position Sensor (Gas) - Black 3 Way
- Data Link Connector - Black 16 Way
- EGR Solenoid (Diesel) - 2 Way
- Engine Coolant Temperature Sensor (Diesel) - Black 2 Way
- Engine Coolant Temperature Sensor (Gas) - Black 2 Way
- Engine Oil Pressure Switch - LT. Green 2 Way
- EVAP/Purge Solenoid (Gas) - Black 2 Way
- Fuel Injector No. 1 (Gas) - Black 2 Way
- Fuel Injector No. 2 (Gas) - Black 2 Way
- Fuel Injector No. 3 (Gas) - Black 2 Way
- Fuel Injector No. 4 (Gas) - Black 2 Way
- Fuel Pump Module - LT. Gray 4 Way
- Generator (2.4L Turbo) - Black 2 Way
- Generator (Gas Except 2.4L Turbo) - Black 2 Way
- Idle Air Control Motor (2.4L) - Black 2 Way
- Ignition Coil (Gas) - Black 3 Way
- Inlet Air Temperature Sensor (Gas) - Black 2 Way
- Knock Sensor (Gas) - Black 2 Way
- Manifold Absolute Pressure Sensor (Gas) - Black 3 Way
- Natural Vacuum Leak Detection Assembly (Except Export) - Black 3 Way
- Oxygen Sensor 1/1 Upstream (Gas) - Black 4 Way
- Oxygen Sensor 1/2 Downstream (Gas) - Black 4 Way
- Powertrain Control Module (1.6L) - Black 90 Way
- Powertrain Control Module C1 (NGC) - Black/Black 38 Way
- Powertrain Control Module C2 (NGC) - Black/Orange 38 Way
- Powertrain Control Module C3 (NGC) - Black/Natural 38 Way
- Powertrain Control Module C4 (NGC) - Black/Green 38 Way
- Radiator Fan Motor (2.4L Turbo) - DK. Gray 4 Way
- Radiator Fan Motor (Except 2.4L Turbo) - Black 3 Way
- Sentry Key Immobilizer Module - Black 6 Way
- Speed Control Servo (2.4L) - Black 4 Way
- Speed Control Switch - Yellow 3 Way
- Surge Solenoid (2.4L Turbo) - Black 2 Way
- Throttle Inlet Pressure Sensor (2.4L Turbo) - Natural 3 Way
- Throttle Inlet Pressure Solenoid (2.4L Turbo) - Black 2 Way
- Throttle Position Sensor (2.4L) - Black 3 Way
- Vehicle Speed Sensor (Gas MTX) - Black 3 Way
- WASTEGATE Solenoid (2.4L Turbo) - Black 2 Way
- Schematic Diagrams
- Charts And Graphs
- Vacuum Gauge Reading Examples
- Camshaft Sensor & Crankshaft Sensor Scope Pattern (Typical)
- Accelerator Pedal Position Sensor Specifications (1.6L)
- Camshaft & Crankshaft Sensor Specifications (1.6L)
- Throttle Position Sensor Specifications (1.6L)
- EVAP Tester
- Turbocharger System Circuit Diagrams
- Fuel Gauge Voltage Specifications
- Evaporative Emission System Schematic
- Sentry Key Immobilizer - Symptoms
- Powertrain Diagnostic Procedures - DRIVEABILITY - 1.6L Gas
- DRIVEABILITY - 1.6L Gas - Symptoms
- DRIVEABILITY - 1.6L Gas - Diagnostic Tests
- P0016-Crank And Cam Out-Of-Sync
- P0030-1/1 O2 Sensor Heater Circuit Open; P0036-1/1 O2 Sensor Heater Circuit Open
- P0031-1/1 O2 Sensor Heater Circuit Low; P0037-1/1 O2 Sensor Heater Circuit Low
- P0032-1/1 O2 Sensor Heater Circuit High; P0038-1/2 O2 Sensor Heater Circuit High
- P0106-BARO Pressure Out Of Range
- P0107-Map Sensor Voltage Too Low
- P0108-Map Sensor Voltage Too High
- P0112-Intake Air Temp Sensor Too Low
- P0113-Intake Air Temp Sensor Too High
- P0117-ECT Sensor Voltage Too Low
- P0118-ECT Sensor Voltage Too High
- P0122-Throttle Position Sensor Circuit #1 Low; P0222-Throttle Position Sensor Circuit #2 Low
- P0123-Throttle Position Sensor Circuit #1 High; P0223-Throttle Position Sensor Circuit #2 High
- P0125-Closed Loop Temp Not Reached
- P0128-Coolant Thermostat
- P0131-1/1 O2 Sensor Shorted To Ground; P0137-1/2 O2 Sensor Shorted To Ground
- P0132-1/1 O2 Sensor Shorted To Voltage; P0138-1/2 O2 Sensor Shorted To Voltage
- P0133-1/1 O2 Sensor Slow Response; P0139-1/2 O2 Sensor Slow Response
- P0134-1/1 O2 Sensor Stays At Center; P0140-1/2 O2 Sensor Stays At Center
- P0171-1/1 Fuel System Lean
- P0172-1/1 Fuel System Rich
- P0201-Injector #1 Control Circuit Open; P0202-Injector #2 Control Circuit Open; P0203-Injector #3 Control Circuit Open; P0204-Injector #4 Control Circuit Open
- P0261-Injector #1 Control Circuit Low; P0264-Injector #2 Control Circuit Low; P0267-Injector #3 Control Circuit Low; P0270-Injector #4 Control Circuit Low
- P0262-Injector #1 Control Circuit High; P0265-Injector #2 Control Circuit High; P0268-Injector #3 Control Circuit High; P0271-Injector #4 Control Circuit High
- P0300-Multiple Cylinder Mis-Fire; P0301-Cylinder #1 Misfire; P0302-Cylinder #2 Misfire; P0303-Cylinder #3 Misfire; P0304-Cylinder #4 Misfire
- P0315-No Crank Learned
- P0325-Knock Sensor #1 Circuit
- P0335-No Crank Signal At Pcm
- P0336-Crankshaft Position Sensor Performance
- P0340-No Cam Signal At Pcm
- P0420-1/1 Catalytic Converter Efficiency
- P0444-EVAP Purge Solenoid Circuit Open
- P0458-EVAP Purge Solenoid Low
- P0459-EVAP Purge Solenoid Circuit High
- P0461-Fuel Level Unit No Change Over Time
- P0462-Fuel Level Sending Unit Volts Too Low
- P0463-Fuel Level Sending Unit Volts Too High
- P0500-No Vehicle Speed Sensor Signal
- P0506-Idle Speed Performance Lower Than Excepted
- P0507-Idle Speed Performance Higher Than Excepted
- P0513-Invalid Skim Key
- P0551-Power Steering Switch Failure
- P0562-Charging System Voltage Too Low
- P0563-Charging System Voltage Too High
- P0572-Brake Switch Circuit Low
- P0573-Brake Switch Circuit High
- P0580-Speed Control Switch Always Low
- P0625-Generator Field Control Circuit Low
- P0626-Generator Field Control Circuit High
- P0628-Fuel Pump Relay Control Circuit Low
- P0629-Fuel Pump Relay Control Circuit High
- P0646-A/C Clutch Relay Control Circuit Low
- P0647-A/C Clutch Relay Control Circuit High
- P0686-ASD Relay Control Circuit Low
- P0687-ASD Relay Control Circuit High
- P0688-ASD Relay Output Circuit Low
- P0690-ASD Relay Output Circuit High
- P0691-Low Speed Fan Relay Control Circuit Low; P0693-High Speed Fan Relay Control Circuit Low
- P0692-Low Speed Fan Relay Control Circuit High P0694-High Speed Fan Relay Control Circuit High
- P0703-Brake Lamp Switch Circuit Performance
- P0719-Brake Lamp Switch Circuit Low
- P0724-Brake Lamp Switch Circuit High
- P0833-Clutch UPSTOP Switch Performance
- P1135-1/1 O2 Heater Element Resistance Out Of Range; P1136-1/2 Heater Element Resistance Out Of Range
- P1594-Charging System Voltage Too High
- P1616-5V Output Reference Voltage #1 Low
- P1617-5V Output Reference Voltage #1 High
- P1618-5V Output Reference Voltage Unstable
- P1626-5V Output Reference Voltage #2 Low
- P1627-5V Output Reference Voltage #2 High
- P1628-5V Output Reference Voltage #1 Unstable
- P1653-PCI Bus Shorted To Ground
- P1654-PCI Bus Shorted To Voltage
- P1656-PCI Bus Not Available
- P1686-No Skim Bus Message Received
- P1687-No Cluster Bus Message
- P2100-Electronic Throttle Control Motor Circuit
- P2101-Electronic Throttle Control Motor Performance
- P2107-Electronic Throttle Control Module Processor; P2108-Electronic Throttle Control Module Performance
- P2122-Accelerator Pedal Position Sensor # 1 Low; P2127-Accelerator Pedal Position Sensor #2 Low
- P2123-Accelerator Pedal Position Sensor #1 High; P2128-Accelerator Pedal Position Sensor #2 High
- P2135-Throttle Position Sensor #1 And #2 Voltage Correlation
- P2138-Accelerator Pedal Position Sensor #1 And #2 Voltage Correlation
- P2300-Ignition Coil #1 Circuit Low; P2303-Ignition Coil #2 Circuit Low
- P2301-Ignition Coil #1 Circuit High; P2304-Ignition Coil #2 Circuit High
- Powertrain Diagnostic Procedures - DRIVEABILITY - NGC
- DRIVEABILITY - NGC - Symptoms
- DRIVEABILITY - NGC - Diagnostic Tests
- P0016-Crankshaft/Camshaft Timing Misalignment
- P0031-O2 Sensor 1/1 Heater Circuit Low; P0037-O2 Sensor 1/2 Heater Circuit Low
- P0032-O2 Sensor 1/1 Heater Circuit High P0038-O2 Sensor 1/2 Heater Circuit High
- P0033-Surge Valve Solenoid Circuit
- P0068-Manifold Pressure/Throttle Position Correlation
- P0071-Ambient Temp Sensor Performance
- P0072-Ambient Temp Sensor Low
- P0073-Ambient Temp Sensor High
- P0107-Map Sensor Low
- P0108-Map Sensor High
- P0111-Intake Air Temperature Sensor Performance
- P0112-Intake Air Temperature Sensor Low
- P0113-Intake Air Temperature Sensor High
- P0116-Engine Coolant Temperature Performance
- P0117-Engine Coolant Temperature Sensor Low
- P0118-Engine Coolant Temperature Sensor High
- P0122-Throttle Position Sensor #1 Low
- P0123-Throttle Position Sensor #1 High
- P0125-Insufficient Coolant Temp For Closed-Loop Fuel Control
- P0128-Thermostat Rationality
- P0129-Barometric Pressure Out-Of-Range
- P0131-O2 Sensor 1/1 Voltage Low; P0137-O2 Sensor 1/2 Voltage Low
- P0132-O2 Sensor 1/1 Voltage High; P0138-O2 Sensor 1/2 Voltage High
- P0133-O2 Sensor 1/1 Slow Response; P0139-O2 Sensor 1/2 Slow Response
- P0135-O2 Sensor 1/1 Heater Performance; P0141-O2 Sensor 1/2 Heater Performance
- P0171-Fuel System 1/1 Lean
- P0172-Fuel System 1/1 Rich
- P0201-Fuel Injector #1; P0202-Fuel Injector #2; P0203-Fuel Injector #3; P0204-Fuel Injector #4
- P0234-OVERBOOST Performance; P1106-BARO Solenoid Performance; P1188 Tip Sensor Performance
- P0243-WASTEGATE Solenoid Circuit
- P0300-Multiple Cylinder Misfire; P0301-Cylinder #1 Misfire; P0302-Cylinder #2 Misfire; P0303-Cylinder #3 Misfire; P0304-Cylinder #4 Misfire
- P0315-No Crank Sensor Learned
- P0325-Knock Sensor #1 Circuit
- P0335-Crankshaft Position Sensor Circuit
- P0339-Crankshaft Position Sensor Intermittent
- P0340-Camshaft Position Sensor Circuit
- P0344-Camshaft Position Sensor Intermittent
- P0420-Catalytic 1/1 Efficiency
- P0440-General EVAP System Failure
- P0441-EVAP Purge System Performance
- P0442-EVAP System Medium Leak; P0455-EVAP System Large Leak
- P0443-EVAP Purge Solenoid Circuit
- P0452-NVLD Pressure Switch Stuck Closed
- P0453-NVLD Pressure Switch Stuck Open
- P0456-EVAP System Small Leak
- P0457-Loose Fuel Cap
- P0461-Fuel Level Sensor #1 Performance
- P0462-Fuel Level Sensor #1 Low; P0463-Fuel Level Sensor #1 High
- P0480-Cooling Fan 1 Control Circuit
- P0481-Cooling Fan 2 Control Circuit
- P0498-NVLD Canister Vent Valve Solenoid Circuit Low
- P0499-NVLD Canister Vent Valve Solenoid Circuit High
- P0501-Vehicle Speed Sensor #1 Performance (Auto Trans)
- P0501-Vehicle Speed Sensor #1 Performance (Manual Trans)
- P0506-Idle Speed Low Performance; P0507-Idle Speed High Performance
- P0508-IAC Valve Sense Circuit Low
- P0509-IAC Valve Sense Circuit High
- P0513-Invalid Skim Key
- P0516-Battery Temperature Sensor Low
- P0517-Battery Temperature Sensor High
- P0522-Oil Pressure Sensor Low
- P0551-Power Steering Switch Performance
- P0562-Battery Voltage Low
- P0563-Battery Voltage High
