Technical Service Bulletins
- A/C Compressor
- New Sae J2788 Refrigerant Recovery Standard (IB07-12-S004)
- Contaminated R134A Refrigerant Found On Market For Automotive Air-Conditioning Systems (IB06-12-S001)
- Replacement Of The Receiver Drier During Air Conditioning Repair And Service (IB00-12-S002)
- R-12 To R-134A A/C System Conversion/Retrofit Procedures (Supersedes Sb00-12-S002) (SB00-12-S004)
- A/C FREON Blends Warning (SB92-12-003)
- A/C FREON Recovery Caution (SB91-12-002)
- A/C Diagnosis Chart (SB91-12-001)
- A/C Poor Cooling - Test/Reroute Thermostat Tube (SB87-12-004)
- Accessories Control Systems
- Aerodynamic Devices
- Air Bag, SRS
- Anti-Theft Systems
- Misfire DTCs P0300, P1380, P1381 and Catalytic Converter Damage Due to Installation of Alarm Systems (02-06-05-004B)
- Misfire DTC'S And Catalytic Converter Damage Due To Installation Of Alarm Systems (IB04-03-S001)
- CURTIS Key Code Cutter And Application Listing (SB03-14-S001)
- Rear Seat HOLDDOWN Hook Warm - Cover (SB89-11-007)
- Tailgate Hinge Binding - Cleaned & Lubed/Replaced (SB87-11-002)
- Automatic Trans
- LOCTITE/PERMATEX Cross-Reference Chart (SB99-14-S001)
- Propylene Glycol Based Engine Coolant (SB96-14-L002)
- Propylene Glycol-Based Engine Coolant Warning (SB94-14-005)
- DEXRON-IIE A/T And Power Steering Fluid (SB93-14-003)
- A/C FREON Blends Warning (SB92-12-003)
- Speedo Bounce/Noise - Modify Speedo Cable Length (SB89-04-005)
- Speedo Cable Noise - Replace Cable (SB87-04-008)
- Auxiliary Emission Control Systems
- Specified Major Emission-Control Components Defect Warranty Coverage Enhancement (WB07-L004)
- Reprogramming Of Powertrain Control Modules (Pcm) (IB03-14-S002)
- Air Regulator Specifications/Testing (SB90-03-003)
- 2.3L Eng Excessive Smoke - Check Valve INSPT/REPL (SB90-03-002)
- 1.8/1.9/2.2/2.3L Eng Stalls Cold - Cut Vacuum Hose (SB88-02-003)
- 2.3L Eng Stalling At Idle - Kinked Vacuum Hose (SB88-02-003)
- 2.3L Eng Stalls At Idle - Kinked Vacuum Hose (SB88-02-003)
- 2.3L Eng Erroneous Code 21 - MISROUTED Vacuum Hose (SB88-03-001)
- 1.9/2.3L Eng Alternator Wire Damage - Modify Clip (SB87-04-003)
- 1.8/2.2/2.3L Eng New Service Fuel Return Line (SB87-03-002)
- Axle Shafts
- MUA5C Trans Droning Noise - Driveline Angle (SB90-05-005)
- Auto Lock Hub Ratcheting Noise - Revised Front Hub (SB88-06-002)
- Ratcheting Front Hub Noise - New Front Hub Assembly (SB88-06-002)
- Front Hub Reassembly - Workshop Manual Correction (SB88-07-001)
- Conversion From Auto To Manual Locking Hub Info (SB85-06-002)
- Blowers, Superchargers & Turbochargers
- Charging Systems
- Clutch
- Cooling System (Mechanical)
- Engine Crankshaft Front Oil Seal Retainer Leakage (SB96-01-L006)
- Propylene Glycol Based Engine Coolant (SB96-14-L002)
- Propylene Glycol-Based Engine Coolant Warning (SB94-14-005)
- Oil Leak - Rear Oil Seal Diagnosis/Repair (SB92-01-002)
- 2.3/2.6L Eng Water Pump Repair Kits (SB89-01-009)
- Recommended Sealants (SB89-14-002)
