Technical Service Bulletins
- A/C Compressor
- Unscheduled Supplemental Services (Including Flushing Services And Additives) And Proper Use Of Gm Simplified Maintenance Schedules (12-06-01-008B)
- Ac Blows Warm Or Poor Performance (PIT5099H)
- Diagnosing Accessory Drive Belt / Serpentine Belt Noise and Availability and Use of Kent-Moore EN-49228 Laser Alignment Tool - Drive Belt (08-06-01-008A)
- Information On New GE-48800 CoolTech Refrigerant Recovery/Recharge Equipment (08-01-38-001)
- Information on GM ACR2000 (J-43600) and New Refrigerant Recovery Recharging Equipment Standard SAE J2788 (07-01-38-004)
- Unnecessary Engine Crankcase and Subsystems Flushing Services and Proper Utilization of Saturn Simplified Maintenance Schedule to Enhance Customer Service Experience (04-00-90-004A)
- Essential Service Tool Update #6 (U.S. Retailers Only) (06-00-89-042)
- Accessories & Equipment
- Diagnostic Tip - SPS Programming SATURN Vehicles (PIC6533)
- Information - Non-Gm Parts And Accessories (Aftermarket) (04-06-04-054D)
- New Labor Operation Codes for Dealer-Installed GM Accessories Replaced During Warranty Coverage Period (02-20-89-014)
- Announcement of Price Increase for MDI (EL-47955) (08-00-89-018A)
- Essential Service Tool Update # 2 (U.S. Retailers Only) (08-00-89-020)
- Essential Service Tool Update #1 (U.S. Retailers Only) (08-00-89-011)
- Essential Service Tool Update #7 (U.S. Retailers Only) (07-00-89-053)
- Essential Service Tool Update #4 (U.S. Retailers Only) (07-00-89-026)
- Essential Service Tool Update #9 (U.S. Retailers Only) (06-00-89-056)
- Essential Service Tool Update #5 (U.S. Retailers Only) (06-00-89-037)
- Accessories Control Systems
- Information On Communication With ONSTAR Module After CANADIAN Cellular Upgrade (15-08-73-001A)
- Diagnostic Tip: Unable To Connect To ONSTAR Or Connects Failed To Voice (PIT5389F)
- Requirements For ONSTAR Over The Air Programming And Updates (PIC6107A)
- ONSTAR- Unwanted Or Phantom Phone Calls (PIC3278G)
- Diagnostic Tip: Diagnosing Vehicles With ONSTAR DTC B101D-37 (PIC5492E)
- Gm Of CANADA ONSTAR® Cellular Communication Upgrade (15-08-44-001H)
- Caller Id Unavailable After ONSTAR Upgrade (PIT5464)
- Various Electrical Concerns (15-08-45-001)
- Diagnostic Tip: Unable To Connect Or Use Hands Free Calling Or No Data On The Call (Failed To Voice) (PIC4310L)
- Diagnostic Tip: CANADIAN ONSTAR Subscriber Unable To Receive Turn-By-Turn Directions While Traveling In The United States (PIT5264C)
- Vehicle Software Enhancements (13-00-89-003)
- Rear Window Defogger - Broken Heating Grid Detection Method (04-08-48-001D)
- Information On Inadvertent Steering Wheel Control (SWC) Button Press Causing Radio Anomalies (08-08-44-028A)
- Required Return Criteria of Complete Electrical Center (EC) and Body Control Module (BCM) with Integrated Electrical Center to Warranty Parts Center (WPC) (05-08-45-002E)
- Diagnostic Tips/Recommendations on GM Accessory 2-Way Remote Start Transmitter When Transmitter Battery is Weak or Dead (09-08-52-004A)
- GM Accessories: 2-Way Advanced Remote Start Systems Part Information (09-00-89-025A)
- GM Training - August 2009 New Course Information (For U.S. Dealers and Aftermarket) (09-00-89-035)
- 4T45 Transmission, Mil/SES On, DTC P1818, Power Door Locks, Cruise Control, Shift Interlock Or Retractable Hardtop Inoperative, Engine Speed Revs Limited, Hybrids-AUTOSTOP, REGEN Or Boost Inoperative (Reprogram TCM) (07-07-30-005C)
- Accessory Drive Belts
- Cold Start Drive Belt TENSIONER Rattle At Low Rpm - Possible Characteristic (PIP4176A)
- Hybrid - TENSIONER Primary Accessory Drive - Pulley Bearing Noise, Rattle Or Squeal - Spring TENSIONER Shoulder Bolt Or Bracket Pivot Bolt Fatigue (Replace Drive Belt TENSIONER) (09-06-01-009B)
- Diagnosing Accessory Drive Belt / Serpentine Belt Noise and Availability and Use of Kent-Moore EN-49228 Laser Alignment Tool - Drive Belt (08-06-01-008A)
- Air Bag, SRS
- Diagnostic Information For Supplemental Inflatable Restraint (Sir) System, Intermittent Air Bag Indicator/Lamp Illuminated With DTC(S) B0012, B0013, B0015, B0016, B0019, B0020, B0022, B0023, B0026, B0033, B0040, B0042 Or B0044 Set (Inspect And Replace Connector Position Assurance (CPA) Retainer) (08-09-41-002H)
- Airbag Light On, DTC B0071 and B0081 Set (Diagnose and Replace Right Front Seatbelt Buckle, If Necessary) (07-09-41-010D)
- General Motors Position Statement on Installation of Used, Salvaged, or Imitation Air Bag System Components (08-09-41-003)
- Essential Service Tool Update # 8 (U.S. Retailers Only) (07-00-89-061)
- Anti-Lock Brakes
- Anti-Theft Systems
- Information On Poor, Limited, Reduced Remote Keyless Entry (RKE) Or Remote Vehicle Start (RVS) Range (PI1018A)
- Key Code Security Rules And Information On Gm KEYCODE Look-Up Application (CANADA Only) (10-00-89-010C)
- Various Intermittent Electrical Concerns - Door Ajar Message, Interior Lights On, Theft Deterrent Alarm, Retained Accessory Power (RAP) Stays On, Discharged Battery (Diagnose/Repair Door Lock Assembly/Circuit) (09-08-64-022A)
- 4T45 Transmission, Mil/SES On, DTC P1818, Power Door Locks, Cruise Control, Shift Interlock Or Retractable Hardtop Inoperative, Engine Speed Revs Limited, Hybrids-AUTOSTOP, REGEN Or Boost Inoperative (Reprogram TCM) (07-07-30-005C)
- Key Code Information (99-00-89-011E)
- Diagnostic Information for Inoperative Remote Vehicle Start (08-08-52-002)
- Information on Adjusting Key Cut Depths in Exacta Key Cutting Machine (06-00-89-053A)
- Door Latch Freezing In Cold Temperatures (05-08-64-002B)
- Automatic Trans
- Information On Ethylene Glycol In Transmission Fluid (08-07-30-035I)
- Unscheduled Supplemental Services (Including Flushing Services And Additives) And Proper Use Of Gm Simplified Maintenance Schedules (12-06-01-008B)
- Information On Driveline Clunk Noise (99-04-20-002O)
- Information On Shifter Sticking And/Or Difficulty Selecting Desired Gear (19-NA-134)
- OEM And Remanufactured Engine And Automatic Transmission/Transaxle Identification (06-00-89-031E)
- Automatic Transmission Shift And Engine DRIVEABILITY Concerns And/Or Mil On Due To Aftermarket Oil Bath Air Filter Use (04-07-30-013D)
- Prior To Any Circuit Testing (PIP5094A)
- Abnormal Noise And Or Vibration While Driving Due To Non-Gm Aftermarket Accessory (PIP3140G)
- Automatic Transmission Oil Cooler Flow Test Essential Tool J-45096 TRANSFLOW® (03-07-30-002B)
- Dealer Reimbursement Procedures For CAC Tier 1 And Tier 2 Empowerment Tools: Diagnostic Fee, Short Term Rental, And Up-Front Towing (U.S. Only) (15-00-89-003)
- Vibration Analysis Worksheet (03-00-91-001I)
- Information On Normal Maintenance Or Warranty Service For 4T40, 4T45, 4T65, 4L60 Automatic Transmission Oil Pan Magnet Upgrade (08-07-30-040C)
- Release Of DEXRON®-VI Automatic Transmission Fluid (ATF) (04-07-30-037E)
- Warranty Administration- Change in Automatic Transmission Add Condition Documentation and Claim Submission (09-07-30-018A)
- Current Model Year Goodwrench Transmission Replacement Assembly Program (00-07-30-009D)
