Repair and Diagnosis (Single Page)
You are viewing the full "tree" of links on one page. This can load slowly, but is easier to search. The same page can appear multiple times under a different folder, that is why the page is so large.View "split tree" where inner folders are split out. where inner links are on separate pages.
Quick Lookups
Common Specs & Procedures
DTC Index
Electrical Component Locations
Fluids
Technical Bulletins
Tire Fitment
Wiring Diagrams- OEM Connector End Views
- Connector End Views
- ABS Hydraulic & Electronic Control Unit Harness Connector End View
- Accelerator Sensor Connector End View
- A/C Triple Pressure Switch Connector End View
- Air Conditioning Relay End View
- Blower Fan Relay End View
- Camshaft Position Sensor Connector End View
- Condenser Fan Relay End View
- Crankshaft Position Sensor Connector End View
- Data Link Connector End View
- Door Switch Connector End View
- ECM Control Relay Connector C46 End View
- Engine Control Module (ECM) Connector End Views
- Engine Coolant Temperature Sensor Connector End View (1.5L)
- Engine Coolant Temperature Sensor Connector End View (1.6L)
- Front Wiper Motor Connector End View
- Fuel Injector Connector End View
- Fuel Pump Relay Connector End View
- Fuel Sending Unit Harness Connector End View
- Hazard Switch Harness Connector End View
- Heated Oxygen Sensor Connector End View
- Idle Speed Control Valve Connector End View
- Ignition Coil Connector End View
- Instrument Cluster Connector End Views
- Knock Sensor Connector End View
- Manifold Absolute Pressure Sensor & Intake Air Temperature Sensor Connector End View
- Mass Air Flow Sensor & Intake Air Temperature Sensor Connector End View
- Multifunction Switch Assembly Connector End Views (With Air Bag)
- Multifunction Switch Assembly Connector End Views (Without Air Bag)
- Park/Neutral Position Switch Connector End View
- Power Antenna Connector End View (Component Side)
- Power Door Lock Actuator Connector End View
- Power Door Lock Control Module Connector End View
- Power Door Mirror Switch Connector End View & Location
- Power Mirror Actuator Connector End View
- Powertrain Control Module Connector End Views
- Power Window Main Switch Connector End View (Front Power Windows Only)
- Power Window Main Switch Connector End View (Front & Rear Power Windows)
- Power Window Relay End View
- Pre-Excitation Resistor Connector End Views
- Purge Control Solenoid Valve Connector End View
- Rear Defogger Relay End View
- Rear Defogger Switch Connector End View (Harness Side)
- Rear Washer Pump Connector End View
- Rear Wiper Motor Connector End View
- Rear Wiper/Washer Switch Connector End View
- Rheostat Harness Connector End View
- SFI Control Relay Connector End View
- Starter Relay End View & Location
- Supplemental Restraint System Control Module Connector End View (With Side Impact Air Bags)
- Supplemental Restraint System Control Module Connector End View (Without Side Impact Air Bags)
- TCM Connector C37-2 End View
- Throttle Position Sensor Connector End View
- Transaxle Range Switch Harness Connector End View
- Connector Locations
- Connector End Views
- System Wiring Diagrams
- Using lemon2025'S Wiring Diagrams
- Air Conditioning
- Anti-Lock Brakes
- Anti-Theft
- Body Control Modules
- Computer Data Lines
- Cooling Fan
- Defoggers
- Engine Performance
- Exterior Lights
- Ground Distribution
- Headlights
- Horn
- Instrument Cluster
- Interior Lights
- Power Antenna
- Power Distribution
- Power Door Locks
- Power Mirrors
- Power Windows
- Radio
- Shift Interlock
- Starting/Charging
- Supplemental Restraints
- Transmission
- Warning Systems
- Wiper/Washer
- Using lemon2025'S System Wiring Diagrams
- OEM Connector End Views
- Accessories & Equipment
- Anti-Theft Systems
- Gauges & Instrument Panels
- Description
- Component Locations
- Trouble Shooting
- Speedometer Inoperative
- Tachometer Inoperative
- Fuel Gauge Inoperative
- Low Fuel Warning Indicator Does Not Light
- Coolant Temperature Gauge Inoperative
- Oil Pressure Warning Indicator Does Not Light
- Low Brake Fluid Warning Indicator Does Not Light
- Door Open Warning Indicator Does Not Light
- Seat Belt Warning Indicator Does Not Light
- Component Tests
- Notes
- Brake Switches
- Brake Warning Indicator
- Coolant Temperature Gauge
- Coolant Temperature Sending Unit
- Door Switch
- El Type Instrument Cluster Inverter
- Fuel Gauge
- Fuel Gauge Sending Unit
- Low Fuel Level Sensor
- Hazard Warning Switch
- Illumination Rheostat
- Oil Pressure Switch
- Oil Pressure Indicator Light
- Seat Belt Warning Switch & Light
- Speedometer
- Tachometer
- Removal & Installation
- Wiring Diagrams
- Heated Glass/Defoggers
- Infotainment
- Power Mirrors
- Steering Column Switches
- Window Motors & Regulators
- Wiper/Washer Systems
- Body & Frame
- Brakes
- Anti-Lock Brakes
- Anti-Lock Brake System
- Description
- Operation
- Bleeding Brake System
- Servicing
- Diagnosis & Testing
- Diagnostic Trouble Code Definitions
- Symptom Tests
- Diagnostic Tests
- Removal & Installation
- Overhaul
- Adjustments
- Torque Specifications
- Wiring Diagrams
- Anti-Lock Brake System
- Mechanical - Hydraulic
- Disc Brakes & Drum Brakes
- Description & Operation
- Bleeding Brake System
- Adjustments
- Testing
- Removal & Installation
- Overhaul
- Torque Specifications
- Disc Brake Specifications
- Drum Brake Specifications
- Disc Brakes & Drum Brakes
- Traction Control
- Anti-Lock Brake System
- Description
- Operation
- Bleeding Brake System
- Servicing
- Diagnosis & Testing
- Diagnostic Trouble Code Definitions
- Symptom Tests
- Diagnostic Tests
- Removal & Installation
- Overhaul
- Adjustments
- Torque Specifications
- Wiring Diagrams
- Anti-Lock Brake System
- Anti-Lock Brakes
- Drivelines & Axles
- Electrical
- Body Electrical
- OEM Connector End Views
- Connector End Views
- ABS Hydraulic & Electronic Control Unit Harness Connector End View
- Accelerator Sensor Connector End View
- A/C Triple Pressure Switch Connector End View
- Air Conditioning Relay End View
- Blower Fan Relay End View
- Camshaft Position Sensor Connector End View
- Condenser Fan Relay End View
- Crankshaft Position Sensor Connector End View
- Data Link Connector End View
- Door Switch Connector End View
- ECM Control Relay Connector C46 End View
- Engine Control Module (ECM) Connector End Views
- Engine Coolant Temperature Sensor Connector End View (1.5L)
- Engine Coolant Temperature Sensor Connector End View (1.6L)
- Front Wiper Motor Connector End View
- Fuel Injector Connector End View
- Fuel Pump Relay Connector End View
- Fuel Sending Unit Harness Connector End View
- Hazard Switch Harness Connector End View
- Heated Oxygen Sensor Connector End View
- Idle Speed Control Valve Connector End View
- Ignition Coil Connector End View
- Instrument Cluster Connector End Views
- Knock Sensor Connector End View
- Manifold Absolute Pressure Sensor & Intake Air Temperature Sensor Connector End View
- Mass Air Flow Sensor & Intake Air Temperature Sensor Connector End View
- Multifunction Switch Assembly Connector End Views (With Air Bag)
- Multifunction Switch Assembly Connector End Views (Without Air Bag)
- Park/Neutral Position Switch Connector End View
- Power Antenna Connector End View (Component Side)
- Power Door Lock Actuator Connector End View
- Power Door Lock Control Module Connector End View
- Power Door Mirror Switch Connector End View & Location
- Power Mirror Actuator Connector End View
- Powertrain Control Module Connector End Views
- Power Window Main Switch Connector End View (Front Power Windows Only)
- Power Window Main Switch Connector End View (Front & Rear Power Windows)
