Section 4 (Automatic Transmission - CVT)
WARNING: This page is about a different variant/trim than selected.
- Specifications
- Description And Operation
- Transaxle Description
- Range Selection
- Torque Converter
- Apply Components
- Transaxle Electronic Control System
- Notes
- Mechatronic Assembly
- Main Control Valve Body
- Pressure Control Solenoids
- Pressure Sensors
- Transmission Control Module (TCM)
- Transmission Fluid Temperature (TFT) Sensor
- Speed Sensors
- Turbine Shaft Speed (TSS) Sensor and Primary Variator Speed Sensor
- Output Shaft (OSS) Sensor
- Transmission Range (TR) Sensor
- Diagnosis And Testing
- Diagnostic Strategy
- Diagnostic Flow Table
- Preliminary Inspection
- Torque Converter Diagnosis
- Visual Inspection
- Diagnostics
- Diagnostic Parameters Identification (PID) Chart
- Diagnostic Trouble Code (DTC) Tables
- Transaxle Connector Layouts
- Pinpoint Tests - Non OSC Equipped Vehicle
- Notes
- Pinpoint Tests
- Pinpoint Test A: Transmission Fluid Pressure Sensors
- Pinpoint Test B: Transmission Fluid Temperature (TFT) Sensor
- Pinpoint Test C: Transmission Range (Tr) Sensor
- Pinpoint Test D: Torque Converter Clutch
- Pinpoint Test E: Excessive Clutch Slippage
- Pinpoint Test F: Output Shaft Speed (OSS) Sensors
- Pinpoint Test G: Turbine Shaft Speed (TSS) Sensor
- Pinpoint Test H: Transmission Control Module Signal
- Pinpoint Test I: Primary Pulley Speed Sensor
- Leakage Inspection
- Transmission Fluid Cooler
- Diagnosis By Symptom
- Notes
- Diagnosis by Symptom Table Directions
- Diagnosis By Symptom Index
- Diagnostic Routines
- Engagement Concern: No Forward
- Engagement Concern: No Reverse
- Engagement Concern: Harsh Reverse
- Engagement Concern: Harsh Forward
- Engagement Concern: Delayed/Soft Reverse
- Engagement Concern: Delayed/Soft Forward
- Engagement Concern: No Forward and No Reverse
- Torque Converter Operation Concerns: No Apply
- Torque Converter Operation Concern: Always Applied
- Torque Converter Operation Concern: Cycling/Shudder/Chatter
- Other Concerns: Shift Lever Efforts High
- Other Concerns: External Leaks
- Other Concerns: Noise/Vibration - Forward or Reverse
- Other Concerns: No Park Range
- Other Concerns: Transaxle Overheating
- Other Concerns: Transaxle Surges (Ratio Oscillation)
- Other Concerns: Loss/Lack of Power/Acceleration
- General Procedures
- Transmission Fluid Cooler Tubes - Backflushing and Cleaning
- Torque Converter Contamination Inspection
- Transmission Fluid Level Check and Setting
- Fluid Pan, Gasket and Filter
- Transmission Fluid Drain and Refill
- Differential Seals - LH
- Differential Seals - RH, All Wheel Drive (AWD)
- Differential Seals - RH, Front Wheel Drive (FWD)
- Transaxle Support Insulator
- Side Shaft Gear Assembly - All Wheel Drive (AWD)
- Side Shaft Gear Assembly - Front Wheel Drive (FWD)
- Manual Control Lever Shaft Seal
- Primary Variator Cover
- Secondary Variator Cover
- High Pressure Filter and Case Cover
- Mechatronic Assembly
- Output Shaft Speed (OSS) Sensor
- Removal
- Disassembly
- Disassembly And Assembly Of Subassemblies
- Side Shaft Gear Assembly
- Differential
- Forward Clutch
- Transmission Range (TR) Sensor
- Primary and Secondary Variator Covers
- High Pressure Filter and Case Cover
- Torque Converter Housing, Reverse Clutch and Pump Assembly - Disassembly
- Transaxle Case - Disassembly
- Variator/Chain and Spur Gear Assembly
- Transaxle Case - Assembly
- Torque Converter Housing, Reverse Clutch and Pump Assembly - Assembly
- Assembly
- Installation