- GM Training - June 2009 New Course Information (For U.S. Dealers and Aftermarket) (09-00-89-026)
- Transmission Fluid Leak Due to Transmission Converter Housing Seal (Inspect with Dye and Black Light, Replace Torque Converter Fluid Seal) (09-07-30-006)
- 6T70, 6T75, 6L50, 6L80 or 6L90 Automatic Transmission - Information on Transmission Fluid Pressure (TFP) Switch Check For False DTCs P0842, P0843, P0872, P0873, P0877, P0878, P0989 or P0990 (07-07-30-015A)
- Transmission Oil Leaking From Transmission Vent (Replace Transmission Case Cover (Channel Plate) Gasket) (01-07-30-032E)
- 6T70/6T75 Transmission - Check Engine Light On, Poor Vehicle Performance, DTCs P0716, P0717, P0722, P0723, P0751, P0756, P0776, P0796, P2714 or P2723 Set (Diagnose and Repair per SI) (07-07-30-019B)
- Automatic Transmission/Transaxle Torque Converter Replacement (01-07-30-010C)
- Grinding and/or Growling Noise in Park on Incline (99-07-30-030F)
- HYDRA-MATIC® Front Wheel Drive 6T70-E (MH2), 6T75-E (MY9) and All Wheel Drive 6T70-E (MH4), 6T75-E (MH6) Automatic Transmission Control Valve Body Assembly Reconditioning (08-07-30-005A)
- Essential Service Tool Update #7 (U.S. Retailers Only) (07-00-89-053)
- Information On 4T40-E (MN4) and 4T45-E (MN5) Front Wheel Drive Automatic Transmission Valve Body Reconditioning, DTC P0741, P0742, P0751, P0752, P0756, P0757, P1811, Harsh Shifts, Slips, No Drive, No Reverse (07-07-30-025)
- 6T75 Automatic Transmission Binding on 3-4 or 4-3 Shift, Check Engine Light On, DTC P0797 Set (Measure Side Clearance Between Hub Seal Rings and Groove, Replace Hub and Hub Seal Rings if Necessary) (07-07-30-022)
- Essential Service Tool Update #5 (U.S. Retailers Only) (07-00-89-032)
- 6T70/6T75 Automatic Transaxle Exchange Program (06-07-30-015B)
- Auxiliary Emission Control Systems
- Information On Close-Coupled Converter And Engine Replacement (06-06-01-010D)
- Difficulty Filling Fuel Tank, MIL/SES Light Illuminated DTC P0446 - Evaporative Emissions (EVAP) Vent System Performance (Inspect/Clean EVAP Canister Vent Valve Solenoid and Install Screen) (07-06-04-023A)
- Warranty Coverage for Emission-Related Reprogramming Events (PCM, ECM and TCM) (4-06-04-036E)
- I/M Readiness as Part of Emission Inspection and Maintenance Program for OBD II Vehicles (00-06-04-033B)
- Axle Shafts
- Battery Management Systems
- Body Electrical
- Information For Electrical Ground Repair - Use New Replacement Fasteners With Conductive Finish (10-08-45-001F)
- Diagnostic Tip: Apple Device Connectivity Issues Due To USB Cord Concern (PIT5399A)
- Intermittent Malfunction Indicator Lamp (Mil) Illuminated, DTC P2138 With Reduced Engine Power (Repair Instrument Panel (IP) To Body Harness Connector) (07-06-04-019F)
- Low Beam Headlamp Bulb Diagnosis/Replacement (Inspect Bulb And Connector) (10-08-42-001E)
- Crank No Start After Hot Soak (PI1462)
- Intermittent No Crank/No Start, No Module Communication, Mil, Warning Lights, Vehicle Messages Or DTCS Set By Various Control Modules - Diagnosing And Repairing Fretting Corrosion (Disconnect Affected Connector And Apply Dielectric Lubricant) (09-06-03-004E)
- Reducing Electrical Intermittents - Recrimping Electrical Connectors and Inspection of Related Wiring Harness Connections When Diagnosing Miscellaneous DTCs, Intermittent Driveability Concerns, Hard Start, No Start, Incorrect Gauges, Inoperative I/C Systems, ECM, TCM, SES/4WD Lamps Illuminated (08-06-03-009A)
- Information on Importance of Using GM-Approved Terminal Probe Test Kit (J 35616) to Diagnose Electrical Concerns (07-00-89-060)
- Information on Parts Restriction on Hybrid Propulsion System Components (SGCM, MGU, Battery, BDU, Generator, Pump Driver) (07-06-01-005A)
- Essential Service Tool Update #8 (U.S. Retailers Only) (06-00-89-049)
- Body Interior
- Diagnostic Tip - SPS Programming SATURN Vehicles (PIC6533)
- Information On Changes To SPS That Warn/Prohibit Reprogramming A Module With Its Current Calibration (17-NA-242)
- Diagnostic Tip: Diagnosing Vehicles With ONSTAR DTC B101D-37 (PIC5492E)
- Gm Of CANADA ONSTAR® Cellular Communication Upgrade (15-08-44-001H)
- Rear Window Defogger - Broken Heating Grid Detection Method (04-08-48-001D)
- Required Return Criteria of Complete Electrical Center (EC) and Body Control Module (BCM) with Integrated Electrical Center to Warranty Parts Center (WPC) (05-08-45-002E)
- Information on Body Control Module (BCM) Functionality Across Vehicle Lines (09-08-47-002)
- OnStar® Labor Operation Codes (05-08-46-005C)
- Brakes Control Systems
- Charging Systems
- (Hybrid) Emergency First Responder Information (PIT4610F)
- Cold Start Drive Belt TENSIONER Rattle At Low Rpm - Possible Characteristic (PIP4176A)
- Intermittent No Crank/No Start, No Module Communication, Mil, Warning Lights, Vehicle Messages Or DTCS Set By Various Control Modules - Diagnosing And Repairing Fretting Corrosion (Disconnect Affected Connector And Apply Dielectric Lubricant) (09-06-03-004E)
- Diagnosing Accessory Drive Belt / Serpentine Belt Noise and Availability and Use of Kent-Moore EN-49228 Laser Alignment Tool - Drive Belt (08-06-01-008A)
- Low Voltage Display on IP Gauge, Lights Dim at Stop Lights, Battery Discharged, No Start, Slow Cranking, Dim Lights at Idle, Low Generator Output (43-64-07A)
- Communication Devices
- Information On Communication With ONSTAR Module After CANADIAN Cellular Upgrade (15-08-73-001A)
- Diagnostic Tip: Unable To Connect To ONSTAR Or Connects Failed To Voice (PIT5389F)
- Requirements For ONSTAR Over The Air Programming And Updates (PIC6107A)
- Diagnostic Tips: XM Audio Traffic And Travel Link Availability And Operation (PIT5353C)
- Diagnostic Tip: Apple Device Connectivity Issues Due To USB Cord Concern (PIT5399A)
- ONSTAR Will Not Power Up (PIC5491K)
- Questionnaire For BLUETOOTH Related Concerns (PIC5932B)
- Normal Characteristic - ONSTAR Power Consumption (PIC4935F)
- Diagnostic Tip - ONSTAR Turn By Turn /TBT Feature Inoperative (PIC4801H)
- ONSTAR- Unwanted Or Phantom Phone Calls (PIC3278G)
- Programming And Activation Of Replacement ONSTAR Modules (VCIM) (PIC5588C)
- Diagnostic Tip: Diagnosing Vehicles With ONSTAR DTC B101D-37 (PIC5492E)
- Gm Of CANADA ONSTAR® Cellular Communication Upgrade (15-08-44-001H)
- Off Route Message During ONSTAR Turn By Turn Operation (PIC5374D)
- No Connect With Disabled Vehicle Or Dropped Calls With 1234567890 Min (PIC5050A)
- Information On Coax Repair Kit Availability (PI0572C)
- Behavior Of Non-Upgraded ONSTAR® Equipped Vehicles Operating In CANADA After Decommissioning Of 2G CDMA Cellular Networks (16-NA-025)
- ONSTAR® System Inoperative After Over-The-Air Update (U.S. Dealers Only) (PI1540)
- Diagnostic Tip: BLUETOOTH Connectivity Issues After Software Update (PIT5468)
- Caller Id Unavailable After ONSTAR Upgrade (PIT5464)
- Various Electrical Concerns (15-08-45-001)
- Unable To Receive Incoming ONSTAR Or HFC (Hands Free Calling) Calls (PIC6101)
- Diagnostic Tip: Unable To Connect Or Use Hands Free Calling Or No Data On The Call (Failed To Voice) (PIC4310L)