- Power Window Relay End View
- Pre-Excitation Resistor Connector End Views
- Purge Control Solenoid Valve Connector End View
- Rear Defogger Relay End View
- Rear Defogger Switch Connector End View (Harness Side)
- Rear Washer Pump Connector End View
- Rear Wiper Motor Connector End View
- Rear Wiper/Washer Switch Connector End View
- Rheostat Harness Connector End View
- SFI Control Relay Connector End View
- Starter Relay End View & Location
- Supplemental Restraint System Control Module Connector End View (With Side Impact Air Bags)
- Supplemental Restraint System Control Module Connector End View (Without Side Impact Air Bags)
- TCM Connector C37-2 End View
- Throttle Position Sensor Connector End View
- Transaxle Range Switch Harness Connector End View
- Connector Locations
- Connector End Views
- OEM Connector End Views
- Charging Systems
- Generators & Regulators
- Description & Operation
- Component Locations
- Adjustments
- Trouble Shooting
- On-Vehicle Testing
- Bench Testing
- Removal & Installation
- Overhaul
- Generator Specifications
- Torque Specifications
- Wiring Diagrams
- Generators & Regulators
- Component Locations
- Fuses & Circuit Breakers
- Gauges
- Instrument Panel
- Description
- Component Locations
- Trouble Shooting
- Speedometer Inoperative
- Tachometer Inoperative
- Fuel Gauge Inoperative
- Low Fuel Warning Indicator Does Not Light
- Coolant Temperature Gauge Inoperative
- Oil Pressure Warning Indicator Does Not Light
- Low Brake Fluid Warning Indicator Does Not Light
- Door Open Warning Indicator Does Not Light
- Seat Belt Warning Indicator Does Not Light
- Component Tests
- Notes
- Brake Switches
- Brake Warning Indicator
- Coolant Temperature Gauge
- Coolant Temperature Sending Unit
- Door Switch
- El Type Instrument Cluster Inverter
- Fuel Gauge
- Fuel Gauge Sending Unit
- Low Fuel Level Sensor
- Hazard Warning Switch
- Illumination Rheostat
- Oil Pressure Switch
- Oil Pressure Indicator Light
- Seat Belt Warning Switch & Light
- Speedometer
- Tachometer
- Removal & Installation
- Wiring Diagrams
- Instrument Panel
- Motors, Switches, Relays
- OEM Connector End Views
- Connector End Views
- ABS Hydraulic & Electronic Control Unit Harness Connector End View
- Accelerator Sensor Connector End View
- A/C Triple Pressure Switch Connector End View
- Air Conditioning Relay End View
- Blower Fan Relay End View
- Camshaft Position Sensor Connector End View
- Condenser Fan Relay End View
- Crankshaft Position Sensor Connector End View
- Data Link Connector End View
- Door Switch Connector End View
- ECM Control Relay Connector C46 End View
- Engine Control Module (ECM) Connector End Views
- Engine Coolant Temperature Sensor Connector End View (1.5L)
- Engine Coolant Temperature Sensor Connector End View (1.6L)
- Front Wiper Motor Connector End View
- Fuel Injector Connector End View
- Fuel Pump Relay Connector End View
- Fuel Sending Unit Harness Connector End View
- Hazard Switch Harness Connector End View
- Heated Oxygen Sensor Connector End View
- Idle Speed Control Valve Connector End View
- Ignition Coil Connector End View
- Instrument Cluster Connector End Views
- Knock Sensor Connector End View
- Manifold Absolute Pressure Sensor & Intake Air Temperature Sensor Connector End View
- Mass Air Flow Sensor & Intake Air Temperature Sensor Connector End View
- Multifunction Switch Assembly Connector End Views (With Air Bag)
- Multifunction Switch Assembly Connector End Views (Without Air Bag)
- Park/Neutral Position Switch Connector End View
- Power Antenna Connector End View (Component Side)
- Power Door Lock Actuator Connector End View
- Power Door Lock Control Module Connector End View
- Power Door Mirror Switch Connector End View & Location
- Power Mirror Actuator Connector End View
- Powertrain Control Module Connector End Views
- Power Window Main Switch Connector End View (Front Power Windows Only)
- Power Window Main Switch Connector End View (Front & Rear Power Windows)
- Power Window Relay End View
- Pre-Excitation Resistor Connector End Views
- Purge Control Solenoid Valve Connector End View
- Rear Defogger Relay End View
- Rear Defogger Switch Connector End View (Harness Side)
- Rear Washer Pump Connector End View
- Rear Wiper Motor Connector End View
- Rear Wiper/Washer Switch Connector End View
- Rheostat Harness Connector End View
- SFI Control Relay Connector End View
- Starter Relay End View & Location
- Supplemental Restraint System Control Module Connector End View (With Side Impact Air Bags)
- Supplemental Restraint System Control Module Connector End View (Without Side Impact Air Bags)
- TCM Connector C37-2 End View
- Throttle Position Sensor Connector End View
- Transaxle Range Switch Harness Connector End View
- Connector Locations
- Connector End Views
- OEM Connector End Views
- Starters
- Wiring Diagrams
- OEM Connector End Views
- Connector End Views
- ABS Hydraulic & Electronic Control Unit Harness Connector End View
- Accelerator Sensor Connector End View
- A/C Triple Pressure Switch Connector End View
- Air Conditioning Relay End View
- Blower Fan Relay End View
- Camshaft Position Sensor Connector End View
- Condenser Fan Relay End View
- Crankshaft Position Sensor Connector End View
- Data Link Connector End View
- Door Switch Connector End View
- ECM Control Relay Connector C46 End View
- Engine Control Module (ECM) Connector End Views
- Engine Coolant Temperature Sensor Connector End View (1.5L)
- Engine Coolant Temperature Sensor Connector End View (1.6L)
- Front Wiper Motor Connector End View
- Fuel Injector Connector End View
- Fuel Pump Relay Connector End View
- Fuel Sending Unit Harness Connector End View
- Hazard Switch Harness Connector End View
- Heated Oxygen Sensor Connector End View
- Idle Speed Control Valve Connector End View
- Ignition Coil Connector End View
- Instrument Cluster Connector End Views
- Knock Sensor Connector End View
- Manifold Absolute Pressure Sensor & Intake Air Temperature Sensor Connector End View
- Mass Air Flow Sensor & Intake Air Temperature Sensor Connector End View
- Multifunction Switch Assembly Connector End Views (With Air Bag)
- Multifunction Switch Assembly Connector End Views (Without Air Bag)
- Park/Neutral Position Switch Connector End View
- Power Antenna Connector End View (Component Side)
- Power Door Lock Actuator Connector End View
- Power Door Lock Control Module Connector End View
- Power Door Mirror Switch Connector End View & Location
- Power Mirror Actuator Connector End View
- Powertrain Control Module Connector End Views
- Power Window Main Switch Connector End View (Front Power Windows Only)
- Power Window Main Switch Connector End View (Front & Rear Power Windows)
- Power Window Relay End View
- Pre-Excitation Resistor Connector End Views
- Purge Control Solenoid Valve Connector End View
- Rear Defogger Relay End View
- Rear Defogger Switch Connector End View (Harness Side)
- Rear Washer Pump Connector End View
- Rear Wiper Motor Connector End View
- Rear Wiper/Washer Switch Connector End View
- Rheostat Harness Connector End View
- SFI Control Relay Connector End View
- Starter Relay End View & Location
- Supplemental Restraint System Control Module Connector End View (With Side Impact Air Bags)
- Supplemental Restraint System Control Module Connector End View (Without Side Impact Air Bags)
- TCM Connector C37-2 End View
- Throttle Position Sensor Connector End View
- Transaxle Range Switch Harness Connector End View
- Connector Locations
- Connector End Views
- System Wiring Diagrams
- Using lemon2025'S Wiring Diagrams
- Air Conditioning
- Anti-Lock Brakes
- Anti-Theft
- Body Control Modules