- Camshaft Front Oil Seal Leak - Inspect Seal Seating (SB86-01-004)
- 1.9/2.2/2.3L Eng Camshaft Oil Seal Leak (SB86-01-004)
- Gasoline/Alcohol Fuel Blend Caution/Guidelines (SB84-02-002)
- Cruise Control Systems
- Inspection Of All Related Wiring Harness Connections When Diagnosing Miscellaneous DTC'S, Intermittent DRIVEABILITY Concerns, Hard Start, No Start, Incorrect Gauges, Inoperative Air Conditioning Systems, Service Engine Soon Lamps Illuminated, 4WD Lamp Illuminated, Instrument Panel Gauges Inoperative, Cruise Inoperative (IB05-04-S005)
- Revised Cruise Control Troubleshooting (SB88-04-001)
- Differentials & Drive Axles
- Driveshaft & Universal Joints
- Engine Control Systems
- Specified Major Emission-Control Components Defect Warranty Coverage Enhancement (WB07-L004)
- Misfire DTCs P0300, P1380, P1381 and Catalytic Converter Damage Due to Installation of Alarm Systems (02-06-05-004B)
- Reprogramming Of Powertrain Control Modules (Pcm) (IB03-14-S002)
- Pcm Reprogramming (IB00-S002)
- Air Regulator Specifications/Testing (SB90-03-003)
- 1.9/2.3L Eng Alternator Wire Damage - Modify Clip (SB87-04-003)
- Entertainment Systems
- Exhaust
- Misfire DTC'S And Catalytic Converter Damage Due To Installation Of Alarm Systems (IB04-03-S001)
- Adjustment Of J-45735 Exhaust BACKPRESSURE Gauge (IB03-14-S001)
- 2.3L/2.6L Engine Exhaust Manifold Stud Nut Removal (SB97-01-L004)
- 2.3/2.6L Eng Exhaust Pipe/Gasket/Nut Replacing Info (SB88-03-004)
- 2.3L Eng Exhaust Pipe/Gasket Replacement - REPL Nuts (SB88-03-004)
- Exterior Body Panels
- Exterior Lights
- Frames, Subframes & Crossmembers
- Front Suspension
- Fuel System
- Top Tier Detergent Gasoline (IB06-02-S001)
- Reprogramming Of Powertrain Control Modules (Pcm) (IB03-14-S002)
- 1.8/2.2/2.3L Diesel Eng Lacks Power - Fouled Screen (SB87-02-001)
- 1.8/1.9/2.3L Eng Backfire - Gas Vapor Filter Clogged (SB87-03-004)
- 1.8/1.9/2.3L Eng Excess Backfire - Gas Vapor Filter (SB87-03-004)
- Fuses & Circuit Breakers
- Electrical Terminal Hardware Kit Available (SB95-14-L004)
- Connector Corrosion - Exposed Relay Cover (SB87-04-005)
- Electrical Connector Corrosion - New Plastic Cover (SB87-04-005)
- 1.8/1.9/2.2/2.3L Eng Alt Wire Damage - Modify Clamp (SB87-04-003)
- 1.9/2.3L Eng Alternator Wire Damage - Modify Clip (SB87-04-003)
- Gauges & Instrument Panels
- Low Voltage Display On IP Gauge, Lights Dim At Stop Lights, Battery Discharged, No Start, Slow Cranking, Dim Lights At Idle, Low Generator Output (IB07-04-S003)
- Inspection Of All Related Wiring Harness Connections When Diagnosing Miscellaneous DTC'S, Intermittent DRIVEABILITY Concerns, Hard Start, No Start, Incorrect Gauges, Inoperative Air Conditioning Systems, Service Engine Soon Lamps Illuminated, 4WD Lamp Illuminated, Instrument Panel Gauges Inoperative, Cruise Inoperative (IB05-04-S005)
- Radio Clock Display Resets With Key Off - #6 Fuse (SB90-04-002)
- Speedo Bounce/Noise - Modify Speedo Cable Length (SB89-04-005)
- Speedometer/Odometer Replacement Labels (SB89-04-002)
