LEMON Manuals: Even more car manuals for everyone: 1960-2025
Home >> Ford >> 2016 >> Focus S, Automatic DCT Trans, Gas >> Repair and Diagnosis (Single Page) >> Engine Performance >> Testing & Diagnosis >> Engine Controls - Pinpoint Test JE: Integrated Ignition Coil Pack Through Pinpoint Test Z: Intermittent - (Except Diesel & Hybrid) >> Pinpoint Test Kc: Fuel Pump Control Module >> Introduction
April 5, 2026: LEMON Manuals is launched! Read the announcement.

Pinpoint Test Kc: Fuel Pump Control Module: Introduction

WARNING: THE FUEL SYSTEM REMAINS UNDER PRESSURE AFTER THE ENGINE IS OFF. RELIEVE PRESSURE BEFORE REPAIRING. HIGHLY FLAMMABLE MIXTURES ARE PRESENT. TO RELEASE PRESSURE FROM THE FUEL SYSTEM, CARRY OUT THE FOLLOWING:
  • CONNECT FUEL PRESSURE TEST KIT 310-D009 (D95L-7211A) OR EQUIVALENT.
  • GRADUALLY OPEN THE TESTING KIT VALVE TO RELIEVE THE FUEL PRESSURE IN THE VEHICLE FUEL SYSTEM AND DRAIN THE FUEL INTO A SUITABLE CONTAINER OR RETURN IT TO THE FUEL TANK.
  • TO AVOID UNNECESSARY FUEL SPILLAGE AND FIRE HAZARD, ANY TIME FUEL LINES ARE DISCONNECTED, THE IGNITION SWITCH MUST BE IN THE OFF POSITION UNLESS FUEL PUMP OPERATION IS REQUIRED FOR TEST PURPOSES.

FAILURE TO FOLLOW THESE INSTRUCTIONS MAY RESULT IN PERSONAL INJURY. 

WARNING: BEFORE WORKING ON OR DISCONNECTING ANY OF THE FUEL TUBES OR FUEL SYSTEM COMPONENTS, RELIEVE THE FUEL SYSTEM PRESSURE TO PREVENT ACCIDENTAL SPRAYING OF FUEL. FUEL IN THE FUEL SYSTEM REMAINS UNDER HIGH PRESSURE, EVEN WHEN THE ENGINE IS NOT RUNNING. FAILURE TO FOLLOW THIS INSTRUCTION MAY RESULT IN SERIOUS PERSONAL INJURY.
WARNING: DO NOT SMOKE, CARRY LIGHTED TOBACCO OR HAVE AN OPEN FLAME OF ANY TYPE WHEN WORKING ON OR NEAR ANY FUEL-RELATED COMPONENT. HIGHLY FLAMMABLE MIXTURES ARE ALWAYS PRESENT AND MAY BE IGNITED. FAILURE TO FOLLOW THESE INSTRUCTIONS MAY RESULT IN SERIOUS PERSONAL INJURY.
WARNING: DO NOT CARRY PERSONAL ELECTRONIC DEVICES SUCH AS CELL PHONES, PAGERS OR AUDIO EQUIPMENT OF ANY TYPE WHEN WORKING ON OR NEAR ANY FUEL-RELATED COMPONENT. HIGHLY FLAMMABLE MIXTURES ARE ALWAYS PRESENT AND MAY BE IGNITED. FAILURE TO FOLLOW THESE INSTRUCTIONS MAY RESULT IN SERIOUS PERSONAL INJURY.
WARNING: WHEN HANDLING FUEL, ALWAYS OBSERVE FUEL HANDLING PRECAUTIONS AND BE PREPARED IN THE EVENT OF FUEL SPILLAGE. SPILLED FUEL MAY BE IGNITED BY HOT VEHICLE COMPONENTS OR OTHER IGNITION SOURCES. FAILURE TO FOLLOW THESE INSTRUCTIONS MAY RESULT IN SERIOUS PERSONAL INJURY.
WARNING: CLEAN ALL FUEL RESIDUE FROM THE ENGINE COMPARTMENT. IF NOT REMOVED, FUEL RESIDUE MAY IGNITE WHEN THE ENGINE IS RETURNED TO OPERATION. FAILURE TO FOLLOW THIS INSTRUCTION MAY RESULT IN SERIOUS PERSONAL INJURY.

This pinpoint test is intended to diagnose the following:

Fig 1: Identifying Fuel Pump (FP) Connector (1 Of 2)
G10766454Courtesy of FORD MOTOR CO.
Fig 2: Identifying Fuel Pump (FP) Connector (2 Of 2)
G10766455Courtesy of FORD MOTOR CO.
Vehicle Connector Pin Circuit
E-Series,
Expedition,
F-150,
Mustang 2.3L,
Mustang 3.7L,
Mustang 5.0L,
Navigator,
Transit		 A 3
4		 FPRTN
FPPWR
EcoSport B 4
1		 FPGND
FPPWR
F-650/F-750,
F-Series Super Duty,
Motorhome/Stripped Chassis/Step Van		 C 3
4		 FPRTN
FPPWR
Focus 2.3L,
Mustang 5.2L		 D 6
3
1
4		 FPRTN
FPPWR
FP2RTN
FP2PWR
KA E 4
5		 FPGND
FPPWR
All other vehicles E 4
5		 FPRTN
FPPWR
Fig 3: Identifying Fuel Pump Control Module Connector
G06054377Courtesy of FORD MOTOR CO.
Vehicle Connector Pin Circuit
F-150,
F-650/F-750,
Focus,
Fusion,
MKC,
MKZ,
Motorhome/Stripped Chassis/Step Van,
Mustang		 A 8
5
7
3
4
1		 FPRTN
FPPWR
FPM
FPC
GND
VPWR Fuel
All other vehicles A 6
8
5
7
3
4
1		 ENS
FPRTN
FPPWR
FPM
FPC
GND
VPWR Fuel
Fig 4: Identifying Fuel Pump Control Module 2 Module Connector
G06054377Courtesy of FORD MOTOR CO.
Pin Circuit
8 FP2RTN (Fuel Pump 2 Return)
5 FP2PWR (Fuel Pump 2 Power)
7 FPM2 (Fuel Pump Monitor 2)
3 FPC (Fuel Pump Command)
4 GND (Ground)
1 VPWR Fuel

Refer to the Wiring Diagrams article for schematic and connector information.