- P0572-Brake Switch #1 Circuit Low
- P0573-Brake Switch #1 Circuit High
- P0580-Speed Control Switch #1 Low
- P0581-Speed Control Switch #1 High
- P0582-Speed Control Vacuum Solenoid Circuit
- P0586-Speed Control Vent Solenoid Circuit
- P0594-Speed Control Servo Power Circuit
- P0600-Serial Communication Link; P0601-Internal Memory Checksum Invalid
- P0622-Generator Field Control Circuit
- P0627-Fuel Pump Relay Circuit
- P0630-VIN Not Programmed In Pcm
- P0632-Odometer Not Programmed In Pcm
- P0633-Skim Key Not Programmed In Pcm
- P0645-A/C Clutch Relay Circuit
- P0685-ASD Relay Control Circuit
- P0688-ASD Relay Sense Circuit Low
- P0700-Transmission Control System/Read Transmission DTCS On The DRBIII®
- P0850-Park/Neutral Switch Performance
- P1105-Tip Sensor Solenoid Circuit
- P1115-General Temp Sensor Performance
- P1187-THOTTLE Inlet Pressure/Map Correlation
- P1189-Tip Sensor Circuit Low
- P1190-Tip Sensor Circuit High
- P1593-Speed Control Switch Stuck
- P1603-Pcm Internal Dual-Port Ram Communication; P1604-Pcm Internal Dual-Port Ram Read/Write Integrity Failure; P1607-Pcm Internal Shutdown Timer Rationality
- P1696-EEPROM Memory Write Denied/Invalid; P1697-EMR (Sri) Mileage Not Stored
- P1854-Tip BARO Out Of Range
- P2074-Manifold Pressure/Throttle Position Correlation - High Flow/Vacuum Leak
- P2096-Down Stream Fuel System 1/2 Lean; P2097-Down Stream Fuel System 1/2 Rich
- P2302-Ignition Coil #1 Secondary Circuit-Insufficient Ionization; P2305-Ignition Coil #2 Secondary Circuit-Insufficient Ionization
- P2503-Charging System Voltage Low
- U0101-No Transmission Bus Message
- U0155-No Cluster Bus Message
- U0168-No Skim Bus Messages
- U110C-No Fuel Level Bus Message
- Powertrain Diagnostic Procedures - Introduction
- DTC Index
- Introduction
- Identification Of System
- System Description And Functional Operation
- General Description
- Functional Operation
- Fuel Control
- On-Board Diagnostics
- Other Controls
- Pcm Operating Modes
- Non-Monitored Circuits
- Skis Overview
- Skim On-Board Diagnostics
- Skis Operation
- Programming The Powertrain Control Module
- Programming The Sentry Key Immobilizer Module
- Programming The Ignition Keys To The Sentry Key Immobilizer Module
- Diagnostic Trouble Codes
- Using The DRBIII®
- DRBIII® Error Messages And Blank Screen
- Disclaimers, Safety, Warnings
- Required Tools And Equipment
- Glossary Of Terms
- Diagnostic Information And Procedures
- Communication - Symptoms
- Symptom: *NO RESPONSE FROM PCM (PCI BUS) - 1.6L
- Symptom: *NO RESPONSE FROM PCM (PCI BUS) - NGC
- Symptom: *NO RESPONSE FROM PCM (PCM SCI ONLY) - NGC
- Symptom: *NO RESPONSE FROM PCM (SCI ONLY) - 1.6L
- Symptom: *NO RESPONSE FROM SENTRY KEY IMMOBILIZER MODULE
- Symptom: *NO RESPONSE FROM TRANSMISSION CONTROL MODULE - NGC
- Symptom: *PCI BUS COMMUNICATION FAILURE
- Communication - Symptoms
- Emission Control System
- Testing & Diagnosis
- Emission Control System
- Emissions Control
- Evaporative Emissions
- Exhaust Gas RECIRCULATION (EGR) System
- On-Board Diagnostics
- O2 Sensor Location & Identification
- Powertrain Diagnostic Procedures - Component Testing
- Sentry Key Immobilizer - Symptoms
- Symptom List: ANTENNA FAILURE; COP FAILURE; EEPROM FAILURE; INTERNAL FAULT; RAM FAILURE; SERIAL LINK INTERNAL FAULT; STACK OVERFLOW FAILURE
- Symptom List: PCM STATUS FAILURE; SERIAL LINK EXTERNAL FAULT
- Symptom List: ROLLING CODE FAILURE; VIN MISMATCH
- Symptom List: TRANSPONDER COMMUNICATION FAILURE; TRANSPONDER CYCLIC REDUNDANCY CHECK (CRC) FAILURE; TRANSPONDER ID MISMATCH; TRANSPONDER RESPONSE MISMATCH
- Starting - Symptoms
- Symptom: *CHECKING FUEL DELIVERY
- Symptom: *CHECKING FUEL PRESSURE LEAK DOWN
- Symptom: *CHECKING HARD START (FUEL DELIVERY SYSTEM)
- Symptom: *ENGINE CRANKS DOES NOT START - 1.6L
- Symptom: *ENGINE CRANKS DOES NOT START - 2.0L/2.4L
- Symptom: *NO CRANK CONDITION 1.6L
- Symptom: *NO CRANK CONDITION 2.0L/2.4L
- Symptom: *NO RESPONSE FROM PCM WITH A NO START CONDITION
- Symptom: *START AND STALL CONDITION 1.6L
- Symptom: *START AND STALL CONDITION 2.0L/2.4L
- Verification Test
- Component Locations
- Powertrain And Skim
- Control And Solenoids
- Throttle Body And Component Locations (2.0L/2.4L)
- Generator Location (1.6L)
- Generator and 1/1 O2 Sensor Locations (2.0L/2.4L)
- ETC Assembly And Ignition Coil Locations (1.6L)
- MAP Sensor And Ignition Coil Location (2.0L/2.4L)
- EVAP Purge Solenoid Location (2.0L/2.4L)
- NVLD Location (2.0L/2.4L)
- Speed Control Servo Locations (2.0L/2.4L)
- Speed Control Servo And Solenoids Component Locations (2.4L Turbo Only)
- Data Link Connector
- Sensors
- Battery Temperature Sensor Location (2.0L/2.4L)
- CKP Sensor Location (1.6L)
- CKP Sensor Location (2.0L/2.4L)
- CMP Sensor Location (2.0L/2.4L)
- Coolant Temperature Sensor Location (2.0L/2.4L)
- ECT Sensor Location (1.6L)
- IAT Sensor Location (2.0L/2.4L)
- Knock Sensor Location (1.6L)
- Knock Sensor Location (2.4L)
- MAP Sensor And Injectors Locations (1.6L)
- MAP Sensor Location (2.0L/2.4L)
- MAP Sensor Location (2.4L Turbo Only)
- APP Sensor Location (1.6L)
- O2 Sensors Location (1.6L)
- VSS Location
- Fuel System
- Relays
- Switches
- Connector PINOUTS
- A/C Compressor Clutch (Gas) - Black 2 Way
- A/C Low Pressure Switch - DK. Green 2 Way
- A/C Pressure Transducer - 2 Way
- Accelerator Pedal Position Sensor (1.6L/Diesel) - 10 Way
- Ambient Temperature Sensor (Except 2.4L Base) - Black 2 Way
- Ambient Temperature Sensor (NGC) - Black 2 Way
- Brake Lamp Switch (Gas) - Gray 6 Way
- Camshaft Position Sensor (Diesel) - Black 3 Way
- Camshaft Position Sensor (Gas) - Black 3 Way
- Clutch Pedal Position Switch (Up) - Black 3 Way
- Crankshaft Position Sensor (Gas) - Black 3 Way
- Data Link Connector - Black 16 Way
- EGR Solenoid (Diesel) - 2 Way
- Engine Coolant Temperature Sensor (Diesel) - Black 2 Way
- Engine Coolant Temperature Sensor (Gas) - Black 2 Way
- Engine Oil Pressure Switch - LT. Green 2 Way
- EVAP/Purge Solenoid (Gas) - Black 2 Way
- Fuel Injector No. 1 (Gas) - Black 2 Way
- Fuel Injector No. 2 (Gas) - Black 2 Way
- Fuel Injector No. 3 (Gas) - Black 2 Way
- Fuel Injector No. 4 (Gas) - Black 2 Way
- Fuel Pump Module - LT. Gray 4 Way
- Generator (2.4L Turbo) - Black 2 Way
- Generator (Gas Except 2.4L Turbo) - Black 2 Way
- Idle Air Control Motor (2.4L) - Black 2 Way
- Ignition Coil (Gas) - Black 3 Way
- Inlet Air Temperature Sensor (Gas) - Black 2 Way
- Knock Sensor (Gas) - Black 2 Way
- Manifold Absolute Pressure Sensor (Gas) - Black 3 Way
- Natural Vacuum Leak Detection Assembly (Except Export) - Black 3 Way
- Oxygen Sensor 1/1 Upstream (Gas) - Black 4 Way
- Oxygen Sensor 1/2 Downstream (Gas) - Black 4 Way
- Powertrain Control Module (1.6L) - Black 90 Way
- Powertrain Control Module C1 (NGC) - Black/Black 38 Way
- Powertrain Control Module C2 (NGC) - Black/Orange 38 Way
- Powertrain Control Module C3 (NGC) - Black/Natural 38 Way
- Powertrain Control Module C4 (NGC) - Black/Green 38 Way
- Radiator Fan Motor (2.4L Turbo) - DK. Gray 4 Way
- Radiator Fan Motor (Except 2.4L Turbo) - Black 3 Way
- Sentry Key Immobilizer Module - Black 6 Way
- Speed Control Servo (2.4L) - Black 4 Way
- Speed Control Switch - Yellow 3 Way
- Surge Solenoid (2.4L Turbo) - Black 2 Way
- Throttle Inlet Pressure Sensor (2.4L Turbo) - Natural 3 Way
- Throttle Inlet Pressure Solenoid (2.4L Turbo) - Black 2 Way
- Throttle Position Sensor (2.4L) - Black 3 Way
- Vehicle Speed Sensor (Gas MTX) - Black 3 Way
- WASTEGATE Solenoid (2.4L Turbo) - Black 2 Way
- Schematic Diagrams
- Charts And Graphs
- Vacuum Gauge Reading Examples
- Camshaft Sensor & Crankshaft Sensor Scope Pattern (Typical)
- Accelerator Pedal Position Sensor Specifications (1.6L)
- Camshaft & Crankshaft Sensor Specifications (1.6L)
- Throttle Position Sensor Specifications (1.6L)
- EVAP Tester
- Turbocharger System Circuit Diagrams
- Fuel Gauge Voltage Specifications
- Evaporative Emission System Schematic
- Sentry Key Immobilizer - Symptoms
- Powertrain Diagnostic Procedures - DRIVEABILITY - 1.6L Gas
- DRIVEABILITY - 1.6L Gas - Symptoms
- DRIVEABILITY - 1.6L Gas - Diagnostic Tests
- P0016-Crank And Cam Out-Of-Sync
- P0030-1/1 O2 Sensor Heater Circuit Open; P0036-1/1 O2 Sensor Heater Circuit Open
- P0031-1/1 O2 Sensor Heater Circuit Low; P0037-1/1 O2 Sensor Heater Circuit Low
- P0032-1/1 O2 Sensor Heater Circuit High; P0038-1/2 O2 Sensor Heater Circuit High
- P0106-BARO Pressure Out Of Range
- P0107-Map Sensor Voltage Too Low
- P0108-Map Sensor Voltage Too High
- P0112-Intake Air Temp Sensor Too Low
- P0113-Intake Air Temp Sensor Too High
- P0117-ECT Sensor Voltage Too Low
- P0118-ECT Sensor Voltage Too High
- P0122-Throttle Position Sensor Circuit #1 Low; P0222-Throttle Position Sensor Circuit #2 Low
- P0123-Throttle Position Sensor Circuit #1 High; P0223-Throttle Position Sensor Circuit #2 High
- P0125-Closed Loop Temp Not Reached
- P0128-Coolant Thermostat
- P0131-1/1 O2 Sensor Shorted To Ground; P0137-1/2 O2 Sensor Shorted To Ground
- P0132-1/1 O2 Sensor Shorted To Voltage; P0138-1/2 O2 Sensor Shorted To Voltage
- P0133-1/1 O2 Sensor Slow Response; P0139-1/2 O2 Sensor Slow Response
- P0134-1/1 O2 Sensor Stays At Center; P0140-1/2 O2 Sensor Stays At Center
- P0171-1/1 Fuel System Lean
- P0172-1/1 Fuel System Rich
- P0201-Injector #1 Control Circuit Open; P0202-Injector #2 Control Circuit Open; P0203-Injector #3 Control Circuit Open; P0204-Injector #4 Control Circuit Open
- P0261-Injector #1 Control Circuit Low; P0264-Injector #2 Control Circuit Low; P0267-Injector #3 Control Circuit Low; P0270-Injector #4 Control Circuit Low
- P0262-Injector #1 Control Circuit High; P0265-Injector #2 Control Circuit High; P0268-Injector #3 Control Circuit High; P0271-Injector #4 Control Circuit High
- P0300-Multiple Cylinder Mis-Fire; P0301-Cylinder #1 Misfire; P0302-Cylinder #2 Misfire; P0303-Cylinder #3 Misfire; P0304-Cylinder #4 Misfire
- P0315-No Crank Learned
- P0325-Knock Sensor #1 Circuit
- P0335-No Crank Signal At Pcm
- P0336-Crankshaft Position Sensor Performance
- P0340-No Cam Signal At Pcm
- P0420-1/1 Catalytic Converter Efficiency
- P0444-EVAP Purge Solenoid Circuit Open
- P0458-EVAP Purge Solenoid Low
- P0459-EVAP Purge Solenoid Circuit High
- P0461-Fuel Level Unit No Change Over Time
