Specifications Index
EXPLORER & MOUNTAINEER SPECIFICATIONS INDEX
| System | Specification/Procedure | ||
|---|---|---|---|
| Air Conditioning | |||
| Service | SPECIFICATIONS | ||
| Torque | TORQUE SPECIFICATIONS | ||
| Axle Nut/Hub Nut | |||
| Front | 184 Ft. Lbs. (250 N.m) | ||
| Rear | 203 Ft. Lbs. (275 N.m) | ||
| Brakes | |||
| Bleeding Sequence | BLEEDING BRAKE SYSTEM | ||
| Disc Brakes | BRAKE SPECIFICATIONS | ||
| Torque | TORQUE SPECIFICATIONS | ||
| Charging | |||
| Generator | GENERATOR SPECIFICATIONS | ||
| Torque | TORQUE SPECIFICATIONS | ||
| Drive Belts | |||
| Adjustment | BELT ADJUSTMENT | ||
| Belt Routing | |||
| 4.0L | BELT ROUTING | ||
| 4.6L | BELT ROUTING | ||
| Engine Cooling | |||
| General Service Specifications | COOLING SYSTEM SPECIFICATIONS | ||
| Radiator Cap Pressure | 13-18 psi (0.9-1.3 kg/cm2 ) | ||
| Thermostat R & I | |||
| 4.0L | THERMOSTAT - 4.0L SOHC | ||
| 4.6L | THERMOSTAT - 4.6L | ||
| Water Pump R & I | |||
| 4.0L | WATER PUMP - 4.0L SOHC | ||
| 4.6L | WATER PUMP - 4.6L | ||
| Engine Mechanical | |||
| 4.0L | |||
| Compression | ENGINE COMPRESSION | ||
| Oil Pressure | 15 psi (103 kPa) minimum oil pressure at normal temperature and 2000 rpm. | ||
| Overhaul | GENERAL SPECIFICATIONS | ||
| Torque | TORQUE SPECIFICATIONS | ||
| 4.6L | |||
| Compression | ENGINE COMPRESSION | ||
| Oil Pressure | 20-45 psi (138-310 kPa) hot @ 1500 rpm | ||
| Overhaul | GENERAL SPECIFICATIONS | ||
| Torque | TORQUE SPECIFICATIONS | ||
| Fluid Specifications | See FLUIDS under MAINTENANCE tab. From within Manager or Service Writer, click the "30/60/90 Interval" or "Maint." button. | ||
| Flywheel/Flex Plate Torque | |||
| 4.0L | INSTALLATION | ||
| 4.6L | INSTALLATION | ||
| Fuel System | |||
| Fuel Filter Location | Behind heat shield and fuel filter shield under vehicle, mounted in fuel filter support. | ||
| Fuel Filter R&I | REMOVAL & INSTALLATION (EXPLORER & MOUNTAINEER) | ||
| Pressure Release Procedure | FUEL SYSTEM PRESSURE RELEASE | ||
| Pressure Specification | |||
| 4.0L | FUEL PRESSURE SPECIFICATIONS | ||
| 4.6L | FUEL PRESSURE SPECIFICATIONS | ||
| Fuel Pressure Test Procedure | FUEL PRESSURE | ||
| Ignition | |||
| Firing Order & Cylinder Identification | |||
| 4.0L | FIRING ORDER & CYLINDER IDENTIFICATION | ||
| 4.6L | FIRING ORDER & CYLINDER IDENTIFICATION | ||
| Ignition Wires (Resistance) | HIGH TENSION WIRE RESISTANCE | ||
| Ignition Wires (Routing) | |||
| 4.0L | SPARK PLUG WIRE ROUTING (4.0L -- EXPLORER & MOUNTAINEER) | ||
| 4.6L | ROUTING | ||
| Spark Plugs | |||
| 4.0L | |||
| Type | Original spark plug, right side: Motorcraft AGRF-22PG Original spark plug, left side: Motorcraft AGRF-22P Service spark plug, both sides: Motorcraft AGSF-22PP |
||
| Gap | .052-.056 In. (1.32-1.42 mm) | ||
| Torque | 13 Ft. Lbs. (17 N.m) | ||
| 4.6L | |||
| Type | Motorcraft AWSF-32P | ||
| Gap | .052-.056 In. (1.32-1.42 mm) | ||
| Torque | 13 Ft. Lbs. (18 N.m) | ||
| Starting | |||
| Starter | STARTER MOTOR SPECIFICATIONS | ||
| Torque | TORQUE SPECIFICATIONS | ||
| Wheel Alignment | |||
| Adjustment Specifications | SPECIFICATIONS | ||
| Torque | TORQUE SPECIFICATIONS | ||
| Wheel & Tire | |||
| Wheel Lug Nut Torque | 100 Ft. Lbs. (135 N.m) | ||