U660E Automatic Transaxle Compensation Code Input Process (TC002-06)

Publication date: 2006-06-09
Reference number: TC002-06

U660E AUTOMATIC TRANSAXLE COMPENSATION CODE INPUT PROCESS

TECHNICAL SERVICE BULLETIN

Reference Number(s): TC002-06, Date of Issue: June 09, 2006

LEXUS:	2007 ES 350
Section:	TRANSMISSION & CLUTCH
COPYRIGHT:	© 2018 Lexus, a division of Toyota Motor Sales, USA License Agreement TMS1002

Introduction

2007 model year ES 350 vehicles are equipped with a U660E (6-speed) transaxle. These transaxles are tested and marked with an automatic transaxle compensation value to improve driveability and reduce the amount of time needed to complete the Transmission Control Module (TCM) "Learning" process.

CAUTION: The transaxle compensation value registration process MUST be performed anytime one of the following components are replaced:

Transaxle
Transmission Control Module (TCM)

Failure to follow the procedure below may lengthen the time to complete the TCM "Learning" process, potentially resulting in performance concerns.

Applicable Vehicles

2007 model year ES 350 vehicles equipped with the U660E (6-speed) automatic transaxle.

Required SSTs

REQUIRED SST

ITEM NO.

SPECIAL SERVICE TOOLS (SSTs)

PART NUMBER

QTY

DRW⁽²⁾

Lexus Diagnostic Tester Kit ⁽¹⁾

NOTE:

All components from this kit/set are required
12 Megabyte Diagnostic Tester Program Card (P/N 01002593-005) with version 13.3a Software (or later) is required

Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002

LEX220036

CAN Interface Module Kit ⁽¹⁾

NOTE:

All components from this kit/set are required

01002744

⁽¹⁾	Essential SSTs.

⁽²⁾	Refers to drawer number in SST Storage System.

NOTE: Additional Diagnostic Tester Kits, CAN Interface Modules, Program Cards, or other SSTs may be ordered by calling SPX/OTC at 1-800-933-8335.

Warranty Information

WARRANTY INFORMATION

OP CODE	DESCRIPTION	TIME	OFP	T1	T2
N/A	Not Applicable to Warranty	-	-	-	-

Registration Procedure

Refer to the Technical Information System (TIS), 2007 model year ES 350 Repair Manual: U660E Automatic Transaxle: Automatic Transaxle System: Manual Shifting Test, Registration.

NOTE: If the transaxle is installed in the vehicle and the QR Code Label cannot be read, it may be necessary to remove the battery and battery tray to access the QR Code Label.

Letter Input Chart

Fig 1: Identifying QR Code Input Chart