- Gas Eng Faulty Low Oil Pressure Reading - Condenser (SB88-01-001)
- 2.6L Eng Low Oil Gauge - New Oil Pressure CONDENSOR (SB89-01-001)
- Turbo Diesel Eng Brake Warning Light - Vacuum Check (SB86-09-003)
- Headlights
- Low Voltage Display On IP Gauge, Lights Dim At Stop Lights, Battery Discharged, No Start, Slow Cranking, Dim Lights At Idle, Low Generator Output (IB07-04-S003)
- Fog Lamp Troubleshooting (SB89-13-001)
- Turn Signal Does Not Cancel (SB87-10-001)
- Turn Signals Do Not Cancel - New Spring & Pin ASSY (SB87-10-001)
- Heated Glass/Defoggers
- HVAC Control Systems
- New Sae J2788 Refrigerant Recovery Standard (IB07-12-S004)
- Inspection Of All Related Wiring Harness Connections When Diagnosing Miscellaneous DTC'S, Intermittent DRIVEABILITY Concerns, Hard Start, No Start, Incorrect Gauges, Inoperative Air Conditioning Systems, Service Engine Soon Lamps Illuminated, 4WD Lamp Illuminated, Instrument Panel Gauges Inoperative, Cruise Inoperative (IB05-04-S005)
- A/C Refrigerant System Sealer And A/C System Leak Detecting Guidelines (IB04-12-S001)
- Replacement Of The Receiver Drier During Air Conditioning Repair And Service (IB00-12-S002)
- R-12 To R-134A A/C System Conversion/Retrofit Procedures (Supersedes Sb00-12-S002) (SB00-12-S004)
- HVAC System Deodorizing Treatment (SB99-12-S002)
- HVAC System Deodorizing Treatment (SB98-12-L001)
- A/C FREON Blends Warning (SB92-12-003)
- A/C FREON Recovery Caution (SB91-12-002)
- A/C Diagnosis Chart (SB91-12-001)
- Fuel/Brake Line Leakage - New Lines/Clips (SB89-12-001)
- Water In Blower Motor - Case Guide Water Diverter (SB88-12-001)
- A/C Poor Cooling - Test/Reroute Thermostat Tube (SB87-12-004)
- Fan-To-Crankshaft Pulley Interference - Spacer Kit (SB87-12-003)
- 4ZD1 Eng A/C Kit Installation (SB87-12-002)
- Receiver Drier Replacement During Air Conditioning Repair & Service (IB00-12-S002)
- Ignition Switch/Steering Lock
- Ignition System
- Interior/Exterior Trim
- Interior/Illumination Lights
- Locking Hubs
- Lubrication System
- Engine Oil Usage Testing And Reporting (SB07-01-S001)
- Precaution In Installing An ISUZU Oil Filter (IB00-01-S001)
- Engine Crankshaft Front Oil Seal Retainer Leakage (SB96-01-L006)
- Propylene Glycol Based Engine Coolant (SB96-14-L002)
- Propylene Glycol-Based Engine Coolant Warning (SB94-14-005)
- A/C FREON Blends Warning (SB92-12-003)
- Oil Leak - Rear Oil Seal Diagnosis/Repair (SB92-01-002)
- 2.3L Eng Excess Exhaust Smoke - Check Valve (SB90-03-002)
- Oil Drain Plug Washer Replacement Requirements (SB89-01-011)
- Recommended Sealants (SB89-14-002)
- 2.2/2.3L Diesel Eng Oil Pump Installation Caution (SB88-01-007)
- Turbocharger Operation/Service Precautions (SB87-14-002)
- Camshaft Front Oil Seal Leak - Inspect Seal Seating (SB86-01-004)
- 1.9/2.2/2.3L Eng Camshaft Oil Seal Leak (SB86-01-004)
- Gasoline/Alcohol Fuel Blend Caution/Guidelines (SB84-02-002)
- Manual Steering
- Manual Trans
- LOCTITE/PERMATEX Cross-Reference Chart (SB99-14-S001)