Fig 5: Identifying Fuel Pump Control Module Relay Connector
G10766458Courtesy of FORD MOTOR CO.
Vehicle Connector Pin Circuit
E-Series,
Motorhome/Stripped Chassis/Step Van		 A 2
1
3
5		 GND
VPWR
B+
VPWR Fuel
EcoSport A 5
2
1
3		 FPPWR
FP
VPWR
B+
Expedition,
MKC,
Mustang,
Navigator,
Transit		 A 2
1, 3
5		 FP
B+
VPWR Fuel
Explorer,
Fusion,
MKS,
MKZ,
Taurus		 B 1
2, 3
5		 FP
B+
VPWR Fuel
Fiesta B 2
1
3
5		 GND
VPWR
B+
VPWR Fuel
KA A 5
2
1, 3		 FPPWR
FP
B+
All other vehicles B 2
1, 3
5		 FP
B+
VPWR Fuel
Fig 6: Identifying Fuel Pump Control Module 2 Relay Connector
G10766459Courtesy of FORD MOTOR CO.
Vehicle Connector Pin Circuit
Mustang 5.2L A 2
1, 3
5		 FP
B+
VPWR Fuel
Focus 2.3L A 1
2
3
5		 FP
GND
B+
VPWR Fuel
Fig 7: Identifying Inertia Fuel Shutoff (IFS) Switch Connector
G10766460Courtesy of FORD MOTOR CO.
Pin Circuit
1 VPWR Fuel - B
2 VPWR Fuel - A
Fig 8: Identifying Body Control Module-C (BCM-C) Connector
G10766461Courtesy of FORD MOTOR CO.
Vehicle Connector Pin Circuit
Edge,
Fusion,
MKZ		 A 29
26		 IES
FP
KA B 7 FP
Transit C 12 FP
All other vehicles A 26 FP
Fig 9: Identifying Body Control Module-E (BCM-E) Connector
G10766462Courtesy of FORD MOTOR CO.
Pin Circuit
E9 VPWR (Vehicle Power)
Fig 10: Identifying Body Control Module-F (BCM-F) Connector
G10766463Courtesy of FORD MOTOR CO.
Vehicle Connector Pin Circuit
Explorer,
Mustang		 A 26 FP
F-150 A 29
26		 IES
FP
All other vehicles B 6 FP
Fig 11: Identifying Restraints Control Module (RCM) Connector
G10766464Courtesy of FORD MOTOR CO.
Vehicle Connector Pin Circuit
Expedition,
Explorer,
Fiesta,
MKS,
Navigator,
Taurus,
Transit		 A 42 ENS
All other vehicles B 19 ENS

Powertrain Control Module (PCM) Connector 

For PCM connector views or reference values, refer to References Values .

Vehicle Connector Pin Circuit
E-Series 5.4L,
Escape/Kuga 2.5L,
F-Series Super Duty		 190-PIN B32
B19		 FPM
FPC
E-Series 6.8L,
F-650/F-750,
Flex TiVCT 3.5L,
MKS 3.7L,
MKT 3.7L,
MKX 3.7L,
Motorhome/Stripped Chassis/Step Van,
Mustang 3.7L,
Mustang 5.0L,
Taurus TiVCT 3.5L,
Taurus 3.7L		 198 PIN B27
B14		 FPM
FPC
EcoSport 2.0L Manual Transmission,
EcoSport 1.6L		 80 PIN B15 FP
EcoSport 2.0L Automatic Transmission 128 PIN B12 FP
Edge 2.0L,
Edge 2.7L,
F-150 2.7L,
F-150 GTDI 3.5L,
Fusion 1.5L,
Fusion 2.0L,
MKZ 2.0L		 198 PIN B29
B27
B39		 IES
FPM
FPC
Edge 3.5L,
F-150 TiVCT 3.5L,
F-150 5.0L		 198 PIN B49
B27
B14		 IES
FPM
FPC
Explorer TiVCT 3.5L,
Explorer 3.7L		 198 PIN B32
B19		 FPM
FPC
Fiesta GTDI 1.6L 198 PIN B4
B37		 FPM
FPC
Fiesta TiVCT 1.6L 128 PIN E13
B37		 FPM
FPC
Focus GDI 2.0L 154 PIN B12
B45		 FPM
FPC
Focus 2.3L 198 PIN B27
B85
B39		 FPM
FPM2
FPC
Fusion 2.5L,
MKZ 3.7L		 190-PIN B9
B32
B19		 IES
FPM
FPC
KA 128 PIN B4 FPM
Mustang 5.2L 198 PIN B27
B31
B14		 FPM
FPM2
FPC
Transit Connect 2.5L 198 PIN B27
B65		 FPM
FPC
All other vehicles 198 PIN B27
B39		 FPM
FPC
scientia non olet · About LEMON Manuals