- P0462-Fuel Level Sending Unit Volts Too Low
- P0463-Fuel Level Sending Unit Volts Too High
- P0500-No Vehicle Speed Sensor Signal
- P0506-Idle Speed Performance Lower Than Excepted
- P0507-Idle Speed Performance Higher Than Excepted
- P0513-Invalid Skim Key
- P0551-Power Steering Switch Failure
- P0562-Charging System Voltage Too Low
- P0563-Charging System Voltage Too High
- P0572-Brake Switch Circuit Low
- P0573-Brake Switch Circuit High
- P0580-Speed Control Switch Always Low
- P0625-Generator Field Control Circuit Low
- P0626-Generator Field Control Circuit High
- P0628-Fuel Pump Relay Control Circuit Low
- P0629-Fuel Pump Relay Control Circuit High
- P0646-A/C Clutch Relay Control Circuit Low
- P0647-A/C Clutch Relay Control Circuit High
- P0686-ASD Relay Control Circuit Low
- P0687-ASD Relay Control Circuit High
- P0688-ASD Relay Output Circuit Low
- P0690-ASD Relay Output Circuit High
- P0691-Low Speed Fan Relay Control Circuit Low; P0693-High Speed Fan Relay Control Circuit Low
- P0692-Low Speed Fan Relay Control Circuit High P0694-High Speed Fan Relay Control Circuit High
- P0703-Brake Lamp Switch Circuit Performance
- P0719-Brake Lamp Switch Circuit Low
- P0724-Brake Lamp Switch Circuit High
- P0833-Clutch UPSTOP Switch Performance
- P1135-1/1 O2 Heater Element Resistance Out Of Range; P1136-1/2 Heater Element Resistance Out Of Range
- P1594-Charging System Voltage Too High
- P1616-5V Output Reference Voltage #1 Low
- P1617-5V Output Reference Voltage #1 High
- P1618-5V Output Reference Voltage Unstable
- P1626-5V Output Reference Voltage #2 Low
- P1627-5V Output Reference Voltage #2 High
- P1628-5V Output Reference Voltage #1 Unstable
- P1653-PCI Bus Shorted To Ground
- P1654-PCI Bus Shorted To Voltage
- P1656-PCI Bus Not Available
- P1686-No Skim Bus Message Received
- P1687-No Cluster Bus Message
- P2100-Electronic Throttle Control Motor Circuit
- P2101-Electronic Throttle Control Motor Performance
- P2107-Electronic Throttle Control Module Processor; P2108-Electronic Throttle Control Module Performance
- P2122-Accelerator Pedal Position Sensor # 1 Low; P2127-Accelerator Pedal Position Sensor #2 Low
- P2123-Accelerator Pedal Position Sensor #1 High; P2128-Accelerator Pedal Position Sensor #2 High
- P2135-Throttle Position Sensor #1 And #2 Voltage Correlation
- P2138-Accelerator Pedal Position Sensor #1 And #2 Voltage Correlation
- P2300-Ignition Coil #1 Circuit Low; P2303-Ignition Coil #2 Circuit Low
- P2301-Ignition Coil #1 Circuit High; P2304-Ignition Coil #2 Circuit High
- Powertrain Diagnostic Procedures - DRIVEABILITY - NGC
- DRIVEABILITY - NGC - Symptoms
- DRIVEABILITY - NGC - Diagnostic Tests
- P0016-Crankshaft/Camshaft Timing Misalignment
- P0031-O2 Sensor 1/1 Heater Circuit Low; P0037-O2 Sensor 1/2 Heater Circuit Low
- P0032-O2 Sensor 1/1 Heater Circuit High P0038-O2 Sensor 1/2 Heater Circuit High
- P0033-Surge Valve Solenoid Circuit
- P0068-Manifold Pressure/Throttle Position Correlation
- P0071-Ambient Temp Sensor Performance
- P0072-Ambient Temp Sensor Low
- P0073-Ambient Temp Sensor High
- P0107-Map Sensor Low
- P0108-Map Sensor High
- P0111-Intake Air Temperature Sensor Performance
- P0112-Intake Air Temperature Sensor Low
- P0113-Intake Air Temperature Sensor High
- P0116-Engine Coolant Temperature Performance
- P0117-Engine Coolant Temperature Sensor Low
- P0118-Engine Coolant Temperature Sensor High
- P0122-Throttle Position Sensor #1 Low
- P0123-Throttle Position Sensor #1 High
- P0125-Insufficient Coolant Temp For Closed-Loop Fuel Control
- P0128-Thermostat Rationality
- P0129-Barometric Pressure Out-Of-Range
- P0131-O2 Sensor 1/1 Voltage Low; P0137-O2 Sensor 1/2 Voltage Low
- P0132-O2 Sensor 1/1 Voltage High; P0138-O2 Sensor 1/2 Voltage High
- P0133-O2 Sensor 1/1 Slow Response; P0139-O2 Sensor 1/2 Slow Response
- P0135-O2 Sensor 1/1 Heater Performance; P0141-O2 Sensor 1/2 Heater Performance
- P0171-Fuel System 1/1 Lean
- P0172-Fuel System 1/1 Rich
- P0201-Fuel Injector #1; P0202-Fuel Injector #2; P0203-Fuel Injector #3; P0204-Fuel Injector #4
- P0234-OVERBOOST Performance; P1106-BARO Solenoid Performance; P1188 Tip Sensor Performance
- P0243-WASTEGATE Solenoid Circuit
- P0300-Multiple Cylinder Misfire; P0301-Cylinder #1 Misfire; P0302-Cylinder #2 Misfire; P0303-Cylinder #3 Misfire; P0304-Cylinder #4 Misfire
- P0315-No Crank Sensor Learned
- P0325-Knock Sensor #1 Circuit
- P0335-Crankshaft Position Sensor Circuit
- P0339-Crankshaft Position Sensor Intermittent
- P0340-Camshaft Position Sensor Circuit
- P0344-Camshaft Position Sensor Intermittent
- P0420-Catalytic 1/1 Efficiency
- P0440-General EVAP System Failure
- P0441-EVAP Purge System Performance
- P0442-EVAP System Medium Leak; P0455-EVAP System Large Leak
- P0443-EVAP Purge Solenoid Circuit
- P0452-NVLD Pressure Switch Stuck Closed
- P0453-NVLD Pressure Switch Stuck Open
- P0456-EVAP System Small Leak
- P0457-Loose Fuel Cap
- P0461-Fuel Level Sensor #1 Performance
- P0462-Fuel Level Sensor #1 Low; P0463-Fuel Level Sensor #1 High
- P0480-Cooling Fan 1 Control Circuit
- P0481-Cooling Fan 2 Control Circuit
- P0498-NVLD Canister Vent Valve Solenoid Circuit Low
- P0499-NVLD Canister Vent Valve Solenoid Circuit High
- P0501-Vehicle Speed Sensor #1 Performance (Auto Trans)
- P0501-Vehicle Speed Sensor #1 Performance (Manual Trans)
- P0506-Idle Speed Low Performance; P0507-Idle Speed High Performance
- P0508-IAC Valve Sense Circuit Low
- P0509-IAC Valve Sense Circuit High
- P0513-Invalid Skim Key
- P0516-Battery Temperature Sensor Low
- P0517-Battery Temperature Sensor High
- P0522-Oil Pressure Sensor Low
- P0551-Power Steering Switch Performance
- P0562-Battery Voltage Low
- P0563-Battery Voltage High
- P0572-Brake Switch #1 Circuit Low
- P0573-Brake Switch #1 Circuit High
- P0580-Speed Control Switch #1 Low
- P0581-Speed Control Switch #1 High
- P0582-Speed Control Vacuum Solenoid Circuit
- P0586-Speed Control Vent Solenoid Circuit
- P0594-Speed Control Servo Power Circuit
- P0600-Serial Communication Link; P0601-Internal Memory Checksum Invalid
- P0622-Generator Field Control Circuit
- P0627-Fuel Pump Relay Circuit
- P0630-VIN Not Programmed In Pcm
- P0632-Odometer Not Programmed In Pcm
- P0633-Skim Key Not Programmed In Pcm
- P0645-A/C Clutch Relay Circuit
- P0685-ASD Relay Control Circuit
- P0688-ASD Relay Sense Circuit Low
- P0700-Transmission Control System/Read Transmission DTCS On The DRBIII®
- P0850-Park/Neutral Switch Performance
- P1105-Tip Sensor Solenoid Circuit
- P1115-General Temp Sensor Performance
- P1187-THOTTLE Inlet Pressure/Map Correlation
- P1189-Tip Sensor Circuit Low
- P1190-Tip Sensor Circuit High
- P1593-Speed Control Switch Stuck
- P1603-Pcm Internal Dual-Port Ram Communication; P1604-Pcm Internal Dual-Port Ram Read/Write Integrity Failure; P1607-Pcm Internal Shutdown Timer Rationality
- P1696-EEPROM Memory Write Denied/Invalid; P1697-EMR (Sri) Mileage Not Stored
- P1854-Tip BARO Out Of Range
- P2074-Manifold Pressure/Throttle Position Correlation - High Flow/Vacuum Leak
- P2096-Down Stream Fuel System 1/2 Lean; P2097-Down Stream Fuel System 1/2 Rich
- P2302-Ignition Coil #1 Secondary Circuit-Insufficient Ionization; P2305-Ignition Coil #2 Secondary Circuit-Insufficient Ionization
- P2503-Charging System Voltage Low
- U0101-No Transmission Bus Message
- U0155-No Cluster Bus Message
- U0168-No Skim Bus Messages
- U110C-No Fuel Level Bus Message
- Powertrain Diagnostic Procedures - Introduction
- DTC Index
- Introduction
- Identification Of System
- System Description And Functional Operation
- General Description
- Functional Operation
- Fuel Control
- On-Board Diagnostics
- Other Controls
- Pcm Operating Modes
- Non-Monitored Circuits
- Skis Overview
- Skim On-Board Diagnostics
- Skis Operation
- Programming The Powertrain Control Module
- Programming The Sentry Key Immobilizer Module
- Programming The Ignition Keys To The Sentry Key Immobilizer Module
- Diagnostic Trouble Codes
- Using The DRBIII®
- DRBIII® Error Messages And Blank Screen
- Disclaimers, Safety, Warnings
- Required Tools And Equipment
- Glossary Of Terms
- Diagnostic Information And Procedures
- Communication - Symptoms
- Symptom: *NO RESPONSE FROM PCM (PCI BUS) - 1.6L
- Symptom: *NO RESPONSE FROM PCM (PCI BUS) - NGC
- Symptom: *NO RESPONSE FROM PCM (PCM SCI ONLY) - NGC
- Symptom: *NO RESPONSE FROM PCM (SCI ONLY) - 1.6L
- Symptom: *NO RESPONSE FROM SENTRY KEY IMMOBILIZER MODULE
- Symptom: *NO RESPONSE FROM TRANSMISSION CONTROL MODULE - NGC
- Symptom: *PCI BUS COMMUNICATION FAILURE
- Communication - Symptoms
- Emission Control System
- Tune-Up
- Emissions
- General Information
- Abbreviations
- Basic Trouble Shooting
- Basic Trouble Shooting - General Information
- Commonly Used Abbreviations - General Information
- Emission Control Abbreviations
- Engine Performance - Trouble Shooting - General Information
- Brakes
- Anti-Lock Brake Safety Precautions - General Information
- Map - Brake Systems
- Brake Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Accelerometers
- Accumulators
- Anchor Pins
- Anti-Lock Brake Control Assembly(Module)
- Anti-Lock Brake Controller
- Anti-Lock Brake Systems
- Axle Seal
- Backing Plates
- Bleeder Screw
- Brake Abs Active Light (Blue)
- Brake Fluid
- Brake Friction Material
- Brake On - Off Switch
- Brake Pads
- Brake Pedals
- Brake Shoe Hardware
- Brake Shoes
- Brake Stoplight Switches
- Brake Warning Light (Amber)
- Brake Warning Light (Red)
- Bulb Sockets
- Bulbs And LEDS
- Caliper Hardware
- Caliper Mounting Pin
- Caliper Piston
- Caliper Shim
- Caliper Slider Pin (Bolt) Dust Boot
- Caliper Slider Pin (Bolt)
- Calipers
- Combination Valve
- Controllers
- Digital Ratio Axle Controllers And Buffers (Drab And Dram)
- Disable Switches
- Drums
- Electrical Brake Pumps
- Electrical Park Motor
- Electrical Pumps And Motors
- Electro-Magnetic Interference
- Electronic Brake Control Modulator
- Electronic Brake Distribution
- Electronic Brake Traction Control Module
- Electronic Controllers
- Electronic Traction Control
- External Brake Cable
- Flow Control Valve
- Fluid Level Sensor Switches
- Fluid
- Four Wheel Drive Switches
- Friction Material
- G Sensors
- Gaskets
- Gravitational Switches
- Grease Seal
- Height Sensing Proportioning Valve
- High Pressure Accumulator
