Data List/Active Test
- DATA LIST
HINT:
Performing the DATA LIST using the intelligent tester allows the relays and actuators, and other items to operate without removing any parts. Performing the DATA LIST as the first step of troubleshooting is one of the methods to save labor time.
- Connect the intelligent tester to the DLC3.
- Turn the ignition switch to the ON position.
- According to the display on the tester, perform the "DATA LIST".
HINT:
The ignition switch must be turned to the ON position to proceed to the Data List using the intelligent tester.
DATA LIST:
DATA LISTItem Measurement Item/Range (Display) Normal Condition Diagnostic Note ABS MOT RELAY ABS motor relay / ON or OFF ON: Motor relay ON - SOL RELAY Solenoid relay / ON or OFF ON: Solenoid relay ON - VSC / TRC OFF SW(1) TRAC OFF switch / ON or OFF ON: TRAC OFF switch ON - IDLE SW Main idle switch / ON or OFF ON: Accelerator pedal released
OFF: Accelerator pedal depressed- STOP LIGHT SW Stop light switch / ON or OFF ON: Brake pedal depressed
OFF: Brake pedal released- PKB SW Parking brake switch / ON or OFF ON: Parking brake applied
OFF: Parking brake released- STEP FORCE SW Stepping force switch / ON or OFF ON: Brake pedal depressed
OFF: Brake pedal released- ABS OPERT FR ABS operation (FR) / BEFORE or OPERATE BEFORE: No ABS operation (FR)
OPERATE: During ABS operation (FR)- ABS OPERT FL ABS operation (FL) / BEFORE or OPERATE BEFORE: No ABS operation (FL)
OPERATE: During ABS operation (FL)- ABS OPERT RR ABS operation (RR) / BEFORE or OPERATE BEFORE: No ABS operation (RR)
OPERATE: During ABS operation (RR)- ABS OPERT RL ABS operation (RL) / BEFORE or OPERATE BEFORE: No ABS operation (RL)
OPERATE: During ABS operation (RL)- WHEEL SPD FR Wheel speed sensor (FR) reading / min.: 0 MPH (0 km/h, max.: 202 MPH (326 km/h) Actual wheel speed Similar speed as indicated on speedometer WHEEL SPD FL Wheel speed sensor (FL) reading / min.: 0 MPH (0 km/h, max.: 202 MPH (326 km/h) Actual wheel speed Similar speed as indicated on speedometer WHEEL SPD RR Wheel speed sensor (RR) reading / min.: 0 MPH (0 km/h, max.: 202 MPH (326 km/h) Actual wheel speed Similar speed as indicated on speedometer WHEEL SPD RL Wheel speed sensor (RL) reading / min.: 0 MPH (0 km/h, max.: 202 MPH (326 km/h)) Actual wheel speed Similar speed as indicated on speedometer DECELERAT SENS Acceleration sensor 1 reading / min.: -1.869 G, max.: 1.869 G Approximately 0 +- 0.13 G at still condition Reading changes when vehicle is tilted DECELERAT SENS2 Acceleration sensor 2 reading / min.: -1.869 G, max.: 1.869 G Approximately 0 +- 0.13 G at still condition Reading changes when vehicle is tilted IG VOLTAGE ECU power supply voltage / NORMAL / TOO LOW NORMAL: 9.5 V to 16.5 V TOO LOW: Below 9.5 V - SFRR ABS solenoid (SFRR) / ON or OFF ON: Operates - SFRH ABS solenoid (SFRH) / ON or OFF ON: Operates - SFLR ABS solenoid (SFLR) / ON or, OFF ON: Operates - SFLH ABS solenoid (SFLH) / ON or OFF ON: Operates - SRRR (SRR) ABS solenoid (SRRR (SRR)) / ON or OFF ON: Operates - SRRH (SRH) ABS solenoid (SRRH (SRH)) / ON or OFF ON: Operates - SRLR ABS solenoid (SRLR) / ON or OFF ON: Operates - SRLH ABS solenoid (SRLH) / ON or OFF ON: Operates - SMF (BA-SOL) TRAC solenoid (SMF) / ON or OFF ON: Operates - SMR TRAC solenoid (SMR) / ON or OFF ON: Operates - ENGINE SPD Engine Speed/ Min.: 0 rpm, Max.: 6000 rpm Actual engine speed - VEHICLE SPD Wheel speed sensor reading / min.: 0 MPH (0 km/h), max.: 202 MPH (326 km/h) Actual vehicle speed Speed indicated on speedometer YAW RATE Yaw rate sensor/ Min.: -128 deg/ s, Max.: 127 deg/s Min.: -128 deg/s
Max.: 127 deg/s- YAW ZERO VALUE Memorized zero value/ Min.: -128 deg/s, Max.: 127 deg/s Min.:-128 deg/s
Max.: 127 deg/s- STEERING ANG Steering angle sensor/ Min.: -1,152 deg, Max.: 1,150.875 deg Left turn: Increase
Right turn: Decrease- MAS CYL PRS 1 Master cylinder pressure sensor 1 reading / min.: 0 V, max.: 5 V When brake pedal is released: 0.3 to 0.9 V Reading increases when brake pedal is depressed SPD SEN FR FR speed sensor open detection / OPN_DET or NORMAL OPN_DET: Momentary interruption