- Computer Data Lines
- Cooling Fan
- Defoggers
- Engine Performance
- Exterior Lights
- Ground Distribution
- Headlights
- Horn
- Instrument Cluster
- Interior Lights
- Power Antenna
- Power Distribution
- Power Door Locks
- Power Mirrors
- Power Windows
- Radio
- Shift Interlock
- Starting/Charging
- Supplemental Restraints
- Transmission
- Warning Systems
- Wiper/Washer
- Using lemon2025'S System Wiring Diagrams
- OEM Connector End Views
- Body Electrical
- Engine Mechanical
- Accessory Drive Belts
- Auxiliary Emission Control Systems
- Emission Control System Visual Inspection Procedures - General Information
- * Please Read This First *
- Emission Control Labels
- Emission Control Visual Inspection
- Notes
- Positive Crankcase Ventilation (PCV)
- Thermostatic Air Cleaner (TAC)
- Fuel Evaporative System (EVAP)
- Catalytic Converters
- Fill Pipe RESTRICTOR (Fr)
- Exhaust Gas RECIRCULATION (EGR) System
- Spark Controls (SPK)
- Air Injection System (AIS)
- Oxygen Sensor (O2)
- Computerized Engine Controls (CEC)
- Early Fuel Evaporation (EFE)
- Emission Maintenance Reminder Light (EMR) (If Equipped)
- Malfunction Indicator Light (Mil)
- Emission Control System Visual Inspection Procedures - General Information
- Electric Cooling Fans
- Cooling System (Mechanical)
- Cooling System Specifications & Drive Belt Routing
- Engine Mechanical System (SOHC 1.5L)
- General
- Specifications
- Tightening Torque
- Service Standard
- Special Tools
- Troubleshooting
- Maintenance
- Checking Engine Oil
- Changing Engine Oil
- Filter Selection
- Procedure For Replacing The Oil Filter
- Selection Of Engine Oil
- Checking Coolant Leak
- Radiator Cap Pressure Test
- Specific Gravity Test
- Relation Between Coolant Concentration And Specific Gravity
- Recommended Coolant
- Checking Compression Pressure
- Adjusting Timing Belt Tension
- Adjusting Drive Belt Tension
- Standard Value:
- Type A Tension Gauge
- Type B Tension Gauge
- Adjusting The Alternator Belt
- Engine Block
- Main Moving System
- Cooling System
- Lubrication System
- Intake And Exhaust System
- Cylinder Head Assembly
- Timing System
- General
- Exhaust
- Engine Mechanical System (SOHC 1.5L)
- General
- Specifications
- Tightening Torque
- Service Standard
- Special Tools
- Troubleshooting
- Maintenance
- Checking Engine Oil
- Changing Engine Oil
- Filter Selection
- Procedure For Replacing The Oil Filter
- Selection Of Engine Oil
- Checking Coolant Leak
- Radiator Cap Pressure Test
- Specific Gravity Test
- Relation Between Coolant Concentration And Specific Gravity
- Recommended Coolant
- Checking Compression Pressure
- Adjusting Timing Belt Tension
- Adjusting Drive Belt Tension
- Standard Value:
- Type A Tension Gauge
- Type B Tension Gauge
- Adjusting The Alternator Belt
- Engine Block
- Main Moving System
- Cooling System
- Lubrication System
- Intake And Exhaust System
- Cylinder Head Assembly
- Timing System
- General
- Engine Mechanical System (SOHC 1.5L)
- Lubrication System
- Engine Mechanical System (SOHC 1.5L)
- General
- Specifications
- Tightening Torque
- Service Standard
- Special Tools
- Troubleshooting
- Maintenance
- Checking Engine Oil
- Changing Engine Oil
- Filter Selection
- Procedure For Replacing The Oil Filter
- Selection Of Engine Oil
- Checking Coolant Leak
- Radiator Cap Pressure Test
- Specific Gravity Test
- Relation Between Coolant Concentration And Specific Gravity
- Recommended Coolant
- Checking Compression Pressure
- Adjusting Timing Belt Tension
- Adjusting Drive Belt Tension
- Standard Value:
- Type A Tension Gauge
- Type B Tension Gauge
- Adjusting The Alternator Belt
- Engine Block
- Main Moving System
- Cooling System
- Lubrication System
- Intake And Exhaust System
- Cylinder Head Assembly
- Timing System
- General
- Engine Mechanical System (SOHC 1.5L)
- Engine Mechanical System (SOHC 1.5L)
- General
- Specifications
- Tightening Torque
- Service Standard
- Special Tools
- Troubleshooting
- Maintenance
- Checking Engine Oil
- Changing Engine Oil
- Filter Selection
- Procedure For Replacing The Oil Filter
- Selection Of Engine Oil
- Checking Coolant Leak
- Radiator Cap Pressure Test
- Specific Gravity Test
- Relation Between Coolant Concentration And Specific Gravity
- Recommended Coolant
- Checking Compression Pressure
- Adjusting Timing Belt Tension
- Adjusting Drive Belt Tension
- Standard Value:
- Type A Tension Gauge
- Type B Tension Gauge
- Adjusting The Alternator Belt
- Engine Block
- Main Moving System
- Cooling System
- Lubrication System
- Intake And Exhaust System
- Cylinder Head Assembly
- Timing System
- General
- Starters
- Timing Belt
- Engine Mechanical System (SOHC 1.5L)
- General
- Specifications
- Tightening Torque
- Service Standard
- Special Tools
- Troubleshooting
- Maintenance
- Checking Engine Oil
- Changing Engine Oil
- Filter Selection
- Procedure For Replacing The Oil Filter
- Selection Of Engine Oil
- Checking Coolant Leak
- Radiator Cap Pressure Test
- Specific Gravity Test
- Relation Between Coolant Concentration And Specific Gravity
- Recommended Coolant
- Checking Compression Pressure
- Adjusting Timing Belt Tension
- Adjusting Drive Belt Tension
- Standard Value:
- Type A Tension Gauge
- Type B Tension Gauge
- Adjusting The Alternator Belt
- Engine Block
- Main Moving System
- Cooling System
- Lubrication System
- Intake And Exhaust System
- Cylinder Head Assembly
- Timing System
- General
- Engine Mechanical System (SOHC 1.5L)
- Engine Performance
- Engine Controls - On-Vehicle Adjustments
- Application
- Emissions
- Emission Applications
- Emission Control Abbreviations
- State Emission Standards - Diesel
- State Emission Standards - Gas
- ALASKA
- ARIZONA
- CALIFORNIA
- Colorado
- CONNECTICUT
- DELAWARE
- District Of COLUMBIA
- GEORGIA
- IDAHO
- ILLINOIS
- INDIANA
- KENTUCKY
- MARYLAND
- MASSACHUSETTS
- MISSOURI
- NEVADA
- New Jersey
- New MEXICO
- New YORK
- North CAROLINA
- OHIO
- OREGON
- PENNSYLVANIA
- RHODE Island
- TENNESSEE
- TEXAS
- UTAH
- VIRGINIA
- WASHINGTON
- WISCONSIN
- U. S. EPA ASM2525 & ASM5015 Start-Up Emission Standards
- U. S. EPA Revised Final ASM Emission Standards (ASM5015 & ASM2525)
- U.S. EPA Im240 Emission Standards
- Mode 6 - 2001-2005 HYUNDAI
- Engine Controls - Pin Voltage Charts
- Remove, Overhaul & Install
- Sensor Range Charts
- Engine Controls - Sensor Operating Range Charts
- Introduction
- Notes
- Sensors
- Acceleration
- Camshaft Position (CMP) Sensor
- Crankshaft Position (CKP) Sensor
- Engine Coolant Temperature (ECT) Sensor
- Fuel Tank Pressure (FTP) Sensor
- Heated Oxygen Sensor (HO2S)
- Heated Oxygen Sensor (HO2S) Heater
- Intake Air Temperature (IAT) Sensor
- Knock Sensor
- Manifold Absolute Pressure (MAP) Sensor
- Mass Airflow (MAF) Sensor
- Throttle Position (TP) Sensor
- Vehicle Speed Sensor (VSS)
- Introduction
- Engine Controls - Sensor Operating Range Charts
- Specifications
- System
- Engine Controls - Basic Diagnostic Procedures
- Introduction
- Preliminary Inspection & Adjustments
- Fuel System
- Ignition Checks
- Idle Speed & Ignition Timing
- Summary
- Engine Controls - Self-Diagnostics
- Introduction
- Self-Diagnostic System
- On Board Diagnostics-II
- Malfunction Indicator Light
- Service Precautions
- Diagnostic Procedure
- Retrieving Diagnostic Trouble Codes
- Freeze Frame Data
- Clearing Diagnostic Trouble Codes
- Diagnostic Trouble Code Definitions
- After-Repair Procedure
- Readiness Drive Cycle
- ECM Location & ECM Connector Identification
- Intermittent Diagnostic Trouble Codes
- Diagnostic Tests
- Notes
- DTC P0101, DTC P0102 & DTC P0103 (1.5L Engine)
- DTC P0106, DTC P0107 & DTC P0108 (1.6L Engine)
- DTC P0111, DTC P0112 & DTC P0113