- Speedo Bounce/Noise - Modify Speedo Cable Length (SB89-04-005)
- MSG4/MSG5 Trans Speedo Cable Bushing Oil Leakage (SB87-05-002)
- Speedo Cable Noise - Replace Cable (SB87-04-008)
- Shudder During Clutch Engagement - Driveline Shims (SB87-06-003)
- Gm76MM/MSG5 Trans Gear Clash - New Synchro Rings (SB87-05-001)
- Improved Top Gear Shaft Bearing (SB86-05-003)
- MSG5L Trans Fill Plug Location/Information (SB86-05-001)
- Mechanical
- Use Of Surface Conditioning Disks (IB05-01-S002)
- Adjustment Of J-45735 Exhaust BACKPRESSURE Gauge (IB03-14-S001)
- LOCTITE/PERMATEX Cross-Reference Chart (SB99-14-S001)
- Use Of Surface Conditioning Discs (IB00-14-S001)
- Precaution In Installing An ISUZU Oil Filter (IB00-01-S001)
- 2.3L/2.6L Engine Exhaust Manifold Stud Nut Removal (SB97-01-L004)
- Engine Crankshaft Front Oil Seal Retainer Leakage (SB96-01-L006)
- Oil Leak - Rear Oil Seal Diagnosis/Repair (SB92-01-002)
- 2.3/2.6L Eng Oil Leak Rear Seal - Rear Oil Seal Tool (SB92-01-001)
- 2.3L Eng Excess Exhaust Smoke - Check Valve (SB90-03-002)
- Crankshaft Bearing Selection Specifications (SB89-01-008)
- Recommended Sealants (SB89-14-002)
- 2.2L Turbo Eng Failed - Short Block REPL/Repair Info (SB88-01-003)
- 2.2/2.3L Eng Conn Rod & Oil Pipe Interference Info (SB88-01-004)
- 2.2L SHORTBLOCK Replacement Warning (SB87-01-002)
- Camshaft Front Oil Seal Leak - Inspect Seal Seating (SB86-01-004)
- 1.9/2.2/2.3L Eng Camshaft Oil Seal Leak (SB86-01-004)
- Gasoline/Alcohol Fuel Blend Caution/Guidelines (SB84-02-002)
- Mechanical - Hydraulic
- Paint & Coatings
- Passive Restraints
- Procedures
- Rear Suspension
- Restraints Control Systems
- Schedule
- Seats
- Starter
- Low Voltage Display On IP Gauge, Lights Dim At Stop Lights, Battery Discharged, No Start, Slow Cranking, Dim Lights At Idle, Low Generator Output (IB07-04-S003)
- CALIFORNIA Consent Order On Settlement Of Lawsuit On Batteries (Proposition 65) (IB00-14-S004)
- Battery Testing/Charging (SB88-04-003)
- Gasoline/Alcohol Fuel Blend Caution/Guidelines (SB84-02-002)
- CALIFORNIA Consent Order-Lawsuit Settlement On Batteries (Proposition 65) (IB00-14-S004)
- Steering Column
- Steering Linkage
- Sun Roof/T-Top/Convertible Top
- System
- Misfire DTCs P0300, P1380, P1381 and Catalytic Converter Damage Due to Installation of Alarm Systems (02-06-05-004B)
- Inspection Of All Related Wiring Harness Connections When Diagnosing Miscellaneous DTC'S, Intermittent DRIVEABILITY Concerns, Hard Start, No Start, Incorrect Gauges, Inoperative Air Conditioning Systems, Service Engine Soon Lamps Illuminated, 4WD Lamp Illuminated, Instrument Panel Gauges Inoperative, Cruise Inoperative (IB05-04-S005)
- Reprogramming Of Powertrain Control Modules (Pcm) (IB03-14-S002)
- LOCTITE/PERMATEX Cross-Reference Chart (SB99-14-S001)
- Engine Crankshaft Front Oil Seal Retainer Leakage (SB96-01-L006)
- Oil Leak - Rear Oil Seal Diagnosis/Repair (SB92-01-002)
- 2.3L Eng Oil In Distributor - Worn Distributor Seal (SB91-04-007)