- Hoses
- Hub
- Hydraulic Control Unit
- Hydraulic Modulators
- Hydro-Boosters
- Hydro-Electric Boosters (POWERMASTER)
- Ignition Disable Switches
- Lamp Driver Relay
- Lateral Acceleration Switches
- LEDS
- Lenses
- Low Pressure Accumulator
- Lug Nut
- Master Cylinder Cover Gasket
- Master Cylinders
- Modulators
- Motor Pack
- Motors
- Pads
- Parking Brake Cable
- Parking Brake Mechanism
- Parking Brake Shoes
- Parking Brake Switches
- Parking Brake Systems
- Pedal Travel Switches
- Pedals
- Power Distribution Center
- POWERMASTER
- Pressure Differential Switches
- Pressure Switches
- Pressure Transducers
- Proportioning Valve
- Pumps
- Relays
- RELUCTOR (Speed) Ring
- Rotors
- Self-Adjusting Systems
- Shoe Hardware
- Shoes
- Sockets
- Speed Sensor (RELUCTOR) Ring
- Speed Sensors (Electronic Wheel And Vehicle)
- Star Wheel
- Steel Brake Lines
- Stoplight Switches
- Stroke Sensor
- Switches
- Tires
- Tone Ring
- Toothed Rings (Tone Wheel)
- Traction Control System (TCS)
- Transfer Tubes
- Vacuum Boosters
- Vacuum Hoses
- Valves
- Wear Indicator
- Wheel Attachment Hardware
- Wheel Bearings, Races And Seals
- Wheel Cylinders
- Wiring Harnesses
- Yaw Rate Sensor
- Brake System CHECKSHEET
- Reason Code Explanation
- Automotive Terminology & Definitions
- Brake Systems
- Map - Routine Inspection Reference Guide
- Routine Inspection Reference Guide
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Maintenance Overview
- Antifreeze/Coolant
- Visual Inspection
- Radiator Cap Test
- Engine Fan
- Cooling System Power Flush And Refill
- Belts (Except Timing Belts)
- Belt TENSIONER
- Automatic Transmission Fluid
- Automatic Transmission Fluid Exchange & Filter Replacement
- Engine Oil
- Air Filters
- Cabin Air Filter
- Brake Fluid
- Battery
- Battery Cables
- Power Steering
- Power Steering Fluid
- Wiper Blades
- Routine Inspection CHECKSHEET
- Routine Inspection - UICS
- Brake Systems
- Drivetrain And Transmission
- Notes
- Automatic Transmission Fluid
- Clutch Master Cylinders
- Cooler Lines
- Coolers
- Differential Fluid
- Drain Plugs And Gaskets
- Filters And Screens
- Fluids And Lubricants
- Hoses, Lines, And Tubes
- Hydraulic Fluid
- Lubricants
- Manual Transmission Fluid
- Mounts (Engine, Transaxle And Transmission)
- Transfer Case Fluid
- Vacuum Hoses
- Electrical Systems
- Engine Performance And Maintenance
- Notes
- Accessory Belts
- Air Filter Elements
- Air Filter Gaskets
- Air Filter Housings And Gaskets
- Air Pump Belts
- Batteries
- Battery Connectors
- Belt Idler Assemblies (Accessory And Cam Belts)
- Belt TENSIONERS (Accessory And Cam Belt)
- Chemical Engine DECARBONIZATION
- Combustion Chamber Cleaning
- Coolant Recovery Tanks
- Coolant
- Distributor Caps
- Distributor Rotors
- Engine Cooling Systems
- Engine DECARBONIZATION
- Engine Oil Drain Plugs And Gaskets
- Engine Oil Filters And Canisters
- Engine Oil
- Fuel Filters
- Fuel Injector Cleaning
- Fuel Injectors
- Fuel System Cleaning Service
- Hose Clamps
- Hose Connectors
- Hose Couplers
- Hoses And Tubes (Fuel Lines, Radiator, Vacuum, By-Pass, Heater, Recovery Tank And Oil Coolers)
- Ignition Wires (Secondary)
- Intake Cleaning
- O2 Sensors
- PCV Breather Elements
- PCV Valves
- Radiator Caps And Pressurized Expansion Tank Caps
- Spark Plugs
- Thermostats And Housings
- Throttle Body Cleaning
- Timing Belts
- Vacuum Hoses, Tubes And Connections (Non-Metallic)
- Exhaust Systems
- Heating, Ventilation And Air Conditioning Systems
- Steering And Suspension, Wheel Alignment, Wheels And Tires
- Wheel & Tire Supplement
- Reason Code Explanation
- Automotive Terminology & Definitions
- Routine Inspection Reference Guide
- Check Lists
- OBD-II Drive Cycles
- Driveline/Axles
- Drive Axle Noise Diagnosis - General Information
- Gear Tooth Contact Patterns - General Information
- Map - Drive Train & Transmission
- Drive Train & Transmission Systems
- Drivetrain And Transmission
- Notes
- Actuators (Electrical)
- Actuators (Vacuum)
- Automatic Transmission / Transaxle Assemblies/CVTS
- Automatic Transmission Fluid
- Axles
- Bearings And Races
- Bell Cranks
- Bell Housings
- Bushings (External)
- Cables (Speedometer)
- Cables (TV, Detent And Shift)
- Carrier Bearings
- Clutch Cables And Cable Housings
- Clutch Discs (Manual Transmissions)
- Clutch Forks
- Clutch Linkages (Mechanical)
- Clutch Master Cylinders
- Clutch Pedals
- Clutch Pivots
- Clutch Pressure Plates
- Clutch Release Bearings
- Clutch Slave Cylinders (Concentric)
- Clutch Slave Cylinders (Conventional Or External)
- Companion Flanges
- Connectors
- Cooler Bypass Valves
- Cooler Lines
- Coolers
- CV Joints
- Differential And Final Drive Assemblies
- Differential Fluid
- Dip Stick Tubes
- Dip Sticks (Fluid Level Indicators)
- Dowel Pins, Guides And Pilot Holes
- Drain Plugs And Gaskets
- Drive Shaft Flanges
- Drive Shafts And Half Shafts
- Dust Boots
- Engine Mounts
- Exciter Rings
- Filler Tubes
- Filters And Screens
- Flanges
- Flex Plates
- Fluid Level Indicators
- Fluids And Lubricants
- Flywheels
- Force Motors
- Gaskets
- Guides
- Half Shafts
- Hoses, Lines, And Tubes
- Housings (Bell, Case, Tail(Extension) And Auxiliary)
- Hydraulic Fluid
- Intermediate Shaft Support Bearings
- Key Interlock Systems
- Limited Slips
- Lines
- Linkages (External)
- Locking Hub Assemblies
- Locking Hub Control Knobs
- Lubricants
- Manual Transmission Fluid
- Manual Transmission/Transaxle Assemblies
- Metal Clad Seals
- METALASTIC Joints
- Modulator Pins
- Modulators
- Mounts (Engine, Transaxle And Transmission)
- Odometer Drives (Mechanical)
- Odometer Heads (Mechanical)
- Oil Pans
- Pans
- Pilot Holes
- Pressure Plates
- Pressure Switches
- Races
- Rubber Joints (METALASTIC)
- Screens
- Seals (Metal Clad)
- Seals
- Selector Interlock Systems
- Sensors
- Servos
- Shift Interlock Systems (Selector And Key Interlock Systems)
- Side Covers
- Slip Yokes
- Solenoids
- Speed Sensors (Electronic Wheel And Vehicle)
- Speedometer- Driven Gear Housing
- Speedometer/Odometer Drives (Mechanical)
- Speedometer/Odometer Heads (Mechanical)
- Speedometers/Odometers (Electronic)
- Switches
- Tone Wheels
- Toothed Rings (Tone Wheel)
- Torque Converters
- Transaxle Mounts
- Transducers (Transmission)
- Transfer Case Assemblies
- Transfer Case Fluid
- Transmission Coolers
- Transmission Mounts
- Transmission Pans
- Transmission Range Indicators (PRNDL)
- Tubes
- Universal Joints (CARDAN Or Cross Type)
- Vacuum Controls
- Vacuum Hoses
- Vacuum Motors
- Vacuum-Operated Switches
- Vehicle Speed Sensors
- Vents
- Vibration Dampers
- Wheel Attachment Hardware
- Wheel Speed Sensors
- Wiring Harnesses And Connectors
- Yokes And Slip Yokes
- Reason Code Explanation
- Automotive Terminology & Definitions
- Trouble Shooting - Clutches - General Information
- DTC Index
- Electrical
- Map - Electrical Systems
- Electrical Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Actuator Motors (Electric)
- Actuator Motors (Vacuum)
- Air Bags
- Alternators And Generators
- Amplifiers
- Antennas
- Batteries
- Battery Cables, Wires And Connectors
- Battery Cables
- Battery Trays And Hold Down Hardware
- Battery Wires
- Belts
- Bulb Sockets
- Bulbs, Sealed Beams And LEDS
- Cd Players
- Cigarette Lighter Assemblies
- Circuit Breakers
- Clutch Switches
- Connectors
- Control Modules
- Cruise Control Brake Switches
- Cruise Control Cables
- Cruise Control Clutch Switches
- Cruise Control Linkages And Cables
- Cruise Control Reservoirs
- Cruise Control Tubes
- Cruise Control Vacuum Dump Release Valves
- Cruise Control Vacuum Hoses, Tubes And
- Cruise Control Vehicle Speed Sensors
- Defoggers
- Defrosters
- Delays
- Dimmers
- Electric Heaters
- Equalizers
- Fuse Blocks
- Fuse Boxes And Blocks
- Fuses, Fusible Links And Circuit Breakers
- Fusible Links
- Gauges
- Generators
- Ground Cables And Straps
- Ground Straps
- Headlight Adjusters
- Heating Elements (Defrosters, Defoggers, Electric Heaters And Seats)
- Horns And Sirens
- Ignition Switches
- Indicator Lights
- Keyless Entry Keypads And Transmitters
- Keyless Entry Transmitters
- LEDS
- Lenses
- Microphones
- Mirrors (ELECTROCHROMATIC And Heated)
- Motors
- Neutral Safety Switches
- Odometers, Speedometers And Tachometers (Cable Driven)
- Odometers
- Power Distribution Center
- Pulleys
- Receivers, Amplifiers, Equalizers And Sub-Woofer Volume Controls
- Relay Boxes
- Relays
- Sealed Beams
- Seat Heaters
- Security Alarm Sensors
- Sirens
- Solenoids
- Speakers And Microphones
- Speedometer And Tachometer Linkages And Cables
- Speedometer Cables
- Speedometers
- Starters
- Sub-Woofer Volume Control
- Switches
- Tachometer Cables
- Tachometers
- Tape Players And Cd Players
- TENSIONERS
- Timers
- Transceivers
- Transducers
- Vacuum Accumulators (Reservoirs)
- Voltage Regulators
- Washer Fluid Level Senders
- Washer Pumps
- Wiper Arms And Blades
- Wiper Blades
- Wiper Hoses And Nozzles
- Wiper Linkages
- Wiper Nozzles
- Wiper Pump Reservoirs
- Wiring Harnesses And Connectors
- Battery, Starting & Charging System CHECKSHEET
- Reason Code Explanation
- Automotive Terminology & Definitions
- Electrical Systems
- Using lemon2025'S System Wiring Diagrams
- Map - Electrical Systems
- Engine
- Engine Overhaul Procedures - General Information
- * Please Read This First *
- Description
- Engine Identification
- Inspection Procedures
- Cleaning Procedures
- Component Cleaning
- Cylinder Head Replacement
- Cylinder Head Overhaul
- Pistons, Connecting Rods & Bearings
- Crankshaft & Main Bearings
- Camshaft
- Timing Chains & Belts
- Timing Gears
- Oil Pump
- Break-In Procedure
- General Cooling System Service - General Information
- Engine Overhaul Procedures - General Information
- Engine Performance
- Electrostatic Discharge Warning - General Information
- Engine Performance Diagnostic Routine Outline - General Information
- Engine Performance Safety Precautions
- Map - Engine Performance & Maintenance
- Engine Performance And Maintenance (Including Exhaust Systems)
- Engine Performance & Maintenance CHECKSHEET
- Engine Performance And Maintenance
- Notes
- Accelerator Pedal Position Sensor
- Accessory Belts
- Accessory Pulleys
- Air Conditioning Cycling Switches
- Air Conditioning Pressure Sensors
- Air Ducts And Tubes
- Air Filter Elements
- Air Filter Gaskets