NORMAL: Normal- SPD SEN FL FL speed sensor open detection / OPN_DET or NORMAL OPN_DET: Momentary interruption
NORMAL: Normal- SPD SEN RR RR speed sensor open detection / OPN_DET or NORMAL OPN_DET: Momentary interruption
NORMAL: Normal- SPD SEN RL RL speed sensor open detection / OPN_DET or NORMAL OPN_DET: Momentary interruption
NORMAL: Normal- EFI COM EFI communication open detection / OPN DET or NORMAL OPN_DET: Momentary interruption
NORMAL: Normal- YAWRATE SEN Yaw rate sensor open detection / OPN_DET or NORMAL OPN_DET: Momentary interruption
NORMAL: Normal- DECELE SEN Acceleration sensor open detection / OPN_DET or NORMAL OPN_DET: Momentary interruption
NORMAL: Normal- STEERING SEN Steering angle sensor open detection / OPN_DET or NORMAL OPN_DET: Momentary interruption
NORMAL: Normal- M/C SEN 1 Master cylinder pressure sensor 1 open detection / OPN DET or NORMAL OPN_DET: Momentary interruption
NORMAL: Normal- ACCELERATOR % The difference of a present accelerator/min.: 0 %, max.: 128% Min.: 0%
Max.: 128%- TORQUE Real engine torque / min.: -1,024 N*m, max.: 1,016 N*m Min.: -1,024 N*m
Max.: 1,016 N*m- TEST MODE Test mode operation / NORMAL or TEST NORMAL: Normal mode
TEST: During test mode- #CODES Number of DTC recorded / min.: 0, max.: 255 Min.: 0, max.: 42 - (1) 2WD
- ACTIVE TEST
HINT:
Performing the ACTIVE TEST using the intelligent tester allows the relays and actuators, and other items to operate without removing any parts. Performing the ACTIVE TEST as the first step of troubleshooting is one of the methods to save labor time.
It is possible to display the DATA LIST during the ACTIVE TEST.
- Connect the intelligent tester to the DLC3.
- Turn the ignition switch to the ON position.
- According to the display on the tester, perform the "ACTIVE TEST".
HINT:
The ignition switch must be turned to the ON position to proceed to the Active Test using the intelligent tester.
ACTIVE TEST:
ACTIVE TESTItem Vehicle Condition / Test Details Diagnostic Note SFRR Turns ABS solenoid (SFRR) ON / OFF Operation of solenoid (clicking sound) can be heard SFRH Turns ABS solenoid (SFRH) ON / OFF Operation of solenoid (clicking sound) can be heard SFLR Turns ABS solenoid (SFLR) ON / OFF Operation of solenoid (clicking sound) can be heard SFLH Turns ABS solenoid (SFLH) ON / OFF Operation of solenoid (clicking sound) can be heard SRRR Turns ABS solenoid (SRRR) ON / OFF Operation of solenoid (clicking sound) can be heard SRRH Turns ABS solenoid (SRRH) ON / OFF Operation of solenoid (clicking sound) can be heard SRLR Turns ABS solenoid (SRLR) ON / OFF Operation of solenoid (clicking sound) can be heard SRLH Turns ABS solenoid (SRLH) ON / OFF Operation of solenoid (clicking sound) can be heard SMF (BA-SOL) Turns TRAC solenoid SMF (BA-SOL) ON / OFF Operation of solenoid (clicking sound) can be heard SMR Turns TRAC solenoid SMR ON / OFF Operation of solenoid (clicking sound) can be heard SFRR & SFRH Turns ABS solenoids (SFRR & SFRH) ON / OFF Operation of solenoid (clicking sound) can be heard SFLR & SFLH Turns ABS solenoids (SFLR & SFLH) ON / OFF Operation of solenoid (clicking sound) can be heard SRH & SRR Turns ABS solenoids (SRH & SRR) ON / OFF Operation of solenoid (clicking sound) can be heard SRLR & SRLH Turns ABS solenoids (SRLR & SRLH) ON / OFF Operation of solenoid (clicking sound) can be heard SFRH & SFLH Turns ABS solenoids (SFRH & SFLH) ON / OFF Operation of solenoid (clicking sound) can be heard SOL RELAY Turns solenoid relay ON / OFF Operation of solenoid (clicking sound) can be heard ABS MOT RELAY Turns ABS motor relay ON / OFF Operation of motor (clicking sound) can be heard ABS WARN LIGHT Turns ABS warning light ON / OFF Observe combination meter VSC WARN LIGHT Turns VSC warning light ON / OFF Observe combination meter VSC/TRC OFF IND(1) Turns TRAC OFF indicator light ON / OFF Observe combination meter SLIP INDI LIGHT Turns SLIP indicator light ON / OFF Observe combination meter BRAKE WRN LIGHT Turns BRAKE warning light ON / OFF Observe combination meter VSC / BR WARN BUZ Turns skid control buzzer ON / OFF Buzzer sound can be heard (1) 2WD