- DTC P0116, DTC P0117 & DTC P0118
- DTC P0121, DTC P0122 & DTC P0123
- DTC P0128: Thermostat Malfunction
- DTC P0130, DTC P0136 & DTC P0140
- DTC P0131 & DTC P0137
- DTC P0132 & DTC P0138
- DTC P0133 & DTC P0134
- DTC P0030, DTC P0031, DTC P0032, DTC P0036, DTC P0037 & DTC P0038
- DTC P0171 & DTC P0172
- DTC P0230: Fuel Pump Relay Malfunction
- DTC P0261, DTC P0262, DTC P0264, DTC P0265, DTC P0267, DTC P0268, DTC P0270 &/Or DTC P0271
- DTC P0300: Random Misfire Detected
- DTC P0301, DTC P0302, DTC P0303 & DTC P0304
- DTC P0325: Knock Sensor Circuit Out Of Range
- DTC P0335 & DTC P0336
- DTC P0340: Camshaft Position Sensor Circuit Malfunction
- DTC P0420: Manifold Catalytic Converter Efficiency Below Threshold
- DTC P0441: Evaporative Emissions Control System Incorrect Purge Flow
- DTC P0442: Evaporative Emissions Control System - Small Leak
- DTC P0444 & DTC P0445
- DTC P0461, DTC P0462 & DTC P0463
- DTC P0501: Vehicle Speed Sensor Range
- DTC P0506 & DTC P0507
- DTC P0562 & DTC P0563
- DTC P0605: Internal Control Module ROM Error
- DTC P1307, DTC P1308 & DTC P1309
- DTC P1401, DTC P1402, DTC P1403 & DTC P0404
- DTC P1505 & DTC P1507
- DTC P1506 & DTC P1508
- DTC P1529 & DTC P1765
- DTC P1586: Encoding Signal Circuit Not Rational
- DTC P1693: Malfunction Indicator Light Request Line Check
- Engine Controls - System & Component Testing
- Introduction
- Computerized Engine Controls
- Engine Sensors & Switches
- Notes
- Sensors
- Acceleration/Rough Road Sensor
- Camshaft Position (CMP) Sensor
- Crankshaft Position (CKP) Sensor
- Engine Coolant Temperature (ECT) Sensor
- Fuel Tank Pressure (FTP) Sensor
- Heated Oxygen Sensor (HO2S)
- Intake Air Temperature (IAT) Sensor
- Knock Sensor (KS)
- Manifold Absolute Pressure (MAP) Sensor
- Mass Airflow (MAF) Sensor
- Manifold Absolute Pressure (MAP) Sensor (Sonata 2.4L)
- Throttle Position (TP) Sensor
- Vehicle Speed Sensor (VSS)
- Switches
- Relays
- Fuel System
- Idle Control System
- Ignition System
- Emission Systems & Sub-Systems
- Engine Controls - Trouble Shooting - No Codes
- Engine Controls - Basic Diagnostic Procedures
- Testing & Diagnosis
- Engine Controls - Basic Diagnostic Procedures
- Introduction
- Preliminary Inspection & Adjustments
- Fuel System
- Ignition Checks
- Idle Speed & Ignition Timing
- Summary
- Engine Controls - Self-Diagnostics
- Introduction
- Self-Diagnostic System
- On Board Diagnostics-II
- Malfunction Indicator Light
- Service Precautions
- Diagnostic Procedure
- Retrieving Diagnostic Trouble Codes
- Freeze Frame Data
- Clearing Diagnostic Trouble Codes
- Diagnostic Trouble Code Definitions
- After-Repair Procedure
- Readiness Drive Cycle
- ECM Location & ECM Connector Identification
- Intermittent Diagnostic Trouble Codes
- Diagnostic Tests
- Notes
- DTC P0101, DTC P0102 & DTC P0103 (1.5L Engine)
- DTC P0106, DTC P0107 & DTC P0108 (1.6L Engine)
- DTC P0111, DTC P0112 & DTC P0113
- DTC P0116, DTC P0117 & DTC P0118
- DTC P0121, DTC P0122 & DTC P0123
- DTC P0128: Thermostat Malfunction
- DTC P0130, DTC P0136 & DTC P0140
- DTC P0131 & DTC P0137
- DTC P0132 & DTC P0138
- DTC P0133 & DTC P0134
- DTC P0030, DTC P0031, DTC P0032, DTC P0036, DTC P0037 & DTC P0038
- DTC P0171 & DTC P0172
- DTC P0230: Fuel Pump Relay Malfunction
- DTC P0261, DTC P0262, DTC P0264, DTC P0265, DTC P0267, DTC P0268, DTC P0270 &/Or DTC P0271
- DTC P0300: Random Misfire Detected
- DTC P0301, DTC P0302, DTC P0303 & DTC P0304
- DTC P0325: Knock Sensor Circuit Out Of Range
- DTC P0335 & DTC P0336
- DTC P0340: Camshaft Position Sensor Circuit Malfunction
- DTC P0420: Manifold Catalytic Converter Efficiency Below Threshold
- DTC P0441: Evaporative Emissions Control System Incorrect Purge Flow
- DTC P0442: Evaporative Emissions Control System - Small Leak
- DTC P0444 & DTC P0445
- DTC P0461, DTC P0462 & DTC P0463
- DTC P0501: Vehicle Speed Sensor Range
- DTC P0506 & DTC P0507
- DTC P0562 & DTC P0563
- DTC P0605: Internal Control Module ROM Error
- DTC P1307, DTC P1308 & DTC P1309
- DTC P1401, DTC P1402, DTC P1403 & DTC P0404
- DTC P1505 & DTC P1507
- DTC P1506 & DTC P1508
- DTC P1529 & DTC P1765
- DTC P1586: Encoding Signal Circuit Not Rational
- DTC P1693: Malfunction Indicator Light Request Line Check
- Engine Controls - System & Component Testing
- Introduction
- Computerized Engine Controls
- Engine Sensors & Switches
- Notes
- Sensors
- Acceleration/Rough Road Sensor
- Camshaft Position (CMP) Sensor
- Crankshaft Position (CKP) Sensor
- Engine Coolant Temperature (ECT) Sensor
- Fuel Tank Pressure (FTP) Sensor
- Heated Oxygen Sensor (HO2S)
- Intake Air Temperature (IAT) Sensor
- Knock Sensor (KS)
- Manifold Absolute Pressure (MAP) Sensor
- Mass Airflow (MAF) Sensor
- Manifold Absolute Pressure (MAP) Sensor (Sonata 2.4L)
- Throttle Position (TP) Sensor
- Vehicle Speed Sensor (VSS)
- Switches
- Relays
- Fuel System
- Idle Control System
- Ignition System
- Emission Systems & Sub-Systems
- Engine Controls - Trouble Shooting - No Codes
- Engine Controls - Basic Diagnostic Procedures
- Theory and Operation
- Engine Controls - Theory & Operation
- Introduction
- Air Induction System
- Computerized Engine Controls
- Notes
- Engine Control Module
- Input Devices
- Notes
- A/C Switch
- Acceleration Sensor (Accent)
- Camshaft Position Sensor
- Crankshaft Position Sensor
- Engine Coolant Temperature Sensor
- Fuel Tank Pressure Sensor
- Heated Oxygen Sensor
- Idle Position Switch (XG350)
- Intake Air Temperature Sensor
- Knock Sensor
- Mass Airflow Sensor
- Manifold Absolute Pressure Sensor (Accent 1.6L, Elantra, Santa Fe 2.4L, Sonata 2.4L & XG350)
- Power Steering Pressure Switch (Santa Fe 2.4L, Santa Fe 2.7L, Sonata 2.4L, Sonata 2.7L & XG350)
- Throttle Position Sensor
- Transaxle Range Switch (A/T)
- Vehicle Speed Sensor
- Output Signals
- Fuel System
- Ignition System
- Emission Systems
- Self-Diagnostic System
- Miscellaneous Controls
- Engine Controls - Theory & Operation
- Vacuum Diagrams
- Wiring Diagrams
- General Information
- Abbreviations
- Basic Trouble Shooting
- Basic Trouble Shooting - General Information
- Commonly Used Abbreviations - General Information
- Emission Control Abbreviations
- Engine Performance - Trouble Shooting - General Information
- Brakes
- Anti-Lock Brake Safety Precautions - General Information
- Map - Brake Systems
- Brake Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Accelerometers
- Accumulators
- Anchor Pins
- Anti-Lock Brake Control Assembly(Module)
- Anti-Lock Brake Controller
- Anti-Lock Brake Systems
- Axle Seal
- Backing Plates
- Bleeder Screw
- Brake Abs Active Light (Blue)
- Brake Fluid
- Brake Friction Material
- Brake On - Off Switch
- Brake Pads
- Brake Pedals
- Brake Shoe Hardware
- Brake Shoes
- Brake Stoplight Switches
- Brake Warning Light (Amber)
- Brake Warning Light (Red)
- Bulb Sockets
- Bulbs And LEDS
- Caliper Hardware
- Caliper Mounting Pin
- Caliper Piston
- Caliper Shim
- Caliper Slider Pin (Bolt) Dust Boot
- Caliper Slider Pin (Bolt)
- Calipers
- Combination Valve
- Controllers
- Digital Ratio Axle Controllers And Buffers (Drab And Dram)
- Disable Switches
- Drums
- Electrical Brake Pumps
- Electrical Park Motor
- Electrical Pumps And Motors
- Electro-Magnetic Interference
- Electronic Brake Control Modulator
- Electronic Brake Distribution
- Electronic Brake Traction Control Module
- Electronic Controllers
- Electronic Traction Control
- External Brake Cable
- Flow Control Valve
- Fluid Level Sensor Switches
- Fluid
- Four Wheel Drive Switches
- Friction Material
- G Sensors
- Gaskets
- Gravitational Switches
- Grease Seal
- Height Sensing Proportioning Valve
- High Pressure Accumulator
- Hoses
- Hub
- Hydraulic Control Unit