- Air Filter Housings And Gaskets
- Air Fuel Ratio Sensors
- Air Injection Control Solenoids
- Air Plenums
- Air Pump Belts
- Air Pumps (Electric Driven)
- Air Tubes
- Aspirator, Check And DECEL Valves
- Baffles
- Ballast Primary Supply Resistor Wires
- Ballast Resistors And Primary Supply Resistors
- Barometric Pressure Sensors
- Batteries
- Battery Cables, Wires And Connectors
- Battery Connectors
- Battery Trays And Hold Down Hardware
- Battery Wires
- Belt Idler Assemblies (Accessory And Cam Belts)
- Belt TENSIONERS (Accessory And Cam Belt)
- Belt-Driven Air Pumps
- Boost Control Mechanism
- Camshaft Position Sensors
- Carburetors And Chokes
- Casting Core Plugs And Expansion Plugs
- Charge Air Coolers ""INTERCOOLERS"" (CAC)
- Check Valves
- Chemical Engine DECARBONIZATION
- Chokes
- Clutch Pedal Position Switches
- Cold Start Injectors
- Combustion Chamber Cleaning
- Connectors
- Coolant Recovery Tanks
- Coolant
- Cooling Fan Motor Modules
- Cooling Fan Motor Relays And Modules
- Cooling Fan Motor Resistors
- Cooling Fan Motor Sensors And Switches
- Cooling Fan Motor Switches
- Cooling Fan Motors
- Crankshaft Position Sensors
- Cylinder Deactivation Solenoid
- Cylinder Head Assemblies
- DECEL Valves
- Deflectors
- Dip Stick Tubes
- Dip Sticks And Tubes
- Distributor Advances And Retarders (Mechanical And Vacuum)
- Distributor Boots And Shields
- Distributor Caps
- Distributor Retarders (Mechanical And Vacuum)
- Distributor Rotors
- Distributor Shields
- Distributors
- Early Fuel Evaporation Valves (Heat Riser Assemblies)
- EGR Coolers
- EGR Exhaust Manifold Passages
- EGR Intake And Exhaust Manifold Passages
- EGR Plates And Coolers
- Electronic Spark Control Modules
- Electronic Transmission Control Devices
- Electronic Transmission Feedback Devices
- Engine Coolant Temperature Sensors
- Engine Cooling Systems
- Engine Covers (Oil Pan, Valve Cover, Timing Cover)
- Engine DECARBONIZATION
- Engine Oil Canisters
- Engine Oil Coolers (External)
- Engine Oil Drain Plugs And Gaskets
- Engine Oil Filters And Canisters
- Engine Oil Gaskets
- Engine Oil Pressure Gauges (Mechanical)
- Engine Oil
- Evaporative Emissions (EVAP) Canister Filters
- Evaporative Emissions (EVAP) Canister Purge Devices
- Evaporative Emissions (EVAP) Canisters
- Evaporative Emissions (EVAP) Feedback Devices
- Exhaust Gas RECIRCULATION Devices
- Exhaust Gas RECIRCULATION Feedback Devices
- Expansion Plugs
- Fan Control Sensor
- Fuel Accumulators And Dampers
- Fuel And Cold Start Injectors
- Fuel Caps
- Fuel Dampers
- Fuel Delivery Check Valves
- Fuel Distributors (BOSCH Cis)
- Fuel Filler Necks And RESTRICTORS
- Fuel Filters
- Fuel Injector Cleaning
- Fuel Injectors
- Fuel Level Senders
- Fuel Pressure Regulators
- Fuel Pumps (In-Tank, External, Electrical Or Mechanical)
- Fuel Rails
- Fuel RESTRICTORS
- Fuel System Cleaning Service
- Fuel Tanks
- Fuel
- Gaskets
- Grommets (Valve Cover)
- Harmonic Dampers
- Heater Control Valves
- Heater Cores
- Hose Clamps
- Hose Connectors
- Hose Couplers
- Hoses And Tube Couplers, Connectors And Clamps
- Hoses And Tubes (Fuel Lines, Radiator, Vacuum, By-Pass, Heater, Recovery Tank And Oil Coolers)
- Housings
- Idle Air Controls
- Idle Speed Control Actuators
- Ignition Boots
- Ignition Coil Towers
- Ignition Coils
- Ignition Control Modules (ICM)
- Ignition Switches
- Ignition Terminals
- Ignition Wires (Secondary)
- Inertia Fuel Shut-Off Switches
- Intake Air Temperature Sensors
- Intake Cleaning
- Intake Manifolds
- In-Tank Fuel Strainers
- INTERCOOLERS
- Knock Sensors
- Liquid Vapor Separators
- Long Block Assemblies
- Manifold Absolute Pressure (Map) Sensors
- Mass Air Flow (MAF) Sensors
- Metal Air Manifolds And Pipes
- Metal Air Pipes
- Mix Control Solenoids
- Motor Mounts
- O2 Sensors
- Oil Pans
- Oil Pressure Sending Units
- Oil Pump Pick-Up Screens
- Oil Pumps
- O-Rings, Gaskets, Seals And Spring Locks
- Park Neutral Position Switches
- PCV Breather Elements
- PCV Orifices
- PCV Valves
- Pick-Up Assemblies (Includes Magnetic, Hall Effect And Optical)
- Power Steering Pressure Sensors
- Powertrain Control Modules (Pcm) And Prom
- Powertrain Control Prom
- Pressurized Expansion Tank Caps
- Radiator / Cooling Fan Blades
- Radiator / Cooling Fan Clutches
- Radiator Caps And Pressurized Expansion Tank Caps
- Radiators
- Roll Over Valves
- Sealing Compounds
- Seals
- Secondary Air Injection System Management Devices
- Sensors
- Short Block Assemblies
- Shrouds, Baffles And Deflectors
- Spark Plugs
- Spring Locks
- Super Chargers
- Switches
- Thermal Vacuum Valves
- Thermostatic Air Door Assemblies
- Thermostats And Housings
- Throttle Bodies
- Throttle Body Cleaning
- Throttle Cables
- Throttle Linkages And Cables
- Throttle Position Sensors
- Throttle Position Switches
- Timing Belt Sprockets
- Timing Belts
- Timing Covers
- Torque Struts
- Transmission Range Switches
- Tube Clamps
- Tube Connectors
- Tube Couplers
- Tubes
- Turbo Chargers
- Vacuum Connections
- Vacuum Hoses, Tubes And Connections (Non-Metallic)
- Vacuum Regulator Solenoids
- Vacuum Tubes
- Valve Covers
- Vehicle Speed Senors
- Volume Air Flow Sensors
- Waste Gate And Boost Control Mechanisms
- Waste Gate Control Solenoids
- Water Pumps (Electric)
- Water Pumps (Non-Electric)
- Wiring Harnesses And Connectors
- Reason Code Explanation
- Automotive Terminology & Definitions
- Parasitic Load Explanation & Test Procedures - General Information
- State Emission Standards - Diesel
- State Emission Standards - Gas
- ALASKA
- ARIZONA
- CALIFORNIA
- Colorado
- CONNECTICUT
- DELAWARE
- District Of COLUMBIA
- GEORGIA
- IDAHO
- ILLINOIS
- INDIANA
- KENTUCKY
- MARYLAND
- MASSACHUSETTS
- MISSOURI
- NEVADA
- New Jersey
- New MEXICO
- New YORK
- North CAROLINA
- OHIO
- OREGON
- PENNSYLVANIA
- RHODE Island
- TENNESSEE
- TEXAS
- UTAH
- VIRGINIA
- WASHINGTON
- WISCONSIN
- U. S. EPA ASM2525 & ASM5015 Start-Up Emission Standards
- U. S. EPA Revised Final ASM Emission Standards (ASM5015 & ASM2525)
- U.S. EPA Im240 Emission Standards
- Waveforms - Injector Pattern Tutorial - General Information
- * Please Read This First *
- Purpose Of This Article
- Is A Lab Scope Necessary?
- The Two Types Of Injector Drivers
- The Two Ways Injector Circuits Are Wired
- Interpreting Injector Waveforms
- Current Waveform Samples
- Notes
- Example #1 - Voltage Controlled Driver
- Example #2 - Voltage Controlled Driver
- Example #3 - Voltage Controlled Driver
- Example #4 - Current Controlled Driver
- Example #5 - Current Controlled Driver
- Example #6 - Current Controlled Driver
- Example #7 - Current Controlled Driver
- Example #8 - Current Controlled Driver
- Voltage Waveform Samples
- Notes
- Example #1 - Voltage Controlled Driver
- Example #2 - Voltage Controlled Driver
- Example #3 - Voltage Controlled Driver
- Example #4 - Current Controlled Driver
- Example #5 - Current Controlled Driver
- Example #6 - Current Controlled Driver
- Example #7 - Current Controlled Driver
- Example #8 - Current Controlled Driver
- Map - Exhaust Systems
- Exhaust Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Catalytic Converters
- Exhaust And Tail Pipes
- Exhaust Connections
- Hangers
- Heat Risers (Mechanical EFE Devices)
- Heat Shields
- Manifolds (Cast And Tube Type)
- Mechanical EFE Devices
- Muffler Valve
- Mufflers And Resonators
- Reason Code Explanation
- Exhaust Systems
- Heating, Ventilation & A/C (HVAC)
- Map - Heating, Ventilation, & Air Conditioning
- Heating, Ventilation & Air Conditioning Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Accumulators
- Actuators (Electrical)
- Actuators (Vacuum)
- Air Conditioning Fittings
- Air Conditioning Hoses
- Air Conditioning Metal Lines
- Air Control Doors
- Air Dams (External)
- Air Distribution System
- Belts
- Blend Doors
- Blower Fans (Blower Wheel Or Squirrel Cage)
- Blower Motors
- Blower Resistors
- Blower Switches
- Cabin Air Filters
- Circuit Breakers
- Compressor Clutch Assemblies
- Compressors
- Condenser Air Seals
- Condenser Fan Motors
- Condensers
- Connectors
- Control Cables
- Control Heads (Function Selectors)
- Control Linkages
- Control Modules
- Coolant
- Cooling Fan Blades
- Cooling Fan Clutches
- Cooling Fan Motors
- Evaporator Drain Tubes
- Evaporator Filters
- Evaporator Pressure Regulators (EPRS)
- Evaporators
- Expansion Valves
- Function Selectors
- Fuses, Fusible Links And Circuit Breakers
- Fusible Links
- Gaskets
- Heater Cases
- Heater Control Valves
- Heater Cores
- Heater Hoses
- High Pressure Relief Valves (HPRV)
- Idlers
- In-Line Filters
- Metal Fittings
- Metal Lines
- Mix And Air Control Doors (Blend Doors)
- ORIFACE Tubes
- O-Rings
- Pilot-Operated Absolutes (POAS)
- Plenums
- Pressure Control Valves
- Pressure Sensors
- Pulleys
- Radiators
- Receiver-DRIERS
- Refrigerant Oil
- Refrigerant
- Relays
- Seals
- Service Ports
- Spring Lock Couplings
- Suction Throttling Valves (STVS)
- Switches (Electrical)
- TENSIONERS
- Thermistors And Pressure Sensors
- Thermostats And Housings
- Vacuum Hoses And Tubes
- Vacuum Reservoirs
- Vacuum Tubes
- Valves In Receiver (VIRS)
- Water Pumps (Electric Auxiliary)
- Wiring Harnesses And Connectors
- Heating, Ventilation & Air Conditioning System CHECKSHEET
- Reason Code Explanation
- Automotive Terminology & Definitions
- Heating, Ventilation & Air Conditioning Systems
- Map - Heating, Ventilation, & Air Conditioning
- Hoist/Jack
- Lubrication & Maintenance
- International Symbols
- Fluid Types
- Fluid Capacities
- Fluid Fill/Check Locations
- Lubrication Points
- Maintenance Schedules
- Hoisting
- Jump Starting
- Towing
- Lubrication & Maintenance
- Identification
- Metric Conversions
- OEM General Information
- Diagnostic Trouble Code Definitions - General Information
- Lubrication & Maintenance
- International Symbols
- Fluid Types
- Fluid Capacities
- Fluid Fill/Check Locations
- Lubrication Points
- Maintenance Schedules
- Hoisting
- Jump Starting
- Towing
- Vehicle Data
- Maintenance Reminder Light (Reset Procedures)
- Emissions Maintenance Reminder (EGR)
- Emissions Maintenance Reminder (EMR Mileage)
- Emissions Maintenance Reminder (MAINT REQD Or Check EGR)
- Emissions Maintenance Reminder (Sri)
- Engine Oil Replacement Reminder
- Maintenance Service Reminder (ASSYST Maintenance Computer)
