Specifications Index
IS350 SPECIFICATIONS INDEX
| System | Specification/Procedure | ||
|---|---|---|---|
| Air Conditioning | |||
| Service | SERVICE DATA | ||
| Torque | TORQUE SPECIFICATIONS | ||
| Axle Nut/Hub Nut | |||
| Front | 294 N.m (2,998 kgf.cm 217 ft.lbs) | ||
| Rear | 290 N.m (2,957 kgf.cm 214 ft.lbs) | ||
| Battery | NA | ||
| Brakes | |||
| Bleeding Sequence | BLEEDING | ||
| Disc Brakes | SERVICE DATA | ||
| Drum Brakes | SERVICE DATA | ||
| Torque | TORQUE SPECIFICATIONS | ||
| Charging | |||
| Generator | SERVICE DATA | ||
| Torque | TORQUE SPECIFICATIONS | ||
| Drive Belts | |||
| Belt Routing | DRIVE BELT | ||
| Belt Tensioning | INSPECTION | ||
| Engine Cooling | |||
| General Service Specifications | SERVICE DATA | ||
| Radiator Cap Pressure | |||
| Standard Value (New Cap) | 93.3-122.7 kPa (0.95-1.25 kgf.cm2 , 13.5-17.8 psi) | ||
| Minimum Standard Value (Used Cap) | 78.5 kPa (0.8 kgf.cm2 , 11.4 psi) | ||
| Thermostat R & I | THERMOSTAT | ||
| Water Pump R & I | WATER PUMP | ||
| Engine Mechanical | |||
| (2GR-FE) | |||
| Compression | SERVICE DATA | ||
| Oil Pressure | At Idle: 80 kPa (0.8 kgf*cm2 , 11.6 psi) or more. At 6,000 RPM: 380 kPa (3.9 kgf*cm2 , 55.5 psi) or more. |
||
| Overhaul | SERVICE DATA | ||
| Torque | TORQUE SPECIFICATIONS | ||
| Fluid Specifications | See FLUIDS under MAINTENANCE tab. | ||
| Flywheel/Flex Plate (Drive Plate) Torque | 83 N.m (846 kgf.cm, 61 ft.lbs) | ||
| Fuel System | |||
| Pressure Specification | At Idle: 304 to 343 kPa (3.1 to 3.5 kgf/cm2 , 44 to 50 psi). After engine Off 5 Min.: 147 kPa (1.5 kgf/cm2 , 21 psi) or more. |
||
| Fuel Pressure Test Procedure | ON-VEHICLE INSPECTION | ||
| Fuel Filter Location | In Tank Type COMPONENTS |
||
| Ignition | |||
| Firing Order & Cylinder Identification | |||
| 2GR-FE | FIRING ORDER & CYLINDER IDENTIFICATION | ||
| Spark Plug (Type = DENSO FK20HBR11) | |||
| Gap | 1.0 to 1.1 mm (0.039 to 0.043 in.) | ||
| Torque | 25 N.m (254 kgf.cm, 18 ft.lbs) | ||
| Starting | |||
| Starter | SERVICE DATA | ||
| Torque | TORQUE SPECIFICATIONS | ||
| Wheel Alignment | |||
| Adjustment Specifications | SERVICE DATA | ||
| Torque | TORQUE SPECIFICATIONS | ||
| Wheel & Tire | |||
| Wheel Lug Nut Torque | 103 N.m (1,050 kgf.cm, 76 ft.lbs) | ||