- Hydraulic Modulators
- Hydro-Boosters
- Hydro-Electric Boosters (POWERMASTER)
- Ignition Disable Switches
- Lamp Driver Relay
- Lateral Acceleration Switches
- LEDS
- Lenses
- Low Pressure Accumulator
- Lug Nut
- Master Cylinder Cover Gasket
- Master Cylinders
- Modulators
- Motor Pack
- Motors
- Pads
- Parking Brake Cable
- Parking Brake Mechanism
- Parking Brake Shoes
- Parking Brake Switches
- Parking Brake Systems
- Pedal Travel Switches
- Pedals
- Power Distribution Center
- POWERMASTER
- Pressure Differential Switches
- Pressure Switches
- Pressure Transducers
- Proportioning Valve
- Pumps
- Relays
- RELUCTOR (Speed) Ring
- Rotors
- Self-Adjusting Systems
- Shoe Hardware
- Shoes
- Sockets
- Speed Sensor (RELUCTOR) Ring
- Speed Sensors (Electronic Wheel And Vehicle)
- Star Wheel
- Steel Brake Lines
- Stoplight Switches
- Stroke Sensor
- Switches
- Tires
- Tone Ring
- Toothed Rings (Tone Wheel)
- Traction Control System (TCS)
- Transfer Tubes
- Vacuum Boosters
- Vacuum Hoses
- Valves
- Wear Indicator
- Wheel Attachment Hardware
- Wheel Bearings, Races And Seals
- Wheel Cylinders
- Wiring Harnesses
- Yaw Rate Sensor
- Brake System CHECKSHEET
- Reason Code Explanation
- Automotive Terminology & Definitions
- Brake Systems
- Map - Routine Inspection Reference Guide
- Routine Inspection Reference Guide
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Maintenance Overview
- Antifreeze/Coolant
- Visual Inspection
- Radiator Cap Test
- Engine Fan
- Cooling System Power Flush And Refill
- Belts (Except Timing Belts)
- Belt TENSIONER
- Automatic Transmission Fluid
- Automatic Transmission Fluid Exchange & Filter Replacement
- Engine Oil
- Air Filters
- Cabin Air Filter
- Brake Fluid
- Battery
- Battery Cables
- Power Steering
- Power Steering Fluid
- Wiper Blades
- Routine Inspection CHECKSHEET
- Routine Inspection - UICS
- Brake Systems
- Drivetrain And Transmission
- Notes
- Automatic Transmission Fluid
- Clutch Master Cylinders
- Cooler Lines
- Coolers
- Differential Fluid
- Drain Plugs And Gaskets
- Filters And Screens
- Fluids And Lubricants
- Hoses, Lines, And Tubes
- Hydraulic Fluid
- Lubricants
- Manual Transmission Fluid
- Mounts (Engine, Transaxle And Transmission)
- Transfer Case Fluid
- Vacuum Hoses
- Electrical Systems
- Engine Performance And Maintenance
- Notes
- Accessory Belts
- Air Filter Elements
- Air Filter Gaskets
- Air Filter Housings And Gaskets
- Air Pump Belts
- Batteries
- Battery Connectors
- Belt Idler Assemblies (Accessory And Cam Belts)
- Belt TENSIONERS (Accessory And Cam Belt)
- Chemical Engine DECARBONIZATION
- Combustion Chamber Cleaning
- Coolant Recovery Tanks
- Coolant
- Distributor Caps
- Distributor Rotors
- Engine Cooling Systems
- Engine DECARBONIZATION
- Engine Oil Drain Plugs And Gaskets
- Engine Oil Filters And Canisters
- Engine Oil
- Fuel Filters
- Fuel Injector Cleaning
- Fuel Injectors
- Fuel System Cleaning Service
- Hose Clamps
- Hose Connectors
- Hose Couplers
- Hoses And Tubes (Fuel Lines, Radiator, Vacuum, By-Pass, Heater, Recovery Tank And Oil Coolers)
- Ignition Wires (Secondary)
- Intake Cleaning
- O2 Sensors
- PCV Breather Elements
- PCV Valves
- Radiator Caps And Pressurized Expansion Tank Caps
- Spark Plugs
- Thermostats And Housings
- Throttle Body Cleaning
- Timing Belts
- Vacuum Hoses, Tubes And Connections (Non-Metallic)
- Exhaust Systems
- Heating, Ventilation And Air Conditioning Systems
- Steering And Suspension, Wheel Alignment, Wheels And Tires
- Wheel & Tire Supplement
- Reason Code Explanation
- Automotive Terminology & Definitions
- Routine Inspection Reference Guide
- Check Lists
- Computer Relearn Procedures - Import
- Introduction
- ACURA
- AUDI
- BMW
- HONDA
- HYUNDAI
- INFINITI
- ISUZU
- Jaguar
- KIA
- Land Rover
- LEXUS
- MAZDA
- MERCEDES-BENZ
- Notes
- Synchronization Of Power Windows
- Activating Steering Angle Sensor
- Synchronization Of Sliding/Tilt-Up Roof
- Easy Entry/Exit Function
- Control Module Version Coding
- Enabling Code Function For Radio
- Notes
- Audio 5 & 10 Models Or Sound 10, 20 & 30 Models (CLK, E & SLK Class)
- Becker 2000 (CL, S & SL Class)
- Becker Mexico, Grand Prix, Europa & Avus Models (SL Class)
- Radio With Navigation Control Module (CL, S & SL Class)
- Radio With 4-Digit Fixed Code (CL, S & SL Class)
- Radio & Radio With Navigation Control Module With 5-Digit Fixed Code (CL, S & SL Class)
- Radio (ML Class)
- Programming Supplemental Restraint System Control Module
- MITSUBISHI
- NISSAN
- PORSCHE
- SAAB
- SUBARU
- SUZUKI
- TOYOTA
- Service Precautions (PRIUS)
- Immobilizer Programming (Except PRIUS)
- Additional Master Key Registration (Except PRIUS)
- Additional Sub-Key Registration (Except PRIUS)
- Erasure Of Transponder Key Code (Except PRIUS)
- Immobilizer Component Replacement Programming Procedures (PRIUS)
- Notes
- Programming When Replacing Transponder Key Electronic Control Unit
- Programming When Replacing Hybrid Vehicle Control Electronic Control Unit
- Programming When Replacing Transponder Key Electronic Control Unit & Hybrid Vehicle Control Electronic Control Unit
- Programming If All Ignition Keys Are Lost
- Ignition Key Registration
- Additional Master Key Registration
- Additional Sub-Key Registration
- Erasure Of Transponder Key Code
- Power Sliding Door REINITIALIZATION Procedure (Sienna)
- Sun Roof Initialization (CAMRY & CELICA)
- VOLKSWAGEN
- VOLVO
- OBD-II Drive Cycles
- Driveline/Axles
- Drive Axle Noise Diagnosis - General Information
- Gear Tooth Contact Patterns - General Information
- Map - Drive Train & Transmission
- Drive Train & Transmission Systems
- Drivetrain And Transmission
- Notes
- Actuators (Electrical)
- Actuators (Vacuum)
- Automatic Transmission / Transaxle Assemblies/CVTS
- Automatic Transmission Fluid
- Axles
- Bearings And Races
- Bell Cranks
- Bell Housings
- Bushings (External)
- Cables (Speedometer)
- Cables (TV, Detent And Shift)
- Carrier Bearings
- Clutch Cables And Cable Housings
- Clutch Discs (Manual Transmissions)
- Clutch Forks
- Clutch Linkages (Mechanical)
- Clutch Master Cylinders
- Clutch Pedals
- Clutch Pivots
- Clutch Pressure Plates
- Clutch Release Bearings
- Clutch Slave Cylinders (Concentric)
- Clutch Slave Cylinders (Conventional Or External)
- Companion Flanges
- Connectors
- Cooler Bypass Valves
- Cooler Lines
- Coolers
- CV Joints
- Differential And Final Drive Assemblies
- Differential Fluid
- Dip Stick Tubes
- Dip Sticks (Fluid Level Indicators)
- Dowel Pins, Guides And Pilot Holes
- Drain Plugs And Gaskets
- Drive Shaft Flanges
- Drive Shafts And Half Shafts
- Dust Boots
- Engine Mounts
- Exciter Rings
- Filler Tubes
- Filters And Screens
- Flanges
- Flex Plates
- Fluid Level Indicators
- Fluids And Lubricants
- Flywheels
- Force Motors
- Gaskets
- Guides
- Half Shafts
- Hoses, Lines, And Tubes
- Housings (Bell, Case, Tail(Extension) And Auxiliary)
- Hydraulic Fluid
- Intermediate Shaft Support Bearings
- Key Interlock Systems
- Limited Slips
- Lines
- Linkages (External)
- Locking Hub Assemblies
- Locking Hub Control Knobs
- Lubricants
- Manual Transmission Fluid
- Manual Transmission/Transaxle Assemblies
- Metal Clad Seals
- METALASTIC Joints
- Modulator Pins
- Modulators
- Mounts (Engine, Transaxle And Transmission)
- Odometer Drives (Mechanical)
- Odometer Heads (Mechanical)
- Oil Pans
- Pans
- Pilot Holes
- Pressure Plates
- Pressure Switches
- Races
- Rubber Joints (METALASTIC)
- Screens
- Seals (Metal Clad)
- Seals
- Selector Interlock Systems
- Sensors
- Servos
- Shift Interlock Systems (Selector And Key Interlock Systems)
- Side Covers
- Slip Yokes
- Solenoids
- Speed Sensors (Electronic Wheel And Vehicle)