- Maintenance Service Reminder (Perform Service)
- Maintenance Service Reminder (Service Reminder Indicator)
- Maintenance Service Reminder (Service Reminder Message)
- Tire Pressure Monitor System Reminder
- Restraints
- Specifications Index
- Steering
- Map - Steering, Suspension, Wheel Alignment, Wheels & Tires
- Steering & Suspension Systems
- Wheel And Tire
- Steering & Suspension CHECKSHEET
- Wheels & Tires CHECKSHEET
- Steering And Suspension, Wheel Alignment, Wheels And Tires
- Notes
- Active Handling
- Active Suspension Control Modules
- Active Variable Ratio Steering
- Active Yaw Control
- Adaptive Cruise Control
- Advance TRAC
- Air Bags
- Air Ride Control Modules
- Air Ride Suspension Torsion Springs (Counter Balancing)
- Air Ride Suspension
- Air Ride Tubes
- Air Shocks And Air Struts
- Air Spring Valves
- Air Springs
- Air Suspension Control Valves
- Air Suspension DRIERS
- Axle Acceleration Sensor
- Ball Joints
- Body Acceleration Sensor
- Bushings
- Center Links
- Compressors
- Continuous Damping Control
- Control Arm Shafts
- Control Arms
- Control Modules
- Distance Regulation Control Module
- Distance Regulation Sensor
- Drag Links
- Dynamic Stability Control
- Dynamic Stability Traction Control
- Electronic Ride Control Shocks And Struts
- Electronic Stability Control
- Electronic Suspension System
- Flex Couplers
- Gaskets
- Height Sensors
- Hydraulic Hoses
- Hydraulic Power Steering Pumps
- Hydraulic Suspension Hoses
- Hydraulic Suspension Pumps
- Idler Arms
- Intermediate Shaft U-Joints
- King Pins
- Modules
- Pitman Arms
- Power Steering Belts
- Power Steering Coolers
- Power Steering Fluid
- Power Steering Hoses
- Power Steering Lines (Steel)
- Power Steering Pumps - Electric
- Power Steering Pumps
- Radar Sensor
- Radius Arms
- Relay Rods
- Relays
- Sensors
- Shock Absorbers, Strut Cartridges And Strut Assemblies
- Spindles
- Springs, Coil, Leaf And Torsion Bars
- STABILITRAC
- Stability Management System
- Steering Angle Sensor
- Steering Arms
- Steering Couplers
- Steering Dampers
- Steering Gears (Except Rack And Pinion)
- Steering Gears, Rack And Pinion
- Steering Knuckles
- Strike Out Bumpers
- Strut Bearing Plate Assemblies
- Strut Rods
- Suspension Pumps (Hydraulic)
- Sway Bar Links
- Sway Bar Mounting Bushings
- Sway Bars
- Switches
- Tie Rod Ends (Inner And Outer)
- Tire Pressure Monitoring System
- Tire Pressure Sensors
- Tires
- Torque Sensor
- Torsion Springs
- Track Bar Bushings
- Track Bars
- Trailing Arm Bushings
- Trailing Arms
- Valve Stems
- Vehicle Dynamics Control
- Vehicle Speed Sensor
- Vehicle Stability Assist
- Vehicle Stability/Skid Control
- Warning Lamps
- Wheel Alignment
- Wheel Attachment Hardware
- Wheel Bearings, Races And Seals
- Wheels (Rims)
- Wiring Harnesses And Connectors
- Reason Code Explanation
- Automotive Terminology & Definitions
- Wheel Alignment Theory & Operation - General Information
- Map - Steering, Suspension, Wheel Alignment, Wheels & Tires
- Towing
- Lubrication & Maintenance
- International Symbols
- Fluid Types
- Fluid Capacities
- Fluid Fill/Check Locations
- Lubrication Points
- Maintenance Schedules
- Hoisting
- Jump Starting
- Towing
- Lubrication & Maintenance
- Traction Control Disable Procedures
- Trouble Shooting - Manual Transmission - General Information
- Heating, Ventilation & A/C (HVAC)
- General Servicing
- Cabin Air Filter
- HVAC Systems (Service Information)
- Heating & Air Conditioning
- Controls
- Distribution
- Plumbing
- Diesel Engine Coolant Heater
- HVAC Control Systems
- HVAC Systems (Service Information)
- Heating & Air Conditioning
- Controls
- Distribution
- Plumbing
- Diesel Engine Coolant Heater
- HVAC Systems (Service Information)
- General Servicing
- Maintenance
- Procedures
- Lubrication & Maintenance
- International Symbols
- Fluid Types
- Fluid Capacities
- Fluid Fill/Check Locations
- Lubrication Points
- Maintenance Schedules
- Hoisting
- Jump Starting
- Towing
- Maintenance Reminder Light (Reset Procedures)
- Emissions Maintenance Reminder (EGR)
- Emissions Maintenance Reminder (EMR Mileage)
- Emissions Maintenance Reminder (MAINT REQD Or Check EGR)
- Emissions Maintenance Reminder (Sri)
- Engine Oil Replacement Reminder
- Maintenance Service Reminder (ASSYST Maintenance Computer)
- Maintenance Service Reminder (Perform Service)
- Maintenance Service Reminder (Service Reminder Indicator)
- Maintenance Service Reminder (Service Reminder Message)
- Tire Pressure Monitor System Reminder
- Lubrication & Maintenance
- Schedule
- Lubrication & Maintenance
- International Symbols
- Fluid Types
- Fluid Capacities
- Fluid Fill/Check Locations
- Lubrication Points
- Maintenance Schedules
- Hoisting
- Jump Starting
- Towing
- Lubrication & Maintenance
- Procedures
- Restraints
- Air Bag, SRS
- Body Diagnostic Procedures
- Introduction
- Identification Of System
- System Description And Functional Operation
- Notes
- Airbag System
- Audio System
- Compass/Temperature Module (CTM)
- Compass/Temperature Mirror
- Description
- Operation
- English / Metric / Off Mode
- Calibration / Zone Mode
- Setting Compass Zone
- First Time Calibration
- Manual Calibration
- Continuous Calibration
- Self-Check Diagnostic
- Outside Temperature
- Temperature Update - Warm
- Temperature Update - Cold
- Extreme Temperature / Open Or Short Condition
- Ambient Temperature Sensor
- Ambient Temperature Sensor Diagnostics
- Instrument Cluster
- Remote Keyless Entry Module
- Sentry Key Immobilizer System (Skis)
- Communication
- Telecommunications
- Window Regulator Modules (Pt27 Only)
- Using The DRBIII®
- Disclaimers, Safety, Warnings
- Required Tools And Equipment
- Glossary Of Terms
- Diagnostic Information And Procedures
- Airbag
- Symptom List: ACCELEROMETER 1; INTERNAL 1; INTERNAL 2; INTERNAL 3; INTERNAL 4' OUTPUT DRIVER 1; OUTPUT DRIVER 2; STORED ENERGY FIRING 1
- Symptom List: AIRBAG WARNING INDICATOR DRIVER; AIRBAG WARNING INDICATOR OPEN; AIRBAG WARNING INDICATOR SHORT
- Symptom: CALIBRATION MISMATCH
- Symptom: CLUSTER MESSAGE MISMATCH
- Symptom: DRIVER SEAT BELT TENSIONER CIRCUIT OPEN
- Symptom: DRIVER SEAT BELT TENSIONER CIRCUIT SHORT
- Symptom: DRIVER SEAT BELT TENSIONER SHORT TO BATTERY
- Symptom: DRIVER SEAT BELT TENSIONER SHORT TO GROUND
- Symptom: DRIVER SQUIB 1 CIRCUIT OPEN
- Symptom: DRIVER SQUIB 1 CIRCUIT SHORT
- Symptom: DRIVER SQUIB 1 SHORT TO BATTERY
- Symptom: DRIVER SQUIB 1 SHORT TO GROUND
- Symptom: LEFT CURTAIN OR SEAT SQUIB CIRCUIT OPEN
- Symptom: LEFT CURTAIN OR SEAT SQUIB CIRCUIT SHORT
- Symptom: LEFT CURTAIN OR SEAT SQUIB SHORT TO BATTERY
- Symptom: LEFT CURTAIN OR SEAT SQUIB SHORT TO GROUND
- Symptom: LEFT SIDE IMPACT SENSOR 1 INTERNAL 1
- Symptom: LOSS OF IGNITION RUN - START
- Symptom: LOSS OF IGNITION RUN ONLY
- Symptom: NO CLUSTER MESSAGE
- Symptom: NO LEFT SIDE IMPACT SENSOR 1 COMMUNICATION
- Symptom: NO ODOMETER MESSAGE
- Symptom: NO PCI TRANSMISSION
- Symptom: NO RIGHT SIDE IMPACT SENSOR 1 COMMUNICATION
- Symptom: PASSENGER SEAT BELT TENSIONER CIRCUIT OPEN
- Symptom: PASSENGER SEAT BELT TENSIONER CIRCUIT SHORT
- Symptom: PASSENGER SEAT BELT TENSIONER SHORT TO BATTERY
- Symptom: PASSENGER SEAT BELT TENSIONER SHORT TO GROUND
- Symptom: PASSENGER SQUIB 1 CIRCUIT OPEN
- Symptom: PASSENGER SQUIB 1 CIRCUIT SHORT
- Symptom: PASSENGER SQUIB 1 SHORT TO BATTERY
- Symptom: PASSENGER SQUIB 1 SHORT TO GROUND
- Symptom: POWER SUPPLY VOLTAGE LOW
- Symptom: RIGHT CURTAIN OR SEAT SQUIB CIRCUIT OPEN
- Symptom: RIGHT CURTAIN OR SEAT SQUIB CIRCUIT SHORT
- Symptom: RIGHT CURTAIN OR SEAT SQUIB SHORT TO BATTERY
- Symptom: RIGHT CURTAIN OR SEAT SQUIB SHORT TO GROUND
- Symptom: RIGHT SIDE IMPACT SENSOR INTERNAL 1
- Symptom: VEHICLE BODY STYLE MISMATCH
- Symptom: *AIRBAG INDICATOR ON WITHOUT ACTIVE TROUBLE CODES
- Audio
- Symptom: ALL OUTPUTS SHORT
- Symptom: ANTENNA HARDWARE FAILURE - SDARS
- Symptom: ANTENNA NOT CONNECTED - SDARS
- Symptom: BUS BUSY - SDARS
- Symptom: BUS LOW - SDARS
- Symptom List: CASSETTE PLAYER INOP; CD MECHANICAL FAILURE; NO PCI TRANSMISSION; *AM/FM SWITCH INOPERATIVE; *ANY STATION PRESET SWITCH INOPERATIVE; *BALANCE INOPERATIVE; *CD EJECT SWITCH INOPERATIVE; *EQUALIZER INOPERATIVE; *FADER INOPERATIVE; *FF/RW SWITCH INOPERATIVE; *HOUR/MINUTE SWITCHES INOPERATIVE; *PAUSE/PLAY SWITCH INOPERATIVE; *PWR SWITCH INOPERATIVE; *SCAN SWITCH INOPERATIVE; *SEEK SWITCH INOPERATIVE; *SET SWITCH INOPERATIVE; *TAPE EJECT SWITCH INOPERATIVE; *TIME SWITCH INOPERATIVE; *TUNE SWITCH INOPERATIVE
- Symptom: CD PLAY FAILURE
- Symptom: CD READ FAILURE
- Symptom: CD TEMPERATURE HIGH
- Symptom: GPS ANTENNA NOT CONNECTED
- Symptom: INTERNAL FAILURE - SDARS
- Symptom: INTERNAL RECEIVER FAILURE - SDARS
- Symptom: LOW VOLTAGE LEVEL
- Symptom: NO ANTENNA CONNECTION
- Symptom: NO COMMUNICATION WITH SDARS
- Symptom: NO J1850 COMMUNICATION - SDARS
- Symptom: POWER AMP SHUTDOWN
- Symptom: RADIO AND NAV GPS ANTENNA NOT CONNECTED
- Symptom: *INOP NO FAULT CODES - SDARS
- Symptom: *POOR RECEPTION - SDARS
- Communication
- Symptom: *NO RESPONSE FROM AIRBAG CONTROL MODULE
- Symptom: *NO RESPONSE FROM AMPLIFIER
- Symptom: *NO RESPONSE FROM ANTILOCK BRAKE MODULE
- Symptom: *NO RESPONSE FROM ECM (PCI BUS) - DIESEL ONLY
- Symptom: *NO RESPONSE FROM ECM (SCI ONLY) - DIESEL ONLY
- Symptom: *NO RESPONSE FROM HANDS FREE MODULE
- Symptom: *NO RESPONSE FROM INSTRUMENT CLUSTER
- Symptom: *NO RESPONSE FROM OVERHEAD CONSOLE (COMPASS/TEMPERATURE MIRROR MODULE)
- Symptom: *NO RESPONSE FROM PCM (PCI BUS) - 1.6L
- Symptom: *NO RESPONSE FROM PCM (PCI BUS) - NGC
- Symptom: *NO RESPONSE FROM PCM (PCM SCI ONLY) - NGC
- Symptom: *NO RESPONSE FROM PCM (SCI ONLY) - 1.6L
- Symptom: *NO RESPONSE FROM RADIO
- Symptom: *NO RESPONSE FROM RKE
- Symptom: *NO RESPONSE FROM SATELLITE RADIO RECEIVER
- Symptom: *NO RESPONSE FROM SENTRY KEY IMMOBILIZER MODULE
- Symptom: *NO RESPONSE FROM TRANSMISSION CONTROL MODULE - NGC
- Symptom: *NO RESPONSE FROM WINDOW REGULATOR MODULE - PT27
- Symptom: *PCI BUS COMMUNICATION FAILURE
- Instrument Cluster
- Symptom List: ABS INDICATOR CIRCUIT OPEN; AIRBAG INDICATOR CIRCUIT OPEN
- Symptom List: ABS MESSAGE NOT RECEIVED; ACM MESSAGE NOT RECEIVED; EATX MESSAGE NOT RECEIVED; NO PCI TRANSMISSION; SBEC MESSAGE NOT RECEIVED; SKIM MESSAGE NOT RECEIVED
- Symptom: EATX MESSAGE MISMATCH