- Air Regulator Specifications/Testing (SB90-03-003)
- 2.3L Eng Excessive Smoke - Check Valve INSPT/REPL (SB90-03-002)
- Recommended Sealants (SB89-14-002)
- 1.8/1.9/2.2/2.3L Eng Stalls Cold - Cut Vacuum Hose (SB88-02-003)
- 2.3L Eng Stalling At Idle - Kinked Vacuum Hose (SB88-02-003)
- 2.3L Eng Stalls At Idle - Kinked Vacuum Hose (SB88-02-003)
- 2.3L Eng Erroneous Code 21 - MISROUTED Vacuum Hose (SB88-03-001)
- 1.8/2.2/2.3L Diesel Eng Lacks Power - Fouled Screen (SB87-02-001)
- 1.8/1.9/2.3L Eng Backfire - Gas Vapor Filter Clogged (SB87-03-004)
- 1.8/1.9/2.3L Eng Excess Backfire - Gas Vapor Filter (SB87-03-004)
- 1.9/2.3L Eng Alternator Wire Damage - Modify Clip (SB87-04-003)
- 1.8/2.2/2.3L Eng New Service Fuel Return Line (SB87-03-002)
- Camshaft Front Oil Seal Leak - Inspect Seal Seating (SB86-01-004)
- 1.9/2.2/2.3L Eng Camshaft Oil Seal Leak (SB86-01-004)
- 1.9L Eng Distributor Cap Boot (SB86-04-008)
- Gasoline/Alcohol Fuel Blend Caution/Guidelines (SB84-02-002)
- Transfer Case
- Inspection Of All Related Wiring Harness Connections When Diagnosing Miscellaneous DTC'S, Intermittent DRIVEABILITY Concerns, Hard Start, No Start, Incorrect Gauges, Inoperative Air Conditioning Systems, Service Engine Soon Lamps Illuminated, 4WD Lamp Illuminated, Instrument Panel Gauges Inoperative, Cruise Inoperative (IB05-04-S005)
- Driveline Sound In Four Wheel Drive Operation (IB01-05-S001)
- MUA5C Trans Droning Noise - Driveline Angle (SB90-05-005)
- Transmission Control Systems
- Wheel Hubs
- Wheels & Tire System
- Information On Proper Tire Pressure (IB06-08-S003)
- Use Of The HAWEKA Flange Plate Adapter For Tire Balancers (IB01-14-S005)
- Driveline Sound In Four Wheel Drive Operation (IB01-05-S001)
- 3/4 Inch (19MM) Wheel Lug Torque Stick (SB99-14-S008)
- Radial Tire Sidewall Indentations - Information (SB94-08-001)
- YOKOHAMA Tires Availability (SB93-08-001)
- Auto Lock Hub Ratcheting Noise - Revised Front Hub (SB88-06-002)
- Ratcheting Front Hub Noise - New Front Hub Assembly (SB88-06-002)
- Front Hub Reassembly - Workshop Manual Correction (SB88-07-001)
- 4WD Tire Recommendations (SB86-08-002)
- Conversion From Auto To Manual Locking Hub Info (SB85-06-002)
- Window Motors & Regulators
- Urethane Adhesives For Stationary Glass And Other Applications (02-08-48-001A)
- Automotive Safety Glass Identification And Maintenance (IB01-11-S001)
- Tailgate Door Hinge Parts & Service Procedure (SB92-11-015)
- Rear Seat HOLDDOWN Hook Warm - Cover (SB89-11-007)
- Loose Weatherstrip Repair (SB87-11-006)
- Tailgate Hinge Binding - Cleaned & Lubed/Replaced (SB87-11-002)
- Wiper/Washer Systems
- Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)
- Electrical Terminal Hardware Kit Available (SB95-14-L004)
- Connector Corrosion - Exposed Relay Cover (SB87-04-005)
- Electrical Connector Corrosion - New Plastic Cover (SB87-04-005)
- 1.8/1.9/2.2/2.3L Eng Alt Wire Damage - Modify Clamp (SB87-04-003)
- 1.9/2.3L Eng Alternator Wire Damage - Modify Clip (SB87-04-003)