- Language Change For ONSTAR® System (U.S. And CANADA Only) (05-08-46-009D)
- Diagnostic Tip: CANADIAN ONSTAR Subscriber Unable To Receive Turn-By-Turn Directions While Traveling In The United States (PIT5264C)
- Information On Aftermarket Device Interference With ONSTAR® Diagnostic Services (08-08-46-004A)
- OnStar® Phone Number Concerns (Phone Number Incorrect/Assigned to Another Vehicle/Phone) That Occur During Diagnosis of OnStar® System (05-08-46-004C)
- Availability of OnStar® for Hearing Impaired (06-08-46-005B)
- Audio Whine Noise from Radio Speakers When Using OnStar® (Install Noise Suppression Filter) (07-08-46-002D)
- GM Training - July 2009 New Course Information (For U.S. Dealers and Aftermarket) (09-00-89-031)
- Information Required Before Contacting GM Technical Assistance or When Ordering Replacement OnStar® VCIM (09-08-46-003)
- OnStar® Labor Operation Codes (05-08-46-005C)
- Information on Verifying OnStar® System Function During Pre-Delivery Inspection (PDI) (06-08-46-006B)
- Information on OnStar® Dual-Mode (Analog/Digital) Systems (06-08-46-008C)
- Re-establishing Communications with OnStar® Center After Battery Disconnect (00-08-46-004C)
- Availability of GM OnStar® Vehicle Diagnostics and GM Goodwrench® Remote Diagnostic Services (06-08-46-002B)
- Incorrect OnStar® Global Positioning System (GPS) Location Reported During OnStar® Call (02-08-46-006C)
- Information on OnStar® Dual-Mode (Analog/Digital) Systems (06-08-46-008A)
- Information On ONSTAR System - Possible Loss Of GPS Signal, Hands-Free Calling Minutes Expire Prematurely And/Or Inability To Add Hands-Free Calling Minutes (02-08-46-007D)
- Diagnostic Information For a Universal Home Remote (UHR) System That Is Not Operating and J 41450 HomeLink Tester Is Not Communicating With UHR Module (07-08-97-001)
- Cooling System (Mechanical)
- Information On Ethylene Glycol In Transmission Fluid (08-07-30-035I)
- Unscheduled Supplemental Services (Including Flushing Services And Additives) And Proper Use Of Gm Simplified Maintenance Schedules (12-06-01-008B)
- Coolant Leaking from Engine (Replace Coolant Crossover Pipe Gaskets) (07-06-20-006B)
- Essential Service Tool Update #3 (U.S. Retailers Only) (08-00-89-023)
- DEX-COOL® Coolant - New Leak Detection Dye J 46366 - Replaces J 29545-6 (05-06-02-002B)
- Revised Thermostat Housing Bolt/Stud Tightening/Torque Specification (07-06-02-007)
- Unnecessary Engine Crankcase and Subsystems Flushing Services and Proper Utilization of Saturn Simplified Maintenance Schedule to Enhance Customer Service Experience (04-00-90-004A)
- Essential Service Tool Update #8 (U.S. Retailers Only) (06-00-89-049)
- Engine Coolant Recycling and Warranty Information (00-06-02-006D)
- Cruise Control Systems
- Differentials & Drive Axles
- Driveshaft & Universal Joints
- Electronic Steering
- Information for Normal Operating Characteristics of Electric Power Steering (EPS) System During Extended Lock-to-Lock Turns or When Held at Maximum Steering Wheel Rotation and/or DTCs C0176 and C0476 Set (06-02-32-002D)
- GM Training - April 2009 New Course Information (For U.S. Dealers and Aftermarket) (09-00-89-020)
- Electronic Suspension
- Engine Control Systems
- Information On Sag Or Hesitation On Acceleration (PIP4112S)
- SES Light Due To A P1174 DTC - Perform Injector Test With AFIT (Ch47976) (PIP4017C)
- (Hybrid) Emergency First Responder Information (PIT4610F)
- DTCS U0111 And U1897 After 07141 BECM Reprogram (PIP4288A)
- Mil On With DTC P0016 And/Or P0017 Setting On A Properly Timed Engine Or Crank No Start (PIP4548G)
- SES Light With Fuel Trim And Or Oxygen Sensor Codes (PIP4925B)
- Intermittent Malfunction Indicator Lamp (Mil) Illuminated, DTC P2138 With Reduced Engine Power (Repair Instrument Panel (IP) To Body Harness Connector) (07-06-04-019F)
- Information On Changes To SPS That Warn/Prohibit Reprogramming A Module With Its Current Calibration (17-NA-242)
- Prior To Any Circuit Testing (PIP5094A)
- Various Electrical Concerns (15-08-45-001)
- Crank No Start After Hot Soak (PI1462)
- Control Module Diagnostic Trouble Code(S) (DTC)(S) P0601, P0602, P0603, P0604, P0606, P062F, P1621, P16F3 Shared In Multiple Modules (05-06-04-060A)
- Deceleration Misfire On All Cylinders 1400 Rpm To 1800 Rpm Diagnosis (PIP5264)
- Malfunction Indicator Lamp (Mil) Illuminated, Reduced Engine Power Message Displayed, DTC P2135 Set (12-06-04-003A)
- Vehicle Software Enhancements (13-00-89-003)
- Information - Non-Gm Parts And Accessories (Aftermarket) (04-06-04-054D)
- Identifying Aftermarket Engine and Transmission Calibrations 2.0L, 2.2L, 2.4L, 2.8L, 2.9L, 3.0L, 3.1L, 3.2L, 3.4L, 3.5L, 3.6L, 3.8L, 3.9L, 4.2L, 4.3L, 4.4L, 4.6L, 4.8L, 5.0L, 5.3L, 5.7L, 6.0L, 6.2L, 7.0L, 7.4L, 8.1L Gas Powered Engines Only and 6T40/45 (MH8), 6T70/75 (MH2, MH4, MH6, MY9), 6L50 (MYB) 6L80 (MYC) or 6L90 (MYD) Automatic Transmission (08-06-04-033D)
- 6T70/6T75 Transmission - Check Engine Light On, Poor Vehicle Performance, DTCs P1825 and P1915 Set (Bulletin Canceled) (07-07-30-026A)
- Information to Avoid Damaging EVAP Canister and Setting DTCs P0442/P0455 When Hoisting Vehicle (05-06-04-004E)
- 4T45 Transmission, Mil/SES On, DTC P1818, Power Door Locks, Cruise Control, Shift Interlock Or Retractable Hardtop Inoperative, Engine Speed Revs Limited, Hybrids-AUTOSTOP, REGEN Or Boost Inoperative (Reprogram TCM) (07-07-30-005C)
- Fuel Gauge Does Not Read Correctly, Fuel Gauge Stuck, Check Engine Light On, DTC P0455, P0461 Set (Reposition Fuel Vapor Line) (09-06-04-007A)
- Warranty Coverage for Emission-Related Reprogramming Events (PCM, ECM and TCM) (4-06-04-036E)
- Information on Parts Restriction on Hybrid Propulsion System Components (SGCM, MGU, Battery, BDU, Generator, Pump Driver) (07-06-01-005A)
- Essential Service Tool Update #7 (U.S. Retailers Only) (06-00-89-046)
- Entertainment Systems
- Diagnostic Tips: XM Audio Traffic And Travel Link Availability And Operation (PIT5353C)
- Diagnostic Tip: Apple Device Connectivity Issues Due To USB Cord Concern (PIT5399A)
- Questionnaire For BLUETOOTH Related Concerns (PIC5932B)
- Programming And Activation Of Replacement ONSTAR Modules (VCIM) (PIC5588C)
- Information On Inappropriate Warranty Claims Submitted For Damaged Radios And Instrument Panel Clusters (IPCS) (08-08-44-015H)
- XM Band Not Receiving All Channels (Preview Mode) (PIC5088F)
- XM Weather, Traffic, Or Travel Link Displaying Dashes, No Data Or Updating Message At Startup (PIC4707E)
- Information On Coax Repair Kit Availability (PI0572C)
- Return Or Reimbursement Of Customer Owned CDS, DVDS Or Navigation Discs (05-08-44-024E)
- Various Electrical Concerns (15-08-45-001)
- Electronic Component Exchange Program Update (U.S. And CANADA Only) (03-00-89-013H)
- Information On Inadvertent Steering Wheel Control (SWC) Button Press Causing Radio Anomalies (08-08-44-028A)
- Information On Eliminating Noise In Audio System When Using Portable Playback Device (06-08-44-015C)
- Popping and/or Reduced Audio on AM Radio Stations When Radio is Powered Up or Turned On (Verify Condition/Replace and Reprogram Radio Using SPS) (10-08-44-002)
