Specifications Index
PRIUS SPECIFICATIONS INDEX
| System | Specification/Procedure | ||
|---|---|---|---|
| Air Conditioning | |||
| Service | SPECIFICATIONS | ||
| Torque | TORQUE SPECIFICATIONS | ||
| Axle Nut/Drive Axle Nut/Axle Hub Nut | |||
| Axle Shaft/Bearing Lock Nut/Drive Axle Nut (Front) | 159 ft.lbs (216 N.m) | ||
| Drive Axle Lock Nut (Rear 4WD) | 159 ft.lbs (216 N.m) | ||
| Axle Hub-To-Axle Carrier Bolts (Rear) | 38 ft.lbs (52 N.m) | ||
| Battery | NA | ||
| Brakes | |||
| Bleeding Sequence | BLEEDING BRAKE SYSTEM | ||
| Disc Brakes | DISC & DRUM BRAKE SPECIFICATIONS | ||
| Drum Brakes | DISC & DRUM BRAKE SPECIFICATIONS | ||
| Torque | TORQUE SPECIFICATIONS | ||
| Charging | |||
| Generator | NA | ||
| Torque | NA | ||
| Drive Belts | |||
| Adjustment | DRIVE BELT TENSION SPECIFICATIONS | ||
| Belt Routing | DRIVE BELT ROUTING | ||
| Engine Cooling | |||
| General Service Specifications | COOLING SYSTEM SPECIFICATIONS | ||
| Radiator Cap Pressure | 10.7-14.9 psi. (Minimum opening pressure is 8.5 psi.) |
||
| Thermostat R & I | THERMOSTAT | ||
| Water Pump R & I | WATER PUMP | ||
| Engine Mechanical | |||
| Compression | ENGINE COMPRESSION | ||
| Normal Compression Pressure | 106 psi. (7.4 kg/cm2 ) | ||
| Minimum Compression Pressure | 77 psi. (5.4 kg/cm2 ) | ||
| Maximum Variation Between Cylinders | 14 psi. (1.0 kg/cm2 ) | ||
| Oil Pressure | |||
| At Idle Speed | 29 kPa (0.3 kgf/cm2 , 4.3 psi) or more | ||
| At 2,250 RPM | 150 - 550 kPa (1.5 - 5.6 kgf/cm2 , 22 - 80 psi) | ||
| Overhaul | ENGINE SPECIFICATIONS | ||
| Torque | TORQUE SPECIFICATIONS | ||
| Fluid Specifications | See FLUIDS under MAINTENANCE tab. | ||
| Flywheel/Flex Plate (Drive Plate) Torque | |||
| Flywheel-To-Crankshaft Bolts | Step 1) 62 Ft.lbs (84 N.m) Step 2) Additional 90 Degree Turn |
||
| Fuel System | |||
| Pressure Specification | 44-50 psi (3.1-3.5 kg/cm2 ) | ||
| Fuel Pressure Test Procedure | PRIUS | ||
| Fuel Filter Location | |||
| FUEL FILTER | |||
| Ignition | |||
| Firing Order & Cylinder Identification | FIRING ORDER & CYLINDER IDENTIFICATION | ||
| Ignition Wires (Resistance) | HIGH TENSION WIRE RESISTANCE | ||
| Ignition Wires (Routing) | Refer to footnotes, see FIRING ORDER & TIMING MARKS | ||
| Spark Plug | |||
| Type | NGK No. IFR5A11 DENSO No. SK16R11 |
||
| Gap | .043 (1.10) | ||
| Torque | 13 ft.lbs (18 N.m) | ||
| Starting | |||
| Starter | NA | ||
| Torque | NA | ||
| Wheel Alignment | |||
| Adjustment Specifications | WHEEL ALIGNMENT SPECIFICATIONS | ||
| Torque | TORQUE SPECIFICATIONS | ||
| Wheel & Tire | |||
| Wheel Lug Nut Torque | 76 ft.lbs (103 N.m) | ||