- Speedometer- Driven Gear Housing
- Speedometer/Odometer Drives (Mechanical)
- Speedometer/Odometer Heads (Mechanical)
- Speedometers/Odometers (Electronic)
- Switches
- Tone Wheels
- Toothed Rings (Tone Wheel)
- Torque Converters
- Transaxle Mounts
- Transducers (Transmission)
- Transfer Case Assemblies
- Transfer Case Fluid
- Transmission Coolers
- Transmission Mounts
- Transmission Pans
- Transmission Range Indicators (PRNDL)
- Tubes
- Universal Joints (CARDAN Or Cross Type)
- Vacuum Controls
- Vacuum Hoses
- Vacuum Motors
- Vacuum-Operated Switches
- Vehicle Speed Sensors
- Vents
- Vibration Dampers
- Wheel Attachment Hardware
- Wheel Speed Sensors
- Wiring Harnesses And Connectors
- Yokes And Slip Yokes
- Reason Code Explanation
- Automotive Terminology & Definitions
- Trouble Shooting - Clutches - General Information
- DTC Index
- Electrical
- Map - Electrical Systems
- Electrical Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Actuator Motors (Electric)
- Actuator Motors (Vacuum)
- Air Bags
- Alternators And Generators
- Amplifiers
- Antennas
- Batteries
- Battery Cables, Wires And Connectors
- Battery Cables
- Battery Trays And Hold Down Hardware
- Battery Wires
- Belts
- Bulb Sockets
- Bulbs, Sealed Beams And LEDS
- Cd Players
- Cigarette Lighter Assemblies
- Circuit Breakers
- Clutch Switches
- Connectors
- Control Modules
- Cruise Control Brake Switches
- Cruise Control Cables
- Cruise Control Clutch Switches
- Cruise Control Linkages And Cables
- Cruise Control Reservoirs
- Cruise Control Tubes
- Cruise Control Vacuum Dump Release Valves
- Cruise Control Vacuum Hoses, Tubes And
- Cruise Control Vehicle Speed Sensors
- Defoggers
- Defrosters
- Delays
- Dimmers
- Electric Heaters
- Equalizers
- Fuse Blocks
- Fuse Boxes And Blocks
- Fuses, Fusible Links And Circuit Breakers
- Fusible Links
- Gauges
- Generators
- Ground Cables And Straps
- Ground Straps
- Headlight Adjusters
- Heating Elements (Defrosters, Defoggers, Electric Heaters And Seats)
- Horns And Sirens
- Ignition Switches
- Indicator Lights
- Keyless Entry Keypads And Transmitters
- Keyless Entry Transmitters
- LEDS
- Lenses
- Microphones
- Mirrors (ELECTROCHROMATIC And Heated)
- Motors
- Neutral Safety Switches
- Odometers, Speedometers And Tachometers (Cable Driven)
- Odometers
- Power Distribution Center
- Pulleys
- Receivers, Amplifiers, Equalizers And Sub-Woofer Volume Controls
- Relay Boxes
- Relays
- Sealed Beams
- Seat Heaters
- Security Alarm Sensors
- Sirens
- Solenoids
- Speakers And Microphones
- Speedometer And Tachometer Linkages And Cables
- Speedometer Cables
- Speedometers
- Starters
- Sub-Woofer Volume Control
- Switches
- Tachometer Cables
- Tachometers
- Tape Players And Cd Players
- TENSIONERS
- Timers
- Transceivers
- Transducers
- Vacuum Accumulators (Reservoirs)
- Voltage Regulators
- Washer Fluid Level Senders
- Washer Pumps
- Wiper Arms And Blades
- Wiper Blades
- Wiper Hoses And Nozzles
- Wiper Linkages
- Wiper Nozzles
- Wiper Pump Reservoirs
- Wiring Harnesses And Connectors
- Battery, Starting & Charging System CHECKSHEET
- Reason Code Explanation
- Automotive Terminology & Definitions
- Electrical Systems
- Using lemon2025'S System Wiring Diagrams
- Map - Electrical Systems
- Engine
- Engine Overhaul Procedures - General Information
- * Please Read This First *
- Description
- Engine Identification
- Inspection Procedures
- Cleaning Procedures
- Component Cleaning
- Cylinder Head Replacement
- Cylinder Head Overhaul
- Pistons, Connecting Rods & Bearings
- Crankshaft & Main Bearings
- Camshaft
- Timing Chains & Belts
- Timing Gears
- Oil Pump
- Break-In Procedure
- General Cooling System Service - General Information
- Engine Overhaul Procedures - General Information
- Engine Performance
- Electrostatic Discharge Warning - General Information
- Engine Performance Diagnostic Routine Outline - General Information
- Engine Performance Safety Precautions
- Map - Engine Performance & Maintenance
- Engine Performance And Maintenance (Including Exhaust Systems)
- Engine Performance & Maintenance CHECKSHEET
- Engine Performance And Maintenance
- Notes
- Accelerator Pedal Position Sensor
- Accessory Belts
- Accessory Pulleys
- Air Conditioning Cycling Switches
- Air Conditioning Pressure Sensors
- Air Ducts And Tubes
- Air Filter Elements
- Air Filter Gaskets
- Air Filter Housings And Gaskets
- Air Fuel Ratio Sensors
- Air Injection Control Solenoids
- Air Plenums
- Air Pump Belts
- Air Pumps (Electric Driven)
- Air Tubes
- Aspirator, Check And DECEL Valves
- Baffles
- Ballast Primary Supply Resistor Wires
- Ballast Resistors And Primary Supply Resistors
- Barometric Pressure Sensors
- Batteries
- Battery Cables, Wires And Connectors
- Battery Connectors
- Battery Trays And Hold Down Hardware
- Battery Wires
- Belt Idler Assemblies (Accessory And Cam Belts)
- Belt TENSIONERS (Accessory And Cam Belt)
- Belt-Driven Air Pumps
- Boost Control Mechanism
- Camshaft Position Sensors
- Carburetors And Chokes
- Casting Core Plugs And Expansion Plugs
- Charge Air Coolers ""INTERCOOLERS"" (CAC)
- Check Valves
- Chemical Engine DECARBONIZATION
- Chokes
- Clutch Pedal Position Switches
- Cold Start Injectors
- Combustion Chamber Cleaning
- Connectors
- Coolant Recovery Tanks
- Coolant
- Cooling Fan Motor Modules
- Cooling Fan Motor Relays And Modules
- Cooling Fan Motor Resistors
- Cooling Fan Motor Sensors And Switches
- Cooling Fan Motor Switches
- Cooling Fan Motors
- Crankshaft Position Sensors
- Cylinder Deactivation Solenoid
- Cylinder Head Assemblies
- DECEL Valves
- Deflectors
- Dip Stick Tubes
- Dip Sticks And Tubes
- Distributor Advances And Retarders (Mechanical And Vacuum)
- Distributor Boots And Shields
- Distributor Caps
- Distributor Retarders (Mechanical And Vacuum)
- Distributor Rotors
- Distributor Shields
- Distributors
- Early Fuel Evaporation Valves (Heat Riser Assemblies)
- EGR Coolers
- EGR Exhaust Manifold Passages
- EGR Intake And Exhaust Manifold Passages
- EGR Plates And Coolers
- Electronic Spark Control Modules
- Electronic Transmission Control Devices
- Electronic Transmission Feedback Devices
- Engine Coolant Temperature Sensors
- Engine Cooling Systems
- Engine Covers (Oil Pan, Valve Cover, Timing Cover)
- Engine DECARBONIZATION
- Engine Oil Canisters
- Engine Oil Coolers (External)
- Engine Oil Drain Plugs And Gaskets
- Engine Oil Filters And Canisters
- Engine Oil Gaskets
- Engine Oil Pressure Gauges (Mechanical)
- Engine Oil
- Evaporative Emissions (EVAP) Canister Filters
- Evaporative Emissions (EVAP) Canister Purge Devices
- Evaporative Emissions (EVAP) Canisters
- Evaporative Emissions (EVAP) Feedback Devices
- Exhaust Gas RECIRCULATION Devices
- Exhaust Gas RECIRCULATION Feedback Devices
- Expansion Plugs
- Fan Control Sensor
- Fuel Accumulators And Dampers
- Fuel And Cold Start Injectors
- Fuel Caps
- Fuel Dampers
- Fuel Delivery Check Valves
- Fuel Distributors (BOSCH Cis)
- Fuel Filler Necks And RESTRICTORS
- Fuel Filters
- Fuel Injector Cleaning
- Fuel Injectors
- Fuel Level Senders
- Fuel Pressure Regulators
- Fuel Pumps (In-Tank, External, Electrical Or Mechanical)
- Fuel Rails
- Fuel RESTRICTORS
- Fuel System Cleaning Service
- Fuel Tanks
- Fuel
- Gaskets
- Grommets (Valve Cover)
- Harmonic Dampers
- Heater Control Valves
- Heater Cores
- Hose Clamps
- Hose Connectors
- Hose Couplers
- Hoses And Tube Couplers, Connectors And Clamps
- Hoses And Tubes (Fuel Lines, Radiator, Vacuum, By-Pass, Heater, Recovery Tank And Oil Coolers)
- Housings
- Idle Air Controls
- Idle Speed Control Actuators
- Ignition Boots
- Ignition Coil Towers
- Ignition Coils
- Ignition Control Modules (ICM)
- Ignition Switches