- Water Leak in Trunk Area of Vehicle/Possible No Audio from Radio (Apply Seam Sealer) (09-08-57-004B)
- Information on Availability of Service Parts for GM Accessory DVD Headrest Systems (09-08-44-016)
- Audio Whine Noise from Radio Speakers When Using OnStar® (Install Noise Suppression Filter) (07-08-46-002D)
- Negative Impact of Dealer-Installed Cloth/Vinyl Roofs on XM Radio and/or OnStar® Systems (02-08-44-007D)
- Rattle Noise From Rear Window Shelf (Align Speaker Mounting Tabs) (09-08-59-001)
- GM Training - April 2009 New Course Information (For U.S. Dealers and Aftermarket) (09-00-89-020)
- Changes to XM Network of Terrestrial Repeaters (08-08-46-006)
- Information on Refurbish Instead of Replace Out of Warranty Radios with Worn Graphics on Faceplate, Knobs or Buttons (08-08-44-026)
- Parts Restriction on Ordering XM Digital Radio Receiver (04-08-44-009A)
- Information On Radio And Instrument Panel Cluster (IPC) Parts Restrictions (U.S. Only) (08-08-44-011)
- Utilizing Tech 2® To Retrieve Part Numbers for Radios, Compact Disc (CD) Changers and Instrument Panel Clusters (IPC) (04-08-44-005C)
- Intermittent Poor Radio Reception (Reprogram Radio) (07-08-44-006A)
- Information on Rear Seat Headphone Foam Ear Pad Replacement if Worn or Damaged (05-08-44-005A)
- Information on Radio and Instrument Panel Cluster (IPC) Part Restrictions (U.S. Only) (06-00-89-038)
- Saturn Aura, ION, Relay, Sky and VUE Radio Receiver Ordering Process (05-08-44-007C)
- Exhaust
- Exterior Body Panels
- Underbody Component Corrosion (PI0281L)
- Hem Flange Rust Repair (02-08-98-002H)
- Intermittent Malfunction Indicator Lamp (Mil) Illuminated, DTC P2138 With Reduced Engine Power (Repair Instrument Panel (IP) To Body Harness Connector) (07-06-04-019F)
- Non-Approval Of "Clipping" (Sectioning Of Two Vehicles) For Collision Repair (07-08-98-001B)
- Information On Drilling High Strength Steel Related To Collision Repair (10-08-98-002A)
- Information On Hem Flange Sealer For Corrosion Protection (06-08-51-005C)
- Corrosion Protection For Metal Panels With Dealer Installed Accessories Fastened By Drilled Holes (03-00-89-008F)
- Squeeze Type Resistance Spot Welding/Equipment (03-08-98-002B)
- Water Leak in Trunk Area of Vehicle/Possible No Audio from Radio (Apply Seam Sealer) (09-08-57-004B)
- Difficulty Filling Fuel Tank, MIL/SES Light Illuminated DTC P0446 - Evaporative Emissions (EVAP) Vent System Performance (Inspect/Clean EVAP Canister Vent Valve Solenoid and Install Screen) (07-06-04-023A)
- GM Training - Changes to Saturn Service Training Standards (STS) Requirements for 2009 and 2010 (U.S. Dealers) (09-00-89-021)
- Corrosion on Rear Compartment Lid Lower Edge, Rust-Colored Stains on Rear Bumper (Repair Corrosion, Refinish As Required) (09-08-66-002)
- Information on Fuel Filler Door Spring Assembly Replacement (07-08-66-001)
- Metal Panel Bonding (02-08-98-001C)
- Urethane Adhesives For Stationary Glass And Other Applications (02-08-48-001A)
- Exterior Lights
- Exterior Lighting Components "Tinted Or Smoked" By An Outside Vendor (15-08-42-001A)
- Various Electrical Concerns (15-08-45-001)
- Low Beam Headlamp Bulb Diagnosis/Replacement (Inspect Bulb And Connector) (10-08-42-001E)
- Intermittently Brake Lights (Stop Lamps) Do Not Function Correctly, Extended Travel To Shift Out Of Park, Cruise Control Inoperative, DTCS C0131, C0161 Or C0277 Set (Bulletin Canceled) (08-05-22-009D)
- Headlamp, Tail Lamp, License Lamp Or Fog/Driving Lamp Damage (02-08-42-001J)
- Condensation/Moisture/Water in Tail Lamps (Replace Affected Tail Lamp Capsule) (09-08-42-001)
- Low Voltage Display on IP Gauge, Lights Dim at Stop Lights, Battery Discharged, No Start, Slow Cranking, Dim Lights at Idle, Low Generator Output (43-64-07A)
- Frames, Subframes & Crossmembers
- Underbody Component Corrosion (PI0281L)
- Information On Drilling High Strength Steel Related To Collision Repair (10-08-98-002A)
- Non-approval of "Clipping" (Sectioning of Two Vehicles) For Collision Repair (07-08-98-001A)
- Essential Service Tool Update #3 (U.S. Retailers Only) (07-00-89-010)
- Information on Repair of Polypropylene Energy Absorbers (63-20-02)
- Front Suspension
- Fuel System
- Top Tier™ Detergent Gasoline And Top Tier™ Diesel Fuel Information And Licensed Brands (05-06-04-022Q)
- SES Light Due To A P1174 DTC - Perform Injector Test With AFIT (Ch47976) (PIP4017C)
- Rough Idle Crank No Start Extended Crank Or Misfire Due To Excessive Carbon On Top Of The Valves Or Sticking Valves (PIP5029H)
- Usage Of E85 Fuel In Gm Vehicles (05-06-04-035E)
- Cylinder 1 Miss On Left Turns And Cylinder 4 Miss On Right Turns - Possible Fuel Contamination (PIP3333C)
- Fuel And Oil Additives - Facts And Myths - Maximizing Gasoline Fuel Economy (05-00-89-072F)
- Top Tier Detergent Gasoline (Deposits, Fuel Economy, No Start, Power, Performance, Stall Concerns) - U.S. Only (04-06-04-047L)
- Gm Fuel System Treatment Plus, Fuel Sending Unit Corrosion And Fuel System Deposits (05-00-89-078C)
- General Motors' Position Regarding Use of E 15 in Model Year 2007 and Newer Vehicles (10-06-04-015)
- Information to Avoid Damaging EVAP Canister and Setting DTCs P0442/P0455 When Hoisting Vehicle (05-06-04-004E)
- Essential Service Tool Update #4 (U.S. Retailers Only) (08-00-89-025)
- Essential Service Tool Update #3 (U.S. Retailers Only) (08-00-89-023)
- Use of E85 Fuels in Vehicles Not Certified by GM as being FlexFuel Compatible / Aftermarket Conversion of Vehicles to Operate on E85 Fuels (06-06-04-035A)
- Unnecessary Engine Crankcase and Subsystems Flushing Services and Proper Utilization of Saturn Simplified Maintenance Schedule to Enhance Customer Service Experience (04-00-90-004A)
- Essential Service Tool Update #8 (U.S. Retailers Only) (06-00-89-049)
- Fuses & Circuit Breakers
- Crank No Start After Hot Soak (PI1462)
- Intermittent No Crank/No Start, No Module Communication, Mil, Warning Lights, Vehicle Messages Or DTCS Set By Various Control Modules - Diagnosing And Repairing Fretting Corrosion (Disconnect Affected Connector And Apply Dielectric Lubricant) (09-06-03-004E)
- Essential Service Tool Update # 8 (U.S. Retailers Only) (07-00-89-061)
- Information on Importance of Using GM-Approved Terminal Probe Test Kit (J 35616) to Diagnose Electrical Concerns (07-00-89-060)
- Service Alert: Concerns With Aftermarket Fuses in GM Vehicles (07-08-45-002)
- Driver's Power Seat Adjuster Inoperative, DRV ST Fuse #2 Open (Repair Seat Wiring Harness) (07-08-50-003)
- Gauges & Instrument Panels
- Interior Cleaning - Instrument Panel (IP), Hard Or Plastic Surfaces, Seats, Carpet, Leather, Vinyl, Fabric Cleaner, Stain Remover, Restorer - Product Availability (06-00-89-029W)
- Verifying Odometer Accuracy (PIC3100G)
- IPC Odometer Programming Method Quick Reference Guide (07-08-49-020O)
- Information On Inappropriate Warranty Claims Submitted For Damaged Radios And Instrument Panel Clusters (IPCS) (08-08-44-015H)
- Various Electrical Concerns (15-08-45-001)
