LEMON Manuals: Even more car manuals for everyone: 1960-2025
Home >> Land Rover >> 2003 >> Range Rover >> Repair and Diagnosis >> Engine Performance >> Fuel Delivery >> Fuel Delivery System >> Removal & Installation >> Fuel - Tank >> Installation
April 5, 2026: LEMON Manuals is launched! Read the announcement.

Fuel - Tank: Installation

  1. Position straps to fuel tank and secure with scrivets.
  2. Fit charcoal canister to charcoal canister purge solenoid feed pipe to fuel tank.
  3. Fit vapor separator to fuel tank and secure with 2 scrivets, connect 2 hoses to fuel tank and secure with clips.
  4. Fit fuel tank breather pipes and charcoal canister vent pipes to clip on fuel tank filler neck.
  5. Position tank assembly and breather pipes to vehicle.
  6. With assistance, fit bolts securing fuel tank to body and tighten to 45 Nm (33 ft. lbs).
    NOTE: Pass vent and breather hoses through body while fitting tank.
  7. Connect fuel hoses to fuel filter.
  8. Position fuel filter to mounting brackets and secure with screws.
  9. Fit fuel tank shields, but do not fit nuts and bolts.
  10. Connect breather hose to filler neck, fit and secure clip.
  11. Position fuel tank vent pipe to filler neck.
  12. Connect fuel tank filler hose to fuel tank filler neck.
  13. Tighten bolts securing subframe to body to 165 Nm (129 ft. lbs).
  14. Fit charcoal canister, tighten 2 bolts and connect 3 pipes to charcoal canister.
  15. Fit bolts and nuts securing fuel tank shields and tighten to 25 Nm (18 ft. lbs).
  16. Fit fuel tank breather hose to fuel tank filler neck and secure with clip.
  17. Fit fuel tank breather pipes and charcoal canister vent pipes to clip on fuel tank filler neck.
  18. Fit securing clip to fuel tank breather hose and charcoal canister vent pipe.
  19. Fit RH rear wheel arch liner. See 76.10.49 LINER -- REAR WHEEL ARCH -- SINGLE .
  20. Insert handbrake cables through body.
  21. Fit rear propeller shaft. See REAR DRIVE SHAFT .
  22. Fit handbrake cable retaining clip.
  23. Fit handbrake cables to compensator.
  24. Fit cable retaining clip to handbrake compensator.
  25. Fit center console. See 76.25.01 CENTER CONSOLE .
  26. Connect multiplug to fuel pump.
  27. Fit RH fuel tank access cover and secure with 4 nuts.
  28. Fill fuel tank with extracted fuel. See TANK - DRAIN .
  29. Connect battery earth lead.
scientia non olet · About LEMON Manuals