- Ignition Terminals
- Ignition Wires (Secondary)
- Inertia Fuel Shut-Off Switches
- Intake Air Temperature Sensors
- Intake Cleaning
- Intake Manifolds
- In-Tank Fuel Strainers
- INTERCOOLERS
- Knock Sensors
- Liquid Vapor Separators
- Long Block Assemblies
- Manifold Absolute Pressure (Map) Sensors
- Mass Air Flow (MAF) Sensors
- Metal Air Manifolds And Pipes
- Metal Air Pipes
- Mix Control Solenoids
- Motor Mounts
- O2 Sensors
- Oil Pans
- Oil Pressure Sending Units
- Oil Pump Pick-Up Screens
- Oil Pumps
- O-Rings, Gaskets, Seals And Spring Locks
- Park Neutral Position Switches
- PCV Breather Elements
- PCV Orifices
- PCV Valves
- Pick-Up Assemblies (Includes Magnetic, Hall Effect And Optical)
- Power Steering Pressure Sensors
- Powertrain Control Modules (Pcm) And Prom
- Powertrain Control Prom
- Pressurized Expansion Tank Caps
- Radiator / Cooling Fan Blades
- Radiator / Cooling Fan Clutches
- Radiator Caps And Pressurized Expansion Tank Caps
- Radiators
- Roll Over Valves
- Sealing Compounds
- Seals
- Secondary Air Injection System Management Devices
- Sensors
- Short Block Assemblies
- Shrouds, Baffles And Deflectors
- Spark Plugs
- Spring Locks
- Super Chargers
- Switches
- Thermal Vacuum Valves
- Thermostatic Air Door Assemblies
- Thermostats And Housings
- Throttle Bodies
- Throttle Body Cleaning
- Throttle Cables
- Throttle Linkages And Cables
- Throttle Position Sensors
- Throttle Position Switches
- Timing Belt Sprockets
- Timing Belts
- Timing Covers
- Torque Struts
- Transmission Range Switches
- Tube Clamps
- Tube Connectors
- Tube Couplers
- Tubes
- Turbo Chargers
- Vacuum Connections
- Vacuum Hoses, Tubes And Connections (Non-Metallic)
- Vacuum Regulator Solenoids
- Vacuum Tubes
- Valve Covers
- Vehicle Speed Senors
- Volume Air Flow Sensors
- Waste Gate And Boost Control Mechanisms
- Waste Gate Control Solenoids
- Water Pumps (Electric)
- Water Pumps (Non-Electric)
- Wiring Harnesses And Connectors
- Reason Code Explanation
- Automotive Terminology & Definitions
- Parasitic Load Explanation & Test Procedures - General Information
- State Emission Standards - Diesel
- State Emission Standards - Gas
- ALASKA
- ARIZONA
- CALIFORNIA
- Colorado
- CONNECTICUT
- DELAWARE
- District Of COLUMBIA
- GEORGIA
- IDAHO
- ILLINOIS
- INDIANA
- KENTUCKY
- MARYLAND
- MASSACHUSETTS
- MISSOURI
- NEVADA
- New Jersey
- New MEXICO
- New YORK
- North CAROLINA
- OHIO
- OREGON
- PENNSYLVANIA
- RHODE Island
- TENNESSEE
- TEXAS
- UTAH
- VIRGINIA
- WASHINGTON
- WISCONSIN
- U. S. EPA ASM2525 & ASM5015 Start-Up Emission Standards
- U. S. EPA Revised Final ASM Emission Standards (ASM5015 & ASM2525)
- U.S. EPA Im240 Emission Standards
- Waveforms - Injector Pattern Tutorial - General Information
- * Please Read This First *
- Purpose Of This Article
- Is A Lab Scope Necessary?
- The Two Types Of Injector Drivers
- The Two Ways Injector Circuits Are Wired
- Interpreting Injector Waveforms
- Current Waveform Samples
- Notes
- Example #1 - Voltage Controlled Driver
- Example #2 - Voltage Controlled Driver
- Example #3 - Voltage Controlled Driver
- Example #4 - Current Controlled Driver
- Example #5 - Current Controlled Driver
- Example #6 - Current Controlled Driver
- Example #7 - Current Controlled Driver
- Example #8 - Current Controlled Driver
- Voltage Waveform Samples
- Notes
- Example #1 - Voltage Controlled Driver
- Example #2 - Voltage Controlled Driver
- Example #3 - Voltage Controlled Driver
- Example #4 - Current Controlled Driver
- Example #5 - Current Controlled Driver
- Example #6 - Current Controlled Driver
- Example #7 - Current Controlled Driver
- Example #8 - Current Controlled Driver
- Map - Exhaust Systems
- Exhaust Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Catalytic Converters
- Exhaust And Tail Pipes
- Exhaust Connections
- Hangers
- Heat Risers (Mechanical EFE Devices)
- Heat Shields
- Manifolds (Cast And Tube Type)
- Mechanical EFE Devices
- Muffler Valve
- Mufflers And Resonators
- Reason Code Explanation
- Exhaust Systems
- Heating, Ventilation & A/C (HVAC)
- Map - Heating, Ventilation, & Air Conditioning
- Heating, Ventilation & Air Conditioning Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Accumulators
- Actuators (Electrical)
- Actuators (Vacuum)
- Air Conditioning Fittings
- Air Conditioning Hoses
- Air Conditioning Metal Lines
- Air Control Doors
- Air Dams (External)
- Air Distribution System
- Belts
- Blend Doors
- Blower Fans (Blower Wheel Or Squirrel Cage)
- Blower Motors
- Blower Resistors
- Blower Switches
- Cabin Air Filters
- Circuit Breakers
- Compressor Clutch Assemblies
- Compressors
- Condenser Air Seals
- Condenser Fan Motors
- Condensers
- Connectors
- Control Cables
- Control Heads (Function Selectors)
- Control Linkages
- Control Modules
- Coolant
- Cooling Fan Blades
- Cooling Fan Clutches
- Cooling Fan Motors
- Evaporator Drain Tubes
- Evaporator Filters
- Evaporator Pressure Regulators (EPRS)
- Evaporators
- Expansion Valves
- Function Selectors
- Fuses, Fusible Links And Circuit Breakers
- Fusible Links
- Gaskets
- Heater Cases
- Heater Control Valves
- Heater Cores
- Heater Hoses
- High Pressure Relief Valves (HPRV)
- Idlers
- In-Line Filters
- Metal Fittings
- Metal Lines
- Mix And Air Control Doors (Blend Doors)
- ORIFACE Tubes
- O-Rings
- Pilot-Operated Absolutes (POAS)
- Plenums
- Pressure Control Valves
- Pressure Sensors
- Pulleys
- Radiators
- Receiver-DRIERS
- Refrigerant Oil
- Refrigerant
- Relays
- Seals
- Service Ports
- Spring Lock Couplings
- Suction Throttling Valves (STVS)
- Switches (Electrical)
- TENSIONERS
- Thermistors And Pressure Sensors
- Thermostats And Housings
- Vacuum Hoses And Tubes
- Vacuum Reservoirs
- Vacuum Tubes
- Valves In Receiver (VIRS)
- Water Pumps (Electric Auxiliary)
- Wiring Harnesses And Connectors
- Heating, Ventilation & Air Conditioning System CHECKSHEET
- Reason Code Explanation
- Automotive Terminology & Definitions
- Heating, Ventilation & Air Conditioning Systems
- Map - Heating, Ventilation, & Air Conditioning
- Identification
- Metric Conversions
- OEM General Information
- How To Use The Engine Performance Section
- Restraints
- Specifications Index
- Steering
- Map - Steering, Suspension, Wheel Alignment, Wheels & Tires
- Steering & Suspension Systems
- Wheel And Tire
- Steering & Suspension CHECKSHEET
- Wheels & Tires CHECKSHEET
- Steering And Suspension, Wheel Alignment, Wheels And Tires
- Notes
- Active Handling
- Active Suspension Control Modules
- Active Variable Ratio Steering
- Active Yaw Control
- Adaptive Cruise Control
- Advance TRAC
- Air Bags
- Air Ride Control Modules
- Air Ride Suspension Torsion Springs (Counter Balancing)
- Air Ride Suspension
- Air Ride Tubes
- Air Shocks And Air Struts
- Air Spring Valves
- Air Springs
- Air Suspension Control Valves
- Air Suspension DRIERS
- Axle Acceleration Sensor
- Ball Joints
- Body Acceleration Sensor
- Bushings
- Center Links
- Compressors
- Continuous Damping Control
- Control Arm Shafts
- Control Arms
- Control Modules
- Distance Regulation Control Module
- Distance Regulation Sensor
- Drag Links
- Dynamic Stability Control
- Dynamic Stability Traction Control
- Electronic Ride Control Shocks And Struts
- Electronic Stability Control
- Electronic Suspension System
- Flex Couplers
- Gaskets
- Height Sensors
- Hydraulic Hoses
- Hydraulic Power Steering Pumps
- Hydraulic Suspension Hoses
- Hydraulic Suspension Pumps
- Idler Arms
- Intermediate Shaft U-Joints
- King Pins
- Modules
- Pitman Arms
- Power Steering Belts
- Power Steering Coolers
- Power Steering Fluid
- Power Steering Hoses
- Power Steering Lines (Steel)
- Power Steering Pumps - Electric
- Power Steering Pumps