- Fuel Gauge Does Not Read Correctly, Fuel Gauge Stuck, Check Engine Light On, DTC P0455, P0461 Set (Reposition Fuel Vapor Line) (09-06-04-007A)
- Trunk Ajar Displayed in DIC with Trunk Closed, Increased Rear Compartment Lid Closing Effort (Adjust Rear Compartment Latch And Lid) (09-08-66-001)
- Reducing Electrical Intermittents - Recrimping Electrical Connectors and Inspection of Related Wiring Harness Connections When Diagnosing Miscellaneous DTCs, Intermittent Driveability Concerns, Hard Start, No Start, Incorrect Gauges, Inoperative I/C Systems, ECM, TCM, SES/4WD Lamps Illuminated (08-06-03-009A)
- Information On Radio And Instrument Panel Cluster (IPC) Parts Restrictions (U.S. Only) (08-08-44-011)
- Utilizing Tech 2® To Retrieve Part Numbers for Radios, Compact Disc (CD) Changers and Instrument Panel Clusters (IPC) (04-08-44-005C)
- PRNDL Display Reduced Visibility For Approximately One Minute (02-08-72-004A)
- Information on Radio and Instrument Panel Cluster (IPC) Part Restrictions (U.S. Only) (06-00-89-038)
- Saturn Aura, ION, Relay, Sky and VUE Instrument Panel Cluster Ordering Process (05-08-49-009D)
- General Servicing
- Headlights
- Exterior Lighting Components "Tinted Or Smoked" By An Outside Vendor (15-08-42-001A)
- Low Beam Headlamp Bulb Diagnosis/Replacement (Inspect Bulb And Connector) (10-08-42-001E)
- Headlamp, Tail Lamp, License Lamp Or Fog/Driving Lamp Damage (02-08-42-001J)
- Replacement of Headlamp Assemblies Under Warranty and Use of GM vs. Non-GM Headlamp Assemblies (08-08-42-005B)
- Heated Glass/Defoggers
- Hoist/Jack
- HVAC Control Systems
- Ac Blows Warm Or Poor Performance (PIT5099H)
- Eliminating Unwanted Odors In Vehicles (00-00-89-027J)
- Air Conditioning Odor (Install Evaporator Core Dryer Kit And Apply Cooling Coil Coating) (99-01-39-004I)
- Diagnostic Tips For Odor Emanating From HVAC System (PI1440)
- Whistle, Tone or High Pitched Hum Noise From HVAC in Cold/Cool Weather (Replace Blower Motor Control Processor) (09-01-39-003A)
- Essential Service Tool Update #3 (U.S. Retailers Only) (08-00-89-023)
- Information On New GE-48800 CoolTech Refrigerant Recovery/Recharge Equipment (08-01-38-001)
- 18 Digit "Snapshot/Charge Summary" Code No Longer Required For A/C Refrigerant System Repairs Submitted For Warranty Reimbursement (05-01-38-008B)
- Contaminated R134a Refrigerant Found on Market for Automotive Air-Conditioning Systems (06-01-39-007)
- Identification
- Ignition Switch/Steering Lock
- Key Code Security Rules And Information On Gm KEYCODE Look-Up Application (CANADA Only) (10-00-89-010C)
- Diagnostic Tips/Recommendations on GM Accessory 2-Way Remote Start Transmitter When Transmitter Battery is Weak or Dead (09-08-52-004A)
- Key Code Information (99-00-89-011E)
- Information on Adjusting Key Cut Depths in Exacta Key Cutting Machine (06-00-89-053A)
- Infotainment
- Questionnaire For BLUETOOTH Related Concerns (PIC5932B)
- Changing Turn-By-Turn Voice Response To Metric Or English Units (PIC5614B)
- Off Route Message During ONSTAR Turn By Turn Operation (PIC5374D)
- Information On Coax Repair Kit Availability (PI0572C)
- DVD Navigation Update Program, Navigation Disc Diagnostic Aid, AVN Software Update Discs And Ordering Information (06-08-44-012G)
- Electronic Component Exchange Program Update (U.S. And CANADA Only) (03-00-89-013H)
- Information On Navigation Radio Not Displaying Accurate Vehicle Location After Radio Replacement, Power Loss Or Battery Replacement (08-08-44-023A)
- Negative Impact of Dealer-Installed Cloth/Vinyl Roofs on XM Radio and/or OnStar® Systems (02-08-44-007D)
- GM Training - April 2009 New Course Information (For U.S. Dealers and Aftermarket) (09-00-89-020)
- Navigation Radio Diagnostic Tips (08-08-44-010F)
- Re-establishing Communications with OnStar® Center After Battery Disconnect (00-08-46-004C)
- Incorrect OnStar® Global Positioning System (GPS) Location Reported During OnStar® Call (02-08-46-006C)
- Information On ONSTAR System - Possible Loss Of GPS Signal, Hands-Free Calling Minutes Expire Prematurely And/Or Inability To Add Hands-Free Calling Minutes (02-08-46-007D)
- Information on Obtaining Replacement Navigation Discs When Radios are Exchanged - Order Replacement Navigation Disc Through Navigation Disc Center (07-08-44-007)
- Interior/Exterior Trim
- Eliminating Unwanted Odors In Vehicles (00-00-89-027J)
- Corrosion Protection For Metal Panels With Dealer Installed Accessories Fastened By Drilled Holes (03-00-89-008F)
- Information on Discoloration, Blistering, Peeling or Erosion of Various Exterior Emblems Including Chevy Bowtie (Bulletin Cancelled) (06-08-111-004B)
- Information on Maintaining Exterior Weatherstrip Appearance (99-08-64-016C)
- Negative Impact of Dealer-Installed Cloth/Vinyl Roofs on XM Radio and/or OnStar® Systems (02-08-44-007D)
- Windshield Pillar Garnish Molding Loose (Replace Retainer) (09-08-110-004A)
- Rattle Noise From Rear Window Shelf (Align Speaker Mounting Tabs) (09-08-59-001)
- Front Door Trim Separates Between Pull Cup and Switch Plate (Install Tie Strap) (08-08-64-017)
- Left Side Instrument Panel (IP) Storage Compartment Door May Not Latch When Pushed Closed (Replace IP Storage Compartment Latch) (07-08-49-021A)
- Poor Fit/Bowing of Trim on Either Side of Rear Glass (Trim Lower Garnish Molding and/or Reposition Wire Harness) (07-08-53-003)
- Left Side Instrument Panel (IP) Storage Compartment Door May Not Latch When Pushed Closed (Replace IP Storage Compartment Latch) (07-08-49-021)
- IP/Dash Trim Misalignment (Loosen and Realign) (07-08-110-003)
- Interior/Illumination Lights
- Lubrication System
- Unscheduled Supplemental Services (Including Flushing Services And Additives) And Proper Use Of Gm Simplified Maintenance Schedules (12-06-01-008B)
- Information On Internal Engine Noise Or Damage After Oil Filter Replacement (07-06-01-016J)
- Information For Engine Concerns Resulting From Lack Of Scheduled Maintenance, Improper Service Or Aftermarket Calibrations (16-NA-222)
- Engine Ticking Noise Or Oil Pressure Fluctuation On Cold Start (PIP5191C)
- Fuel And Oil Additives - Facts And Myths - Maximizing Gasoline Fuel Economy (05-00-89-072F)
- Diagnostic Information On Internal Engine Noise Or Damage After Oil Filter Replacement (10-06-01-003C)
- Global Information For Gm DEXOS 1™ And DEXOS 2™, Engine Oil Specifications, Licensed Brands, And Service Fill (11-00-90-001B)
- 60 Degree V6 Engine Oil Leak at Crankshaft Front Oil Seal (Use New Crankshaft Front Oil Seal Installer Tool EN-48869) (07-06-01-023)
- Unnecessary Engine Crankcase and Subsystems Flushing Services and Proper Utilization of Saturn Simplified Maintenance Schedule to Enhance Customer Service Experience (04-00-90-004A)
- Essential Service Tool Update #8 (U.S. Retailers Only) (06-00-89-049)
- Manual Steering
- Unscheduled Supplemental Services (Including Flushing Services And Additives) And Proper Use Of Gm Simplified Maintenance Schedules (12-06-01-008B)
- Cold Start Drive Belt TENSIONER Rattle At Low Rpm - Possible Characteristic (PIP4176A)
- Vibration Analysis Worksheet (03-00-91-001I)
