Steering And Wheel Alignment - Repair (R55) -- Cooper
- Safety And General Information
- 00 Safety information for working on vehicles with automatic engine start-stop function (MSA)
- 00..... Safety instructions for handling oil
- 72 12... Components requiring inspection and/or replacement after airbag deployment
- 32..... Overview of steering
- 32 00... General wheel alignment diagram and definitions
- 32 00... Identification of suspension without label
- 32 00... Moving vehicle into design position
- 32 00... Moving vehicle into normal position
- 32 00... Information replacement of steering gear/steering column/steering shaft following accident damage
- 31 00... Front axle + steering repair work requiring subsequent wheel alignment
- 33 00... Rear axle repair work requiring subsequent wheel alignment
- 32 00... Test conditions for chassis/wheel alignment check
- 32 00 150 KDS chassis/wheel alignment check with vehicle load up to design position
- 32 00 155 KDS wheel alignment check with ride height measurement without vehicle load
- 61 31 996 Carrying out steering angle sensor adjustment
- 32 00 620 Adjusting rear axle
- 32 00 610 Adjusting toe-in and camber on front axle
- 32 00... Performing rim runout compensation
- Mechanical Steering Gear
- 32 00... Information on replacement of steering gear/steering column/steering shaft following accident damage
- 32 11... Instructions for removing and installing ear clips
- 32 11 100 Replacing gaiter for steering box on left or right
- 32 21 231 Replacing (removing and installing) left or right track rod
- 32 21 151 Replacing left or right track rod end
- Steering Gear With Servo Unit
- 32 00... Information on replacement of steering gear/steering column/steering shaft following accident damage
- 32 13 572 Replace electrical steering box (EPS)
- 32 11 100 Replacing gaiter for steering box on left or right
- 32 21 231 Replacing (removing and installing) left or right track rod
- 32 21 151 Replacing left or right track rod end
- 32 43 550 Replace EPS unit
- Steering Arms, Tie Rods, Steering Damper
- Steering Column
- 32 31 020 Removing and installing/replacing lower section of steering column shroud
- 32 31 082 Removing and installing/replacing steering angle sensor
- 32 31 090 Removing and installing/replacing steering column
- 32 31... Removing and installing/replacing steering column lock
- 32 31 004 Removing and installing/replacing steering column shroud upper section
- Steering Wheel
- Steering Wheel Airbag
- Electronic Power Steering