LEMON Manuals: Even more car manuals for everyone: 1960-2025
Home >> Pontiac >> 2003 >> Aztek AWD >> Repair and Diagnosis >> External Pages >> Different car >> Section 584 (Wheel Alignment Specifications & Adjustment Procedures) >> Repair Instructions >> Front Toe Adjustment
April 5, 2026: LEMON Manuals is launched! Read the announcement.

Front Toe Adjustment

WARNING: This page is about a different car, the 2002 Pontiac Grand Prix. However, it is still accessible from the selected car via links, so may be relevant.
  1. Remove the small seal clamp from the inner tie rod boot.
  2. Position the steering wheel in the straight ahead position.
  3. Loosen the hex nut on the tie rod (2). Turn the tie rod shaft (1) in order to obtain the proper toe angle. Refer to Wheel Alignment Specifications .
  4. Confirm the number of threads showing on each tie rod end is nearly equal.
    NOTE: Refer to FASTENER NOTICE .
  5. Confirm that the tie rod ends (3) are square before you tighten the lock nuts (2).

    Tighten 

    Tighten the hex nuts at the tie rod ends to 68 N.m (50 lb ft).

    IMPORTANT: Ensure the seals do not twist.
  6. Install the seal clamps.
    Fig 1: Adjusting Front Toe
    G01673293Courtesy of GENERAL MOTORS CORP.
scientia non olet · About LEMON Manuals