Specifications with CONSULT-II
CAUTION:
Items displayed are data calculated by control unit and may indicate normal operation even if output circuit (harness) is open or shorted.
CONTROL UNIT INSPECTION REFERENCE
| Monitor item | Display content | Data monitor |
NOTE:
Error inspection checklist
|
|
|---|---|---|---|---|
| Condition | Reference value in normal operation | |||
| N-POSI SIG | Conditions of N, R and P position signals | N position | ON | "PARK/NEUTRAL POSITION SWITCH " |
| Any position other than N | OFF | |||
| R-POSI SIG | When R position | ON | ||
| Not R position | OFF | |||
| P-POSI SIG | When P position | ON | ||
| Not P position | OFF | |||
| GEAR POSITION | A/T gear position | 1st gear | 1 | - |
| 2nd gear | 2 | |||
| 3rd gear | 3 | |||
| 4th gear | 4 | |||
| 5th gear | 5 | |||
| VHCL SPEED FR VHCL SPEED FL VHCL SPEED RR VHCL SPEED RL |
Wheel speed | Vehicle stopped | 0 [km/h] | "WHEEL SENSOR " |
| Vehicle running (Note 1) | Almost in accordance with speedometer display (within +/-10 %) | |||
| THRTL OPENING | Throttle actuator opening/closing is displayed (linked with accelerator pedal). | Accelerator pedal not depressed (ignition switch is ON) | 0% | "ENGINE SYSTEM CONTROL SIGNAL " |
| Depress accelerator pedal (ignition switch is ON) | 0 to 100% | |||
| ENGINE RPM | With engine running | With engine stopped | 0 rpm | |
| Engine running | Almost in accordance with tachometer display | |||
| STEERING ANGLE SIG | Steering angle detected by steering angle sensor | Straight-ahead | Approx. 0° | "STEERING ANGLE SENSOR " |
| Steering wheel turned | -720 to 720° | |||
| YAW RATE SEN | Yaw rate detected by yaw rate sensor | Vehicle stopped | Approx. 0 d/s | "YAW RATE/SIDE G SENSOR " |
| Vehicle running | -70 to 70 d/s | |||
| SIDE G-SEN | Transverse G detected by side G sensor | Vehicle stopped | Approx. 0 m/s2 | |
| Vehicle running | -24.3 to 24.1 m/s2 | |||
| PRESS SENSOR | Brake fluid pressure detected by pressure sensor | With ignition switch turned ON and brake pedal released | Approx. 0 bar | "PRESSURE SENSOR " |
| With ignition switch turned ON and brake pedal depressed | -40 to 300 bar | |||
| ABS CONT VOLT | Battery voltage supplied to VDC/TCS/ABS control unit | Ignition switch ON | 10 to 16 V | "VDC/TCS/ABS CONTROL UNIT POWER SUPPLY AND GROUND CIRCUIT " |
| STOP LAMP SW | Brake pedal operation | Brake pedal depressed | ON | "STOP LAMP SWITCH " |
| Brake pedal depressed | OFF | |||
| PARK BRAKE SW | Parking brake status | Parking brake depressed | ON | "PARKING BRAKE SWITCH " |
| Parking brake not depressed | OFF | |||
| OFF SW | OFF switch ON/OFF status | VDC OFF switch on (When VDC OFF indicator lamp is on) | ON | "VDC OFF SWITCH " |
| VDC OFF switch off (When VDC OFF indicator lamp is OFF) | OFF | |||
| ABS WARN LAMP | ABS warning lamp ON condition (Note 2) | ABS warning lamp on | ON | "ABS WARNING LAMP, VDC OFF INDICATOR LAMP, AND SLIP INDICATOR LAMP " |
| ABS warning lamp off | OFF | |||
| VDC OFF LAMP | VDC OFF indicator lamp status (Note 2) | When VDC OFF indicator lamp is on | ON | |
| When VDC OFF indicator lamp is off | OFF | |||
| SLIP LAMP | SLIP indicator lamp status (Note 2) | When SLIP indicator lamp is ON. | ON | "ABS WARNING LAMP, VDC OFF INDICATOR LAMP, AND SLIP INDICATOR LAMP " |
| When SLIP indicator lamp is OFF. | OFF | |||
| EV SIGNAL-FL EV SIGNAL-RR EV SIGNAL-FR EV SIGNAL-RL AV SIGNAL-FL AV SIGNAL-RR AV SIGNAL-FR AV SIGNAL-RL |
Solenoid valve operation | Actuator (solenoid) is active ("ACTIVE TEST" with CONSULT-II). | ON | "SOLENOID AND VDC SWITCHING VALVE " |
| When actuator (solenoid) is not active. | OFF | |||
| USV SIGNAL-P USV SIGNAL-S MAV SIGNAL-P MAV SIGNAL-S |
VDC switch-over valve status | When actuator (switch-over valve) is active ("ACTIVE TEST" with CONSULT-II). | ON | |
| When actuator (switch-over valve) is not active. | OFF | |||
| M/R OUTPUT | Actuator motor and motor relay status (ON/OFF) | When actuator motor and motor relay are active ("ACTIVE TEST" with CONSULT-II). | ON | "ACTUATOR MOTOR AND MOTOR RELAY " |
| When actuator motor and motor relay are inactive. | OFF | |||
| FLUID LEV SW | Brake fluid level switch status | When brake fluid level switch ON. | ON | "BRAKE FLUID LEVEL SWITCH " |
| When brake fluid level switch OFF. | OFF | |||
| Note 1: Confirm tire pressure is normal. Note 2: ON/OFF timing of warning lamp and indicator lamp. Refer to "ABS WARNING LAMP, VDC OFF INDICATOR LAMP, AND SLIP INDICATOR LAMP ". |
||||