- Symptom: EEPROM CHECKSUM FAILURE
- Symptom: FUEL LEVEL SENSOR OPEN
- Symptom: FUEL LEVEL SENSOR SHORT
- Symptom: FUEL LEVEL SENSOR STUCK
- Symptom: PANEL DIMMER OPEN
- Symptom: PANEL DIMMER SHORTED
- Symptom: *ALL GAUGES INOPERATIVE
- Symptom: *ANY PCI BUS INDICATOR INOPERATIVE
- Symptom: *BRAKE WARNING INDICATOR ALWAYS ON
- Symptom: *BRAKE WARNING INDICATOR INOPERATIVE
- Symptom: *FRONT FOG LAMP INDICATOR INOPERATIVE
- Symptom: *FUEL GAUGE INACCURATE
- Symptom: *HIGH BEAM INDICATOR INOPERATIVE
- Symptom: *INSTRUMENT CLUSTER DIMMING INOPERATIVE
- Symptom: *LOW OIL PRESSURE INDICATOR ALWAYS ON
- Symptom: *LOW OIL PRESSURE INDICATOR INOPERATIVE
- Symptom: *ONE GAUGE INOPERATIVE
- Symptom: *PRND OR AUTOSTICK DISPLAY INOPERATIVE OR INACCURATE
- Symptom: *REAR FOG LAMP INDICATOR INOPERATIVE - BUX ONLY
- Symptom: *SEAT BELT INDICATOR NOT OPERATING PROPERLY
- Symptom: *VF DISPLAY INOPERATIVE
- Interior Lighting
- Overhead Console
- Power Door Locks/RKE
- Symptom: BODY STYLE MISMATCH
- Symptom: DRIVER DOOR SWITCH FAILURE
- Symptom: INCORRECT MODULE TYPE CONFIGURATION FOR PART NUMBER
- Symptom: MODULE NOT CONFIGURED FOR RKE
- Symptom: NO AIRBAG MESSAGES RECEIVED
- Symptom: NO PCM MESSAGES RECEIVED
- Symptom: NO SKIM MESSAGES RECEIVED
- Symptom: PASSENGER DOOR OR LIFTGATE SWITCH FAILURE - PT44
- Symptom:* ALL DOORS (EXCEPT DRIVER)FAIL TO LOCK
- Symptom: * ALL DOORS (EXCEPT DRIVER)FAIL TO LOCK AND UNLOCK
- Symptom:* ALL DOORS (EXCEPT DRIVER)FAIL TO UNLOCK
- Symptom: *ALL DOOR LOCKS INOPERATIVE
- Symptom: *ALL DOORS FAIL TO LOCK
- Symptom: *ALL DOORS FAIL TO UNLOCK
- Symptom: *ALL LOCKS INOPERATIVE FROM ONE LOCK SWITCH
- Symptom: *DECKLID RELEASE SWITCH INOPERATIVE - PT27
- Symptom: *DECKLID SOLENOID INOPERATIVE - PT27
- Symptom: *DOORS LOCKABLE WITH KEY IN IGNITION AND DRIVER DOOR OPEN
- Symptom: *DRIVER DOOR FAILS TO LOCK
- Symptom: *DRIVER DOOR FAILS TO LOCK AND UNLOCK
- Symptom: *DRIVER DOOR FAILS TO UNLOCK
- Symptom: *DRIVER DOOR FAILS UNLOCK - PT27
- Symptom: *LIFTGATE LOCK MOTOR FAILS TO LOCK OR UNLOCK
- Symptom: *ONE DOOR FAILS TO LOCK AND UNLOCK - PT27
- Symptom: *ONE PASSENGER DOOR FAILS TO LOCK AND UNLOCK
- Symptom: *PASSENGER DOOR FAILS TO UNLOCK - PT27
- Symptom: *RKE INOPERATIVE
- Power Top
- Symptom: AMBIENT TEMP MESSAGE NOT RECEIVED
- Symptom: POWER TOP RELAY CONTROL CIRCUIT OPEN
- Symptom: POWER TOP RELAY INOPERATIVE
- Symptom: POWER TOP SWITCH MUX CIRCUIT OPEN
- Symptom: POWER TOP SWITCH MUX CIRCUIT SHORT TO GROUND
- Symptom: POWER TOP SWITCH MUX CIRCUIT VALUE OUT OF RANGE
- Symptom: SPEED MESSAGE NOT RECEIVED
- Power Windows
- Symptom: BATTERY VOLTAGE TOO HIGH
- Symptom: BATTERY VOLTAGE TOO LOW
- Symptom: FRONT WINDOW MOTOR MALFUNCTION
- Symptom: FRONT WINDOW SWITCH MUX CIRCUIT OPEN
- Symptom: FRONT WINDOW SWITCH MUX CIRCUIT SHORT TO GROUND
- Symptom: FRONT WINDOW SWITCH MUX CIRCUIT VALUE OUT OF RANGE
- Symptom: IGNITION SWITCH OUTPUT OPEN
- Symptom: REAR WINDOW MOTOR CIRCUIT OPEN OR SHORTED
- Symptom: REAR WINDOW SWITCH MUX CIRCUIT OPEN
- Symptom: REAR WINDOW SWITCH MUX CIRCUIT SHORT TO GROUND
- Symptom: REAR WINDOW SWITCH MUX CIRCUIT VALUE OUT OF RANGE
- Symptom: WINDOW DROP SWITCH SENSE CIRCUIT OPEN
- Symptom: *DOOR AJAR CIRCUIT OPEN
- Symptom: *DOOR WINDOWS STAY IN DROP DOWN POSITION
- Symptom: *WINDOW DROPS OR JERKS DURING OPENING
- Telecommunication
- Symptom: AUDIO HARDWARE MESSAGE NOT RECEIVED
- Symptom List: BLUETOOTH ERROR; FLASH CHECKSUM ERROR; FLASH WRITE ERROR; PCI BUS INTERNAL ERROR; RAM WRITE ERROR; ROM CHECKSUM ERROR
- Symptom List: BODY STYLE MESSAGE NOT RECEIVED; INVALID BODY STYLE
- Symptom: GENERAL MICROPHONE FAULT
- Symptom: IGNITION POWER MESSAGE NOT RECEIVED
- Symptom List: LEFT AUDIO INPUT SHORT TO GROUND; LEFT AUDIO INPUT SHORT TO VOLTAGE; LEFT AUDIO OUTPUT 1 SHORT TO GROUND; LEFT AUDIO OUTPUT 1 SHORT TO VOLTAGE
- Symptom List: MIRROR POWER CIRCUIT SHORT TO GROUND; MIRROR POWER CIRCUIT SHORT TO VOLTAGE
- Symptom List: PCI BUS BUSY; PCI BUS CIRCUIT OPEN; PCI BUS CIRCUIT SHORT TO GROUND; PCI BUS CIRCUIT SHORT TO VOLTAGE
- Symptom List: PHONE SWITCH STUCK; VOICE RECOGNITION SWITCH STUCK' VOICE RECOGNITION/PHONE SWITCH CIRCUIT RATIONALITY; VOICE RECOGNITION/PHONE SWITCH CIRCUIT SHORT TO GROUND; VOICE RECOGNITION/PHONE SWITCH CIRCUIT SHORT TO VOLTAGE
- Symptom: PRNDL MESSAGE NOT RECEIVED
- Symptom: RADIO MESSAGE NOT RECEIVED
- Symptom List: RIGHT AUDIO INPUT SHORT TO GROUND; RIGHT AUDIO INPUT SHORT TO VOLTAGE; RIGHT AUDIO OUTPUT 1 SHORT TO GROUND; RIGHT AUDIO OUTPUT 1 SHORT TO VOLTAGE
- Symptom: RPM MESSAGE NOT RECEIVED
- Symptom: VIN MESSAGE NOT RECEIVED
- Symptom: VIN MISMATCH
- Vehicle Theft/Security
- Symptom: HOOD AJAR SWITCH MISSING (EXPORT ONLY)
- Symptom: MODULE PREVIOUSLY CONFIGURED FOR VTSS
- Symptom: *ALARM TRIPS ON ITS OWN
- Symptom: *HEADLAMPS FAIL TO FLASH DURING ALARM
- Symptom: *HORN FAILS TO SOUND DURING ALARM
- Symptom: *INTRUSION SENSOR CANNOT BE DISABLED (EXPORT ONLY)
- Symptom: *INTRUSION SENSOR FAILS TO TRIP VTSS (EXPORT ONLY)
- Symptom: *INTRUSION SENSOR REPEATEDLY TRIGGERS VTSS (EXPORT ONLY)
- Symptom: *OPEN DRIVER DOOR FAILS TO TRIP ALARM
- Symptom: *OPEN LIFTGATE FAILS TO TRIP ALARM
- Symptom: *OPEN PASSENGER DOOR FAILS TO TRIP ALARM
- Symptom: *PARK LAMPS FAIL TO FLASH DURING ALARM
- Symptom List: *VTSS FAILS TO ARM FROM LEFT DOOR CYLINDER LOCK SWITCH (EXPORT ONLY); *VTSS FAILS TO ARM/DISARM FROM LEFT DOOR CYLINDER LOCK SWITCH
- Symptom List: *VTSS FAILS TO ARM FROM LIFTGATE CYLINDER LOCK SWITCH (EXPORT ONLY); *VTSS FAILS TO ARM/DISARM FROM LIFTGATE CYLINDER LOCK SWITCH
- Symptom List: *VTSS FAILS TO ARM FROM RIGHT DOOR CYLINDER LOCK SWITCH (EXPORT ONLY); *VTSS FAILS TO ARM/DISARM FROM RIGHT DOOR CYLINDER LOCK SWITCH
- Symptom: *VTSS INDICATOR FAILS TO FLASH
- Symptom: *VTSS INDICATOR STAYS ON STEADY DURING ARMING
- Symptom: *VTSS SIREN INOPERATIVE (EXPORT ONLY)
- Verifications Tests
- Airbag
- Component Locations
- Connector PINOUTS
- Airbag Control Module (Orc) (Base) - Yellow 23 Way
- Airbag Control Module C1 (Orc) (Premium) - Yellow 32 Way
- Airbag Control Module C2 (Orc) (Premium) - Yellow 32 Way
- Ambient Temperature Sensor (Except 2.4L Base) - Black 2 Way
- Amplifier Audio C1 - 20 Way
- Anti-Lock Brake Module - Black 47 Way
- C203 (Pt27) - LT. Gray (Body Side)
- C203 (Pt27) - LT. Gray (Instrument Panel Side)
- C204 (Pt27) - (Instrument Panel Side)
- C204 (Pt27) - (Left Front Door Side)
- C204 (Pt44 LHP) - Natural (Instrument Panel Side)
- C204 (Pt44 LHP) - Natural (Left Front Door Side)
- C205 (Pt27) - (Instrument Panel Side)
- C205 (Pt27) - (Right Front Door Side)
- C305 - Yellow (Airbag Side)
- C305 - Yellow (UNIBODY Side)
- C306 - Yellow (Airbag Side)
- C306 - Yellow (UNIBODY Side)
- C343 (Pt27) - LT. Gray (DECKLID Jumper Side)
- C343 (Pt27) - LT. Gray (DECKLID Side)
- C349 (Pt27) - Blue (Body Side
- C349 (Pt27) - Blue (DECKLID Jumper Side)
- C362 (Pt27) - LT. Gray (Body Side)
- C362 (Pt27) - LT. Gray (Power Top Side)
- CLOCKSPRING - DK. Green 7 Way
- Compass/Temperature Mirror Module (Pt27) - Black 10 Way
- Data Link Connector - Black 16 Way
- DECKLID Cylinder Unlock Switch (Pt27) - LT. Gray 2 Way
- DECKLID Handle Switch (Pt27) - White 2 Way
- DECKLID Release Motor (Pt27) - Black 3 Way
- DECKLID Release Switch (Pt27) - Black 2 Way
- Dome Lamp - Black 3 Way
- Dome Lamp/Intrusion Sensor (Export) - White 4 Way
- Driver Airbag Squib 1 - Yellow 2 Way
- Driver Door Ajar Switch - Black 2 Way
- Driver Door Handle Switch (Pt27) - 2 Way
- Driver Door Power Lock Motor/Ajar Switch - Black 4 Way
- Driver Rear Window Motor (Pt27) - Black 2 Way
- Driver Seat Belt TENSIONER - Yellow 2 Way
- Driver Window Regulator Module (Pt27) - Black 20 Way
- Engine Control Module C1 (Diesel) - Black 81 Way
- Front Power Window Switch - Black 14 Way
- Fuel Pump Module - LT. Gray 4 Way
- Fuses (FB)
- Hands Free Module C1 - DK. Gray 22 Way
- Hands Free Module C2 (Satellite Radio) - DK. Gray 10 Way
- Hands Free Module C3 - Black 10 Way
- High Note Horn (Export) - Black 2 Way
- Hood Ajar Switch (Export) - Black 2 Way
- Ignition Switch C1 - 10 Way
- Instrument Cluster C1 - Black 26 Way
- Instrument Cluster C2 - Black 10 Way
- Left Cylinder Lock Switch - Black 2 Way
- Left Door Lock Switch - Black 3 Way
- Left Front Power Window Motor (Pt44) - Black 2 Way
- Left Instrument Panel Speaker - Black 2 Way
- Left Rear Speaker (Pt44) - Black 2 Way
- Left Seat Airbag Squib (LHP) - Yellow 2 Way
- Left Seat Airbag Squib (RHD) - Yellow 2 Way
- Left Side Impact Sensor 1 - Gray 2 Way
- Liftgate Ajar Switch - White 2 Way
- Liftgate Cylinder Lock Switch - LT. Gray 2 Way
- Liftgate Handle Switch (Pt44) - Natural 2 Way
- Liftgate Power Lock Motor - Black 4 Way
- Liftgate Release Motor (Pt44) - Black 3 Way
- Low Note Horn - Black 2 Way
- Multi-Function Switch - Gray 20 Way
- Overhead Console Module - Black 12 Way
- Passenger Airbag Squib 1 - Yellow 2 Way
- Passenger Door Ajar Switch - Black 2 Way
- Passenger Door Handle Switch (Pt27) - 2 Way
- Passenger Door Power Lock Motor/Ajar Switch - Black 4 Way
- Passenger Rear Window Motor (Pt27) - Black 2 Way
- Passenger Seat Belt TENSIONER - Yellow 2 Way
- Passenger Window Regulator Module (Pt27) - Black 20 Way
- Fuses (PDC)
- Power Top Motor (Pt27) - 2 Way
- Power Top Relay (Pt27) - Black 6 Way
- Power Top Switch (Pt27) - 3 Way
- Powertrain Control Module (1.6L) - Black 90 Way
- Powertrain Control Module C1 (NGC) - Black/Black 38 Way
- Radio C1 - White 22 Way
- Radio C2 (Hands Free) - DK. Gray 10 Way
- Rear View Mirror C1 - Black 12 Way
- Remote Keyless Entry Module - Black 26 Way
- Right Cylinder Lock Switch (Export) - Black 2 Way
- Right Door Lock Switch - Black 3 Way
- Right Front Door Speaker - 3 Way
- Right Front Power Window Motor (Pt44) - Black 2 Way
- Right Rear Power Window Motor (Pt44) - Black 2 Way
- Right Seat Airbag Squib (LHP) - Yellow 2 Way
- Right Seat Airbag Squib (RHP) - Yellow 2 Way
- Right Side Impact Sensor 1 - Gray 2 Way
- Sentry Key Immobilizer Module - Black 6 Way
- Siren (Export) - Black 4 Way
- Schematic Diagrams
- Restraints
- Restraints
- Child Restraint Anchor - Except Pt27
- Child Restraint Anchor - Pt27
- CLOCKSPRING
- Driver Airbag
- Driver Airbag Cover
- Front Seat Belt & Retractor - Except Pt27
- Front Seat Belt & Retractor - Pt27
- Front Seat Belt Buckle
- Front Seat Belt Height Adjuster