- Diagnostic Tips/Recommendations When Power Steering Pump Replacement is Necessary (06-02-32-013B)
- Diagnosing Accessory Drive Belt / Serpentine Belt Noise and Availability and Use of Kent-Moore EN-49228 Laser Alignment Tool - Drive Belt (08-06-01-008A)
- EI08118 - Power Steering Whine/Growl Noise (Bleed Power Steering System) (08-02-32-004B)
- Essential Service Tool Update #1 (U.S. Retailers Only) (07-00-89-002)
- Unnecessary Engine Crankcase and Subsystems Flushing Services and Proper Utilization of Saturn Simplified Maintenance Schedule to Enhance Customer Service Experience (04-00-90-004A)
- Manual Trans
- Mechanical
- Information On Internal Engine Noise Or Damage After Oil Filter Replacement (07-06-01-016J)
- Engine Repair Tip For Installation Of Pistons (PI1394B)
- Information For Engine Concerns Resulting From Lack Of Scheduled Maintenance, Improper Service Or Aftermarket Calibrations (16-NA-222)
- Diagnostic Tips For Knocking, Rattle, Squeak And/Or Squeal Type Noise From Engine - Engine Replacement Recommendations For HFV6 Gen 1 And Gen 2 (PIP5216G)
- Engine Ticking Noise Or Oil Pressure Fluctuation On Cold Start (PIP5191C)
- Whine Noise From Timing Chain Area (PIP3535D)
- OEM And Remanufactured Engine And Automatic Transmission/Transaxle Identification (06-00-89-031E)
- Information On Close-Coupled Converter And Engine Replacement (06-06-01-010D)
- Automatic Transmission Shift And Engine DRIVEABILITY Concerns And/Or Mil On Due To Aftermarket Oil Bath Air Filter Use (04-07-30-013D)
- Rough Idle Crank No Start Extended Crank Or Misfire Due To Excessive Carbon On Top Of The Valves Or Sticking Valves (PIP5029H)
- Abnormal Noise And Or Vibration While Driving Due To Non-Gm Aftermarket Accessory (PIP3140G)
- Engine Squealing Type Noise On Start-Up Or Vibration Or Intermittent Loss Of Accessory Drive (08-06-01-006E)
- Dealer Reimbursement Procedures For CAC Tier 1 And Tier 2 Empowerment Tools: Diagnostic Fee, Short Term Rental, And Up-Front Towing (U.S. Only) (15-00-89-003)
- Global Information For Gm DEXOS 1™ And DEXOS 2™, Engine Oil Specifications, Licensed Brands, And Service Fill (11-00-90-001B)
- Vibration Analysis Worksheet (03-00-91-001I)
- Hydraulic Versus Mechanical TENSIONERS (TT001-13)
- Hybrid - TENSIONER Primary Accessory Drive - Pulley Bearing Noise, Rattle Or Squeal - Spring TENSIONER Shoulder Bolt Or Bracket Pivot Bolt Fatigue (Replace Drive Belt TENSIONER) (09-06-01-009B)
- Diagnosing Accessory Drive Belt / Serpentine Belt Noise and Availability and Use of Kent-Moore EN-49228 Laser Alignment Tool - Drive Belt (08-06-01-008A)
- Essential Service Tool Update #4 (U.S. Retailers Only) (08-00-89-025)
- Essential Service Tool Update # 8 (U.S. Retailers Only) (07-00-89-061)
- Essential Service Tool Update #7 (U.S. Retailers Only) (07-00-89-053)
- Essential Service Tool Update #5 (U.S. Retailers Only) (07-00-89-032)
- GM Performance Parts Engine Warranty Q & A (04-06-01-019A)
- Essential Service Tool Update #3 (U.S. Retailers Only) (07-00-89-010)
- Essential Service Tool Update #2 (U.S. Retailers Only) (07-00-89-008)
- Essential Service Tool Update #1 (U.S. Retailers Only) (07-00-89-002)
- Unnecessary Engine Crankcase and Subsystems Flushing Services and Proper Utilization of Saturn Simplified Maintenance Schedule to Enhance Customer Service Experience (04-00-90-004A)
- Essential Service Tool Update #8 (U.S. Retailers Only) (06-00-89-049)
- Mechanical - Hydraulic
- Abnormal Noise And Or Vibration While Driving Due To Non-Gm Aftermarket Accessory (PIP3140G)
- Brake Lathe Calibration Procedure (VSS20040074)
- Vibration Analysis Worksheet (03-00-91-001I)
- Information On Resurfacing Park Brake Portion Of Rear Brake Rotor (12-05-26-001)
- Disc Brake Warranty Service and Procedures - Lateral Runout (LRO), Rotor Pulsation, Pads, Wear, Noise, Refinish, Clean-up, Corrosion, Squeak, Grind, Groan (05-05-22-002E)
- GM Training - April 2009 New Course Information (For U.S. Dealers and Aftermarket) (09-00-89-020)
- Brake Align® System for Brake Rotor Lateral Runout Correction (01-05-23-001B)
- Essential Service Tool Update #5 (U.S. Retailers Only) (07-00-89-032)
- Brake Rotor/Drum Refinishing Labor Operations (06-05-22-007)
- Mirrors
- Paint & Coatings
- Hem Flange Rust Repair (02-08-98-002H)
- Refinishing Aluminum And Chrome Wheels (99-08-51-007G)
- Application Of Anti-Corrosion Materials (01-08-51-003E)
- Information On Hem Flange Sealer For Corrosion Protection (06-08-51-005C)
- Pre-Painting/Cleaning Process For TPO Plastic Fascias (08-08-51-002A)
- Corrosion Protection For Metal Panels With Dealer Installed Accessories Fastened By Drilled Holes (03-00-89-008F)
- Water Leak in Trunk Area of Vehicle/Possible No Audio from Radio (Apply Seam Sealer) (09-08-57-004B)
- Bumps or Rust Colored Spots in Paint Due to Rail or Iron Dust (Remove Rail Dust) (43-17-01B)
- Corrosion on Rear Compartment Lid Lower Edge, Rust-Colored Stains on Rear Bumper (Repair Corrosion, Refinish As Required) (09-08-66-002)
- Parking Brake System
- Passive Restraints
- Rear Suspension
- Restraints Control Systems
- Information On Passenger Presence Sensing System (PPS Or PSS) Concerns With Custom Upholstery, Accessory Seat Heaters Or Other Comfort Enhancing Devices (06-08-50-009J)
- Information On Changes To SPS That Warn/Prohibit Reprogramming A Module With Its Current Calibration (17-NA-242)
- Diagnostic Information For Supplemental Inflatable Restraint (Sir) System, Intermittent Air Bag Indicator/Lamp Illuminated With DTC(S) B0012, B0013, B0015, B0016, B0019, B0020, B0022, B0023, B0026, B0033, B0040, B0042 Or B0044 Set (Inspect And Replace Connector Position Assurance (CPA) Retainer) (08-09-41-002H)
- Prior To Any Circuit Testing (PIP5094A)
- Seat Belt Buckle Latching Issues And/Or Seat Belt Warning Lights Illuminated (09-09-40-001C)
- Vehicle Software Enhancements (13-00-89-003)
- Replacement Conversion Of Passenger Presence System (PPS), Supplemental Inflatable Restraints (Sir) Indicator/Lamp On, DTC B0081 Set (Replace Passenger Presence System (PPS), Revise Seat Wiring Harness) (10-09-41-003A)
- Airbag Light On, DTC B0071 and B0081 Set (Diagnose and Replace Right Front Seatbelt Buckle, If Necessary) (07-09-41-010D)
- Airbag Readiness Light ON with DTC B0081 or B0092 Set in Passenger Presence System (PPS) SDM (Remove Passenger Seat Cushion Cover and Allow to Dry) (06-09-41-008C)
- Seats
- Information On Passenger Presence Sensing System (PPS Or PSS) Concerns With Custom Upholstery, Accessory Seat Heaters Or Other Comfort Enhancing Devices (06-08-50-009J)
- Eliminating Unwanted Odors In Vehicles (00-00-89-027J)
- Seat Belt Extender Availability (99-09-40-005H)
- Various Electrical Concerns (15-08-45-001)
- Information On Driver Or Passenger Seat Head Restraint Concerns With Comfort, Custom Upholstery Or Other Comfort Enhancing Devices (10-08-50-003A)
- Unable to Remove Front Seat Mounting Bolt (10-08-50-002A)
- Warranty Admin - Front Seat Cushion Frame Replacement and Front Seat Back Frame Replacement Labor Operations C6060 and C6068 (07-08-50-006)