- Radar Sensor
- Radius Arms
- Relay Rods
- Relays
- Sensors
- Shock Absorbers, Strut Cartridges And Strut Assemblies
- Spindles
- Springs, Coil, Leaf And Torsion Bars
- STABILITRAC
- Stability Management System
- Steering Angle Sensor
- Steering Arms
- Steering Couplers
- Steering Dampers
- Steering Gears (Except Rack And Pinion)
- Steering Gears, Rack And Pinion
- Steering Knuckles
- Strike Out Bumpers
- Strut Bearing Plate Assemblies
- Strut Rods
- Suspension Pumps (Hydraulic)
- Sway Bar Links
- Sway Bar Mounting Bushings
- Sway Bars
- Switches
- Tie Rod Ends (Inner And Outer)
- Tire Pressure Monitoring System
- Tire Pressure Sensors
- Tires
- Torque Sensor
- Torsion Springs
- Track Bar Bushings
- Track Bars
- Trailing Arm Bushings
- Trailing Arms
- Valve Stems
- Vehicle Dynamics Control
- Vehicle Speed Sensor
- Vehicle Stability Assist
- Vehicle Stability/Skid Control
- Warning Lamps
- Wheel Alignment
- Wheel Attachment Hardware
- Wheel Bearings, Races And Seals
- Wheels (Rims)
- Wiring Harnesses And Connectors
- Reason Code Explanation
- Automotive Terminology & Definitions
- Wheel Alignment Theory & Operation - General Information
- Map - Steering, Suspension, Wheel Alignment, Wheels & Tires
- Traction Control Disable Procedures
- Trouble Shooting - Manual Transmission - General Information
- Heating, Ventilation & A/C (HVAC)
- A/C Compressor
- Heating, Ventilation & Air Conditioning
- General
- Air Conditioning System
- Instructions
- On-Vehicle Inspection
- Installation Of Manifold Gauge Set
- Evacuating Refrigerant System
- Charging Refrigerant System
- Refrigerant Level Check
- Performance Test
- Electronic Leak Detector
- Discharging The Refrigeration System
- How Is The Magnetic Clutch Is Energized
- Refrigeration Cycle
- Components
- Performance Test Diagnosis
- Oil Level Check
- Adding Oil For Replacement Component Parts
- Inspection
- Manual A/C Compressor Controls
- Heater
- Blower Controls
- Blower And A/C Controls (Manual)
- Heating, Ventilation & Air Conditioning
- General Servicing
- Cabin Air Filter
- Heating, Ventilation & Air Conditioning
- General
- Air Conditioning System
- Instructions
- On-Vehicle Inspection
- Installation Of Manifold Gauge Set
- Evacuating Refrigerant System
- Charging Refrigerant System
- Refrigerant Level Check
- Performance Test
- Electronic Leak Detector
- Discharging The Refrigeration System
- How Is The Magnetic Clutch Is Energized
- Refrigeration Cycle
- Components
- Performance Test Diagnosis
- Oil Level Check
- Adding Oil For Replacement Component Parts
- Inspection
- Manual A/C Compressor Controls
- Heater
- Blower Controls
- Blower And A/C Controls (Manual)
- HVAC Control Systems
- Heating, Ventilation & Air Conditioning
- General
- Air Conditioning System
- Instructions
- On-Vehicle Inspection
- Installation Of Manifold Gauge Set
- Evacuating Refrigerant System
- Charging Refrigerant System
- Refrigerant Level Check
- Performance Test
- Electronic Leak Detector
- Discharging The Refrigeration System
- How Is The Magnetic Clutch Is Energized
- Refrigeration Cycle
- Components
- Performance Test Diagnosis
- Oil Level Check
- Adding Oil For Replacement Component Parts
- Inspection
- Manual A/C Compressor Controls
- Heater
- Blower Controls
- Blower And A/C Controls (Manual)
- Heating, Ventilation & Air Conditioning
- A/C Compressor
- Restraints
- Air Bag, SRS
- Air Bag Restraint Systems
- Description & Operation
- Component Locations
- System Operation Check
- Air Bag Safety Precautions
- Disabling & Activating Air Bag System
- Disposal Procedures
- Post-Collision Inspection
- Removal & Installation
- Diagnostics
- Diagnostic Tests
- DTC B1111, B1112: Battery Voltage High Or Low
- DTC B1346, B1347: Driver-Side Air Bag Resistance High/Low
- DTC B1348, B1354, B1363, B1369, B1380, B1384, B1401, B1404: Component Shorted To Ground
- Notes
- Check Driver-side AIR Bag Squib Circuit
- Check Passenger-side AIR Bag Squib Circuit
- Check Driver-side Seat Belt Pretensioner Squib Circuit
- Check Passenger-side Seat Belt Pretensioner Squib Circuit
- Check Driver Side Impact AIR Bag Squib Circuit
- Check Passenger Side Impact AIR Bag Squib Circuit
- Check Driver-side Satellite Sensor Circuit
- Check Passenger-side Satellite Sensor Circuit
- Check SRSCM
- DTC B1349, B1355, B1364, B1370, B1381, B1385, B1402, B1405: Component Shorted To Battery
- Notes
- Check Driver-side AIR Bag Squib Circuit
- Check Passenger-side AIR Bag Squib Circuit
- Check Driver-side Seat Belt Pretensioner Squib Circuit
- Check Passenger-side Seat Belt Pretensioner Squib Circuit
- Check Driver Side Impact AIR Bag Squib Circuit
- Check Passenger Side Impact AIR Bag Squib Circuit
- Check Driver-side Satellite Sensor Circuit
- Check Passenger-side Satellite Sensor Circuit
- Check SRSCM
- DTC B1352, B1353: Passenger-Side Air Bag Resistance High Or Low
- DTC B1361, B1362, B1367, B1368 Driver Or Passenger Seat Belt PRETENSIONER Resistance High Or Low
- DTC B1378, B1379, B1382, B1383: Driver Or Passenger Side Impact Air Bag Resistance High Or Low
- DTC B1400, B1403, B1408, B1409: Satellite Sensor Defect/Communication Error
- DTC B1620, B1650, B1651, B1652, B1661: SRSCM Internal Codes
- DTC B2500: Air Bag Warning Light
- Diagnostic Tests (Without Side Impact Air Bags)
- DTC B1111, B1112: Battery Voltage High Or Low
- DTC B1346, B1347: Driver-Side Air Bag Resistance High/Low
- DTC B1348, B1354, B1363, B1369: Component Shorted To Ground
- DTC B1349, B1355, B1364, B1370: Component Shorted To Battery
- DTC B1352, B1353: Passenger-Side Air Bag Resistance High Or Low
- DTC B1361, B1362, B1367, B1368: Driver Or Passenger Seat Belt PRETENSIONER Resistance High Or Low
- DTC B1620, B1650, B1651, B1652, B1661: SRSCM Internal Codes
- DTC B2500: Air Bag Warning Light
- Torque Specifications
- Wiring Diagrams
- Air Bag Restraint Systems
- Air Bag, SRS
- Steering
- Manual Steering
- Manual Rack & Pinion Steering System
- Power Rack & Pinion Steering System
- Power Steering
- Manual Rack & Pinion Steering System
- Power Rack & Pinion Steering System
- Steering Columns
- Manual Steering
- Suspension
- Front Suspension System
- Description
- Adjustments & Inspection
- Removal & Installation
- Lower Ball Joint
- Upper Ball Joint
- Lower Control Arm Bushings
- Lower Control Arm
- Stabilizer Bar
- Steering Knuckle
- Strut Assembly
- Removal (Accent, Elantra & Santa Fe)
- Disassembly (Accent, Elantra & Santa Fe)
- Inspection (Accent, Elantra & Santa Fe)
- Reassembly (Accent, Elantra & Santa Fe)
- Installation (Accent, Elantra & Santa Fe)
- Removal (Sonata & XG350)
- Disassembly (Sonata & XG350)
- Inspection (Sonata & XG350)
- Reassembly (Sonata & XG350)
- Installation (Sonata & XG350)
- Upper Control Arm
- Upper Control Arm Bushings
- Wheel Bearings
- Torque Specifications
- Special Tools
- Rear Suspension System
- Description
- Adjustments & Inspection
- Removal & Installation
- Shock Absorber
- Stabilizer Bar
- Strut Assembly
- Rear Suspension Arm
- Rear Suspension Arm Bushings
- Rear Suspension Assembly
- Trailing Arm
- Trailing Arm Bushing
- Upper Arm (Sonata & XG350)
- Wheel Bearing
- Removal (Accent & Elantra)
- Inspection (Accent & Elantra)
- Installation (Accent & Elantra)
- Removal (Santa Fe 2WD)
- Inspection (Santa Fe 2WD)
- Installation (Santa Fe 2WD)
- Removal (Santa Fe 4WD)
- Inspection (Santa Fe 4WD)
- Installation (Santa Fe 4WD)
- Removal (Sonata & XG350)
- Disassembly & Inspection (Sonata & XG350)
- Assembly & Installation (Sonata & XG350)
- Special Tools
- Torque Specifications
- Wheel Alignment Specifications & Adjustment Procedures
- Front Suspension System
- Transmission
- Clutch
- Manual Trans
- External Pages