- Occupant Restraint Controller
- Passenger Airbag
- Passenger Airbag Cover
- Rear Center Seat Belt & Retractor
- Rear Seat Belt & Retractor - Except Pt27
- Rear Seat Belt & Retractor - Pt27
- Rear Seat Belt Buckle - Except Pt27
- Rear Seat Belt Buckle - Pt27
- Satellite Acceleration Sensor - Except Pt27
- Satellite Acceleration Sensor - Pt27
- Seat Airbag
- Seat Belt Cinch Bar
- Body Diagnostic Procedures
- Passive Restraints
- Restraints
- Child Restraint Anchor - Except Pt27
- Child Restraint Anchor - Pt27
- CLOCKSPRING
- Driver Airbag
- Driver Airbag Cover
- Front Seat Belt & Retractor - Except Pt27
- Front Seat Belt & Retractor - Pt27
- Front Seat Belt Buckle
- Front Seat Belt Height Adjuster
- Occupant Restraint Controller
- Passenger Airbag
- Passenger Airbag Cover
- Rear Center Seat Belt & Retractor
- Rear Seat Belt & Retractor - Except Pt27
- Rear Seat Belt & Retractor - Pt27
- Rear Seat Belt Buckle - Except Pt27
- Rear Seat Belt Buckle - Pt27
- Satellite Acceleration Sensor - Except Pt27
- Satellite Acceleration Sensor - Pt27
- Seat Airbag
- Seat Belt Cinch Bar
- Restraints Control Systems
- Restraints
- Child Restraint Anchor - Except Pt27
- Child Restraint Anchor - Pt27
- CLOCKSPRING
- Driver Airbag
- Driver Airbag Cover
- Front Seat Belt & Retractor - Except Pt27
- Front Seat Belt & Retractor - Pt27
- Front Seat Belt Buckle
- Front Seat Belt Height Adjuster
- Occupant Restraint Controller
- Passenger Airbag
- Passenger Airbag Cover
- Rear Center Seat Belt & Retractor
- Rear Seat Belt & Retractor - Except Pt27
- Rear Seat Belt & Retractor - Pt27
- Rear Seat Belt Buckle - Except Pt27
- Rear Seat Belt Buckle - Pt27
- Satellite Acceleration Sensor - Except Pt27
- Satellite Acceleration Sensor - Pt27
- Seat Airbag
- Seat Belt Cinch Bar
- Seat Belts
- Restraints
- Restraints
- Child Restraint Anchor - Except Pt27
- Child Restraint Anchor - Pt27
- CLOCKSPRING
- Driver Airbag
- Driver Airbag Cover
- Front Seat Belt & Retractor - Except Pt27
- Front Seat Belt & Retractor - Pt27
- Front Seat Belt Buckle
- Front Seat Belt Height Adjuster
- Occupant Restraint Controller
- Passenger Airbag
- Passenger Airbag Cover
- Rear Center Seat Belt & Retractor
- Rear Seat Belt & Retractor - Except Pt27
- Rear Seat Belt & Retractor - Pt27
- Rear Seat Belt Buckle - Except Pt27
- Rear Seat Belt Buckle - Pt27
- Satellite Acceleration Sensor - Except Pt27
- Satellite Acceleration Sensor - Pt27
- Seat Airbag
- Seat Belt Cinch Bar
- Restraints
- Air Bag, SRS
- Steering
- Manual Steering
- Steering System
- Steering
- Column
- Gear
- Pump
- Steering System
- Power Steering
- Steering System
- Steering
- Column
- Gear
- Pump
- Steering System
- Steering Column
- Steering System
- Steering
- Column
- Gear
- Pump
- Steering System
- Steering Gear
- Steering System
- Steering
- Column
- Gear
- Pump
- Steering System
- Steering Linkage
- Steering System
- Steering
- Column
- Gear
- Pump
- Steering System
- Manual Steering
- Suspension
- Front Suspension
- Suspension System
- Front Suspension
- Rear Suspension
- Wheel Alignment
- Suspension System
- Rear Suspension
- Suspension System
- Front Suspension
- Rear Suspension
- Wheel Alignment
- Suspension System
- Wheel Alignment
- Suspension System
- Front Suspension
- Rear Suspension
- Wheel Alignment
- Suspension System
- Wheels & Tire System
- Front Suspension
- Transmission
- Automatic Trans
- 41TE Automatic Transmission - Diagnosis & Overhaul
- 41TE Automatic Transaxle
- Description
- Diagnosis And Testing
- Diagnosis And Testing - 41TE Transaxle General Diagnosis
- Diagnosis And Testing - Road Test
- Diagnosis And Testing - Hydraulic Pressure Tests
- Notes
- TEST ONE-SELECTOR IN LOW (1st GEAR)
- TEST TWO-SELECTOR IN DRIVE (2nd GEAR)
- TEST TWO A-SELECTOR IN OD (4th Gear)
- TEST THREE-OVERDRIVE CLUTCH CHECK (3rd and 2nd Gear)
- TEST FOUR-SELECTOR IN OVERDRIVE (4th Gear)
- TEST FIVE-SELECTOR IN OVERDRIVE (4th Gear-CC on)
- Test Six-Selector In Reverse
- Test Result Indications
- Diagnosis And Testing - Clutch Air Pressure Tests
- Diagnosis And Testing - Torque Converter Housing Fluid Leakage
- Removal
- Disassembly
- Assembly
- Installation
- Schematics And Diagrams
- Specifications
- Special Tools
- Accumulator
- Driving Clutches
- Final Drive
- Fluid
- Gear Shift Bezel
- Gear Shift Cable
- Gear Shift Knob
- Holding Clutches
- Input Clutch Assembly
- Oil Pump
- Planetary GEARTRAIN
- Seal - Oil Pump
- Shift Interlock Cable
- Shift Interlock Mechanism
- Shift Interlock System
- Shift Mechanism
- Solenoid/Pressure Switch ASSY
- Speed Sensor - Input
- Speed Sensor - Output
- Torque Converter
- Transmission Control Relay
- Transmission Range Sensor
- Valve Body
- 41TE Automatic Transaxle
- Automatic Transmission Diagnostic Procedures
- DTC Index
- Introduction
- Identification Of System
- System Description And Functional Operation
- Disclaimers, Safety, And Warnings
- Required Tools And Equipment
- Glossary Of Terms
- Diagnostic Information And Procedures
- Communication - Symptoms
- Transmission - NGC - Symptoms
- Symptom: *BACKUP LAMPS COME ON WHILE SHIFTER IS NOT IN REVERSE POSITION
- Symptom: *BACKUP LAMPS INOPERATIVE
- Symptom: *NO MANUAL AUTOSTICK OPERATION
- Symptom: *PRNDL FAULT CLEARING PROCEDURE
- Symptom: *TRANSMISSION NOISY WITH NO DTC'S PRESENT
- Symptom: *TRANSMISSION SHIFTS EARLY WITH NO DTC'S
- Symptom: *TRANSMISSION SIMULATOR 8333 WILL NOT POWER UP
- Transmission - NGC - Diagnostic Tests
- P0122-Throttle Position Sensor/Apps Low
- P0123-Throttle Position Sensor/Apps High
- P0124-Throttle Position Sensor/Apps Intermittent
- P0218-High Temperature Operation Activated
- P0562-Low Battery Voltage
- P0602-Control Module Programming Error
- P0604-Internal TCM; P0605-Internal TCM; P0613-Internal TCM
- P0706-Check Shifter Signal
- P0711-Transmission Temperature Sensor Performance
- P0712-Transmission Temperature Sensor Low
- P0713-Transmission Temperature Sensor High
- P0714-Transmission Temperature Sensor Intermittent
- P0715-Input Speed Sensor Error
- P0720-Output Speed Sensor Error
- P0725-Engine Speed Sensor Circuit
- P0731-Gear Ratio Error In 1ST
- P0732-Gear Ratio Error In 2ND
- P0733-Gear Ratio Error In 3RD
- P0734-Gear Ratio Error In 4TH
- P0736-Gear Ratio Error In Reverse
- P0740-TCC Out Of Range
- P0750-LR Solenoid Circuit
- P0755-2/4 Solenoid Circuit
- P0760-Od Solenoid Circuit
- P0765-UD Solenoid Circuit
- P0841-LR Pressure Switch Sense Circuit
- P0845-2/4 Hydraulic Pressure Test Failure
- P0846-2/4 Pressure Switch Sense Circuit
- P0870-Od Hydraulic Pressure Test Failure
- P0871-Od Pressure Switch Sense Circuit
- P0884-Power Up At Speed
- P0888-Relay Output Always Off
- P0890-Switched Battery
- P0891-Transmission RLY Always On
- P0897-Worn Out/Burnt Transaxle Fluid
- P0944-Loss Of Prime
- P0952-AUTOSTICK Input Circuit Low
- P0992-2-4/Od Hydraulic Pressure Test Failure
- P1652-Serial Communication Link Malfunction
- P1684-Battery Was Disconnected
- P1687-No Communication With The Mic
- P1694-Bus Communication With Engine Module
- P1775-Solenoid Switch Valve Latched In TCC Position
- P1776-Solenoid Switch Valve Latched In LR Position
- P1790-Fault Immediately After Shift
- P1793-TRD Link Communication Error
- P1794-Speed Sensor Ground Error
- P1797-Manual Shift Overheat
- Verification Tests
- Component Locations
- Connector PINOUTS
- AUTOSTICK Switch - Natural 4 Way
- Data Link Connector - Black 16 Way
- Input Speed Sensor - Gray 2 Way
- Left Back-Up Lamp - Gray 2 Way
- Output Speed Sensor - Gray 2 Way
- Powertrain Control Module C1 (NGC) - Black/Black 38 Way
- Powertrain Control Module C2 (NGC) - Black/Orange 38 Way
- Powertrain Control Module C3 (NGC) - Black/Natural 38 Way
- Powertrain Control Module C4 (NGC) - Black/Green 38 Way
- Right Back-Up Lamp - Gray 2 Way
- Throttle Position Sensor (2.4L) - Black 3 Way
- Transmission Range Sensor (2.4L) - DK. Gray 10 Way
- Transmission Solenoid/Pressure Switch Assembly (2.4L) - Black 8 Way
- Schematic Diagrams
- Charts And Graphs
- Engine Cooling System & Automatic Transmission Cooling System
- Cooling
- Accessory Drive - 1.6L SOHC
- Accessory Drive - 2.0/2.4L DOHC
- Engine - 1.6L SOHC
- Engine - 1.6L SOHC
- Coolant
- Hose Clamps
- Coolant Recovery Container
- Engine Block Heater
- Engine Coolant Temp Sensor
- Engine Coolant Thermostat And Housing
- Radiator Pressure Cap
- Radiator DRAINCOCK
- Radiator Fan
- Radiator
- Heater Return Tube
- Water Pump/Power Steering Pump Assembly
- Engine - 2.0/2.4L DOHC
- Engine - 2.0/2.4L DOHC
- Coolant
- Coolant Recovery Container
- Cooling System Pressure Cap
- Engine Block Heater
- Engine Coolant Temperature Sensor
- Engine Coolant Thermostat
- Hose Clamps
- Radiator Fan
- Radiator
- Radiator DRAINCOCK
- Thermostat Housing
- Water Pump
- Water Pump Inlet Tube
- Transmission
- 41TE Automatic Transmission - Diagnosis & Overhaul
- Transmission Control Systems
- 41TE Automatic Transmission - Diagnosis & Overhaul
- 41TE Automatic Transaxle
- Description
- Diagnosis And Testing
- Diagnosis And Testing - 41TE Transaxle General Diagnosis
- Diagnosis And Testing - Road Test
- Diagnosis And Testing - Hydraulic Pressure Tests
- Notes
- TEST ONE-SELECTOR IN LOW (1st GEAR)
- TEST TWO-SELECTOR IN DRIVE (2nd GEAR)
- TEST TWO A-SELECTOR IN OD (4th Gear)
- TEST THREE-OVERDRIVE CLUTCH CHECK (3rd and 2nd Gear)
- TEST FOUR-SELECTOR IN OVERDRIVE (4th Gear)
- TEST FIVE-SELECTOR IN OVERDRIVE (4th Gear-CC on)
- Test Six-Selector In Reverse
- Test Result Indications
- Diagnosis And Testing - Clutch Air Pressure Tests
- Diagnosis And Testing - Torque Converter Housing Fluid Leakage
- Removal
- Disassembly
- Assembly
- Installation
- Schematics And Diagrams
- Specifications
- Special Tools
- Accumulator
- Driving Clutches
- Final Drive
- Fluid
- Gear Shift Bezel
- Gear Shift Cable
- Gear Shift Knob
- Holding Clutches
- Input Clutch Assembly
- Oil Pump
- Planetary GEARTRAIN
- Seal - Oil Pump
- Shift Interlock Cable
- Shift Interlock Mechanism
- Shift Interlock System
- Shift Mechanism
- Solenoid/Pressure Switch ASSY
- Speed Sensor - Input
- Speed Sensor - Output
- Torque Converter
- Transmission Control Relay
- Transmission Range Sensor
- Valve Body
- 41TE Automatic Transaxle
- 41TE Automatic Transmission - Diagnosis & Overhaul
- Automatic Trans
- External Pages