- Driver's Power Seat Adjuster Inoperative, DRV ST Fuse #2 Open (Repair Seat Wiring Harness) (07-08-50-003)
- Starter
- Cold Weather And Long Stand Time Battery Maintenance And Testing Tips (15-06-03-001F)
- Warranty Administration - Battery Testing And Warranty Replacement Requirements (North AMERICA Only) (03-06-03-004Z)
- ACDELCO® Replacement Battery Warranty Procedures (03-06-03-003D)
- Various Intermittent Electrical Concerns - Door Ajar Message, Interior Lights On, Theft Deterrent Alarm, Retained Accessory Power (RAP) Stays On, Discharged Battery (Diagnose/Repair Door Lock Assembly/Circuit) (09-08-64-022A)
- Battery Part Restriction Program Effective March 1st, 2008 (08-06-03-002C)
- Diagnostic Tips/Recommendations on GM Accessory 2-Way Remote Start Transmitter When Transmitter Battery is Weak or Dead (09-08-52-004A)
- GM Accessories: 2-Way Advanced Remote Start Systems Part Information (09-00-89-025A)
- Reducing Electrical Intermittents - Recrimping Electrical Connectors and Inspection of Related Wiring Harness Connections When Diagnosing Miscellaneous DTCs, Intermittent Driveability Concerns, Hard Start, No Start, Incorrect Gauges, Inoperative I/C Systems, ECM, TCM, SES/4WD Lamps Illuminated (08-06-03-009A)
- Low Voltage Display on IP Gauge, Lights Dim at Stop Lights, Battery Discharged, No Start, Slow Cranking, Dim Lights at Idle, Low Generator Output (43-64-07A)
- GM Dealer Visits: Proper Management of Batteries in Dealer Parts Stock / Vehicle Inventory (08-06-03-005)
- Battery Charging Tips (Includes Information References for HP2 Hybrid Truck [PHT] 42-volt System) (02-06-03-009C)
- Vehicle Battery Maintenance While in Dealer Stock (05-06-03-007A)
- Check Engine Light On, Battery Warning Light On, DTC P1A5A and/or P1A59 Set (Inspect Hybrid Batteries for Voltage Imbalance or Corrosion, Replace Batteries, if Necessary) (07-06-03-006A)
- Information on Parts Restriction on Hybrid Propulsion System Components (SGCM, MGU, Battery, BDU, Generator, Pump Driver) (07-06-01-005A)
- Starter Cranks After Key Is Released (Normal Condition) (03-06-03-001D)
- Essential Service Tool Update #5 (U.S. Retailers Only) (07-00-89-032)
- Intermittent No Crank, No Start (03-06-03-006A)
- Steering Column
- Proper Wheel Installation And Wheel Torque Techniques (12-03-10-002A)
- Information On Inadvertent Steering Wheel Control (SWC) Button Press Causing Radio Anomalies (08-08-44-028A)
- Clunk, Knock or Rattle Noise From Front of Vehicle While Driving or Turning Over Bumps at Low Speeds (Diagnose Noise and Perform Outlined Repair) (06-02-32-007G)
- Steering Column Tilt Wheel Release Lever Inoperative/Broken (Replace Tilt Wheel Release Lever Kit and/or Release Lever Retainer (Tilt Teeth)) (09-02-35-006)
- Essential Service Tool Update # 8 (U.S. Retailers Only) (07-00-89-061)
- Steering Control Systems
- Steering Gear
- Steering Linkage
- Sun Roof/T-Top/Convertible Top
- Intermittent Sunroof Operation, Bind, Noise, Auto-Reverse, And/Or Water Leaks (PIC5260F)
- Various Electrical Concerns (15-08-45-001)
- Corrosion Protection For Metal Panels With Dealer Installed Accessories Fastened By Drilled Holes (03-00-89-008F)
- General Guide to Panoramic Sunroof Noise Issues (05-08-67-014M)
- 4T45 Transmission, Mil/SES On, DTC P1818, Power Door Locks, Cruise Control, Shift Interlock Or Retractable Hardtop Inoperative, Engine Speed Revs Limited, Hybrids-AUTOSTOP, REGEN Or Boost Inoperative (Reprogram TCM) (07-07-30-005C)
- Sunshade Will Roll Out When Panoramic Sunroof Is Closed, But Will Not Rewind When Opening Sunroof (Add Washer, Reinstall Sunshade) (09-08-67-003)
- GM Training - GM Moveable Roof Systems Hands-On (#12040.30H) (U.S. Dealers) (This is not a Saturn STS Requirement) (08-00-89-027)
- Rattle Noise From Sunroof Area When Driving Over Bumps (Install Flocking Tape and Foam Strip) (07-08-59-008A)
- Rattle Noise From Sunroof Area When Driving Over Bumps (Install Flocking Tape and Foam Strip) (07-08-59-008)
- Suspension Control Systems
- Vehicle Software Enhancements (13-00-89-003)
- TPMS System Service and Re-Learning Sensor IDs (10-03-16-001)
- Reducing Electrical Intermittents - Recrimping Electrical Connectors and Inspection of Related Wiring Harness Connections When Diagnosing Miscellaneous DTCs, Intermittent Driveability Concerns, Hard Start, No Start, Incorrect Gauges, Inoperative I/C Systems, ECM, TCM, SES/4WD Lamps Illuminated (08-06-03-009A)
- Warranty Reduction - Transfer of Tire Pressure Monitoring (TPM) Sensors to Replacement Wheels and Allowable TPM Sensor Replacements (08-03-16-003)
- Information on Correctly Setting Tire Pressure at PDI Using Tire Pressure Monitoring (TPM) System as a Reference (07-03-16-001B)
- System
- Information On Sag Or Hesitation On Acceleration (PIP4112S)
- DTCS U0111 And U1897 After 07141 BECM Reprogram (PIP4288A)
- Mil On With DTC P0016 And/Or P0017 Setting On A Properly Timed Engine Or Crank No Start (PIP4548G)
- SES Light With Fuel Trim And Or Oxygen Sensor Codes (PIP4925B)
- Automatic Transmission Shift And Engine DRIVEABILITY Concerns And/Or Mil On Due To Aftermarket Oil Bath Air Filter Use (04-07-30-013D)
- Intermittent Malfunction Indicator Lamp (Mil) Illuminated, DTC P2138 With Reduced Engine Power (Repair Instrument Panel (IP) To Body Harness Connector) (07-06-04-019F)
- Prior To Any Circuit Testing (PIP5094A)
- Usage Of E85 Fuel In Gm Vehicles (05-06-04-035E)
- Crank No Start After Hot Soak (PI1462)
- Control Module Diagnostic Trouble Code(S) (DTC)(S) P0601, P0602, P0603, P0604, P0606, P062F, P1621, P16F3 Shared In Multiple Modules (05-06-04-060A)
- Deceleration Misfire On All Cylinders 1400 Rpm To 1800 Rpm Diagnosis (PIP5264)
- Malfunction Indicator Lamp (Mil) Illuminated, Reduced Engine Power Message Displayed, DTC P2135 Set (12-06-04-003A)
- Vehicle Software Enhancements (13-00-89-003)
- Identifying Aftermarket Engine and Transmission Calibrations 2.0L, 2.2L, 2.4L, 2.8L, 2.9L, 3.0L, 3.1L, 3.2L, 3.4L, 3.5L, 3.6L, 3.8L, 3.9L, 4.2L, 4.3L, 4.4L, 4.6L, 4.8L, 5.0L, 5.3L, 5.7L, 6.0L, 6.2L, 7.0L, 7.4L, 8.1L Gas Powered Engines Only and 6T40/45 (MH8), 6T70/75 (MH2, MH4, MH6, MY9), 6L50 (MYB) 6L80 (MYC) or 6L90 (MYD) Automatic Transmission (08-06-04-033D)
- 6T70/6T75 Transmission - Check Engine Light On, Poor Vehicle Performance, DTCs P1825 and P1915 Set (Bulletin Canceled) (07-07-30-026A)
- Difficulty Filling Fuel Tank, MIL/SES Light Illuminated DTC P0446 - Evaporative Emissions (EVAP) Vent System Performance (Inspect/Clean EVAP Canister Vent Valve Solenoid and Install Screen) (07-06-04-023A)
- Fuel Gauge Does Not Read Correctly, Fuel Gauge Stuck, Check Engine Light On, DTC P0455, P0461 Set (Reposition Fuel Vapor Line) (09-06-04-007A)
- Reducing Electrical Intermittents - Recrimping Electrical Connectors and Inspection of Related Wiring Harness Connections When Diagnosing Miscellaneous DTCs, Intermittent Driveability Concerns, Hard Start, No Start, Incorrect Gauges, Inoperative I/C Systems, ECM, TCM, SES/4WD Lamps Illuminated (08-06-03-009A)
