LEMON Manuals: Even more car manuals for everyone: 1960-2025
Home >> Pontiac >> 2004 >> Aztek Base, AWD >> Repair and Diagnosis >> External Pages >> Different car >> Section 257 (Battery, Charging System And Starting System) >> Repair Instructions >> Battery Replacement >> Installation Procedure
April 5, 2026: LEMON Manuals is launched! Read the announcement.

Installation Procedure

WARNING: This page is about a different car, the 2004 Pontiac Grand Prix. However, it is still accessible from the selected car via links, so may be relevant.
  1. Install the insulator to the battery.
    2. IMPORTANT: Do not tip the battery more than 40 degrees during installation.
  2. Install the battery.
  3. Install the battery hold down.
    4. NOTE: Refer to Fastener Notice in Cautions and Notices.
  4. Install the battery hold down bolt.

    Tighten:  Tighten the bolt to 18 N.m (13 lb ft).

  5. Install the positive battery terminal (1) to the battery.

    Tighten:  Tighten the nut to 15 N.m (11 lb ft).

    6. Fig 1: Identifying Battery Terminals & Ground Wire
    GM911131Courtesy of GENERAL MOTORS CORP.
  6. Install the right front diagonal brace. Refer to Brace Replacement - Front Fender Upper Diagonal in Body Front End.
  7. Connect the negative battery cable. Refer to Battery Negative Cable Disconnect/Connect Procedure .
scientia non olet · About LEMON Manuals