LEMON Manuals: Even more car manuals for everyone: 1960-2025
Home >> Ford >> 2023 >> Escape ST-Line Select >> Repair and Diagnosis >> External Pages >> Different car >> Section 1128 (Charging System - General Information) >> Diagnosis And Testing >> Charging System >> Pinpoint Tests >> Pinpoint Test D: Radio Interference
April 5, 2026: LEMON Manuals is launched! Read the announcement.

Pinpoint Test D: Radio Interference

WARNING: This page is about a different car, the 2022 Ford Police Interceptor Utility and 2022 Ford Explorer. However, it is still accessible from the selected car via links, so may be relevant.
  1. NOTE: If the Original Equipment Manufacturer (OEM) Audio Control Module (ACM) has been replaced with an aftermarket unit, the vehicle may not pass this test. Return the vehicle to Original Equipment Manufacturer (OEM) condition before following this pinpoint test.
    NOTE: If the engine is operated at greater than 2, 000 Revolutions Per Minute (RPM) momentarily, the generator self-excites. Make sure when the generator is disconnected the engine rpm stays below 2, 000 Revolutions Per Minute (RPM). If it rises above 2, 000 Revolutions Per Minute (RPM), turn the ignition to the OFF position and start the test over again.
    NOTE: Inspect for any aftermarket accessories that have been added to the vehicle. Check the wiring for these accessories and be sure they have not been attached to the generator circuits and are positioned away from the generator wiring.

    Normal Operation and Fault Conditions 

    The generator radio suppression equipment reduces interference transmitted through the speakers by the vehicle electrical system.

    Possible Sources 

    • Generator
    • In-vehicle entertainment system
    • Wiring, terminals or connectors

    Visual Inspection and Pre-checks 

    • Inspect the generator.
    • Inspect the in-vehicle entertainment system.

  2. D1 VERIFY THE GENERATOR IS THE SOURCE OF THE AUDIO SYSTEM INTERFERENCE

    • Start the engine.

    • Allow the engine to idle.

    • Tune the audio system to a station where interference is present.

    • Ignition OFF.

    • Disconnect Generator C102A .

    • Start the engine.

    • Allow the engine to idle.

    Is the interference present with the generator disconnected? 

    Yes  DIAGNOSE the audio system. Refer to the appropriate engine article for the procedure.
    No  INSTALL a new generator. REFER to: Generator - 2.3L EcoBoost (201kW/273PS) . REFER to: Generator - 3.0L EcoBoost . REFER to: Generator - 3.3L Duratec-V6 .
scientia non olet · About LEMON Manuals