- 6T70/6T75 Transmission - Check Engine Light On, Poor Vehicle Performance, DTCs P0716, P0717, P0722, P0723, P0751, P0756, P0776, P0796, P2714 or P2723 Set (Diagnose and Repair per SI) (07-07-30-019B)
- Diagnostic Trouble Codes (DTCs) Required On Repair Orders (06-00-89-050B)
- LAT, BAS, Engine Runs Rough Cold, Misfire, MIL/SES Light Illuminated, DTCs P0300, P0301, P0302, P0303, P0304 (Replace All Four Fuel Injectors) (08-06-04-025)
- Check Engine Light On, Battery Warning Light On, DTC P1A5A and/or P1A59 Set (Inspect Hybrid Batteries for Voltage Imbalance or Corrosion, Replace Batteries, if Necessary) (07-06-03-006A)
- Information On 4T40-E (MN4) and 4T45-E (MN5) Front Wheel Drive Automatic Transmission Valve Body Reconditioning, DTC P0741, P0742, P0751, P0752, P0756, P0757, P1811, Harsh Shifts, Slips, No Drive, No Reverse (07-07-30-025)
- Normal Characteristics of Malfunction Indicator Lamp (MIL) During On-Board Diagnostic (OBD) Inspection/Maintenance (I/M) Testing (06-06-04-037)
- Towing
- Towing Systems
- Transmission Control Systems
- Information On Changes To SPS That Warn/Prohibit Reprogramming A Module With Its Current Calibration (17-NA-242)
- Prior To Any Circuit Testing (PIP5094A)
- Control Module Diagnostic Trouble Code(S) (DTC)(S) P0601, P0602, P0603, P0604, P0606, P062F, P1621, P16F3 Shared In Multiple Modules (05-06-04-060A)
- Vehicle Software Enhancements (13-00-89-003)
- Identifying Aftermarket Engine and Transmission Calibrations 2.0L, 2.2L, 2.4L, 2.8L, 2.9L, 3.0L, 3.1L, 3.2L, 3.4L, 3.5L, 3.6L, 3.8L, 3.9L, 4.2L, 4.3L, 4.4L, 4.6L, 4.8L, 5.0L, 5.3L, 5.7L, 6.0L, 6.2L, 7.0L, 7.4L, 8.1L Gas Powered Engines Only and 6T40/45 (MH8), 6T70/75 (MH2, MH4, MH6, MY9), 6L50 (MYB) 6L80 (MYC) or 6L90 (MYD) Automatic Transmission (08-06-04-033D)
- 4T45 Transmission, Mil/SES On, DTC P1818, Power Door Locks, Cruise Control, Shift Interlock Or Retractable Hardtop Inoperative, Engine Speed Revs Limited, Hybrids-AUTOSTOP, REGEN Or Boost Inoperative (Reprogram TCM) (07-07-30-005C)
- Warranty Coverage for Emission-Related Reprogramming Events (PCM, ECM and TCM) (4-06-04-036E)
- Wheel Alignment
- Wheels & Tire System
- Guidelines When Changing Tire And Wheel Size (PIT3271P)
- Vibration Shortly After Tires Are Mounted/Preventing Vibration From Wheel Slip (Tire Sliding On Wheel) (12-03-10-001E)
- Information On Proper Tire Pressure (00-00-90-002M)
- Vehicle Vibration Diagnosis And TAC Requests For Assistance With Vibration Related Complaints (PIP5338B)
- Information On Hunter Road Force Balancer (17-NA-170)
- Non-Design Intent Wheel Lock Nuts And Lug Nuts (17-NA-126)
- Tire Slowly Goes Flat, Tire Air Loss, Low Tire Pressure Warning Light Illuminated, Aluminum Wheel Bead Seat Corrosion (Clean And Resurface Wheel Bead Seat) (08-03-10-006H)
- Information On Slight Or Mild Tire Feathering And Recommended Practices (Normal Tire Wear Condition) (07-03-10-008E)
- Information On Tire/Wheel Characteristics (Vibration, Balance, Shake, Flat Spotting) Of Gm Original Equipment Tires (03-03-10-007J)
- Abnormal Noise And Or Vibration While Driving Due To Non-Gm Aftermarket Accessory (PIP3140G)
- Various Electrical Concerns (15-08-45-001)
- Use Of Nitrogen Gas In Tires (05-03-10-020F)
- Statement On Tire Sealant Included In Gm Inflator Kits (Supplied With New Vehicles Or As Gm Accessory) (09-03-10-013B)
- Proper Wheel Installation And Wheel Torque Techniques (12-03-10-002A)
- Dealership Service Consultant Procedure As Vehicle Comes Into Service Drive For Tire Pressure Monitor (TPM) System Message, Light And Customer Information (09-03-16-002B)
- Wheel Balancing Machine Finish Damage To Chrome Clad Or CHROMETECH® Wheels (09-03-10-016A)
- Gm Tire Warranty Program Goodwill Guidelines (U.S. Only) (08-03-10-012B)
- 18 Inch Accessory Wheels Available Through GM Accessories (07-03-10-006D)
- General Motors New Vehicle Wheel Warranty Coverage (07-03-10-015B)
- Guidelines for Using Labor Operations E0200, E0201, E0203, E0204 - Wheel Balance (72-05-03)
- TPMS System Service and Re-Learning Sensor IDs (10-03-16-001)
- Information on Proper Wheel Changing Procedures and Cautions (06-03-10-010A)
- Low Tire Pressure, Leaking Cast Aluminum Wheels (Repair with Adhesive Sealant) (93-U-57)
- Tire Puncture Repair Procedures For All Cars and Light Duty Trucks (04-03-10-001F)
- TPM System Overview, Diagnosing Tire Pressure Monitor System (TPM) Concerns and TPM Frequently Asked Questions (FAQ) (07-03-16-004C)
- Information on Replacement Wheel Weights (09-03-10-017)
- Mounting, Balancing And Installation Of Accessory Wheels And Tires Available Through Gm Accessories (08-03-10-004A)
- Use of Chrome or Chrome Plated Steel Valve Caps on Aluminum Valve Stems (08-03-10-005A)
- Spare Tire Hold Down Stud Sticks Up Through Load Floor (Install Nut) (09-08-110-005)
- EI07266 - Vehicle/Tire Vibration, P275/55R20, LT245/75R16, P265/70R17, P245/70R17, P285/45R22, LT265/75R17- Diagnostic Information to Reduce Vibration Concerns (07-03-10-013D)
- Performance Characteristics of Vehicles with Accessory Wheel/Tire Assemblies Installed as "Upsized" to Original Equipment (05-03-10-005D)
- Minimizing Damage to Tire Pressure Monitor (TPM) Sensors During Tire Mounting/Dismounting (08-03-10-007)
- Warranty Reduction - Transfer of Tire Pressure Monitoring (TPM) Sensors to Replacement Wheels and Allowable TPM Sensor Replacements (08-03-16-003)
- Pitting and Brake Dust on Chrome Wheels (04-03-10-012B)
- Accessory Package - Installation of Cargo Capacity Reduction Label (U.S. Only) (07-00-89-027)
- Information on Correctly Setting Tire Pressure at PDI Using Tire Pressure Monitoring (TPM) System as a Reference (07-03-16-001B)
- Essential Service Tool Update #6 (U.S. Retailers Only) (06-00-89-042)
- Window Motors & Regulators
- Information On Side Door Window Glass Chipping Caused By Hanging Vehicle Key Lock Box (06-08-64-001D)
- Repair Information For Reconnection Of Rear Window (Defroster) Contact Or Tab (03-08-48-006J)
- Diagnostic Tips - Installing Rear Window To Regulator Assembly (PIC5823)
- Rear Window Defogger - Broken Heating Grid Detection Method (04-08-48-001D)
- Distortion in Outer Surface of Vehicle Glass (00-08-48-005D)
- Clear Stain or Film on Inside Perimeter of Windshield Glass (Clean/Polish Glass) (09-08-48-006)
- Marks/Stains on Windshield When Wet (Clean Windshield) (09-08-48-002A)
- Warranty Admin - Guidelines for Claiming C0034 - Windshield Replacement (72-05-04)
- Poor Fit/Bowing of Trim on Either Side of Rear Glass (Trim Lower Garnish Molding and/or Reposition Wire Harness) (07-08-53-003)
- Urethane Adhesives For Stationary Glass And Other Applications (02-08-48-001A)
- Wiper/Washer Systems
- Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)
- Diagnostic Tip: Apple Device Connectivity Issues Due To USB Cord Concern (PIT5399A)
- Intermittent Malfunction Indicator Lamp (Mil) Illuminated, DTC P2138 With Reduced Engine Power (Repair Instrument Panel (IP) To Body Harness Connector) (07-06-04-019F)
- Prior To Any Circuit Testing (PIP5094A)
- Information On Coax Repair Kit Availability (PI0572C)
- Crank No Start After Hot Soak (PI1462)